Standardized total tract digestibility of calcium varies among sources of calcium carbonate, but not among sources of dicalcium phosphate, but microbial phytase increases calcium digestibility in calcium carbonate1

Review: Aspects of digestibility and requirements for minerals and vitamin D by growing pigs and sows

Some of the biggest changes in mineral nutrition for pigs that have occurred due to recent research were caused by the understanding that there is a loss of endogenous Ca and P into the intestinal tract of pigs. This resulted in development of the concept of formulating diets based on standardized total tract digestibility (STTD) rather than apparent total tract digestibility because the values for STTD of these minerals are additive in mixed diets. There are, however, no recent summaries of research on digestibility and requirements of macro- and microminerals and vitamin D for pigs. Therefore, the objective of this review was to summarize selected results of research conducted over the last few decades to determine the digestibility and requirements of some minerals and vitamin D fed to sows and growing pigs. Benefits of microbial phytase in terms of increasing the digestibility of most minerals have been demonstrated. Negative effects on the growth performance of pigs of over-feeding Ca have also been demonstrated, and frequent analysis of Ca in complete diets and raw materials is, therefore, recommended. There is no evidence that current requirements for vitamin D for weanling or growing-finishing pigs are not accurate, but it is possible that gestating and lactating sows need more vitamin D than currently recommended. Vitamin D analogs and metabolites such as 1(OH)D3 and 25(OH)D3 have beneficial effects when added to diets for sows in combination with vitamin D3. Recent research on requirements for macrominerals other than Ca and P is scarce, but it is possible that Mg in diets containing low levels of soybean meal is marginal. Some of the chelated microminerals have increased digestibility compared with sulfate forms, and hydroxylated forms of Cu and Zn appear to be superior to sulfate or oxide forms. Likewise, dicopper oxide and Cu methionine hydroxy analog have a greater positive effect on the growth performance of growing pigs than copper sulfate. The requirement for Mn may need to be increased whereas there appears to be no benefits of providing Fe above current requirements. In conclusion, diets for pigs should be formulated based on values for STTD of Ca and P and there are negative effects of providing excess Ca in diets. It is possible vitamin D analogs and metabolites offer benefits over vitamin D3 in diets for sows. Likewise, chelated forms of microminerals or chemical forms of minerals other than sulfates or oxides may result in improved pig performance.

- Invited Review - Mineral composition and phosphorus digestibility in feed phosphates fed to pigs and poultry

Phosphorus (P) is a macro mineral needed for bone mineralization and cell membrane structure and P is also involved in several fundamental pathways of metabolism in the body. Because of the low concentration and digestibility of P in plant ingredients that are the main components of diets for poultry and pigs, feed phosphates are usually included in diets in addition to the P contributed by plant ingredients. The most widely used feed phosphates in poultry and swine diets are dicalcium phosphate (DCP) and monocalcium phosphate (MCP), but tricalcium phosphate (TCP), monosodium phosphate (MSP), and magnesium phosphate (MgP) may be used as well. Because feed phosphates are mostly produced from rock phosphate, feed phosphates have impurities that contain minerals other than P. Concentrations of P in feed phosphates range from 14.8% (MgP) to 25.7% (MSP). The standardized total tract digestibility (STTD) of P in pigs ranges from 71% (TCP) to 95% (MSP). The STTD of Ca and the standardized ileal digestibility (SID) of P and Ca in feed phosphates fed to pigs and poultry have been determined only in a few experiments. Available data indicate that the STTD of Ca and SID of P in MCP are greater than in DCP in both poultry and pigs, but the SID of Ca is similar between DCP and MCP fed to broilers. Information on mineral concentrations and digestibility values in feed phosphates is needed in diet formulation for pigs and poultry, but if diets are formulated to contain equal concentrations of digestible P and Ca, it is unlikely that animal performance will be impacted by the source of feed phosphates used in the diet.

Digestibility of calcium in calcium-containing ingredients and requirements for digestible calcium by growing pigs

The concentration of Ca in plant feed ingredients is low compared with the requirement for pigs and most Ca in diets for pigs is provided by limestone and Ca phosphate. To determine digestibility values for Ca that are additive in mixed diets, the standardized total tract digestibility (STTD) of Ca needs to be calculated, and the STTD of Ca by growing pigs in most Ca-containing ingredients has been reported. Although Ca is an inexpensive nutrient compared with P and amino acids, excess Ca needs to be avoided because excess dietary Ca results in reduced P digestibility, reduced feed intake, and reduced growth performance of pigs. Recent data indicate that most diets produced for pigs in the United States and Europe contain ~0.20 percentage units more Ca than formulated, which likely is because of the use of limestone as a carrier in feed additives or as a flow agent in other ingredients. An excess of this magnitude without a corresponding excess of P will result in a reduction in daily gain of growing pigs by 50 to 100 g. Greater emphasis, therefore, needs to be placed on determining the concentration of Ca in diets for pigs. Microbial phytase increases the digestibility of both Ca and P and it is, therefore, important that the release of both Ca and P by phytase is considered in diet formulation. However, due to the relationship between Ca and P in postabsorptive metabolism, diets need to be formulated based on a ratio between digestible Ca and digestible P. To maximize average daily gain, this ratio needs to be less than 1.40:1.0 in diets for weanling pigs, and the ratio needs to be reduced as the body weight of pigs increases. In contrast, to maximize bone ash, the digestible Ca to digestible P ratio needs to increase from 1.67:1.0 in 11 to 25 kg pigs to 2.33:1.0 in finishing pigs. Gestating sows have reduced STTD and retention of Ca and P compared with growing pigs and formulation of diets for sows based on digestibility values obtained in growing pigs will result in inaccuracies in the provision of Ca and P. There is, however, a lack of data for the digestibility of Ca and P by gestating and lactating sows, and responses to microbial phytase by sows are not fully understood. There is, therefore, a need for research to generate more data in this area. In the present review, a summary of data for the digestibility of Ca in feed ingredients for pigs and estimates for the requirement for digestible Ca by growing and finishing pigs are provided.

Effects of microbial phytase on standardized total tract digestibility of phosphorus in feed phosphates fed to growing pigs

An experiment was conducted to test the hypothesis that the apparent total tract digestibility (ATTD) and the standardized total tract digestibility (STTD) of P in feed phosphates are increased by microbial phytase when fed to growing pigs. Monocalcium phosphate (MCP), monosodium phosphate (MSP), and magnesium phosphate (MgP) from volcanic deposits were used in the experiment. Three corn-soybean meal based diets that contained 0, 500, or 4,000 units of microbial phytase (FTU), but no feed phosphates, were formulated. Nine additional diets were formulated by adding each of the three feed phosphates to the three basal diets. A P-free diet was also formulated to estimate the basal endogenous loss of P, and therefore, 13 diets were used in the experiment. A total of 117 growing barrows (initial body weight: 15.56 ± 1.68 kg) were allotted to the 13 diets with 9 pigs per diet. Pigs were housed individually in metabolism crates equipped with a feeder and a nipple drinker. Installation of a screen floor under the slatted floor allowed for collection of feces. Diets were fed for 10 d, with the initial 5 d being a period of adaptation to the diet followed by a collection period of 4 d. During the experiment, pigs were fed equal amounts of feed twice daily at 0800 and 1600 h. Results indicated that the ATTD and STTD of P in all diets increased with the inclusion of 500 or 4,000 FTU, but the ATTD and STTD of P in the feed phosphates were not affected by the inclusion of phytase. This indicates that the increases in ATTD and STTD of P that were observed in the mixed diets when phytase was used were due to the release of P from phytate in corn and soybean meal and not from an increase in digestibility of P in feed phosphates. However, MgP had a lower (P < 0.05) ATTD and STTD of P than MCP and MSP. In conclusion, microbial phytase does not increase the digestibility of P in MCP, MSP, or MGP, but the digestibility of P in MgP is less than in MCP and MSP.

Ileal and total tract digestibility of energy and nutrients in pig diets supplemented with a novel consensus bacterial 6-phytase variant

An experiment was conducted to test the hypothesis that increasing levels of a novel phytase increases the apparent ileal digestibility (AID) and apparent total tract digestibility (ATTD) of nutrients in diets fed to young pigs. A negative control (NC) diet based on corn, soybean meal, and canola meal that contained approximately 0.83% phytate (i.e., 0.23% phytate-bound P) was formulated to be deficient in Ca, P, and standardized ileal digestible amino acids (AA). Five additional diets were formulated by adding 250, 500, 1,000, 2,000, or 4,000 phytase units/kg of the novel phytase to the NC diets. Eighteen ileal-cannulated pigs (17.81 ± 1.71 kg) were allotted to a 6 × 3 incomplete Latin square design with six diets and three 11-day periods. There were three pigs per diet in each period; therefore, there were nine replicate pigs per diet. The initial 5 d of each period was considered an adaptation period to the diet. For each period, fecal samples were collected via anal stimulation on days 6, 7, 8, and 9, whereas ileal digesta were collected on days 10 and 11 using standard procedures. Results indicated that the AID of crude protein, indispensable AA, and dispensable AA was increased (quadratic, P < 0.05) as the concentration of microbial phytase increased in the diets. Dietary inclusion of the novel phytase at 1,000 or 2,000 FTU/kg increased the AID of total AA from 73.7% to 79.8%. Increasing levels of microbial phytase increased (quadratic, P < 0.05) the AID of dry matter and minerals (i.e., Ca, P, K, Mg, Cu) in the diets. Likewise, a linear increase (P < 0.05) in the AID of ash and Na was observed as the inclusion level of phytase increased in the diets. Increasing levels of microbial phytase increased (linear, P < 0.01) the AID of gross energy (GE) and starch in the diets. A quadratic (P < 0.05) increase in the ATTD of ash, Ca, P, K, and Cu in experimental diets was observed as the concentration of microbial phytase increased in the diets. The ATTD of Mg and GE also increased (linear; P < 0.05) as concentration of dietary phytase increased. In conclusion, the novel microbial phytase used in this experiment was effective in increasing the AID of dry matter, GE, starch, minerals, and AA, as well as the ATTD of gross energy and minerals in diets formulated to be deficient in Ca, P, and AA.

Microbial phytase reduces basal endogenous loss of calcium in pigs fed diets containing phytate phosphorus at commercial levels

The objective of this experiment was to test the hypothesis that increasing dietary phytase reduces basal endogenous loss of Ca and increases P balance in pigs. Seventy barrows (initial body weight: 17.66 ± 1.69 kg) were allotted to seven Ca-free diets using a randomized complete block design with two blocks and five pigs per diet in each block. All diets were based on corn, potato protein concentrate, and full-fat rice bran. A positive control (PC) diet was formulated to contain P at the requirement for standardized total tract digestible (STTD) P by 11 to 25 kg pigs. Six negative control (NC) diets were formulated by reducing the provision of digestible P by 0.15% and adding 0, 250, 500, 1,000, 2,000, or 4,000 phytase units/kg diet. Pigs were housed individually in metabolism crates that allowed for total, but separate, collection of urine and feces. Daily feed allowance was 3.0 times the maintenance requirement for metabolizable energy and was divided into two equal meals. Diets were fed for 12 d with the first 5 d considered the adaptation period. Urine collections started on day 6 in the morning and ceased on day 10 in the morning. Fecal markers were also included in the morning meals on day 6 and day 10 and feces were collected according to the marker-to-marker procedure. Results indicated that the apparent total tract digestibility of dry matter was not affected by dietary P or phytase levels. The basal endogenous loss of Ca was not affected by dietary P, but exponentially decreased (P = 0.030) as phytase level increased in the diets. Phosphorus retention (g/d) and standardized total tract digestibility of phosphorus were greater (P < 0.05) in pigs fed the PC diet compared with pigs fed the NC diet with no phytase. The STTD of P exponentially (P < 0.001) increased as phytase level increased in the diets, but because of the lack of Ca, retention of P (% of absorbed) linearly decreased (P = 0.006) as phytase increased. In conclusion, basal endogenous loss of Ca decreased as dietary phytase increased demonstrating that endogenous Ca can be bound to phytate in the intestinal tract of pigs. However, STTD of P increased as phytase level in the diets increased.

Effects of 25-hydroxycholecalciferol (25-OH-D3) and 1-hydroxycholecalciferol (1-OH-D3) on serum bone biomarkers and calcium and phosphorus balance and concentrations of energy in diets without or with microbial phytase fed to sows in late gestation

The objective was to test the hypothesis that supplementation of diets for gestating sows with 25-hydroxycholecalciferol (25-OH-D3) or 1-hydroxycholecalciferol (1-OH-D3) affects serum biomarkers for bone and increases Ca and P balance and the apparent total tract digestibility (ATTD) of gross energy (GE), and the concentrations of digestible energy (DE) and metabolizable energy (ME) in diets without or with microbial phytase. Sixty multiparous sows were allotted to 1 of 6 diets. Diets were formulated using a 3 × 2 factorial with 3 inclusions of supplemental vitamin D metabolite (no metabolite, 25-OH-D3, or 1-OH-D3) and 2 inclusion levels of microbial phytase (0 or 1,000 units). Sows were housed individually in metabolism crates and feces and urine were collected quantitatively. Results indicated that there was no difference in the ATTD of dry matter (DM) and GE and concentration of DE among the 3 diets containing microbial phytase, but the ATTD of DM and GE and concentration of DE was greater (P < 0.05) in diets containing 1-OH-D3 compared with the diet without a vitamin D metabolite if phytase was not used (interaction; P < 0.05). In diets without microbial phytase, ME was greater in diets containing either one of the 2 vitamin D metabolites than in the diet without a vitamin D metabolite, but among diets with microbial phytase, the ME of the 1-OH-D3 diet was less than of the 25-OH-D3 diet (interaction; P < 0.05). No effect of microbial phytase on concentrations of DE and ME was observed. There was no interaction between supplementation of microbial phytase and vitamin D metabolites for Ca and P balances, and regardless of metabolite supplementation, use of microbial phytase increased (P < 0.05) the ATTD and retention of Ca and P. Regardless of dietary phytase, the ATTD and retention of Ca and P increased (P < 0.05) for sows fed a diet containing one of the vitamin D metabolites compared with sows fed the diet without a vitamin D metabolite. Serum biomarkers for bone resorption or bone tissue synthesis were not affected by experimental diets. In conclusion, the ATTD of DM and GE, concentrations of DE and ME, and Ca and P balance in phytase-free diets fed to sows in late gestation were increased by supplementation with 1-OH-D3 or 25-OH-D3, but no differences between the 2 vitamin D metabolites were observed. Supplementation of diets with microbial phytase increased Ca and P balance, but did not affect DE and ME of diets.

The impact of dietary calcium content on phosphorus absorption and retention in growing pigs is enhanced by dietary microbial phytase supplementation

Sixty growing male pigs were used to test the hypothesis that high dietary Ca content reduces P absorption to a greater extent in microbial phytase-supplemented diets via reducing inositol phosphate (IP) degradation and enhancing P precipitation. Pigs were equally allotted over diets with three Ca contents 2·0, 5·8 and 9·6 g/kg with or without microbial phytase (0 v. 500 FTU/kg) in a 2 × 3 factorial arrangement. Faeces and urine were collected at the end of the 21-d experimental period. Subsequently, pigs were euthanised and digesta quantitatively collected from different gastrointestinal tract (GIT) segments. Increasing dietary Ca content reduced apparent P digestibility in all GIT segments posterior to the stomach (P < 0·001), with greater effect in phytase-supplemented diets in the distal small intestine (Pinteraction = 0·007) and total tract (Pinteraction = 0·023). Nonetheless, increasing dietary Ca to 5·8 g/kg enhanced P retention, but only in phytase-supplemented diets. Ileal IP6 degradation increased with phytase (P < 0·001) but decreased with increasing dietary Ca content (P = 0·014). Proportion of IP esters in total IP (∑IP) indicated that IP6/∑IP was increased while IP4/∑IP and IP3/∑IP were reduced with increasing dietary Ca content and also with a greater impact in phytase-supplemented diets (Pinteraction = 0·025, 0·018 and 0·009, respectively). In all GIT segments, P solubility was increased with phytase (P < 0·001) and tended to be reduced with dietary Ca content (P < 0·096). Measurements in GIT segments showed that increasing dietary Ca content reduced apparent P digestibility via reducing IP degradation and enhancing P precipitation, with a greater impact in phytase-supplemented diets due to reduced IP degradation.

Quantities of ash, Ca, and P in metacarpals, metatarsals, and tibia are better correlated with total body bone ash in growing pigs than ash, Ca, and P in other bones

The objective was to determine correlations between individual bones and total body bone ash to identify the bone that is most representative of total body bone ash in growing pigs. Twenty growing pigs were allotted to 1 of 2 diets that were formulated to contain 60% or 100% of the requirement for standardized total tract digestible (STTD) P. Both diets had an STTD Ca to STTD P ratio of 1.90:1. Growth performance and carcass weights were determined. Metacarpals, metatarsals, femur, tibia, fibula, 3rd and 4th ribs, and 10th and 11th ribs, and all other bones from the left half of the carcass were collected separately. Each bone was defatted and ashed. Pigs fed the diet containing 100% of required Ca and P had greater (P < 0.05) average daily gain, gain to feed, and ash concentration (%) in total and all individual bones except femur and fibula compared with pigs fed the diet containing 60% of required Ca and P. Calcium and P concentrations in bone ash were not affected by dietary treatments. Weights (g) of bone ash, bone Ca, and bone P were greater (P < 0.05) or tended to be greater (P < 0.10) for pigs fed the diet containing 100% of required Ca and P. Correlation coefficients between the weight of ashed metacarpals, metatarsals, and tibia and the weight of total bone ash were >0.95. In conclusion, metacarpals, metatarsals, and tibia were more representative of total body bone ash compared with other bones.

Formulation of diets for pigs based on a ratio between digestible calcium and digestible phosphorus results in reduced excretion of calcium in urine without affecting retention of calcium and phosphorus compared with formulation based on values for total calcium

An experiment was conducted to test the hypothesis that formulating diets for pigs based on a ratio between standardized total tract digestible (STTD) Ca and STTD P instead of total Ca and STTD P does not decrease Ca retention, but increases P utilization. Forty barrows (59.4 ± 3.8 kg) were individually housed in metabolism crates and allotted to four corn-soybean meal-based diets in a randomized complete block design with two blocks and five pigs per diet in each block. Diets were formulated using a 2 × 2 factorial design with two diet formulation principles (total Ca or STTD Ca) and two inclusion levels of microbial phytase (0 or 500 units per kg of feed). Phytase was assumed to release 0.11% STTD P and 0.16% total Ca. Diets were formulated based on requirements for total Ca and STTD P or a ratio between STTD Ca and STTD P of 1.25:1. Diets were fed for 11 d and fecal and urine samples were collected from feed provided from day 6 to day 10. Interactions (P < 0.05) between diet formulation principle and phytase level were observed for Ca intake, Ca in feces, Ca absorbed, Ca retained, P digestibility, P absorbed, and P in urine. Phytase increased (P < 0.05) the digestibility of Ca in both total Ca and STTD Ca diets. Without phytase, Ca intake, Ca in feces, and Ca absorbed was greater (P < 0.05) from pigs fed total Ca diets than from pigs fed STTD Ca diets, but P absorbed, P digestibility, and P in urine was greater (P < 0.05) from pigs fed STTD Ca diets than from pigs fed total Ca diets. However, in the presence of phytase, no differences between diet formulation principles were observed in these variables. Regardless of phytase, Ca in urine was lower (P < 0.05) from pigs fed STTD Ca diets than from pigs fed total Ca diets. There were no differences in Ca retention between pigs fed STTD Ca diets and total Ca diets, but pigs fed total Ca diets retained less (P < 0.05) Ca if diets contained phytase. No differences in P retention were observed between diet formulation principles, but pigs fed non-phytase diets retained more (P < 0.05) P than pigs fed diets with phytase. In conclusion, because diets formulated based on STTD Ca contain less Ca than total Ca diets, pigs fed STTD Ca diets excreted less Ca in urine, but retention of Ca was not affected. Formulating non-phytase diets based on STTD Ca instead of total Ca increased P absorption, which confirms the detrimental effect of excess Ca on P digestibility. However, P retention was not improved if pigs were fed STTD Ca diets.

Formulating diets based on digestible calcium instead of total calcium does not affect growth performance or carcass characteristics, but microbial phytase ameliorates bone resorption caused by low calcium in diets fed to pigs from 11 to 130 kg

An experiment was conducted to test the hypothesis that the requirement for Ca expressed as a ratio between standardized total tract digestible (STTD) Ca and STTD P obtained in short-term experiments may be applied to pigs fed diets without or with microbial phytase from 11 to 130 kg. In a 5-phase program, 160 pigs (body weight: 11.2 ± 1.8 kg) were randomly allotted to 32 pens and 4 corn-soybean meal-based diets in a 2 × 2 factorial design with 2 diet formulation principles (total Ca or STTD Ca), and 2 phytase inclusion levels (0 or 500 units/kg of feed) assuming phytase released 0.11% STTD P and 0.16% total Ca. The STTD Ca:STTD P ratios were 1.40:1, 1.35:1, 1.25:1, 1.18:1, and 1.10:1 for phases 1 to 5, and STTD P was at the requirement. Weights of pigs and feed left in feeders were recorded at the end of each phase. At the conclusion of phase 1 (day 24), 1 pig per pen was euthanized and a blood sample and the right femur were collected. At the end of phases 2 to 5, a blood sample was collected from the same pig in each pen. At the conclusion of the experiment (day 126), the right femur of 1 pig per pen was collected and carcass characteristics from this pig were measured. No interactions were observed between diet formulation principle and phytase inclusion for growth performance in any phase and no differences among treatments were observed for overall growth performance. Plasma Ca and P and bone ash at the end of phase 1 were also not influenced by dietary treatments. However, on day 126, pigs fed nonphytase diets formulated based on total Ca had greater bone ash than pigs fed STTD Ca-based diets, but if phytase was used, no differences were observed between the 2 formulation principles (interaction P < 0.05). At the end of phases 2 and 3, pigs fed diets without phytase had greater (P < 0.05) plasma P than pigs fed diets with phytase, but no differences were observed at the end of phases 4 and 5. A negative quadratic effect (P < 0.05) of phase (2 to 5) on the concentration of plasma Ca was observed, whereas plasma P increased (quadratic; P < 0.05) from phases 2 to 5. However, there was no interaction or effect of diet formulation principle or phytase inclusion on any carcass characteristics measured. In conclusion, STTD Ca to STTD P ratios can be used in diet formulation for growing-finishing pigs without affecting growth performance or carcass characteristics and phytase inclusion ameliorates bone resorption caused by low dietary Ca and P.

A new source of high-protein distillers dried grains with solubles (DDGS) has greater digestibility of amino acids and energy, but less digestibility of phosphorus, than de-oiled DDGS when fed to growing pigs

AbstractThree experiments were conducted to test the hypothesis that standardized ileal digestibility (SID) of amino acids (AA), concentration of metabolizable (ME), and standardized total tract digestibility (STTD) of P in a new source of distillers dried grains with solubles (DDGS; ProCap DDGS) are greater than in conventional de-oiled DDGS. In experiment 1, nine barrows (initial BW: 67.2 ± 6.4 kg) with a T-cannula in the distal ileum were allotted to a triplicated 3 × 3 Latin square design with three diets and three periods for a total of nine replicate pigs per diet. Two diets included ProCap DDGS or de-oiled DDGS as the sole source of crude protein (CP) and AA. An N-free diet was used to determine the basal endogenous losses of CP and AA. Ileal digesta were collected on days 5 and 6 of each period after 4 d of adaptation to diets. Results from experiment 1 indicated that ProCap DDGS contained more CP and AA compared with de-oiled DDGS. The SID of all AA in ProCap DDGS was greater (P < 0.001) compared with de-oiled DDGS with the exception that the SID of Pro was not different between the two sources of DDGS. In experiment 2, 24 growing barrows (initial BW: 32.7 ± 3.1 kg) were housed individually in metabolism crates and used in a randomized complete block design and fed a corn-based diet or two diets containing corn and each source of DDGS with eight replicate pigs per diet. Fecal and urine samples were collected for 4 d after 7 d of adaptation. Results from experiment 2 indicated that concentration of ME in ProCap DDGS was greater (P < 0.05) compared with corn or de-oiled DDGS. In experiment 3, 32 growing barrows (initial BW: 20.2 ± 0.9 kg) were placed in metabolism crates and allotted to four diets with eight pigs per diet using a 2 × 2 factorial treatment arrangement. The de-oiled DDGS and ProCap DDGS were both included in a diet without microbial phytase and a diet with microbial phytase (500 units/kg diet). Pigs were adapted to the diets for 5 d and fecal samples were collected for 4 d. Results from experiment 3 indicated that inclusion of phytase in the diet containing ProCap DDGS increased (P < 0.05) the STTD of P, but addition of phytase to the de-oiled DDGS diet did not increase STTD of P (interaction, P < 0.001), but the STTD of P was greater (P < 0.05) in de-oiled DDGS compared with ProCap DDGS. In conclusion, ProCap DDGS has greater SID of AA and contains more ME, but has reduced STTD of P compared with conventional de-oiled DDGS.

Intrinsic phytase in hybrid rye increases the digestibility of phosphorus in corn and soybean meal in diets fed to growing pigs

An experiment was conducted to test the hypothesis that inclusion of hybrid rye in diets containing corn and soybean meal (SBM) without or with microbial phytase improves the apparent total tract digestibility (ATTD) and the standardized total tract digestibility (STTD) of P because of the intrinsic phytase activity in hybrid rye. Forty-eight growing barrows (initial body weight: 39.5 ± 7.7 kg) were allotted to six diets. A basal diet containing corn and SBM; a rye-based diet; and a diet containing corn, SBM, and rye were formulated. Each diet was formulated without and with microbial phytase (500 units/kg of diet) for a total of six diets. Fecal samples were collected for 4 d following a 5-d adaptation period according to the marker-to-marker procedure. Results indicated that no interactions between diets and concentration of phytase were observed for any of the response criteria measured. The ATTD and STTD of P and the ATTD of Ca differed (P < 0.05) among diets, but regardless of diet, the concentration of P in feces was reduced (P < 0.05) by adding microbial phytase to the diets. As a consequence, microbial phytase increased (P < 0.05) ATTD and STTD of P, and the ATTD of Ca was also increased (P < 0.05) by the use of microbial phytase. Measured values for the ATTD and STTD of P in the diets containing corn, SBM, and hybrid rye without or with phytase were greater (P < 0.05) than values that were predicted based on the ATTD and STTD of P for the corn-SBM and the hybrid rye diet. The observation that STTD predicted from the individual ingredients underestimated the STTD of P in the mixed diet indicates that the intrinsic phytase in hybrid rye resulted in increased digestibility of the P in the corn and SBM included in the corn-SBM-hybrid rye diet. In conclusion, microbial phytase increased the ATTD and STTD of P and the ATTD of Ca regardless of feed ingredients used in diets fed to pigs. In addition, the intrinsic phytase from hybrid rye increased the ATTD and STTD of P in corn and SBM.

Increasing calcium from deficient to adequate concentration in diets for gestating sows decreases digestibility of phosphorus and reduces serum concentration of a bone resorption biomarker

The objective of this experiment was to test the hypothesis that the concentration of Ca in diets fed to late gestating sows affects the apparent total tract digestibility (ATTD) and retention of Ca and P, serum concentrations of Ca and P, hormones, and blood biomarkers for bone formation and resorption. Thirty-six sows (average parity = 2.8) were housed in metabolism crates from day 91 to day 104 of gestation and fed 1 of 4 experimental diets containing 25, 50, 75, or 100% of the requirement for Ca. All diets met the requirement for P. The initial 5 d of each period were the adaptation period, which was followed by 4 d of quantitative collection of feces and urine. At the end of the collection period, a blood sample was collected from all sows. Results indicated that feed intake, weights of dried fecal and urine samples, and the ATTD of DM were not affected by dietary Ca, but ATTD of Ca increased (quadratic, P < 0.05) as Ca in diets increased. Urine Ca output was not affected by dietary Ca, but Ca retention increased (quadratic, P < 0.05) as Ca intake increased. Fecal P output increased (linear, P < 0.001) as dietary Ca increased, which resulted in a linear decrease (P < 0.001) in the ATTD of P. Urine P output also decreased (linear, P < 0.001) as dietary Ca increased, but P retention increased (linear, P < 0.05). Regressing the apparent total tract digestible Ca against dietary Ca intake resulted in a regression line with a slope of 0.33, indicating that true total tract digestibility of Ca in calcium carbonate was 33%. Serum concentrations of Ca and P and estrogen, calcitonin, and parathyroid hormone were not affected by dietary Ca. Serum concentration of carboxyterminal cross-linked telopeptide of type I collagen (CTX-I) decreased (linear, P < 0.05) as dietary Ca increased, which is a result of reduced bone resorption as dietary Ca increased. Serum bone-specific alkaline phosphatase tended to decrease (linear, P < 0.10) as Ca in diets increased, but the concentration of osteocalcin (OC) in serum was not affected by dietary Ca. The ratio between OC and CTX-I tended to increase (P < 0.10) as dietary Ca increased, which indicated that there was more bone formation than resorption in sows as dietary Ca increased. In conclusion, P digestibility in late gestating sows decreased, but retention of P increased, as dietary Ca increased from inadequate to adequate levels and blood biomarkers for bone resorption changed as Ca and P retention increased.

Nutritional evaluation of different varieties of sorghum and the effects on nursery pig growth performance

Five experiments were conducted to determine the standardized total tract digestibility (STTD) of P, digestible energy (DE), metabolizable energy (ME), and standardized ileal digestibility (SID) of amino acids (AA) in three sorghum varieties compared with corn and to determine the effects of sorghum varieties on nursery pig growth. In exp. 1, 48 barrows (initially 18.6 kg) were housed individually in metabolism crates. Treatments were arranged in a 2 × 4 factorial evaluating two levels of microbial phytase (0 or 500 units/kg) and four grain sources (corn, high-lysine, red, or white sorghum). Added phytase improved (P < 0.05) STTD of P in all ingredients, but was not different among the grains. In exp. 2, the DE and ME in the three sorghum varieties were not different from corn. In exp. 3, 10 growing barrows (initially 25.9 kg) with a T-cannula in the terminal ileum were used. Standardized ileal digestible Lys, Met, Thr, and Val were greater (P < 0.05) in corn than in the sorghum-based diets with no differences among the sorghum varieties. In exp. 4, 160 pigs (initially 6.3 kg) were randomly allotted to one of four dietary treatments with five pigs per pen and eight replicate pens per treatment in a 20-d experiment. Dietary treatments included corn or the three sorghum varieties, where the varieties of sorghum replaced corn on an SID Lys basis. No differences among treatments were observed in any growth performance parameters. In exp. 5, treatments consisted of a corn-based diet, a diet based on conventional sorghum (a mixture of red and white sorghum), and four diets with high-lysine sorghum containing increasing amounts of feed-grade AA, replacing soybean meal. Overall, pigs fed the high-lysine sorghum diet with the greatest amount of added feed-grade AA had the poorest gain:feed ratio (G:F; P < 0.05) compared with pigs fed all the other experimental diets. Within those fed the high-lysine sorghum and feed-grade AA, average daily gain, final body weight (linear, P < 0.10), and G:F (linear, P < 0.01) decreased as feed-grade AA increased. In summary, no differences in STTD of P or in DE and ME were observed among the grain sources. The SID AA values for the three sorghum varieties were not different; however, they were all lower than for corn. These results indicate that these varieties of sorghum can successfully replace corn in nursery pig diets if diets are formulated to account for differences in AA digestibility.

Effect of dietary supplementation of xylanase in a wheat-based diet containing canola meal on growth performance, nutrient digestibility, organ weight, and short-chain fatty acid concentration in digesta when fed to weaned pigs

This study was designed to determine the effect of dietary supplementation of xylanase on growth performance, nutrient digestibility, organ weight, digesta pH, and concentration of short-chain fatty acids (SCFA) of weaned pigs fed wheat-canola meal (CM) diets over a 35-d period. A total of 144 piglets (72 barrows and 72 gilts) weaned at 18 ± 2 d of age, with initial body weight (BW) of 6.2 ± 0.7 kg, received one of eight dietary treatments based on randomized complete block design. BW and feed intake were recorded weekly to calculate average daily gain (ADG), average daily feed intake (ADFI), and feed efficiency (G:F). Treatments consisted of a control wheat-soybean meal-based diet and wheat-regular (RCM), dehulled (DCM), or coarse CM (CCM) without and with 16,000 BXU/kg xylanase (Econase XT). All diets contained 500 FTU/kg of phytase (Quantum Blue 5G) and titanium dioxide (0.3%). Apparent total tract digestibility (ATTD) of neutral detergent fiber (NDF), crude protein (CP), phosphorous (P), calcium (Ca), dry matter, and diet were determined. On day 35, one pig per pen was euthanized to evaluate the main factors of protein, xylanase supplementation, and sex on organ weight, ileal and colon digesta pH, and colon digesta concentrations of SCFA. The main factors did not affect growth performance. Xylanase supplementation improved nutrient digestibilities in all diets and increased ileal and colonic digesta pH without affecting the growth performance of weaned pigs fed wheat and CM-based diets. A protein-xylanase effect (P < 0.05) resulted in increasing the ATTD of NDF from 28% to 32% and from 29% to 37% for RCM and DCM, respectively. The ATTD of CP was greater (P < 0.05) with xylanase supplementation (75% vs. 70%). Xylanase supplementation increased ATTD of P and Ca. A three-way interaction (P < 0.05) for protein-xylanase-gender for colon pH, acetic, and propionic acid in the colon digesta of pigs indicated that, in addition to the protein source, piglet sex could have influenced how xylanase works. Xylanase supplementation increased (P < 0.05) the weight of the liver and spleen and tended (P < 0.10) to increase the size of the kidney. In conclusion, dietary supplementation of xylanase increased nutrient digestibility and digesta pH but did not influence the growth performance of weaned pigs fed wheat and CM-based diets over a 35-d period.