The role of muscle proteases and lipases in flavor development during the processing of dry-cured ham

Investigating the effects of low-salt processing on the umami peptides of dry-cured ham using peptidomics techniques

This study investigated the effect of low-salt processing on the umami peptide profile of dry-cured hams. Peptidomics data showed 633 umami peptides in the low- and full-salt groups. Among them, 36.2% and 26.5% of shared umami peptides in the low-salt group were significantly down- and up-regulated in relative abundance. Multivariate statistical analysis showed 1011 significantly different umami peptides (SDUPs) in the low- and full-salt groups. Creatine kinase M-type (CKM) and fast skeletal muscle troponin T (TnTf) were the main precursor proteins of these SDUPs. At the end of processing, the relative expression of CKM was lower in the low-salt group than in the full-salt group (P < 0.05), but there was no significant difference in TnTf. More dipeptidyl peptidase cleavage sites were observed in CKM and TnTf proteins in the low-salt group.

Investigating the impact of lipid molecules and heat transfer on aroma compound formation and binding in roasted chicken skin: A UHPLC-HRMS and GC-O-MS study

The UHPLCHRMS and Gas Chromatography-Olfactometry-Mass Spectrometry (GC-O-MS) techniques were applied to investigate effects of lipid molecules and heat transfer on the generation of aroma compounds in roasted chicken skin. Nineteen odorants were identified as most important aroma contributors based on odor activity values (OAVs) exceeding 1. Lipidomic analysis identified 3926 lipids in the samples, in which triglycerides (TG), phosphatidylcholine (PC), phosphatidylethanolamine (PE), and ceramide (Cer) had a contribution of 20.63%, 12.46%, 11.95%, and 11.39%, respectively. Furthermore, it was observed that PS(18:3e_22:5) and TG(18:0_18:1_18:1) serve as significant chemical markers for distinguishing chicken skin during the roasting (p < 0.05). TGs, notably TG(16:1_18:1_18:2) and TG(18:1_18:2_18:2), were postulated as key retainers for binding crucial aroma compounds. Meanwhile, PC, PE, and Cer played pivotal roles in aroma compound formation. Additionally, higher thermal conductivity and reduced thermal diffusivity significantly contributed to the formation of key odorants.

Exploring the novel antioxidant peptides in low-salt dry-cured ham: Preparation, purification, identification and molecular docking

Dry-cured ham is important source of bioactive peptides. In this study, the antioxidant activities of peptides and components from low and fully salted dry-cured hams were compared by peptidomics. And novel antioxidant peptides were identified and characterized. The results showed that the peptides (<3 KDa) extracted from low-salt dry-cured ham had higher antioxidant activity. Therefore, the antioxidant peptides in low-salt dry-cured ham were further characterized and the mechanism of their antioxidant activity was investigated. From the five candidate peptides selected, we found DWPDARGIWHND (DD12) to be highly stable, non-sensitizing, and non-toxic with the highest free radical scavenging activity. Molecular docking predicted that DD12 interacted with Keap1 through hydrogen-bond formation and hydrophobic interactions, suggesting that DD12 had good cellular antioxidant activity. DD12 peptide can bind to DPPH• and ABTS•+, resulting in strong free radical scavenging activity. Our findings support the development and application of natural antioxidant peptides in dry-cured ham.

Genome-Wide Association Study for Weight Loss at the End of Dry-Curing of Hams Produced from Purebred Heavy Pigs

Dissecting the genetics of production traits in livestock is of outmost importance, both to understand biological mechanisms underlying those traits and to facilitate the design of selection programs incorporating that information. For the pig industry, traits related to curing are key for protected designation of origin productions. In particular, appropriate ham weight loss after dry-curing ensures high quality of the final product and avoids economic losses. In this study, we analyzed data (N = 410) of ham weight loss after approximately 20 months of dry-curing. The animals used for ham production were purebred pigs belonging to a commercial line. A genome-wide association study (GWAS) of 29,844 SNP markers revealed the polygenic nature of the trait: 221 loci explaining a small percentage of the variance (0.3-1.65%) were identified on almost all Sus scrofa chromosomes. Post-GWAS analyses revealed 32 windows located within regulatory regions and 94 windows located in intronic regions of specific genes. In total, 30 candidate genes encoding receptors and enzymes associated with ham weight loss (MTHFD1L, DUSP8), proteolysis (SPARCL1, MYH8), drip loss (TNNI2), growth (CDCA3, LSP1, CSMD1, AP2A2, TSPAN4), and fat metabolism (AGPAT4, IGF2R, PTDSS2, HRAS, TALDO1, BRSK2, TNNI2, SYT8, GTF2I, GTF2IRD1, LPCAT3, ATN1, GNB3, CMIP, SORCS2, CCSER1, SPP1) were detected.

Effect of Overripening on the Physico-Chemical and Sensory Characteristics of Boneless, Salt-Reduced Iberian Dry-Cured Ham

The aim of this study was to evaluate the effect of extended maturation and temperature increase on the physico-chemical, biochemical, instrumental color and texture, sensory, and acceptability parameters of cured and boneless Iberian hams. Given the limited knowledge in this area, our objective was to develop a ham with enhanced proteolysis, potentially leading to increased bioactive peptide generation and superior sensory characteristics compared to salt-reduced counterparts. To achieve this, a batch of hams cured up to 38% loss at 30 °C and two batches cured up to 42% loss at 30 °C and 36 °C were evaluated. Results showed that the increase in processing time and temperature significantly enhanced (p < 0.05) ham proteolysis and amino acid content without adversely affecting its texture. No significant differences were observed in instrumental texture parameters or sensory attributes as evaluated by consumers. These processing conditions also increased the content of free amino acids, improving the product quality. Overall, these processing modifications resulted in hams with excellent sensory acceptability and enhanced bioactive potential despite the salt reduction.

TMT-labeled quantitative proteomic reveals the mechanism of proteolysis and taste improvement of dry-cured bacon with Staphylococcus co-inoculation

To understand the mechanism of co-inoculation of Staphylococcus xylosus and Staphylococcus vitulinus (SX & SV) on structural protein degradation and taste enhancement of dry-cured bacon, protease activities, protein degradation, surface morphology of proteins and taste parameters of dry-cured bacon with Staphylococcus inoculation were investigated. The dry-cured bacon with co-inoculation of Staphylococcus xylosus and Staphylococcus vitulinus showed the best taste attributes. High residual activities in cathepsin B + L (more than 1.6-fold) and alanyl aminopeptidase (more than 1.4-fold) accelerated structural protein degradation in SX & SV. 32 down-regulated proteins were identified in SX & SV by TMT-labeled quantitative proteomic compared with control group; myosin and actin showed the most intense response to the accumulation of sweet and umami amino acids, and atomic force microscopy confirmed structural proteins breakdown by morphological changes. The accumulation of glutamic acid, alanine and lysine was mainly responsible for taste improvement of dry-cured bacon with Staphylococcus co-inoculation.

Insight into the Relationship between the Causes of Off-Odour and Microorganism Communities in Xuanwei Ham

To expound on the correlation between the microorganism communities and the formation of off-odour in Xuanwei ham, the microorganism communities and volatile compounds were investigated in the biceps femoris (BF) and semimembranosus (SM) of Xuanwei ham with different quality grades (normal ham and spoiled ham). The single molecule real-time sequencing showed that differential bacteria and fungi were more varied in normal hams than in spoiled hams. Headspace solid-phase microextraction-gas chromatography (HS-SPME-GC-MS) results indicated that aldehydes and alcohols were significantly higher in spoiled hams than those in normal hams (p < 0.05). The off-odour of spoiled hams was dominated by ichthyic, malodourous, sweaty, putrid, sour, and unpleasant odours produced by compounds such as trimethylamine (SM: 13.05 μg/kg), hexanal (BF: 206.46 μg/kg), octanal (BF: 59.52 μg/kg), methanethiol (SM: 12.85 μg/kg), and valeric acid (BF: 15.08 μg/kg), which are positively correlated with Bacillus cereus, Bacillus subtilis, Bacillus licheniformis, Pseudomonas sp., Aspergillus ruber, and Moraxella osloensis. Furthermore, the physicochemical property and quality characteristics results showed that high moisture (BF: 56.32 g/100 g), pH (BF: 6.63), thiobarbituric acid reactive substances (TBARS) (SM: 1.98 MDA/kg), and low NaCl content (SM: 6.31%) were also responsible for the spoilage of hams with off-odour. This study provided a deep insight into the off-odour of Xuanwei ham from the perspective of microorganism communities and a theoretical basis for improving the flavour and overall quality of Xuanwei hams.

Generation of kokumi γ-glutamyl short peptides in Spanish dry-cured ham during its processing

The typical dry-cured ham flavor is rich in umami and brothy perceptions, for which short peptides may contribute. Particularly, γ-glutamyl peptides could be the responsible of these previously reported attributes, as they exert a synergistic interaction with other basic tastes and modify the intensity of salty, sweet, and umami tastes. The content of peptides has been reported to evolve along the processing, but no kokumi γ-glutamyl peptides have been identified in Spanish dry-cured hams yet. In this research, nine γ-glutamyl dipeptides (γ-EA, γ-EC, γ-EE, γ-EF, γ-EL, γ-EM, γ-EV, γ-EW, and γ-EY) and two γ-glutamyl tripeptides (GSH and γ-EVG) have been quantitated at 6, 12, 18 and 24 months of traditional processing of Spanish dry-cured ham by performing a Q Exactive Orbitrap-based tandem mass spectrometry. The results show an increase of γ-EA, γ-EE, γ-EF, γ-EL, γ-EM and γ-EVG, obtaining maximums at 24 months of curing ranging from 0.14 (γ-EVG) to 18.86 (γ-EL) μg/g dry-cured ham. Otherwise, γ-EV, γ-EW and γ-EY accumulated until the 18th month of storage to 15.10, 0.54 and 3.17 μg/g dry-cured ham, respectively; whereas γ-EC and GSH amounts decreased starting from 0.0676 and 4.41 μg/g dry-cured ham, respectively at earlier stages. The concentration dynamics of these compounds may be linked with proteolytic and oxidative reactions during processing. In addition, due to their synergistic effect on kokumi activity, this could constitute insights of the brothy perceptions of dry-cured ham, and these peptides probably contribute to the sensory differences existing in long processed Spanish dry-cured hams.

Aging mechanism for improving the tenderness and taste characteristics of meat

Tenderness and taste characteristics of meat are the key determinants of the meat choices of consumers. This review summarizes the contemporary research on the molecular mechanisms by which postmortem aging of meat improves the tenderness and taste characteristics. The fundamental mechanism by which postmortem aging improves the tenderness of meat involves the operation of the calpain system due to apoptosis, resulting in proteolytic enzyme-induced degradation of cytoskeletal myofibrillar proteins. The improvement of taste characteristics by postmortem aging is mainly explained by the increase in the content of taste-related peptides, free amino acids, and nucleotides produced by increased hydrolysis activity. This review improves our understanding of the published research on tenderness and taste characteristics of meat and provides insights to improve these attributes of meat through postmortem aging.

Investigation of textural and physicochemical changes during the manufacturing process of pastırma, a dry-cured meat product

The changes in textural and physicochemical properties and stability of meat proteins during the production of pastırma were studied. Samples taken at different production stages (raw material, curing, first drying, second drying and final product) were analyzed. The pH decreased at the end of the curing but increased after the first and second drying. While moisture content and water activity decreased throughout the pastırma production, salt content and Thiobarbituric acid-reactive substances (TBARS) increased. Production stages affected the free fatty acids, residual nitrite content and color parameters (P < 0.01). These results showed that considerable physicochemical changes occurred in the production stages of pastırma. The denaturation temperatures for myosin and actin decreased at the end of the curing, however, no denaturation peak for myosin was observed in the later stages. Hardness, cohesiveness and chewiness increased throughout the pastırma production. Warner-Bratzler (WB) shear force increased at the end of the first drying and in the final product. These results are important in terms of obtaining the desired textural properties in the final product. Also, remarkable correlations were detected among the determined properties during the manufacturing process. The study provided considerable findings for the development of industrial pastırma production.

Comparative Quantitation of Kokumi γ-Glutamyl Peptides in Spanish Dry-Cured Ham under Salt-Reduced Production

Salting is a crucial step during the production of dry-cured ham and it is not well known whether it has an impact on the generation of taste-active peptides. The present study focused on the quantitation of kokumi γ-glutamyl peptides in low-salted Spanish dry-cured hams with 12 months of processing. By using mass spectrometry, peptides were quantitated from samples obtained after ethanolic deproteinization-based and non-ethanolic deproteinization-based extraction methods. Peptides γ-EA, γ-EE, and γ-EL registered mean values of 0.31, 2.75, and 11.35 µg/g of dry-cured ham, respectively, with no differences observed between both extraction protocols. However, γ-EF, γ-EM, γ-EV, γ-EW, γ-EY, and γ-EVG presented significantly (p < 0.05) higher concentrations in the ethanolic deproteinized samples showing values of 5.58, 4.13, 13.90, 0.77, 3.71, and 0.11 µg/g of dry-cured ham, respectively. These outcomes reflect the importance of protocols for the extraction of peptides to achieve the most feasible results. In addition, potential precursors for the formation of γ-glutamyl peptides are generated during dry-curing under salt restriction. The kokumi activity of these γ-glutamyl peptides could enhance the sensory attributes countering the taste deficiencies caused by the salt restriction.

Effects of ultrasound treatment on muscle structure, volatile compounds, and small molecule metabolites of salted Culter alburnus fish

This study investigated the effects of ultrasound treatment on the quality of salted Culter alburnus fish. The results showed that with the increasing ultrasound power, the structural degradation of muscle fibers was intensified, and the conformation of myofibrillar protein was significantly changed. The high-power ultrasound treatment group (300 W) had relatively higher thiobarbiturate reactive substance content (0.37 mg malondialdehyde eq/kg) and peroxidation value (0.63 mmol/kg). A total of 66 volatile compounds were identified with obvious differences among groups. The 200 W ultrasound group exhibited fewer fishy substances (Hexanal, 1-Pentene-3-ol, and 1-Octane-3-ol). Compared with control group, ultrasound groups (200, 300 W) contained more umami taste-related amino peptides such as γ-Glu-Met, γ-Glu-Ala, and Asn-pro. In the ultrasound treatment group, L-isoleucine and L-methionine, which may be used as flavor precursors, were significantly down-regulated, while carbohydrates and its metabolites were up-regulated. Amino acid, carbohydrate, and FA (fatty acyls) metabolism products in salted fish were enriched by ultrasound treatment, and those products might ultimately be related to the taste and flavor of salted fish.

Role of Enzymatic Reactions in Meat Processing and Use of Emerging Technologies for Process Intensification

Meat processing involves different transformations in the animal muscle after slaughtering, which results in changes in tenderness, aroma and colour, determining the quality of the final meat product. Enzymatic glycolysis, proteolysis and lipolysis play a key role in the conversion of muscle into meat. The accurate control of enzymatic reactions in meat muscle is complicated due to the numerous influential factors, as well as its low reaction rate. Moreover, exogenous enzymes are also used in the meat industry to produce restructured products (transglutaminase), to obtain bioactive peptides (peptides with antioxidant, antihypertensive and gastrointestinal activity) and to promote meat tenderization (papain, bromelain, ficin, zingibain, cucumisin and actinidin). Emerging technologies, such as ultrasound (US), pulsed electric fields (PEF), moderate electric fields (MEF), high-pressure processing (HPP) or supercritical CO₂ (SC-CO₂), have been used to intensify enzymatic reactions in different food applications. This review aims to provide an overview of the enzymatic reactions taking place during the processing of meat products, how they could be intensified by using emerging technologies and envisage potential applications.

1H NMR Reveals the Mechanism of Potassium Lactate on Proteolysis and Taste Metabolites of Rugao Ham

To deepen the understanding of the effect of potassium lactate on the taste of Rugao ham, proteolysis index, enzyme activities and protein degradation of Rugao ham salted with potassium lactate (0%, 0.5%, 1%, 2%) were investigated. Metabolites of Rugao ham were identified by 1H nuclear magnetic resonance (NMR) spectroscopy and the metabolic pathways of the key metabolites were enriched by the Kyoto Encyclopedia of Genes and Genomes (KEGG); the relationship between taste and metabolites was assessed by partial least square discriminant analysis (PLS-DA). The hams with 2% potassium lactate showed lower cathepsin B and L activities, and higher aminopeptidase activities than that of the control group. The contents of free amino acids and organic acids significantly increased from the control to the treatment of 2% potassium lactate. PLS-DA further demonstrated that aspartate, glutamate, alanine, serine, threonine, acetate, lactate, succinate, carnosine, β-glucose and glycerol were the key metabolites to improve the taste of Rugao ham in the treatment of 2% potassium lactate. Metabolic pathways analysis further demonstrated that amino acids metabolism was the main pathway for the taste development of Rugao ham.

Quality Control of Jinhua Ham from the Influence between Proteases Activities and Processing Parameters: A Review

Endogenous proteases are significant for Jinhua ham quality. Protein degradation affects the chemical traits, texture and the formation of flavor substances. Protease activities are affected by different process parameters, such as processing temperature, maturation time, salt content and the drying rate. They affect ham quality, which can be controlled by process parameters. The influences of key factors on Jinhua ham quality are briefly summarized, which can provide a theoretical basis for the selection of specific parameters in dry-cured ham processing. Furthermore, some suggestions are proposed for correcting and improving the flavor and textural defects of ham, yet the effectiveness depends on the operating conditions. The determination of enzyme activity is not real-time and unsupervised at the moment. Future research will focus on the determination of the actual endogenous protease activity and the quantitative relationship between the enzyme activity and main processing parameters.

Influence of Pig Genetic Line and Salt Reduction on Peptide Production and Bioactivity of Dry-Cured Hams

Ham (Jamón) is a product of great value in Spanish gastronomy, although experts have recommended reducing its consumption due to its high salt content and its relationship with cardio-vascular diseases due to the increase in blood pressure it may cause. Therefore, the objective of this study was to evaluate how the reduction of salt content and the pig genetic line influence bioactivity in boneless hams. For this purpose, 54 hams were studied, 18 boneless Iberian hams (RIB), 18 boneless white hams from commercial cross-bred pigs (RWC), and 18 salted and traditionally processed Iberian hams (TIB) to check if the pig genetic line (RIB vs. RWC) or the processing (RIB vs. TIB) affect the peptide production and bioactivity of the hams. The pig genetic line significantly affected the activity of ACE-I and DPPH, with RWC having the highest ACE-I activity and RIB having the highest antioxidative activity. This coincides with the results obtained in the identification of the peptides and the bioactivity analysis performed. Salt reduction positively affected the different hams, influencing their proteolysis and increasing their bioactivity in traditionally cured hams.

Impact of Nitrite Supplementation on Bioactive Peptides during Sausage Processing

The goal of this investigation was to examine the impact of nitrite supplementation on the concentration, antioxidant properties, and species of antioxidant peptides in fermented sausages. The polypeptide concentration in nitrite-supplemented sausages was markedly elevated during sausage processing compared to the blank control (p < 0.05). Moreover, nitrite supplementation in fermented sausages markedly enhanced the DPPH, as well as the ABTS, hydroxyl radical, and superoxide anion free radical scavenging abilities (FRSA) of polypeptides (p < 0.05). The ferrous ion chelating ability was also significantly enhanced (p < 0.05). Based on the liquid chromatograph-mass spectrometer (LC-MS) analysis of the sausage, LPGGGHGDL, TKYRVP, FLKMN, SAGNPN, GLAGA, LPGGGT, DLEE, GKFNV, GLAGA, AEEEYPDL, HCNKKYRSEM, TSNRYHSYPWG, and other polypeptides exhibited antioxidant properties. Moreover, the number of species of antioxidant polypeptides in the nitrite-supplemented sausage was greater in comparison to the controls. Based on this evidence, it may be concluded that nitrite supplementation positively modulated antioxidant polypeptide formation in fermented sausages, thereby providing strong evidence that nitrite supplementation significantly enhances sausage quality.

Bioactive and Sensory Di- and Tripeptides Generated during Dry-Curing of Pork Meat

Dry-cured pork products, such as dry-cured ham, undergo an extensive proteolysis during manufacturing process which determines the organoleptic properties of the final product. As a result of endogenous pork muscle endo- and exopeptidases, many medium- and short-chain peptides are released from muscle proteins. Many of them have been isolated, identified, and characterized, and some peptides have been reported to exert relevant bioactivity with potential benefit for human health. However, little attention has been given to di- and tripeptides, which are far less known, although they have received increasing attention in recent years due to their high potential relevance in terms of bioactivity and role in taste development. This review gathers the current knowledge about di- and tripeptides, regarding their bioactivity and sensory properties and focusing on their generation during long-term processing such as dry-cured pork meats.

Changes in the Physical-Chemical Properties and Volatile Flavor Components of Dry-Cured Donkey Leg during Processing

In order to explore the quality variation and flavor formation of dry-cured donkey leg, the changes in physical−chemical composition, lipolytic, free amino acids content and volatile flavor compounds were investigated in this study. Six fresh, trimmed hind legs with average weight of 8.12 ± 0.8 kg were taken from male Dezhou donkeys slaughtered at the age of 24 months with the average live weight of 240 kg. The entire processing time was eight months long including six stages, specifically: cooling, salting, air-drying, fermenting and aging. Samples were collected at 0 d, 10 d, 20 d, 30 d, 65 d, 105 d and 165 d of processing. The results showed that the pH value remained stable in the range of 6.2~6.6. The moisture and water activity significantly decreased (p < 0.05) during processing. The chloride content, ash, total volatile basic nitrogen (TVB-N) and peroxide value (POV) significantly increased (p < 0.05), from 0.45% to 12.39%, from 3% to 17%, from 1.43 mg/kg to 8.98 mg/kg and from 1.39 g/100 g to 5.26 g/100 g, respectively. The thiobarbituric acid (TBARS) value reached its highest value of 0.39 mg MDA/kg at the end of the salting stage and then decreased to 0.34 mg MDA/kg. Eighteen free amino acids and fifteen free fatty acids were detected, and their contents were significantly increased during processing (p < 0.05). Volatile compounds were analyzed using solid-phase microextraction (SPME) and gas chromatography−mass spectrometry (GC−MS). Among 114 volatile compounds detected in dry-cured donkey leg, aldehydes, esters, alkane and alcohols were more abundant in the final products, with relative concentrations of 41.88%, 5.72%, 5.35% and 5.25%, respectively. Processing significantly affected the physical−chemical properties, which could contribute to the formation of flavor substances of dry-cured donkey leg.

Traditional processing increases biological activities of Dendrobium offificinale Kimura et. Migo in Southeast Yunnan, China

The orchid Dendrobium officinale grows throughout southeast China and southeast Asian countries and is used to treat inflammation and diabetes in traditional Chinese medicine. Tie pi feng dou is a well-known traditional Chinese medicine made from the dried D. officinale stems. Processing alters the physicochemical properties of TPFD; however, it is unclear how processing affects the quality and medicinal value of this plant. Here, we analyzed and compared the chemical composition of fresh stems of D. officinale and TPFD and explored possible explanations for the enhanced medicinal efficacy of processed D. officinale stems using qualitative and quantitative methods. To identify the components of FSD and TPFD, we used ultra-high-performance liquid chromatography combined with mass spectrometry in negative and positive ion modes and interpreted the data using the Human Metabolome Database and multivariate statistical analysis. We detected 23,709 peaks and identified 2352 metabolites; 370 of these metabolites were differentially abundant between FSD and TPFD (245 more abundant in TPFD than in FSD, and 125 less abundant), including organooxygen compounds, prenol lipids, flavonoids, carboxylic acids and their derivatives, and fatty acyls. Of these, 43 chemical markers clearly distinguished between FSD and TPFD samples, as confirmed using orthogonal partial least squares discriminant analysis. A pharmacological activity analysis showed that, compared with FSD, TPFD had significantly higher levels of some metabolites with anti-inflammatory activity, consistent with its use to treat inflammation. In addition to revealing the basis of the medicinal efficacy of TPFD, this study supports the benefits of the traditional usage of D. officinale.

Effect of Muscle Fibre Type on the Fatty Acids Profile and Lipid Oxidation of Dry-Cured Venison SM (semimembranosus) Muscle

The aim of the study was to describe the effect of fibre type on the fatty acid profile and lipid oxidation observed in dry-cured ham produced from individual semimembranosus venison (roe-deer, fallow deer, deer and wild boar) muscles. The results indicated that wild boar meat was characterised by the highest percentage of IA fibres and it contained the higher percentage of MUFA, but a low of PUFA and SFA, and was characterised by a(n-6)/(n-3) ratio lower than in the case of deer meat and greater susceptibility to oxidative changes. The highest percentage of SFA, and the lowest of MUFA and PUFA, was recorded in fallow deer meat, which was also characterised by the highest percentage of white fibres. The curing and drying processes increased the percentage share of SFA and the susceptibility of muscle lipids to oxidation, decreased the percentage of PUFA, and caused insignificant changes in the (n-6)/(n-3) ratio of fatty acids. The products were also characterised by a low amount of fat.

Paradoxical effects of lipolysis on the lipid oxidation in meat and meat products

Lipolysis in meat and meat products is a phenomenon involving hydrolysis of lipids, notably via enzymatic catalysis that takes place even postmortem. During refrigerated and frozen storage of meat, in particular fish, endogenous lipolytic enzymes actively degrade triacylglycerols and phospholipids resulting in accumulation of free fatty acids and other hydrolytic products. A classical conjecture suggests that lipolysis enhances lipid oxidation which is involved in quality deterioration of fresh meat and, to some degrees, flavor development of certain meat products. Recent studies (<5 years) have shown that under some circumstances, lipolysis of certain lipolytic enzymes can inhibit lipid oxidation in muscle models, which provides more insight in lipid oxidation mechanisms in muscle matrices as well as implies potential strategies for improving meat quality. This review will discuss such paradoxical effects and potential mechanisms of lipolysis on lipid oxidation in meat and meat products.

Sensoproteomic Discovery of Taste-Modulating Peptides and Taste Re-engineering of Soy Sauce

Soy sauce, one of the most common Asian fermented foods, exhibits a distinctive savory taste profile. In the present study, targeted quantitation of literature-known taste compounds, calculation of dose-over-threshold factors, and taste re-engineering experiments enabled the identification of 34 key tastants. Following the sensoproteomics approach, 14 umami-, kokumi-, and salt-enhancing peptides were identified for the first time, with intrinsic taste threshold concentrations in the range of 166-939 μmol/L and taste-modulating threshold concentrations ranging from 42 to 420 μmol/L. The lowest taste-modulating threshold concentrations were found for the leucyl peptide LDYY with an umami- and salt-enhancing threshold of 42 μmol/L. Addition of the 14 newly identified peptides to the taste recombinate (aRec_Dipeptides) increased the overall taste intensity and mouthfulness of the recombinate, and comparison with the authentic soy sauce confirmed the identification of all key tastants. Finally, these data as well as the quantitative profiling of several (non)-fermented foods highlight the importance of fermentation with respect to taste formation. On the basis of this knowledge, microorganisms with specific digestion patterns may be used to tailor the taste profile and especially the salt taste sensation of soy sauces.

Seaweed Inclusion in Finishing Lamb Diet Promotes Changes in Micronutrient Content and Flavour-Related Compounds of Raw Meat and Dry-Cured Leg (Fenalår)

Innovative feeding strategies tend to improve the quality properties of raw material and dry-cured products. In the present study, Norwegian White female lambs (n = 24) were finished during 35 days on three different diets: control (CD), control supplemented with seaweed (5% DM) (SD), and pasture (PD). The quality of raw meat (Semimembranosus + Adductor) and deboned dry-cured lamb leg (fenalår; n = 24) was studied. The heme, SFA, MUFA, and PUFA content in raw meat was not affected with finishing diet. The SD significantly increased the selenium, iodine, and arsenic content in raw meat and in the dry-cured leg the iodine and arsenic. The dry-cured leg from SD-lamb had the highest amount of iodine with 130 µg I/100 g which corresponds to 60% of Adequate Intake. Aldehydes, ketones, and esters in raw meat and dry-cured lamb leg were significantly affected by finishing diet; CD showed increased esters in raw meat and aldehydes in the dry-cured leg compared to SD and PD. The significantly higher content of simple sugars, mannose being the most dominant, was found in the dry-cured leg from SD-lamb compared to CD and PD. Finishing diets had no effect on the taste profile of dry-cured lamb leg. This study showed the potential of seaweed in iodine biofortification of lamb meat and dry-cured products. Iodine-rich meat products should reduce iodine-deficiency among humans.

Investigating the Short Peptidome Profile of Italian Dry-Cured Ham at Different Processing Times by High-Resolution Mass Spectrometry and Chemometrics

Short peptides have been spiking interest owing to their significant contribution to the taste and functional properties of dry-cured ham. In this study, a suspect screening approach based on high-resolution mass spectrometry was employed for the comprehensive characterization of the short endogenous peptidome in dry-cured ham samples at different processing stages (14, 22, and 34 months). After careful manual spectra interpretation, a chemometric approach based on principal component analysis was employed for highlighting the differences between the three sets of samples. A total of 236 short peptide sequences was tentatively identified, including 173 natural short peptides and 63 sequences containing non-proteinogenic amino acids, the highest number ever reported for endogenous sequences in dry-cured ham. Samples in the latest processing stages presented a generally higher abundance of dipeptides, indicating residual proteolytic activity. Moreover, the several annotated modified short peptides, mainly pyroglutamination and lactoyl conjugation, allowed hypothesizing several reactions occurring over time. For the first time, several lactoyl-dipeptides were tentatively identified in dry-cured ham samples with maximum concentration in the late processing stage samples. The presented results significantly contribute to the understanding of the reaction involving short peptides that affect the sensory and functional properties of dry-cured ham.

Effect of Salt Reduction on the Quality of Boneless Dry-Cured Ham from Iberian and White Commercially Crossed Pigs

Iberian dry-cured ham has great value in a traditional Spanish diet, although experts have recommended its consumption should be reduced because of its high salt content and link to cardiovascular diseases. Eighteen boneless Iberian hams (RIB), eighteen boneless white commercially crossed pig hams (RWC), and eighteen traditionally salted and processed Iberian hams (TIB) were manufactured to check whether the breed (RIB vs. RWC) or the processing (RIB vs. TIB) affects their physical–chemical and sensory characteristics. Moisture, protein, total nitrogen, nonprotein nitrogen, proteolysis index, NaCl, and ash contents were higher in RWC, contrary to the fat values, which were more than double in RIB. All macrominerals, except Ca, were affected by the processing stage and breed, whereas only the micromineral Zn was higher in RWC. The breed did not affect the free amino acid content; however, the total content was slightly higher in RWC. Regarding the manufacturing process, the deboning of RIB allowed the reduction of salt by over 30%. However, the microbiological stability was not affected, resulting in a safe product. Although deboning and salt reduction significantly affect the hardness, adhesiveness, deformation, and elasticity of dry-cured hams, consumers value all sensory parameters with higher scores in RIB.

LC-MS/MS-based metabolomics and sensory evaluation characterize metabolites and texture of normal and spoiled dry-cured hams

The spoiled dry-cured ham commonly shows unpleasant taste and odour. To deepen the understanding in the formation mechanism of unpleasant taste in spoiled ham, sensory attributes, texture parameters, protein degradation, metabolites were investigated between normal and spoiled hams; the relationship between the sensory quality and metabolites of dry-cured ham was further evaluated by partial least square discriminant analysis (PLS-DA). The scores of richness and overall acceptance were significantly lower in spoiled ham, and more than 12.5-fold values in adhesiveness were found in spoiled ham than normal ham. Myofibrillar proteins including actin, troponin-T and myosin light chain showed excessive degradation in spoiled ham. Forty-two kinds of metabolites mainly derived from protein degradation were identified by LC-MS/MS, and amino acid derivatives and oligopeptides were the key components to distinguish spoiled and normal hams demonstrated by PLS-DA. Purine metabolism, pyrimidine metabolism and protein degradation were the main metabolism pathways in spoiled ham.

Quantification and in silico analysis of taste dipeptides generated during dry-cured ham processing

Small peptides such as dipeptides contribute to a great extent to the characteristic taste of dry-cured hams. In this study, hydrophilic interaction liquid chromatography (HILIC) combined to tandem mass spectrometry was used to separate, identify, and quantify seven dipeptides in dry-cured hams sampled at different processing times (6, 12, 18, and 24 months). Results showed an increased concentration of dipeptides DA, DG, EE, ES, and EV with the length of processing, obtaining values up to 23 μg/g of dry-cured ham, which suggests an intense action of muscle enzymes dipeptidyl peptidases during the process. The dipeptide VG significantly decreased from 7 to 4 μg/g of dry-cured ham as the processing increased from 6 to 24 months, whereas the dipeptide PA showed low values between 380 and 550 ng/g of dry-cured ham at all the sampling times. Additionally, in silico analyses reported the sensory characteristics of the studied dipeptides, mostly giving bitter and umami taste, and predicted their allergenicity, toxicity, and physicochemical properties. These results could be useful for further studies related to the pleasant taste of dry-cured hams.

New Method for Obtaining a Bioactive Essence Extracted from Iberian Ham Fat Rich in MUFA and Antioxidants

Iberian ham is one of the most representative Spanish products and presents an excellent nutritional and sensory quality. Iberian ham trimming fat is considered a by-product and to give a new use to this remaining part could represent a healthy and innovative option for obtaining sustainable foods. The purpose of this work was to obtain a new bioactive ingredient from Iberian ham trimming fat with the highest amount of antioxidants and monounsaturated fatty acids (MUFA), using a new non-invasive solvent-free method. To obtain the essence, two different extraction procedures were carried out. After fatty acid characterization, degree of acidity, peroxide index and a basic sensory analysis were performed. Antioxidant in vitro activity and total phenolic compounds (TPC) were also determined. This new ingredient showed a better sensory profile than raw ham fat, a lower degree of acidity, a higher content of MUFAs, and also showed a higher antioxidant capacity and an increase in phenolic compounds compared to the raw material. This bioactive essence could be used as a food, a cosmetic or a nutraceutical ingredient to prevent certain diseases related to oxidative stress and could also contribute to the maintenance of the circular economy.

Characterization of the Volatile Compounds of Zhenba Bacon at Different Process Stages Using GC-MS and GC-IMS

Zhenba bacon (ZB), a type of Chinese traditional bacon with a long history, has attracted considerable attention in the Southwest of China for its unique flavor. To elucidate the changing course of aroma components during the process of ZB, four stages of process stages were assessed by GC-MS and GC-IMS coupled with multivariate data analysis. A total of 44 volatile compounds were identified by GC-IMS, including 5 esters, 8 alcohols, 12 aldehydes, 3 ketones, 1 furan and 2 sulfides; 40 volatile compounds were identified by GC-MS, 4 ketones, 7 phenols, 8 alcohols, 6 esters, 6 aldehydes, and 6 other compounds were detected. During the curing period, the amount and content of esters in Zhenba bacon gradually increased. Phenols appear in large quantities during the smoking period. The VOCs (volatile organic compounds) in the gallery plots were the most diverse in YZ samples, which are mainly esters. POV (peroxide value) and TBARS (thiobarbituric acid reactive substance) showed that lipid oxidation played an important role in the formation of volatile flavor components of bacon. This study provides valuable analytical data to explain the flavor formation of Zhenba bacon.

Health and safety aspects of traditional European meat products. A review

Meat products constitute one of the most important groups of traditional foods. Thanks to the unique and favorable organoleptic characteristics, and high quality, they are willingly chosen by consumers. Lately, there has been a growing concern over the health aspects of these products. Therefore, the aim of this study was to analyze the nutritional value and factors affecting quality and health safety of traditional meat products on the basis of available literature. The study findings have revealed various issues with uniformity of traditional meat products. Products of the same name may differ substantially considering nutritional value. Reports also indicate that there are some discrepancies which can be attributed to product character (traditional/conventional). They mainly concern the content of moisture, protein, salt, fat, and fatty acid profile. Research suggests that traditional meat products may also be associated with some health safety issues, such as the presence of pathogens, polycyclic aromatic hydrocarbons, nitrate and nitrite residues, N-nitrosamines, biogenic amines and heavy metals.

Volatile compounds in high-pressure-treated dry-cured ham: A review

The use of high pressure processing (HPP) for the treatment of dry-cured ham and other meat products has considerably increased worldwide. Its well-documented lethal effect on pathogenic and spoilage bacteria ensures the microbial safety of dry-cured ham and extends its shelf life. However, the effects of HPP on the volatile compounds, odor and aroma of dry-cured ham are less known. In the present review, the effects of HPP on the enzymes and microorganisms responsible for the generation of volatile compounds in dry-cured ham and the changes in the levels of the main groups of volatile compounds resulting from different HPP treatments are discussed. Particular attention is devoted to the fate of odor-active compounds after HPP treatments and throughout further commercial storage. The use of efficient sensory techniques yielding odor and aroma outputs closer to those perceived by consumers is encouraged. Needs for future research on the volatile compounds, odor and aroma of HPP-treated dry-cured ham are highlighted.

Characterization of Umami Dry-Cured Ham-Derived Dipeptide Interaction with Metabotropic Glutamate Receptor (mGluR) by Molecular Docking Simulation

Dry-cured ham-derived dipeptides, generated along a dry-curing process, are of high importance since they play a role in flavor development of dry-cured ham. The objective of this study was to analyze the residues of the less-studied metabotropic glutamate receptor 1 (mGluR1) implicated in the recognition of umami dry-cured ham dipeptides by molecular docking simulation using the AutoDock Suite tool. AH, DA, DG, EE, ES, EV, and VG (and glutamate) were found to attach the enzyme with inhibition constants ranging from 12.32 µM (AH) to 875.75 µM (ES) in the case if Rattus norvegicus mGluR1 and 17.44 µM (VG) to 294.68 µM (DG) in the case of Homo sapiens, in the open–open conformations. Main interactions were done with key receptor residues Tyr74, Ser186, Glu292, and Lys409; and Ser165, Ser186, and Asp318, respectively, for the two receptors in the open–open conformations. However, more residues may be involved in the complex stabilization. Specifically, AH, EE and ES relatively established a higher number of H-bonds, but AH, EV, and VG presented relatively lower Ki values in all cases. The results obtained here could provide information about structure and taste relationships and constitute a theoretical reference for the interactions of novel umami food-derived peptides.

The effect of aging on beef taste, aroma and texture, and the role of microorganisms: a review

The present review summarizes the advantages and disadvantages of three different aging methods (traditional dry aging, wet aging in vacuum shrink pack and dry aging in a highly moisture-permeable bag), discusses the effects of aging on beef which focus on the formation of taste-active compounds and aroma-active compounds and texture changes, and speculates the role of microbes. All these three aging methods can improve the aroma, flavor and texture of beef to varying degrees. It is concluded that the improvement in the taste during aging may be attributed to the following three aspects: First, the release of reducing sugars from the transition of glycogen and ATP; Second, the formation of free amino acids (FAAs) and peptides through proteolysis; Third, IMP, GMP, inosine and hypoxanthine which are produced by the degradation of nucleotides. The improvement of aroma is related to the volatile aroma-active components, which are produced by the thermal oxidation/degradation of fatty acids and the Maillard reaction between amino acids and reducing sugars during aging. And the change of texture is mainly owing to the degradation of cytoskeletal myofibrin and collagen with intramural connective tissue in meat by the endogenous proteolysis system. The role of microorganism in aging will be the main direction of further research.

Fermented meat sausages and the challenge of their plant-based alternatives: A comparative review on aroma-related aspects

Traditional fermented meat sausages are produced around the world due to their convenience and sensory characteristics which are responsible for their high acceptability. They constitute a cultural heritage as shown by the high diversity of products around the world. Recent trends are addressing issues regarding innovation in their formulation by reduction of salt, fat and additives (curing salts). However, the current trend towards a reduction in the consumption of meat has produced an increase in the formulation of meat product analogues. This trend is the main focus of producers to offer new attractive products to consumers even though the aroma profile of traditional fermented meat sausages is not reached. In this manuscript, we review and discuss the chemistry of aroma formation in traditional fermented meat sausages in contrast to the potential of plant-based ingredients used in meat analogues.

A comprehensive review on molecular mechanism of defective dry-cured ham with excessive pastiness, adhesiveness, and bitterness by proteomics insights

Excessive bitterness, pastiness, and adhesiveness are the main organoleptic and textural defects of dry-cured ham, which often cause a lot of financial losses to manufacturers and seriously damage the quality of the product. These sensory and textural defects are related to the protein degradation of dry-cured ham. Proteomics shows great potential to improve our understanding of the molecular mechanism of sensory and textural defects and identify biomarkers for monitoring their quality traits. This review presents some of the major achievements and considerations in organoleptic and textural defects of dry-cured ham by proteomics analysis in the recent decades and gives an overview about how to correct sensory and textural defects of dry-cured ham. Proteomics reveals that muscle proteins derived from myofibril and cytoskeleton and involved in metabolic enzymes and oxygen transport have been identified as potential biomarkers in defective dry-cured ham. Relatively high residual activities of cathepsin B and L are responsible for the excessive degradation of these protein biomarkers in defective dry-cured ham. Ultrasound-assisted mild thermal or high-pressure treatment shows a good correction for the organoleptic and textural defects of dry-cured ham by changing microstructure and conformation of muscle proteins by accelerating degradation of proteins and polypeptides into free amino acids.