External electric field promotes ammonia stripping from wastewater

Evaluating Ammonia Toxicity and Growth Kinetics of Four Different Microalgae Species

Although wastewater with high ammonia concentration is an ideal alternative environment for microalgae cultivation, high ammonia concentrations are toxic to microalgae and inhibit microalgae growth. In this study, the ammonia responses of four widely used microalgae species were investigated. Chlorella vulgaris, Chlorella minutissima, Chlamydomonas reinhardtii and Arthrospira platensis were grown in batch reactors maintained at seven different NH4Cl concentrations at a constant pH of 8. Growth and nitrogen removal kinetics were monitored. IC50 values for the mentioned species were found as 34.82 mg-FA/L, 30.17 mg-FA/L, 27.2 mg-FA/L and 44.44 mg-FA/L, respectively, while specific growth rates for different ammonia concentrations ranged between 0.148 and 1.271 d-1. C. vulgaris demonstrated the highest biomass growth under an ammonia concentration of 1700.95 mg/L. The highest removal of nitrogen was observed for A. platensis with an efficiency of 99.1%. The results showed that all tested species could grow without inhibition in ammonia levels comparable to those found in municipal wastewater. Furthermore, it has been concluded that species C. vulgaris and A. platensis can tolerate high ammonia levels similar to those found in high strength wastewaters.

Bubble Turbulent Gas-Permeable Membrane for Ammonia Recovery from Swine Wastewater: Mass Transfer Enhancement and Antifouling Mechanisms

Recovering ammonium from swine wastewater employing a gas-permeable membrane (GM) has potential but suffers from the limitations of unattractive mass transfer and poor-tolerance antifouling properties. Turbulence is an effective approach to enhancing the release of volatile ammonia from wastewater while relying on interfacial disturbance to interfere with contaminant adhesion. Herein, we design an innovative gas-permeable membrane coupled with bubble turbulence (BT-GM) that enhances mass transfer while mitigating membrane fouling. Bubbles act as turbulence carriers to accelerate the release and migration of ammonia from the liquid phase, increasing the ammonia concentration gradient at the membrane-liquid interface. In comparison, the ammonium mass transfer rate of the BT-GM process applied to real swine wastewater is 38% higher than that of conventional GM (12 h). Through a computational fluid dynamics simulation, the turbulence kinetic energy of BT-GM system is 3 orders of magnitude higher than that of GM, and the effective mass transfer area is nearly 3 times that of GM. Seven batches of tests confirmed that the BT-GM system exhibits remarkable antifouling ability, broadens its adaptability to complex water quality, and practically promotes the development of sustainable resource recycling.

Synergistic mechanisms between chlorine-mediated electrochemical advanced oxidation and ultraviolet light for ammonia removal

The combination of chlorine-mediated electrochemical advanced oxidation (Cl-EAO) and ultraviolet (UV) radiation (UV-E/Cl) can efficiently remove ammonia from wastewater. However, the synergistic mechanisms between Cl-EAO and UV need to be explored in more detail. Thus, in this study, the ammonia oxidation performance of Cl-EAO and UV-E/Cl systems were compared, while the synergistic mechanisms were identified by the performance of UV/chlorine oxidation (UV-ClO) system and the results of electron paramagnetic resonance (EPR) analysis, free radical inhibition assays, and determination of steady-state concentration of free radicals. It was found that, compared with the Cl-EAO system, UV increased the ammonia removal rate by 42.85% and reduced the active chlorine concentration (56.64%) and nitrate yield (53.61%). In the Cl-EAO, and UV-E/Cl systems, Cl• were detected, and the free radical inhibition assays and determination of steady-state concentration of free radicals suggested that UV increased the concentration of Cl• by 51.47%, resulting in Cl• becoming the major contributor to ammonia oxidation in the UV-E/Cl system. Besides, UV also increase the concentrations of HO• and Cl2•-, which further promoted the organic matter removal in the real domestic wastewater. This study also discussed the ammonia oxidation performance of the UV-E/Cl system in real domestic wastewater, even with the presence of significant levels of organic and inorganic anions in the wastewater, UV increased the ammonia oxidation by 21.95%. The results of this study thus clarify the mechanisms and potential applications of UV-E/Cl technology.

Fouling-free membrane stripping for ammonia recovery from real biogas slurry

Hydrophobic gas permeable membranes (GPMs) exhibit great potential in stripping or recovering ammonia from wastewater, but they also suffer from severe fouling issues due to the complex water matrix, since the related process is often operated under highly alkaline conditions (pH > 11). In this study, we proposed a novel membrane stripping process by integrating a cation exchange membrane (CEM) in alkali-driven Donnan dialysis prior to GPM for efficient and robust ammonia recovery from real biogas slurry. During the conventional stripping for diluted biogas slurry, the ammonia removal across GPM finally decreased by 15% over 6 consecutive batches, likely due to the obvious deposition of inorganic species and penetration of organic compounds (rejection of 90% only). In contrast, a constant ammonia removal of 80% and organic matter rejection of more than 99%, as well as negligible fouling of both membranes, were found for the proposed novel stripping process operated over 120 h. Our results demonstrated that additional divalent cations clearly aggravated the fouling of GPM in conventional stripping, where only weak competition across CEM was found in the CEM-GPM hybrid mode. Then, for raw biogas slurry, the new stripping achieved a stable ammonia removal up to 65%, and no fouling occurrence was found, superior to that in the control (declined removal from 87% to 55%). The antifouling mechanism by integrating CEM prior to GPM involves size exclusion and charge repulsion towards varying foulants. This work highlighted that the novel membrane stripping process of hybrid CEM-GPM significantly mitigated membrane fouling and can be regarded as a potential alternative for ammonia recovery from high-strength complex streams.

Macro-nutrients recovery from liquid waste as a sustainable resource for production of recovered mineral fertilizer: Uncovering alternative options to sustain global food security cost-effectively

Global food security, which has emerged as one of the sustainability challenges, impacts every country. As food cannot be generated without involving nutrients, research has intensified recently to recover unused nutrients from waste streams. As a finite resource, phosphorus (P) is largely wasted. This work critically reviews the technical applicability of various water technologies to recover macro-nutrients such as P, N, and K from wastewater. Struvite precipitation, adsorption, ion exchange, and membrane filtration are applied for nutrient recovery. Technological strengths and drawbacks in their applications are evaluated and compared. Their operational conditions such as pH, dose required, initial nutrient concentration, and treatment performance are presented. Cost-effectiveness of the technologies for P or N recovery is also elaborated. It is evident from a literature survey of 310 published studies (1985-2022) that no single technique can effectively and universally recover target macro-nutrients from liquid waste. Struvite precipitation is commonly used to recover over 95 % of P from sludge digestate with its concentration ranging from 200 to 4000 mg/L. The recovered precipitate can be reused as a fertilizer due to its high content of P and N. Phosphate removal of higher than 80 % can be achieved by struvite precipitation when the molar ratio of Mg²⁺/PO₄^3- ranges between 1.1 and 1.3. The applications of artificial intelligence (AI) to collect data on critical parameters control optimization, improve treatment effectiveness, and facilitate water utilities to upscale water treatment plants. Such infrastructure in the plants could enable the recovered materials to be reused to sustain food security. As nutrient recovery is crucial in wastewater treatment, water treatment plant operators need to consider (1) the costs of nutrient recovery techniques; (2) their applicability; (3) their benefits and implications. It is essential to note that the treatment cost of P and/or N-laden wastewater depends on the process applied and local conditions.

Nitrogen Recovery from Different Livestock Slurries with an Innovative Stripping Process

Ammonia (NH3) emissions deriving from the management of livestock manure have a significant environmental impact, and therefore it is important to reduce them. Among the available options, the process of NH3 stripping is promising to remove NH3 from manures and digestates recovering it as a mineral fertilizer (e.g., ammonium sulfate) that is more widely adoptable on farms. The traditional stripping process takes place in batches; however, in this study, a continuous process was evaluated using a lab scale plant in which four reactors were used in series with different hydraulic retention times (HRTs) of 12 or 20 days. The NH3 recovery of each reactor was studied for the liquid fraction of pig slurry, dairy cattle slurry and digestate, applying simple headspace aeration. For 20 days of HRT, totals of 92%, 83% and 67% of NH3 were stripped from the digestate, pig slurry and dairy cattle slurry, respectively. For 12 days of HRT, total NH3 recoveries were 83%, 60% and 41% for the digestate, pig slurry and dairy cattle slurry, respectively. The inlet NH3 concentration and inlet total alkalinity had a positive and negative effect, respectively, on the specific NH3 removal rate for each reactor. Stripping NH3 on farm scale can abate NH3 emissions in response to the environmental concerns of European policies.