Production, purification, and characterization of human scFv antibodies expressed in Saccharomyces cerevisiae, Pichia pastoris, and Escherichia coli

Novel multimodal cation-exchange membrane for the purification of a single-chain variable fragment from Pichia pastoris supernatant

A novel salt-tolerant cation-exchange membrane, prepared with a multimodal ligand, 2-mercaptopyridine-3-carboxylic acid (MMC-MPCA), was examined for its purification properties in a bind-and-elute mode from the high conductivity supernatant of a Pichia pastoris fermentation producing and secreting a single-chain variable fragment (scFv). If successful, this approach would eliminate the need for a buffer exchange prior to product capture by ion-exchange. Two fed-batch fermentations of Pichia pastoris resulted in fermentation supernatants reaching an scFv titer of 395.0 mg/L and 555.7 mg/L, both with a purity of approximately 83 %. The MMC-MPCA membrane performance was characterized in terms of pH, residence time (RT), scFv load, and scFv concentration to identify the resulting dynamic binding capacity (DBC), yield, and purity achieved under optimal conditions. The MMC-MPCA membrane exhibited the highest DBC of 39.06 mg/mL at pH 5.5, with a residence time of 1 min, while reducing the pH below 5.0 resulted in a significant decrease of the DBC to around 2.5 mg/mL. With almost no diffusional limitations, reducing the RT from 2 to 0.2 min did not negatively impact the DBC of the MMC-MPCA membrane, resulting in a significant improvement in productivity of up to 180 mg/mL/min at 0.2 min RT. Membrane fouling was observed when reusing the membranes at 0.2 and 0.5 min RT, likely due to the enhanced adsorption of impurities on the membrane. Changing the amount of scFv loaded onto the membrane column did not show any changes in yield, instead a 10-20 % loss of scFv was observed, which suggested that some of the produced scFv were fragmented or had aggregated. When performing the purification under the optimized conditions, the resulting purity of the product improved from 83 % to approximately 92-95 %.

A Shiga Toxin B-Subunit-Based Lectibody Boosts T Cell Cytotoxicity towards Gb3-Positive Cancer Cells

Aberrant glycosylation plays a crucial role in tumour progression and invasiveness. Tumour-associated carbohydrate antigens (TACAs) represent a valuable set of targets for immunotherapeutic approaches. The poor immunogenicity of glycan structures, however, requires a more effective and well-directed way of targeting TACAs on the surface of cancer cells than antibodies. The glycosphingolipid globotriaosylceramide (Gb3) is a well-established TACA present in a multitude of cancer types. Its overexpression has been linked to metastasis, invasiveness, and multidrug resistance. In the present study, we propose to use a dimeric fragment of the Shiga toxin B-subunit (StxB) to selectively target Gb3-positive cancer cells in a StxB-scFv UCHT1 lectibody. The lectibody, comprised of a lectin and the UCHT1 antibody fragment, was produced in E. coli and purified via Ni-NTA affinity chromatography. Specificity of the lectibody towards Gb3-positive cancer cell lines and specificity towards the CD3 receptor on T cells, was assessed using flow cytometry. We evaluated the efficacy of the lectibody in redirecting T cell cytotoxicity towards Gb3-overexpressing cancer cells in luciferase-based cytotoxicity in vitro assays. The StxB-scFv UCHT1 lectibody has proven specific for Gb3 and could induce the killing of up to 80% of Gb3-overexpressing cancer cells in haemorrhagic and solid tumours. The lectibody developed in this study, therefore, highlights the potential that lectibodies and lectins in general have for usage in immunotherapeutic approaches to boost the efficacy of established cancer treatments.

Calcium-dependent affinity ligands for the purification of antibody fragments at neutral pH

The emerging formats of antibody fragments for biotherapeutics suffer from inadequate purification methods, delaying the advances of innovative therapies. One of the top therapeutic candidates, the single-chain variable fragment (scFv), requires the development of individual purification protocols dependent on the type of scFv. The available approaches that are based on selective affinity chromatography but do not involve the use of a purification tag, such as Protein L and Protein A chromatography, require acidic elution buffers. These elution conditions can cause the formation of aggregates and thereby greatly compromise the yield, which can be a major problem for scFvs that are generally unstable molecules. Due to the costly and time-consuming production of biological drugs, like antibody fragments, we have engineered novel purification ligands that elute the scFvs in a calcium-dependent manner. The developed ligands are equipped with new, selective binding surfaces and were shown to efficiently elute all captured scFv at neutral pH with the use of a calcium chelator. Further, two of three ligands were proven not to bind to the CDRs of the scFv, indicating potential for use as generic affinity ligands to a range of different scFvs. Multimerization and optimization of the most promising ligand led to a 3-fold increase in binding capacity for the hexamer compared to the monomer, in addition to highly selective and efficient purification of a scFv with >95% purity in a single purification step. This calcium-dependent ligand could revolutionize the scFv industry, greatly facilitating the purification procedure and improving the quality of the final product.

The RESP AI model accelerates the identification of tight-binding antibodies

High-affinity antibodies are often identified through directed evolution, which may require many iterations of mutagenesis and selection to find an optimal candidate. Deep learning techniques hold the potential to accelerate this process but the existing methods cannot provide the confidence interval or uncertainty needed to assess the reliability of the predictions. Here we present a pipeline called RESP for efficient identification of high affinity antibodies. We develop a learned representation trained on over 3 million human B-cell receptor sequences to encode antibody sequences. We then develop a variational Bayesian neural network to perform ordinal regression on a set of the directed evolution sequences binned by off-rate and quantify their likelihood to be tight binders against an antigen. Importantly, this model can assess sequences not present in the directed evolution library and thus greatly expand the search space to uncover the best sequences for experimental evaluation. We demonstrate the power of this pipeline by achieving a 17-fold improvement in the K_D of the PD-L1 antibody Atezolizumab and this success illustrates the potential of RESP in facilitating general antibody development.

Single-Chain Fragment Variable: Recent Progress in Cancer Diagnosis and Therapy

Simple Summary

Recombinant antibody fragments have shown remarkable potential as diagnostic and therapeutic tools in the fight against cancer. The single-chain fragment variable (scFv) that contains the complete antigen-binding domains of a whole antibody, has several advantages such as a high specificity and affinity for antigens, a low immunogenicity, and the proven ability to penetrate tumor tissues and diffuse. This review provides an overview of the current studies on the principle, generation, and applications of scFvs, particularly in the diagnosis and therapy of cancer, and underscores their potential use in clinical trials.

Abstract

Cancer remains a public health problem worldwide. Although conventional therapies have led to some excellent outcomes, some patients fail to respond to treatment, they have few therapeutic alternatives and a poor survival prognosis. Several strategies have been proposed to overcome this issue. The most recent approach is immunotherapy, particularly the use of recombinant antibodies and their derivatives, such as the single-chain fragment variable (scFv) containing the complete antigen-binding domains of a whole antibody that successfully targets tumor cells. This review describes the recent progress made with scFvs as a cancer diagnostic and therapeutic tool, with an emphasis on preclinical approaches and their potential use in clinical trials.

Dopamine D2 and Serotonin 5-HT1A Dimeric Receptor-Binding Monomeric Antibody scFv as a Potential Ligand for Carrying Drugs Targeting Selected Areas of the Brain

Targeted therapy uses multiple ways of ensuring that the drug will be delivered to the desired site. One of these ways is an encapsulation of the drug and functionalization of the surface. Among the many molecules that can perform such a task, the present work focused on the antibodies of single-chain variable fragments (scFvs format). We studied scFv, which specifically recognizes the dopamine D₂ and serotonin 5-HT_1A receptor heteromers. The scFv_D2–5-HT1A protein was analyzed biochemically and biologically, and the obtained results indicated that the antibody is properly folded and non-toxic and can be described as low-immunogenic. It is not only able to bind to the D₂–5-HT_1A receptor heteromer, but it also influences the cAMP signaling pathway and—when surfaced on nanogold particles—it can cross the blood–brain barrier in in vitro models. When administered to mice, it decreased locomotor activity, matching the effect induced by clozapine. Thus, we are strongly convinced that scFvD₂–5-HT_1A, which was a subject of the present investigation, is a promising targeting ligand with the potential for the functionalization of nanocarriers targeting selected areas of the brain.

Targeted Codelivery of Prodigiosin and Simvastatin Using Smart BioMOF: Functionalization by Recombinant Anti-VEGFR1 scFv

Biological metal-organic frameworks (BioMOFs) are hybrid compounds in which metal nodes are linked to biocompatible organic ligands and have potential for medical application. Herein, we developed a novel BioMOF modified with an anti-VEGFR1 scFv antibody (D16F7 scFv). Our BioMOF is co-loaded with a combination of an anticancer compound and a lipid-lowering drug to simultaneously suppress the proliferation, growth rate and metastases of cancer cells in cell culture model system. In particular, Prodigiosin (PG) and Simvastatin (SIM) were co-loaded into the newly synthesized Ca-Gly BioMOF nanoparticles coated with maltose and functionalized with a recombinant maltose binding protein-scFv fragment of anti-VEGFR1 (Ca-Gly-Maltose-D16F7). The nanoformulation, termed PG + SIM-NP-D16F7, has been shown to have strong active targeting behavior towards VEGFR1-overexpresing cancer cells. Moreover, the co-delivery of PG and SIM not only effectively inhibits the proliferation of cancer cells, but also prevents their invasion and metastasis. The PG + SIM-NP-D16F7 nanocarrier exhibited stronger cytotoxic and anti-metastatic effects compared to mono-treatment of free drugs and drug-loaded nanoparticles. Smart co-delivery of PG and SIM on BioMOF nanoparticles had synergistic effects on growth inhibition and prevented cancer cell metastasis. The present nanoplatform can be introduced as a promising tool for chemotherapy compared with mono-treatment and/or non-targeted formulations.

Production of scFv, Fab, and IgG of CR3022 Antibodies Against SARS-CoV-2 Using Silkworm-Baculovirus Expression System

COVID-19, caused by SARS-CoV-2, is currently spreading around the world and causing many casualties. Antibodies against such emerging infectious diseases are one of the important tools for basic viral research and the development of diagnostic and therapeutic agents. CR3022 is a monoclonal antibody against the receptor binding domain (RBD) of the spike protein (S protein) of SARS-CoV found in SARS patients, but it was also shown to have strong affinity for that of SARS-CoV-2. In this study, we produced large amounts of three formats of CR3022 antibodies (scFv, Fab and IgG) with high purity using a silkworm-baculovirus expression vector system. Furthermore, SPR measurements showed that the affinity of those silkworm-produced IgG antibodies to S protein was almost the same as that produced in mammalian expression system. These results indicate that the silkworm-baculovirus expression system is an excellent expression system for emerging infectious diseases that require urgent demand for diagnostic agents and therapeutic agents.

Non-Antibody-Based Binders for the Enrichment of Proteins for Analysis by Mass Spectrometry

There is often a need to isolate proteins from body fluids, such as plasma or serum, prior to further analysis with (targeted) mass spectrometry. Although immunoglobulin or antibody-based binders have been successful in this regard, they possess certain disadvantages, which stimulated the development and validation of alternative, non-antibody-based binders. These binders are based on different protein scaffolds and are often selected and optimized using phage or other display technologies. This review focuses on several non-antibody-based binders in the context of enriching proteins for subsequent liquid chromatography-mass spectrometry (LC-MS) analysis and compares them to antibodies. In addition, we give a brief introduction to approaches for the immobilization of binders. The combination of non-antibody-based binders and targeted mass spectrometry is promising in areas, like regulated bioanalysis of therapeutic proteins or the quantification of biomarkers. However, the rather limited commercial availability of these binders presents a bottleneck that needs to be addressed.

Autoinduction as Means for Optimization of the Heterologous Expression of Recombinant Single-Chain Fv (scFv) Antibodies

The monoclonal antibodies and the recombinant antibody fragments are widely used in the biotechnology studies and in medicine as a powerful therapeutic and diagnostic tool. The most commonly used recombinant antibody fragments are single-chain fragment variable (scFv) because of their small size and minimal immunogenicity while still retaining high-affinity antigen binding. A wide range of expression systems such as bacterial and eukaryotic cell systems enable the sufficient production of scFv antibodies. However, their stable expression in soluble form and correct protein folding are often insufficient. In the present study, we present the autoinduction as a key element of the optimized scheme for heterologous expression of human monoclonal scFv antibodies (clones A1 and A12) in Escherichia coli HB2151, which resulted in two-fold increase of the total protein yield in 24 h.

Predicted N-terminal N-linked glycosylation sites may underlie membrane protein expression patterns in Saccharomyces cerevisiae

N-linked glycosylation is one type of posttranslational modification that proteins undergo during expression. The following describes the effects of N-linked glycosylation on high-level membrane protein expression in yeast with an emphasis on Saccharomyces cerevisiae. N-linked glycosylation is highlighted here as an important consideration when preparing membrane protein gene constructs for expression in S. cerevisiae, which continues to be used as a workhorse in both research and industrial applications. Non-native N-linked glycosylation commonly occurs during the heterologous expression of mammalian proteins in many yeast species which can have important immunological consequences when used in the production of biotherapeutic proteins or peptides. Further, non-native N-linked glycosylation can lead to improper protein folding and premature degradation, which can impede high-level expression yields and hinder downstream analysis. Multiple strategies are presented in this article, which suggest different methods that can be implemented to circumvent the unwanted consequences of N-linked glycosylation during the expression process. These considerations may have long-term benefits for high-level protein production in S. cerevisiae across a broad spectrum of expression targets with special emphasis placed on G-protein coupled receptors, one of the largest families of membrane proteins.

Designing and generating a single-chain fragment variable (scFv) antibody against IL2Rα (CD25): An in silico and in vitro study

OBJECTIVES

IL-2Rα plays a critical role in maintaining immune function. However, expression and secretion of CD25 in various malignant disorders and autoimmune diseases are now well established. Thus, CD25 is considered an important target candidate for antibody-based therapy. This study aimed to find the most suitable linker peptide to construct a functional anti-CD25 single-chain fragment variable (scFv) by bioinformatics studies and its production in a bacterial expression system.

MATERIALS AND METHODS

Here, the 3D structures of the scFvs with different linkers were predicted and molecular dynamics simulation was performed to compare their structures and dynamics. Then, interactions between five models of scFv and human CD25 were calculated via molecular docking. According to MD and docking results, the anti-CD25 scFvs with (Gly4Ser)3 linker were constructed and cloned into pET-22b(+). Then, recombinant plasmids were transformed into Escherichia coli Bl21 (DE3) for expression using IPTG and lactose as inducers. Anti-CD25 scFv was purified from the periplasm and detected by SDS-PAGE and Western blot. Afterward, functionality was evaluated using ELISA.

RESULTS

In silico analysis showed that the model containing (Gly4Ser)3 as a linker has more stability compared with other linkers. The results of SDS-PAGE, Western blot, and ELISA confirmed the accuracy of anti-CD25 scFv production and its ability to bind to the human CD25.

CONCLUSION

Conclusively, our work provides a theoretical and experimental basis for production of an anti-CD25 scFv, which may be applied for various malignant disorders and autoimmune diseases.

Characterization of a single chain variable fragment of nivolumab that targets PD-1 and blocks PD-L1 binding

Activated T-cells express Programmed cell Death protein 1 (PD-1), a key immune checkpoint receptor. PD-1 functions primarily in peripheral tissues, where T cells may encounter tumor-derived immunosuppressive ligands. Monoclonal antibodies that disrupt the interaction between T-cell derived PD-1 and immunosuppressive ligands, such as PD-L1, have revolutionized approaches to cancer therapy. For instance, Nivolumab is a monoclonal Ab that targets human PD-1 and has played an important role in immune checkpoint therapy. Herein we report the purification and initial characterization of a ~27 kDa single chain variable fragment (scFv) of Nivolumab that targets human PD-1 and blocks binding by PD-L1. The possibility that the anti-PD-1 scFv can serve as both an anti-tumor agent and as an anti-viral agent is discussed. IMPORTANCE: The clinical significance of anti-PD-1 antibodies for treatment of a range of solid tumors is well documented (reviewed in [1-4]). In this report, we describe the results of studies that establish that an anti-PD-1 scFv purified from E. coli binds tightly to human PD-1. Furthermore, we demonstrate that upon binding, the anti-PD-1 scFv disrupts the interaction between PD-1 and PD-L1. Thus, the properties of this scFv, including its small size, stability and affinity for human PD-1, suggest that it has the potential to be a useful reagent in subsequent immunotherapeutic, diagnostic and anti-viral applications.

Exploration and Modulation of Antibody Fragment Biophysical Properties by Replacing the Framework Region Sequences

In order to increase the successful development of recombinant antibodies and fragments, it seems fundamental to enhance their expression and/or biophysical properties, such as the thermal, chemical, and pH stabilities. In this study, we employed a method bases on replacing the antibody framework region sequences, in order to promote more particularly single-chain Fragment variable (scFv) product quality. We provide evidence that mutations of the VH- C-C′ loop might significantly improve the prokaryote production of well-folded and functional fragments with a production yield multiplied by 27 times. Additional mutations are accountable for an increase in the thermal (+19.6 °C) and chemical (+1.9 M) stabilities have also been identified. Furthermore, the hereby-produced fragments have shown to remain stable at a pH of 2.0, which avoids molecule functional and structural impairments during the purification process. Lastly, this study provides relevant information to the understanding of the relationship between the antibodies amino acid sequences and their respective biophysical properties.

Bacterial expression and characterization of an anti-CD22 single-chain antibody fragment

Single-chain variable fragment (scFv) antibodies are fusion proteins of the variable regions of the heavy and light chains of immunoglobulins connected with a short linker peptide. They possess unique and superior features compared to whole antibodies for immunotherapy of various carcinomas, including hematologic B-cell malignancies. In the presented study we obtained efficient production of the recombinant anti-CD22 scFv in Escherichia coli expression system. The active recombinant protein was successfully recovered from inclusion bodies. Assays were performed to assess the in vitro targeting properties and specificity of the obtained anti-CD22 scFv antibody in the CD22 positive and negative lymphoma cell lines.

DNA-Mediated Assembly of Multispecific Antibodies for T Cell Engaging and Tumor Killing

Targeting T-cells against cancer cells is a direct means of treating cancer, and has already shown great responses in clinical treatment of B-cell malignancies. A simple way to redirect T-cells to cancer cells is by using multispecific antibody (MsAb) that contains different arms for specifically "grabbing" the T-cells and cancer cells; as such, the T-cells are activated upon target engagement and the killing begins. Here, a nucleic acid mediated protein-protein assembly (NAPPA) approach is implemented to construct a MsAb for T-cell engaging and tumor killing. Anti -CD19 and -CD3 single-chain variable fragments (scFvs) are conjugated to different l-DNAs with sequences that form the Holliday junction, thus allowing spontaneous assembly of homogeneous protein-DNA oligomers containing two anti-CD19 and one anti-CD3 scFvs. The new MsAb shows strong efficacy in inducing Raji tumor cell cytotoxicity in the presence of T-cells with EC50 ≈ 0.2 × 10-9 m; it also suppresses tumor growth in a Raji xenograft mouse model. The data indicates that MsAbs assembled from protein-DNA conjugates are effective macromolecules for directing T-cells for tumor killing. The modular nature of the NAPPA platform allows rapid generation of complex MsAbs from simple antibody fragments, while offering a general solution for preparing antibodies with high-order specificity.

Design and Production of Bispecific Antibodies

With the current biotherapeutic market dominated by antibody molecules, bispecific antibodies represent a key component of the next-generation of antibody therapy. Bispecific antibodies can target two different antigens at the same time, such as simultaneously binding tumor cell receptors and recruiting cytotoxic immune cells. Structural diversity has been fast-growing in the bispecific antibody field, creating a plethora of novel bispecific antibody scaffolds, which provide great functional variety. Two common formats of bispecific antibodies on the market are the single-chain variable fragment (scFv)-based (no Fc fragment) antibody and the full-length IgG-like asymmetric antibody. Unlike the conventional monoclonal antibodies, great production challenges with respect to the quantity, quality, and stability of bispecific antibodies have hampered their wider clinical application and acceptance. In this review, we focus on these two major bispecific types and describe recent advances in the design, production, and quality of these molecules, which will enable this important class of biologics to reach their therapeutic potential.

Influence of carbon source on cell size and production of anti LDL (-) single-chain variable fragment by a recombinant Pichia pastoris strain

The aim of this work was to study the effect of the carbon source (glycerol, sucrose, glucose or a sucrose/glucose mixture) on the production of the anti LDL (-) single-chain variable fragment (scFv) by the recombinant Pichia pastoris SMD 1168 strain as well as on the cell size. The use of glucose as a carbon source in the growth phase led to a remarkable increase in cell size compared with glycerol, while the smallest cells were obtained with sucrose likely due to the occurrence of an energetic stress. The scFv concentration seemed to be related to cell number rather than to cell concentration, which in its turn showed no significant dependence on the carbon source. Yeast cells grown on sucrose had a mean diameter (0.736 ± 0.097 μm) about 35% shorter than those grown on glucose and allowed for the highest final concentration of the scFv antibody fragment (93.7 ± 0.2 mg/L). These results demonstrate that sucrose is the best carbon source for the expression of such an antibody fragment by the recombinant P. pastoris strain, which may be very useful for the diagnostic analysis of the so-called "bad cholesterol".

Impacts of the -1 Amino Acid on Yeast Production of Protein-Intein Fusions

Expressing antibodies as fusions to the non-self-cleaving Mxe GyrA intein allows for site-specific chemical functionalization via expressed protein ligation. It is highly desirable to maximize the yield of functionalizable protein; and previously an evolved intein, 202-08, was identified that could increase protein fusion production in yeast. Given that the -1 amino acid residue upstream of inteins can affect cleavage efficiency, we examined the effects of amino acid variability at this position on 202-08 intein cleavage efficiency and secretion yield. Varying the -1 residue resulted in a wide range of cleavage behaviors with some amino acids yielding substantial autocleaved product that could not be functionalized. Autocleavage was noticeably higher with the 202-08 intein compared with the wild-type Mxe GyrA intein and resulted directly from the catalytic activity of the intein. Refeeding of production cultures with nitrogen base and casamino acids reduced, but did not eliminate autocleavage, while increasing protein-intein production up to seven-fold. Importantly, two amino acids, Gly and Ala, at the -1 position resulted in good cleavage efficiency with no undesirable autocleavage, and can be used in concert with refeeding strategies to increase total functionalizable protein yield for multiple protein fusion partners. Taken together, we describe an optimized yeast expression platform for protein-intein fusions. © 2018 American Institute of Chemical Engineers Biotechnol. Prog., 35: e2736, 2019.

Screening and expressing HIV-1 specific antibody fragments in Saccharomyces cerevisiae

Yeast displaying techniques have been widely used for identifying novel single-chain variable fragments (scFvs) and engineering their binding properties. In this study, we establish a set of vectors for scFv screening and production in the yeast system of Saccharomyces cerevisiae. This suite includes a display vector pYS for screening of recombinant scFv libraries as well as an expression vector pYE for production of scFv candidates in Saccharomyces cerevisiae. The display vector, pYS, give the identification of the HIV-1-specific scFv clones from one scFv display library by fluorescence-activated cell sorting. Subsequently, the expression vector pYE can offer high quality scFvs of interest up to hundreds of microgram scale for bioactivity analysis. As the result, one identified scFv was confirmed to exhibit HIV-1 neutralization activity in a cell line-based pseudovirus assay. The advantage of this system enables the identical post-translation of mammalian scFvs in the same host cells. Therefore, this vector set can be useful for the rapid screening and expression of antibody genes.

Biophysical characterization and molecular simulation of electrostatically driven self-association of a single-chain antibody

Colloidal protein-protein interactions (PPI) are often expected to impact key behaviors of proteins in solution, such as aggregation rates and mechanisms, aggregate structure, protein solubility, and solution viscosity. PPI of an anti-fluorescein single chain antibody variable fragment (scFv) were characterized experimentally at low to intermediate ionic strength using a combination of static light scattering and sedimentation equilibrium ultracentrifugation. Surprisingly, the results indicated that interactions were strongly net-attractive and electrostatics promoted self-association. Only repulsive interactions were expected based on prior work and calculations based a homology model of a related scFv crystal structure. However, the crystal structure lacks the charged, net-neutral linker sequence. PyRosetta was used to generate a set of scFv structures with different linker conformations, and coarse-grained Monte Carlo simulations were used to evaluate the effect of different linker configurations via second osmotic virial coefficient (B₂₂ ) simulations. The results show that the configuration of the linker has a significant effect on the calculated B₂₂ values, and can result in strong electrostatic attractions between oppositely charged residues on the protein surface. This is particularly relevant for development of non-natural antibody products, where charged linkers and other loop regions may be prevalent. The results also provide a preliminary computational framework to evaluate the effect of unstructured linkers on experimental protein-protein interaction parameters such as B₂₂ .

Cultivation of Pichia pastoris carrying the scFv anti LDL (-) antibody fragment. Effect of preculture carbon source

Antibodies and antibody fragments are nowadays among the most important biotechnological products, and Pichia pastoris is one of the most important vectors to produce them as well as other recombinant proteins. The conditions to effectively cultivate a P. pastoris strain previously genetically modified to produce the single-chain variable fragment anti low density lipoprotein (−) under the control of the alcohol oxidase promoter have been investigated in this study. In particular, it was evaluated if, and eventually how, the carbon source (glucose or glycerol) used in the preculture preceding cryopreservation in 20% glycerol influences both cell and antibody fragment productions either in flasks or in bioreactor. Although in flasks the volumetric productivity of the antibody fragment secreted by cells precultured, cryopreserved and reactivated in glycerol was 42.9% higher compared with cells precultured in glucose, the use of glycerol in bioreactor led to a remarkable shortening of the lag phase, thereby increasing it by no less than thrice compared to flasks. These results are quite promising in comparison with those reported in the literature for possible future industrial applications of this cultivation, taking into account that the overall process time was reduced by around 8 h.

Production of anti-amoxicillin ScFv antibody and simulation studying its molecular recognition mechanism for penicillins

The molecular recognition mechanism of an antibody for its hapten is very interesting. The objective of this research was to study the intermolecular interactions of an anti-amoxicillin antibody with penicillin drugs. The single chain variable fragment (ScFv) antibody was generated from a hybridoma cell strain excreting the monoclonal antibody for amoxicillin. The recombinant ScFv antibody showed similar recognition ability for penicillins to its parental monoclonal antibody: simultaneous recognizing 11 penicillins with cross-reactivities of 18-107%. The three-dimensional structure of the ScFv antibody was simulated by using homology modeling, and its intermolecular interactions with 11 penicillins were studied by using molecular docking. Results showed that three CDRs are involved in antibody recognition; CDR L3 Arg 100, CDR H3 Tyr226, and CDR H3 Arg 228 were the key contact amino acid residues; hydrogen bonding was the main antibody-drug intermolecular force; and the core structure of penicillin drugs was the main antibody binding position. These results could explain the recognition mechanism of anti-amoxicillin antibody for amoxicillin and its analogs. This is the first study reporting the production of ScFv antibody for penicillins and stimulation studying its recognition mechanism.

Production and Directional Evolution of Antisarafloxacin ScFv Antibody for Immunoassay of Fluoroquinolones in Milk

A recombinant antisarafloxacin ScFv antibody was produced by direct transformation of its gene into Rosetta-gami(DE3) for expression, and then its recognition mechanisms for 12 fluoroquinolones were studied using the molecular docking method. On the basis of the results of virtual mutation, the ScFv antibody was evolved by directional mutagenesis of contact amino acid residue Tyr99 to His. The ScFv mutant showed highly increased affinity for the 12 drugs with up to sevenfold improved sensitivity. Finally, the mutant was used to develop an indirect competitive enzyme linked immunosorbent assay for determination of the 12 drugs in milk. The limits of detection were in the range of 0.3-8.0 ng/mL; the ties were in the range of 5-106%, and the recoveries from the standard fortified blank milk were in the range of 62.0-89.3%. This is the first study reporting the evolution of an ScFv antibody using a directional mutagenesis strategy based on virtual mutation.

Systematic screening of soluble expression of antibody fragments in the cytoplasm of E. coli

Background

Disulfide bonds are the most common structural, post-translational modification found in proteins. Antibodies contain up to 25 disulfide bonds depending on type, with scFv fragments containing two disulfides and Fab fragments containing five or six disulfide bonds. The production of antibody fragments that contain native disulfide bonds can be challenging, especially on a large scale. The protein needs to be targeted to prokaryotic periplasm or the eukaryotic endoplasmic reticulum. These compartments are specialised for disulfide bond formation, but both compartments have limitations.

Results

Here we show that the introduction into the cytoplasm of a catalyst of disulfide bond formation and a catalyst of disulfide bond isomerization allows the efficient formation of natively folded scFv and Fab antibody fragments in the cytoplasm of Escherichia coli with intact reducing pathways. Eleven scFv and eleven Fab fragments were screened and ten of each were obtained in yields of >5 mg/L from deep-well plates. Production of eight of the scFv and all ten of the Fab showed a strong dependence on the addition of the folding factors. Yields of purified scFv of up to 240 mg/L and yields of purified Fab fragments of up to 42 mg/L were obtained. Purified fragments showed circular dichroism spectra consistent with being natively folded and were biologically active.

Conclusions

Our results show that the efficient production of soluble, biologically active scFv and Fab antibody fragments in the cytoplasm of E. coli is not only possible, but facile. The required components can be easily transferred between different E. coli strains.

Electronic supplementary material

The online version of this article (doi:10.1186/s12934-016-0419-5) contains supplementary material, which is available to authorized users.

Process development of a human recombinant diabody expressed in E. coli: engagement of CD99-induced apoptosis for target therapy in Ewing's sarcoma

Ewing's sarcoma (EWS) is the second most common primary bone tumor in pediatric patients characterized by over expression of CD99. Current management consists in extensive chemotherapy in addition to surgical resection and/or radiation. Recent improvements in treatment are still overshadowed by severe side effects such as toxicity and risk of secondary malignancies; therefore, more effective strategies are urgently needed. The goal of this work was to develop a rapid, inexpensive, and "up-scalable" process of a novel human bivalent single-chain fragment variable diabody (C7 dAbd) directed against CD99, as a new therapeutic approach for EWS. We first investigated different Escherichia coli constructs of C7 dAbd in small-scale studies. Starting from 60 % soluble fraction, we obtained a yield of 25 mg C7 dAbd per liter of bacterial culture with the construct containing pelB signal sequence. In contrast, a low recovery of C7 dAbd was achieved starting from periplasmic inclusion bodies. In order to maximize the yield of C7 dAbd, large-scale fermentation was optimized. We obtained from 75 % soluble fraction 35 mg C7 dAbd per L of cell culture grown in a synthetic media containing 3 g/L of vegetable peptone and 1 g/L of yeast extract. Furthermore, we demonstrated the better efficacy of the cell lysis by homogenization versus periplasmic extraction, in reducing endotoxin level of the C7 dAbd. For gram-scale purification, a direct aligned two-step chromatography cascade based on binding selectivity was developed. Finally, we recovered C7 dAbd with low residual process-related impurities, excellent reactivity, and apoptotic ability against EWS cells.

Process development of periplasmatically produced single chain fragment variable against epidermal growth factor receptor in Escherichia coli

Prokaryotic production systems have been widely used to manufacture recombinant therapeutic proteins. Economically, the prokaryotic production – especially of small therapeutic molecules – is advantageous compared to eukaryotic production strategies. However, due to the potential endotoxin and host cell protein contamination, the requirements for the purification process are disproportionately higher and therefore more expensive and elaborate to circumvent. For this reason, the goal of this work was to develop and establish a rapid, simple, inexpensive and ‘up-scalable’ production and purification process, using the therapeutic relevant protein anti-EGFR scFv hu225 as model molecule. Configuring high cell density cultivation of Escherichia coli – using the rha-BAD expression system as production platform – a specific product concentration up to 20 mgscFv/gCDW was obtained. By combining freeze-and-thaw, osmotic shock and pH induced host cell protein precipitation, almost 70% of the product was extracted from the biomass. In a novel approach a mixed mode chromatography was implemented as a capturing and desalting step, which allowed the direct application of further ion exchange chromatography steps for purification up to pharmaceutical grade. Thereby, 50% of the produced scFv could be purified within 10 h while maintaining the biological activity.

An evolved Mxe GyrA intein for enhanced production of fusion proteins

Expressing antibodies as fusions to the non-self-cleaving Mxe GyrA intein enables site-specific, carboxy-terminal chemical modification of the antibodies by expressed protein ligation (EPL). Bacterial antibody-intein fusion protein expression platforms typically yield insoluble inclusion bodies that require refolding to obtain active antibody-intein fusion proteins. Previously, we demonstrated that it was possible to employ yeast surface display to express properly folded single-chain antibody (scFv)-intein fusions, therefore permitting the direct small-scale chemical functionalization of scFvs. Here, directed evolution of the Mxe GyrA intein was performed to improve both the display and secretion levels of scFv-intein fusion proteins from yeast. The engineered intein was shown to increase the yeast display levels of eight different scFvs by up to 3-fold. Additionally, scFv- and green fluorescent protein (GFP)-intein fusion proteins can be secreted from yeast, and while fusion of the scFvs to the wild-type intein resulted in low expression levels, the engineered intein increased scFv-intein production levels by up to 30-fold. The secreted scFv- and GFP-intein fusion proteins retained their respective binding and fluorescent activities, and upon intein release, EPL resulted in carboxy-terminal azide functionalization of the target proteins. The azide-functionalized scFvs and GFP were subsequently employed in a copper-free, strain-promoted click reaction to site-specifically immobilize the proteins on surfaces, and it was demonstrated that the functionalized, immobilized scFvs retained their antigen binding specificity. Taken together, the evolved yeast intein platform provides a robust alternative to bacterial intein expression systems.

Versatility of Homogeneous Time-Resolved Fluorescence Resonance Energy Transfer Assays for Biologics Drug Discovery

Identification of potential lead antibodies in the drug discovery process requires the use of assays that not only measure binding of the antibody to the target molecule but assess a wide range of other characteristics. These include affinity ranking, measurement of their ability to inhibit relevant protein-protein interactions, assessment of their selectivity for the target protein, and determination of their species cross-reactivity profiles to support in vivo studies. Time-resolved fluorescence resonance energy transfer is a technology that offers the flexibility for development of such assays, through the availability of donor and acceptor fluorophore-conjugated reagents for detection of multiple tags or fusion proteins. The time-resolved component of the technology reduces potential assay interference, allowing screening of a range of different crude sample types derived from the bacterial or mammalian cell expression systems often used for antibody discovery projects. Here we describe the successful application of this technology across multiple projects targeting soluble proteins and demonstrate how it has provided key information for the isolation of potential therapeutic antibodies with the desired activity profile.

A putative OTU domain-containing protein 1 deubiquitinating enzyme is differentially expressed in thyroid cancer and identifies less-aggressive tumours

Background:

This study aimed to identify novel biomarkers for thyroid carcinoma diagnosis and prognosis.

Methods:

We have constructed a human single-chain variable fragment (scFv) antibody library that was selected against tumour thyroid cells using the BRASIL method (biopanning and rapid analysis of selective interactive ligands) and phage display technology.

Results:

One highly reactive clone, scFv-C1, with specific binding to papillary thyroid tumour proteins was confirmed by ELISA, which was further tested against a tissue microarray that comprised of 229 thyroid tissues, including: 110 carcinomas (38 papillary thyroid carcinomas (PTCs), 42 follicular carcinomas, 30 follicular variants of PTC), 18 normal thyroid tissues, 49 nodular goitres (NG) and 52 follicular adenomas. The scFv-C1 was able to distinguish carcinomas from benign lesions (P=0.0001) and reacted preferentially against T1 and T2 tumour stages (P=0.0108). We have further identified an OTU domain-containing protein 1, DUBA-7 deubiquitinating enzyme as the scFv-binding antigen using two-dimensional polyacrylamide gel electrophoresis and mass spectrometry.

Conclusions:

The strategy of screening and identifying a cell-surface-binding antibody against thyroid tissues was highly effective and resulted in a useful biomarker that recognises malignancy among thyroid nodules and may help identify lower-risk cases that can benefit from less-aggressive management.

Co-expression of foreign proteins tethered to HIV-1 envelope glycoprotein on the cell surface by introducing an intervening second membrane-spanning domain

The envelope glycoprotein (Env) of human immunodeficiency virus type I (HIV-1) mediates membrane fusion. To analyze the mechanism of HIV-1 Env-mediated membrane fusion, it is desirable to determine the expression level of Env on the cell surface. However, the quantification of Env by immunological staining is often hampered by the diversity of HIV-1 Env and limited availability of universal antibodies that recognize different Envs with equal efficiency. To overcome this problem, here we linked a tag protein called HaloTag at the C-terminus of HIV-1 Env. To relocate HaloTag to the cell surface, we introduced a second membrane-spanning domain (MSD) between Env and HaloTag. The MSD of transmembrane protease serine 11D, a type II transmembrane protein, successfully relocated HaloTag to the cell surface. The surface level of Env can be estimated indirectly by staining HaloTag with a specific membrane-impermeable fluorescent ligand. This tagging did not compromise the fusogenicity of Env drastically. Furthermore, fusogenicity of Env was preserved even after the labeling with the ligands. We have also found that an additional foreign peptide or protein such as C34 or neutralizing single-chain variable fragment (scFv) can be linked to the C-terminus of the HaloTag protein. Using these constructs, we were able to determine the required length of C34 and critical residues of neutralizing scFv for blocking membrane fusion, respectively.

Prokaryotic expression and refolding of EGFR extracellular domain and generation of phage display human scFv against EGFR

The epidermal growth factor receptor (EGFR), overexpressed in many epithelial tumors, is emerging as an attractive target for cancer therapy. Antibodies to the extracellular region of EGFR play a key role in the development of a mechanistic understanding and cancer therapy. In the present study, we demonstrated for the first time that EGFR-truncated extracellular domain (EGFR-tED), which was expressed in Escherichia coli BL21 (DE3) cells in the form of inclusion bodies, could be purified and renatured. The EGFR-tED protein was purified by gel filtration and Ni-NTA affinity chromatography with high purity (>90%) and refolded by a urea gradient size-exclusion chromatography, which could bind its ligand EGF in a concentration-dependent manner. The renatured EGFR was used for biopanning anti-EGFR scFvs from a human synthetic antibody phage display library. Combined with an additional cell-based ELISA screen, a novel scFv, E10, was obtained with two-fold more potent on the binding to EGFR-bearing tumor cells (the epidermoid carcinoma cell line A431) and the inhibition of A431 cells proliferation than scFv 11F8, suggesting that the E10 has the potential to be developed as therapeutic agents to solid tumors associated with EGFR overexpression.

Development of a secretion system for the production of heterologous proteins in Corynebacterium glutamicum using the Porin B signal peptide

Corynebacterium glutamicum is one of the useful hosts for the secretory production of heterologous proteins because of intrinsic attributes such as the presence of few endogenous proteins and proteases in culture medium. Here, we report the development of a new secretory system for the production of heterologous proteins by using the porin B (PorB) signal peptide in C. glutamicum. We examined two different endoxylanases and an antibody fragment (scFv) as model proteins for secretory production. In the flask cultivations, all the examined proteins were successfully produced as active forms into the culture medium with high efficiency. For the high-level production of endoxylanase, fed-batch cultivation was also performed in a lab-scale (5L) bioreactor, and the endoxylanases were efficiently secreted in the culture medium at levels as high as 615mg/L. From the culture supernatant, the secreted endoxylanases could be purified with high purity via one-step affinity column chromatography.

Label-free electrochemical detection of an Entamoeba histolytica antigen using cell-free yeast-scFv probes

Inexpensive, simple and quick detection of pathogen antigens in human samples is a key global health objective. Limiting factors include the cost and complexity of diagnostic tests that utilize antibody probes. Herein, we present a method for label-free electrochemical detection of a protein from the enteric pathogen Entamoeba histolytica using cell-free yeast-embedded antibody-like fragments (yeast-scFv) as novel affinity reagents.

Synergistic capture of Clostridium botulinum type A neurotoxin by scFv antibodies to novel epitopes

A non-immune library of human single chain fragment variable (scFv) antibodies displayed on Saccharomyces cerevisiae was screened for binding to the Clostridium botulinum neurotoxin serotype A binding domain [BoNT/A (Hc)] with the goal of identifying scFv to novel epitopes. To do this, an antibody-mediated labeling strategy was used in which antigen-binding yeast clones were selected after labeling with previously characterized monoclonal antibodies (MAbs) specific to the Hc. Twenty unique scFv clones were isolated that bound Hc. Of these, 3 also bound to full-length BoNT/A toxin complex with affinities ranging from 5 to 48 nM. Epitope binning showed that the three unique clones recognized at least two epitopes distinct from one another as well as from the detection MAbs. After production in E. coli, scFv were coupled to magnetic particles and tested for their ability to capture BoNT/A holotoxin using an Endopep-MS assay. In this assay, toxin captured by scFv coated magnetic particles was detected by incubation of the complex with a peptide containing a BoNT/A-specific cleavage sequence. Mass spectrometry was used to detect the ratio of intact peptide to cleavage products as evidence for toxin capture. When tested individually, each of the scFv showed a weak positive Endopep-MS result. However, when the particles were coated with all three scFv simultaneously, they exhibited significantly higher Endopep-MS activity, consistent with synergistic binding. These results demonstrate novel approaches toward the isolation and characterization of scFv antibodies specific to unlabeled antigens. They also provide evidence that distinct scFv antibodies can work synergistically to increase the efficiency of antigen capture onto a solid support.