Anammox Granules Acclimatized to Mainstream Conditions Can Achieve a Volumetric Nitrogen Removal Rate Comparable to Sidestream Systems

Superior mainstream partial nitritation in an acidic membrane-aerated biofilm reactor

Shortcut nitrogen removal holds significant economic appeal for mainstream wastewater treatment. Nevertheless, it is too difficult to achieve the stable suppression of nitrite-oxidizing bacteria (NOB), and simultaneously maintain the activity of ammonia-oxidizing bacteria (AOB). This study proposes to overcome this challenge by employing the novel acid-tolerant AOB, namely "Candidatus Nitrosoglobus", in a membrane-aerated biofilm reactor (MABR). Superior partial nitritation was demonstrated in low-strength wastewater from two aspects. First, the long-term operation (256 days) under the acidic pH range of 5.0 to 5.2 showed the successful NOB washout by the in situ free nitrous acid (FNA) of approximately 1 mg N/L. This was evidenced by the stable nitrite accumulation ratio (NAR) close to 100 % and the disappearance of NOB shown by 16S rRNA gene amplicon sequencing and fluorescence in situ hybridization. Second, oxygen was sufficiently supplied in the MABR, leading to an unprecedentedly high ammonia oxidation rate (AOR) at 2.4 ± 0.1 kg N/(m3 d) at a short hydraulic retention time (HRT) of a mere 30 min. Due to the counter diffusion of substrates, the present acidic MABR displayed a significantly higher apparent oxygen affinity (0.36 ± 0.03 mg O2/L), a marginally lower apparent ammonia affinity (14.9 ± 1.9 mg N/L), and a heightened sensitivity to FNA and pH variations, compared with counterparts determined by flocculant acid-tolerant AOB. Beyond supporting the potential application of shortcut nitrogen removal in mainstream wastewater, this study also offers the attractive prospect of intensifying wastewater treatment by markedly reducing the HRT of the aerobic unit.

An overlooked effect of hydroxylamine on anammox granular sludge: Promoting granulation and boosting activity

The exogenous hydroxylamine dosing has been proven to enhance nitrite supply for anammox bacteria. In this study, exogenous hydroxylamine was fed into a sequencing batch reactor to investigate its long-term effect on anammox granular sludge. The results showed that hydroxylamine enhanced the reactor's performance with an increase in total nitrogen removal rate from 0.23 to 0.52 kg N/m3/d and an increase in bacterial activity from 11.65 to 78.24 mg N/g VSS/h. Meanwhile, hydroxylamine promoted granulation by eluting flocs. And higher anammox activity and granulation were supported by extracellular polymeric substances (EPS) characteristics. Moreover, Candidatus Brocadia's abundance increased from 1.10 % to 3.03 %, and its symbiosis with heterotrophic bacteria was intensified. Additionally, molecular docking detailed the mechanism of the hydroxylamine effect. Overall, this study would provide new insights into the hydroxylamine dosing strategy application.

Sponge iron strengthens the activity of anammox biofilm under low nitrogen conditions in a two-stage fixed-bed biofilm reactor

Strengthening the activity competitiveness of anaerobic ammonium oxidation (anammox) bacteria (AnAOB) under low nitrogen conditions is indispensable for mainstream anammox application. This study demonstrates that sponge iron addition (42.8 g/L) effectively increased apparent AnAOB activity and extracellular polymeric substance (EPS) production of low load anammox biofilms cultivated under low (influent of 60 mg N/L) and even ultra-low (influent of 10 mg N/L) nitrogen conditions. In-situ batch tests showed that after sponge iron addition the specific AnAOB activity in the low and ultra-low nitrogen systems further increased to 1.18 and 0.47 mmol/g VSS/h, respectively, with an apparent growth rate for AnAOB of 0.011 ± 0.001 d-1 and 0.004 ± 0.001 d-1, respectively. The averaged EPS concentration of anammox biofilm in both low (from 35.84 to 71.05 mg/g VSS) and ultra-low (from 44.14 to 57.59 mg/g VSS) nitrogen systems increased significantly, while a higher EPS protein/polysaccharide ratio, which was positively correlated with AnAOB activity, was observed in the low nitrogen system (3.54 ± 0.34) than that in the ultra-low nitrogen system (1.82 ± 0.10). In addition, Candidatus Brocadia was detected as dominant AnAOB in the anammox biofilm under the low (12.2 %) and ultra-low (24.7 %) nitrogen condition. Notably, the genus Streptomyces (26.3 %), capable for funge-like codenitrification, increased unexpectedly in the low nitrogen system, but not affecting the nitrogen removal performance. Therefore, using sponge iron to strengthen AnAOB activity under low nitrogen conditions is feasible, providing support for mainstream anammox applications.

Distinctive species interaction patterns under high nitrite stress shape inefficient denitrifying phosphorus removal performance

Denitrifying phosphorus removal using nitrite as an electron acceptor is an innovative, resource-efficient approach for nitrogen and phosphorus removal. However, the inhibitory effects of nitrite on anoxic phosphorus uptake and process stability are unclear. This study investigated the total phosphorus removal performance under nitrite stress and analyzed microbiome responses in 186 sludge samples. The results indicated that the total phosphorus removal rates and dominant taxon abundance were highly similar under nitrite stress. High nitrite stress induced a community-state shift, leading to unstable dynamics and decreased total phosphorus removal. This shift resulted from increased species cooperation. Notably, the shared genera OLB8 and Zoogloea under non-inhibitory nitrite stress, suggesting their vital roles in mitigating nitrite stress by enhancing carbon and energy metabolism. The response patterns of these bacterial communities to high nitrite stress can guide the design and optimization of high-nitrogen wastewater reactors.

Robust rehabilitation of anammox system by granular activated carbon under long-term starvation stress: Microbiota restoration and metabolic reinforcement

This article investigates the buffering capacity and recovery-enhancing ability of granular activated carbon (GAC) in a starved (influent total nitrogen: 20 mg/L) anaerobic ammonium oxidation (anammox) reactor. The findings revealed that anammox aggregated and sustained basal metabolism with shorter performance recovery lag (6 days) and better nitrogen removal efficiency (84.9 %) due to weak electron-repulsion and abundance redox-active groups on GAC's surface. GAC-supported enhanced extracellular polymeric substance secretion aided anammox in resisting starvation. GAC also facilitated anammox bacterial proliferation and expedited the restoration of anammox microbial community from a starved state to its initial-level. Metabolic function analyses unveiled that GAC improved the expression of genes involved in amino acid metabolism and sugar-nucleotide biosynthesis while promoted microbial cross-feeding, ultimately indicating the superior potential of GAC in stimulating more diverse metabolic networks in nutrient-depleted anammox consortia. This research sheds light on the microbial and metabolic mechanisms underlying GAC-mediated anammox system in low-substrate habitats.

A critical review of improving mainstream anammox systems: Based on macroscopic process regulation and microscopic enhancement mechanisms

Full-scale anaerobic ammonium oxidation (anammox) engineering applications are vastly limited by the sensitivity of anammox bacteria to the complex mainstream ambience factors. Therefore, it is of great necessity to comprehensively summarize and overcome performance-related challenges in mainstream anammox process at the macro/micro level, including the macroscopic process variable regulation and microscopic biological metabolic enhancement. This article systematically reviewed the recent important advances in the enrichment and retention of anammox bacteria and main factors affecting metabolic regulation under mainstream conditions, and proposed key strategies for the related performance optimization. The characteristics and behavior mechanism of anammox consortia in response to mainstream environment were then discussed in details, and we revealed that the synergistic nitrogen metabolism of multi-functional bacterial genera based on anammox microbiome was conducive to mainstream anammox nitrogen removal processes. Finally, the critical outcomes of anammox extracellular electron transfer (EET) at the micro level were well presented, carbon-based conductive materials or exogenous electron shuttles can stimulate and mediate anammox EET in mainstream environments to optimize system performance from a micro perspective. Overall, this review advances the extensive implementation of mainstream anammox practice in future as well as shedding new light on the related EET and microbial mechanisms.

Combination of Sequencing Batch Operation and A/O Process to Achieve Partial Mainstream Anammox: Pilot-Scale Demonstration and Microbial Ecological Mechanism

In this study, sequencing batch operation was successfully combined with a pilot-scale anaerobic biofilm-modified anaerobic/aerobic membrane bioreactor to achieve anaerobic ammonium oxidation (anammox) without inoculation of anammox aggregates for municipal wastewater treatment. Both total nitrogen and phosphorus removal efficiencies of the reactor reached up to 80% in the 250-day operation, with effluent concentrations of 4.95 mg-N/L and 0.48 mg-P/L. In situ enrichment of anammox bacteria with a maximum relative abundance of 7.86% was observed in the anaerobic biofilm, contributing to 18.81% of nitrogen removal, with denitrification being the primary removal pathway (38.41%). Denitrifying phosphorus removal (DPR) (40.54%) and aerobic phosphorus uptake (48.40%) played comparable roles in phosphorus removal. Metagenomic sequencing results showed that the biofilm contained significantly lower abundances of NO-reducing functional genes than the bulk sludge (p < 0.01), favoring anammox catabolism in the former. Interactions between the anammox bacteria and flanking community were dominated by cooperation behaviors (e.g., nitrite supply, amino acids/vitamins exchange) in the anaerobic biofilm community network. Moreover, the hydrolytic/fermentative bacteria and endogenous heterotrophic bacteria (Dechloromonas, Candidatus competibacter) were substantially enriched under sequencing batch operation, which could alleviate the inhibition of anammox bacteria by complex organics. Overall, this study provides a feasible and promising strategy for substantially enriching anammox bacteria and achieving partial mainstream anammox as well as DPR.

In a quest for high-efficiency mainstream partial nitritation-anammox (PN/A) implementation: One-stage or two-stage?

Partial nitritation-anammox (PN/A) process is known as an energy-efficient technology for wastewater nitrogen removal, which possesses a great potential to bring wastewater treatment plants close to energy neutrality with reduced carbon footprint. To achieve this goal, various PN/A processes implemented in a single reactor configuration (one-stage system) or two separately dedicated reactors configurations (two-stage system) were explored over the past decades. Nevertheless, large-scale implementation of these PN/A processes for low-strength municipal wastewater treatment has a long way to go owing to the low efficiency and effectiveness in nitrogen removal. In this work, we provided a comprehensive analysis of one-stage and two-stage PN/A processes with a focus on evaluating their engineering application potential towards mainstream implementation. The difficulty for nitrite-oxidizing bacteria (NOB) out-selection was revealed as the critical operational challenge to achieve the desired effluent quality. Additionally, the operational strategies of low oxygen commonly adopted in one-stage systems for NOB suppression and facilitating anammox bacteria growth results in a low nitrogen removal rate (NRR). Introducing denitrification into anammox system was found to be necessary to improve the nitrogen removal efficiency (NRE) by reducing the produced nitrate with in-situ utilizing the organics from wastewater itself. However, this may lead to part of organics oxidized with additional oxygen consumed in one-stage system, further compromising the NRR. By applying a relatively high dissolved oxygen in PN reactor with residual ammonium control, and followed by a granules-based anammox reactor feeding with a small portion of raw municipal wastewater, it appeared that two-stage system could achieve a good effluent quality as well as a high NRR. In contrast to the widely studied one-stage system, this work provided a unique perspective that more effort should be devoted to developing a two-stage PN/A process to evaluate its application potential of high efficiency and economic benefits towards mainstream implementation.

Highly Enriched Anammox Bacteria with a Novel Granulation Model Regulated by Epistylis spp. in Domestic Wastewater Treatment

Anammox granulation is an efficient solution proffered to enrich slow-growing anammox bacteria (AnAOB), but the lack of effective granulation strategies for low-strength domestic wastewater impedes its application. In this study, a novel granulation model regulated by Epistylis spp. for highly enriched AnAOB was revealed for the first time. Notably, anammox granulation was achieved within 65 d of domestic wastewater treatment. The stalks of Epistylis spp. were found to act as the skeleton of granules and provide attachment points for bacterial colonization, and the expanded biomass layer in turn provided more area for the unstalked free-swimming zooids. Additionally, Epistylis spp. exerted much less predation stress on AnAOB than on nitrifying bacteria, and AnAOB tended to grow in aggregates in the interior of granules, thus favoring the growth and retention of AnAOB. Ultimately, the relative abundance of AnAOB reached up to a maximum of 8.2% in granules (doubling time of 9.9 d) compared to 1.1% in flocs (doubling time of 23.1 d), representing the most substantial disparity between granules and flocs. Overall, our findings advance the current understanding of interactions involved in granulation between protozoa and microbial communities and offer new insight into the specific enrichment of AnAOB under the novel granulation model.

Simultaneous removal of nitrate and ammonium by hydrogen-based partial denitrification coupled with anammox in a membrane biofilm reactor

Hydrogen-based membrane biofilm reactors (MBfRs) are effective for nitrogen removal. However, the safety of hydrogen limited the application of MBfR. Here, a hydrogen-based partial denitrification system coupled with anammox (H₂-PDA) was constructed in an MBfR for reducing hydrogen demand significantly. The metabolomics and structures of microbial communities were analyzed to determine the phenotypic differences and drivers underlying denitrification, anammox, and H₂-PDA. These findings indicated that total nitrogen (TN) removal increased from 57.1% in S1 to 93.7% in S2. During the H₂-PDA process, partial denitrification and anammox contributed to TN removal by 93.7% and 6.3%, respectively. Community analysis indicated that the H₂-PDA system was dominated by the genus Meiothermus, which is involved in partial denitrification. Collectively, these findings confirmed the feasibility of incorporating the H₂-PDA process in a MBfR and form a foundation for the establishment of novel and practical methods for efficient nitrogen removal.

Optimum relative frequency and fluctuating substrate selection in reinforcing anammox-mediated anabolic adaptation

Adaptation to substrate fluctuations is a life actuality of microbes in global municipal wastewater treatment plants (WWTPs). Yet there remains a lack of definite information on how influent changes with different alternation frequencies shape the stability of anammox consortia and the metabolic regulations they feedback. According to human rhythmic activity, day-fluctuant fed (every 6 h, alternating between 50 and 100 mg NH₄⁺-N/L) substantially diminished the robustness of nitrogen removal efficiency (NRE; 84.1 ± 7.0%, left-skewed distribution [R² = 0.87]) and shock-resistance ability (>30% effluent variability). Unexpectedly, the anammox ecosystem under week-fluctuant mode (every 6 d) displayed adapted growth (NRE 86.6 ± 3.1%, normal distribution [R² = 0.97]), higher extracellular polymeric substances (EPS) yields, and superior tolerance (juggling the shortest recovery time and highest NRE, tightest protein secondary structure facing long-term load shocks) than steady-state (75 mg NH₄⁺-N/L). 16S sequencing showed that the influent disturbance led to increased levels of bacterial diversity, however, a similar microbiota composition between week-fluctuant and steady systems was detected. Notably, K strategist Candidatus Kuenenia was more sensitive to substrate fluctuations, with the lower relative abundance at day-fluctuant (23.4 ± 5.1%) and week-fluctuant (39.5 ± 4.3%) than at steady-state community (47.5 ± 4.2%). Conversely, Candidatus Jettenia had higher relative abundance at day-fluctuant (i.e., 1.3 ± 0.1%) compared to that at week-fluctuant (0.2 ± 0.04%) and steady-state (0.05 ± 0.03%). Importantly, untargeted metabolomics revealed that week-fluctuant grown anammox microbiota increased protein synthesis and transporter expression while decreasing expression of catabolic pathways (citric acid cycle and bypass) as a strategy for efficient substrate uptake and utilization, which clearly different to day-fluctuant and steady-state survival ways. Overall, we predictively reported an "anabolic adaptation growth state" for the anammox consortia and put forward the associated reinforcement control strategy.

Response of the mainstream anammox process to the biodegradable carbon sources in the granule-based systems: The difference in self-stratification of the microbial community

The inevitable introduction of biodegradable carbon sources (such as monosaccharides and volatile fatty acids) originating from pretreatment units might affect the performance of the mainstream anaerobic ammonium oxidation (anammox) process. Two model carbon sources (glucose and acetate) were selected to investigate their effects on granule-based anammox systems under mainstream conditions (70 mg total nitrogen (TN) L^-1, 15 °C). At a nitrogen loading rate of 2.87 ± 0.80 kg N m^-3 d^-1, a satisfactory effluent quality (TN < 10 mg L^-1) was achieved in the presence of glucose or acetate at a chemical oxygen demand (COD/N) ratio of 0.5. The contribution of anammox to nitrogen removal decreased with increasing COD/N ratio to 1.0 because the expression of anammox functional genes was inhibited, whereas the expression of denitrifying functional genes was promoted. However, the nitrogen removal efficiency of the two considered reactors was maintained above 80 %. Self-stratification of the microbial community along the reactor height facilitated a functional balance through the retention of anammox bacteria in granules but resulted in washout of denitrifying bacteria in flocs under a high-flow pattern. These findings highlighted the advantages of granule-based systems in the mainstream anammox process due to their inherent biomass self-segregation property and the need for the development of targeted biomass retention strategies.

Low strength wastewater anammox start-up and stable operation by inoculating sponge-iron sludge: Cooperation of biological iron and iron bacteria

The application of anaerobic ammonium oxidation (Anammox) technology in low-strength wastewater treatment still faces difficult in-situ start-ups and unstable operations. Sponge-iron sludge (R1) was used as a novel inoculum to provide a promising solution. Conventional activated sludge (R0) was used as the control. However, little is known about the feasibility and performance during the start-up and operation of Anammox combined with biological iron and iron bacteria in an iron sludge system. Anammox was successfully started both in R1 (87 days) and R0 (89 days) with a low-strength influent (with a nitrogen loading rate (NLR) of 43.64 ± 0.41 g N/(m3⋅d)). During long-term operation, the R0 nevertheless produced higher nitrates (9.7 ± 0.1 mg/L) than expected. In contrast, R1 presented no excess nitrate production (2.1 ± 0.06 mg/L). The total inorganic nitrogen (TIN) removal efficiency increased from 78.2 ± 7.1% in R0 to 86.1 ± 4.3% in R1. The iron sludge in R1 was divided equally into three parts and three different nitrogen-feeding methods were used over the 34 days of operation, as follows: first using a mixture of ammonium (27.15 ± 1.0 mg/L) and nitrite (32.7 ± 1.7 mg/L), then only ammonium (27.15 ± 1.0 mg/L) and lastly only nitrite (32.7 ± 1.7 mg/L) as the influent. R1 was a coupled system composed of Anammox, Feammox, and NOx--dependent Fe(II) oxidation (NDFO). The contribution of Feammox and NDFO to TIN removal was 27.1 ± 1.2% and 31.9 ± 0.7%. However, Anammox was the primary nitrogen transformation pathway. X-ray diffraction (XRD) analysis shows that iron hydroxide (Fe(OH)3) and iron oxide hydroxide (FeOOH) were generated in R1. The produced Fe(OH)3 and FeOOH were capable of participating in Feammox and formed a Fe(II)/Fe(III) cycle which further removed nitrogen. Therefore, a highly stable and impressive nitrogen removal performance was demonstrated in the iron sludge Anammox system under the cooperation of biological iron and iron bacteria. The study considered the enrichment of norank_c_OM190, Desulfuromonas, and Thiobacillus and their contribution to the Anammox, Feammox, and NDFO processes, respectively. This study provides a new perspective for the start-up and stable operation of low-strength wastewater Anammox engineering applications.

A review on upgrading of the anammox-based nitrogen removal processes: Performance, stability, and control strategies

The anaerobic ammonia oxidation (anammox) process is a promising biological nitrogen removal technology. However, owing to the sensitivity and slow cell growth of anammox bacteria, long startup time and initially low nitrogen removal rate (NRR) are still limiting factors of practical applications of anammox process. Moreover, nitrogen removal efficiency (NRE) is often lower than 88 %. This review summarizes the most common methods for improving NRR by increasing microorganism concentration, and modifying reactor configuration. Recent integrated anammox-based systems were evaluated, including hydroxyapatite (HAP)-enhanced one-stage partial nitritation/anammox (PNA) process for a high NRR of over 2 kg N/m3/d at 25 °C, partial denitrification/anammox (PDA) process, and simultaneous partial nitrification, anammox, and denitrification process for a high NRE of up to 100 %. After discussing the challenges for the application of these systems critically, a combined system of anaerobic digestion, HAP-enhanced one-stage PNA and PDA is proposed in order to achieve a high NRR, high NRE, and phosphorus removal simultaneously.

Removal of extracellular deoxyribonucleic acid increases the permeability and mass transfer of anammox granular sludge with different sizes

As a key component of extracellular polymeric substances (EPS), extracellular deoxyribonucleic acid (eDNA) acts as a bridge in maintaining the structural stability of granular sludge. However, its ability of carrying antibiotic resistance genes (ARGs) promotes the gene horizontal transfer, raising a high risk for human health. In this study, a series of batch tests were performed to elucidate the response of anammox granular sludge (AnGS) with different sizes (S-AnGS with diameters lower than 0.9 mm and L-AnGS with diameters of 0.9-2 mm) to the removal of eDNA and corresponding mechanism. The results showed that the highest bioactivity of S-AnGS and L-AnGS was achieved by adding DNase I, and the absolute abundance of hzsA in the systems also increased. The dominant microorganism in each sludge was Candidatus Kuenenia, which maintained a higher relative abundance of 24% in S-AnGS. Settling experiments demonstrated that the permeability of AnGS was positively correlated with the addition of DNase I. The permeability index of granular sludge, Г, rose by 58.54% in S-AnGS and 11.79% in L-AnGS. The absence of eDNA is conducive to the increase in the permeability and porosity of AnGS. Similarity in the functional genes and microbial communities of intracellular and extracellular DNA implied the occurrence of gene transmembrane transfer. The findings enrich our knowledge of eDNA in anammox granules and provide a guidance for the specific control of gene transfer through reducing eDNA.

Evaluation of long-term preservation and reactivation efficiency of anaerobic ammonium oxidation (anammox) microorganisms based on activation energy

The preservation efficiency of mainstream (M-ANA) and sidestream anaerobic ammonium oxidation (anammox) (S-ANA) were evaluated based on their activation energy (E_a). The E_a of M-ANA cultivated under low nitrogen loads was lower than that of S-ANA, which greatly contributed to enhancing the viability of anammox during preservation at 4 °C. After preservation for 140 d, the decay rate (b_AN) of M-ANA ranged from 0.0012 to 0.0013/d; the b_AN of S-ANA was 0.0036-0.0041/d. The addition of hydrazine, which requires minimal energy to activate anammox metabolism, is highly beneficial for the viability of microorganisms. The low E_a of anammox contributes to efficient reactivation with rapid reactivation of heme c, and the addition of hydrazine makes the process more beneficial. Although the specific nitrogen removal rate of the M-SNA seed sludge was much lower than that of S-ANA, the rate of M-ANA became higher after 48 days of reactivation.

Response of amino acid metabolism to decreased temperatures in anammox consortia: Strong, efficient and flexible

Although amino acid (AA) metabolism is basis of bacterial activities, unique characteristics of its response to decreased temperatures are not fully understood. Achieving nitrogen removal rate of 130-150 mg N/ (L∙d), metabolic differences of anammox consortia between 35 °C and four decreased temperatures (15-30 °C) were revealed respectively. 0-11.4-fold abundance variation of marker metabolites evidenced change of key metabolism (metabolism of AA, lipid and energy production) at decreased temperatures. However, AA metabolism varied more obviously than others, implying stronger response and higher functional potential. Efficiently, network topology confirmed more cellular processes represented by growth metabolism and biofilm formation were influenced by AA metabolism. Flexibly, down-regulated biosynthesis of unfavorable AAs for psychrophilic enzyme differed from enhanced biosynthesis of costly AAs, which only matched partial decreased temperatures to save energy. This work elucidates advantages of AA metabolism over others, exogenous amino acids could significantly promote activity of anammox bacteria at decreased temperatures.

Physiology of anammox adaptation to low temperatures and promising biomarkers: A review

The adaptation of bacteria involved in the anaerobic ammonium oxidation (anammox) to low temperatures in the mainstream of WWTP will unlock substantial treatment savings. However, their adaptation mechanisms have begun to be revealed only very recently. This study reviewed the state-of-the-art knowledge on these mechanisms from -omics studies, crucially including metaproteomics and metabolomics. Anammox bacteria adapt to low temperatures by synthesizing both chaperones of RNA and proteins and chemical chaperones. Furthermore, they preserve energy for the core metabolism by reducing biosynthesis in general. Thus, in this study, a number of biomarkers are proposed to help practitioners assess the extent of anammox bacteria adaptation and predict the decomposition of biofilms/granules or slower growth. The promising biomarkers also include unique ladderane lipids. Further proteomic and metabolomic studies are necessary for a more detailed understanding of anammox low-temperature adaptation, thus easing the transition to more cost-effective and sustainable wastewater treatment.

Anammox sludge preservation: Preservative agents, temperature and substrate

The difficulties of enrichment and preservation of anaerobic ammonium oxidation bacteria (AnAOB) greatly limit their application in practice. Herein, traditional and emerging preservative agents (e.g., EPS + N2H4, betaine, glycerol and trehalose) were evaluated for their preservation of AnAOB-dominant sludge at different temperatures (e.g., 4 °C and room temperature). In addition, the effects of substrates on preservation were also considered. The results showed that adding betaine or glycerol at 4 °C was the optimal strategy for preserving anammox granular sludge. The relative anammox activities (rAA) increased by 145.26% and 158.30% at the recovery phase, respectively. Moreover, the absolute abundances of functional gene hzsA increased by 339% and 46%, respectively. Although the granular properties and microbial community structures changed during the preservation, the general performance of anammox granules could effectively restored. Collectively, this study provides the optimal strategies for anammox sludge preservation at low temperatures.

Performance and mechanism analysis of gel immobilized anammox bacteria in treating different proportions of domestic wastewater: a valid alternative to granular sludge

The treatment performance of anaerobic ammonia oxidation (anammox) immobilized filler on different proportions of domestic wastewater was evaluated. The results showed that, in comparison to synthetic wastewater, 50% domestic wastewater promoted the anammox reaction of immobilized filler, while 100% domestic wastewater had no significant effect on the anammox activity of immobilized filler but the total nitrogen removal efficiency (TNRE) was improved through enhanced denitrification. The TNRE of the immobilized filler was 82.5%, which was significantly higher than that of AnGS (69.7%), and its average anammox contribution rate was more than 90%. This was because the encapsulated anammox biomass could better maintain competitive advantages and coordinate the symbiotic relationship with denitrifying bacteria. Moreover, lower NH₄⁺-N concentration resulted in greater influence of C/N ratio on anammox performance than COD concentration, while the opposite was true at high NH₄⁺-N concentration. This study verified that anammox immobilized filler is effective for mainstream applications.

The anammox coupled partial-denitrification process in an integrated granular sludge and fixed-biofilm reactor developed for mainstream wastewater treatment: Performance and community structure

This study describes an integrated granular sludge and fixed-biofilm (iGB) reactor innovatively designed to carry out the anammox/partial-denitrification (A/PD) process for nitrogen removal with mainstream municipal wastewater. The iGB-A/PD reactor consists of anammox granules inoculated in the lower region of reactor and an acclimated fixed-biofilm positioned in the upper region. Compared to the other reported A/PD systems for mainstream wastewater treatment, this iGB-A/PD reactor is notable due to its higher quality effluent with a total inorganic nitrogen (TIN) of ∼3 mg•L^-1 and operation at a high nitrogen removal rate (NRR) of 0.8 ± 0.1 kg-N•m^-3•d^-1. Reads-based metatranscriptomic analysis found that the expression values of hzsA and hdh, key genes associated with anammox, were much higher than other functional genes on nitrogen conversion, confirming the major roles of the anammox bacteria in nitrogen bio-removal. In both regions of the reactor, the nitrate reduction genes (napA/narG) had expression values of 56-99 RPM, which were similar to that of the nitrite reduction genes (nirS/nirK). The expression reads from genes for dissimilatory nitrate reduction to ammonium (DNRA), nrfA and nirB, were unexpectedly high, and were over the half of the levels of reads from genes required for nitrate reduction. Kinetic assays confirmed that the granules had an anammox activity of 16.2 g-NH₄⁺-N•kg^-1-VSS•d^-1 and a nitrate reduction activity of 4.1 g-N•kg^-1-VSS•d^-1. While these values were changed to be 4.9 g- NH₄⁺-N•kg^-1-VSS•d^-1and 4.3 g-N•kg^-1-VSS•d^-1 respectively in the fixed-biofilm. Mass flux determination found that PD and DNRA was responsible for ∼50% and ∼25% of nitrate reduction, respectively, in the whole reactor, consistent with high effluent quality and treatment efficiency via a nitrite loop. Metagenomic binning analysis revealed that new and unidentified anammox species, affiliated with Candidatus Brocadia, were the dominant anammox organisms. Myxococcota and Planctomycetota were the principal organisms associated with the PD and DNRA processes, respectively.

Cultivation of sulfide-driven partial denitrification granules for efficient nitrite generation from nitrate-sulfide-laden wastewater

Sulfide partial denitrification (SPD) is an alternative pathway for nitrite production accompanied with elemental sulfur (S⁰) production for nitrate removal from wastewater with anammox. In this study, the SPD granular sludge was cultivated for the first time in an upflow anaerobic sludge bed (UASB) reactor to reach the efficacy of maximum nitrate-to-nitrite transformation ratio of 92% and an in-situ maximum NO₃^--N reduction rate of 2.46 kg-N/m³-d, both much higher than literature results. Mature granules had an average particle size of 2.52 mm and hold smooth surface with excess rod bacteria. The elements Ca and S, and proteins in extracellular polymeric substances contributed to granule structure's stability. Enriched Thiobacillus genus was proposed to accumulate nitrite at moderate HRT (2-6 h). The immobilized functional strains assist efficient partial nitrification reactions to be realized with formed S⁰ as byproduct.

Hydroxylamine metabolism in mainstream denitrifying ammonium oxidation (DEAMOX) process: Achieving fast start-up and robust operation with bio-augmentation assistance under ambient temperature

Nitrogen removal from mainstream wastewater via DEnitrifying AMmonium OXidation (DEAMOX) is often challenged by undulated actual temperature and high loading rate. Here, we discovered NH₂OH addition (HA) and bio-augmentation (BA) tactics on start-up and operation performance of DEAMOXs (R1 and R2) under ambient temperature (11.3-31.7 °C). Over 340-day operation suggested that R2 received 10 mg/L HA and 1:25 BA ratio (v/v, anammox/partial denitrification sludge) achieved desirable nitrogen removal efficiency (NRE) of 97.22% after 145-day, while R1 under higher BA ratio of 1:12.5 without HA obtained lower NRE (90.86%) after 184-day. Batch tests revealed that nitrate-nitrite transformation ratio reached 98.64% at low COD/NO₃^--N of 2.6 with HA. Significantly, compared with R2, R1 recovered quickly with satisfactory effluent total nitrogen of 4.21 mg/L despite nitrogen loading rate greater than 0.15 kg N/m³/d and temperature decreased to 14.6 °C. The abundant narG represented high nitrate reduction potential, hzsA and hdh were extensively detected as the symbolisation of anammox metabolism. Thauera, Denitratisoma and unclassified f Comamonadaceae dominated nitrite accumulation. Ca. Brocadia as the dominant anammox bacteria, and its population maintained stable against low temperature and load shocks by NH₂OH intensification. Overall, this study offers an opportunity for the wide-applications of DEAMOX treating mainstream wastewater.

Architecture of HAP-anammox granules contributed to high capacity and robustness of nitrogen removal under 7°C

The anaerobic ammonium oxidation (anammox) process is an autotrophic nitrogen removal process with great potential as a cost-effective and highly efficient technology in the wastewater treatment field. The main challenges yet to be overcome in this new frontier technology are operating at lower temperatures and achieving a high and stable nitrogen removal efficiency. In this study, an up-flow expanded bed reactor with hydroxyapatite (HAP)-anammox granules was operated for more than 200 days at 7°C. The nitrogen loading rate (NLR) was improved from 1.0 g-N/L/d to 3.6 g-N/L/d, together with a high-level nitrogen removal efficiency of 84-92%, which is the highest to date at extremely low temperatures in a continuous experiment. Candidatus Kuenenia was revealed to be the only dominant anammox genus, with a relative abundance of 35.3-37.5%. The optimal operational temperature was around 35°C and the apparent activation energy (E_a) was calculated as 78.37 kJ/mol. The three-layers architecture and architectural evolution of HAP-anammox granules into HAP-cores and peeling biofilms with outstanding settling performance were characterized. Under 7°C, the high capacity of nitrogen removal with robust removal efficiency using HAP-anammox granules was achieved.

Partial-nitritation of low-strength anaerobic effluent: A moderate-high dissolved oxygen concentration facilitates ammonia-oxidizing bacteria disinhibition and nitrite-oxidizing bacteria suppression

Integrating anaerobic treatment with partial nitritation (PN)/anammox is a promising technology to achieve energy-efficient wastewater treatment, while partial nitritation of the mainstream anaerobic effluent (Aneff) was rarely reported. A PN reactor fed with low-strength Aneff was employed in this study to investigate the performance and technology bottleneck of this process. When operated at low dissolved oxygen (DO) concentration (0.30-0.43 mg/L), gene coding hydroxylamine oxidation (hao) was severely suppressed by bio-refractory organics, which results in a decreased ammonia-oxidizing bacteria activity and nitrite accumulation rate. The ammonium conversion and nitrite accumulation were recovered by increasing the DO concentration to a moderate-high level (1.10 ± 0.20 mg/L) and achieved long-term stable operation. At this condition, hao showed a dramatic increase while gene encoding nitrite oxidoreductase was appropriately suppressed; the effluent NO₂^-/NH₄⁺ ratio reached 1.17, and a low NO₃^-/NO_x^- ratio of 0.38 was achieved simultaneously. The findings in this study revealed the adverse effects of Aneff on PN and supported a practical operating strategy for efficient PN of Aneff.

Rapid formation of granules coupling n-DAMO and anammox microorganisms to remove nitrogen

Granular sludge exhibits unique features, including rapid settling velocity, high loading rate and relative insensitivity against inhibitors, thus being a favorable platform for the cultivation of slow-growing and vulnerable microorganisms, such as anaerobic ammonium oxidation (anammox) bacteria and nitrite/nitrate-dependent anaerobic methane oxidation (n-DAMO) microorganisms. While anammox granules have been widely applied, little is known about how to speed up the granulation process of n-DAMO microorganisms, which grow even slower than anammox bacteria. In this study, we used mature anammox granules as biotic carriers to embed n-DAMO microorganisms, which obtained combined anammox + n-DAMO granules within 6 months. The results of whole-granule 16S rRNA gene amplicon sequencing showed the coexistence of anammox bacteria, n-DAMO bacteria and n-DAMO archaea. The microbial stratification along granule radius was further elucidated by cryosection-16S rRNA gene amplicon sequencing, showing the dominance of n-DAMO archaea and anammox bacteria at inner and outer layers, respectively. Moreover, the images of cryosection-fluorescence in situ hybridization (FISH) verified this stratification and also indicated a shift in microbial stratification. Specifically, n-DAMO bacteria and n-DAMO archaea attached to the anammox granule surface initially, which moved to the inner layer after 4-months operation. On the basis of combined anammox + n-DAMO granules, a practically useful nitrogen removal rate (1.0 kg N/m³/d) was obtained from sidestream wastewater, which provides new avenue to remove nitrogen from wastewater using methane as carbon source.