Freshwater microalgae selection for simultaneous wastewater nutrient removal and lipid production

Microalgae separation in MP-PVC contaminated wastewater using plant-based coagulant over different extraction methods in Bauru, Brazil

This study investigates the effectiveness of coagulation-flocculation and sedimentation (CFS) for separating microalgae, focusing on the use of various Moringa oleifera extracts as natural coagulants. We examined photobioreactor effluent (PBR) both with and without microplastic PVC (MP-PVC) contamination, referred to as PBR R2 and PBR R1, respectively. Utilising response surface methodology, we identified optimal conditions for the removal of microalgae and MP-PVC. Validation tests demonstrated that the aqueous extract of delipidated Moringa oleifera powder (AEDMOP) achieved high removal efficiencies, with coagulant dosages of 630 mg L-1 for PBR R1 and 625 mg L-1 for PBR R2. Both conditions showed microalgae removal efficiencies exceeding 83% for turbidity, colour, OD540 nm, OD680 nm, and OD750 nm, and 63% for OD254 nm. Interestingly, the optimised conditions for PBR R2 required slightly less coagulant, likely due to the additional particulate matter from MP-PVC. While extracellular polymeric substances (EPS) exhibited a marginal effect on flocculation, further investigation into their role in CFS is necessary. Our findings highlight the potential of AEDMOP for efficient microalgae separation, even in the presence of microplastics.

Wastewater treatment optimization utilizing polyvinyl alcohol cryogel immobilized microalgae for nutrient removal

This study investigated the use of polyvinyl alcohol (PVA) cryogels to immobilize microalgae for wastewater treatment. Chlorella sorokiniana was successfully entrapped in PVA cryogels via repeated freeze/thaw cycles. The nutrient removal efficiency of these cryogels was tested in a continuously stirred photobioreactor under varying conditions, both with and without the addition of an organic carbon source (sodium acetate). The presence of organic carbon significantly enhanced nutrient removal. Specifically, PVA cryogels with immobilized C. sorokiniana achieved 100% nitrogen removal and 97.2% phosphorus removal under mixotrophic conditions. Furthermore, the maximum nutrient removal capacities of the PVA cryogels were found to be 0.033 mg-N/cube·day for nitrogen and 0.0047 mg-P/cube·day for phosphorus. As the inorganic carbon (bicarbonate) concentration increased from 5 to 100 mg/L, the N/P ratio rose from 6 to 8, with a higher N/P ratio of 10 observed when nitrate nitrogen was used as the nitrogen source, compared to ammonia nitrogen, at 100 mg/L bicarbonate. This study offers an effective method for using microalgae immobilized in PVA cryogels for wastewater treatment. The findings highlight the potential for PVA cryogels to significantly improve nutrient removal efficiency, particularly in the presence of organic carbon sources, thereby enhancing bioreactor performance. High nitrogen and phosphorus removal efficiencies can help reduce eutrophication in water bodies, protect aquatic ecosystems, and enable nutrient recovery and reuse, supporting a circular economy in wastewater treatment practices.

Marine diatom algae cultivation in simulated dairy wastewater and biomass valorization

Liquid byproducts and organic wastes generated from dairy processing units contribute as the largest source of industrial food wastewater. Though bacteria-mediated treatment strategies are largely implemented, a more effective and innovative management system is needed of the hour. Thus, the current study involves the cultivation of centric diatoms, Chaetoceros gracilis, and Thalassiosira weissflogii in simulated dairy wastewater (SDWW) formulated using varying amounts of milk powder with artificial seawater f/2 media (ASW). The results revealed that cell density and biomass productivity were highest in the 2.5% SDWW treatment cultures of both the strains, the maximum being in C. gracilis (7.5 × 106 cells mL - 1; 21.1 mg L-1 day-1). Conversely, the total carotenoid, chrysolaminarin, and phenol content were negatively impacted by SDWW. However, a considerable enhancement in the total lipid content was reported in the 2.5% SDWW culture of both species. Furthermore, the fatty acid profiling revealed that though the total polyunsaturated fatty acid (PUFA) content was highest in the control setups, the total mono polyunsaturated fatty acid (MUFA) content was higher in the 5% SDWW setups (30.66% in C. gracilis and 33.21% in T. weissflogii). In addition to it, in the cultures utilizing energy from external carbon sources provided by SDWW, the biodiesel produced was also enhanced owing to the heightened cetane number. Thus, the current study evidently highlights the organic carbon acquisition potential of marine diatoms with the scope of providing sustainable biorefinery.

Microalgae-mediated bioremediation: current trends and opportunities-a review

Environmental pollution poses a critical global challenge, and traditional wastewater treatment methods often prove inadequate in addressing the complexity and scale of this issue. On the other hand, microalgae exhibit diverse metabolic capabilities that enable them to remediate a wide range of pollutants, including heavy metals, organic contaminants, and excess nutrients. By leveraging the unique metabolic pathways of microalgae, innovative strategies can be developed to effectively remediate polluted environments. Therefore, this review paper highlights the potential of microalgae-mediated bioremediation as a sustainable and cost-effective alternative to conventional methods. It also highlights the advantages of utilizing microalgae and algae-bacteria co-cultures for large-scale bioremediation applications, demonstrating impressive biomass production rates and enhanced pollutant removal efficiency. The promising potential of microalgae-mediated bioremediation is emphasized, presenting a viable and innovative alternative to traditional treatment methods in addressing the global challenge of environmental pollution. This review identifies the opportunities and challenges for microalgae-based technology and proposed suggestions for future studies to tackle challenges. The findings of this review advance our understanding of the potential of microalgae-based technology wastewater treatment.

Application of ANN-MOGA for nutrient sequestration for wastewater remediation and production of polyunsaturated fatty acid (PUFA) by Chlorella sorokiniana MSP1

Chlorella bears excellent potential in removing nutrients from industrial wastewater and lipid production enriched with polyunsaturated fatty acids. However, due to the changing nutrient dynamics of wastewater, growth and metabolic activity of Chlorella are affected. In order to sustain microalgal growth in wastewater with concomitant production of PUFA rich lipids, RSM (Response Surface Methodology) followed by heuristic hybrid computation model ANN-MOGA (Artificial Neural Network- Multi-Objective Genetic Algorithm) were implemented. Preliminary experiments conducted taking one factor at a time and design matrix of RSM with process variables viz. Sodium chloride (1 mM-40 mM), Magnesium sulphate (100 mg-800 mg) and incubation time (4th day to 20th day) were validated by ANN-MOGA. The study reported improved biomass and lipid yield by 54.25% and 12.76%, along with total nitrogen and phosphorus removal by 21.92% and 18.72% respectively using ANN-MOGA. It was evident from FAME results that there was a significantly improved concentration of linoleic acid (19.1%) and γ-linolenic acid (21.1%). Improved PUFA content makes it a potential feedstock with application in cosmeceutical, pharmaceutical and nutraceutical industry. The study further proves that C. sorokiniana MSP1 mediated industrial wastewater treatment with PUFA production is an effective way in providing environmental benefits along with value addition. Moreover, ANN-MOGA is a relevant tool that could control microalgal growth in wastewater.

Advanced nanomaterials and metal-organic frameworks for catalytic bio-diesel production from microalgal lipids - A review

Increasing energy demands require exploring renewable, eco-friendly (green), and cost-effective energy resources. Among various sources of biodiesel, microalgal lipids are an excellent resource, owing to their high abundance in microalgal biomass. Transesterification catalyzed by advanced materials, especially nanomaterials and metal-organic frameworks (MOFs), is a revolutionary process for overcoming the energy crisis. This review elaborates on the conversion of microalgal lipids (including genetically modified algae) into biodiesel while primarily focusing on the transesterification of lipids into biodiesel by employing catalysts based on above mentioned advanced materials. Furthermore, current challenges faced by this process for industrial scale upgradation are presented with future perspectives and concluding remarks. These materials offer higher conversion (>90%) of microalgae into biodiesel. Nanocatalytic processes, lack the need for higher pressure and temperature, which simplifies the overall process for industrial-scale application. Green biodiesel production from microalgae offers better fuel than fossil fuels in terms of performance, quality, and less environmental harm. The chemical and thermal stability of advanced materials (particularly MOFs) is the main benefit of the blue recycling of catalysts. Advanced materials-based catalysts are reported to reduce the risk of biodiesel contamination. While purity of glycerin as side product makes it useful skin-related product. However, these aspects should still be controlled in future studies. Further studies should relate to additional aspects of green production, including waste management strategies and quality control of obtained products. Finally, catalysts stability and recycling aspects should be explored.

Screening of microalgae species and evaluation of algal-lipid stimulation strategies for biodiesel production

Microalgae is considered an alternative source for biodiesel production producing renewable, sustainable and carbon-neutral energy. Microalgae property changes among species, which determines the efficiency of biodiesel production. Besides the lipid content evaluation, multi-principles (including high lipid productivity, high biomass yield, pollution resistance and desired fatty acid, etc.) for superior oil-producing species screening was proposed in this review and three microalgae species (Chlorella vulgaris, Scenedesmus obliquus and Mychonastes afer) with high bio-lipid producing prospect were screened out based on big data digging and analysis. The multilateral strategies for algal-lipid stimulating were also compared, among which, nutrient restriction, temperature control, heterotrophy and chemicals addition showed high potential in enhancing lipid accumulation; while electromagnetic field showed little effect. Interestingly, it was found that the lipid accumulation was more sensitive to nitrogen (N)-limitation other than phosphorus (P). Nutrient restriction, salinity stress etc. enhanced lipid accumulation by creating a stressed environment. Hence, optimum conditions (e.g. N:15-35 mg/L and P:4-16 mg/L) should be set to balance the lipid accumulation and biomass growth, and further guarantee the algal-lipid productivity. Otherwise, two-step cultivation could be applied during all the stressed stimulation. Different from lab study, effectiveness, operability and economy should be all considered for stimulation strategy selection. Nutrient restriction, temperature control and heterotrophy were highly feasible after the multidimensional evaluation.

Effects of feast-famine nutrient regimes on wastewater algal biofuel communities

Microalgae accumulate lipids in response to nutrient deprivation, and these lipids are a biodiesel fuel stock. Algal cultivation with secondary wastewater effluent is one proposed platform for biofuel production, which provides nutrients to algae while further polishing wastewater effluent. Algal bioreactors were tested using a feast-famine feeding regiment in simulated secondary wastewater effluent to evaluate the effects on lipid content and algal community structure. Algal polycultures were inoculated into reactors fed with synthetic secondary wastewater effluent at pH 7.5 and 9 and operated under a feast-famine nutrient (N, P, and BOD) supply regime in sequencing batch reactors. Fatty acid methyl ester contents of the reactors were assessed, which showed a decrease in lipid content after the feast-famine cycling (from 12.2% initially to 5.2% after four cycles at pH 9). This decrease in lipid content was not correlated with an increase in carbohydrate storage within biomass, nor an increase in bacterial biomass abundance relative to algal biomass in the reactors. The eukaryotic microbial communities from reactors operated at pH 9 diverged from reactors operated at pH 7.5 during cycling, with the pH 9 reactors becoming dominated by a single Operational Taxonomic Unit aligning to the Scenedesmus genus. These results suggest that high pH and feast-famine nutrient cycling may select for a less diverse algal community with a lower lipid content within a secondary wastewater polishing scheme.

Microalgae bioreactor for nutrient removal and resource recovery from wastewater in the paradigm of circular economy

Every day, large quantities of wastewater are discharged from various sources that could be reused. Wastewater contains nutrients such as nitrogen or phosphorus, which can be recovered. Microalgae-based technologies have attracted attention in this sector, as they are able to bioremediate wastewater, harnessing its nutrients and generating algal biomass useful for different downstream uses, as well as having other advantages. There are multiple species of microalgae capable of growing in wastewater, achieving nutrient removal efficiencies surpassing 70%. On the other hand, microalgae contain lipids that can be extracted for energy recovery in biodiesel. Currently, there are several methods of lipid extraction from microalgae. Other biofuels can also be obtained from microalgae biomass, such as bioethanol, biohydrogen or biogas. This review also provides information on bioenergy products and products in the agri-food industry as well as in the field of human health based on microalgae biomass within the concept of circular bioeconomy.

Biological-Based Produced Water Treatment Using Microalgae: Challenges and Efficiency

Produced water (PW) is the most significant waste stream generated in the oil and gas industries. The generated PW has the potential to be a useful water source rather than waste. While a variety of technologies can be used for the treatment of PW for reuse, biological-based technologies are an effective and sustainable remediation method. Specifically, microalgae, which are a cost-effective and sustainable process that use nutrients to eliminate organic pollutants from PW during the bioremediation process. In these treatment processes, microalgae grow in PW free of charge, eliminate pollutants, and generate clean water that can be recycled and reused. This helps to reduce CO2 levels in the atmosphere while simultaneously producing biofuels, other useful chemicals, and added-value products. As such, this review focuses on PW generation in the oil and gas industry, PW characteristics, and examines the available technologies that can be used for PW remediation, with specific attention to algal-based technologies. In addition, the various aspects of algae growth and cultivation in PW, the effect of growth conditions, water quality parameters, and the corresponding treatment performance are presented. Lastly, this review emphasizes the bioremediation of PW using algae and highlights how to harvest algae that can be processed to generate biofuels for added-value products as a sustainable approach.

Algae as potential feedstock for various bioenergy production

Depletion of non-renewable feedstock and severe wastewater pollution due to human activities have created negative impact to living organisms. The potential solution is to implement wastewater treatment and bioelectricity production through algae-based microbial fuel cell. The algae biomass produced from microbial fuel cell could be further processed to generate biofuels through their unique compositions. The consumption of nutrients in wastewater through algae cultivation and biomass produced to be utilized for energy supply have showed the potential of algae to solve the issues faced nowadays. This review introduces the background of algae and mitigation of wastewater using algae as well as the bioenergy status in Malaysia. The mechanisms of nutrient assimilation such as nitrogen, phosphorus, carbon, and heavy metals are included, followed by the application of algae in microbial fuel cell's chambers. Lastly, the status of algae for bioenergy production are covered.

A Review about Microalgae Wastewater Treatment for Bioremediation and Biomass Production—A New Challenge for Europe

Microalgae have received much attention in the last few years. Their use is being extended to different fields of application and technologies, such as food, animal feed, and production of valuable polymers. Additionally, there is interest in using microalgae for removal of nutrients from wastewater. Wastewater treatment with microalgae allows for a reduction in the main chemicals responsible for eutrophication (nitrogen and phosphate), the reduction of organic substrates (by decreasing parameters such as BOD and COD) and the removal of other substances such as heavy metals and pharmaceuticals. By selecting and reviewing 202 articles published in Scopus between 1992 and 2020, some aspects such as the feasibility of microalgae cultivation on wastewater and potential bioremediation have been investigated and evaluated. In this review, particular emphasis was placed on the different types of wastewaters on which the growth of microalgae is possible, the achievable bioremediation and the factors that make large-scale microalgae treatment feasible. The results indicated that the microalgae are able to grow on wastewater and carry out effective bioremediation. Furthermore, single-step treatment with mixotrophic microalgae could represent a valid alternative to conventional processes. The main bottlenecks are the large-scale feasibility and costs associated with biomass harvesting.

Exploration of Microalgal Species for Nutrient Removal from Anaerobically Digested Swine Wastewater and Potential Lipids Production

Bio-treatment of anaerobically treated swine wastewater (ADSW) mediated by microalgae has been deemed as a promising strategy. In the present study, six microalgal strains were used to conduct batch experiments in 0~100% ADSW in order to evaluate their potentials for nutrient removal and biodiesel production. Two strains, Chlorella vulgaris FACHB-8 and Chlorella sp. FACHB-31, were selected based on their better growth performances, higher tolerance to wastewater (up to 100%), and better nutrient removal abilities. The capacity of each strain to remove TN, TP, NH₄⁺-N, as well as lipid production and biomass composition in 100% ADSW were further examined. After 15 days of culture, 87.68~89.85%, 92.61~93.68%, and 97.02~97.86% of the nitrogen, phosphorus, and ammonia nitrogen were removed by Chlorella sp. FACHB-31 and C. vulgaris FACHB-8. Their lipid content and lipid productivities were 29.63~33.33% and 18.91~23.10 mg L^-1 d^-1, respectively. Proteins were both the major biomass fraction followed by lipids and then carbohydrates. Their fatty acid profiles both mainly consisted of C-16:0, C-18:1, C-18:0, and C-18:2. Taken together, our results suggest that C. vulgaris FACHB-8 and Chlorella sp. FACHB-31 are potential candidates for biodiesel production by using ADSW as a good feedstock.

Kinetic modeling of autotrophic microalgae mainline processes for sewage treatment in phosphorus-replete and -deplete culture conditions

A kinetic model of autotrophic microalgal growth in sewage was developed to determine the biokinetic processes involved, including carbon-, nitrogen- and phosphorus-limited microalgal growth, dependence on light intensity, temperature and pH, light attenuation and gas exchange to the atmosphere. A new feature was the differentiation between two metabolic pathways of phosphorus consumption according to the availability of extracellular phosphorus. Two scenarios were differentiated: phosphorus-replete and -deplete culture conditions. In the former, the microalgae absorbed phosphorus to grow and store polyphosphate. In the latter the microalgae used the stored polyphosphate as a phosphorus source for growth. Calibration and validation were performed with experimental data from a pilot-scale membrane photobioreactor (MPBR) fed with the permeate obtained from an anaerobic membrane bioreactor (AnMBR) pilot plant fed with real urban wastewater. 12 of the model parameters were calibrated. Despite the dynamics involved in the operating and environmental conditions, the model was able to reproduce the overall process performance with a single set of model parameters values. Four periods of different environmental and operational conditions were accurately simulated. Regarding the former, light and temperature ranged 10-406 μmol·m^-2·s^-1 and 19.7-32.1 °C, respectively. Concerning the later, the photobioreactors widths were 0.25 and 0.10 m, and the biomass and hydraulic retention times ranged 3-4.5 and 1.5-2.5 days, respectively. The validation of the model resulted in an overall correlation coefficient (R²) of 0.9954. The simulation results showed the potential of the model to predict the dynamics of the different components: the relative proportions of microalgae, nitrogen and phosphorus removal, polyphosphate storage and consumption, and soluble organic matter concentration, as well as the influence of environmental parameters on the microalgae's biokinetic processes. The proposed model could provide an effective tool for the industry to predict microalgae production and comply with the discharge limits in areas declared sensitive to eutrophication.

A Review on Synchronous Microalgal Lipid Enhancement and Wastewater Treatment

Microalgae are unicellular photosynthetic eukaryotes that can treat wastewater and provide us with biofuel. Microalgae cultivation utilizing wastewater is a promising approach for synchronous wastewater treatment and biofuel production. However, previous studies suggest that high microalgae biomass production reduces lipid production and vice versa. For cost-effective biofuel production from microalgae, synchronous lipid and biomass enhancement utilizing wastewater is necessary. Therefore, this study brings forth a comprehensive review of synchronous microalgal lipid and biomass enhancement strategies for biofuel production and wastewater treatment. The review emphasizes the appropriate synergy of the microalgae species, culture media, and synchronous lipid and biomass enhancement conditions as a sustainable, efficient solution.

Growth of Chlorella pyrenoidosa on different septic tank effluents from rural areas for lipids production and pollutants removal

Septic tank effluent from rural areas was an ideal medium for cultivating oleaginous microalgae. However, the characteristics of septic tank effluents varied greatly due to the different incoming wastewater, and bring uncertain risks for algal growth. In this study, an oleaginous microalgae was cultivated in septic effluents from different mixed wastewater. The results showed that the effluent from pure toilet wastewater was the best medium to achieve the highest biomass yield (1.68 g·L^-1) and productivity (154.6 mg·L^-1·d^-1). In contrast, the discharge of kitchen or laundry wastewater reduced the biomass production by 50.5-79.1%. That caused much lower lipids production in effluents from mixed wastewater regardless of its high lipids content and saturation degree. The results suggest that the discharge of kitchen or laundry wastewater bring risks for biomass and lipids production, and should be separated from the toilet wastewater before entering into septic tank.

Microalgae as Sustainable Biofactories to Produce High-Value Lipids: Biodiversity, Exploitation, and Biotechnological Applications

Microalgae are often called “sustainable biofactories” due to their dual potential to mitigate atmospheric carbon dioxide and produce a great diversity of high-value compounds. Nevertheless, the successful exploitation of microalgae as biofactories for industrial scale is dependent on choosing the right microalga and optimum growth conditions. Due to the rich biodiversity of microalgae, a screening pipeline should be developed to perform microalgal strain selection exploring their growth, robustness, and metabolite production. Current prospects in microalgal biotechnology are turning their focus to high-value lipids for pharmaceutic, nutraceutic, and cosmetic products. Within microalgal lipid fraction, polyunsaturated fatty acids and carotenoids are broadly recognized for their vital functions in human organisms. Microalgal-derived phytosterols are still an underexploited lipid resource despite presenting promising biological activities, including neuroprotective, anti-inflammatory, anti-cancer, neuromodulatory, immunomodulatory, and apoptosis inductive effects. To modulate microalgal biochemical composition, according to the intended field of application, it is important to know the contribution of each cultivation factor, or their combined effects, for the wanted product accumulation. Microalgae have a vital role to play in future low-carbon economy. Since microalgal biodiesel is still costly, it is desirable to explore the potential of oleaginous species for its high-value lipids which present great global market prospects.

Increasing Phosphorus Uptake Efficiency by Phosphorus-Starved Microalgae for Municipal Wastewater Post-Treatment

Four microalgal species, Chlorella vulgaris, Botryococcus braunii, Ankistrodesmus falcatus, and Tetradesmus obliquus were studied for enhanced phosphorus removal from municipal wastewater after their exposure to phosphorus starvation. Microalgae were exposed to phosphorus starvation conditions for three and five days and then used in a batch experiment to purify an effluent from a small WWTP. After 3-day P-starvation, C. vulgaris biomass growth rate increased by 50% and its PO₄ removal rate reached > 99% within 7 days. B. braunii maintained good biomass growth rate and nutrient removal regardless of the P-starvation. All species showed 2–5 times higher alkaline phosphatase activity increase for P-starved biomass than at the reference conditions, responding to the decline of PO₄ concentration in wastewater and biomass poly-P content. The overall efficiency of biomass P-starvation on enhanced phosphorus uptake was found to be dependent on the species, N/P molar ratio in the wastewater, as well as the biomass P content.

Insights into upstream processing of microalgae: A review

The aim of this review is to provide insights into the upstream processing of microalgae, and to highlight the advantages of each step. This review discusses the most important steps of the upstream processing in microalgae research such as cultivation modes, photobioreactors design, preparation of culture medium, control of environmental factors, supply of microalgae seeds and monitoring of microalgal growth. An extensive list of bioreactors and their working volumes used, elemental composition of some well-known formulated cultivation media, different types of wastewater used for microalgal cultivation and environmental variables studied in microalgae research has been compiled in this review from the vast literature. This review also highlights existing challenges and knowledge gaps in upstream processing of microalgae and future research needs are suggested.

Pilot-scale phycoremediation using Muriellopsis sp. for wastewater reclamation in the Atacama Desert: microalgae biomass production and pigment recovery

Municipal wastewater phycoremediation represents a promising circular economy-based process for wastewater reclamation used to recover water and produce biomass. This study aimed to evaluate a pilot-scale phycoremediation system, using the most efficient strain of microalgae for wastewater reclamation in the Atacama Desert. Nitrogen and phosphorus removal, as well as biomass growth, were compared in different microalgae treatments, namely Muriellopsis sp., Scenedesmus almeriensis, Chlamydomonas segnis, Chlorella pyrenoidosa and Chlorella vulgaris. The most efficient treatments, Muriellopsis sp. and S. almeriensis, were scaled up to 20-L bubble column reactors to evaluate nutrient removal and biomass biochemical profile for potential biotechnological application. Finally, Muriellopsis sp. was selected for a pilot-scale phycoremediation experiment (800-L raceway), which removed 84% of nitrogen, 93% of phosphorus and other chemical compounds after 4 days of treatment to meet most of the Chilean standards for irrigation water (NCh. 1333. DS. MOP No. 867/78). Faecal coliforms count was reduced by 99.9%. Furthermore, biomass productivity reached 104.25 mg·L^-1·day^-1 value with 51% protein, and pigment content of 0.6% carotenoid, with 0.3% lutein. These results indicate the potential of wastewater phycoremediation at an industrial scale for the production of irrigation water and carotenoid using Muriellopsis sp.

Removal of Nitrogen and Phosphorus from Thickening Effluent of an Urban Wastewater Treatment Plant by an Isolated Green Microalga

Microalgae are photosynthetic microorganisms and are considered excellent candidates for a wide range of biotechnological applications, including the removal of nutrients from urban wastewaters, which they can recover and convert into biomass. Microalgae-based systems can be integrated into conventional urban wastewater treatment plants (WW-TP) to improve the water depuration process. However, microalgal strain selection represents a crucial step for effective phytoremediation. In this work, a microalga isolated from the effluent derived from the thickening stage of waste sludge of an urban WW-TP was selected and tested to highlight its potential for nutrient removal. Ammonium and phosphate abatements by microalgae were evaluated using both the effluent and a synthetic medium in a comparative approach. Parallelly, the isolate was characterized in terms of growth capability, morphology, photosynthetic pigment content and photosystem II maximum quantum yield. The isolated microalga showed surprisingly high biomass yield and removal efficiency of both ammonium and phosphate ions from the effluent but not from the synthetic medium. This suggests its clear preference to grow in the effluent, linked to the overall characteristics of this matrix. Moreover, biomass from microalgae cultivated in wastewater was enriched in photosynthetic pigments, polyphosphates, proteins and starch, but not lipids, suggesting its possible use as a biofertilizer.

Fast cultivation and harvesting of oil-producing microalgae Ankistrodesmus falcatus var. acicularis fed with anaerobic digestion liquor via biogranulation in addition to nutrients removal

This study examined the feasibility of cultivation and harvesting of oil-producing microalgae (i.e. Ankistrodesmus falcatus var. acicularis) via biogranulation in two identical sequencing batch reactors (SBRs) fed with synthetic anaerobic digestion liquor. Easily settled algae granules with compact structure appeared around day 90 and mature granules were obtained after 150 days' operation. The microalgae settleability was remarkably improved, signaling by the substantial decrease of sludge volume index (SVI₃₀) from initially >3000 to 53.44 ± 3.31 mL/g, with settling velocity correspondingly increased from nearly 0 to 18.47 ± 0.23 m/h. Although the percentage of the target microalgae (Ankistrodesmus falcatus var. acicularis) decreased along with the granulation process, the biomass concentration (2-4 g/L) and biomass productivity (130-270 mg/L/d) using biogranulation were 10-20 times and 16-34 times that by the traditional suspension method. Compared to the seed microalgae cells, more extracellular polymeric substances (EPS) (162.54 ± 3.60 mg/g-mixed liquor volatile suspended solids (MLVSS)) with a higher proteins/polysaccharides ratio (7.62) were excreted from the mature algae granules. Moreover, the mature microalgae granules showed comparable nutrients removal, averagely 96% and 86% of dissolved organic carbon (DOC) and NH₄⁺-N from the digestion liquor, respectively, reflecting its great potential for simultaneous microalgae cultivation, harvesting and wastewater treatment.

Characterization of Chlorella sorokiniana and Chlorella vulgaris fatty acid components under a wide range of light intensity and growth temperature for their use as biological resources

This study aims to characterize the potential of three strains of microalgal species (Chlorella sorokiniana KNUA114 and KNUA122; C. vulgaris KNUA104) for use as feedstock, based on their fatty acid compositions. Each strain was molecularly identified using four marker genes (ITS, SSU, rbcL, and tufA) and phylogenetically characterized. C. sorokiniana and C. vulgaris collected from Ulleung Island, South Korea, were homologous with other known species groups. Samples' fatty acid components were measured using GC/MS analysis in growth temperatures of 10 °C, 25 °C, and 35 °C. The growth rate of C. sorokiniana strains was higher than that of C. vulgaris under high-temperature conditions, confirming the potential industrial applicability of the former as feedstock material. Additionally, saturated fatty acid contents and productivities increased as biological resources of the C. sorokiniana strains were higher than those of C. vulgaris under high light intensity and temperature conditions. These results suggest that the fatty acid components of C. sorokiniana strains may potentially be used as biological resources (e.g., feedstock).

Simultaneous wastewater treatment and lipid production by Scenedesmus sp. HXY2

Screening for highly efficient microalgae is an important technique for improving treatment efficiency. In this study, eight species of microalgae (five Scenedesmus and three Desmodesmus) were isolated from water and soil in the Hexi Corridor region, China, and identified by 18S rRNA gene sequence analysis. Scenedesmus sp. HXY2 grew well under high total organic carbon and ammonia conditions and had the highest nutrient removal efficiency (>95%). On day 12, the biomass of Scenedesmus sp. HXY2 was 7.2 × 10⁶ cells mL^-1. The lipid content and productivity of this species were 15.56% and 5.67 mg L^-1 day^-1, respectively. The proportion of unsaturated fatty acids (60.07%) indicated that the lipids of Scenedesmus sp. HXY2 were suitable for biodiesel production. Scenedesmus sp. HXY2 showed great potential for growth in wastewater with high ammonia and organic contents to simultaneously purify wastewater and produce lipids.

Cultivating microalgae in wastewater for biomass production, pollutant removal, and atmospheric carbon mitigation; a review

Water shortage is one of the leading global problems along with the depletion of energy resources and environmental deterioration. Recent industrialization, global mobility, and increasing population have adversely affected the freshwater resources. The wastewater sources are categorized as domestic, agricultural and industrial effluents and their disposal into water bodies poses a harmful impact on human and animal health due to the presence of higher amounts of nitrogen, phosphorus, sulfur, heavy metals and other organic/inorganic pollutants. Several conventional treatment methods have been employed, but none of those can be termed as a universal method due to their high cost, less efficiency, and non-environment friendly nature. Alternatively, wastewater treatment using microalgae (phycoremediation) offers several advantages over chemical-based treatment methods. Microalgae cultivation using wastewater offers the highest atmospheric carbon fixation rate (1.83 kg CO₂/kg of biomass) and fastest biomass productivity (40-50% higher than terrestrial crops) among all terrestrial bio-remediators with concomitant pollutant removal (80-100%). Moreover, the algal biomass may contain high-value metabolites including omega-3-fatty acids, pigments, amino acids, and high sugar content. Hence, after extraction of high-value compounds, residual biomass can be either directly converted to energy through thermochemical transformation or can be used to produce biofuels through biological fermentation or transesterification. This review highlights the recent advances in microalgal biotechnology to establish a biorefinery approach to treat wastewater. The articulation of wastewater treatment facilities with microalgal biorefinery, the use of microalgal consortia, the possible merits, and demerits of phycoremediation are also discussed. The impact of wastewater-derived nutrient stress and its exploitation to modify the algal metabolite content in view of future concerns of cost-benefit ratios of algal biorefineries is also highlighted.

Comparison of monoculture and mixed culture (Scenedesmus obliquus and wild algae) for C, N, and P removal and lipid production

This study compared the efficiency of nutrient removal and lipid accumulation by a monoculture of Scenedesmus obliquus and mixed cultures of microalgae. The highest removal efficiencies of ammonium (99.2%), phosphate (91.2%), and total organic carbon (83.6%) occurred in the monoculture. All the mixed cultures were dominated by S. quadricauda; in some mixed cultures, the proportions of Chlamydomonas reinhardtii and C. microsphaera reached > 20%. The lipid content and lipid production in the monoculture were 15.9% and 52.3 mg kg^-1, respectively, significantly higher than those in all the mixed cultures of microalgae. In all the mixed cultures, the proportion of palmitic acid was > 50%. The results suggest that the monoculture had advantages over the mixed culture of microalgae in terms of nutrient removal and lipid production.

Biochemical response of indigenous microalgal consortia to variations in nitrogen concentration of treated effluent

Cultivation conditions influence microalgal cellular components, such as lipid accumulation under nutrient depletion, high light irradiation and salinity stress. In this study, indigenous microalgal consortia were cultivated in batch mode using an actual treated effluent. The temporal response of cellular components to the variations in nitrogen concentration and influence of light irradiation on the response were investigated. Prolonged exposure of indigenous microalgal consortia to nitrogen exhaustion had minor effects on total lipid accumulation and enhancement of energy content. Nitrogen replenishment was followed by immediate crude protein accumulation for growth recovery. Total lipid reduction was observed under light and dark conditions after nitrogen replenishment. A one-day lag after nitrogen replenishment in the total lipid reduction was revealed under nitrogen depletion; meanwhile, under nitrogen exhaustion, lipids were utilised as the primary carbon and/or energy source after replenishment, as represented by the decrease from 10.8% to 9.04% within 6 h after the replenishment.

Chlorella zofingiensis as a promising strain in wastewater treatment

This study was conducted to evaluate the efficiency of treatment by C. zofingiensis, C. vulgaris and Scenedesmus sp. in terms of nutrient loading, lipid productivity and the activity of photosystem II. Results from nutrient loading suggested that the nitrogen loading of C. zofingiensis at 0.406 mg/L/h was higher than C. vulgaris and Scenedesmus sp., and the phosphorus loading of C. zofingiensis at 0.075 mg/L/h was higher than C. vulgaris. During the treating process, C. zofingiensis accumulated lipid with higher productivity of 26.57 mg/L/d than C. vulgaris and Scenedesmus sp. In combination with photosynthetic efficiency, C. zofingiensis possessed superior trophic transfer efficiency and absorption capability, even in worse environmental conditions. C. zofingiensis, therefore, exhibited the promising application prospect in wastewater treatment.

Enhanced nitrogen removal and energy saving in a microalgal-bacterial consortium treating real municipal wastewater

The optimization of total nitrogen removal from municipal wastewater was investigated in a laboratory-scale photo-sequencing batch reactor (PSBR) operated with a mixed microalgal-bacterial consortium spontaneously acclimatized to real wastewater. No external aeration was provided in the PSBR to reduce energy consumption: oxygen was only supplied by the microalgal photosynthesis. The enhancement of total nitrogen removal was achieved through: (1) feeding of wastewater in the dark phase to provide readily biodegradable COD when oxygen was not produced, promoting denitrification; (2) intermittent use of the mixer to favor simultaneous nitrification-denitrification inside the dense flocs and to achieve 41% energy saving with respect to continuous mixing. Efficient COD removal (86 ± 2%) was observed, obtaining average effluent concentrations of 37 mg/L and 22 mg/L of total COD and soluble COD, respectively. TKN removal was 97 ± 3%, with an average effluent concentration of 0.5 ± 0.7 mg NH₄ ⁺-N/L. Assimilation of nitrogen by heterotrophic bacteria accounted only for 20% of TKN removal, whilst the major part of TKN was nitrified. In particular, the nitrification rate was 1.9 mgN L^-1 h^-1 (specific rate 2.4 mgN gTSS^-1 h^-1), measured with dissolved oxygen near zero, when the oxygen demand was higher than the oxygen produced by photosynthesis. Total nitrogen of 6.3 ± 4.4 mgN/L was measured in the effluent after PSBR optimization.

Effect of lipid-free microalgal biomass and waste glycerol on growth and lipid production of Scenedesmus obliquus: Innovative waste recycling for extraordinary lipid production

In the present work, a novel approach of using growth medium with different substitutions of lipid-free algal hydrolysate (LFAH, 0, 5, 10 and 15%) and/or waste glycerol (WG, 0, 5, 10 and 20 g L^-1) for enhanced biodiesel production from Scenedesmus obliquus was studied. Combination of different concentrations of WG with 15% LFAH showed the maximum significant biomass productivity, which represented 27.4, 30.5 and 28.9% over the control at combined 5, 10 and 20 g L^-1 WG, respectively. The combinations of different LFAH with 20 g L^-1 WG showed the maximum significant lipid accumulation, where lipid productivity showed its maximum significant value of 59.66 mg L^-1 d^-1 using LFAH15-WG10. In addition, LFAH15-WG10 significantly enhanced total FAMEs yield by 21.2% over the control. Moreover, it reduced polyunsaturated fatty acids (PUFAs) ratio from 52.1% to 47.8% of total FAMEs, and increased monounsaturated fatty acids (MUFAs) ratio from 26.6% to 31.3% of total FAMEs.

Growth improvement and metabolic profiling of native and commercial Chlorella sorokiniana strains acclimatized in recycled agricultural wastewater

This study investigated acclimation ability of native Chlorella sorokiniana (CS-N) and commercial Chlorella sorokiniana (CS-C) in palm oil mill effluent (POME), their metabolic profile and feasibility of effluent recycling for dilution purpose. Maximum specific growth rate, µ_max and lag time, λ of the microalgae were evaluated. Result shows both strains produced comparable growth in POME, with µ_max of 0.31 day^-1 and 0.30 day^-1 respectively, albeit longer λ by the CS-C. However, three cycles of acclimation was able to reduce λ from eight days to two days for CS-C. Metabolic profiling using principal component analysis (PCA) shows clear cluster of acclimatized strains to suggest better stress tolerance of CS-N. Finally, a remarkable µ_max of 0.57 day^-1 without lag phase was achieved using acclimatized CS-N in 40% POME concentration. Acclimation has successfully shortened the λ and dilution with final effluent was proved to be feasible for further improvement of the microalgae growth.

Environmental drivers that influence microalgal species in fullscale wastewater treatment high rate algal ponds

In the last decade, studies have focused on identifying the most suitable microalgal species for coupled high rate algal pond (HRAP) wastewater treatment and resource recovery. However, one of the challenges facing outdoor HRAP systems is maintaining microalgal species dominance. By increasing our understanding of the environmental drivers of microalgal community composition within the HRAP environment, it may be possible to manipulate the system in such a way to favour the growth of desirable species. In this paper, we investigate the microalgal community composition in two full-scale HRAPs over a 23-month period. We compare wastewater treatment performance between dominant species and identify the environmental drivers that trigger change in community composition. A total of 33 microalgal species were identified over the 23-month period but species richness (the number of species present at any given time) was low and was not related to either productivity or nutrient removal efficiency. Species turnover of the dominant microalgae happened rapidly, typically <1 week. Changes in the influent NH₄-N concentration and zooplankton grazer numbers were significantly associated with species turnover, accounting for 80% of the changes in dominant species throughout the 23-month study period. Both nutrient removal and biomass production did not differ between the two HRAPs when the dominant species was the same or differed in the two ponds. These results suggest that microalgal functional groups are more important than individual species for full-scale HRAP performance. This study has increased our understanding of some of the environmental drivers of the microalgae within the HRAP environment, which may assist with improving wastewater treatment and resource recovery.

Lipid for biodiesel production from attached growth Chlorella vulgaris biomass cultivating in fluidized bed bioreactor packed with polyurethane foam material

The potential to grow attached microalgae Chlorella vulgaris in fluidized bed bioreactor was materialized in this study, targeting to ease the harvesting process prior to biodiesel production. The proposed thermodynamic mechanism and physical property assessment of various support materials verified polyurethane to be suitable material favouring the spontaneous adhesion by microalgae cells. The 1-L bioreactor packed with only 2.4% (v/v) of 1.00-mL polyurethane foam cubes could achieve the highest attached growth microalgae biomass and lipid weights of 812±122 and 376±37mg, respectively, in comparison with other cube sizes. The maturity of attached growth microalgae biomass for harvesting could also be determined from the growth trend of suspended microalgae biomass. Analysis of FAME composition revealed that the harvested microalgae biomass was dominated by C16-C18 (>60%) and mixture of saturated and mono-unsaturated fatty acids (>65%), satiating the biodiesel standard with adequate cold flow property and oxidative stability.

Comparative life cycle assessment study on environmental impact of oil production from micro-algae and terrestrial oilseed crops

In this study the LCA methodology is applied in order to satisfy two goals: i) to evaluate the hot spots in site-specific production chain of biodiesel from terrestrial and micro-algae feedstock; ii) to compare quantitatively, utilizing primary data, the impacts of the first generation in respect to the third generation bio-fuels. Results show that micro-algae are neither competitive yet with traditional oil crops nor with fossil fuel. The use of renewable technologies as photovoltaics and biogas self production might increase the competitiveness of micro-algae oil. Further investigations are however necessary to optimize their production chain and to increase the added value of co-products.

Valorization of Spent Escherichia coli Media Using Green Microalgae Chlamydomonas reinhardtii and Feedstock Production

The coupling of Chlamydomonas reinhardtii biomass production for nutrients removal of Escherichia coli anaerobic broth (EAB) is thought to be an economically feasible option for the cultivation of microalgae. The feasibility of growing microalgae in using EAB high in nutrients for the production of more biomass was examined. EAB comprised of nutrient-abundant effluents, which can be used to produce microalgae biomass and remove environment pollutant simultaneously. In this study, C. reinhardtii 21gr (cc1690) was cultivated in different diluted E. coli anaerobic broth supplemented with trace elements under mixotrophic and heterotrophic conditions. The results showed that C. reinhardtii grown in 1×, 1/2×, 1/5× and 1/10×E. coli anaerobic broth under mixotrophic conditions exhibited specific growth rates of 2.71, 2.68, 1.45, and 1.13 day^-1, and biomass production of 201.9, 184.2, 175.5, and 163.8 mg L^-1, respectively. Under heterotrophic conditions, the specific growth rates were 1.80, 1.86, 1.75, and 1.02 day^-1, and biomass production were 45.6, 29.4, 15.8, and 12.1 mg L^-1, respectively. The removal efficiency of chemical oxygen demand, total-nitrogen and total-phosphorus from 1×E. coli anaerobic broth was 21.51, 22.41, and 15.53%. Moreover, the dry biomass had relatively high carbohydrate (44.3%) and lipid content (18.7%). Therefore, this study provides an environmentally sustainable as well economical method for biomass production in promising model microalgae and subsequently paves the way for industrial use.

Cell growth and lipid accumulation of a microalgal mutant Scenedesmus sp. Z-4 by combining light/dark cycle with temperature variation

BACKGROUND

The light/dark cycle is one of the most important factors affecting the microalgal growth and lipid accumulation. Biomass concentration and lipid productivity could be enhanced by optimization of light/dark cycles, and this is considered an effective control strategy for microalgal cultivation. Currently, most research on effects of light/dark cycles on algae is carried out under autotrophic conditions and little information is about the effects under mixotrophic cultivation. At the same time, many studies related to mixotrophic cultivation of microalgal strains, even at large scale, have been performed to obtain satisfactory biomass and lipid production. Therefore, it is necessary to investigate cellular metabolism under autotrophic and mixotrophic conditions at different light/dark cycles. Even though microalgal lipid production under optimal environmental factors has been reported by some researchers, the light/dark cycle and temperature are regarded as separate parameters in their studies. In practical cases, light/dark cycling and temperature variation during the day occur simultaneously. Therefore, studies about the combined effects of light/dark cycles and temperature variation on microalgal lipid production are of practical value, potentially providing significant guidelines for large-scale microalgal cultivation under natural conditions.

RESULTS

In this work, cell growth and lipid accumulation of an oleaginous microalgal mutant, Scenedesmus sp. Z-4, were investigated at five light/dark cycles (0 h/24 h, 8 h/16 h, 12 h/12 h, 16 h/8 h, and 24 h/0 h) in batch culture. The results showed that the optimal light/dark cycle was 12 h/12 h, when maximum lipid productivity rates of 56.8 and 182.6 mg L^-1 day^-1 were obtained under autotrophic and mixotrophic cultivation, respectively. Poor microalgal growth and lipid accumulation appeared in the light/dark cycles of 0 h/24 h and 24 h/0 h under autotrophic condition. Prolonging the light duration was unfavorable to the production of chlorophyll a and b, which was mainly due to photooxidation effect. Polysaccharide was converted into lipid and protein when the light irradiation time increased from 0 to 12 h; however, further increasing irradiation time had a negative effect on lipid accumulation. Due to the dependence of autotrophically cultured cells on light energy, the light/dark cycle has a more remarkable influence on cellular metabolism under autotrophic conditions. Furthermore, the combined effects of temperature variation and light/dark cycle of 12 h/12 h on cell growth and lipid accumulation of microalgal mutant Z-4 were investigated under mixotrophic cultivation, and the results showed that biomass was mainly produced at higher temperatures during the day, and a portion of biomass was converted into lipid under dark condition.

CONCLUSIONS

The extension of irradiation time was beneficial to biomass accumulation, but not in favor of lipid production. Even though effects of light/dark cycles on autotrophic and mixotrophic cells were not exactly the same, the optimal lipid productivities of Scenedesmus sp. Z-4 under both cultivation conditions were achieved at the light/dark of 12 h/12 h. This may be attributed to its long-term acclimation in natural environment. By combining temperature variation with optimal light/dark cycle of 12 h/12 h, this study will be of great significance for practical microalgae-biodiesel production in the outdoor conditions.