In vitro evaluation of pooled buffy coat platelets treated with photochemical pathogen inactivation using amotosalen

Platelet derived cytokine accumulation in platelet concentrates treated for pathogen reduction

BACKGROUND

Pathogen reduction technologies (PRTs) prevent replication and proliferation of pathogens in platelet (PLT) concentrates (PCs) by modifying nucleic acids. Due to increased cell activation, PRT may also lead to increased cytokine release from α granules and promote adverse transfusion reactions in the recipient.

DESIGN

Fifteen double-dose leukoreduced apheresis PCs were collected on the Trima Accel platform (vs. 5.2.) allowing for the resuspension in PLT additive solution (PAS) immediately after collection. After a 2-h resting period (1st hour without, 2nd hour with agitation), splitting was performed: one unit remained untreated to serve as control (C), while the other was riboflavin-UVB treated using the Mirasol-PRT system according to the manufacturer's instructions (M). During 8 days of storage, PCs were analyzed for contaminating white and red blood cells, bacterial growth, PLT activation, LDH and cytokine release (MIP-1 α, RANTES, PF4, and TGF-β-1). Results obtained were opposed to a former study, where triple-dose PCs underwent Mirasol-PRT prior to resuspension or the INTERCEPT BLOOD SYSTEM (psoralen-UVA) or remained untreated.

RESULTS

Despite similar LDH release, PRT treatment was associated with significantly higher (p<0.05) cell activation but only slightly higher cytokine accumulation during storage. Differences became significant only for PF4 and RANTES at day 8 of storage. On the other hand, in the investigation on triple-dose PCs (yielding higher cytokine levels), TGF beta-1 and RANTES remained significantly (p<0.05) lower after PRT treatment compared to untreated units.

CONCLUSION

Factors, such as collection modality, onset of resuspension and additional amounts of magnesium/potassium in the PAS used may be of equal or even greater impact for cytokine accumulation in stored PCs than PRT treatment.

[Evolution of techniques for preparation of labile blood products (LBP): pathogen inactivation in LBP]

The techniques for inactivation of pathogens in labile blood products (LBP) would appear to be the new strategy which will permit us to increase transfusion safety in the face of the risks of transmission of pathogenic agents by LBP. Various methods are in the course of development or already validated and used in France. The latter only apply however to plasma or platelet concentrates. The mechanisms of action and the efficacy of inactivation and attenuation of pathogenic agents vary with the different techniques. Each of these constitutes a preparative procedure composed of unit steps which have to be fully mastered in order to ensure the quality and transfusion efficacy of the treated product.

Evaluation of White Blood Cell- and Platelet-Derived Cytokine Accumulation in MIRASOL-PRT-Treated Platelets

BACKGROUND: Soluble mediators in platelet concentrates (PCs) released from contaminating white blood cells (WBCs) and platelets (PLTs) themselves are supposed to promote allergic and non-hemolytic febrile transfusion reactions in the recipient. Pathogen reduction technologies (PRTs) prevent replication and proliferation of pathogens as well as of WBCs, and may reduce cytokine accumulation in PCs during storage and prevent adverse events after PLT transfusion. On the other hand, such treatments may also lead to increased cytokine production by stimulation of WBCs or PLTs due to the photochemical or photodynamical process itself. MATERIAL AND METHODS: 12 triple-dose PLT apheresis collections were leukoreduced by the process-controlled leukoreduction system of the Trima Accel machine and split into 3 units undergoing Mirasol-PRT treatment (M) or gamma irradiation (X) or remaining untreated (C). During storage for up to 7 days, PLT activation, WBC-derived Th-1/2, and inflammatory as well as PLT-derived cytokines were measured by cytometric bead array and enzymelinked immunosorbent assay, respectively. RESULTS: Independent of treatment, all PLT products exhibited low levels of WBC-associated cytokines near or below assay detection limits. WBC-associated cytokines were not elevated by Mirasol-PRT treatment. PLT-derived cytokines were detected at higher levels and increased significantly during storage in all units. Most likely due to higher PLT activation, M units showed significantly higher levels of PLT-derived cytokines compared to untreated and gamma-irradiated units on day 5 of storage. CONCLUSION: In all PCs, PLTs themselves were the main source of cytokine release. Mirasol-PRT treatment was associated with a significantly increased PLT activation and accumulation of PLT-derived cytokines during storage, without affecting WBC-derived cytokines relative to controls.

In vitro evaluation of metabolic changes and residual platelet responsiveness in photochemical treated and gamma-irradiated single-donor platelet concentrates during long-term storage

BACKGROUND

Photochemical treatment (PCT) prevents replication of pathogens in platelet concentrates (PCs) by cross-linking nucleic acids and thus affects all cells containing DNA or RNA.

STUDY DESIGN AND METHODS

Fourteen double-dose single-donor PCs were divided into two study arms. The double-dose PCs were split in two identical units, PCT and conventional control PCs. Study Arm A consisted of seven PCT PCs with corresponding untreated controls, whereas Study Arm B consisted of seven PCT PCs with corresponding gamma-irradiated control. Metabolic changes and agonist-induced platelet (PLT) response were evaluated during storage for up to 12 days.

RESULTS

Higher rate of PLT destruction, illustrated by reduced PLT content, increased lactate dehydrogenase levels, and higher CD61+ microparticle formation rate, were observed after PCT. Generally PCT accelerated metabolic changes in PCs and reduced agonist-induced (collagen or thrombin receptor activator peptide [TRAP]) aggregation responses. Flow cytometric analysis of CD62P and CD42b (GPIbalpha) expression showed higher spontaneous PLT activation in PCT PCs from 5 days of storage. Correspondingly, a reduced capacity for up regulation of CD62P expression and down regulation of CD42b was observed in PCT PLTs after stimulation by the agonists ADP or TRAP.

CONCLUSION

Generally reduced in vitro PLT quality was observed after PCT during storage for up to 12 days, with marked reduction from 5 days of storage. Compared to conventional PCs, reduced agonist-induced aggregation and glycoprotein expression were observed after PCT during storage, corresponding to significantly higher level of spontaneous PLT activation in PCT PCs. Clinical studies of efficacy and safety of PCT PCs stored for more than 5 days are recommended.

Cytokine accumulation in photochemically treated and gamma-irradiated platelet concentrates during storage

BACKGROUND

Photochemical treatment (PCT) for pathogen reduction of platelet concentrates (PCs) affects all cells containing DNA and/or RNA. Soluble mediators, which may cause transfusion reactions, are determined by the balance between secretion and/or cell destruction and binding and/or degradation.

STUDY DESIGN AND METHODS

Ten double-dose single-donor leukoreduced PCs were split in two identical units. Two study arms were created: Study Arm A consisting of five PCT PCs with corresponding untreated control PCs and Study Arm B consisting of five PCT PCs with corresponding gamma-irradiated control PCs. PCs that had added PAS-III (Intersol) were treated with amotosalen and ultraviolet A light. Corresponding controls PCs, to which PAS-II (T-sol) were added, received no treatment or were gamma-irradiated before storage. Platelet (PLT)-derived (CCL5/RANTES, CXCL4/PF4, CCL3/MIP-1alpha, transforming growth factor [TGF]-beta, CXCL8/interleukin [IL]-8, IL-1beta) as well as white blood cell (WBC)-associated (IL-6, IL-10, IL-11, IL-12, tumor necrosis factor, interferon-gamma) cytokines were investigated by enzyme-linked immunosorbent assay and cytometric bead array during storage for up to 12 days.

RESULTS

Independent of previous treatment we observed that all concentrates showed low levels of WBC-associated cytokines. PLT-derived cytokines were detected at higher levels and showed significant increase during storage. Statistical analysis showed lower PLT content per unit in PCT PCs, higher levels of activation variables in PCT PCs, and higher levels and accumulation rate of CCL5, CXCL4, TGF-beta, and CXCL8 in PCT PCs.

CONCLUSION

PLTs are the main source of released cytokines during storage of untreated, gamma-irradiated, and PCT PCs. PCT may affect the level of PLT-derived cytokines in PCs. No additional reduction of WBC-associated cytokines were observed after PCT in prestorage leukoreduced PCs.

Pathogen inactivation techniques

The desire to rid the blood supply of pathogens of all types has led to the development of many technologies aimed at the same goal--eradication of the pathogen(s) without harming the blood cells or generating toxic chemical agents. This is a very ambitious goal, and one that has yet to be achieved. One approach is to shun the 'one size fits all' concept and to target pathogen-reduction agents at the Individual component types. This permits the development of technologies that might be compatible with, for example, plasma products but that would be cytocidal and thus incompatible with platelet concentrates or red blood cell units. The technologies to be discussed include solvent detergent and methylene blue treatments--designed to inactivate plasma components and derivatives; psoralens (S-59--amotosalen) designed to pathogen-reduce units of platelets; and two products aimed at red blood cells, S-303 (a Frale--frangible anchor-linker effector compound) and Inactine (a binary ethyleneimine). A final pathogen-reduction material that might actually allow one material to inactivate all three blood components--riboflavin (vitamin B2)--is also under development. The sites of action of the amotosalen (S-59), the S-303 Frale, Inactine, and riboflavin are all localized in the nucleic acid part of the pathogen. Solvent detergent materials act by dissolving the plasma envelope, thus compromising the integrity of the pathogen membrane and rendering it non-infectious. By disrupting the pathogen's ability to replicate or survive, its infectivity is removed. The degree to which bacteria and viruses are affected by a particular pathogen-reducing technology relates to its Gram-positive or Gram-negative status, to the sporulation characteristics for bacteria, and the presence of lipid or protein envelopes for viruses. Concerns related to photoproducts and other breakdown products of these technologies remain, and the toxicology of pathogen-reduction treatments is a major ongoing area of investigation. Clearly, regulatory agencies have a major role to play in the evaluation of these new technologies. This chapter will cover the several types of pathogen-reduction systems, mechanisms of action, the inactivation efficacy for specific types of pathogens, toxicology of the various systems and the published research and clinical trial data supporting their potential usefulness. Due to the nature of the field, pathogen reduction is a work in progress and this review should be considered as a snapshot in time rather than a clear picture of what the future will bring.

De la détection bactérienne à l'inactivation des pathogènes

Bacterial contamination of blood components remains the highest infectious risk in blood transfusion, the risk is particularly high when it affects platelet concentrates (PC). In France, the residual risk of transfusion reaction due to bacterial contamination of PC has been decreasing slowly since 1994 but for all severity 1 case occurs with about 25,000 distributed PC and one death occurs with 200,000 distributed units. This reduction of the risk may be due to the measures which were implemented during the last 10 years in order to prevent contamination during donation. Improving strategies for reducing the risks of bacterial contamination is one of the priorities of the French National Blood Transfusion Service (l'Etablissement Français du sang - EFS). The main target remains PC. Bacterial detection or pathogens inactivation are now available and are able to reduce (for detection) or prevent (for inactivation) the occurrence of reaction due to bacterial contamination of PC. Up to now, the choice is in favour of bacterial detection. A national study was carried out in seven regional EFS at the end of 2004. It aims at confirming the feasibility of a systematic bacterial screening of PC before their delivery. The first conclusions show that this screening can be implemented with acceptable modifications in term of platelets availability. We can expect in a next future that new pathogens reduction technique and/or new detection systems will be available, certainly more efficient to prevent reaction due to bacterial contamination. Implementation of actual detection methods is probably a temporary solution.