Effects of increasing concentrations of an Escherichia coli phytase on the apparent ileal digestibility of amino acids and the apparent total tract digestibility of energy and nutrients in corn-soybean meal diets fed to growing pigs

Review: Aspects of digestibility and requirements for minerals and vitamin D by growing pigs and sows

Some of the biggest changes in mineral nutrition for pigs that have occurred due to recent research were caused by the understanding that there is a loss of endogenous Ca and P into the intestinal tract of pigs. This resulted in development of the concept of formulating diets based on standardized total tract digestibility (STTD) rather than apparent total tract digestibility because the values for STTD of these minerals are additive in mixed diets. There are, however, no recent summaries of research on digestibility and requirements of macro- and microminerals and vitamin D for pigs. Therefore, the objective of this review was to summarize selected results of research conducted over the last few decades to determine the digestibility and requirements of some minerals and vitamin D fed to sows and growing pigs. Benefits of microbial phytase in terms of increasing the digestibility of most minerals have been demonstrated. Negative effects on the growth performance of pigs of over-feeding Ca have also been demonstrated, and frequent analysis of Ca in complete diets and raw materials is, therefore, recommended. There is no evidence that current requirements for vitamin D for weanling or growing-finishing pigs are not accurate, but it is possible that gestating and lactating sows need more vitamin D than currently recommended. Vitamin D analogs and metabolites such as 1(OH)D3 and 25(OH)D3 have beneficial effects when added to diets for sows in combination with vitamin D3. Recent research on requirements for macrominerals other than Ca and P is scarce, but it is possible that Mg in diets containing low levels of soybean meal is marginal. Some of the chelated microminerals have increased digestibility compared with sulfate forms, and hydroxylated forms of Cu and Zn appear to be superior to sulfate or oxide forms. Likewise, dicopper oxide and Cu methionine hydroxy analog have a greater positive effect on the growth performance of growing pigs than copper sulfate. The requirement for Mn may need to be increased whereas there appears to be no benefits of providing Fe above current requirements. In conclusion, diets for pigs should be formulated based on values for STTD of Ca and P and there are negative effects of providing excess Ca in diets. It is possible vitamin D analogs and metabolites offer benefits over vitamin D3 in diets for sows. Likewise, chelated forms of microminerals or chemical forms of minerals other than sulfates or oxides may result in improved pig performance.

Recombinant Phytase Modulates Blood Amino Acids and Proteomics Profiles in Pigs Fed with Low-Protein, -Calcium, and -Phosphorous Diets

A beneficial effect of corn-expressed phytase (CEP) on the growth performance of pigs fed with very low-protein (VLP) diets was previously shown. Little is known whether this improvement is related to alterations in the expression profiles of blood proteins and amino acids (AAs). The objective of this study was to investigate whether supplementation of VLP, low-calcium (Ca), and low-P diets with a CEP would alter the blood AAs and protein expression profiles in pigs. Forty-eight pigs were subjected to one of the following groups (n = 8/group) for 4 weeks: positive control (PC), negative control-reduced protein (NC), NC + low-dose CEP (LD), NC + high-dose CEP (HD), LD with reduced Ca/P (LDR), and HD with reduced Ca/P (HDR). Plasma leucine and phenylalanine concentrations were reduced in NC; however, the LD diet recovered the concentration of these AAs. Serum proteomics analysis revealed that proteins involved with growth regulation, such as selenoprotein P were upregulated while the IGF-binding proteins family proteins were differentially expressed in CEP-supplemented groups. Furthermore, a positive correlation was detected between growth and abundance of proteins involved in bone mineralization and muscle structure development. Taken together, CEP improved the blood profile of some essential AAs and affected the expression of proteins involved in the regulation of growth.

Classifying Genetic Lines in Pork Production by Ileal Crude Protein and Amino Acid Digestibility in Growing Pigs

The first aim of the study was to evaluate the effect of different dietary lysine (LYS) to energy (DE) ratios on the apparent ileal digestibility (AID) of crude protein (CP) and selected amino acids (AA) in growing pigs (40-60 kg) of different genotypes. The second aim was to classify genotypes into groups based on the AID of CP and AAs. The trials were conducted on a total of 90 cross-bred barrows (30 animals/genotype) in two replicates. Before the trial series, the experimental animals (average initial body weight (BW) = 40.9 ± 8.5 kg) were surgically fitted with post valve T-cannula (PVTC). The diets were formulated with six different total LYS/DE ratios. Titanium dioxide (TiO₂) was added to the diets (5 g/kg) as an indigestible marker. Based on our results, it can be concluded that the LYS/DE ratio of the diets affected the AID of the CP and AA in different ways by each genotype (p < 0.05). It can also be concluded that pigs of different genetic potential can be classified with a high accuracy (91.7%) in respect of their CP and AA digestive capacity. Our results indicate the development of genetic-profile-based swine nutrition technologies as a future direction.

Iron requirements of broiler chickens as affected by supplemental phytase

Iron is routinely supplemented in broiler feeds intending to prevent dietary deficiencies. The present research was conducted with the objective of assessing Fe requirements of broilers when fed supplemental phytase. A total of 1,280 1-d-old male Cobb × Cobb 500 were distributed in a 2 × 5 factorial arrangement (phytase-supplemented feeds × 5 graded increases of supplemental Fe) in 80 battery cages, eight replications of eight chicks each. The trial was replicated once. Chicks were fed a Fe-deficient diet without phytase (Fe analyzed at 31.30 ± 3.79 mg/kg) from placement to 7 d and then randomly distributed into battery cages with corresponding dieting treatments with or without phytase and graded increases of supplemental Fe. Feeds were formulated with corn and soybean meal (SBM), laboratory-grade calcium carbonate, and phosphoric acid; therefore, the vast majority of dietary Fe originated from corn and SBM (analyzed diet had 53.3 ± 1.41 mg/kg Fe). Phytase was added in excess to the producer recommendation of 1,000 FYT (4,452 ± 487 FYT/kg analyzed) such that phytate degradation was expected to be maximized. Supplemental Fe was from laboratory-grade ferrous sulfate heptahydrate (FeSO47H2O) which was increasingly added to the feeds (analyzed Fe in the supplemented feeds were: 53.3 ± 1.41, 65.5 ± 0.59, 77.2 ± 1.97, 87.6 ± 1.72, 97.7 ± 1.33 mg/kg). There were no interactions between phytase and dietary Fe for any response throughout the study (P > 0.05). Supplementing phytase had no effects on Fe intake or Fe excretion, as well as on hematocrit (Ht), hemoglobin (Hb), ferritin, Fe contents in the liver or thigh muscle color (P > 0.05). However, phytase-supplemented feeds produced better live performance as well as higher ileal digestible energy and Fe digestibility (P < 0.05). No effects were found for dietary Fe in live performance at day 28 (P > 0.05). On the other hand, increasing dietary Fe led to linear increases in Fe retention and excretion, Fe contents in livers, as well as Ht and Hb at 14 d (P < 0.05). Quadratic responses (P < 0.05) were observed for Hb at 21 d, serum ferritin on days 14, 21, and 28 (maximum responses were 83.3, 104.0, 91.9, and 88.3 mg/kg Fe, respectively). In conclusion, supplementing Fe adding to a total of 97.7 mg/kg dietary Fe did not affect live performance traits. However, the average of Fe-related blood parameters was maximized at 91.9 mg/kg dietary Fe. Supplementing phytase provided a significant increase in Fe digestibility.

Digestibility of calcium in calcium-containing ingredients and requirements for digestible calcium by growing pigs

The concentration of Ca in plant feed ingredients is low compared with the requirement for pigs and most Ca in diets for pigs is provided by limestone and Ca phosphate. To determine digestibility values for Ca that are additive in mixed diets, the standardized total tract digestibility (STTD) of Ca needs to be calculated, and the STTD of Ca by growing pigs in most Ca-containing ingredients has been reported. Although Ca is an inexpensive nutrient compared with P and amino acids, excess Ca needs to be avoided because excess dietary Ca results in reduced P digestibility, reduced feed intake, and reduced growth performance of pigs. Recent data indicate that most diets produced for pigs in the United States and Europe contain ~0.20 percentage units more Ca than formulated, which likely is because of the use of limestone as a carrier in feed additives or as a flow agent in other ingredients. An excess of this magnitude without a corresponding excess of P will result in a reduction in daily gain of growing pigs by 50 to 100 g. Greater emphasis, therefore, needs to be placed on determining the concentration of Ca in diets for pigs. Microbial phytase increases the digestibility of both Ca and P and it is, therefore, important that the release of both Ca and P by phytase is considered in diet formulation. However, due to the relationship between Ca and P in postabsorptive metabolism, diets need to be formulated based on a ratio between digestible Ca and digestible P. To maximize average daily gain, this ratio needs to be less than 1.40:1.0 in diets for weanling pigs, and the ratio needs to be reduced as the body weight of pigs increases. In contrast, to maximize bone ash, the digestible Ca to digestible P ratio needs to increase from 1.67:1.0 in 11 to 25 kg pigs to 2.33:1.0 in finishing pigs. Gestating sows have reduced STTD and retention of Ca and P compared with growing pigs and formulation of diets for sows based on digestibility values obtained in growing pigs will result in inaccuracies in the provision of Ca and P. There is, however, a lack of data for the digestibility of Ca and P by gestating and lactating sows, and responses to microbial phytase by sows are not fully understood. There is, therefore, a need for research to generate more data in this area. In the present review, a summary of data for the digestibility of Ca in feed ingredients for pigs and estimates for the requirement for digestible Ca by growing and finishing pigs are provided.

Effects of microbial phytase on standardized total tract digestibility of phosphorus in feed phosphates fed to growing pigs

An experiment was conducted to test the hypothesis that the apparent total tract digestibility (ATTD) and the standardized total tract digestibility (STTD) of P in feed phosphates are increased by microbial phytase when fed to growing pigs. Monocalcium phosphate (MCP), monosodium phosphate (MSP), and magnesium phosphate (MgP) from volcanic deposits were used in the experiment. Three corn-soybean meal based diets that contained 0, 500, or 4,000 units of microbial phytase (FTU), but no feed phosphates, were formulated. Nine additional diets were formulated by adding each of the three feed phosphates to the three basal diets. A P-free diet was also formulated to estimate the basal endogenous loss of P, and therefore, 13 diets were used in the experiment. A total of 117 growing barrows (initial body weight: 15.56 ± 1.68 kg) were allotted to the 13 diets with 9 pigs per diet. Pigs were housed individually in metabolism crates equipped with a feeder and a nipple drinker. Installation of a screen floor under the slatted floor allowed for collection of feces. Diets were fed for 10 d, with the initial 5 d being a period of adaptation to the diet followed by a collection period of 4 d. During the experiment, pigs were fed equal amounts of feed twice daily at 0800 and 1600 h. Results indicated that the ATTD and STTD of P in all diets increased with the inclusion of 500 or 4,000 FTU, but the ATTD and STTD of P in the feed phosphates were not affected by the inclusion of phytase. This indicates that the increases in ATTD and STTD of P that were observed in the mixed diets when phytase was used were due to the release of P from phytate in corn and soybean meal and not from an increase in digestibility of P in feed phosphates. However, MgP had a lower (P < 0.05) ATTD and STTD of P than MCP and MSP. In conclusion, microbial phytase does not increase the digestibility of P in MCP, MSP, or MGP, but the digestibility of P in MgP is less than in MCP and MSP.

Ileal and total tract digestibility of energy and nutrients in pig diets supplemented with a novel consensus bacterial 6-phytase variant

An experiment was conducted to test the hypothesis that increasing levels of a novel phytase increases the apparent ileal digestibility (AID) and apparent total tract digestibility (ATTD) of nutrients in diets fed to young pigs. A negative control (NC) diet based on corn, soybean meal, and canola meal that contained approximately 0.83% phytate (i.e., 0.23% phytate-bound P) was formulated to be deficient in Ca, P, and standardized ileal digestible amino acids (AA). Five additional diets were formulated by adding 250, 500, 1,000, 2,000, or 4,000 phytase units/kg of the novel phytase to the NC diets. Eighteen ileal-cannulated pigs (17.81 ± 1.71 kg) were allotted to a 6 × 3 incomplete Latin square design with six diets and three 11-day periods. There were three pigs per diet in each period; therefore, there were nine replicate pigs per diet. The initial 5 d of each period was considered an adaptation period to the diet. For each period, fecal samples were collected via anal stimulation on days 6, 7, 8, and 9, whereas ileal digesta were collected on days 10 and 11 using standard procedures. Results indicated that the AID of crude protein, indispensable AA, and dispensable AA was increased (quadratic, P < 0.05) as the concentration of microbial phytase increased in the diets. Dietary inclusion of the novel phytase at 1,000 or 2,000 FTU/kg increased the AID of total AA from 73.7% to 79.8%. Increasing levels of microbial phytase increased (quadratic, P < 0.05) the AID of dry matter and minerals (i.e., Ca, P, K, Mg, Cu) in the diets. Likewise, a linear increase (P < 0.05) in the AID of ash and Na was observed as the inclusion level of phytase increased in the diets. Increasing levels of microbial phytase increased (linear, P < 0.01) the AID of gross energy (GE) and starch in the diets. A quadratic (P < 0.05) increase in the ATTD of ash, Ca, P, K, and Cu in experimental diets was observed as the concentration of microbial phytase increased in the diets. The ATTD of Mg and GE also increased (linear; P < 0.05) as concentration of dietary phytase increased. In conclusion, the novel microbial phytase used in this experiment was effective in increasing the AID of dry matter, GE, starch, minerals, and AA, as well as the ATTD of gross energy and minerals in diets formulated to be deficient in Ca, P, and AA.

Apparent digestibility of energy and nutrients and efficiency of microbial phytase is influenced by body weight of pigs

An experiment was conducted to test the hypothesis that regardless of pig body weight (BW), increasing dietary phytase results in increased phytate degradation and improved digestibility of minerals, amino acids (AA), and gross energy (GE). Eighteen pigs were equipped with a T-cannula in the distal ileum and allotted to a triplicated 6 × 3 Youden square design with six diets and three collection periods of 7 d, for a total of nine replicate pigs per diet. This design was repeated four times to simulate four production phases, and there was a 7-d resting period before each collection phase started (BW at start of collections: 29.3, 53.6, 85.1, and 114.4 kg for phases 1, 2, 3, and 4, respectively). Six corn-soybean meal diets were formulated by including 0, 250, 500, 1,000, 2,000, or 4,000 phytase units/kg feed (FTU). The six diets were used throughout the experiment. Samples of feces and ileal digesta were collected in each period. Results indicated that regardless of pig BW, increasing inclusion of phytase increased (quadratic; P < 0.05) apparent ileal digestibility (AID) of crude protein (CP) and most AA, increased apparent total tract digestibility (ATTD) of Ca, P, K, Mg (linear and quadratic; P < 0.05), and Na (linear; P < 0.05), but decreased (linear and quadratic; P < 0.05) AID and ATTD of GE. In all phases, ileal concentrations of inositol phosphate (IP) 6, IP5, IP4, and IP3 decreased (linear and quadratic; P < 0.05), whereas ileal inositol increased (linear and quadratic; P < 0.05) with increasing dietary phytase. However, as pig BW increased, AID of GE, CP, and AA increased (linear, P < 0.05), and the AID of a few AA (Met, Phe, Thr, Trp, Ala, Asp, Gly, and Ser) also increased quadratically (P < 0.05). The ATTD of GE, K, and Mg increased (linear and quadratic; P < 0.05), but ATTD of Ca and Na (linear; P < 0.05) and of P (linear and quadratic; P < 0.05) decreased as pig BW increased. Ileal IP6 and IP3 (linear and quadratic; P < 0.05) and ileal IP5 and IP4 (linear; P < 0.05) increased, whereas ileal inositol decreased (linear; P < 0.05) as pig BW increased. In conclusion, regardless of pig BW, increasing dietary phytase increased phytate degradation and inositol release in the small intestine, and consequently increased mineral and AA digestibility. Older pigs have reduced Ca, P, and Na digestibility, but increased K, Mg, AA, and GE digestibility compared with younger pigs. The efficiency of dietary phytase to degrade phytate appears to decrease as pigs get older.

Increasing Doses of Bacterial Phytase (Citrobacter braakii) Improves Performance and Carcass Characteristics of Pigs in Growing and Finishing Phases

Simple Summary

Phytases of bacterial origin are the exogenous enzymes most widely used in the diets of monogastric animals, acting on the hydrolysis of phytate (myo-inositol 1,2,3,4,5,6-hexakis [dihydrogen] phosphate) to release the phosphate from this complex. However, the efficiency of phytase varies according to the aspects inherent to its own structure and origin, the age and physiological state of the animal, and the dietary composition. Overall, we found that supplementation with phytase between 1500 and 3000 units of phytase (FYT)/kg of feed in diets based on corn and soybean meal with a reduction in inorganic phosphorus (0.13%) and calcium (0.11%) improves the daily weight gain (DWG) and live weight (LW) of animals in the growing phase, which affects performance on finishing phases and slaughter body weight. This input could result in a reduction in the use of phosphorus sources, improving environmental issues with an increase in the main zootechnical parameters.

Abstract

The effects of increasing doses of bacterial phytase (Citrobacter braakii) on performance and carcass characteristics of growing-finishing pigs was evaluated. A total of 120 barrows weighing 25.16 ± 2.80 kg and 68 days old were submitted to five treatments: positive control diet (PC) containing inorganic phosphorus (P) and limestone (Ca); negative control (NC) with reductions in P (by 0.13%) and Ca (by 0.11%); and three NC diets supplemented with 1500 (NC15), 3000 (NC30) and 4500 (NC45) units of phytase (FYT)/kg. The daily weight gain (DWG) in growth phase I (68–91 days) was higher in the PC, NC15 and NC30, compared to the NC (1.06, 1.06, 1.06 vs. 0.95, respectively). The DWG in finishing phase II (141–156 days) was higher in the NC15 (1.20 kg) and NC30 (1.14 kg) than in the NC45 (0.94 kg). The final weights (LW156) in the NC15 (122.95 kg LW) were higher than NC (116.47 kg LW) and NC45 (114.43 kg LW). Over the entire period, a quadratic effect (2012 FYT) was observed for the DWG. The increasing levels of phytase in corn and soybean meal-based diets improved the DWG and carcass traits; however, the addition of more than 3000 FYT/kg of feed should be carefully studied to determine enzyme viability.

Interactive Effects of Copper Sources and a High Level of Phytase in Phosphorus-Deficient Diets on Growth Performance, Nutrient Digestibility, Tissue Mineral Concentrations, and Plasma Parameters in Nursery Pigs

The present study investigated the interactive effects of copper sources and a high level of phytase on growth performance, nutrient digestibility, tissue mineral concentrations, and plasma parameters in nursery pigs. Weaning piglets (N = 192; 6.06 ± 0.99 kg), blocked by body weight, were randomly allotted to 1 of 4 dietary treatments, with 12 pens per treatment and 4 pigs per pen. A basal diet for each phase was formulated to meet nutrient requirements for nursery pigs with the exception that standardized total tract digestibility (STTD) P was reduced by 0.12% and Ca was adjusted to achieve Ca/STTD P = 2.15. The 4 dietary treatments were arranged in a 2 × 2 factorial design, with 2 Cu sources (125 mg/kg Cu from copper methionine hydroxy analogue chelate (Cu-MHAC) or copper sulfate (CuSO₄)) and 2 phytase levels (0 or 1500 phytase units (FTU)/kg). Results showed that there was an interaction (P < 0.05) between Cu sources and phytase on ADG during days 0-41. When phytase was not present in the diets (P deficient), there was no difference between the two Cu sources in terms of ADG during days 0-41, whereas with phytase in the diets, Cu-MHAC tended to improve (P < 0.10) ADG during days 0-41 compared with CuSO₄. Pigs fed Cu-MHAC had greater apparent total tract digestibility (ATTD) of neutral and acid detergent fiber and STTD of P than those fed CuSO₄. Phytase increased (P < 0.05) growth performance, ATTD of Ca and P, and plasma inositol and growth hormone concentrations. In conclusion, Cu-MHAC may be more effective in improving growth rate than CuSO₄ when phytase was supplemented at 1500 FTU/kg. Cu-MHAC enhanced fiber and P digestibility regardless of phytase, compared with CuSO₄. Phytase addition in P-deficient diets was effective in improving growth performance, Ca and P digestibility, and plasma inositol and growth hormone concentrations.

Influence of a novel consensus bacterial 6-phytase variant on mineral digestibility and bone ash in young growing pigs fed diets with different concentrations of phytate-bound phosphorus

A 20-d experiment was conducted to test the hypothesis that phytase increases nutrient digestibility, bone ash, and growth performance of pigs fed diets containing 0.23%, 0.29%, or 0.35% phytate-bound P. Within each level of phytate, five diets were formulated to contain 0, 500, 1,000, 2,000, or 4,000 phytase units (FTU)/kg of a novel phytase (PhyG). Three reference diets were formulated by adding a commercial Buttiauxella phytase (PhyB) at 1,000 FTU/kg to diets containing 0.23%, 0.29%, or 0.35% phytate-bound P. A randomized complete block design with 144 individually housed pigs (12.70 ± 4.01 kg), 18 diets, and 8 replicate pigs per diet was used. Pigs were adapted to diets for 15 d followed by 4 d of fecal collection. Femurs were collected on the last day of the experiment. Results indicated that diets containing 0.35% phytate-bound P had reduced (P < 0.01) digestibility of Ca, P, Mg, and K compared with diets containing less phytate-bound P. Due to increased concentration of total P in diets with high phytate, apparent total tract digestible P and bone ash were increased by PhyG to a greater extent in diets with 0.29% or 0.35% phytate-bound P than in diets with 0.23% phytate-bound P (interaction, P < 0.05). At 1,000 FTU/kg, PhyG increased P digestibility and bone P more (P < 0.05) than PhyB. The PhyG increased (P < 0.01) pig growth performance, and pigs fed diets containing 0.35% or 0.29% phytate-bound P performed better (P < 0.01) than pigs fed the 0.23% phytate-bound P diets. In conclusion, the novel phytase (i.e., PhyG) is effective in increasing bone ash, mineral digestibility, and growth performance of pigs regardless of dietary phytate level.

Effects of a novel E. coli phytase expressed in Pseudomonas fluorescens on growth, bone mineralization, and nutrient digestibility in pigs fed corn-soybean meal diets

Two studies were conducted to determine the effects of a novel Escherichia coli phytase expressed in Pseudomonas fluorescens on growth performance, bone mineralization, and nutrient digestibility in pigs fed corn-soybean meal diets. In experiment 1, 160 nursery pigs (9.79 ± 1.22 kg) were randomly allotted to one of four treatments with 10 pens per treatment and four pigs per pen. Phase I and phase II diets were provided from d 0 to d 14 and d 14 to d 28, respectively. Treatments included: positive control (PC) with all nutrients meeting requirements; negative control (NC) with standardized total tract digestible (STTD) P reduced by 0.15% and 0.14% compared with PC in phase I and phase II, respectively; and NC diets containing 250 or 500 units of phytase (FTU) per kilogram. Results demonstrated that pigs fed PC had greater (P < 0.01) ADG and G:F for the overall experimental period, and greater (P < 0.01) bone ash and P concentrations, compared with pigs fed NC or diets with phytase supplementation. Pigs fed diets containing phytase had greater (P < 0.01) ADG and G:F for the overall experimental period compared with pigs fed the NC diet without phytase, and bone ash and P weights were increased (P < 0.01) as well. In experiment 2, 63 growing barrows (56.25 ± 2.54 kg) were blocked by BW and randomly allotted to one of seven treatments with nine pens per treatment and one pig per pen. A basal corn–soybean meal diet was formulated to meet nutrient requirements for growing pigs with the exception that STTD P was reduced by 0.18% compared with the requirement, and Ca was included to achieve a Ca:STTD P ratio of 2.15. Six additional diets were formulated by adding 250, 500, 750, 1,000, 1,500, or 2,000 FTU/kg of phytase to the basal diet. Pigs were fed experimental diets for 12 d with 7 d of adaptation and 5 d of fecal sample collection. Results indicated that there was a linear (P < 0.01) increase in apparent total tract digestibility of ash and ether extract, and STTD of Ca and P also increased (linear, P < 0.05) in response to increasing doses of phytase. Increasing phytase levels in the diets resulted in increase (quadratic, P < 0.05) in apparent ileal digestibility of Arg, His, Ile, Lys, Trp, Asp, and Glu. In conclusion, the novel E. coli phytase was effective in increasing growth performance, bone mineralization, and Ca and P digestibility in pigs fed corn–soybean meal-based diets. Results also indicated that this phytase had the potential to enhance the digestibility of fat and certain AA.

Intrinsic phytase in hybrid rye increases the digestibility of phosphorus in corn and soybean meal in diets fed to growing pigs

An experiment was conducted to test the hypothesis that inclusion of hybrid rye in diets containing corn and soybean meal (SBM) without or with microbial phytase improves the apparent total tract digestibility (ATTD) and the standardized total tract digestibility (STTD) of P because of the intrinsic phytase activity in hybrid rye. Forty-eight growing barrows (initial body weight: 39.5 ± 7.7 kg) were allotted to six diets. A basal diet containing corn and SBM; a rye-based diet; and a diet containing corn, SBM, and rye were formulated. Each diet was formulated without and with microbial phytase (500 units/kg of diet) for a total of six diets. Fecal samples were collected for 4 d following a 5-d adaptation period according to the marker-to-marker procedure. Results indicated that no interactions between diets and concentration of phytase were observed for any of the response criteria measured. The ATTD and STTD of P and the ATTD of Ca differed (P < 0.05) among diets, but regardless of diet, the concentration of P in feces was reduced (P < 0.05) by adding microbial phytase to the diets. As a consequence, microbial phytase increased (P < 0.05) ATTD and STTD of P, and the ATTD of Ca was also increased (P < 0.05) by the use of microbial phytase. Measured values for the ATTD and STTD of P in the diets containing corn, SBM, and hybrid rye without or with phytase were greater (P < 0.05) than values that were predicted based on the ATTD and STTD of P for the corn-SBM and the hybrid rye diet. The observation that STTD predicted from the individual ingredients underestimated the STTD of P in the mixed diet indicates that the intrinsic phytase in hybrid rye resulted in increased digestibility of the P in the corn and SBM included in the corn-SBM-hybrid rye diet. In conclusion, microbial phytase increased the ATTD and STTD of P and the ATTD of Ca regardless of feed ingredients used in diets fed to pigs. In addition, the intrinsic phytase from hybrid rye increased the ATTD and STTD of P in corn and SBM.

Effects of dietary crude protein level and N-carbamylglutamate supplementation on nutrient digestibility and digestive enzyme activity of jejunum in growing pigs

Three experiments were conducted to investigate the effects of dietary crude protein (CP) level and N-carbamylglutamate (NCG) supplementation on apparent total tract digestibility (ATTD) and ileal digestibility of nutrients and digestive enzyme activity of jejunum in growing pigs. In experiment 1, 10 Duroc × Landrace × Yorkshire barrows (initial BW: 48.7 kg) were allotted to a three-period switchback design with five experimental diets and two replicate pigs per diet in each period. Diets were categorized as high CP (HP, 18% CP), moderate low CP (MLP, 15% CP), very low CP (VLP, 12% CP), and MLP and VLP with 0.1% NCG supplementation. Feces and urine were collected from day 6 to day 11 after a 5-d adaptation period. The DE, ME, and ATTD of GE, OM, CP, NDF, ADF, and P decreased (P < 0.01) with a reduction of dietary CP, but no effect of dietary treatments on pig daily N retention was detected. The NCG supplementation increased (P < 0.01) DE and ATTD of ADF of the VLP diet. In experiment 2, 10 jejunal-cannulated Duroc × Landrace × Yorkshire barrows (initial BW: 44.5 kg) were fed five diets for three periods as experiment 1. Jejunal fluid was collected on days 6 and 8 after a 5-d adaptation period. The digestive enzymes activity was not affected by dietary CP level, except for α-amylase, for which there was a decrease (P < 0.01) in pigs fed VLP diets compared to HP and MLP diets. In experiment 3, 12 ileal-cannulated Duroc × Landrace × Yorkshire barrows (initial BW: 46.7 kg) were allotted to a three-period switchback design with six diets and two replicate pigs per diet in each period. The six experimental diets consisted of five experimental diets as experiment 1 and one N-free diet. Ileal digesta was collected from day 6 to day 8 after a 5-d adaptation period. Results indicated that apparent ileal digestibility (AID) of CP and P and ileal digestibility of Arg, His, Ile, Leu, Phe, and all dispensable AA, except Pro, decreased (P < 0.01) in pigs fed VLP diet compared to HP and MLP diets, but AID of GE, OM, EE, NDF, and ADF were not affected. The supplementation of NCG in the VLP diet increased (P < 0.01) the AID of CP and ileal digestibility of Arg, His, Leu, Phe, Val, Ser, and Tyr. In conclusion, reducing dietary CP level decreased nutrient digestibility, but improved the efficiency of dietary N utilization and reduced N emission. Moderate reduction of dietary CP level had a minimal effect on nutrient digestibility and digestive enzyme activity. Additionally, NCG supplementation plays a beneficial effect on nutrient digestion only if the dietary CP level is extremely lowered.

Effect of a Multi-Carbohydrase and Phytase Complex on the Ileal and Total Tract Digestibility of Nutrients in Cannulated Growing Pigs

The current study evaluated the influence of a multi-carbohydrase and phytase complex (MCPC) on the ileal and total tract digestibility of nutrients in growing pigs. A total of eight barrows (initial BW = 30.7 ± 1.1 kg) were surgically fitted with a T-cannula at the distal ileum and randomly allotted to four groups. The experiment was conducted according to a 4 × 4 Latin square design, each period lasting 10 days. Pigs were fed four experimental diets, which consisted of two basal diets (BD1, low phytate; BD2, high phytate) with or without MCPC containing at least 1800 U xylanase, 6600 U α-arabinofuranosidase, 1244 U β-glucanase, and 1000 U phytase per/kg corn-soybean meal with 15% corn distillers based diet. The high phytate diet reduced (p < 0.05) the apparent ileal digestibility (AID) of crude protein by 1.4% and the apparent total tract digestibility (ATTD) of organic matter, crude protein, and gross energy by 1.7, 2.3, and 1.9%, respectively, and tended to decrease (p = 0.10) the ATTD of Ca by 17.3%, relative to the low phytate diet. The dietary supplementation of the MCPC increased (p < 0.05) the AID of phosphorus (P) and calcium (Ca) by 34.2% and 31.1% for BD1 and 26.7% and 41.3% for BD2, respectively, and increased (p < 0.05) ATTD of crude fat, P, and Ca by 1.4%, 45.6%, and 9.6% for BD1 and 3.1%, 66.0%, and 52.7% for BD2, respectively. The MCPC supplementation did not significantly increase the AID and (or) ATTD of crude protein, organic matter, and starch. In conclusion, the dietary supplementation of the MCPC could improve the AID of P and Ca and the ATTD of crude fat, P, and Ca.

Maturational Changes Alter Effects of Dietary Phytase Supplementation on the Fecal Microbiome in Fattening Pigs

Age-related successions in the porcine gut microbiome may modify the microbial response to dietary changes. This may especially affect the bacterial response to essential nutrients for bacterial metabolism, such as phosphorus (P). Against this background, we used phytase supplementation (0 or 650 phytase units/kg complete feed) to alter the P availability in the hindgut and studied the dietary response of the fecal bacterial microbiome from the early to late fattening period. Fecal DNA were isolated after 0, 3, 5 and 10 weeks and the V3-V4 region of the 16S rRNA gene was sequenced. Permutational analysis of variance showed distinct bacterial communities for diet and week. Alpha-diversity and taxonomy indicated progressing maturation of the bacterial community with age. Prevotellaceae declined, whereas Clostridiaceae and Ruminococcaceae increased from weeks 0 to 3, 5, and 10, indicating changes in fiber-digesting capacities with age. Phytase affected all major bacterial taxa but reduced species richness (Chao1) and diversity (Shannon and Simpson). To conclude, present results greatly support the importance of available P for bacterial proliferation, including fibrolytic, lactic acid- and butyrate-producing genera, in pigs. Results also emphasize the necessity to assess bacterial responses to dietary manipulation at several time points throughout the fattening period.

Assessing current phytase release values for calcium, phosphorus, amino acids, and energy in diets for growing-finishing pigs. Transl Anim Sci 2020;4:txaa034. [PMID: 32705032 DOI: 10.1093/tas/txaa034]

Two experiments were conducted to determine the effects of feeding 1,500 phytase units (FYT/kg; Ronozyme HiPhos 2,500; DSM Nutritional Products, Parsippany, NJ) when credited with its corresponding nutrient release values to growing-finishing pigs. The assumed phytase release values were 0.146% standardized total tract digestible (STTD) P, 0.102% STTD Ca, 8.6 kcal/kg of net energy (NE), and 0.0217%, 0.0003%, 0.0086%, 0.0224%, 0.0056%, 0.0122%, and 0.0163% standardized ileal digestible Lys, Met, Met+Cys, Thr, Trp, Ile, and Val, respectively. In Exp. 1, 1,215 pigs (PIC 359 × Camborough, initially 28.0 ± 0.46 kg) were used. Pens were assigned to one of three dietary treatments with 27 pigs per pen and 15 pens per treatment. Experimental diets consisted of a control with no added phytase or diets with 1,500 FYT fed either in the grower period (days 0-57) then switched to the control diet until market or fed throughout the entire study (day 0 to market). Diets containing added phytase were adjusted based on the supplier-provided expected nutrient release values. During the grower period, pigs fed the control diet with no added phytase had increased (P < 0.05) average daily gain (ADG) and gain-to-feed ratio (G:F) compared with pigs fed added phytase. Overall, pigs fed either the control or phytase only in the grower period had increased (P < 0.05) ADG and G:F compared with pigs fed phytase until market. In Exp. 2, 2,268 pigs (PIC 337 × 1050, initially 28.5 ± 1.96 kg) were used. There were six dietary treatments with 27 pigs per pen and 14 pens per treatment. Experimental diets consisted of a control with no added phytase or five diets with 1,500 FYT assuming nutrient release values for Ca and P; Ca, P, and Amino Acid (AA); Ca, P, AA, and half of the suggested NE; Ca, P, AA, and full NE; or no nutrient release. Overall, there was no evidence for difference in ADG or average daily feed intake among treatments; however, pigs fed the diet containing 1,500 FYT assuming that no nutrient release had improved (P < 0.05) G:F compared to pigs fed diets containing 1,500 FYT assuming either Ca and P or Ca, P, AA, and full NE release, with others intermediate. In summary, pigs fed phytase-added diets accounting for full nutrient release values in both experiments had the poorest performance. This suggests that using all of the nutrient release values attributed to this source of phytase was too aggressive and resulted in lower nutrient concentrations than needed to optimize performance.

Phytate degradation cascade in pigs as affected by phytase supplementation and rapeseed cake inclusion in corn-soybean meal-based diets

Two experiments (Exp.) with ileally cannulated growing barrows were conducted. The concentrations of positional inositol phosphate (InsP) isomers in ileal digesta and feces were determined, as well as the prececal and total tract phytate (InsP6) hydrolysis, and digestibility of dry matter, P, Ca, nitrogen, and gross energy. Prececal amino acid (AA) digestibility and digestive enzyme activities in ileal digesta were also studied. In both Exp., pigs had an initial body weight (BW) of 28 kg and were completely randomized to a Double Latin Square Design with eight pigs, four diets, and three periods of 12 d each. Feces and ileal digesta were collected for 5 d and 2 d, respectively. Pigs were housed individually in stainless steel metabolic units. Water was available ad libitum and feed was provided two times daily at an amount of 4% of mean BW. In Exp. 1, pigs received a corn-soybean meal (SBM)-based diet that was supplemented with 0, 750, 1,500, or 3,000 FTU of a microbial phytase/kg diet. In Exp. 2, pigs were allotted to a 2 × 2 arrangement of diets based on corn and SBM or an SBM-rapeseed cake (RSC) mix and phytase supplementation at 0 or 1,500 FTU/kg of diet. In ileal digesta of pigs fed without the phytase supplement, the dominating InsP isomers beside InsP6 were InsP5 isomers. The InsP pattern in ileal digesta changed with the inclusion of microbial phytase in both Exp., as there was a remarkable increase in Ins(1,2,5,6)P4 concentration (P < 0.001). In both Exp., the myo-inositol concentration in ileal digesta was greater upon phytase addition (P < 0.001). Without phytase supplementation, prececal and total tract P digestibility were low, whereas hardly any InsP6 was excreted in feces. There was no difference between prececal and total tract P digestibility values. For most AA studied in Exp. 2, prececal digestibility was lower (P < 0.01) when the diet contained RSC. However, phytase supplementation did not significantly affect prececal AA digestibility in both Exp. The present study showed that InsP6 disappearance by the end of the ileum can be increased up to around 90% in SBM- and SBM-RSC-based diets when microbial phytase is supplemented, but prececal P digestibility hardly exceeded 60%. The study confirms that pigs cannot benefit from a remarkable InsP6 degradation in the hindgut.

Phytase dosing affects phytate degradation and Muc2 transporter gene expression in broiler starters

This study was conducted to determine effects of high phytase use on growth performance, amino acid (AA) digestibility, intestinal phytate breakdown, and nutrient transporter expression in starter broiler chickens. Male Ross 308 chicks were allocated to 24 pens, at 15 birds/pen and assigned to one of 4 dietary treatments. Treatments were: a control diet (PCa+) that contained adequate levels of calcium (Ca) and phosphorus (P) for growing broiler chicks; a reduced Ca and P diet (PCa-:-1.5 g P/kg and -1.6 g Ca/kg), and 2 additional diets in which phytase was supplemented in the PCa- diet at 1,500 (PCa-Phy1500) and 3,000 (PCa-Phy3000) FTU/kg feed. A common starter diet was fed from day 1 to 8. From day 8 to 22, birds were fed the 4 experimental diets. On day 22, birds were killed for sample collection. From day 8 to 15, average daily gain and average daily feed intake were not different across treatments (P < 0.05) but gain-to-feed ratio (G:F) was reduced (P < 0.006) in the PCa- treatment compared with other treatments. There were no further performance differences, but a tendency of phytase treatments improving the overall G:F (P = 0.079; day 8-22). Up to both the duodenum-jejunum and ileum, phytate, P, and Ca disappearance were increased (P < 0.05) in the PCa-Phy1500 and PCa-Phy3000 treatments compared with PCa- treatment. Phytase dose dependently increased myoinositol (MI) concentration in the digesta from both the duodenum-jejunum and ileum (P < 0.001). The highest concentration of MI was found in the PCa-Phy3000 treatment. Plasma MI concentration was increased by phytase supplementation (P < 0.001). Prececal disappearance of Cys was lower (P < 0.05) in the PCa- treatment than in PCa1and PCa-Phy3000 treatment. Expression of MUC2 in the duodenum-jejunum was higher (P < 0.05) in the PCa-Phy3000 treatment than in other treatments. Phytase-induced hydrolysis of phytate led to elevated digesta and plasma MI concentrations and reduced digesta concentrations of phytate breakdown intermediates.

Extra-phosphoric effects of super dosing phytase on growth performance of pigs is not solely due to release of myo-inositol

Two experiments were conducted to determine the effects of myo-inositol and phytase on growth performance, plasma metabolites, and nutrient digestibility of growing pigs. In experiment 1, 96 growing pigs with average initial body weight (BW) of 26.2 kg were used in a 25-d growth performance study. Pigs were assigned to four dietary treatments with three pigs per pen and eight replicate pens per treatment in a randomized complete block design. The four treatments were control diet (CD); CD + 2 g/kg inositol; CD + 1,000 FYT/kg phytase and CD + 3,000 FYT/kg phytase. Pigs were weighed individually every week. On day 25, blood sample was collected from one pig per pen to measure plasma metabolites concentrations. In experiment 2, 16 barrows (initial BW 34.8 ± 8.2 kg) were surgically fitted with T-cannulas. Pigs were allotted to four blocks based on BW and assigned to a quadruplicate 4 × 2 incomplete Latin square design with same four dietary treatments and two periods. Ileal digesta samples were collected from each pig on days 6 and 7 of each period to determine apparent ileal digestibility (AID) of nutrients. Phytase supplementation increased final BW and average daily gain (ADG) compared with CD (P < 0.05) with no effects on average daily feed intake (ADFI) and gain to feed (G:F) was higher in 3,000 FYT/kg phytase (P < 0.05). Inositol supplementation had no effects on growth performance. Plasma myo-inositol concentration was increased by inositol supplementation, and 3,000 FYT/kg phytase increased myo-inositol in the plasma by 97.2% (P < 0.05). Plasma P concentration was increased by 1,000 or 3,000 FYT/kg phytase with no effects on alkaline phosphatase (ALP), glucose, triglycerides (TAG), calcium (Ca), and urea concentrations. Phytase supplementation reduced (P < 0.05) the phytate-P concentration in the ileal digesta and increased the digestibility of phytate-P and total P with no effects on the AID of dry matter (DM), gross energy (GE), nitrogen (N), and Ca. In conclusion, the beneficial effects of 3,000 FYT/kg phytase on feed efficiency may due to the increased release of both myo-inositol and phosphorus (P), and may not be solely due to myo-inositol release by this level of phytase.

Effect of microbial phytase supplementation on P digestibility in pigs: a meta-analysis

The objectives of this meta-analysis were to determine to which extent phosphorus (P) digestibility and digestible P concentration in pig diets were increased by phytase supplementation and to quantify factors that potentially influence effects of phytase supplementation. A data set with a total of 547 data lines was compiled from 88 experiments published in 74 peer-reviewed papers between 2007 and April 2019. An exponential model was determined as more suitable to describe the response of P digestibility to phytase supplementation than a polynomial model. Phytase supplementation increased P digestibility by 25.6 percentage points (standard error (SE) = 1.54) to a plateau at 64.9% (SE = 1.82). The digestible P concentration was increased by phytase supplementation in the order of 1.01 g/kg (SE = 0.102) to a plateau at 2.62 g/kg (SE = 0.122). Goodness-of-fit criteria were R² = 0.780 and root mean square error = 7.55% for P digestibility, and R² = 0.691 and root mean square error = 0.48 g/kg for digestible P concentration. Consideration of further factors such as mineral P supplementation (yes or no), ad libitum vs. restrictive feeding, mixed diets vs. single feed ingredients, sex and age of pigs did not increase the accuracy of prediction in this data set. Some of these traits exhibited responses, but they likely are artefacts generated through the imbalanced structure of the data set. Effects of dietary total P, phytate (InsP₆), InsP₆-P to total P ratio, and Ca on the effect of supplemented phytase were not quantifiable. The present meta-analysis showed that responses to phytase supplementation can be well predicted although variation in P digestibility and digestible P concentration in the data set was high. Overall, predicted effects of phytase on P digestibility well corresponded to predictions made 25 years ago.

Insoluble dietary fiber does not affect the ability of phytase to release phosphorus from phytate in the diet of nursery pigs1

Phytase is added to swine diets to improve the utilization of phytate-bound P in swine diets. This provides financial and environmental benefits to the pig industry. However, it is unclear if phytase works equally well in all dietary circumstances. The objective of this experiment was to determine if insoluble fiber affects the efficacy of the phytase enzyme in nursery pigs when fed diets limiting in P content. A total of 480 pigs (initial BW 5.48 ± 0.14 kg) were blocked by BW and randomly assigned (10 pigs per pen) to treatment within the block. A common nutrient-adequate diet was fed from days -14 to -5, and two basal P deficient diets (either a corn-soy diet containing 0.16% standardized total tract digestible [STTD] P [low insoluble fiber [LF]], or a corn-soybean meal plus 20% corn bran containing 0.14% STTD P [high insoluble fiber [HF]]) were fed from days -5 to 0 to acclimate pigs to a P deficient diet. From days 0 to 21, pigs received eight dietary treatments (six pens per treatment: n = 6). Experimental diets consisted of LF supplemented with one of four levels of added phytase (0, 109, 218, and 327 phytase units [FTU]/kg; Quantum Blue 5 G, AB Vista, Wiltshire, United Kingdom) expected to provide 0.16, 0.21, 0.26, and 0.31% STTD P, respectively, or HF supplemented with one of the same four levels of added phytase expected to provide 0.14, 0.19, 0.24, and 0.29% STTD P. Titanium dioxide was added to the diet at 0.4% as an indigestible marker. On day 21, one pig representing the average BW for each pen was euthanized, and fibulae were collected and analyzed for bone ash. Fecal samples were collected from each pen on days 19-20. Data were analyzed using PROC MIXED of SAS. There were no interactions between insoluble fiber and phytase for any of the variables evaluated. For days 0-21, adding phytase increased ADG (P < 0.001) with the response being linear (P < 0.001), whereas insoluble fiber decreased ADG (P = 0.033). There were no effects of phytase or insoluble fiber on ADFI (P = 0.381 and P = 0.632, respectively). Phytase improved G:F ratio (P < 0.001) with the response being linear (P < 0.001). Insoluble fiber tended to decrease G:F ratio (P = 0.097). Phytase increased bone ash (P = 0.005) with the response being linear (P = 0.001), but there was no effect of insoluble fiber (P = 0.949). Phytase did not affect the apparent total tract digestibility of DM, NDF, or ADF (P > 0.050), whereas insoluble fiber decreased the ATTD of DM (P < 0.001), NDF (P < 0.001), and ADF (P < 0.001). In conclusion, the addition of insoluble fiber did not affect the ability of phytase to improve growth performance and bone mineralization in nursery pigs fed a P deficient diet.

Effects of microbial phytase on mucin synthesis, gastric protein hydrolysis, and degradation of phytate along the gastrointestinal tract of growing pigs

An experiment was conducted to test the hypothesis that pigs fed diets supplemented with exogenous phytase reduce mucin synthesis in the small intestine, increase protein hydrolysis in the stomach, increase breakdown of phytate along the gastrointestinal tract, and increase mineral and AA digestibility. A diet based on corn, soybean meal, and canola meal was formulated to meet requirements for growing pigs except for Ca and P, which were lower than requirements. Three additional diets were formulated by adding 750, 1,500, or 3,000 units of phytase (FTU) per kilogram to the basal diet. Eight growing barrows (38.45 ± 3.06 kg) were prepared with a T-cannula in the duodenum and another T-cannula in the distal ileum. Pigs were housed individually and allotted to a replicated 4 × 4 Latin square design with four pigs and four periods in each square. Each period lasted 14 d with the initial 7 d being the adaptation period to the diets. Pigs were fed twice daily in combined amounts equal to 3.2 times the estimated requirement for maintenance energy. Results indicated that the apparent ileal digestibility (AID) and the apparent total tract digestibility (ATTD) of Ca and P increased (linear and quadratic, P ≤ 0.05) as phytase inclusion increased. However, values for AID of Ca and P were not different from values for ATTD of Ca and P, indicating that there is no net absorption of Ca and P in the hindgut. The apparent duodenal digestibility (ADD) of Ca and P was ~30% and 10% to 20%, respectively, indicating some digestion in the stomach of both Ca and P. A quadratic increase (P < 0.05) of the AID of GE was observed with the breakpoint around 1,500 FTU, but there was a negative linear (P ≤ 0.001) effect of dietary phytase on the ATTD of GE. Phytase did not affect mucin synthesis in the small intestine, protein hydrolysis in the stomach, or ileal digestibility of dispensable and indispensable AA. However, degradation of higher phytate esters (IP6 and IP5) into lower phytate esters (IP4 and IP3) and inositol increased as dietary phytase increased, indicating that it is possible to completely degrade dietary phytate if microbial phytase is included by at least 3,000 FTU in the diet. In conclusion, supplementing diets with phytase resulted in increased degradation of phytate and phytate esters and improved digestibility of Ca and P, but phytase did not change intestinal mucin synthesis, gastric protein hydrolysis, or the AID of AA.