Variation and factors on heavy metal speciation during co-composting of rural sewage sludge and typical rural organic solid waste

Biorefinery of waste activated sludge: Nutrient recovery and microbial lipid production by Yarrowia lipolytica

The rising generation of waste activated sludge (WAS) demands a fundamental shift towards resource reuse and recovery. The conventional methodologies used to manage this by-product derived from wastewater treatment plants are increasingly constrained due to stringent regulatory measures aimed at mitigating its adverse impacts on the environment and public health. Therefore, this work evaluated a promising strategy for the efficient management of WAS, transforming it into a valuable renewable source to produce high-value-added compounds, such as lipids and a slow-release fertilizer (struvite). Wet oxidation (WO) was identified as a suitable technique for solubilising WAS while generating short-chain fatty acids (primarily acetic acid). It was found that conducting WO at 200 °C for 120 min resulted in a 65% reduction of the total suspended solids (TSS) content and 87% of the volatile suspended solids (VSS) content. Additionally, under these conditions, 4440 ± 105 mg/L and 593 ± 21 mg/L of acetic and propionic acid were obtained, respectively, which were assimilated by Yarrowia lipolytica to produce biolipids. Furthermore, the rupture of WAS flocs also led to the solubilisation of 980 ± 8 mg/L of ammonium. During the struvite precipitation stage, a NH4:PO4:Mg ratio of 1:1.5:1.5 was found to be the most effective for removing soluble ammonium (97.4 ± 0.8%), resulting in a high-purity struvite formation, and enhancing the carbon/nitrogen (C/N) ratio of the oxidised WAS from 3 to 105. This improvement in the C/N ratio raised the lipid content from 36 ± 1% to 49 ± 1% during the cultivation of Y. lipolytica. The application of the sequencing batch culture strategy further increased lipid content to 59 ± 1%, with 6.0 ± 0.3 g/L as the final concentration after the fifth cycle. The lipids produced, mainly monounsaturated fatty acids with 40% of oleic acid, offer potential as biodiesel feedstock. This lipid composition led to biodiesel properties, including cetane number, iodine value, kinematic viscosity and density that met international standards. Therefore, this research presents a promising alternative not only for WAS management but also for harnessing valuable resources, thereby establishing a basis for large-scale studies.

Heavy metal tolerance and detoxification mechanism mediated by heavy metal resistance genes in compost habitat

Heavy metal pollution from compost is one of the most concerned environmental problems, which poses a threat to the ecosystem and human health. This study aims to reveal the heavy metal tolerance and detoxification mechanism mediated by heavy metal resistance genes (HMRGs) in compost habitat through metagenomics combined with chemical speciation analysis of heavy metals. The results showed that there were 37 HMRGs corresponding to 7 common heavy metal(loid)s in composting, and they had the ability to transform heavy metals into stable or low-toxic speciation by regulating enzyme transport, redox, methylation, etc. This study summarized the heavy metal metabolism pathway mediated by HMRGs, providing a new perspective for understanding the transformation of heavy metals in the composting process.

Mechanism and ecological environmental risk assessment of peroxymonosulfate for the treatment of heavy metals in soil

Oxidation technologies based on peroxymonosulfate (PMS) have been effectively used for the remediation of soil organic pollutants due to their high efficiency. However, the effects of advanced PMS-based oxidation technologies on other soil pollutants, such as heavy metals, remain unknown. In this study, changes in the form of heavy metals in soil after using PMS and the risk of pollution to the ecological environment were investigated. Furthermore, two risk assessment methods, the mung bean germination toxicity test and groundwater leaching soil column test, were employed to evaluate the soil before and after PMS treatment. The results showed that PMS has a strong ability to degrade complex compounds, enabling the transformation of heavy metals, such as Cd, Pb, and Zn, from stable to active states in the soil. The risk assessments showed that PMS treatment activated heavy metals in the soil, which delayed the growth of plants, increased heavy metal content in plant tissues and the risk of groundwater pollution. These findings provide a new perspective for understanding the effects of PMS on soil, thus facilitating the sustained and reliable development of future research in the field of advanced oxidation applied to soil treatment.

Biochemical changes, metal content, and spectroscopic analysis in sewage sludge composted with lignocellulosic residue using FTIR-MIR and FTIR-NIR

The use of lignocellulosic residues, originating from sawdust, in composting sewage sludge for organic fertilizer production, is a practice of growing interest. However, few studies have explored the effect of the proportion of sawdust and sewage sludge raw materials on composting performance in the humification process. This study assessed the addition of sawdust in the sewage sludge composting process, regarding carbon content, presence of heavy metals, and humification of the organic compost. The experimental design employed was a randomized complete block design with five treatments featuring different proportions of organic residues to achieve C/N ratios between 30-1 (T1: 100% sewage sludge and 0% sawdust, T2: 86% sewage sludge and 14.0% sawdust, T3: 67% sewage sludge and 33% sawdust, T4: 55% sewage sludge and 45% sawdust, and T5: 46.5% sewage sludge and 53.5% sawdust) and five replications, totaling 25 experimental units. The addition of lignocellulosic residue in sewage sludge composting increased the levels of TOC and the C/N ratio, reduced the levels of pH, P, N, Na, Ba, and Cr, and did not interfere with the levels of K, Ca, Mg, S, CEC, labile carbon, and metals Fe, Zn, Cu, Mn, Ni, and Pb. The increase in the proportion of sawdust residue favored the degradation of aliphatic groups, increasing the presence of aromatic structures and reducing humification at the end of composting. The use of sawdust as a lignocellulosic residue in sewage sludge composting is a viable and efficient alternative to produce high-quality organomineral fertilizers.

Removal of toxic metals from sewage sludge by EDTA and hydrodynamic cavitation and use of the sludge as fertilizer

Sewage sludge (SS) is rich in plant nutrients, including P, N, and organic C, but often contains toxic metals (TMs), which hinders its potential use in agriculture. The efficiency of removal of TMs by washing with ethylenediamine tetraacetate (EDTA), in combination with hydrodynamic cavitation (HC) and the usability of washed sewage sludge as fertilizer were investigated. The environmental risk was assessed. During 8 wash batches an average 35, 68, 47 and 45 % of Pb, Zn, Cd and Cu, respectively, as well as 22 and 5 % Mn and Fe were removed from the SS. The process solutions and EDTA were recycled at a pH gradient of 12.5-2, which was achieved by adding quicklime (CaO) and then acidification by H2SO4, so that no wastewater was produced, only solid waste (ReSoil® method). The quality of the recycled process solutions (they remained unsaturated with salts) and the efficiency of the washing process were maintained across all batches. On average, 46 % of the EDTA was lost during the process and was replenished. The initial leachability of EDTA-mobilized Pb, Zn, Cu, Cr and Fe remaining in the washed SS increased 6-, 17-, 3-, 11- and 11-fold, respectively, but not to hazardous levels except for Zn. After washing, P and K remained in the SS, plant-available P increased 3.3-fold, while total N and C were reduced by 20.28 and 2.44 %, respectively. Washed SS was used as fertilizer in the pot experiment. The yield of Brassica juncea did not improve, the uptake of TMs by the plants and the leaching of TMs from the soil were minimal. Our study highlighted the drawbacks and potential feasibility of the new SS washing method.

Co-composting of sewage sludge as an effective technology for the production of substrates with reduced content of pharmaceutical residues

Sewage sludge is a valuable source of elements such as phosphorus and nitrogen. At the same time, heavy metals, emerging organic compounds, micropollutants (pharmaceuticals, pesticides, PCPs, microplastics), or some potentially dangerous bacteria can be present. In this study, the sewage sludge was aerobically treated by composting with other materials (co-composted), and the resulting substrate was tested for suitability of its use in agriculture. Closer attention was focused on the pharmaceuticals (non-steroidal antiphlogistics, sartanes, antiepileptics, caffeine, and nicotine metabolites) content and ecotoxicity of the resulting substrates in the individual phases of sludge co-composting. It has been verified that during co-composting there is a potential for reduction of the content of pharmaceutical in the substrates up to 90 %. The course of the temperature in the thermophilic phase is decisive. Growth and ecotoxicity experiments demonstrated that with a suitable co-composting procedure, the resulting stabilized matter is suitable as a substrate for use in plant production, and the risk of using sewage sludge on agricultural land is substantially reduced.

Impacts and mechanism of coal fly ash on kitchen waste composting performance: The perspective of microbial community

Aerobic composting is eco-friendly and sustainable practice for kitchen waste (KW) disposal to restore soil fertility and reduce environmental risks. However, KW compact structure, perishable nature, acidification by anaerobic acidogens, inhibits the metabolism of aerobic microbes, insufficient breakdown of organic matters, and prolong the composting duration. This study, co-composted coal fly ash (FA), to regulate bacterial dynamics, co-occurrence patterns and nutrients transformation in KW composting. Our results indicated, FA created suitable environment by increasing pH and temperature, which facilitated the proliferation and reshaping of microbial community. FA fostered the relative abundances of phlya (Proteobacteria, Chloroflexi and Actinobacteriota) and genera (Bacillus, Paenibacillus and Lysinibacillus), which promoted the nutrients transformation (phosphorus and nitrogen) in KW compost. FA enhanced the mutualistic correlations between bacterial communities, promoted the network complexity (nodes & edges) and contains more positive connections, which reflect the FA amendment effects. KW mature compost seed germination index reached >85% of FA treatment, indicated the final products fully met the Chinese national standard for organic fertilizer. These findings might provide opportunity to advance the KW composting and collaborative management of multiple waste to curb the current environmental challenges.

Relationships between arsenic biotransformation genes, antibiotic resistance genes, and microbial function under different arsenic stresses during composting

Although the arsenic contamination and antibiotic resistance genes (ARGs) during composting have been studied separately, there is limited information on their interactions, particularly, the relationship between arsenic biotransformation genes (ABGs) and ARGs. Therefore, the present study used different forms of arsenic stress (organic and inorganic arsenic at 10 and 50 mg/kg) in pig manure and straw co-composting, to evaluate the effects of arsenic stress on microbial community structures, metabolic function, ABGs, and ARGs. The results showed that arsenic stress had different effects on different parameters and promoted the microbial formation of humic acid and the biodegradation of fulvic acid. Inorganic arsenic showed more rapid effects on microbial community structure, visible within about 20 days, while the effects of organic arsenic were later (about 45 days) due to the necessity of transformation. Moreover, the addition of organic roxarsone and inorganic arsenic resulted in higher expression of ABGs and ARGs, respectively. Arsenic addition also caused increased expression of genes associated with replication and repair. A significant relationship was observed between ABG and ARG expression, for instance, genes involved in arsenic reduction and oxidation were influenced by genes involved in aminoglycoside and chloramphenicol resistance genes (p < 0.05). These complex interactions among microorganisms, functional genes, and external parameters contribute to the understanding of the mechanisms underlying cross-contamination.

Effects of an assistive electric field on heavy metal passivation during manure composting

Composting is one of main technologies for treating and thus utilizing livestock manure and sludge. However, heavy metals are major concerns in compost utilization due to their potential environmental hazards and health risks. This study aimed to investigate the effects of electric field-assisted composting on the variations of heavy metals and the affecting factors. The results showed that electric field significantly reduced the contents of bioavailable heavy metals including Mn, Zn, Cu, Ni, and Cd, with their bioavailable concentrations decreasing by 61.7, 63.8, 64.9, 83.7, and 63.8 %, respectively. The heavy metals being transformed into stable states were increased, indicating that the electric field also passivated these heavy metals and reduced their biological toxicity and stabilized their forms. Spearman's correlation analysis revealed that the changes in substances, temperature, and organic matter were the dominant environmental factors affecting the forms of heavy metals. Microbial community analysis indicated an increase in the abundance of metal-resistant bacteria such as Pseudomonas and Bacillus during electric field-assisted composting, with their relative abundances being increased to 2.66 % and 15.63 % in the pile of electric field-assisted composting, respectively, compared to the values of 1.88 % and 4.36 % respectively in the conventional composting. The current study suggests that electric field-assisted composting can significantly reduce the availability of heavy metals in the compost, and thus mitigate the health risks associated with its application.

The transformation of heavy metal speciation during rapid high-temperature aerobic fermentation of food waste and their potential mechanisms

In this study, the content changes of multiple trace heavy metals (HMs) in food waste using a new rapid high-temperature aerobic fermentation (RTAF) technology and their relationships with different physicochemical factors were researched. The results indicated that the content of HMs in the decomposed products met the industry standards for organic fertilizers (NY/T525-2021, China). Physicochemical factors played an important role in controlling the changes in HM content. The component evolution of dissolved organic matter was studied, and its influences on the transformation of HM speciation showed that the RTAF process converted proteins into humus-like substances. Redundancy analysis revealed that the main factors driving the speciation transformation of HMs were tyrosine-like substances or microbial-derived humus (C3), molecular weight of dissolved organic matter (SUVA254) and humification degree (E250/E365). The increase in humification degree contributed to passivating HMs. The correlation network analysis results showed that the exchangeable HMs (Exc-HMs) were related to Lactobacillus and Pediococcu. Additionally, the cytoskeleton, coenzyme transport and metabolic function of microorganisms affected the Exc-HM content. These research results can provide a scientific basis for the prevention and control of HM pollution during the treatment of food waste.

Regulating sludge composting with percarbonate facilitated the methylation and detoxification of arsenic mediated via reactive oxygen species

This study purposed to demonstrate the impact of reactive oxygen species (ROS) on arsenic detoxification mechanism in sludge composting with percarbonate. In this study, sodium percarbonate was used as an additive. Adding sodium percarbonate increased the content of H2O2 and OH, which the experimental group (SPC) was higher than the control group (CK). In addition, it decreased the bioavailability of arsenic by 19.10%. Metagenomic analysis found that Firmicutes and Pseudomonas took an active part in the overall compost as the dominant bacteria of arsenic methylation. ROS positively correlated with arsenic oxidation and methylation genes (arsC, arsM), with the gene copy number of arsC and arsM increasing to 7.74 × 1012, 5.24 × 1012 in SPC. In summary, the passivation of arsenic could be achieved by adding percarbonate, which promoted the methylation of arsenic, reduced the toxicity of arsenic, and provided a new idea for the harmless management of sludge.

Study on sewage characteristics in rural China and pollutants removal performance of biologically enhanced internal circulation treatment system

With rapid economic development and urbanization in China, rural wastewater treatment has become an important issue. This study investigated 63 rural sewage treatment stations in northern, central and southern Shaanxi, China for a 1-year period, 2021 to 2022. The main purpose of the research was to investigate the quality and discharge characteristics of rural sewage, along with current problems in rural wastewater treatment, in order to provide evidence for the optimal construction and operation of rural sewage treatment stations. We found that the biodegradability of rural wastewater is adequate, and BOD5/COD ratio in sewage was 0.4, which is suitable for biological treatment. It has obvious intermittent flow cut-off characteristics, and the range of cut-off duration of sewage was 6-16 h/d, which leads to poor pollutant removal efficiency (COD: 50.0 ± 29.2%, NH4+-N: 46.0 ± 26.1%, TN: 38.5 ± 24.9% and TP: 38.3 ± 23.8%) in sewage treatment stations. In response to the above characteristics, the rural sewage biologically enhanced internal circulation treatment (BEICT) system was constructed. After 97 days of operation, the system has a stable removal effect on TN and TP with an average removal rate of 77.42% and 89.69%, respectively, under the condition of influent interruption for 12 h per day. The activated sludge of system maintained good activity and stable sedimentation performance during the whole experiment, with MLVSS/MLSS and SVI of 0.72 and 128 mL/g, respectively. This study can provide the basis and technical support for the accurate design of rural sewage treatment facilities, and has important significance for guiding the treatment of rural domestic sewage in China.

Assessing the suitability of municipal sewage sludge and coconut bran as breeding medium for Oryza sativa L. seedlings and developing a standardized substrate

The utilization of organic solid waste (OSW) for preparing standardized seedling substrates is a main challenge due to its temporal and spatial variability. This study aims to form models based on data from the literature and validate them through experiments to explore a standardized seedling substrate. The typical OSW in Hainan Province, including municipal sewage sludge (MSS), coconut bran (CB), seaweed mud (SM), and municipal sewage sludge biochar (MSSB), was used as raw material. A series of six mixing ratios was tested, namely: T1 (0% MSS: 90% CB), T2 (10% MSS: 80% CB), T3 (30% MSS: 60% CB), T4 (50% MSS: 40% CB), T5 (70% MSS: 20% CB), and T6 (90% MSS: 0% CB). SM and MSSB were added as amendment materials at 5% (w/w) for each treatment. The physicochemical properties of substrates, agronomic traits of rice seedlings and microbial diversity were analyzed. The results showed that the four kinds of OSW played an active role in providing rich sources of nutrients. The dry weight of the above-ground part was 2.98 times greater in T3 than that of the commercial substrate. Furthermore, the microbial analysis showed a higher abundance of Actinobacteria in T3, representing the stability of the composted products. Finally, the successful fitting of the results with the linear regression models could establish relationship equations between the physicochemical properties of the substrate and the growth characteristics of seedlings. The relevant parameters suitable for the growth of rice seedlings were as follows: pH (6.46-7.01), EC (less than 2.12 mS cm-1), DD (0.13-0.16 g cm-3), and TPS (65.68-82.73%). This study proposed relevant parameters and models for standardization of seedling substrate, which would contribute to ensuring the quality of seedlings and OSW resource utilization.

Transformation of Zn and Cr during co-combustion of sewage sludge and coals: influence of coal and steam

Combustion experiments of sewage sludge (SS) blended with low-rank coal were conducted through a drop tube furnace (DTF) to explore the effects of low-rank coal type, blending ratio, and steam on the transformation of Zn and Cr. The results showed that the retention rates of Zn and Cr in ash increased from 24.35% and 71.49% for sludge combustion alone to 53.77% and 117.49%, respectively, for coal blended to SS with a mass ratio of 7:3. The greater the proportion of low-rank coal in the fuel, the greater the residual rate of heavy metals in the ash. Meanwhile, rapid diffusion of vapor occupied adsorption sites on metal mineral surfaces, reducing the retention of Zn and Cr in the co-combustion ash. The leaching toxicity analysis of ash showed that the co-combustion ash of SS with coal was free from leaching toxicity hazards in simulated scenarios. The extraction rate of Zn in co-combustion ash increased from 90.72% with hydrothermal acid leaching to 95.46% with microwave-assisted in 2 mol/L H2SO4 extract. The extraction rate of Cr in hydrothermal acid leaching was 62.80%, which was much higher than that in microwave-assisted extraction (31.76%).

Independent and combined effects of sepiolite and palygorskite on humus spectral properties and heavy metal bioavailability during chicken manure composting

The effects of the independent and combined addition strategies of sepiolite and palygorskite on humification and heavy metals (HMs) during chicken manure composting were evaluated. Results showed that clay mineral addition showed a favorable effect on composting, prolonged the duration of the thermophilic phase (5-9 d) and improved the TN content (14%-38%) compared to CK. Independent strategy enhanced the humification degree in equal measures with the combined strategy. Carbon nuclear magnetic resonance spectroscopy (¹³C NMR) and fourier transform infrared spectroscopy (FTIR) confirmed that aromatic carbon species increased by 31%-33% during composting process. Excitation-emission matrix (EEM) fluorescence spectroscopy showed that humic acid-like compounds increased by 12%-15%. In addition, the maximum passivation rate of Cr, Mn, Cu, Zn, As, Cd, Pb and Ni were 51.35%, 35.98%, 30.39%, 32.46%, -87.02%, 36.61% and 27.62%, respectively. The independent addition of palygorskite exhibits the most potent effects for most HMs. Pearson correlation analysis indicated that pH and aromatic carbon were the key determinants of the HMs passivation. This study provided preliminary evidence and perspective of the application of clay minerals on the humification and safety of composting.

Simultaneous passivation of heavy metals and removal of antibiotic resistance genes by calcium peroxide addition during sewage sludge composting

This research evaluated the effects of calcium peroxide (CP) at 0% (CK, w/w), 5% (T1, w/w), and 10% (T2, w/w), on heavy metals (HMs) mobility and prevalence of antibiotic resistance genes (ARGs) during sludge composting. T1 and T2 significantly reduced (p < 0.05) the mobility of Cu (29.34%, and 32.94%, respectively), Ni (24.07%, and 31.48%, respectively) and Zn (33.28%, and 54.11%, respectively) compared to CK after the composting. CP addition resulted in a decrease in mobile genetic elements (MGEs) and ARGs during composting. Together with structural equation model and random forest analysis depicted MGEs had a primary association with total ARGs variations during composting. Microbial analysis indicated CP downregulated the expression of the genes associated with two-component and type IV secretion system, thus reducing the prevalence of ARGs. This study demonstrates that application of CP is a feasible strategy to mitigate both ARGs and HMs hazards during composting.

Microbial metabolism and humic acid formation in response to enhanced copper and zinc passivation during composting of wine grape pomace and pig manure

Copper (Cu) and zinc (Zn) in piglet feed can lead to heavy metals (HMs) accumulation in pig manure (PM). Composting is crucial for recycling biowaste and decreasing HMs bioavailability. This study aimed to investigate the impact of adding wine grape pomace (WGP) on the bioavailability of HMs during PM composting. WGP facilitated the passivation of HMs through Cytophagales and Saccharibacteria_genera_incertae_sedis which promoted the formation of humic acid (HA). Polysaccharide and aliphatic groups in HA dominated the transformation of chemical forms of HMs. Moreover, adding 60% and 40% WGP enhanced the Cu and Zn passivation effects by 47.24% and 25.82%, respectively. Polyphenol conversion rate and core bacteria were identified as key factors in affecting HMs passivation. These results offered new insights into the fate of HMs during PM composting in response to the addition of WGP, which is helpful to practical application of WGP to inactivate HMs for improving compost quality.

A Review on Remediation of Iron Ore Mine Tailings via Organic Amendments Coupled with Phytoremediation

Mining operations degrade natural ecosystems by generating a large quantity of mine tailings. Mine tailings remain in dams/open ponds without further treatment after valuable metals such as iron ore have been extracted. Therefore, rehabilitation of tailings to mitigate the negative environmental impacts is of the utmost necessity. This review compares existing physical, chemical and amendment-assisted phytoremediation methods in the rehabilitation of mine tailings from the perspective of cost, reliability and durability. After review and discussion, it is concluded that amendment-assisted phytoremediation has received comparatively great attention; however, the selection of an appropriate phytoremediator is the critical step in the process. Moreover, the efficiency of phytoremediation is solely dependent on the amendment type and rate. Further, the application of advanced plant improvement technologies, such as genetically engineered plants produced for this purpose, would be an alternative solution. Further research is needed to determine the suitability of this method for the particular environment.

Antibiotic and heavy metal resistance genes in sewage sludge survive during aerobic composting

Municipal sewage sludge has been generated in increasing amounts with the acceleration of urbanization and economic development. The nutrient rich sewage sludge can be recycled by composting that has a great potential to produce stabilized organic fertilizer and substrate for plant cultivation. However, little is known about the metals, pathogens and antibiotic resistance transfer risks involved in applying the composted sludge in agriculture. We studied changes in and relationships between heavy metal contents, microbial communities, and antibiotic resistance genes (ARGs), heavy metal resistance genes (HMRGs) and mobile genetic elements (MGEs) in aerobic composting of sewage sludge. The contents of most of the analyzed heavy metals were not lower after composting. The bacterial α-diversity was lower, and the community composition was different after composting. Firmicutes were enriched, and Proteobacteria and potential pathogens in the genera Arcobacter and Acinetobacter were depleted in the composted sludge. The differences in bacteria were possibly due to the high temperature phase during the composting which was likely to affect temperature-sensitive bacteria. The number of detected ARGs, HMRGs and MGEs was lower, and the relative abundances of several resistance genes were lower after composting. However, the abundance of seven ARGs and six HMRGs remained on the same level after composting. Co-occurrence analysis of bacterial taxa and the genes suggested that the ARGs may spread via horizontal gene transfer during composting. In summary, even though aerobic composting is effective for managing sewage sludge and to decrease the relative abundance of potential pathogens, ARGs and HMRGs, it might include a potential risk for the dissemination of ARGs in the environment.

Experimental study on the redistribution law of heavy metals in sludge disintegration

Aiming at the problems of large output of excess sludge, difficulty in treatment and disposal, and the potential toxicity of heavy metals restricting its resource utilization, this paper studies the redistribution law of heavy metals in the process of sludge disintegration. The dissertation investigates the distribution law of typical heavy metals such as Cu, Pb, Cd, Zn in the process of microwave and citric acid-microwave cracking sludge under different specific energy and fixed specific energy conditions. The Tessier five-step continuous extraction method was used to extract heavy metals, and the changes in their content and chemical forms were analyzed, which provided certain technical support for the subsequent harmless treatment and resource utilization of excess sludge. The main findings of this paper are as follows: The dissolution rate of heavy metals Cu, Pb, Cd, and Zn increased rapidly during the citric acid-microwave cracking process in the TS specific energy range of 0-45000 kJ/kg, and then gradually tended to be gradual. The maximum dissolution rates of Cu, Pb, Cd, Zn were 8.06%, 16.58%, 14.69%, and 24.11%, respectively. The concentrations of Cu, Pb, Cd, and Zn in the sludge were mainly F4; F3, F4; F2, F3. The proportions of stable states of Cu, Pb, Cd, and Zn in sludge increased to 88.6%, 55.91%, 35.7%, and 31.35%, respectively. When the specific energy was 45000 kJ/kg TS, the concentrations of Pb, Zn, and Cd in the solid phase of the sludge appeared to increase under microwave cracking alone and decrease under the combined action of citric acid and microwave. The concentration of Cu in the solid phase of the sludge increased slightly. The dissolution rates of Pb, Cd, and Zn by microwave alone and citric acid-microwave method were 14.23% and 16.58%, 10.34% and 14.69%, 17.53%, and 24.11%, respectively. The dissolution rates of Cu by both methods were lower. The steady state ratios of Pb and Zn in the citric acid-microwave method increased to 55.91% and 31.25%, respectively; the steady state ratio of Cd in the microwave alone method increased to 39.51%; both methods had no significant effect on the stability of Cu.

Total petroleum hydrocarbons and influencing factors in co-composting of rural sewage sludge and organic solid wastes

Co-composting is an efficient strategy for collaborative disposal of multiple organic wastes in rural areas. In this study, we explored the co-composting of rural sewage sludge and other organic solid wastes (corn stalks and kitchen waste), with a focus on the variation of total petroleum hydrocarbons (TPH) during this process. 12% corn-derived biochar was applied in the composting (BC), with no additives applied as the control treatment (CK). The TPH contents of piles after composting ranged from 0.70 to 0.74 mg/g, with overall removal efficiencies of 35.6% and 61.1% for CK and BC, respectively. The results indicate that the addition of 12% biochar increased the rate of TPH degradation and accelerated the degradation process. 16s rDNA high-throughput sequencing was applied to investigate the biodiversity and bacterial community succession during the composting process. Diverse bacterial communities with TPH degradation functions were observed in the composting process, including Acinetobacter, Flavobacterium, Paenibacillus, Pseudomonas, and Bacillus spp. These functional bacteria synergistically degraded TPH, with cooperative behavior dominating during composting. Biochar amendment enhanced the microbial activity and effectively promoted the biodegradation of TPH. The physicochemical properties of the compost piles, including environmental factors (pH and temperature), nutrients (nitrogen, phosphorus, potassium), and humic substances produced in composting (humic acids and fulvic acids), directly and indirectly affected the variation in TPH contents. In conclusion, this work illustrates the variation in TPH content and associated influencing factors during co-composting of rural organic solid wastes, providing valuable guidance toward the further optimization of rural organic waste management.

Performance assessment of in-vessel composter through heavy metal immobilization and humification of Parthenium hysterophorus

The bioconversion of Parthenium hysterophorus was performed through rotary drum composter and examined the mechanism of humification and heavy metals immobilization in the process. The 20th day compost contains a significant increase in humic substances of 28.7% compared to the initial day mix. The bioavailable fractions of heavy metals have reduced by 30 to 55% in the 20th day compost compared to the initial day mix. The leaching potential of cadmium has been reduced by 69% in the 20th day compost. The immobile fractions (F5) of Cd, Ni and Pb have been increased to 100, 99 and 78% in the 20th day compost. The mitotic index was increased by 1.7 and 51.6% in 25% dosed compost extract compared to the control and P. hysterophorus extract respectively. The transition of heavy metals to immobile fraction indicated the biodegradation capability of P. hysterophorus through rotary drum composting.

Succession and change of potential pathogens in the co-composting of rural sewage sludge and food waste

Composting is an effective way to prevent and control the spread of pathogenic microorganisms which could put potential risk to humans and environment, from rural solid waste, especially sewage sludge and food waste. In the study, we aim to analyze the changes of pathogenic bacteria during the co-composting of rural sewage sludge and food waste. The results showed that only 27 pathogenic bacteria were detected after composting, compared to 50 pathogenic bacteria in the raw mixed pile. About 74% of pathogen concentrations dropped below 1000 copies/g after composting. Lactobacillus, Bacillus, Paenibacillus and Comamonas were the core pathogenic bacteria in the compost, of which concentrations were all significantly lower than that in the raw mixed pile at the end of composting. The concentration of Lactobacillus decreased to 3.03 × 10³ copies/g compared to 0 d with 1.25 × 10⁹ copies/g by the end of the composting, while that of Bacillus, Paenibacillus and Comamonas decreased to 2.77 × 10⁴ copies/g, 2.13 × 10⁴ copies/g and 3.38 × 10² copies/g, respectively, with 1.26 × 10⁷ copies/g, 4.71 × 10⁶ copies/g, 1.69 × 10⁸ copies/g on 0 d. Redundancy analysis (RDA) indicated that physicochemical factors and substances could affect the changes of pathogenic bacteria during composting, while temperature was the key influencing factor. In addition, certain potential pathogenic bacteria, such as Bacteroides-Bifidobacterium, show statistically strong and significant co-occurrence during composting, which may increase the risk of multiple infections and also influence their distribution. These findings provide a theoretical reference for biosafety prevention and control in the treatment and disposal of rural solid waste.

Immobilization of Zn and Cu in Conditions of Reduced C/N Ratio during Sewage Sludge Composting Process

In this paper we present results of research on the transformation of chemical forms of two elements (Cu, Zn) that occurred at the highest concentration in sewage sludge being processed in a composting process. The factor that had impact on the direction of the observed transformation was the amount of straw added to the mix with sewage sludge at the batch preparation stage including elimination of an additional source of organic carbon (straw). The analysis of contents of Cu and Zn chemical forms was performed applying Tessiere’s methodology. It was ascertained that reduction of supplementation has positive impact on the allocation of tested elements in organic (IV) and residual (V) fractions with a simultaneous decrease of heavy metals mobile forms share in bioavailable fractions, mostly ion exchangeable (I) and carbonate (II). Using an artificial neural network (ANN), a tool was developed to classify composts based on Austrian standards taking into account only I ÷ IV fractions treated as a labile, potentially bioavailable, part of heavy metals bound in various chemical forms in compost. The independent variables that were predictors in the ANN model were the composting time, C/N, and total content of the given element (total Cu, Zn). The sensitivity coefficients for three applied predictors varied around 1, which proves their significant impact on the final result. Correctness of the predictions of the generated network featuring an MLP 3-5-3 structure for the test set was 100%.