The serum-free growth of cultured cells in bovine colostrum and in milk obtained later in the lactation period

Establishing elements of a synthetic biology platform for Vaccinia virus production: BioBrick™ design, serum-free virus production and microcarrier-based cultivation of CV-1 cells

Vaccinia virus (VACV) is an established vector for vaccination and is beginning to prove effective as an oncolytic agent. Industrial production of VACV stands to benefit in future from advances made by synthetic biology in genome engineering and standardisation. The CV-1 cell line can be used for VACV propagation and has been used extensively with the CRISPR/Cas9 system for making precise edits of the VACV genome. Here we take first steps toward establishing a scalable synthetic biology platform for VACV production with CV-1 cells featuring standardised biological tools and serum free cell cultivation. We propose a new BioBrick™ plasmid backbone format for inserting transgenes into VACV. We then test the performance of CV-1 cells in propagation of a conventional recombinant Lister strain VACV, VACVL-15 RFP, in a serum-free process. CV-1 cells grown in 5% foetal bovine serum (FBS) Dulbecco’s Modified Eagle Medium (DMEM) were adapted to growth in OptiPRO and VP-SFM brands of serum-free media. Specific growth rates of 0.047 h⁻¹ and 0.044 h⁻¹ were observed for cells adapted to OptiPRO and VP-SFM respectively, compared to 0.035 h⁻¹ in 5% FBS DMEM. Cells adapted to OptiPRO and to 5% FBS DMEM achieved recovery ratios of over 96%, an indication of their robustness to cryopreservation. Cells adapted to VP-SFM showed a recovery ratio of 82%. Virus productivity in static culture, measured as plaque forming units (PFU) per propagator cell, was 75 PFU/cell for cells in 5% FBS DMEM. VP-SFM and OptiPRO adaptation increased VACV production to 150 PFU/cell and 350 PFU/cell respectively. Boosted PFU/cell from OptiPRO-adapted cells persisted when 5% FBS DMEM or OptiPRO medium was observed during the infection step and when titre was measured using cells adapted to 5% FBS DMEM or OptiPRO medium. Finally, OptiPRO-adapted CV-1 cells were successfully cultivated using Cytodex-1 microcarriers to inform future scale up studies.

Short communication: Bovine-derived proteins activate STAT3 in human skeletal muscle in vitro

Bovine milk contains biologically active peptides that may modulate growth and development within humans. In this study, targeted bovine-derived proteins were evaluated for their effects on signal transducer and activator of transcription-3 (STAT3) phosphorylation in human skeletal muscle cells. Following an acute exposure, bovine-derived acidic fibroblast growth factor-1 (FGF) and leukemia inhibitory factor (LIF) activated STAT3 in differentiating myotubes. Chronic exposure to FGF and LIF during the proliferative phase reduced myoblast proliferation and elevated MyoD and creatine kinase (CKM) mRNA expression without altering apoptotic genes. In mature myotubes, neither FGF nor LIF elicited any action. Together, these data indicate that a reduction in proliferation in the presence of bovine-derived FGF or LIF may stimulate early maturation of myoblasts.

Bovine colostrum or milk as a serum substitute for the cultivation of a mouse hybridoma

A mouse-mouse hybridoma was grown in serum-free medium supplemented with bovine milk or colostrum. Bovine colostrum supported growth of the hybridoma whereas bovine milk alone did not support cellular proliferation. For growth in medium supplemented with colostrum, the maximum cell concentration achieved was 1.4 x 10(6) cells/mL in 2.2% colostrum, which is 44% of that obtained in 9% serum. When cells were grown in media containing milk and low amounts of serum (<1%) the maximum cell concentration in 2.2% milk with 0.4% serum was 2 x 10(6) cells/ml, whereas it was only 0.2 x 10(6) cells/ml and 1.3 x 10(6) cells/ml in 2.2% milk alone and 0.4% serum alone, respectively. Similar behavior was observed for growth in media containing colostrum and low amounts of serum. The monoclonal antibody production in media containing combinations of serum and milk or colostrum was comparable to that obtained in media with higher serum concentrations. Experiments performed with conditioned media suggest that the rapid decrease in viability, after the maximum cell concentration has been reached, is partially due to the presence of some inhibitory components generated during the cell culture rather than due to depletion of some serum components.

Bovine colostrum promotes growth and migration of the human keratinocyte HaCaT cell line

Bovine colostrum represents a rich source of growth factors, which are known to play a central role in wound healing. The aim of our study was to investigate the possible mitogenic and motogenic effects induced by colostrum on human keratinocytes. Cell proliferation evaluated by 3-(4,5-dimethyl-2-thiazolyl)-2,5-diphenyl-2H-tetrazolium bromide test and 5-Bromo-2'-deoxyuridine incorporation revealed that colostrum exerts a growth promoting activity. Scratch assay and immunofluorescence of actin cytoskeleton showed its effectiveness also in inducing cell migration. Furthermore, colostrum treatment increases the levels of tyrosine phosphorylated proteins and the activated forms of the extracellular signal-regulated kinases 1 and 2 and such effects appear to be repressed by the tyrosine kinase inhibitor genistein. Our results indicate that the biological activities of colostrum are specifically mediated by the growth factor-induced activation of tyrosine kinase receptors and underline the relevance of the synergistic action exerted by the growth factors in stimulating keratinocyte proliferation and migration essential for tissue repair.

Biologically active factors in bovine milk and dairy byproducts: influence on cell culture

Substantial progress has been made in our knowledge of the biological properties of mammal milks. Many nutritional, biochemical, immunological, or other biological properties have been studied in mature or industrially processed bovine milk as well as in human milk and colostrum. This article is a critical review of selected publications covering (1) the use of bovine milk or dairy byproducts (processed acid and enzymatic whey fractions) as a serum substitute for cell cultures, (2) specific factors in bovine milk and industrially processed milk the affect cell proliferation, and (3) the known functional and biological roles of two whey proteins: beta-lactoglobulin and the PP3 component.

Identification and partial purification of a basic fibroblast growth factor-like growth factor derived from bovine colostrum

Bovine colostrum that had been collected up to 6 h postpartum was fractionated by ammonium sulfate precipitation, and various fractions were examined for basic fibroblast growth factor activity. Activity that stimulated cell growth was detected in the cream fraction, which was purified by isoelectric focusing and heparin affinity chromatography. Three peaks were eluted from the heparin affinity column at approximately 0.5, 1, and 1.75 M NaCl. Although activity that stimulated cell growth was detected in the second and third peaks, a reaction with antibasic fibroblast growth factor antibody was observed only in the third peak. Fractions in the second and third peaks were examined by SDS-PAGE and Western blot analysis. Activity that stimulated cell growth was detected in the second and third peaks; however, after Western blot analysis using antibasic fibroblast growth factor, only the third peak yielded positive bands at 15 and 28 kDa. These fractions were further subjected to a neutralization test using antibasic fibroblast growth factor antibody. The activity that stimulated cell growth in the second peak was virtually unchanged; however, the activity in the third peak was diminished, showing a relative activity of less than 10% at 1.25 micrograms/ml. Therefore, neutralization of the activity that stimulates cell growth by antibasic fibroblast growth factor antibody suggests that the third peak, which was eluted at approximately 1.5 to 2 M NaCl in heparin affinity chromatography, might be a basic fibroblast growth factor-like growth factor.

Milk-derived growth factors as serum supplements for the growth of fibroblast and epithelial cells

We have investigated the response of several epithelial and fibroblastic cells to a mitogenic extract of bovine milk. Cation exchange chromatography was used to produce a mitogen-rich fraction from an industrial whey source that, although comprising only 0.5% of total whey protein, contained the bulk of the growth factor activity. This fraction was a source of potent growth promoting activity for all mesodermal-derived cells tested, including human skin and embryonic lung fibroblasts, Balb/c 3T3 fibroblasts, and rat L6 myoblasts. Maximal growth of all these cell types exceeded that observed in 10% fetal bovine serum. Feline kidney and baby hamster fibroblasts and Chinese hamster ovary cells were less responsive, achieving a maximal growth response of 50-75% that observed in 10% fetal bovine serum. Maximal growth achieved in whey-extract-supplemented cultures of Balb/c 3T3 and human skin fibroblasts, and L6 myoblast cultures exceeded that seen in response to recombinant acidic or basic fibroblast growth factor, platelet-derived growth factor, insulin-like growth factor, or epidermal growth factor. Importantly, addition of low concentrations of fetal bovine serum to the whey-derived mitogenic fraction produced an additive response. However, concentrated milk-derived factors were found to be inhibitory to the growth of all epithelial lines tested, including rat intestinal epithelial cells, canine kidney epithelial cells, and mink lung cells. It is concluded that industrial whey extracted in this form constitutes an important source of potent growth-promoting agents for the supplementation of mesodermal-derived cell cultures.

Bovine colostrum ultrafiltrate supplemented with adult bovine serum and transferrin: an effective FBS substitute for cultivation of Vero and CHO-K1 cells

A mixture containing an ultrafiltrate fraction (UF) of bovine colostrum (6.7%), adult bovine serum (BS) (1%), and human holo-transferrin (hTF) (5 mg/liter) was developed for cultivation of Chinese hamster ovary cells (CHO-K1) and African green monkey kidney cells (Vero). The growth-supporting activity of the mixture (UF/BS/hTF) was comparable to that of 1 to 10% fetal bovine serum (FBS) and considerably better than 1 to 2% BS. Cells could be directly seeded from FBS-supplemented medium to UF/BS/hTF-supplemented medium without any weaning period, even at initial plating density of 1700 cells/ml. Vero and CHO-K1 cells were cultivated in UF/BS/hTF-supplemented media for up to 43 days without any apparent reduction in growth. The UF/BS/hTF mixture could also be used as a freezing medium. Cells were passaged twice in the mixture, frozen, and stored at liquid N2 for 11 wk. After thawing, the viability of Vero and CHO-K1 cells was reduced 13 and 7%, respectively, and both cell lines started to grow well. Additional hTF could be replaced with bovine holo-transferrin, although a high concentration (150 mg/liter) should be used for CHO-K1 cells. The results suggest that the UF/BS/hTF mixture provides a new economical alternative to FBS in cultivation of Vero and CHO-K1 cells in the presence of reduced protein amounts.

Bovine colostrum ultrafiltrate: an effective supplement for the culture of mouse-mouse hybridoma cells

An ultrafiltrate fraction (UF) of bovine colostrum has been successfully used as a cell culture supplement for growth and monoclonal IgG antibody production of cultured mouse-mouse hybridomas derived from spleen cells. In this study we compared the ability of UF to support growth and antibody production of IgA hybridomas derived from Peyer's patch cells with that of an IgG hybridoma cell line. One IgG (LPC2) and two IgA hybridoma cell lines (RB3 and P2E7) were used as models. The optimal UF concentration for Ig production and cell growth for both the IgA hybridoma RB3 and the IgG hybridomas was 5-10%. Initial plating density was found to be a critical factor for IgA hybridoma cell growth: the IgA hybridomas required a seeding density of at least 70,000 cells/ml to grow compared to 15,000 IgG hybridoma cells/ml (Pakkanen et al., 1992). The addition of small amounts (up to 2%) of FBS in 10% UF supplemented medium did not enhance IgA production or cell growth. RB3 and LPC2 cells seeded at equal density and grown in 10% UF for 8 days attained maximum cell densities at 3-4 days that were 58% (RB3) or 34% (LPC2) lower than those in 10% FBS, but the total amounts of monoclonal antibody produced were 73% and 83%, respectively, of that in 10% FBS. Thus, Ig production per cell was 22-27% higher in 10% UF than in 10% FBS. Hybridoma cells could be cultured for at least 5 weeks without any reduction in growth rates, if medium was partially but not completely replaced twice a week. This suggests that hybridoma cells maintained in UF supplemented medium secrete growth promoting factors. Cells maintained in UF for up to 5 weeks sustained similar monoclonal antibody production rates as in short term culture. These results show that UF can be used as an economical and effective hybridoma culture supplement for the production of both IgG and IgA antibodies.

Bovine colostrum fraction as a serum substitute for the cultivation of mouse hybridomas

Fractions of bovine colostrum were prepared and their ability to support the growth of mouse-mouse hybridomas in culture was tested. Whey was prepared from defatted colostrum by removal of casein using acid precipitation. An ultrafiltrate was obtained from cleared whey by filtration through membranes with a nominal molecular mass cut-off of 100,000 Da. Colostrum ultrafiltrate contained 1.16 milligrams protein, 0.24 milligrams immunoglobulin G (IgG) and less than 0.24 EU (endotoxin unit)/ml endotoxins. The effect of defatted colostrum, whey and ultrafiltrate as serum substitutes was examined by cultivation of hybridoma cells in minimal essential medium containing different concentrations of the supplements. Under optimal conditions in ultrafiltrate-supplemented medium, the maximal cell concentration was 35-40% of that obtained using 10% foetal bovine serum, and IgG production per cell was equal to that achieved using serum. In 1% defatted colostrum the maximum hybridoma concentration was about 30% of that in 10% serum, but at higher concentrations hybridoma growth was significantly reduced. The growth-promoting activity of whey was low. The results show that bovine colostrum ultrafiltrate provides a very attractive alternative to serum for production of monoclonal antibodies.

Factors in ruminant colostrum that influence cell growth and murine IgE antibody responses

Bovine colostrum was investigated as a source of biologically active molecules capable of stimulating the growth of mammalian cells in culture and modifying the immune response in a murine model. An extract prepared from bovine colostral whey by cation exchange and reversed-phase chromatography stimulated the growth of L6 rat myoblasts, Balb/c-3T3 mouse fibroblasts and BHK-21 baby hamster kidney cells with equal or greater potency than fetal bovine serum. Fractionation of the bovine colostral extract by gel-permeation chromatography in M-acetic acid identified a number of cell-growth factors for each cell type. Bovine colostral extract was compared with an ovine colostral whey preparation for its ability to modulate IgE antibody responses in mice. Doses of 8 and 4 mg/d of ovine colostral whey or bovine colostral extract specifically suppressed IgE antibody responses, whereas at lower doses suppression did not occur. We conclude that bovine colostrum contains cell-growth factors as well as immunomodulatory factors that are able to regulate the IgE response in a heterologous species.

Insulin in bovine colostrum and milk: evolution throughout lactation and binding to caseins

The changes in insulin concentration in bovine milk in the first period of lactation and its association with other milk proteins were studied. Highest concentration was found in the first milking (327 ng/ml). This concentration fell within the first 24 h postpartum to about 50% of its initial value. By d 3, the level was about 25%, and, on d 7, a stable concentration was reached at approximately 46 ng/ml (about 14% of its initial value). This concentration is about 100 times higher than that in serum, which suggests a specific mechanism of transfer from blood to milk. Colostral whey obtained by ultrafiltration or ultracentrifugation contains much less insulin than colostrum. When colostrum or milk was incubated with [125I]insulin and whey and casein fractions were separated by precipitation, it was observed that most insulin remained with the casein. However, when colostrum was incubated with [125I]insulin and subjected to gel filtration, most of the radioactivity corresponded to free insulin, indicating that insulin is associated with the precipitated casein but not with the casein micelles in solution.

Isolation and characterisation of milk growth factor, a transforming-growth-factor-beta 2-related polypeptide, from bovine milk

A strategy was developed for the purification of a biologically active polypeptide growth and migration factor from skimmed bovine milk. This 25-kDa dimeric molecule, termed milk growth factor (MGF), was isolated by a method consisting of a combination of strong cation-exchange chromatography, low-pressure hydrophobic-interaction chromatography, hydrophobic-interaction HPLC and size-exclusion HPLC steps, which separated the protein according to its properties of charge, hydrophobicity and size, respectively. On average, a total purification of 10(6)-10(7)-fold and a yield of approximately 115 +/- 78 ng/MGF/milk was obtained using the method described. All purification steps were performed with novel combinations of ethanol and volatile acidic salt (ammonium acetate) solutions in order to retain biological activity of the protein. These conditions, together with the easy removal of salt by lyophilization, facilitated the detection of biological activity in fractions collected at each step of the purification by means of a sensitive in vitro fibroblast-migration assay in which the half-maximal activity was obtained at a concentration of approximately 17 +/- 4 pg/ml (i.e. approximately 1 pM) of the pure protein. Biological activity of the dimeric protein was unaffected by heat treatment or exposure to acid (pH 2.0), but was lost upon reduction to its monomeric form. Amino acid composition and sequence analyses demonstrate that MGF is related to transforming growth factor type beta 2.

Lipid peroxidation and activities of tyrosine aminotransferase and glutamine synthetase in hepatoma and glioma cells grown in bovine colostrum-supplemented medium

The growth stimulating properties of bovine serum and colostrum were compared in rat hepatoma (HTC) and glioma (C6) cell cultures. A colostrum concentration of 2% was optimal for HTC cells, which then reached a terminal density 40% of that in serum-supplemented medium. The corresponding figures for C6 cells were 10 and 81%, respectively. After 4 d in culture, levels of lipid hydroperoxides were measured and compared. Highest levels of lipid hydroperoxides were found in HTC and C6 cells grown in unsupplemented medium. HTC and C6 cells grown in serum supplemented medium contained levels of 52 and 64%, respectively, of that in unsupplemented medium. The corresponding levels for cells grown in presence of colostrum were 40% for HTC and 44% for C6 cells. To obtain information on any functional alterations in the cells due to the presence of colostrum the induction of tyrosine aminotransferase (EC 2.6.1.5) and glutamine synthetase (EC 6.3.1.2) by dexamethasone was studied. Although colostrum seemed to increase the basal activities of the enzymes, no significant effects on the degree of induction could be detected.

Purification and characterization of bovine milk fibronectin

Fibronectins were isolated from both bovine colostrum and fresh milk, and they were found to be very similar to plasma fibronectin. The concentration of fibronectin in milk decreased post partum: 30 micrograms/ml after 0 d and 2 micrograms/ml after 7-851 d. No fibronectin could be detected in any brands of ultra heat treated liquid milk on the market (less than or equal to 0.006 micrograms/ml).

Growth factors and wound healing in the hamster

We have investigated the effect of topically applied mitogenic preparations on the healing of full-thickness skin wounds in the Syrian hamster. In an attempt to accelerate the healing process, dexamethasone and insulin, platelet-derived growth factor, fibroblast growth factor, thrombin, defined medium F for fibroblasts, liver cell supernatant, epidermal growth factor, and colostrum were applied to the wounds. These mitogens had no significant influence on the rate of wound contraction or on the time to complete healing in full-thickness, noncompromised skin wounds in this animal model.

Phenotypic transformation of normal rat kidney cells in a growth-factor-defined medium: induction by a neuroblastoma-derived transforming growth factor independently of the EGF receptor

Polypeptide growth factor activity in serum can be destroyed by treatment with dithiothreitol. When such growth-factor-inactivated serum is used as a supplement of culture media instead of regular serum, normal rat kidney (NRK) cells become quiescent unless defined polypeptide growth factors like insulin and epidermal growth factor (EGF) are added. On this basis a growth-factor-defined medium has been developed for NRK cells, which permits cell proliferation as rapidly as in media supplemented with serum, even at low cell densities. Moreover, cells can be serially passaged in this medium. NRK cells can be induced to grow in semisolid media when incubated with transforming growth factors. The growth-factor-defined medium permits soft agar growth experiments of NRK cells, without interference from polypeptide growth factors in serum. Using this assay system we have shown that EGF alone is unable to induce any degree of anchorage-independent growth in NRK cells. However, a recently identified transforming growth factor from mouse neuroblastoma cells which does not compete with EGF for receptor binding is able to induce progressively growing colonies of NRK cells in soft agar, even without additional EGF.

Stimulation of the proliferation of the Madin-Darby canine kidney (MDCK) epithelial cell line by high-density lipoproteins and their induction of 3-hydroxy-3-methylglutaryl coenzyme A reductase activity

MDCK Cells seeded on extracellular matrix- (ECM) coated dishes and exposed to medium supplemented with high-density lipoproteins (HDLs, 750 micrograms protein/ml) and transferrin (10 micrograms/ml) have a proliferative rate, final cell density, and morphological appearance similar to those of cells grown in serum-supplemented medium. The mitogenic stimulus provided by HDLs is not limited by the initial cell density at which cultures are seeded, nor is it limited in time, since cells grown in medium supplemented with transferrin and HDLs grew to at least 50 generations. The presence of HDLs in the medium is required in order for cells to survive, since cells actively proliferating in the presence of medium supplemented with HDLs and transferrin begin to die within 2 days after being transferred to medium supplemented only with transferrin. Low-density lipoprotein (LDL) is mitogenic for MDCK cells when present at low concentrations (from 2.5 to 100 micrograms protein/ml). Above 100 micrograms protein/ml, LDL is cytotoxic and therefore cannot support cell proliferation at an optimal rate. The mitogenic effect of HDLs is also observed when cells are maintained on fibronectin-coated dishes. However, the proliferative rate of the cells is suboptimal and cultures cannot be passaged on this substrate indefinitely, as they can be on ECM-coated dishes. A close association between the ability of HDLs to support cell proliferation and their ability to induce the activity of 3-hydroxy-3-methylglutaryl coenzyme A (HMG CoA) reductase is observed. HMG CoA reductase activity is 18 times higher (70 pmoles/min/10(6) cells) in proliferating cells than in confluent, nondividing cells (4 pmoles/min/10(6) cells). The HMG Coa reductase activity of sparse cells is more sensitive to induction by HDLs (eight-fold higher than control cells) than is the enzyme activity of confluent cells (two-fold higher than control levels). The dose-response relationship between the abilities of HDLs to support proliferation and to induce HMG CoA reductase activity are similar. The time course of the stimulation of proliferation and the increase in enzyme activity of sparse, quiescent cells after exposure to HDLs are parallel. The HMG CoA reductase activity of sparse MDCK cells is induced six-fold by exposure to compactin, a competitive inhibitor of HMG CoA reductase. This induction of HMG CoA reductase is prevented by mevalonic acid, not affected by LDL, and synergistically enhanced by simultaneous exposure to HDLs. HDLs effect a rescue from the cytotoxic effect of compactin, whereas LDL does not.(ABSTRACT TRUNCATED AT 400 WORDS)