Developing a More Sustainable Protein and Amino Acid Supply of Laying Hens in a Split Feeding System

Two model experiments were conducted to investigate the different protein and amino acid supply of laying hens fed split feeding (SF) diets. In Experiment 1, one conventional (C) and one SF dietary treatment were established, and the diets were implemented for 12 weeks. The concentrations of crude protein, SID Lys, Met, Met + Cys Arg, Val, Thr, Leu, Ile, and Trp of the SF morning diet were the same as in the C diet. The crude protein content of the SF afternoon diet was lower (92%), while the SID values of Lys, Met, Met + Cys were identical compared to the C diet (100%). The SF treatment resulted in a reduced protein/N intake, better feed conversion ratio, higher eggshell thickness and apparent ileal digestibility of Asp, Leu, Lys, Gly, and Ser, and lower concentration of N forms (total, fecal, NH4+, uric acid, urinary) in the excreta compared to the C treatment. In Experiment 2, a control and a low protein (-2% crude protein but the same SID values of Lys, Met, Met + Cys, Thr, Val) SF treatment were compared for 6 weeks. The low protein SF treatment led to a decreased protein/N intake, higher laying rate, lower egg weight, higher ileal digestibility of Ala, Asp, Leu, and Ile, and similar N emission compared to the control SF treatment.

The influence of whole-corn feeding method during the finishing stage on the performance of overfed mule ducks

The aim of this trial was to compare 2 feeding systems based on whole corn, a loose-mix and a free-choice feeding system, during the finishing stage on the performance of ducks. Five hundred sixteen day-old male mule ducks (Muscovy drake × Pekin duck) were divided into 3 groups that differed in the presentation of the diet they received between 58 and 88 d of age: a complete pelleted diet (Control (CON) group; AMEn 12.1 MJ/kg, CP 15.0%) containing 500 g of corn per kg; or whole corn (AMEn 13.9 MJ/kg, CP 7.3%) and protein-rich pellets (AMEn 10.3 MJ/kg, CP 22.7%) in equal quantities mixed in the same feeders (loose-mix feeding [LMF] group) or in 2 separate feeders (free-choice feeding [FCF] group). From 89 to 99 d, 72 birds/group were overfed with a mixture containing mainly corn and water and then slaughtered to determine the weight and commercial value of the fatty liver. Feed intake was measured daily. Body weight (BW) was measured at 58, 88, and 99 d of age. From 58 to 88 d, total feed intake of the FCF group was +7% and +9% (+558 g and +672 g) higher than in the groups CON and LMF, respectively (P = 0.005). At 88 d, the BW was higher in the CON group than in the FCF group (4,959 vs. 4,778 g, P < 0.001), the LMF group being intermediate (4,874 g). During the experimental stage, the feed conversion ratio was higher in the FCF group than in the 2 others (+32%, P = 0.024), but the energy intake was similar between the 3 groups (92.6 MJ/duck, P = 0.353).After overfeeding (99 d), the BW (6,593 g), weight (642 g), and commercial grading of fatty liver were similar (P > 0.05) in the 3 groups. The present results suggest that loose-mix feeding during the finishing stage using whole corn is a solution for reducing feed cost.

Exploring the economic potential of reducing broiler lameness

1. The present study was designed first to explore the potential economic benefits of adopting management practices to reduce lameness in broiler farms, and second to explore farmers' possible perceptions of this potential in the Swedish context. The likely financial effects were addressed using a normative economic model, whereas a questionnaire-based survey was used to obtain in-depth knowledge about the perceptions of a group of broiler farmers in Sweden. 2. The three alternative practices (out of 6 tested) which realised the greatest improvements in gross margin and net return to management compared to the conventional practice were feeding whole wheat, sequential feeding and meal feeding. 3. The model showed that the negative effect of feeding whole wheat on feed conversion rate was outweighed by the effect of a low feed price and the associated decrease in feed costs. The price of wheat played a major role in the improvement of economic performance, whereas the reduction of lameness itself made a relatively minor contribution. 4. Apparently, the surveyed farmers do not recognise the potential of the positive effects of changing feed or feeding practices on both broiler welfare and farm economics although their implementation can be of great importance in the broiler sector where profit margins are very tight.​.

Effects of sequential feeding with low- and high-protein diets on growth performances and plasma metabolite levels in geese

This study was conducted by two trials to investigate effects of sequential feeding with low- and high-protein diets on growth traits and plasma metabolites in geese. In Trial I, the effect of sequential feeding under time-restricted feeding system was investigated. Seventy-two White Roman goslings were randomly allotted into either sequential feeding (S1) or control feeding (C1) group. All goslings were fed for 1 h at morning and at evening, respectively, from 2 to 8 weeks of age. S1 group was offered 13% CP diet at morning and 19% CP diet at evening. C1 group was offered the same diet (16% CP; mixed equally with the two diets mentioned above) at both morning and evening. Blood samples were hourly collected for 4 h after feeding at both morning and evening for the determination of the postprandial plasma levels of glucose, triacylglycerol and uric acid at the end of experiment. Results showed that BW, average daily gain (ADG), and daily feed intake (FI) were not different between groups, but the feed efficiency (FE) in S1 group was significantly higher than that in C1 group (P<0.05). The areas under curve (AUC) of plasma postprandial levels of glucose, triacylglycerol and uric acid were not affected by treatment, but the AUC of triacylglycerol and uric acid in morning were lower than those in evening (P<0.05). In Trial II, the effect of sequential feeding under ad libitum feeding system was investigated. Twenty-four goslings were randomly allotted into either sequential feeding (S2) or control feeding (C2) group. Diets were altered at 0600 and 1800 h, respectively, and geese were fed ad libitum from 4 to 8 weeks of age. S2 group was offered 14% CP diet at morning and 20% CP diet at evening. C2 group was supplied the same diet (mixed with the two diets according to the ratio of diets consumed by S2 group on the preceded day) at both morning and evening. Results showed that the ADG in S2 group was higher than those in C2 group (P<0.05). Summarized data from both trials showed that sequential feeding improves daily gain and FE in growing geese.

Modulation of energy and protein supplies in sequential feeding in laying hens

Sequential feeding (SF) consists of splitting energy (E) and protein/calcium (P) fractions temporally, improving the feed conversion ratio (FCR) of hens compared with a continuous distribution during the day. In a previous study, the E fraction (with a low level of protein) was provided in the morning, whereas the P fraction (with low level of energy) was given in the afternoon. However, there is no clear evidence that a requirement in energy or proteins is connected to these distribution sequences, whereas the requirement for calcium is known to be required in the afternoon. To evaluate the effects on performances of the modulation of energy and protein supplies in SF, five different sequential treatments were offered: E0P0/E0P0; E+P+/E-P-; E+P-/E-P+; E0P+/E0P- and E+P0/E-P0 where E+ represents a high energy level, E0 a moderate one and E- a low one (with the same meaning for P regarding protein supply). Afternoon fractions were provided with particulate calcium. A total of 168 Hendrix hens were housed in individual cages from 20 to 39 weeks of age in two environmentally contrasted rooms. Feed intake in the morning and afternoon fractions, egg production, egg weight, BW and weight of digestive organs were recorded. No diet effect was observed concerning feed intake, egg production and BW. These results suggested that hens are not able to fit their feed intake on energy or protein level of fractions within half-day duration, whereas at the day scale same protein and energy intakes were observed. Moreover, the time of nutrient distribution in feeding did not seem to have an impact on birds' performances. These studies have also demonstrated that, despite strong environmental pressure, the hens with SF had attenuated performance but continue to produce eggs.

The influence of choice feeding and cereal type (corn or triticale) during the finishing period on performance of mule ducks

The aim of this trial was to study the influence of choice feeding and cereal type (corn or triticale) during the finishing period on performance of ducks. In total, 624 one-day-old male mule ducks (Cairina moschata × Anas platyrhynchos) were divided into 3 groups differing in the diet they received between 56 and 84 d of age: a commercial complete pelleted diet (control group; AMEn 12.1 MJ/kg, CP 15%), or corn whole seeds (AMEn 14.4 MJ/kg, CP 7.3%) and protein-rich pellets (AMEn 9.9 MJ/kg, CP 22.7%) in 2 separated feeders [choice feeding with corn (CFC) group]; or triticale whole seeds (AMEn 13.0 MJ/kg, CP 10.5%) and protein-rich pellets (AMEn 11.2 MJ/kg, CP 19.5%) in 2 separated feeders [choice feeding with triticale (CFT) group]. From 85 to 96 d, 96 birds/group were overfed with corn. Feed intake (complete pellets or cereal and protein-rich pellets) per pen was measured at 60, 62, 65, 69, 78, and 84 d of age. Body weight and body traits were measured at 56 to 84 d of age. Over the entire period, from 56 to 84 d, the feed intake of the CFC group was 7% lower than the control group, and 5% lower than that in the CFT group (P = 0.002). Whatever the diet tested, at 56 and 84 d of age, the BW (4,099 and 4,779 g, P = 0.42 and P = 0.35, respectively) and the carcass traits (P > 0.05) of ducks were similar in the 3 groups. During and after overfeeding, the performances of the ducks were also similar (P > 0.05). The present results suggest that CFC during the finishing period is a solution to reduce the cost of diet destined to ducks. Indeed, using locally grown grains could reduce the economic and environmental impacts of duck feeding, reducing the transportation and crushing processes.

Effect of feeding diets based on coarse maize on productive performance, gizzard development and energy utilisation of laying hens

1. A total of 2200 White Leghorn layers were used to study the effect of feeding coarse maize on productive performance, gizzard weight, apparent metabolisable energy (AME) and egg quality parameters. 2. The experiment was a completely randomised design with 5 treatments, each being replicated 5 times (88 birds per replicate). Dietary treatments included a control diet with 600 g/kg of ground maize (6 mm sieve) and experimental diets with 150, 300, 450 or 600 g/kg coarse maize (10 mm sieve) replacing (w/w) ground maize. Diets, in mash form, were offered from 39 to 62 weeks of age. 3. Over the entire experimental period, dietary treatments had no effect on any of the production parameters, except on feed intake. A quadratic effect was observed for feed intake, where intake increased at 150 g/kg coarse maize inclusion. At higher inclusion levels of coarse maize, feed intake was similar to that of the control diet. But the differences in daily intake between dietary treatments were only around 1 g/bird and may not be of any biological significance. 4. Dietary treatments had no effect on gizzard weight, AME or egg quality. 5. The results indicate that coarse maize could completely replace maize in layer diets with no adverse effect on egg production, egg quality and dietary energy utilisation. In the current work, although the proportion of coarse particles (over 1 mm) increased with increasing inclusion levels of coarse maize, the differences in the percentage of particles above 1 mm between the fine control (0 g/kg coarse maize) and coarsest (600 g/kg coarse maize) diets was only 15%, and this may limit the value of the findings reported herein.

Effects on performance of ground wheat with or without insoluble fiber or whole wheat in sequential feeding for laying hens

Sequential feeding (SF) is an innovative system for laying hens consisting of nutrients separating energy, protein, and calcium supplies to fulfill nutrient requirements at the relevant time of day. In previous studies, hens received whole wheat in the morning and a balancer diet (rich in protein and calcium) in the afternoon. To improve SF utilization, the aim was to substitute whole wheat in the morning by an alternative energy supply: ground wheat and ground corn, with or without a proportion of whole wheat and insoluble fiber. The goal was to obtain the advantages observed in previous experiments with whole wheat [bigger gizzard, thinner hens, reduced feed conversion ratio (FCR)]. Four hundred thirty-two ISA Brown hens were housed in collective cages from 20 to 35 wk of age divided into 8 different treatments: a continuous control diet, a sequential diet with whole wheat in the morning, 3 wheat-based diets (ground wheat, ground wheat and 20% whole wheat, and ground wheat with 5% insoluble fiber) and 3 ground corn-based (ground corn, ground corn and 20% whole wheat, and ground corn with 5% insoluble fiber) provided in the morning. All sequential regimens received the same balancer diet rich in protein and calcium in the afternoon. Whole wheat SF gave the best results with an improved FCR compared with continuous control and all other SF diets. Wheat- and corn-based diets showed intermediate results between whole wheat SF and continuous feeding. Gizzard weight was higher and hens were lighter than with conventional continuous feeding, leading to an average FCR improvement of 3.2% compared with a continuous control. Thus, it is possible in SF diets to substitute, at least partially, whole wheat by ground wheat or ground corn with added insoluble fiber or some whole wheat, allowing more flexibility and economic optimization.

Influence of feeding sorghum on the growth, gizzard development and carcass traits of growing geese

The aim of this trial was to study the influence of feed form on the performance, gizzard development and carcass traits of growing geese. Between 42 and 98 days of age, 360 geese (type Maxipalm(®)) were fed a diet containing 500 g sorghum/kg (nitrogen-corrected apparent metabolizable energy 12.6 MJ/kg, 15.1 g/kg CP). Birds were divided into three groups differing in feed form: complete pellets (Control group, n = 120); a coarse-ground meal (CG group, n = 120); or a mixture containing protein-rich pellets and sorghum whole grains (M group, n = 120). Feed intake per pen (40 birds/pen) was measured weekly between 42 and 98 days of age, and individual live weight (LW) was measured every 2 weeks. At 84 and 98 days of age, 12 birds were slaughtered in each group to measure the gizzard development and body traits. Irrespective of the goose sex, LW at 98 days was lower for the CG group than for the Control group (5555 v. 5888 g, P < 0.05 for males and 5039 v. 5215 g, P < 0.05 for females). The feed intake over the entire period was 5.5% higher in the M group (P < 0.05) than in the Control and CG groups but the feed conversion ratio (6.91, P > 0.05) was similar in the three groups. The gizzard development (as % of LW) was higher in birds of the CG group than those of the Control and M groups at 84 days of age (+13.98% and +13.51%, respectively; P < 0.05) but was similar in all three groups at 98 days of age (4.01%, P > 0.05). The relative liver development was lower in the birds of the CG group than those of the other two groups at 84 and 98 days of age (-20%, P < 0.001 and -10%, P < 0.05, respectively). The other body traits were similar in the three groups at both 84 and 98 days of age. The present results suggest that a simplified diet presented in the form of a mixture of sorghum whole grains and protein-rich pellets did not reduce the performance of growing geese.

Prospects from agroecology and industrial ecology for animal production in the 21st century

Agroecology and industrial ecology can be viewed as complementary means for reducing the environmental footprint of animal farming systems: agroecology mainly by stimulating natural processes to reduce inputs, and industrial ecology by closing system loops, thereby reducing demand for raw materials, lowering pollution and saving on waste treatment. Surprisingly, animal farming systems have so far been ignored in most agroecological thinking. On the basis of a study by Altieri, who identified the key ecological processes to be optimized, we propose five principles for the design of sustainable animal production systems: (i) adopting management practices aiming to improve animal health, (ii) decreasing the inputs needed for production, (iii) decreasing pollution by optimizing the metabolic functioning of farming systems, (iv) enhancing diversity within animal production systems to strengthen their resilience and (v) preserving biological diversity in agroecosystems by adapting management practices. We then discuss how these different principles combine to generate environmental, social and economic performance in six animal production systems (ruminants, pigs, rabbits and aquaculture) covering a long gradient of intensification. The two principles concerning economy of inputs and reduction of pollution emerged in nearly all the case studies, a finding that can be explained by the economic and regulatory constraints affecting animal production. Integrated management of animal health was seldom mobilized, as alternatives to chemical drugs have only recently been investigated, and the results are not yet transferable to farming practices. A number of ecological functions and ecosystem services (recycling of nutrients, forage yield, pollination, resistance to weed invasion, etc.) are closely linked to biodiversity, and their persistence depends largely on maintaining biological diversity in agroecosystems. We conclude that the development of such ecology-based alternatives for animal production implies changes in the positions adopted by technicians and extension services, researchers and policymakers. Animal production systems should not only be considered holistically, but also in the diversity of their local and regional conditions. The ability of farmers to make their own decisions on the basis of the close monitoring of system performance is most important to ensure system sustainability.

Effect of sequential feeding on nitrogen excretion, productivity, and meat quality of broiler chickens

The aim of this trial was to investigate the effect of a 24-h cycle sequential feeding program on nitrogen excretion, incidence of foot pad lesions, productive performance, quality traits, and chemical composition of broiler chicken breast meat. In total, 1,320 one-day-old male Cobb 700 chicks were split into 2 groups of 6 replicates each. From 1 to 10 d of age, all of the chickens received the same prestarter diet (ME 3,058 kcal/kg; CP 226 g/kg). The control group (CON) received 1 of 3 diets for 24-h cycles: starter (ME 3,162 kcal/kg; CP 205 g/kg), grower (ME 3,224 kcal/kg; CP 192 g/kg), and finisher diets (ME 3,242 kcal/kg; CP 184 g/kg) from d 11 to 18, 19 to 38, and 39 to 44 of age, respectively. The sequential feeding group (SF) received the same diets as the CON birds for half of the day, and then low-protein and isoenergetic diets for the remaining half of the day. Birds submitted to the SF program showed better utilization of dietary nitrogen compared with the CON birds (45.0 vs. 46.1% of N excreted/N ingested, respectively; P < 0.05), and consequently the SF birds had lower nitrogen excretion compared with the CON birds (24.8 vs. 25.9 N g/kg of BW, respectively; P < 0.01). The SF birds exhibited a significantly lower incidence (7 vs. 13%) of foot pad lesions and consumed 70 g of feed/bird more than the CON birds. The SF birds also had a significantly higher feed conversion rate compared with that of the CON birds (1.84 vs. 1.78, respectively). The SF breast meat exhibited a significantly lower ultimate pH, a higher cook loss, and a lower lipid content compared with the values found for the CON group. The SF approach in poultry husbandry had positive repercussions on environmental and animal welfare aspects, but adversely affected feed efficiency, and altered some meat traits (mainly pH and cook loss).