Rapid assessment of bovine spongiform encephalopathy prion inactivation by heat treatment in yellow grease produced in the industrial manufacturing process of meat and bone meals

Meat and bone meal biochar can effectively reduce chemical fertilizer requirements for crop production and impart competitive advantages to soil

Safe and effective circulation of nutrient-rich meat and bone meal (MBM) could become a carbon-based alternative to limited chemical fertilizers (CFs). Therefore, MBM biochars (MBMCs) were produced at 500, 800, and 1000 °C to evaluate their effects on plant growth, nutrient uptake, and soil characteristics. The results revealed that MBMC produced at 500 °C (MBMC500) contained the maximum amount of C, N, and phytoavailable P. All additional MBMC doses with recommended CF increased sorghum shoot yield (6.7-16%) and significantly improved P uptake. Additional experiments were conducted with decreasing doses of CF (100-0%) with or without MBMC500 (7 t/ha) to quantify its actual fertilizing value. MBMC500 showed the capability to reduce CF requirement by 20% without compromising the optimum yield (by 100% CF) while increasing pH, CEC, total-N, available-P, Mg, and microbial population of post-harvest soil. Although a δ¹⁵N analysis confirmed MBMC500 as a source of plant N, a reduction in N uptake by MBMC500 + 80% CF treatment compared to 100% CF might have limited further sorghum growth. Thus, future studies should concentrate on producing MBMC with better N utilization capability and achieving maximum CF reduction without negative environmental impacts.

Biodegradation of bovine spongiform encephalopathy prions in compost

To reduce the transmission risk of bovine spongiform encephalopathy prions (PrPBSE), specified risk materials (SRM) that can harbour PrPBSE are prevented from entering the feed and food chains. As composting is one approach to disposing of SRM, we investigated the inactivation of PrPBSE in lab-scale composters over 28 days and in bin composters over 106-120 days. Lab-scale composting was conducted using 45 kg of feedlot manure with and without chicken feathers. Based on protein misfolding cyclic amplification (PMCA), after 28 days of composting, PrPBSE seeding activity was reduced by 3-4 log10 with feathers and 3 log10 without. Bin composters were constructed using ~ 2200 kg feedlot manure and repeated in 2017 and 2018. PMCA results showed that seeding activity of PrPBSE was reduced by 1-2 log10 in the centre, but only by 1 log10 in the bottom of bin composters. Subsequent assessment by transgenic (Tgbov XV) mouse bioassay confirmed a similar reduction in PrPBSE infectivity. Enrichment for proteolytic microorganisms through the addition of feathers to compost could enhance PrPBSE degradation. In addition to temperature, other factors including varying concentrations of PrPBSE and the nature of proteolytic microbial populations may be responsible for differential degradation of PrPBSE during composting.

Subclinical infection occurs frequently following low dose exposure to prions by blood transfusion

Infectious prion diseases have very long incubation periods, and the role that subclinical infections play in transmission, persistence and re-emergence of these diseases is unclear. In this study, we used a well-established model of vCJD (sheep experimentally infected with bovine spongiform encephalopathy, BSE) to determine the prevalence of subclinical infection following exposure by blood transfusion from infected donors. Many recipient sheep survived for years post-transfusion with no clinical signs and no disease-associated PrP (PrP^Sc) found in post mortem tissue samples by conventional tests. Using a sensitive protein misfolding cyclic amplification assay (PMCA), we found that the majority of these sheep had detectable PrP^Sc in lymph node samples, at levels approximately 10⁵-10⁶ times lower than in equivalent samples from clinically positive sheep. Further testing revealed the presence of PrP^Sc in other tissues, including brain, but not in blood samples. The results demonstrate that subclinical infection is a frequent outcome of low dose prion infection by a clinically relevant route for humans (blood transfusion). The long term persistence of low levels of infection has important implications for prion disease control and the risks of re-emergent infections in both humans and animals.

Assessing the aggregated probability of entry of a novel prion disease agent into the United Kingdom

In 2018 prion disease was detected in camels at an abattoir in Algeria for the first time. The emergence of prion disease in this species made it prudent to assess the probability of entry of the pathogen into the United Kingdom (UK) from this region. Potentially contaminated products were identified as evidenced by other prion diseases. The aggregated probability of entry of the pathogen was estimated as very high and high for legal milk and cheese imports respectively and very high, high and high for illegal meat, milk and cheese products respectively. This aggregated probability represents a qualitative assessment of the probability of one or more entry events per year into the UK; it gives no indication of the number of entry events per year. The uncertainty associated with these estimates was high due to the unknown variation in prevalence of infection in camels and an uncertain number and type of illegal products entering the UK. Potential public health implications of this pathogen are unknown although there is currently no evidence of zoonotic transmission of prion diseases other than bovine spongiform encephalopathy to humans.

Eliminating transmissibility of bovine spongiform encephalopathy by dry-heat treatment

Bovine spongiform encephalopathy (BSE) prion is more resistant to heat inactivation compared to other prions, but the effect of heat inactivation has been reported to differ depending on the BSE-contaminated tissue state or heating type. We aimed to evaluate the secure level of inactivation of original BSE transmissibility by dry-heating. Cattle tissues affected with BSE were subjected to dry-heat treatment for 20 min at various temperatures ranging from 150 to 1000 °C. To assess the inactivation effect, we conducted protein misfolding cyclic amplification (PMCA) and follicular dendritic cell (FDC) assays in transgenic mice expressing bovine prion protein genes. Under dry-heating at 600 °C or higher, BSE cattle tissues lost their transmissibility in transgenic mice. In contrast, transmissibility was detected in the cattle tissues treated at temperatures of 400 °C or lower through the FDC assay combined with PMCA. In this study, we confirmed that transmissibility was eliminated in BSE-affected cattle tissues by dry-heating at 600 °C or higher.

Evaluation of the Application for new alternative biodiesel production process for rendered fat of Cat 1 (BDI-RepCat process, AT)

A new alternative method for the production of biodiesel from rendered fat of all categories of animal by‐products was assessed. The process was compared to the approved biodiesel production process described in Chapter IV Section 2 D of Annex IV of Commission Regulation (EU) 142/2011. Tallow derived from Category 1 material is treated according to Method 1 from the same Regulation (133°C, 20 min, 3 bar) and subsequently mixed with 15% methanol, heated to reaction temperature (220°C) in several heat exchangers and transferred into the continuous conversion reactor by means of a high pressure pump (80 bar) for 30 min. In the conversion phase, there is an exposure to methanol in the absence of alkaline or acidic conditions. The impact of this procedure on the thermostability of transmissible spongiform encephalopathy (TSE) has not been assessed in the literature. After the reaction, the biodiesel/glycerol mixture is distilled under vacuum at a minimum temperature of 150°C and a maximum pressure of 10 mbar, which is equivalent to the distillation step in the approved biodiesel production process, for which a 3 log₁₀ reduction factor in PrP27–30 was obtained. Therefore, a similar level of TSE infectivity reduction could be expected for that phase of the method. A previous EFSA Opinion established that a reduction of 6 log₁₀ in TSE infectivity should be achieved by any proposed alternative method in order to be equivalent to the approved processing method. This level of reduction has not been shown with experimental trials run under conditions equivalent to the ones described for the RepCat process. It was not possible to conclude whether or not the level of TSE infectivity reduction in the RepCat process is at least of 6 log₁₀. Therefore, it was also not possible to conclude about the equivalence with the approved biodiesel production process.

Selective propagation of mouse-passaged scrapie prions with long incubation period from a mixed prion population using GT1-7 cells

In our previous study, we demonstrated the propagation of mouse-passaged scrapie isolates with long incubation periods (L-type) derived from natural Japanese sheep scrapie cases in murine hypothalamic GT1-7 cells, along with disease-associated prion protein (PrPSc) accumulation. We here analyzed the susceptibility of GT1-7 cells to scrapie prions by exposure to infected mouse brains at different passages, following interspecies transmission. Wild-type mice challenged with a natural sheep scrapie case (Kanagawa) exhibited heterogeneity of transmitted scrapie prions in early passages, and this mixed population converged upon one with a short incubation period (S-type) following subsequent passages. However, when GT1-7 cells were challenged with these heterologous samples, L-type prions became dominant. This study demonstrated that the susceptibility of GT1-7 cells to L-type prions was at least 105 times higher than that to S-type prions and that L-type prion-specific biological characteristics remained unchanged after serial passages in GT1-7 cells. This suggests that a GT1-7 cell culture model would be more useful for the economical and stable amplification of L-type prions at the laboratory level. Furthermore, this cell culture model might be used to selectively propagate L-type scrapie prions from a mixed prion population.

Rapid and Highly Sensitive Detection of Variant Creutzfeldt-Jakob Disease Abnormal Prion Protein on Steel Surfaces by Protein Misfolding Cyclic Amplification: Application to Prion Decontamination Studies

The prevalence of variant Creutzfeldt-Jakob disease (vCJD) in the population remains uncertain, although it has been estimated that 1 in 2000 people in the United Kingdom are positive for abnormal prion protein (PrP^TSE) by a recent survey of archived appendix tissues. The prominent lymphotropism of vCJD prions raises the possibility that some surgical procedures may be at risk of iatrogenic vCJD transmission in healthcare facilities. It is therefore vital that decontamination procedures applied to medical devices before their reprocessing are thoroughly validated. A current limitation is the lack of a rapid model permissive to human prions. Here, we developed a prion detection assay based on protein misfolding cyclic amplification (PMCA) technology combined with stainless-steel wire surfaces as carriers of prions (Surf-PMCA). This assay allowed the specific detection of minute quantities (10⁻⁸ brain dilution) of either human vCJD or ovine scrapie PrP^TSE adsorbed onto a single steel wire, within a two week timeframe. Using Surf-PMCA we evaluated the performance of several reference and commercially available prion-specific decontamination procedures. Surprisingly, we found the efficiency of several marketed reagents to remove human vCJD PrP^TSE was lower than expected. Overall, our results demonstrate that Surf-PMCA can be used as a rapid and ultrasensitive assay for the detection of human vCJD PrP^TSE adsorbed onto a metallic surface, therefore facilitating the development and validation of decontamination procedures against human prions.

Subcritical Water Hydrolysis Effectively Reduces the In Vitro Seeding Activity of PrPSc but Fails to Inactivate the Infectivity of Bovine Spongiform Encephalopathy Prions

The global outbreak of bovine spongiform encephalopathy (BSE) has been attributed to the recycling of contaminated meat and bone meals (MBMs) as feed supplements. The use of MBMs has been prohibited in many countries; however, the development of a method for inactivating BSE prions could enable the efficient and safe use of these products as an organic resource. Subcritical water (SCW), which is water heated under pressure to maintain a liquid state at temperatures below the critical temperature (374°C), exhibits strong hydrolytic activity against organic compounds. In this study, we examined the residual in vitro seeding activity of protease-resistant prion protein (PrP^Sc) and the infectivity of BSE prions after SCW treatments. Spinal cord homogenates prepared from BSE-infected cows were treated with SCW at 230–280°C for 5–7.5 min and used to intracerebrally inoculate transgenic mice overexpressing bovine prion protein. Serial protein misfolding cyclic amplification (sPMCA) analysis detected no PrP^Sc in the SCW-treated homogenates, and the mice treated with these samples survived for more than 700 days without any signs of disease. However, sPMCA analyses detected PrP^Sc accumulation in the brains of all inoculated mice. Furthermore, secondary passage mice, which inoculated with brain homogenates derived from a western blotting (WB)-positive primary passage mouse, died after an average of 240 days, similar to mice inoculated with untreated BSE-infected spinal cord homogenates. The PrP^Sc accumulation and vacuolation typically observed in the brains of BSE-infected mice were confirmed in these secondary passage mice, suggesting that the BSE prions maintained their infectivity after SCW treatment. One late-onset case, as well as asymptomatic but sPMCA-positive cases, were also recognized in secondary passage mice inoculated with brain homogenates from WB-negative but sPMCA-positive primary passage mice. These results indicated that SCW-mediated hydrolysis was insufficient to eliminate the infectivity of BSE prions under the conditions tested.