Challenges and advances in the development of inhalable drug formulations for cystic fibrosis lung disease

Pulmonary Delivery of Antibiotics to the Lungs: Current State and Future Prospects

This paper presents a comprehensive review of the current literature, clinical trials, and products approved for the delivery of antibiotics to the lungs. While there are many literature reports describing potential delivery systems, few of these have translated into marketed products. Key challenges remaining are the high doses required and, for powder formulations, the ability of the inhaler and powder combination to deliver the dose to the correct portion of the respiratory tract for maximum effect. Side effects, safety concerns, and disappointing clinical trial results remain barriers to regulatory approval. In this review, we describe some possible approaches to address these issues and highlight prospects in this area.

Design and development of DSPE-PEG2000/DPPC disk-like micelles for targeted delivery of icariin phytochemical in pulmonary fibrosis

Icariin (ICA)-loaded DSPE-PEG2000/DPPC disk-like micelles were synthesized utilizing the thin film hydration method to enhance the solubility and delivery of ICA to the lungs. The micellar formulation significantly improved the water solubility of ICA. This was attributed to the high encapsulation efficiency (95 %) and drug loading capacity (12 %) of the DSPE-PEG2000/DPPC micelles. Comprehensive characterization using Fourier-transform infrared spectroscopy (FT-IR) and X-ray diffraction (XRD). Particle size analysis through dynamic light scattering (DLS) and transmission electron microscopy (TEM) demonstrated the formation of stable micelles with an average particle size around 10 nm. In vitro aerosolization studies using the next-generation impactor (NGI) revealed that the fine particle fraction was 63.5 ± 4 %, which means that over 60 % of the aerosolized ICA/DSPE-PEG2000/DPPC micelles were capable of reaching and targeting the deep lung alveoli, indicating their potential efficacy for pulmonary delivery. Cytotoxicity assessments via the MTT assay showed IC50 values of ICA-loaded DSPE-PEG2000/DPPC micelles were 117 ± 8 μg/mL, 29 ± 3 μg/mL, and 21 ± 1 μg/mL at 24, 48, and 72 h, respectively, highlighting the time-dependent cytotoxic effects of the ICA-loaded micelles on A549 cells. However, the IC50 values of free ICA were > 500 μg/mL, 252 ± 3 μg/mL, and 109 ± 2 μg/mL, respectively at three different time points. That indicated that ICA-loaded nano micelles enhanced the cytotoxicity of ICA. Furthermore, the cellular uptake of the nano micelles by A549 cells was visualized and confirmed using EVOS fluorescence imaging and flow cytometry techniques. In addition, RAW 264.7 M2 polarization studies indicated ICA loaded DSPE-PEG2000/DPPC micelles have potential for treating pulmonary fibrosis. These findings suggest that DSPE-PEG2000/DPPC micelles significantly enhance the solubility and delivery of ICA, presenting a promising nanocarrier system for targeted pulmonary fibrosis therapy.

Nanoparticles as Drug Delivery Vehicles for People with Cystic Fibrosis

Cystic Fibrosis (CF) is a life-shortening, genetic disease that affects approximately 145,000 people worldwide. CF causes a dehydrated mucus layer in the lungs, leading to damaging infection and inflammation that eventually result in death. Nanoparticles (NPs), drug delivery vehicles intended for inhalation, have become a recent source of interest for treating CF and CF-related conditions, and many formulations have been created thus far. This paper is intended to provide an overview of CF and the effect it has on the lungs, the barriers in using NP drug delivery vehicles for treatment, and three common material class choices for these NP formulations: metals, polymers, and lipids. The materials to be discussed include gold, silver, and iron oxide metallic NPs; polyethylene glycol, chitosan, poly lactic-co-glycolic acid, and alginate polymeric NPs; and lipid-based NPs. The novelty of this review comes from a less specific focus on nanoparticle examples, with the focus instead being on the general theory behind material function, why or how a material might be used, and how it may be preferable to other materials used in treating CF. Finally, this paper ends with a short discussion of the two FDA-approved NPs for treatment of CF-related conditions and a recommendation for the future usage of NPs in people with Cystic Fibrosis (pwCF).

Beyond antibiotics: Emerging antivirulence strategies to combat Pseudomonas aeruginosa in cystic fibrosis

Pseudomonas aeruginosa is an opportunistic pathogen that poses a significant threat to individuals suffering from cystic fibrosis (CF). The pathogen is highly prevalent in CF individuals and is responsible for chronic infection, resulting in severe tissue damage and poor patient outcome. Prolonged antibiotic administration has led to the emergence of multidrug resistance in P. aeruginosa. In this direction, antivirulence strategies achieving targeted inhibition of bacterial virulence pathways, including quorum sensing, efflux pumps, lectins, and iron chelators, have been explored against CF isolates of P. aeruginosa. Hence, this review article presents a bird's eye view on the pulmonary infections involving P. aeruginosa in CF patients by laying emphasis on factors contributing to bacterial colonization, persistence, and disease progression along with the current line of therapeutics against P. aeruginosa in CF. We further collate scientific literature and discusses various antivirulence strategies that have been tested against P. aeruginosa isolates from CF patients.

Hybrid Lipid/Polymer Nanoparticles to Tackle the Cystic Fibrosis Mucus Barrier in siRNA Delivery to the Lungs: Does PEGylation Make the Difference?

Inhaled siRNA therapy has a unique potential for treatment of severe lung diseases, such as cystic fibrosis (CF). Nevertheless, a drug delivery system tackling lung barriers is mandatory to enhance gene silencing efficacy in the airway epithelium. We recently demonstrated that lipid-polymer hybrid nanoparticles (hNPs), comprising a poly(lactic-co-glycolic) acid (PLGA) core and a lipid shell of dipalmitoyl phosphatidylcholine (DPPC), may assist the transport of the nucleic acid cargo through mucus-covered human airway epithelium. To study in depth the potential of hNPs for siRNA delivery to the lungs and to investigate the hypothesized benefit of PEGylation, here, an siRNA pool against the nuclear factor-κB (siNFκB) was encapsulated inside hNPs, endowed with a non-PEGylated (DPPC) or a PEGylated (1,2-distearoyl-sn-glycero-3-phosphoethanolamine-poly(ethylene glycol) or DSPE-PEG) lipid shell. Resulting hNPs were tested for their stability profiles and transport properties in artificial CF mucus, mucus collected from CF cells, and sputum samples from a heterogeneous and representative set of CF patients. Initial information on hNP properties governing their interaction with airway mucus was acquired by small-angle X-ray scattering (SAXS) studies in artificial and cellular CF mucus. The diffusion profiles of hNPs through CF sputa suggested a crucial role of lung colonization of the corresponding donor patient, affecting the mucin type and content of the sample. Noteworthy, PEGylation did not boost mucus penetration in complex and sticky samples, such as CF sputa from patients with polymicrobial colonization. In parallel, in vitro cell uptake studies performed on mucus-lined Calu-3 cells grown at the air-liquid interface (ALI) confirmed the improved ability of non-PEGylated hNPs to overcome mucus and cellular lung barriers. Furthermore, effective in vitro NFκB gene silencing was achieved in LPS-stimulated 16HBE14o- cells. Overall, the results highlight the potential of non-PEGylated hNPs as carriers for pulmonary delivery of siRNA for local treatment of CF lung disease. Furthermore, this study provides a detailed understanding of how distinct models may provide different information on nanoparticle interaction with the mucus barrier.

Developing ciprofloxacin dry powder for inhalation: A story of challenges and rational design in the treatment of cystic fibrosis lung infection

Cystic fibrosis (CF) is an inherited multisystem disease affecting the lung which leads to a progressive decline in lung function as a result of malfunctioning mucociliary clearance and subsequent chronic bacterial infections. Pseudomonas aeruginosa is the predominant cause of lung infection in CF patients and is associated with significant morbidity and mortality. Thus, antibiotic therapy remains the cornerstone of the treatment of CF. Pulmonary delivery of antibiotics for lung infections significantly reduces the required dose and the associated systemic side effects while improving therapeutic outcomes. Ciprofloxacin is one of the most widely used antibiotics against P. aeruginosa and the most effective fluoroquinolone. However, in spite of the substantial amount of research aimed at developing ciprofloxacin powder for inhalation, none of these formulations has been commercialized. Here, we present an integrated view of the diverse challenges associated with delivering ciprofloxacin dry particles to the lungs of CF patients and the rationales behind recent formulations of ciprofloxacin dry powder for inhalation. This review will discuss the challenges in developing ciprofloxacin powder for inhalation along with the physiological and pathophysiological challenges such as ciprofloxacin lung permeability, overproduction of viscous mucus and bacterial biofilms. The review will also discuss the current and emerging particle engineering approaches to overcoming these challenges. By doing so, we believe the review will help the reader to understand the current limitations in developing an inhalable ciprofloxacin powder and explore new opportunities of rational design strategies.

Rapid Ex-Vivo Ciliogenesis and Dose-Dependent Effect of Notch Inhibition on Ciliogenesis of Respiratory Epithelia

Background: Cilia are actin based cellular protrusions conserved from algae to complex multicellular organisms like Homo sapiens. Respiratory motile cilia line epithelial cells of the tracheobronchial tree, beat in a synchronous, metachronal wave, moving inhaled pollutants and pathogens cephalad. Their role in both congenital disorders like primary ciliary dyskinesia (PCD) to acquired disorders like chronic obstructive pulmonary disease (COPD) continues to evolve. In this current body of work we outline a protocol optimized to reciliate human nasal epithelial cells and mouse tracheal cells in vitro. Using this protocol, we knocked down known cilia genes, as well as use a small molecule inhibitor of Notch, N-[N-(3,5-Difluorophenacetyl)-L-alanyl]-S-phenylglycine t-butyl Ester (DAPT), to assess the effect of these on ciliogenesis in order to show the validity of our protocol. Methods: Tracheas were harvested from wild-type, adult C57B6 mice, pronase digested and sloughed off epithelial cells grown to confluence in stationary culture on rat-tail collagen coated wells. Upon reaching confluence, collagen was digested and cells placed suspension culture protocol to reciliate the cells. Using this suspension culture protocol, we employed siRNA gene knockdown to assay gene functions required for airway ciliogenesis. Knock down of Dynein axonemal heavy chain 5 (Dnah5), a ciliary structural protein, was confirmed using immunostaining. Mouse tracheal cells were treated in suspension with varying doses of DAPT, an inhibitor of Notch, with the purpose of evaluating its effect and dose response on ciliogenesis. The optimum dose was then used on reciliating human nasal epithelial cells. Results: siRNA knockdown of Foxj1 prevented ciliation, consistent with its role as a master regulator of motile cilia. Knockdown of Dnai1 and Dnah5 resulted in immotile cilia, and Cand1 knockdown, a centrosome protein known to regulate centrosome amplification, inhibited airway ciliogenesis. Dnah5 knockdown was confirmed with significantly decreased immunostaining of cilia for this protein. Inhibiting Notch signaling by inhibiting gamma secretase with DAPT enhanced the percentage of ciliation, and resulted in longer cilia that beat with higher frequency in both mouse and human airway epithelia. Conclusions: Modifying existing reciliation protocols to suit both human nasal epithelial and mouse tracheal tissue, we have shown that knockdown of known cilia-related genes have the expected effects. Additionally, we have demonstrated the optimal dosage for significantly improving reciliation of airway epithelia using DAPT. Given that cilia length and function are significantly compromised in COPD, these findings open up interesting avenues for further exploration.

Nanomedicine Approaches for the Pulmonary Treatment of Cystic Fibrosis

Cystic fibrosis (CF) is a genetic disease affecting today nearly 70,000 patients worldwide and characterized by a hypersecretion of thick mucus difficult to clear arising from the defective CFTR protein. The over-production of the mucus secreted in the lungs, along with its altered composition and consistency, results in airway obstruction that makes the lungs susceptible to recurrent and persistent bacterial infections and endobronchial chronic inflammation, which are considered the primary cause of bronchiectasis, respiratory failure, and consequent death of patients. Despite the difficulty of treating the continuous infections caused by pathogens in CF patients, various strategies focused on the symptomatic therapy have been developed during the last few decades, showing significant positive impact on prognosis. Moreover, nowadays, the discovery of CFTR modulators as well as the development of gene therapy have provided new opportunity to treat CF. However, the lack of effective methods for delivery and especially targeted delivery of therapeutics specifically to lung tissues and cells limits the efficiency of the treatments. Nanomedicine represents an extraordinary opportunity for the improvement of current therapies and for the development of innovative treatment options for CF previously considered hard or impossible to treat. Due to the peculiar environment in which the therapies have to operate characterized by several biological barriers (pulmonary tract, mucus, epithelia, bacterial biofilm) the use of nanotechnologies to improve and enhance drug delivery or gene therapies is an extremely promising way to be pursued. The aim of this review is to revise the currently used treatments and to outline the most recent progresses about the use of nanotechnology for the management of CF.

Neutrophil-targeted, protease-activated pulmonary drug delivery blocks airway and systemic inflammation

Pulmonary drug delivery presents a unique opportunity to target lower airway inflammation, which is often characterized by the massive recruitment of neutrophils from blood. However, specific therapies are lacking modulation of airway neutrophil function, and difficult challenges must be overcome to achieve therapeutic efficacy against pulmonary inflammation, notably drug hydrophobicity, mucociliary and macrophage-dependent clearance, and high extracellular protease burden. Here, we present a multistage, aerodynamically favorable delivery platform that uses extracellular proteolysis to its advantage to deliver nanoparticle-embedded hydrophobic drugs to neutrophils within the lower airways. Our design consists of a self-regulated nanoparticle-in-microgel system, in which microgel activation is triggered by extracellular elastase (degranulated by inflammatory neutrophils), and nanoparticles are loaded with Nexinhib20, a potent neutrophil degranulation inhibitor. Successful in vivo delivery of Nexinhib20 to the airways and into neutrophils promoted resolution of the inflammatory response by dampening neutrophil recruitment and degranulation, proinflammatory cytokine production in both airway and systemic compartments, as well as the presence of neutrophil-derived pathological extracellular vesicles in the lung fluid. Our findings showcase a new platform that overcomes challenges in pulmonary drug delivery and allows customization to match the proteolytic footprint of given diseases.

Antimicrobial activity profiles of Amphiphilic Xanthone derivatives are a function of their molecular Oligomerization

Currently, membrane-targeting small antimicrobial peptidomimetics (SAP) are important in antibiotic development because bacteria appear to develop resistance to these surface-active compounds less readily. However, the molecular membrane-targeting action of SAPs has received little attention. In this study, we investigated the effect of oligomerization of amphiphilic xanthone, a model SAP, on its antimicrobial properties against both Gram-positive and Gram-negative bacteria. First, oligomer formation by an amphiphilic xanthone, compound 2 (also coded as AM052), was investigated via solution-state nuclear magnetic resonance (NMR) spectroscopy. Then, the effects of oligomerization on membrane disruption were further studied via biophysical approaches. The results showed that the antimicrobial activities of SAPs develop in several stages: oligomer formation in aqueous solution, initial binding of oligomers to the membrane-water interface followed by insertion into the membrane bilayer, aggregation of antimicrobial oligomers in the membrane, and induced membrane leakage. Ultimately, the presence of the oligomers in the bacterial membrane leads to decreased membrane fluidity and bacterial cell death. Interestingly, the early formation of large oligomers leads to stronger membrane disruption and more rapid bacterial killing. However, reduced antimicrobial activities against Gram-negative bacteria were observed for compounds that formed larger oligomers because the LPS layer acts as a barrier to large complexes. Taken together, our results suggest that oligomerization of SAPs has a strong impact on their antimicrobial properties.

Pulmonary Delivery of Ceftazidime for the Treatment of Melioidosis in a Murine Model

Burkholderia pseudomallei, the etiological agent responsible for melioidosis, exhibits a great public health toll in its endemic regions. The elevation of B. pseudomallei to a Tier I select agent underscores the urgent need for effective therapeutics and preventatives. The current treatment regimen for melioidosis is suboptimal, requiring an intensive phase of intravenous antibiotic followed by months of oral antibiotics. Inhaled antibiotics are a promising avenue to pursue for pulmonary diseases, including melioidosis, since this mode of delivery mimics the likely exposure route and can provide high drug doses directly to the infected tissue. Ceftazidime was delivered via a nose-only system to BALB/c mice challenged with B. pseudomallei. Mice treated with nebulized ceftazidime became symptomatic but survived until study end, which was comparable to those treated intraperitoneally. Upon necropsy, bacteria remained within the spleens of the majority of the experimental animals. The effectiveness of nebulized ceftazidime warrants additional studies to improve the treatment regimen and to test as a prophylactic therapy against B. pseudomallei.

Synthesis and Characterization of Nanocomposite Microparticles (nCmP) for the Treatment of Cystic Fibrosis-Related Infections

PURPOSE

Pulmonary antibiotic delivery is recommended as maintenance therapy for cystic fibrosis (CF) patients who experience chronic infections. However, abnormally thick and sticky mucus present in the respiratory tract of CF patients impairs mucus penetration and limits the efficacy of inhaled antibiotics. To overcome the obstacles of pulmonary antibiotic delivery, we have developed nanocomposite microparticles (nCmP) for the inhalation application of antibiotics in the form of dry powder aerosols.

METHODS

Azithromycin-loaded and rapamycin-loaded polymeric nanoparticles (NP) were prepared via nanoprecipitation and nCmP were prepared by spray drying and the physicochemical characteristics were evaluated.

RESULTS

The nanoparticles were 200 nm in diameter both before loading into and after redispersion from nCmP. The NP exhibited smooth, spherical morphology and the nCmP were corrugated spheres about 1 μm in diameter. Both drugs were successfully encapsulated into the NP and were released in a sustained manner. The NP were successfully loaded into nCmP with favorable encapsulation efficacy. All materials were stable at manufacturing and storage conditions and nCmP were in an amorphous state after spray drying. nCmP demonstrated desirable aerosol dispersion characteristics, allowing them to deposit into the deep lung regions for effective drug delivery.

CONCLUSIONS

The described nCmP have the potential to overcome mucus-limited pulmonary delivery of antibiotics.

Improving the efficacy of inhaled drugs in cystic fibrosis: challenges and emerging drug delivery strategies

Cystic fibrosis (CF) is the most common autosomal recessive disease in Caucasians associated with early death. Although the faulty gene is expressed in epithelia throughout the body, lung disease is still responsible for most of the morbidity and mortality of CF patients. As a local delivery route, pulmonary administration represents an ideal way to treat respiratory infections, excessive inflammation and other manifestations typical of CF lung disease. Nonetheless, important determinants of the clinical outcomes of inhaled drugs are the concentration/permanence at the lungs as well as the ability of the drug to overcome local extracellular and cellular barriers. This review focuses on emerging delivery strategies used for local treatment of CF pulmonary disease. After a brief description of the disease and formulation rules dictated by CF lung barriers, it describes current and future trends in inhaled drugs for CF. The most promising advanced formulations are discussed, highlighting the advantages along with the major challenges for researchers working in this field.

PEI-engineered respirable particles delivering a decoy oligonucleotide to NF-κB: inhibiting MUC2 expression in LPS-stimulated airway epithelial cells

A specific and promising approach to limit inflammation and mucin iperproduction in chronic lung diseases relies on specific inhibition of nuclear Factor-κB (NF-κB) by a decoy oligonucleotide (dec-ODN). To fulfill the requirements dictated by translation of dec-ODN therapy in humans, inhalable dry powders were designed on a rational basis to provide drug protection, sustained release and to optimize pharmacological response. To this end, large porous particles (LPP) for dec-ODN delivery made of a sustained release biomaterial (poly(lactic-co-glycolic) acid, PLGA) and an “adjuvant” hydrophilic polymer (polyethylenimine, PEI) were developed and their effects on LPS-stimulated human airway epithelial cells evaluated. The composite PLGA/PEI particles containing dec-ODN (i.e., LPP_PEI) were successfully engineered for widespread deposition in the lung and prolonged release of intact dec-ODN in vitro. LPP_PEI caused a prolonged inhibition of IL-8 and MUC2 expression in CF human bronchial epithelial cells and human epithelial pulmonary NCI-H292 cells, respectively, as compared to naked dec-ODN. Nonetheless, as compared to previously developed LPP, the presence of PEI was essential to construct a dec-ODN delivery system able to act in mucoepidermoid lung epithelial cells. In perspective, engineering LPP with PEI may become a key factor for tuning carrier properties, controlling lung inflammation and mucin production which, in turn, can foster in vivo translation of dec-ODN therapy.

Lung imaging - two dimensional gamma scintigraphy, SPECT, CT and PET

This review will cover the principles of imaging the deposition of inhaled drugs and some of the state-of-the art imaging techniques being used today. Aerosol deposition can be imaged and quantified by the addition of a radiolabel to the aerosol formulation. The subsequent imaging of the inhaled deposition pattern can be acquired by different imaging techniques. Specifically, this review will focus on the use of two-dimensional planar, gamma scintigraphy, SPECT, CT and PET. This review will look at how these imaging techniques are used to investigate the mechanisms of drug delivery in the lung and how the lung anatomy and physiology have the potential to alter therapeutic outcomes.

Engineered PLGA nano- and micro-carriers for pulmonary delivery: challenges and promises

Objectives

The aim of this review is to summarize the current state-of-the-art in poly(lactic-co-glycolic acid) (PLGA) carriers for inhalation. It presents the rational of use, the potential and the recent advances in developing PLGA microparticles and nanoparticles for pulmonary delivery. The most promising particle engineering strategies are discussed, highlighting the advantages along with the major challenges for researchers working in this field.

Key findings

Biodegradable polymer carriers, such as PLGA particles, may permit effective protection and long-term delivery of the inhaled drug and, when adequately engineered, its efficient transport to the target. The carrier can be designed for inhalation on the basis of several strategies through the adequate combination of available particle technologies and excipients. In so doing, the properties of PLGA particles can be finely tuned at micro-size and nano-size level to fulfill specific therapeutic needs. This means not only to realize optimal in vitro/in vivo lung deposition of the formulation, which is still crucial, but also to control the fate of the drug in the lung after particle landing.

Summary

Although many challenges still exist, PLGA carriers may be highly beneficial and present a new scenario for patients suffering from chronic lung diseases and for pharmaceutical companies working to develop novel inhaled products.