Biofiltration of methane using hybrid mixtures of biochar, lava rock and compost

Methane removal efficiencies of biochar-mediated landfill soil cover with reduced depth

Biochar amendment for landfill soil cover has the potential to enhance methane removal efficiency while minimizing the soil depth. However, there is a lack of information on the response of biochar-mediated soil cover to the changes in configuration and operational parameters during the methane transport and transformation processes. This study constructed three biochar-amended landfill soil covers, with reduced soil depths from 75 cm (C2) to 55 cm (C3) and 45 cm (C4), and the control group (C1) with 75 cm and no biochar. Two operation phases were conducted under two soil moisture contents and three inlet methane fluxes in each phase. The methane removal efficiency increased for all columns along with the increase in methane flux. However, increasing moisture content from 10% to 20% negatively influenced the methane removal efficiency due to mass transfer limitation when at a low inlet methane flux, especially for C1; while this adverse effect could be alleviated by a high flux. Except for the condition with low moisture content and flux combination, C3 showed comparable methane removal efficiency to C2, both dominating over C1. As for C4 with only 45 cm, a high moisture content combined with a high methane flux enabled its methane removal efficiency to be competitive with other soil depths. In addition to the geotechnical reasons for gas transport processes, the evolution in methanotroph community structure (mainly type I methanotrophs) induced by biochar amendment and variations in soil properties supplemented the biological reasons for the varying methane removal efficiencies.

Assessing the performance of farm soil-based and hybrid biofilters for methane abatement

Mitigating methane (CH4) emissions using methanotrophs (methane-oxidizing bacteria, MOB), is a simple, energy efficient and cheap technology. The abundance and distribution of MOB in the environmental samples is critical for efficient removal of emitted CH4 from any source. This study evaluated the performance of farm soils without and with cheap, easily accessible bulking materials as sustainable hybrid biofilter media. Soil-only biofilters removed up to 865 ± 19 g CH4 m-3 d-1 with well-drained organic carbon-rich soils compared with 264 ± 14 g CH4 m-3 d-1 for poorly drained soil. The removal efficiency decreased with increasing flow rate (0.16→0.24 L min-1) and subsequent priming could not return soil biofilters to their previous removal rate.Hybrid biofilters using organic, carbon-rich soils and compost removed up to 2698 g CH4 m-3 d-1 (flow rate 0.35 L min-1). Increasing CH4 flow rates also reduced their efficiency, but the hybrid biofilters with compost quickly regained most of their efficiency and removed up to 2262 g CH4 m-3 d-1 (flow rate 0.3 L min-1) after remixing of biofilter media. These results show that hybrid biofilters removed higher CH4 than soil-only biofilters and were also more resilient. The MOB gene abundance results complement the CH4 removal capacity of both soil-only and hybrid biofilter materials used. The more aerobic, carbon-rich soils had more abundant MOB than the poorly drained soil. The most porous hybrid biofilter with compost and more available nutrients to sustain bacterial growth and activity had the highest MOB abundance and removed the most CH4.

Application of nitrogen-rich sunflower husks biochar promotes methane oxidation and increases abundance of Methylobacter in nitrogen-poor soil

The area of sunflower crops is steadily increasing. A beneficial way of managing sunflower waste biomass could be its use as a feedstock for biochar production. Biochar is currently being considered as an additive for improving soil parameters, including the ability to oxidise methane (CH4) - one of the key greenhouse gases (GHG). Despite the high production of sunflower husk, there is still insufficient information on the impact of sunflower husk biochar on the soil environment, especially on the methanotrophy process. To fill this knowledge gap, an experiment was designed to evaluate the effects of addition of sunflower husk biochar (produced at 450-550 °C) at a wide range of doses (1-100 Mg ha-1) to Haplic Luvisol. In the presented study, the CH4 oxidation potential of soil with and without sunflower husk biochar was investigated at 60 and 100% water holding capacity (WHC), and with the addition of 1% CH4 (v/v). The comprehensive study included GHG exchange (CH4 and CO2), physicochemical properties of soil (pH, soil organic carbon (SOC), dissolved organic carbon (DOC), nitrate nitrogen (NO3--N), WHC), and the structure of soil microbial communities. That study showed that even low biochar doses (5 and 10 Mg ha-1) were sufficient to enhance pH, SOC, DOC and NO3--N content. Importantly, sunflower husk biochar was significant source of NO3--N, which soil concentration increased from 9.40 ± 0.09 mg NO3--N kg-1 for the control to even 19.40 ± 0.26 mg NO3--N kg-1 (for 100 Mg ha-1). Significant improvement of WHC (by 11.0-12.4%) was observed after biochar addition at doses of 60 Mg ha-1 and higher. At 60% WHC, application of biochar at a dose of 40 Mg ha-1 brought significant improvements in CH4 oxidation rate, which was 4.89 ± 0.37 mg CH4-C kg-1 d-1. Higher biochar doses were correlated with further improvement of CH4 oxidation rates, which at 100 Mg ha-1 was seventeen-fold higher (8.36 ± 0.84 mg CH4-C kg-1 d-1) than in the biochar-free control (0.48 ± 0.28 mg CH4-C kg-1 d-1). CO2 emissions were not proportional to biochar doses and only grew circa (ca.) twofold from 3.16 to 6.90 mg CO2-C kg-1 d-1 at 100 Mg ha-1. Above 60 Mg ha-1, the diversity of methanotrophic communities increased, with Methylobacter becoming the most abundant genus, which was as high as 7.45%. This is the first, such advanced and multifaceted study of the wide range of sunflower husk biochar doses on Haplic Luvisol. The positive correlation between soil conditions, methanotroph abundance and CH4 oxidation confirmed the multifaceted, positive effect of sunflower husk biochar on Haplic Luvisol. Sunflower husk biochar can be successfully used for Haplic Luvisol supplementation. This additive facilitates soil protection against degradation and has the potential to mitigate GHG emissions.

Evaluation of packing materials for thermophilic biofilter by refined evaluation scheme and application in the treatment of SO2 with high temperature

The selection of packing materials is essential to maintaining biofilter performance in waste gas treatment. In this study, 12 types of packing materials were evaluated to determine the most suitable for the SO2 removal by a thermophilic biofilter. Scanning electron microscopy and the Baunauer-Emmett-Teller equation were utilized to identify the texture of the tested packing materials, while Fourier transform infrared spectroscopy and X-ray diffraction were applied to analyze the surface functional groups and crystal structures, respectively. Characteristics were accompanied by economic considerations. Results showed that the polyurethane sponge had better porous structure and water retention than other packing materials. In terms of microbial growth and carrier economy, it was chosen for the biofilter used to treat SO2. The performance of a full-scale thermophilic biofilter with polyurethane sponge as the packing material was investigated for the purification of SO2-containing gases at an inlet temperature of 55 °C. The biofilter effectively removed SO2 at an average removal rate of 93.36%. Thermophilic bacteria and sulfur-oxidizing bacteria, e.g., Bacillus thermophilus, could attached growth on the surface of selected packing materials and exhibited degradation activity. This study provides an effective and feasible method of packing material selection for biological waste gas treatment.

Impact of Landfill Gas Exposure on Vegetation in Engineered Landfill Biocover Systems Implemented to Minimize Fugitive Methane Emissions from Landfills

Engineered landfill biocovers (LBCs) minimize the escape of methane into the atmosphere through biological oxidation. Vegetation plays a crucial role in LBCs and can suffer from hypoxia caused by the displacement of root-zone oxygen due to landfill gas and competition for oxygen with methanotrophic bacteria. To investigate the impact of methane gas on vegetation growth, we conducted an outdoor experiment using eight vegetated flow-through columns filled with a 45 cm mixture of 70% topsoil and 30% compost, planted with three types of vegetation: native grass blend, Japanese millet, and alfalfa. The experiment included three control columns and five columns exposed to methane, as loading rates gradually increased from 75 to 845 gCH₄/m²/d over a period of 65 days. At the highest flux, we observed a reduction of 51%, 31%, and 19% in plant height, and 35%, 25%, and 17% in root length in native grass, Japanese millet, and alfalfa, respectively. The column gas profiles indicated that oxygen concentrations were below the levels required for healthy plant growth, which explains the stunted growth observed in the plants used in this experiment. Overall, the experimental results demonstrate that methane gas has a significant impact on the growth of vegetation used in LBCs.

Enhanced removal of refractory humic- and fulvic-like organics from biotreated landfill leachate by ozonation in packed bubble columns

Biotreated landfill leachate contains much refractory organics such as humic and fulvic acids, which can be degraded by O₃. However, the low O₃ mass transfer and high energy cost limit its wide application in landfill leachate treatment. Previous studies proved that packed bubble columns could enhance the O₃ mass transfer and increase the synthetic humic acids wastewater degradation, but the performance of packed bubble columns in real wastewater treatment has not been investigated. Therefore, this study aims to evaluate the feasibility of application of packed bubble column in the real biotreated landfill leachates treatment and provide insights into the transformation of organic matters in leachates during ozonation. Packed bubble columns with lava rocks or metal pall rings (LBC or MBC) were applied and compared with a non-packed bubble column (BC). At an applied O₃ dose of 8.35 mg/(L_{water sample} min), the initial COD (400 mg/L) was only removed for 26% in BC and 32% in MBC while this was 46% in LBC, indicating LBC has the best performance. GC-MS analysis shows that raw biotreated leachate contains potential endocrine disruptors such as di(2-ethylhexyl) phthalate (DEHP). 61% of DEHP was removed in LBC and the least intermediate oxidation products from humic- and fulvic-like organics was detected in LBC. The highest O₃ utilization efficiency (89%) and hydroxyl radical (OH) exposure rate (3.0 × 10^-10 M s) were observed in LBC with lowest energy consumption (E_EO) for COD removal of 18 kWh/m³. The enhanced ozonation efficiency in LBC and MBC was attributed to the improved O₃ mass transfer. Besides, LBC had additional adsorptive and catalytic activity that promoted the decomposition of O₃ to generate OH. This study demonstrates that a packed bubble column increases removal and decreases energy use when treating landfill leachate, thus promoting the application of ozonation.

Total value wall: Full scale demonstration of a green wall for grey water treatment and recycling

Greywater treatment and reuse for non-potable purposes in urban areas has become a widely researched topic to reduce the burden on fresh water resources. This study reports on the use of a green wall for treating grey water and reusing the effluent for toilet flushing, called Total Value Wall (TVW). Initially, the effectiveness of (mixtures of) different substrates, i.e. lava, lightweight expanded clay aggregates, organic soil and biochar was investigated by means of column tests. All substrates were first examined for hydraulic characteristics and later on the columns were fed with synthetic grey wastewater and followed up in terms of removal efficiency of COD and detergents. The mixture consisting of lava (50%), organic soil (25%) and biochar (25%) proved to be optimal both in terms of percolation rates and removal efficiencies, and was thus selected for the full-scale system. The full-scale TVW of 14.4 m² was installed at a terraced house in Ghent (Belgium), and was loaded with grey water at 100 L per day. Influent and effluent quality were routinely monitored by grab sampling, water savings were monitored by means of flow meters, and electricity consumption was also accounted for. The TVW was further equipped with sensors that measure temperature, Particulate Matter (PM₁₀) and CO₂ in the air. The full-scale system obtained effluent concentrations of 13 mg.L^-1 TSS, 91 mg.L^-1 COD and 5 mg.L^-1 BOD₅. Ammonium and total coliforms were removed with removal rates of 97% and 99% (2 log units) respectively. However, an increase in effluent concentration of nitrate and phosphate was observed due to leaching from the selected substrate. Available data from the temperature sensors have clearly demonstrated the additional benefit of the TVW as an insulating layer, keeping the heat outside on warmer days, and keeping the heat inside on colder days. Overall, this study demonstrated that the TVW is a sustainable system for greywater treatment and reuse.

Intensified ozonation in packed bubble columns for water treatment: Focus on mass transfer and humic acids removal

Ozonation has been widely applied for the oxidation of contaminants in wastewater, and the disinfection of water. However, low ozone (O₃) mass transfer efficiency in common ozonation reactors requires high O₃ doses and causes high energy consumption. In this study, to intensify the O₃ mass transfer and oxidation of humic acids (HA) solution, a lava rock packed bubble column (LBC) and a metal pall ring packed bubble column (MBC) were developed and evaluated. In comparison with non-packed bubble column (BC), both LBC and MBC enhanced the O₃ mass transfer efficiency and the generation of hydroxyl radicals, thereby increasing the HA removal from an aqueous solution. At applied O₃ dose of 33.3 mg/(L_column h), the HA removal efficiency in BC was only 47%. When MBC and LBC were applied, it increased to 66% and 72%, respectively. Meanwhile, the O₃ utilization efficiency in LBC reached 68%, which was higher than that in MBC (50%) and BC (21%). Consequently, LBC has the lowest energy consumption (E_EO) for HA removal (1.4 kWh/m³), followed by MBC (1.6 kWh/m³) and BC (2.9 kWh/m³). LBC had better performance than MBC due to the adsorptive and catalytic roles of lava rock on the ozonation process. This study demonstrates the advantages of using lava rocks as packed materials in O₃ bubble column over metal pall rings in intensifying O₃ mass transfer and organic matters removal, which provides some insights into promoting the industrial application of O₃.

RNA stable isotope probing and high-throughput sequencing to identify active microbial community members in a methane-driven denitrifying biofilm

AIMS

Aerobic methane oxidation coupled to denitrification (AME-D) is a promising process for removing nitrate from groundwater and yet its microbial mechanism and ecological implications are not fully understood. This study used RNA stable isotope probing (RNA-SIP) and high-throughput sequencing to identify the micro-organisms that are actively involved in aerobic methane oxidation within a denitrifying biofilm.

METHODS AND RESULTS

Two RNA-SIP experiments were conducted to investigate labelling of RNA and methane monooxygenase (pmoA) transcripts when exposed to ¹³ C-labelled methane over a 96-hour time period and to determine active bacteria involved in methane oxidation in a denitrifying biofilm. A third experiment was performed to ascertain the extent of ¹³ C labelling of RNA using isotope ratio mass spectrometry (IRMS). All experiments used biofilm from an established packed bed reactor. IRMS confirmed ¹³ C enrichment of the RNA. The RNA-SIP experiments confirmed selective enrichment by the shift of pmoA transcripts into heavier fractions over time. Finally, high-throughput sequencing identified the active micro-organisms enriched with ¹³ C.

CONCLUSIONS

Methanotrophs (Methylovulum spp. and Methylocystis spp.), methylotrophs (Methylotenera spp.) and denitrifiers (Hyphomicrobium spp.) were actively involved in AME-D.

SIGNIFICANCE AND IMPACT OF THE STUDY

This is the first study to use RNA-SIP and high-throughput sequencing to determine the bacteria active within an AME-D community.

Bioelimination of low methane concentrations emitted from wastewater treatment plants: a review

Sewage from residents and industries is collected and transported to wastewater treatment plants (WWTPs) with sewer networks. The operation of WWTPs results in emissions of greenhouse gases, such as methane (CH₄), mostly due to sludge anaerobic digestion. Amounts of emissions depend on the source of influent, i.e. municipal and industrial wastewater as well as sewer systems (gravity and rising). Wastewater is the fifth-largest source of anthropogenic CH₄ emissions in the world and represents 7-9% of total global CH₄ emissions into the atmosphere. Global wastewater CH₄ emission grew by approximately 20% from 2005 to 2020 and is expected to grow by 8% between 2020 and 2030, which makes wastewater an important CH₄ emitter worldwide. This review initially considers the emission of CH₄ from WWTPs and sewer networks. In the second part, biotechniques available for biodegradation of low CH₄ concentrations (<5% v/v) encountered in WWTPs have been studied. The paper reviews major bioreactor configurations for the treatment of polluted air, i.e. biotrickling filters, bioscrubbers, two-liquid phase bioreactors, biofilters, and hybrid reactor configurations, after which it focuses on CH₄ biofiltration systems. Biofiltration represents a simple and efficient approach to bio-oxidize CH₄ in waste gases from WWTPs. Major factors influencing a biofilter's performance along with knowledge gaps in relation to its application for treating gaseous emissions from WWTPs are discussed.

Synchrotron X-ray microtomography and multifractal analysis for the characterization of pore structure and distribution in softwood pellet biochar

Biochar pores in the micrometer range (1-100 µm) derive from cellular structures of the plant biomass subjected to pyrolysis or can be the result of mechanical processing, such as pelleting. In this study, synchrotron X-ray microtomography was used to investigate the internal pore structure of softwood pellet biochar produced by slow pyrolysis at 550 and 700 °C. The microtomographic data sets consisted of 2025 images of 2560 × 2560 voxels with a voxel side length of 0.87 µm. The three-dimensional reconstructions revealed that pelleting and pyrolysis significantly altered the pore structures of the wood feedstock, creating a network of connected pores between fragments that resembled the wood morphology. While higher pyrolysis temperature increased the specific surface area (as determined by BET nitrogen adsorption), it did not affect the total observed porosity. Multifractal analysis was applied to assess the characteristics of the frequency distribution of pores along each of the three dimensions of reconstructed images of five softwood pellet biochar samples. The resulting singularity and Rényi spectra (generalized dimensions) indicated that the distribution of porosity had monofractal scaling behavior, was homogeneous within the analyzed volumes and consistent between replicate samples. Moreover, the pore distributions were isotropic (direction-independent), which is in strong contrast with the anisotropic pore structure of wood. As pores at the scale analyzed in this study are relevant, for example, for the supply of plant accessible water and habitable space for microorganisms, our findings combined with the ability to reproduce biochar with such pore distribution offer substantial advantages in various biochar applications.

SUPPLEMENTARY INFORMATION

The online version contains supplementary material available at 10.1007/s42773-021-00104-3.

Microbial mechanisms related to the effects of bamboo charcoal and bamboo vinegar on the degradation of organic matter and methane emissions during composting

In this study, functional microbial sequencing, quantitative PCR, and phylogenetic investigation of communities by reconstruction of unobserved states (PICRUSt) were employed to understand the microbial mechanisms related to the effects of bamboo charcoal (BC) and bamboo vinegar (BV) on the degradation of organic matter (OM) and methane (CH₄) emissions during composting. BC + BV resulted in the highest degradation of OM. BV was most effective treatment in controlling CH₄ emissions and it significantly reduced the abundance of the mcrA gene. Methanobrevibacter, Methanosarcina, and Methanocorpusculum were closely related to CH₄ emissions during the thermophilic composting period. PICRUSt analysis showed that BC and/or BV enhanced the metabolism associated with OM degradation and reduced CH₄ metabolism. Structural equation modeling indicated that BC + BV strongly promoted the metabolic activity of microorganisms, which had a positive effect on CH₄ emissions. Together these results suggest that BC + BV may be a suitable composting strategy if the aerobic conditions can be effectively improved during the thermophilic composting period.

Methane Elimination Using Biofiltration Packed With Fly Ash Ceramsite as Support Material

Methane is a greenhouse gas and significantly contributes to global warming. Methane biofiltration with immobilized methane-oxidizing bacteria (MOB) is an efficient and eco-friendly approach for methane elimination. To achieve high methane elimination capacity (EC), it is necessary to use an exceptional support material to immobilize MOB. The MOB consortium was inoculated in biofilters to continuusly eliminate 1% (v/v) of methane. Results showed that the immobilized MOB cells outperformed than the suspended MOB cells. The biofilter packed with fly ash ceramsite (FAC) held the highest average methane EC of 4.628 g h^–1 m^–3, which was 33.4% higher than that of the biofilter with the suspended MOB cells. The qPCR revealed that FAC surface presented the highest pmoA gene abundance, which inferred that FAC surface immobilized the most MOB biomass. The XPS and contact angle measurement indicated that the desirable surface elemental composition and stronger surface hydrophilicity of FAC might favor MOB immobilization and accordingly improve methane elimination.

Hierarchical porous structured polysulfide supported nZVI/biochar and efficient immobilization of selenium in the soil

Soil pollution with selenium is a significant environmental problem in several areas of the world, which extremely affects the growth of plants and human health. Thus, it is necessary to find an effective method to immobilize selenium in the soil to make it less bioavailable and less accessible. In this study, the low-cost biochar-supported nanoscale zero-valent iron and polysulfide (PS-nZVI@BC) are produced and used for the immobilization of selenium (Se) in soil. The FTIR, UV-Vis, XRD, VSM, SEM and XPS techniques validate surface properties and morphology of PS-nZVI@BC. Introduction of S^2- led to the in-situ formation of FeS on the surface of the biochar supported zero valent iron. Two intense Bragg peaks (2θ) of 40.5°, 44.5° were corresponded to Fe⁰ basal plane, indicating the presence of nZVI in nZVI@BC and PS-nZVI@BC. The modified biochar presents a magnetic saturation value of 0.008 emu/mg, reasonably less than the reported values of bare nZVI. The soil immobilization showed that the PS-nZVI@BC is more effective for the control of selenium than the biochar and nZVI@BC. The available selenium content decreased by 77.29% in PS-nZVI@BC amended soil after 30 days. From sequential extraction procedure (SEP) results, it was observed that PS-nZVI@BC promoted the conversion of more accessible Se (water-soluble and exchangeable fractions) into the less accessible forms (acid-soluble, organic, and residual fractions) to reduce the toxicity of Se. Surface sorption, reduction and complexation were dominant mechanisms for Se immobilization. Hence, PS-nZVI@BC is promising and effective for immobilizing Se in contaminated soils and improving the soil properties.

Exploring the mechanisms of organic matter degradation and methane emission during sewage sludge composting with added vesuvianite: Insights into the prediction of microbial metabolic function and enzymatic activity

Effect mechanisms of organic matter (OM) degradation and methane (CH₄) emission during sewage sludge (SS) composting with added vesuvianite (V) were studied by high-throughput sequencing (HTS) and phylogenetic investigation of communities by reconstruction of unobserved states (PICRUSt). Results show that the addition of V accelerated the OM degradation and decreased the cumulative CH₄ emissions by 33.6% relative to the control. In addition, V significantly decreased the mcrA gene abundance and the methanogen community richness at the genus level. PICRUSt also indicated that V strengthens the microbial metabolic function and enzymatic activity related to OM degradation, and reduced the enzymatic activity related to CH₄ production. Methanogens community variation analysis proved the ratio of carbon and nitrogen and moisture content are the significant variables affecting CH₄ emissions. Thus, optimizing the ratio of carbon and nitrogen and moisture content will decrease CH₄ emission during SS composting.

Biofiltration of methane

The on-going annual increase in global methane (CH₄) emissions can be largely attributed to anthropogenic activities. However, as more than half of these emissions are diffuse and possess a concentration less than 3% (v/v), physical-chemical treatments are inefficient as an abatement technology. In this regard, biotechnologies, such as biofiltration using methane-oxidizing bacteria, or methanotrophs, are a cost-effective and efficient means of combating diffuse CH₄ emissions. In this review, a number of abiotic factors including temperature, pH, water content, packing material, empty-bed residence time, inlet gas flow rate, CH₄ concentration, as well biotic factors, such as biomass development, are reviewed based on empirical findings on CH₄ biofiltration studies that have been performed in the last decades.