Profiles of Volatile Flavor Compounds in Milk Fermented with Different Proportional Combinations of Lactobacillus delbrueckii subsp. bulgaricus and Streptococcus thermophilus

Effect of different isolation sources of Lactococcus lactis subsp. lactis on volatile metabolites in fermented milk

Lactococcus lactis subsp. lactis (L. lactis subsp. lactis) is a commonly used starter cultures in fermented dairy products, contributing distinct flavor and texture characteristics with high application value. However, the strains from different isolates have different contributions to milk fermentation. Therefore, this study aimed to investigate the influence of L. lactis subsp. lactis isolated from various sources on the volatile metabolites present in fermented milk. In this study, L. lactis subsp. lactis from different isolation sources (yogurt, koumiss and goat yogurt) was utilized as a starter culture for fermentation. The volatile metabolites of fermented milk were subsequently analyzed by headspace solid phase microextraction gas chromatography-mass spectrography (HS-SPME-GC-MS). The results indicated significant differences in the structure and abundance of volatile metabolites in fermented milk produced with different isolates (R2Y = 0.96, Q2 = 0.88). Notably, the strains isolated from goat yogurt appeared to enhance the accumulation of ketones (goat yogurt vs yogurt milk: 50 %; goat yogur vs koumiss: 27.3 %)and aldehydes (goat yogurt vs yogurt milk: 21.4 %; goat yogurt vs koumiss: 54.5 %) in fermented milk than strains isolated from koumiss and yogurt milk. It significantly promoted the production of 8 flavor substances (1 substance with OAV ≥ 1 and 6 substances with OAV > 0.1) and enhanced the biosynthesis of valine, leucine, and isoleucine. This study provides valuable insights for the application of Lactococcus lactis subsp. lactis isolated from different sources in fermented dairy production and screening of potential starter cultures.

Qualitative and quantitative rapid detection of VOCs differentially released by VAP-associated bacteria using PTR-MS and FGC-PTR-MS

Ventilator-associated pneumonia (VAP) is a prevalent disease caused by microbial infection, resulting in significant morbidity and mortality within the intensive care unit (ICU). The rapid and accurate identification of pathogenic bacteria causing VAP can assist clinicians in formulating timely treatment plans. In this study, we attempted to differentiate bacterial species in VAP by utilizing the volatile organic compounds (VOCs) released by pathogens. We cultured 6 common bacteria in VAP in vitro, including Acinetobacter baumannii, Enterobacter cloacae, Escherichia coli, Pseudomonas aeruginosa, Stenotrophomonas maltophilia, and Staphylococcus aureus, which covered most cases of VAP infection in clinic. After the VOCs released by bacteria were collected in sampling bags, they were quantitatively detected by a proton transfer reaction-mass spectrometry (PTR-MS), and the characteristic ions were qualitatively analyzed through a fast gas chromatography-proton transfer reaction-mass spectrometry (FGC-PTR-MS). After conducting principal component analysis (PCA) and analysis of similarities (ANOSIM), we discovered that the VOCs released by 6 bacteria exhibited differentiation following 3 h of quantitative cultivation in vitro. Additionally, we further investigated the variations in the types and concentrations of bacterial VOCs. The results showed that by utilizing the differences in types of VOCs, 6 bacteria could be classified into 5 sets, except for A. baumannii and E. cloacae which were indistinguishable. Furthermore, we observed significant variations in the concentration ratio of acetaldehyde and methyl mercaptan released by A. baumannii and E. cloacae. In conclusion, the VOCs released by bacteria could effectively differentiate the 6 pathogens commonly associated with VAP, which was expected to assist doctors in formulating treatment plans in time and improve the survival rate of patients.

Comparative Transcriptomic Analysis of the Flavor Production Mechanism in Yogurt by Traditional Starter Strains

Synergistic fermentation of milk by Streptococcus thermophilus and Lactobacillus delbrueckii ssp. bulgaricus is one of the key factors that determines the quality of yogurt. In this study, the mechanism whereby yogurt flavor compounds are produced by mixture of S. thermophilus SIT-20.S and L. delbrueckii ssp. bulgaricus SIT-17.B were investigated by examining these strains' flavor production, growth, and gene transcription. The results showed that yogurt produced by a 10:1 mixture of the aforementioned strains had the highest abundance of acetoin, whereas yogurt produced by a 1:1 mixture had the highest abundance of diacetyl and acetaldehyde. In addition, the growth of S. thermophilus SIT-20.S was enhanced in the 10:1 mixture. Transcriptomic analysis revealed differentially expressed genes in the flavor-compound-related pathways of S. thermophilus SIT-20.S and L. delbrueckii ssp. bulgaricus SIT-17.B in yogurts produced by 10:1 and 1:1 mixture compared with those produced by either strain alone. Mixed fermentations regulated the expression of genes related to glycolysis, resulting in an increase of pyruvate, which is an important precursor for diacetyl and acetoin synthesis. The gene encoding the acetoin reductase (SIT-20S_orf01454) was decreased in S. thermophilus SIT-20.S, which ensured the accumulation of acetoin. Besides, gene encoding the acetaldehyde dehydrogenase (SIT-20S_orf00949) was upregulated in S. thermophilus SIT-20.S, and the expression of alcohol dehydrogenase (SIT-20S_orf01479; SIT-17B_orf00943) was downregulated in both strains, maintaining the abundance of acetaldehyde. In addition, the gene encoding the NADH oxidase (SIT-17B_orf00860) in L. delbrueckii ssp. bulgaricus SIT-17.B were upregulated, which promoted the accumulation of diacetyl and acetoin. In conclusion, we characterized the mechanism by which S. thermophilus and L. delbrueckii ssp. bulgaricus synergistically generated yogurt flavor compounds during their production of yogurt and highlighted the importance of appropriate proportions of fermentation starters for improving the flavor of yogurts.

Fermentation characteristics and postacidification of yogurt by Streptococcus thermophilus CICC 6038 and Lactobacillus delbrueckii ssp. bulgaricus CICC 6047 at optimal inoculum ratio

This study aimed to investigate the symbiosis between Streptococcus thermophilus CICC 6038 and Lactobacillus delbrueckii ssp. bulgaricus CICC 6047. In addition, the effect of their different inoculum ratios was determined, and comparison experiments of fermentation characteristics and storage stability of milk fermented by their monocultures and cocultures at optimal inoculum ratio were performed. We found the time to obtain pH 4.6 and ΔpH during storage varied among 6 inoculum ratios (1:1, 2:1, 10:1, 19:1, 50:1, 100:1). By the statistical model to evaluate the optimal ratio, the ratio of 19:1 was selected, which exhibited high acidification rate and low postacidification with pH values remaining between 4.2 and 4.4 after a 50-d storage. Among the 3 groups included in our analyses (i.e., the monocultures of S. thermophilus CICC 6038 [St] and Lb. bulgaricus CICC 6047 [Lb] and their cocultures [St+Lb] at 19:1), the coculture group showed higher acidification activity, improved rheological properties, richer typical volatile compounds, more desirable sensor quality after the fermentation process than the other 2 groups. However, the continuous accumulation of acetic acid during storage showed that acetic acid was more highly correlated with postacidification than d-lactic acid for the Lb group and St+Lb group. Our study emphasized the importance of selecting an appropriate bacterial consortium at the optimal inoculum ratio to achieve favorable fermentation performance and enhanced postacidification stability during storage.

Effect of industrial wastewater treatment system upgrade on the composition of emitted odorants and volatile organic compounds from a cheese production facility

This study investigates the rarely studied volatile organic compound emissions from a cheese production facility and the impact of its wastewater treatment system upgrade on the composition of emitted odorants. Wastewater grab samples were collected from six separate wastewater channels before (2019) and after (2021) the system upgrade and analyzed for volatile organic compounds, pH, total dissolved solids, and electrical conductivity. Results showed that the channel from hard cheese production in 2021 had the highest number of volatile organic compounds (35), followed by the fresh cheese production channel (22). Following the industrial wastewater treatment system upgrade, a mineral oil contamination occurred; however, the number of odorants with nasal impact frequency (NIF) ≥ 0.5 in the effluent decreased from 11 to 5. 2-Propenoic acid butyl ester (NIF 0.75) stood out as the most prominent compound, described as fruity, waxy, or green. After the industrial wastewater treatment system upgrades, we observed a decrease in the number of odorants. However other measures must be taken to ensure proper wastewater processing. PRACTITIONER POINTS: More than 60 VOCs were identified in 6 channels from the cheese production facility.15 odorants in cheese production wastewater were detected by SPME-GC-MS/O. The most potent odorants before and after the system upgrade were 1-octen-3-ol and 2-propenoic acid butyl ester, respectively. The upgrades of the industrial wastewater treatment system had a positive impact on reducing the number of odorants and their odor intensity.

Microbial Conjugated Linolenic Acid-Enriched Fermented Milk Using Lipase-Hydrolyzed Flaxseed Oil: Biochemical, Organoleptic and Storage Traits

The bioactive conjugated linolenic acid (CLNA) can be microbiologically produced by different probiotic strains when in the presence of α-linolenic acid (α-LNA). Food matrices are a good vector, such as has been previously demonstrated with fermented milk enriched with microbial CLNA by Bifidobacterium breve DSM 20091 from lipase-hydrolyzed flaxseed oil. The aim of the present work was to further assess the nutritional, biochemical and organoleptic properties of the developed dairy product, as well as its storage stability throughout 28 days at 4 °C, proving its suitability for consumption. Milk lactose hydrolyzed into glucose (0.89 g/100 g) and galactose (0.88 g/100 g), which were further metabolized into lactic (0.42 g/100 g), acetic (0.44 g/100 g) and propionic (0.85 g/100 g) acids. Titratable acidity reached 0.69% and pH 4.93. Compared with the control (no CLNA), fat content was slightly higher (2.0 g/100 g). Acetic acid was the major volatile (83.32%), lacking important dairy flavor contributors, like acetaldehyde. Sensory analysis revealed predominant astringency and bitterness. No microbial concerns arose during storage, but the CLNA content increased, and some saturated fatty acids seemed to oxidize. In conclusion, the CLNA-enriched fermented milk revealed reasonable compositional properties, yet further improvements are needed for optimal consumer acceptance and a prolonged shelf-life.

Application of Sorbent-Based Extraction Techniques in Food Analysis

This review presents an outline of the application of the most popular sorbent-based methods in food analysis. Solid-phase extraction (SPE) is discussed based on the analyses of lipids, mycotoxins, pesticide residues, processing contaminants and flavor compounds, whereas solid-phase microextraction (SPME) is discussed having volatile and flavor compounds but also processing contaminants in mind. Apart from these two most popular methods, other techniques, such as stir bar sorptive extraction (SBSE), molecularly imprinted polymers (MIPs), high-capacity sorbent extraction (HCSE), and needle-trap devices (NTD), are outlined. Additionally, novel forms of sorbent-based extraction methods such as thin-film solid-phase microextraction (TF-SPME) are presented. The utility and challenges related to these techniques are discussed in this review. Finally, the directions and need for future studies are addressed.

An overview of fermentation in the food industry - looking back from a new perspective

Fermentation is thought to be born in the Fertile Crescent, and since then, almost every culture has integrated fermented foods into their dietary habits. Originally used to preserve foods, fermentation is now applied to improve their physicochemical, sensory, nutritional, and safety attributes. Fermented dairy, alcoholic beverages like wine and beer, fermented vegetables, fruits, and meats are all highly valuable due to their increased storage stability, reduced risk of food poisoning, and enhanced flavor. Over the years, scientific research has associated the consumption of fermented products with improved health status. The fermentation process helps to break down compounds into more easily digestible forms. It also helps to reduce the amount of toxins and pathogens in food. Additionally, fermented foods contain probiotics, which are beneficial bacteria that help the body to digest food and absorb nutrients. In today's world, non-communicable diseases such as cardiovascular disease, type 2 diabetes, cancer, and allergies have increased. In this regard, scientific investigations have demonstrated that shifting to a diet that contains fermented foods can reduce the risk of non-communicable diseases. Moreover, in the last decade, there has been a growing interest in fermentation technology to valorize food waste into valuable by-products. Fermentation of various food wastes has resulted in the successful production of valuable by-products, including enzymes, pigments, and biofuels.

The Controversial Nature of Some Non-Starter Lactic Acid Bacteria Actively Participating in Cheese Ripening

This mini review deals with some controversial non-starter lactic acid bacteria (NSLAB) species known to be both human and animal pathogens but also health-promoting and probiotic. The focus is on Lactococcus garvieae, two Streptococcus species (S. uberis and S. parauberis), four Weissella species (W. hellenica, W. confusa, W. paramesenteroides, and W. cibaria), and Mammalicoccus sciuri, which worldwide, are often found within the microbiotas of different kinds of cheese, mainly traditional artisanal cheeses made from raw milk and/or relying on environmental bacteria for their ripening. Based on literature data, the virulence and health-promoting effects of these bacteria are examined, and some of the mechanisms of these actions are reviewed. Additionally, their possible roles in cheese ripening are also discussed. The analysis of the literature data available so far showed that, in general, the pathogenic and the beneficial strains, despite belonging to the same species, show somewhat different genetic constitutions. Yet, when the safety of a given strain is assessed, genomic analysis on its own is not enough, and a polyphasic approach including additional physiological and functional tests is needed.

Influence of Different Ratios of Lactobacillus delbrueckii subsp. bulgaricus and Streptococcus thermophilus on Fermentation Characteristics of Yogurt

Lactic acid bacteria (LAB) are industrially important bacteria that are widely used in the fermented food industry, especially in the manufacture of yogurt. The fermentation characteristics of LAB are an important factor affecting the physicochemical properties of yogurts. Here, different ratios of L. delbrueckii subsp. bulgaricus IMAU20312 and S. thermophilus IMAU80809 were compared with a commercial starter JD (control) for their effects on viable cell counts, pH values, titratable acidity (TA), viscosity and water holding capacity (WHC) of milk during fermentation. Sensory evaluation and flavour profiles were also determined at the end of fermentation. All samples had a viable cell count above 5.59 × 10⁷ CFU/mL at the end of fermentation, and a significant increase in TA and decrease in pH were observed. Viscosity, WHC and the sensory evaluation results of one treatment ratio (A3) were closer to the commercial starter control than the others. A total of 63 volatile flavour compounds and 10 odour-active (OAVs) compounds were detected in all treatment ratios and the control according to the results from solid-phase micro-extraction-gas chromatography-mass spectrometry (SPME-GC-MS). Principal components analysis (PCA) also indicated that the flavour characteristics of the A3 treatment ratio were closer to the control. These results help us understand how the fermentation characteristics of yogurts are affected by the ratio of L. delbrueckii subsp. bulgaricus to S. thermophilus in starter cultures; this is useful for the development of value-added fermented dairy products.

The effect of glutathione biosynthesis of Streptococcus thermophilus ST-1 on cocultured Lactobacillus delbrueckii ssp. bulgaricus ATCC11842

Streptococcus thermophilus and Lactobacillus delbrueckii ssp. bulgaricus are the main species used for yogurt preparation. Glutathione (GSH) can be synthesized by S. thermophilus and plays a crucial role in combating environmental stress. However, the effect of GSH biosynthesis by S. thermophilus on cocultured L. delbrueckii ssp. bulgaricus is still unknown. In this study, a mutant S. thermophilus ΔgshF was constructed by deleting the GSH synthase. The wild strain S. thermophilus ST-1 and ΔgshF mutants were cocultured with L. delbrueckii ssp. bulgaricus ATCC11842 by using Transwell chambers (Guangzhou Shuopu Biotechnology Co., Ltd.), respectively. It was proven that the GSH synthesized by S. thermophilus ST-1 could be absorbed and used by L. delbrueckii ssp. bulgaricus ATCC11842, and promote growth ability and stress tolerance of L. delbrueckii ssp. bulgaricus ATCC11842. The biomass of L. delbrueckii ssp. bulgaricus ATCC11842 cocultured with S. thermophilus ST-1 or ΔgshF (adding exogenous GSH) increased by 1.8 and 1.4 times compared with the biomass of L. delbrueckii ssp. bulgaricus ATCC11842 cocultured with S. thermophilus ΔgshF. Meanwhile, after H₂O₂ and low-temperature treatments, the bacterial viability of L. delbrueckii ssp. bulgaricus cocultured with S. thermophilus ΔgshF, with or without GSH, was decreased by 41 and 15% compared with that of L. delbrueckii ssp. bulgaricus cocultured with S. thermophilus ST-1. Furthermore, transcriptome analysis showed that the expression levels of genes involved in purine nucleotide and pyrimidine nucleotide metabolism in L. delbrueckii ssp. bulgaricus ATCC11842 were at least 3 times increased when cocultured with S. thermophilus (fold change > 3.0). Moreover, compared with the mutant strain ΔgshF, the wild-type strain ST-1 could shorten the fermented curd time by 5.3 hours during yogurt preparation. These results indicated that the GSH synthesized by S. thermophilus during cocultivation effectively enhanced the activity of L. delbrueckii ssp. bulgaricus and significantly improved the quality of fermented milk.

Effect of olive by-products feed supplementation on physicochemical and microbiological profile of Provola cheese

Introduction

With the purpose to evaluate the effects of dietary olive cake, a source of bioactive phenolic compounds, as feed supplementation of lactating dairy cows on fatty acid composition, volatile organic compounds, and microbiological profiles of Provola cheese, we performed a two-arm study where control and experimental administered cows derived dairy have been compared.

Methods

Our panel of analyses include metabolomics, physicochemical detected variables, culture dependent and independent analyses, and a stringent statistical approach aimful at disclosing only statistically significant results.

Results and discussion

Looking at the physicochemical variable's profiles, a higher content of unsaturated fatty acids, polyunsaturated fatty acid, and conjugated linoleic acids as well of proteins were observed in experimental cheese samples, indicating the beneficial effect of dietary supplementation. Furthermore, based on volatilome composition, a clear cluster separation between control and experimental cheeses was obtained, mainly related to terpenes degradation, able of influencing their aroma and taste. Microbiological results showed a decrease of some spoilage related microbial groups in experimental cheeses, probably due to the inhibitory effect exerted by polyphenols compounds, that contrarily did not affect the core taxa of all cheese samples. This paper confirmed the promising utilization of olive by-product in farming practices to obtain more sustainable and safe dairy food products with lower environmental impact, mainly in Sicily and Mediterranean area, where waste disposal poses serious environmental and economic problems.

Advances in characterization of probiotics and challenges in industrial application

An unbalanced diet and poor lifestyle are common reasons for numerous health complications in humans. Probiotics are known to provide substantial benefits to human health by producing several bioactive compounds, vitamins, short-chain fatty acids and short peptides. Diets that contain probiotics are limited to curd, yoghurt, kefir, kimchi, etc. However, exploring the identification of more potential probiotics and enhancing their commercial application to improve the nutritional quality would be a significant step to utilizing the maximum benefits. The complex evolution patterns among the probiotics are the hurdles in their characterization and adequate application in the industries and dairy products. This article has mainly discussed the molecular methods of characterization that are based on the analysis of ribosomal RNA, whole genome, and protein markers and profiles. It also has critically emphasized the emerging challenges in industrial applications of probiotics.

Bacterial communities in home-made Doushen with and without chili pepper

Doushen is a traditional Chinese fermented soybean product prepared with sterilizated soybeans under open conditions. However, little is known on the bacterial community and their influence on the flavor of Doushen. In the present study, Doushen samples with and without chili pepper were collected to reveal the bacterial community and assess a correlation between bacterial community and VFCs in the two kinds of Doushen samples. We identified four phyla and 97 bacterial genera in the two kinds of Doushen samples. In addition, a total of 17 significantly different OTUs were detected by LEfSe (Line Discriminant Analysis (LDA) Effect Size). Results of Principal coordinates analysis (PCoA), unweighted pair-group method (UPGMA) and functional and phenotypes prediction showed that bacterial communities in the two kinds of Doushen were significantly different. Spearman correlation analysis showed that all the dominant genera, except Clostridium Sensu stricto 1, were significantly correlated with the characteristic VFCs. This study provides a theoretical basis for improving the flavour quality of traditional homemade Doushen.

Multivariate Optimization Procedure for Dynamic Headspace Extractions Coupled to GC(×GC)

Volatile organic compounds (VOCs) are ubiquitous chemicals of great interest in the study of aromas and flavours of foods. Many recent studies present optimized headspace (HS) and dynamic headspace (DHS) methods for specific sample types; however, the literature does not present ­(to the best of our knowledge) a generalized procedure for the thorough optimization of a DHS extraction. This article presents an approach using design of experiments (DoE) for the optimization of DHS extraction parameters. The approach is demonstrated for two different food sample types with diverse populations of VOCs: active sourdough colony as an example with a high moisture content, and sourdough bread as an example with a lower moisture content. Optimized methods are assessed for VOC extraction reproducibility and exhaustiveness; guidelines for DHS optimization are presented.

LAB Fermentation Improves Production of Bioactive Compounds and Antioxidant Activity of Withania somnifera Extract and Its Metabolic Signatures as Revealed by LC-MS/MS

In this study we investigated the effect of lactic acid bacteria (LAB) fermentation on the ingredients and anti-oxidant activity of Withania somnifera extract. Four strains of LAB could proliferate normally in medium containing W. somnifera extract after the pH reached 3.1~3.5. LAB fermentation increased the content of alcohols and ketones, endowing the extract with the characteristic aroma of fermentation. Compared to the control, the DPPH and ABTS free radical scavenging rates in the fermented samples were significantly improved, ranging from 48.5% to 59.6% and 1.2% to 6.4%. The content of total phenols was significantly increased by 36.1% during the fermentation of mixed bacteria. Moreover, the original composition spectrum of the extract was significantly changed while the differentially accumulated metabolites (DAMs) were closely related to bile secretion, tryptophan metabolism and purine metabolism. Therefore, LAB fermentation can be used as a promising way to improve the flavor and bioactivity of the extracts of W. somnifera, making the ferments more attractive for use as functional food.

The Impacts of Lactiplantibacillus plantarum on the Functional Properties of Fermented Foods: A Review of Current Knowledge

One of the most varied species of lactic acid bacteria is Lactiplantibacillus plantarum (Lb. plantarum), formerly known as Lactobacillus plantarum. It is one of the most common species of bacteria found in foods, probiotics, dairy products, and beverages. Studies related to genomic mapping and gene locations of Lb. plantarum have shown the novel findings of its new strains along with their non-pathogenic or non-antibiotic resistance genes. Safe strains obtained with new technologies are a pioneer in the development of new probiotics and starter cultures for the food industry. However, the safety of Lb. plantarum strains and their bacteriocins should also be confirmed with in vivo studies before being employed as food additives. Many of the Lb. plantarum strains and their bacteriocins are generally safe in terms of antibiotic resistance genes. Thus, they provide a great opportunity for improving the nutritional composition, shelf life, antioxidant activity, flavour properties and antimicrobial activities in the food industry. Moreover, since some Lb. plantarum strains have the ability to reduce undesirable compounds such as aflatoxins, they have potential use in maintaining food safety and preventing food spoilage. This review emphasizes the impacts of Lb. plantarum strains on fermented foods, along with novel approaches to their genomic mapping and safety aspects.

Volatilomics-Based Microbiome Evaluation of Fermented Dairy by Prototypic Headspace-Gas Chromatography–High-Temperature Ion Mobility Spectrometry (HS-GC-HTIMS) and Non-Negative Matrix Factorization (NNMF)

Fermented foods, such as yogurt and kefir, contain a versatile spectrum of volatile organic compounds (VOCs), including ethanol, acetic acid, ethyl acetate, and diacetyl. To overcome the challenge of overlapping peaks regarding these key compounds, the drift tube temperature was raised in a prototypic high-temperature ion mobility spectrometer (HTIMS). This HS-GC-HTIMS was used for the volatilomic profiling of 33 traditional kefir, 13 commercial kefir, and 15 commercial yogurt samples. Pattern recognition techniques, including principal component analysis (PCA) and NNMF, in combination with non-targeted screening, revealed distinct differences between traditional and commercial kefir while showing strong similarities between commercial kefir and yogurt. Classification of fermented dairy samples into commercial yogurt, commercial kefir, traditional mild kefir, and traditional tangy kefir was also possible for both PCA- and NNMF-based models, obtaining cross-validation (CV) error rates of 0% for PCA-LDA, PCA-kNN (k = 5), and NNMF-kNN (k = 5) and 3.3% for PCA-SVM and NNMF-LDA. Through back projection of NNMF loadings, characteristic substances were identified, indicating a mild flavor composition of commercial samples, with high concentrations of buttery-flavored diacetyl. In contrast, traditional kefir showed a diverse VOC profile with high amounts of flavorful alcohols (including ethanol and methyl-1-butanol), esters (including ethyl acetate and 3-methylbutyl acetate), and aldehydes. For validation of the results and deeper understanding, qPCR sequencing was used to evaluate the microbial consortia, confirming the microbial associations between commercial kefir and commercial yogurt and reinforcing the differences between traditional and commercial kefir. The diverse flavor profile of traditional kefir primarily results from the yeast consortium, while commercial kefir and yogurt is primarily, but not exclusively, produced through bacterial fermentation. The flavor profile of fermented dairy products may be used to directly evaluate the microbial consortium using HS-GC-HTIMS analysis.

Extracellular Polysaccharide Extraction from Streptococcus thermophilus in Fermented Milk

Lactic acid bacteria such as Streptococcus thermophilus are known to produce extracellular polysaccharide (EPS) in fermented foods that enhance the creaminess and mouthfeel of the product, such as yogurt. Strains producing larger amounts of EPS are highly sought-after, and therefore, robust and accurate quantification methodologies are important. This study found that two commonly used methodologies significantly underestimated the amount of EPS produced as measured using a milk matrix. To this end, a proteolytic step was implemented prior to EPS extraction (Method C). An initial proteolytic step using xanthan gum-spiked milk significantly increased recovery yield to 64%, compared to 27.8% for Method A and 34.3% for Method B. Method C showed no improvement when assessed using a chemically defined medium. Method C was further validated using three strains of S. thermophilus with varying EPS-production capabilities (ST^LOW, ST^MID, ST^HIGH). Overall, Method C demonstrated significant improvements in the EPS extraction yield for all three S. thermophilus strains in fermented milk. On average, Method C improved isolation yield by ∼3- to 6-fold compared with Method A and by ∼2- to 3-fold compared with method B. There were no significant differences between samples when they were grown in a chemically defined medium, highlighting the importance of a proteolytic step specifically for fermented milk samples. In commercial applications, accurate quantification of EPS-production is an important aspect when finding new strains. IMPORTANCE Extracellular polysaccharide (EPS) production by milk-fermenting microorganisms is a highly sought-after trait in improving the perceived thickness, creaminess, and mouthfeel of yogurt. Streptococcus thermophilus are commonly isolated and their EPS production is quantified in the search for higher-producing strains. In this study, we demonstrated that two commonly used methods for isolating EPS from milk samples significantly underestimated the true amount of EPS present. We demonstrated that the addition of a proteolytic step prior to EPS extraction isolated over 2-fold more EPS than identical samples processed using the traditional protocols. We further validated this method in fermented milk samples from three strains of S. thermophilus that included a low-, mid-, and high-EPS producing strain. Again, we showed significant improvements in EPS isolation using a proteolytic step. In the search for new S. thermophilus strains with enhanced EPS production, accurate quantification in an optimal medium is essential.

Enhancement of Labneh Quality by Laser-Induced Modulation of Lactocaseibacillus casei NRRL B-1922

Labneh is positioned in the top ranking of the bestselling dairy products all over the world due to its health benefits and delicious taste. Labneh production depends mainly on probiotic bacteria in the fermentation of milk. Probiotic bacteria have many health benefits, which are driven by their selective bioactive metabolites that quantitively affect the fermentation products. The current investigation aimed to study the implementation of photobiomodulation through the irradiation of Lacticaseibacillus casei NRRL-B-1922 by a He–Ne laser (630 nm) with different laser doses (3, 6 & 12 J/cm2) prior to milk fermentation. This procedure sought to improve the probiotic bacteria’s activities while enhancing the labneh’s characteristics and consequently produce a more favorable labneh product with better marketing qualities. The photobiostimulated bacterial starter was found to induce increased titratable acidity with the moisture reduction of the labneh product under cold storage conditions for 20 days. The effect was most prominent when using a 12 J/cm2 laser dose. The flavor-aiding components, mainly diacetyl and acetaldehyde compounds, and sensory scores were increased in the labneh produced by irradiated L. casei when compared to the non-radiated probiotic culture after storing the products under cold conditions for 20 consecutive days. Moreover, the antioxidant and proteolytic activities of labneh produced by treated L. casei (12 J/cm2 laser dose) after cold storage were significantly elevated by 41 and 14%, respectively. In conclusion, we can report significantly improved selected characteristics in the final products after the employment of photobiomodulation process, the potential application of this concept on the industrial scale, and its implications on lengthening the product shelf life with improved qualities.

The fatty acid profiles of the mixed fermented milk and its anti-inflammation properties in LPS-induced Raw 264.7 cell model

Increasing knowledge of probiotics has shown that co-cultures of probiotics can achieve better fermentation and beneficial effects, and adding LAB to fermented milk fat products can increase the production of...

Analytical Characterization of the Widely Consumed Commercialized Fermented Beverages from Russia (Kefir and Ryazhenka) and South Africa (Amasi and Mahewu): Potential Functional Properties and Profiles of Volatile Organic Compounds

In this study, four commercialized indigenous fermented beverages most highly consumed in Russia (kefir and ryazhenka) and South Africa (amasi and mahewu) were analyzed for their potential health-promoting properties and flavor-forming volatile organic compounds (VOC). The analysis of antioxidant capacity demonstrated superiority of dairy-based beverages (kefir, ryazhenka and amasi) over the corn-based mahewu; however, mahewu outperformed dairy-based beverages in terms of its potential antihypertensive effect (i.e., the ability to inhibit angiotensin I converting enzyme). The fatty acid (FA) content of kefir and ryazhenka were more diverse compared to that of amasi, but included a lesser amount of branched chain FA. In terms of calculated FA nutritional indices (e.g., indices of atherogenicity and thrombogenicity), kefir and ryazhenka performed similarly and significantly better than amasi. The agreement between beverages theoretical flavor profiles, which was obtained based on the flavors of individual VOC, and consumers’ flavor perception allow hypothesizing about the contribution of detected VOC to the overall products’ flavor. The obtained data expand current knowledge regarding traditional fermented beverages and their values in terms of national dietary recommendations. Additionally, reported VOC profiles will promote the inclusion of traditional fermented beverages into the rations based on the flavor pairing concept (which is controversial but widely applied).

Effect of Supercritical Extract from Black Poplar and Basket Willow on the Quality of Natural and Probiotic Drinkable Yogurt

Yogurt is a fermented milk drink produced by Streptococcus thermophilus, Lactobacillus delbrüeckii ssp. bulgaricus, or Lactobacillus rhamnosus, which can be enriched with polyphenolic compounds to enhance its antioxidant properties. Supercritical (scCO2/H2O) extracts obtained from the mixture of bark and wood of black poplar (Populus nigra) and basket willow (Salix viminalis) are the source of bioactive compounds. The aim of the study was to assess the effect of supercritical extracts from the P. nigra and S. viminalis on the fermentation, quality, and bioactive properties of drinkable natural and probiotic yogurts. The incorporation of scCO2/H2O extracts at a dose of 0.01% (w/v) into milk for the production of natural and probiotic yogurts increases their functional properties by enhancing the antioxidant activity without causing negative effects on the physicochemical and organoleptic properties of products. The antioxidant activity of yogurt with scCO2/H2O extract from P. nigra and S. viminalis was higher than control yogurts by 1.3-13.2% and 4.4-37.5%, respectively. The addition of a supercritical S. viminalis extract reduced the time of natural and probiotic yogurt fermentation. Natural and probiotic yogurt with scCO2/H2O extracts added was characterised by a bacterial population size of over 7 log cfu/g, and the microflora was active throughout the cold storage period. FTIR analysis confirmed the presence of scCO2/H2O extracts from P. nigra or S. viminalis in both types of yogurt. A secondary structure analysis confirmed interactions between compounds of scCO2/H2O extract from P. nigra and S. viminalis extract with milk proteins. These interactions affect the compounds' structural and functional properties by changing, e.g., their digestibility and antioxidant properties.

Effect of Immobilization Support and Fermentation Temperature on Beer and Fermented Milk Aroma Profiles

The food industry increasingly produces wastes like coconut and peanut shells. In addition, low temperature fermentation is always a challenge. Therefore, in the present study, a sustainable exploitation of these by-products is proposed through the production of carriers for immobilized cells of yeast and bacteria. The immobilized cells, after thermally drying, were evaluated for their efficiency in beer and milk fermentations respectively, in various fermentation temperatures and storage for up to three months. The beers and fermented milks were evaluated for their aroma and the results showed products of high quality. Coconut shells resulted in better products with increased fruity ester content in fermented milks and reduced dimethyl sulfite and vicinal diketones and increased ratio of esters to alcohol in beers. These results reveal the possibilities of immobilized cells in coconut and peanut shells for application in food industry, however, more research is needed to evaluate their effect on sensory characteristics and possible prebiotic and probiotic potential especially in the case of fermented milks.

Production and Characterization of a Novel Low-Sugar Beverage from Red Jujube Fruits and Bamboo Shoots Fermented with Selected Lactiplantibacillus plantarum

Red jujube fruits and bamboo shoots are rich in many nutrients and have the advantage of high yield in China. However, the storage of fresh fruits is difficult, and there are no fermented products using both as raw materials. In order to develop the two raw materials into novel products and improve their nutritional value, this study reports the production and characterization of a beverage via fermentation of red jujube fruits and bamboo shoots with Lactiplantibacillus plantarum. L. plantarum TUST-232 was selected as the starter from several different strains by comparing pH value and the number of viable cells, which reached 8.91 log CFU/mL in the beverage fermented for 14 h at 37 °C with 0.3% inoculation. After fermentation, the beverage showed improvement in the contents of several nutrients and antioxidant indices, with a decrease of 44.10% in sucrose content, along with increases of 11.09%, 12.30%, and 59.80% in total phenolic content, total antioxidant capacity, and superoxide anion scavenging ability, respectively. These results indicate that L. plantarum fermentation of red jujube fruits and bamboo shoots could be an effective way to develop a new beverage with high nutritional value, high antioxidant capacity, and high dietary fiber content. This research provided experimental support for the development of new fermentation products with the functions of improving health and body functions.

Effect of Lactobacillus rhamnosus on Physicochemical Properties of Fermented Plant-Based Raw Materials

To overcome texture and flavor challenges in fermented plant-based product development, the potential of microorganisms is generating great interest in the food industry. This study examines the effect of Lactobacillus rhamnosus on physicochemical properties of fermented soy, oat, and coconut. L. rhamnosus was combined with different lactic acid bacteria strains and Bifidobacterium. Acidification, titratable acidity, and viability of L. rhamnosus and Bifidobacterium were evaluated. Oscillation and flow tests were performed to characterize rheological properties of fermented samples. Targeted and untargeted volatile organic compounds in fermented samples were assessed, and sensory evaluation with a trained panel was conducted. L. rhamnosus reduced fermentation time in soy, oat, and coconut. L. rhamnosus and Bifidobacterium grew in all fermented raw materials above 10⁷ CFU/g. No significant effect on rheological behavior was observed when L. rhamnosus was present in fermented samples. Acetoin levels increased and acetaldehyde content decreased in the presence of L. rhamnosus in all three bases. Diacetyl levels increased in fermented oat and coconut samples when L. rhamnosus was combined with a starter culture containing Streptococcus thermophilus and with another starter culture containing S. thermophilus, L. bulgaricus and Bifidobacterium. In all fermented oat samples, L. rhamnosus significantly enhanced fermented flavor notes, such as sourness, lemon, and fruity taste, which in turn led to reduced perception of base-related attributes. In fermented coconut samples, gel firmness perception was significantly improved with L. rhamnosus. The findings suggest that L. rhamnosus can improve fermentation time and sensory perception of fermented plant-based products.

Off-flavors generated during long-term ambient storage of pasteurized drinking yogurt from skim milk

Few studies have examined sensory quality changes during the storage of pasteurized drinking yogurt (PDY), and the cause of off-flavor development is unclear. Off-flavors generated during 90-d ambient storage (25 °C) of PDY from reconstituted skim milk were investigated by sensory evaluation, volatile component analysis with gas chromatography-mass spectroscopy, and gas chromatography-olfactometry. Rancid off-flavor was induced by increased fatty acid concentration due to fat decomposition by heat-stable lipase. Masking of off-flavors was inhibited by degradation of diacetyl, which originally contributed to yogurt-like flavors. Maillard reaction particular to ambient storage of PDY resulted in changes in the furaneol and sotolon levels, which may be involved in enhancement of off-flavors. Finally, our findings indicated that production of 4-vinylguaiacol may be involved in off-flavor development. The results of this study will contribute to the development of PDY with a longer shelf life and superior flavor.

Metabolic footprint analysis of volatile metabolites to discriminate between different key time points in the fermentation and storage of starter cultures and probiotic Lactobacillus casei Zhang milk

Interest has been growing in the co-fermentation of starter cultures with probiotic bacteria in milk. However, the representative metabolites and metabolic changes at different key time points during milk fermentation and storage in starter cultures and probiotic bacteria are still unclear. In this study, we used gas chromatography/mass spectrometry-based metabolomics to identify volatile metabolites and discriminate between 6 different time points [fermentation initiation (FI), fermentation curd (FC), fermentation termination (FT), storage 1 d (S1d), storage 7 d (S7d), and storage 14 d (S14d)] during the fermentation and storage of starter cultures and Lactobacillus casei Zhang milk. Of the 52 volatile metabolites identified, 15 contributed to discrimination of the 6 time points. Then, using the profile from the different time points, we analyzed pairwise comparisons (FI vs. FC; FC vs. FT; FT vs. S1d; S1d vs. S7d; S7d vs. S14d); these time-lapse comparisons showed metabolic progressions from one fermentation stage to the next. We found representative and exclusive metabolites at specific fermentation and storage time points. The greatest difference in metabolites occurred between FC and FT, and the metabolic profiles between S7d and S14d were most similar. Interestingly, decanoic acid, octanoic acid, and hexanoic acid reached their highest level at storage 14 d, indicating that the post-fermentation storage of fermented milk with L. casei Zhang may add more probiotic functions. This work provides detailed insight into the time-specific profiles of volatile metabolites and their dynamic changes; these data may be used for understanding and eventually predicting metabolic changes in milk fermentation and storage, where probiotic strains may be used.

Electronic Nose for Monitoring Odor Changes of Lactobacillus Species during Milk Fermentation and Rapid Selection of Probiotic Candidates

Probiotic bacteria have been associated with a unique production of aroma compounds in fermented foods but rapid methods for discriminating between foods containing probiotic, moderately probiotic, or non-probiotic bacteria remain aloof. An electronic nose (e-nose) is a high-sensitivity instrument capable of non-invasive volatile measurements of foods. In our study, we applied the e-nose to differentiate probiotic, moderately probiotic, and non-probiotic Lactobacillus bacteria strains at different fermentation time points (0th, 4th, and 11th) of milk fermentation. The pH of the changing milk medium was monitored with their corresponding increase in microbial cell counts. An e-nose with two gas chromatographic columns was used to develop classification models for the different bacteria groups and time points and to monitor the formation of the aromatic compounds during the fermentation process. Results of the e-nose showed good classification accuracy of the different bacteria groups at the 0th (74.44% for column 1 and 82.78% for column 2), the 4th (89.44% for column 1 and 92.22% for column 2), and the 11th (81.67% for column 1 and 81.67% for column 2) hour of fermentation. The loading vectors of the classification models showed the importance of some specific aroma compounds formed during the fermentation. Results show that aroma monitoring of the fermentation process with the e-nose is a promising and reliable analytical method for the rapid classification of bacteria strains according to their probiotic activity and for the monitoring of aroma changes during the fermentation process.

Effect of Lactobacillus rhamnosus on Physicochemical Properties of Fermented Plant-Based Raw Materials

Texture and flavor are currently the main challenges in the development of plant-based dairy alternatives. To overcome them, the potential of microorganisms for fermentation of plant-based raw materials is generating great interest in the food industry. This study examines the effect of Lactobacillus rhamnosus, LGG® (LGG® is a trademark of Chr. Hansen A/S) on the physicochemical properties of fermented soy, oat, and coconut. LGG® was combined with different lactic acid bacteria (LAB) strains and Bifidobacterium, BB-12® (BB-12® is a trademark of Chr. Hansen A/S). Acidification, titratable acidity, and growth of LGG® and BB-12® were evaluated. Oscillation and flow tests were performed to analyze the rheological properties of fermented samples. Acids, carbohydrates, and volatile organic compounds in fermented samples were identified, and a sensory evaluation with a trained panel was conducted. LGG® reduced fermentation time in all three bases. LGG® and BB-12® grew in all fermented raw materials above 107 CFU/g. LGG® had no significant effect on rheological behavior of the samples. Acetoin levels increased and acetaldehyde content decreased in the presence of LGG® in all three bases. Diacetyl levels increased in fermented oat and coconut samples when LGG® was combined with YOFLEX® YF-L01 and NU-TRISH® BY-01 (YOFLEX® and NU-TRISH® are trademarks of Chr. Hansen A/S). In all fermented oat samples, LGG® significantly enhanced fermented flavor notes, such as sourness, lemon, and fruity taste, which in turn led to reduced perception of the attributes related to the base. In fermented coconut samples, gel firmness perception was significantly improved in the presence of LGG®. These findings suggest supplementation of LAB cultures with LGG® to improve fermentation time and sensory perception of fermented plant-based products.

Chemical-Sensory Traits of Fresh Cheese Made by Enzymatic Coagulation of Donkey Milk

Making cheese from donkey milk is considered unfeasible, due to difficulties in coagulation and curd forming. Two recent studies have reported the protocols for making fresh cheese by using camel chymosin or calf rennet, but the chemical and sensory characteristics of the products were not thoroughly investigated. The present paper aims to give a further contribution to the field, by investigating cheesemaking with microbial rennet and evaluating the chemical composition, total fatty acid, volatile organic compounds (VOCs) and sensory profile of the resultant product. Six trials were undertaken at laboratory scale on donkey milk from a Martina Franca ass, by applying the technological scheme as reported for calf rennet, with some modifications. Bulk cow milk was used as a control. Donkey milk coagulated rapidly, but the curd remained soft, and was only suitable for making fresh cheese; differently, cow milk coagulated almost instantaneously under these strong technological conditions, giving rise to a semi-hard curd in very short time. The moisture level of donkey cheese was almost the same as reported in the literature, whereas the yield was higher, probably due to the high protein content of the milk used. The total fatty acid composition of cheese presented some differences with respect to milk, mostly consisting in a higher presence of saturated compounds. A connection with a better retention of the large sized fat globules into the curd was hypothesised and discussed. The VOC analyses, performed by solid-phase micro extraction gas chromatography-mass spectrometry, allowed the identification of 11 compounds in milk and 18 in cheese. The sensory characteristics of donkey cheese were strongly different with respect to the control, and revealed unique and pleasant flavours.

Dietary Compounds Influencing the Sensorial, Volatile and Phytochemical Properties of Bovine Milk

The main aim of this study was to evaluate the volatile profile, sensory perception, and phytochemical content of bovine milk produced from cows fed on three distinct feeding systems, namely grass (GRS), grass/clover (CLV), and total mixed ration (TMR). Previous studies have identified that feed type can influence the sensory perception of milk directly via the transfer of volatile aromatic compounds, or indirectly by the transfer of non-volatile substrates that act as precursors for volatile compounds. In the present study, significant differences were observed in the phytochemical profile of the different feed and milk samples. The isoflavone formonoetin was significantly higher in CLV feed samples, but higher in raw GRS milk, while other smaller isoflavones, such as daidzein, genistein, and apigenin were highly correlated to raw CLV milk. This suggests that changes in isoflavone content and concentration in milk relate to diet, but also to metabolism in the rumen. This study also found unique potential volatile biomarkers in milk (dimethyl sulfone) related to feeding systems, or significant differences in the concentration of others (toluene, p-cresol, ethyl and methyl esters) based on feeding systems. TMR milk scored significantly higher for hay-like flavor and white color, while GRS and CLV milk scored significantly higher for a creamy color. Milk samples were easily distinguishable by their volatile profile based on feeding system, storage time, and pasteurization.

PacBio sequencing reveals bacterial community diversity in cheeses collected from different regions

Cheese is a fermented dairy product that is popular for its unique flavor and nutritional value. Recent studies have shown that microorganisms in cheese play an important role in the fermentation process and determine the quality of the cheese. We collected 12 cheese samples from different regions and studied the composition of their bacterial communities using PacBio small-molecule real-time sequencing (Pacific Biosciences, Menlo Park, CA). Our data revealed 144 bacterial genera (including Lactobacillus, Streptococcus, Lactococcus, and Staphylococcus) and 217 bacterial species (including Lactococcus lactis, Streptococcus thermophilus, Staphylococcus equorum, and Streptococcus uberis). We investigated the flavor quality of the cheese samples using an electronic nose system and we found differences in flavor-quality indices among samples from different regions. We found a clustering tendency based on flavor quality using principal component analysis. We found correlations between lactic acid bacteria and the flavor quality of the cheese samples. Biodegradation and metabolism of xenobiotics, and lipid-metabolism-related pathways, were predicted to contribute to differences in cheese flavor using Phylogenetic Investigation of Communities by Reconstruction of Unobserved States (PICRUSt). This preliminary study explored the bacterial communities in cheeses collected from different regions and their potential genome functions from the perspective of flavor quality.