1
|
Weisz L, Reif D, Weilguni S, Parravicini V, Saracevic E, Krampe J, Kreuzinger N. Feasibility study of electrodialysis as an ammonium reuse process for covering the nitrogen demand of an industrial wastewater treatment plant. THE SCIENCE OF THE TOTAL ENVIRONMENT 2024; 954:176699. [PMID: 39366584 DOI: 10.1016/j.scitotenv.2024.176699] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/15/2024] [Revised: 09/28/2024] [Accepted: 10/01/2024] [Indexed: 10/06/2024]
Abstract
Electrodialysis (ED) is a cost-effective membrane technology used is a variety of fields for desalination and concentration. This feasibility study explores the potential of ED as an NH4-N recovery technology from anaerobic digestate liquor (ADL), and the use of the concentrate as a nitrogen source in an industrial wastewater treatment plant (WWTP). Three neighboring WWTPs were the focus of this study: Two municipal WWTPs A and B, operating anaerobic sludge stabilization, and a pulp & paper WWTP C, utilizing urea as a nitrogen source. Two-stage bench-scale experiments with the municipal ADL from WWTP A and WWTP B were conducted, and performance indicators were determined. A concentration of approximately 10 g NH4-N/L and 15 g NH4-N/L was obtained in stages 1 and 2, respectively. The NH4-N removal was above 85 % in all experiment, while recovery varied between 25 and 95 %. The specific energy consumption (SEC) was on average 12.9 kWh/kg NH4-N. Moreover, mass and energy balances in a model WWTP demonstrated that an ED side-stream treatment for NH4-N removal coupled with microfiltration (MF) pre-treatment results in a net energy gain, also without the added benefit of the ED concentrate as a nitrogen source.
Collapse
Affiliation(s)
- Liad Weisz
- Institute of Water Quality and Resource Management, TU Wien, Vienna, Austria.
| | - Daniela Reif
- Institute of Water Quality and Resource Management, TU Wien, Vienna, Austria
| | - Sascha Weilguni
- Institute of Water Quality and Resource Management, TU Wien, Vienna, Austria
| | - Vanessa Parravicini
- Institute of Water Quality and Resource Management, TU Wien, Vienna, Austria
| | - Ernis Saracevic
- Institute of Water Quality and Resource Management, TU Wien, Vienna, Austria
| | - Jörg Krampe
- Institute of Water Quality and Resource Management, TU Wien, Vienna, Austria
| | - Norbert Kreuzinger
- Institute of Water Quality and Resource Management, TU Wien, Vienna, Austria
| |
Collapse
|
2
|
Xiao Y, Mackey HR, Tang W, Lu H, Hao T. Disentangling microbial niche balance and intermediates' trade-offs for anaerobic digestion stability and regulation. WATER RESEARCH 2024; 261:122000. [PMID: 38944003 DOI: 10.1016/j.watres.2024.122000] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/09/2023] [Revised: 06/02/2024] [Accepted: 06/24/2024] [Indexed: 07/01/2024]
Abstract
Anaerobic digestion (AD) is a key technology for converting organic matters to methane-rich biogas. However, nutrient imbalance can destabilize the whole digestion. To realize stable operation of AD and improve its efficiency, this work considers a new strategy to control the intermediate concentrations of poor AD under nutrient stress. For this purpose, long-term digestion under different nutrient conditions was investigated. Results showed that the feedstock with a low C/N ratio (= 6) caused VFA accumulation (2072 ± 632 mg/L), leading to the inhibition of methane production. Employing a substrate with a higher C/N ratio (= 11) and/or adding NH4HCO3 (200 mg NH4+-N/Ladd) could alleviate the VFA inhibition, but excessive dosage of NH4HCO3 would induce ammonia inhibition. Through the established digestion balance between free ammonia nitrogen (FAN) between 0 and 25 mg/L, volatile fatty acid (VFA) 510-2100 mg/L, and alkalinity (ALK) 3300-7800 mg/L, an efficient methane yield of 150-250 mL/g VS was achieved and stable operation of AD under nutrient stress (low C/N ratio) was realized. Metabolic reconstruction between Euryarchaeota sp. MAG162, Methanosarcina mazei MAG53 and Mesotoga infera MAG119 highlighted that microbial niche balance was developed as a result of digestion balance, which is beneficial for stable operation of AD. These findings improved our understanding of the interaction mechanism between intermediates and microbial niches for stability control in AD.
Collapse
Affiliation(s)
- Yihang Xiao
- Department of Civil and Environmental Engineering, Faculty of Science and Technology, University of Macau, Macau, China
| | - Hamish R Mackey
- Department of Civil and Natural Resources Engineering, University of Canterbury, Christchurch, New Zealand
| | - Wentao Tang
- Department of Civil and Environmental Engineering, The Hong Kong University of Science and Technology, Hong Kong, China
| | - Hui Lu
- School of Environmental Science and Engineering, Sun Yat-sen University, Guangzhou, China
| | - Tianwei Hao
- Department of Civil and Environmental Engineering, Faculty of Science and Technology, University of Macau, Macau, China.
| |
Collapse
|
3
|
Wang X, Campuzano S, Guenne A, Mazéas L, Chapleur O. Inhibition of anaerobic digestion by various ammonia sources resulted in subtle differences in metabolite dynamics. CHEMOSPHERE 2024; 351:141157. [PMID: 38218245 DOI: 10.1016/j.chemosphere.2024.141157] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/11/2023] [Revised: 12/22/2023] [Accepted: 01/07/2024] [Indexed: 01/15/2024]
Abstract
The impact of ammonia on anaerobic digestion performance and microbial dynamics has been extensively studied, but the concurrent effect of anions brought by ammonium salt should not be neglected. This paper studied this effect using metabolomics and a time-course statistical framework. Metabolomics provides novel perspectives to study microbial processes and facilitates a more profound understanding at the metabolic level. The advanced statistical framework enables deciphering the complexity of large metabolomics data sets. More specifically, a series of lab-scale batch reactors were set up with different ammonia sources added. Samples of nine time points over the degradation were analyzed with liquid chromatography-mass spectrometry. A filtering procedure was applied to select the promising metabolomic peaks from 1262 peaks, followed by modeling their intensities across time. The metabolomic peaks with similar time profiles were clustered, evidencing the correlation of different biological processes. Differential analysis was performed to seek the differences in metabolite dynamics caused by different anions. Finally, tandem mass spectrometry and metabolite annotation provided further information on the molecular structure and possible metabolic pathways. For example, the consumption of 5-aminovaleric acid, a short-chain fatty acid obtained from l-lysine degradation, was slowed down by phosphates. Overall, by investigating the effect of anions on anaerobic digestion, our study demonstrated the effectiveness of metabolomics in providing detailed information in a set of samples from different experimental conditions. With the statistical framework, the approach enables capturing subtle differences in metabolite dynamics between samples while accounting for the differences caused by time variations.
Collapse
Affiliation(s)
- Xiaoqing Wang
- Université Paris-Saclay, INRAE, PRocédés biOtechnologiques au Service de l'Environnement, 92761, Antony, France
| | - Stephany Campuzano
- Université Paris-Saclay, INRAE, PRocédés biOtechnologiques au Service de l'Environnement, 92761, Antony, France
| | - Angéline Guenne
- Université Paris-Saclay, INRAE, PRocédés biOtechnologiques au Service de l'Environnement, 92761, Antony, France
| | - Laurent Mazéas
- Université Paris-Saclay, INRAE, PRocédés biOtechnologiques au Service de l'Environnement, 92761, Antony, France
| | - Olivier Chapleur
- Université Paris-Saclay, INRAE, PRocédés biOtechnologiques au Service de l'Environnement, 92761, Antony, France.
| |
Collapse
|
4
|
Bhattarai B, Bhattacharjee AS, Coutinho FH, Goel R. Investigating the viral ecology and contribution to the microbial ecology in full-scale mesophilic anaerobic digesters. CHEMOSPHERE 2024; 349:140743. [PMID: 37984648 DOI: 10.1016/j.chemosphere.2023.140743] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/02/2023] [Revised: 11/14/2023] [Accepted: 11/15/2023] [Indexed: 11/22/2023]
Abstract
In an attempt to assess the diversity of viruses and their potential to modulate the metabolism of functional microorganisms in anaerobic digesters, we collected digestate from three mesophilic anaerobic digesters in full-scale wastewater treatment plants treating real municipal wastewater. The reads were analyzed using bioinformatics algorithms to elucidate viral diversity, identify their potential role in modulating the metabolism of functional microorganisms, and provide essential genomic information for the potential use of virus-mediated treatment in controlling the anaerobic digester microbiome. We found that Siphoviridae was the dominant family in mesophilic anaerobic digesters, followed by Myoviridae and Podoviridae. Lysogeny was prevalent in mesophilic anaerobic digesters as the majority of metagenome-assembled genomes contained at least one viral genome within them. One virus within the genome of an acetoclastic methanogen (Methanothrix soehngenii) was observed with a gene (fwdE) acquired via lateral transfer from hydrogenotrophic methanogens. The virus-mediated acquisition of fwdE gene enables possibility of mixotrophic methanogenesis in Methanothrix soehngenii. This evidence highlighted that lysogeny provides fitness advantage to methanogens in anaerobic digesters by adding flexibility to changing substrates. Similarly, we found auxiliary metabolic genes, such as cellulase and alpha glucosidase, of bacterial origin responsible for sludge hydrolysis in viruses. Additionally, we discovered novel viral genomes and provided genomic information on viruses infecting acidogenic, acetogenic, and pathogenic bacteria that can potentially be used for virus-mediated treatment to deal with the souring problem in anaerobic digesters and remove pathogens from biosolids before land application. Collectively, our study provides a genome-level understanding of virome in conjunction with the microbiome in anaerobic digesters that can be used to optimize the anaerobic digestion process for efficient biogas generation.
Collapse
Affiliation(s)
- Bishav Bhattarai
- The University of Utah, Department of Civil and Environmental Engineering, 110 S Central Campus Drive, Salt Lake City, UT, 84112, United States.
| | - Ananda Shankar Bhattacharjee
- Department of Environmental Sciences, The University of California, Riverside, Riverside, CA, United States; USDA-ARS, United States Salinity Laboratory, Riverside, CA, United States
| | - Felipe H Coutinho
- Department of Marine Biology and Oceanography, Institute of Marine Sciences, Consejo Superior de Investigaciones Científicas (ICM-CISC), Barcelona, Spain
| | - Ramesh Goel
- The University of Utah, Department of Civil and Environmental Engineering, 110 S Central Campus Drive, Salt Lake City, UT, 84112, United States.
| |
Collapse
|
5
|
Bucci L, Ghiotto G, Zampieri G, Raga R, Favaro L, Treu L, Campanaro S. Adaptation of Anaerobic Digestion Microbial Communities to High Ammonium Levels: Insights from Strain-Resolved Metagenomics. ENVIRONMENTAL SCIENCE & TECHNOLOGY 2024; 58:580-590. [PMID: 38114447 PMCID: PMC10785762 DOI: 10.1021/acs.est.3c07737] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/19/2023] [Revised: 11/29/2023] [Accepted: 11/30/2023] [Indexed: 12/21/2023]
Abstract
Ammonia release from proteinaceous feedstocks represents the main inhibitor of the anaerobic digestion (AD) process, which can result in a decreased biomethane yield or even complete failure of the process. The present study focused on the adaptation of mesophilic AD communities to a stepwise increase in the concentration of ammonium chloride in synthetic medium with casein used as the carbon source. An adaptation process occurring over more than 20 months allowed batch reactors to reach up to 20 g of NH4+ N/L without collapsing in acidification nor ceasing methane production. To decipher the microbial dynamics occurring during the adaptation and determine the genes mostly exposed to selective pressure, a combination of biochemical and metagenomics analyses was performed, reconstructing the strains of key species and tracking them over time. Subsequently, the adaptive metabolic mechanisms were delineated by following the single nucleotide variants (SNVs) characterizing the strains and prioritizing the associated genes according to their function. An in-depth exploration of the archaeon Methanoculleus bourgensis vb3066 and the putative syntrophic acetate-oxidizing bacteria Acetomicrobium sp. ma133 identified positively selected SNVs on genes involved in stress adaptation. The intraspecies diversity with multiple coexisting strains in a temporal succession pattern allows us to detect the presence of an additional level of diversity within the microbial community beyond the species level.
Collapse
Affiliation(s)
- Luca Bucci
- Department
of Biology (DIBIO), University of Padova, Via Ugo Bassi 58/B, 35131 Padova, Italy
| | - Gabriele Ghiotto
- Department
of Biology (DIBIO), University of Padova, Via Ugo Bassi 58/B, 35131 Padova, Italy
| | - Guido Zampieri
- Department
of Biology (DIBIO), University of Padova, Via Ugo Bassi 58/B, 35131 Padova, Italy
| | - Roberto Raga
- Department
of Civil, Environmental and Architectural Engineering (ICEA), University of Padova, Via Marzolo 9, 35131 Padova, Italy
| | - Lorenzo Favaro
- Department
of Agronomy Food Natural Resources Animals and Environment (DAFNAE), University of Padova,
Campus Agripolis, Viale dell’Università
16, 35020 Legnaro, Italy
| | - Laura Treu
- Department
of Biology (DIBIO), University of Padova, Via Ugo Bassi 58/B, 35131 Padova, Italy
| | - Stefano Campanaro
- Department
of Biology (DIBIO), University of Padova, Via Ugo Bassi 58/B, 35131 Padova, Italy
| |
Collapse
|
6
|
Liu F, Zhang Y, Zhang Y, Yang J, Shen W, Yang S, Quan Z, Liu B, Yuan Z, Zhang Y. Thermodynamic restrictions determine ammonia tolerance of functional floras during anaerobic digestion. BIORESOURCE TECHNOLOGY 2024; 391:129919. [PMID: 37884096 DOI: 10.1016/j.biortech.2023.129919] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/10/2023] [Revised: 10/14/2023] [Accepted: 10/23/2023] [Indexed: 10/28/2023]
Abstract
Ammonia inhibition is a major challenge in anaerobic digestion processes, affecting the activity and performance of functional floras, including syntrophic butyrate oxidation (FSBO), syntrophic propionate oxidation (FSPO), acetoclastic methanogenesis (FAMs), and hydrogenotrophic methanogenesis (FHMs). FHMs was more tolerant to ammonia, with a half maximal inhibitory concentration (IC50) of 18.80 g/L, followed by FSBO (IC50 = 14.26 g/L) and FSPO (IC50 = 10.47 g/L), and FAMs was the most sensitive to ammonia with the lowest IC50 (1.74 g/L). The order of ammonia tolerance (IC50) was found to be correlated with the Gibbs free energy of metabolic reactions in each functional flora. The results suggested the functional flora with higher energy availability (exergonic capacity) exhibited enhanced ammonia resistance ability. These findings provide insights into the thermodynamic restrictions and ammonia tolerance mechanisms of functional floras, which can guide the optimization and operation of anaerobic digestion systems for efficient methane production.
Collapse
Affiliation(s)
- Fengqin Liu
- College of Life Sciences, Henan Agricultural University, No.63 Agricultural Road, Zhengzhou 450002, China
| | - Yifan Zhang
- College of Life Sciences, Henan Agricultural University, No.63 Agricultural Road, Zhengzhou 450002, China
| | - Yu Zhang
- College of Life Sciences, Henan Agricultural University, No.63 Agricultural Road, Zhengzhou 450002, China
| | - Jiale Yang
- College of Life Sciences, Henan Agricultural University, No.63 Agricultural Road, Zhengzhou 450002, China
| | - Wenyan Shen
- College of Life Sciences, Henan Agricultural University, No.63 Agricultural Road, Zhengzhou 450002, China
| | - Shuilian Yang
- College of Resources and Environmental Sciences, Henan Agricultural University, No.63 Agricultural Road, Zhengzhou 450002, China
| | - Zhiyu Quan
- College of Life Sciences, Henan Agricultural University, No.63 Agricultural Road, Zhengzhou 450002, China
| | - Bingshan Liu
- Analytical Instrument Center, Henan Agricultural University, Wenhua Road No. 95, Zhengzhou 450002, China
| | - Zhiliang Yuan
- College of Life Sciences, Henan Agricultural University, No.63 Agricultural Road, Zhengzhou 450002, China
| | - Yupeng Zhang
- College of Resources and Environmental Sciences, Henan Agricultural University, No.63 Agricultural Road, Zhengzhou 450002, China.
| |
Collapse
|
7
|
Mills S, Yen Nguyen TP, Ijaz UZ, Lens PNL. Process stability in expanded granular sludge bed bioreactors enhances resistance to organic load shocks. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2023; 342:118271. [PMID: 37269726 DOI: 10.1016/j.jenvman.2023.118271] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/04/2023] [Revised: 05/21/2023] [Accepted: 05/24/2023] [Indexed: 06/05/2023]
Abstract
Environmental perturbations such as changes in organic loading rate (OLR) can have deleterious effects on the anaerobic digestion process, leading to VFA accumulation and process failure. However, the operational history of a reactor, such as prior exposure to VFA build up, can impact a reactor's resistance to shock loads. In the present study, the effects of long term (>100 days) bioreactor (un)stability on OLR shock resistance were assessed. Three 4 L EGSB bioreactors were subjected to varying levels of process stability. Operational conditions such as OLR, temperature and pH were maintained stable in R1; R2 was subjected to a series of minor OLR perturbations and R3 was subjected to a series of non-OLR perturbations, including ammonium, temperature, pH and sulfide. The effect of these different operational histories on each reactor's resistance to a sudden 8-fold increase in OLR were assessed by monitoring COD removal efficiency and biogas production. The microbial communities of each reactor were monitored using 16S rRNA gene sequencing to understand the relationship between microbial diversity and reactor stability. It was determined that the stable (un-perturbed) reactor performed best in terms of its resistance to a large OLR shock, despite its lower microbial community diversity.
Collapse
Affiliation(s)
- Simon Mills
- National University of Ireland, Galway, University Road, Galway, H91 TK33, Ireland.
| | - Thi Phi Yen Nguyen
- National University of Ireland, Galway, University Road, Galway, H91 TK33, Ireland
| | - Umer Zeeshan Ijaz
- National University of Ireland, Galway, University Road, Galway, H91 TK33, Ireland; Water & Environment Research Group, University of Glasgow, Mazumdar-Shaw Advanced Research Centre, Glasgow G11 6EW, United Kingdom; Department of Molecular and Clinical Cancer Medicine, University of Liverpool, Liverpool L69 7BE, United Kingdom
| | - Piet N L Lens
- National University of Ireland, Galway, University Road, Galway, H91 TK33, Ireland.
| |
Collapse
|
8
|
Yi Y, Dolfing J, Jin G, Fang X, Han W, Liu L, Tang Y, Cheng L. Thermodynamic restrictions determine ammonia tolerance of methanogenic pathways in Methanosarcina barkeri. WATER RESEARCH 2023; 232:119664. [PMID: 36775717 DOI: 10.1016/j.watres.2023.119664] [Citation(s) in RCA: 3] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/02/2022] [Revised: 01/20/2023] [Accepted: 01/21/2023] [Indexed: 06/18/2023]
Abstract
Ammonia is a ubiquitous potential inhibitor of anaerobic digestion processes, mainly exhibiting inhibition towards methanogenic activity. However, knowledge as to how ammonia affects the methanogens is still limited. In this study, we cultured a multitrophic methanogen, Methanosarcina barkeri DSM 800, with acetate, H2/CO2, and methanol to evaluate the influence of ammonia on different methanogenic pathways. Aceticlastic methanogenesis was more sensitive to increased ammonia concentrations than hydrogenotrophic and methylotrophic methanogenesis. Theoretical maximum NH3 tolerances of M. barkeri fed with acetate, H2/CO2, and methanol were calculated to be 39.1 ± 9.0, 104.3 ± 7.4, and 85.7 ± 1.0 mg/L, respectively. The order of the ΔG range of M. barkeri under three methanogenic pathways reflected the order of ammonia tolerance of M. barkeri. Our results provide insights into the role of the thermodynamic potential of methanogenesis on the tolerance of ammonia stress; and shed light on the mechanism of ammonia inhibition on anaerobic digestion.
Collapse
Affiliation(s)
- Yue Yi
- Key Laboratory of Development and Application of Rural Renewable Energy, Biogas Institute of Ministry of Agriculture and Rural Affairs, Section 4-13, Renmin South Road, Chengdu, Sichuan 610041, China; College of Architecture and Environment, Sichuan University, No. 24, South Section 1, First Ring Road, Chengdu, Sichuan 610065, China
| | - Jan Dolfing
- Faculty of Energy and Environment, Northumbria University, Wynne Jones 2.11, Ellison Place, Newcastle-upon-Tyne NE1 8QH, UK
| | - Ge Jin
- Key Laboratory of Development and Application of Rural Renewable Energy, Biogas Institute of Ministry of Agriculture and Rural Affairs, Section 4-13, Renmin South Road, Chengdu, Sichuan 610041, China
| | - XiaoYu Fang
- Key Laboratory of Development and Application of Rural Renewable Energy, Biogas Institute of Ministry of Agriculture and Rural Affairs, Section 4-13, Renmin South Road, Chengdu, Sichuan 610041, China
| | - WenHao Han
- Key Laboratory of Development and Application of Rural Renewable Energy, Biogas Institute of Ministry of Agriculture and Rural Affairs, Section 4-13, Renmin South Road, Chengdu, Sichuan 610041, China
| | - LaiYan Liu
- Key Laboratory of Development and Application of Rural Renewable Energy, Biogas Institute of Ministry of Agriculture and Rural Affairs, Section 4-13, Renmin South Road, Chengdu, Sichuan 610041, China
| | - YueQin Tang
- College of Architecture and Environment, Sichuan University, No. 24, South Section 1, First Ring Road, Chengdu, Sichuan 610065, China.
| | - Lei Cheng
- Key Laboratory of Development and Application of Rural Renewable Energy, Biogas Institute of Ministry of Agriculture and Rural Affairs, Section 4-13, Renmin South Road, Chengdu, Sichuan 610041, China.
| |
Collapse
|
9
|
Shen J, Zheng W, Xu Y, Yu Z. The inhibition of high ammonia to in vitro rumen fermentation is pH dependent. Front Vet Sci 2023; 10:1163021. [PMID: 37065225 PMCID: PMC10097989 DOI: 10.3389/fvets.2023.1163021] [Citation(s) in RCA: 3] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/10/2023] [Accepted: 03/14/2023] [Indexed: 04/03/2023] Open
Abstract
Ammonia is an important rumen internal environment indicator. In livestock production, feeding a large amount of non-protein nitrogen to ruminants will create high ammonia stress to the animals, which increases the risk of ammonia toxicity. However, the effects of ammonia toxicity on rumen microbiota and fermentation are still unknown. In this study, an in vitro rumen fermentation technique was used to investigate the effects of different concentrations of ammonia on rumen microbiota and fermentation. To achieve the four final total ammonia nitrogen (TAN) concentrations of 0, 8, 32, and 128 mmol/L, ammonium chloride (NH4Cl) was added at 0, 42.8, 171.2, and 686.8 mg/100 mL, and urea was added at 0, 24, 96, and 384 mg/100 mL. Urea hydrolysis increased, while NH4Cl dissociation slightly reduced the pH. At similar concentrations of TAN, the increased pH of the rumen culture by urea addition resulted in a much higher free ammonia nitrogen (FAN) concentration compared to NH4Cl addition. Pearson correlation analysis revealed a strong negative correlation between FAN and microbial populations (total bacteria, protozoa, fungi, and methanogens) and in vitro rumen fermentation profiles (gas production, dry matter digestibility, total volatile fatty acid, acetate, propionate, etc.), and a much weaker correlation between TAN and the above indicators. Additionally, bacterial community structure changed differently in response to TAN concentrations. High TAN increased Gram-positive Firmicutes and Actinobacteria but reduced Gram-negative Fibrobacteres and Spirochaetes. The current study demonstrated that the inhibition of in vitro rumen fermentation by high ammonia was pH-dependent and was associated with variations of rumen microbial populations and communities.
Collapse
Affiliation(s)
- Junshi Shen
- Laboratory of Gastrointestinal Microbiology, National Center for International Research on Animal Gut Nutrition, Nanjing Agricultural University, Nanjing, China
- Ruminant Nutrition and Feed Engineering Technology Research Center, College of Animal Science and Technology, Nanjing Agricultural University, Nanjing, China
- *Correspondence: Junshi Shen
| | - Wenjin Zheng
- Laboratory of Gastrointestinal Microbiology, National Center for International Research on Animal Gut Nutrition, Nanjing Agricultural University, Nanjing, China
- Ruminant Nutrition and Feed Engineering Technology Research Center, College of Animal Science and Technology, Nanjing Agricultural University, Nanjing, China
| | - Yixuan Xu
- Laboratory of Gastrointestinal Microbiology, National Center for International Research on Animal Gut Nutrition, Nanjing Agricultural University, Nanjing, China
- Ruminant Nutrition and Feed Engineering Technology Research Center, College of Animal Science and Technology, Nanjing Agricultural University, Nanjing, China
| | - Zhongtang Yu
- Department of Animal Sciences, The Ohio State University, Columbus, OH, United States
| |
Collapse
|
10
|
Liu C, Zhang X, Chen C, Yin Y, Zhao G, Chen Y. Physiological Responses of Methanosarcina barkeri under Ammonia Stress at the Molecular Level: The Unignorable Lipid Reprogramming. ENVIRONMENTAL SCIENCE & TECHNOLOGY 2023; 57:3917-3929. [PMID: 36820857 DOI: 10.1021/acs.est.2c09631] [Citation(s) in RCA: 4] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/18/2023]
Abstract
Acetotrophic methanogens' dysfunction in anaerobic digestion under ammonia pressure has been widely concerned. Lipids, the main cytomembrane structural biomolecules, normally play indispensable roles in guaranteeing cell functionality. However, no studies explored the effects of high ammonia on acetotrophic methanogens' lipids. Here, a high-throughput lipidomic interrogation deciphered lipid reprogramming in representative acetoclastic methanogen (Methanosarcina barkeri) upon high ammonia exposure. The results showed that high ammonia conspicuously reduced polyunsaturated lipids and longer-chain lipids, while accumulating lipids with shorter chains and/or more saturation. Also, the correlation network analysis visualized some sphingolipids as the most active participant in lipid-lipid communications, implying that the ammonia-induced enrichment in these sphingolipids triggered other lipid changes. In addition, we discovered the decreased integrity, elevated permeability, depolarization, and diminished fluidity of lipid-supported membranes under ammonia restraint, verifying the noxious ramifications of lipid abnormalities. Additional analysis revealed that high ammonia destabilized the structure of extracellular polymeric substances (EPSs) capable of protecting lipids, e.g., declining α-helix/(β-sheet + random coil) and 3-turn helix ratios. Furthermore, the abiotic impairment of critical EPS bonds, including C-OH, C═O-NH-, and S-S, and the biotic downregulation of functional proteins involved in transcription, translation, and EPS building blocks' supply were unraveled under ammonia stress and implied as the crucial mechanisms for EPS reshaping.
Collapse
Affiliation(s)
- Chao Liu
- State Key Laboratory of Pollution Control and Resources Reuse, School of Environmental Science and Engineering, Tongji University, 1239 Siping Road, Shanghai 200092, China
| | - Xuemeng Zhang
- State Key Laboratory of Pollution Control and Resources Reuse, School of Environmental Science and Engineering, Tongji University, 1239 Siping Road, Shanghai 200092, China
| | - Chuang Chen
- State Key Laboratory of Pollution Control and Resources Reuse, School of Environmental Science and Engineering, Tongji University, 1239 Siping Road, Shanghai 200092, China
| | - Yue Yin
- State Key Laboratory of Pollution Control and Resources Reuse, School of Environmental Science and Engineering, Tongji University, 1239 Siping Road, Shanghai 200092, China
| | - Guohua Zhao
- School of Chemical Science and Engineering, Tongji University, 1239 Siping Road, Shanghai 200092, China
| | - Yinguang Chen
- State Key Laboratory of Pollution Control and Resources Reuse, School of Environmental Science and Engineering, Tongji University, 1239 Siping Road, Shanghai 200092, China
| |
Collapse
|
11
|
Su J, Lv W, Ren L, Kong X, Luo L, Awasthi MK, Yan B. Effect of water regime on the dynamics of free ammonia during high solid anaerobic digestion of pig manure. CHEMOSPHERE 2023; 312:137328. [PMID: 36410500 DOI: 10.1016/j.chemosphere.2022.137328] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/20/2022] [Revised: 11/13/2022] [Accepted: 11/17/2022] [Indexed: 06/16/2023]
Abstract
Free ammonia (FAN) inhibition is commonly encountered during high solid anaerobic digestion (HSAD) of pig manure. The performance of HSAD is highly related to its operational water regime; however, little information is available regarding the dynamics of free ammonia with varied water regimes. In this work, four treatments were set with equal amount of water supply but varied addition frequencies, i.e. add once but at different times in treatments T1 and T2, add twice in T3 while it was three times in treatment T4. Results showed that the whole methanogenic process ran smoothly with the average methane gas production rate maintaining at 191.1 LCH4/kgVSadded. Although a higher methane gas production rate of 217.4 LCH4/kgVSadded was achieved in T1, one time water addition triggered a higher ammonia inhibition potential. Cumulative FAN release was 6.03 mgFAN/kgVSadded in T1 while the balance between FAN and ammonia tended to the fraction of FAN. In T4, cumulative FAN of 5.07 mgFAN/kgVSadded was evolved, which was lower than that in T1 but similar to the situation in T2. The lowest FAN was observed in T3, indicating that a moderate frequency of dilution might be conducive to alleviate free ammonia inhibition.
Collapse
Affiliation(s)
- Jian Su
- College of Resources and Environment, Hunan Agricultural University, Changsha 410128, China
| | - Wenjuan Lv
- College of Resources and Environment, Hunan Agricultural University, Changsha 410128, China
| | - Liheng Ren
- College of Resources and Environment, Hunan Agricultural University, Changsha 410128, China
| | - Xiaoliang Kong
- College of Resources and Environment, Hunan Agricultural University, Changsha 410128, China
| | - Lin Luo
- College of Resources and Environment, Hunan Agricultural University, Changsha 410128, China
| | - Mukesh Kumar Awasthi
- College of Natural Resources and Environment, Northwest A&F University, Yangling, Shaanxi Province, 712100, China.
| | - Binghua Yan
- College of Resources and Environment, Hunan Agricultural University, Changsha 410128, China.
| |
Collapse
|
12
|
Wang Z, Wang S, Hu Y, Du B, Meng J, Wu G, Liu H, Zhan X. Distinguishing responses of acetoclastic and hydrogenotrophic methanogens to ammonia stress in mesophilic mixed cultures. WATER RESEARCH 2022; 224:119029. [PMID: 36099760 DOI: 10.1016/j.watres.2022.119029] [Citation(s) in RCA: 7] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/13/2022] [Revised: 08/14/2022] [Accepted: 08/26/2022] [Indexed: 06/15/2023]
Abstract
A shift from the acetoclastic to the hydrogenotrophic pathway in methanogenesis under ammonia inhibition is a common observation in anaerobic digestion. However, there are still considerable knowledge gaps concerning the differential ammonia tolerance of acetoclastic and hydrogenotrophic methanogens (AMs and HMs), their responses to different ammonia species (NH4+, NH3), and their recoverability after ammonia inhibition. With the successful enrichment of mesophilic AMs and HMs cultures, this study aimed at addressing the above knowledge gaps through batch inhibition/recovery tests and kinetic modeling under varying total ammonia (TAN, 0.2-10 g N/L) and pH (7.0-8.5) conditions. The results showed that the tolerance level of HMs to free ammonia (FAN, IC50=1345 mg N/L) and NH4+ (IC50=6050 mg N/L) was nearly 11 times and 3 times those of AMs (NH3, IC50=123 mg N/L; NH4+, IC50=2133 mg N/L), respectively. Consistent with general belief, the AMs were more impacted by FAN. However, the HMs were more adversely affected by NH4+ when the pH was ≤8.0. A low TAN (1.0-4.0 g N/L) could cause irreversible inhibition of the AMs due to significant cell death, whereas the activity of HMs could be fully or even over recovered from severe ammonia stress (FAN≤ 0.9 g N/L or TAN≤10 g N/L; pH ≤8.0). The different tolerance responses of AMs and HMs might be associated with the cell morphology, multiple energy-converting systems, and Gibbs free energy from substrate-level phosphorylation.
Collapse
Affiliation(s)
- Zhongzhong Wang
- Civil Engineering, College of Science and Engineering, National University of Ireland, Galway, Ireland; Ryan Institute, National University of Ireland, Galway, Ireland; MaREI Center for Marine and Renewable Energy, National University of Ireland, Galway, Ireland
| | - Shun Wang
- Civil Engineering, College of Science and Engineering, National University of Ireland, Galway, Ireland; Ryan Institute, National University of Ireland, Galway, Ireland; MaREI Center for Marine and Renewable Energy, National University of Ireland, Galway, Ireland
| | - Yuansheng Hu
- Civil Engineering, College of Science and Engineering, National University of Ireland, Galway, Ireland; Ryan Institute, National University of Ireland, Galway, Ireland.
| | - Bang Du
- Civil Engineering, College of Science and Engineering, National University of Ireland, Galway, Ireland
| | - Jizhong Meng
- Civil Engineering, College of Science and Engineering, National University of Ireland, Galway, Ireland; Ryan Institute, National University of Ireland, Galway, Ireland
| | - Guangxue Wu
- Civil Engineering, College of Science and Engineering, National University of Ireland, Galway, Ireland
| | - He Liu
- Jiangsu Key Laboratory of Anaerobic Biotechnology, School of Environment and Civil Engineering, Jiangnan University, Wuxi 214122, Jiangsu Province, PR China
| | - Xinmin Zhan
- Civil Engineering, College of Science and Engineering, National University of Ireland, Galway, Ireland; Ryan Institute, National University of Ireland, Galway, Ireland; MaREI Center for Marine and Renewable Energy, National University of Ireland, Galway, Ireland.
| |
Collapse
|
13
|
Rossi A, Morlino MS, Gaspari M, Basile A, Kougias P, Treu L, Campanaro S. Analysis of the anaerobic digestion metagenome under environmental stresses stimulating prophage induction. MICROBIOME 2022; 10:125. [PMID: 35965344 PMCID: PMC9377139 DOI: 10.1186/s40168-022-01316-w] [Citation(s) in RCA: 7] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [MESH Headings] [Grants] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 03/17/2022] [Accepted: 06/25/2022] [Indexed: 06/15/2023]
Abstract
BACKGROUND The viral community has the potential to influence the structure of the microbiome and thus the yield of the anaerobic digestion process. However, the virome composition in anaerobic digestion is still under-investigated. A viral induction experiment was conducted on separate batches undergoing a series of DNA-damaging stresses, in order to coerce temperate viruses to enter the lytic cycle. RESULTS The sequencing of the metagenome revealed a viral community almost entirely composed of tailed bacteriophages of the order Caudovirales. Following a binning procedure 1,092 viral and 120 prokaryotic genomes were reconstructed, 64 of which included an integrated prophage in their sequence. Clustering of coverage profiles revealed the presence of species, both viral and microbial, sharing similar reactions to shocks. A group of viral genomes, which increase under organic overload and decrease under basic pH, uniquely encode the yopX gene, which is involved in the induction of temperate prophages. Moreover, the in-silico functional analysis revealed an enrichment of sialidases in viral genomes. These genes are associated with tail proteins and, as such, are hypothesised to be involved in the interaction with the host. Archaea registered the most pronounced changes in relation to shocks and featured behaviours not shared with other species. Subsequently, data from 123 different samples of the global anaerobic digestion database was used to determine coverage profiles of host and viral genomes on a broader scale. CONCLUSIONS Viruses are key components in anaerobic digestion environments, shaping the microbial guilds which drive the methanogenesis process. In turn, environmental conditions are pivotal in shaping the viral community and the rate of induction of temperate viruses. This study provides an initial insight into the complexity of the anaerobic digestion virome and its relation with the microbial community and the diverse environmental parameters. Video Abstract.
Collapse
Affiliation(s)
- Alessandro Rossi
- Department of Biology, University of Padua, via U. Bassi 58/b, 35131, Padova, Italy
| | - Maria Silvia Morlino
- Department of Biology, University of Padua, via U. Bassi 58/b, 35131, Padova, Italy
| | - Maria Gaspari
- Department of Hydraulics, Soil Science and Agricultural Engineering, Faculty of Agriculture, Aristotle University of Thessaloniki, GR-54124, Thessaloniki, Greece
| | - Arianna Basile
- Department of Biology, University of Padua, via U. Bassi 58/b, 35131, Padova, Italy
| | - Panagiotis Kougias
- Soil and Water Resources Institute, Hellenic Agricultural Organisation Demeter, Thermi, 57001, Thessaloniki, Greece
| | - Laura Treu
- Department of Biology, University of Padua, via U. Bassi 58/b, 35131, Padova, Italy.
| | - Stefano Campanaro
- Department of Biology, University of Padua, via U. Bassi 58/b, 35131, Padova, Italy
- CRIBI biotechnology center, University of Padua, via U. Bassi 58/b, 35131, Padova, Italy
| |
Collapse
|
14
|
Regulation of Dietary Protein Solubility Improves Ruminal Nitrogen Metabolism In Vitro: Role of Bacteria-Protozoa Interactions. Nutrients 2022; 14:nu14142972. [PMID: 35889928 PMCID: PMC9325197 DOI: 10.3390/nu14142972] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/27/2022] [Revised: 07/17/2022] [Accepted: 07/18/2022] [Indexed: 01/01/2023] Open
Abstract
Precision dietary interventions (e.g., altering proportions of dietary protein fractions) has significant implications for the efficiency of nutrient use in ruminants, as well as lowering their environmental footprint, specifically nitrogen (N) emissions. Soluble protein (SP) is defined as the protein fraction that is rapidly degraded in the rumen (e.g., non-protein N and true protein), and our previous study found that regulating SP levels could improve N efficiency in Hu sheep. Thus, the present study was conducted to explore in vitro how protein fractions with different SP levels modulate the rumen microbial community and its association with N metabolism. Four dietary treatments with different SP proportions and similar crude protein (CP) content (~14%) were formulated (% of CP): 20 (S20), 30 (S30), 40 (S40) and 50 (S50). Results showed that NH3-N content increased with increasing SP levels at 4, 12 and 24 h; TVFA, acetate, propionate and valerate were higher in S30 and S40 (p < 0.05) and had quadratic effects (p < 0.05). Moreover, dry matter digestibility (DMD) and N digestibility (ND) were all decreased with S20 and S50 (p < 0.05). The S30 and S40 treatments increased the abundance of Bacteroidetes and Prevotella (Prevotella_ruminicola) but decreased the abundance of Firmicutes and Proteobacteria (p < 0.05). Bacterial pathways related to amino acid and fatty acid metabolism also were enriched with S30 and S40. The abundance of Entodinium was increased with S30 and S40 and had a positive correlation with Prevotella, and these two genera also played an important role in N metabolism and VFA synthesis of this study. In conclusion, bacterial and protozoal communities were altered by the level of SP (% of CP), with higher SP levels (~50% of CP) increasing the microbial diversity but being detrimental to rumen N metabolism.
Collapse
|
15
|
Methane Production Potential from Apple Pomace, Cabbage Leaves, Pumpkin Residue and Walnut Husks. APPLIED SCIENCES-BASEL 2022. [DOI: 10.3390/app12126128] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 02/06/2023]
Abstract
Circular economy aims to eliminate organic waste through its transformation, composting and processing into other products or energy. The main aim of the study was to determine the specific methane yield (SMY) of anaerobic digestion (AD) of four different fruit and vegetable residues (FVR). In addition, the reduction in greenhouse gas (GHG) emissions was calculated based on the assumption that maize will be replaced by the FVR as a feedstock for biogas production. The SMY of four residues (apple pomace, cabbage leaves, pumpkin peels and fibrous strands and walnut husks) was measured in the biomethane potential test (BMP) in wet anaerobic digestion technology. The highest SMY (297.81 ± 0.65 NL kgVS−1) was observed for cabbage leaves while the lowest SMY (131.07 ± 1.30 kgVS−1) was found for walnut husks. The concentrations of two inhibitory gasses (NH3 and H2S) in biogas were low and did not affect the AD process. Only biogas produced from cabbage leaves was characterised by higher NH3 and H2S concentrations resulting from the highest protein concentration in this waste. FVR used as feedstock in biogas production may decrease the area of maize cultivation. Therefore, the GHG emissions from maize cultivation will be reduced. In Poland only, the use of four studied FVR as feedstock for biogas production would contribute to the reduction of GHG emissions by 43,682 t CO2 eq.
Collapse
|
16
|
Biological Aspects, Advancements and Techno-Economical Evaluation of Biological Methanation for the Recycling and Valorization of CO2. ENERGIES 2022. [DOI: 10.3390/en15114064] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 02/04/2023]
Abstract
Nowadays, sustainable and renewable energy production is a global priority. Over the past decade, several Power-to-X (PtX) technologies have been proposed to store and convert the surplus of renewable energies into chemical bonds of chemicals produced by different processes. CO2 is a major contributor to climate change, yet it is also an undervalued source of carbon that could be recycled and represents an opportunity to generate renewable energy. In this context, PtX technologies would allow for CO2 valorization into renewable fuels while reducing greenhouse gas (GHG) emissions. With this work we want to provide an up-to-date overview of biomethanation as a PtX technology by considering the biological aspects and the main parameters affecting its application and scalability at an industrial level. Particular attention will be paid to the concept of CO2-streams valorization and to the integration of the process with renewable energies. Aspects related to new promising technologies such as in situ, ex situ, hybrid biomethanation and the concept of underground methanation will be discussed, also in connection with recent application cases. Furthermore, the technical and economic feasibility will be critically analyzed to highlight current options and limitations for implementing a sustainable process.
Collapse
|
17
|
Cai Y, Janke L, Meng X, Zheng Z, Zhao X, Pröter J, Schäfer F. The absolute concentration and bioavailability of trace elements: Two vital parameters affecting anaerobic digestion performance of chicken manure leachate. BIORESOURCE TECHNOLOGY 2022; 350:126909. [PMID: 35227919 DOI: 10.1016/j.biortech.2022.126909] [Citation(s) in RCA: 8] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/03/2022] [Revised: 02/19/2022] [Accepted: 02/22/2022] [Indexed: 06/14/2023]
Abstract
It is currently unclear whether trace elements (TEs) deficiency is due to low bioavailability or low absolute TEs concentrations, especially in high-pH anaerobic digestion (AD) systems. A mixed solution of TEs and EDTA-Na2 were used separately in mono-AD of chicken manure (CM) leachate to investigate this research gap. The results showed relatively low bioavailability of Fe, Mn, and Zn. The bioavailability of all TEs remained stable along with a gradual increase in total ammonia nitrogen concentration. Both TE and EDTA-Na2 supplementation improved the bioavailability of TEs, but TEs supplementation also gave a high proportion of soluble TEs. Adding TEs improved methane production efficiency (+38.3%) and decreased the H2S content. The exchangeable fraction of specific TE (Mo) in H2/CO2 pathway was higher in the TEs treatment. TEs bioavailability and absolute concentrations of available TEs are critical aspects that need to be scrutinized to assess the risk of TEs deficiency.
Collapse
Affiliation(s)
- Yafan Cai
- School of Chemical Engineering, Zhengzhou University, Kexue Dadao 100, 450001 Zhengzhou, PR China; Department of Biochemical Conversion, Deutsches Biomassforschungszentrum gemeinnützige GmbH, Torgauer Straße116, 04347 Leipzig, Germany.
| | - Leandro Janke
- Department of Biochemical Conversion, Deutsches Biomassforschungszentrum gemeinnützige GmbH, Torgauer Straße116, 04347 Leipzig, Germany; Department of Energy and Technology, Swedish University of Agricultural Sciences, Box 7032, 750 07 Uppsala, Sweden
| | - Xingyao Meng
- Beijing Technology and Business University, State Environmental Protection Key Laboratory of Food Chain Pollution Control, Beijing 100048, PR China
| | - Zehui Zheng
- College of Agronomy and Biotechnology/Biomass Engineering Center, China Agricultural University, Beijing 100193, PR China
| | - Xiaoling Zhao
- School of Chemical Engineering, Zhengzhou University, Kexue Dadao 100, 450001 Zhengzhou, PR China
| | - Jürgen Pröter
- Department of Biochemical Conversion, Deutsches Biomassforschungszentrum gemeinnützige GmbH, Torgauer Straße116, 04347 Leipzig, Germany
| | - Franziska Schäfer
- Department of Biochemical Conversion, Deutsches Biomassforschungszentrum gemeinnützige GmbH, Torgauer Straße116, 04347 Leipzig, Germany.
| |
Collapse
|
18
|
Yan Y, Yan M, Ravenni G, Angelidaki I, Fu D, Fotidis IA. Novel bioaugmentation strategy boosted with biochar to alleviate ammonia toxicity in continuous biomethanation. BIORESOURCE TECHNOLOGY 2022; 343:126146. [PMID: 34673199 DOI: 10.1016/j.biortech.2021.126146] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/23/2021] [Revised: 09/06/2021] [Accepted: 09/08/2021] [Indexed: 06/13/2023]
Abstract
This study investigated for the first time if ammonia tolerant methanogenic consortia can be stored in gel (biogel) and used in a later time on-demand as bioaugmentation inocula, to efficiently relieve ammonia inhibition in continuous biomethanation systems. Moreover, wood biochar was assessed as a potential enhancer of the novel biogel bioaugmentation process. Three thermophilic (55 °C), continuous stirred-tank reactors (RBgel, RChar and RMix), operated at 4.5 g NH4+-N L-1 were exposed to biogel, biochar and mixture of biogel and biochar, respectively, while a fourth reactor (RCtrl) was used as control. The results showed that the methane production yields of RMix, RChar and RBgel increased by 28.6%, 20.2% and 10.7%, respectively compared to RCtrl. The highest methane yield was achieved by the synergistic interaction between biogel and biochar. Additionally, biogel stimulated a rapid recovery of Methanoculleus thermophilus sp. and syntrophic acetate oxidising bacteria populations.
Collapse
Affiliation(s)
- Yixin Yan
- School of Civil Engineering Southeast University, 210096, Nanjing, China; Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800, Kgs. Lyngby, Denmark
| | - Miao Yan
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800, Kgs. Lyngby, Denmark; NUS Environmental Research Institute, National University of Singapore, 1 Create Way, 138602, Singapore
| | - Giulia Ravenni
- Department of Chemical and Biochemical Engineering, Technical University of Denmark, Building 313, 4000, Roskilde, Denmark
| | - Irini Angelidaki
- Department of Chemical and Biochemical Engineering, Technical University of Denmark, Kgs. Lyngby, Denmark
| | - Dafang Fu
- School of Civil Engineering Southeast University, 210096, Nanjing, China
| | - Ioannis A Fotidis
- School of Civil Engineering Southeast University, 210096, Nanjing, China; Faculty of Engineering and Natural Sciences, Tampere University, Tampere, Finland; Faculty of Environment, Ionian University, 29100, Zakynthos, Greece.
| |
Collapse
|
19
|
Kim GB, Cayetano RDA, Park J, Jo Y, Jeong SY, Lee MY, Kim SH. Effect of low-thermal pretreatment on the methanogenic performance and microbiome population of continuous high-solid anaerobic digester treating dewatered sludge. BIORESOURCE TECHNOLOGY 2021; 341:125756. [PMID: 34419881 DOI: 10.1016/j.biortech.2021.125756] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/29/2021] [Revised: 08/06/2021] [Accepted: 08/08/2021] [Indexed: 06/13/2023]
Abstract
Undigested and dewatered sludge at 10% total solids was pretreated at 60 °C for 3 h and fed to a lab-scale horizontal anaerobic bioreactor for 130 days with solids retention time (SRTs) from 25 to 16 d. The low-thermal pretreatment enabled higher net energy production, improved sludge treatment efficiency, and enhanced digestion stability. The highest average biomethane yield and production rate were 138.5 mL/g VS and 0.43 L/L.d, respectively, and the economic benefit was expected to be the maximum at SRT 16 d. Pretreatment did not increase the specific methanogenic activity per unit methanogen, but resulted in higher abundance of methanogenic archaea and hydrolytic bacteria. Methanogenic population shifted from hydrogenotrophic to acetoclastic, consistent with predicted gene expression at SRT equal or below 20 d. Anaerobic digestion along with low-thermal could be a feasible management strategy for undigested dewatered sludge from small WWTPs.
Collapse
Affiliation(s)
- Gi-Beom Kim
- School of Civil and Environmental Engineering, Yonsei University, Seoul 03722, Republic of Korea
| | - Roent Dune A Cayetano
- School of Civil and Environmental Engineering, Yonsei University, Seoul 03722, Republic of Korea
| | - Jungsu Park
- School of Civil and Environmental Engineering, Yonsei University, Seoul 03722, Republic of Korea
| | - Yura Jo
- School of Civil and Environmental Engineering, Yonsei University, Seoul 03722, Republic of Korea
| | - Seong Yeob Jeong
- Environment N Energy O&M Inc, Gyeonggi-do 17970, Republic of Korea
| | - Myung Yeol Lee
- Environment N Energy O&M Inc, Gyeonggi-do 17970, Republic of Korea
| | - Sang-Hyoun Kim
- School of Civil and Environmental Engineering, Yonsei University, Seoul 03722, Republic of Korea.
| |
Collapse
|
20
|
Cieciura-Włoch W, Borowski S, Domański J. Dark fermentative hydrogen production from hydrolyzed sugar beet pulp improved by nitrogen and phosphorus supplementation. BIORESOURCE TECHNOLOGY 2021; 340:125622. [PMID: 34365303 DOI: 10.1016/j.biortech.2021.125622] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/20/2021] [Revised: 07/14/2021] [Accepted: 07/16/2021] [Indexed: 06/13/2023]
Abstract
The effect of nitrogen and phosphorous addition on hydrogen production from hydrolyzed Sugar beet pulp (SBP) was investigated using (NH4)3PO4, NH4Cl and K3PO4 as the supplements. In batch tests, the maximal hydrogen production of 279 dm3/kgVS was observed for K3PO4, which was added to SBP in a dose of 1 g/dm3. In semi-continuous experiments, the greatest hydrogen production of 36 dm3/kgVS was reported for the same supplement, and this value was twice higher than that of the control run. The analysis of microbiota revealed that the majority of bacteria was affiliated to the orders Clostridiales, Lactobacillales and Coriobacteriales. Moreover, a noticeable methane production was associated with the activity of Methanosphaera sp., which could grow in a low pH environment of dark fermentation.
Collapse
Affiliation(s)
- Weronika Cieciura-Włoch
- Department of Environmental Biotechnology, Faculty of Biotechnology and Food Science, Lodz University of Technology, Wolczanska 171/173, 90-924 Lodz, Poland.
| | - Sebastian Borowski
- Department of Environmental Biotechnology, Faculty of Biotechnology and Food Science, Lodz University of Technology, Wolczanska 171/173, 90-924 Lodz, Poland.
| | - Jarosław Domański
- Department of Environmental Biotechnology, Faculty of Biotechnology and Food Science, Lodz University of Technology, Wolczanska 171/173, 90-924 Lodz, Poland.
| |
Collapse
|
21
|
Cai Y, Gallegos D, Zheng Z, Stinner W, Wang X, Pröter J, Schäfer F. Exploring the combined effect of total ammonia nitrogen, pH and temperature on anaerobic digestion of chicken manure using response surface methodology and two kinetic models. BIORESOURCE TECHNOLOGY 2021; 337:125328. [PMID: 34120063 DOI: 10.1016/j.biortech.2021.125328] [Citation(s) in RCA: 13] [Impact Index Per Article: 4.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/30/2021] [Revised: 05/19/2021] [Accepted: 05/21/2021] [Indexed: 06/12/2023]
Abstract
Ammonia inhibition is the most challenging issue in the anaerobic digestion (AD) of nitrogen-rich substrates. Total ammonia nitrogen (TAN) concentration, temperature and pH are the main operational parameters affecting the chemical equilibrium between free ammonium nitrogen (NH3; FAN) and ammonium ions (NH4+). However, it is still unclear how these parameters together affect digestion performance by influencing this equilibrium. To determine the effect and linkages of these parameters, a Box-Behnken design-response surface methodology (RSM), correlation analysis and two kinetic models were carried out. The results revealed that the linear effect of TAN, the interaction effect between TAN and temperature, and temperature and pH were significant, however, the quadratic effect of TAN, temperature and pH were also significant. Furthermore, TAN and temperature were positively correlated with Mmax, k and Rmax. Findings from this study could provide a theoretical basis to develop the way of relieving ammonia inhibition.
Collapse
Affiliation(s)
- Yafan Cai
- Department of Biochemical Conversion, Deutsches Biomassforschungszentrum Gemeinnützige GmbH, Torgauer Straße116, 04347 Leipzig, Germany; School of Chemical Engineering, Zhengzhou University, Kexue Dadao 100, 450001 Zhengzhou, China; College of Agronomy and Biotechnology/Biomass Engineering Center, China Agricultural University, Beijing 100193, China
| | - Daniela Gallegos
- Department of Biochemical Conversion, Deutsches Biomassforschungszentrum Gemeinnützige GmbH, Torgauer Straße116, 04347 Leipzig, Germany
| | - Zehui Zheng
- College of Agronomy and Biotechnology/Biomass Engineering Center, China Agricultural University, Beijing 100193, China
| | - Walter Stinner
- Department of Biochemical Conversion, Deutsches Biomassforschungszentrum Gemeinnützige GmbH, Torgauer Straße116, 04347 Leipzig, Germany; Sino-German Biomass Research Center Anhui (C-DBFZ Anhui), Hefei University, Jinxiu Dadao 99, 230601 Hefei, PR China
| | - Xiaofen Wang
- College of Agronomy and Biotechnology/Biomass Engineering Center, China Agricultural University, Beijing 100193, China
| | - Jürgen Pröter
- Department of Biochemical Conversion, Deutsches Biomassforschungszentrum Gemeinnützige GmbH, Torgauer Straße116, 04347 Leipzig, Germany
| | - Franziska Schäfer
- Department of Biochemical Conversion, Deutsches Biomassforschungszentrum Gemeinnützige GmbH, Torgauer Straße116, 04347 Leipzig, Germany.
| |
Collapse
|
22
|
Yan M, Zhu X, Treu L, Ravenni G, Campanaro S, Goonesekera EM, Ferrigno R, Jacobsen CS, Zervas A, Angelidaki I, Fotidis IA. Comprehensive evaluation of different strategies to recover methanogenic performance in ammonia-stressed reactors. BIORESOURCE TECHNOLOGY 2021; 336:125329. [PMID: 34052546 DOI: 10.1016/j.biortech.2021.125329] [Citation(s) in RCA: 15] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/21/2021] [Revised: 05/20/2021] [Accepted: 05/21/2021] [Indexed: 06/12/2023]
Abstract
In this study, strategies for recovery of ammonia-stressed AD reactors were attempted, by addition of preserved bioaugmentation consortium in gel (BioG), fresh consortium in liquid medium (BioL), woodchip biochar (BW), and straw biochar (BS). In comparison to control group with ammonia, effective treatments, i.e., BioG, BioL, BW and BS raised the maximum methane production rate by 77%, 23%, 35%, and 24%, respectively. BW possibly acted as interspecies electrical conduits for Direct Electron Transfer based on conductivity and SEM analysis. BioG facilitated slow release of bioaugmentation inocula from gel into the AD system, which protected them from a direct environmental shock. According to microbial analysis, both BioG, BioL and BW resulted in increased relative abundance of Methanothermobacter thermautotrophicus; and BS induced selective raise of Methanosarcina thermophila. The increase of methanogens via these strategies led to the faster recovery of the AD process.
Collapse
Affiliation(s)
- Miao Yan
- Department of Environmental Engineering, Technical University of Denmark, Building 115, Kgs. Lyngby DK-2800, Denmark
| | - Xinyu Zhu
- Department of Chemical and Biochemical Engineering, Technical University of Denmark, Building 227, Kgs. Lyngby DK-2800, Denmark
| | - Laura Treu
- Department of Biology, University of Padova, Via U. Bassi 58/b, Padova 35121, Italy
| | - Giulia Ravenni
- Department of Chemical and Biochemical Engineering, Technical University of Denmark, Building 313, Roskilde 4000, Denmark
| | - Stefano Campanaro
- Department of Biology, University of Padova, Via U. Bassi 58/b, Padova 35121, Italy
| | - Estelle Maria Goonesekera
- Department of Environmental Engineering, Technical University of Denmark, Building 115, Kgs. Lyngby DK-2800, Denmark
| | - Rosa Ferrigno
- Department of Environmental Engineering, Technical University of Denmark, Building 115, Kgs. Lyngby DK-2800, Denmark
| | - Carsten S Jacobsen
- Department of Environmental Science, Aarhus University, Frederiksborgvej 399, Roskilde DK-4000, Denmark
| | - Athanasios Zervas
- Department of Environmental Science, Aarhus University, Frederiksborgvej 399, Roskilde DK-4000, Denmark
| | - Irini Angelidaki
- Department of Chemical and Biochemical Engineering, Technical University of Denmark, Building 227, Kgs. Lyngby DK-2800, Denmark
| | - Ioannis A Fotidis
- Department of Environmental Engineering, Technical University of Denmark, Building 115, Kgs. Lyngby DK-2800, Denmark; Faculty of Engineering and Natural Sciences, Tampere University, Tampere, Finland; School of Civil Engineering Southeast University Nanjing, 210096, China.
| |
Collapse
|
23
|
Lee J, Kim E, Hwang S. Effects of inhibitions by sodium ion and ammonia and different inocula on acetate-utilizing methanogenesis: Methanogenic activity and succession of methanogens. BIORESOURCE TECHNOLOGY 2021; 334:125202. [PMID: 33957457 DOI: 10.1016/j.biortech.2021.125202] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/31/2021] [Revised: 04/15/2021] [Accepted: 04/16/2021] [Indexed: 06/12/2023]
Abstract
Acetate-fed anaerobic sequential batch experiments with four different inhibitory conditions (non-inhibitory (Lo), sodium-ion inhibitory (Na), ammonia inhibitory (Am), combined inhibitory (Hi)) were conducted using thirteen different inocula to investigate the inhibition effects by sodium-ion and ammonia and different inocula on acetate-utilizing methanogenesis and succession of methanogens. Sodium-ion and ammonia significantly extended lag-time λ and reduced specific-methanogenic-activity RCH4, and caused synergistic inhibition. The inhibition differed according to the initial methanogen community structures: the inhibition effects on λ and RCH4 were strongest ininocula with Methanosaeta concilii dominant and weakest in inocula with Methanoculleus bourgensis dominant. These inhibitory conditions determined the succession of methanogens: the most competitive methanogens were Methanosaeta concilii in Lo, Methanosarcina sp. in Na, Methanosarcina sp. and Methanoculleus bourgensis in Am, Methanoculleus bourgensis in Hi. This study provides valuable information for microbial management and optimization for AD processes treating wastewater that is rich in protein and/or salt.
Collapse
Affiliation(s)
- Joonyeob Lee
- Department of Environmental Engineering, Pukyong National University, Busan 48513, Republic of Korea
| | - Eunji Kim
- Division of Environmental Science and Engineering, Pohang University of Science and Technology, Pohang, Gyeongbuk 37673, Republic of Korea
| | - Seokhwan Hwang
- Division of Environmental Science and Engineering, Pohang University of Science and Technology, Pohang, Gyeongbuk 37673, Republic of Korea.
| |
Collapse
|
24
|
Dalby FR, Hafner SD, Petersen SO, VanderZaag AC, Habtewold J, Dunfield K, Chantigny MH, Sommer SG. Understanding methane emission from stored animal manure: A review to guide model development. JOURNAL OF ENVIRONMENTAL QUALITY 2021; 50:817-835. [PMID: 34021608 DOI: 10.1002/jeq2.20252] [Citation(s) in RCA: 14] [Impact Index Per Article: 4.7] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/26/2020] [Accepted: 05/14/2021] [Indexed: 06/12/2023]
Abstract
National inventories of methane (CH4 ) emission from manure management are based on guidelines from the Intergovernmental Panel on Climate Change using country-specific emission factors. These calculations must be simple and, consequently, the effects of management practices and environmental conditions are only crudely represented in the calculations. The intention of this review is to develop a detailed understanding necessary for developing accurate models for calculating CH4 emission from liquid manure, with particular focus on the microbiological conversion of organic matter to CH4 . Themes discussed are (a) the liquid manure environment; (b) methane production processes from a modeling perspective; (c) development and adaptation of methanogenic communities; (d) mass and electron conservation; (e) steps limiting CH4 production; (f) inhibition of methanogens; (g) temperature effects on CH4 production; and (h) limits of existing estimation approaches. We conclude that a model must include calculation of microbial response to variations in manure temperature, substrate availability and age, and management system, because these variables substantially affect CH4 production. Methane production can be reduced by manipulating key variables through management procedures, and the effects may be taken into account by including a microbial component in the model. When developing new calculation procedures, it is important to include reasonably accurate algorithms of microbial adaptation. This review presents concepts for these calculations and ideas for how these may be carried out. A need for better quantification of hydrolysis kinetics is identified, and the importance of short- and long-term microbial adaptation is highlighted.
Collapse
Affiliation(s)
- Frederik R Dalby
- Dep. of Biological and Chemical Engineering, Aarhus Univ., Aarhus, 8200, Denmark
| | - Sasha D Hafner
- Dep. of Biological and Chemical Engineering, Aarhus Univ., Aarhus, 8200, Denmark
- Hafner Consulting LLC, Reston, VA, 20191, USA
| | | | - Andrew C VanderZaag
- Ottawa Research and Development Ctr., Agriculture and Agri-Food Canada, Ottawa, ON, K1A 0C6, Canada
| | - Jemaneh Habtewold
- Ottawa Research and Development Ctr., Agriculture and Agri-Food Canada, Ottawa, ON, K1A 0C6, Canada
| | - Kari Dunfield
- School of Environmental Science, Univ. of Guelph, Guelph, ON, N1G 2W1, Canada
| | - Martin H Chantigny
- Quebec Research and Development Ctr., Agriculture and Agri-Food Canada, Quebec, QC, G1V 2J3, Canada
| | - Sven G Sommer
- Dep. of Biological and Chemical Engineering, Aarhus Univ., Aarhus, 8200, Denmark
| |
Collapse
|
25
|
Cai C, Li L, Hua Y, Liu H, Dai X. Ferroferric oxide promotes metabolism in Anaerolineae other than microbial syntrophy in anaerobic methanogenesis of antibiotic fermentation residue. THE SCIENCE OF THE TOTAL ENVIRONMENT 2021; 758:143601. [PMID: 33261864 DOI: 10.1016/j.scitotenv.2020.143601] [Citation(s) in RCA: 17] [Impact Index Per Article: 5.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/18/2020] [Revised: 10/28/2020] [Accepted: 10/31/2020] [Indexed: 06/12/2023]
Abstract
Antibiotic fermentation residue (AFR) is a kind of protein-rich biosolids that would be utilized as valuable substrates for biogas production. However, the effectiveness of conductive material supplementation and its effect on the microbiome in anaerobic digestion of AFR have not been fully elucidated. The objective of this study is to access the impact of Fe3O4 addition on anaerobic digestion of AFR and reveal its microbial mechanism. By adding Fe3O4 at concentration of 150 mg/gTS to two typical AFRs, the methane yield was decreased while the methane production rate was significantly enhanced by 48% and 21%, respectively. Genomic analyses revealed that the Fe3O4 addition altered the microbial community by selecting the unknown genus of Anaerolineae with the metabolic capacity of carbohydrate hydrolysis and proteolysis. Meanwhile, the hydrogenotrophic methanogenesis was the dominant pathway in the AFR digestion system, which was mostly contributed by the Methanoculleus and Methanolinea. More interestingly, Methanoculleus might possess fermentative capability involved in the versatile hydrolysis pathway. Although the genes related to electrically conductive pili were detected, the induction of direct interspecies electron transfer by Fe3O4 supplementation was not confirmed in this study. In summary, except the accelerated methane production rate, Fe3O4 addition functioned as biostimulator for Anaerolineae other than electron conduit in anaerobic methanogenesis in the AFR digestion system.
Collapse
Affiliation(s)
- Chen Cai
- State Key Laboratory of Pollution Control and Resources Reuse, College of Environmental Science and Engineering, Tongji University, Shanghai 200092, China
| | - Lei Li
- State Key Laboratory of Pollution Control and Resources Reuse, College of Environmental Science and Engineering, Tongji University, Shanghai 200092, China
| | - Yu Hua
- State Key Laboratory of Pollution Control and Resources Reuse, College of Environmental Science and Engineering, Tongji University, Shanghai 200092, China
| | - Huiling Liu
- State Key Laboratory of Pollution Control and Resources Reuse, College of Environmental Science and Engineering, Tongji University, Shanghai 200092, China
| | - Xiaohu Dai
- State Key Laboratory of Pollution Control and Resources Reuse, College of Environmental Science and Engineering, Tongji University, Shanghai 200092, China.
| |
Collapse
|
26
|
Niu J, Feng Y, Wang N, Liu S, Liang Y, Liu J, He W. Effects of high ammonia loading and in-situ short-cut nitrification in low carbon‑nitrogen ratio wastewater treatment by biocathode microbial electrochemical system. THE SCIENCE OF THE TOTAL ENVIRONMENT 2021; 755:142641. [PMID: 33049541 DOI: 10.1016/j.scitotenv.2020.142641] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/03/2020] [Revised: 09/20/2020] [Accepted: 09/25/2020] [Indexed: 06/11/2023]
Abstract
The microbial electrochemical system (MES) has great advantages in wastewater treatment for rapid chemical oxygen demand (COD) removal and low sludge yield rate. Herein, biocathode MES was proposed to remove COD from high-ammonia wastewater with low carbon‑nitrogen ratio and regulate the nitrogen forms in effluent for ANAMMOX process. The biocathode was more sensitive to ammonia nitrogen (NH4+-N) than anode and determined the power generation of MES. With COD of 500-550 mg L-1 in influent, increasing NH4+-N from 50 to 150 mg L-1 improved maximum power output (Pmax) from 3.0 ± 0.2 to 3.4 ± 0.1 W m-3, which was then reduced with further increase of NH4+-N from 300 to 600 mg L-1. However, for the cathodic reductive current, the negative effects of ammonia only revealed with NH4+-N ≥ 450 mg L-1. The cathodic equilibrium potential drop determined the power degradation, because the increased reductive compounds (NH4+ and COD) in catholyte. The high NH4+-N reduced the abundance of denitrifiers, exoelectrogens and organic-degrading bacteria on electrodes, while that of nitrogen-fixing bacteria increased. External alkalinity addition achieved in-situ short-cut nitrification and nitrite accumulation. With comparable NH4+ and NO2-, limited NO3- and low COD, the biocathode MES effluent was then suitable for subsequence ANAMMOX process.
Collapse
Affiliation(s)
- Jiaojiao Niu
- School of Environmental Science and Engineering, Academy of Ecology and Environment, Tianjin University, No. 92 Weijin Road, Nankai District, Tianjin 300072, China
| | - Yujie Feng
- School of Environmental Science and Engineering, Academy of Ecology and Environment, Tianjin University, No. 92 Weijin Road, Nankai District, Tianjin 300072, China
| | - Naiyu Wang
- School of Environmental Science and Engineering, Academy of Ecology and Environment, Tianjin University, No. 92 Weijin Road, Nankai District, Tianjin 300072, China
| | - Shujuan Liu
- School of Environmental Science and Engineering, Academy of Ecology and Environment, Tianjin University, No. 92 Weijin Road, Nankai District, Tianjin 300072, China
| | - Yuhai Liang
- College of Natural Resources and Environment, South China Agricultural University, Guangzhou 510642, China
| | - Jia Liu
- School of Environmental Science and Engineering, Academy of Ecology and Environment, Tianjin University, No. 92 Weijin Road, Nankai District, Tianjin 300072, China
| | - Weihua He
- School of Environmental Science and Engineering, Academy of Ecology and Environment, Tianjin University, No. 92 Weijin Road, Nankai District, Tianjin 300072, China.
| |
Collapse
|
27
|
Schneider C, Evangelio Oñoro A, Hélix-Nielsen C, Fotidis IA. Forward-osmosis anaerobic-membrane bioreactors for brewery wastewater remediation. Sep Purif Technol 2021. [DOI: 10.1016/j.seppur.2020.117786] [Citation(s) in RCA: 9] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/18/2022]
|
28
|
Letelier-Gordo CO, Mancini E, Pedersen PB, Angelidaki I, Fotidis IA. Saline fish wastewater in biogas plants - Biomethanation toxicity and safe use. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2020; 275:111233. [PMID: 32827897 DOI: 10.1016/j.jenvman.2020.111233] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/22/2020] [Revised: 06/29/2020] [Accepted: 08/12/2020] [Indexed: 06/11/2023]
Abstract
Increasing marine land-based recirculating aquaculture systems (RAS) and stricter environmental regulations, pose new challenges to the aquaculture industry on how to treat and dispose saline fish wastewater. The fish wastewater could be incorporated into biogas reactors, but currently, the effects of salinity on the biomethanation process are poorly known. This study aimed to assess the toxicity of fish wastewater with different salinities on the biomethanation process and to propose optimum co-digestion scenarios for maximal methane potential and safe use in biogas plants. Results showed that, depending on salinity and organic content, it is possible to efficiently co-digest from 3.22 to 61.85% fish wastewater (v/v, wastewater/manure) and improve the maximum methane production rate from 2.72 to 61.85%, respectively compared to cow manure mono-digestion. Additionally, salinity was identified as the main inhibitor of biomethanation process with a half-maximal inhibitory concentration (IC50) of 4.37 g L-1, while sulphate reduction was identified as a secondary inhibitor.
Collapse
Affiliation(s)
- Carlos O Letelier-Gordo
- National Institute of Aquatic Resources, Section for Aquaculture, North Sea Research Centre, Technical University of Denmark, DK-9850, Hirtshals, Denmark
| | - Enrico Mancini
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800, Kgs. Lyngby, Denmark
| | - Per Bovbjerg Pedersen
- National Institute of Aquatic Resources, Section for Aquaculture, North Sea Research Centre, Technical University of Denmark, DK-9850, Hirtshals, Denmark
| | - Irini Angelidaki
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800, Kgs. Lyngby, Denmark
| | - Ioannis A Fotidis
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800, Kgs. Lyngby, Denmark; School of Civil Engineering Southeast University Nanjing, 210096, China.
| |
Collapse
|
29
|
Ting HNJ, Lin L, Cruz RB, Chowdhury B, Karidio I, Zaman H, Dhar BR. Transitions of microbial communities in the solid and liquid phases during high-solids anaerobic digestion of organic fraction of municipal solid waste. BIORESOURCE TECHNOLOGY 2020; 317:123951. [PMID: 32822895 DOI: 10.1016/j.biortech.2020.123951] [Citation(s) in RCA: 11] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/26/2020] [Revised: 07/28/2020] [Accepted: 07/31/2020] [Indexed: 06/11/2023]
Abstract
This study presents a microbiological diagnosis of a mesophilic high-solids anaerobic digestion (HSAD) system with percolate recirculation. The results demonstrated a significant decrease in microbial diversity in both the solid digestate and the liquid percolate. Also, the digestate from the top and middle sections of the digester had similar diversity, whereas the digestate from the bottom of the tank had a slightly lower diversity. These results suggest that despite percolate recirculation, substrate gradients might have developed across the system. Archaeal communities showed shifts towards known hydrogenotrophic and ammonia-tolerant methanogens (genera Methanocelleus, Methanolinea, Methanosarcina, vadin CA11, etc.), which was a consequence of decreased volatile fatty acids and increased ammonia-nitrogen levels over time. Compared to initial solid and liquid inoculum, the relative abundances of some bacteria (phyla Proteobacteria and Firmicutes) and archaea of the genus Methanosarcina changed between two phases in the opposite direction, indicating a shift of microbes between two phases.
Collapse
Affiliation(s)
- Hok Nam Joey Ting
- Civil and Environmental Engineering, University of Alberta, Edmonton, AB, Canada
| | - Long Lin
- Civil and Environmental Engineering, University of Alberta, Edmonton, AB, Canada
| | - Raul Bello Cruz
- Civil and Environmental Engineering, University of Alberta, Edmonton, AB, Canada
| | - Bappi Chowdhury
- Civil and Environmental Engineering, University of Alberta, Edmonton, AB, Canada
| | - Ibrahim Karidio
- Edmonton Waste Management Centre, City of Edmonton, Edmonton, AB, Canada
| | - Hamid Zaman
- Civil and Environmental Engineering, University of Alberta, Edmonton, AB, Canada; Edmonton Waste Management Centre, City of Edmonton, Edmonton, AB, Canada
| | - Bipro Ranjan Dhar
- Civil and Environmental Engineering, University of Alberta, Edmonton, AB, Canada.
| |
Collapse
|
30
|
Ali M, Yue D. Population dynamics of microbial species under high and low ammonia nitrogen in the alternate layer bioreactor landfill (ALBL) approach. BIORESOURCE TECHNOLOGY 2020; 315:123787. [PMID: 32673982 DOI: 10.1016/j.biortech.2020.123787] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/06/2020] [Revised: 06/28/2020] [Accepted: 07/01/2020] [Indexed: 06/11/2023]
Abstract
Anaerobic landfill process is still believed to be a complex ecosystem due to the lack of knowledge on the functional activities of microbial species. This research sought to introduce a novel landfill bioreactor, named here as the alternate layer bioreactor landfill (ALBL) of fresh MSW (FW) and stabilized waste (CT) to avoid inhibitory conditions for the microbial species in anaerobic landfill. The stabilized waste layer in the bottom of landfill cell significantly changed microbial ecology of fresh MSW which in turn reduced the concentrations of NH4-N (29-31%) and VFAs (33-38%) in the ALBL approach, compared to fresh MSW disposal in sanitary landfill. The reduction of NH4-N favored early onset of methanogenesis within 6 weeks and methane (CH4) content of landfill gas increased from 11% to 40-50% (v/v), owing to the coexistence of Methanosarcinales (36-50%) and Methanomicrobiales (26-28%) archaea. The acetoclastic methanogenesis was achieved by reducing NH4-N toxicity in the ALBL.
Collapse
Affiliation(s)
- Munawar Ali
- School of Environment, Tsinghua University, Beijing 100084, China
| | - Dongbei Yue
- School of Environment, Tsinghua University, Beijing 100084, China.
| |
Collapse
|
31
|
Swine manure valorization in fabrication of nutrition and energy. Appl Microbiol Biotechnol 2020; 104:9921-9933. [PMID: 33074416 DOI: 10.1007/s00253-020-10963-8] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/24/2020] [Revised: 10/08/2020] [Accepted: 10/12/2020] [Indexed: 12/11/2022]
Abstract
Renewable energy can boost the growing population's need and rapid budgetary development. To reduce fossil fuel consumption is the initial purpose of renewable and sustainable energy, producing valuable bio-based products. The fermenters, using for pretreatment of swine manure, and involvement of swine carcasses are reported to enhance organic loading rate followed by improved biogas yield on household digesters. The compositions such as animal residues, pathogenic microbes, pharmaceutical residues and nutrient compositions including undigested feed are still confused. Therefore, it is mandatory to optimize and stabilize anaerobic practice and digestate filtration purification for consequential fertilizer consumption. The effective bio-methane recovery from energy-rich compounds is challenging due to slow degradation procedures. The pretreatment procedure could enhance lipid depolymerization and improve anaerobic fermentation. This article deeply focuses on biodegradation of swine manure. The components of this manure were evaluated and established several approaches to improve biogas production. Furthermore, recycling of co-digestates was discussed in detail as fertilizer consumption including hygienic aspects of manure and pretreatment strategies of biomass residues. KEY POINTS: • Co-digestion of manure and carcasses enhance bio-methane production. • Removel of ammonia from biogas digester may improve bio-methane gas. • A strong antimicrobial influence has been reported on biogas production.
Collapse
|
32
|
Yan M, Treu L, Zhu X, Tian H, Basile A, Fotidis IA, Campanaro S, Angelidaki I. Insights into Ammonia Adaptation and Methanogenic Precursor Oxidation by Genome-Centric Analysis. ENVIRONMENTAL SCIENCE & TECHNOLOGY 2020; 54:12568-12582. [PMID: 32852203 PMCID: PMC8154354 DOI: 10.1021/acs.est.0c01945] [Citation(s) in RCA: 38] [Impact Index Per Article: 9.5] [Reference Citation Analysis] [Abstract] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/28/2020] [Revised: 08/22/2020] [Accepted: 08/27/2020] [Indexed: 05/04/2023]
Abstract
Ammonia released from the degradation of protein and/or urea usually leads to suboptimal anaerobic digestion (AD) when N-rich organic waste is used. However, the insights behind the differential ammonia tolerance of anaerobic microbiomes remain an enigma. In this study, the cultivation in synthetic medium with different carbon sources (acetate, methanol, formate, and H2/CO2) shaped a common initial inoculum into four unique ammonia-tolerant syntrophic populations. Specifically, various levels of ammonia tolerance were observed: consortia fed with methanol and H2/CO2 could grow at ammonia levels up to 7.25 g NH+-N/L, whereas the other two groups (formate and acetate) only thrived at 5.25 and 4.25 g NH+-N/L, respectively. Metabolic reconstruction highlighted that this divergent microbiome might be achieved by complementary metabolisms to maximize biomethane recovery from carbon sources, thus indicating the importance of the syntrophic community in the AD of N-rich substrates. Besides, sodium/proton antiporter operon, osmoprotectant/K+ regulator, and osmoprotectant synthesis operon may function as the main drivers of adaptation to the ammonia stress. Moreover, energy from the substrate-level phosphorylation and multiple energy-converting hydrogenases (e.g., Ech and Eha) could aid methanogens to balance the energy request for anabolic activities and contribute to thriving when exposed to high ammonia levels.
Collapse
Affiliation(s)
- Miao Yan
- Department of Environmental
Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kongens Lyngby, Denmark
| | - Laura Treu
- Department of Biology, University
of Padova, Via U. Bassi
58/b, 35121 Padova, Italy
| | - Xinyu Zhu
- Department of Environmental
Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kongens Lyngby, Denmark
| | - Hailin Tian
- Department of Environmental
Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kongens Lyngby, Denmark
- NUS Environmental Research Institute, National
University of Singapore, 1 Create Way, 138602, Singapore
| | - Arianna Basile
- Department of Biology, University
of Padova, Via U. Bassi
58/b, 35121 Padova, Italy
| | - Ioannis A. Fotidis
- Department of Environmental
Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kongens Lyngby, Denmark
- School of Civil Engineering, Southeast University, 210096 Nanjing, China
| | - Stefano Campanaro
- Department of Biology, University
of Padova, Via U. Bassi
58/b, 35121 Padova, Italy
- CRIBI Biotechnology Center, University of Padua, 35131 Padua, Italy
| | - Irini Angelidaki
- Department of Environmental
Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kongens Lyngby, Denmark
| |
Collapse
|
33
|
Deng Y, Qiu Y, Yao Y, Ayiania M, Davaritouchaee M. Weak-base pretreatment to increase biomethane production from wheat straw. ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2020; 27:37989-38003. [PMID: 32617819 DOI: 10.1007/s11356-020-09914-7] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/16/2020] [Accepted: 06/26/2020] [Indexed: 06/11/2023]
Abstract
Weak-base pretreatment of wheat straw was investigated for its ability to improve biomethane production. Anaerobic digestion (AD) was performed on wheat straw pretreated with 3%, 5%, or 7% Na2CO3 as a weak base. Scanning electron microscopy (SEM), X-ray diffraction (XRD), and Fourier Transform Infrared Spectroscopy (FTIR) spectra demonstrated disruption of lignocellulosic structures by pretreatment. In the 5% Na2CO3 treatment group, cellulose and hemicellulose were retained effectively, with efficient removal of lignin. The removal rates of cellulose, hemicellulose, and lignin were 27.9%, 20.4%, and 31.0%, respectively, after 5% Na2CO3 pretreatment. The methane content (53.3-77.3%) was improved in the 5% Na2CO3 treatment group, with maximum methane production (307.9 L/kg VS) that was 41.6% higher than that of the untreated sample. Cellulose and hemicelluloses were degraded 59.3% and 56.3% after AD. It took 20 days to reach 80% of the maximum cumulative methane production for the 5% Na2CO3 pretreatment group, which was 4 days faster than the untreated group. These results indicate that 5% Na2CO3 pretreatment improve the lignocellulose structure of wheat straw, allowing better biodegradability of wheat straw in AD for increased biogas production, enhanced methane content, and decreased digestion time.
Collapse
Affiliation(s)
- Yuanfang Deng
- College of Mechanical and Electronic Engineering, Northwest A&F University, Yangling, 712100, Shaanxi, China
- Jiangsu Key Laboratory for Biomass-based Energy and Enzyme Technology, Huaiyin Normal University, Huaian, 223300, Jiangsu, China
| | - Yaojing Qiu
- Department of Biological Systems Engineering, Washington State University, Pullman, WA, USA
| | - Yiqing Yao
- College of Mechanical and Electronic Engineering, Northwest A&F University, Yangling, 712100, Shaanxi, China.
- Northwest Research Center of Rural Renewable Energy, Exploitation and Utilization of Ministry of Agriculture, Northwest A&F University, Yangling, 712100, Shaanxi, China.
| | - Michael Ayiania
- Department of Biological Systems Engineering, Washington State University, Pullman, WA, USA
| | - Maryam Davaritouchaee
- The Gene & Linda Voiland School of Chemical Engineering and Bioengineering, Washington State University, Pullman, WA, 99164, USA
| |
Collapse
|
34
|
Prudente M, Massazza DA, Busalmen JP, Romeo HE. Urine dilution with a synthetic wastewater (Syntho) boosts the electricity production in a bio-electrochemical system powered by un-pretreated human urine. Bioelectrochemistry 2020; 137:107639. [PMID: 32942188 DOI: 10.1016/j.bioelechem.2020.107639] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [Key Words] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/18/2020] [Revised: 08/18/2020] [Accepted: 08/18/2020] [Indexed: 11/29/2022]
Abstract
Human urine can be turned into electricity in bio-electrochemical systems. The acclimation of electro-active bacteria to culture media with increasing urine concentrations has led to raising the obtained current densities, which typically followed a Monod-like evolution profile as a function of urine concentration. However, the acclimation protocol has been so far evaluated using pretreated urine samples (fermented or precipitated), not raw (un-pretreated) urine. We demonstrate that, when un-pretreated urine is used, the microbial adaptation to increasingly concentrated urine leads to a current density profile that does not reach a saturation-like phase, but follows a Han/Levenspiel-type trend (bell-shaped). By diluting un-pretreated urine with a synthetic domestic wastewater (Syntho) up to concentrations matching those of the maximum in the Han/Levenspiel-like current profile (15-20% v/v) it is possible to avoid the drop in the electro-active response, generating anodic current densities as high as 3.6 ± 0.2 A.m-2 (per actual surface area), 35-fold higher than those reached in pure un-pretreated urine.
Collapse
Affiliation(s)
- Mariano Prudente
- División Polímeros Nanoestructurados, Instituto de Investigaciones en Ciencia y Tecnología de Materiales (INTEMA), Consejo Nacional de Investigaciones Científicas y Técnicas (CONICET), 7600 Mar del Plata, Argentina
| | - Diego A Massazza
- División Ingeniería de Interfases y Bio-procesos, Instituto de Investigaciones en Ciencia y Tecnología de Materiales (INTEMA), Consejo Nacional de Investigaciones Científicas y Técnicas (CONICET), 7600 Mar del Plata, Argentina
| | - Juan P Busalmen
- División Ingeniería de Interfases y Bio-procesos, Instituto de Investigaciones en Ciencia y Tecnología de Materiales (INTEMA), Consejo Nacional de Investigaciones Científicas y Técnicas (CONICET), 7600 Mar del Plata, Argentina
| | - Hernán E Romeo
- División Polímeros Nanoestructurados, Instituto de Investigaciones en Ciencia y Tecnología de Materiales (INTEMA), Consejo Nacional de Investigaciones Científicas y Técnicas (CONICET), 7600 Mar del Plata, Argentina.
| |
Collapse
|
35
|
Gaspareto TC, Scapini T, Venturin B, Tápparo DC, Camargo AF, Luccio MD, Valerio A, Favretto R, Antes FG, Steinmetz RLR, Treichel H, Kunz A. Pre-treatment Strategies for Value Addition in Poultry Litter. Front Bioeng Biotechnol 2020; 8:477. [PMID: 32523940 PMCID: PMC7261907 DOI: 10.3389/fbioe.2020.00477] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/18/2019] [Accepted: 04/23/2020] [Indexed: 11/13/2022] Open
Abstract
We studied different pre-treatments of poultry litter aiming to add economic value to this residue. Strategies were applied to extract ammonium nitrogen with the aim of allowing its further use as fertilizer, and to promote the hydrolysis and solubilization of lignocellulosic components with the aim of facilitating its subsequent conversion to biogas. Ammonia extraction was performed by solubilization in water in a one-step process and by successive extraction steps (3 times 60 min). Successive extractions presented greater removal of total ammonia nitrogen than did one-step extraction, solubilizing about 36% of the ammonia in water. In parallel pre-treatment using ultrasound was performed to increase carbon bioavailability for anaerobic digestion. Using this tool, 24.7 g kg−1 of total organic carbon and 13.0 g kg−1 of total reducing sugars were solubilized, employing 10% dry mass sample amount, 100% amplitude ultrasound at frequency of 20 kHz amplitude and 2.5 min of treatment (energy input of 299 ± 7 kJ L−1; 3,822 ± 95 kJ kg−1). Anaerobic digestion of ultrassound pre-treated biomass was evaluated using a biological biogas production assay, and an increase of 10% of biogas production was obtained compared to untreated samples (147.9 and 163.0 mL g−1 for crude and pre-treated PL, respectively). The findings suggest that these are environmentally friendly and sustainable strategies to add economic value to poultry litter, reducing the environmental impacts of improper disposal.
Collapse
Affiliation(s)
- Taís Carla Gaspareto
- Laboratory of Microbiology and Bioprocess, Federal University of Fronteira Sul, Erechim, Brazil
| | - Thamarys Scapini
- Laboratory of Microbiology and Bioprocess, Federal University of Fronteira Sul, Erechim, Brazil
| | | | | | - Aline Frumi Camargo
- Laboratory of Microbiology and Bioprocess, Federal University of Fronteira Sul, Erechim, Brazil
| | - Marco Di Luccio
- Department of Chemical and Food Engineering, Federal University of Santa Catarina, Florianópolis, Brazil
| | - Alexsandra Valerio
- Department of Chemical and Food Engineering, Federal University of Santa Catarina, Florianópolis, Brazil
| | - Rafael Favretto
- Center for Agricultural Sciences, Santa Catarina State University, Lages, Brazil
| | | | | | - Helen Treichel
- Laboratory of Microbiology and Bioprocess, Federal University of Fronteira Sul, Erechim, Brazil
| | - Airton Kunz
- Laboratory of Microbiology and Bioprocess, Federal University of Fronteira Sul, Erechim, Brazil.,Western Paraná State University, Cascavel, Brazil.,Embrapa Suínos e Aves, Concórdia, Brazil
| |
Collapse
|
36
|
Tápparo DC, Rogovski P, Cadamuro RD, Marques Souza DS, Bonatto C, Frumi Camargo A, Scapini T, Stefanski F, Amaral A, Kunz A, Hernández M, Treichel H, Rodríguez-Lázaro D, Fongaro G. Nutritional, Energy and Sanitary Aspects of Swine Manure and Carcass Co-digestion. Front Bioeng Biotechnol 2020; 8:333. [PMID: 32411682 PMCID: PMC7200981 DOI: 10.3389/fbioe.2020.00333] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/28/2019] [Accepted: 03/25/2020] [Indexed: 01/28/2023] Open
Abstract
Renewable energy can assist the management of the effects of population growth and rapid economic development on the sustainability of animal husbandry. The primary aim of renewable energy is to minimize the use of fossil fuels via the creation of environmentally friendly energy products from depleted fossil fuels. Digesters that treat swine manure are extensively used in treatment systems; and inclusion of swine carcasses can increase the organic loading rate (OLR) thereby improving biogas yield and productivity on farms. However, the characteristics of the components including animal residues, proteins, lipids, remains of undigested feed items, antimicrobial drug residues, pathogenic microorganisms and nutrient contents, are complex and diverse. It is therefore necessary to manage the anaerobic process stability and digestate purification for subsequent use as fertilizer. Efficient methane recovery from residues rich in lipids is difficult because such residues are only slowly biodegradable. Pretreatment can promote solubilization of lipids and accelerate anaerobic digestion, and pretreatments can process the swine carcass before its introduction onto biodigesters. This review presents an overview of the anaerobic digestion of swine manure and carcasses. We analyze the characteristics of these residues, and we identify strategies to enhance biogas yield and process stability. We consider energy potential, co-digestion of swine manure and carcasses, physical, chemical, and biological pretreatment of biomass, sanitary aspects of swine manure and co-digestates and their recycling as fertilizers.
Collapse
Affiliation(s)
- Deisi Cristina Tápparo
- Western Paraná State University - UNIOESTE/CCET/PGEAGRI, Cascavel, Brazil
- Embrapa Suínos e Aves, Concórdia, Brazil
| | - Paula Rogovski
- Laboratory of Applied Virology, Department of Microbiology, Parasitology and Immunology, Federal University of Santa Catarina (UFSC), Florianópolis, Brazil
| | - Rafael Dorighello Cadamuro
- Laboratory of Applied Virology, Department of Microbiology, Parasitology and Immunology, Federal University of Santa Catarina (UFSC), Florianópolis, Brazil
| | - Doris Sobral Marques Souza
- Laboratory of Applied Virology, Department of Microbiology, Parasitology and Immunology, Federal University of Santa Catarina (UFSC), Florianópolis, Brazil
| | - Charline Bonatto
- Department of Chemical and Food Engineering, Federal University of Santa Catarina, Florianópolis, Brazil
- Laboratory of Microbiology and Bioprocesses, Federal University of Fronteira Sul, Erechim, Brazil
| | - Aline Frumi Camargo
- Laboratory of Microbiology and Bioprocesses, Federal University of Fronteira Sul, Erechim, Brazil
| | - Thamarys Scapini
- Laboratory of Microbiology and Bioprocesses, Federal University of Fronteira Sul, Erechim, Brazil
| | - Fábio Stefanski
- Laboratory of Microbiology and Bioprocesses, Federal University of Fronteira Sul, Erechim, Brazil
| | - André Amaral
- Western Paraná State University - UNIOESTE/CCET/PGEAGRI, Cascavel, Brazil
| | | | - Marta Hernández
- Laboratory of Molecular Biology and Microbiology, Instituto Tecnológico Agrario de Castilla y León, Valladolid, Spain
| | - Helen Treichel
- Laboratory of Microbiology and Bioprocesses, Federal University of Fronteira Sul, Erechim, Brazil
| | - David Rodríguez-Lázaro
- Division of Microbiology, Department of Biotechnology and Food Science, Universidad de Burgos, Burgos, Spain
| | - Gislaine Fongaro
- Laboratory of Applied Virology, Department of Microbiology, Parasitology and Immunology, Federal University of Santa Catarina (UFSC), Florianópolis, Brazil
| |
Collapse
|
37
|
Effects of Increasing Nitrogen Content on Process Stability and Reactor Performance in Anaerobic Digestion. ENERGIES 2020. [DOI: 10.3390/en13051139] [Citation(s) in RCA: 11] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/17/2022]
Abstract
The aim of this study was to analyse the effect of different nitrogen increase rates in feedstock on the process stability and conversion efficiency in anaerobic digestion (AD). The research was conducted in continuously stirred tank reactors (CSTR), initially filled with two different inocula: inocula #1 with low and #2 with high nitrogen (N) concentrations. Three N feeding regimes were investigated: the “0-increase” feeding regime with a constant N amount in feeding and the regimes “0.25-increase” and “0.5-increase” where the N concentrations in feedstock were raised by 0.25 and 0.5 g·kg−1, respectively, related to fresh matter (FM) every second week. The N concentration inside the reactors increased according to the feeding regimes. The levels of inhibition (Inhibition) in specific methane yields (SMY), related to the conversion efficiency of the substrates, were quantified. At the N concentration in digestate of 10.82 ± 0.52 g·kg−1 FM measured in the reactors with inoculum #2 and “0.5-increase” feeding regime, the level of inhibition was equal to 38.99% ± 14.99%. The results show that high nitrogen increase rates in feeding regime are negatively related to the efficiency of the AD process, even if low volatile fatty acid (VFA) concentrations indicate a stable process.
Collapse
|
38
|
Wang H, Lim TT, Duong C, Zhang W, Xu C, Yan L, Mei Z, Wang W. Long-Term Mesophilic Anaerobic Co-Digestion of Swine Manure with Corn Stover and Microbial Community Analysis. Microorganisms 2020; 8:microorganisms8020188. [PMID: 32013160 PMCID: PMC7074675 DOI: 10.3390/microorganisms8020188] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/23/2019] [Revised: 01/28/2020] [Accepted: 01/28/2020] [Indexed: 01/12/2023] Open
Abstract
Long-term anaerobic co-digestion of swine manure (SM) and corn stover (CS) was conducted using semi-continuously loaded digesters under mesophilic conditions. A preliminary test was first conducted to test the effects of loading rates, and results indicated the 3 g-VS L−1 d−1 was the optimal loading rate. Based on the preliminary results, a verification replicated test was conducted with 3 g-VS L−1 d−1 loading rate and different SM/CS ratios (1:1, 2:1 and 1:2). Results showed that a SM/CS ratio of 2/1 was optimal, based on maximum observed methane-VSdes generation and carbon conversion efficiency (72.56 ± 3.40 mL g−1 and 40.59%, respectively). Amplicon sequencing analysis suggested that microbial diversity was increased with CS loading. Amino-acid-degrading bacteria were abundant in the treatment groups. Archaea Methanoculleus could enhance biogas and methane productions.
Collapse
Affiliation(s)
- Haipeng Wang
- Heilongjiang Provincial Key Laboratory of Environmental Microbiology and Recycling of Agro-Waste in Cold Region, College of Life Science and Biotechnology, Heilongjiang Bayi Agricultural University, Daqing 163319, China; (H.W.); (W.Z.); (C.X.); (L.Y.)
| | - Teng Teeh Lim
- Agriculture Systems Management, Division of Food Systems and Bioengineering, University of Missouri, Columbia, MO 65211-5200, USA; (T.T.L.); (C.D.)
| | - Cuong Duong
- Agriculture Systems Management, Division of Food Systems and Bioengineering, University of Missouri, Columbia, MO 65211-5200, USA; (T.T.L.); (C.D.)
| | - Wei Zhang
- Heilongjiang Provincial Key Laboratory of Environmental Microbiology and Recycling of Agro-Waste in Cold Region, College of Life Science and Biotechnology, Heilongjiang Bayi Agricultural University, Daqing 163319, China; (H.W.); (W.Z.); (C.X.); (L.Y.)
| | - Congfeng Xu
- Heilongjiang Provincial Key Laboratory of Environmental Microbiology and Recycling of Agro-Waste in Cold Region, College of Life Science and Biotechnology, Heilongjiang Bayi Agricultural University, Daqing 163319, China; (H.W.); (W.Z.); (C.X.); (L.Y.)
| | - Lei Yan
- Heilongjiang Provincial Key Laboratory of Environmental Microbiology and Recycling of Agro-Waste in Cold Region, College of Life Science and Biotechnology, Heilongjiang Bayi Agricultural University, Daqing 163319, China; (H.W.); (W.Z.); (C.X.); (L.Y.)
| | - Zili Mei
- Key Laboratory of Development and Application of Rural Renewable Energy, Ministry of Agriculture and Rural Affairs, Chengdu 610041, China;
| | - Weidong Wang
- Heilongjiang Provincial Key Laboratory of Environmental Microbiology and Recycling of Agro-Waste in Cold Region, College of Life Science and Biotechnology, Heilongjiang Bayi Agricultural University, Daqing 163319, China; (H.W.); (W.Z.); (C.X.); (L.Y.)
- Correspondence: ; Tel.: +86-13836729365
| |
Collapse
|
39
|
Tian H, Yan M, Treu L, Angelidaki I, Fotidis IA. Hydrogenotrophic methanogens are the key for a successful bioaugmentation to alleviate ammonia inhibition in thermophilic anaerobic digesters. BIORESOURCE TECHNOLOGY 2019; 293:122070. [PMID: 31491648 DOI: 10.1016/j.biortech.2019.122070] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.4] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/25/2019] [Revised: 08/20/2019] [Accepted: 08/24/2019] [Indexed: 05/20/2023]
Abstract
Bioaugmentation to alleviate ammonia inhibition under thermophilic anaerobic digestion has never been reported, as well as the working mechanism that allows a fast and successful bioaugmentation. Thus two bioaugmentation inocula (an enriched culture, and a mixed culture composed 50/50 by Methanoculleus thermophilus and the enriched culture) on the recovery of ammonia-inhibited thermophilic continuous reactors was assessed. The results showed that bioaugmentation improved methane yield by 11-13% and decreased the volatile fatty acids (VFA) by 45-52% compared to the control reactor (abiotic augmentation). Moreover, the importance of hydrogenotrophic methanogens to a fast and successful bioaugmentation was recognized. Specifically, the instant hydrogen partial pressure reduction by the bioaugmented hydrogenotroph created thermodynamically favourable conditions for the acetate oxidation process and consequently, the catabolism of other VFA. High-throughput sequencing results strengthened this explanation by showing that the bioaugmented M. thermophilus stimulated the growth of syntrophic acetate oxidising bacterium Thermacetogenium phaeum, immediately after bioaugmentation.
Collapse
Affiliation(s)
- Hailin Tian
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, 2800 Kgs. Lyngby, Denmark; Environmental Research Institute, National University of Singapore, 1 Create Way, Create Tower, Singapore 138602, Singapore
| | - Miao Yan
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, 2800 Kgs. Lyngby, Denmark
| | - Laura Treu
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, 2800 Kgs. Lyngby, Denmark; Department of Biology, University of Padua, 35131 Padua, Italy
| | - Irini Angelidaki
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, 2800 Kgs. Lyngby, Denmark
| | - Ioannis A Fotidis
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, 2800 Kgs. Lyngby, Denmark.
| |
Collapse
|
40
|
Ali S, Hua B, Huang JJ, Droste RL, Zhou Q, Zhao W, Chen L. Effect of different initial low pH conditions on biogas production, composition, and shift in the aceticlastic methanogenic population. BIORESOURCE TECHNOLOGY 2019; 289:121579. [PMID: 31228742 DOI: 10.1016/j.biortech.2019.121579] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/20/2019] [Revised: 05/25/2019] [Accepted: 05/27/2019] [Indexed: 05/09/2023]
Abstract
Anaerobic digestion (AD) reactors often encounter low pH inhibition during startup and high organic loading periods. The use of a large amount of NaOH in order to raise and buffer the low pH, is reported to be inhibitory to methanogens. In order to address this problem, we acclimatized aceticlastic methanogens to low pH. Methanogens were successfully acclimatized to initial low pH down to 3.5 in a lengthy, five months, acclimatization period. The aceticlastic methanogen, Methanothrix soehngenii which was 96.3% of the total methanogenic population at pH 4.5 and 86.75% at pH 3.5, demonstrated that they were the most tolerant aceticlastic methanogens to low pH. After acclimatization, methane yield at pH 4.5 was comparable to neutral pH. Methanosaeta maintained its dominance over Methanosarcina at an elevated level of acetate (66 mM), and a negative correlation was observed between them. There was a positive correlation between the CH4 content and pH.
Collapse
Affiliation(s)
- Salman Ali
- College of Environmental Science and Engineering/Sino-Canada Joint R&D Centre on Water and Environmental Safety, Nankai University, Tianjin 300071, PR China
| | - Binbin Hua
- College of Environmental Science and Engineering/Sino-Canada Joint R&D Centre on Water and Environmental Safety, Nankai University, Tianjin 300071, PR China
| | - Jinhui Jeanne Huang
- College of Environmental Science and Engineering/Sino-Canada Joint R&D Centre on Water and Environmental Safety, Nankai University, Tianjin 300071, PR China.
| | - Ronald L Droste
- Department of Civil Engineering, University of Ottawa, Ottawa, ON, K1N 6N5, Canada
| | - Qixing Zhou
- College of Environmental Science and Engineering/Sino-Canada Joint R&D Centre on Water and Environmental Safety, Nankai University, Tianjin 300071, PR China
| | - Weixin Zhao
- College of Environmental Science and Engineering/Sino-Canada Joint R&D Centre on Water and Environmental Safety, Nankai University, Tianjin 300071, PR China
| | - Lu Chen
- College of Environmental Science and Engineering/Sino-Canada Joint R&D Centre on Water and Environmental Safety, Nankai University, Tianjin 300071, PR China
| |
Collapse
|
41
|
Damaceno FM, Buligon EL, Pires Salcedo Restrepo JC, Chiarelotto M, Niedzialkoski RK, de Mendonça Costa LA, de Lucas Junior J, de Mendonça Costa MSS. Semi-continuous anaerobic co-digestion of flotation sludge from broiler chicken slaughter and sweet potato: Nutrients and energy recovery. THE SCIENCE OF THE TOTAL ENVIRONMENT 2019; 683:773-781. [PMID: 31150897 DOI: 10.1016/j.scitotenv.2019.05.314] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/30/2019] [Revised: 05/20/2019] [Accepted: 05/20/2019] [Indexed: 06/09/2023]
Abstract
Energy production based on the proper allocation of environmental liabilities is in line with the concept of sustainability. Flotation sludge (S) is a type of waste derived from the physical treatment of the wastewater generated in significant quantities during chicken slaughter in Brazil. If not treated, this wastewater may contribute to pollution, but further treatment provides clean energy and nutrient recycling. The present study aimed at evaluating the reduction of (S) organic load by means of mono and co-digestion with sweet potatoes (P) while promoting its conversion into energy (methane) and nutrients (digestate). Semi-continuous reactors (60 L capacity) were used with a hydraulic retention time of 25 days. The reactors were fed daily with 2.4 L consisting of 60% digestate recirculation, 40% non-chlorinated water and 4.5% total solids (TS). Using nine reactors and six progressive periods, eleven conditions were evaluated with three replicates each. The percentages of (P) and (S) varied from 0 to 100. The best observed condition in terms of energy recovery and TS removal was 60% of P + 40% of S (p ≤ 0.05), as it presented values of at least an increase of 92% in total biogas volume, an increase of 123% in specific methane production, an increase of 98% in specific methane yield and an increase of 44% in TS removal efficiency compared to mono-digestions. The fertilizer potential of the digestate generated in the different conditions was calculated and evaluated according to the area of (P) production. The results varied from 3.6 to 10.8 ha of (P) using 100 m3 of digestate. A multivariate analysis showed that higher amounts of (P) in substrate composition favor energy recycling while higher concentrations of (S) enhance the production of a digestate with valuable agronomic characteristics.
Collapse
Affiliation(s)
- Felippe Martins Damaceno
- Research Group on Water Resources and Environmental Sanitation, Western Paraná State University, Agricultural Engineering Graduate Program, Rua Universitária, 2069, Jardim Universitário, 85.819-110 Cascavel, Parana, Brazil
| | - Eduardo L Buligon
- Research Group on Water Resources and Environmental Sanitation, Western Paraná State University, Agricultural Engineering Graduate Program, Rua Universitária, 2069, Jardim Universitário, 85.819-110 Cascavel, Parana, Brazil
| | - Juan C Pires Salcedo Restrepo
- Research Group on Water Resources and Environmental Sanitation, Western Paraná State University, Agricultural Engineering Graduate Program, Rua Universitária, 2069, Jardim Universitário, 85.819-110 Cascavel, Parana, Brazil
| | - Maico Chiarelotto
- Research Group on Water Resources and Environmental Sanitation, Western Paraná State University, Agricultural Engineering Graduate Program, Rua Universitária, 2069, Jardim Universitário, 85.819-110 Cascavel, Parana, Brazil
| | - Rosana Krauss Niedzialkoski
- Research Group on Water Resources and Environmental Sanitation, Western Paraná State University, Agricultural Engineering Graduate Program, Rua Universitária, 2069, Jardim Universitário, 85.819-110 Cascavel, Parana, Brazil
| | - Luiz Antonio de Mendonça Costa
- Research Group on Water Resources and Environmental Sanitation, Western Paraná State University, Agricultural Engineering Graduate Program, Rua Universitária, 2069, Jardim Universitário, 85.819-110 Cascavel, Parana, Brazil
| | - Jorge de Lucas Junior
- Department of Rural Engineering, São Paulo State University, College of Agricultural and Veterinary Sciences at Jaboticabal, São Paulo, Brazil
| | - Monica Sarolli Silva de Mendonça Costa
- Research Group on Water Resources and Environmental Sanitation, Western Paraná State University, Agricultural Engineering Graduate Program, Rua Universitária, 2069, Jardim Universitário, 85.819-110 Cascavel, Parana, Brazil.
| |
Collapse
|
42
|
Yang J, Wang D, Luo Z, Zeng W. Influence of reflux ratio on the anaerobic digestion of pig manure in leach beds coupled with continuous stirred tank reactors. WASTE MANAGEMENT (NEW YORK, N.Y.) 2019; 97:115-122. [PMID: 31447018 DOI: 10.1016/j.wasman.2019.08.005] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.2] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/27/2019] [Revised: 08/05/2019] [Accepted: 08/05/2019] [Indexed: 06/10/2023]
Abstract
The effect of reflux ratio on the anaerobic mono-digestion of pig manure (PM) in leach beds coupled with continuous stirred tank reactors (CSTRs) has been studied in this work, and contents of volatile fatty acids (VFAs) and biogas yields were determined for three groups of leach bed reactor (LBR) - CSTR systems. The obtained results indicated that the reflux of biogas slurry increased both the pH of the acid-producing phase and acetic acid yield and repeatedly degraded the refractory organic matter in the biogas slurry. The larger reflux ratio increased the inoculation volume and substantially enhanced the mass transfer process. The maximum values of the biogas and methane yields equal to 259.49 and 167.44 mL/g volatile solids, respectively, were achieved at a reflux ratio of 100%. Moreover, the weight of the PM leachate residue was reduced by 94.14%, and the total nutrient content (N + P2O5 + K2O) was relatively high (1.48%), which was suitable for vegetable seedling substrates. In conclusion, during the treatment of PM in LBR-CSTRs, the solid phase remains on the leach bed, and the leachate is supplied to a biogas tank, which effectively increases its stability of operation.
Collapse
Affiliation(s)
- Jie Yang
- College of Natural Resources and Environment, South China Agricultural University, Guangzhou, Guangdong 510642, PR China
| | - Dehan Wang
- College of Natural Resources and Environment, South China Agricultural University, Guangzhou, Guangdong 510642, PR China.
| | - Zifeng Luo
- College of Natural Resources and Environment, South China Agricultural University, Guangzhou, Guangdong 510642, PR China
| | - Weishen Zeng
- College of Natural Resources and Environment, South China Agricultural University, Guangzhou, Guangdong 510642, PR China
| |
Collapse
|
43
|
Interactive Effects of Chemical Composition of Food Waste during Anaerobic Co-Digestion under Thermophilic Temperature. SUSTAINABILITY 2019. [DOI: 10.3390/su11102933] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.4] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/17/2022]
Abstract
The effects of chemical composition (carbohydrates, lipids, and protein) on the anaerobic co-digestion performance of food wastes (FW) were investigated from the viewpoints of methane production, dynamic parameters, and microbial community structure. The results of this study showed that a notable gasification rate was positively correlated with the proportion of the composition. A T2 reactor, which consisted of 60% carbohydrates, 20% lipids, and 20% protein, held a higher gasification rate of 65.09% compared to other groups, while its process parameters showed some deficiency regarding the stability of digestion, especially for low biochemical methane potential (BMP), which was not beneficial for the actual practice. A T4 reactor, with a highest gasification rate of 70.68%, held the maximum BMP (497.44 mL/g VS). The stable chemical parameters achieved the optimal proportion, consisting of 40% carbohydrates, 40% lipids, and 20% protein. Furthermore, its microbial populations were rich and achieved a balance of the two main dominant communities of acetoclastic methanogens and hydrogenotrophic methanogens, whose relative abundance was close. It was obvious that interactive effects were caused by different proportional composition, which led to constantly changing chemical parameters and microbial community.
Collapse
|
44
|
Shamurad B, Gray N, Petropoulos E, Tabraiz S, Acharya K, Quintela-Baluja M, Sallis P. Co-digestion of organic and mineral wastes for enhanced biogas production: Reactor performance and evolution of microbial community and function. WASTE MANAGEMENT (NEW YORK, N.Y.) 2019; 87:313-325. [PMID: 31109531 DOI: 10.1016/j.wasman.2019.02.021] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/25/2018] [Revised: 02/06/2019] [Accepted: 02/07/2019] [Indexed: 06/09/2023]
Abstract
Mineral wastes (MWs) from municipal solid waste incineration plants and construction demolition sites are rich in minerals, heavy metals and have acid neutralising capacity. This renders such MWs a promising source of bulk and trace elements to enhance and stabilize biogas production in anaerobic processes. However, finding a MW with typical heavy metal concentrations, which promotes anaerobic digestion (AD) without adverse effects on the microbial community of the reactor is of major importance. To investigate the impact of several MW additives (1. incineration bottom ash; 2. fly ash; 3. boiler ash; 4. cement-based waste) as AD co-substrates, six 5 L single stage mesophilic, continuously stirred tank reactors (CSTR) were setup. Two different feeding regimes were employed including: (a) a liquid-recycled feeding method (LRFM); (b) a draw-and-fill feeding method (DFFM). Under the LRFM regime, one gram MW per gram organic waste enhanced process stability (pH), increased methane production (25-45% increase), and yielded (450-520 mL CH4/g VS); DFFM enhanced digestibility to a lesser degree. Illumina HiSeq 16S rRNA community sequencing of reactors showed that the microbial community compositions were unaffected by the presence of MW additives in comparison to unamended controls, but MW amendment accelerated bacterial growth (determined by qPCR). In contrast, different feeding regimes altered the microbial communities; Methanoculleus (hydrogenotrophic) and Methanosaeta (acetoclastic) were the most abundant methanogenic genera in the LRFM reactors, and the more metabolically versatile Methanosarcina genus dominated under DFFM.
Collapse
Affiliation(s)
- Burhan Shamurad
- School of Engineering, Newcastle University, Newcastle upon Tyne, UK.
| | - Neil Gray
- School of Engineering, Newcastle University, Newcastle upon Tyne, UK
| | | | - Shamas Tabraiz
- School of Engineering, Newcastle University, Newcastle upon Tyne, UK
| | - Kishor Acharya
- School of Engineering, Newcastle University, Newcastle upon Tyne, UK
| | | | - Paul Sallis
- School of Engineering, Newcastle University, Newcastle upon Tyne, UK
| |
Collapse
|
45
|
Lv Z, Chen Z, Chen X, Liang J, Jiang J, Loake GJ. Effects of various feedstocks on isotope fractionation of biogas and microbial community structure during anaerobic digestion. WASTE MANAGEMENT (NEW YORK, N.Y.) 2019; 84:211-219. [PMID: 30691895 DOI: 10.1016/j.wasman.2018.11.043] [Citation(s) in RCA: 25] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/21/2018] [Revised: 10/22/2018] [Accepted: 11/27/2018] [Indexed: 06/09/2023]
Abstract
Feedstock type influences bacterial and methanogenic communities in anaerobic digestion. These two communities work tightly to maintain the stability of anaerobic digestion. How to quick report the changes of microbial community structure especially methanogenesis is the key issue for optimizing anaerobic digestion process. In this study, 13C isotope fractionations of CH4 and CO2 in biogas and microbial community composition were analyzed in 5 different feedstocks. Our results showed that grass silage, maize silage and swine manure fed reactors had similar δ 13C values and methanogenic community composition, dominated by Methanosarcinaceae. The lowest δ 13CH4 values were detected in straw and chicken manure fed reactors, reflecting reduced microbial degradation of material or the presence of toxic components in these feedstocks. The straw fed bioreactor lead to low δ 13CH4 values, probably reflecting relatively high levels of the syntrophic acetate oxidizing bacteria, Synergistaceae and Syntrophaceae, which might work collectively with hydrogenotrophic methanogens, resulting in the low δ 13CH4 values in this bioreactor. Significantly, all core microbes in the 5 different feedstock fed bioreactors were either Clostridia species or related to the Synergistaceae (syntrophic acetate oxidizing bacteria).
Collapse
Affiliation(s)
- Zuopeng Lv
- The Key Laboratory of Biotechnology for Medicinal Plants of Jiangsu Province, Jiangsu Normal University, Shanghai Road 101, 221116 Xuzhou, China; Jiangsu Normal University - Edinburgh University, Centre for Transformative Biotechnology of Medicinal and Food Plants, Jiangsu Normal University, 101 Shanghai Road, Xuzhou, China.
| | - Zhongbing Chen
- Department of Applied Ecology, Faculty of Environmental Sciences, Czech University of Life Sciences Prague, Kamýcká 129, 16500 Prague, Czech Republic
| | - Xin Chen
- The Key Laboratory of Biotechnology for Medicinal Plants of Jiangsu Province, Jiangsu Normal University, Shanghai Road 101, 221116 Xuzhou, China; Jiangsu Normal University - Edinburgh University, Centre for Transformative Biotechnology of Medicinal and Food Plants, Jiangsu Normal University, 101 Shanghai Road, Xuzhou, China
| | - Jiazhuo Liang
- The Key Laboratory of Biotechnology for Medicinal Plants of Jiangsu Province, Jiangsu Normal University, Shanghai Road 101, 221116 Xuzhou, China; Jiangsu Normal University - Edinburgh University, Centre for Transformative Biotechnology of Medicinal and Food Plants, Jiangsu Normal University, 101 Shanghai Road, Xuzhou, China
| | - Jihong Jiang
- The Key Laboratory of Biotechnology for Medicinal Plants of Jiangsu Province, Jiangsu Normal University, Shanghai Road 101, 221116 Xuzhou, China; Jiangsu Normal University - Edinburgh University, Centre for Transformative Biotechnology of Medicinal and Food Plants, Jiangsu Normal University, 101 Shanghai Road, Xuzhou, China
| | - Gary J Loake
- Jiangsu Normal University - Edinburgh University, Centre for Transformative Biotechnology of Medicinal and Food Plants, Jiangsu Normal University, 101 Shanghai Road, Xuzhou, China; Institute of Molecular Plant Sciences, School of Biological Sciences, University of Edinburgh, King's Buildings, Edinburgh EH9 3JH, UK
| |
Collapse
|
46
|
Process Disturbances in Agricultural Biogas Production—Causes, Mechanisms and Effects on the Biogas Microbiome: A Review. ENERGIES 2019. [DOI: 10.3390/en12030365] [Citation(s) in RCA: 45] [Impact Index Per Article: 9.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 02/03/2023]
Abstract
Disturbances of the anaerobic digestion process reduce the economic and environmental performance of biogas systems. A better understanding of the highly complex process is of crucial importance in order to avoid disturbances. This review defines process disturbances as significant changes in the functionality within the microbial community leading to unacceptable and severe decreases in biogas production and requiring an active counteraction to be overcome. The main types of process disturbances in agricultural biogas production are classified as unfavorable process temperatures, fluctuations in the availability of macro- and micronutrients (feedstock variability), overload of the microbial degradation potential, process-related accumulation of inhibiting metabolites such as hydrogen (H2), ammonium/ammonia (NH4+/NH3) or hydrogen sulphide (H2S) and inhibition by other organic and inorganic toxicants. Causes, mechanisms and effects on the biogas microbiome are discussed. The need for a knowledge-based microbiome management to ensure a stable and efficient production of biogas with low susceptibility to disturbances is derived and an outlook on potential future process monitoring and control by means of microbial indicators is provided.
Collapse
|
47
|
Zhang W, Zhang F, Li YX, Jianxiong Zeng R. Inhibitory effects of free propionic and butyric acids on the activities of hydrogenotrophic methanogens in mesophilic mixed culture fermentation. BIORESOURCE TECHNOLOGY 2019; 272:458-464. [PMID: 30390538 DOI: 10.1016/j.biortech.2018.10.076] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.2] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/26/2018] [Revised: 10/23/2018] [Accepted: 10/26/2018] [Indexed: 06/08/2023]
Abstract
The aim of this work was to study the inhibitory of free propionic acid (FPA) and free butyric acid (FBA) on enriched hydrogenotrophic methanogens. It demonstrated that concentrations of FPA and FBA were correlated well with the specific methanogenic activity. Coenzyme M concentrations also agreed well with the trends of FPA and FBA. Two fators of C50% (concentration at 50% inhibition) and CRC (recoverable concentration from inhibition) were used to quantitively analyze the inhibitory order using the former result of free acetic acid (FAA) and the results of FBA and FPA. The order according to C50% was FAA (5.2 mM) > FBA (8.3 mM) > FPA (8.5 mM), while for CRC it was FPA (9.3 mM) > FAA = FBA (13.5 mM). After comparing with literatue, it suggests that the toxicities of these three organic acids are similar. Thus, accumulating free organic acid offers a cost-effective method to inhibit methanogenesis.
Collapse
Affiliation(s)
- Wei Zhang
- Fujian Provincial Key Laboratory of Soil Environmental Health and Regulation, College of Resources and Environment, Fujian Agriculture and Forestry University, Fuzhou, Fujian 350002, China; CAS Key Laboratory for Urban Pollutant Conversion, Department of Chemistry, University of Science and Technology of China, Hefei, Anhui 230026, China
| | - Fang Zhang
- Fujian Provincial Key Laboratory of Soil Environmental Health and Regulation, College of Resources and Environment, Fujian Agriculture and Forestry University, Fuzhou, Fujian 350002, China
| | - Yong-Xin Li
- Fujian Provincial Key Laboratory of Soil Environmental Health and Regulation, College of Resources and Environment, Fujian Agriculture and Forestry University, Fuzhou, Fujian 350002, China
| | - Raymond Jianxiong Zeng
- Fujian Provincial Key Laboratory of Soil Environmental Health and Regulation, College of Resources and Environment, Fujian Agriculture and Forestry University, Fuzhou, Fujian 350002, China; CAS Key Laboratory for Urban Pollutant Conversion, Department of Chemistry, University of Science and Technology of China, Hefei, Anhui 230026, China.
| |
Collapse
|
48
|
Tian H, Treu L, Konstantopoulos K, Fotidis IA, Angelidaki I. 16s rRNA gene sequencing and radioisotopic analysis reveal the composition of ammonia acclimatized methanogenic consortia. BIORESOURCE TECHNOLOGY 2019; 272:54-62. [PMID: 30308408 DOI: 10.1016/j.biortech.2018.09.128] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.6] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/02/2018] [Revised: 09/24/2018] [Accepted: 09/25/2018] [Indexed: 06/08/2023]
Abstract
Different mesophilic and thermophilic methanogenic consortia were acclimatised and enriched to extreme total ammonia (9.0 and 5.0 g NH4+-N L-1, respectively) and free ammonia (1.0 and 1.4 g NH3-N L-1, respectively) levels in this study. [2-14C] acetate radioisotopic analyses showed the dominance of aceticlastic methanogenesis in all enriched consortia. According to 16S rRNA gene sequencing result, in mesophilic consortia, methylotrophic Methanomassiliicoccus luminyensis was predominant, followed by aceticlastic Methanosarcina soligelidi. A possible scenario explaining the dominance of M. luminyensis includes the use of methylamine produced by Tissierella spp. and biomass build-up by metabolizing acetate. Nevertheless, further studies are needed to pinpoint the exact metabolic pathway of M. luminyensis. In thermophilic consortia, aceticlastic Methanosarcina thermophila was the sole dominant methanogen. Overall, results derived from this study demonstrated the efficient biomethanation ability of these ammonia-tolerant methanogenic consortia, indicating a potential application of these consortia to solve ammonia toxicity problems in future full-scale reactors.
Collapse
Affiliation(s)
- Hailin Tian
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kgs. Lyngby, Denmark
| | - Laura Treu
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kgs. Lyngby, Denmark
| | - Konstantinos Konstantopoulos
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kgs. Lyngby, Denmark
| | - Ioannis A Fotidis
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kgs. Lyngby, Denmark.
| | - Irini Angelidaki
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kgs. Lyngby, Denmark
| |
Collapse
|
49
|
Astals S, Peces M, Batstone DJ, Jensen PD, Tait S. Characterising and modelling free ammonia and ammonium inhibition in anaerobic systems. WATER RESEARCH 2018; 143:127-135. [PMID: 29940358 DOI: 10.1016/j.watres.2018.06.021] [Citation(s) in RCA: 12] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/19/2018] [Revised: 06/04/2018] [Accepted: 06/11/2018] [Indexed: 06/08/2023]
Abstract
Inhibition by ammoniacal nitrogen, consisting of free ammonia (NH3) and ammonium ion (NH4+), has been widely investigated for anaerobic digestion. However, despite the large amount of research on the subject, ammoniacal nitrogen inhibition still threatens many anaerobic digesters. This paper presents (i) a method to reliably characterise ammoniacal nitrogen inhibition and (ii) a robust inhibition modelling approach. Results showed that NH3 and NH4+ inhibition need to be jointly determined, which can only be done by performing inhibition tests at various total ammoniacal nitrogen (TAN) concentrations and pH values. These test conditions were reliably achieved using the salts NH4HCO3 and NH4Cl without pH adjustment, rather than by using NH4Cl with pH adjustment. The use of only salts showed a lower pH change during the inhibition test (∼1.5 days), thereby decreasing the uncertainty in TAN speciation and strengthening the test and model outputs. A threshold inhibition function satisfactorily described (R2 > 0.99) the joint inhibition of NH3 and NH4+ on three distinct inocula, and provided a better description of the inhibition testing results than a non-competitive inhibition function (R2 ∼0.70). The key advantage of the proposed threshold inhibition function is its capacity to identify the inhibition lower limit (concentration where inhibition starts; KImin) and upper limit (concentration where inhibition is complete; KImax). The threshold inhibition function also identifies the 50% inhibition concentration (KI50) at the midpoint of KImin and KImax. Finally, experimental and model results show that at pH 7.3-7.7 and TAN concentrations above 2000 mgN·L-1, both NH3 and NH4+ contribute significantly to overall inhibition.
Collapse
Affiliation(s)
- S Astals
- Advanced Water Management Centre, The University of Queensland, Brisbane, 4072, QLD, Australia.
| | - M Peces
- Centre for Solid Waste Bioprocessing, Schools of Civil and Chemical Engineering, The University of Queensland, 4072, QLD, Australia
| | - D J Batstone
- Advanced Water Management Centre, The University of Queensland, Brisbane, 4072, QLD, Australia
| | - P D Jensen
- Advanced Water Management Centre, The University of Queensland, Brisbane, 4072, QLD, Australia
| | - S Tait
- Advanced Water Management Centre, The University of Queensland, Brisbane, 4072, QLD, Australia
| |
Collapse
|
50
|
Lu Y, Liaquat R, Astals S, Jensen P, Batstone D, Tait S. Relationship between microbial community, operational factors and ammonia inhibition resilience in anaerobic digesters at low and moderate ammonia background concentrations. N Biotechnol 2018; 44:23-30. [DOI: 10.1016/j.nbt.2018.02.013] [Citation(s) in RCA: 20] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/20/2017] [Revised: 02/22/2018] [Accepted: 02/23/2018] [Indexed: 10/17/2022]
|