A requirement for phosphoenolpyruvate carboxylase in the cyanobacterium Synechococcus PCC 7942

Sustainable production of photosynthetic isobutanol and 3-methyl-1-butanol in the cyanobacterium Synechocystis sp. PCC 6803

BACKGROUND

Cyanobacteria are emerging as green cell factories for sustainable biofuel and chemical production, due to their photosynthetic ability to use solar energy, carbon dioxide and water in a direct process. The model cyanobacterial strain Synechocystis sp. PCC 6803 has been engineered for the isobutanol and 3-methyl-1-butanol production by introducing a synthetic 2-keto acid pathway. However, the achieved productions still remained low. In the present study, diverse metabolic engineering strategies were implemented in Synechocystis sp. PCC 6803 for further enhanced photosynthetic isobutanol and 3-methyl-1-butanol production.

RESULTS

Long-term cultivation was performed on two selected strains resulting in maximum cumulative isobutanol and 3-methyl-1-butanol titers of 1247 mg L-1 and 389 mg L-1, on day 58 and day 48, respectively. Novel Synechocystis strain integrated with a native 2-keto acid pathway was generated and showed a production of 98 mg isobutanol L-1 in short-term screening experiments. Enhanced isobutanol and 3-methyl-1-butanol production was observed when increasing the kivdS286T copy number from three to four. Isobutanol and 3-methyl-1-butanol production was effectively improved when overexpressing selected genes of the central carbon metabolism. Identified genes are potential metabolic engineering targets to further enhance productivity of pyruvate-derived bioproducts in cyanobacteria.

CONCLUSIONS

Enhanced isobutanol and 3-methyl-1-butanol production was successfully achieved in Synechocystis sp. PCC 6803 strains through diverse metabolic engineering strategies. The maximum cumulative isobutanol and 3-methyl-1-butanol titers, 1247 mg L-1 and 389 mg L-1, respectively, represent the current highest value reported. The significantly enhanced isobutanol and 3-methyl-1-butanol production in this study further pave the way for an industrial application of photosynthetic cyanobacteria-based biofuel and chemical synthesis from CO2.

Production of succinate by engineered strains of Synechocystis PCC 6803 overexpressing phosphoenolpyruvate carboxylase and a glyoxylate shunt

BACKGROUND

Cyanobacteria are promising hosts for the production of various industrially important compounds such as succinate. This study focuses on introduction of the glyoxylate shunt, which is naturally present in only a few cyanobacteria, into Synechocystis PCC 6803. In order to test its impact on cell metabolism, engineered strains were evaluated for succinate accumulation under conditions of light, darkness and anoxic darkness. Each condition was complemented by treatments with 2-thenoyltrifluoroacetone, an inhibitor of succinate dehydrogenase enzyme, and acetate, both in nitrogen replete and deplete medium.

RESULTS

We were able to introduce genes encoding the glyoxylate shunt, aceA and aceB, encoding isocitrate lyase and malate synthase respectively, into a strain of Synechocystis PCC 6803 engineered to overexpress phosphoenolpyruvate carboxylase. Our results show that complete expression of the glyoxylate shunt results in higher extracellular succinate accumulation compared to the wild type control strain after incubation of cells in darkness and anoxic darkness in the presence of nitrate. Addition of the inhibitor 2-thenoyltrifluoroacetone increased succinate titers in all the conditions tested when nitrate was available. Addition of acetate in the presence of the inhibitor further increased the succinate accumulation, resulting in high levels when phosphoenolpyruvate carboxylase was overexpressed, compared to control strain. However, the highest succinate titer was obtained after dark incubation of an engineered strain with a partial glyoxylate shunt overexpressing isocitrate lyase in addition to phosphoenolpyruvate carboxylase, with only 2-thenoyltrifluoroacetone supplementation to the medium.

CONCLUSIONS

Heterologous expression of the glyoxylate shunt with its central link to the tricarboxylic acid cycle (TCA) for acetate assimilation provides insight on the coordination of the carbon metabolism in the cell. Phosphoenolpyruvate carboxylase plays an important role in directing carbon flux towards the TCA cycle.

Systematic identification and elimination of flux bottlenecks in the aldehyde production pathway of Synechococcus elongatus PCC 7942

Isotopically nonstationary metabolic flux analysis (INST-MFA) provides a versatile platform to quantitatively assess in vivo metabolic activities of autotrophic systems. By applying INST-MFA to recombinant aldehyde-producing cyanobacteria, we identified metabolic alterations that correlated with increased strain performance in order to guide rational metabolic engineering. We identified four reactions adjacent to the pyruvate node that varied significantly with increasing aldehyde production: pyruvate kinase (PK) and acetolactate synthase (ALS) fluxes were directly correlated with product formation, while pyruvate dehydrogenase (PDH) and phosphoenolpyruvate carboxylase (PPC) fluxes were inversely correlated. Overexpression of enzymes for PK or ALS did not result in further improvements to the previous best-performing strain, while downregulation of PDH expression (through antisense RNA expression) or PPC flux (through expression of the reverse reaction, phosphoenolpyruvate carboxykinase) provided significant improvements. These results illustrate the potential of INST-MFA to enable a systematic approach for iterative identification and removal of pathway bottlenecks in autotrophic host cells.

Recent Advances in the Photoautotrophic Metabolism of Cyanobacteria: Biotechnological Implications

Cyanobacteria constitute the only phylum of oxygen-evolving photosynthetic prokaryotes that shaped the oxygenic atmosphere of our planet. Over time, cyanobacteria have evolved as a widely diverse group of organisms that have colonized most aquatic and soil ecosystems of our planet and constitute a large proportion of the biomass that sustains the biosphere. Cyanobacteria synthesize a vast array of biologically active metabolites that are of great interest for human health and industry, and several model cyanobacteria can be genetically manipulated. Hence, cyanobacteria are regarded as promising microbial factories for the production of chemicals from highly abundant natural resources, e.g., solar energy, CO₂, minerals, and waters, eventually coupled to wastewater treatment to save costs. In this review, we summarize new important discoveries on the plasticity of the photoautotrophic metabolism of cyanobacteria, emphasizing the coordinated partitioning of carbon and nitrogen towards growth or compound storage, and the importance of these processes for biotechnological perspectives. We also emphasize the importance of redox regulation (including glutathionylation) on these processes, a subject which has often been overlooked.

Oligomerization and characteristics of phosphoenolpyruvate carboxylase in Synechococcus PCC 7002

Phosphoenolpyruvate carboxylase (PEPc) is an essential enzyme in plants. A photosynthetic form is present both as dimer and tetramer in C4 and CAM metabolism. Additionally, non-photosynthetic PEPcs are also present. The single, non-photosynthetic PEPc of the unicellular cyanobacterium Synechococcus PCC 7002 (Synechococcus), involved in the TCA cycle, was examined. Using size exclusion chromatography (SEC) and small angle X-ray scattering (SAXS), we observed that PEPc in Synechococcus exists as both a dimer and a tetramer. This is the first demonstration of two different oligomerization states of a non-photosynthetic PEPc. High concentration of Mg2+, the substrate PEP and a combination of low concentration of Mg2+ and HCO3- induced the tetramer form of the carboxylase. Using SEC-SAXS analysis, we showed that the oligomerization state of the carboxylase is concentration dependent and that, among the available crystal structures of PEPc, the scattering profile of PEPc of Synechococcus agrees best with the structure of PEPc from Escherichia coli. In addition, the kinetics of the tetramer purified in presence of Mg2+ using SEC, and of the mixed population purified in presence of Mg2+ using a Strep-tagged column were examined. Moreover, the enzyme showed interesting allosteric regulation, being activated by succinate and inhibited by glutamine, and not affected by either malate, 2-oxoglutarate, aspartic acid or citric acid.

Analysis and elucidation of phosphoenolpyruvate carboxylase in cyanobacteria

Phosphoenolpyruvate carboxylase (PEPC) a cytosolic enzyme of higher plants is also found in bacteria and cyanobacteria. Genetic and biochemical investigations have indicated that there are several isoforms of PEPC belonging to C3; C3/C4 and C4 groups but, the evolution of PEPC in cyanobacteria is not yet understood. The present study opens up an opportunity to understand the isoforms and functions of PEPC in cyanobacteria. The variations observed in PEPC among lower and higher orders of cyanobacteria, suggests convergent evolution of PEPC. There is a specific PEPC phosphorylation residue 'serine' at the N-terminus and PEPC determinant residue 'serine' at the C-terminal that facilitates high affinity for substrate binding. These residues were unique to higher orders of cyanobacteria, but, not in lower orders and other prokaryotes. The different PEPC forms of cyanobacteria were investigated for their kinetic properties with phosphoenolpyruvate as the substrate and the findings corroborated well with the in silico findings. In vitro enzymatic study of cyanobacteria belonging to three different orders demonstrated the role of aspartate as an allosteric effector, which inhibited PEPC by interacting with the highly conserved residues in the active site. The differences in mode of inhibition among the different order, thus, give a fair picture about the cyanobacterial PEPCs. The higher orders appear to possess the sequence coordinates and functionally conserved residues similar to isoforms of C4 type higher plants, whereas isoforms of PEPC of the lower orders did not resemble either that of C3 or C4 plants.

Exploring metabolic engineering design principles for the photosynthetic production of lactic acid by Synechocystis sp. PCC6803

BACKGROUND

Molecular engineering of the intermediary physiology of cyanobacteria has become important for the sustainable production of biofuels and commodity compounds from CO2 and sunlight by "designer microbes." The chemical commodity product L-lactic acid can be synthesized in one step from a key intermediary metabolite of these organisms, pyruvate, catalyzed by a lactate dehydrogenase. Synthetic biology engineering to make "designer microbes" includes the introduction and overexpression of the product-forming biochemical pathway. For further optimization of product formation, modifications in the surrounding biochemical network of intermediary metabolism have to be made.

RESULTS

To improve light-driven L-lactic acid production from CO2, we explored several metabolic engineering design principles, using a previously engineered L-lactic acid producing mutant strain of Synechocystis sp. PCC6803 as the benchmark. These strategies included: (i) increasing the expression level of the relevant product-forming enzyme, lactate dehydrogenase (LDH), for example, via expression from a replicative plasmid; (ii) co-expression of a heterologous pyruvate kinase to increase the flux towards pyruvate; and (iii) knockdown of phosphoenolpyruvate carboxylase to decrease the flux through a competing pathway (from phosphoenolpyruvate to oxaloacetate). In addition, we tested selected lactate dehydrogenases, some of which were further optimized through site-directed mutagenesis to improve the enzyme's affinity for the co-factor nicotinamide adenine dinucleotide phosphate (NADPH). The carbon partitioning between biomass and lactic acid was increased from about 5% to over 50% by strain optimization.

CONCLUSION

An efficient photosynthetic microbial cell factory will display a high rate and extent of conversion of substrate (CO2) into product (here: L-lactic acid). In the existing CO2-based cyanobacterial cell factories that have been described in the literature, by far most of the control over product formation resides in the genetically introduced fermentative pathway. Here we show that a strong promoter, in combination with increased gene expression, can take away a significant part of the control of this step in lactic acid production from CO2. Under these premises, modulation of the intracellular precursor, pyruvate, can significantly increase productivity. Additionally, production enhancement is achieved by protein engineering to increase co-factor specificity of the heterologously expressed LDH.

Light-induced gene expression of fructose 1,6-bisphosphate aldolase during heterotrophic growth in a cyanobacterium, Synechocystis sp. PCC 6803

Synechocystis sp. PCC 6803 exhibits light-activated heterotrophic growth (LAHG) under dark conditions with glucose as a carbon source. The light activation is remarkable at a late period of photoautotrophic preculture, such as the late-linear and stationary growth phases. To understand the physiological effects of light irradiation and glucose under LAHG conditions, their effects on the expression of soluble proteins were analyzed by means of 2D-PAGE. Various soluble proteins, which were minimal under photoautotrophic preculture conditions, were observed clearly under LAHG conditions, suggesting that proteins were synthesized actively under these conditions. Fructose 1,6-bisphosphate aldolase, one of the glycolytic enzymes, was found to be induced under LAHG conditions on 2D-PAGE. The activity of fructose 1,6-bisphosphate aldolase, which had decreased during photoautotrophic preculture, also increased under LAHG conditions, similar to the mRNA level of the encoding gene, fbaA. In addition, we found that a deletion mutant of sll1330, a putative gene containing a helix-turn-helix DNA-binding motif, could not grow under LAHG conditions, whereas it could grow photoautotrophically. The increases in the protein level of FbaA and fbaA gene expression observed in wild-type cells under LAHG conditions were greatly inhibited in the deletion mutant. These results suggest that the regulation of fbaA gene expression by way of sll1330 is one of the important processes in Synechocystis sp. PCC 6803 under light pulse LAHG conditions.

Interaction between carbon and nitrogen metabolism during akinete development in the cyanobacterium Anabaena torulosa

Nutrient enrichment with a nitrogen (as nitrate) or carbon (as fructose) source to unaerated diazo and photoautorophic cultures of the cyanobacterium Anabaena torulosa induced early development of akinetes with high frequency. When cultures under any mode of nutrition were aerated, akinetes were not differentiated. Unaerated cultures with nitrate nitrogen or fructose exhibited higher respiratory rates and nitrogen assimilation compared to aerated cultures. This was evidenced by increased respiratory O2 uptake and high activities of pyruvate kinase, malate dehydrogenase (NAD+), nitrogenase and nitrate reductase signifying that akinete forming unaerated cultures exhibited high carbon dissimilation and nitrogen assimilation resulting in high nitrogenous build up in the cells. Aerated, non-akinete cultures, on the other hand, were associated with low respiratory O2 uptake, low pyruvate kinase and malate dehydrogenase (NAD+) activities, suggesting that carbon dissimilation was not favoured either in presence of nitrate or fructose. Moreover, higher activity of NADP+ linked malate dehydrogenase and lower nitrate reductase activity in aerated cultures led to a high carbon and low nitrogen content of the cells resulting in high cellular C:N ratio. The results suggest that interaction between carbon and nitrogen metabolism regulates akinete development in A. torulosa.

Transcriptional regulation of the respiratory genes in the cyanobacterium Synechocystis sp. PCC 6803 during the early response to glucose feeding

The coordinated expression of the genes involved in respiration in the photosynthetic cyanobacterium Synechocystis sp. PCC 6803 during the early period of glucose (Glc) treatment is poorly understood. When photoautotrophically grown cells were supplemented with 10 mm Glc in the light or after a dark adaptation period of 14 h, significant increases in the respiratory activity, as determined by NAD(P)H turnover, respiratory O(2) uptake rate, and cytosolic alkalization, were observed. At the same time, the transcript levels of 18 genes coding for enzymes associated with respiration increased with differential induction kinetics; these genes were classified into three groups based on their half-rising times. Transcript levels of the four genes gpi, zwf, pdhB, and atpB started to increase along with a net increase in NAD(P)H, while the onset of net NAD(P)H consumption coincided with an increase in those of the genes tktA, ppc, pdhD, icd, ndhD2, ndbA, ctaD1, cydA, and atpE. In contrast, the expression of the atpI/G/D/A/C genes coding for ATP synthase subunits was the slowest among respiratory genes and their expression started to accumulate only after the establishment of cytosolic alkalization. These differential effects of Glc on the transcript levels of respiratory genes were not observed by inactivation of the genes encoding the Glc transporter or glucokinase. In addition, several Glc analogs could not mimic the effects of Glc. Our findings suggest that genes encoding some enzymes involved in central carbon metabolism and oxidative phosphorylation are coordinately regulated at the transcriptional level during the switch of nutritional mode.

Pleiotropic effect of a histidine kinase on carbohydrate metabolism in Synechocystis sp. strain PCC 6803 and its requirement for heterotrophic growth

The deletion of a gene coding for a histidine kinase (sll0750, Hik8) in the unicellular cyanobacterium Synechocystis sp. strain PCC 6803 resulted in a conditional lethal phenotype with a pleiotropic effect on the expression of genes involved in glucose metabolism. This mutant had comparable doubling times to wild type (WT) in continuous-light-grown photoautotrophic and mixotrophic cultures, whereas it grew poorly under mixotrophic conditions with different light and dark cycles. Growth was completely stopped, and cells eventually died, when the light duration was less than 6 h on a 24-h regimen. Northern blot analysis demonstrated that steady-state transcript levels of genes encoding key enzymes of glycolysis, gluconeogenesis, the oxidative pentose phosphate pathway, and glycogen metabolism were significantly altered in a strain with mutant hik8 (Deltahik8) grown with or without glucose. In some cases, differential expression was dependent on growth conditions (photoautotrophic versus mixotrophic). The enzyme activities of glucose-6-phosphate dehydrogenase, 6-phosphogluconate dehydrogenase, and phosphofructokinase were significantly reduced in Deltahik8 compared to WT. Glycogen determination indicated that Deltahik8 accumulated glycogen under mixotrophic conditions but was unable to utilize these reserves for heterotrophic growth. The results suggest that the loss of gap1 transcription in the absence of Hik8 was the key factor that rendered cells unable to catabolize glucose and grow heterotrophically. Additionally, the transcript levels of the phytochrome gene (cph1) and its cotranscribed response regulator gene (rcp1) were significantly reduced and its dark inducibility was lost in Deltahik8. The results demonstrated that Hik8 plays an important role in glucose metabolism and is necessary for heterotrophic growth.

Characterization of a gene encoding dihydrolipoamide dehydrogenase of the cyanobacterium Synechocystis sp. strain PCC 6803

The authors previously reported the isolation and partial characterization of a periplasmically located dihydrolipoamide dehydrogenase (LPD) from the cyanobacterium Synechocystis sp. strain PCC 6803. In the present work the gene (lpdA; database accession number Z48564) encoding the apoprotein of this LPD in Synechocystis PCC 6803 has been identified, sequenced and analysed. The lpdA gene codes for a protein starting with methionine, which is post-translationally removed. The mature protein contains an N-terminal serine and consists of 473 amino acids with a deduced molecular mass of 51421 Da (including one FAD). The LPD is an acidic protein with a calculated isoelectric point of 5.17. Comparison of the amino acid sequence of the Synechocystis LPD with protein sequences in the databases revealed that the enzyme shares identities of 31-35% with all 18 LPDs so far sequenced and published. As a first step in determining the role of this cyanobacterial LPD, attempts were made to generate an LPD-free Synechocystis mutant by insertionally inactivating the lpdA gene with a kanamycin-resistance cassette. However, the selected transformants appeared to be heteroallelic, containing both the intact lpdA gene and the lpdA gene inactivated by the drug-resistance cassette. The heteroallelic mutant studied, which had about 50% of the wild-type LPD activity, caused acidification of the growth medium. Growth over a prolonged time was only possible after an increased buffering of the medium. Since it is reported in the literature that inactivation of the pyruvate dehydrogenase complex (PDC) leads to acidosis, a function of the LPD in a cytoplasmic-membrane-associated PDC is conceivable.

A protein involved in co-ordinated regulation of inorganic carbon and glucose metabolism in the facultative photoautotrophic cyanobacterium Synechocystis PCC6803

The involvement of a gene of Synechocystis PCC6803, icfG, in the co-ordinated regulation of inorganic carbon and glucose metabolism, was established. The icfG gene codes for a 72 kDa protein, which shows no homology with those registered in data libraries. Expression of icfG required glucose, the actual inducer probably being glucose-6-phosphate, and was independent of light and of the external inorganic carbon concentration. Mutants carrying an inactivated copy of icfG were constructed. Their growth characteristics were identical to those of the wild type under all regimes except in limiting inorganic carbon with glucose being present either before or after the transfer to the limiting conditions. These conditions completely prevented growth, both in the light and in the dark. The inhibition could be relieved by several intermediates of the tricarboxylic acid cycle. Assays of various enzymic activities related to inorganic carbon uptake and to its assimilation via either the Calvin cycle or phosphoenolpyruvate carboxylase did not reveal the level of action of IcfG. Possible models include a blockage of the assimilation of both carbon sources in the absence of IcfG, or the inhibition of Ci incorporation route(s) essential under limiting inorganic carbon conditions, even when glucose is present, and even in the dark.