Comparative effects of GAC addition on methane productivity and microbial community in mesophilic and thermophilic anaerobic digestion of food waste

Microbial activity of the inoculum determines the impact of activated carbon, magnetite and zeolite on methane production

The conversion of organic matter to methane through anaerobic digestion (AD) process can be enhanced by different materials. However, literature reports show inconsistent results on the effect of materials in different AD systems. In this study, we evaluated the influence of the inoculum's activity on methane production (MP) efficiency in the presence of different materials (activated carbon (AC), magnetite (Mag), and zeolite (Zeo)). The inocula included pure cultures of methanogens, syntrophic cocultures, and complex microbial communities, and the kinetic parameters assessed were the lag phase duration and methane production rates (MPR). The results showed that the microbial activity of the inocula is an important factor determining materials' effect on MP kinetics. AC, Mag, and Zeo significantly enhanced the MP profiles of less active microbial communities or low-active microorganisms by decreasing lag phases duration up to 85 %, consequently increasing MPR up to 15 times. Contrarily, these materials did not affect highly active microbial communities or pure cultures, as MP profiles tend to be similar with and without materials. These results indicate that from an applied point of view, the addition of materials to anaerobic bioreactors should be considered only when the methanogenic activity of the sludge is low or compromised.

Mechanisms of horizontal gene transfer and viral contribution to the fate of intracellular and extracellular antibiotic resistance genes in anaerobic digestion supplemented with conductive materials under ammonia stress

The addition of conductive materials (CMs) is an effective strategy for mitigating ammonia inhibition during anaerobic digestion (AD). However, the introduction of CMs can result in increased antibiotic resistance genes (ARGs) pollution, potentially facilitated by enhanced horizontal gene transfer (HGT). The complex dynamics of intracellular and extracellular ARGs (iARGs/eARGs) and the mechanisms underlying their transfer, mediated by CMs, in ammonia-stressed AD systems remain unclear. In this study, we investigated the effects of three commonly used CMs-nano magnetite (Mag), nano zero-valent iron (nZVI), and granular activated carbon (GAC)-on the fate of iARGs and eARGs during the AD of waste activated sludge under ammonia stress. The results revealed an unexpected enrichment of iARGs by 1.5 %-10.9 % and a reduction of eARGs by 14.1 %-25.2 % in CM-supplemented AD. This discrepancy in the dynamics of iARGs and eARGs may be attributed to changes in microbial hosts and the horizontal transfer of ARGs. Notably, CMs activated prophages within antibiotic-resistant bacteria (ARB) and their symbiotic partners involved in vitamin B12 provision, leading to the lysis of ARB and the subsequent release of eARGs for transformation. Additionally, the abundance of potentially mobile ARGs, which co-occurred with mobile genetic elements, increased by 56.6 %-134.5 % with CM addition, highlighting an enhanced potential for the HGT of ARGs. Specifically, Mag appeared to promote both transformation and conjugation processes, while nZVI only promoted conjugation. Moreover, none of the three CMs had any discernible impact on transduction. GAC proved superior to both nano Mag and nZVI in controlling the enrichment of iARGs, reducing eARGs, and limiting HGTs simultaneously. Overall, these findings provide novel insights into the role of viruses and the mechanisms of ARG spread in CM-assisted AD, offering valuable information for developing strategies to mitigate ARG pollution in practical applications.

Discovery of a Microbial Carrier with High Adsorption Affinity for Syntrophic Long-Chain Fatty Acid-Degrading Microorganisms

Long-chain fatty acid (LCFA) degradation primarily involves several species of Syntrophomonas and hydrogenotrophic methanogens, constituting the rate-limiting step in anaerobic digestion. It is crucial to augment their abundance to enhance LCFA degradation. Utilizing microbial carriers presents an effective strategy to maintain the microorganisms on the surface and prevent their washout from the digester. In this study, we aimed to identify a suitable microbial carrier with a superior adsorption capacity for LCFA-degrading microorganisms. We tested various polymers, poly(vinyl alcohol) (PVA), polypropylene (PP), polyethylene glycol (PEG), and polyvinylidene chloride (PVDC), adding them to the sludge at the concentration of 28.25 g L-1 and incubating with olive oil. The amplicon sequencing analysis revealed that PVDC retained Syntrophomonas more abundantly than the other polymers. Remarkably, PVDC predominantly adsorbed LCFA-degrading S. sapovorans and S. zehnderi, whereas medium- to short-chain fatty acid-degrading S. wolfei was abundant in the sludge. Moreover, hydrogenotrophic Methanospirillum hungatei was detected at 2.3-9.5 times higher abundance on PVDC compared to the sludge. Further analysis indicated that not only these LCFA-degrading syntrophic microbial communities but also Propionispira and Anaerosinus, which are capable of lipid hydrolysis and glycerol degradation, became dominant on PVDC. Actually, chemical analysis confirmed that adding PVDC promoted the olive oil degradation. These results underscore the potential of PVDC in promoting anaerobic LCFA degradation.

Adding Granular Activated Carbon and Zerovalent Iron to the High-Solid Anaerobic Digestion System of the Organic Fraction of Municipal Solid Waste: Anaerobic Digestion Performance and Microbial Community Analysis

Anaerobic digestion (AD) performance and microbial dynamics were investigated in a high-solid anaerobic digestion (HSAD) system of the organic fraction of municipal solid waste (OFMSW). 1, 5, 10, and 15% (w/w, dry weight of the OFMSW) of granular activated carbon (GAC) and zerovalent iron (ZVI) were added to the HSAD system. The results showed that adding ZVI and GAC can improve the methane yield of the OFMSW. Notably, R-(GAC + ZVI) exhibited the highest cumulative methane yield of 343.0 mL/gVS, which was 57.1% higher than that of the R-control. At the genus level, the dominant bacteria included norank_f__norank_o__MBA03, norank_f__norank_o__norank_c__norank_p__Firmicutes, Fastidiosipila, norank_f__Rikenellaceae, and Sphaerochaeta, while Methanoculleus, Methanobacterium, and Methanosarcina were the dominant archaea. The highest relative abundance of norank_f__norank_o__norank_c__norank_p__Firmicutes was 30.8% for the R-(GAC + ZVI), which was 71.4% higher than that of the R-control. The relative abundance of Methanoculleus and Methanobacterium for the R-(GAC + ZVI) and the R-control group accounted for 79.0 and 90.8% of the total archaeal abundance, respectively. Additionally, the relative abundance of Methanosarcina was 10.6% for R-(GAC + ZVI), which was higher than that of the R-control (1.1%). After the addition of GAC and ZVI, the electron transfer capacity of the HSAD system was enhanced, resulting in promoted methane production. Thus, the simultaneous addition of GAC and ZVI to the HSAD system can be an effective strategy to promote the cumulative methane yield of the OFMSW.

Co-enhancing effects of zero valent iron and magnetite on anaerobic methanogenesis of food waste at transition temperature (45 °C) and various organic loading rates

Deoiling of food waste (FW) after hydrothermal pretreatment occurs at high temperatures, and more energy is required for substrate cooling before the anaerobic digestion (AD) process. AD at the transition temperature (for example 45 °C) is good for energy saving and carbon emission reducing when treating deoiling FW. However, the metabolic activity of methanogens must increase at the transition temperatures. This study proposes the use of zero-valent iron (Fe0) and magnetite (Fe3O4) to boost CH4 yield from deoiling FW. The results showed a co-enhancing effect on CH4 yield upgradation when using Fe0 and Fe3O4 simultaneously, and the highest CH4 yield reached 536.23 mLCH4/gVS, which was 67.5 % higher than that of Fe0 alone (320.14 mLCH4/gVS). In addition, a high organic loading was favorable for increasing the CH4 yield from deoiling FW. Microbial diversity analysis suggested that the dominant methanogenic pathway at 45 °C was hydrogenotrophic methanogenesis. Herein, a potential metabolic pathway analysis revealed that the co-enhancing effects of Fe0 and Fe3O4 enhanced syntrophic methanogenesis and possibly boosted electron transfer efficiency.

Boosting thermophilic anaerobic digestion with conductive materials: Current outlook and future prospects

Thermophilic anaerobic digestion (TAD) can provide superior process kinetics, higher methane yields, and more pathogen destruction than mesophilic anaerobic digestion (MAD). However, the broader application of TAD is still very limited, mainly due to process instabilities such as the accumulation of volatile fatty acids and ammonia inhibition in the digesters. An emerging technique to overcome the process disturbances in TAD and enhance the methane production rate is to add conductive materials (CMs) to the digester. Recent studies have revealed that CMs can promote direct interspecies electron transfer (DIET) among the microbial community, increasing the TAD performance. CMs exhibited a high potential for alleviating the accumulation of volatile fatty acids and inhibition caused by high ammonia levels. However, the types, properties, sources, and dosage of CMs can influence the process outcomes significantly, along with other process parameters such as the organic loading rates and the type of feedstocks. Therefore, it is imperative to critically review the recent research to understand the impacts of using different CMs in TAD. This review paper discusses the types and properties of CMs applied in TAD and the mechanisms of how they influence methanogenesis, digester start-up time, process disturbances, microbial community, and biogas desulfurization. The engineering challenges for industrial-scale applications and environmental risks were also discussed. Finally, critical research gaps have been identified to provide a framework for future research.

Effects of different types of granular activated carbon on methanogenesis of carbohydrate-rich food waste: Performance, microbial communities and optimization

Granular activated carbon (GAC) supplementation is an efficient method for enhancing methane production during the anaerobic digestion of food waste, but it remains unclear which type of GAC is optimal and what potential mechanisms are involved with different types of GAC, particularly for the methanogenic system of carbohydrate-rich food waste. This study selected three commercial GAC (GAC#1, GAC#2, GAC#3) with very distinct physical and chemical properties, and investigated their impacts on the methanogenesis of carbohydrate-rich food waste with an inoculation/substrate ratio of 1. Results indicated that Fe-doped GAC#3 had a lower specific surface area but higher conductivity, yet exhibited superior performance in facilitating methanogenesis compared with GAC#1 and GAC#2, which possessed larger specific surface areas. The addition of 10 g/L GAC#3 enhanced the methane yield by 10-folds through regulating pH levels, alleviating volatile fatty acids-induced stress, enhancing key enzymatic activity, as well as enriching direct interspecies electron transfer-mediated syntrophic partner of Syntrophomonas with Methanosarcina. Furthermore, GAC#1, which had the largest specific surface area but exhibited the poorest performance, was chemically modified to enhance its ability in promoting methanogenesis. The resulting material, named MGAC#1 (Fe3O4-loaded GAC#1), exhibited superior electro-conductivity and high methane production efficiency. The methane yield of 588 mL/g-VS showed a remarkable increase of 468 % compared with GAC#1, and a modest increase of 13 % compared with GAC#3, surpassing most values reported in literature. These findings suggested that the Fe3O4-loaded GAC with lager specific surface area, was the optimal choice for the methanogenesis of sole readily acidogenic waste, providing valuable insights for the preparation of superior-quality GAC for application in biogas industry.

Direct interspecies electron transfer mechanisms of a biochar-amended anaerobic digestion: a review

This paper explores the mechanisms of biochar that facilitate direct interspecies electron transfer (DIET) among syntrophic microorganisms leading to improved anaerobic digestion. Properties such as specific surface area (SSA), cation exchange capacity (CEC), presence of functional groups (FG), and electrical conductivity (EC) were found favorable for increased methane production, reduction of lag phase, and adsorption of inhibitors. It is revealed that these properties can be modified and are greatly affected by the synthesizing temperature, biomass types, and residence time. Additionally, suitable biochar concentration has to be observed since dosage beyond the optimal range can create inhibitions. High organic loading rate (OLR), pH shocks, quick accumulation and relatively low degradation of VFAs, and the presence of heavy metals and toxins are the major inhibitors identified. Summaries of microbial community analysis show fermentative bacteria and methanogens that are known to participate in DIET. These are Methanosaeta, Methanobacterium, Methanospirillum, and Methanosarcina for the archaeal community; whereas, Firmicutes, Proteobacteria, Synergistetes, Spirochetes, and Bacteroidetes are relatively for bacterial analyses. However, the number of defined cocultures promoting DIET is very limited, and there is still a large percentage of unknown bacteria that are believed to support DIET. Moreover, the instantaneous growth of participating microorganisms has to be validated throughout the process.

Production of short-chain fatty acids (SCFAs) as chemicals or substrates for microbes to obtain biochemicals

Carboxylic acids have become interesting platform molecules in the last years due to their versatility to act as carbon sources for different microorganisms or as precursors for the chemical industry. Among carboxylic acids, short-chain fatty acids (SCFAs) such as acetic, propionic, butyric, valeric, and caproic acids can be biotechnologically produced in an anaerobic fermentation process from lignocellulose or other organic wastes of agricultural, industrial, or municipal origin. The biosynthesis of SCFAs is advantageous compared to chemical synthesis, since the latter relies on fossil-derived raw materials, expensive and toxic catalysts and harsh process conditions. This review article gives an overview on biosynthesis of SCFAs from complex waste products. Different applications of SCFAs are explored and how these acids can be considered as a source of bioproducts, aiming at the development of a circular economy. The use of SCFAs as platform molecules requires adequate concentration and separation processes that are also addressed in this review. Various microorganisms such as bacteria or oleaginous yeasts can efficiently use SCFA mixtures derived from anaerobic fermentation, an attribute that can be exploited in microbial electrolytic cells or to produce biopolymers such as microbial oils or polyhydroxyalkanoates. Promising technologies for the microbial conversion of SCFAs into bioproducts are outlined with recent examples, highlighting SCFAs as interesting platform molecules for the development of future bioeconomy.

Granular activated carbon stimulates biogas production in pilot-scale anaerobic digester treating agro-industrial wastewater

This work examines the continuous addition (5 g/L) of conductive granular activated carbon (GAC) in an integrated pilot-scale unit containing an anaerobic digester (180 L) and an aerobic submerged membrane bioreactor (1600 L) connected in series for the treatment of agro-industrial wastewater. Biogas production increased by 32 % after the addition of GAC. Methanosaeta was the dominant methanogen in the digester, and its relative abundance increased after the addition of GAC. The final effluent after post-treatment with the aerobic membrane bioreactor had a total solids content <0.01 g/L and a chemical oxygen demand between 120 and 150 mg/L. A simple cost analysis showed that GAC addition is potentially profitable, but alternatives ways of retaining the GAC in the system need to be found. Overall, this study provides useful scientific data for the possible application of GAC in full-scale biogas projects.

Mechanisms, performance, and the impact on microbial structure of direct interspecies electron transfer for enhancing anaerobic digestion-A review

Direct interspecies electron transfer (DIET) has been received tremendous attention, recently, due to the advantages of accelerating methane production via organics reduction during anaerobic digestion (AD) process. DIET-based syntrophic relationships not only occurred with the existence of pili and some proteins in the microorganism, but also can be conducted by conductive materials. Therefore, more researches into understanding and strengthening DIET-based syntrophy have been conducted with the aim of improving methanogenesis kinetics and further enhance methane productivity in AD systems. This study summarized the mechanisms, application and microbial structures of typical conductive materials (carbon-based materials and iron-based materials) during AD reactors operation. Meanwhile, detail analysis of studies on DIET (from substrates, dosage and effectiveness) via conductive materials was also presented in the study. Moreover, the challenges of applying conductive materials in boosting methane production were also proposed, which was supposed to provide a deep insight in DIET for full scale application.

Fate of intracellular, extracellular polymeric substances-associated, and cell-free antibiotic resistance genes in anaerobic digestion of thermally hydrolyzed sludge

Thermal hydrolysis of sludge is a promising approach to mitigate antibiotic resistance genes (ARGs) propagation in anaerobic digestion (AD). Although ARGs in sludge may be fractioned into intracellular, extracellular polymeric substance (EPS)-associated, and cell-free ARGs, the fate of these different fractions in AD has never been investigated. This study presents a detailed characterization of intracellular and extracellular ARGs in AD of sludge thermally hydrolyzed at 90 °C and 140 °C. EPS-associated ARGs represented the major fraction of the total extracellular ARGs in all samples, while its lowest abundance was observed for thermal hydrolysis at 140 °C along with the lowest EPS levels. The results suggested a positive correlation between EPS-associated ARGs with intracellular and cell-free ARGs. Furthermore, various EPS components, such as proteins and e-DNA, were positively correlated with β-lactam resistance genes. sul1 dominated all samples as an EPS-associated resistance gene. These results provide new insights into the significance of different ARGs fractions in their overall dissemination in AD integrated with thermal hydrolysis.

Carbon cloth amendment for boosting high-solids anaerobic digestion with percolate recirculation: Spatial patterns of microbial communities

The addition of conductive materials in anaerobic digestion (AD) is a promising method for boosting biomethane recovery from organic waste. However, conductive additives have rarely been investigated for the high-solids anaerobic digestion (HSAD). Here, the impact of adding carbon cloth in the solid phase of an HSAD system with percolate recirculation was investigated. Furthermore, spatial patterns of microbial communities in suspended biomass, percolate, and carbon cloth attached biofilm were assessed. Carbon cloth increased biomethane yield from source-separated organics (SSO) by 20% more than the unamended control by shortening the lag phase (by 15%) and marginally improving the methanogenesis rate constant (by ∼8%) under a batch operation for 50 days. Microbial community analysis demonstrated higher relative abundances of the archaeal population in the carbon cloth amended reactor than in unamended control (12%-21% vs. 5%-15%). Compared to percolate and suspension, carbon cloth attached microbial community showed higher enrichment of known electroactive Pseudomonas species along with Methanosarcina and Methanobacterium species, indicating the possibility of DIET-based syntrophy among these species.

The Effect of Operating Strategies on the Anaerobic Digestion of Gentamicin Mycelial Residues: Insights into the Enhancement of Methane Production and Attenuation of Gentamicin Resistance

Anaerobic digestion (AD) has been widely employed for converting various biowastes into renewable energy. However, AD of gentamicin mycelial residues (GMRs, a byproduct of gentamicin production) is limited by ammonia inhibition and antimicrobial resistance risk. Compared to mesophilic AD (MMAD) of GMRs, this study looked into three semicontinuous AD processes, i.e., codigestion with wheat straw, thermophilic digestion (TAcoD), and AD at shortened retention time (RT). Results showed that a stable and safe AD could be achieved under suitable operating conditions. Co-digestion could effectively mitigate the adverse effect of ammonia inhibition. The methane production increased by 35.86% in TAcoD compared to that in MMAD and 43.99% of hazardous waste was reduced in TAcoD. Concerning the antimicrobial resistance of AD system, gentamicin was degraded efficiently and the degradation process was not involved in the expression of antibiotic resistance genes (ARGs) related to modifying enzyme. Effective removal of ARGs under three operating strategies was associated with a higher reduction in bacterial abundance of potential hosts. In addition, the changes in the relevant proteins for transformation and conjugation as predicted by PICRUSt suggested that thermophilic condition and shorter RT were conducive to the reduction of the dissemination risks of ARGs.

Potential of biogas residue biochar modified by ferric chloride for the enhancement of anaerobic digestion of food waste

Biogas residue biochar (BRB) and BRB modified by ferric chloride (BRB-FeCl₃) were applied to promote anaerobic digestion (AD) of food waste (FW), related mechanisms were also proposed in this study. Results indicated BRB-FeCl₃ showed higher specific surface area, more abundant functional groups and impregnate iron than BRB, and they respectively increased 22.50% and 12.79% cumulative methane yields compared with control group because of accelerated volatile fatty acids (VFAs) transformation, which were confirmed by enhanced metabolism of glycolysis, fatty acid degradation and pyruvate. BRB, especially BRB-FeCl₃ facilitated the growth of Syntrophomonas, Methanofollis, Methanoculleus and Methanosarcina, which further promoted the methanogenesis by enhancing the metabolic activities of methanol, dimethylamine and methylamine pathways, thereby causing more metabolically diverse methanogenic pathways. Metagenomics analysis revealed BRB, especially BRB-FeCl₃ promoted the relative abundances of functional genes involved in direct interspecies electron transfer (DIET). Present study explored the enhancement mechanisms and feasibility of BRB-FeCl₃ for AD process.

Insights into the role of biochar on the acidogenic process and microbial pathways in a granular sulfate-reducing up-flow sludge bed reactor

In this study, the effect of biochar on sulfate reduction and anaerobic acidogenic process was explored in a granular sulfate-reducing up-flow sludge bed reactor in both long-term operation and batch tests. Both bioreactors had a high sulfate reduction efficiency of over 95% during the long-term operation, while the reactor with biochar addition showed higher sulfate reduction efficiency and stronger robustness against volatile fatty acids accumulation with a higher organic loading and sulfate loading rate. Batch tests showed that adding biochar significantly lessened the lag phase of the sulfate-reducing process, accelerated the adaption of acidogens, and facilitated both production and utilization of volatile fatty acids. The microbial pathways proved that biochar could regulate the acidification fermentation pathway and facilitate the enrichment of assimilative desulfurization bacteria. Overall, this study revealed that the acidogenic sulfate-reducing metabolic pathway could be enhanced by biochar, offering a potential application for effective sulfate-laden wastewater treatment.

Improved methanogenesis in anaerobic wastewater treatment by magnetite@polyaniline (Fe3O4@PANI) composites

The magnetite@polyaniline (Fe₃O₄@PANI) composites with different Fe₃O₄ loadings were prepared, and their effect on methane production in anaerobic systems was investigated. The Fe₃O₄@PANI composite with a 40% loading of Fe₃O₄ showed a better performance on accelerating methane production rate than other composites. The methane production rate was increased by 26.98% at the Fe₃O₄@PANI dosage of 0.6 g L^-1. The results of the contact angle and CLSM revealed that Fe₃O₄@PANI had a good bio-affinity and contact directly with bacteria and archaea. Then the mechanisms related to the enhancement of methane production by the composites were explored by the species annotation and enzyme activity. It showed that Fe₃O₄@PANI promoted the enrichment of DIET-related functional bacteria and archaea and improved the enzyme activity related to the acetoclastic methanogenic pathway.

Insights into high-solids anaerobic digestion of food waste enhanced by activated carbon via promoting direct interspecies electron transfer

High-solids anaerobic digestion (HS-AD) of food waste frequently confronted the acidification and failure under high organic loading rates (OLRs). Results indicated powdered activated carbon (PAC) addition significantly enhanced methane production and process stability than granular activated carbon, and columnar activated carbon at higher OLRs via accelerating the propionate consumption. Potential direct interspecies electron transfer (DIET) partners, including various syntrophic oxidation bacteria and methanogens, were enriched with the activated carbon (AC) addition. Furthermore, DIET contribution to methane production was 35% by PAC, predicated by the modified Anaerobic Digestion Model No.1 (ADM1). This study deeply elucidated the DIET mechanism and offered the potential foundations for the selection and applications of AC-based materials in HS-AD of food waste.

Propagation of antibiotic resistance genes during anaerobic digestion of thermally hydrolyzed sludge and their correlation with extracellular polymeric substances

The positive impact of the thermal hydrolysis process (THP) of sewage sludge on antibiotic resistance genes (ARGs) removal during anaerobic digestion (AD) has been reported in the literature. However, little information is available on how changes in different extracellular polymeric substances (EPS) due to THP can influence ARG propagation during AD. This study focused on systematically correlating EPS components and ARG abundance in AD of sewage sludge pretreated with THP (80 °C, 110 °C, 140 °C, 170 °C). THP under different conditions improved sludge solubilization followed by improved methane yields in the biochemical methane potential (BMP) test. The highest methane yield of 275 ± 11.5 ml CH₄/g COD was observed for THP-140 °C, which was 40.5 ± 2.5% higher than the control. Increasing THP operating temperatures showed a non-linear response of ARG propagation in AD due to the rebound effect. The highest ARGs removal in AD was achieved with THP at 140 °C. The multivariate analysis showed that EPS polysaccharides positively correlated with most ARGs and integrons, except for macrolides resistance genes. In contrast, EPS protein was only strongly correlated with β-lactam resistance genes. These results suggest that manipulating THP operating conditions targeting specific EPS components will be critical to effectively mitigating the dissemination of particular ARG types in AD.

Abrogating the inhibitory effects of volatile fatty acids and ammonia in overloaded food waste anaerobic digesters via the supplementation of nano-zero valent iron modified biochar

The effects of different recovery strategies on inhibited anaerobic digestion (AD) of food waste (FW) was examined in this study, with the finding that dosing pine woodchip biochar could reverse the effect of volatile fatty acids (VFA) inhibition (mainly propionic acid) and yielded 105.55% more methane than the control. The addition of nano-zerovalent iron (nZVI) promoted the generation of VFA while causing a slight inhibition of the methanogens initially. In due time, the nZVI digester was able to recover and eventually produced 192.22% more methane compared to the control. Finally, nZVI-modified biochar was proved to be able to avoid the inhibitory effects brought about by the nanoparticles. The results indicated reduced dosage requirements as compared to using pristine pine woodchip biochar and accumulated 204.84% more methane than the control. The introduction of nZVI-biochar also promoted the growth of Methanosarcina species methanogens, which can perform direct-interspecies electron transfer. While all the recovery strategies using the additives were feasible, the results suggested that the use of modified biochar holds great potential as a significantly lower amount of amendment is required for the recovery of the inhibited AD system.

Effects of temperature and HRT on biogas production in moving and fixed bed of a novel upflow anaerobic hybrid (UAHB) reactor

The upflow anaerobic hybrid (UAHB) reactor combines the advantages of a upflow anaerobic sludge blanket (UASB-type) reactor and an anaerobic filter in a single compartment. A novel configuration of the UAHB reactor, composed of two three-phase separators (3PHS), was proposed to evaluate the biogas production in the moving and fixed bed in the treatment of synthetic sewage at a temperature range of 14-21 °C and hydraulic retention time (HRT) of 12, 10 and 8 h. The bench-scale reactor was operated in three different phases with organic loading rate (VOLR) of 0.6 (0.3-0.7), 0.7 ± 0.2, and 1.1 ± 0.1 kg COD m^-3 d^-1, respectively, for 225 days. The average removal efficiency of chemical oxygen demand (COD_t) was 78 (42-89)%, and the total biogas yield was 3090 (1704-4782) mL d^-1, with 66% of the lower 3PHS (moving bed) and 34% of the upper 3PHS (fixed bed). However, no significant difference was observed between the biogas yield on the 3PHS (p-value = 0.5048), thus confirming the influence of temperature in the biogas production. The average percentage of methane was 76 (60-82)% for both beds, and the filter media increased the production by 21%. Thus, it can be concluded that the fixed bed suppressed the instability of the moving bed regarding the biogas production and contributed to the final quality of the effluent.

New insights of anaerobic performance, antibiotic resistance gene removal, microbial community structure: applying graphite-based materials in wet anaerobic digestion

The addition of carbonaceous materials into anaerobic digestion (AD) has gained widespread attention due to their significant effects on anaerobic performance and antibiotic resistance gene (ARG) removal. This study selected graphite, graphene, and graphene oxide (GO) as additives to investigate variations in AD performance, ARG removal, microbial community diversity and structure in wet AD systems. The results indicated that the addition of graphite-based materials in wet AD systems could increase degradation of solid organic matters by 0.91%-3.41% and utilization of soluble organic fractions by 10.43%-13.67%, but could not stimulate methane production. After the addition of graphite and graphene, ARG removal rates were effectively increased to 90.85% and 94.22%, respectively. However, the total ARG removal rate was reduced to 77.46% with the addition of GO. In addition, the microbial diversity in the wet AD process was enhanced with the addition of GO only, graphite and graphene led to a reduction in it. As for bacterial community, graphite and graphene increased the abundance of Thermotogae from 43.43% to 57.42% and 58.74%, while GO increased the abundance of Firmicute from 49.90% to 56.27%. For the archaeal community, the proportion of hydrogenotrophic methanogens was improved when adding each graphite-based material; however, only GO increased Methanosaeta that was acetoclastic methanogens. Finally, methanogens were found as the ARG host, and ARGs that belong to the same subtype might exist in the same host bacteria.

Carbon based conductive materials mediated recalcitrant toxicity mitigation during anaerobic digestion of thermo-chemically pre-treated organic fraction of municipal solid waste

High-temperature thermal pretreatment alone or in conjugation with chemical pretreatment (highly acidic or alkaline) produced recalcitrant compounds, which inhibits the anaerobic digestion (AD) process performance. This study aims to develop a strategy to use carbon-based conductive materials to mitigate the recalcitrant toxicity and enhance the methane generation in the downstream AD. The formation of recalcitrant compounds, mainly the furan derivatives, i.e., furfural and 5-HydroxyMethyl furfurals (5-HMF) during thermo-chemical pretreatment of OFMSW at 150 °C, 175 °C, 200 °C with 3 g/L-NaOH dose, and the alleviation of their inhibitory effects by adding 25 g/L of each of granular activated carbon (GAC) and granular biochar (GBC) during mesophilic AD were studied. The addition of conductive materials resulted in the highest biogas yield of 462 mL/gVS_added (GAC) and 449 mL/gVS_added (GBC) for 175°C-3g/L-NaOH pretreatment, which was >45% higher over control. The highest improvement of >65% in biogas yield was observed for 200°C-3g/L-NaOH pretreatment despite the lower biogas yield. The conductive materials amended digester shows a significant decrease in the 5-HMF and furfurals concertation. The highest reduction in 5-HMF (44%) and furfural (51%) concentrations were observed for 200°C-3g/L-NaOH pretreatment, and 25 g/L GBC amended tests. The score plots from the principal component analysis (PCA) of the characterization of the digestate showed that the data were significant, whereas the loading plots depicted the correlation of different experimental parameters studied (like fate of recalcitrant, biogas yield and other parameters post AD of OFMSW when aided with conductive materials). Application of regression models in all the batch assays depicted that a lag phase of 2-4 days was observed in Modified Gompertz Model (MGM), 4-5 days in Logistic Model (LM) and a rapid hydrolysis was proven with the value of hydrolysis coefficient being between 0.003 and 0.029 from the first-order (FO) model.

Carbon-based conductive materials enhance biomethane recovery from organic wastes: A review of the impacts on anaerobic treatment

Amongst the most important sustainable waste management strategies, anaerobic biotechnology has had a central role over the past century in the management of high-pollution load sources, such as food, agricultural and municipal wastes. During anaerobic digestion (AD), valuable by-products such as digestate and biogas are produced. Biogas (mainly composed of methane) is generated through a series of reactions between bacteria and archaea. Enhancement of AD process with higher methane yield, accelerated methane production rate, and shorter start-up time is possible via tapping into a novel methanogenic pathway discovered a decade ago. This fundamentally new concept that is a substitute to interspecies hydrogen transfer is called direct interspecies electron transfer (DIET). DIET, a thermodynamically more feasible way of electron transfer, has been proven to occur between bacteria and methanogens. It is well-documented that amendment of carbon-based conductive materials (CCMs) can stimulate DIET via serving as an electrical conduit between microorganisms. Therefore, different types of CCMs such as biochar and activated carbon have been amended to a variety of AD reactors and enhancement of process performance was reported. In this review, a comparative analysis is presented for enhancement of AD performance in relation to major CCM related factors; electrical conductivity, redox properties, particle size and dosage. Additionally, the impacts of AD operational conditions such as organic loading rate and temperature on CCM amended reactors were discussed. Further, the changes in microbial communities of CCM amended reactors were reviewed and future perspectives along with challenges for CCM application in AD have been provided.

Energy conversion performance in co-hydrothermal carbonization of sewage sludge and pinewood sawdust coupling with anaerobic digestion of the produced wastewater

Energy conversion and utilization of sewage sludge (SS) and lignocellulosic biomass are an important measure to deal with environmental pollution and resource utilization. Addressing the waste by-product in a clean way is essential. In this study, solid char fuel (hydrochar) was obtained through co-hydrothermal carbonization of SS with pinewood sawdust (PS), and methane gas was obtained through anaerobic digestion (AD) of hydrothermal carbonization wastewater (HTCWW). The energy conversion performance of the feedstock organics under different HTC conditions (temperature of 160 °C, 220 °C, and 280 °C; reaction time of 0, 2, and 4 h; feedstock liquid-solid mass ratio of 4:1, 10:1, and 16:1), and the mass and energy yields of hydrochar and methane and their influencing factors were emphasized. More than 60% of the energy in SS and PS can be recovered by coupling the HTC-AD process. With the increase in hydrothermal reaction temperature and reaction time, the mass yield of hydrochar decreased, but the higher heating value increased. The maximum energy yield of hydrochar was 86.47% under the HTC temperature of 160 °C, liquid-solid ratio of 10:1, and reaction time of 2 h. The HTCWW obtained at a lower temperature (160 °C) showed the highest cumulative methane yield of 304.16 mL-CH₄/g-COD.

Microbial characteristics of the leachate contaminated soil of an informal landfill site

Because informal landfills are not constructed in a regulated manner, they will inevitably become a source of leachate pollution to the surrounding environment over time. Microbes are an important part of the soil system, playing a vital role in maintaining the normal functionality of soil. This study investigated the microbial composition and co-occurrence pattern in the leachate contaminated soil of an informal landfill site. The landfill leachate underwent horizontal and vertical migration through the contaminated soil, resulting in significant differences in the microbial compositions of horizontal surface soil (CS) and vertical subsurface soil (DS and ES) compared to uncontaminated soil (S). The microbial diversity of CS, DS, and ES was lower than that of S. Due to the migration of landfill leachate, the microbial composition of the surface soil was substantially changed. The dominant phyla in S included Proteobacteria (26.88%), Chloroflexi (23.68%), Actinobacteroita (17.36%), and Acidobacteroita (16.86%), but in contaminated soils, Firmicutes (35.27-86.68%) were the dominant bacteria. A network analysis indicated that Bacilli, Clostridia, and Thermacetogeniazai of the Firmicutes were the keystone taxa and played a vital role in maintaining the stability of the soil ecosystem. A functional annotation of prokaryotic taxa (FAPROTAX) analysis showed that the microbes involved in the C-, N-, and S-cycles in contaminated soil were significantly different to those in uncontaminated soil. The proportion of (aerobic)-chemoheterotrophy and cellulolysis functional communities in contaminated soils was significantly reduced, while there was an increase in functional communities, such as anammox and denitrification, which are not conducive to soil nitrogen fixation. This negatively affected the maintenance of normal soil ecological functions. This study identified the microbial characteristics in leachate contaminated soil and the results will be beneficial for the remediation of contaminated soil in informal landfill sites.

Biogas Potential Assessment of the Composite Mixture from Duckweed Biomass

The article presents the research results of anaerobic digestion processes in bioreactors of composite mixtures based on initial and residual biomass of Lemna minor duckweed and additives: inoculum (manure), food waste, and spent sorbents to determine biogas potential (biogas volume, methane content). Duckweed Lemna minor, which is widespread in freshwater reservoirs, is one of the promising aquatic vegetation species for energy use. Residual biomass is obtained by chemically extracting valuable components from the primary product. The purpose of the research was to evaluate the possibility of the energy potential of residual biomass of Lemna minor to reduce the consumption of fossil fuels and reduce greenhouse gas emissions. This is in line with the International Energy Agency (IEA) scenarios for the reduction of environmental impact. The obtained results confirm the feasibility of using this type of waste for biogas/biomethane production. The recommendations on the optimal composition of the mixture based on the residual biomass of Lemna minor, which will allow for an increase in biogas production, are given. The obtained data can be used in the design of bioreactors.

Significance of different mixing conditions on performance and microbial communities in anaerobic digester amended with granular and powdered activated carbon

Conductive materials amendment in anaerobic digestion (AD) is a promising strategy for boosting the methanogenesis process. Despite mixing is a critical parameter, the behavior of digesters amended with conductive additives upon different mixing conditions has rarely been investigated. This study investigated continuous mixing, intermittent mixing (10 min in every 12 h), and non-mixing conditions for digesters amended with granular activated carbon (GAC) and powdered activated carbon (PAC). The non-mixed GAC digester provided the highest methane yield (318 ± 28 mL/g COD) from synthetic blackwater, while intermittently mixed GAC and control exhibited similar methane yields (290-294 mL/g COD). For non-mixed systems, microbial richness and diversity increased with GAC and PAC amendment. In contrast, continuous and intermittent mixing increased microbial diversity and richness in control reactors while reduced the same in GAC and PAC amended reactors. Overall, various mixing conditions distinctly changed the degree of enrichment/retention of microbes and consequently influenced methane recovery.

Anaerobic bacterial responses to carbonaceous materials and implications for contaminant transformation: Cellular, metabolic, and community level findings

Carbonaceous materials (CM) enhance the abundance and activity of bacteria capable of persistent organic (micro)pollutant (POP) degradation. This review synthesizes anaerobic bacterial responses to minimally modified CM in non-fuel cell bioremediation applications at three stages: attachment, metabolism, and biofilm genetic composition. Established relationships between biological behavior and CM surface properties are identified, but temporal relationships are not well understood, making it difficult to connect substratum properties and "pioneer" bacteria with mature microorganism-CM systems. Stark differences in laboratory methodology at each temporal stage results in observational, but not causative, linkages as system complexity increases. This review is the first to critically examine relationships between material and cellular properties with respect to time. The work highlights critical knowledge gaps that must be addressed to accurately predict microorganism-CM behavior and to tailor CM properties for optimized microbial activity, critical frontiers in establishing this approach as an effective bioremediation strategy.

Enhancing the performance of thermophilic anaerobic digestion of food waste by introducing a hybrid anaerobic membrane bioreactor

The thermophilic anaerobic digestion of food waste was a long-term challenge for maintaining process stability. A hybrid submerged anaerobic membrane bioreactor (AnMBR), integrating 27%(v/v) polyurethane sponge as fixed carriers were therefore investigated at (50 ± 2) °C. The organics removal efficiencies, COD mass balance, and membrane filtration performance were investigated in a 75-days continuously operated experiment. The results showed that methane production reached 0.31 L/(kg·COD) under an organic loading rate of 7.3 kg·COD/(m³·d). The low concentration of total volatile fatty acids of 247 ~ 274 mg/L and a high proportion of Methanosarcina (>97%) represented the high stability of the thermophilic process. Approximately 21% of biomass grew on the carriers in the hybrid AnMBR and induced a much lower suspended solids concentration and viscosity of bulk sludge. Noticeable lower trans-membrane pressure was consequently observed. The affecting factors identified by PCA analysis proved the advantages of the hybrid AnMBR for alleviating membrane fouling formation.

Effects of bentonite on antibiotic resistance genes in biogas slurry and residue from thermophilic and mesophilic anaerobic digestion of food waste

Anaerobic digestion (AD) processes of food waste (FW) have potential risk on environments due to the prevalence and dissemination of antibiotic resistance genes (ARGs). This study investigated the effect of bentonite on methane production and the abundance of ARGs in biogas slurry and residue during AD of FW. Results showed that methane production increased by 68.52% and 56.79% with 3 g/L and 5 g/L of bentonite in mesophilic and thermophilic digestion, respectively. Adding 5 g/L of bentonite effectively reduced the genes of ermB, ermF, tetQ, tetX, sul1, sul2 and intI1 with a range of 80.82% - 100.00% in biogas residue under mesophilic reactor. The abundance of ARGs and intI1 in biogas residue were lower than in slurry under both temperatures with 5 g/L of bentonite. Statistical analysis indicated that bentonite and temperature were main driver factors which could impact ARGs by influencing the abundance and structure of microbial communities.

High-Solid Anaerobic Digestion: Reviewing Strategies for Increasing Reactor Performance

High-solid and solid-state anaerobic digestion are technologies capable of achieving high reactor productivity. The high organic load admissible for this type of configuration makes these technologies an ideal ally in the conversion of waste into bioenergy. However, there are still several factors associated with these technologies that result in low performance. The economic model based on a linear approach is unsustainable, and changes leading to the development of a low-carbon model with a high degree of circularity are necessary. Digestion technology may represent a key driver leading these changes but it is undeniable that the profitability of these plants needs to be increased. In the present review, the digestion process under high-solid-content configurations is analyzed and the different strategies for increasing reactor productivity that have been studied in recent years are described. Percolating reactor configurations and the use of low-cost adsorbents, nanoparticles and micro-aeration seem the most suitable approaches to increase volumetric production and reduce initial capital investment costs.

Thermophilic co-digestion of blackwater and organic kitchen waste: Impacts of granular activated carbon and different mixing ratios

Biogas (methane) as a source of renewable energy, was produced in the anaerobic co-digestion of blackwater (BW, municipal toilet wastewater) and organic kitchen waste (KW). The impact on methane production of various BW to KW mixing ratios, with and without the addition of granular activated carbon (GAC), were studied under thermophilic (55 °C) temperatures. GAC is reported to enhance methane production in such digestions through direct interspecies electron transfer. The results showed that the co-digestion of BW and KW under the 1:2 VS ratio significantly improved the biomethane potential (BMP). In the absence of GAC, an optimal BW:KW ratio was found to be 1:2, achieving a BMP of 0.76 g CH₄-COD/g feed-COD. With GAC addition, the BMP increased to 0.81 g CH₄-COD/g feed-COD, the lag phase in the digestion was significantly reduced, and the methane production rate increased. Microbial communities in the BW-KW anaerobic digestion were analyzed with and without the addition of GAC. Methanothermobacter and Methanosarcina were predominant archaea in BW-KW digests, with and without GAC amendment, while a third methanogen, Methanomassiliicoccus, was enriched with the addition of GAC to the digest. Further, through SEM image, the enrichment of pili-like stucture was observed in GAC surface.

High-rate blackwater anaerobic digestion under septic tank conditions with the amendment of biosolids-derived biochar synthesized at different temperatures

Septic tanks have been widely used for blackwater treatment in developing countries, while high-rate septic tanks with improved methane recovery are yet to be achieved. This study investigated biosolids-derived biochar (synthesized at 300℃, 425℃, and 550℃) as an additive for developing high-rate septic tanks. The experiments were conducted with anaerobic bioreactors operated with synthetic blackwater under septic tank conditions. All biochar amended reactors demonstrated a steady increase in daily methane production for increasing OLR from 0.08 to 3 g COD/L/d. The control reactor showed significant process disturbances at OLRs ≥ 2 g COD/L/d with an accumulation of volatile fatty acids followed by pH drop. At OLR of 3 g COD/L/d, the daily methane production from biochar amended reactors was ~ 4.3 times higher than the control (300 vs. 70 mL per day). Biochar addition established a robust microbiome consisted of a higher abundance of hydrogenotrophic and acetoclastic methanogens and hydrogen-producing fermentative bacteria.

Fate of disposable face masks in high-solids anaerobic digestion: Experimental observations and review of potential environmental implications

Face masks became a part of our daily life amid the global COVID-19 (SARS-CoV-2) pandemic. Most of the face masks are made for single-use and primarily disposed of in garbage bins with other non-recyclable wastes. To date, little is known about how disposable face masks in municipal solid waste (MSW) would interfere with high-solids anaerobic digestion (HSAD) in waste management facilities. Here, we first report preliminary results from a lab experiment conducted with the organic fraction of municipal solid waste (OFMSW) amended with used disposable face masks. The lab-scale HSAD systems were operated with percolate recirculation comparable to commercial HSAD systems typically used for full-scale processing of OFMSW. The results suggested that the presence of face masks in OFMSW could negatively affect methane productivity and kinetics. In the digesters amended with face masks, total cumulative methane production decreased by up to 18%, along with a 12-29% decrease in maximum methane production rates than the control digester (without face masks). Moreover, lag phases increased by 7-14%. The results also suggested that the type of polymeric materials used in face masks would be more critical than their total number/loading in the digester, which warrants further investigation. The visual inspection of digestate showed that the face masks were mostly undegraded after 40 days of operation. Much remains unknown about how the undegraded face masks will affect the digestate management practices, such as composting, land application, and landfilling. However, the review of existing literature suggested that they can be a potential source of plastic and microplastic pollution and amplify transmission of antibiotic resistance genes to the ecosystem. In summary, this study underscores the importance of developing safe and reliable disposal guidelines and management plans for single-use face masks.

Direct interspecies electron transfer mechanism in enhanced methanogenesis: A mini-review

The role of direct interspecies electron transfer (DIET) on enhancement of methanogenesis has been studied. This mini-review updated the current researches on the potential role of DIET on enhanced performance for anaerobic digestion of organic substrates with effective strategies implemented. Since most experimental observations correlated with the DIET mechanism are yet to be consolidated, this article categorized and discussed the current experimental observations supporting DIET mechanism for methanogenesis, mainly based on those with supplement of carbon materials, from which the prospects and challenges for further studies to confirm the role of DIET in anaerobic digestion processes were highlighted.

Roles of modified biochar in the performance, sludge characteristics, and microbial community features of anaerobic reactor for treatment food waste

Anaerobic digestion (AD) is a green technology widely applied to food waste treatment. Although the AD has high efficiency, instability often occurs. The main purpose of the study is to understand the mechanism of modified biochar improving AD performance. The effects of different modified biochar on the efficiency and microecology of an anaerobic reactor treating food waste were investigated. Bagasse biochar was used as the substrate to explore the effects of iron-modified (A), chitosan-modified (B), iron-chitosan-modified (C) and iron‑magnesium-chitosan-modified (D) biochar on the anaerobic digestion process, sludge characteristics and microbial community. The results show that the average COD removal efficiency of the four reactors during the last five days of the experimentation period was 86.95%, 85.90%, 92.22% and 93.29%, respectively. Adding iron‑magnesium-chitosan-modified biochar could improve the efficiency of COD removal in the anaerobic reactor under ammonia nitrogen stress. On day 10 of operation, the content of coenzyme F₄₂₀ in the sludge of anaerobic reactors C and D reached to 0.44 and 0.57 mmol/g, respectively, indicating that the metal-chitosan complex biochar could promote the production of coenzyme F₄₂₀ in the early stage of the experiment. Within the four anaerobic reactors, Firmicutes, Bacteroidetes, Proteobacteria and Chloroflexi were the dominant bacteria, and the abundance of Chloroflexi reached a maximum of 26.24% in the reactor C. As for archaea, Methanobacterium and Methanothrix were the most dominant accounting for 44.03%, 49.88%, 31.29%, 52.01% and 38.34%, 34.52%, 50.9%, 35.72% respectively in the four reactors. KEGG functional analysis showed that the energy metabolism of bacteria and archaea in the reactor D was the largest among the four reactors. Meanwhile, the gene abundance associated with carbohydrate metabolism and membrane transport of microorganisms in the reactor D was greater than that of other groups.

Hyperthermophilic Composting Technology for Organic Solid Waste Treatment: Recent Research Advances and Trends

Organic solid waste is considered a renewable resource that can be converted by various technologies into valuable products. Conventional thermophilic composting (TC), a well-studied and mature technology, can be applied to organic solid waste treatment to achieve waste reduction, mineralization, and humification simultaneously. However, poor efficiency, a long processing period, as well as low compost quality have always limited its wide application. In order to overcome these shortages, hyperthermophilic composting (HTC) has been recently put forward. This paper reviews the basic principle, process flow, operation parameters, research advances, and application status of HTC. Compared with the TC process, the shorter composting period and higher temperature and treatment efficiency, as well as more desirable compost quality, can be achieved during HTC by inoculating the waste with hyperthermophilic microbes. Additionally, HTC can reduce greenhouse gas emission, increase the removal rate of microplastics and antibiotic residues, and achieve in-situ remediation of heavy metal-polluted soils, which greatly improve its application potential for organic solid waste treatment. This paper also proposes the limitations and future prospects of HTC technology for a wider application. As a result, this review advances our understanding of the HTC process, which promotes its further investigation and application.

Comparison of microbial community structures between mesophilic and thermophilic anaerobic digestion of vegetable waste

The anaerobic digestion performance correlates with the functional microbial community. Mesophilic and thermophilic digestions of vegetable waste were conducted, and dynamics of the microbial community were investigated. The mesophilic and thermophilic collapsed stages occurred at organic loading rates of 1.5 and 2.0 g VS/(L d) due to the accumulation of volatile fatty acids with final concentrations of 2276 and 6476 mg/L, respectively. A high concentration of volatile fatty acids caused the severe inhibition of methanogens, which finally led to the imbalance between acetogenesis and methanogenesis. The mesophilic digestion exhibited a higher microbial diversity and richness than the thermophilic digestion. Syntrophic acetate-oxidizing coupled with hydrogenotrophic methanogenesis was the dominant pathway in the thermophilic stable system, and acetoclastic methanogenesis in the mesophilic stable system. The dominant acidogens, syntrophus, and methanogens were unclassified_f__Anaerolineaceae (8.68%), Candidatus_Cloacamonas (19.70%), Methanosaeta (6.10%), and Methanosarcina (4.08%) in the mesophilic stable stage, and Anaerobaculum (12.59%), Syntrophaceticus (4.84%), Methanosarcina (30.58%), and Methanothermobacter (3.17%) in thermophilic stable stage. Spirochaetae and Thermotogae phyla were the characteristic microorganisms in the mesophilic and thermophilic collapsed stages, respectively. These findings provided valuable information for the deep understanding of the difference of the microbial community and methane-producing mechanism between mesophilic and thermophilic digestion of vegetable waste.

Optimization of thermal hydrolysis process for enhancing anaerobic digestion in a wastewater treatment plant with existing primary sludge fermentation

Many wastewater treatment plants (WWTPs) adopted primary sludge fermentation to produce sludge liquor for the biological denitrification process. The fermented primary sludge (FPS) is usually co-digested with thickened waste activated sludge (TWAS) in the anaerobic digestion (AD) process. To date, there has been limited information on how the sludge thermal hydrolysis process (THP) could be retrofitted for enhancing AD in WWTPs with the existing primary sludge fermentation process. This study assessed two THP retrofitting schemes, (FPS + TWAS and TWAS alone) combining different exposure times (15, 30, and 60 min) and temperatures (140, 160, and 180 °C). The results suggested that temperature had more impact on sludge solubilization than exposure times. Notably, 180 °C was the most effective for sludge solubilization under both schemes. However, a higher degree of solubilization did not necessarily lead to higher methane yields. The THP of FPS + TWAS attained considerably higher methane yield than the pretreatment of TWAS alone.

A high-rate anaerobic biofilm reactor for biomethane recovery from source-separated blackwater at ambient temperature

Anaerobic bioreactors for source-separated blackwater are mostly operated at low organic loading rates (OLRs) due to low biodegradability and the potential of ammonia inhibition. In this study, an anaerobic biofilm reactor having conductive carbon fibers as the media was investigated for the high-rate treatment of blackwater collected from vacuum toilets. The bioreactor was operated at different OLRs ranged from 0.77 to 3.01 g COD/L-d in four stages for a total operating period of ~ 250 days. With the increase of OLRs, the specific methane production rate increased from 105.3 to 304.6 ml/L-d with high methane content in biogas (75.5%-83%). The maximum methane yield was achieved at hydraulic retention time (HRT) of 15 days. Highest organics and suspended solids removal (80%-83%) were achieved at 20-days HRT, while increased OLRs resulted in diminished removal efficiencies. The state variables, including pH, total ammonia nitrogen, short-chain volatile fatty acids, and soluble chemical oxygen demand, indicated the system had a great capability to withstand the high OLRs. Microbial community analysis revealed that the high performance might be attributed to direct interspecies electron transfer (DIET) facilitated by potentially electroactive bacteria (e.g., Syntrophomonas, Clostridium) and electrotrophic archaea (e.g., Methanosaeta and Methanosarcina species) enriched on the carbon fibers. PRACTITIONER POINTS: An anaerobic biofilm reactor was investigated for biomethane recovery from source-separated blackwater. Conductive carbon fibers were utilized as the media to stimulate enrichment of potentially electroactive methanogenic communities. The bioreactor was operated at ambient temperature for over 250 days. High methane production rate and high-quality biogas were achieved at OLRs ranged from 0.77 to 3.01 g COD/L-d. Microbial community analysis suggested direct interspecies electron transfer (DIET) between specific electroactive bacteria and electrotrophic archaea.

Transitions of microbial communities in the solid and liquid phases during high-solids anaerobic digestion of organic fraction of municipal solid waste

This study presents a microbiological diagnosis of a mesophilic high-solids anaerobic digestion (HSAD) system with percolate recirculation. The results demonstrated a significant decrease in microbial diversity in both the solid digestate and the liquid percolate. Also, the digestate from the top and middle sections of the digester had similar diversity, whereas the digestate from the bottom of the tank had a slightly lower diversity. These results suggest that despite percolate recirculation, substrate gradients might have developed across the system. Archaeal communities showed shifts towards known hydrogenotrophic and ammonia-tolerant methanogens (genera Methanocelleus, Methanolinea, Methanosarcina, vadin CA11, etc.), which was a consequence of decreased volatile fatty acids and increased ammonia-nitrogen levels over time. Compared to initial solid and liquid inoculum, the relative abundances of some bacteria (phyla Proteobacteria and Firmicutes) and archaea of the genus Methanosarcina changed between two phases in the opposite direction, indicating a shift of microbes between two phases.

Enhancing anaerobic digestion for rural wastewater treatment with granular activated carbon (GAC) supplementation

Notwithstanding many efforts to increase the efficiency of anaerobic digestion at low-temperature (winter) conditions, a cost-effective and efficient method is lacking. This study proposes a low-cost method of low-temperature (<35 °C) anaerobic digestion of wastewater, involving supplementation with granular activated carbon (GAC). Supplementation with GAC was found to reduce the lag time by 29.8% (from 15.1 to 10.6 days) and increase the maximum methane production rate by 23.4% (from 6.4 to 7.9 mL/day) at 25 °C. Network analysis demonstrated a strong co-occurrence of Syntrophobacteriales and hydrogenotrophic methanogens (Methanobacteriaceae; WSA2; Methanoregulaceae). GAC supplementation can drastically reduce the time required for organic matter decomposition and methane production, thereby increase the efficiency of wastewater treatment.

Methanogenic pathway and microbial succession during start-up and stabilization of thermophilic food waste anaerobic digestion with biochar

One of the major obstacles for thermophilic anaerobic digestion is the process instability during start-up. This study proposed the use of a cost-effective additive, biochar, to accelerate and stabilize the start-up of thermophilic semi-continuous food waste anaerobic digestion. The results showed that the reactors with biochar addition resulted in up to 18% higher methane yield as compared to the control reactors (without biochar). The key microbial networks were elucidated through thermochemical and microbial analysis. Particularly, the addition of biochar promoted the growth of electroactive Clostridia and other electroactive bacteria, while the absence of biochar promoted the growth of homoacetogenic Clostridia and syntrophic acetate oxidizing bacteria. It was revealed that biochar promoted direct interspecies electron transfer between the microbes and was responsible for the faster degradation of volatile fatty acids. Furthermore, reactors with biochar also enhanced the thermodynamically favourable acetoclastic methanogenic pathway due to the higher abundance of Methanosarcina.

Powdered activated carbon facilitates methane productivity of anaerobic co-digestion via acidification alleviating: Microbial and metabolic insights

Low methanogenic efficiency caused by excess acidification is a challenge during anaerobic digestion. This study indicated that both granular activated carbon (GAC) and powdered activated carbon (PAC) promoted the start-up of methanogenesis and methane output in anaerobic co-digestion of food waste and fruit-vegetable waste. Moreover, PAC performed better than GAC. Specifically, the highest cumulative methane yield and shortest lag phase were observed in 5 g/L PAC and 10 g/L PAC group, 22.0% higher and 62.5% shorter than that without activated carbon supplementation, respectively. PAC facilitated the methane productivity by effectively accelerating volatile fatty acids (VFAs) consumption and thereby alleviating acidification. Syntrophic VFAs oxidizing bacteria (Gelria and Syntrophomonas) and direct interspecies electron transfer related microorganisms (Geobacter and Methanosarcina) were remarkably enriched by PAC. Furthermore, metagenomic analysis showed that both PAC and GAC might facilitate the electron transfer between microbes by acting as the electrical bridge and enhance both hydrogenotrophic and aceticlastic pathways.

A comparison and evaluation of the effects of biochar on the anaerobic digestion of excess and anaerobic sludge

The mechanisms and enhancing effects of different biochar loadings on the digesters receiving low and high excess (or anaerobic) sludge loadings were thoroughly examined in the present study. This was done to explore an efficient method for converting excess sludge to anaerobic sludge. Biochar had an obvious effect on the anaerobic digestion of excess sludge but not on the anaerobic sludge. When the amount of biochar added was equivalent to 100% of the sludge TS, the cumulative methane yields of anaerobic digestion inoculated with small and large amounts of excess sludge were respectively 30.2 and 1.7 times that of those without biochar. The number of methanogens in the digesters that received small and large inoculations of excess sludge with 100% biochar, were respectively 105.4% and 20.6% higher than those without biochar. The biochar enhanced the systems performance because it selectively enriched the Trichococcus and Methanomicrobiales tightly attach to it. This enhanced the synergy and overall activity of the system by promoting biofilm development. Ultimately, the integration of 100% biochar and excess sludge can be used as a substitute for anaerobic sludge as an inoculum by giving similar overall performance.