1
|
Zhou P, Li D, Zhang C, Ping Q, Wang L, Li Y. Comparison of different sewage sludge pretreatment technologies for improving sludge solubilization and anaerobic digestion efficiency: A comprehensive review. THE SCIENCE OF THE TOTAL ENVIRONMENT 2024; 921:171175. [PMID: 38402967 DOI: 10.1016/j.scitotenv.2024.171175] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/07/2023] [Revised: 02/20/2024] [Accepted: 02/20/2024] [Indexed: 02/27/2024]
Abstract
Anaerobic digestion (AD) of sewage sludge reduces organic solids and produces methane, but the complex nature of sludge, especially the difficulty in solubilization, limits AD efficiency. Pretreatments, by destroying sludge structure and promoting disintegration and hydrolysis, are valuable strategies to enhance AD performance. There is a plethora of reviews on sludge pretreatments, however, quantitative comparisons from multiple perspectives across different pretreatments remain scarce. This review categorized various pretreatments into three groups: Physical (ultrasonic, microwave, thermal hydrolysis, electric decomposition, and high pressure homogenization), chemical (acid, alkali, Fenton, calcium peroxide, and ozone), and biological (microaeration, exogenous bacteria, and exogenous hydrolase) pretreatments. The optimal conditions of various pretreatments and their impacts on enhancing AD efficiency were summarized; the effects of different pretreatments on microbial community in the AD system were comprehensively compared. The quantitative comparison based on dissolution degree of COD (DDCOD) indicted that the sludge solubilization performance is in the order of physical, chemical, and biological pretreatments, although with each below 40 % DDCOD. Biological pretreatment, particularly microaeration and exogenous bacteria, excel in AD enhancement. Pretreatments alter microbial ecology, favoring Firmicutes and Methanosaeta (acetotrophic methanogens) over Proteobacteria and Methanobacterium (hydrogenotrophic methanogens). Most pretreatments have unfavorable energy and economic outcomes, with electric decomposition and microaeration being exceptions. On the basis of the overview of the above pretreatments, a full energy and economy assessment for sewage sludge treatment was suggested. Finally, challenges associated with sludge pretreatments and AD were analyzed, and future research directions were proposed. This review may broaden comprehension of sludge pretreatments and AD, and provide an objective basis for the selection of sludge pretreatment technologies.
Collapse
Affiliation(s)
- Pan Zhou
- State Key Laboratory of Pollution Control and Resource Reuse, College of Environmental Science and Engineering, Tongji University, Shanghai 200092, PR China
| | - Dunjie Li
- State Key Laboratory of Pollution Control and Resource Reuse, College of Environmental Science and Engineering, Tongji University, Shanghai 200092, PR China
| | - Cong Zhang
- State Key Laboratory of Pollution Control and Resource Reuse, College of Environmental Science and Engineering, Tongji University, Shanghai 200092, PR China
| | - Qian Ping
- State Key Laboratory of Pollution Control and Resource Reuse, College of Environmental Science and Engineering, Tongji University, Shanghai 200092, PR China; Shanghai Institute of Pollution Control and Ecological Security, Shanghai 200092, PR China
| | - Lin Wang
- State Key Laboratory of Pollution Control and Resource Reuse, College of Environmental Science and Engineering, Tongji University, Shanghai 200092, PR China; Shanghai Institute of Pollution Control and Ecological Security, Shanghai 200092, PR China
| | - Yongmei Li
- State Key Laboratory of Pollution Control and Resource Reuse, College of Environmental Science and Engineering, Tongji University, Shanghai 200092, PR China; Shanghai Institute of Pollution Control and Ecological Security, Shanghai 200092, PR China.
| |
Collapse
|
2
|
Ma M, Duan W, Huang X, Zeng D, Hu L, Gui W, Zhu G, Jiang J. Application of calcium peroxide in promoting resource recovery from municipal sludge: A review. CHEMOSPHERE 2024; 354:141704. [PMID: 38490612 DOI: 10.1016/j.chemosphere.2024.141704] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/07/2023] [Revised: 02/26/2024] [Accepted: 03/11/2024] [Indexed: 03/17/2024]
Abstract
The harmless disposal, resource recovery, and synergistic efficiency reduction of municipal sludge have been the research focuses for the last few years. Calcium peroxide (CaO2) is a multifunctional and safe peroxide that produces an alkaline oxidation environment to promote the fermentation of municipal sludge to produce hydrogen (H2) and volatile fatty acids (VFAs), thus realizing sludge resource recovery. This review outlines the research achievements of CaO2 in sludge resource recovery, improvement of sludge dewaterability, and removal of pollutants from sludge in recent years. Meanwhile, the mechanism of CaO2 and its influencing factors have also been comprehensively summarized. Finally, the future development direction of the application of CaO2 in municipal sludge is prospected. This review would provide theoretical reference for the potential engineering applications of CaO2 in improving sludge treatment in the future.
Collapse
Affiliation(s)
- Mengsha Ma
- Collaborative Innovation Center of Atmospheric Environment and Equipment Technology, Jiangsu Key Laboratory of Atmospheric Environment Monitoring and Pollution Control, School of Environmental Science and Engineering, Nanjing University of Information Science & Technology, Nanjing, 210044, China
| | - Weiyan Duan
- Ocean College of Hebei Agricultural University, Qinhuangdao, Hebei Province, China
| | - Xiao Huang
- Collaborative Innovation Center of Atmospheric Environment and Equipment Technology, Jiangsu Key Laboratory of Atmospheric Environment Monitoring and Pollution Control, School of Environmental Science and Engineering, Nanjing University of Information Science & Technology, Nanjing, 210044, China; Shenzhen Key Laboratory of Water Resources Utilization and Environmental Pollution Control, School of Civil and Environmental Engineering, Harbin Institute of Technology (Shenzhen), Shenzhen, 518055, China.
| | - Daojing Zeng
- Collaborative Innovation Center of Atmospheric Environment and Equipment Technology, Jiangsu Key Laboratory of Atmospheric Environment Monitoring and Pollution Control, School of Environmental Science and Engineering, Nanjing University of Information Science & Technology, Nanjing, 210044, China
| | - Liangshan Hu
- Collaborative Innovation Center of Atmospheric Environment and Equipment Technology, Jiangsu Key Laboratory of Atmospheric Environment Monitoring and Pollution Control, School of Environmental Science and Engineering, Nanjing University of Information Science & Technology, Nanjing, 210044, China
| | - Wenjing Gui
- Collaborative Innovation Center of Atmospheric Environment and Equipment Technology, Jiangsu Key Laboratory of Atmospheric Environment Monitoring and Pollution Control, School of Environmental Science and Engineering, Nanjing University of Information Science & Technology, Nanjing, 210044, China
| | - Gaoming Zhu
- Collaborative Innovation Center of Atmospheric Environment and Equipment Technology, Jiangsu Key Laboratory of Atmospheric Environment Monitoring and Pollution Control, School of Environmental Science and Engineering, Nanjing University of Information Science & Technology, Nanjing, 210044, China
| | - Jiahong Jiang
- New York University, New York, NY, 10012, United States
| |
Collapse
|
3
|
Hangri S, Derbal K, Policastro G, Panico A, Contestabile P, Pontoni L, Race M, Fabbricino M. Combining pretreatments and co-fermentation as successful approach to improve biohydrogen production from dairy cow manure. ENVIRONMENTAL RESEARCH 2024; 246:118118. [PMID: 38199469 DOI: 10.1016/j.envres.2024.118118] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/04/2023] [Revised: 01/02/2024] [Accepted: 01/04/2024] [Indexed: 01/12/2024]
Abstract
The present paper is focused on enhancing the production of biohydrogen (bioH2) from dairy cow manure (DCM) through dark fermentation (DF). Two enhancement production strategies have been tested: i) the combination of H2O2 with sonification as pretreatment and ii) the co-fermentation with cheese whey as co-substrate. Concerning the pretreatment, the best combination was investigated according to the response surface methodology (RSM) by varying H2O2 dosage between 0.0015 and 0.06 g/gTS and ultrasonic specific energy input (USEI) between 35.48 and 1419.36 J/gTS. The increase of carbohydrates concentration was used as target parameter. Results showed that the combination of 0.06 g/gTS of H2O2 with 1419.36 J/gTS of USEI maximized the concentration of carbohydrates. The optimized conditions were used to pretreat the substrate prior conducting DF tests. The use of pretreatment resulted in obtaining a cumulative bioH2 volume of 51.25 mL/L and enhanced the bioH2 production by 125% compared to the control test conducted using raw DCM. Moreover, the second strategy, i.e. co-fermentation with cheese whey (20% v/v) as co-substrate ended up to enhancing the DF performance as the bioH2 production reached a value of 334.90 mL/L with an increase of 1372% compared to the control DF test. To further improve the process, dark fermentation effluents (DFEs) were valorized via photo fermentation (PF), obtaining an additional hydrogen production aliquot.
Collapse
Affiliation(s)
- S Hangri
- Department of Process Engineering National Polytechnic School of Constantine, Algeria
| | - K Derbal
- Department of Process Engineering National Polytechnic School of Constantine, Algeria
| | - G Policastro
- Department of Engineering and Computer Science Telematic University, Pegaso, Italy.
| | - A Panico
- Department of Engineering, University of Campania "Luigi Vanvitelli", Italy.
| | - P Contestabile
- Department of Engineering, University of Campania "Luigi Vanvitelli", Italy
| | - L Pontoni
- Department of Civil, Architectural and Environmental Engineering, University of Naples Federico II, Italy
| | - M Race
- Department of Civil and Mechanical Engineering University of Cassino and Southern, Lazio, Italy
| | - M Fabbricino
- Department of Civil, Architectural and Environmental Engineering, University of Naples Federico II, Italy
| |
Collapse
|
4
|
Bermúdez-Penabad N, Rodríguez-Montes A, Alves M, Kennes C, Veiga MC. Optimization of methane production from solid tuna waste: Thermal pretreatment and co-digestion. WASTE MANAGEMENT (NEW YORK, N.Y.) 2024; 177:203-210. [PMID: 38340568 DOI: 10.1016/j.wasman.2024.01.050] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/23/2023] [Revised: 01/24/2024] [Accepted: 01/29/2024] [Indexed: 02/12/2024]
Abstract
Fish canning industries generate large amounts of solid waste during their processing operations, creating a significant environmental challenge. Nonetheless, this waste can be efficiently and sustainably treated through anaerobic digestion. In this study, the potential of biogas production from anaerobic digestion of thermally pretreated and co-digested solid tuna waste was investigated. The thermal pretreatment of raw fish viscera resulted in a 50 % increase in methane yield, with a production of 0.27 g COD-CH4/g COD added. However, this pretreatment did not lead to a significant increase in biogas production for cooked tuna viscera. When non-thermally pretreated raw viscera was tested, a large accumulation of volatile fatty acids and long chain fatty acids was observed, with levels reaching 21 and 6 g COD/L, respectively. On the other hand, anaerobic co-digestion of cooked tuna viscera with fat waste significantly enhanced methane production, achieving 0.87 g COD-CH4/g COD added. In contrast, co-digestion of cooked tuna viscera with dairy waste and sewage sludge resulted in notably lower yields of 0.36 and 0.46 g COD-CH4/g COD added, respectively. These results may be related to the C/N ratio, which was found to be within the optimal range for anaerobic digestion only in the tuna and fat waste co-digestion assay.
Collapse
Affiliation(s)
- Noela Bermúdez-Penabad
- Chemical Engineering Laboratory, Faculty of Sciences and Interdisciplinary Center for Chemistry and Biology (CICA), University of A Coruña, Rúa da Fraga, 10, 15008 A Coruña, Spain; Institute for Biotechnology and Bioengineering (IBB), Centre of Biological Engineering, University of Minho, 4710-057 Braga, Portugal
| | - Andrea Rodríguez-Montes
- Chemical Engineering Laboratory, Faculty of Sciences and Interdisciplinary Center for Chemistry and Biology (CICA), University of A Coruña, Rúa da Fraga, 10, 15008 A Coruña, Spain
| | - Madalena Alves
- Institute for Biotechnology and Bioengineering (IBB), Centre of Biological Engineering, University of Minho, 4710-057 Braga, Portugal
| | - Christian Kennes
- Chemical Engineering Laboratory, Faculty of Sciences and Interdisciplinary Center for Chemistry and Biology (CICA), University of A Coruña, Rúa da Fraga, 10, 15008 A Coruña, Spain
| | - María C Veiga
- Chemical Engineering Laboratory, Faculty of Sciences and Interdisciplinary Center for Chemistry and Biology (CICA), University of A Coruña, Rúa da Fraga, 10, 15008 A Coruña, Spain.
| |
Collapse
|
5
|
Chen P, Wang E, Zheng Y, Ran X, Ren Z, Guo J, Dong R. Synergistic effect of hydrothermal sludge and food waste in the anaerobic co-digestion process: microbial shift and dewaterability. ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2024; 31:18723-18736. [PMID: 38349498 DOI: 10.1007/s11356-024-32282-5] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/17/2023] [Accepted: 01/27/2024] [Indexed: 03/09/2024]
Abstract
While thermal hydrolysis technology is commonly employed for sewage sludge treatment in extensive wastewater treatment facilities, persistent challenges remain, including issues such as ammonia-induced digestive inhibition and reduced productivity stemming from nutrient deficiency within the hydrothermal sludge. In this study, the effects of hydrothermal sludge-to-food waste mixing ratios and fermentation temperatures on anaerobic co-digestion were systematically investigated through a semi-continuous experiment lasting approximately 100 days. The results indicated that anaerobic co-digestion of hydrothermal sludge and food waste proceeded synergistically at any mixing ratio, and the synergistic effect is mainly attributed to the improvement of carbohydrate removal and digestive system stability. However, thermophilic digestion did not improve the anaerobic performance and methane yield. On the contrary, mesophilic digestion performed better in terms of organic matter removal, especially in the utilization of soluble carbohydrates, soluble proteins, and VFAs. Microbial community analysis revealed that the transition from mesophilic to thermophilic anaerobic co-digestion prompts changes in the methane-producing pathways. Specifically, the transition entails a gradual shift from pathways involving acetoclastic and hydrogenotrophic methanogenesis to a singular hydrogenotrophic methanogenesis pathway. This shift is driven by thermodynamic tendencies, as reflected in Gibbs free energy, as well as environmental factors like ammonia nitrogen and volatile fatty acids. Lastly, it is worth noting that the introduction of food waste did lead to a reduction in cake solids following dewatering. Nevertheless, it was observed that thermophilic digestion had a positive impact on dewatering performance.
Collapse
Affiliation(s)
- Penghui Chen
- College of Engineering, China Agricultural University, Beijing, 100083, People's Republic of China
| | - Enzhen Wang
- College of Engineering, China Agricultural University, Beijing, 100083, People's Republic of China
| | - Yonghui Zheng
- College of Engineering, China Agricultural University, Beijing, 100083, People's Republic of China
| | - Xueling Ran
- College of Engineering, China Agricultural University, Beijing, 100083, People's Republic of China
| | - Zhengran Ren
- Beijing Drainage Group Co. Ltd, Beijing, 100022, China
| | - Jianbin Guo
- College of Engineering, China Agricultural University, Beijing, 100083, People's Republic of China.
| | - Renjie Dong
- College of Engineering, China Agricultural University, Beijing, 100083, People's Republic of China
- Yantai Institute, China Agricultural University, Yantai, 264032, Shandong, People's Republic of China
| |
Collapse
|
6
|
Yang J, Chen R, Zhang Q, Zhang L, Li Q, Zhang Z, Wang Y, Qu B. Green and chemical-free pretreatment of corn straw using cold isostatic pressure for methane production. THE SCIENCE OF THE TOTAL ENVIRONMENT 2023; 897:165442. [PMID: 37442465 DOI: 10.1016/j.scitotenv.2023.165442] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/06/2023] [Revised: 06/19/2023] [Accepted: 07/08/2023] [Indexed: 07/15/2023]
Abstract
In this study, the effect of cold isostatic pressure (CIP) pretreatment on the physicochemical properties and subsequent anaerobic digestion (AD) performance of corn straw (CS) was explored. The CS was subjected to CIP pretreatment by pressures of 200, 400 and 600 MPa, respectively, while AD was carried out at medium temperature (35 ± 2 °C). The results showed that CIP pretreatment disrupted the dense structure of the CS and altered the crystallinity index and surface hydrophobicity of the CS, thereby affecting the AD process. The presence of CIP pretreatment increased the initial reducing sugar concentration by 0.11-0.27 g/L and increased the maximum volatile fatty acids content by 112.82-436.64 mg/L, which facilitated the process of acidification and hydrolysis of the AD. It was also observed that the CIP pretreatment maintained the pH in the range of 6.37-7.30, maintaining the stability of the overall system. Moreover, the cumulative methane production in the CIP pretreatment group increased by 27.17 %-64.90 % compared to the control group. Analysis of the microbial results showed that CIP pretreatment increased the abundance of cellulose degrading bacteria Ruminofilibacter from 21.50 % to 27.53 % and acetoclastic methanogen Methanosaeta from 45.48 % to 56.92 %, thus facilitating the hydrolysis and methanogenic stages. The energy conversion analysis showed that CIP is a green and non-polluting pretreatment strategy for the efficient AD of CS to methane.
Collapse
Affiliation(s)
- Jiancheng Yang
- College of Art and Science, Northeast Agr Univ, Harbin 150030, People's Republic of China
| | - Ruijie Chen
- College of Art and Science, Northeast Agr Univ, Harbin 150030, People's Republic of China
| | - Quanguo Zhang
- Huanghe S&T Univ, Inst Agr Engn, Zhengzhou 450006, People's Republic of China; Henan Agr Univ, Key Lab New Mat & Facil Rural Renewable Energy, MOA China, Zhengzhou 450002, People's Republic of China
| | - Linhai Zhang
- Taiyuan Donglong Machinery Co., Ltd., Taiyuan 030013, People's Republic of China
| | - Qichen Li
- Institute of Environment and Sustainable Development in Agriculture, Chinese Academy of Agricultural Sciences, Beijing 100081, People's Republic of China
| | - Zhiyun Zhang
- College of Animal Medicine, Northeast Agr Univ, Harbin 150030, People's Republic of China
| | - Yuxin Wang
- College of Art and Science, Northeast Agr Univ, Harbin 150030, People's Republic of China
| | - Bin Qu
- College of Art and Science, Northeast Agr Univ, Harbin 150030, People's Republic of China.
| |
Collapse
|
7
|
Chandrasekaran S, Banu JR, Kumar G. Effect of thermal-calcium peroxide mediated exopolymer release on disperser pre-treatment for efficient anaerobic digestion. ENVIRONMENTAL RESEARCH 2023; 235:116635. [PMID: 37454801 DOI: 10.1016/j.envres.2023.116635] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/25/2023] [Revised: 07/02/2023] [Accepted: 07/10/2023] [Indexed: 07/18/2023]
Abstract
The present study aimed to improve the hydrolysis potential of paper mill sludge through a two-phase disintegration process. In Particular, attention was focused on removal of extracellular polymeric substance (EPS) i.e. deflocculation of sludge in order to improve the efficiency of subsequent disperser disintegration. During deflocculation, carbohydrate, protein and deoxyribonucleic acids (DNA) were used as assessment parameters. During disintegration, soluble chemical oxygen demand (SCOD) and suspended solids (SS) reduction were used as assessment index to evaluate the efficiency of disintegration. A greater EPS removal was attained while deflocculating the sludge at calcium peroxide dosage of 0.05 g/g suspended solids (SS) and at a temperature of 70 °C. When comparing the disintegrated samples, a clear variation was noted in deflocculated and disintegrated sludge (19.2%) than the disintegrated sludge alone (13.5%). This clearly shows the need for deflocculation prior to disintegration. Likewise, a higher biomethane production of 0.214 L/g COD was achieved in deflocculated and disintegrated sludge than the pretreated sludge alone. Deflocculation reduces sludge management cost from 170 USD (Disperser alone (D alone disintegration)) to 51 USD (Thermal calcium peroxide mediated-Disperser (TCaO2-D disintegration), indicating the efficiency of the proposed disintegration.
Collapse
Affiliation(s)
- Sivaraman Chandrasekaran
- Center of Excellence in Environmental Studies (CEES), King Abdulaziz University, Jeddah, 21589, Saudi Arabia
| | - J Rajesh Banu
- Department of Biotechnology, Central University of Tamil Nadu, Neelakudi, Thiruvarur, 610005, Tamil Nadu, India
| | - Gopalakrishnan Kumar
- School of Civil and Environmental Engineering, Yonsei University, Seoul, 03722, South Korea; Department of Chemistry, Bioscience and Environmental Engineering, Faculty of Science and Technology, University of Stavanger, Forus 4036, Stavanger, Norway.
| |
Collapse
|
8
|
Daniel F, Sekar M, Gavurová B, Govindasamy C, Moorthy R K, P B, T R P. Recovering biogas and nutrients via novel anaerobic co-digestion of pre-treated water hyacinth for the enhanced biogas production. ENVIRONMENTAL RESEARCH 2023; 231:116216. [PMID: 37224944 DOI: 10.1016/j.envres.2023.116216] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/28/2022] [Revised: 05/19/2023] [Accepted: 05/20/2023] [Indexed: 05/26/2023]
Abstract
The present investigation explores the feasibility of generating biogas from water hyacinth (WH) through a pretreatment process. The WH samples were subjected to a high concentration of H2SO4 pretreatment to enhance biogas production. The H2SO4 pretreatment aids in breaking down the lignocellulosic materials found in the WH. Additionally, it helps modify the cellulose, hemicellulose, and lignin, which assists in the anaerobic digestion process. The samples underwent pretreatment with 5% v/v H2SO4 for 60 min. Biogas production was conducted for both untreated and pretreated samples. Furthermore, sewage sludge and cow dung were used as inoculants to promote fermentation in the absence of oxygen. The results of this study demonstrate that the pretreatment of water hyacinth with 5% v/v H2SO4 for 60 min considerably enhances biogas production through the anaerobic co-digestion process. The maximum biogas production was recorded by T. Control-1, with a production rate of 155 mL on the 15th day compared to all other controls. All the pretreated samples showed the highest biogas production on the 15th day, which is comparatively five days earlier than the untreated samples. In terms of CH4 production, the maximum yield was observed between the 25th and 27th days. These findings suggest that water hyacinth is a viable source of biogas production, and the pretreatment method significantly improves biogas yield. This study presents a practical and innovative approach to biogas production from water hyacinth and highlights the potential for further research in this area.
Collapse
Affiliation(s)
- Freedon Daniel
- Department of Mechanical Engineering, SRM Institute of Science and Technology, Ghaziabad, India
| | - M Sekar
- School of Mechanical Engineering, Sathyabama Institute of Science and Technology, India
| | - Beata Gavurová
- Technical University of Košice, Faculty of Mining, Ecology, Process Control and Geotechnologies, Letná 1/9, 042 00, Košice-Sever, Slovak Republic
| | - Chandramohan Govindasamy
- Department of Community Health Sciences, College of Applied Medical Sciences, King Saud University, P.O. Box 10219, Riyadh, 11433, Saudi Arabia
| | - Krishnan Moorthy R
- Department of Electrical and Electronics, Sathyabama Institute of Science and Technology, India
| | - Boomadevi P
- School of Mechanical Engineering, Sathyabama Institute of Science and Technology, India
| | - Praveenkumar T R
- Department of Construction Technology and Management, Wollega University, Nekemte, Ethiopia.
| |
Collapse
|
9
|
Ćwiertniewicz-Wojciechowska M, Cema G, Ziembińska-Buczyńska A. Sewage sludge pretreatment: current status and future prospects. ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2023; 30:88313-88330. [PMID: 37453013 PMCID: PMC10412499 DOI: 10.1007/s11356-023-28613-7] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/13/2022] [Accepted: 07/01/2023] [Indexed: 07/18/2023]
Abstract
Sewage sludge is regarded by wastewater treatment plants as problematic, from a financial and managerial point of view. Thus, a variety of disposal routes are used, but the most popular is methane fermentation. The proportion of macromolecular compounds in sewage sludges varies, and substrates treated in methane fermentation provide different amounts of biogas with various quality and quantity. Depending on the equipment and financial capabilities for methane fermentation, different methods of sewage sludge pretreatment are available. This review presents the challenges associated with the recalcitrant structure of sewage sludge and the presence of process inhibitors. We also examined the diverse methods of sewage sludge pretreatment that increase methane yield. Moreover, in the field of biological sewage sludge treatment, three future study propositions are proposed: improved pretreatment of sewage sludge using biological methods, assess the changes in microbial consortia caused with pretreatment methods, and verification of microbial impact on biomass degradation.
Collapse
Affiliation(s)
| | - Grzegorz Cema
- Department of Environmental Biotechnology, Silesian University of Technology, Akademicka 2A, 44-100, Gliwice, Poland
| | | |
Collapse
|
10
|
Hu Y, Liu S, Wang X, Zhang S, Hu T, Wang X, Wang C, Wu J, Xu L, Xu G, Hu F. Enhanced anaerobic digestion of kitchen waste at different solids content by alkali pretreatment and bentonite addition: Methane production enhancement and microbial mechanism. BIORESOURCE TECHNOLOGY 2023; 369:128369. [PMID: 36423763 DOI: 10.1016/j.biortech.2022.128369] [Citation(s) in RCA: 4] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/30/2022] [Revised: 11/16/2022] [Accepted: 11/17/2022] [Indexed: 06/16/2023]
Abstract
High solid anaerobic digestion (AD) has been considered as a promising and sustainable technology for treating kitchen waste. To enhance AD of kitchen waste, alkali pretreatment and bentonite addition treatment (AP/Be) was performed on kitchen waste, and microbial community was investigated at different total solids (TS) content (10%, 13%, 19%, 22% and 25%). The results indicated that after AP/Be treatment, methane yield was as high as 198 mL CH4/g volatile solid (VS), which increased by 236% as the control. Moreover, microbial community analysis revealed that AP/Be treatment enriched bacterial microbial diversity. At TS of 10%, AP/Be treatment enhanced the hydrogenotrophic methanogens (Methanobacterium) significantly. In addition, the dominant methanogenic pathways changed at different TS content. These results demonstrated AP/Be treatment had a positive effect on methanogenesis during kitchen waste anaerobic digestion process. This study threw new insights towards enhancing kitchen waste anaerobic digestion, as well as the microbial mechanism.
Collapse
Affiliation(s)
- Yuying Hu
- School of Civil Engineering and Architecture, East China Jiao Tong University, Nanchang 330013, China.
| | - Susu Liu
- School of Civil Engineering and Architecture, East China Jiao Tong University, Nanchang 330013, China
| | - Xiaofan Wang
- School of Civil Engineering and Architecture, East China Jiao Tong University, Nanchang 330013, China
| | - Shihao Zhang
- School of Civil Engineering and Architecture, East China Jiao Tong University, Nanchang 330013, China
| | - Tengfang Hu
- School of Civil Engineering and Architecture, East China Jiao Tong University, Nanchang 330013, China
| | - Xin Wang
- School of Civil Engineering and Architecture, East China Jiao Tong University, Nanchang 330013, China
| | - Chuqiao Wang
- School of Civil Engineering and Architecture, East China Jiao Tong University, Nanchang 330013, China
| | - Jing Wu
- State Key Joint Laboratory of Environment Simulation and Pollution Control, School of Environment, Tsinghua University, Beijing 100084, China
| | - Li Xu
- Jiangxi Water Science Detecting and Researching Co., Ltd., Jingdezhen 333000, China
| | - Gaoping Xu
- Jiangxi Water Science Detecting and Researching Co., Ltd., Jingdezhen 333000, China
| | - Fengping Hu
- School of Civil Engineering and Architecture, East China Jiao Tong University, Nanchang 330013, China; State Key Joint Laboratory of Environment Simulation and Pollution Control, School of Environment, Tsinghua University, Beijing 100084, China
| |
Collapse
|
11
|
Anaerobic Digestion of the Residue (Combination of Wastewater and Solid Waste) from a New Olive-Oil Manufacturing Process Based on an Olive Cold-Pressing System: Kinetic Approach and Process Performance. Processes (Basel) 2022. [DOI: 10.3390/pr10122552] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/02/2022] Open
Abstract
This research evaluates the anaerobic digestion (AD) process of the residue generated in a new olive-oil manufacturing process for cold-pressed olive, a residue consisting of a mixture of the wastewater and solid waste obtained from this process. Additionally, in order to assess the possible influence of the level of ripening of the olives on the performance of anaerobic processing, olives of the Picual variety were collected at two stages, i.e., green olives and olives in veraison. The AD processes of the residues obtained from the cold-pressing process and the process without pressure (control) were comparatively assessed by means of biochemical methane potential (BMP) assays conducted at mesophilic temperature (35 ± 1 °C). Maximum values for methane yield (390 ± 1 NL CH4/kg VSadded) and biodegradability (84.5%) were obtained from the cold-pressed green olive residues. For the rest of the wastes studied, biodegradability also reached high values, ranging from 79.1 to 79.6%. The logistic model adequately fit the experimental data and allowed for the assessment of the anaerobic biodegradation of these wastes and for obtaining the kinetic parameters for each case studied. The theoretical values for ultimate methane production predicted from this model showed less than a 1% deviation from the experimental values. A decrease was detected for both types of olives tested in the rate of maximum methane production, Rm, during the cold-pressing process, from 44.3 ± 0.1 to 30.1 ± 1.3 L CH4/(kg VS·d) (green olives) and from 43.9 ± 1.5 to 38.7 ± 1.6 L CH4/(kg VS·d) (olives in veraison). Finally, the highest energy output result was detected in the waste from cold-pressed green olives (15.7 kJ/g VSremoved), which coincided with its high methane yield.
Collapse
|
12
|
Wu L, Wei W, Liu X, Wang D, Ni BJ. Potentiality of recovering bioresource from food waste through multi-stage Co-digestion with enzymatic pretreatment. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2022; 319:115777. [PMID: 35982572 DOI: 10.1016/j.jenvman.2022.115777] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/13/2022] [Revised: 07/15/2022] [Accepted: 07/15/2022] [Indexed: 06/15/2023]
Abstract
Food waste (FW) is not only a major social, nutritional and environmental issue, but also an underutilized resource with significant energy, which has not been fully explored currently. Considering co-digestion can adjust carbon to nitrogen ratio (C/N) of the feedstock and improve the synergetic interactions among microorganisms, anaerobic co-digestion (AnCoD) is then becoming an emerging approach to achieve higher energy recovery from FW while ensuring the stability of the system. To obtain higher economic gain from such biodegradable wastes, increasing attention has been paid on optimizing the system configuration or applying enzymatic hydrolysis before digesting FW. A better understanding on the potentiality of correlating enzymatic pretreatment and AnCoD operated in various system configuration would enhance the bioresource recovery from FW and increase revenue through treating this organic waste. Specifically, the biobased chemicals outputs from FW-related co-digestion system with different configuration were firstly compared in this review. A deep discussion concerning the challenges for achieving bioresources recovery from FW co-digestion systems with enzymatic pretreatment was then given. Recommendations for future studies regarding FW co-digestion were then proposed at last.
Collapse
Affiliation(s)
- Lan Wu
- Centre for Technology in Water and Wastewater, School of Civil and Environmental Engineering, University of Technology Sydney, Sydney, NSW, 2007, Australia
| | - Wei Wei
- Centre for Technology in Water and Wastewater, School of Civil and Environmental Engineering, University of Technology Sydney, Sydney, NSW, 2007, Australia
| | - Xuran Liu
- Centre for Technology in Water and Wastewater, School of Civil and Environmental Engineering, University of Technology Sydney, Sydney, NSW, 2007, Australia
| | - Dongbo Wang
- Key Laboratory of Environmental Biology and Pollution Control, College of Environmental Science and Engineering, Hunan University, Changsha, 410082, China.
| | - Bing-Jie Ni
- Centre for Technology in Water and Wastewater, School of Civil and Environmental Engineering, University of Technology Sydney, Sydney, NSW, 2007, Australia.
| |
Collapse
|
13
|
Jin W, Dai Z, Wang L, Cai F, Song C, Liu G, Chen C. Recycling different textile wastes for methane production: Morphological and microstructural changes and microbial community dynamics. WASTE MANAGEMENT (NEW YORK, N.Y.) 2022; 151:154-162. [PMID: 35952413 DOI: 10.1016/j.wasman.2022.07.018] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/02/2022] [Revised: 06/13/2022] [Accepted: 07/16/2022] [Indexed: 06/15/2023]
Abstract
The dramatic increase of textile wastes has become a major global concern, which calls for alternative practices to alleviate severe environmental pollution and waste of resources due to their improper disposal and management. Anaerobic digestion (AD) is a cost-effective and eco-friendly technology that allows the bioconversion of organic wastes into clean energy (methane), which might be potentially useful for recycling textile wastes. In this study, AD was applied to 11 commonly available textile wastes in daily life to explore their feasibility, along with the methane production efficiency, biodegradability (BD), degradation mechanism, and microbial community dynamics during AD. The results showed that all textile wastes presented an obvious decomposition from an integrated shape to fragmented pieces within 18 days except blue denim. The highest experimental methane production (EMP) of 356.0 mL/g volatile solids (VS) and BD of 78.0 % were obtained with flax. The degradation mechanism could be concluded that predominant bacteria, especially Clostridium sensu stricto, first attached to the surface of textile waste and converted its main compositions cellulose and hemicellulose into acetate as the core intermediate. Then, acetate was utilized by the major methanogen, Methanothrix, through the acetoclastic methanogenesis pathway to produce methane. This study not only enriches the understanding of textile wastes degradation mechanisms during AD and provides very useful data on methane production from commonly available textile wastes but also proposes a promising method for efficiently recycling and utilizing the diverse range of textile wastes to reduce waste pollution and generate clean energy simultaneously.
Collapse
Affiliation(s)
- Wenxiong Jin
- College of Chemical Engineering, Beijing University of Chemical Technology, Beijing 100029, China
| | - Zhuangqiang Dai
- College of Chemical Engineering, Beijing University of Chemical Technology, Beijing 100029, China
| | - Ligong Wang
- College of Chemical Engineering, Beijing University of Chemical Technology, Beijing 100029, China
| | - Fanfan Cai
- College of Chemical Engineering, Beijing University of Chemical Technology, Beijing 100029, China
| | - Chao Song
- College of Chemical Engineering, Beijing University of Chemical Technology, Beijing 100029, China
| | - Guangqing Liu
- College of Chemical Engineering, Beijing University of Chemical Technology, Beijing 100029, China
| | - Chang Chen
- College of Chemical Engineering, Beijing University of Chemical Technology, Beijing 100029, China.
| |
Collapse
|
14
|
Chen Y, Qin Z, Zhang P, Li X, Feng L. Polycyclic aromatic hydrocarbons stimulate acidogenesis, acetogenesis and methanogenesis during anaerobic co-digestion of waste activated sludge and food waste. BIORESOURCE TECHNOLOGY 2022; 360:127567. [PMID: 35788387 DOI: 10.1016/j.biortech.2022.127567] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/04/2022] [Revised: 06/27/2022] [Accepted: 06/28/2022] [Indexed: 06/15/2023]
Abstract
Polycyclic aromatic hydrocarbons (PAHs) have been reported to influence acetic acid production during anaerobic treatment. However, investigations of the impacts of PAHs on the anaerobic co-digestion of waste activated sludge and food waste are limited. Therefore, the effects of PAHs on anaerobic co-digestion were explored in this study. Four kinds of PAHs all exhibited positive contributions to methane production, especially phenanthrene. Mechanism exploration revealed that acidogenesis, acetogenesis, and methanogenesis were improved in the presence of phenanthrene, and acetotrophic methanogenesis had the greatest improvement with 69.4%. Dominant bacteria and archaea related to acetic acid and methane accumulation were changed by phenanthrene. Moreover, extracellular polymeric substances, coenzyme F420, and McrA gene copy number were promoted by phenanthrene, which was beneficial for the generation of acetic acid and methane. Overall, this study provides new insights into the role of organic pollutants in the anaerobic co-digestion of solid wastes.
Collapse
Affiliation(s)
- Yinguang Chen
- State Key Laboratory of Pollution Control and Resources Reuse, School of Environmental Science and Engineering, Tongji University, 1239 Siping Road, Shanghai 200092, China; Shanghai Institute of Pollution Control and Ecological Security, Shanghai 200092, China
| | - Zhiyi Qin
- State Key Laboratory of Pollution Control and Resources Reuse, School of Environmental Science and Engineering, Tongji University, 1239 Siping Road, Shanghai 200092, China
| | - Pei Zhang
- State Key Laboratory of Pollution Control and Resources Reuse, School of Environmental Science and Engineering, Tongji University, 1239 Siping Road, Shanghai 200092, China
| | - Xiaolu Li
- State Key Laboratory of Pollution Control and Resources Reuse, School of Environmental Science and Engineering, Tongji University, 1239 Siping Road, Shanghai 200092, China
| | - Leiyu Feng
- State Key Laboratory of Pollution Control and Resources Reuse, School of Environmental Science and Engineering, Tongji University, 1239 Siping Road, Shanghai 200092, China; Shanghai Institute of Pollution Control and Ecological Security, Shanghai 200092, China.
| |
Collapse
|
15
|
Ma J, Feng S, Zhang Z, Wang Z, Kong W, Yuan P, Shen B, Mu L. Pyrolysis characteristics of biodried products derived from municipal organic wastes: Synergistic effect of bulking agents and modification of biodegradation. ENVIRONMENTAL RESEARCH 2022; 206:112300. [PMID: 34736638 DOI: 10.1016/j.envres.2021.112300] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/02/2021] [Revised: 10/15/2021] [Accepted: 10/25/2021] [Indexed: 06/13/2023]
Abstract
Derived from the biodrying of municipal organic wastes (MOWs), biodried products (BPs) are widely identified as renewable energy sources. In this study, for efficient energy recovery, the pyrolysis characteristics of BPs were investigated by comprehensive kinetic analysis, with special focus on the synergistic effect of bulking agents and the influence of biodegradation. Compared with theoretical raw materials (RMs), it was suggested that the synergistic effect of organics and lignocelluloses in RMs promoted decomposition in Stage 1 (400-570 K), especially for the pyrolysis of RM using sawdust, during which the positive effect achieved decomposition in advance with lower overlap ratio (0.9264) and ΔW (-9.50% at 619.0 K) values. Furthermore, compared with RMs, it was indicated that the kinetic indices (Ea and ln A values) of the BPs were upward in Stage 1 and decreased in Stage 2 due to biodegradation. The results of ΔH, ΔG and ΔS indicated that BP pyrolysis required more heat supply as the reaction progressed but formed a more organized activated complex. In addition, biodegradation observably decreased the generation of gas products and typical functional groups of volatiles during BP pyrolysis, such as CO2 and CO, which presented decreasing ratios of 32.18-42.47% and 30.25-46.47%, respectively. In general, the pyrolysis of BPs was intensified by bulking agents and modified by biodegradation.
Collapse
Affiliation(s)
- Jiao Ma
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin, 300401, China
| | - Shuo Feng
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin, 300401, China
| | - Zhikun Zhang
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin, 300401, China
| | - Zhuozhi Wang
- School of Chemical Engineering and Technology, Hebei University of Technology, Tianjin, 300130, China
| | - Wenwen Kong
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin, 300401, China
| | - Peng Yuan
- School of Chemical Engineering and Technology, Hebei University of Technology, Tianjin, 300130, China
| | - Boxiong Shen
- School of Chemical Engineering and Technology, Hebei University of Technology, Tianjin, 300130, China.
| | - Lan Mu
- School of Mechanical Engineering, Tianjin University of Commerce, Tianjin, 300134, China.
| |
Collapse
|
16
|
Ma JJ, Jiang CL, Tao XH, Sheng JL, Sun XZ, Zhang TZ, Zhang ZJ. Insights on dissolved organic matter and bacterial community succession during secondary composting in residue after black soldier fly larvae (Hermetia illucens L.) bioconversion for food waste treatment. WASTE MANAGEMENT (NEW YORK, N.Y.) 2022; 142:55-64. [PMID: 35176599 DOI: 10.1016/j.wasman.2022.01.034] [Citation(s) in RCA: 16] [Impact Index Per Article: 8.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/12/2021] [Revised: 01/20/2022] [Accepted: 01/23/2022] [Indexed: 06/14/2023]
Abstract
Black soldier fly larvae (Hermetia illucens L. BSFL) bioconversion is a promising biotechnology for food waste treatment. However, the separated residues still do not meet criteria for use as land application biofertilizers. In this work, we investigated a full-scale BSFL bioconversion project to explore features of dissolved organic matter (DOM) and its associated responses of bacterial community succession in residue during secondary composting. Data showed that the concentrations of total nitrogen and ammonium nitrogen decreased by 11.8% and 22.6% during the secondary composting, respectively, while the nitrate nitrogen concentration increased 18.7 times. The DOM concentration decreased by 69.1%, in which protein-like, alcohol-phenol, and biodegradable aliphatic substances were metabolized by bacteria during the thermophilic phase together with the accumulation of humus-like substances, resulting in an increase in the relative concentration of aromatic compounds. The structure of the bacterial community varied at different stages of the bioprocess, in which Bacteroidetes, Actinobacteria, Proteobacteria, and Firmicutes were the dominant bacterial phyla. Lysinibacillus, Pusillimonas, and Caldicoprobacter were found to be key contributors in the degradation and formation of DOM. The DOM concentration (33.4%) and temperature (17.7%) were the prime environmental factors that promoted succession of the bacterial community. Through bacterial metabolism, the structural stability of DOM components was improved during the composting process, and the degrees of humification and aromaticity were also increased. This study depicted the dynamic features of DOM and the associated bacterial community succession in residue during secondary composting, which is conducive with the reuse of BSFL residue as biofertilizer for agriculture.
Collapse
Affiliation(s)
- Jing-Jin Ma
- College of Natural Research and Environmental Sciences, ZheJiang University, YuHangTang Ave 688, HangZhou, ZheJiang Province 310058, PR China
| | - Cheng-Liang Jiang
- HangZhou GuSheng Technology Company Limited, XiangWang Ave 1118, HangZhou 311121, PR China; ZheJiang FuMei Biotechnology Company Limited, PingYao Future Complex Park, PingYao Ave, HangZhou 311115, PR China
| | - Xing-Hua Tao
- College of Natural Research and Environmental Sciences, ZheJiang University, YuHangTang Ave 688, HangZhou, ZheJiang Province 310058, PR China
| | - Jian-Lin Sheng
- HangZhou GuSheng Technology Company Limited, XiangWang Ave 1118, HangZhou 311121, PR China; ZheJiang FuMei Biotechnology Company Limited, PingYao Future Complex Park, PingYao Ave, HangZhou 311115, PR China
| | - Xin-Zhao Sun
- College of Natural Research and Environmental Sciences, ZheJiang University, YuHangTang Ave 688, HangZhou, ZheJiang Province 310058, PR China
| | - Ting-Zhou Zhang
- ZheJiang Cofine Biotechnology Company Limited, HaiNing 314400, PR China
| | - Zhi-Jian Zhang
- College of Natural Research and Environmental Sciences, ZheJiang University, YuHangTang Ave 688, HangZhou, ZheJiang Province 310058, PR China; China Academy of West Region Development, ZheJiang University, YuHangTang Ave 866, HangZhou 310058, PR China.
| |
Collapse
|
17
|
Gulsen Akbay HE, Dizge N, Kumbur H. Enhancing biogas production of anaerobic co-digestion of industrial waste and municipal sewage sludge with mechanical, chemical, thermal, and hybrid pretreatment. BIORESOURCE TECHNOLOGY 2021; 340:125688. [PMID: 34358985 DOI: 10.1016/j.biortech.2021.125688] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/08/2021] [Revised: 07/23/2021] [Accepted: 07/27/2021] [Indexed: 06/13/2023]
Abstract
This study presents the effect of mechanical, chemical, thermal, and hybrid pretreatment on anaerobic digestion of fruit-juice industrial waste (FW) co-digested with municipal sewage sludge (MSS). The pretreatment of the substrates with ultrasonication, microwave, weak alkali-acid caused an increase in cumulative biogas production of approximately 20.9, 14.9, 8.1, and 5.2%, respectively. Beside this, thermal and strong acid-alkali pretreatment reduced biogas production. The highest cumulative biogas and methane yield was increased with hybrid pretreatment which contains ultrasonication (US) and alkali (AL) pretreatment by 36% and 49%, respectively. Also, compared to untreated mixture, the soluble COD, carbohydrate, and protein removal efficiencies were increased from 42.6% to 65.6%, 65.1% to 86.6%, and 17.3% to 62.4%, respectively for US-AL pretreatment. The kinetic parameters of cumulative biogas production for the selected reactors were further estimated with Monod, Cone, and Transference Function models.
Collapse
Affiliation(s)
| | - Nadir Dizge
- Department of Environmental Engineering, Mersin University, Mersin 33343, Turkey
| | - Halil Kumbur
- Department of Environmental Engineering, Mersin University, Mersin 33343, Turkey
| |
Collapse
|
18
|
Rajendran N, Gurunathan B, Han J, Krishna S, Ananth A, Venugopal K, Sherly Priyanka RB. Recent advances in valorization of organic municipal waste into energy using biorefinery approach, environment and economic analysis. BIORESOURCE TECHNOLOGY 2021; 337:125498. [PMID: 34320774 DOI: 10.1016/j.biortech.2021.125498] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/28/2021] [Revised: 06/28/2021] [Accepted: 06/29/2021] [Indexed: 06/13/2023]
Abstract
Researcher's all around works on a copious technique to lessen waste production and superintend the waste management for long-term socio-economic and environmental benefits. Value-added products can be produced from municipal waste by using holistic and integrated approaches. In this review, a detail about the superiority of the different methods like anaerobic digestion, biofuel production, incineration, pyrolysis and gasification were used for the conversion of municipal waste to feedstock for alternate energy and its economic- environmental impacts were consolidated. Most conversion techniques were environmentally friendly to manage municipal waste. The biological process was more economically feasible compare to the thermal process, for the reason thermal process required a large amount of capital investment and energy utilization. In the thermal process, gasification shows low emission, and pyrolysis shows low capital investment and economically feasible compare to other thermal processes. Waste to energy technology significantly reduced the emission and energy demand.
Collapse
Affiliation(s)
- Naveenkumar Rajendran
- Department of Biotechnology, St. Joseph's College of Engineering, Chennai 600119, India; School of Chemical Engineering, Jeonbuk National University, 54896, Republic of Korea
| | - Baskar Gurunathan
- Department of Biotechnology, St. Joseph's College of Engineering, Chennai 600119, India.
| | - Jeehoon Han
- School of Chemical Engineering, Jeonbuk National University, 54896, Republic of Korea; School of Semiconductor and Chemical Engineering, Jeonbuk National University, 54896, Republic of Korea
| | - Saraswathi Krishna
- Department of Biotechnology, Karpaga Vinayaga College of Engineering and Technology, Kancheepuram 603308, India
| | - A Ananth
- Department of Microbiology, Srinivasan College of Arts and Science, Perambalur 621212, India
| | - K Venugopal
- Department of Biotechnology, Karpaga Vinayaga College of Engineering and Technology, Kancheepuram 603308, India
| | | |
Collapse
|
19
|
Zhuang H, Lee PH, Wu Z, Jing H, Guan J, Tang X, Tan GYA, Leu SY. Genomic driven factors enhance biocatalyst-related cellulolysis potential in anaerobic digestion. BIORESOURCE TECHNOLOGY 2021; 333:125148. [PMID: 33878497 DOI: 10.1016/j.biortech.2021.125148] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/08/2021] [Revised: 04/01/2021] [Accepted: 04/04/2021] [Indexed: 06/12/2023]
Abstract
Anaerobic digestion (AD) is a promising technology to recover bioenergy from biodegradable biomass, including cellulosic wastes. Through a few fractionation/separation techniques, cellulose has demonstrated its potential in AD, but the performance of the process is rather substrate-specific, as cellulolysis bacteria are sensitive to the enzyme-substrate interactions. Cellulosome is a self-assembled enzyme complex with many functionalized modules in the bacteria which has been gradually studied, however the genomic fingerprints of the culture-specific cellulosome in AD are relatively unclear especially under processing conditions. To clarify the key factors affecting the cellulosome induced cellulolysis, this review summarized the most recent publications of AD regarding the fates of cellulose, sources and functional genes of cellulosome, and omics methods for functional analyses. Different processes for organic treatment including applying food grinds in sewer, biomass valorization, cellulose fractionation, microaeration, and enzymatic hydrolysis enhanced fermentation, were highlighted to support the sustainable development of AD technology.
Collapse
Affiliation(s)
- Huichuan Zhuang
- Dept. of Civil and Environmental Engineering, The Hong Kong Polytechnic University, Hung Hom, Kowloon, Hong Kong; Department of Civil Engineering, The University of Hong Kong, Pokfulam Road, Hong Kong
| | - Po-Heng Lee
- Dept. of Civil and Environmental Engineering, Imperial College London, South Kensington Campus, London SW7 2AZ, UK
| | - Zhuoying Wu
- Dept. of Civil and Environmental Engineering, Imperial College London, South Kensington Campus, London SW7 2AZ, UK
| | - Houde Jing
- Dept. of Civil and Environmental Engineering, The Hong Kong Polytechnic University, Hung Hom, Kowloon, Hong Kong
| | - Jianyu Guan
- Dept. of Civil and Environmental Engineering, The Hong Kong Polytechnic University, Hung Hom, Kowloon, Hong Kong
| | - Xiaojing Tang
- Dept. of Civil and Environmental Engineering, The Hong Kong Polytechnic University, Hung Hom, Kowloon, Hong Kong
| | - Giin-Yu Amy Tan
- Department of Civil Engineering, The University of Hong Kong, Pokfulam Road, Hong Kong
| | - Shao-Yuan Leu
- Dept. of Civil and Environmental Engineering, The Hong Kong Polytechnic University, Hung Hom, Kowloon, Hong Kong.
| |
Collapse
|
20
|
Serrano A, Siles JÁ, Gutiérrez MDC, Martín MDLÁ. Comparison of Pre-treatment Technologies to Improve Sewage Sludge Biomethanization. Appl Biochem Biotechnol 2020; 193:777-790. [PMID: 33188508 DOI: 10.1007/s12010-020-03454-z] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/06/2020] [Accepted: 11/08/2020] [Indexed: 10/23/2022]
Abstract
This research study evaluates various pre-treatments to improve sewage sludge solubilization prior to treatment by mesophilic anaerobic digestion. Microwave, thermal, and sonication pre-treatments were compared as these pre-treatments are the most commonly used for this purpose. The solubilization of sewage sludge was evaluated through the variation in soluble total organic carbon (sTOC, mg/L) and soluble total nitrogen (sTN, mg/L). Thermal and microwave pre-treatments increased sTOC/VS by 19.2% and 83.4% (VS, total volatile solids), respectively, after applying lower specific energy through (20 kJ/g TS, approximately) (TS, total solids) unlike the sonication pre-treatment, which required 136 kJ/g TS. Although sTN content did not increase significantly with the pre-treatments with respect to sTOC, both showed proportional trends. Sonication pre-treatments allowed the highest increase in volatile fatty acids (VFA) with respect to the raw sewage sludge (15% ∆VFA/sTOC). Methane production with and without pre-treatment was also evaluated. Methane production increased by 95% after applying sonication pre-treatment compared to the methane production of raw sewage sludge. Thermal and microwave pre-treatments entailed lower improvements (29% and 20%, respectively). Economically, thermal pre-treatments were the most viable alternative at real scale. Graphical abstract.
Collapse
Affiliation(s)
- Antonio Serrano
- Department of Inorganic Chemistry and Chemical Engineering, University of Cordoba, Campus Universitario de Rabanales, Edificio Marie Curie (C-3), Ctra. N IV, km 396, 14071, Cordoba, Spain
| | - José Ángel Siles
- Department of Inorganic Chemistry and Chemical Engineering, University of Cordoba, Campus Universitario de Rabanales, Edificio Marie Curie (C-3), Ctra. N IV, km 396, 14071, Cordoba, Spain
| | - María Del Carmen Gutiérrez
- Department of Inorganic Chemistry and Chemical Engineering, University of Cordoba, Campus Universitario de Rabanales, Edificio Marie Curie (C-3), Ctra. N IV, km 396, 14071, Cordoba, Spain
| | - María de Los Ángeles Martín
- Department of Inorganic Chemistry and Chemical Engineering, University of Cordoba, Campus Universitario de Rabanales, Edificio Marie Curie (C-3), Ctra. N IV, km 396, 14071, Cordoba, Spain.
| |
Collapse
|