1
|
Liu J, Li R, Li Y, Sun Y. Selection of indigenous Saccharomyces cerevisiae strains with good oenological and aroma characteristics for winemaking in Ningxia China. Food Chem X 2024; 23:101693. [PMID: 39184318 PMCID: PMC11342883 DOI: 10.1016/j.fochx.2024.101693] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/11/2024] [Revised: 07/21/2024] [Accepted: 07/22/2024] [Indexed: 08/27/2024] Open
Abstract
Ningxia is one of the well-known wine producing regions in China. However, the oenological and aroma characteristics of indigenous yeasts remains hidden. The fermentative and oenological properties including stress resistance, hydrogen sulfide, foam production levels; killer phenotype, and flocculation of 89 Ningxia indigenous Saccharomyces cerevisiae isolates and ten commercial yeasts were evaluated. The fermentative and oenological properties of the tested strains varied significantly. They could resist 500 g/L glucose, 300 mg/L SO2, 14% (v/v) ethanol and pH 2.8, and produce more esters. They also produce low levels of ethanol and could conduct fermentations vigorously and at a high rate. Cabernet Sauvignon wines made with NXU 21-24 showed the high intensity of tropical fruit, dry fruit, temperate fruit, and spicy flavor. The floral flavor in NXU 21-102 fermented wine is very intense. The indigenous S. cerevisiae strains of NXU 21-102 and NXU 21-24 exhibited potential use as starter cultures in wine production.
Collapse
Affiliation(s)
- Junyu Liu
- College of Enology and Horticulture, Ningxia University, Yinchuan 750021, Ningxia, PR China
| | - Ruirui Li
- School of Food Science and Engineering, Ningxia University, Yinchuan 750021, Ningxia, PR China
| | - Ying Li
- College of Enology and Horticulture, Ningxia University, Yinchuan 750021, Ningxia, PR China
- Engineering Research Center of Grape and Wine, Ministry of Education, Yinchuan 750021, Ningxia, China
| | - Yue Sun
- College of Enology and Horticulture, Ningxia University, Yinchuan 750021, Ningxia, PR China
- Engineering Research Center of Grape and Wine, Ministry of Education, Yinchuan 750021, Ningxia, China
| |
Collapse
|
2
|
Sica J, Vendramini C, Nadai C, Molinelli Z, Carlot M, Giacomini A, Corich V. Strain prevalence and killer factor only partially influence the fermentation activity of pairwise Saccharomyces cerevisiae wine strains inoculation. PLoS One 2024; 19:e0300212. [PMID: 38683869 PMCID: PMC11057759 DOI: 10.1371/journal.pone.0300212] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/09/2023] [Accepted: 02/22/2024] [Indexed: 05/02/2024] Open
Abstract
Commercial Saccharomyces cerevisiae starters are single-strain cultures widely used in winemaking to optimise the fermentation process and improve the organoleptic quality of wine. Unfortunately, the worldwide extensive use of a limited number of industrial strains led to the standardisation of the sensory properties, reducing the identity of wines. Therefore, the use of multi-strain S. cerevisiae starters can be an alternative tool to alter the sensory profile of wines, increasing the diversity of wine styles. However, this strategy may be interesting only if the overall fermentation kinetics is not affected. To date, there is a lack of information regarding the influence of multi-strain starters on the overall fermentation process in wine. In this context, killer toxins, affecting the viability of sensitive strains, can play a significant role. This study aimed to evaluate the effects of pairing eight wine strains of S. cerevisiae (two sensitive, three neutral and three killer) in co-fermentations compared to single-strain fermentations. Results evidenced that, among co-fermentations where the strain prevalence was significant, the killer strains constituted 79% to 100% of the total yeast population when co-inoculated with a sensitive one. However, in most of the cases, co-fermentations kinetics were similar to those of sensitive strains or worse than both strains. Thus, the presence of a killer strain alone is not sufficient to predict the overall fermentation progress, which is an essential information in winemaking. Interestingly, the neutral strain P304.4 was always prevalent, regardless of the second strain and, in most of the co-fermentations, the overall fermentation trend was similar to the P304.4 single-strain fermentation. Regardless of killer activity, our results suggest that the effect of strains on fermentative kinetics is still unpredictable, and further studies are needed to thoroughly explore strain to strain interactions in winemaking.
Collapse
Affiliation(s)
- Jacopo Sica
- Department of Agronomy Food Natural Resources Animals and Environment (DAFNAE), University of Padova, Legnaro (PD), Italy
| | - Chiara Vendramini
- Department of Agronomy Food Natural Resources Animals and Environment (DAFNAE), University of Padova, Legnaro (PD), Italy
| | - Chiara Nadai
- Department of Agronomy Food Natural Resources Animals and Environment (DAFNAE), University of Padova, Legnaro (PD), Italy
- Interdepartmental Centre for Research in Viticulture and Enology (CIRVE), University of Padova, Conegliano (TV), Italy
| | - Zeno Molinelli
- Department of Agronomy Food Natural Resources Animals and Environment (DAFNAE), University of Padova, Legnaro (PD), Italy
| | - Milena Carlot
- Department of Agronomy Food Natural Resources Animals and Environment (DAFNAE), University of Padova, Legnaro (PD), Italy
- Interdepartmental Centre for Research in Viticulture and Enology (CIRVE), University of Padova, Conegliano (TV), Italy
| | - Alessio Giacomini
- Department of Agronomy Food Natural Resources Animals and Environment (DAFNAE), University of Padova, Legnaro (PD), Italy
- Interdepartmental Centre for Research in Viticulture and Enology (CIRVE), University of Padova, Conegliano (TV), Italy
| | - Viviana Corich
- Department of Agronomy Food Natural Resources Animals and Environment (DAFNAE), University of Padova, Legnaro (PD), Italy
- Interdepartmental Centre for Research in Viticulture and Enology (CIRVE), University of Padova, Conegliano (TV), Italy
| |
Collapse
|
3
|
YEHIA HM, EL-KHADRAGY MF, Al-MASOUD AH, RAMADAN EM, EL-DIN MFS. Killer yeast isolated from some foods and its biological activity. FOOD SCIENCE AND TECHNOLOGY 2022. [DOI: 10.1590/fst.119721] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/22/2022]
|
4
|
Sheppard S, Dikicioglu D. Dynamic modelling of the killing mechanism of action by virus-infected yeasts. J R Soc Interface 2020; 16:20190064. [PMID: 30890050 DOI: 10.1098/rsif.2019.0064] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/14/2022] Open
Abstract
Killer yeasts are microorganisms, which can produce and secrete proteinaceous toxins, a characteristic gained via infection by a virus. These toxins are able to kill sensitive cells of the same or a related species. From a biotechnological perspective, killer yeasts are beneficial due to their antifungal/antimicrobial activity, but also regarded as problematic for large-scale fermentation processes, whereby those yeasts would kill starter cultures species and lead to stuck fermentations. Here, we propose a mechanistic model of the toxin-binding kinetics pertaining to the killer population coupled with the toxin-induced death kinetics of the sensitive population to study toxic action. The dynamic model captured the transient toxic activity starting from the introduction of killer cells into the culture at the time of inoculation through to induced cell death. The kinetics of K1/K2 activity via its primary pathway of toxicity was 5.5 times faster than its activity at low concentration inducing the apoptotic pathway in sensitive cells. Conversely, we showed that the primary pathway for K28 was approximately three times slower than its equivalent apoptotic pathway, indicating the particular relevance of K28 in biotechnological applications where the toxin concentration is rarely above those limits to trigger the primary pathway of killer activity.
Collapse
Affiliation(s)
- Sean Sheppard
- 1 St John's College , St John's Street, Cambridge , UK
| | - Duygu Dikicioglu
- 2 Department of Chemical Engineering and Biotechnology, University of Cambridge , Cambridge , UK
| |
Collapse
|
5
|
Belda I, Ruiz J, Alonso A, Marquina D, Santos A. The Biology of Pichia membranifaciens Killer Toxins. Toxins (Basel) 2017; 9:toxins9040112. [PMID: 28333108 PMCID: PMC5408186 DOI: 10.3390/toxins9040112] [Citation(s) in RCA: 53] [Impact Index Per Article: 7.6] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/10/2017] [Revised: 03/07/2017] [Accepted: 03/20/2017] [Indexed: 02/07/2023] Open
Abstract
The killer phenomenon is defined as the ability of some yeast to secrete toxins that are lethal to other sensitive yeasts and filamentous fungi. Since the discovery of strains of Saccharomyces cerevisiae capable of secreting killer toxins, much information has been gained regarding killer toxins and this fact has substantially contributed knowledge on fundamental aspects of cell biology and yeast genetics. The killer phenomenon has been studied in Pichia membranifaciens for several years, during which two toxins have been described. PMKT and PMKT2 are proteins of low molecular mass that bind to primary receptors located in the cell wall structure of sensitive yeast cells, linear (1→6)-β-d-glucans and mannoproteins for PMKT and PMKT2, respectively. Cwp2p also acts as a secondary receptor for PMKT. Killing of sensitive cells by PMKT is characterized by ionic movements across plasma membrane and an acidification of the intracellular pH triggering an activation of the High Osmolarity Glycerol (HOG) pathway. On the contrary, our investigations showed a mechanism of killing in which cells are arrested at an early S-phase by high concentrations of PMKT2. However, we concluded that induced mortality at low PMKT2 doses and also PMKT is indeed of an apoptotic nature. Killer yeasts and their toxins have found potential applications in several fields: in food and beverage production, as biocontrol agents, in yeast bio-typing, and as novel antimycotic agents. Accordingly, several applications have been found for P. membranifaciens killer toxins, ranging from pre- and post-harvest biocontrol of plant pathogens to applications during wine fermentation and ageing (inhibition of Botrytis cinerea, Brettanomyces bruxellensis, etc.).
Collapse
Affiliation(s)
- Ignacio Belda
- Department of Microbiology, Biology Faculty, Complutense University of Madrid, 28040 Madrid, Spain.
| | - Javier Ruiz
- Department of Microbiology, Biology Faculty, Complutense University of Madrid, 28040 Madrid, Spain.
| | - Alejandro Alonso
- Department of Microbiology, Biology Faculty, Complutense University of Madrid, 28040 Madrid, Spain.
| | - Domingo Marquina
- Department of Microbiology, Biology Faculty, Complutense University of Madrid, 28040 Madrid, Spain.
| | - Antonio Santos
- Department of Microbiology, Biology Faculty, Complutense University of Madrid, 28040 Madrid, Spain.
| |
Collapse
|
6
|
Satora P, Cioch M, Tarko T, Wołkowicz J. Killer strains ofSaccharomyces: application for apple wine production. JOURNAL OF THE INSTITUTE OF BREWING 2016. [DOI: 10.1002/jib.338] [Citation(s) in RCA: 6] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/10/2022]
Affiliation(s)
- P. Satora
- Department of Fermentation Technology and Technical Microbiology; University of Agriculture; Krakow Poland
- Malopolska Centre of Biotechnology; Krakow Poland
| | - M. Cioch
- Department of Fermentation Technology and Technical Microbiology; University of Agriculture; Krakow Poland
| | - T. Tarko
- Department of Fermentation Technology and Technical Microbiology; University of Agriculture; Krakow Poland
| | - J. Wołkowicz
- Department of Fermentation Technology and Technical Microbiology; University of Agriculture; Krakow Poland
| |
Collapse
|
7
|
Bajaj BK, Raina S, Singh S. Killer toxin from a novel killer yeastPichia kudriavzeviiRY55 with idiosyncratic antibacterial activity. J Basic Microbiol 2012; 53:645-56. [DOI: 10.1002/jobm.201200187] [Citation(s) in RCA: 41] [Impact Index Per Article: 3.4] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/03/2012] [Accepted: 05/29/2012] [Indexed: 11/06/2022]
Affiliation(s)
| | - Sandeepu Raina
- School of Biotechnology, University of Jammu; Jammu; India
| | - Satbir Singh
- School of Biotechnology, University of Jammu; Jammu; India
| |
Collapse
|
8
|
Maturano YP, Nally MC, Toro ME, Castellanos de Figueroa LI, Combina M, Vazquez F. Monitoring of killer yeast populations in mixed cultures: influence of incubation temperature of microvinifications samples. World J Microbiol Biotechnol 2012; 28:3135-42. [PMID: 22806751 DOI: 10.1007/s11274-012-1123-1] [Citation(s) in RCA: 5] [Impact Index Per Article: 0.4] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/07/2011] [Accepted: 06/30/2012] [Indexed: 10/28/2022]
Abstract
Killer yeasts are frequently used to combat and prevent contamination by wild-type yeasts during wine production and they can even dominate the wine fermentation. Stuck and sluggish fermentations can be caused by an unbalanced ratio of killer to sensitive yeasts in the bioreactor, and therefore it is important to determine the proportion of both populations. The aim of this study was to provide a simple tool to monitor killer yeast populations during controlled mixed microvinifications of killer and sensitive Saccharomyces cerevisiae. Samples were periodically extracted during vinification, seeded on Petri dishes and incubated at 25 and 37 °C; the latter temperature was assayed for possible inactivation of killer toxin production. Colonies developed under the described conditions were randomly transferred to killer phenotype detection medium. Significant differences in the killer/sensitive ratio were observed between both incubation temperatures in all microvinifications. These results suggest that 37 °C seems a better option to determine the biomass of sensitive yeasts, in order to avoid underestimation of sensitive cells in the presence of killer yeasts during fermentations. Incubation at a toxin-inhibiting temperature clearly showed the real ratio of killer to sensitive cells in fermentation systems.
Collapse
|
9
|
Maqueda M, Zamora E, Álvarez ML, Ramírez M. Characterization, ecological distribution, and population dynamics of Saccharomyces sensu stricto killer yeasts in the spontaneous grape must fermentations of southwestern Spain. Appl Environ Microbiol 2012; 78:735-43. [PMID: 22101056 PMCID: PMC3264118 DOI: 10.1128/aem.06518-11] [Citation(s) in RCA: 28] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/11/2011] [Accepted: 11/12/2011] [Indexed: 11/20/2022] Open
Abstract
Killer yeasts secrete protein toxins that are lethal to sensitive strains of the same or related yeast species. Among the four types of Saccharomyces killer yeasts already described (K1, K2, K28, and Klus), we found K2 and Klus killer yeasts in spontaneous wine fermentations from southwestern Spain. Both phenotypes were encoded by medium-size double-stranded RNA (dsRNA) viruses, Saccharomyces cerevisiae virus (ScV)-M2 and ScV-Mlus, whose genome sizes ranged from 1.3 to 1.75 kb and from 2.1 to 2.3 kb, respectively. The K2 yeasts were found in all the wine-producing subareas for all the vintages analyzed, while the Klus yeasts were found in the warmer subareas and mostly in the warmer ripening/harvest seasons. The middle-size isotypes of the M2 dsRNA were the most frequent among K2 yeasts, probably because they encoded the most intense K2 killer phenotype. However, the smallest isotype of the Mlus dsRNA was the most frequent for Klus yeasts, although it encoded the least intense Klus killer phenotype. The killer yeasts were present in most (59.5%) spontaneous fermentations. Most were K2, with Klus being the minority. The proportion of killer yeasts increased during fermentation, while the proportion of sensitive yeasts decreased. The fermentation speed, malic acid, and wine organoleptic quality decreased in those fermentations where the killer yeasts replaced at least 15% of a dominant population of sensitive yeasts, while volatile acidity and lactic acid increased, and the amount of bacteria in the tumultuous and the end fermentation stages also increased in an unusual way.
Collapse
Affiliation(s)
- Matilde Maqueda
- Departamento de Ciencias Biomédicas (Área de Microbiología), Facultad de Ciencias, Universidad de Extremadura, Badajoz, Spain
| | | | | | - Manuel Ramírez
- Departamento de Ciencias Biomédicas (Área de Microbiología), Facultad de Ciencias, Universidad de Extremadura, Badajoz, Spain
| |
Collapse
|
10
|
Ciani M, Comitini F. Non-Saccharomyces wine yeasts have a promising role in biotechnological approaches to winemaking. ANN MICROBIOL 2010. [DOI: 10.1007/s13213-010-0069-5] [Citation(s) in RCA: 97] [Impact Index Per Article: 6.9] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022] Open
|
11
|
Coelho AR, Tachi M, Pagnocca FC, Nobrega GMA, Hoffmann FL, Harada KI, Hirooka EY. Purification of Candida guilliermondii and Pichia ohmeri killer toxin as an active agent against Penicillium expansum. Food Addit Contam Part A Chem Anal Control Expo Risk Assess 2010; 26:73-81. [PMID: 19680874 DOI: 10.1080/02652030802227227] [Citation(s) in RCA: 15] [Impact Index Per Article: 1.1] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/20/2022]
Abstract
An antifungal assay with cell-free culture supernatant of Pichia ohmeri 158 and Candida guilliermondii P3 was tested against Penicillium expansum strain #2 at 25 degrees C by measuring hyphal length and percentage conidia germination. C. guilliermondii was more effective against P. expansum conidia germination (58.15% inhibition), while P. ohmeri showed higher inhibition of mycelial growth (66.17%), indicating a probable mechanism associated with killer activity. This killer toxin (molecular mass <3 kDa) was partially purified by normal phase HPLC, using TSKgel Amide-80 analytical and preparative columns. Compared with crude extract, the killer toxin eluted from the post analytical column significantly inhibited P. expansum:% inhibition rose from 42.16 to 90.93% (C. guilliermondii) and 39.32 to 91.12% (P. ohmeri) (p < 0.05). The one-step purification process was adequate in isolating killer toxin from culture supernatant and also increased anti-Penicillium activity.
Collapse
|
12
|
ORTIZ-ZAMORA O, CORTÉS-GARCÍA R, RAMÍREZ-LEPE M, GÓMEZ-RODRÍGUEZ J, AGUILAR-USCANGA M. ISOLATION AND SELECTION OF ETHANOL-RESISTANT AND OSMOTOLERANT YEASTS FROM REGIONAL AGRICULTURAL SOURCES IN MEXICO. J FOOD PROCESS ENG 2009. [DOI: 10.1111/j.1745-4530.2008.00244.x] [Citation(s) in RCA: 13] [Impact Index Per Article: 0.9] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/26/2022]
|
13
|
Santos A, San Mauro M, Bravo E, Marquina D. PMKT2, a new killer toxin from Pichia membranifaciens, and its promising biotechnological properties for control of the spoilage yeast Brettanomyces bruxellensis. MICROBIOLOGY-SGM 2009; 155:624-634. [PMID: 19202111 DOI: 10.1099/mic.0.023663-0] [Citation(s) in RCA: 89] [Impact Index Per Article: 5.9] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/18/2022]
Abstract
Pichia membranifaciens CYC 1086 secretes a killer toxin (PMKT2) that is inhibitory to a variety of spoilage yeasts and fungi of agronomical interest. The killer toxin in the culture supernatant was concentrated by ultrafiltration and purified to homogeneity by two successive steps, including native electrophoresis and HPLC gel filtration. Biochemical characterization of the toxin showed it to be a protein with an apparent molecular mass of 30 kDa and an isoelectric point of 3.7. At pH 4.5, optimal killer activity was observed at temperatures up to 20 degrees C. Above approximately this pH, activity decreased sharply and was barely noticeable at pH 6. The toxin concentrations present in the supernatant during optimal production conditions exerted a fungicidal effect on a variety of fungal and yeast strains. The results obtained suggest that PMKT2 has different physico-chemical properties from PMKT as well as different potential uses in the biocontrol of spoilage yeasts. PMKT2 was able to inhibit Brettanomyces bruxellensis while Saccharomyces cerevisiae was fully resistant, indicating that PMKT2 could be used in wine fermentations to avoid the development of the spoilage yeast without deleterious effects on the fermentative strain. In small-scale fermentations, PMKT2, as well as P. membranifaciens CYC 1086, was able to inhibit B. bruxellensis, verifying the biocontrol activity of PMKT2 in simulated winemaking conditions.
Collapse
Affiliation(s)
- A Santos
- Department of Microbiology, Biology Faculty, Complutense University of Madrid, 28040 Madrid, Spain
| | - M San Mauro
- Department of Microbiology, Biology Faculty, Complutense University of Madrid, 28040 Madrid, Spain
| | - E Bravo
- Department of Microbiology, Biology Faculty, Complutense University of Madrid, 28040 Madrid, Spain
| | - D Marquina
- Department of Microbiology, Biology Faculty, Complutense University of Madrid, 28040 Madrid, Spain
| |
Collapse
|
14
|
Buzzini P, Turchetti B, Vaughan-Martini AE. The use of killer sensitivity patterns for biotyping yeast strains: the state of the art, potentialities and limitations. FEMS Yeast Res 2007; 7:749-60. [PMID: 17425671 DOI: 10.1111/j.1567-1364.2007.00238.x] [Citation(s) in RCA: 28] [Impact Index Per Article: 1.6] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/30/2022] Open
Abstract
In recent years molecular techniques have been the most useful tools for the unequivocal identification of undetermined strains at the species level. In many instances, however, a further discrimination at the strain level (biotyping) is required, such as during epidemiological investigations, in which the distribution of pathogenic microorganisms is studied, and for patent protection purposes. Although molecular methods are routinely used also for yeast biotyping, several nonmolecular techniques have been proposed. One of these, the determination of the killer sensitivity pattern (KSP) towards a panel of selected killer toxins has proven to be a good auxiliary method. Despite the plethora of studies published, the potential and limitations of the determination of KSPs have never been critically evaluated. In this review the use of this nonmolecular technique as a biotyping tool is discussed and compared with some currently used DNA-based procedures. In addition, methodological, mechanistic and ecological implications are evaluated.
Collapse
Affiliation(s)
- Pietro Buzzini
- Dipartimento di Biologia Vegetale e Biotecnologie Agroambientali, Sezione di Microbiologia Applicata, University of Perugia, Perugia, Italy.
| | | | | |
Collapse
|
15
|
Ambrona J, Vinagre A, Maqueda M, Alvarez ML, Ramírez M. Rhodamine-pink as a genetic marker for yeast populations in wine fermentation. JOURNAL OF AGRICULTURAL AND FOOD CHEMISTRY 2006; 54:2977-84. [PMID: 16608218 DOI: 10.1021/jf052844d] [Citation(s) in RCA: 11] [Impact Index Per Article: 0.6] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 05/08/2023]
Abstract
Winemaking with selected yeasts requires simple techniques to monitor the inoculated yeast. New high-concentration rhodamine-resistant mutants and low-concentration rhodamine-pink mutants, easy to detect by replica-plate assay, were obtained from selected wine yeasts. The rhodamine-pink mutations were dominant and were located at the pdr5 locus that encodes for the Pdr5 ATP-binding cassette multidrug resistance transporter. The mutants were genetically stable but had lost the killer phenotype of the parent yeast strain. They were genetically improved by elimination of recessive growth-retarding alleles followed by crossing with selected killer wine yeasts. Several spore-clones were selected according to their must fermentation kinetics and the organoleptic quality of the wine. Some spore-clones were tested in industrial winemaking, and they were easily monitored during must fermentation using a simple color-plate assay. They accounted for >96% of the total yeasts in the must, and the resulting wine had as good a quality as those made with standard commercial wine yeasts. The rhodamine-pink yeasts may also be detected by direct seeding onto rhodamine agar or by observation under fluorescence microscopy. These possibilities greatly reduce the time of analysis and make the monitoring procedure for rhodamine-pink yeasts faster, easier, and cheaper than for the genetically marked wine yeasts obtained previously.
Collapse
Affiliation(s)
- Jesús Ambrona
- Departamento de Microbiología, Facultad de Ciencias, Universidad de Extremadura, 06071 Badajoz, Spain
| | | | | | | | | |
Collapse
|
16
|
Ambrona J, Maqueda M, Zamora E, Ramírez M. Sulfometuron resistance as a genetic marker for yeast populations in wine fermentations. JOURNAL OF AGRICULTURAL AND FOOD CHEMISTRY 2005; 53:7438-43. [PMID: 16159170 DOI: 10.1021/jf0514468] [Citation(s) in RCA: 9] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 05/04/2023]
Abstract
Winemaking with selected yeasts requires simple and cheap techniques to monitor the yeast population dynamics. We obtained new sulfometuron (smr) resistant mutants, easy to detect by replica-plate assay, from selected wine yeasts. The mutations were dominant and were located at the ilv2 locus that encodes for acetolactate synthase enzyme. The mutants were genetically stable and maintained the killer phenotype of the parent yeast strain. They were genetically improved by elimination of recessive growth-retarding alleles followed by spore clone selection according to the must fermentation kinetics and the organoleptic quality of the wine. Some mutants were tested in industrial winemaking and were easily monitored during must fermentation using a simple plate assay. They accounted for more than 95% of the total yeasts in the must, and the resulting wine had as good a quality as those made with standard commercial wine yeasts.
Collapse
Affiliation(s)
- Jesús Ambrona
- Departamento de Microbiología, Facultad de Ciencias, Universidad de Extremadura, Badajoz, Spain
| | | | | | | |
Collapse
|
17
|
Santos A, Marquina D, Leal JA, Peinado JM. (1-->6)-beta-D-glucan as cell wall receptor for Pichia membranifaciens killer toxin. Appl Environ Microbiol 2000; 66:1809-13. [PMID: 10788343 PMCID: PMC101416 DOI: 10.1128/aem.66.5.1809-1813.2000] [Citation(s) in RCA: 92] [Impact Index Per Article: 3.8] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/20/2022] Open
Abstract
The killer toxin from Pichia membranifaciens CYC 1106, a yeast isolated from fermenting olive brines, binds primarily to the (1-->6)-beta-D-glucan of the cell wall of a sensitive yeast (Candida boidinii IGC 3430). The (1-->6)-beta-D-glucan was purified from cell walls of C. boidinii by alkali and hot-acetic acid extraction, a procedure which solubilizes glucans. The major fraction of receptor activity remained with the alkali-insoluble (1-->6)-beta- and (1-->3)-beta-D-glucans. The chemical (gas-liquid chromatography) and structural (periodate oxidation, infrared spectroscopy, and (1)H nuclear magnetic resonance) analyses of the fractions obtained showed that (1-->6)-beta-D-glucan was a receptor. Adsorption of most of the killer toxin to the (1-->6)-beta-D-glucan was complete within 2 min. Killer toxin adsorption to the linear (1-->6)-beta-D-glucan, pustulan, and a glucan from Penicillium allahabadense was observed. Other polysaccharides with different linkages failed to bind the killer toxin. The specificity of the killer toxin for its primary receptor provides an effective means to purify the killer toxin, which may have industrial applications for fermentations in which salt is present as an adjunct, such as olive brines. This toxin shows its maximum killer activity in the presence of NaCl. This report is the first to identify the (1-->6)-beta-D-glucan as a receptor for this novel toxin.
Collapse
Affiliation(s)
- A Santos
- Department of Microbiology, Biology Faculty, Complutense University of Madrid, Madrid 28040, Spain
| | | | | | | |
Collapse
|
18
|
Lowes KF, Shearman CA, Payne J, MacKenzie D, Archer DB, Merry RJ, Gasson MJ. Prevention of yeast spoilage in feed and food by the yeast mycocin HMK. Appl Environ Microbiol 2000; 66:1066-76. [PMID: 10698773 PMCID: PMC91944 DOI: 10.1128/aem.66.3.1066-1076.2000] [Citation(s) in RCA: 64] [Impact Index Per Article: 2.7] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/29/1999] [Accepted: 11/24/1999] [Indexed: 11/20/2022] Open
Abstract
The yeast Williopsis mrakii produces a mycocin or yeast killer toxin designated HMK; this toxin exhibits high thermal stability, high pH stability, and a broad spectrum of activity against other yeasts. We describe construction of a synthetic gene for mycocin HMK and heterologous expression of this toxin in Aspergillus niger. Mycocin HMK was fused to a glucoamylase protein carrier, which resulted in secretion of biologically active mycocin into the culture media. A partial purification protocol was developed, and a comparison with native W. mrakii mycocin showed that the heterologously expressed mycocin had similar physiological properties and an almost identical spectrum of biological activity against a number of yeasts isolated from silage and yoghurt. Two food and feed production systems prone to yeast spoilage were used as models to assess the ability of mycocin HMK to act as a biocontrol agent. The onset of aerobic spoilage in mature maize silage was delayed by application of A. niger mycocin HMK on opening because the toxin inhibited growth of the indigenous spoilage yeasts. This helped maintain both higher lactic acid levels and a lower pH. In yoghurt spiked with dairy spoilage yeasts, A. niger mycocin HMK was active at all of the storage temperatures tested at which yeast growth occurred, and there was no resurgence of resistant yeasts. The higher the yeast growth rate, the more effective the killing action of the mycocin. Thus, mycocin HMK has potential applications in controlling both silage spoilage and yoghurt spoilage caused by yeasts.
Collapse
Affiliation(s)
- K F Lowes
- Institute of Food Research, Norwich Research Park, Colney, Norwich NR4 7UA, United Kingdom
| | | | | | | | | | | | | |
Collapse
|
19
|
Musmanno RA, Coratza G. Studies on strong and weak killer phenotypes of wine yeasts: production, activity of toxin in must, and its effect in mixed culture fermentation. J Appl Microbiol 1999; 87:932-938. [PMID: 10692075 DOI: 10.1046/j.1365-2672.1999.00954.x] [Citation(s) in RCA: 13] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/20/2022]
Abstract
Two different killer phenotypes were detected among K+ (killer) yeasts isolated from spontaneous wine fermentations using a plate bioassay. The two phenotypes differed in their degree of killer activity, and were designated as SK+(strong killer) and WK+(weak killer). Strains showing either phenotype were assayed for expression of killer activity under different growth conditions. Growth in must negatively affected expression of the killer activity of both phenotypes. The supernatant fluids from must cultures showed a lower killing effect than those from yeast phosphate dextrose broth (YPDB) cultures. The ability of the two K+ phenotypes to prevail on K-sensitive yeasts was studied in mixed-culture fermentation experiments. Under these conditions, only strains showing SK+ phenotype were able to prevail on the K-sensitive yeasts. These results suggest that the K+ phenotype could play a relevant role in spontaneous fermentations provided that the strain exhibits an SK+ phenotype, and that the latter phenotype should be preferred when selected K + strains are to be used as fermentation starters.
Collapse
Affiliation(s)
- RA Musmanno
- Dipartimento di Biologia Molecolare - Sezione di Microbiologia, Università degli Studi di Siena, Siena, Italy
| | | |
Collapse
|
20
|
Soares GA, Sato HH. Killer toxin of Saccharomyces cerevisiae Y500-4L active against Fleischmann and Itaiquara commercial brands of yeast. ACTA ACUST UNITED AC 1999. [DOI: 10.1590/s0001-37141999000300012] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.1] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/21/2022]
Abstract
The strain Saccharomyces cerevisiae Y500-4L, previously selected from the must of alcohol producing plants and showing high fermentative and killer capacities, was characterized according to the interactions between the yeasts and examined for curing and detection of dsRNA plasmids, which code for the killer character. The killer yeast S. cerevisiae Y500-4L showed considerable killer activity against the Fleischmann and Itaiquara commercial brands of yeast and also against the standard killer yeasts K2 (S. diastaticus NCYC 713), K4 (Candida glabrata NCYC 388) and K11 (Torulopsis glabrata ATCC 15126). However S. cerevisiae Y500-4L showed sensitivity to the killer toxin produced by the standard killer yeasts K8 (Hansenula anomala NCYC 435), K9 (Hansenula mrakii NCYC 500), K10 (Kluyveromyces drosophilarum NCYC 575) and K11 (Torulopsis glabrata ATCC 15126). No M-dsRNA plasmid was detected in the S. cerevisiae Y500-4L strain and these results suggest that the genetic basis for toxin production is encoded by chromosomal DNA. The strain S. cerevisiae Y500-4L was more resistant to the loss of the phenotype killer with cycloheximide and incubation at elevated temperatures (40oC) than the standard killer yeast S. cerevisiae K1.
Collapse
|
21
|
Abstract
The killer phenomenon in yeasts has been revealed to be a multicentric model for molecular biologists, virologists, phytopathologists, epidemiologists, industrial and medical microbiologists, mycologists, and pharmacologists. The surprisingly widespread occurrence of the killer phenomenon among taxonomically unrelated microorganisms, including prokaryotic and eukaryotic pathogens, has engendered a new interest in its biological significance as well as its theoretical and practical applications. The search for therapeutic opportunities by using yeast killer systems has conceptually opened new avenues for the prevention and control of life-threatening fungal diseases through the idiotypic network that is apparently exploited by the immune system in the course of natural infections. In this review, the biology, ecology, epidemiology, therapeutics, serology, and idiotypy of yeast killer systems are discussed.
Collapse
Affiliation(s)
- W Magliani
- Istituto di Microbiologia, Facoltà di Medicina e Chirurgia, Università degli Studi di Parma, Italy
| | | | | | | | | |
Collapse
|
22
|
Medina K, Carrau FM, Gioia O, Bracesco N. Nitrogen availability of grape juice limits killer yeast growth and fermentation activity during mixed-culture fermentation with sensitive commercial yeast strains. Appl Environ Microbiol 1997; 63:2821-5. [PMID: 9212430 PMCID: PMC168579 DOI: 10.1128/aem.63.7.2821-2825.1997] [Citation(s) in RCA: 13] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 02/04/2023] Open
Abstract
The competition between selected or commercial killer strains of type K2 and sensitive commercial strains of Saccharomyces cerevisiae was studied under various conditions in sterile grape juice fermentations. The focus of this study was the effect of yeast inoculation levels and the role of assimilable nitrogen nutrition on killer activity. A study of the consumption of free amino nitrogen (FAN) by pure and mixed cultures of killer and sensitive cells showed no differences between the profiles of nitrogen assimilation in all cases, and FAN was practically depleted in the first 2 days of fermentation. The effect of the addition of assimilable nitrogen and the size of inoculum was examined in mixed killer and sensitive strain competitions. Stuck and sluggish wine fermentations were observed to depend on nitrogen availability when the ratio of killer to sensitive cells was low (1:10 to 1:100). A relationship between the initial assimilable nitrogen content of must and the proportion of killer cells during fermentation was shown. An indirect relationship was found between inoculum size and the percentage of killer cells: a smaller inoculum resulted in a higher proportion of killer cells in grape juice fermentations. In all cases, wines obtained with pure-culture fermentations were preferred to mixed-culture fermentations by sensory analysis. The reasons why killer cells do not finish fermentation under competitive conditions with sensitive cells are discussed.
Collapse
Affiliation(s)
- K Medina
- Catedra de Ciencia y Tecnologia de los Alimentos, Facultad de Quimica, Universidad de la Republica, Montevideo, Uruguay
| | | | | | | |
Collapse
|
23
|
Abstract
Microflora in wound sites of preharvest maize (including bacteria, yeasts, and filamentous fungi) may play a role in attracting insects to maize plants and may also interact with growth and mycotoxin production by filamentous fungi. As little data are available about the yeasts occurring on maize from the U.S. corn belt, samples of milled maize from experimental plantings at the University of Illinois River Valley Sand Field were analyzed. Yeast counts showed slight yearly fluctuation and varied between 3.60 and 5.88 (log cfu/g maize). The majority of the yeasts were Candida guilliermondii (approximately 55%), Candida zeylanoides (24%), Candida shehatae (11%), and Debaryomyces hansenii (3%). Also present were Trichosporon cutaneum, Cryptococcus albidus var. aerius, and Pichia membranifaciens. The occurrence of killer yeasts was also evaluated. Killer yeasts were detected in maize for the first time and were identified as Trichosporon cutaneum and Candid zeylanoides. These were able to kill some representative yeasts isolated from maize, including Candida guilliermondii, Candida shehatae, and Cryptococcus albidus var. aerius. Other maize yeasts (Candida zeylanoides, Debaryomyces hansenii, Pichia membranifaciens) were not affected. The majority of yeasts found on maize were unable to ferment its major sugars, i.e., sucrose and maltose. Some (e.g., Candida zeylanoides) were not even able to assimilate these sugars. The importance of these properties in relation to insect attraction to preharvest ears of maize is discussed.
Collapse
Affiliation(s)
- M J Nout
- Department of Food Science, Agricultural University, Wageningen, The Netherlands.
| | | | | |
Collapse
|
24
|
Llorente P, Marquina D, Santos A, Peinado JM, Spencer-Martins I. Effect of salt on the killer phenotype of yeasts from olive brines. Appl Environ Microbiol 1997; 63:1165-7. [PMID: 9055432 PMCID: PMC168407 DOI: 10.1128/aem.63.3.1165-1167.1997] [Citation(s) in RCA: 58] [Impact Index Per Article: 2.1] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 02/03/2023] Open
Abstract
The killer properties of yeasts isolated from olive brines were examined in the absence and presence of sodium chloride in concentrations of up to 6% (wt/vol). An apparent enhancement of the killing action as the salt concentration increased, as well as changes in the spectra of activity against selected target strains, was observed in a few strains. Culture filtrates from killer strains grown at different NaCl concentrations (0, 3, or 6% [wt/vol]) were tested against sensitive yeasts cultivated under the same conditions. While the sensitivity of the target strain greatly increased in the presence of salt, no significant effect on toxin production was noticed.
Collapse
Affiliation(s)
- P Llorente
- Departamento de Microbiología, Facultad de Biología, Universidad Complutense de Madrid, Spain
| | | | | | | | | |
Collapse
|
25
|
Carrau FM, Neirotti E, Gioia O. Stuck wine fermentations: Effect of killer/sensitive yeast interactions. ACTA ACUST UNITED AC 1993. [DOI: 10.1016/0922-338x(93)90056-e] [Citation(s) in RCA: 17] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/27/2022]
|