Application of E/Z-Isomerization Technology for Enhancing Processing Efficiency, Health-Promoting Effects, and Usability of Carotenoids: A Review and Future Perspectives

Possibility of refining carotenoid geometrical isomer analysis utilizing DFT-based quantum chemical calculations

We performed quantum chemical calculations based on the density functional theory (DFT) for the all-E- and several Z-isomers of three commercially important carotenoids (lycopene, β-carotene, and astaxanthin) and theoretically obtained the UV-Vis spectrum, response factor (determined from absorption intensities of the all-E- and the Z-isomers), and Q-ratio for each carotenoid isomer. The calculated spectra reproduced the experimental spectral shapes (e.g., the appearance of the Z-peaks and the blue shift of the main peaks for the Z-isomers) very well. The calculated response factors and Q-ratios also showed good agreement with reported values. Notably, response factors, which are difficult to determine experimentally, were well reproduced. These results suggest that quantum chemical calculations can be an effective tool for refining quantitative analysis and obtaining spectral data for carotenoids for which standards are difficult to obtain.

Iodine-induced synthetic method and pharmacokinetic study of cis- and trans-crocetin

Objective

This experiment aimed to obtain the relatively rare cis-crocetin isomer from natural plants, which predominantly exist in the more stable all-trans configuration. This was achieved through iodine-induced isomerization, followed by purification and structural identification. The study also aimed to compare the pharmacokinetic differences between cis- and trans-crocetin in vivo.

Methods

Trans-crocetin of high purity was extracted by hydrolysis from gardenia yellow pigment. Cis-crocetin was then synthesized through an optimized electrophilic addition reaction induced by elemental iodine, and subsequently separated and purified via silica gel column chromatography. Structural identification of cis-crocetin was determined using IR, UV, and NMR techniques. In vivo pharmacokinetic studies were conducted for both cis- and trans-crocetin. In addition to this, we have conducted a comparative study on the in vivo anti-hypoxic activity of trans- and cis-crocetin.

Results

Under the selected reaction conditions using DMF as the solvent, with a concentration of 2.5 mg/mL for both trans-crocetin and the iodine solution, and adjusting the illumination time according to the amount of trans-crocetin, the rate of iodine-induced isomerization was the fastest. Cis-crocetin was successfully obtained and, after purification, its structure was identified and found to be consistent with reported data. Cis-crocetin exhibited a faster absorption rate and higher bioavailability, and despite its shorter half-life, it could partially convert to trans-crocetin in the body, thereby extending the duration of the drug's action within the body to some extent.

Conclusion

This study accomplished the successful preparation and structural identification of cis-crocetin. Additionally, through pharmacokinetic studies, it uncovered notable variations in bioavailability between cis- and trans-crocetin. These findings serve as a solid scientific foundation for future functional research and practical applications in this field.

Effects of Astaxanthin Preparation Form on the Efficiency of Egg Yolk Pigmentation in Laying Hens

This study investigated the effects of the preparation form of astaxanthin on egg yolk pigmentation and egg quality in laying hens. The following four astaxanthin sources were prepared in this study: (1) dried cell powder of Paracoccus carotinifaciens (Panaferd-AX), (2) fine cell powder of P. carotinifaciens (Panaferd-P), (3) astaxanthin oil suspension, and (4) water-soluble astaxanthin powder. These astaxanthin preparations were added to the basal diet at a final concentration of 2 mg/kg and fed to White Leghorn laying hens for 14 days. Although the administration of these astaxanthin preparations did not largely affect egg quality (i.e., egg weight, yolk weight, albumen height, and Haugh unit), feeding significantly improved astaxanthin concentration and yolk color fan score. When water-soluble astaxanthin powder was fed, the yolk astaxanthin concentration and color fan score were most improved, followed by Panaferd-P. These results indicated that astaxanthin pulverization and water solubilization significantly improved its bioavailability in laying hens. Furthermore, although diets rich in (all-E)-astaxanthin were fed to the hens, approximately 30% of astaxanthin was present as the Z-isomers in the egg yolk. These findings may contribute to improving not only the egg quality but the nutritional value of hen eggs.

Isomerization of carotenoids in photosynthesis and metabolic adaptation

In nature, carotenoids are present as trans- and cis-isomers. Various physical and chemical factors like light, heat, acids, catalytic agents, and photosensitizers can contribute to the isomerization of carotenoids. Living organisms in the process of evolution have developed different mechanisms of adaptation to light stress, which can also involve isomeric forms of carotenoids. Particularly, light stress conditions can enhance isomerization processes. The purpose of this work is to review the recent studies on cis/trans isomerization of carotenoids as well as the role of carotenoid isomers for the light capture, energy transfer, photoprotection in light-harvesting complexes, and reaction centers of the photosynthetic apparatus of plants and other photosynthetic organisms. The review also presents recent studies of carotenoid isomers for the biomedical aspects, showing cis- and trans-isomers differ in bioavailability, antioxidant activity and biological activity, which can be used for therapeutic and prophylactic purposes.

Isothiocyanate-functionalized silica as an efficient heterogeneous catalyst for carotenoid isomerization

Daily consumption of carotenoids is associated with multiple health benefits, but their bioavailability is generally extremely low. In this context, the Z-isomerization is receiving attention as a method for increasing carotenoid bioavailability because this approach is superior to conventional physical approaches. Here we investigated the feasibility of using isothiocyanate-functionalized silica (Si-NCS) as a heterogeneous catalyst for carotenoid isomerization. We found that this catalyst promoted Z-isomerization of (all-E)-carotenoids with high efficiency, e.g., when lycopene and astaxanthin solutions were incubated at 50 °C with 10 mg/mL Si-NCS, their total Z-isomer ratios increased by approximately 80 and 50 %, respectively. Furthermore, the Z-isomerization was successfully performed continuously by introducing carotenoid solution into a column packed with Si-NCS. Materials rich in carotenoid Z-isomers have not been used in practical applications due to high production cost and quality limitations (e.g., low Z-isomer ratio). The use of Si-NCS has sufficient potential to solve both these issues.

The chromogenic mechanism of natural pigments and the methods and techniques to improve their stability: A systematic review

Pigments have become a very important part of food research, not only adding sensory properties to food, but also providing functional properties to the food system. In this paper, we review the source, structure, modification, encapsulation and current status of the three main types of natural pigments that have been studied in recent years: polyphenolic flavonoids, tetraterpenoids and betaines. By examining the modification of pigment, the improvement of their stability and the impact of new food processing methods on the pigments, a deeper understanding of the properties and applications of the three pigments is gained, the paper reviews the research status of pigments in order to promote their further research and provide new innovations and ideas for future research in this field.

High-temperature Supercritical CO2 Extraction of Lycopene from Tomato Powder for Enhancing Z-Isomerization and Recovery of Lycopene

This study aimed to investigate the effect of extraction conditions (temperature, pressure, and entrainer content) on the total Z-isomer ratio and recovery of lycopene in the extracts obtained after supercritical CO₂ (SC-CO₂) extraction of lycopene from tomato powder, with a particular focus on high-temperature conditions (≥ 80°C). The results showed that high-temperature SC-CO₂ extraction promoted the thermal isomerization of lycopene in a temperature-dependent manner up to 120℃. For example, when lycopene extraction was carried out at 80, 100, 120, and 140°C and a pressure of 30 MPa with an entrainer, ethanol, for 180 min, the total Z-isomer ratios obtained were 25.0, 57.2, 67.2, and 67.0%, respectively. The entrainer content also affected the Z-isomer ratio of lycopene, but the pressure had little effect. Interestingly, when SC-CO₂ extraction was performed under high-temperature conditions (≥ 100°C), the extraction efficiency of lycopene was dramatically improved, e.g., when lycopene was extracted at 80, 100, 120, and 140°C under the same other conditions as above, the recovery rates of lycopene were 4.6, 28.5, 79.9, 84.8%, respectively. In general, SC-CO₂ extraction of fat-soluble components is performed at temperatures in the range of 40-80°C because the SC-CO₂ density decreases with increasing temperature, and thus, their solubility (extraction efficiency) decreases. However, our results showed that the lycopene recovery increased in a temperature-dependent manner, which might be due to the solubility enhancement associated with thermal Z-isomerization of lycopene (i.e., lycopene Z-isomers have greater solubility than the naturally occurring all-E-isomer). The high-temperature SC-CO₂ extraction of lycopene from tomato materials not only enhances the Z-isomer ratio of lycopene in the resulting extracts but also improves lycopene recovery. This new finding will greatly contribute to the value addition and cost reduction of natural lycopene sources obtained by SC-CO₂ extraction.

Extraction of Fucoxanthin Isomers from the Edible Brown Seaweed Undaria pinnatifida Using Supercritical CO2: Effects of Extraction Conditions on Isomerization and Recovery of Fucoxanthin

Fucoxanthin, a characteristic carotenoid found in brown seaweeds, has been reported to exert beneficial biological activities, including antiobesity and anticancer activities Moreover, the Z-isomers of this compound potentially have greater bioavailability and biological activities than the naturally predominant all-E-isomer. Therefore, the consumption of Z-isomer-rich fucoxanthin through daily meals and dietary supplements may have beneficial effects. In this study, we aimed to investigate the effects of different extraction conditions on the Z-isomer ratio and recovery of fucoxanthin obtained from Undaria pinnatifida using supercritical CO2 (SC-CO2), particularly focusing on the high-temperature conditions that enhance thermal Z-isomerization. High-temperature SC-CO2 extraction at ≥ 120°C was found to enhance the thermal isomerization of fucoxanthin. For example, when the extraction was performed at 40, 80, 120, and 160°C and 30 MPa for 30 min with a co-solvent (ethanol), the total Z-isomer ratios were 11.7, 11.5, 18.7, and 26.5%, respectively. Furthermore, the high-temperature extraction significantly improved fucoxanthin recovery under high-pressure (≥ 30 MPa) conditions in the presence of the co-solvent. For example, when fucoxanthin was extracted at 40, 80, 120, and 160°C under the same conditions as above, the recoveries were 17.5, 20.6, 30.7, and 29.5%, respectively. Hence, the high-temperature SC-CO2 extraction of fucoxanthin from U. pinnatifida would not only enhance health benefits of fucoxanthin via the Z-isomerization but also improve the productivity. Moreover, the use of non-toxic CO2 and a low-toxicity organic solvent (ethanol) ensures that the final fucoxanthin product is safe for consumption. The Z-isomer-rich fucoxanthin obtained using this method is accordingly considered to have potential for use as a dietary supplement.

Oral Supplementation with Z-Isomer-Rich Astaxanthin Inhibits Ultraviolet Light-Induced Skin Damage in Guinea Pigs

The effect of oral supplementation with astaxanthin of different Z-isomer ratios on ultraviolet (UV) light-induced skin damage in guinea pigs was investigated. Astaxanthin with a high Z-isomer content was prepared from the all-E-isomer via thermal isomerization. Intact (all-E)-astaxanthin and the prepared Z-isomer-rich astaxanthin were suspended in soybean oil and fed to guinea pigs for three weeks. The UV-light irradiation was applied to the dorsal skin on the seventh day after the start of the test diet supplementation, and skin parameters, such as elasticity, transepidermal water loss (TEWL), and pigmentation (melanin and erythema values), were evaluated. The accumulation of astaxanthin in the dorsal skin was almost the same after consumption of the all-E-isomer-rich astaxanthin diet (E-AST-D; total Z-isomer ratio = 3.2%) and the Z-isomer-rich astaxanthin diet (Z-AST-D; total Z-isomer ratio = 84.4%); however, the total Z-isomer ratio of astaxanthin in the skin was higher in the case of the Z-AST-D supplementation. Both diets inhibited UV light-induced skin-damaging effects, such as the reduction in elasticity and the increase in TEWL level. Between E-AST-D and Z-AST-D, Z-AST-D showed better skin-protective ability against UV-light exposure than E-AST-D, which might be because of the greater UV-light-shielding ability of astaxanthin Z-isomers than the all-E-isomer. Furthermore, supplementation with Z-AST-D resulted in a greater reduction in skin pigmentation caused by astaxanthin accumulation compared to that of E-AST-D. This study indicates that dietary astaxanthin accumulates in the skin and appears to prevent UV light-induced skin damage, and the Z-isomers are more potent oral sunscreen agents than the all-E-isomer.