1
|
Ran C, Zhou X, Liu K. Insights into the mechanisms of plasma physicochemical characteristics on ultralong-lasting plasma-activated water: the influence of DC power polarity on RONS generation. Phys Chem Chem Phys 2024; 26:18408-18417. [PMID: 38913406 DOI: 10.1039/d4cp00384e] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 06/25/2024]
Abstract
In our recent work, we successfully developed an innovative method based on pin-water discharge for preparing ultralong-lasting plasma-activated water (PAW) with a lifetime of up to 720 hours at room temperature. However, the impact of power polarity on the preparation method for ultralong-lasting PAW remains unclear. In this study, we discovered that ultralong-lasting PAW could only be achieved with positive polarity. Further analysis of the liquid reactive oxygen and nitrogen species (RONS) revealed that the absence of H2O2 in the discharge chamber was crucial for the failure of ultralong-lasting PAW preparation at negative polarity. To elucidate the mechanism underlying the generation of RONS at different polarities, we conducted plasma feature diagnosis, compared discharge morphologies, and performed theoretical analyses based on chemical reactions. Our results indicated that the introduction of water vapor molecules through intense spraying at positive polarity led to an increase in the generation of H2O2-related source particles, while also interfering with N2-related electron collision reactions and chemical reaction coefficients, ultimately affecting the production of NO2-. Consequently, there was relatively less liquid NO2- and more abundant H2O2 in the discharge chamber at positive polarity, whereas the opposite trend was observed for these two key RONS at negative polarity. Furthermore, the minimal amount of NO2- at positive polarity and the tiny amount of H2O2 at negative polarity in the discharge chamber would be respectively consumed by the relatively abundant H2O2 at positive polarity and NO2- at negative polarity.
Collapse
Affiliation(s)
- Congfu Ran
- State Key Laboratory of Power Transmission Equipment Technology, School of Electrical Engineering, Chongqing University, Chongqing 400044, People's Republic of China.
| | - Xiongfeng Zhou
- State Key Laboratory of Power Transmission Equipment Technology, School of Electrical Engineering, Chongqing University, Chongqing 400044, People's Republic of China.
| | - Kun Liu
- State Key Laboratory of Power Transmission Equipment Technology, School of Electrical Engineering, Chongqing University, Chongqing 400044, People's Republic of China.
| |
Collapse
|
2
|
Song JS, Jung S. The pH acidity and nitrate accumulation by plasma discharge enhanced the growth and phytochemicals of soybean sprouts grown in reused water. Food Chem X 2024; 22:101345. [PMID: 38623501 PMCID: PMC11016968 DOI: 10.1016/j.fochx.2024.101345] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/16/2023] [Revised: 03/26/2024] [Accepted: 03/31/2024] [Indexed: 04/17/2024] Open
Abstract
This study investigated the effect of plasma treatment on reused water and evaluated the interactions of the plasma-treated water (PTW) with plants or microbes to determine the optimal PTW for reuse. The repeated treatment gradually accumulated nitrate (NO3-) in the PTW and lowered its pH; afterward, it led to the sprouted soybeans accumulating other inorganic ions in the PTW. The biomass of soybean sprouts was enhanced by the accumulated NO3- but decreased due to the pH effect. Meanwhile, the acidic pH reduced the microbial counts, but they increased after sprinkling the PTW over the sprouts. The optimal PTW in our study, which had a gradual increase of NO3- (≤321.8 mg·L-1) with an acceptable pH (≥pH 3), significantly enhanced the biomass by 4.2% compared to the untreated control. Additionally, it increased the total content of amino acids and isoflavones by 9% and 18% in the growing part, respectively.
Collapse
Affiliation(s)
- Jong-Seok Song
- Institute of Plasma Technology, Korea Institute of Fusion Energy, 37 Dongjangsan-ro, Gunsan, 54004, Republic of Korea
- Department of Plasma and Nuclear Fusion, UST-KFE School, 169-148 Gwahak-ro, Yuseong-gu, Daejeon 34133, Republic of Korea
| | - Sunkyung Jung
- Institute of Plasma Technology, Korea Institute of Fusion Energy, 37 Dongjangsan-ro, Gunsan, 54004, Republic of Korea
| |
Collapse
|
3
|
Du MR, Guo YY, Wei HZ, Zhu YP, Liu RR, Ma RN, Shi FK, Guo JS, Zhuang J. The effectiveness of gliding arc discharge plasma in sterilizing artificial seawater contaminated with Vibrio parahaemolyticus. JOURNAL OF HAZARDOUS MATERIALS 2024; 476:135015. [PMID: 38943886 DOI: 10.1016/j.jhazmat.2024.135015] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/23/2024] [Revised: 06/19/2024] [Accepted: 06/22/2024] [Indexed: 07/01/2024]
Abstract
The rapid proliferation of the halophilic pathogen Vibrio parahaemolyticus poses a severe health hazard to halobios and significantly impedes intensive mariculture. This study aimed to evaluate the potential application of gliding arc discharge plasma (GADP) to control the infection of Vibrio parahaemolyticus in mariculture. This study investigated the inactivation ability of GADP against Vibrio parahaemolyticus in artificial seawater (ASW), changes in the water quality of GADP-treated ASW, and possible inactivation mechanisms of GADP against Vibrio parahaemolyticus in ASW. The results indicate that GADP effectively inactivated Vibrio parahaemolyticus in ASW. As the volume of ASW increased, the time required for GADP sterilization also increased. However, the complete sterilization of 5000 mL of ASW containing Vibrio parahaemolyticus of approximately 1.0 × 104 CFU/mL was achieved within 20 min. Water quality tests of the GADP-treated ASW demonstrated that there were no significant changes in salinity or temperature when Vibrio parahaemolyticus (1.0 ×104 CFU/mL) was completely inactivated. In contrast to the acidification observed in plasma-activated water (PAW) in most studies, the pH of ASW did not decrease after treatment with GADP. The H2O2 concentration in the GADP-treated ASW decreased after post-treatment. The NO2-concentration in the GADP-treated ASW remained unchanged after post-treatment. Further analysis revealed that GADP induced oxidative stress in Vibrio parahaemolyticus, which increased cell membrane permeability and intracellular ROS levels of Vibrio parahaemolyticus. This study provides a viable solution for infection with the halophilic pathogen Vibrio parahaemolyticus and demonstrates the potential of GADP in mariculture.
Collapse
Affiliation(s)
- Meng-Ru Du
- School of Biomedical Engineering (Suzhou), Division of Life Sciences and Medicine, University of Sciences and Technology of China, Suzhou 215163, China; Suzhou Institute of Biomedical Engineering and Technology, Chinese Academy of Science, Suzhou 215163, China
| | - Yu-Yi Guo
- School of Biomedical Engineering (Suzhou), Division of Life Sciences and Medicine, University of Sciences and Technology of China, Suzhou 215163, China; Suzhou Institute of Biomedical Engineering and Technology, Chinese Academy of Science, Suzhou 215163, China
| | - Han-Ze Wei
- School of Biomedical Engineering (Suzhou), Division of Life Sciences and Medicine, University of Sciences and Technology of China, Suzhou 215163, China; Suzhou Institute of Biomedical Engineering and Technology, Chinese Academy of Science, Suzhou 215163, China
| | - Yu-Pan Zhu
- Henan Key Laboratory of Ion-beam Bioengineering, School of Agricultural Sciences, Zhengzhou University, Zhengzhou 450052, China
| | - Rong-Rong Liu
- School of Biomedical Engineering (Suzhou), Division of Life Sciences and Medicine, University of Sciences and Technology of China, Suzhou 215163, China; Suzhou Institute of Biomedical Engineering and Technology, Chinese Academy of Science, Suzhou 215163, China
| | - Ruo-Nan Ma
- Henan Key Laboratory of Ion-beam Bioengineering, School of Agricultural Sciences, Zhengzhou University, Zhengzhou 450052, China
| | - Fu-Kun Shi
- School of Biomedical Engineering (Suzhou), Division of Life Sciences and Medicine, University of Sciences and Technology of China, Suzhou 215163, China; Suzhou Institute of Biomedical Engineering and Technology, Chinese Academy of Science, Suzhou 215163, China.
| | - Jin-Song Guo
- School of Biomedical Engineering (Suzhou), Division of Life Sciences and Medicine, University of Sciences and Technology of China, Suzhou 215163, China; Suzhou Institute of Biomedical Engineering and Technology, Chinese Academy of Science, Suzhou 215163, China.
| | - Jie Zhuang
- School of Biomedical Engineering (Suzhou), Division of Life Sciences and Medicine, University of Sciences and Technology of China, Suzhou 215163, China; Suzhou Institute of Biomedical Engineering and Technology, Chinese Academy of Science, Suzhou 215163, China.
| |
Collapse
|
4
|
Zou F, Shinali TS, Yang M, Zhong Y, Wu J, Wang L, Wang H. Incorporation of ascorbic acid in chitosan-based coating combined with plasma-activated water: A technology for quality preservation of red grapes after simulated transportation. Int J Biol Macromol 2024; 270:132366. [PMID: 38759852 DOI: 10.1016/j.ijbiomac.2024.132366] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/14/2023] [Revised: 05/10/2024] [Accepted: 05/12/2024] [Indexed: 05/19/2024]
Abstract
Red grapes possess multiple bioactivities but are highly susceptible to spoilage due to the lack of efficient preservation techniques. Plasma-activated water (PAW) treatment and the incorporation of antioxidants in bio-based coatings are promising methods for preserving produce. In this study, we tested a novel combination by incorporating ascorbic acid (AA) into a chitosan-based edible coating (CH) and combining it with plasma-activated water (PAW) treatment (CA-PAW) before simulating transport vibrations to extend the shelf-life of red grapes. The results from storage at 4 °C for 20 d indicated that the CA-PAW treatment reduced microbial counts by 2.62 log10 CFU/g for bacteria, 1.72 log10 CFU/g for yeasts and molds, and 1.1 log10 CFU/g for coliforms, in comparison to the control group treated with sterile deionized water. Total phenols and total flavonoid content were the highest observed, at 111.2 mg GAE/100 g and 262.67 mg RE/100 g, respectively. This treatment also inhibited water migration and erosion, and reduced damage to cell structure. Microstructural observations revealed that the CH coating on the surface of red grapes diminished the degradation of bioactive components. In conclusion, the CA-PAW treatment effectively inhibited the adverse physiological changes caused by vibration and mechanical damage to red grapes, maintained their nutritional and sensory qualities, and extended the shelf life by at least 8 d.
Collapse
Affiliation(s)
- Fanglei Zou
- College of Engineering, China Agricultural University, Beijing 100083, China
| | - Tharushi S Shinali
- College of Engineering, China Agricultural University, Beijing 100083, China
| | - Miao Yang
- College of Engineering, China Agricultural University, Beijing 100083, China
| | - Yuanliang Zhong
- College of Engineering, China Agricultural University, Beijing 100083, China
| | - Junhua Wu
- College of Engineering, China Agricultural University, Beijing 100083, China
| | - Liangju Wang
- College of Engineering, China Agricultural University, Beijing 100083, China
| | - Hongying Wang
- College of Engineering, China Agricultural University, Beijing 100083, China.
| |
Collapse
|
5
|
Suwannarat S, Tephiruk N, Sunan S, Ruangwong K, Srisonphan S. Disinfection Efficacy of Electrohydraulic Discharge Plasma against Xanthomonas campestris pv campestris: A Sustainable Seed Treatment Approach. ACS APPLIED BIO MATERIALS 2024; 7:1469-1477. [PMID: 38231151 PMCID: PMC11080453 DOI: 10.1021/acsabm.3c00862] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/25/2023] [Revised: 01/02/2024] [Accepted: 01/07/2024] [Indexed: 01/18/2024]
Abstract
The prevalence of plant diseases caused by pathogens such as Xanthomonas campestris pv campestris (Xcc) poses a significant challenge to sustainable agriculture, necessitating the development of effective and eco-friendly disinfection methods. In this study, we investigated the efficacy of electrohydraulic discharge plasma (EHDP) as a promising alternative for disinfection against Xcc, a pathogen responsible for black rot in cruciferous vegetables. Unlike conventional gas-phase plasma, EHDP introduces two pivotal components: gas-liquid interface plasma (GLIP) and its consequential byproduct, plasma-activated water (PAW). While GLIP enables dual-phase production of reactive oxygen and nitrogen species (RONS), PAW is a reservoir of liquid-phase long-lived RONS, thereby enhancing its bactericidal efficacy. In our evaluations, we tested EHDP-induced GLIP and EHDP-induced PAW against Xcc cells in both in vitro (Xcc suspension) and in vivo (Xcc-inoculated cabbage seeds) settings, achieving noteworthy results. Within 15 min, these methods eliminated ∼98% of the Xcc cells in suspension. For in vivo assessments, nontreated seeds exhibited an infection rate of 98%. In contrast, both EHDP treatments showed a significant reduction, with ∼60% fewer seeds infected while maintaining ∼90% germination rate. In addition, the liquid-phase RONS in EHDP-PAW may enhance seed vigor with a faster germination rate within the initial 5 days. Remarkably, around 90% of EHDP-PAW-treated seeds yielded healthy seedlings, indicating dual benefits in bacterial suppression and seed growth stimulation. In contrast, the percentage of healthy seedlings from nontreated, Xcc-inoculated seeds was approximately 70%. Our research demonstrates the feasibility of using eco-friendly EHDP in the seed disinfection process.
Collapse
Affiliation(s)
- Sawita Suwannarat
- Department
of Plant Pathology, Faculty of Agriculture, Kasetsart University, 50 Ngam Wong Wan Rd, Ladyaow Chatuchak, Bangkok 10900, Thailand
| | - Naowarat Tephiruk
- Department
of Electrical Engineering, Faculty of Engineering, Kasetsart University, 50 Ngam Wong Wan Rd, Ladyaow Chatuchak, Bangkok 10900, Thailand
| | - Suwanna Sunan
- Department
of Plant Pathology, Faculty of Agriculture, Kasetsart University, 50 Ngam Wong Wan Rd, Ladyaow Chatuchak, Bangkok 10900, Thailand
| | - Khomsan Ruangwong
- Department
of Electrical Engineering, Faculty of Engineering, Kasetsart University, 50 Ngam Wong Wan Rd, Ladyaow Chatuchak, Bangkok 10900, Thailand
| | - Siwapon Srisonphan
- Department
of Electrical Engineering, Faculty of Engineering, Kasetsart University, 50 Ngam Wong Wan Rd, Ladyaow Chatuchak, Bangkok 10900, Thailand
| |
Collapse
|
6
|
Xiong L, Feng L, Nie M, Li D, Zhang Z, Liu C, Dai Z, Xiao Y, Xu Y. Effect of Plasma-Activated Water (PAW) on the Postharvest Quality of Shepherd's Purse ( Capsella bursa-pastoris). Foods 2024; 13:703. [PMID: 38472816 DOI: 10.3390/foods13050703] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/15/2024] [Revised: 02/20/2024] [Accepted: 02/20/2024] [Indexed: 03/14/2024] Open
Abstract
Plasma-activated water (PAW) treatment is an effective technique for the quality retention of fresh vegetables with cold atmospheric plasma using controllable parameters. This study investigated the effect of PAW on the postharvest quality of shepherd's purse (Capsella bursa-pastoris). The results displayed that PAW treatment with an activation time of 5, 10, 15, and 20 min reduced the yellowing rate and weight loss of the shepherd's purse during 9 days of storage. Compared with untreated samples, PAW treatment at different times reduced the number of total bacteria, coliform, yeast, and mold by 0.18-0.94, 0.59-0.97, 0.90-1.18, and 1.03-1.17 Log CFU/g after 9 days of storage, respectively. Additionally, the treatments with PAW-5 and PAW-10 better preserved ascorbic acid, chlorophyll, total phenol, and total flavonoid contents. They also maintained the higher antioxidant and CAT activity and inhibited the formation of terpenes, alcohols, and nitrogen oxide compounds of the shepherd's purse at the end of storage. The microstructural result illustrated that the cells of the shepherd's purse treated with PAW-5 and PAW-10 were relatively intact, with a small intercellular space after storage. This study demonstrated that PAW treatment effectively improved the postharvest quality of shepherd's purse.
Collapse
Affiliation(s)
- Lingming Xiong
- Institute of Agro-Product Processing, Jiangsu Academy of Agricultural Sciences, Nanjing 210014, China
| | - Lei Feng
- Institute of Agro-Product Processing, Jiangsu Academy of Agricultural Sciences, Nanjing 210014, China
| | - Meimei Nie
- Institute of Agro-Product Processing, Jiangsu Academy of Agricultural Sciences, Nanjing 210014, China
| | - Dajing Li
- Institute of Agro-Product Processing, Jiangsu Academy of Agricultural Sciences, Nanjing 210014, China
| | - Zhongyuan Zhang
- Institute of Agro-Product Processing, Jiangsu Academy of Agricultural Sciences, Nanjing 210014, China
| | - Chunquan Liu
- Institute of Agro-Product Processing, Jiangsu Academy of Agricultural Sciences, Nanjing 210014, China
| | - Zhuqing Dai
- Institute of Agro-Product Processing, Jiangsu Academy of Agricultural Sciences, Nanjing 210014, China
| | - Yadong Xiao
- Institute of Agro-Product Processing, Jiangsu Academy of Agricultural Sciences, Nanjing 210014, China
| | - Yayuan Xu
- Institute of Agro-Product Processing, Jiangsu Academy of Agricultural Sciences, Nanjing 210014, China
| |
Collapse
|
7
|
Cheng JH, Du R, Sun DW. Regulating bacterial biofilms in food and biomedicine: unraveling mechanisms and Innovating strategies. Crit Rev Food Sci Nutr 2024:1-17. [PMID: 38384205 DOI: 10.1080/10408398.2024.2312539] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 02/23/2024]
Abstract
Bacterial biofilm has brought a lot of intractable problems in food and biomedicine areas. Conventional biofilm control mainly focuses on inactivation and removal of biofilm. However, with robust construction and enhanced resistance, the established biofilm is extremely difficult to eradicate. According to the mechanism of biofilm development, biofilm formation can be modulated by intervening in the key factors and regulatory systems. Therefore, regulation of biofilm formation has been proposed as an alternative way for effective biofilm control. This review aims to provide insights into the regulation of biofilm formation in food and biomedicine. The underlying mechanisms for early-stage biofilm establishment are summarized based on the key factors and correlated regulatory networks. Recent developments and applications of novel regulatory strategies such as anti/pro-biofilm agents, nanomaterials, functionalized surface materials and physical strategies are also discussed. The current review indicates that these innovative methods have contributed to effective biofilm control in a smart, safe and eco-friendly way. However, standard methodology for regulating biofilm formation in practical use is still missing. As biofilm formation in real-world systems could be far more complicated, further studies and interdisciplinary collaboration are still needed for simulation and experiments in the industry and other open systems.
Collapse
Affiliation(s)
- Jun-Hu Cheng
- School of Food Science and Engineering, South China University of Technology, Guangzhou, China
- Academy of Contemporary Food Engineering, South China University of Technology, Guangzhou Higher Education Mega Centre, Guangzhou, China
- Engineering and Technological Research Centre of Guangdong Province on Intelligent Sensing and Process Control of Cold Chain Foods, & Guangdong Province Engineering Laboratory for Intelligent Cold Chain Logistics Equipment for Agricultural Products, Guangzhou Higher Education Mega Centre, Guangzhou, China
| | - Rong Du
- School of Food Science and Engineering, South China University of Technology, Guangzhou, China
- Academy of Contemporary Food Engineering, South China University of Technology, Guangzhou Higher Education Mega Centre, Guangzhou, China
- Engineering and Technological Research Centre of Guangdong Province on Intelligent Sensing and Process Control of Cold Chain Foods, & Guangdong Province Engineering Laboratory for Intelligent Cold Chain Logistics Equipment for Agricultural Products, Guangzhou Higher Education Mega Centre, Guangzhou, China
| | - Da-Wen Sun
- School of Food Science and Engineering, South China University of Technology, Guangzhou, China
- Academy of Contemporary Food Engineering, South China University of Technology, Guangzhou Higher Education Mega Centre, Guangzhou, China
- Engineering and Technological Research Centre of Guangdong Province on Intelligent Sensing and Process Control of Cold Chain Foods, & Guangdong Province Engineering Laboratory for Intelligent Cold Chain Logistics Equipment for Agricultural Products, Guangzhou Higher Education Mega Centre, Guangzhou, China
- Food Refrigeration and Computerized Food Technology (FRCFT), Agriculture and Food Science Centre, University College Dublin, National University of Ireland, Dublin 4, Ireland
| |
Collapse
|
8
|
Borkar SB, Negi M, Acharya TR, Lamichhane P, Kaushik N, Choi EH, Kaushik NK. Mitigation of T3SS-mediated virulence in waterborne pathogenic bacteria by multi-electrode cylindrical-DBD plasma-generated nitric oxide water. CHEMOSPHERE 2024; 350:140997. [PMID: 38128737 DOI: 10.1016/j.chemosphere.2023.140997] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/13/2023] [Revised: 12/06/2023] [Accepted: 12/18/2023] [Indexed: 12/23/2023]
Abstract
S. enterica, S. flexneri, and V. parahaemolyticus bacteria are globally recognized to cause severe diarrheal diseases, consisting of Type III Secretion System (T3SS) effectors that help in bacterial infection and virulence in host cells. This study investigates the properties of multi-electrode cylindrical DBD plasma-generated nitric oxide water (MCDBD-PG-NOW) treatment on the survival and virulence of S. enterica, S. flexneri, and V. parahaemolyticus bacteria. The Colony Forming Unit (CFU) assay, live/dead cell staining, lipid peroxidation assay, and bacteria morphological analysis showed substantial growth inhibition of bacteria. Moreover, to confirm the interaction of reactive nitrogen species (RNS) with bacterial membrane biotin switch assay, DAF-FM, and FTIR analysis were carried out, which established the formation of S-nitrosothiols in the cell membrane, intracellular accumulation of RNS, and changes in the cell composition post-PG-NOW treatment. Furthermore, the conventional culture-based method and a quantitative PCR using propidium monoazide showed minimal VBNC induction under similar condition. The efficiency of bacteria to adhere to mammalian colon cells was significantly reduced. In addition, the infection rate was also controlled by disrupting the virulent genes, leading to the collapse of the infection mechanism. This study provides insights into whether RNS generated from PG-NOW might be beneficial for preventing diarrheal infections.
Collapse
Affiliation(s)
- Shweta B Borkar
- Department of Electrical and Biological Physics /Plasma Bioscience Research Center, Kwangwoon University, Seoul, 01897, South Korea
| | - Manorma Negi
- Department of Electrical and Biological Physics /Plasma Bioscience Research Center, Kwangwoon University, Seoul, 01897, South Korea
| | - Tirtha Raj Acharya
- Department of Electrical and Biological Physics /Plasma Bioscience Research Center, Kwangwoon University, Seoul, 01897, South Korea
| | - Prajwal Lamichhane
- Department of Electrical and Biological Physics /Plasma Bioscience Research Center, Kwangwoon University, Seoul, 01897, South Korea
| | - Neha Kaushik
- Department of Biotechnology, College of Engineering, The University of Suwon, Hwaseong, 18323, South Korea.
| | - Eun Ha Choi
- Department of Electrical and Biological Physics /Plasma Bioscience Research Center, Kwangwoon University, Seoul, 01897, South Korea.
| | - Nagendra Kumar Kaushik
- Department of Electrical and Biological Physics /Plasma Bioscience Research Center, Kwangwoon University, Seoul, 01897, South Korea.
| |
Collapse
|
9
|
Mozzon M, Foligni R, Mannozzi C, Galdenzi F, Laurita R, Tappi S, Dalla Rosa M. Effect of plasma-activated water (PAW) soaking on the lipid oxidation of sardine (Sardina pilchardus) fillets. Food Res Int 2024; 176:113823. [PMID: 38163686 DOI: 10.1016/j.foodres.2023.113823] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/11/2023] [Revised: 11/25/2023] [Accepted: 12/02/2023] [Indexed: 01/03/2024]
Abstract
The efficacy of plasma-activated water (PAW) as a chemical-free and environmentally friendly preservative has been documented for a variety of foods, but the onset of lipid oxidation induced by plasma-reactive species has been less extensively studied. In this work, global indices (peroxide value, UV specific absorbance) and direct analytical determinations of volatile and non-volatile oxidation products were performed on sardine lipids extracted from fish fillets immersed in PAW (treatments) and distilled water (controls) for 10-30 min. Evidence of PAW-induced lipid oxidation was provided by higher UV specific absorbances and higher levels of C5-C9 secondary volatile oxidation products in the treated samples. However, the degree of fatty acid oxidation was not sufficient to cause a significant reduction in nutritionally valuable eicosapentaenoic acid and docosahexaenoic acid. Twelve cholesterol oxidation products (COPs) were identified in the sardine lipids, but no significant differences in total COPs content were found between PAW processed and control samples.
Collapse
Affiliation(s)
- Massimo Mozzon
- Department of Agricultural, Food and Environmental Sciences (D3A), Università Politecnica delle Marche, Via Brecce Bianche 10, 60131 Ancona, Italy.
| | - Roberta Foligni
- Department of Agricultural, Food and Environmental Sciences (D3A), Università Politecnica delle Marche, Via Brecce Bianche 10, 60131 Ancona, Italy.
| | - Cinzia Mannozzi
- Scuola di Scienze del Farmaco e dei Prodotti della Salute, Università degli Studi di Camerino, Via Madonna delle Carceri, 9, 62032 Camerino, MC, Italy.
| | - Filippo Galdenzi
- Department of Agricultural, Food and Environmental Sciences (D3A), Università Politecnica delle Marche, Via Brecce Bianche 10, 60131 Ancona, Italy.
| | - Romolo Laurita
- Department of Industrial Engineering (DIN), University of Bologna, Via Terracini 24, 40131 Bologna, Italy; Interdepartmental Centre for Industrial Research Health Sciences and Technologies, University of Bologna, Via Zamboni 33, 40136 Bologna, Italy.
| | - Silvia Tappi
- Department of Agricultural and Food Sciences (DISTAL), University of Bologna, Piazza Goidanich 60, 47521 Cesena, Italy; Interdepartmental Centre for Industrial Agrofood Research (CIRI Agrofood), University of Bologna, Via Quinto Bucci 336, 47521 Cesena, Italy.
| | - Marco Dalla Rosa
- Department of Agricultural and Food Sciences (DISTAL), University of Bologna, Piazza Goidanich 60, 47521 Cesena, Italy; Interdepartmental Centre for Industrial Agrofood Research (CIRI Agrofood), University of Bologna, Via Quinto Bucci 336, 47521 Cesena, Italy.
| |
Collapse
|
10
|
Wang J, Cui Y, Zhang M, Wang L, Aihaiti A, Maimaitiyiming R. Pulsed-control plasma-activated water: An emerging technology to assist ultrasound for fresh-cut produce washing. ULTRASONICS SONOCHEMISTRY 2024; 102:106739. [PMID: 38154207 PMCID: PMC10792264 DOI: 10.1016/j.ultsonch.2023.106739] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/19/2023] [Revised: 12/14/2023] [Accepted: 12/18/2023] [Indexed: 12/30/2023]
Abstract
In this study, we explored the use of plasma-activated water (PAW) in combination with ultrasound (US) for food disinfection. Our research introduces a novel approach that utilizes a pulsed-control (PC) method to modify the PAW. The resulting PCPAW exhibits significantly higher concentrations of key reactive oxygen and nitrogen species (RONS) compared to conventional PAW. The disinfection efficacy of US-PCPAW against fresh-cut lettuce was compared to that of US-PAW, US, and PCPAW. The combination of US and PCPAW was highly effective in reducing food-borne pathogens, surpassing single treatments in count reduction and minimizing cross-contamination. Furthermore, our study demonstrates that US-PCPAW effectively controls browning appearance without compromising sensory attributes. These findings suggest that PCPAW, as a novel disinfectant, can be a valuable addition to US to enhance the quality and safety of fresh-cut produce.
Collapse
Affiliation(s)
- Jiayi Wang
- Xinjiang Key Laboratory of Biological Resources and Genetic Engineering, College of Life Science & Technology, Xinjiang University, Urumqi 830046, China; College of Food and Chemical Engineering, Shaoyang University, Shaoyang 422000, China.
| | - Yincang Cui
- Xinjiang Key Laboratory of Biological Resources and Genetic Engineering, College of Life Science & Technology, Xinjiang University, Urumqi 830046, China; Physics and Chemistry Analysis Center, Xinjiang University, Urumqi 830046, China
| | - Minwei Zhang
- Xinjiang Key Laboratory of Biological Resources and Genetic Engineering, College of Life Science & Technology, Xinjiang University, Urumqi 830046, China
| | - Liang Wang
- Xinjiang Key Laboratory of Biological Resources and Genetic Engineering, College of Life Science & Technology, Xinjiang University, Urumqi 830046, China
| | - Aihemaitijiang Aihaiti
- Xinjiang Key Laboratory of Biological Resources and Genetic Engineering, College of Life Science & Technology, Xinjiang University, Urumqi 830046, China
| | - Ruxianguli Maimaitiyiming
- Xinjiang Key Laboratory of Biological Resources and Genetic Engineering, College of Life Science & Technology, Xinjiang University, Urumqi 830046, China
| |
Collapse
|
11
|
Sojithamporn P, Leksakul K, Sawangrat C, Charoenchai N, Boonyawan D. Degradation of Pesticide Residues in Water, Soil, and Food Products via Cold Plasma Technology. Foods 2023; 12:4386. [PMID: 38137190 PMCID: PMC10743213 DOI: 10.3390/foods12244386] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/17/2023] [Revised: 11/30/2023] [Accepted: 12/02/2023] [Indexed: 12/24/2023] Open
Abstract
Water, soil, and food products contain pesticide residues. These residues result from excessive pesticides use, motivated by the fact that agricultural productivity can be increased by the use of these pesticides. The accumulation of these residues in the body can cause health problems, leading to food safety concerns. Cold plasma technology has been successfully employed in various applications, such as seed germination, bacterial inactivation, wound disinfection, surface sterilization, and pesticide degradation. In recent years, researchers have increasingly explored the effectiveness of cold plasma technology in the degradation of pesticide residues. Most studies have shown promising outcomes, encouraging further research and scaling-up for commercialization. This review summarizes the use of cold plasma as an emerging technology for pesticide degradation in terms of the plasma system and configuration. It also outlines the key findings in this area. The most frequently adopted plasma systems for each application are identified, and the mechanisms underlying pesticide degradation using cold plasma technology are discussed. The possible factors influencing pesticide degradation efficiency, challenges in research, and future trends are also discussed. This review demonstrates that despite the nascent nature of the technology, the use of cold plasma shows considerable potential in regards to pesticide residue degradation, particularly in food applications.
Collapse
Affiliation(s)
- Phanumas Sojithamporn
- Graduate Program in Industrial Engineering, Department of Industrial Engineering, Faculty of Engineering, Chiang Mai University, Chiang Mai 50200, Thailand;
| | - Komgrit Leksakul
- Department of Industrial Engineering, Faculty of Engineering, Chiang Mai University, Chiang Mai 50200, Thailand; (C.S.); (N.C.)
| | - Choncharoen Sawangrat
- Department of Industrial Engineering, Faculty of Engineering, Chiang Mai University, Chiang Mai 50200, Thailand; (C.S.); (N.C.)
| | - Nivit Charoenchai
- Department of Industrial Engineering, Faculty of Engineering, Chiang Mai University, Chiang Mai 50200, Thailand; (C.S.); (N.C.)
| | - Dheerawan Boonyawan
- Plasma and Beam Physics Research Center (PBP), Faculty of Science, Chiang Mai University, Chiang Mai 50200, Thailand;
| |
Collapse
|
12
|
Wang Y, Liu Y, Zhao Y, Sun Y, Duan M, Wang H, Dai R, Liu Y, Li X, Jia F. Bactericidal efficacy difference between air and nitrogen cold atmospheric plasma on Bacillus cereus: Inactivation mechanism of Gram-positive bacteria at the cellular and molecular level. Food Res Int 2023; 173:113204. [PMID: 37803533 DOI: 10.1016/j.foodres.2023.113204] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/14/2023] [Revised: 06/19/2023] [Accepted: 06/27/2023] [Indexed: 10/08/2023]
Abstract
As an emerging food processing technology, cold atmospheric plasma (CAP) has attracted great attention in the field of microbial inactivation. Although CAP has been proven to effectively inactivate a variety of foodborne pathogens, there is less research on the inactivation of Bacillus cereus, and the exact inactivation mechanism is still unclear. Elucidating the inactivation mechanism will help to develop and optimize this sterilization method, with the prospective application in industrialized food production. This study aims to explore the bactericidal efficacy difference between air and nitrogen CAP on B. cereus, a typical Gram-positive bacterium, and reveals the inactivation mechanism of CAP at the cellular and molecular level, by observing the change of the cell membrane, cell morphological damage, intracellular antioxidant enzyme activity and cellular biomacromolecules changes. The results showed that both air CAP and nitrogen CAP could effectively inactivate B. cereus, which was due to the reactive oxygen and nitrogen species (RONS) generated by the plasma causing bacterial death. The damage pathways of CAP on Gram-positive bacteria could be explained by disrupting the bacterial cell membrane and cell morphology, disturbing the intracellular redox homeostasis, and destroying biomacromolecules in the cells. The differences in active species generated by the plasma were the main reason for the different bactericidal efficiencies of air CAP and nitrogen CAP, where air CAP producing RONS with stronger oxidative capacity in a shorter time. This study indicates that air CAP is an effective, inexpensive and green technology for B. cereus inactivation, providing a basis for industrial application in food processing.
Collapse
Affiliation(s)
- Yuhan Wang
- College of Food Science and Nutritional Engineering, China Agricultural University, Beijing 100083, China
| | - Yana Liu
- College of Food Science and Nutritional Engineering, China Agricultural University, Beijing 100083, China
| | - Yijie Zhao
- College of Food Science and Nutritional Engineering, China Agricultural University, Beijing 100083, China
| | - Yingying Sun
- College of Food Science and Nutritional Engineering, China Agricultural University, Beijing 100083, China
| | - Miaolin Duan
- College of Food Science and Nutritional Engineering, China Agricultural University, Beijing 100083, China
| | - Han Wang
- College of Food Science and Nutritional Engineering, China Agricultural University, Beijing 100083, China
| | - Ruitong Dai
- College of Food Science and Nutritional Engineering, China Agricultural University, Beijing 100083, China
| | - Yi Liu
- College of Food Science and Nutritional Engineering, China Agricultural University, Beijing 100083, China
| | - Xingmin Li
- College of Food Science and Nutritional Engineering, China Agricultural University, Beijing 100083, China.
| | - Fei Jia
- Department of Biological and Agricultural Engineering, University of Arkansas, Fayetteville, AR 72701, USA.
| |
Collapse
|
13
|
Mir S, Kooshki S. Innovative Method for Water-in-Oil Emulsion Treatment Using Atmospheric Nonthermal-Plasma Technology. LANGMUIR : THE ACS JOURNAL OF SURFACES AND COLLOIDS 2023; 39:14459-14473. [PMID: 37734063 DOI: 10.1021/acs.langmuir.3c02268] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 09/23/2023]
Abstract
The field of plasma-liquid interactions is rapidly growing, with increasing publications across applications. While plasma's interactions with water and oil have been researched, there is a notable gap in the study of plasma-emulsion interactions and their practical applications. Investigating plasma-emulsion interactions offers a dual advantage, as demonstrated in this study, as it is applicable to both water/oil separation and emulsion stabilization processes. This study introduces a groundbreaking approach utilizing the fountain dielectric barrier discharge (FDBD) plasma reactor. The reactor exposes a model emulsion to different plasma gases, such as air, nitrogen, argon, and ammonia, along with varying parameters of plasma input voltage and treatment time. Consequently, due to demulsification, the emulsion segregates into distinct water and oil phases. Remarkably, the results demonstrate that short-term plasma treatment leads to the separation of over 99% of emulsified water. However, prolonged exposure to plasma for around 7 min reveals a decrease in the volume of free-separated water, implying the occurrence of stable emulsion formation instead of further demulsification. To optimize experimental conditions for compliance with regulatory requirements, the study employs the response surface methodology (RSM). Adapting pH and separation contours in three-dimensional (3D) RSM plots shows that achieving higher separation is likely associated with higher pH levels in air, nitrogen, and argon plasmas. Notably, the plasma treatment involving ammonia gas elevates the pH level and yields the highest degree of separation compared with air, nitrogen, or argon plasmas.
Collapse
Affiliation(s)
- Sonia Mir
- Department of Chemical Engineering, Amirkabir University of Technology (Tehran Polytechnic), 424 Hafez Avenue, Tehran 15875-4413, Iran
| | - Saeed Kooshki
- Division of Environmental Physics, Faculty of Mathematics, Physics, and Informatics, Comenius University, Mlynská dolina F2, Bratislava 842 48, Slovakia
| |
Collapse
|
14
|
Sahraeian S, Rashidinejad A, Niakousari M. Enhanced properties of non-starch polysaccharide and protein hydrocolloids through plasma treatment: A review. Int J Biol Macromol 2023; 249:126098. [PMID: 37543265 DOI: 10.1016/j.ijbiomac.2023.126098] [Citation(s) in RCA: 4] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/26/2023] [Revised: 07/10/2023] [Accepted: 07/24/2023] [Indexed: 08/07/2023]
Abstract
Hydrocolloids are important ingredients in food formulations and their modification can lead to novel ingredients with unique functionalities beyond their nutritional value. Cold plasma is a promising technology for the modification of food biopolymers due to its non-toxic and eco-friendly nature. This review discusses the recent published studies on the effects of cold plasma treatment on non-starch hydrocolloids and their derivatives. It covers the common phenomena that occur during plasma treatment, including ionization, etching effect, surface modification, and ashing effect, and how they contribute to various changes in food biopolymers. The effects of plasma treatment on important properties such as color, crystallinity, chemical structure, rheological behavior, and thermal properties of non-starch hydrocolloids and their derivatives are also discussed. In addition, this review highlights the potential of cold plasma treatment to enhance the functionality of food biopolymers and improve the quality of food products. The mechanisms underlying the effects of plasma treatment on food biopolymers, which can be useful for future research in this area, are also discussed. Overall, this review paper presents a comprehensive overview of the current knowledge in the field of cold plasma treatment of non-starch hydrocolloids and their derivatives and highlights the areas that require further investigation.
Collapse
Affiliation(s)
- Shahriyar Sahraeian
- Department of Food Science and Technology, College of Agriculture, Shiraz University, Shiraz, Iran
| | - Ali Rashidinejad
- Riddet Institute, Massey University, Private Bag 11222, Palmerston North 4442, New Zealand.
| | - Mehrdad Niakousari
- Department of Food Science and Technology, College of Agriculture, Shiraz University, Shiraz, Iran
| |
Collapse
|
15
|
Abdo A, McWhorter A, Hasse D, Schmitt-John T, Richter K. Efficacy of Plasma-Treated Water against Salmonella Typhimurium: Antibacterial Activity, Inhibition of Invasion, and Biofilm Disruption. Antibiotics (Basel) 2023; 12:1371. [PMID: 37760668 PMCID: PMC10525256 DOI: 10.3390/antibiotics12091371] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/31/2023] [Revised: 07/02/2023] [Accepted: 08/24/2023] [Indexed: 09/29/2023] Open
Abstract
Plasma-treated water (PTW) has emerged as a potential sanitizing agent. This study evaluated antibacterial activity, inhibition of invasion, and biofilm disruption effects of PTW against Salmonella Typhimurium. Minimum inhibitory concentrations (MICs) and minimum bactericidal concentrations (MBCs) were determined for different PTW types. Time-kill assays were conducted to assess bactericidal effects, while polarized Caco-2 cells were used to evaluate invasion inhibition. Biofilm formation and cell viability were examined following PTW treatment using Salmonella Typhimurium isolates, while biofilm disruption and regrowth prevention were investigated using the Bioflux system. PTW exhibited antibacterial activity against all Salmonella Typhimurium isolates, with MICs of 25% for PTW1 and PTW2, and 50% for PTW3, PTW4, and PTW5. MBCs of 50% in media were observed for all PTW types. Undiluted PTW1 and PTW2 showed the highest bactericidal capacity, significantly reduced Salmonella viability, and completely inhibited bacterial invasion, while PTW3 and PTW5 also showed significant invasion reduction. Bioflux experiments confirmed the eradication of biofilms by PTW1 and PTW2, with no regrowth observed 72 h after PTW was removed. PTW demonstrated significant antibacterial activity, inhibition of invasion, biofilm disruption, and reduction of bacterial viability against Salmonella Typhimurium. This highlights PTW's potential as an effective sanitizer for reducing Salmonella contaminations.
Collapse
Affiliation(s)
- Adrian Abdo
- Richter Lab, Department of Surgery, Basil Hetzel Institute for Translational Health Research, The Queen Elizabeth Hospital, University of Adelaide, Woodville, SA 5011, Australia;
| | - Andrea McWhorter
- School of Animal and Veterinary Sciences, University of Adelaide, Roseworthy, SA 5371, Australia;
| | | | | | - Katharina Richter
- Richter Lab, Department of Surgery, Basil Hetzel Institute for Translational Health Research, The Queen Elizabeth Hospital, University of Adelaide, Woodville, SA 5011, Australia;
- Institute for Photonics and Advanced Sensing, University of Adelaide, Adelaide, SA 5005, Australia
| |
Collapse
|
16
|
Aihaiti A, Maimaitiyiming R, Wang L, Wang J. Processing of Fresh-Cut Potato Using Plasma-Activated Water Prepared by Decreasing Discharge Frequency. Foods 2023; 12:2285. [PMID: 37372496 DOI: 10.3390/foods12122285] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/26/2023] [Revised: 06/02/2023] [Accepted: 06/02/2023] [Indexed: 06/29/2023] Open
Abstract
As a novel non-thermal processing method, the concentration of active compounds in plasma-activated water (PAW) is usually adjusted by changing the voltage and preparation time. We recently adjusted the discharge frequency and found that the PAW properties were improved. In this study, fresh-cut potato was selected as a model, and PAW was prepared using a frequency of 200 Hz (200 Hz-PAW). Its efficacy was compared with that of PAW prepared using 10 kHz. The results showed that the ozone, hydrogen peroxide, nitrate, and nitrite concentrations in 200 Hz-PAW were 5.00-, 3.62-, 8.05-, and 1.48-fold higher than those of 10 kHz-PAW. PAW inactivated the browning-related enzymes polyphenol oxidase and peroxidase, lowering the browning index and inhibiting browning; 200 Hz-PAW exhibited the lowest of these parameters during storage. In addition, PAW induced PAL to promote phenolic synthesis and increase antioxidant activity to delay malondialdehyde accumulation; 200 Hz-PAW exhibited the highest of these parameters. Moreover, 200 Hz-PAW had the lowest weight loss and electrolyte leakage rates. Furthermore, microbial analysis showed that the lowest aerobic mesophilic, mold, and yeast counts during storage were observed in the 200 Hz-PAW group. These results suggest that frequency-controlled PAW has the potential to treat fresh-cut produce.
Collapse
Affiliation(s)
- Aihemaitijiang Aihaiti
- Xinjiang Key Laboratory of Biological Resources and Genetic Engineering, College of Life Science and Technology, Xinjiang University, Urumqi 830046, China
| | - Ruxianguli Maimaitiyiming
- Xinjiang Key Laboratory of Biological Resources and Genetic Engineering, College of Life Science and Technology, Xinjiang University, Urumqi 830046, China
| | - Liang Wang
- Xinjiang Key Laboratory of Biological Resources and Genetic Engineering, College of Life Science and Technology, Xinjiang University, Urumqi 830046, China
| | - Jiayi Wang
- Xinjiang Key Laboratory of Biological Resources and Genetic Engineering, College of Life Science and Technology, Xinjiang University, Urumqi 830046, China
| |
Collapse
|
17
|
Herianto S, Arcega RD, Hou CY, Chao HR, Lee CC, Lin CM, Mahmudiono T, Chen HL. Chemical decontamination of foods using non-thermal plasma-activated water. THE SCIENCE OF THE TOTAL ENVIRONMENT 2023; 874:162235. [PMID: 36791866 DOI: 10.1016/j.scitotenv.2023.162235] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/06/2022] [Revised: 02/06/2023] [Accepted: 02/09/2023] [Indexed: 06/18/2023]
Abstract
The presence of chemical contaminants in foods and agricultural products is one of the major safety issues worldwide, posing a serious concern to human health. Nonthermal plasma (NTP) containing richly reactive oxygen and nitrogen species (RONS) has been trialed as a potential decontamination method. Yet, this technology comes with multiple downsides, including adverse effects on the quality of treated foods and limited exposure to entire surfaces on samples with hard-to-reach spots, further hindering real-life applications. Therefore, plasma-activated water (PAW) has been recently developed to facilitate the interactions between RONS and contaminant molecules in the liquid phase, allowing a whole surface treatment with efficient chemical degradation. Here, we review the recent advances in PAW utilized as a chemical decontamination agent in foods. The reaction mechanisms and the main RONS contributors involved in the PAW-assisted removal of chemical contaminants are briefly outlined. Also, the comprehensive effects of these treatments on food qualities (chemical and physical characteristics) and toxicological evaluation of PAW (in vitro and in vivo) are thoroughly discussed. Ultimately, we identified some current challenges and provided relevant suggestions, which can further promote PAW research for real-life applications in the future.
Collapse
Affiliation(s)
- Samuel Herianto
- Department of Food Safety/Hygiene and Risk Management, College of Medicine, National Cheng Kung University, Tainan 70101, Taiwan; Chemical Biology and Molecular Biophysics Program, Taiwan International Graduate Program (TIGP), Academia Sinica, Taipei 11529, Taiwan; Institute of Chemistry, Academia Sinica, Taipei 11529, Taiwan; Department of Chemistry (Chemical Biology Division), College of Science, National Taiwan University, Taipei 10617, Taiwan
| | - Rachelle D Arcega
- Department of Food Safety/Hygiene and Risk Management, College of Medicine, National Cheng Kung University, Tainan 70101, Taiwan
| | - Chih-Yao Hou
- Department of Seafood Science, College of Hydrosphere, National Kaohsiung University of Science and Technology, Kaohsiung 81157, Taiwan
| | - How-Ran Chao
- Department of Environmental Science and Engineering, College of Engineering, National Pingtung University of Science and Technology, Pingtung 91201, Taiwan; Institute of Food Safety Management, College of Agriculture, National Pingtung University of Science and Technology, Pingtung 91201, Taiwan; Emerging Compounds Research Center, General Research Service Center, National Pingtung University of Science and Technology, Pingtung 91201, Taiwan
| | - Ching-Chang Lee
- Department of Environmental and Occupational Health, College of Medicine, National Cheng Kung University, Tainan 70101, Taiwan; Research Center of Environmental Trace Toxic Substances, College of Medicine, National Cheng Kung University, Tainan 70101, Taiwan
| | - Chia-Min Lin
- Department of Seafood Science, College of Hydrosphere, National Kaohsiung University of Science and Technology, Kaohsiung 81157, Taiwan
| | - Trias Mahmudiono
- Department of Nutrition, Faculty of Public Health, Universitas Airlangga, Surabaya 60115, Indonesia
| | - Hsiu-Ling Chen
- Department of Food Safety/Hygiene and Risk Management, College of Medicine, National Cheng Kung University, Tainan 70101, Taiwan; Research Center of Environmental Trace Toxic Substances, College of Medicine, National Cheng Kung University, Tainan 70101, Taiwan; Department of Nutrition, Faculty of Public Health, Universitas Airlangga, Surabaya 60115, Indonesia.
| |
Collapse
|
18
|
Xiao H, Zhang S, Xi F, Yang W, Zhou L, Zhang G, Zhu H, Zhang Q. Preservation effect of plasma-activated water (PAW) treatment on fresh walnut kernels. INNOV FOOD SCI EMERG 2023. [DOI: 10.1016/j.ifset.2023.103304] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 03/03/2023]
|
19
|
Weihe T, Yao Y, Opitz N, Wagner R, Krall J, Schnabel U, Below H, Ehlbeck J. Plasma-Treated Water: A Comparison with Analog Mixtures of Traceable Ingredients. Microorganisms 2023; 11:microorganisms11040932. [PMID: 37110355 PMCID: PMC10146649 DOI: 10.3390/microorganisms11040932] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/28/2023] [Revised: 03/22/2023] [Accepted: 03/27/2023] [Indexed: 04/05/2023] Open
Abstract
Plasma-treated water (PTW) possess anti-microbial potential against Pseudomonas fluorescence, which is observable for both suspended cells and cells organized in biofilms. Against that background, the chemical composition of PTW tends to focus. Various analytical techniques have been applied for analyses, which reveal various traceable reactive oxygen and nitrogen compounds (RONS). Based on these findings, it is our aim to generate a PTW analog (anPTW), which has been compared in its anti-microbial efficiency with freshly generated PTW. Additionally, a solution of every traceable compound of PTW has been mixed according to their PTW concentration. As references, we treated suspended cells and mature biofilms of P. fluorescence with PTW that originates from a microwave-driven plasma source. The anti-microbial efficiency of all solutions has been tested based on a combination of a proliferation, an XTT, and a live–dead assay. The outcomes of the test proved an anti-microbial power of PTW that suggests more active ingredients than the traceable compounds HNO3, HNO2, and H2O2 or the combined mixture of the analog.
Collapse
Affiliation(s)
- Thomas Weihe
- Department of Plasma Biotechnology, Leibniz Institute for Plasma Science and Technology, 17489 Greifswald, Germany
| | - Yijiao Yao
- Department of Plasma Biotechnology, Leibniz Institute for Plasma Science and Technology, 17489 Greifswald, Germany
- Department of Food & Nutritional Sciences, University of Reading, Whiteknights, Reading RG6 6AD, UK
| | - Nevin Opitz
- Institute for Hygiene and Environmental Medicine, Greifswald University Hospital, 17489 Greifswald, Germany
| | - Robert Wagner
- Department of Plasma Biotechnology, Leibniz Institute for Plasma Science and Technology, 17489 Greifswald, Germany
| | - Johanna Krall
- Center of Microbiology and Environmental System Science, Division of Terrestrial Ecosystem Research, University of Vienna, 1010 Vienna, Austria
| | - Uta Schnabel
- Department of Plasma Biotechnology, Leibniz Institute for Plasma Science and Technology, 17489 Greifswald, Germany
| | - Harald Below
- Independent Researcher, 17489 Greifswald, Germany
| | - Jörg Ehlbeck
- Department of Plasma Biotechnology, Leibniz Institute for Plasma Science and Technology, 17489 Greifswald, Germany
| |
Collapse
|
20
|
Guo L, Zhao P, Jia Y, Li T, Huang L, Wang Z, Liu D, Hou Z, Zhao Y, Zhang L, Li H, Kong Y, Li J, Wang X, Rong M. Efficient inactivation of the contamination with pathogenic microorganisms by a combination of water spray and plasma-activated air. JOURNAL OF HAZARDOUS MATERIALS 2023; 446:130686. [PMID: 36610342 PMCID: PMC9796360 DOI: 10.1016/j.jhazmat.2022.130686] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 11/15/2022] [Revised: 12/19/2022] [Accepted: 12/26/2022] [Indexed: 06/17/2023]
Abstract
The global pandemic caused by SARS-CoV-2 has lasted two and a half years and the infections caused by the viral contamination are still occurring. Developing efficient disinfection technology is crucial for the current epidemic or infectious diseases caused by other pathogenic microorganisms. Gas plasma can efficiently inactivate different microorganisms, therefore, in this study, a combination of water spray and plasma-activated air was established for the disinfection of pathogenic microorganisms. The combined treatment efficiently inactivated the Omicron-pseudovirus through caused the nitration modification of the spike proteins and also the pathogenic bacteria. The combined treatment was improved with a funnel-shaped nozzle to form a temporary relatively sealed environment for the treatment of the contaminated area. The improved device could efficiently inactivate the Omicron-pseudovirus and bacteria on the surface of different materials including quartz, metal, leather, plastic, and cardboard and the particle size of the water spray did not affect the inactivation effects. This study supplied a disinfection strategy based on plasma-activated air for the inactivation of contaminated pathogenic microorganisms.
Collapse
Affiliation(s)
- Li Guo
- State Key Laboratory of Electrical Insulation and Power Equipment, Center for Plasma Biomedicine, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Pengyu Zhao
- State Key Laboratory of Electrical Insulation and Power Equipment, Center for Plasma Biomedicine, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Yikang Jia
- State Key Laboratory of Electrical Insulation and Power Equipment, Center for Plasma Biomedicine, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Tianhui Li
- School of Life Science and Technology, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Lingling Huang
- State Key Laboratory of Electrical Insulation and Power Equipment, Center for Plasma Biomedicine, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Zifeng Wang
- State Key Laboratory of Electrical Insulation and Power Equipment, Center for Plasma Biomedicine, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Dingxin Liu
- State Key Laboratory of Electrical Insulation and Power Equipment, Center for Plasma Biomedicine, Xi'an Jiaotong University, Xi'an 710049, PR China.
| | - Zhanwu Hou
- School of Life Science and Technology, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Yizhen Zhao
- Department of Applied Physics, School of Physics, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Lei Zhang
- Department of Applied Physics, School of Physics, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Hua Li
- School of Life Science and Technology, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Yu Kong
- School of Life Science and Technology, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Juntang Li
- Research Centre for Occupation and Environment Medicine, Collaborative Innovation Centre for Medical Equipment, Key Laboratory of Biological Damage Effect and Protection, Luoyang 471031, PR China.
| | - Xiaohua Wang
- State Key Laboratory of Electrical Insulation and Power Equipment, Center for Plasma Biomedicine, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Mingzhe Rong
- State Key Laboratory of Electrical Insulation and Power Equipment, Center for Plasma Biomedicine, Xi'an Jiaotong University, Xi'an 710049, PR China
| |
Collapse
|
21
|
Hadinoto K, Yang H, Zhang T, Cullen PJ, Prescott S, Trujillo FJ. The antimicrobial effects of mist spraying and immersion on beef samples with plasma-activated water. Meat Sci 2023; 200:109165. [PMID: 36958246 DOI: 10.1016/j.meatsci.2023.109165] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/05/2023] [Revised: 03/10/2023] [Accepted: 03/11/2023] [Indexed: 03/16/2023]
Abstract
The use of plasma-activated water (PAW) as an antimicrobial agent to inactivate Salmonella Typhimurium on chilled beef during meat washing was evaluated. Two meat washing methods, spraying and immersion, were evaluated at contact times of 15, 30 and 60 s and meat storage times of 0, 1 and 7 days. The temperature of PAW was elevated to 55 °C for washing as it increased the microbial inactivation compared to ambient temperature. At the contact time of 60 s and meat storage time of 7 days, PAW spraying and immersion achieved 0.737-log10 and 0.710-log10 reductions against Salmonella Typhimurium, respectively; there were no significant differences between both washing methods, with spraying being preferred for commercial implementation. Compared to untreated and water-treated samples, meat washing with PAW alone improved the S. Typhimurium inactivation and did not cause negative impacts on the lightness and hue angle values, TBARS value, water holding capacity and pH. However, PAW reduced the redness, yellowness and chroma values with the decreased oxymyoglobin values of 44.1% at the storage time of 1 day. PAW spraying at 55 °C followed by additional water washing at 25 °C for 60 s achieved 0.696-log10 reduction and mitigated a reduction in (i) the redness value, from 11.3 to 18.2, (ii) the yellowness value, from 9.19 to 11.1, and (iii) the chroma value, from 14.5 to 21.3, without displaying colour differences (∆E), as detected by human eyes, compared to water-treated samples. Moreover, the content of myoglobin forms was maintained by additional water washing.
Collapse
Affiliation(s)
| | - Hanxia Yang
- School of Chemical Engineering, UNSW Sydney, Australia
| | - Tianqi Zhang
- School of Chemical and Biomolecular Engineering, Faculty of Engineering, The University of Sydney, Australia
| | - Patrick J Cullen
- School of Chemical and Biomolecular Engineering, Faculty of Engineering, The University of Sydney, Australia
| | | | | |
Collapse
|
22
|
Fernández-Gómez P, Cobo-Díaz JF, Oliveira M, González-Raurich M, Alvarez-Ordóñez A, Prieto M, Walsh JL, Sivertsvik M, Noriega-Fernández E, López M. Susceptibility and transcriptomic response to plasma-activated water of Listeria monocytogenes planktonic and sessile cells. Food Microbiol 2023; 113:104252. [PMID: 37098419 DOI: 10.1016/j.fm.2023.104252] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/29/2022] [Revised: 03/05/2023] [Accepted: 03/06/2023] [Indexed: 03/09/2023]
Abstract
Plasma-Activated Water (PAW) was generated from tap water using a surface dielectric barrier discharge at different discharge power (26 and 36 W) and activation time (5 and 30 min). The inactivation of a three-strain Listeria monocytogenes cocktail in planktonic and biofilm state was evaluated. PAW generated at 36 W-30 min showed the lowest pH and the highest hydrogen peroxide, nitrates, nitrites contents and effectiveness against cells on planktonic state, resulting in 4.6 log reductions after a 15-min treatment. Although the antimicrobial activity in biofilms formed on stainless steel and on polystyrene was lower, increasing the exposure time to 30 min allowed an inactivation >4.5 log cycles. The mechanisms of action of PAW were investigated using chemical solutions that mimic its physico-chemical characteristics and also RNA-seq analysis. The main transcriptomic changes affected carbon metabolism, virulence and general stress response genes, with several overexpressed genes belonging to the cobalamin-dependent gene cluster.
Collapse
|
23
|
Influence of a transient spark plasma discharge on producing high molecular masses of chemical products from L-cysteine. Sci Rep 2023; 13:2059. [PMID: 36739465 PMCID: PMC9899256 DOI: 10.1038/s41598-023-28736-4] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/25/2022] [Accepted: 01/24/2023] [Indexed: 02/06/2023] Open
Abstract
Cold atmospheric pressure plasmas are considered a forthcoming method in many research areas. Plasma modification of biomolecules has received much attention in addition to plasma-treated biomaterials. Hence, in this work, we operated a transient spark plasma (TSP) discharge to study its effect on the L-cysteine chemical structure. the TSP was configured in a pin-to-ring electrode arrangement and flowed by Ar gas. We also investigated the effect of two chemicals; dimethyl sulfoxide (DMSO) and hydrogen peroxide (H2O2) by the bubbling method to show how they can change the creation of new chemical bioproducts. Ultraviolet-Visible absorption spectroscopy, Fourier transform infrared spectroscopy and Liquid chromatography-mass spectroscopy were used to investigate any changes in chemical bonds of cysteine structure and to depict the generation of new biomolecules. Based on the displayed results plasma-generated reactive species had a great role in the chemical structure of the cysteine. Entering DMSO and H2O2 into the plasma caused the creation of new products and the heaviest biomolecule was produced by the simultaneous addition of DMSO and H2O2. The results also predicted that some chemical products and amino acids with a higher value molecular masse produced from the polymerization process of cysteine solution. The strong oxidation process is responsible for the heavy chemical compounds.
Collapse
|
24
|
Yang S, Dai J, Aweya JJ, Lin R, Weng W, Xie Y, Jin R. The Antibacterial Activity and Pickering Emulsion Stabilizing Effect of a Novel Peptide, SA6, Isolated from Salt-Fermented Penaeus vannamei. FOOD BIOPROCESS TECH 2023. [DOI: 10.1007/s11947-023-03000-9] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/22/2023]
|
25
|
Production, characterization, microbial inhibition, and in vivo toxicity of cold atmospheric plasma activated water. INNOV FOOD SCI EMERG 2023. [DOI: 10.1016/j.ifset.2022.103265] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/09/2023]
|
26
|
Impact of ultraviolet light and cold plasma on fatty acid profile of raw chicken and pork meat. J Food Compost Anal 2022. [DOI: 10.1016/j.jfca.2022.104872] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/19/2022]
|
27
|
Treatment of Escherichia coli contaminated water with different pulse-powered NTP configurations and analysis for post treatment efficacy. Sci Rep 2022; 12:20380. [PMID: 36437264 PMCID: PMC9701784 DOI: 10.1038/s41598-022-24248-9] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/27/2022] [Accepted: 11/11/2022] [Indexed: 11/28/2022] Open
Abstract
A cost-effective and energy efficient method for water sterilization is a challenging demand in the present scenario where scarcity of pure water is rising. Non-Thermal Plasma (NTP) finds promising applications in environmental processes and has advantages over conventional water treatment methods. Escherichia coli contaminated water treatment using multiple pin plasma reactor and atmospheric pressure plasma jet reactor was undertaken in this work. High voltage pulsed power was used for generating non-thermal plasma in these reactors and various configurations were tested for treating the contaminated water. The most feasible configuration among these was identified from the treatment efficiency and survival rate plots of E. coli colonies. It was observed that with an exposure of 15 min NTP, 100 percent bacterial removal was achieved using plasma jet reactor configuration. The presence of bacteria after NTP-treated time was also checked and confirmed for complete removal of bacteria. An optimum time of 15 min plasma exposure for 100 ml was found to be effective for complete removal of microorganisms and the sterility was maintained up to 60 min after the treatment. Non-thermal plasma-based treatment of bacteria-contaminated water is found to be promising and could be considered for scale-up and analysis.
Collapse
|
28
|
Effect of the pH on the Antibacterial Potential and Cytotoxicity of Different Plasma-Activated Liquids. Int J Mol Sci 2022; 23:ijms232213893. [PMID: 36430372 PMCID: PMC9693261 DOI: 10.3390/ijms232213893] [Citation(s) in RCA: 9] [Impact Index Per Article: 4.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/25/2022] [Revised: 11/06/2022] [Accepted: 11/08/2022] [Indexed: 11/16/2022] Open
Abstract
In this study, different plasma-activated liquids were evaluated for their antimicrobial effects against Escherichia coli, as well as for their cytotoxicity on mammalian cells. The PALs were prepared from distilled (DIS), deionized (DI), filtered (FIL), and tap (TAP) water. Additionally, 0.9% NaCl saline solution (SAL) was plasma-activated. These PALs were prepared using 5 L/min air gliding arc plasma jet for up to 60.0 min of exposure. Subsequently, the physicochemical properties, such as, the oxidation-reduction potential (ORP), the pH, the conductivity, and the total dissolved solids (TDS) were characterized by a water multiparameter. The PALs obtained showed a drastic decrease in the pH with increasing plasma exposure time, in contrast, the conductivity and TDS increased. In a general trend, the UV-vis analyses identified a higher production of the following reactive species of nitrogen and oxygen (RONS), HNO2, H2O2, NO3-, and NO2-. Except for the plasma-activated filtered water (PAW-FIL), where there was a change in the position of NO2- and NO3- at some pHs, The higher production of HNO2 and H2O2-reactive species was observed at a low pH. Finally, the standardized suspensions of Escherichia coli were exposed to PAL for up to 60.0 min. The plasma-activated deionized water (PAW-DI pH 2.5), plasma-activated distilled water (PAW-DIS pH 2.5 and 3), and plasma-activated tap water (PAW-TAP 3.5) showed the best antimicrobial effects at exposure times of 3.0, 10.0, and 30.0 min, respectively. The MTT analysis demonstrated low toxicity of all of the PAL samples. Our results indicate that the plasma activation of different liquids using the gliding arc system can generate specific physicochemical conditions that produce excellent antibacterial effects for E. coli with a safe application, thus bringing future contributions to creating new antimicrobial protocols.
Collapse
|
29
|
Application of plasma-activated water in the food industry: A review of recent research developments. Food Chem 2022; 405:134797. [DOI: 10.1016/j.foodchem.2022.134797] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/13/2022] [Revised: 10/25/2022] [Accepted: 10/26/2022] [Indexed: 11/07/2022]
|
30
|
Wang H, Zhang Y, Jiang H, Cao J, Jiang W. A comprehensive review of effects of electrolyzed water and plasma-activated water on growth, chemical compositions, microbiological safety and postharvest quality of sprouts. Trends Food Sci Technol 2022. [DOI: 10.1016/j.tifs.2022.10.017] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/06/2022]
|
31
|
Han J, Dong P, Holman BWB, Yang H, Chen X, Zhu L, Luo X, Mao Y, Zhang Y. Processing interventions for enhanced microbiological safety of beef carcasses and beef products: A review. Crit Rev Food Sci Nutr 2022; 64:2105-2129. [PMID: 36148812 DOI: 10.1080/10408398.2022.2121258] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/03/2022]
Abstract
Chilled beef is inevitably contaminated with microorganisms, starting from the very beginning of the slaughter line. A lot of studies have aimed to improve meat safety and extend the shelf life of chilled beef, of which some have focused on improving the decontamination effects using traditional decontamination interventions, and others have investigated newer technologies and methods, that offer greater energy efficiency, lower environmental impacts, and better assurances for the decontamination of beef carcasses and cuts. To inform industry, there is an urgent need to review these interventions, analyze the merits and demerits of each technology, and provide insight into 'best practice' to preserve microbial safety and beef quality. In this review, the strategies and procedures used to inhibit the growth of microorganisms on beef, from slaughter to storage, have been critiqued. Critical aspects, where there is a lack of data, have been highlighted to help guide future research. It is also acknowledge that different intervention programs for microbiological safety have different applications, dependent on the initial microbial load, the type of infrastructures, and different stages of beef processing.
Collapse
Affiliation(s)
- Jina Han
- Lab of Beef Processing and Quality Control, College of Food Science and Engineering, Shandong Agricultural University, Taian, Shandong, P. R. China
- National R&D Center for Beef Processing Technology, Tai'an, Shandong, P. R. China
| | - Pengcheng Dong
- Lab of Beef Processing and Quality Control, College of Food Science and Engineering, Shandong Agricultural University, Taian, Shandong, P. R. China
- National R&D Center for Beef Processing Technology, Tai'an, Shandong, P. R. China
| | - Benjamin W B Holman
- Centre for Red Meat and Sheep Development, NSW Department of Primary Industries, Cowra, New South Wales, Australia
| | - Huixuan Yang
- Lab of Beef Processing and Quality Control, College of Food Science and Engineering, Shandong Agricultural University, Taian, Shandong, P. R. China
- National R&D Center for Beef Processing Technology, Tai'an, Shandong, P. R. China
| | - Xue Chen
- Lab of Beef Processing and Quality Control, College of Food Science and Engineering, Shandong Agricultural University, Taian, Shandong, P. R. China
- National R&D Center for Beef Processing Technology, Tai'an, Shandong, P. R. China
| | - Lixian Zhu
- Lab of Beef Processing and Quality Control, College of Food Science and Engineering, Shandong Agricultural University, Taian, Shandong, P. R. China
- National R&D Center for Beef Processing Technology, Tai'an, Shandong, P. R. China
| | - Xin Luo
- Lab of Beef Processing and Quality Control, College of Food Science and Engineering, Shandong Agricultural University, Taian, Shandong, P. R. China
- National R&D Center for Beef Processing Technology, Tai'an, Shandong, P. R. China
| | - Yanwei Mao
- Lab of Beef Processing and Quality Control, College of Food Science and Engineering, Shandong Agricultural University, Taian, Shandong, P. R. China
- National R&D Center for Beef Processing Technology, Tai'an, Shandong, P. R. China
| | - Yimin Zhang
- Lab of Beef Processing and Quality Control, College of Food Science and Engineering, Shandong Agricultural University, Taian, Shandong, P. R. China
- National R&D Center for Beef Processing Technology, Tai'an, Shandong, P. R. China
| |
Collapse
|
32
|
Quantitative Analysis of Plant Cytosolic Calcium Signals in Response to Water Activated by Low-Power Non-Thermal Plasma. Int J Mol Sci 2022; 23:ijms231810752. [PMID: 36142664 PMCID: PMC9506352 DOI: 10.3390/ijms231810752] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/29/2022] [Revised: 08/27/2022] [Accepted: 09/06/2022] [Indexed: 11/25/2022] Open
Abstract
Non-thermal plasma technology is increasingly being applied in the plant biology field. Despite the variety of beneficial effects of plasma-activated water (PAW) on plants, information about the mechanisms of PAW sensing by plants is still limited. In this study, in order to link PAW perception to the positive downstream responses of plants, transgenic Arabidopsis thaliana seedlings expressing the Ca2+-sensitive photoprotein aequorin in the cytosol were challenged with water activated by low-power non-thermal plasma generated by a dielectric barrier discharge (DBD) source. PAW sensing by plants resulted in the occurrence of cytosolic Ca2+ signals, whose kinetic parameters were found to strictly depend on the operational conditions of the plasma device and thus on the corresponding mixture of chemical species contained in the PAW. In particular, we highlighted the effect on the intracellular Ca2+ signals of low doses of DBD-PAW chemicals and also presented the effects of consecutive plant treatments. The results were discussed in terms of the possibility of using PAW-triggered Ca2+ signatures as benchmarks to accurately modulate the chemical composition of PAW in order to induce environmental stress resilience in plants, thus paving the way for further applications in agriculture.
Collapse
|
33
|
Effects of High Voltage Atmospheric Cold Plasma Treatment on the Number of Microorganisms and the Quality of Trachinotus ovatus during Refrigerator Storage. Foods 2022; 11:foods11172706. [PMID: 36076891 PMCID: PMC9455416 DOI: 10.3390/foods11172706] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/18/2022] [Revised: 08/31/2022] [Accepted: 09/02/2022] [Indexed: 12/03/2022] Open
Abstract
In order to investigate the effects of high voltage atmospheric cold plasma (HVACP) treatment on the number of microorganisms in and the quality of Trachinotus ovatus during refrigerator storage, fresh fish was packaged with gases CO2:O2:N2 (80%:10%:10%) and treated by HVACP at 75 kV for 3 min; then, the samples were stored at 4 ± 1 °C for nine days. The microbial numbers, water content, color value, texture, pH value, thiobarbituric acid reactive substance (TBARS), and total volatile base nitrogen (TVB-N) values of the fish were analyzed during storage. The results showed the growth of the total viable bacteria (TVB), psychrophilic bacteria, Pseudomonas spp., H2S-producing bacteria, yeast, and lactic acid bacteria in the treated samples was limited, and they were 1.11, 1.01, 1.04, 1.13, 0.77, and 0.80 log CFU/g−1 lower than those in the control group after nine days of storage, respectively. The hardness, springiness, and chewiness of the treated fish decreased slowly as the storage time extended, and no significant changes in either pH or water content were found. The lightness (L*) value increased and the yellowness (b*) value decreased after treatment, while no changes in the redness (a*) value were found. The TBARS and TVB-N of the treated samples increased to 0.79 mg/kg and 21.99 mg/100 g, respectively, after nine days of refrigerator storage. In conclusion, HVACP can limit the growth of the main microorganisms in fish samples effectively during nine days of refrigerator storage with no significant negative impact on their quality. Therefore, HVACP is a useful nonthermal technology to extend the refrigerator shelf-life of Trachinotus ovatus.
Collapse
|
34
|
Aaliya B, Sunooj KV, Navaf M, Akhila PP, Sudheesh C, Sabu S, Sasidharan A, Sinha SK, George J. Influence of plasma-activated water on the morphological, functional, and digestibility characteristics of hydrothermally modified non-conventional talipot starch. Food Hydrocoll 2022. [DOI: 10.1016/j.foodhyd.2022.107709] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
|
35
|
Yan Y, Xue X, Jin X, Niu B, Chen Z, Ji X, Shi M, He Y. Effect of annealing using plasma-activated water on the structure and properties of wheat flour. Front Nutr 2022; 9:951588. [PMID: 36034897 PMCID: PMC9403792 DOI: 10.3389/fnut.2022.951588] [Citation(s) in RCA: 4] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/24/2022] [Accepted: 07/18/2022] [Indexed: 11/13/2022] Open
Abstract
In this study, wheat flour (WF) was modified by annealing (ANN) using plasma-activated water (PAW) for the first time. Compared with WF and DW-WF, the results of scanning electron microscopy (SEM) and particle-size analysis showed that the granule structure of wheat starch in PAW-WF was slightly damaged, and the particle size of PAW-WF was significantly reduced. The results of X-ray diffraction and Fourier transforming infrared spectroscopy indicated that PAW-ANN could reduce the long-range and short-range order degrees of wheat starch and change the secondary structure of the protein in WF, in which the content of random coils and α-helices was significantly increased. In addition, the analysis of solubility, viscosity, and dynamic rheological properties showed that PAW-ANN improved the solubility and gel properties of WF and decreased its viscosity properties and short-term regeneration. PAW-ANN, as a green modification technology, has the potential for further application in WF modification, as well as in the production of flour products.
Collapse
Affiliation(s)
- Yizhe Yan
- College of Food and Bioengineering, Henan Key Laboratory of Cold Chain Food Quality and Safety Control, Zhengzhou University of Light Industry, Zhengzhou, China
| | - Xinhuan Xue
- College of Food and Bioengineering, Henan Key Laboratory of Cold Chain Food Quality and Safety Control, Zhengzhou University of Light Industry, Zhengzhou, China
| | - Xueyuan Jin
- School of Clinical Medicine, Hainan Vocational University of Science and Technology, Haikou, China
| | - Bin Niu
- College of Food Science and Technology, Henan Agricultural University, Zhengzhou, China
| | - Zhenzhen Chen
- College of Food and Bioengineering, Henan Key Laboratory of Cold Chain Food Quality and Safety Control, Zhengzhou University of Light Industry, Zhengzhou, China
| | - Xiaolong Ji
- College of Food and Bioengineering, Henan Key Laboratory of Cold Chain Food Quality and Safety Control, Zhengzhou University of Light Industry, Zhengzhou, China
| | - Miaomiao Shi
- College of Food and Bioengineering, Henan Key Laboratory of Cold Chain Food Quality and Safety Control, Zhengzhou University of Light Industry, Zhengzhou, China
| | - Yuan He
- College of Food and Bioengineering, Henan Key Laboratory of Cold Chain Food Quality and Safety Control, Zhengzhou University of Light Industry, Zhengzhou, China
| |
Collapse
|
36
|
|
37
|
Mechanistic Insight into Permeation of Plasma-Generated Species from Vacuum into Water Bulk. Int J Mol Sci 2022; 23:ijms23116330. [PMID: 35683009 PMCID: PMC9181481 DOI: 10.3390/ijms23116330] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/29/2022] [Revised: 05/20/2022] [Accepted: 05/25/2022] [Indexed: 11/18/2022] Open
Abstract
Due to their potential benefits, cold atmospheric plasmas (CAPs), as biotechnological tools, have been used for various purposes, especially in medical and agricultural applications. The main effect of CAP is associated with reactive oxygen and nitrogen species (RONS). In order to deliver these RONS to the target, direct or indirect treatment approaches have been employed. The indirect method is put into practice via plasma-activated water (PAW). Despite many studies being available in the field, the permeation mechanisms of RONS into water at the molecular level still remain elusive. Here, we performed molecular dynamics simulations to study the permeation of RONS from vacuum into the water interface and bulk. The calculated free energy profiles unravel the most favourable accumulation positions of RONS. Our results, therefore, provide fundamental insights into PAW and RONS chemistry to increase the efficiency of PAW in biological applications.
Collapse
|
38
|
Wang H, Li Y, Xi Q, Han R, Cullen PJ, Du Q, Yang Y, Forghani F, Zhang J, Wang J. Application of plasma activated water for Escherichia coli decontamination and shelf-life extension of kale. FOOD QUALITY AND SAFETY 2022. [DOI: 10.1093/fqsafe/fyac041] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/13/2022]
Abstract
Abstract
The aim of this study was to examine the effectiveness of plasma activated water (PAW) for inactivating Escherichia coli and retention of key quality factors for kale. Different plasma discharge times (1, 2, 3, 4, 5 and 10 minutes) and different exposure times (2, 4, 6, 8, 10 and 15 minutes) were used to investigate the inactivation effect of E. coli spot-inoculated on kale. The influence of different exposure times on the pH, hardness and color of kale was studied post- treatment. In addition, the effects of PAW on the shelf-life of kale over 12 days of storage at 4 °C was investigated. The results showed that after the treatment of 5-PAW-8 (8 min treatment by PAW generated by 5 min plasma discharge), the population of E. coli on kale was reduced about 1.55 log CFU/g and the changes of pH, hardness and color of kale were not significant (P > 0.05). During the storage period after 5-PAW-8 treatment, the statue of hardness, weight loss, color, surface morphology and ascorbic acid were found to be better than two control groups (P < 0.05). Furthermore, no significant changes were observed in pH values, the content of total phenols and 1,1-dipheny1-2-picrylhydrazyl radical-scavenging capacity (P > 0.05). It is indicated that PAW treatment is a promising method for improving the microbiological safety and extending the shelf-life of kale.
Collapse
Affiliation(s)
| | | | | | | | - Patrick J Cullen
- School of Chemical and Biomolecular Engineering, University of Sydney, Sydney , NSW, Australia
| | | | | | - Fereidoun Forghani
- Molecular Epidemiology, Inc., 15300 Bothell Way NE , Lake Forest Park, WA 98155, USA
| | | | | |
Collapse
|
39
|
Perinban S, Orsat V, Raghavan V. Influence of plasma activated water treatment on enzyme activity and quality of fresh-cut apples. Food Chem 2022; 393:133421. [DOI: 10.1016/j.foodchem.2022.133421] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/24/2022] [Revised: 05/20/2022] [Accepted: 06/05/2022] [Indexed: 11/26/2022]
|
40
|
Plasma-activated water: A cutting-edge technology driving innovation in the food industry. Food Res Int 2022; 156:111368. [DOI: 10.1016/j.foodres.2022.111368] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/07/2022] [Revised: 05/03/2022] [Accepted: 05/10/2022] [Indexed: 11/20/2022]
|
41
|
Comparison of the Effect of Plasma-Activated Water and Artificially Prepared Plasma-Activated Water on Wheat Grain Properties. PLANTS 2022; 11:plants11111471. [PMID: 35684244 PMCID: PMC9183031 DOI: 10.3390/plants11111471] [Citation(s) in RCA: 4] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 05/06/2022] [Revised: 05/23/2022] [Accepted: 05/27/2022] [Indexed: 11/17/2022]
Abstract
Recently, much attention has been paid to the use of low-temperature plasmas and plasma-activated water (PAW) in various areas of biological research. In addition to its use in medicine, especially for low-temperature disinfection and sterilization, a number of works using plasma in various fields of agriculture have already appeared. While direct plasma action involves the effects of many highly reactive species with short lifetimes, the use of PAW involves the action of only long-lived particles. A number of articles have shown that the main stable components of PAW are H2O2, O3, HNO2, and HNO3. If so, then it would be faster and much more practical to artificially prepare PAW by directly mixing these chemicals in a given ratio. In this article, we review the literature describing the composition and properties of PAW prepared by various methods. We also draw attention to an otherwise rather neglected fact, that there are no significant differences between the action of PAW and artificially prepared PAW. The effect of PAW on the properties of wheat grains (Triticum aestivum L.) was determined. PAW exposure increased germination, shoot length, and fresh and dry shoot weight. The root length and R/S length, i.e., the ratio between the underground (R) and aboveground (S) length of the wheat seedlings, slightly decreased, while the other parameters changed only irregularly or not at all. Grains artificially inoculated with Escherichia coli were significantly decontaminated after only one hour of exposure to PAW, while Saccharomyces cerevisiae decontamination required soaking for 24 h. The differences between the PAW prepared by plasma treatment and the PAW prepared by artificially mixing the active ingredients, i.e., nitric acid and hydrogen peroxide, proved to be inconsistent and statistically insignificant. Therefore, it may be sufficient for further research to focus only on the effects of artificial PAW.
Collapse
|
42
|
Plasma-Activated Water for Food Safety and Quality: A Review of Recent Developments. INTERNATIONAL JOURNAL OF ENVIRONMENTAL RESEARCH AND PUBLIC HEALTH 2022; 19:ijerph19116630. [PMID: 35682216 PMCID: PMC9180626 DOI: 10.3390/ijerph19116630] [Citation(s) in RCA: 11] [Impact Index Per Article: 5.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 04/09/2022] [Revised: 05/23/2022] [Accepted: 05/26/2022] [Indexed: 11/17/2022]
Abstract
Plasma-activated water (PAW) has received a lot of attention lately because of its antibacterial efficacy and eco-friendly nature. Compared to traditional disinfectants, this novel and intriguing option has a high disinfectant capacity while causing little to no modifications to the foodstuffs. Until now, PAW has successfully demonstrated its effectiveness against a broad range of microorganisms on a wide variety of food items. Though the efficacy of PAW in microbial reduction has been extensively reviewed, a relatively significant issue of food quality has been largely overlooked. This review aims to summarize the current studies on the physicochemical characteristics and antimicrobial potential of PAW, with an in-depth focus on food quality and safety. According to recent studies, PAW can be a potential microbial disinfectant that extends the shelf life of various food products, such as meat and fish products, fruits and vegetables, cereal products, etc. However, the efficacy varies with treatment conditions and the food ingredients applied. There is a mixed opinion about the effect of PAW on food quality. Based on the available literature, it can be concluded that there has been no substantial change in the biochemical properties of most of the tested food products. However, some fruits and vegetables had a higher value for the enzyme superoxide dismutase (SOD) after PAW treatment, while only a few demonstrated a decrease in the Thiobarbituric acid reactive substances (TBARS) value. Sensory properties also showed no significant difference, with some exceptions in meat and fish products.
Collapse
|
43
|
Lim J, Hong EJ, Kim SB, Ryu S. The Effect of Gap Distance between a Pin and Water Surface on the Inactivation of Escherichia coli Using a Pin-to-Water Plasma. Int J Mol Sci 2022; 23:ijms23105423. [PMID: 35628234 PMCID: PMC9145933 DOI: 10.3390/ijms23105423] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/18/2022] [Revised: 05/09/2022] [Accepted: 05/10/2022] [Indexed: 02/04/2023] Open
Abstract
Atmospheric plasmas have been applied for the inactivation of microorganisms. Industrials demand to investigate the relation of the key reactive species induced by plasmas and the operating parameters including boundary conditions in order to control plasma treatment processes. In this study, we investigated the effect of gap distance between a pin-electrode and water surface on inactivation efficacy. When the gap distance decreased from 5 mm to 1 mm, the reduction of Escherichia coli (E. coli) was increased to more than 4 log CFU/mL. The reactive oxygen species measured optically and spectrophotometrically were influenced by gap distance. The results from electron spin resonance (ESR) analysis showed that the pin-to-water plasma generated hydroxyl radical (OH•) and singlet oxygen (1O2) in the water and superoxide radical (O2−•) served as a precursor of OH•. The inactivation of E. coli was significantly alleviated by sodium azide (1O2 scavenger), indicating that 1O2 contributes the most to bacterial inactivation. These findings provide a potentially effective strategy for bacterial inactivation using a pin-to-water plasma.
Collapse
|
44
|
Milhan NVM, Chiappim W, Sampaio ADG, Vegian MRDC, Pessoa RS, Koga-Ito CY. Applications of Plasma-Activated Water in Dentistry: A Review. Int J Mol Sci 2022; 23:ijms23084131. [PMID: 35456947 PMCID: PMC9029124 DOI: 10.3390/ijms23084131] [Citation(s) in RCA: 7] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/05/2022] [Revised: 04/05/2022] [Accepted: 04/06/2022] [Indexed: 12/12/2022] Open
Abstract
The activation of water by non-thermal plasma creates a liquid with active constituents referred to as plasma-activated water (PAW). Due to its active constituents, PAW may play an important role in different fields, such as agriculture, the food industry and healthcare. Plasma liquid technology has received attention in recent years due to its versatility and good potential, mainly focused on different health care purposes. This interest has extended to dentistry, since the use of a plasma–liquid technology could bring clinical advantages, compared to direct application of non-thermal atmospheric pressure plasmas (NTAPPs). The aim of this paper is to discuss the applicability of PAW in different areas of dentistry, according to the published literature about NTAPPs and plasma–liquid technology. The direct and indirect application of NTAPPs are presented in the introduction. Posteriorly, the main reactors for generating PAW and its active constituents with a role in biomedical applications are specified, followed by a section that discusses, in detail, the use of PAW as a tool for different oral diseases.
Collapse
Affiliation(s)
- Noala Vicensoto Moreira Milhan
- Oral Biopathology Graduate Program, São José dos Campos Institute of Science & Technology, São Paulo State University, UNESP, São Paulo 12245-000, Brazil; (A.d.G.S.); (M.R.d.C.V.); (C.Y.K.-I.)
- Correspondence: ; Tel.: +55-12-991851206
| | - William Chiappim
- Plasma and Processes Laboratory, Department of Physics, Aeronautics Institute of Technology, Praça Marechal Eduardo Gomes 50, São José dos Campos 12228-900, Brazil; (W.C.); (R.S.P.)
| | - Aline da Graça Sampaio
- Oral Biopathology Graduate Program, São José dos Campos Institute of Science & Technology, São Paulo State University, UNESP, São Paulo 12245-000, Brazil; (A.d.G.S.); (M.R.d.C.V.); (C.Y.K.-I.)
| | - Mariana Raquel da Cruz Vegian
- Oral Biopathology Graduate Program, São José dos Campos Institute of Science & Technology, São Paulo State University, UNESP, São Paulo 12245-000, Brazil; (A.d.G.S.); (M.R.d.C.V.); (C.Y.K.-I.)
| | - Rodrigo Sávio Pessoa
- Plasma and Processes Laboratory, Department of Physics, Aeronautics Institute of Technology, Praça Marechal Eduardo Gomes 50, São José dos Campos 12228-900, Brazil; (W.C.); (R.S.P.)
| | - Cristiane Yumi Koga-Ito
- Oral Biopathology Graduate Program, São José dos Campos Institute of Science & Technology, São Paulo State University, UNESP, São Paulo 12245-000, Brazil; (A.d.G.S.); (M.R.d.C.V.); (C.Y.K.-I.)
- Department of Environment Engineering, São José dos Campos Institute of Science & Technology, São Paulo State University, UNESP, São Paulo 12247-016, Brazil
| |
Collapse
|
45
|
Gao Y, Francis K, Zhang X. Review on formation of cold plasma activated water (PAW) and the applications in food and agriculture. Food Res Int 2022; 157:111246. [DOI: 10.1016/j.foodres.2022.111246] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/01/2022] [Revised: 04/08/2022] [Accepted: 04/09/2022] [Indexed: 12/28/2022]
|
46
|
Effects of tempering with plasma-activated water on total plate count and quality properties of wheat flour. J Cereal Sci 2022. [DOI: 10.1016/j.jcs.2022.103468] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/18/2022]
|
47
|
Emelianova AG, Petrova NV, Fremez C, Fontanié M, Tarasov SА, Epstein ОI. Therapeutic potential of highly diluted antibodies in antibiotic-resistant infection. Eur J Pharm Sci 2022; 173:106161. [DOI: 10.1016/j.ejps.2022.106161] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/13/2021] [Revised: 12/02/2021] [Accepted: 03/02/2022] [Indexed: 12/31/2022]
|
48
|
Hu R, Zhang M, Liu W, Mujumdar AS, Bai B. Novel synergistic freezing methods and technologies for enhanced food product quality: A critical review. Compr Rev Food Sci Food Saf 2022; 21:1979-2001. [PMID: 35179815 DOI: 10.1111/1541-4337.12919] [Citation(s) in RCA: 9] [Impact Index Per Article: 4.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/15/2021] [Revised: 12/19/2021] [Accepted: 01/04/2022] [Indexed: 11/28/2022]
Abstract
Freezing has a long history as an effective food preservation method, but traditional freezing technologies have quality limitations, such as the potential for water loss and/or shrinkage and/or nutrient loss, etc. in the frozen products. Due to enhanced quality preservation and simpler thawing operation, synergistic technologies for freezing are emerging as the optimal methods for frozen food processing. This article comprehensively reviewed the recently developed synergistic technologies for freezing and pretreatment, for example, ultrasonication, cell alive system freezing, glass transition temperature regulation, high pressure freezing, pulsed electric field pretreatment, osmotic pretreatment, and antifreeze protein pretreatment, etc. The mechanisms and applications of these techniques are outlined briefly here. Though the application of new treatments in freezing is relatively mature, reducing the energy consumption in the application of these new technologies is a key issue for future research. It is also necessary to consider scale-up issues involved in large-scale applications as much of the research effort so far is limited to laboratory or pilot scale. For future development, intelligent freezing should be given more attention. Freezing should automatically identify and respond to different freezing conditions according to the nature of different materials to achieve more efficient freezing. PRACTICAL APPLICATION: This paper provides a reference for subsequent production and research, and analyzes the advantages and disadvantages of different novel synergistic technologies, which points out the direction for subsequent industry development and research. At the same time, it provides new ideas for the freezing industry.
Collapse
Affiliation(s)
- Rui Hu
- State Key Laboratory of Food Science and Technology, Jiangnan University, Wuxi, Jiangsu, P. R. China.,Jiangsu Province International Joint Laboratory on Fresh Food Smart Processing and Quality Monitoring, Jiangnan University, Wuxi, Jiangsu, P. R. China
| | - Min Zhang
- State Key Laboratory of Food Science and Technology, Jiangnan University, Wuxi, Jiangsu, P. R. China.,International Joint Laboratory on Food Safety, Jiangnan University, Wuxi, Jiangsu, P. R. China
| | - Wenchao Liu
- State Key Laboratory of Food Science and Technology, Jiangnan University, Wuxi, Jiangsu, P. R. China.,International Joint Laboratory on Food Safety, Jiangnan University, Wuxi, Jiangsu, P. R. China
| | - Arun S Mujumdar
- Department of Bioresource Engineering, Macdonald Campus, McGill University, Ste. Anne decBellevue, Quebec, Canada
| | - Baosong Bai
- Yechun Food Production and Distribution Co., Ltd., Yangzhou, Jiangsu, P. R. China
| |
Collapse
|
49
|
Xi W, Guo L, Liu D, Zhou R, Wang Z, Wang W, Liu Z, Wang X, Ostrikov KK, Rong M. Upcycle hazard against other hazard: Toxic fluorides from plasma fluoropolymer etching turn novel microbial disinfectants. JOURNAL OF HAZARDOUS MATERIALS 2022; 424:127658. [PMID: 34802825 DOI: 10.1016/j.jhazmat.2021.127658] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/27/2021] [Revised: 10/12/2021] [Accepted: 10/28/2021] [Indexed: 06/13/2023]
Abstract
The release of toxic fluoride byproducts is a seemingly unavoidable artifact of surface engineering, causing severe environmental and human health problems. Here we propose and implement a new "upcycle hazard against other hazard" concept in the case study of cold atmospheric plasma surface modification of fluoropolymers such as polytetrafluorethylene (PTFE). Capitalizing on the excellent controllability, precision and energy efficiency of the plasma surface processing, complemented with the recently discovered ability of plasmas to activate water to produce a potent electrochemical disinfectant, referred to as the plasma-activated water (PAW), we demonstrate a radically new solution to capture the hazardous gaseous fluorides into the PAW and use the as-fluorinated PAW (F-PAW) as a very effective antimicrobial disinfectant. A customized surface discharge reactor is developed to evaluate the effects of fluorides released from the plasma etching of PTFE on the chemistries in gas-phase plasmas and F-PAW, as well as the antibacterial effect of F-PAW. The results show that gaseous fluorides, including COF2, CF3COF, and SiF4 are produced in gas-phase plasmas, and the dissolution of thus-generated fluorides into PAW has a strong effect on inactivating catalase and destroying the oxidation resistance of bacterial cells. As a result, the antibacterial effect of PAW-fluorides against the methicillin-resistant Staphylococcus aureus (MRSA) is enhanced by > 5 log reductions, suggesting that otherwise hazardous fluorides from the plasma processing of PTFE can be used to enhance the microbial disinfection efficiency of PAW. The demonstrated approach opens new avenues for sustainable hazard valorization exemplified by converting toxic fluoride-etching products into potent antimicrobial and potentially anti-viral disinfectants.
Collapse
Affiliation(s)
- Wang Xi
- State Key Laboratory of Electrical Insulation and Power Equipment, Center for Plasma Biomedicine, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Li Guo
- State Key Laboratory of Electrical Insulation and Power Equipment, Center for Plasma Biomedicine, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Dingxin Liu
- State Key Laboratory of Electrical Insulation and Power Equipment, Center for Plasma Biomedicine, Xi'an Jiaotong University, Xi'an 710049, PR China.
| | - Renwu Zhou
- State Key Laboratory of Electrical Insulation and Power Equipment, Center for Plasma Biomedicine, Xi'an Jiaotong University, Xi'an 710049, PR China; School of Chemical and Biomolecular Engineering, University of Sydney, Sydney, NSW 2006, Australia
| | - Zifeng Wang
- State Key Laboratory of Electrical Insulation and Power Equipment, Center for Plasma Biomedicine, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Wei Wang
- State Key Laboratory of Electrical Insulation and Power Equipment, Center for Plasma Biomedicine, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Zhijie Liu
- State Key Laboratory of Electrical Insulation and Power Equipment, Center for Plasma Biomedicine, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Xiaohua Wang
- State Key Laboratory of Electrical Insulation and Power Equipment, Center for Plasma Biomedicine, Xi'an Jiaotong University, Xi'an 710049, PR China
| | - Kostya Ken Ostrikov
- School of Chemistry and Physics, Centre for Materials Science, Centre for Clean Energy Technologies and Practices, and Centre for a Waste-free World, Queensland University of Technology (QUT), Brisbane, QLD 4000, Australia
| | - Mingzhe Rong
- State Key Laboratory of Electrical Insulation and Power Equipment, Center for Plasma Biomedicine, Xi'an Jiaotong University, Xi'an 710049, PR China
| |
Collapse
|
50
|
Okyere AY, Rajendran S, Annor GA. Cold plasma technologies: Their effect on starch properties and industrial scale-up for starchmodification. Curr Res Food Sci 2022; 5:451-463. [PMID: 35243357 PMCID: PMC8866071 DOI: 10.1016/j.crfs.2022.02.007] [Citation(s) in RCA: 29] [Impact Index Per Article: 14.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/01/2021] [Revised: 01/29/2022] [Accepted: 02/15/2022] [Indexed: 11/28/2022] Open
Abstract
Native starches have limited applications in the food industry due to their unreactive and insoluble nature. Cold plasma technology, including plasma-activated water (PAW), has been explored to modify starches to enhance their functional, thermal, molecular, morphological, and physicochemical properties. Atmospheric cold plasma and low-pressure plasma systems have been used to alter starches and have proven successful. This review provides an in-depth analysis of the different cold plasma setups employed for starch modifications. The effect of cold plasma technology application on starch characteristics is summarized. We also discussed the potential of plasma-activated water as a novel alternative for starch modification. This review provides information needed for the industrial scale-up of cold plasma technologies as an eco-friendly method of starch modification. Cold plasma technology could be an effective, sustainable alternative for starch modification. The extent of modification of starches from different botanical sources depends on the type of cold plasma technology used. For mainstream adoption of cold plasma modified starches, research on safety and consumer perception must be conducted.
Collapse
|