Separation and purification of phenolic compounds from pomegranate juice by ultrafiltration and nanofiltration membranes

Membrane Separations in Biomass Processing

The development of integrated biorefineries and the greater utilization of biomass resources to reduce dependence on fossil fuel-derived products require research emphasis not just on conversion strategies but also on improving separations associated with biorefining. A significant roadblock towards developing biorefineries is the lack of effective separation techniques evidenced by the relative deficiency of literature in this area. Additionally, high conversion yields may only be realized if effective separations generate feedstock of sufficient purity - this makes research into biomass conversion strategies all the more critical. In this review, the challenges associated with biomass separations are discussed, followed by an overview of the most appropriate separation strategies for processing biomass. One of the unit operations most appealing for biorefining, membrane separations (MS), is then considered along with a review of the recent literature utilizing this technique in biomass processing.

The Operational Performance of an Ultrafiltration Pilot Unit for the Treatment of Ultra-Concentrated Brines

The valorization of ultra-concentrated seawater brines, named bitterns, requires preliminary purification processes, such as membrane filtration, before they can be fully exploited. This study investigates the performance of an ultrafiltration pilot plant aimed at separating organic matter and large particles from real bitterns. An empirical model for the bittern viscosity was developed to better characterize the membrane. Distinct variations in permeability, fouling resistance and rejection coefficient were observed under operational pressures ranging from 2 to 4 bar. Working at low pressure (2 bar), the pilot plant achieves permeability and rejection coefficient values of 17 L/m2hbar and 95%, respectively. Foulant behavior was characterized by determining a "fouling resistance", obtaining an average value of 1013 m-1. Tests with three distinct bittern samples were conducted to assess the influence of chemical composition and organic matter content on membrane permeability and fouling characteristics. The collected data enabled a comprehensive characterization of the ultrafiltration pilot unit working with this particular saline feed solution, which has very high technical-economic potential.

Concentrating Cocoa Polyphenols-Clarification of an Aqueous Cocoa Extract by Protein Precipitation and Filtration

The seeds of Theobroma cacao L. are rich in antioxidant flavonoids such as flavan-3-ols, which are valued for their health benefits. In this context, it is of interest to improve flavanol content in cocoa extracts. The present study aimed at improving the clarification process of an aqueous cocoa extract using protein precipitation and filtration. Five pH modifications and two bentonite amounts were tested for their effects on protein precipitation and flavanol content. Micro- and ultrafiltration as a subsequent step was done by testing three different ceramic membranes (30, 80, and 200 nm). Lower pH in pre-treatment reduced protein content and kept flavanols constant, while at higher pH, flavanols were reduced up to 40%. Larger membrane pores enhanced polyphenol permeation, while smaller pores limited protein permeation. Adjusting pH to the isoelectric point increased protein adsorption, improving filtration quality despite decreased permeate flux. However, membrane fouling results in higher permeate quality due to increased selectivity. Furthermore, the addition of bentonite during filtration reduced both protein and flavanol content in the permeate, similar to the effects seen in the pre-treatment of the supernatant. Optimizing pH and membrane pore size enhances the recovery and quality of polyphenols during filtration, balancing protein removal and flavanol retention.

Sweet sorghum juice clarification and concentration: a review

Sweet sorghum is a promising biomaterial, considering its nutritional and energy value, unpretentiousness in cultivation and its promising economic parameters of processing. The concentrate of sweet sorghum juice is an outstanding material for food purposes, meeting the emerging trends of the industry. This review presents data on the physicochemical properties of sweet sorghum juice and sirup, as well as technological details on the processes of its pretreatment, clarification, and concentration. Physicochemical properties of raw juice of sweet sorghum, as well as purified juice and sirup, are discussed in terms of material pretreatment, methods of clarification and concentration, and storage conditions. Comprehensive theoretical principles, methodological details and explanations of the consistency of sweet sorghum juice processing are given. This work focuses entirely on the relationship between sweet sorghum juice treatment methods and its composition and provides versatile source of information for food science community, farmers, and entrepreneurs.

Polyphenol-Rich Extracts from Agroindustrial Waste and Byproducts: Results and Perspectives According to the Green Chemistry and Circular Economy

Polyphenols are natural secondary metabolites found in plants endowed with multiple biological activities (antioxidant, anti-inflammatory, antimicrobial, cardioprotective, and anticancer). In view of these properties, they find many applications and are used as active ingredients in nutraceutical, food, pharmaceutical, and cosmetic formulations. In accordance with green chemistry and circular economy strategies, they can also be recovered from agroindustrial waste and reused in various sectors, promoting sustainable processes. This review described structural characteristics, methods for extraction, biological properties, and applications of polyphenolic extracts obtained from two selected plant materials of the Mediterranean area as olive (Olea europaea L.) and pomegranate (Punica granatum L.) based on recent literature, highlighting future research perspectives.

Green Separation by Using Nanofiltration of Tristerix tetrandus Fruits and Identification of Its Bioactive Molecules through MS/MS Spectrometry

Membrane technology allows the separation of active compounds, providing an alternative to conventional methods such as column chromatography, liquid-liquid extraction, and solid-liquid extraction. The nanofiltration of a Muérdago (Tristerix tetrandus Mart.) fruit juice was realized to recover valuable metabolites using three different membranes (DL, NFW, and NDX (molecular weight cut-offs (MWCOs): 150~300, 300~500, and 500~700 Da, respectively)). The metabolites were identified by ESI-MS/MS. The results showed that the target compounds were effectively fractionated according to their different molecular weights (MWs). The tested membranes showed retention percentages (RPs) of up to 100% for several phenolics. However, lower RPs appeared in the case of coumaric acid (84.51 ± 6.43% (DL), 2.64 ± 2.21% (NFW), 51.95 ± 1.23% (NDX)) and some other phenolics. The RPs observed for the phenolics cryptochlorogenic acid and chlorogenic acid were 99.74 ± 0.21 and 99.91 ± 0.01% (DL membrane), 96.85 ± 0.83 and 99.20 ± 0.05% (NFW membrane), and 92.98 ± 2.34 and 98.65 ± 0.00% (NDX membrane), respectively. The phenolic quantification was realized by UHPLC-ESI-MS/MS. The DL membrane allowed the permeation of amino acids with the MW range of about 300~100 Da (aspartic acid, proline, tryptophan). This membrane allowed the highest permeate flux (22.10-27.73 L/m2h), followed by the membranes NDX (16.44-20.82 L/m2h) and NFW (12.40-14.45 L/m2h). Moreover, the DL membrane allowed the highest recovery of total compounds in the permeate during the concentration process (19.33%), followed by the membranes NFW (16.28%) and NDX (14.02%). Permeate fractions containing phenolics and amino acids were identified in the membrane permeates DL (10 metabolites identified), NFW (13 metabolites identified), and NDX (10 metabolites identified). Particularly, tryptophan was identified only in the DL permeate fractions obtained. Leucine and isoleucine were identified only in the NFW permeate fractions, whereas methionine and arginine were identified only in the NDX ones. Liquid permeates of great interest to the food and pharmaceutical industries were obtained from plant resources and are suitable for future process optimization and scale-up.

One-step enrichment of phenolics from Chaenomeles speciosa (Sweet) Nakai fruit using macroporous resin: Adsorption/desorption characteristics, process optimization and UPLC-QqQ-MS/MS-based quantification

Chaenomeles speciosa (Sweet) Nakai fruit is a good source of phenolics with many health benefits. In this work, the enrichment of C. speciosa fruit total phenolics (CSFTP) using macroporous resins was studied. NKA-Ⅱ resin was selected for enriching CSFTP due to its highest adsorption/desorption quantity. Adsorption characteristics of CSFTP on NKA-Ⅱ resin exhibited a good fit with the Langmuir isotherm model and pseudo-second order kinetics model. This adsorption was spontaneous, exothermic, and entropy-decreasing through a physisorption mechanism. The breakthrough-elution curves were studied to optimize CSFTP enrichment conditions. One-step enrichment increased CSFTP content in the extracts from 26.51 % to 78.63 %, with a recovery of 81.03 %. A UPLC-QqQ-MS/MS method in multiple reaction monitoring (MRM) mode was established and validated for the simultaneous quantification of seven phenolic compounds. This study demonstrates the feasibility of industrial enrichment of CSFTP using NKA-Ⅱ resin and proposes a reliable method for quality control of CSFTP-rich products.

Pomegranate (Punica granatum L.) and its phytochemicals as anxiolytic; an underreported effect with therapeutic potential: A systematic review

Anxiety is a mental disorder characterized by excessive concern about possible future threats that, if prolonged, becomes a pathology that must be controlled through psychotherapy and medication. Currently, the pharmacological treatment for anxiety involves the use of antidepressants and benzodiazepines; however, these treatments often come with adverse effects. Thus, there is a need to seek natural compounds that can help alleviate anxiety and reduce these side effects. On the other hand, pomegranate (PG) fruit is known to have important health benefits, which have been compiled in several reviews. However, its anxiolytic effect has not been thoroughly studied, and clinical research on this topic is lacking. The aim of this work was to conduct a systematic review of studies exploring the anxiolytic-like effect of PG and its phytochemicals. Databases such as Pubmed, ScienceDirect, Springer link, Google scholar, Worldwide science, and Web of science were searched for articles using predetermined terms. Inclusion criteria were established, and original articles that met these criteria were selected. The data collected included information on PG part and variety, species, sample size, anxiety model, dose, route and time of administration, reference drug, main results, and the mechanisms of action. Fifty-nine studies were found that reported the anxiolytic-like effect of PG and its phytochemicals such as anthocyanins, flavonoids, tannins, organic acids, and xanthonoids. The literature suggests that the mechanisms of action behind this effect involved the inhibition of the GABAergic receptor, NMDA, CaMKII/CREB pathway; the reduction of oxidative stress, inhibiting TLR4 and nNOS; modulation of cytokines and the expression of NFkB, GAD67, and iNOS, as well as the activation of Nrf2 and AMPK. PG and some of its phytochemicals could be considered as a novel alternative for the treatment of pathological anxiety. This review is the first to document the anxiolytic-like effect of PG.

Application of Ultrafiltration for Recovery of Polyphenols from Rose Petal Byproduct

One main objective of this study was to increase the utilization of raw material in the rose (Rosa damascena Mill.) essential oil industry by the application of membrane technologies. In this research, distilled (dearomatized) rose petals, the primary byproduct in essential oil production, were subjected to an enzyme-assisted extraction and subsequent membrane separation for partial concentration at different levels using UF1-PAN and UF10-PAN membranes. The results show that the permeate flux decreased with a rise in volume reduction ratio and increased with a rise in transmembrane pressure and feed flow rate. At the beginning of the process, the highest flux was with the UF1-PAN membrane, but at the end of the process, it was with the UF10-PAN membrane. Total polyphenols of the retentates increased by 27-39% and 26-67% during ultrafiltration with the UF1-PAN and UF10-PAN membranes, respectively, with the highest value obtained for the UF10-PAN membrane at VRR 6. The highest concentration factor and rejection of total solids, total polyphenols, redox-active antioxidants, and radical scavenging antioxidants were obtained at VRR 6 with the UF10-PAN membrane. The use of green technology based on enzyme-assisted extraction and ultrafiltration for recovery and concentration of polyphenols from rose petal byproduct solves practical environmental problems for the treatment and utilization of byproducts from the rose oil industry. The retentate obtained could be used in the food production, cosmetic, and pharmaceutical industries.

Application of Emerging Techniques in Reduction of the Sugar Content of Fruit Juice: Current Challenges and Future Perspectives

In light of the growing interest in products with reduced sugar content, there is a need to consider reducing the natural sugar concentration in juices while preserving the initial concentration of nutritional compounds. This paper reviewed the current state of knowledge related to mixing juices, membrane processes, and enzymatic processes in producing fruit juices with reduced concentrations of sugars. The limitations and challenges of these methods are also reviewed, including the losses of nutritional ingredients in membrane processes and the emergence of side products in enzymatic processes. As the existing methods have limitations, the review also identifies areas that require further improvements and technological innovations.

Incorporation of Functionalized Halloysite Nanotubes (HNTs) into Thin-Film Nanocomposite (TFN) Nanofiltration Membranes for Water Softening

Incorporating nanoparticles (NPs) into the selective layer of thin-film composite (TFC) membranes is a common approach to improve the performance of the resulting thin-film nanocomposite (TFN) membranes. The main challenge in this approach is the leaching out of NPs during membrane operation. Halloysite nanotubes (HNTs) modified with the first generation of poly(amidoamine) (PAMAM) dendrimers (G1) have shown excellent stability in the PA layer of TFN reverse-osmosis (RO) membranes. This study explores, for the first time, using these NPs to improve the properties of TFN nanofiltration (NF) membranes. Membrane performance was evaluated in a cross-flow nanofiltration (NF) system using 3000 ppm aqueous solutions of MgCl₂, Na₂SO₄ and NaCl, respectively, as feed at 10 bar and ambient temperature. All membranes showed high rejection of Na₂SO₄ (around 97-98%) and low NaCl rejection, with the corresponding water fluxes greater than 100 L m^-2 h^-1. The rejection of MgCl₂ (ranging from 82 to 90%) was less than that for Na₂SO₄. However, our values are much greater than those reported in the literature for other TFN membranes. The remarkable rejection of MgCl₂ is attributed to positively charged HNT-G1 nanoparticles incorporated in the selective polyamide (PA) layer of the TFN membranes.

The Temperature Influence on Drying Kinetics and Physico-Chemical Properties of Pomegranate Peels and Seeds

Pomegranate is a fruit desirable for its nutritional and medicinal properties which has a great industrial potential that is yet under-explored. Notable for its integral use, the peels are used in medicinal infusions and the seeds consumed without restrictions. In this sense, the objective of this work is to determine the drying kinetics of pomegranate peels and seeds in a hot air circulation oven, at temperatures of 50, 60, and 70 °C, adjust mathematical models to experimental data, determine the effective diffusivities and thermodynamic properties of the process and the physicochemical characteristics of peels and seeds of fresh pomegranates and in their flours. Twelve models were used to adjust the drying kinetics, obtaining better results with the Diffusion Approximation model, Verma, and modified Henderson and Pabis. The effective diffusivities were well represented by an Arrhenius equation, with activation energies of 31.39 kJ/mol for seeds and 10.60 kJ/mol for peels. In the drying process, the seeds showed higher values of enthalpy, entropy, and Gibbs free energy concerning peels. Pomegranate peel and seed flours have proximal composition and distinct physicochemical characteristics, with high fiber, carbohydrate, and energy content. In addition, peel flours stand out for their mineral content, and seed flours do for their lipid and protein content.

Effect of Acetone as Co-Solvent on Fabrication of Polyacrylonitrile Ultrafiltration Membranes by Non-Solvent Induced Phase Separation

For the first time, the presence of acetone in the casting solutions of polyacrylonitrile (PAN) in dimethylsulfoxide or N-methyl-2-pyrrolidone was studied with regards to thermodynamical aspects of phase separation of polymeric solutions induced by contact with non-solvent (water), formation and performance of porous membranes of ultrafiltration range. The positions of the liquid equilibrium binodals on the phase diagrams of these three-component and pseudo-three-component mixtures were determined. For PAN-N-methyl-2-pyrrolidone-water glass transition curve on a ternary phase diagram was plotted experimentally for the first time. The real-time evolution of the structure of mixtures of PAN with solvents (co-solvents) upon contact with a non-solvent (water) has been studied. The thermodynamic analysis of the phase diagrams of these mixtures, together with optical data, made it possible to propose a mechanism of structure formation during non-solvent induced phase separation of different mixtures. The addition of acetone promotes the formation of a spongy layer on the membrane surface, which decreases the probability of defect formation on the membrane surface and keeps finger-like macrovoids from the underlying layers of the membrane. It was shown that the molecular weight cut-off (MWCO) of the membranes can be improved from 58 down to 1.8 kg/mol by changing the acetone content, while polymer concentration remained the same.

Concentration of Polyphenolic Antioxidants in Apple Juice and Extract Using Ultrafiltration

The aim of the present work was to study the potential of ultrafiltration with three polyacrylonitrile membranes (1, 10, and 25 kDa) to concentrate polyphenolic antioxidants in apple juice and extract. The permeate flux, total polyphenols, polyphenolic profile, phenolic acid content, and total antioxidant capacity were determined using the FRAP and DPPH tests, the content of water-soluble proteins during ultrafiltration was established, and the concentration factors and rejections were determined. The permeate flux decreased by increasing the volume reduction ratio and decreasing the molecular weight cut-off of the membranes. The concentration factor and rejection of polyphenolics increased with the increase in the volume reduction ratio (VRR) for all membranes and both liquids. The concentration and rejection effectiveness of the 1 kDa membrane was higher than those observed for 10 and 25 kDa during the ultrafiltration of the apple extract, while these values were comparable for 1 and 10 kDa during the ultrafiltration of the apple juice. The concentration factors and rejections of total polyphenols were higher in the extract than in the juice. Chlorogenic acid was the main compound in the polyphenol profile of apple juice. The total content of phenolic acids, determined by using HPLC, increased by 15-20% as a result of the membrane concentration, but the separation process did not significantly change the ratio between the individual compounds.

Partial Removal of Sugar from Apple Juice by Nanofiltration and Discontinuous Diafiltration

Partial removal of sugars in fruit juices without compromising their biofunctional properties represents a significant technological challenge. The current study was aimed at evaluating the separation of sugars from phenolic compounds in apple juice by using three different spiral-wound nanofiltration (NF) membranes with a molecular weight cut-off (MWCO) in the range of 200–500 Da. A combination of diafiltration and batch concentration processes was investigated to produce apple juice with reduced sugar content and improved health properties thanks to the preservation and concentration of phenolic compounds. For all selected membranes, permeate flux and recovery rate of glucose, fructose, and phenolic compounds, in both diafiltration and concentration processes, were evaluated. The concentration factor of target compounds as a function of the volume reduction factor (VRF) as well as the amount of adsorbed compound on the membrane surface from mass balance analysis were also evaluated. Among the investigated membranes a thin-film composite membrane with an MWCO of 200–300 Da provided the best results in terms of the preservation of phenolic compounds in the selected operating conditions. More than 70% of phenolic compounds were recovered in the retentate stream while the content of sugars was reduced by about 60%.

New Hybrid Nanofiltration Membranes with Enhanced Flux and Separation Performances Based on Polyphenylene Ether-Ether-Sulfone/Polyacrylonitrile/SBA-15

This study presents the preparation of hybrid nanofiltration membranes based on poly(1,4-phenylene ether ether sulfone), polyacrylonitrile, poly(vinyl pyrrolidone), and SBA-15 mesoporous silica. Laser treatment of polymeric solutions to enhance the hydrophilicity and performance of membranes was investigated. The membranes’ structure was characterized using scanning electron (SEM) and atomic force (AFM) microscopy and contact angle measurements. The addition of PAN in the casting solution produced significant changes in the membrane structure, from finger-like porous structures to sponge-like porous structures. Increased PAN concentration in the membrane composition enhanced the hydrophilicity of the membrane surface, which also accounted for the improvement in the antifouling capabilities. The permeation of apple pomace extract and the content of polyphenols and flavonoids were used to evaluate the efficacy of the hybrid membranes created. The results showed that the hybrid nanofiltration membranes based on PPEES/PAN/PVP/SBA-15: 15/5/1/1 and 17/3/1/1 exposed to laser for 5 min present a higher rejection coefficient to total polyphenols (78.6 ± 0.7% and 97.8 ± 0.9%, respectively) and flavonoids (28.7 ± 0.2% and 50.3 ± 0.4%, respectively) and are substantially better than a commercial membrane with MWCO 1000 Da or PPEES-PVP-based membrane.

Recovery of Natural Polyphenols from Spinach and Orange By-Products by Pressure-Driven Membrane Processes

Spinach and orange by-products are well recognized for their health benefits due to the presence of natural polyphenols with antioxidant activity. Therefore, the demand to produce functional products containing polyphenols recovered from vegetables and fruits has increased in the last decade. This work aims to use the integrated membrane process for the recovery of polyphenols from spinach and orange wastes, implemented on a laboratory scale. The clarification (microfiltration and ultrafiltration, i.e., MF and UF), pre-concentration (nanofiltration, NF), and concentration (reverse osmosis, RO) of the spinach and orange extracts were performed using membrane technology. Membrane experiments were carried out by collecting 1 mL of the permeate stream after increasing the flow rate in 1 mL/min steps. The separation and concentration factors were determined by HPLC-DAD in terms of total polyphenol content and by polyphenol families: hydroxybenzoic acids, hydroxycinnamic acids, and flavonoids. The results show that the transmembrane flux depended on the feed flow rate for MF, UF, NF, and RO techniques. For the spinach and orange matrices, MF (0.22 µm) could be used to remove suspended solids; UF membranes (30 kDa) for clarification; NF membranes (TFCS) to pre-concentrate; and RO membranes (XLE for spinach and BW30 for orange) to concentrate. A treatment sequence is proposed for the two extracts using a selective membrane train (UF, NF, and RO) to obtain polyphenol-rich streams for food, pharmaceutical, and cosmetic applications, and also to recover clean water streams.

Membrane-based Operations for the Fractionation of Polyphenols and Polysaccharides From Winery Sludges

The present work investigated the impact of ultrafiltration (UF) and nanofiltration (NF) membranes on the recovery and fractionation of polyphenolic compounds and polysaccharides from Sangiovese and Cabernet Sauvignon wine lees. A laboratory-made flat-sheet membrane in cellulose acetate (CA400-38) was used in the UF treatment of Sangiovese wine lees; three laboratory-made flat-sheet membranes in cellulose acetate (CA316, CA316-70, CA400-22) and a polyamide commercial membrane (NF90) were used in the NF treatment of Cabernet Sauvignon wine lees. All membranes were characterized in terms of hydraulic permeability and rejection toward references solutes; the performances of the membranes were measured in terms of productivity, fouling index, cleaning efficiency and retention toward target compounds.

Experimental results indicated that all UF and NF membranes were effective in separating target compounds rejecting more than 92% of polysaccharides with polyphenols preferentially permeating through the membrane. The UF membrane rejected more than 40% of total polyphenols; rejections toward non-flavonoids and flavonoids were less than 25% and 12.5%, respectively.

The laboratory-made NF membranes exhibited higher permeate flux values (of the order of 11–12 L/m2h) in comparison with the commercial NF membrane, despite the observed differences in the retention of specific solutes. Among the prepared membranes the CA316 showed a total rejection toward most part of non-flavonoids and flavonoids.

The experimental results support the use of UF and NF processes in a sequential design to fractionate and refine phenolic compounds from winery sludge for the production of concentrated fractions with high antioxidant activities.

Study on the cross-flow ultrafiltration of mixtures of macromolecular organic and inorganic salts

Ultrafiltration (UF) has been widely applied to water treatment in the past few decades, but severe membrane fouling is one of the most significant obstacles for its further development. In reality, the constituents of feed water are complex, and the fouling behavior could be different from that induced by a single foulant. In this study, the membrane fouling induced by mixed organic foulant (sodium alginate, SA) and inorganic ions under various conditions were investigated. The effects of ion concentration and valence on the combined fouling as well as the rejection performance were examined. The results showed that compared to SA alone, the presence of inorganic ions could aggravate the organic fouling of UF membranes significantly. The fouling became more severe as the ion concentration increased. Also, ions with higher valence tended to exacerbate the fouling compared with monovalent ions. It was also found that the existence of inorganic ions had negligible effects on the rejection of organic molecules, however, the rejection of salts can be improved because of the organic matter. In addition, the analysis of the classic fouling models showed that the complete blocking model is the main fouling mechanism of the mixed SA and inorganic salts.

Effects of Gum Arabic Coatings Enriched with Lemongrass Essential Oil and Pomegranate Peel Extract on Quality Maintenance of Pomegranate Whole Fruit and Arils

The effects of gum arabic coatings combined with lemongrass oil and/or pomegranate peel extract on freshly harvested mature 'Wonderful' pomegranate fruit were studied. Fruit were coated with gum arabic (GA) (1.5% w/v) alone or enriched with lemongrass oil (LM) (0.1% v/v) and/or pomegranate peel extract (PP) (1% w/v). Fruit were packed into standard open top ventilated cartons (dimensions: 0.40 m long, 0.30 m wide and 0.12 m high), and stored for 6 weeks at 5 ± 1 °C (90% RH). Evaluations were made every 2 weeks of cold storage and after 5 d of shelf life (20 °C and 65% RH). Fruit coated with GA + PP (4.09%) and GA + PP + LM (4.21%) coatings recorded the least cumulative weight loss compared to the uncoated control (9.87%). After 6 weeks, uncoated control and GA + PP + LM recorded the highest (24.55 mg CO2Kg-1h-1) and lowest (10.76 mg CO2Kg-1h-1) respiration rate, respectively. Coating treatments reduced the incidence of decay and treatments GA + LM + PP and GA + PP recorded the highest total flavonoid content between 2 and 6 weeks of storage. The findings suggest that GA coatings with/without LM and PP can be a beneficial postharvest treatment for 'Wonderful' pomegranates to reduce weight loss and decay development during cold storage.

The bioactivity and applications of pomegranate peel extract: A review

Pomegranate peel (PP) is a by-product in the processing of pomegranate products, which is usually discarded as a waste. However, a large number of researches have shown that pomegranate peel extract (PPE) is rich in a variety of phenolic substances, among which ellagic acid (EA), as one of the main active components, has significant biological activities, such as anti-oxidation, anti-tumor, anti-inflammatory, neuroprotection, anti-viral, and anti-bacterial. We analyzed the mechanism of EA's biological activity, and discussed its application in the food industry, for instance, food preservation, food additives, and functional foods. Combined with the research status of PPE, we discussed the limitations and development potential of PPE, in order to provide theoretical reference and scientific basis for the development and utilization of pomegranate by-products. PRACTICAL APPLICATIONS: Pomegranate peel (PP), the inedible part of the fruit, is usually treated as waste. In recent years, researchers have been committed to exploring various bioactive ingredients in PP and exploring its potential benefits to human health, which has far-reaching significance. In this paper, the chemical constituents of polyphenols in PP were reviewed, mainly focusing on the biological activity and mechanism of ellagic acid (EA). We reviewed the applications and invention patents of pomegranate peel extract (PPE) in food field, including food preservation, food additive, and functional foods, providing reference for the recycling and reuse of PP.

Membrane techniques in the production of beverages

The most important developments in membrane techniques used in the beverage industry are discussed. Particular emphasis is placed on the production of fruit and vegetable juices and nonalcoholic drinks, including beer and wine. This choice was dictated by the observed consumer trends, who increasingly appreciate healthy food and its taste qualities.

Advances and Applications of Hollow Fiber Nanofiltration Membranes: A Review

Hollow fiber nanofiltration (NF) membranes have gained increased attention in recent years, partly driven by the availability of alternatives to polyamide-based dense separation layers. Moreover, the global market for NF has been growing steadily in recent years and is expected to grow even faster. Compared to the traditional spiral-wound configuration, the hollow fiber geometry provides advantages such as low fouling tendencies and effective hydraulic cleaning possibilities. The alternatives to polyamide layers are typically chemically more stable and thus allow operation and cleaning at more extreme conditions. Therefore, these new NF membranes are of interest for use in a variety of applications. In this review, we provide an overview of the applications and emerging opportunities for these membranes. Next to municipal wastewater and drinking water processes, we have put special focus on industrial applications where hollow fiber NF membranes are employed under more strenuous conditions or used to recover specific resources or solutes.

The isolation of water-soluble natural products - challenges, strategies and perspectives

Covering period: up to 2019Water-soluble natural products constitute a relevant group of secondary metabolites notably known for presenting potent biological activities. Examples are aminoglycosides, β-lactam antibiotics, saponins of both terrestrial and marine origin, and marine toxins. Although extensively investigated in the past, particularly during the golden age of antibiotics, hydrophilic fractions have been less scrutinized during the last few decades. This review addresses the possible reasons on why water-soluble metabolites are now under investigated and describes approaches and strategies for the isolation of these natural compounds. It presents examples of several classes of hydrosoluble natural products and how they have been isolated. Novel stationary phases and chromatography techniques are also reviewed, providing a perspective towards a renaissance in the investigation of water-soluble natural products.

Novel perspectives of environmental proteomics

The connection among genome expression, proteome alteration, metabolism regulation and phenotype change under environmental stresses is very vague. It is a tough task for the traditional research approaches to reveal the related scientific mechanisms of the above connection at molecular and systematic levels. Proteomics approach is an insightful tool for revealing the biological functions, metabolic networks and functional protein interaction networks of cells and organisms under stresses at the systematic level. The purpose of this review is to provide an insightful guideline on how to set up a proteomic investigation for revealing biomolecule mechanisms, protein biomarkers and metabolism networks related to stress response, pollutant recognition, transport and biodegradation, and providing an insightful high-throughput approach for screening functional enzymes and effective microbes based on bioinformatics and functional verification method. Furthermore, the toxicity evaluation of pollutants and byproducts by proteomics approaches provides a scientific insight for early diagnosis of ecological risk and determination of the effectiveness of pollutant treatment techniques.

Prediction of Permeate Flux in Ultrafiltration Processes: A Review of Modeling Approaches

In any membrane filtration, the prediction of permeate flux is critical to calculate the membrane surface required, which is an essential parameter for scaling-up, equipment sizing, and cost determination. For this reason, several models based on phenomenological or theoretical derivation (such as gel-polarization, osmotic pressure, resistance-in-series, and fouling models) and non-phenomenological models have been developed and widely used to describe the limiting phenomena as well as to predict the permeate flux. In general, the development of models or their modifications is done for a particular synthetic model solution and membrane system that shows a good capacity of prediction. However, in more complex matrices, such as fruit juices, those models might not have the same performance. In this context, the present work shows a review of different phenomenological and non-phenomenological models for permeate flux prediction in UF, and a comparison, between selected models, of the permeate flux predictive capacity. Selected models were tested with data from our previous work reported for three fruit juices (bergamot, kiwi, and pomegranate) processed in a cross-flow system for 10 h. The validation of each selected model's capacity of prediction was performed through a robust statistical examination, including a residual analysis. The results obtained, within the statistically validated models, showed that phenomenological models present a high variability of prediction (values of R-square in the range of 75.91-99.78%), Mean Absolute Percentage Error (MAPE) in the range of 3.14-51.69, and Root Mean Square Error (RMSE) in the range of 0.22-2.01 among the investigated juices. The non-phenomenological models showed a great capacity to predict permeate flux with R-squares higher than 97% and lower MAPE (0.25-2.03) and RMSE (3.74-28.91). Even though the estimated parameters have no physical meaning and do not shed light into the fundamental mechanistic principles that govern these processes, these results suggest that non-phenomenological models are a useful tool from a practical point of view to predict the permeate flux, under defined operating conditions, in membrane separation processes. However, the phenomenological models are still a proper tool for scaling-up and for an understanding the UF process.

Purification and Identification of Novel Antioxidant Peptides from Enzymatically Hydrolysed Samia ricini Pupae

The emergence of excessive free radicals leads to the destruction of various systems within the body. These free radicals also affect nutritional values, color, taste, and emit an odor akin to rancid food. Most food industries use synthetic antioxidants, such as BHT (butylated hydroxytoluene) or BHA (butylated hydroxy anisole). However, high doses of these can be harmful to our health. Therefore, an antioxidant compounds, such as bioactive peptides from edible animals or plants, have emerged to be a very promising alternative as they reduce potential side effects. This study focused on the purification and identification of antioxidant peptides from protein hydrolysates of wild silkworm pupae (Samia ricini). Antioxidant peptides were purified from the hydrolysate by ultrafiltration and RP-HPLC. The results showed that protein hydrolysate from S. ricini pupae by trypsin with a molecular weight lower than 3 kDa and highly hydrophobic property, exhibited strong DPPH radical scavenging activity and chelating activity. Further identification of peptides from the fraction with the highest antioxidant activity was carried out using LC-MS/MS. Three novel peptides, i.e., Met-Ley-Ile-Ile-Ile-Met-Arg, Leu-Asn-Lys-Asp-Leu-Met-Arg, and Glu-Asn-Ile-Ile-Leu-Phe-Arg, were identified. The results of this study indicated that the protein hydrolysate from S. ricini pupae possessed potent biological activity, and the novel antioxidant peptides could be utilized to develop health-related antioxidants in food industry.

Advances in laccase-triggered anabolism for biotechnology applications

This is the first comprehensive overview of laccase-triggered anabolism from fundamental theory to biotechnology applications. Laccase is a typical biological oxidordeuctase that induces the one-electronic transfer of diverse substrates for engendering four phenoxy radicals with concomitant reduction of O₂ into 2H₂O. In vivo, laccase can participate in anabolic processes to create multifarious functional biopolymers such as fungal pigments, plant lignins, and insect cuticles, using mono/polyphenols and their derivatives as enzymatic substrates, and is thus conducive to biological tissue morphogenesis and global carbon storage. Exhilaratingly, fungal laccase has high redox potential (E° = 500-800 mV) and thermodynamic efficiency, making it a remarkable candidate for utilization as a versatile catalyst in the green and circular economy. This review elaborates the anabolic mechanisms of laccase in initiating the polymerization of natural phenolic compounds and their derivatives in vivo via radical-based self/cross-coupling. Information is also presented on laccase immobilization engineering that expands the practical application ranges of laccase in biotechnology by improving the enzymatic catalytic activity, stability, and reuse rate. Particularly, advances in biotechnology applications in vitro through fungal laccase-triggered macromolecular biosynthesis may provide a key research direction beneficial to the rational design of green chemistry.

Identification of Anthocyanins and Their Fouling Mechanisms during Non-Thermal Nanofiltration of Blueberry Aqueous Extracts

Organic fouling in the nanofiltration (NF) process, which is a non-thermal technology to recover active components, is a critical problem limiting its applications. This study seeks to identify the anthocyanins on the NF membrane and explore their fouling mechanisms during concentration of blueberry extracts. Seven kinds of monomeric anthocyanins in foulants-delphinidin-3-O-galactoside, delphinidin-3-O-glucoside, delphinidin-3-O-arabinoside, cyanidin-3-O-galactoside, petunidin-3-O-galactoside, peonidin-3-O-glucoside, and malvidin-3-O-glucoside-were identified. Moreover, chalcone, myricetin derivative, and an unknown substance with [M⁺H]⁺ at m/z 261.1309, which is the fragment ion corresponding to the break of glycoside bond of anthocyanins, were obtained. Interactions between anthocyanins and membrane made from polyamide were principally governed by the CH-π and π-π stacking of aromatic rings, the establishment of hydrogen bonds, and electrostatic interaction. This study will be helpful to further control fouling and choice of cleaning agents in concentration of anthocyanins-rich extracts.

Recovery of Bioactive Compounds from Pomegranate (Punica granatum L.) Peel Using Pressurized Liquid Extraction

Pressurized liquid extraction (PLE) is a clean and environmentally friendly alternative for the recovery of bioactive compounds from fruit by-products. Herein we focused on PLE for the extraction of bioactive compounds from pomegranate peel using a combination of pressurized water and ethanol. The main aim was to determine the optimal PLE conditions, i.e., ethanol percentage and process temperature, to obtain a pomegranate peel extract (PPE) with maximum total phenolic content (TPC), punicalagin content, and antimicrobial activity (AMA). The experimental design was conducted using a central composite design with axial points. Response surface methodology was applied to optimize the response variables using the desirability function. Multiple response optimization indicated a process temperature of 200 °C and ethanol of 77% as optimal conditions. The TPC and the punicalagin content of PPE-PLE obtained under optimal conditions were 164.3 ± 10.7 mg GAE/g DW and 17 ± 3.6 mg/g DW, respectively. Our findings support the efficacy of PLE on TPC recovery but not in punicalagin recovery. The AMA against S. aureus was 14 mm. The efficacy of PPE-PLE in food applications must continue to be studied in order to achieve adequate information on its potential for developing new food additives.

Effect of Pectinolytic Enzyme Pretreatment on the Clarification of Cranberry Juice by Ultrafiltration

Cranberries, mainly processed as juice, have garnered interest over the past decade due to their high content of phytochemical compounds related to promising health benefits. To meet consumer expectations, a juice clarification step is usually incorporated to remove suspended solids. The use of pectinolytic enzyme and membrane processes are commonly applied to the production of clarified juices, but no studies have been done on cranberry juice. In this study, the effects of 60 (D60) and 120 min (D120) of depectinization by pectinolytic enzymes coupled to clarification by ultrafiltration (UF) (membrane molecular weight cut-off (MWCO) of 50, 100 and 500 kDa) was evaluated on the filtration performance, membrane fouling and cranberry juice composition. Compared to fresh juice, depectinization for 60 and 120 min reduced the UF duration by 16.7 and 20 min, respectively. The best filtration performance, in terms of permeate fluxes, was obtained with the 500 kDa MWCO UF membrane despite the highest total flux decline (41.5 to 57.6%). The fouling layer at the membrane surface was composed of polyphenols and anthocyanins. Compared to fresh juice, anthocyanin decreased (44% and 58% for D60 and D120, respectively) in depectinized juices whereas proanthocyanidin (PAC) content increased by 16%. In view of the industrial application, a 60 min depectinization coupled to clarification by a 500 kDa UF membrane could be viewed as a good compromise between the enhancement of filtration performance and the loss of polyphenols and their fouling at the membrane surface.

Recovery of Phenolic Compounds from Red Grape Pomace Extract through Nanofiltration Membranes

The winemaking process generates a large amount of residues such as vine shots, stalks, grape pomace, and wine lees, which were only recently considered for exploitation of their valuable compounds. The purpose of this work was to investigate the performance of nanofiltration for the recovery of phenolic compounds, with bioactive capacity like antioxidant, from red grape pomace extract. Four membranes were compared in this study-three cellulose acetate (CA series: lab-prepared by phase inversion) and one commercial (NF90). All membranes were characterized for their hydraulic permeability and rejection coefficients to reference solutes like saccharose, glucose, raffinose, polyethylene glycol, sodium chloride, and sodium sulfate. Permeation flowrates and rejection coefficients towards total phenolics content, antioxidant activity, proanthocyanidins, glucose and fructose were measured in the nanofiltration of grape pomace extract using selected operating conditions. Among the investigated membranes, the CA400-22 exhibited the highest permeate flux (50.58 L/m² h at 20 bar and 25 °C), low fouling index (of about 23%), the lowest rejection coefficients towards the reference solutes and the best performance in terms of separation between sugars and phenolic compounds. Indeed, the observed rejections for glucose and fructose were 19% and 12%, respectively. On the other hand, total phenolics content and proanthocyanidins were rejected for 73% and 92%, respectively.