1
|
Rampanti G, Cardinali F, Bande De León CM, Ferrocino I, Franciosa I, Milanović V, Foligni R, Tejada Portero L, Garofalo C, Osimani A, Aquilanti L. Onopordum platylepis (Murb.) Murb. as a novel source of thistle rennet: First application to the manufacture of traditional Italian raw ewe's milk cheese. Food Res Int 2024; 192:114838. [PMID: 39147526 DOI: 10.1016/j.foodres.2024.114838] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/13/2024] [Revised: 07/07/2024] [Accepted: 07/26/2024] [Indexed: 08/17/2024]
Abstract
In this study, for the very first time, aqueous extracts obtained from flowers of spontaneously grown or cultivated Onopordum platylepis (Murb.) Murb. thistles were used as coagulating agents for the pilot-scale manufacture of Caciofiore, a traditional Italian raw ewe's milk cheese. Cheese prototypes were compared to control cheeses curdled with a commercial thistle rennet obtained from flowers of Cynara cardunculus L. After 45 days of ripening under controlled conditions, both the experimental and control cheese prototypes were analyzed for: cheese yield, physico-chemical (pH, titratable acidity, aw, proximate composition), morpho-textural (color and texture), and microbiological parameters (viable cell counts and species composition assessed by Illumina sequencing), as well as volatile profile by SPME-GC-MS. Slight variations in titratable acidity, color, and texture were observed among samples. Based on the results overall collected, neither the yield nor the proximate composition was apparently affected by the type of thistle coagulant. However, the experimental cheese prototypes curdled with extracts from flowers of both spontaneous or cultivated thistles showed 10 % higher values of water-soluble nitrogen compared to the control prototypes. On the other hand, these latter showed slightly higher loads of presumptive lactococci, thermophilic cocci, coliforms, and eumycetes, but lower counts of Escherichia coli. No statistically significant differences were revealed by the metataxonomic analysis of the bacterial and fungal biota. Though most volatile organic compounds (VOCs) were consistent among the prototypes, significant variability was observed in the abundance of some key aroma compounds, such as butanoic, hexanoic, and octanoic acids, ethanol, propan-2-ol, isobutyl acetate, 2-methyl butanoic acid, and 3-methyl butanal. However, further investigations are required to attribute these differences to either the type of coagulant or the metabolic activity of the microorganisms occurring in the analyzed cheese samples. The results overall collected support the potential exploitation of O. platylepis as a novel source of thistle coagulant to produce ewe's milk cheeses.
Collapse
Affiliation(s)
- Giorgia Rampanti
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, 60131 Ancona, Italy
| | - Federica Cardinali
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, 60131 Ancona, Italy
| | - Cindy María Bande De León
- Department of Human Nutrition and Food Technology, Universidad Católica de Murcia (UCAM), Campus de los Jerónimos, Guadalupe 30107, Spain
| | - Ilario Ferrocino
- Department of Agricultural, Forest, and Food Science, University of Turin (UNITO), Largo Paolo Braccini 2, 10095 Grugliasco, Italy
| | - Irene Franciosa
- Department of Agricultural, Forest, and Food Science, University of Turin (UNITO), Largo Paolo Braccini 2, 10095 Grugliasco, Italy
| | - Vesna Milanović
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, 60131 Ancona, Italy
| | - Roberta Foligni
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, 60131 Ancona, Italy
| | - Luis Tejada Portero
- Department of Human Nutrition and Food Technology, Universidad Católica de Murcia (UCAM), Campus de los Jerónimos, Guadalupe 30107, Spain
| | - Cristiana Garofalo
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, 60131 Ancona, Italy
| | - Andrea Osimani
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, 60131 Ancona, Italy
| | - Lucia Aquilanti
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, 60131 Ancona, Italy.
| |
Collapse
|
2
|
Gapp C, Dijamentiuk A, Mangavel C, Callon C, Theil S, Revol-Junelles AM, Chassard C, Borges F. Serial fermentation in milk generates functionally diverse community lineages with different degrees of structure stabilization. mSystems 2024; 9:e0044524. [PMID: 39041801 PMCID: PMC11334471 DOI: 10.1128/msystems.00445-24] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/28/2024] [Accepted: 06/26/2024] [Indexed: 07/24/2024] Open
Abstract
Microbial communities offer considerable potential for tackling environmental challenges by improving the functioning of ecosystems. Top-down community engineering is a promising strategy that could be used to obtain communities of desired function. However, the ecological factors that control the balance between community shaping and propagation are not well understood. Dairy backslopping, which consists of using part of the previous production to inoculate a new one, can be used as a model engineering approach to investigate community dynamics during serial propagations. In this study, 26 raw milk samples were serially propagated 6 times each, giving rise to 26 community lineages. Bacterial community structures were analyzed by metabarcoding, and acidification was recorded by pH monitoring. The results revealed that different types of community lineages could be obtained in terms of taxonomic composition and dynamics. Five lineages reached a repeatable community structure in a few propagation steps, with little variation between the final generations, giving rise to stable acidification kinetics. Moreover, these stabilized communities presented a high variability of structure and diverse acidification properties between community lineages. Besides, the other lineages were characterized by different levels of dynamics leading to parallel or divergent trajectories. The functional properties and dynamics of the communities were mainly related to the relative abundance and the taxonomic composition of lactic acid bacteria within the communities. These findings highlight that short-term schemes of serial fermentation can produce communities with a wide range of dynamics and that the balance between community shaping and propagation is intimately linked to community structure. IMPORTANCE Microbiome applications require approaches for shaping and propagating microbial communities. Shaping allows the selection of communities with desired taxonomic and functional properties, while propagation allows the production of the biomass required to inoculate the engineered communities in the target ecosystem. In top-down community engineering, where communities are obtained from a pool of mixed microorganisms by acting on environmental variables, a major challenge is to master the balance between shaping and propagation. However, the ecological factors that favor high dynamics of community structure and, conversely, those that favor stability during propagation are not well understood. In this work, short-term dairy backslopping was used to investigate the key role of the taxonomic composition and structure of bacterial communities on their dynamics. The results obtained open up interesting prospects for the biotechnological use of microbiomes, particularly in the field of dairy fermentation, to diversify approaches for injecting microbial biodiversity into cheesemaking processes.
Collapse
Affiliation(s)
- Chloé Gapp
- Université de Lorraine, LIBio, Nancy, France
- Université Clermont Auvergne, INRAE, VetAgro Sup, UMR 0545 Fromage, Aurillac, France
| | | | | | - Cécile Callon
- Université Clermont Auvergne, INRAE, VetAgro Sup, UMR 0545 Fromage, Aurillac, France
| | - Sébastien Theil
- Université Clermont Auvergne, INRAE, VetAgro Sup, UMR 0545 Fromage, Aurillac, France
| | | | - Christophe Chassard
- Université Clermont Auvergne, INRAE, VetAgro Sup, UMR 0545 Fromage, Aurillac, France
| | | |
Collapse
|
3
|
Martin AJ, Revol-Junelles AM, Petit J, Gaiani C, Leyva Salas M, Nourdin N, Khatbane M, Mafra de Almeida Costa P, Ferrigno S, Ebel B, Schivi M, Elfassy A, Mangavel C, Borges F. Deciphering Rind Color Heterogeneity of Smear-Ripened Munster Cheese and Its Association with Microbiota. Foods 2024; 13:2233. [PMID: 39063317 PMCID: PMC11276107 DOI: 10.3390/foods13142233] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/18/2024] [Revised: 07/10/2024] [Accepted: 07/11/2024] [Indexed: 07/28/2024] Open
Abstract
Color is one of the first criteria to assess the quality of cheese. However, very limited data are available on the color heterogeneity of the rind and its relationship with microbial community structure. In this study, the color of a wide range of smear-ripened Munster cheeses from various origins was monitored during storage by photographic imaging and data analysis in the CIELAB color space using luminance, chroma, and hue angle as descriptors. Different levels of inter- and intra-cheese heterogeneity were observed. The most heterogeneous Munster cheeses were the darkest with orange-red colors. The most homogeneous were the brightest with yellow-orange. K-means clustering revealed three clusters distinguished by their color heterogeneity. Color analysis coupled with metabarcoding showed that rinds with heterogeneous color exhibited higher microbial diversity associated with important changes in their microbial community structure during storage. In addition, intra-cheese community structure fluctuations were associated with heterogeneity in rind color. The species Glutamicibacter arilaitensis and Psychrobacter nivimaris/piscatorii were found to be positively associated with the presence of undesirable brown patches. This study highlights the close relationship between the heterogeneity of the cheese rind and its microbiota.
Collapse
Affiliation(s)
- Amandine J. Martin
- Laboratoire d’Ingénierie des Biomolécules (LIBio), Université de Lorraine, F-54000 Nancy, France; (A.J.M.); (A.-M.R.-J.); (J.P.); (C.G.); (M.L.S.); (N.N.); (M.K.); (M.S.); (A.E.); (C.M.)
| | - Anne-Marie Revol-Junelles
- Laboratoire d’Ingénierie des Biomolécules (LIBio), Université de Lorraine, F-54000 Nancy, France; (A.J.M.); (A.-M.R.-J.); (J.P.); (C.G.); (M.L.S.); (N.N.); (M.K.); (M.S.); (A.E.); (C.M.)
| | - Jérémy Petit
- Laboratoire d’Ingénierie des Biomolécules (LIBio), Université de Lorraine, F-54000 Nancy, France; (A.J.M.); (A.-M.R.-J.); (J.P.); (C.G.); (M.L.S.); (N.N.); (M.K.); (M.S.); (A.E.); (C.M.)
| | - Claire Gaiani
- Laboratoire d’Ingénierie des Biomolécules (LIBio), Université de Lorraine, F-54000 Nancy, France; (A.J.M.); (A.-M.R.-J.); (J.P.); (C.G.); (M.L.S.); (N.N.); (M.K.); (M.S.); (A.E.); (C.M.)
| | - Marcia Leyva Salas
- Laboratoire d’Ingénierie des Biomolécules (LIBio), Université de Lorraine, F-54000 Nancy, France; (A.J.M.); (A.-M.R.-J.); (J.P.); (C.G.); (M.L.S.); (N.N.); (M.K.); (M.S.); (A.E.); (C.M.)
| | - Nathan Nourdin
- Laboratoire d’Ingénierie des Biomolécules (LIBio), Université de Lorraine, F-54000 Nancy, France; (A.J.M.); (A.-M.R.-J.); (J.P.); (C.G.); (M.L.S.); (N.N.); (M.K.); (M.S.); (A.E.); (C.M.)
| | - Mohammed Khatbane
- Laboratoire d’Ingénierie des Biomolécules (LIBio), Université de Lorraine, F-54000 Nancy, France; (A.J.M.); (A.-M.R.-J.); (J.P.); (C.G.); (M.L.S.); (N.N.); (M.K.); (M.S.); (A.E.); (C.M.)
| | | | - Sandie Ferrigno
- INRIA Nancy—Grand Est, Institut Elie Cartan de Lorraine (IECL), Equipe BIology, Genetics and Statistics (BIGS), Université de Lorraine, F-54000 Nancy, France;
| | - Bruno Ebel
- Laboratoire Réactions et Génie des Procédés, Université de Lorraine, CNRS UMR 7274, F-54518 Vandoeuvre les Nancy, France;
| | - Myriam Schivi
- Laboratoire d’Ingénierie des Biomolécules (LIBio), Université de Lorraine, F-54000 Nancy, France; (A.J.M.); (A.-M.R.-J.); (J.P.); (C.G.); (M.L.S.); (N.N.); (M.K.); (M.S.); (A.E.); (C.M.)
| | - Annelore Elfassy
- Laboratoire d’Ingénierie des Biomolécules (LIBio), Université de Lorraine, F-54000 Nancy, France; (A.J.M.); (A.-M.R.-J.); (J.P.); (C.G.); (M.L.S.); (N.N.); (M.K.); (M.S.); (A.E.); (C.M.)
| | - Cécile Mangavel
- Laboratoire d’Ingénierie des Biomolécules (LIBio), Université de Lorraine, F-54000 Nancy, France; (A.J.M.); (A.-M.R.-J.); (J.P.); (C.G.); (M.L.S.); (N.N.); (M.K.); (M.S.); (A.E.); (C.M.)
| | - Frédéric Borges
- Laboratoire d’Ingénierie des Biomolécules (LIBio), Université de Lorraine, F-54000 Nancy, France; (A.J.M.); (A.-M.R.-J.); (J.P.); (C.G.); (M.L.S.); (N.N.); (M.K.); (M.S.); (A.E.); (C.M.)
| |
Collapse
|
4
|
Lecaudé C, Orieux N, Chuzeville S, Bertry A, Coissac E, Boyer F, Bonin A, Colomb-Boeckler N, Mathieu B, Recour M, Vindret J, Pignol C, Romand S, Petite C, Taberlet P, Charles C, Bel N, Hauwuy A. Deciphering microbial communities of three Savoyard raw milk cheeses along ripening and regarding the cheese process. Int J Food Microbiol 2024; 418:110712. [PMID: 38723541 DOI: 10.1016/j.ijfoodmicro.2024.110712] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/15/2023] [Revised: 03/26/2024] [Accepted: 04/17/2024] [Indexed: 05/27/2024]
Abstract
Different Savoyard cheeses are granted with PDO (Protected Designation or Origin) and PGI (Protected Geographical Indication) which guarantees consumers compliance with strict specifications. The use of raw milk is known to be crucial for specific flavor development. To unravel the factors influencing microbial ecosystems across cheese making steps, according to the seasonality (winter and summer) and the mode of production (farmhouse and dairy factory ones), gene targeting on bacteria and fungus was used to have a full picture of 3 cheese making technologies, from the raw milk to the end of the ripening. Our results revealed that Savoyard raw milks are a plenteous source of biodiversity together with the brines used during the process, that may support the development of specific features for each cheese. It was shown that rinds and curds have very contrasted ecosystem diversity, composition, and evolution. Ripening stage was selective for some bacterial species, whereas fungus were mainly ubiquitous in dairy samples. All ripening stages are impacted by the type of cheese technologies, with a higher impact on bacterial communities, except for fungal rind communities, for which the technology is the more discriminant. The specific microorganism's abundance for each technology allow to see a real bar-code, with more or less differences regarding bacterial or fungal communities. Bacterial structuration is shaped mainly by matrices, differently regarding technologies while the influence of technology is higher for fungi. Production types showed 10 differential bacterial species, farmhouses showed more ripening taxa, while dairy factory products showing more lactic acid bacteria. Meanwhile, seasonality looks to be a minor element for the comprehension of both microbial ecosystems, but the uniqueness of each dairy plant is a key explicative feature, more for bacteria than for fungus communities.
Collapse
Affiliation(s)
- Cresciense Lecaudé
- CERAQ, Centre de ressources pour l'agriculture de qualité et de montagne, 40 Rue du Terraillet, 73190 Saint-Baldoph, France.
| | - Nicolas Orieux
- ENILV, Ecole Nationale des industries du lait et de la viande, 212Rue Anatole France, 74800 La Roche-sur-Foron, France
| | - Sarah Chuzeville
- ACTALIA, Centre technique d'expertise agroalimentaire, Division d'expertise analytique sur le lait et les produits laitiers, 419 Rte des Champs Laitiers, 74800 Eteaux, France
| | - Alicia Bertry
- ACTALIA, Centre technique d'expertise agroalimentaire, Division d'expertise analytique sur le lait et les produits laitiers, 419 Rte des Champs Laitiers, 74800 Eteaux, France
| | - Eric Coissac
- Université Grenoble Alpes, Université Savoie Mont-Blanc, CNRS, LECA, Laboratoire d'Ecologie Alpine, 38000 Grenoble, France
| | - Frederic Boyer
- Université Grenoble Alpes, Université Savoie Mont-Blanc, CNRS, LECA, Laboratoire d'Ecologie Alpine, 38000 Grenoble, France
| | - Aurélie Bonin
- Université Grenoble Alpes, Université Savoie Mont-Blanc, CNRS, LECA, Laboratoire d'Ecologie Alpine, 38000 Grenoble, France
| | - Nelly Colomb-Boeckler
- ACTALIA, Centre technique d'expertise agroalimentaire, Division d'expertise analytique sur le lait et les produits laitiers, 419 Rte des Champs Laitiers, 74800 Eteaux, France
| | - Bruno Mathieu
- Syndicat Interprofessionnel du Reblochon, 28 Rue Louis Haase, 74230 Thônes, France
| | - Manon Recour
- Syndicat Interprofessionnel du Reblochon, 28 Rue Louis Haase, 74230 Thônes, France
| | - Joël Vindret
- sifa syndicat interprofessionnel du fromage abondance, 16 chemin d'Hirmentaz, 74200 Thonon-les-Bains, France
| | - Céline Pignol
- Savoicime, Syndicat Interprofessionnel de la Tomme de Savoie, 10 Allée Jules Vernes, 74150 Rumilly, France
| | - Stéphane Romand
- Syndicat Interprofessionnel du Reblochon, 28 Rue Louis Haase, 74230 Thônes, France
| | - Caroline Petite
- Syndicat Interprofessionnel de la Tome des Bauges, Rue Henri Bouvier, 73630 Le Chatelard, France
| | - Pierre Taberlet
- Université Grenoble Alpes, Université Savoie Mont-Blanc, CNRS, LECA, Laboratoire d'Ecologie Alpine, 38000 Grenoble, France
| | - Cécile Charles
- CERAQ, Centre de ressources pour l'agriculture de qualité et de montagne, 40 Rue du Terraillet, 73190 Saint-Baldoph, France
| | - Nadège Bel
- ACTALIA, Centre technique d'expertise agroalimentaire, Division d'expertise analytique sur le lait et les produits laitiers, 419 Rte des Champs Laitiers, 74800 Eteaux, France
| | - Agnès Hauwuy
- CERAQ, Centre de ressources pour l'agriculture de qualité et de montagne, 40 Rue du Terraillet, 73190 Saint-Baldoph, France
| |
Collapse
|
5
|
Ritschard JS, Schuppler M. The Microbial Diversity on the Surface of Smear-Ripened Cheeses and Its Impact on Cheese Quality and Safety. Foods 2024; 13:214. [PMID: 38254515 PMCID: PMC10814198 DOI: 10.3390/foods13020214] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/07/2023] [Revised: 01/03/2024] [Accepted: 01/05/2024] [Indexed: 01/24/2024] Open
Abstract
Smear-ripened cheeses are characterized by a viscous, red-orange surface smear on their rind. It is the complex surface microbiota on the cheese rind that is responsible for the characteristic appearance of this cheese type, but also for the wide range of flavors and textures of the many varieties of smear-ripened cheeses. The surface smear microbiota also represents an important line of defense against the colonization with undesirable microorganisms through various types of interaction, such as competitive exclusion or production of antimicrobial substances. Predominant members of the surface smear microbiota are salt-tolerant yeast and bacteria of the phyla Actinobacteria, Firmicutes, and Proteobacteria. In the past, classical culture-based approaches already shed light on the composition and succession of microorganisms and their individual contribution to the typicity of this cheese type. However, during the last decade, the introduction and application of novel molecular approaches with high-resolution power provided further in-depth analysis and, thus, a much more detailed view of the composition, structure, and diversity of the cheese smear microbiota. This led to abundant novel knowledge, such as the identification of so far unknown community members. Hence, this review is summarizing the current knowledge of the diversity of the surface smear microbiota and its contribution to the quality and safety of smear-ripened cheese. If the succession or composition of the surface-smear microbiota is disturbed, cheese smear defects might occur, which may promote food safety issues. Hence, the discussion of cheese smear defects in the context of an increased understanding of the intricate surface smear ecosystem in this review may not only help in troubleshooting and quality control but also paves the way for innovations that can lead to safer, more consistent, and higher-quality smear-ripened cheeses.
Collapse
Affiliation(s)
| | - Markus Schuppler
- Laboratory of Food Microbiology, Institute of Food, Nutrition and Health, ETH Zurich, Schmelzbergstrasse 7, 8092 Zurich, Switzerland;
| |
Collapse
|
6
|
Sioziou E, Kakouri A, Bosnea L, Samelis J. Antilisterial activity of raw sheep milk from two native Epirus breeds: Culture-dependent identification, bacteriocin gene detection and primary safety evaluation of the antagonistic LAB biota. CURRENT RESEARCH IN MICROBIAL SCIENCES 2023; 6:100209. [PMID: 38116185 PMCID: PMC10727937 DOI: 10.1016/j.crmicr.2023.100209] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/21/2023] Open
Abstract
Raw milk from native small ruminant breeds in Epirus, Greece, is a valuable natural source of autochthonous lactic acid bacteria (LAB) strains with superior biotechnological properties. In this study, two bulk milks (RM1, RM2) from two local sheep yards, intended for traditional Kefalotyri cheese production, were preselected for bacteriocin-like antilisterial activity by in vitro tests. Their antagonistic LAB biota was quantified followed by polyphasic (16S rRNA gene sequencing; IGS for Enterococcus; a multiplex-PCR for Leuconostoc) identification of 42 LAB (RM1/18; RM2/24) isolates further evaluated for bacteriocin encoding genes and primary safety traits. Representative isolates of the numerically dominant mesophilic LAB were Leuconostoc mesenteroides (10) in both RMs, Streptococcus parauberis (7) in RM2, and Lactococcus lactis (1) in RM1; the subdominant thermophilic LAB isolates were Enterococcus durans (8), E. faecium (6), E. faecalis (3), E. hirae (1), E. hermanniensis (1), Streptococcus lutetiensis (2), S. equinus (1) and S. gallolyticus (1). Based on their rpoB, araA, dsr and sorA profiles, six Ln. mesenteroides strains (8 isolates) were atypical lying between the subspecies mesenteroides and dextranicum, whereas two strains profiled with Ln. mesenteroides subsp. jonggajibkimchi that is first-time reported in Greek dairy food. Two RM1 E. faecium strain biotypes (3 isolates) showed strong, enterocin-mediated antilisterial activity due to entA/entB/entP possession. One E. durans from RM1 possessed entA and entP, while additional nine RM2 isolates of the E. faecium/durans group processed entA or entP singly. All showed direct (cell-associated) antilisterial activity only, as also both S. lutetiensis strains from RM2 did strongly. Desirably, no LAB isolate was β-hemolyrtic, or cytolysin-positive, or possessed vanA, vanB for vancomycin resistance, or agg, espA, hyl, and IS16 virulence genes. However, all three E. faecalis from RM2 possessed gelE and/or ace virulence genes. In conclusion, all Ln. mesenteroides strains, the two safe, enterocin A-B-P-producing E. faecium strains, and the two antilisterial S. lutetiensis strains should be validated further as potential costarter or adjunct cultures in Kefalotyri cheese. The prevalence of α-hemolytic pyogenic streptococci in raw milk, mainly S. parauberis in RM2, requires consideration in respect to subclinical mastitis in sheep and the farm hygiene overall.
Collapse
Affiliation(s)
- Eleni Sioziou
- Department of Dairy Research, Institute of Technology of Agricultural Products, Hellenic Agricultural Organization – DIMITRA, Ethnikis Antistaseos 3, Katsikas, Ioannina 45221, Greece
| | - Athanasia Kakouri
- Department of Dairy Research, Institute of Technology of Agricultural Products, Hellenic Agricultural Organization – DIMITRA, Ethnikis Antistaseos 3, Katsikas, Ioannina 45221, Greece
| | - Loulouda Bosnea
- Department of Dairy Research, Institute of Technology of Agricultural Products, Hellenic Agricultural Organization – DIMITRA, Ethnikis Antistaseos 3, Katsikas, Ioannina 45221, Greece
| | - John Samelis
- Department of Dairy Research, Institute of Technology of Agricultural Products, Hellenic Agricultural Organization – DIMITRA, Ethnikis Antistaseos 3, Katsikas, Ioannina 45221, Greece
| |
Collapse
|
7
|
Rampanti G, Raffo A, Melini V, Moneta E, Nardo N, Saggia Civitelli E, Bande-De León C, Tejada Portero L, Ferrocino I, Franciosa I, Cardinali F, Osimani A, Aquilanti L. Chemical, microbiological, textural, and sensory characteristics of pilot-scale Caciofiore cheese curdled with commercial Cynara cardunculus rennet and crude extracts from spontaneous and cultivated Onopordum tauricum. Food Res Int 2023; 173:113459. [PMID: 37803784 DOI: 10.1016/j.foodres.2023.113459] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/19/2023] [Revised: 08/30/2023] [Accepted: 09/10/2023] [Indexed: 10/08/2023]
Abstract
The aim of this study was the chemical, microbiological, textural, and sensory characterization of pilot-scale prototypes of an Italian ewe's raw milk cheese (Caciofiore) curdled with commercial Cynara cardunculus rennet, used as a control, and crude extracts obtained from flowers of either spontaneous or cultivated Onopordum tauricum. Hence, the control and experimental cheese prototypes produced in two rounds of cheesemaking trials were assayed, at the end of their 60-day maturation, for the following features: pH, titratable acidity, dry matter, fat, total and soluble nitrogen (TN and SN, respectively), ash, salt, protein, lactose, viable plate counts and composition of the bacterial and fungal populations, color, texture, volatile organic compounds (VOCs), and olfactory attributes by sensory analysis (the latter for the sole prototypes curdled with the commercial rennet and the extract obtained from cultivated O. tauricum). The data overall collected showed a very low impact of the type of thistle rennet on the analyzed cheese traits, with significant differences being exclusively found for SN/TN%, titratable acidity, color, and adhesiveness. By contrast, a higher impact of the cheesemaking round was seen, with significant differences being observed for salt content, load of presumptive lactobacilli, thermophilic cocci, and Escherichia coli, and levels of the following VOCs: 2,3-butanedione, 2-pentanone, 1-butanol, 2-heptanone, 3-methyl-1-butanol, 2-heptanol, 2-nonanone, dimethyl trisulfide, 2-methyl propanoic acid, butanoic acid, and 3-methyl butanoic acid. Sensory analysis revealed a strong ewe's cheese odor, accompanied by other olfactory notes, such as pungent, sour curd, sweet, and Parmesan cheese-like notes, in all the analysed cheese prototypes. Moreover, key odor active compounds, including butanoic acid, ethyl butanoate, 2,3-butanedione, 1-octen-3-one, and dimethyl trisulfide, were identified by GC-olfactometry analysis. Regarding the odor attributes as determined by sensory analysis, again the type of rennet had an almost negligible impact, with significant differences being only perceived for 1 or 2 out of 20 odor attributes, depending on the analytical conditions applied. Although some aspects deserve further investigation, the results herein collected confirm that O. tauricum can be regarded as an alternative source of thistle rennet for the manufacture of Caciofiore cheese, and more in general, Mediterranean ewe's milk cheeses.
Collapse
Affiliation(s)
- Giorgia Rampanti
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, 60131 Ancona, Italy
| | - Antonio Raffo
- CREA-Research Centre for Food and Nutrition, Via Ardeatina, 546, 00178 Rome, Italy.
| | - Valentina Melini
- CREA-Research Centre for Food and Nutrition, Via Ardeatina, 546, 00178 Rome, Italy
| | - Elisabetta Moneta
- CREA-Research Centre for Food and Nutrition, Via Ardeatina, 546, 00178 Rome, Italy
| | - Nicoletta Nardo
- CREA-Research Centre for Food and Nutrition, Via Ardeatina, 546, 00178 Rome, Italy
| | | | - Cindy Bande-De León
- Department of Human Nutrition and Food Technology, Universidad Católica de Murcia (UCAM), Campus de los Jerónimos, Guadalupe 30107, Spain
| | - Luis Tejada Portero
- Department of Human Nutrition and Food Technology, Universidad Católica de Murcia (UCAM), Campus de los Jerónimos, Guadalupe 30107, Spain
| | - Ilario Ferrocino
- Department of Agricultural, Forest, and Food Science, University of Turin (UNITO), Largo Paolo Braccini 2, 10095 Grugliasco, Italy
| | - Irene Franciosa
- Department of Agricultural, Forest, and Food Science, University of Turin (UNITO), Largo Paolo Braccini 2, 10095 Grugliasco, Italy
| | - Federica Cardinali
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, 60131 Ancona, Italy
| | - Andrea Osimani
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, 60131 Ancona, Italy
| | - Lucia Aquilanti
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, 60131 Ancona, Italy.
| |
Collapse
|
8
|
Bonilla-Luque OM, Possas A, Cabo ML, Rodríguez-López P, Valero A. Tracking microbial quality, safety and environmental contamination sources in artisanal goat cheesemaking factories. Food Microbiol 2023; 114:104301. [PMID: 37290877 DOI: 10.1016/j.fm.2023.104301] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/15/2022] [Revised: 04/26/2023] [Accepted: 04/27/2023] [Indexed: 06/10/2023]
Abstract
A harmonised microbiological survey was performed in two artisanal factories of raw goat milk cheeses (A and B) located in the Andalusian region (Spain). A total of 165 different control points or samples (raw materials, final products, food-contact surfaces [FCS], and air) were examined as microbial and pathogen sources of contamination of artisanal goat raw milk cheeses. For raw milk samples analysed from both producers, the concentrations of aerobic-mesophilic bacteria (AMB), total coliforms, coagulase-positive Staphylococcus spp. (CPS), lactic-acid bacteria (LAB) and moulds and yeasts ranged between 3.48 and 8.59, 2.45-5.48, 3.42-4.81, 4.99-8.59 and 3.35-6.85 log cfu/mL respectively. For the same microbial groups, the analysis of raw milk cheeses revealed concentrations ranging from 7.82 to 8.88, 2.00-6.82, 2.00-5.28, 8.11-9.57 and 2.00-5.76 log cfu/g, respectively. Although the raw material analysed from producer A presented higher microbial loads and between-batch variability, it was B the producer with the most loaded final products. Regarding the microbial air quality, the fermentation area, storage room, milk reception and packaging room were the most AMB loaded places, while the ripening chamber was the area with higher fungal loads in bioareosol from both producers. Conveyor belts, cutting machine, storage boxes and brine tank were highlighted as the most contaminated FCS evaluated. Staphylococcus aureus was the only pathogen detected within the set of 51 isolates from samples as revealed by MALDI-TOF and molecular PCR, with a prevalence of 12.5% for samples from the producer B. The public health risk attributed to the consumption of artisanal goat cheese should not be neglected, and may consider the whole cheesemaking processing chain, from microbiological quality of raw milk to the ready-to-eat final product, especially concerning the presence of S. aureus.
Collapse
Affiliation(s)
- Olga María Bonilla-Luque
- Department of Food Science and Technology, UIC Zoonosis y Enfermedades Emergentes (ENZOEM), CeiA3, Universidad de Córdoba, Campus Rabanales, 14014, Córdoba, Spain.
| | - Arícia Possas
- Department of Food Science and Technology, UIC Zoonosis y Enfermedades Emergentes (ENZOEM), CeiA3, Universidad de Córdoba, Campus Rabanales, 14014, Córdoba, Spain.
| | - Marta L Cabo
- Laboratory of Microbiology and Technology of Marine Products (MICROTEC), Instituto de Investigacións Mariñas, CSIC, Eduardo Cabello, 6, 36208, Vigo, Spain.
| | - Pedro Rodríguez-López
- Laboratory of Microbiology and Technology of Marine Products (MICROTEC), Instituto de Investigacións Mariñas, CSIC, Eduardo Cabello, 6, 36208, Vigo, Spain; Department of Animal and Food Science, Faculty of Veterinary Medicine, Universitat Autònoma de Barcelona, Travessera Dels Turons S/n, 08193, Bellaterra, Cerdanyola Del Vallès, Spain.
| | - Antonio Valero
- Department of Food Science and Technology, UIC Zoonosis y Enfermedades Emergentes (ENZOEM), CeiA3, Universidad de Córdoba, Campus Rabanales, 14014, Córdoba, Spain.
| |
Collapse
|
9
|
Korena K, Krzyzankova M, Florianova M, Karasova D, Babak V, Strakova N, Juricova H. Microbial Succession in the Cheese Ripening Process-Competition of the Starter Cultures and the Microbiota of the Cheese Plant Environment. Microorganisms 2023; 11:1735. [PMID: 37512907 PMCID: PMC10385115 DOI: 10.3390/microorganisms11071735] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/09/2023] [Revised: 06/26/2023] [Accepted: 06/29/2023] [Indexed: 07/30/2023] Open
Abstract
A large variety of cheeses can be produced using different manufacturing processes and various starter or adjunct cultures. In this study, we have described the succession of the microbial population during the commercial production and subsequent ripening of smear-ripened cheese using 16S rRNA gene sequencing. The composition of the microbiota during the first 6 days of production was constant and consisted mainly of LAB (lactic acid bacteria) originating from the starter culture. From day 7, the proportion of LAB decreased as other bacteria from the production environment appeared. From the 14th day of production, the relative proportion of LAB decreased further, and at the end of ripening, bacteria from the environment wholly dominated. These adventitious microbiota included Psychrobacter, Pseudoalteromonas haloplanktis/hodoensis, Vibrio toranzoniae, and Vibrio litoralis (Proteobacteria phylum), as well as Vagococcus and Marinilactibacillus (Firmicutes phylum), Psychrilyobacter (Fusobacteria phylum), and Malaciobacter marinus (Campylobacterota phylum), all of which appeared to be characteristic taxa associated with the cheese rind. Subsequent analysis showed that the production and ripening of smear-ripened cheese could be divided into three stages, and that the microbiota compositions of samples from the first week of production, the second week of production, and supermarket shelf life all differed.
Collapse
Affiliation(s)
- Kristyna Korena
- Veterinary Research Institute, Hudcova 296/70, 621 00 Brno, Czech Republic
| | | | - Martina Florianova
- Veterinary Research Institute, Hudcova 296/70, 621 00 Brno, Czech Republic
| | - Daniela Karasova
- Veterinary Research Institute, Hudcova 296/70, 621 00 Brno, Czech Republic
| | - Vladimir Babak
- Veterinary Research Institute, Hudcova 296/70, 621 00 Brno, Czech Republic
| | - Nicol Strakova
- Veterinary Research Institute, Hudcova 296/70, 621 00 Brno, Czech Republic
| | - Helena Juricova
- Veterinary Research Institute, Hudcova 296/70, 621 00 Brno, Czech Republic
| |
Collapse
|
10
|
Hansen AÅ, Langsrud S, Carlehög M, Haugen JE, Moen B. CO2 packaging increases shelf life through reduction of off-odor production by CO2 tolerant bacteria in addition to growth inhibition of the spoilage bacteriota. Food Control 2023. [DOI: 10.1016/j.foodcont.2022.109390] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/14/2022]
|
11
|
Microbial Dynamics of a Specialty Italian Raw Ewe's Milk Cheese Curdled with Extracts from Spontaneous and Cultivated Onopordum tauricum Willd. Microorganisms 2023; 11:microorganisms11010219. [PMID: 36677511 PMCID: PMC9863127 DOI: 10.3390/microorganisms11010219] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/15/2022] [Revised: 01/08/2023] [Accepted: 01/10/2023] [Indexed: 01/18/2023] Open
Abstract
Milk coagulants prepared by maceration of flowers harvested from both spontaneous and cultivated Onopordum tauricum Willd. and a commercially available coagulant obtained from Cynara cardunculus L. (control) were assayed for small-scale manufacturing of Caciofiore, an Italian specialty raw ewe's milk cheese produced in a family run dairy farm located in the Marche region (Central Italy). The microbiota of the three thistle-based milk coagulants and their effect on the microbial dynamics of raw milk cheeses during fermentation and maturation (from day 0 up until day 60) were investigated through a combined approach based on viable counting and Illumina DNA sequencing. In both the control and experimental cheeses, despite the slight differences emerged depending on the coagulant used, Lactococcus lactis and Debaryomyces hansenii were the prevalent species among bacteria and fungi, respectively. Moreover, raw ewe's milk was the main factor affecting the evolution of both the bacterial and fungal microbiota in all cheeses. The overall similarities between control and experimental cheeses herein analyzed supports the exploitation of Onopordum tauricum Willd. as an alternative milk coagulating agent for production of Caciofiore and, more in general, raw ewe's milk cheeses.
Collapse
|
12
|
Unno R, Suzuki T, Osaki Y, Matsutani M, Ishikawa M. Causality Verification for the Correlation between the Presence of Nonstarter Bacteria and Flavor Characteristics in Soft-Type Ripened Cheeses. Microbiol Spectr 2022; 10:e0289422. [PMID: 36354338 PMCID: PMC9769828 DOI: 10.1128/spectrum.02894-22] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/04/2022] [Accepted: 10/16/2022] [Indexed: 11/12/2022] Open
Abstract
Flavor characteristics of ripened cheese are established by various bacteria, such as lactic acid bacteria, Actinobacteria, and Proteobacteria, which spontaneously develop during the cheese-manufacturing process. We previously revealed the relationship between bacterial microbiota and flavor components in soft-type ripened cheeses by using a multiomics approach that combined metagenomics and metabolomics; however, we could not establish a causal relationship. This study aimed to substantiate the causal nature of the correlations revealed by the multiomics approach by using cheese-ripening tests with single isolate inoculation. The bacterial diversity and composition in surface mold-ripened cheeses from Japan and France varied, depending on the differences between the milks (pasteurized or raw), cheese positions (core or rind), and manufacturers. Although the volatile compounds did not clearly reflect the distinctive characteristics of the cheese samples, nonstarter lactic acid bacteria, Actinobacteria, and Proteobacteria positively correlated with ketones and sulfur compounds, as evidenced by a Spearman's correlation analysis. Cheese-ripening tests conducted after inoculation with single bacterial strains belonging to the above-mentioned taxa confirmed that these bacteria formed volatile compounds, in agreement with the correlations observed. In particular, various flavor compounds, such as acids, esters, ketones, and sulfur compounds, were detected in cheese inoculated with Pseudoalteromonas sp. TS-4-4 strain. These findings provide important insights into the role of nonstarter bacteria in the development of cheese flavor and into the effectiveness of the multiomics approach in screening for bacteria that can improve the quality of cheese products. IMPORTANCE Our previous study revealed that the existence of various bacteria, such as lactic acid bacteria, Actinobacteria, and Proteobacteria, clearly correlated with the abundance of flavor components, such as volatile compounds, in soft-type ripened cheeses via a multiomics approach that used 16S rRNA gene amplicon sequencing and headspace gas chromatography-mass spectrometry. However, this approach only showed correlations derived from statistical analyses rather than causal relationships. Therefore, in the present study, we performed cheese-ripening tests using nonstarter bacteria to substantiate the correlations revealed by the multiomics approach in soft-type ripened cheese. Our results suggest the capability of nonstarter bacteria, such as Proteobacteria, to impart flavor to cheese and the effectiveness of the multiomics approach in screening for microbial isolates that can improve the quality of cheese. Overall, our research provides new insights into the importance of bacteria in cheese production.
Collapse
Affiliation(s)
- Ryosuke Unno
- Department of Fermentation Science, Faculty of Applied Bioscience, Tokyo University of Agriculture, Tokyo, Japan
| | - Toshihiro Suzuki
- Department of Fermentation Science, Faculty of Applied Bioscience, Tokyo University of Agriculture, Tokyo, Japan
| | - Yumika Osaki
- Department of Fermentation Science, Faculty of Applied Bioscience, Tokyo University of Agriculture, Tokyo, Japan
| | | | - Morio Ishikawa
- Department of Fermentation Science, Faculty of Applied Bioscience, Tokyo University of Agriculture, Tokyo, Japan
| |
Collapse
|
13
|
Orhan-Yanıkan E, Gülseren G, Ayhan K. Antimicrobial characteristics of Thymus vulgaris and Rosa damascena oils against some milk-borne bacteria. Microchem J 2022. [DOI: 10.1016/j.microc.2022.108069] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/06/2022]
|
14
|
Ramos-Vivas J, Tapia O, Elexpuru-Zabaleta M, Pifarre KT, Armas Diaz Y, Battino M, Giampieri F. The Molecular Weaponry Produced by the Bacterium Hafnia alvei in Foods. Molecules 2022; 27:molecules27175585. [PMID: 36080356 PMCID: PMC9457839 DOI: 10.3390/molecules27175585] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/04/2022] [Revised: 08/24/2022] [Accepted: 08/26/2022] [Indexed: 11/16/2022] Open
Abstract
Hafnia alvei is receiving increasing attention from both a medical and veterinary point of view, but the diversity of molecules it produces has made the interest in this bacterium extend to the field of probiotics, the microbiota, and above all, to its presence and action on consumer foods. The production of Acyl Homoserine Lactones (AHLs), a type of quorum-sensing (QS) signaling molecule, is the most often-studied chemical signaling molecule in Gram-negative bacteria. H. alvei can use this communication mechanism to promote the expression of certain enzymatic activities in fermented foods, where this bacterium is frequently present. H. alvei also produces a series of molecules involved in the modification of the organoleptic properties of different products, especially cheeses, where it shares space with other microorganisms. Although some strains of this species are implicated in infections in humans, many produce antibacterial compounds, such as bacteriocins, that inhibit the growth of true pathogens, so the characterization of these molecules could be very interesting from the point of view of clinical medicine and the food industry. Lastly, in some cases, H. alvei is responsible for the production of biogenic amines or other compounds of special interest in food health. In this article, we will review the most interesting molecules that produce the H. alvei strains and will discuss some of their properties, both from the point of view of their biological activity on other microorganisms and the properties of different food matrices in which this bacterium usually thrives.
Collapse
Affiliation(s)
- José Ramos-Vivas
- Research Group on Foods, Nutritional Biochemistry and Health, Universidad Europea del Atlántico, 39011 Santander, Spain
- Research Group on Foods, Nutritional Biochemistry and Health, Universidad Internacional Iberoamericana, Campeche 24560, Mexico
- CIBER of Infectious Diseases—CIBERINFEC, Instituto de Salud Carlos III, 28029 Madrid, Spain
- Correspondence: (J.R.-V.); (M.B.)
| | - Olga Tapia
- Research Group on Foods, Nutritional Biochemistry and Health, Universidad Europea del Atlántico, 39011 Santander, Spain
| | - María Elexpuru-Zabaleta
- Research Group on Foods, Nutritional Biochemistry and Health, Universidad Europea del Atlántico, 39011 Santander, Spain
| | - Kilian Tutusaus Pifarre
- Research Group on Foods, Nutritional Biochemistry and Health, Universidad Europea del Atlántico, 39011 Santander, Spain
- Research Group on Foods, Nutritional Biochemistry and Health, Universidad Internacional Iberoamericana, Campeche 24560, Mexico
| | - Yasmany Armas Diaz
- Department of Clinical Sciences, Polytechnic University of Marche, 60131 Ancona, Italy
| | - Maurizio Battino
- Research Group on Foods, Nutritional Biochemistry and Health, Universidad Europea del Atlántico, 39011 Santander, Spain
- Department of Clinical Sciences, Polytechnic University of Marche, 60131 Ancona, Italy
- International Joint Research Laboratory of Intelligent Agriculture and Agri-Products Processing, Jiangsu University, Zhenjiang 212013, China
- Correspondence: (J.R.-V.); (M.B.)
| | - Francesca Giampieri
- Research Group on Foods, Nutritional Biochemistry and Health, Universidad Europea del Atlántico, 39011 Santander, Spain
- Department of Biochemistry, Faculty of Sciences, King Abdulaziz University, Jeddah 80200, Saudi Arabia
| |
Collapse
|
15
|
The Mutual Influence of Predominant Microbes in Sourdough Fermentation: Focusing on Flavor Formation and Gene Transcription. Foods 2022; 11:foods11152373. [PMID: 35954139 PMCID: PMC9367918 DOI: 10.3390/foods11152373] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/07/2022] [Revised: 08/03/2022] [Accepted: 08/04/2022] [Indexed: 11/17/2022] Open
Abstract
The interplay between microorganisms generally plays a vital role in food fermentation. In this study, the mutual influence of Saccharomyces cerevisiae and Fructilactobacillus sanfranciscensis, the two predominant microbes in the sourdough ecosystem, were investigated in situ during fermentation. Doughs fermented with S. cerevisiae, F. sanfranciscensis, or their combination were compared regarding acid production, microbial density, and volatiles. Furthermore, in situ gene expressions were investigated using RNA-sequencing. The results showed that the presence of S. cerevisiae had no visible influence on F. sanfranciscensis, whereas F. sanfranciscensis facilitated the growth of S. cerevisiae but affected its volatile production since metabolites such as 3-methyl-1-butanol decreased. The RNA-sequencing demonstrated that S. cerevisiae significantly changed the gene transcripts implicated in amino acid metabolism in F. sanfranciscensis and may stimulate its growth suggested by the enrichment of the KEGG pathway of peptidoglycan biosynthesis.
Collapse
|
16
|
Jiang L, Chen Y, Deng L, Liu F, Wang T, Shi X, Wang B. Bacterial community diversity and its potential contributions to the flavor components of traditional smoked horsemeat sausage in Xinjiang, China. Front Microbiol 2022; 13:942932. [PMID: 35966695 PMCID: PMC9365192 DOI: 10.3389/fmicb.2022.942932] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/13/2022] [Accepted: 07/05/2022] [Indexed: 11/13/2022] Open
Abstract
Smoked horsemeat sausage is a famous fermented traditional food in Xinjiang, China. However, the microbial diversity and its potential contributions to the flavor components of smoked horsemeat sausage are unclear. In this study, the microbial community and flavor components of smoked horsemeat sausage from six regions of Xinjiang were measured by using amplicon sequencing and headspace solid-phase microextraction combined with gas chromatography–mass spectrometry (HS-SPME-GC–MS) technology, respectively. Relations among microbial communities, flavor components and environmental factors were subsequently predicted based on redundancy analysis (RDA) and Monte Carlo permutation tests. Although smoked horsemeat sausage samples from different regions possessed distinct microbial communities, lactic acid bacteria (LAB) were identified as the dominant consortium in smoked horsemeat sausage. Lactobacillus, Vagococcus, Lactococcus, and Carnobacterium were detected at high abundance in different sausages. The moisture content, nitrite content, and pH of the sausage might be important factors influencing the dominant bacterial community, according to the RDA. Among the dominant consortia, the eight core bacterial genera showed considerable correlations with the formation of sixteen volatile compounds in smoked horsemeat sausage based on multivariate statistical analysis. For example, the levels of Leuconostoc and Lactobacillus were positively correlated with those of 1-hexadecanol, hexyl acetate, 2-methyl-phenol, 1-pentanol, d-limonene, and 2-heptanone, and the levels of Leuconostoc, Lactobacillus, and Weissella were negatively correlated with those of 1-octanol, acetic acid, octanal, heptanal, and 1-hexanol. This study will provide a theoretical basis for understanding the microbial metabolic modes of Xinjiang smoked horsemeat sausages.
Collapse
Affiliation(s)
- Lei Jiang
- College of Life and Geographical Sciences, Kashi University, Kashi, China
| | - Yu Chen
- Food College, Shihezi University, Shihezi, China
- College of Enology, Northwest A&F University, Yangling, China
| | - Li Deng
- Food College, Shihezi University, Shihezi, China
| | - Fei Liu
- College of Life and Geographical Sciences, Kashi University, Kashi, China
| | - Tengbin Wang
- Xinjiang Academy of Analysis and Testing, Wulumuqi, China
| | - Xuewei Shi
- Food College, Shihezi University, Shihezi, China
- Xuewei Shi,
| | - Bin Wang
- Food College, Shihezi University, Shihezi, China
- *Correspondence: Bin Wang,
| |
Collapse
|
17
|
Characterization of Microbial Shifts during the Production and Ripening of Raw Ewe Milk-Derived Idiazabal Cheese by High-Throughput Sequencing. BIOLOGY 2022; 11:biology11050769. [PMID: 35625497 PMCID: PMC9138791 DOI: 10.3390/biology11050769] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 04/13/2022] [Revised: 05/05/2022] [Accepted: 05/11/2022] [Indexed: 11/17/2022]
Abstract
Simple Summary Idiazabal is a traditional cheese produced from raw ewe milk in the Basque Country (Southwestern Europe). The sensory properties of raw milk cheeses have been attributed, among other factors, to microbial shifts that occur during the production and ripening processes. In this study, we used high-throughput sequencing technologies to investigate the microbiota of Latxa ewe raw milk and the dynamics during cheese production and ripening processes. The microbiota of raw milk was composed of lactic acid bacteria (LAB), environmental bacteria and non-desirable bacteria. Throughout the cheese making and ripening processes, the growth of LAB was promoted, whereas that of non-desirable and environmental bacteria was inhibited. Moreover, some genera not reported previously in raw ewe milk were detected and clear differences were observed in the bacterial composition of raw milk and cheese among producers, in relation to LAB and environmental or non-desirable bacteria, some of which could be attributed to the production of flavour related compounds. Abstract In this study, we used high-throughput sequencing technologies (sequencing of V3–V4 hypervariable regions of 16S rRNA gene) to investigate for the first time the microbiota of Latxa ewe raw milk and the bacterial shifts that occur during the production and ripening of Idiazabal cheese. Results revealed several bacterial genera not reported previously in raw ewe milk and cheese, such as Buttiauxella and Obesumbacterium. Both the cheese making and ripening processes had a significant impact on bacterial communities. Overall, the growth of lactic acid bacteria (LAB) (Lactococcus, Lactobacillus, Leuconostoc, Enterococcus, Streptococcus and Carnobacterium) was promoted, whereas that of non-desirable and environmental bacteria was inhibited (such as Pseudomonas and Clostridium). However, considerable differences were observed among producers. It is noteworthy that the starter LAB (Lactococcus) predominated up to 30 or 60 days of ripening and then, the growth of non-starter LAB (Lactobacillus, Leuconostoc, Enterococcus and Streptococcus) was promoted. Moreover, in some cases, bacteria related to the production of volatile compounds (such as Hafnia, Brevibacterium and Psychrobacter) also showed notable abundance during the first few weeks of ripening. Overall, the results of this study enhance our understanding of microbial shifts that occur during the production and ripening of a raw ewe milk-derived cheese (Idiazabal), and could indicate that the practices adopted by producers have a great impact on the microbiota and final quality of this cheese.
Collapse
|
18
|
Merchán AV, Ruiz-Moyano S, Hernández MV, Martín A, Lorenzo MJ, Benito MJ. Characterization of autochthonal Hafnia spp. strains isolated from Spanish soft raw ewe's milk PDO cheeses to be used as adjunct culture. Int J Food Microbiol 2022; 373:109703. [DOI: 10.1016/j.ijfoodmicro.2022.109703] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/18/2021] [Revised: 04/19/2022] [Accepted: 05/01/2022] [Indexed: 11/17/2022]
|
19
|
Ritschard JS, Van Loon H, Amato L, Meile L, Schuppler M. High Prevalence of Enterobacterales in the Smear of Surface-Ripened Cheese with Contribution to Organoleptic Properties. Foods 2022; 11:foods11030361. [PMID: 35159512 PMCID: PMC8834058 DOI: 10.3390/foods11030361] [Citation(s) in RCA: 4] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/30/2021] [Revised: 01/21/2022] [Accepted: 01/22/2022] [Indexed: 11/16/2022] Open
Abstract
The smear of surface-ripened cheese harbors complex microbiota mainly composed of typical Gram-positive aerobic bacteria and yeast. Gram-negative bacteria are usually classified as un-wanted contaminants. In order to investigate the abundance and impact of Gram-negative bacte-ria naturally occurring in the smear of surface-ripened cheese, we performed a culture-based analysis of smear samples from 15 semi-hard surface-ripened cheese varieties. The quantity, di-versity and species distribution of Proteobacteria in the surface smear of the analyzed cheese vari-eties were unexpectedly high, and comprised a total of 22 different species. Proteus and Morganella predominated most of the analyzed cheese varieties, while Enterobacter, Citrobacter, Hafnia and Serratia were also found frequently. Further physiological characterization of Proteus isolates re-vealed strong proteolytic activity, and the analysis of volatiles in the smear cheese surface head-space suggested that Enterobacterales produce volatile organic flavor compounds that contribute to the organoleptic properties of surface-ripened cheese. Autochthonous members of Enterobac-terales were found in 12 of the 15 smear samples from surface-ripened cheeses, suggesting that they are part of the typical house microbiota that shape the organoleptic properties of the cheese rather than represent unwanted contaminants. However, further investigation on safety issues of the individual species should be performed in order to manage the health risk for consumers.
Collapse
Affiliation(s)
- Jasmine S. Ritschard
- Laboratory of Food Microbiology, Institute of Food, Nutrition and Health, ETH Zurich, Schmelzbergstrasse 7, 8092 Zurich, Switzerland; (J.S.R.); (H.V.L.)
| | - Hanne Van Loon
- Laboratory of Food Microbiology, Institute of Food, Nutrition and Health, ETH Zurich, Schmelzbergstrasse 7, 8092 Zurich, Switzerland; (J.S.R.); (H.V.L.)
| | - Lea Amato
- Laboratory of Food Biotechnology, Institute of Food, Nutrition and Health, ETH Zurich, Schmelzbergstrasse 7, 8092 Zurich, Switzerland; (L.A.); (L.M.)
| | - Leo Meile
- Laboratory of Food Biotechnology, Institute of Food, Nutrition and Health, ETH Zurich, Schmelzbergstrasse 7, 8092 Zurich, Switzerland; (L.A.); (L.M.)
| | - Markus Schuppler
- Laboratory of Food Microbiology, Institute of Food, Nutrition and Health, ETH Zurich, Schmelzbergstrasse 7, 8092 Zurich, Switzerland; (J.S.R.); (H.V.L.)
- Correspondence:
| |
Collapse
|
20
|
Sameli N, Samelis J. Growth and Biocontrol of Listeria monocytogenes in Greek Anthotyros Whey Cheese without or with a Crude Enterocin A-B-P Extract: Interactive Effects of the Native Spoilage Microbiota during Vacuum-Packed Storage at 4 °C. Foods 2022; 11:foods11030334. [PMID: 35159485 PMCID: PMC8834202 DOI: 10.3390/foods11030334] [Citation(s) in RCA: 4] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/15/2021] [Revised: 01/20/2022] [Accepted: 01/21/2022] [Indexed: 02/01/2023] Open
Abstract
Effective biopreservation measures are needed to control the growth of postprocess Listeria monocytogenes contamination in fresh whey cheeses stored under refrigeration. This study assessed growth and biocontrol of inoculated (3 log10 CFU/g) L. monocytogenes in vacuum-packed, fresh (1-day-old) or ‘aged’ (15-day-old) Anthotyros whey cheeses, without or with 5% of a crude enterocin A-B-P extract (CEntE), during storage at 4 °C. Regardless of CEntE addition, the pathogen increased by an average of 2.0 log10 CFU/g in fresh cheeses on day 15. Gram-negative spoilage bacteria also increased by an average of 2.5 log10 CFU/g. However, from day 15 to the sell-by date (days 35–40), L. monocytogenes growth ceased, and progressively, the populations of the pathogen declined in most cheeses. This was due to an unmonitored, batch-dependent natural acidification by spoilage lactic acid bacteria, predominantly Leuconostoc mesenteroides, which reduced the cheese pH to 5.5, and finally to ≤5.0. The pH reductions and associated declines in pathogen viability were greater in the CEntE-treated samples within each batch. L. monocytogenes failed to grow in cheeses previously ‘aged’ in retail for 15 days. Overall, high population levels (>7.5 log10 CFU/g) of psychrotrophic Enterobacteriaceae, particularly Hafnia alvei, were associated with an extended growth and increased survival of L. monocytogenes during storage.
Collapse
|
21
|
Anastasiou R, Kazou M, Georgalaki M, Aktypis A, Zoumpopoulou G, Tsakalidou E. Omics Approaches to Assess Flavor Development in Cheese. Foods 2022; 11:188. [PMID: 35053920 PMCID: PMC8775153 DOI: 10.3390/foods11020188] [Citation(s) in RCA: 10] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/15/2021] [Revised: 01/03/2022] [Accepted: 01/09/2022] [Indexed: 12/27/2022] Open
Abstract
Cheese is characterized by a rich and complex microbiota that plays a vital role during both production and ripening, contributing significantly to the safety, quality, and sensory characteristics of the final product. In this context, it is vital to explore the microbiota composition and understand its dynamics and evolution during cheese manufacturing and ripening. Application of high-throughput DNA sequencing technologies have facilitated the more accurate identification of the cheese microbiome, detailed study of its potential functionality, and its contribution to the development of specific organoleptic properties. These technologies include amplicon sequencing, whole-metagenome shotgun sequencing, metatranscriptomics, and, most recently, metabolomics. In recent years, however, the application of multiple meta-omics approaches along with data integration analysis, which was enabled by advanced computational and bioinformatics tools, paved the way to better comprehension of the cheese ripening process, revealing significant associations between the cheese microbiota and metabolites, as well as their impact on cheese flavor and quality.
Collapse
Affiliation(s)
- Rania Anastasiou
- Laboratory of Dairy Research, Department of Food Science and Human Nutrition, Agricultural University of Athens, Iera Odos 75, 118 55 Athens, Greece; (M.K.); (M.G.); (A.A.); (G.Z.); (E.T.)
| | | | | | | | | | | |
Collapse
|
22
|
Abreu ACDS, Carazzolle MF, Crippa BL, Barboza GR, Mores Rall VL, de Oliveira Rocha L, Silva NCC. Bacterial diversity in organic and conventional Minas Frescal cheese production using targeted 16S rRNA sequencing. Int Dairy J 2021. [DOI: 10.1016/j.idairyj.2021.105139] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/21/2022]
|
23
|
Ma X, Bi J, Li X, Zhang G, Hao H, Hou H. Contribution of Microorganisms to Biogenic Amine Accumulation during Fish Sauce Fermentation and Screening of Novel Starters. Foods 2021; 10:foods10112572. [PMID: 34828853 PMCID: PMC8621993 DOI: 10.3390/foods10112572] [Citation(s) in RCA: 7] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/16/2021] [Revised: 10/13/2021] [Accepted: 10/19/2021] [Indexed: 11/16/2022] Open
Abstract
In this study, high-throughput sequencing and culture-dependent and HPLC methods were used to investigate the contribution and regulation of biogenic amines (BAs) by dominant microorganisms during fish sauce fermentation. The results showed that the microbial composition constantly changed with the fermentation of fish sauce. Tetragenococcus (40.65%), Lentibacillus (9.23%), Vagococcus (2.20%), Psychrobacter (1.80%), Pseudomonas (0.98%), Halomonas (0.94%) and Staphylococcus (0.16%) were the dominant microflora in fish sauce. The content of BAs gradually increased as the fermentation progressed. After 12 months of fermentation, the histamine content (55.59 mg/kg) exceeded the toxic dose recommended by the Food and Drug Administration (FDA). Correlation analysis showed that dominant microorganisms have a great contribution to the accumulation of BAs. By analyzing the BA production capacity of dominant isolates, the accumulation of BAs in fish sauce might be promoted by Tetragenococcus and Halomonas. Moreover, four strains with high BA reduction ability were screened out of 44 low BA-producing dominant strains, and their influence on BA accumulation in fermented foods was determined. Results demonstrated that Staphylococcus nepalensis 5-5 and Staphylococcus xylosus JCM 2418 might be the potential starters for BA control. The present study provided a new idea for the control of BAs in fermented foods.
Collapse
Affiliation(s)
- Xinxiu Ma
- School of Food Science and Technology, Dalian Polytechnic University, No. 1, Qinggongyuan, Ganjingzi District, Dalian 116034, China; (X.M.); (J.B.); (X.L.); (G.Z.); (H.H.)
- Liaoning Key Lab for Aquatic Processing Quality and Safety, No. 1, Qinggongyuan, Ganjingzi District, Dalian 116034, China
| | - Jingran Bi
- School of Food Science and Technology, Dalian Polytechnic University, No. 1, Qinggongyuan, Ganjingzi District, Dalian 116034, China; (X.M.); (J.B.); (X.L.); (G.Z.); (H.H.)
- Liaoning Key Lab for Aquatic Processing Quality and Safety, No. 1, Qinggongyuan, Ganjingzi District, Dalian 116034, China
| | - Xinyu Li
- School of Food Science and Technology, Dalian Polytechnic University, No. 1, Qinggongyuan, Ganjingzi District, Dalian 116034, China; (X.M.); (J.B.); (X.L.); (G.Z.); (H.H.)
- Liaoning Key Lab for Aquatic Processing Quality and Safety, No. 1, Qinggongyuan, Ganjingzi District, Dalian 116034, China
| | - Gongliang Zhang
- School of Food Science and Technology, Dalian Polytechnic University, No. 1, Qinggongyuan, Ganjingzi District, Dalian 116034, China; (X.M.); (J.B.); (X.L.); (G.Z.); (H.H.)
- Liaoning Key Lab for Aquatic Processing Quality and Safety, No. 1, Qinggongyuan, Ganjingzi District, Dalian 116034, China
| | - Hongshun Hao
- School of Food Science and Technology, Dalian Polytechnic University, No. 1, Qinggongyuan, Ganjingzi District, Dalian 116034, China; (X.M.); (J.B.); (X.L.); (G.Z.); (H.H.)
- Liaoning Key Lab for Aquatic Processing Quality and Safety, No. 1, Qinggongyuan, Ganjingzi District, Dalian 116034, China
| | - Hongman Hou
- School of Food Science and Technology, Dalian Polytechnic University, No. 1, Qinggongyuan, Ganjingzi District, Dalian 116034, China; (X.M.); (J.B.); (X.L.); (G.Z.); (H.H.)
- Liaoning Key Lab for Aquatic Processing Quality and Safety, No. 1, Qinggongyuan, Ganjingzi District, Dalian 116034, China
- Correspondence: ; Tel.: +86-411-8632-2020
| |
Collapse
|
24
|
Cardinali F, Ferrocino I, Milanović V, Belleggia L, Corvaglia MR, Garofalo C, Foligni R, Mannozzi C, Mozzon M, Cocolin L, Osimani A, Aquilanti L. Microbial communities and volatile profile of Queijo de Azeitão PDO cheese, a traditional Mediterranean thistle-curdled cheese from Portugal. Food Res Int 2021; 147:110537. [PMID: 34399514 DOI: 10.1016/j.foodres.2021.110537] [Citation(s) in RCA: 27] [Impact Index Per Article: 9.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/15/2021] [Revised: 06/09/2021] [Accepted: 06/14/2021] [Indexed: 12/16/2022]
Abstract
The production of ovine or caprine milk cheeses with thistle rennet is a common practice in the Mediterranean basin. The aim of the present study was to obtain information on bacteria and yeast communities harboured by Queijo de Azeitão PDO cheese through viable counting and, for the first time, via metataxonomic analysis. Moreover, solid phase microextraction (SPME) technique was applied to characterize Queijo de Azeitão PDO cheese volatile compounds. Nine cheese samples were collected from three different artisan producers located in Portugal. The results of physico-chemical analyses showed significant differences between producers, with mean values ranging from 5.40 ± 0.25 (Producer 1) to 6.00 ± 0.22 (Producer 2). As for TTA, Producer 1 showed the highest mean value attesting at 18.04 ± 6.57 mL of 0.1 M NaOH used to reach pH 8.3. Regarding lactic acid concentration, Producer 1 showed the highest mean value attesting at 0.488 ± 0.106 g 100 g-1, whereas, for acetic acid, no significant differences were evidenced among producers with values comprised between 0.141 ± 0.021 g 100 g-1 and 0.245 ± 0.016 g 100 g-1. No significant differences were observed between overall mean values of the three producers for viable counts of presumptive lactococci, thermophilic cocci, presumptive lactobacilli, thermophilic lactobacilli and total mesophilic aerobes with values in the order of 7-8 log cfu g-1. Moreover, no significant differences were evidenced for viable counts of coagulase-negative cocci, enterococci, Enterobacteriaceae and Pseudomonadaceae. As for eumycetes, cheeses from Producer 1 showed the lowest mean value (2.78 ± 2.42 log cfu g-1) in respect with values detected in cheeses from Producer 2 and 3. Concerning microbiota and mycobiota of the analyzed cheeses, the alpha diversity index did not show any significant difference between the three producers in terms of composition and complexity of the microbial population. A simple composition was apparently shared by the three producers, whose cheese manufactures were dominated by the presence of Leuconostoc mesenteroides (37% of the relative frequency in average), Lactococcus lactis (29%), Lacticaseibacillus zeae (4.7%), Lentilactobacillus kefiri (4.4%), Serratia spp. (3.5%), Lactiplantibacillus plantarum (2.7%), and Latilactobacillus sakei (2.5%). The mycobiota composition showed the neat dominance of Yarrowia lipolytica (46.7% of the relative frequency in average), followed by Candida ethanolica (13.6%), Kurtzmaniella zeylanoides (9.4%), Geotrichum candidum (8.8%), Galactomyces geotrichum (8.7%), Kluyveromyces lactis (3.5%), and Geotrichum silvicola (2.7%). The volatile profile analysis allowed 24 different compounds to be identified: 7 acids, 7 esters, 4 alcohols, 3 ketones, 2 aromatic hydrocarbons, and 1 aldehyde. The most represented volatile organic compounds (VOCs) were 2-butanone, butanoic acid and hexanoic acid. A positive correlation between Len. kefiri and hexanoic acid and isopentyl isobutyrate was observed (P < 0.05), whereas Y. lipolytica displayed the highest number of positive correlations with 3-methyl-butanal, 2-pentanone and 2-pentanol (P < 0.05). To the authors' knowledge, this is the very first detection of Len. kefiri in a raw ewe's milk cheese coagulated with vegetable rennet.
Collapse
Affiliation(s)
- Federica Cardinali
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, Ancona, Italy
| | - Ilario Ferrocino
- Department of Agricultural, Forest, and Food Science, University of Turin, Largo Paolo Braccini 2, Grugliasco, Torino, Italy
| | - Vesna Milanović
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, Ancona, Italy
| | - Luca Belleggia
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, Ancona, Italy
| | - Maria Rita Corvaglia
- Department of Agricultural, Forest, and Food Science, University of Turin, Largo Paolo Braccini 2, Grugliasco, Torino, Italy
| | - Cristiana Garofalo
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, Ancona, Italy
| | - Roberta Foligni
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, Ancona, Italy
| | - Cinzia Mannozzi
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, Ancona, Italy
| | - Massimo Mozzon
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, Ancona, Italy
| | - Luca Cocolin
- Department of Agricultural, Forest, and Food Science, University of Turin, Largo Paolo Braccini 2, Grugliasco, Torino, Italy
| | - Andrea Osimani
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, Ancona, Italy.
| | - Lucia Aquilanti
- Dipartimento di Scienze Agrarie, Alimentari ed Ambientali, Università Politecnica delle Marche, via Brecce Bianche, Ancona, Italy
| |
Collapse
|
25
|
Unno R, Suzuki T, Matsutani M, Ishikawa M. Evaluation of the Relationships Between Microbiota and Metabolites in Soft-Type Ripened Cheese Using an Integrated Omics Approach. Front Microbiol 2021; 12:681185. [PMID: 34168634 PMCID: PMC8219077 DOI: 10.3389/fmicb.2021.681185] [Citation(s) in RCA: 9] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/16/2021] [Accepted: 05/12/2021] [Indexed: 01/04/2023] Open
Abstract
Cheese ripening is effected by various microorganisms and results in the characteristic flavors of cheese. Owing to the complexity of the microbiota involved, the relationship between microorganisms and components during ripening remains unclear. In this study, metagenomics and metabolomics were integrated to reveal these relationships in three kinds of surface mold-ripened cheeses and two kinds of bacterial smear-ripened cheeses. The microbiota is broadly divided into two groups to correspond with different cheese types. Furthermore, surface mold-ripened cheese showed similar microbiota regardless of the cheese variety, whereas bacterial smear-ripened cheese showed specific microbiota characterized by marine bacteria (MB) and halophilic and alkaliphilic lactic acid bacteria for each cheese variety. In the metabolite analysis, volatile compounds suggested differences in cheese types, although organic acids and free amino acids could not determine the cheese characteristics. On the other hand, Spearman correlation analysis revealed that the abundance of specific bacteria was related to the formation of specific organic acids, free amino acids, and volatile compounds. In particular, MB was positively correlated with esters and pyrazines, indicating their contribution to cheese quality. These methodologies and results further our understanding of microorganisms and allow us to select useful strains for cheese ripening.
Collapse
Affiliation(s)
- Ryosuke Unno
- Department of Fermentation Science, Faculty of Applied Bioscience, Tokyo University of Agriculture, Tokyo, Japan
| | - Toshihiro Suzuki
- Department of Fermentation Science, Faculty of Applied Bioscience, Tokyo University of Agriculture, Tokyo, Japan
| | | | - Morio Ishikawa
- Department of Fermentation Science, Faculty of Applied Bioscience, Tokyo University of Agriculture, Tokyo, Japan
| |
Collapse
|
26
|
Mayo B, Rodríguez J, Vázquez L, Flórez AB. Microbial Interactions within the Cheese Ecosystem and Their Application to Improve Quality and Safety. Foods 2021; 10:602. [PMID: 33809159 PMCID: PMC8000492 DOI: 10.3390/foods10030602] [Citation(s) in RCA: 36] [Impact Index Per Article: 12.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/25/2021] [Accepted: 03/09/2021] [Indexed: 12/26/2022] Open
Abstract
The cheese microbiota comprises a consortium of prokaryotic, eukaryotic and viral populations, among which lactic acid bacteria (LAB) are majority components with a prominent role during manufacturing and ripening. The assortment, numbers and proportions of LAB and other microbial biotypes making up the microbiota of cheese are affected by a range of biotic and abiotic factors. Cooperative and competitive interactions between distinct members of the microbiota may occur, with rheological, organoleptic and safety implications for ripened cheese. However, the mechanistic details of these interactions, and their functional consequences, are largely unknown. Acquiring such knowledge is important if we are to predict when fermentations will be successful and understand the causes of technological failures. The experimental use of "synthetic" microbial communities might help throw light on the dynamics of different cheese microbiota components and the interplay between them. Although synthetic communities cannot reproduce entirely the natural microbial diversity in cheese, they could help reveal basic principles governing the interactions between microbial types and perhaps allow multi-species microbial communities to be developed as functional starters. By occupying the whole ecosystem taxonomically and functionally, microbiota-based cultures might be expected to be more resilient and efficient than conventional starters in the development of unique sensorial properties.
Collapse
Affiliation(s)
- Baltasar Mayo
- Departamento de Microbiología y Bioquímica, Instituto de Productos Lácteos de Asturias (IPLA), Consejo Superior de Investigaciones Científicas (CSIC), Paseo Río Linares s/n, 33300 Villaviciosa, Spain; (J.R.); (L.V.); (A.B.F.)
| | | | | | | |
Collapse
|
27
|
Suzuki T, Matsutani M, Matsuyama M, Unno R, Matsushita H, Sugiyama M, Yamasato K, Koizumi Y, Ishikawa M. Growth and metabolic properties of halophilic and alkaliphilic lactic acid bacterial strains of Marinilactibacillus psychrotolerans isolated from surface-ripened soft cheese. Int Dairy J 2021. [DOI: 10.1016/j.idairyj.2020.104840] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/28/2022]
|
28
|
Mileriene J, Serniene L, Henriques M, Gomes D, Pereira C, Kondrotiene K, Kasetiene N, Lauciene L, Sekmokiene D, Malakauskas M. Effect of liquid whey protein concentrate-based edible coating enriched with cinnamon carbon dioxide extract on the quality and shelf life of Eastern European curd cheese. J Dairy Sci 2020; 104:1504-1517. [PMID: 33309377 DOI: 10.3168/jds.2020-18732] [Citation(s) in RCA: 9] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/16/2020] [Accepted: 09/12/2020] [Indexed: 01/09/2023]
Abstract
Fresh unripened curd cheese has long been a well-known Eastern European artisanal dairy product; however, due to possible cross-contamination from manual production steps, high moisture content (50-60%), and metabolic activity of present lactic acid bacteria, the shelf life of curd cheese is short (10-20 d). Therefore, the aim of this study was to improve the shelf life of Eastern European acid-curd cheese by applying an antimicrobial protein-based (5%, wt/wt) edible coating. The bioactive edible coating was produced from liquid whey protein concentrate (a cheese production byproduct) and fortified with 0.3% (wt/wt, solution basis) Chinese cinnamon bark (Cinnamomum cassia) CO2 extract. The effect of coating on the cheese was evaluated within package-free (group 1) and additionally vacuum packaged (group 2) conditions to represent types of cheeses sold by small and big scale manufacturers. The cheese samples were examined over 31 d of storage for changes of microbiological (total bacterial count, lactic acid bacteria, yeasts and molds, coliforms, enterobacteria, Staphylococcus spp.), physicochemical (pH, lactic acid, protein, fat, moisture, color change, rheological, and sensory properties). The controlled experiment revealed that in group 1, applied coating affected appearance and color by preserving moisture and decreasing growth of yeasts and molds during prolonged package-free cheese storage. In group 2, coating did not affect moisture, color, or texture, but had a strong antimicrobial effect, decreasing the counts of yeasts and molds by 0.79 to 1.55 log cfu/g during 31 d of storage. In both groups, coating had no effect on pH, lactic acid, protein, and fat contents. Evaluated sensory properties (appearance, odor, taste, texture, and overall acceptability) of all samples were similar, indicating no effect of the coating on the flavor of curd cheese. The edible coating based on liquid whey protein concentrate with the incorporation of cinnamon extract was demonstrated to efficiently extend the shelf life of perishable fresh curd cheese, enhance its functional value, and contribute to a more sustainable production process.
Collapse
Affiliation(s)
- Justina Mileriene
- Department of Food Safety and Quality, Veterinary Academy, Lithuanian University of Health Sciences, Tilžės str. 18, LT-47181 Kaunas, Lithuania.
| | - Loreta Serniene
- Department of Food Safety and Quality, Veterinary Academy, Lithuanian University of Health Sciences, Tilžės str. 18, LT-47181 Kaunas, Lithuania
| | - Marta Henriques
- Department of Food Science and Technology, College of Agriculture, Polytechnic Institute of Coimbra, Bencanta, PT-3045-601 Coimbra, Portugal; Research Center for Natural Resources, Environment and Society (CERNAS), College of Agriculture, Polytechnic Institute of Coimbra, Bencanta, PT-3045-601 Coimbra, Portugal
| | - David Gomes
- Department of Food Science and Technology, College of Agriculture, Polytechnic Institute of Coimbra, Bencanta, PT-3045-601 Coimbra, Portugal
| | - Carlos Pereira
- Department of Food Science and Technology, College of Agriculture, Polytechnic Institute of Coimbra, Bencanta, PT-3045-601 Coimbra, Portugal; Research Center for Natural Resources, Environment and Society (CERNAS), College of Agriculture, Polytechnic Institute of Coimbra, Bencanta, PT-3045-601 Coimbra, Portugal
| | - Kristina Kondrotiene
- Department of Food Safety and Quality, Veterinary Academy, Lithuanian University of Health Sciences, Tilžės str. 18, LT-47181 Kaunas, Lithuania
| | - Neringa Kasetiene
- Department of Food Safety and Quality, Veterinary Academy, Lithuanian University of Health Sciences, Tilžės str. 18, LT-47181 Kaunas, Lithuania
| | - Lina Lauciene
- Department of Food Safety and Quality, Veterinary Academy, Lithuanian University of Health Sciences, Tilžės str. 18, LT-47181 Kaunas, Lithuania
| | - Dalia Sekmokiene
- Department of Food Safety and Quality, Veterinary Academy, Lithuanian University of Health Sciences, Tilžės str. 18, LT-47181 Kaunas, Lithuania
| | - Mindaugas Malakauskas
- Department of Food Safety and Quality, Veterinary Academy, Lithuanian University of Health Sciences, Tilžės str. 18, LT-47181 Kaunas, Lithuania
| |
Collapse
|
29
|
Lactic acid bacterial diversity in Brie cheese focusing on salt concentration and pH of isolation medium and characterisation of halophilic and alkaliphilic lactic acid bacterial isolates. Int Dairy J 2020. [DOI: 10.1016/j.idairyj.2020.104757] [Citation(s) in RCA: 9] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/18/2022]
|
30
|
Cosetta CM, Kfoury N, Robbat A, Wolfe BE. Fungal volatiles mediate cheese rind microbiome assembly. Environ Microbiol 2020; 22:4745-4760. [PMID: 32869420 DOI: 10.1111/1462-2920.15223] [Citation(s) in RCA: 21] [Impact Index Per Article: 5.3] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/11/2020] [Revised: 08/28/2020] [Accepted: 08/28/2020] [Indexed: 12/01/2022]
Abstract
In vitro studies in plant, soil, and human systems have shown that microbial volatiles can mediate microbe-microbe or microbe-host interactions. These previous studies have often used artificially high concentrations of volatiles compared to in situ systems and have not demonstrated the roles volatiles play in mediating community-level dynamics. We used the notoriously volatile cheese rind microbiome to identify bacteria responsive to volatiles produced by five widespread cheese fungi. Vibrio casei had the strongest growth stimulation when exposed to all fungi. In multispecies community experiments, fungal volatiles caused a shift to a Vibrio-dominated community, potentially explaining the widespread occurrence of Vibrio in surface-ripened cheeses. RNA sequencing identified activation of the glyoxylate shunt as a possible mechanism underlying volatile-mediated growth promotion and community assembly. Our study demonstrates how airborne chemicals could be used to control the composition of microbiomes and illustrates how volatiles may impact the development of cheese rinds.
Collapse
Affiliation(s)
- Casey M Cosetta
- Department of Biology, Tufts University, 200 Boston Ave, Medford, MA, 02155, USA
| | - Nicole Kfoury
- Department of Chemistry, Tufts University, 62 Talbot Ave., Medford, MA, 02155, USA
| | - Albert Robbat
- Department of Chemistry, Tufts University, 62 Talbot Ave., Medford, MA, 02155, USA
| | - Benjamin E Wolfe
- Department of Biology, Tufts University, 200 Boston Ave, Medford, MA, 02155, USA
| |
Collapse
|
31
|
Safety assessment of Gram-negative bacteria associated with traditional French cheeses. Food Microbiol 2019; 79:1-10. [DOI: 10.1016/j.fm.2018.11.001] [Citation(s) in RCA: 12] [Impact Index Per Article: 2.4] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/25/2018] [Revised: 09/25/2018] [Accepted: 11/03/2018] [Indexed: 12/21/2022]
|
32
|
Ben-Harb S, Saint-Eve A, Panouillé M, Souchon I, Bonnarme P, Dugat-Bony E, Irlinger F. Design of microbial consortia for the fermentation of pea-protein-enriched emulsions. Int J Food Microbiol 2019; 293:124-136. [PMID: 30690292 DOI: 10.1016/j.ijfoodmicro.2019.01.012] [Citation(s) in RCA: 34] [Impact Index Per Article: 6.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/20/2018] [Revised: 01/02/2019] [Accepted: 01/21/2019] [Indexed: 01/12/2023]
Abstract
In order to encourage Western populations to increase their consumption of vegetables, we suggest turning legumes into novel, healthy foods by applying an old, previously widespread method of food preservation: fermentation. In the present study, a total of 55 strains from different microbial species (isolated from cheese or plants) were investigated for their ability to: (i) grow on a emulsion containing 100% pea proteins and no carbohydrates or on a 50:50 pea:milk protein emulsion containing lactose, (ii) increase aroma quality and reduce sensory off-flavors; and (iii) compete against endogenous micro organisms. The presence of carbohydrates in the mixed pea:milk emulsion markedly influenced the fermentation by strongly reducing the pH through lactic fermentation, whereas the absence of carbohydrates in the pea emulsion promoted alkaline or neutral fermentation. Lactic acid bacteria assigned to Lactobacillus plantarum, Lactobacillus rhamnosus, Lactococcus lactis and Lactobacillus casei species grew well in both the pea and pea:milk emulsions. Most of the fungal strains tested (particularly those belonging to the Mucor and Geotrichum genera) were also able to grow on both emulsions. Although most Actinobacteria and Proteobacteria did not compete with endogenous microbiota (Bacillus), some species such as Hafnia alvei, Acinetobacter johnsonii and Glutamicibacter arilaitensis grew strongly and appeared to restrict the development of the endogenous microbiota when the pea emulsion was inoculated with a combination of three to nine strains. In the mixed emulsions, lactic fermentation inhibited Actinobacteria and Proteobacteria (e.g. Brevibacterium casei, Corynebacterium casei, Staphylococcus lentus) to the greatest extent but also inhibited Bacillus (e.g. Bacillus subtilis and Bacillus licheniformis). Overall, this procedure enabled us to select two microbial consortia able to colonize pea-based products and positively influence the release of volatile compounds by generating a roasted/grilled aroma for the 100% pea emulsion, and a fruity, lactic aroma for the 50:50 pea:milk emulsion. Moreover, the fermentation in the pea-based emulsions reduced the level of hexanal, which otherwise leads to an undesired green pea aroma. Our present results show how the assembly of multiple microbial cultures can help to develop an innovative food product.
Collapse
Affiliation(s)
- Salma Ben-Harb
- UMR GMPA, AgroParisTech, INRA, Université Paris-Saclay, 78850 Thiverval-Grignon, France
| | - Anne Saint-Eve
- UMR GMPA, AgroParisTech, INRA, Université Paris-Saclay, 78850 Thiverval-Grignon, France
| | - Maud Panouillé
- UMR GMPA, AgroParisTech, INRA, Université Paris-Saclay, 78850 Thiverval-Grignon, France
| | - Isabelle Souchon
- UMR GMPA, AgroParisTech, INRA, Université Paris-Saclay, 78850 Thiverval-Grignon, France
| | - Pascal Bonnarme
- UMR GMPA, AgroParisTech, INRA, Université Paris-Saclay, 78850 Thiverval-Grignon, France
| | - Eric Dugat-Bony
- UMR GMPA, AgroParisTech, INRA, Université Paris-Saclay, 78850 Thiverval-Grignon, France
| | - Françoise Irlinger
- UMR GMPA, AgroParisTech, INRA, Université Paris-Saclay, 78850 Thiverval-Grignon, France.
| |
Collapse
|
33
|
Potentiality of the use of starter culture in PDO Strachitunt production on chemical-physical and microbiological features: A pilot study. Lebensm Wiss Technol 2018. [DOI: 10.1016/j.lwt.2018.08.034] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
|
34
|
Ritschard JS, Amato L, Kumar Y, Müller B, Meile L, Schuppler M. The role of the surface smear microbiome in the development of defective smear on surface-ripened red-smear cheese. AIMS Microbiol 2018; 4:622-641. [PMID: 31294238 PMCID: PMC6613336 DOI: 10.3934/microbiol.2018.4.622] [Citation(s) in RCA: 12] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/29/2018] [Accepted: 09/20/2018] [Indexed: 01/05/2023] Open
Abstract
The complex smear microbiota colonizing the surface of red-smear cheese fundamentally impacts the ripening process, appearance and shelf life of cheese. To decipher the prokaryotic composition of the cheese smear microbiome, the surface of a semi-hard surface ripened cheese was studied post-ripening by culture-based and culture-independent molecular approaches. The aim was to detect potential bacterial alterations in the composition of the cheese smear microbiota resulting from cheese storage in vacuum film-prepackaging, which is often accompanied by the development of a surface smear defect. Next-generation sequencing of amplified 16S rRNA gene fragments revealed an unexpected high diversity of a total of 132 different genera from the domains Bacteria and Archaea on the cheese surface. Beside typical smear organisms, our study revealed the presence of several microorganisms so far not associated with cheese, but related to milk, farm and cheese dairy environments. A 16S ribosomal RNA based analysis from total RNA identified the major metabolically active populations in the cheese surface smear as Actinobacteria of the genera Corynebacterium, Brevibacterium, Brachybacterium and Agrococcus. Comparison of data on a higher phylogenetic level revealed distinct differences in the composition of the cheese smear microbiome from the different samples. While the proportions of Proteobacteria and Bacteroidetes were increased in the smear of prepacked samples and in particular in defective smear, staphylococci showed an opposite trend and turned out to be strongly decreased in defective smear. In conclusion, next-generation sequencing of amplified 16S rRNA genes and 16S rRNA from total RNA extracts provided a much deeper insight into the bacterial composition of the cheese smear microbiota. The observed shifts in the microbial composition of samples from defect surface smear suggest that certain members of the Proteobacteria contribute to the observed negative organoleptic properties of the surface smear of cheese after prepacking in plastic foil.
Collapse
Affiliation(s)
- Jasmine S Ritschard
- Laboratory of Food Microbiology, Institute of Food, Nutrition and Health, ETH Zurich, Schmelzbergstrasse 7, 8092 Zurich, Switzerland
| | - Lea Amato
- Laboratory of Food Biotechnology, Institute of Food, Nutrition and Health, ETH Zurich, Schmelzbergstrasse 7, 8092 Zurich, Switzerland
| | - Yadhu Kumar
- Eurofins GATC Biotech AG, Jakob-Stadler-Platz 7, 78467 Konstanz, Germany
| | - Britta Müller
- Eurofins GATC Biotech AG, Jakob-Stadler-Platz 7, 78467 Konstanz, Germany
| | - Leo Meile
- Laboratory of Food Biotechnology, Institute of Food, Nutrition and Health, ETH Zurich, Schmelzbergstrasse 7, 8092 Zurich, Switzerland
| | - Markus Schuppler
- Laboratory of Food Microbiology, Institute of Food, Nutrition and Health, ETH Zurich, Schmelzbergstrasse 7, 8092 Zurich, Switzerland
| |
Collapse
|
35
|
Afshari R, Pillidge CJ, Dias DA, Osborn AM, Gill H. Cheesomics: the future pathway to understanding cheese flavour and quality. Crit Rev Food Sci Nutr 2018; 60:33-47. [DOI: 10.1080/10408398.2018.1512471] [Citation(s) in RCA: 29] [Impact Index Per Article: 4.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/13/2022]
Affiliation(s)
- Roya Afshari
- School of Science, RMIT University, Bundoora, Victoria, Australia
| | | | - Daniel A. Dias
- School of Health and Biomedical Sciences, RMIT University, Bundoora, Victoria, Australia
| | - A. Mark Osborn
- School of Science, RMIT University, Bundoora, Victoria, Australia
| | - Harsharn Gill
- School of Science, RMIT University, Bundoora, Victoria, Australia
| |
Collapse
|
36
|
Meason-Smith C, Older CE, Ocana R, Dominguez B, Lawhon SD, Wu J, Patterson AP, Rodrigues Hoffmann A. Novel association of Psychrobacter and Pseudomonas with malodour in bloodhound dogs, and the effects of a topical product composed of essential oils and plant-derived essential fatty acids in a randomized, blinded, placebo-controlled study. Vet Dermatol 2018; 29:465-e158. [PMID: 30251442 DOI: 10.1111/vde.12689] [Citation(s) in RCA: 13] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Accepted: 07/25/2018] [Indexed: 12/17/2022]
Abstract
BACKGROUND The pathogenesis and treatment of cutaneous malodour in dogs have not been investigated previously. Staphylococcus and Corynebacterium spp. are associated with human axillary malodour. HYPOTHESIS Staphylococcus and Corynebacterium spp. are associated with cutaneous malodour in dogs, and treatment with a topical essential oil-based product will improve malodour and reduce the abundance of odour-causing bacteria. ANIMALS Twenty seven bloodhound dogs from a south Texas boarding facility were enrolled in this study. METHODS AND MATERIALS Skin swabs were taken from the axilla and dorsum of 27 dogs at initiation of the study. Mean malodour scores were used to assign dogs to control or malodour groups. The malodourous dogs were randomly assigned to a treatment or placebo group, received four weekly topical applications of the spot-on or placebo, and samples were recollected. Next-generation sequencing (NGS) and real-time quantitative PCR (qPCR) were performed on all swabs. RESULTS Psychrobacter and Pseudomonas spp. were significantly more abundant (P < 0.001, P = 0.006; respectively), and overall bacterial diversity was reduced (P = 0.0384) on the skin of malodourous dogs. Staphylococcus and Corynebacterium spp. were not associated with malodour. The topical essential oil-based product significantly (P = 0.0078) improved malodour in the treatment group and shifted their bacterial community structure. CONCLUSIONS AND CLINICAL IMPORTANCE A novel association of bacterial genera with malodour in bloodhound dogs, identified by NGS, highlights future targets for odour control. The topical treatment significantly reduced malodour. The interaction between the topical treatment and cutaneous microbiota should be further investigated and may be useful in other dermatological conditions involving microbiota.
Collapse
Affiliation(s)
- Courtney Meason-Smith
- Department of Veterinary Pathobiology, College of Veterinary Medicine & Biomedical Sciences, Texas A&M University, 4467 TAMU, College Station, TX, 77843, USA
| | - Caitlin E Older
- Department of Veterinary Pathobiology, College of Veterinary Medicine & Biomedical Sciences, Texas A&M University, 4467 TAMU, College Station, TX, 77843, USA
| | - Roxanna Ocana
- Department of Veterinary Pathobiology, College of Veterinary Medicine & Biomedical Sciences, Texas A&M University, 4467 TAMU, College Station, TX, 77843, USA
| | - Brandon Dominguez
- Department of Large Animal Clinical Sciences, College of Veterinary Medicine & Biomedical Sciences, Texas A&M University, 4475 TAMU, College Station, TX, 77843, USA
| | - Sara D Lawhon
- Department of Veterinary Pathobiology, College of Veterinary Medicine & Biomedical Sciences, Texas A&M University, 4467 TAMU, College Station, TX, 77843, USA
| | - Jing Wu
- Department of Veterinary Pathobiology, College of Veterinary Medicine & Biomedical Sciences, Texas A&M University, 4467 TAMU, College Station, TX, 77843, USA
| | - Adam P Patterson
- Department of Small Animal Clinical Sciences, College of Veterinary Medicine & Biomedical Sciences, Texas A&M University, 4474 TAMU, College Station, TX, 77843, USA
| | - Aline Rodrigues Hoffmann
- Department of Veterinary Pathobiology, College of Veterinary Medicine & Biomedical Sciences, Texas A&M University, 4467 TAMU, College Station, TX, 77843, USA
| |
Collapse
|
37
|
Haastrup MK, Johansen P, Malskær AH, Castro-Mejía JL, Kot W, Krych L, Arneborg N, Jespersen L. Cheese brines from Danish dairies reveal a complex microbiota comprising several halotolerant bacteria and yeasts. Int J Food Microbiol 2018; 285:173-187. [PMID: 30176565 DOI: 10.1016/j.ijfoodmicro.2018.08.015] [Citation(s) in RCA: 32] [Impact Index Per Article: 5.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/23/2018] [Revised: 06/06/2018] [Accepted: 08/15/2018] [Indexed: 11/19/2022]
Abstract
The Danish Danbo cheese is a surface ripened semi-hard cheese, which before ripening is submerged in brine for up to 24 h. The brining is required in order to obtain the structural and organoleptic properties of the cheeses. Likewise, the content of NaCl in the cheese will influence especially the surface microbiota being of significant importance for flavour development and prevention of microbial spoilage. Even though the microbiota on cheese surfaces have been studied extensively, limited knowledge is available on the occurrence of microorganisms in cheese brine. The aim of the present study was to investigate by both culture-dependent and -independent techniques the brine microbiota in four Danish dairies producing Danbo cheese. The pH of the brines varied from 5.1 to 5.6 with a dry matter content from 20 to 27% (w/w). The content of lactate varied from 4.1 to 10.8 g/L and free amino acids from 65 to 224 mg/L. Bacteria were isolated on five different media with NaCl contents of 0.85-23.0% (w/v) NaCl. The highest count of 6.3 log CFU/mL was obtained on TSA added 4% (w/v) NaCl. For yeasts, the highest count was 3.7 log CFU/mL on MYGP added 8% (w/v) NaCl. A total of 31 bacterial and eight eukaryotic species were isolated including several halotolerant and/or halophilic species. Among bacteria, counts of ≥6.0 log CFU/mL were obtained for Tetragenococcus muriaticus and Psychrobacter celer, while counts between ≥4.5 and < 6.0 log CFU/mL were obtained for Lactococcus lactis, Staphylococcus equorum, Staphylococcus hominis, Chromohalobacter beijerinckii, Chromohalobacter japonicus and Microbacterium maritypicum. Among yeasts, counts of ≥3.5 log CFU/mL were only obtained for Debaryomyces hansenii. By amplicon-based high-throughput sequencing of 16S rRNA gene and ITS2 regions for bacteria and eukaryotes respectively, brines from the same dairy clustered together indicating the uniqueness of the dairy brine microbiota. To a great extent the results obtained by amplicon sequencing fitted with the culture-dependent technique though each of the two methodologies identified unique genera/species. Dairy brine handling procedures as e.g. microfiltration were found to influence the brine microbiota. The current study proves the occurrence of a specific dairy brine microbiota including several halotolerant and/or halophilic species most likely of sea salt origin. The importance of these species during especially the initial stages of cheese ripening and their influence on cheese quality and safety need to be investigated. Likewise, optimised brine handling procedures and microbial cultures are required to ensure an optimal brine microbiota.
Collapse
Affiliation(s)
- Martin Kragelund Haastrup
- Department of Food Science, University of Copenhagen, Rolighedsvej 26, DK-1958 Frederiksberg C, Denmark
| | - Pernille Johansen
- Department of Food Science, University of Copenhagen, Rolighedsvej 26, DK-1958 Frederiksberg C, Denmark
| | - Agnete Harboe Malskær
- Department of Food Science, University of Copenhagen, Rolighedsvej 26, DK-1958 Frederiksberg C, Denmark
| | - Josué L Castro-Mejía
- Department of Food Science, University of Copenhagen, Rolighedsvej 26, DK-1958 Frederiksberg C, Denmark
| | - Witold Kot
- Environmental Microbiology and Biotechnology, University of Aarhus, Frederiksborgvej 399, DK-4000 Roskilde, Denmark
| | - Lukasz Krych
- Department of Food Science, University of Copenhagen, Rolighedsvej 26, DK-1958 Frederiksberg C, Denmark
| | - Nils Arneborg
- Department of Food Science, University of Copenhagen, Rolighedsvej 26, DK-1958 Frederiksberg C, Denmark
| | - Lene Jespersen
- Department of Food Science, University of Copenhagen, Rolighedsvej 26, DK-1958 Frederiksberg C, Denmark.
| |
Collapse
|
38
|
Early blowing in raw goats' milk cheese: gas production capacity of Enterobacteriaceae species present during manufacturing and ripening. J DAIRY RES 2018; 85:331-338. [PMID: 30088458 DOI: 10.1017/s0022029918000511] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/07/2022]
Abstract
The aim of this study was to identify the main Enterobacteriaceae species responsible for early gas blowing during curdling and the first week of ripening in raw goats' milk cheese. Two batches of raw goats' milk cheese were selected. One of them showed early blowing within the first 24 h of cheese ripening while the other showed no alteration. Although initial levels of Enterobacteriaceae were similar in defective and non-defective cheese, their dynamics (growth and disappearance rates of the species detected) were different. Klebsiella oxytoca and Enterobacter cloacae were the main species in the defective curd, whereas Buttiauxela spp. was predominant in normal curd. Hafnia alvei was the prevailing isolated species for both normal and defective cheese throughout the ripening process. The highest gas production was rendered by K. oxytoca and H. alvei, mainly isolated from curd and cheese. However, other species relevant in milk or curd, like Pantoea ssp. or Buttiauxela spp. were considered as low gas producers. The analysis of digitalized images of cheese showed that most of the cheese eyes were formed before the first week of ripening, although this process continued during maturation.According to the species found in the defective and non-defective cheese, their proportions at different ripening stages, their ability to produce gas and eye formation, K. oxytoca might be considered the most likely responsible for early blowing in raw goats' milk cheeses; while H. alvei increased the eyes number in the later stages of the ripening period.
Collapse
|
39
|
Gonçalves MTP, Benito MJ, Córdoba MDG, Egas C, Merchán AV, Galván AI, Ruiz-Moyano S. Bacterial Communities in Serpa Cheese by Culture Dependent Techniques, 16S rRNA Gene Sequencing and High-throughput Sequencing Analysis. J Food Sci 2018; 83:1333-1341. [PMID: 29660816 DOI: 10.1111/1750-3841.14141] [Citation(s) in RCA: 20] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/22/2017] [Revised: 03/02/2018] [Accepted: 03/06/2018] [Indexed: 11/30/2022]
Abstract
Serpa cheese is one of the traditional regional Portuguese cheeses having the Protected Denomination of Origin (PDO) designation. This study investigated the bacterial community in the traditional Portuguese Serpa cheese. The microorganisms identified at the end of ripening (30 days) mainly were lactic acid bacteria (LAB). Lactobacillus paracasei/Lactobacillus casei was the main species in cheese from PDO registered industries, whereas in non-PDO registered industries Lactobacillus brevis was highlighted, among other LAB. Enterobacteriaceae species were detected at 20% to 40% of the total isolates. The results obtained by high-throughput sequencing analysis confirmed that LAB was the main microbial group, with Lactococcus genus contributing to approximately 40% to 60% of the population, followed by Leuconostoc and Lactobacillus. The Enterobacteriaceae family was also important. The differences between bacterial communities from PDO and non-PDO registered industries suggest that the lack of regulation of the cheese-making practices may influence unfavorably. The new knowledge about bacterial diversity in Serpa cheese could be useful to set up new ripening conditions, which favor the development of desirable microorganisms. PRACTICAL APPLICATION The control of the manufacturing process of traditional cheeses can be improved through the knowledge of the bacterial diversity that develops. Thus, the growth of desirable microorganisms can be promoted to homogenize the final product.
Collapse
Affiliation(s)
| | - María José Benito
- Nutrición y Bromatología, Escuela de Ingenierías Agrarias, Univ. de Extremadura, Avd. Adolfo Suárez s/n, 06007, Badajoz, Spain.,Inst. Univ. de Investigación en Recursos Agrarios (INURA), Avd. De la Investigación s/n, Univ. de Extremadura, 06006, Badajoz, Spain
| | - María de Guía Córdoba
- Nutrición y Bromatología, Escuela de Ingenierías Agrarias, Univ. de Extremadura, Avd. Adolfo Suárez s/n, 06007, Badajoz, Spain.,Inst. Univ. de Investigación en Recursos Agrarios (INURA), Avd. De la Investigación s/n, Univ. de Extremadura, 06006, Badajoz, Spain
| | - Conceição Egas
- UCBiotech-CNC, BiocantPark, Núcleo 04, Lote 08, 3060-197, Cantanhede, Portugal
| | - Almudena V Merchán
- Nutrición y Bromatología, Escuela de Ingenierías Agrarias, Univ. de Extremadura, Avd. Adolfo Suárez s/n, 06007, Badajoz, Spain.,Inst. Univ. de Investigación en Recursos Agrarios (INURA), Avd. De la Investigación s/n, Univ. de Extremadura, 06006, Badajoz, Spain
| | - Ana I Galván
- Nutrición y Bromatología, Escuela de Ingenierías Agrarias, Univ. de Extremadura, Avd. Adolfo Suárez s/n, 06007, Badajoz, Spain.,Inst. Univ. de Investigación en Recursos Agrarios (INURA), Avd. De la Investigación s/n, Univ. de Extremadura, 06006, Badajoz, Spain
| | - Santiago Ruiz-Moyano
- Nutrición y Bromatología, Escuela de Ingenierías Agrarias, Univ. de Extremadura, Avd. Adolfo Suárez s/n, 06007, Badajoz, Spain.,Inst. Univ. de Investigación en Recursos Agrarios (INURA), Avd. De la Investigación s/n, Univ. de Extremadura, 06006, Badajoz, Spain
| |
Collapse
|
40
|
Sieuwerts S, Bron PA, Smid EJ. Mutually stimulating interactions between lactic acid bacteria and Saccharomyces cerevisiae in sourdough fermentation. Lebensm Wiss Technol 2018. [DOI: 10.1016/j.lwt.2017.12.022] [Citation(s) in RCA: 54] [Impact Index Per Article: 9.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/26/2022]
|
41
|
Schmitz-Esser S, Dzieciol M, Nischler E, Schornsteiner E, Bereuter O, Mann E, Wagner M. Abundance and potential contribution of Gram-negative cheese rind bacteria from Austrian artisanal hard cheeses. Int J Food Microbiol 2017; 266:95-103. [PMID: 29190534 DOI: 10.1016/j.ijfoodmicro.2017.11.013] [Citation(s) in RCA: 15] [Impact Index Per Article: 2.1] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/14/2017] [Revised: 10/23/2017] [Accepted: 11/18/2017] [Indexed: 11/19/2022]
Abstract
Many different Gram-negative bacteria have been shown to be present on cheese rinds. Their contribution to cheese ripening is however, only partially understood until now. Here, cheese rind samples were taken from Vorarlberger Bergkäse (VB), an artisanal hard washed-rind cheese from Austria. Ripening cellars of two cheese production facilities in Austria were sampled at the day of production and after 14, 30, 90 and 160days of ripening. To obtain insights into the possible contribution of Advenella, Psychrobacter, and Psychroflexus to cheese ripening, we sequenced and analyzed the genomes of one strain of each genus isolated from VB cheese rinds. Additionally, quantitative PCRs (qPCRs) were performed to follow the abundance of Advenella, Psychrobacter, and Psychroflexus on VB rinds during ripening in both facilities. qPCR results showed that Psychrobacter was most abundant on cheese rinds and the abundance of Advenella decreased throughout the first month of ripening and increased significantly after 30days of ripening (p<0.01). Psychrobacter and Psychroflexus increased significantly during the first 30 ripening days (p<0.01), and decreased to their initial abundance during the rest of the ripening time (p<0.05). Genome sequencing resulted in 17 to 27 contigs with assembly sizes of 2.7 Mbp for Psychroflexus, 3 Mbp for Psychrobacter, and 4.3 Mbp for Advenella. Our results reveal that each genome harbors enzymes shown to be important for cheese ripening in other bacteria such as: Cystathionine/Methionine beta or gamma-lyases, many proteases and peptidases (including proline iminopeptidases), aminotransferases, and lipases. Thus, all three isolates have the potential to contribute positively to cheese ripening. In conclusion, the three species quantified were stable community members throughout the ripening process and their abundance on cheese rinds together with the results from genome sequencing suggest an important contribution of these bacteria to cheese ripening.
Collapse
Affiliation(s)
- Stephan Schmitz-Esser
- Institute for Milk Hygiene, Department for Farm Animals and Veterinary Public Health, University of Veterinary Medicine, 1210 Vienna, Austria.
| | - Monika Dzieciol
- Institute for Milk Hygiene, Department for Farm Animals and Veterinary Public Health, University of Veterinary Medicine, 1210 Vienna, Austria
| | - Eva Nischler
- Institute for Milk Hygiene, Department for Farm Animals and Veterinary Public Health, University of Veterinary Medicine, 1210 Vienna, Austria
| | - Elisa Schornsteiner
- Institute for Milk Hygiene, Department for Farm Animals and Veterinary Public Health, University of Veterinary Medicine, 1210 Vienna, Austria
| | | | - Evelyne Mann
- Institute for Milk Hygiene, Department for Farm Animals and Veterinary Public Health, University of Veterinary Medicine, 1210 Vienna, Austria
| | - Martin Wagner
- Institute for Milk Hygiene, Department for Farm Animals and Veterinary Public Health, University of Veterinary Medicine, 1210 Vienna, Austria
| |
Collapse
|
42
|
Dietary Fibers and Protective Lactobacilli Drive Burrata Cheese Microbiome. Appl Environ Microbiol 2017; 83:AEM.01494-17. [PMID: 28842539 DOI: 10.1128/aem.01494-17] [Citation(s) in RCA: 10] [Impact Index Per Article: 1.4] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/08/2017] [Accepted: 08/07/2017] [Indexed: 12/22/2022] Open
Abstract
This study was aimed at improving the functional attributes and shelf life of burrata cheese by using protective lactobacilli (Lactobacillus plantarum LPAL and Lactobacillus rhamnosus LRB), fructooligosaccharides, and inulin. Six burrata cheeses were made using (i) the traditional protocol (control), (ii) the addition of 0.5% fructooligosaccharides and inulin (DF cheese), (iii) protective lactobacilli in milk alone (PL cheese), (iv) protective lactobacilli in milk and governing liquid (2PL cheese), (v) protective lactobacilli in milk and dietary fibers (DF_PL cheese), and (vi) protective lactobacilli in milk and governing liquid and dietary fibers (DF_2PL cheese). As expected, DF, DF_PL, and DF_2PL cheeses showed 1.5% of total fibers. Burrata cheeses produced by adding protective lactobacilli only in milk (PL and DF_PL cheeses) showed the lowest acidification during cheese making and storage. Lactic and acetic acids and ethanol were found at the lowest concentrations in these samples. Analyses of cultivable microbiota and the microbiome showed that protective lactobacilli reduced the house microbiota components (e.g., Streptococcus thermophilus, Lactococcus lactis, and Leuconostoc lactis) during cheese making and storage. Protective lactobacilli slowed the growth of staphylococci, coliforms, and Pseudomonas spp., especially in early storage. According to the different microbiome assemblies, burrata samples differed in peptide profiles and the levels of free amino acids. As shown by a sensory analysis, the addition of protective lactobacilli in milk improved the flavor and increased the shelf life of burrata cheese. In comparison to cheeses made using protective cultures only in milk, the shelf lives of those containing cultures also in the governing liquid were not further prolonged and they received lower acceptability scores by the panelists.IMPORTANCE This study provides more in-depth knowledge of the microbiome of burrata cheese and the set-up for a novel biotechnology using prebiotic dietary fibers and protective probiotic Lactobacillus plantarum LPAL and Lactobacillus rhamnosus LRB in milk. The biotechnology proposed in this study should be considered a useful tool to improve the functional value of burrata cheese. The use of protective lactobacilli in milk enhanced the flavor formation and shelf life of burrata cheese.
Collapse
|
43
|
Hernández-Galán L, Cattenoz T, Le Feunteun S, Canette A, Briandet R, Le-Guin S, Guedon E, Castellote J, Delettre J, Dugat Bony E, Bonnarme P, Spinnler HE, Martín del Campo ST, Picque D. Effect of dairy matrices on the survival of Streptococcus thermophilus , Brevibacterium aurantiacum and Hafnia alvei during digestion. Food Res Int 2017; 100:477-488. [DOI: 10.1016/j.foodres.2017.07.044] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/12/2017] [Revised: 07/07/2017] [Accepted: 07/13/2017] [Indexed: 12/13/2022]
|
44
|
Godziszewska J, Guzek D, Pogorzelska E, Brodowska M, Górska-Horczyczak E, Sakowska A, Wojtasik-Kalinowska I, Gantner M, Wierzbicka A. A simple method of the detection of pork spoilage caused by Rahnella aquatilis. Lebensm Wiss Technol 2017. [DOI: 10.1016/j.lwt.2017.05.049] [Citation(s) in RCA: 12] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/26/2022]
|
45
|
Calasso M, Mancini L, De Angelis M, Conte A, Costa C, Del Nobile MA, Gobbetti M. Multiple microbial cell-free extracts improve the microbiological, biochemical and sensory features of ewes’ milk cheese. Food Microbiol 2017; 66:129-140. [DOI: 10.1016/j.fm.2017.04.011] [Citation(s) in RCA: 5] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/07/2016] [Revised: 04/23/2017] [Accepted: 04/23/2017] [Indexed: 11/30/2022]
|
46
|
Tabla R, Gómez A, Simancas A, Rebollo JE, Molina F, Roa I. Enterobacteriaceae species during manufacturing and ripening of semi–hard and soft raw ewe’s milk cheese: Gas production capacity. Small Rumin Res 2016. [DOI: 10.1016/j.smallrumres.2016.11.008] [Citation(s) in RCA: 16] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/20/2022]
|
47
|
Ceugniez A, Taminiau B, Coucheney F, Jacques P, Delcenserie V, Daube G, Drider D. Use of a metagenetic approach to monitor the bacterial microbiota of "Tomme d'Orchies" cheese during the ripening process. Int J Food Microbiol 2016; 247:65-69. [PMID: 27817942 DOI: 10.1016/j.ijfoodmicro.2016.10.034] [Citation(s) in RCA: 28] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/09/2015] [Revised: 10/10/2016] [Accepted: 10/27/2016] [Indexed: 12/17/2022]
Abstract
The study of microbial ecosystems in artisanal foodstuffs is important to complete in order to unveil its diversity. The number of studies performed on dairy products has increased during the last decade, particularly those performed on milk and cheese derivative products. In this work, we investigated the bacterial content of "Tomme d'Orchies" cheese, an artisanal pressed and uncooked French cheese. To this end, a metagenetic analysis, using Illumina technology, was utilized on samples taken from the surface and core of the cheese at 0, 1, 3, 14 and 21days of ripening process. In addition to the classical microbiota found in cheese, various strains likely from environmental origin were identified. A large difference between the surface and the core content was observed within samples withdrawn during the ripening process. The main species encountered in the core of the cheese were Lactococcus spp. and Streptococcus spp., with an inversion of this ratio during the ripening process. Less than 2.5% of the whole population was composed of strains issued from environmental origin, as Lactobacillales, Corynebacterium and Brevibacterium. In the core, about 85% of the microbiota was attributed to the starters used for the cheese making. In turn, the microbiota of the surface contained less than 30% of these starters and interestingly displayed more diversity. The predominant genus was Corynebacterium sp., likely originating from the environment. The less abundant microbiota of the surface was composed of Bifidobacteria, Brevibacterium and Micrococcales. To summarize, the "Tomme d'Orchies" cheese displayed a high diversity of bacterial species, especially on the surface, and this diversity is assumed to arise from the production environment and subsequent ripening process.
Collapse
Affiliation(s)
- Alexandre Ceugniez
- Univ. Lille, INRA, ISA, Univ. Artois, Univ. Littoral Côte d'Opale, EA 7394 - ICV - Institut Charles Viollette, F-59000 Lille, France
| | - Bernard Taminiau
- Fundamental and Applied Research for Animal & Health (FARAH), Food Science Department, Faculty of Veterinary Medicine, University of Liège, Liège B-4000, Belgium
| | - Françoise Coucheney
- Univ. Lille, INRA, ISA, Univ. Artois, Univ. Littoral Côte d'Opale, EA 7394 - ICV - Institut Charles Viollette, F-59000 Lille, France.
| | - Philippe Jacques
- Univ. Lille, INRA, ISA, Univ. Artois, Univ. Littoral Côte d'Opale, EA 7394 - ICV - Institut Charles Viollette, F-59000 Lille, France
| | - Véronique Delcenserie
- Fundamental and Applied Research for Animal & Health (FARAH), Food Science Department, Faculty of Veterinary Medicine, University of Liège, Liège B-4000, Belgium
| | - Georges Daube
- Fundamental and Applied Research for Animal & Health (FARAH), Food Science Department, Faculty of Veterinary Medicine, University of Liège, Liège B-4000, Belgium
| | - Djamel Drider
- Univ. Lille, INRA, ISA, Univ. Artois, Univ. Littoral Côte d'Opale, EA 7394 - ICV - Institut Charles Viollette, F-59000 Lille, France
| |
Collapse
|
48
|
Trmčić A, Chauhan K, Kent DJ, Ralyea RD, Martin NH, Boor KJ, Wiedmann M. Coliform detection in cheese is associated with specific cheese characteristics, but no association was found with pathogen detection. J Dairy Sci 2016; 99:6105-6120. [PMID: 27289158 DOI: 10.3168/jds.2016-11112] [Citation(s) in RCA: 36] [Impact Index Per Article: 4.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/29/2016] [Accepted: 05/02/2016] [Indexed: 11/19/2022]
Abstract
Coliform detection in finished products, including cheese, has traditionally been used to indicate whether a given product has been manufactured under unsanitary conditions. As our understanding of the diversity of coliforms has improved, it is necessary to assess whether coliforms are a good indicator organism and whether coliform detection in cheese is associated with the presence of pathogens. The objective of this study was (1) to evaluate cheese available on the market for presence of coliforms and key pathogens, and (2) to characterize the coliforms present to assess their likely sources and public health relevance. A total of 273 cheese samples were tested for presence of coliforms and for Salmonella, Staphylococcus aureus, Shiga toxin-producing Escherichia coli, Listeria monocytogenes, and other Listeria species. Among all tested cheese samples, 27% (75/273) tested positive for coliforms in concentrations >10cfu/g. Pasteurization, pH, water activity, milk type, and rind type were factors significantly associated with detection of coliforms in cheese; for example, a higher coliform prevalence was detected in raw milk cheeses (42% with >10cfu/g) compared with pasteurized milk cheese (21%). For cheese samples contaminated with coliforms, only water activity was significantly associated with coliform concentration. Coliforms isolated from cheese samples were classified into 13 different genera, including the environmental coliform genera Hafnia, Raoultella, and Serratia, which represent the 3 genera most frequently isolated across all cheeses. Escherichia, Hafnia, and Enterobacter were significantly more common among raw milk cheeses. Based on sequencing of the housekeeping gene clpX, most Escherichia isolates were confirmed as members of fecal commensal clades of E. coli. All cheese samples tested negative for Salmonella, Staph. aureus, and Shiga toxin-producing E. coli. Listeria spp. were found in 12 cheese samples, including 5 samples positive for L. monocytogenes. Although no association was found between coliform and Listeria spp. detection, Listeria spp. were significantly more likely to be detected in cheese with the washed type of rind. Our data provide information on specific risk factors for pathogen detection in cheese, which will facilitate development of risk-based strategies to control microbial food safety hazards in cheese, and suggest that generic coliform testing cannot be used to assess the safety of natural cheese.
Collapse
Affiliation(s)
- A Trmčić
- Milk Quality Improvement Program, Department of Food Science, Cornell University, Ithaca, NY 14850
| | - K Chauhan
- Milk Quality Improvement Program, Department of Food Science, Cornell University, Ithaca, NY 14850
| | - D J Kent
- Milk Quality Improvement Program, Department of Food Science, Cornell University, Ithaca, NY 14850
| | - R D Ralyea
- Milk Quality Improvement Program, Department of Food Science, Cornell University, Ithaca, NY 14850
| | - N H Martin
- Milk Quality Improvement Program, Department of Food Science, Cornell University, Ithaca, NY 14850
| | - K J Boor
- Milk Quality Improvement Program, Department of Food Science, Cornell University, Ithaca, NY 14850
| | - M Wiedmann
- Milk Quality Improvement Program, Department of Food Science, Cornell University, Ithaca, NY 14850.
| |
Collapse
|
49
|
|
50
|
Dugat-Bony E, Sarthou AS, Perello MC, de Revel G, Bonnarme P, Helinck S. The effect of reduced sodium chloride content on the microbiological and biochemical properties of a soft surface-ripened cheese. J Dairy Sci 2016; 99:2502-2511. [DOI: 10.3168/jds.2015-10502] [Citation(s) in RCA: 12] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/09/2015] [Accepted: 12/15/2015] [Indexed: 11/19/2022]
|