Monitoring of occupational exposure to epichlorohydrin by genetic effects and hemoglobin adducts

Internal exposure to heat-induced food contaminants in omnivores, vegans and strict raw food eaters: biomarkers of exposure to 2- and 3-monochloropropanediol (urinary excretion) and glycidol (hemoglobin adduct N-2,3-dihydroxypropyl-Val)

Fatty acid esters of 2/3-monochloropropanediol (2/3-MCPD) and glycidol are formed mainly during heat processing (deodorization) of vegetable oils, and are hydrolyzed by lipases in the gastrointestinal tract leading to the absorption of 2/3-MCPD and glycidol. The International Agency for Research on Cancer (IARC) has classified 3-MCPD as possibly and glycidol as probably carcinogenic to humans. The aims of the current work were to clarify the exposure to 2/3-MCPD and glycidol associated with different dietary habits (omnivore, vegan, raw-food eating), and the exposure development between 2017 and 2021 in German study participants. The questions were addressed using the daily urinary excretion of 2/3-MCPD and the hemoglobin adduct N-(2,3-dihydroxypropyl)-Val (DHP-Val) formed from glycidol as biomarkers of exposure, which were determined in two dietary studies including 36 omnivores, 36 vegans and 16 strict raw food eaters (abstaining from any heated food for at least four months). The median urinary excretion of 2- and 3-MCPD in non-smoking omnivores and vegans was 0.87 and 1.35 µg/day (2-MCPD), respectively, and 0.79 and 1.03 µg/day (3-MCPD), respectively. The 2/3-MCPD concentrations in urine samples of raw food eaters were usually below the limit of detection. The median DHP-Val levels in non-smoking vegans and omnivores were 3.9 pmol/g Hb each, and 1.9 pmol/g Hb in raw food eaters. Between 2017 and 2021, the exposure to 3-MCPD and glycidol did not change, however, the median 2-MCPD excretion decreased (p = 0.02, omnivores and vegans combined). The correlation between daily excretions of 2/3-MCPD determined 4 years apart was weak, whereas a moderate correlation was observed for DHP-Val (rS = 0.66) in this timeframe. In conclusion, the exposure to glycidol in omnivores and vegans was alike, whereas the 2/3-MCPD exposure was somewhat (albeit not significantly) higher in vegans. While 2/3-MCPD were hardly detectable in urine samples of raw food eaters, the median DHP-Val level (about 50% of those in omnivores) indicates a glycidol source independent of the dietary exposure.

A comparison of the exposure system of glycidol-related chemicals on the formation of glycidol-hemoglobin adducts

Glycidol fatty acid esters that are present in foods are degraded in vivo to the animal carcinogen glycidol, which binds to the N-terminal valine of hemoglobin (Hb) to form N-(2,3-dihydroxypropyl)valine (diHOPrVal) adducts. The existence of other chemicals that are converted to glycidol is unknown. To determine the effect of different exposure conditions on the formation of diHOPrVal adducts, several glycidol-related chemicals (3-monochloropropane-1,2-diol; 3-MCPD, epichlorohydrin, glyceraldehyde, acrylic acid, and 1,2-propanediol) were evaluated using in vitro and in vivo (single/repeated dose) methods. In vitro, the reaction of 3-MCPD or epichlorohydrin with human Hb produced 17% and 0.7% of diHOPrVal, as compared to equimolar glycidol, respectively. Following a single administration of glycidol-related compounds to ICR mice, diHOPrVal formation was observed only in the epichlorohydrin-treated group after day 5 of exposure. After 14 days of repeated dosing, the amounts of diHOPrVal produced by epichlorohydrin and 3-MCPD in vivo were <1% of diHOPrVal produced by an equal molar concentration of glycidol. Furthermore, glyceraldehyde group produced 0.2% of diHOPrVal at the same molar concentration of glycidol equivalents, in which diHOPrVal formation could not be confirmed by the in vitro assay. The results indicate the usefulness of diHOPrVal as an exposure marker for glycidol; however, the contribution of its formation in vivo by exposure to various chemicals will be necessary to validate and interpret the results.

Pathways to Identify Electrophiles In Vivo Using Hemoglobin Adducts: Hydroxypropanoic Acid Valine Adduct and Its Possible Precursors

Analytical methods and tools for the characterization of the human exposome by untargeted mass spectrometry approaches are advancing rapidly. Adductomics methods have been developed for untargeted screening of short-lived electrophiles, in the form of adducts to proteins or DNA, in vivo. The identification of an adduct and its precursor electrophile in the blood is more complex than that of stable chemicals. The present work aims to illustrate procedures for the identification of an adduct to N-terminal valine in hemoglobin detected with adductomics, and pathways for the tracing of its precursor and possible exposure sources. Identification of the adduct proceeded via preparation and characterization of standards of adduct analytes. Possible precursor(s) and exposure sources were investigated by measurements in blood of adduct formation by precursors in vitro and adduct levels in vivo. The adduct was identified as hydroxypropanoic acid valine (HPA-Val) by verification with a synthesized reference. The HPA-Val was measured together with other adducts (from acrylamide, glycidamide, glycidol, and acrylic acid) in human blood (n = 51, schoolchildren). The HPA-Val levels ranged between 6 and 76 pmol/g hemoglobin. The analysis of reference samples from humans and rodents showed that the HPA-Val adduct was observed in all studied samples. No correlation of the HPA-Val level with the other studied adducts was observed in humans, nor was an increase in tobacco smokers observed. A small increase was observed in rodents exposed to glycidol. The formation of the HPA-Val adduct upon incubation of blood with glycidic acid (an epoxide) was shown. The relatively high adduct levels observed in vivo in relation to the measured reactivity of the epoxide, and the fact that the epoxide is not described as naturally occurring, suggest that glycidic acid is not the only precursor of the HPA-Val adduct identified in vivo. Another endogenous electrophile is suspected to contribute to the in vivo HPA-Val adduct level.

Does External Exposure of Glycidol-Related Chemicals Influence the Forming of the Hemoglobin Adduct, N-(2,3-dihydroxypropyl)valine, as a Biomarker of Internal Exposure to Glycidol?

Glycidyl fatty acid esters (GE) are constituents of edible oils and fats, and are converted into glycidol, a genotoxic substance, in vivo. N-(2,3-dihydroxypropyl)valine (diHOPrVal), a hemoglobin adduct of glycidol, is used as a biomarker of glycidol and GE exposure. However, high background levels of diHOPrVal are not explained by daily dietary exposure to glycidol and GE. In the present study, several glycidol-related chemicals (glycidol, (±)-3-chloro-1,2-propanediol, glycidyl oleate, epichlorohydrin, propylene oxide, 1-bromopropane, allyl alcohol, fructose, and glyceraldehyde) that might be precursors of diHOPrVal, were administered to mice, and diHOPrVal formation from each substance was examined with LC-MS/MS. DiHOPrVal was detected in animals treated with glycidol and glycidyl oleate but not in mice treated with other chemicals (3-MCPD, epichlorohydrin, propylene oxide, 1-bromopropane, allyl alcohol, fructose, and glyceraldehyde). The amount of diHOPrVal per administered dose produced from other chemicals was negligible compared to the amounts associated with dietary glycidol and GE. The present study provides important knowledge for exploring other sources for internal exposure to glycidol.

Internal Doses of Glycidol in Children and Estimation of Associated Cancer Risk

The general population is exposed to the genotoxic carcinogen glycidol via food containing refined edible oils where glycidol is present in the form of fatty acid esters. In this study, internal (in vivo) doses of glycidol were determined in a cohort of 50 children and in a reference group of 12 adults (non-smokers and smokers). The lifetime in vivo doses and intakes of glycidol were calculated from the levels of the hemoglobin (Hb) adduct N-(2,3-dihydroxypropyl)valine in blood samples from the subjects, demonstrating a fivefold variation between the children. The estimated mean intake (1.4 μg/kg/day) was about two times higher, compared to the estimated intake for children by the European Food Safety Authority. The data from adults indicate that the non-smoking and smoking subjects are exposed to about the same or higher levels compared to the children, respectively. The estimated lifetime cancer risk (200/10⁵) was calculated by a multiplicative risk model from the lifetime in vivo doses of glycidol in the children, and exceeds what is considered to be an acceptable cancer risk. The results emphasize the importance to further clarify exposure to glycidol and other possible precursors that could give a contribution to the observed adduct levels.

The hemoglobin adduct N-(2,3-dihydroxypropyl)-valine as biomarker of dietary exposure to glycidyl esters: a controlled exposure study in humans

Fatty acid esters of glycidol (glycidyl esters) are heat-induced food contaminants predominantly formed during industrial deodorization of vegetable oils and fats. After consumption, the esters are digested in the gastrointestinal tract, leading to a systemic exposure to the reactive epoxide glycidol. The compound is carcinogenic, genotoxic and teratogenic in rodents, and rated as probably carcinogenic to humans (IARC group 2A). Assessment of exposure from occurrence and consumption data is difficult, as lots of different foods containing refined oils and fats may contribute to human exposure. Therefore, assessment of the internal exposure using the hemoglobin adduct of glycidol, N-(2,3-dihydroxypropyl)-valine (2,3-diHOPr-Val), may be promising, but a proof-of-principle study is needed to interpret adduct levels with respect to the underlying external exposure. A controlled exposure study was conducted with 11 healthy participants consuming a daily portion of about 36 g commercially available palm fat with a relatively high content of ester-bound glycidol (8.7 mg glycidol/kg) over 4 weeks (total amount 1 kg fat, individual doses between 2.7 and 5.2 µg/kg body weight per day). Frequent blood sampling was performed to monitor the 2,3-diHOPr-Val adduct levels during formation and the following removal over 15 weeks, using a modified Edman degradation and ultrahigh performance liquid chromatography-tandem mass spectrometry (UHPLC-MS/MS). Results demonstrated for the first time that the relatively high exposure during the intervention period was reflected in corresponding distinct increases of 2,3-diHOPr-Val levels in all participants, following the expected slope for hemoglobin adduct formation and removal over time. The mean adduct level increased from 4.0 to 12.2 pmol 2,3-diHOPr-Val/g hemoglobin. By using a nonlinear mixed model, values for the adduct level/dose ratio (k, mean 0.082 pmol 2,3-diHOPr-Val/g hemoglobin per µg glycidol/kg body weight) and the adduct lifetime (τ, mean 104 days, likely the lifetime of the erythrocytes) were determined. Interindividual variability was generally low. 2,3-DiHOPr-Val was therefore proven to be a biomarker of the external dietary exposure to fatty acid esters of glycidol. From the background adduct levels observed in our study, a mean external glycidol exposure of 0.94 µg/kg body weight was estimated. This value is considerably higher than current estimates for adults using occurrence and consumption data of food. Possible reasons for this discrepancy are discussed (other oral or inhalational glycidol sources, endogenous formation, exposure to other chemicals also forming the adduct 2,3-diHOPr-Val). Further research is necessary to clarify the issue.

Exposure assessment of process-related contaminants in food by biomarker monitoring

Exposure assessment is a fundamental part of the risk assessment paradigm, but can often present a number of challenges and uncertainties. This is especially the case for process contaminants formed during the processing, e.g. heating of food, since they are in part highly reactive and/or volatile, thus making exposure assessment by analysing contents in food unreliable. New approaches are therefore required to accurately assess consumer exposure and thus better inform the risk assessment. Such novel approaches may include the use of biomarkers, physiologically based kinetic (PBK) modelling-facilitated reverse dosimetry, and/or duplicate diet studies. This review focuses on the state of the art with respect to the use of biomarkers of exposure for the process contaminants acrylamide, 3-MCPD esters, glycidyl esters, furan and acrolein. From the overview presented, it becomes clear that the field of assessing human exposure to process-related contaminants in food by biomarker monitoring is promising and strongly developing. The current state of the art as well as the existing data gaps and challenges for the future were defined. They include (1) using PBK modelling and duplicate diet studies to establish, preferably in humans, correlations between external exposure and biomarkers; (2) elucidation of the possible endogenous formation of the process-related contaminants and the resulting biomarker levels; (3) the influence of inter-individual variations and how to include that in the biomarker-based exposure predictions; (4) the correction for confounding factors; (5) the value of the different biomarkers in relation to exposure scenario's and risk assessment, and (6) the possibilities of novel methodologies. In spite of these challenges it can be concluded that biomarker-based exposure assessment provides a unique opportunity to more accurately assess consumer exposure to process-related contaminants in food and thus to better inform risk assessment.

Measurement of micronuclei and internal dose in mice demonstrates that 3-monochloropropane-1,2-diol (3-MCPD) has no genotoxic potency in vivo

In this study 3-monochloropropane-1,2-diol (3-MCPD), a compound that appears as contaminant in refined cooking oils, has been studied with regard to genotoxicity in vivo (mice) with simultaneous measurement of internal dose using state-of-the-art methodologies. Genotoxicity (chromosomal aberrations) was measured by flow cytometry with dual lasers as the frequency of micronuclei in erythrocytes in peripheral blood from BalbC mice intraperitoneally exposed to 3-MCPD (0, 50, 75, 100, 125 mg/kg). The internal doses of 3-MCPD in the mice were calculated from N-(2,3-dihydroxypropyl)-valine adducts to hemoglobin (Hb), quantified at very low levels by high-resolution mass spectrometry. Convincing evidence for absence of genotoxic potency in correlation to measured internal doses in the mice was demonstrated, despite relatively high administered doses of 3-MCPD. The results are discussed in relation to another food contaminant that is formed as ester in parallel to 3-MCPD esters in oil processing, i.e. glycidol, which has been studied previously by us in a similar experimental setup. Glycidol has been shown to be genotoxic, and in addition to have ca. 1000 times higher rate of adduct formation compared to that observed for 3-MCPD. The conclusion is that at simultaneous exposure to 3-MCPD and glycidol the concern about genotoxicity would be glycidol.

LC-MS/MS screening strategy for unknown adducts to N-terminal valine in hemoglobin applied to smokers and nonsmokers

Electrophilically reactive compounds have the ability to form adducts with nucleophilic sites in DNA and proteins, constituting a risk for toxic effects. Mass spectrometric detection of adducts to N-terminal valine in hemoglobin (Hb) after detachment by modified Edman degradation procedures is one approach for in vivo monitoring of exposure to electrophilic compounds/metabolites. So far, applications have been limited to one or a few selected reactive species, such as acrylamide and its metabolite glycidamide. This article presents a novel screening strategy for unknown Hb adducts to be used as a basis for an adductomic approach. The method is based on a modified Edman procedure, FIRE, specifically developed for LC-MS/MS analysis of N-terminal valine adducts in Hb detached as fluorescein thiohydantoin (FTH) derivatives. The aim is to detect and identify a priori unknown Hb adducts in human blood samples. Screening of valine adducts was performed by stepwise scanning of precursor ions in small mass increments, monitoring four fragments common for the FTH derivative of valine with different N-substitutions in the multiple-reaction mode, covering a mass range of 135 Da (m/z 503-638). Samples from six smokers and six nonsmokers were analyzed. Control experiments were performed to compare these results with known adducts and to check for artifactual formation of adducts. In all samples of smokers and nonsmokers, seven adducts were identified, of which six have previously been studied. Nineteen unknown adducts were observed, and 14 of those exhibited fragmentation patterns similar to earlier studied FTH derivatives of adducts to valine. Identification of the unknown adducts will be the focus of future work. The presented methodology is a promising screening tool using Hb adducts to indicate exposure to potentially toxic electrophilic compounds and metabolites.

Genotoxic effects of ethylene oxide, propylene oxide and epichlorohydrin in humans: update review (1990-2001)

Ethylene oxide (EtO), propylene oxide (PO) and epichlorohydrin (ECH) are important industrial chemicals widely used as intermediates for various synthetic products. EtO and PO are also environmental pollutants. In this review we summarize data published during the period 1990-2001 concerning both the genotoxic and carcinogenic effects of these epoxides in humans. The use of DNA and hemoglobin adducts as biomarkers of exposure and the role of polymorphism, as well as confounding factors, are discussed. We have also included recent in vitro data comprising genotoxic effects induced by EtO, PO and ECH in mammalian cells. The uncertainties regarding cancer risk estimation still persist, in spite of the large database collected.

Mass spectrometric identification of a candidate biomarker peptide from the in vitro interaction of epichlorohydrin with red blood cells

The reaction products of epichlorohydrin with human alpha- and beta- globins, obtained through in vitro incubation of these compounds and red blood cells, were determined by using reversed-phase high-performance liquid chromatography (RP-HPLC), electrospray ionization mass spectrometry and matrix-assisted laser desorption/ionization tandem mass spectrometry. The alpha-globin was much more reactive than the beta-globin. At low incubation ratios, approximating the order of magnitude of epichlorohydrin concentration as found in workplaces, the only modified peptide still detectable was the 62-90 belonging to the alpha-chain and carrying an incremental mass of 92 u on either His72 or His89. Given that the two peptides co-eluted in a single chromatographic peak during RP-HPLC separation, they could be chosen as suitable biomarkers for quantification in the setting up of a new methodology for the biological monitoring of persons occupationally exposed, replacing currently known procedures.

Heating of food and haemoglobin adducts from carcinogens: possible precursor role of glycidol

Studies of adducts from reactive compounds to haemoglobin (Hb) by gas chromatography-tandem mass spectrometry according to the N-alkyl Edman method reveals the occurrence of N-(2,3-dihydroxypropyl)valine (diHOPrVal) at levels of 1-2 pmol/g Hb, in persons without known exposure. The hypothesis that this background originates from glycidol or related compounds during heating of food was tested in experiments with rats. Animals fed fried animal feed for 30 or 72 days showed an increase of the diHOPrVal level by about 50% compared with controls. Several arguments, such as the formation of reactive oxiranes by heat-induced dehydration of glycol configurations in glycerol and sugars, support the idea that glycidol (or e.g. glycidyl esters) are precursors of the adduct. In Hb samples, reduced for stabilisation of aldehyde adducts, relatively high levels of adducts determined as diHOPrVal were found, although without significant relation to frying of the feed. There is thus no indication that reduction in vivo of, for example, the Schiff base from glyceraldehyde, is a pathway for formation of the diHOPrVal. The background level of diHOPrVal in humans Hb is low, and the cancer risk associated with exposure to the specific alkylator-probably glycidol-formed in cooking, is therefore presumably low. The result implies, however, that low-molecular mass mutagenic oxiranes formed during the heating of food should be studied further.

Adducts with haemoglobin and with DNA in epichlorohydrin-exposed rats

Epichlorohydrin (1-chloro-2,3-epoxypropane; ECH) is an important industrial chemical and a carcinogen in experimental animals. The main aims of the present study were to characterize the adduct formation in female Wistar rats and to identify adducts that could potentially be used in human biomonitoring studies. The total binding of radioactivity to haemoglobin in rats administered 0, 0. 11, 0.22, 0.43, or 0.97 mmol [3H]ECH/kg body weight by i.p. injection, and sacrificed 24 h after treatment, was linearly related to a dose up to 0.43 mmol/kg body weight. The binding at the highest dose was higher than predicted by extrapolation from lower doses, indicating saturation of a metabolic process for elimination of ECH. Ion-exchange chromatography of a globin hydrolysate showed one major radioactivity peak corresponding to S-(3-chloro-2-hydroxypropyl)cysteine. The half-life of this adduct was estimated as about 4 days by analysis of globin from rats administered 0.43 mmol/kg body weight and sacrificed after 1, 2 and 9 days. Crosslinking of the adduct, presumably with glutathione, appeared to be the predominant secondary reaction. Hydrolysis of N-(3-chloro-2-hydroxypropyl)valine, the primary reaction product of ECH with N-terminal valine, would give N-(2,3-dihydroxypropyl)valine. A sensitive gas chromatography/mass spectrometry method for the dihydroxypropyl adduct was used to follow its formation and removal after administration of nonlabelled ECH (0.11 mmol/kg body weight). The level of this adduct reached a maximum of about 20 pmol/g globin after a few weeks, corresponding to about 0.1% of the initial binding of ECH to globin. N-7-(3-Chloro-2-hydroxypropyl)guanine was detected in rats administered 0.97 mmol [3H]ECH/kg body weight and sacrificed 6 h after treatment. The adduct levels in haemoglobin and DNA were compared with previously reported adduct levels in male Fischer 344 rats exposed to propylene oxide. Despite its higher chemical reactivity, the capacity of ECH to alkylate macromolecules in vivo was found to be somewhat lower than that of propylene oxide.