Azo dye decolorization by a halotolerant consortium under microaerophilic conditions

Mechanism of decolorization and degradation of direct brown D3G by a halo-thermophilic consortium

Azo dye wastewater has garnered significant attention from researchers because of its association with high-temperature, high-salt, and high-alkali conditions. In this study, consortium ZZ efficiently decolorized brown D3G under halophilic and thermophilic conditions. he results indicated that consortium ZZ, which was mainly dominated by Marinobacter, Bacillus, and Halomonas, was achieved decolorization rates ranging from 1 to 10% at temperatures between 40 °C and 50 °C, while maintaining a pH range of 7 to 10 for direct brown D3G degradation. Through the comprehensive utilization of UV-vis spectral analysis, Fourier transform infrared (FTIR), gas chromatography mass spectrometric (GC-MS) techniques, as well as metagenomic analysis, the decolorization and degradation pathway of direct brown by consortium ZZ was proposed. The azo dye reductase, lignin peroxidase, and laccase were also highly expressed in the decolorization process. Additionally, phytotoxicity tests using seeds of Cucumis sativus and Oryza sativa revealed that the intermediates generated showed no significant toxicity compared with distilled water. This investigation elucidated the pivotal contribution of consortium ZZ to azo dye degradation and provided novel theoretical insights along with practical guidance for azo dye treatment at halo-thermophilic conditions.

Potential of halophiles and alkaliphiles in bioremediation of azo dyes-laden textile wastewater: a review

Azo dye-laden textile wastewater must be treated before release due to various health and environmental concerns. Bioremediation of textile wastewater, however, is a challenge owing to its alkaline and saline nature as mesophilic microbes, in general, are either not able to thrive or show less efficiency under such hostile environment. Thus, pre-treatment for neutralization or salinity removal becomes a prerequisite before applying microbes for treatment, causing extra economical and technical burden. Extremophilic bacteria can be the promising bioremediating tool because of their inherent ability to survive and show toxicants removal capability under such extreme conditions without need of pre-treatment. Among extremophiles, halophilic and alkaliphilic bacteria which are naturally adapted to high salt and pH are of special interest for the decolorization of saline-alkaline-rich textile wastewater. The current review article is an attempt to provide an overview of the bioremediation of azo dyes and azo dye-laden textile wastewater using these two classes of extremophilic bacteria. The harmful effects of azo dyes on human health and environment have been discussed herein. Halo-alkaliphilic bacteria circumvent the extreme conditions by various adaptations, e.g., production of certain enzymes, adjustment at the protein level, pH homeostasis, and other structural adaptations that have been highlighted in this review. The unique properties of alkaliphiles and halophiles, to not only sustain but also harboring high dye removal competence at high pH and salt concentration, make them a good candidate for designing future bioremediation strategies for the management of alkaline, salt, and azo dye-laden industrial wastewaters.

Screening and identification of microbes from polluted environment for azodye (Turquoise blue) decolorization

Turquoise blue dye is frequently used for industrial dyeing applications. But the release of untreated colored wastewater became an environmental and public health hazard. Microbial remediation of Azodye is environmentally safe and an alternative to a physicochemical approach. The aim of this research is to isolate and characterize turquoise blue dye degrading microbes from polluted environment. Microbial isolation and purification from soil and effluent sample was done on PDA and NA. Turquoise blue dye degrading test was investigated under optimized conditions using -the definitive screening design method. UV-Vis spectrophotometer used to measure the degradation percentage at 620 nm and 25 °C. The results revealed that 24 fungi and 6 bacterial species were identified from the contaminated site using Biolog Microstation and MALDI-TOF. Among all identified microbial species Pencilium citrinum Thom BCA & Penicillium heriquei show the highest percentage decolorization of turquoise blue dye up to 300 ppm with 90 % removal at pH4 and 87 % at pH 7 up to 400 ppm respectively. The azodye degradation ability of these fungi species used in the development of mycoremediation technologies provide an alternative option for Azodye removal after HPLC analysis, molecular characterization, and toxic analysis.

Microbial alchemists: unveiling the hidden potentials of halophilic organisms for soil restoration

Salinity, resulting from various contaminants, is a major concern to global crop cultivation. Soil salinity results in increased osmotic stress, oxidative stress, specific ion toxicity, nutrient deficiency in plants, groundwater contamination, and negative impacts on biogeochemical cycles. Leaching, the prevailing remediation method, is expensive, energy-intensive, demands more fresh water, and also causes nutrient loss which leads to infertile cropland and eutrophication of water bodies. Moreover, in soils co-contaminated with persistent organic pollutants, heavy metals, and textile dyes, leaching techniques may not be effective. It promotes the adoption of microbial remediation as an effective and eco-friendly method. Common microbes such as Pseudomonas, Trichoderma, and Bacillus often struggle to survive in high-saline conditions due to osmotic stress, ion imbalance, and protein denaturation. Halophiles, capable of withstanding high-saline conditions, exhibit a remarkable ability to utilize a broad spectrum of organic pollutants as carbon sources and restore the polluted environment. Furthermore, halophiles can enhance plant growth under stress conditions and produce vital bio-enzymes. Halophilic microorganisms can contribute to increasing soil microbial diversity, pollutant degradation, stabilizing soil structure, participating in nutrient dynamics, bio-geochemical cycles, enhancing soil fertility, and crop growth. This review provides an in-depth analysis of pollutant degradation, salt-tolerating mechanisms, and plant-soil-microbe interaction and offers a holistic perspective on their potential for soil restoration.

Adsorption and biodegradation of the azo dye methyl orange using Ralstonia pickettii immobilized in polyvinyl alcohol (PVA)-alginate-hectorite beads (BHec-RP)

Biological methods are widely used to treat dye waste, particularly methyl orange (MO) dye. The importance of MO degradation stems from its classification as a toxic dye. Within the scope of this research, successful bio-decolorization of MO was achieved through the use of Ralstonia pickettii bacteria immobilized in a PVA-alginate-hectorite matrix (BHec-RP). The optimum conditions for the degradation were observed at a composition of PVA (10%), hectorite (1%), static incubation, 40 °C, and pH 7. Subsequently, the adsorption kinetics of BHec-RP (dead cells) as well as the degradation kinetics of BHec-RP (live cells) and MO using free R. pickettii cells were evaluated. The decolorization of MO using BHec-RP (dead cells) is an adsorption process following pseudo-first-order kinetics (0.6918 mg g-1 beads) and occurs in a monolayer or physical process. Meanwhile, the adoption of BHec-RP (live cells) and free R. pickettii cells shows a degradation process under pseudo-first-order kinetics, with the highest rates at an initial MO concentration of 50 mg L-1 being 0.025 mg L-1 h-1 and 0.015 mg L-1 h-1, respectively. These results show that the immobilization system is superior compared to free R. pickettii cells. Furthermore, the degradation process shows the inclusion of several enzymes, such as azoreductase, NADH-DCIP reductase, and laccase, presumed to be included in the fragmentation of molecules. This results in five fragments based on LC-QTOF/MS analysis, with m/z values of 267.12; 189.09; 179.07; 169.09; and 165.05.

Decolorization and detoxification of Brilliant Crocein GR by a newly enriched thermophilic consortium

The environmental pollution caused by azo dyes at high temperatures has become an urgent problem. However, little attention has been paid to decolorizing azo dyes by thermophilic consortiums. In this study, a thermophilic bacterial consortium (BCGR-T) mainly composed of two genera, namely, Caldibacillus (70.90%) and Aeribacillus (17.63%) was first enriched, which can decolorize Brilliant Crocein GR (BCGR) at high temperatures (50-75 °C), pH values of 6∼8, dye concentrations (100-400 mg/L) and salinities (1-5%, w/v). The enzyme activity results showed that the azoreductase activity was nearly 8.8 times that of the control (p < 0.01), and the intracellular lignin peroxidase was also highly expressed with enzyme activity of 5.64 U (min-1 mg-1 protein) (p < 0.05), indicated that both azoreductase and intracellular lignin peroxidase played an important part in the decolorization process. Furthermore, seven new intermediate metabolic products, including aniline, phthalic acid, 2-carboxy benzaldehyde, phenylacetic acid, benzoic acid, toluene, and 4-methyl-hexanoic acid, were identified. In addition, functional genes related with the azo dye decolorization, such as those encoding the azoreductase, laccase, FMN reductase, NADPH-/NADH-quinone oxidoreductases and NADPH-/NADH dehydrogenases, catechol dioxygenase, homogentisate 1,2-dioxygenase, protocatechuate 3,4-dioxygenase, gentisate 1,2-dioxygenase, azobenzene reductase, naphthalene 1,2-dioxygenase, benzoate/toluate 1,2-dioxygenase, and anthranilate 1,2-dioxygenase and so on were found in the metagenome of the consortium BCGR-T. Finally, a new decolorization pathway of the thermophilic consortium BCGR-T was proposed. In addition, the phototoxicity of BCGR decreased after decolorization. Overall, the thermophilic consortium BCGR-T could be a promising candidate in the treatment of high concentration azo dye wastewater at high temperatures.

Microorganism-mediated bioremediation of dyes from contaminated soil: Mechanisms, recent advances, and future perspectives

Many methods have been proposed for the remediation of dye-contaminated soils, a widespread form of environment pollution. Bioremediation, it is hoped, can combine ecological benefits with efficiency of dye decontamination. We review the types and sources of dye contaminants; their possible effects on plant, animal, and human health; and emerging strategies for microbial bioremediation. Challenges, limitations, recommendations for future research, and prospects for large-scale commercialization of microbial bioremediation are discussed.

Adaptive characteristics of indigenous microflora in an organically contaminated high salinity groundwater

Salinity, a critical factor, could directly or indirectly affect the microbial community structure and diversity. Changes in salinity levels act as environmental filters that influence the transformation of key microbial species. This study investigates the adaptive characteristics of indigenous microflora in groundwater in relation to external organic pollutants under high salinity stress. A highly mineralized shallow groundwater in Northwest China was conducted as the study area, and six representative sampling points were chosen to explore the response of groundwater hydrochemical parameters and microflora, as well as to identify the tolerance mechanisms of indigenous microflora to combined pollution. The results revealed that the dominant genera found in high salinity groundwater contaminated with organic pollutants possess the remarkable ability to degrade such pollutants even under challenging high salinity conditions, including Halomonas, Pseudomonas, Halothiobacillus, Sphingomonas, Lutibacter, Aquabacterium, Thiomicrospira, Aequorivita, etc. The hydrochemical factors, including total dissolved solids (TDS), sulfide, nitrite, nitrate, oxidation reduction potential (ORP), NH3-N, Na, Fe, benzene series, phenols, and halogenated hydrocarbons, demonstrated a significant influence on microflora. High levels of sulphate and sulfide in groundwater can exhibit dual effects on microflora. On one hand, these compounds can inhibit the growth and metabolism of microorganisms. On the other hand, they can also serve as effective electron donors/receptors during the microbial degradation of organic pollutants. Microorganisms exhibit resilience to the inhibitory effects of high salinity and organic pollutants via a series of tolerance mechanisms, such as strengthening the extracellular membrane barrier, enhancing the synthesis of relevant enzymes, initiating novel biochemical reactions, improving cellular self-healing capabilities, responding to unfavorable environmental conditions by migration, and enhancing the S cycle for the microbial metabolism of organic pollutants.

Mathematical modeling for operative improvement of the decoloration of Acid Red 27 by a novel microbial consortium of Trametes versicolor and Pseudomonas putida: A multivariate sensitivity analysis

In this work, it is presented a first approach of a mathematical and kinetic analysis for improving the decoloration and further degradation process of an azo dye named acid red 27 (AR27), by means of a novel microbial consortium formed by the fungus Trametes versicolor and the bacterium Pseudomonas putida. A multivariate analysis was carried out by simulating scenarios with different operating conditions and developing a specific mathematical model based on kinetic equations describing all stages of the biological process, from microbial growth and substrate consuming to decoloration and degradation of intermediate compounds. Additionally, a sensitivity analysis was performed by using a factorial design and the Response Surface Method (RSM), for determining individual and interactive effects of variables like, initial glucose concentration, initial dye concentration and the moment in time for bacterial inoculation, on response variables assessed in terms of the minimum time for: full decoloration of AR27 (R1 = 2.375 days); maximum production of aromatic metabolites (R2 = 1.575 days); and full depletion of aromatic metabolites (R3 = 12.9 days). Using RSM the following conditions improved the biological process, being: an initial glucose concentration of 20 g l-1, an initial AR27 concentration of 0.2 g l-1 and an inoculation moment in time of P. putida at day 1. The mathematical model is a feasible tool for describing AR27 decoloration and its further degradation by the microbial consortium of T. versicolor and P. putida, this model will also work as a mathematical basis for designing novel bio-reaction systems than can operate with the same principle of the described consortium.

Potential Environmental Contaminants: Exploring Hydrolyzed Dyes in Household Washing Sources and Electrochemical Degradation

Reactive dyes are often released into the environment during the washing process due to their susceptibility to hydrolysis. The hydrolysis experiment of a pure reactive dye, red 195 (RR 195), and the washing experiment of RR 195-colored fabrics (CFSCs) were carried out successively to explore the sources of hydrolyzed dyes in the washing microenvironment. Reversed-phase high-performance liquid chromatography (RP-HPLC) was used for the analysis of hydrolysis intermediates and final products of reactive red 195. The experimental results indicated that the structure of the dye washing shed is consistent with the final hydrolysate of reactive red 195, which is the main colored contaminant in washing wastewater. To eliminate the hydrolyzed dyes from the source, an electrochemical degradation device was designed. The degradation parameters, including voltage, electrolyte concentration, and dye shedding concentration are discussed in the electrochemical degradation experiment. The electrochemical degradation device was also successfully implemented and verified in a home washing machine.

Microbial diversity, transformation and toxicity of azo dye biodegradation using thermo-alkaliphilic microbial consortia

In this research, the transformation and toxicity of Reactive Red 141 and 239 biodegraded under anaerobic-aerobic conditions as well as metagenomic analysis of Reactive Red 239 degrading microbial consortia collected from Shala Hot spring were investigated. Toxicity of dyes before treatment and after treatment on three plants, fish and microorganisms were done. A halotolerant and thermo-alkaliphilic bacterial consortia decolorizing azo dyes (>98% RR 141 and > 96% RR 239 in 7 h) under optimum conditions of salt concentration (0.5%), temperature (55 °C) and pH (9), were used. Toxicity effect of untreated dyes and treated dyes in Tomato > Beetroot > Cabbage plants, while the effect was Leuconostoc mesenteroides > Lactobacillus plantarum > Escherichia coli in microorganisms. Among fishes, the toxicity effect was highest in Oreochromis niloticus followed by Cyprinus carpio and Clarias gariepinus. The three most dominant phyla that could be in charge of decolorizing RR 239 under anaerobic-aerobic systems were Bacteroidota (22.6-29.0%), Proteobacteria (13.5-29.0%), and Chloroflexi (8.8-23.5%). At class level microbial community structure determination, Bacteroidia (18.9-27.2%), Gammaproteobacteria (11.0-15.8%), Alphaproteobacteria (2.5-5.0%) and Anaerolineae (17.0-21.9%) were dominant classes. The transformation of RR 141 and RR 239 into amine compounds were proposed via high performance liquid chromatography-mass spectroscopy (HPLC/MS) and fourier transform infrared spectroscopy (FT-IR). Overall, dye containing wastewaters treated under anaerobic-aerobic systems using thermo-alkaliphilic microbial consortia were found to be safe to agricultural (fishes and vegetables) purposes.

Leveraging molecular docking to understand Congo red degradation by Staphylococcus caprae MB400

Congo red (CR) is a genotoxic, sulphonated azo dye and poses significant pollution problem. We hereby report its degradation by Staphylococcus caprae MB400. The bacterium initially propagated as a suspected contaminant upon CR dye supplemented nutrient agar plates, forming zones of clearance around its growth area. The bacterium was purified, gram stained and identified as Staphylococcus caprae via 16S rRNA gene sequencing. Dye decolourization was analysed in liquid culture, and Fourier-transform infrared spectroscopy (FTIR) was conducted for analysis of degraded product/metabolites. A decolourization of ~ 96.0% at 100 µg/ml concentration and pH 7 after 24 h of incubation was observed. Structure of the azoreductase enzyme, responsible for breakage of the bond in the dye and ultimately decolourization, was predicted, and molecular docking was harnessed for understanding the mechanism behind the reduction of azo bond (-N=N-) and conversion to metabolites. Our analysis revealed 12 residues critical for structural interaction of the azoreductase enzyme with this dye. Among these, protein backbone region surrounding four residues, i.e. Lys65, Phe122, Ile166 and Phe169, showed major displacement changes, upon binding with the dye. However, overall the conformational changes were not large.

Bioremediation of reactive orange 16 by industrial effluent-adapted bacterial consortium VITPBC6: process optimization using response surface methodology (RSM), enzyme kinetics, pathway elucidation, and detoxification

Textile effluent is one of the most hazardous industrial pollutant sources. It is generated in huge volumes and contains a wide array of toxicants. Reactive azo dyes, which are xenobiotic compounds, are predominantly utilized by textile industries for dyeing cotton, viscose, wool, and silk. The conventional physicochemical treatments used by industrial effluent treatment plants are ineffective in dye degradation. The present study thus attempted to find a potential treatment for reactive azo dyes. A novel bacterial consortium VITPBC6 was constructed with the most potent and compatible reactive orange 16 (RO-16) decolorizing isolates of tannery and textile effluents, and the isolates were identified as Bacillus flexus VITSP6, Bacillus paraflexus VITSPB7, Bacillus megaterium VITSPB9, Bacillus firmus VITEPB1, B. flexus VITEPB2, and Bacillus aryabhattai VITEPB3. The physicochemical factors of RO-16 decolorization were optimized by response surface methodology. Consortium VITPBC6 was able to tolerate a high concentration of RO-16 up to 800 mg L^-1. A cocktail of enzymes including azoreductase, tyrosinase, laccase, lignin peroxidase, and manganese peroxidase was involved in RO-16 degradation by VITPBC6. Consortium VITPBC6 degraded RO-16 following zero-order reaction. The enzymes of consortium VITPBC6 had a V_max of 352 mg L^-1 day^-1 for RO-16 degradation; however, the K_m value was high. VITPBC6 biodegraded RO-16 resulting in the formation of small aromatic compounds. Lastly, different toxicity assays conducted with untreated RO-16 and its corresponding biodegraded metabolite revealed that the toxicity of biodegraded metabolites was significantly lower than the untreated dye.

Low salinity enhances azo dyes degradation in aerobic granular sludge systems: Performance and mechanism analysis

The biodegradation performance of azo dyes can be enhanced under low salinity conditions, but the internal biodegradation mechanism is still unclear. Aerobic granular sludge (AGS), a salt-tolerant biological wastewater treatment technology, was used in this study to explore the enhancement mechanism of acid orange 7 (AO7) degradation at low salinity level (1.0 %). Results indicated that the AGS structure and reactor performance were almost unaffected by different AO7 concentrations (5-10 mg/L). Compared with salt-free conditions, the AO7 removal efficiency was elevated by 9.9 %-19.0 % at 1.0 % salinity level, owing to the enrichment of AO7 decolorizing bacteria (e.g. Acinetobacter) and functional enzymes (e.g. FMN-dependent azoreductase). The up-regulated genes involving in the key metabolic functions (e.g. carbon metabolism and oxidative phosphorylation) promoted the electron and energy production, thereby facilitating the AO7 decolorization and degradation. These results aid understanding of the enhancement mechanism of AO7 biodegradation under low salinity conditions from macroscopic and microscopic perspectives.

Tailor-made novel electrospun polycaprolactone/polyethyleneimine fiber membranes for laccase immobilization: An all-in-one material to biodegrade textile dyes and phenolic compounds

In spite of many works on the biodegradation of textile dyes and phenolic compounds, we propose a new, inexpensive, environmentally friendly, and sustainable material based on electrospun fiber and immobilized laccase. The polycaprolactone (PCL)/polyethyleneimine (PEI) electrospun fibers were optimized and prepared by electrospinning technique according to the operational parameters like PCL concentration (12 wt%), PEI concentration (10 wt%), voltage (16 kV), needle tip-collector distance (20 cm), and injection speed (0.7 mL/h). Next, characterization studies were performed to investigate the morphology and structure of the electrospun fibers without and with laccase. The crude laccase was obtained by cultivating the white rot fungus T. trogii (TT), and T. versicolor (TV). The resulting electrospun fibers showed a smooth surface with a mean diameter of around 560 nm, and larger diameters were observed after laccase immobilization. According to the results, immobilization increased the stability properties of laccase such as storage, and operational. For instance, the residual activity of the PCL/PEI/TTL and PCL/PEI/TVL after 10 repeated cycles, was 33.2 ± 0.2% and 26.0 ± 0.9%, respectively. After 3 weeks of storage, they retained around 30% of their original activity. Moreover, the PCL/PEI/TTL and PCL/PEI/TVL were found to possess high decolorization yield to remove Orange II and Malachite Green textile dyes from solutions imitating polluted waters. Among them, the PCL/PEI/TTL exhibited the highest decolorization efficiencies of Orange II and Malachite Green after 8 continuous uses at pH 5 and a temperature of 50 °C, reaching over 86%, and 46%, respectively. Moreover, PCL/PEI/TTL and PCL/PEI/TVL effectively degraded the 2,6-dichlorophenol phenolic compound at an optimal pH and temperature range and exhibited maximum removal efficiency of 52.6 ± 0.1% and 64.5 ± 7.6%, respectively. Our approach combines the advantageous properties of electrospun fiber material and immobilization strategy for the efficient use of industrial scale important enzymes such as laccase in various enzymatic applications.

Preparation of Fe3O4@Fe(0) immobilized enzyme to enhance the efficient degradation of methoxychlor

The presence of methoxychlor (MXC) in soil and wastewater is considered a nonnegligible environmental threat. Herein, Fe₃O₄@Fe(0) was obtained by NaBH₄ reduction of Fe₃O₄ nanoparticles and served as a carrier for laccase to construct catalyst. The catalyst was evaluated for the degradation of MXC in treated wastewater and soil with 2, 2'-azino-bis (3-ethylbenzothiazoline-6-sulfonic acid) (ABTS) being used as cocatalyst. The removal rate of MXC in wastewater and soil was found to be 89% and 88% in optimum conditions, and the influences of initial MXC concentration, pH, and temperature on the degradation rate were evaluated. The metabolites including 2-methylpentane, 3-methylpentane, and n-pentane of MXC were identified, and possible degradation mechanisms were proposed. Overall, this work successfully demonstrates not only the ability to degrade MXC in different circumstances but also provides a new idea for environmental remediation in the future.

A novel combination of immobilized Enterococcus casseliflavus sp. nov. with silver nanoparticles into a reusable matrix of Ca-Alg beads as a new strategy for biotreatment of Disperse Blue 183: Insights into metabolic characterization, biotoxicity, and mutagenic properties

Recent advances in immobilized biologic systems for decolorizing azo dyes are gaining great attention due to microorganisms like bacteria and nanoparticles that could stimulate decolorization. Enhanced decolorization performance was observed in this study, indicating the great potential of the immobilized complex of bacterial cells and AgNPs as an alternative to the traditional biological processes to improve the performance of biological systems. The biodegradation and decolorization of Disperse Blue183 (DB 183) were investigated utilizing a novel combination of Enterococcus casseliflavus strain A₂ mediated by silver nanoparticles synthesized by Marinospirillum alkaliphilum strain N in three different conditions. Ⅰ: free bacterial strain A₂ (100% dye removal in 72 h), Ⅱ: immobilized bacterial strain A₂ in Ca-Alg beads (100% dye removal in 15 h), and Ⅲ: immobilized bacterial strain A₂ with silver nanoparticles (AgNPs) as support in Ca-Alg beads (100% dye removal in 9 h). The presence of bacterial cells and nanoparticles in Ca-Alg beads was assessed and proved by scanning electron microscope (SEM) and X-ray energy diffraction (EDX) analysis. Moreover, DB 183 and its decolorization metabolites were evaluated by applying UV-Vis, infrared spectroscopy (FTIR), and GC/MS, and the results showed that the dye was degraded. The antimicrobial effect, brine shrimp toxicity (BST) test, and mutagenicity assay in the presence and absence of metabolic activation (+S9/-S9) were run to assess DB 183 and metabolite obtained from biodegradation. The antimicrobial activity of DB 183 disappeared after treatment. Further, the results of the BST test determined that the dye has moderate biotoxicity (LC₅₀:0.064 mg/mL), and the after-treatment product was not toxic. According to the Ames test, DB 183 had mutagenicity effect (69-84%), and the metabolic activation increased the mutagenicity of the dye) 12-25%). However, the percentage mutagenicity of decolorization products decreased, ranging from 50 to 80% without activation (-S9) and 83-96% in present activation (+S9). This work used the immobilized bacterial cells and AgNPs Ca-Alg gel beads for the first time to introduce this kind of system as a suitable technique for rapid decolorization. Using this application enables a remarkable reduction in the time dedicated to the bioremediation of dyeing wastewater.

Biofilm-mediated decolorization, degradation and detoxification of synthetic effluent by novel biofilm-producing bacteria isolated from textile dyeing effluent

Biofilm-mediated bioremediation of xenobiotic pollutants is an environmental friendly biological technique. In this study, 36 out of 55 bacterial isolates developed biofilms in glass test tubes containing salt-optimized broth plus 2% glycerol (SOBG). Scanning electron microscopy, Fourier transform infrared (FTIR) spectroscopy, and Congo red- and Calcofluor binding results showed biofilm matrices contain proteins, curli, nanocellulose-rich polysaccharides, nucleic acids, lipids, and peptidoglycans. Several functional groups including -OH, N-H, C-H, CO, COO^-, -NH_2, PO, C-O, and C-C were also predicted. By sequencing, ten novel biofilm-producing bacteria (BPB) were identified, including Exiguobacterium indicum ES31G, Kurthia gibsonii ES43G, Kluyvera cryocrescens ES45G, Cedecea lapagei ES48G, Enterobacter wuhouensis ES49G, Aeromonas caviae ES50G, Lysinibacillus sphaericus ES51G, Acinetobacter haemolyticus ES52G, Enterobacter soli ES53G, and Comamonas aquatica ES54G. The Direct Red (DR) 28 (a carcinogenic and mutagenic dye used in dyeing and biomedical processes) decolorization process was optimized in selected bacterial isolates. Under optimum conditions (SOBG medium, 75 mg L^-1 dye, pH 7, 28 °C, microaerophilic condition and within 72 h of incubation), five of the bacteria tested could decolorize 97.8% ± 0.56-99.7% ± 0.45 of DR 28 dye. Azoreductase and laccase enzymes responsible for biodegradation were produced under the optimum condition. UV-Vis spectral analysis revealed that the azo (-NN-) bond peak at 476 nm had almost disappeared in all of the decolorized samples. FTIR data revealed that the foremost characteristic peaks had either partly or entirely vanished or were malformed or stretched. The chemical oxygen demand decreased by 83.3-91.3% in the decolorized samples, while plant probiotic bacterial growth was indistinguishable in the biodegraded metabolites and the original dye. Furthermore, seed germination (%) was higher in the biodegraded metabolites than the parent dye. Thus, examined BPB could provide potential solutions for the bioremediation of industrial dyes in wastewater.

Evaluating the potential of thermo-alkaliphilic microbial consortia for azo dye biodegradation under anaerobic-aerobic conditions: Optimization and microbial diversity analysis

Wastewaters in textile industry are mainly characterized by higher pH, color, salt and chemical oxygen demand (COD) values, which are environmentally undesirable. Among these textile effluent characteristics, color removal is the most challenging task. In this study, the potential of Rift Valley halotolerant and thermo-alkaliphilic microbial consortia (collected from Shala hot spring located in Ethiopia) for azo dye biodegradation under anaerobic-aerobic conditions were evaluated. Optimization and microbial diversity analysis were done using Reactive Red 141. Under optimum conditions of pH (9), temperature (55 °C), salinity (0.5%), and nutrients, microbial consortia can remove >98% color and 92.7 ± 7.3% COD under anaerobic and aerobic conditions, respectively. In addition, the consortia was capable of decolorizing initial dye concentrations of 100-1000 mg/L, and various dye types including Everzol Blue LX, RY 84, RR 239, RB 198 and RY 700. The 16S rRNA gene sequence results showed that Bacteroidetes (25.3%) > Proteobacteria (21.0%) > Chloroflexi (18.5%) > Halobacterota (6.2%) dominant phyla. Based on the findings, non-color effluent adapted Rift Valley halotolerant and thermo-alkaliphilic bacterial consortia can be a potential candidate for bioremediation of textile and other industries characterized by higher salinity, temperature and pH.

Azo dyes degradation by microorganisms - An efficient and sustainable approach

Synthetic aromatic compounds consisting of various functional groups are known as dyes. These colored compounds are often discharged in effluents, and they are very dangerous to aquatic life. Basically, the dye industry started by using natural plant and insect sources, and then suddenly turned into artificial manufacturing. Natural equilibrium of our environment gets changed by the reduction in photosynthetic activity due to the dyes. In China 900,000 tons of all kinds of dyes are usually produced, which are used in many industries like food, textile, food, paper and leather. Untreated wastewater contaminates aquatic bodies by causing eutrophication, change in water color, oxygen depletion which affect aquatic organisms to a great extent. Dye wastewater is now the key environmental pollution form. In recent eras an extensive study line has been developed to explore the dye decolorization and biodegradation under both aerobic as well as anaerobic conditions. In this review, the chemistry, toxicity and microbial biodegradation/decolorization are presented. Some recent studies along with the new techniques and methodologies of remediating the dye pollution are also discussed to provide the bases of their handling. Overall, efficient and high biodegradation potential make microbes an impending foundation for green chemistry to eradicate toxic dyes from industrial wastewater.

Degradation of phenanthrene by consortium 5H under hypersaline conditions

PAHs have been widely detected to accumulate in saline and hypersaline environments. Moderately halophilic microbes are considered the most suitable player for the elimination of PAHs in such environments. In this study, consortium 5H was enriched under 5% salinity and completely degraded phenanthrene in 5 days. By high-throughput sequencing, consortium 5H was identified as being mainly composed of Methylophaga, Marinobacter and Thalassospira. Combined with the investigation of intermediates and enzymatic activities, the degradation pathway of consortium 5H on phenanthrene was proposed. Consortium 5H was identified as having the ability to tolerate a wide range of salinities (1%-10%) and initial PAH concentrations (50 mg/L to 400 mg/L). It was also able to function under neutral to weak alkaline conditions (pH from 6 to 9) and the phytotoxicity of the produced intermediates showed no significant difference with distilled water. Furthermore, the metagenome of consortium 5H was measured and analyzed, which showed a great abundance of catabolic genes contained in consortium 5H. This study expanded the knowledge of PAH-degradation under hypersaline environments and consortium 5H was proposed to have good potential for the elimination of PAH pollution in saline/hypersaline environments.

Biodegradation and Detoxification of Azo Dyes by Halophilic/Halotolerant Microflora Isolated From the Salt Fields of Tibet Autonomous Region China

This study aimed to decolorize azo dyes in high-salt industrial wastewater under high-salt and low oxygen conditions using extreme halophilic/halotolerant bacteria screened from the salt fields of Tibet, which consisted of Enterococcus, unclassified Enterobacteriaceae, Staphylococcus, Bacillus, and Kosakonia. Under the optimal conditions, 600 mg/l Congo red, Direct Black G (DBG), Amaranth, methyl red, and methyl orange could be completely decolorized in 24, 8, 8, 12, and 12 h, respectively. When the DBG concentration was 600 mg/l, NADH–DCIP, laccase, and azo reductase were confirmed to be the primary reductase and oxidase during the degradation process, and the degradation pathways were verified. The microflora could not only tolerate changes in salt concentrations of 0–80 g/l, but also displayed strong degradative ability. Under high-salt concentrations (≥ 60 g/l NaCl), NADH–DCIP reductase was primarily used to decolorize the azo dye. However, under low salt concentrations (≤ 40 g/l NaCl), azo reductase began to function, and manganese peroxidase and lignin peroxidase could cooperate to participate in DBG degradation. Additionally, the halophilic/halophilic microflora was shown to convert the toxic DBG dye to metabolites of low toxicity based on phytotoxicity analysis, and a new mechanism for the microflora to degrade DBG was proposed based on intermediates identified by liquid chromatography-mass spectrometry (LC–MS). This study revealed that the halophilic/halophilic microflora has effective ecological and industrial value for treating wastewater from the textile industry.

Decolourization of azo dye using a batch bioreactor by an indigenous bacterium Enterobacter aerogenes ES014 from the waste water dye effluent and toxicity analysis

Effluents of textile industries caused serious environmental problem throughout the world. In this study, a total of 23 bacterial strains from five bacterial species were isolated from the dye effluent. Of these strains, a unique and novel Enterobacter aerogenes ES014 was utilized for dye decolourization and toxicity analysis. The selected strain could effectively decolourize three selected azo dyes. It showed the capability for decolourizing acid orange (82.3 ± 3.6%), methyl orange (78.2 ± 3.3%), and congo red (81.5 ± 3.2%). The selected bacterial strain significantly decolourized 100 mg/L acid orange at 35 °C, pH 7.5 with 6% sodium chloride concentration. Most of the tested nitrogen and carbon sources effectively enhanced decolourization process. It showed the ability to decolourize acid orange in the culture medium containing 1.5% glucose (100 ± 2.8%) and 0.8% beef extract (100 ± 3.1%). A laboratory-scale batch bioreactor was used to decolourize azo dye at optimized culture conditions. The decolourizing ability improved with 100 mL/h hydraulic retention time. The treated wastewater quality was improved due to sharp depletion of Total Dissolved Solids (TDS), pH, Chemical Oxygen Demand (COD), alkalinity and sulphate concentration. The selected bacteria has the potential to produce dye degrading laccase. Laccase was detected during fermentation process in batch bioreactor as a key enzyme for decolourization produced by E. aerogenes ES014. Phytotoxicity and acute toxicity analysis were performed using Arachis hypogaea (pea nut) seed and first instar larvae of Artemia parthenogenetica (brine shrimp). The seed germination rate of treated wastewater was improved (94.3 ± 1.8%) and enhanced survival rate (91.7 ± 2.9%) in the first instar Artemia larvae treated with wastewater after 24 h. Overall, E. aerogenes ES014, might be a promising bacterial strain for the treatment of textile effluents with high azo dye concentrations.

Solid leather wastes as adsorbents for cationic and anionic dye removal

The removal of anionic and cationic dyes from aqueous solutions was investigated by different leather shavings, which are solid wastes generated in the leather industry. Wet-blue leather shavings (WB), vegetable-tanned leather shavings (VT), pickled hide (not tanned) shavings (PIC) and wet-white leather (pre-tanned) shavings (WW) were used. The cationic dye was Basic Red 2 and the anionic dye was Acid Brown 414. Point of zero charge, functional groups, shrinkage temperature and adsorbent surface area were characterized. The point of zero charge was 4.0, 6.0, 3.9 and 4.1 for WB, VT, PIC and WW, respectively. The specific surface area showed low values which was expected for this type of material. Tanning agent influence was verified through shrinkage temperature analysis of leather shavings. Main functional groups of the acid dye and the collagen structure of the solid wastes were determined. The tests with Basic Red 2 solutions showed only VT had a considerable removal for this cationic dye (96.7%). The tests with Acid Brown 414 were carried out with different contact times and adsorbent mass. Results showed high efficiency of WW and PIC, whose percentages of dye removal were above 96% at contact time of 30 min and above 90% using 20 mg of adsorbent. In this way, the final dye removal was 98.1% and 98.3% for contact time tests and 97.7% and 98% for adsorbent mass tests for WW and PIC, respectively. These results highlight the promising use of leather shavings as alternative adsorbents for the treatment of wastewater containing dyes.

Zein adsorbents with micro/nanofibrous membrane structure for removal of oils, organic dyes, and heavy metal ions in aqueous solution

Developing multi-functional media for effectively removing different contaminants coexisted in wastewater system is highly desired. Herein, zein, a natural protein possessing abundant functional groups in molecule, is chosen to be fabricated into micro/nanofibrous membranes as adsorbents and separation media. Zein fibers with novel groove ribbon structures, which possess better structural characteristics, are designed for obtaining good adsorption performance. The adsorption performances of zein fiber membranes are evaluated. The results show that zein fiber membranes have the adsorption capacities up to 94 g/g for motor oil, 168 mg/g for Congo red, and 189 mg/g for Pb²⁺ ion for 1000 mg/L initial solution concentration, showing considerable competitiveness as compared with the reported adsorbents. The zein membrane with groove ribbon fiber morphology exhibits optimal adsorption capability and can be attractive multi-functional separation media.

Review on effect of different type of dyes on advanced oxidation processes (AOPs) for textile color removal

The textile industry is one of the most valuable industries, especially in developing countries, because it employs a large portion of the workforce. However, the development of the textile industry has led to increasing concern about environmental issues. Wastewater from the textile industry has a high COD and an undesirable color. Color is one of the problems with the wastewater due to its toxicity and low biodegradability. Color in textile wastewater mainly originates from the dyestuff used during the dyeing or printing process. Amongst all of available technology for color removal, advanced oxidation processes (AOPs) are considered one of the best and the most potential technology. However, the understanding of AOPs reaction mechanism to degrade dyestuff is still limited. In general, dyes degradation mechanism will vary and mainly depend on the chemical structure of the dyes itself. Some reaction pathway that seems less favorable thermodynamically can still happen during the process. Understanding the mechanism will be beneficial for future dyes improvement, especially on developing the moiety of the aromatic compound in order to produce easily degraded dyes while maintaining the fastness quality.

Enzymatic biodegradation, kinetic study, and detoxification of Reactive Red-195 by Halomonas meridiana isolated from Marine Sediments of Andaman Sea, India

Azo dyes are a significant class of hazardous chemicals that are extensively utilised in diverse industries. Industries that manufacture and consume reactive azo dyes generate hyper-saline wastewater. The ability of halotolerant bacteria to thrive under extreme environmental conditions thus makes them a potential candidate for reactive azo dye degradation. An efficient halotolerant bacterium (isolate SAIBP-6) with the capability to degrade 87.15% of azo dye Reactive Red 195 (RR-195) was isolated from sea sediment and identified as Halomonas meridiana SAIBP-6. Strain SAIBP-6 maintained potential decolourisation under a wide range of environmental conditions viz. 35-45°C temperature, 50-450 mg/L RR-195, pH 7-9, and 50-150 g/L NaCl. However, maximum decolourisation occurred at 40°C, 200 mg/L RR-195 dye, pH 9, and 50 g/L NaCl, under static conditions. Tyrosinase and azoreductase were responsible for dye degradation. The reaction catalysed by these enzymes followed zero-order kinetics. The maximum velocity (Vmax) of the enzymatic reaction was 4.221 mg/(L.h) and the Michaelis constant (Km) was 517.982 mg/L. Strain SAIBP-6 also efficiently decolourised Reactive Black-5 and Reactive Yellow-160 dye. The biodegradation process was further studied with the help of UV-Vis spectral scan, ultra-high performance liquid chromatography (UPLC), fourier-transform infra-red spectroscopy (FT-IR), and proton nuclear magnetic resonance (¹H NMR) analysis. Finally, cytogenotoxicity assay conducted with the meristematic root tip cells of Allium cepa and phytotoxicity assay conducted with the seeds of Vigna mungo led to the inference that strain SAIBP-6 significantly reduced the toxicity of RR-195 after biodegradation.

Degradation of Azo Dyes: Bacterial Potential for Bioremediation

The use of dyes dates to ancient times and has increased due to population and industrial growth, leading to the rise of synthetic dyes. These pollutants are of great environmental impact and azo dyes deserve special attention due their widespread use and challenging degradation. Among the biological solutions developed to mitigate this issue, bacteria are highlighted for being versatile organisms, which can be applied as single organism cultures, microbial consortia, in bioreactors, acting in the detoxification of azo dyes breakage by-products and have the potential to combine biodegradation with the production of products of economic interest. These characteristics go hand in hand with the ability of various strains to act under various chemical and physical parameters, such as a wide range of pH, salinity, and temperature, with good performance under industry, and environmental, relevant conditions. This review encompasses studies with promising results related to the use of bacteria in the bioremediation of environments contaminated with azo dyes in the most diverse techniques and parameters, both in environmental and laboratory samples, also addressing their mechanisms and the legislation involving these dyes around the world, showcasing the importance of bacterial bioremediation, specialty in a scenario in an ever-increasing pursuit for sustainable production.

Sustainable carbonaceous biochar adsorbents derived from agro-wastes and invasive plants for cation dye adsorption from water

This study investigated methyl orange (MO) dye adsorption using three biochars produced from agro-waste and invasive plants; the latter consisted of wattle bark (BA), mimosa (BM), and coffee husks (BC). BC had the lowest specific surface area (2.62 m²/g) compared to BA (393.15 m²/g) and BM (285.53 m²/g). The adsorption efficiency of MO was stable at pH 2-7 (95%-96%), whilst it had reduced stability at pH 7-12. Between 0 and 30 min, MO adsorption efficiency was >82%, and at 120 min, representative adsorption equilibrium had occurred. The maximum adsorption capacity of the biochars was 12.3 mg/g. The underlying adsorption mechanisms of the three biochars were governed by electrostatic adsorption and pore diffusion. There was an abundance of active sites for adsorption in BA and BM, while chemical adsorption appeared to be more vital for BC, as it contained more functional groups on its surface. The highest MO adsorption efficiency occurred with BM. BC was not recommended for MO removal, as it was observed to stain the water when a dose exceeding 5.0 g/L was utilized.

Efficient biodegradation of Congo red dye using fungal consortium incorporated with Penicillium oxalicum and Aspergillus tubingensis

A novel approach had been carried out to develop fungal consortium, namely, RH-2, containing two marine procured fungal isolates in order to evaluate biodegradation of recalcitrant diazo dye Congo red. The fungi were isolated from the seacoast of Diu, India. According to the ITS sequencing, the strains were identified as Penicillium oxalicum (DS-2) and Aspergillus tubingensis (DS-4). Discs of 12 mm were cut out from the edge of both the fungal isolates (DS-2 and DS-4) and inoculated in flasks consisting of potato dextrose broth with 100 mg/L Congo red for the development of fungal consortium RH-2. The degradation by the fungal consortium RH-2 was more effective than the fungal monocultures DS-2 and DS-4 with the respective degradation reaching 97.15 ± 0.15%, 68.96 ± 0.09%, and 29.96 ± 0.21% in addition of yeast extract (1% w/v) within 12 h. The influence of dextrose (1% w/v), yeast extract (1% w/v), pH 5, and salt concentration (1% w/v) enhanced the degradation potential of fungal consortium RH-2. The maximal degradation was correlated with the production of laccase (12.498 ± 0.21 U/mL) and manganese peroxidase (10.314 ± 0.25 U/mL). The catabolism of Congo red was confirmed by UV-Visible spectroscopic analysis (Congo red λ-max = 499 nm) and ATR-FTIR spectroscopic analysis. The filtrates obtained after Congo red degradation were also evaluated for microbial toxicity against bacteria (Bacillus haynesii) and phytotoxicity analysis on plant seed (Trigonella foenum) which revealed that the filtrate acquired after the treatment of Congo red by fungal consortium RH-2 was less toxic than the original dye in nature. A novel aspect is determined by the evidence of mutualistic interaction between two different fungi for the rapid decolorization and degradation of dye providing a prospective of utilizing the developed consortium RH-2 as a cost-effective approach in textile wastewater treatment for cleaner environment.

Recent advances in the biodegradation of azo dyes

As dye demand continues to rapidly increase in the food, pharmaceutical, cosmetic, paper, textile, and leather industries, an industrialization increase is occurring. Meanwhile, the degradation and removal of azo dyes have raised broad concern regarding the hazards posed by these dyes to the ecological environment and human health. Physicochemical treatments have been applied but are hindered by high energy and economic costs, high sludge production, and chemicals handling. Comparatively, the bioremediation technique is an eco-friendly, removal-efficient, and cost-competitive method to resolve the problem. This paper provides scientific and technical information about recent advances in the biodegradation of azo dyes. It expands the biodegradation efficiency, characteristics, and mechanisms of various microorganisms containing bacteria, fungi, microalgae, and microbial consortia, which have been reported to biodegrade azo dyes. In addition, information about physicochemical factors affecting dye biodegradation has been compiled. Furthermore, this paper also sketches the recent development and characteristics of advanced bioreactors.

Development and characterization of a halo-thermophilic bacterial consortium for decolorization of azo dye

Textile wastewater is characterized by high salinity and high temperature, and azo dye decolorization by mixed cultures under extreme salinity and thermophilic environments has received little attention. High salinity and temperature inhibit the biodecolorization efficiency in textile wastewater. In the present study, a halo-thermophilic bacterial consortium (HT1) that can decolorize azo dye at 10% salinity and 50 °C was enriched. Bacillus was the dominant genus, and this genus may play a key role in the decolorization process. HT1 can decolorize metanil yellow G (MYG) at a wide range of pH values (6-8), temperatures (40-60 °C), dye concentrations (100-200 mg/L) and salinities (1-15%). Laccase, manganese peroxidase, lignin peroxidase and azoreductase are involved in the decolorization process of MYG. In addition, the decolorization pathway of MYG was proposed based on GC-MS and FTIR results. The toxicity of MYG decreased after decolorization by HT1. A metagenomic sequencing approach was applied to identify the functional genes involved in degradation. Overall, this halo-thermophilic bacterial consortium could be a promising candidate for the treatment of textile wastewater under elevated temperature and salinity conditions.

Decolorization of Synthetic Azo Dyes under Anaerobic Condition in A Continuous Stirred Tank Reactor

Biological treatment for textile wastewater always has a limitation in term of time of reaction and uncertainty along the process. This study focused on the decolorization of synthetic azo dyes in batch reactors with controlled thermotolerant anaerobic conditions. Less-volatile digested sludge collected from a palm oil biogas reactor was used as the organic biodegradation agent for azo dyes. Digested sludge contains high amounts of microbes with uncertain species viable for decolorization purposes. Sodium acetate trihydrate (C2H9NaO5) was used as carbon source and mixed with a specific composition of minimum salt media (MSM) in batch reactors as an additional nutrient. Digested sludge both in mesophilic (35°C) and thermophilic (55°C) conditions were found to be capable of decolorizing 100, 200 and 300 ppm of three types of azo dyes: Reactive Green 19 (45.56%, 69.73%; 63%, 73.49%; 70.02%, 75.92%), Reactive Orange 16 (46.08%, 78.4%; 64.21%, 85.52%; 74.95%, 85.91%) and Reactive Red 120 (29.11%, 85.32%; 63.35%, 87.69%; 72.02%, 89.5%) respectively after 7 days incubation time. Statistical analysis also showed that the anaerobic thermophilic conditions had significantly accelerated the decolorization process. The anaerobic thermophilic environment will be a good factor to include in future textile wastewater treatment plants.

Enhanced azo dye biodegradation at high salinity by a halophilic bacterial consortium

The aim of this work was to study the bioaugmentation of hydrolysis acidification (HA) by a halophilic bacterial consortium. A bacterial consortium was enriched at 5% salinity, and it decolorized metanil yellow G (MYG) at salinities of 1%-15% and dye concentrations of 100-400 mg/L under static conditions. A HA system was constructed to assess the effectiveness of bioaugmentation by the halophilic bacterial consortium. The HA system showed obviously better performance for decolorization and COD_Mn removal and presented higher the 5-day biological oxygen demand (BOD₅)/COD_Mn (B/C) ratio after bioaugmentation. MiSeq sequencing results indicated that the bacterial communities remarkably shifted and that the bacterial diversity was increased after bioaugmentation. Marinobacterium invaded the native microbe community and became the dominant bacterial genus in the bioaugmented HA, and it played a key role in azo dye decolorization. Therefore, bioaugmentation with a halophilic bacterial consortium improved the HA system for decolorization of azo compounds.

Modification of screen-printed gold electrode with 1,4-dithiothreitol: application to sensitive voltammetric determination of Sudan II

Objectives

The aim of this study is to investigate the electrochemical behavior of Sudan II (SuII) using a screen-printed gold electrode (SPGE) modified with 1,4-dithiothreitol (DTT) and to determine the amount of Sudan II by voltammetry.

Materials and Methods

A DTT-modified screen-printed gold electrode (DTT/SPGE) was fabricated and its application for differential pulse voltammetric (DPV) determination of SuII was reported. Fourier transform infrared spectroscopy (FT-IR), cyclic voltammetry and electrochemical impedance spectroscopy were used for the characterization of the modified electrode. The effects of instrumental and chemical parameters were optimized for the determination of SuII. The fabricated electrode was used for the analysis of SuII in fortified and real samples. High-performance liquid chromatography was preferred as a reference method for the evaluation of the obtained voltammetric results.

Results

The electrochemical studies and FT-IR demonstrated that the SPGE was modified with DTT. The obtained peak current at DTT/SPGE was 6.67 times higher than that recorded with SPGE. At the optimized conditions of DPV in pH = 2.5 of H2SO4, the oxidation peak current of SuII was proportional to its concentration in range: 0.001–1.500 μmol l–1 with a detection limit of 0.0002 μmol l–1 (S/N = 3). For the analysis of SuII, 101.67%–104.33% of recovery percentage was obtained.

Conclusions

A new electrode was successfully improved for the determination of SuII. This highly selective and sensitive electrode supplied the fast determination of SuII in ketchup, chili sauce and salsa dip sauce. In addition, voltammetric and chromatographic results are found to be consistent.

Application of macroalgal biomass derived biochar and bioelectrochemical system with Shewanella for the adsorptive removal and biodegradation of toxic azo dye

The present study aimed towards adsorptive removal of the toxic azo dye onto biochar derived from Eucheuma spinosum biomass. Characterization of the produced biochar was performed using X-ray diffraction (XRD), scanning electron microscopy (SEM), X-ray photoelectron spectroscopy (XPS), Fourier transform infrared spectroscopy (FTIR), and Brunauer-Emmett-Teller (BET). Eucheuma spinosum biochar (ES-BC) produced at 600 °C revealed a maximum adsorption capacity of 331.97 mg/g towards reactive red 120 dye. The adsorption data fitted best to the pseudo-second order kinetics (R² > 0.99) and Langmuir isotherm (R² > 0.98) models. These adsorption models signified the chemisorption mechanism with monolayer coverage of the adsorbent surface with dye molecules. Furthermore, the adsorption process was mainly governed by electrostatic interaction, ion exchange, metal complexation, and hydrogen bonding as supported by the solution pH, FTIR, XPS, and XRD investigation. Nevertheless, alone adsorption technology could not offer a complete solution for eliminating the noxious dyes. Therefore, the bioelectrochemical system (BES) equipped with previously isolated marine Shewanella marisflavi BBL25 was intended for the complete remediation of azo dye. The BES II demonstrated highest dye decolorization (97.06%) within 48 h at biocathode where the reductive cleavage of the azo bond occurred. Cyclic voltammetry (CV) studies of the BES revealed perfect redox reactions taking place where the redox mediators shuttled the electrons to the dye molecule to accelerate the dye decolorization. Besides, the GC-MS analysis revealed biotransformation of the dye into less toxic metabolites as tested using a phyto and cytogenotoxicity.

Remediation of textile effluents for water reuse: Decolorization and desalination using Escherichia fergusonii followed by detoxification with activated charcoal

Textile effluents contain high levels of pollutants of different categories like dyes, metal salts, acids, bases and microorganisms. Remediation of textile effluents is often challenging because of its composition, which also varies between dyeing units. In this study, we demonstrate the novel use of a waste-water bacterium, Escherichia fergusonii, in the effective remediation of textile effluents. The bacteria application efficiently caused a reduction of color (98.4%), total dissolved solids (75%), sulphates (87%), bicarbonates (83%), chlorides (64%), calcium (84%), and chemical oxygen demand (81%) of the textile effluents. The bacteria-treated effluents were further disinfected and detoxified by treating with rice husk activated charcoal. After the charcoal treatment, the chemical oxygen demand decreased further by 11.5% and biochemical oxygen demand decreased by 85%. The effluents remediated using the two-step process were subjected to toxicity assays using zebrafish (Danio rerio) model. The textile effluents treated using Escherichia fergusonii, followed by activated charcoal were found to be non-toxic and suitable for reuse for domestic applications. Thus, we present here, a simple, less energy-intensive, economic, two-step process as a complete solution for textile effluent treatment. The results of this investigation can be used to simplify the remediation process of textile effluents in common treatment plants as well as the individual dyeing units.

Ethanol as an efficient cosubstrate for the biodegradation of azo dyes by Providencia rettgeri: Mechanistic analysis based on kinetics, pathways and genomics

Azo dyes pose hazards to ecosystems and human health and the cosubstrate strategy has become the focus for the bioremediation of azo dyes. Herein, Brilliant Crocein (BC), a model pollutant, was biodegraded by Providencia rettgeri domesticated from activated sludge. Additional ethanol, as a cosubstrate, could accelerate P. rettgeri growth and BC biodegradation, as reflected by the Gompertz models. This phenomenon was attributed to the smaller metabolites and greater number of potential pathways observed under the synergistic effect of ethanol. Genomic analysis of P. rettgeri showed that functional genes related to azo bond cleavage, redox reactions, ring opening and hydrolysis played crucial roles in azo dye biodegradation. Furthermore, the mechanism proposed was that ethanol might stimulate the production of additional reducing power via the expression of related genes, leading to the cleavage of azo bonds and aromatic rings. However, biodegradation without ethanol could only partly cleave the azo bonds.

The Cyclic AMP Receptor Protein, Crp, Is Required for the Decolorization of Acid Yellow 36 in Shewanella putrefaciens CN32

Shewanella shows good application potentials in the decolorization and detoxification of azo dye wastewater. However, the molecular mechanism of decolorization is still lacking. In this study, it was found that Shewanella putrefaciens CN32 exhibited good decolorization ability to various azo dyes, and a global regulatory protein cAMP receptor protein (Crp) was identified to be required for the decolorization of acid yellow 36 (AY) by constructing a transposon mutant library. Then, the molecular mechanism of AY decolorization regulated by Crp was further investigated. RT-qPCR and electrophoretic mobility shift assay (EMSA) results showed that Crp was able to directly bind to the promoter region of the cymA gene and promote its expression. Riboflavin acting as an electron shuttle could accelerate the AY decolorization efficiency of S. putrefaciens CN32 wild-type (WT) but did not show a promoting effect to Δcrp mutant and ΔcymA mutant, further confirming that Crp promotes the decolorization through regulating electron transport chains. Moreover, the mutant with cymA overexpression could slightly enhance the AY decolorization efficiency compared with the WT strain. In addition, it was found that MtrA, MtrB, and MtrC partially contribute to the electron transfer from CymA to dye molecules, and other main electron transport chains need to be identified in future experiments. This study revealed the molecular mechanism of a global regulator Crp regulating the decolorization of azo dye, which is helpful in understanding the relationship between the decolorization and other metabolic processes in S. putrefaciens CN32.

Franconibacter sp., 1MS: A New Strain in Decolorization and Degradation of Azo Dyes Ponceau S Red and Methyl Orange

The aim of the present study is focused on the decolorization and degradation of azo dyes Ponceau S Red and Methyl Orange by a bacterial strain isolated from the gold mining district of San Martin de Loba, South of Bolivar (Colombia) sediment samples and identified as Franconibacter sp. 1MS (GenBank: MT568543) based on phenotypic and genotypic methods. A higher percentage of decolorization at 100 mg/L concentration, 37 °C, and pH 7 was recorded at 120 h of incubation period for both dyes. The UV-vis, Fourier transform infrared spectroscopy, and gas chromatography-mass spectrometry analysis of the original dyes and their degraded metabolites confirmed that the decolorization was due to degradation. The proposed metabolic pathways for biodegradation of both dyes have been elucidated, which showed the formation of five intermediate metabolites, namely, N,N-dimethylbenzyl-1,4-diamine, sulfonamide, 1,4-diaminobenzene, 2,5-diaminobenzenesulfonic acid, and 1-amino-2-naphthol, which are not only highly toxic but also be able to be converted through metabolic activation into mutagenic, carcinogenic, and/or teratogenic species. The phytotoxicity studies of the original dye and degraded metabolites were tested on Phaseolus vulgaris and divulged that the degraded metabolites have toxic effects. An effective phytostimulation was observed in Ponceau S Red, which could be attributed to its capacity for enrichment of the culture medium with essential nutrients, a favorable environment for the growth of the plant.

Decolorization and detoxification of azo dye by halo-alkaliphilic bacterial consortium: Systematic investigations of performance, pathway and metagenome

The high pH and salinity of textile wastewater is a major hindrance to azo dye decolorization. In this study, a mixed bacterial consortium ZW1 was enriched under saline (10% salinity) and alkaline (pH 10.0) conditions to decolorize Methanil Yellow G (MY-G). Consortium ZW1 was mainly composed of Halomonas (49.8%), Marinobacter (30.7%) and Clostridiisalibacter (19.2%). The effects of physicochemical factors were systematically investigated, along with the degradation pathway and metagenome analysis. The co-carbon source was found to be necessary, and the addition of yeast extract led to 93.3% decolorization of 100 mg/L MY-G within 16 h (compared with 1.12% for control). The optimum pH, salinity, temperature and initial dye concentration were 8.0, 5-10%, 40 °C and 100 mg/L, respectively. The typical dye-related degradation enzymes were most effective at 10% salinity. Consortium ZW1 was also able to differentially decolorize five other direct and acidic dyes in a short period. Phototoxicity tests revealed the detoxification of MY-G degradation products. Combining UV-vis, FTIR and GC-MS detection, the MY-G degradation pathway by consortium ZW1 was proposed. Furthermore, metagenomic approach was used to elucidate the functional potential of genes in MY-G biodegradation. These results signify the broad potential application of halo-alkaliphilic consortia in the bioremediation of dyeing wastewater.

Augmented Biodegradation of Textile Azo Dye Effluents by Plant Endophytes: A Sustainable, Eco-Friendly Alternative

Textile industry consumes a large proportion of available water and releases huge amounts of toxic azo dye effluents, leading to an inevitable situation of acute environmental pollution that has been a significant threat to mankind. Decolorization or detoxification of harmful azo dyes has become a global priority to overcome the disastrous consequences and salvage the ecosystem. Biodegradation of textile azo dyes by endophytes stands to be a lucrative and viable alternative over conventional physico-chemical methods, owing to their eco-friendliness, cost-competitive and non-toxic nature. Especially, plant endophytic microbes exhibit promising biodegradation potential which has wired up the effective removal of textile azo dyes, attributing to their ability to produce dye degrading enzymes, laccases, peroxidases and azoreductases. Although both bacterial and fungal endophytes have been tried for azo dye degradation, endophytic fungi find broader application over bacteria. Despite of the advancements made in microbe-mediated biodegradation, there is still a need to fill the gap in lab to in situ translation of biodegradation research. This review concisely accentuates the xenobiotics of textile azo dyes and microbial mechanisms of biodegradation of textile azo dyes, positing plant endophytic community, especially bacterial and fungal endophytes as the potential dye degraders, highlighting currently reported dye degrading endophytic species.

Elucidation of fungal dye-decolourizing peroxidase (DyP) and ligninolytic enzyme activities in decolourization and mineralization of azo dyes

AIM

The aim of the study is to investigate the efficiency of Geotrichum candidum in the decolourization and mineralization of synthetic azo dyes.

METHODS AND RESULTS

It includes screening of enzymes from G. candidum and its optimization, followed by decolourization and mineralization studies. Decolourization was observed to be maximum in methyl orange (94·6%) followed by Congo red (85%), trypan blue (70·4%) and Eriochrome Black T (55·6%) in 48 h, suggesting the plausible degradation of the azo dyes by G. candidum. The enzyme activity study showed that DyP-type peroxidase has highest activity of 900 mU ml^-1 compared to that of laccase (405 mU ml^-1 ) and lignin peroxidase (LiP) (324 mU ml^-1 ) at optimized pH (6) and temperature (35°C). Moreover, the rate of decolourization was found to be directly proportional to the production of laccase and LiP, unlike DyP-type peroxidase. Furthermore, mineralization study demonstrated reduction in aromatic amines, showing 20% mineralization of methyl orange.

CONCLUSION

Geotrichum candidum with its enzyme system is able to efficiently decolourize and mineralize the experimental azo dyes.

SIGNIFICANCE AND IMPACT OF THE STUDY

The efficient decolourization and mineralization of azo dyes makes G. candidum a promising alternative in the treatment of textile effluent contaminated with azo dyes.

Performance of a Newly Isolated Salt-Tolerant Yeast Strain Sterigmatomyces halophilus SSA-1575 for Azo Dye Decolorization and Detoxification

The effective degradation of hazardous contaminants remains an intractable challenge in wastewater processing, especially for the high concentration of salty azo dye wastewater. However, some unique yeast symbionts identified from the termite gut system present an impressive function to deconstruct some aromatic compounds, which imply that they may be valued to work on the dye degradation for various textile effluents. In this investigation, a newly isolated and unique yeast strain, Sterigmatomyces halophilus SSA-1575, was identified from the gut system of a wood-feeding termite (WFT), Reticulitermes chinensis. Under the optimized ambient conditions, the yeast strain SSA-1575 showed a complete decolorization efficiency on Reactive Black 5 (RB5) within 24 h, where this azo dye solution had a concentration of a 50 mg/L RB5. NADH-dichlorophenol indophenol (NADH-DCIP) reductase and lignin peroxidase (LiP) were determined as the key reductase and oxidase of S. halophilus SSA-1575. Enhanced decolorization was recorded when the medium was supplemented with carbon and energy sources, including glucose, ammonium sulfate, and yeast extract. To understand a possible degradation pathway well, UV-Vis spectroscopy, FTIR and Mass Spectrometry analyses were employed to analyze the possible decolorization pathway by SSA-1575. Determination of relatively high NADH-DCIP reductase suggested that the asymmetric cleavage of RB5 azo bond was mainly catalyzed by NADH-DCIP reductase, and finally resulting in the formation of colorless aromatic amines devoid of any chromophores. The ecotoxicology assessment of RB5 after a decolorization processing by SSA-1575, was finally conducted to evaluate the safety of its metabolic intermediates from RB5. The results of Microtox assay indicate a capability of S. halophilus SSA-1575, in the detoxification of the toxic RB5 pollutant. This study revealed the effectiveness of halotolerant yeasts in the eco-friendly remediation of hazardous pollutants and dye wastewater processing for the textile industry.

Study on the efficient removal of azo dyes by heterogeneous photo-Fenton process with 3D flower-like layered double hydroxide

As organic dyes are the main pollutants in water pollution, seeking effective removal solutions is urgent for humans and the environment. A novel environmentally friendly three-dimensional CoFe-LDHs (3D CoFe-LDHs) catalyst was synthesized by one-step hydrothermal method. Scanning electron microscopy, energy dispersive spectroscopy, Fourier transform infrared spectra, X-ray diffraction, X-ray photoelectron spectroscopy, Brunauer-Emmett-Teller technique as well as UV-Vis diffuse reflectance spectra were used to characterize the prepared samples. The experimental results revealed that 3D CoFe-LDHs exhibited a rapid decolorization of methyl orange and Rhodamine B by heterogeneous photo-Fenton process after reaching the adsorption equilibrium, and the final decolorization efficiency reached 91.18% and 93.56%, respectively. On the contrary, the decolorizing effect of 3D CoFe-LDHs on neutral blue was relatively weak. The initial concentrations of azo dyes, pH and H₂O₂ concentration affected the decolorization of dyes and the catalyst maintained excellent reusability and stability after reuse over five cycles. The quenching experiments found that •OH, •O₂ ^- and h⁺ were the main active substances and reaction mechanisms were further proposed. The study suggests that the synergistic effect of photocatalysis and Fenton oxidation process significantly improved the removal of azo dyes and the synthesized catalyst had potentially promising applications for difficult-to-biodegrade organic pollutants in wastewater.

Azo dye degrading bacteria tolerant to extreme conditions inhabit nearshore ecosystems: Optimization and degradation pathways

Nearshore ecosystems are transitional zones, and they may harbor a diverse microbial community capable of degrading azo dyes under extreme environmental conditions. In this study, thirteen bacterial strains capable of degrading eight azo dyes were isolated in nearshore environments and characterized using high throughput 16 S rRNA sequencing. The results of this study demonstrate that the biodegradability of azo dyes was influenced by their chemical structure and position of functional groups as well as the type of bacteria. The decolorization rate of Methyl Orange (95%) was double that of the heavier and sterically hindered Reactive Yellow 84 (<40%). Shewanella indica strain ST2, Oceanimonas smirnovii strain ST3, Enterococcus faecalis strain ST5, and Clostridium bufermentans strain ST12 demonstrated potential application in industrial effluent treatment as they were tolerant to a wide range of environmental parameters (pH: 5-9, NaCl: 0-70 g L^-1, azo dye concentration: 100-2000 mg L^-1) including exposure to metals. Analysis of the transformation products using GC-MS revealed that different bacterial strains may have different biotransformation pathways. This study provides critical insight on the in-situ biotransformation potential of azo dyes in marine environments.