1
|
Sarikaya B, Bück H, Pohen G, Rodrigues F, Günster K, Wefelmeier K, Miebach K, Blank LM, Büchs J. Adaptive laboratory evolution in a novel parallel shaken pH-auxostat. Biotechnol Bioeng 2024. [PMID: 38932440 DOI: 10.1002/bit.28789] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/15/2024] [Accepted: 06/15/2024] [Indexed: 06/28/2024]
Abstract
Adaptive laboratory evolution (ALE) is a widely used microbial strain development and optimization method. ALE experiments, to select for faster-growing strains, are commonly performed as serial batch cultivations in shake flasks, serum bottles, or microtiter plates or as continuous cultivations in bioreactors on a laboratory scale. To combine the advantages of higher throughput in parallel shaken cultures with continuous fermentations for conducting ALE experiments, a new Continuous parallel shaken pH-auxostat (CPA) was developed. The CPA consists of six autonomous parallel shaken cylindrical reactors, equipped with real-time pH control of the culture medium. The noninvasive pH measurement and control are realized by biocompatible pH sensor spots and a programmable pump module, to adjust the dilution rate of fresh medium for each reactor separately. Two different strains of the methylotrophic yeast Ogataea polymorpha were used as microbial model systems for parallel chemostat and pH-auxostat cultivations. During cultivation, the medium is acidified by the microbial activity of the yeast. For pH-auxostat cultivations, the growth-dependent acidification triggers the addition of fresh feed medium into the reactors, leading to a pH increase and thereby to the control of the pH to a predetermined set value. By controlling the pH to a predetermined set value, the dilution rate of the continuous cultivation is adjusted to values close to the washout point, in the range of the maximum specific growth rate of the yeast. The pH control was optimized by conducting a step-response experiment and obtaining tuned PI controller parameters by the Chien-Hrones-Reswick (CHR) PID tuning method. Two pH-auxostat cultivations were performed with two different O. polymorpha strains at high dilution rates for up to 18 days. As a result, up to 4.8-fold faster-growing strains were selected. The increased specific maximum growth rates of the selected strains were confirmed in subsequent batch cultivations.
Collapse
Affiliation(s)
- Burak Sarikaya
- AVT-Biochemical Engineering, RWTH Aachen University, Aachen, Germany
| | - Hendrik Bück
- AVT-Biochemical Engineering, RWTH Aachen University, Aachen, Germany
| | - Gino Pohen
- AVT-Biochemical Engineering, RWTH Aachen University, Aachen, Germany
| | - Filipe Rodrigues
- AVT-Biochemical Engineering, RWTH Aachen University, Aachen, Germany
| | - Karsten Günster
- AVT-Biochemical Engineering, RWTH Aachen University, Aachen, Germany
| | - Katrin Wefelmeier
- iAMB-Institute of Applied Microbiology, ABBt-Aachen Biology and Biotechnology, RWTH Aachen University, Aachen, Germany
| | - Katharina Miebach
- AVT-Biochemical Engineering, RWTH Aachen University, Aachen, Germany
| | - Lars M Blank
- iAMB-Institute of Applied Microbiology, ABBt-Aachen Biology and Biotechnology, RWTH Aachen University, Aachen, Germany
| | - Jochen Büchs
- AVT-Biochemical Engineering, RWTH Aachen University, Aachen, Germany
| |
Collapse
|
2
|
Lapierre FM, Huber R. Feeding strategies for Sporosarcina pasteurii cultivation unlock more efficient production of ureolytic biomass for MICP. Biotechnol J 2024; 19:e2300466. [PMID: 38581094 DOI: 10.1002/biot.202300466] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/05/2023] [Revised: 01/12/2024] [Accepted: 01/29/2024] [Indexed: 04/08/2024]
Abstract
The bacterium Sporosarcina pasteurii is the most commonly used microorganism for Microbial Induced Calcite Precipitation (MICP) due to its high urease activity. To date, no proper fed-batch cultivation protocol for S. pasteurii has been published, even though this cultivation method has a high potential for reducing costs of producing microbial ureolytic biomass. This study focusses on fed-batch cultivation of S. pasteurii DSM33. The study distinguishes between limited fed-batch cultivation and extended batch cultivation. Simply feeding glucose to a S. pasteurii culture does not seem beneficial. However, it was exploited that S. pasteurii is auxotrophic for two vitamins and amino acids. Limited fed-batch cultivation was accomplished by feeding the necessary vitamins or amino acids to a culture lacking them. Feeding nicotinic acid to a nicotinic acid deprived culture resulted in a 24% increase of the specific urease activity compared to a fed culture without nicotinic acid limitation. Also, extended batch cultivation was explored. Feeding a mixture of glucose and yeast extract results in OD600 of ≈70 at the end of cultivation, which is the highest value published in literature so far. These results have the potential to make MICP applications economically viable.
Collapse
Affiliation(s)
- Frédéric M Lapierre
- Department of Engineering and Management, Munich University of Applied Sciences, Munich, Germany
| | - Robert Huber
- Department of Engineering and Management, Munich University of Applied Sciences, Munich, Germany
| |
Collapse
|
3
|
Keshri J, Smith KM, Svendsen MK, Keillor HR, Moss ML, Jordan HJ, Larkin AM, Garrish JK, Line JE, Ball PN, Oakley BB, Seal BS. Phenotypic Characterization and Draft Genome Sequence Analyses of Two Novel Endospore-Forming Sporosarcina spp. Isolated from Canada Goose ( Branta canadensis) Feces. Microorganisms 2023; 12:70. [PMID: 38257897 PMCID: PMC10818898 DOI: 10.3390/microorganisms12010070] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/22/2023] [Revised: 12/15/2023] [Accepted: 12/22/2023] [Indexed: 01/24/2024] Open
Abstract
In an attempt to isolate new probiotic bacteria, two Gram-variable, spore-forming, rod-shaped aerobic bacteria designated as strain A4 and A15 were isolated from the feces of Canada geese (Branta canadensis). Strain A4 was able to grow in high salt levels and exhibited lipase activity, while A15 did not propagate under these conditions. Both were positive for starch hydrolysis, and they inhibited the growth of Staphylococcus aureus. The strains of the 16S rRNA sequence shared only 94% similarity to previously identified Sporosarcina spp. The ANI (78.08%) and AAI (82.35%) between the two strains were less than the species threshold. Searches for the most similar genomes using the Mash/Minhash algorithm showed the nearest genome to strain A4 and A15 as Sporosarcina sp. P13 (distance of 21%) and S. newyorkensis (distance of 17%), respectively. Sporosarcina spp. strains A4 and A15 contain urease genes, and a fibronectin-binding protein gene indicates that these bacteria may bind to eukaryotic cells in host gastrointestinal tracts. Phenotypic and phylogenetic data, along with low dDDH, ANI, and AAI values for strains A4 and A15, indicate these bacteria are two novel isolates of the Sporosarcina genus: Sporosarcina sp. A4 sp. nov., type strain as Sporosarcina cascadiensis and Sporosarcina sp. A15 sp. nov., type strain Sporosarcina obsidiansis.
Collapse
Affiliation(s)
- Jitendra Keshri
- College of Veterinary Medicine, Western University of Health Sciences, Pomona, CA 91766, USA;
| | - Kristina M. Smith
- Biology Program, Oregon State University Cascades, Bend, OR 97702, USA; (K.M.S.); (M.K.S.); (H.R.K.); (M.L.M.); (H.J.J.); (A.M.L.); (P.N.B.)
| | - Molly K. Svendsen
- Biology Program, Oregon State University Cascades, Bend, OR 97702, USA; (K.M.S.); (M.K.S.); (H.R.K.); (M.L.M.); (H.J.J.); (A.M.L.); (P.N.B.)
| | - Haley R. Keillor
- Biology Program, Oregon State University Cascades, Bend, OR 97702, USA; (K.M.S.); (M.K.S.); (H.R.K.); (M.L.M.); (H.J.J.); (A.M.L.); (P.N.B.)
| | - Madeline L. Moss
- Biology Program, Oregon State University Cascades, Bend, OR 97702, USA; (K.M.S.); (M.K.S.); (H.R.K.); (M.L.M.); (H.J.J.); (A.M.L.); (P.N.B.)
| | - Haley J. Jordan
- Biology Program, Oregon State University Cascades, Bend, OR 97702, USA; (K.M.S.); (M.K.S.); (H.R.K.); (M.L.M.); (H.J.J.); (A.M.L.); (P.N.B.)
| | - Abigail M. Larkin
- Biology Program, Oregon State University Cascades, Bend, OR 97702, USA; (K.M.S.); (M.K.S.); (H.R.K.); (M.L.M.); (H.J.J.); (A.M.L.); (P.N.B.)
| | - Johnna K. Garrish
- Poultry Microbiological Safety & Processing Research Unit, U.S. National Poultry Research Center, Athens, GA 30605, USA; (J.K.G.); (J.E.L.)
| | - John Eric Line
- Poultry Microbiological Safety & Processing Research Unit, U.S. National Poultry Research Center, Athens, GA 30605, USA; (J.K.G.); (J.E.L.)
| | - Patrick N. Ball
- Biology Program, Oregon State University Cascades, Bend, OR 97702, USA; (K.M.S.); (M.K.S.); (H.R.K.); (M.L.M.); (H.J.J.); (A.M.L.); (P.N.B.)
| | - Brian B. Oakley
- College of Veterinary Medicine, Western University of Health Sciences, Pomona, CA 91766, USA;
| | - Bruce S. Seal
- Biology Program, Oregon State University Cascades, Bend, OR 97702, USA; (K.M.S.); (M.K.S.); (H.R.K.); (M.L.M.); (H.J.J.); (A.M.L.); (P.N.B.)
| |
Collapse
|
4
|
Kariminia T, Rowshanzamir MA, Abtahi SM, Soleimanian-Zad S, Bak HM, Baghbanan A. Soil microbial improvement using enriched vinasse as a new abundant waste. Sci Rep 2023; 13:22279. [PMID: 38097757 PMCID: PMC10721901 DOI: 10.1038/s41598-023-49401-w] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/11/2023] [Accepted: 12/07/2023] [Indexed: 12/17/2023] Open
Abstract
This study proposes the use of vinasse, an inexpensive and readily available waste biopolymer, as a fundamental component of a waste culture medium that can enhance the effectiveness and cost-efficiency of the microbial-induced calcite precipitation (MICP) method for sustainable soil improvement. Vinasse enriched with urea, sodium caseinate, or whey protein concentrate is employed to optimize bacterial growth and urease activity of Sporosarcina pasteurii (S. pasteurii) bacterium. The best culture medium is analyzed using Taguchi design of experiments (TDOE) and statistical analysis, considering the concentration of vinasse and urea as effective parameters during growth time. To test the best culture medium for bio-treated soil, direct shear tests were performed on loose and bio-treated sand. The results demonstrate a substantial cost reduction from $0.455 to $0.005 per liter when using the new culture medium (vinasse and urea) compared to the conventional Nutrient Broth (NB) culture medium. Additionally, the new medium enhances soil shear strength, increasing the friction angle by 2.5 degrees and cohesion to 20.7 kPa compared to the conventional medium. Furthermore, the recycling of vinasse as a waste product can promote the progress of a circular economy and reduce environmental pollution. As ground improvement is essential for many construction projects, especially those that require high shear strength or are built on loose soil, this study provides a promising approach to achieving cost-effective and sustainable soil microbial improvement using enriched vinasse.
Collapse
Affiliation(s)
- Tahereh Kariminia
- Department of Civil Engineering, Isfahan University of Technology, Isfahan, 84156-83111, Iran
| | - Mohammad A Rowshanzamir
- Department of Civil Engineering, Isfahan University of Technology, Isfahan, 84156-83111, Iran
| | - S Mahdi Abtahi
- Department of Civil Engineering, Isfahan University of Technology, Isfahan, 84156-83111, Iran.
| | - Sabihe Soleimanian-Zad
- Department of Food Science and Technology, College of Agriculture, Isfahan University of Technology, Isfahan, 84156-83111, Iran
- Research Institute for Biotechnology and Bioengineering, Isfahan University of Technology, Isfahan, 84156-83111, Iran
| | - Hamid Mortazavi Bak
- School of Civil and Environmental Engineering, University of New South Wales, Sydney, 2052, Australia
| | - Alireza Baghbanan
- Department of Mining Engineering, Isfahan University of Technology, Isfahan, 84156-83111, Iran
| |
Collapse
|
5
|
Carter MS, Tuttle MJ, Mancini JA, Martineau R, Hung CS, Gupta MK. Microbially Induced Calcium Carbonate Precipitation by Sporosarcina pasteurii: a Case Study in Optimizing Biological CaCO 3 Precipitation. Appl Environ Microbiol 2023; 89:e0179422. [PMID: 37439668 PMCID: PMC10467343 DOI: 10.1128/aem.01794-22] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 07/14/2023] Open
Abstract
Current production of traditional concrete requires enormous energy investment that accounts for approximately 5 to 8% of the world's annual CO2 production. Biocement is a building material that is already in industrial use and has the potential to rival traditional concrete as a more convenient and more environmentally friendly alternative. Biocement relies on biological structures (enzymes, cells, and/or cellular superstructures) to mineralize and bind particles in aggregate materials (e.g., sand and soil particles). Sporosarcina pasteurii is a workhorse organism for biocementation, but most research to date has focused on S. pasteurii as a building material rather than a biological system. In this review, we synthesize available materials science, microbiology, biochemistry, and cell biology evidence regarding biological CaCO3 precipitation and the role of microbes in microbially induced calcium carbonate precipitation (MICP) with a focus on S. pasteurii. Based on the available information, we provide a model that describes the molecular and cellular processes involved in converting feedstock material (urea and Ca2+) into cement. The model provides a foundational framework that we use to highlight particular targets for researchers as they proceed into optimizing the biology of MICP for biocement production.
Collapse
Affiliation(s)
- Michael S. Carter
- Materials and Manufacturing Directorate Air Force Research Lab, Wright-Patterson Air Force Base, Dayton, Ohio, USA
- Biological and Nanoscale Technologies Division, UES, Inc., Dayton, Ohio, USA
| | - Matthew J. Tuttle
- Materials and Manufacturing Directorate Air Force Research Lab, Wright-Patterson Air Force Base, Dayton, Ohio, USA
- Biological and Nanoscale Technologies Division, UES, Inc., Dayton, Ohio, USA
| | - Joshua A. Mancini
- Materials and Manufacturing Directorate Air Force Research Lab, Wright-Patterson Air Force Base, Dayton, Ohio, USA
- Biological and Nanoscale Technologies Division, UES, Inc., Dayton, Ohio, USA
| | - Rhett Martineau
- Materials and Manufacturing Directorate Air Force Research Lab, Wright-Patterson Air Force Base, Dayton, Ohio, USA
- Biological and Nanoscale Technologies Division, UES, Inc., Dayton, Ohio, USA
| | - Chia-Suei Hung
- Materials and Manufacturing Directorate Air Force Research Lab, Wright-Patterson Air Force Base, Dayton, Ohio, USA
| | - Maneesh K. Gupta
- Materials and Manufacturing Directorate Air Force Research Lab, Wright-Patterson Air Force Base, Dayton, Ohio, USA
| |
Collapse
|
6
|
Goldmanns J, Röhling GA, Lipa MK, Scholand T, Deitert A, May T, Haas EP, Boy M, Herold A, Büchs J. Development of a chemically defined medium for Paenibacillus polymyxa by parallel online monitoring of the respiration activity in microtiter plates. BMC Biotechnol 2023; 23:25. [PMID: 37507713 PMCID: PMC10385886 DOI: 10.1186/s12896-023-00793-7] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/07/2022] [Accepted: 07/10/2023] [Indexed: 07/30/2023] Open
Abstract
BACKGROUND One critical parameter in microbial cultivations is the composition of the cultivation medium. Nowadays, the application of chemically defined media increases, due to a more defined and reproducible fermentation performance than in complex media. In order, to improve cost-effectiveness of fermentation processes using chemically defined media, the media should not contain nutrients in large excess. Additionally, to obtain high product yields, the nutrient concentrations should not be limiting. Therefore, efficient medium optimization techniques are required which adapt medium compositions to the specific nutrient requirements of microorganisms. RESULTS Since most Paenibacillus cultivation protocols so far described in literature are based on complex ingredients, in this study, a chemically defined medium for an industrially relevant Paenibacillus polymyxa strain was developed. A recently reported method, which combines a systematic experimental procedure in combination with online monitoring of the respiration activity, was applied and extended to identify growth limitations for Paenibacillus polymyxa. All cultivations were performed in microtiter plates. By systematically increasing the concentrations of different nutrient groups, nicotinic acid was identified as a growth-limiting component. Additionally, an insufficient buffer capacity was observed. After optimizing the growth in the chemically defined medium, the medium components were systematically reduced to contain only nutrients relevant for growth. Vitamins were reduced to nicotinic acid and biotin, and amino acids to methionine, histidine, proline, arginine, and glutamate. Nucleobases/-sides could be completely left out of the medium. Finally, the cultivation in the reduced medium was reproduced in a laboratory fermenter. CONCLUSION In this study, a reliable and time-efficient high-throughput methodology was extended to investigate limitations in chemically defined media. The interpretation of online measured respiration activities agreed well with the growth performance of samples measured in parallel via offline analyses. Furthermore, the cultivation in microtiter plates was validated in a laboratory fermenter. The results underline the benefits of online monitoring of the respiration activity already in the early stages of process development, to avoid limitations of medium components, oxygen limitation and pH inhibition during the scale-up.
Collapse
Affiliation(s)
- Jennifer Goldmanns
- RWTH Aachen University, AVT - Biochemical Engineering, Forckenbeckstraße 51, 52074, Aachen, Germany
| | - Georg Andreas Röhling
- RWTH Aachen University, AVT - Biochemical Engineering, Forckenbeckstraße 51, 52074, Aachen, Germany
| | - Marie Kristine Lipa
- RWTH Aachen University, AVT - Biochemical Engineering, Forckenbeckstraße 51, 52074, Aachen, Germany
| | - Theresa Scholand
- RWTH Aachen University, AVT - Biochemical Engineering, Forckenbeckstraße 51, 52074, Aachen, Germany
| | - Alexander Deitert
- RWTH Aachen University, AVT - Biochemical Engineering, Forckenbeckstraße 51, 52074, Aachen, Germany
| | - Tobias May
- BASF SE, Carl-Bosch-Straße 38, Ludwigshafen am Rhein, 67056, Germany
| | | | - Matthias Boy
- BASF SE, Carl-Bosch-Straße 38, Ludwigshafen am Rhein, 67056, Germany
| | - Andrea Herold
- BASF SE, Carl-Bosch-Straße 38, Ludwigshafen am Rhein, 67056, Germany
| | - Jochen Büchs
- RWTH Aachen University, AVT - Biochemical Engineering, Forckenbeckstraße 51, 52074, Aachen, Germany.
| |
Collapse
|
7
|
Dewi AK, Sharma RK, Das K, Sukul U, Lin PY, Huang YH, Lu CM, Lu CK, Chen TH, Chen CY. Biologically-induced synthetic manganese carbonate precipitate (BISMCP) for potential applications in heavy metal removal. Heliyon 2023; 9:e15919. [PMID: 37223715 PMCID: PMC10200859 DOI: 10.1016/j.heliyon.2023.e15919] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/14/2022] [Revised: 01/14/2023] [Accepted: 04/26/2023] [Indexed: 05/25/2023] Open
Abstract
Heavy metal pollution of water is a burning issue of today's world. Among several strategies involved for heavy metal remediation purpose, biomineralization has shown great potential. Of late, research has been focused on developing effective mineral adsorbents with reduced time and cost consumption. In this present paper, the Biologically-Induced Synthetic Manganese Carbonate Precipitate (BISMCP) was produced based on the biologically-induced mineralization method, employing Sporosarcina pasteurii in aqueous solutions containing urea and MnCl2. The prepared adsorbent was characterized using Fourier transform infrared spectroscopy (FTIR), scanning electron microscopy (SEM), SEM-energy dispersive X-ray spectroscopy (SEM-EDX), X-ray diffraction (XRD) and BET surface area analyzer. EDX analysis showed the elements in the crystal BISMCP were Mn, C, and O. XRD result of BISMCP determined the crystal structure, which is close to rhodochrosite (MnCO3). Spectral peaks of FTIR at 1641.79 cm-1 confirmed the appearance of C[bond, double bond]O binding, with strong stretching of CO32- in Amide I. From the six kinds of BISMCP produced, sample MCP-6 has the higher specific surface area by BET analysis at 109.01 m2/g, with pore size at 8.76 nm and higher pore volume at 0.178 cm3/g. These specifications will be suitable as an adsorbent for heavy metal removal by adsorption process. This study presents a preliminary analysis of the possibility of BISMCP for heavy metals adsorption using ICP multi-element standard solution XIII (As, Cr, Cd, Cu, Ni, and Zn). BISMCP formed from 0.1 MnCl2 and 30 ml of bacteria volume (MCP-6) produced a better adsorbent material than others concentrations, with the adsorption efficiency of total As at 98.9%, Cr at 97.0%, Cu at 94.7%, Cd at 88.3%, Zn at 48.6%, and Ni at 29.5%. Future work could be examined its efficiency adsorbing individual heavy metals.
Collapse
Affiliation(s)
- Anggraeni Kumala Dewi
- Department of Physics, National Chung Cheng University, University Road, Minhsiung, Chiayi County, 62102, Taiwan
- Doctoral Program in Science, Technology, Environment, and Mathematics, Department of Earth and Environmental Sciences, National Chung Cheng University, 168 University Road, Min-Hsiung, Chiayi County, 62102, Taiwan
| | - Raju Kumar Sharma
- Doctoral Program in Science, Technology, Environment, and Mathematics, Department of Earth and Environmental Sciences, National Chung Cheng University, 168 University Road, Min-Hsiung, Chiayi County, 62102, Taiwan
- Department of Chemistry and Biochemistry, National Chung Cheng University, 168 University Road, Min-Hsiung, Chiayi County, 62102, Taiwan
| | - Koyeli Das
- Doctoral Program in Science, Technology, Environment, and Mathematics, Department of Earth and Environmental Sciences, National Chung Cheng University, 168 University Road, Min-Hsiung, Chiayi County, 62102, Taiwan
- Department of Biomedical Sciences, Graduate Institute of Molecular Biology, National Chung Cheng University, 168 University Road, Min-Hsiung, Chiayi County, 62102, Taiwan
| | - Uttara Sukul
- Doctoral Program in Science, Technology, Environment, and Mathematics, Department of Earth and Environmental Sciences, National Chung Cheng University, 168 University Road, Min-Hsiung, Chiayi County, 62102, Taiwan
- Department of Biomedical Sciences, Graduate Institute of Molecular Biology, National Chung Cheng University, 168 University Road, Min-Hsiung, Chiayi County, 62102, Taiwan
| | - Pin-Yun Lin
- Department of Chemistry and Biochemistry, National Chung Cheng University, 168 University Road, Min-Hsiung, Chiayi County, 62102, Taiwan
| | - Yi-Hsun Huang
- Doctoral Program in Science, Technology, Environment, and Mathematics, Department of Earth and Environmental Sciences, National Chung Cheng University, 168 University Road, Min-Hsiung, Chiayi County, 62102, Taiwan
| | - Chung Ming Lu
- Doctoral Program in Science, Technology, Environment, and Mathematics, Department of Earth and Environmental Sciences, National Chung Cheng University, 168 University Road, Min-Hsiung, Chiayi County, 62102, Taiwan
- Department of Chemical Engineering, National Chung Cheng University, University Road, Minhsiung, Chiayi County, 62102, Taiwan
| | - Cheng-Kang Lu
- Department of Chest Division, Internal Medicine, Ditmanson Medical Foundation Chiayi Christian Hospital 600566, Taiwan
| | - Tsung-Hsien Chen
- Department of Internal Medicine, Ditmanson Medical Foundation Chiayi Christian Hospital 600566, Taiwan
| | - Chien-Yen Chen
- Doctoral Program in Science, Technology, Environment, and Mathematics, Department of Earth and Environmental Sciences, National Chung Cheng University, 168 University Road, Min-Hsiung, Chiayi County, 62102, Taiwan
- Center for Nano Bio-Detection, Center for Innovative Research on Aging Society, AIM-HI, National Chung Cheng University, 168, University Road, Min-Hsiung, Chiayi County, 62102, Taiwan
| |
Collapse
|
8
|
Awdah Saad AW, Mohd Anas SN, Seminin NS, Naim PNS, Abdulaziz D, Go R, Abdul Aziz NA, Mohamed Ghazali MFS, Mustafa M. The Impact of Calcium Chloride in Cementation Solution on Microbial Induced Calcite Precipitation: A Systematic Review. PERTANIKA JOURNAL OF SCIENCE AND TECHNOLOGY 2023. [DOI: 10.47836/pjst.31.2.14] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 03/05/2023]
Abstract
This review aims to quantify the impact of calcium chloride in cementation solutions on Microbial Induced Calcite Precipitation (MICP). Specific soil strength properties, such as the Unconfined Compressive Strength (UCS) test, permeability (k) and calcium carbonate content of the soil, form the basis of quantifying the test results. Relevant articles from various online databases such as Scopus, Science Direct, ProQuest Dissertations and Theses Global (PQDT), Mendeley and Google Scholar are obtained with search strings of suitable keywords. The Preferred Reporting Items for Systematic Reviews and Meta-Analyses (PRISMA) were used to screen and select related articles based on exclusion and inclusion characteristics. This review shows a positive correlation between calcium concentrations and soil strength properties, where higher concentrations of calcium solutions induce stronger bonding between soil particles due to better calcite precipitation. However, we also note a reversed correlation when the concentration of calcium solutions is higher than 1 M. This review also verifies that the MICP process enhances soil strength using optimum calcium chloride concentration to avoid soil brittleness. This result benefits other fields, such as agricultural and soil engineering.
Collapse
|
9
|
Berg C, Herbst L, Gremm L, Ihling N, Paquet-Durand O, Hitzmann B, Büchs J. Assessing the capabilities of 2D fluorescence monitoring in microtiter plates with data-driven modeling for secondary substrate limitation experiments of Hansenula polymorpha. J Biol Eng 2023; 17:12. [PMID: 36782293 PMCID: PMC9926666 DOI: 10.1186/s13036-023-00332-0] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/02/2022] [Accepted: 02/06/2023] [Indexed: 02/15/2023] Open
Abstract
BACKGROUND Non-invasive online fluorescence monitoring in high-throughput microbioreactors is a well-established method to accelerate early-stage bioprocess development. Recently, single-wavelength fluorescence monitoring in microtiter plates was extended to measurements of highly resolved 2D fluorescence spectra, by introducing charge-coupled device (CCD) detectors. Although introductory experiments demonstrated a high potential of the new monitoring technology, an assessment of the capabilities and limits for practical applications is yet to be provided. RESULTS In this study, three experimental sets introducing secondary substrate limitations of magnesium, potassium, and phosphate to cultivations of a GFP-expressing H. polymorpha strain were conducted. This increased the complexity of the spectral dynamics, which were determined by 2D fluorescence measurements. The metabolic responses upon growth limiting conditions were assessed by monitoring of the oxygen transfer rate and extensive offline sampling. Using only the spectral data, subsequently, partial least-square (PLS) regression models for the key parameters of glycerol, cell dry weight, and pH value were generated. For model calibration, spectral data of only two cultivation conditions were combined with sparse offline sampling data. Applying the models to spectral data of six cultures not used for calibration, resulted in an average relative root-mean-square error (RMSE) of prediction between 6.8 and 6.0%. Thus, while demanding only sparse offline data, the models allowed the estimation of biomass accumulation and glycerol consumption, even in the presence of more or less pronounced secondary substrate limitation. CONCLUSION For the secondary substrate limitation experiments of this study, the generation of data-driven models allowed a considerable reduction in sampling efforts while also providing process information for unsampled cultures. Therefore, the practical experiments of this study strongly affirm the previously claimed advantages of 2D fluorescence spectroscopy in microtiter plates.
Collapse
Affiliation(s)
- Christoph Berg
- grid.1957.a0000 0001 0728 696XAVT - Aachener Verfahrenstechnik, Biochemical Engineering, RWTH Aachen University, Forckenbeckstraße 51, 52074 Aachen, Germany
| | - Laura Herbst
- grid.1957.a0000 0001 0728 696XAVT - Aachener Verfahrenstechnik, Biochemical Engineering, RWTH Aachen University, Forckenbeckstraße 51, 52074 Aachen, Germany
| | - Lisa Gremm
- grid.1957.a0000 0001 0728 696XAVT - Aachener Verfahrenstechnik, Biochemical Engineering, RWTH Aachen University, Forckenbeckstraße 51, 52074 Aachen, Germany
| | - Nina Ihling
- grid.1957.a0000 0001 0728 696XAVT - Aachener Verfahrenstechnik, Biochemical Engineering, RWTH Aachen University, Forckenbeckstraße 51, 52074 Aachen, Germany
| | - Olivier Paquet-Durand
- grid.9464.f0000 0001 2290 1502Department of Process Analytics & Cereal Science, Institute for Food Science and Biotechnology, University of Hohenheim, Garbenstraße 23, 70599 Stuttgart, Germany
| | - Bernd Hitzmann
- grid.9464.f0000 0001 2290 1502Department of Process Analytics & Cereal Science, Institute for Food Science and Biotechnology, University of Hohenheim, Garbenstraße 23, 70599 Stuttgart, Germany
| | - Jochen Büchs
- AVT - Aachener Verfahrenstechnik, Biochemical Engineering, RWTH Aachen University, Forckenbeckstraße 51, 52074, Aachen, Germany.
| |
Collapse
|
10
|
Influencing factors on ureolytic microbiologically induced calcium carbonate precipitation for biocementation. World J Microbiol Biotechnol 2023; 39:61. [PMID: 36576609 PMCID: PMC9797461 DOI: 10.1007/s11274-022-03499-8] [Citation(s) in RCA: 6] [Impact Index Per Article: 6.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/07/2022] [Accepted: 12/13/2022] [Indexed: 12/29/2022]
Abstract
Microbiologically induced calcium carbonate precipitation (MICP) is a technique that has received a lot of attention in the field of geotechnology in the last decade. It has the potential to provide a sustainable and ecological alternative to conventional consolidation of minerals, for example by the use of cement. From a variety of microbiological metabolic pathways that can induce calcium carbonate (CaCO3) precipitation, ureolysis has been established as the most commonly used method. To better understand the mechanisms of MICP and to develop new processes and optimize existing ones based on this understanding, ureolytic MICP is the subject of intensive research. The interplay of biological and civil engineering aspects shows how interdisciplinary research needs to be to advance the potential of this technology. This paper describes and critically discusses, based on current literature, the key influencing factors involved in the cementation of sand by ureolytic MICP. Due to the complexity of MICP, these factors often influence each other, making it essential for researchers from all disciplines to be aware of these factors and its interactions. Furthermore, this paper discusses the opportunities and challenges for future research in this area to provide impetus for studies that can further advance the understanding of MICP.
Collapse
|
11
|
Wu HR, Peng C, Chen M. Rethinking the complexity and uncertainty of spatial networks applied to forest ecology. Sci Rep 2022; 12:15917. [PMID: 36151102 PMCID: PMC9508254 DOI: 10.1038/s41598-022-16485-9] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/08/2022] [Accepted: 07/11/2022] [Indexed: 11/09/2022] Open
Abstract
Characterizing tree spatial patterns and interactions are helpful to reveal underlying processes assembling forest communities. Spatial networks, despite their complexity, are powerful to examine spatial interactions at an individual level using well-defined patterns. However, complex forestation networks introduce uncertainties. Validation methods are needed to assess whether network-based metrics can identify different processes. Here, we constructed three types of networks, which reflect various aspects of tree competition. Based on five spatial null models and 199 Monte-Carlo simulations, we were able to select network-based metrics that exhibited well performance in distinguishing different processes. This technique was then applied to a tropical forest dataset in Costa Rica. We found that the average node degree and the clustering coefficient are good metrics like the paired correlation function. In addition, the network approach can identify fine-scale spatial variations of tree competition and its underlying causes. Our analyzes also indicate that a bit of caution is needed when defining the network structure as well as designing network-based metrics. We suggested that validation techniques using corresponding spatial null models are critically important to reduce the negative effects caused by uncertainties of the network.
Collapse
Affiliation(s)
- Hao-Ran Wu
- Department of Bioinformatics, College of Life Sciences, Zhejiang University, Hangzhou, 310058, China
| | - Chen Peng
- Department of Bioinformatics, College of Life Sciences, Zhejiang University, Hangzhou, 310058, China
| | - Ming Chen
- Department of Bioinformatics, College of Life Sciences, Zhejiang University, Hangzhou, 310058, China.
| |
Collapse
|
12
|
Lapierre FM, Bolz I, Büchs J, Huber R. Developing a fluorometric urease activity microplate assay suitable for automated microbioreactor experiments. Front Bioeng Biotechnol 2022; 10:936759. [PMID: 36185447 PMCID: PMC9515450 DOI: 10.3389/fbioe.2022.936759] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/05/2022] [Accepted: 08/19/2022] [Indexed: 11/15/2022] Open
Abstract
Quantifying urease activity is an important task for Microbial Induced Calcite Precipitation research. A new urease activity microplate assay using a fluorescent pH indicator is presented. The method is also suitable for automated measurements during microbioreactor experiments. The assay reagent consists of the green fluorescent pH-indicator fluorescein, urea and a phosphate buffer. After sample addition, the microbial urease hydrolyses urea, which results in a pH and hence fluorescence increase. The fluorescence signal can be measured with a microplate reader or with the microbioreactor system BioLector, allowing for automated urease activity measurements during cultivation experiments. In both measurement systems, the fluorescence signal slope highly correlates with the urease activity measured offline with standard methods. Automated measurement is possible, as no sample preparation such as centrifugation or adjusting of the optical density is required. The assay was developed so that the culture samples turbidity, salinity or buffer concentration does not have a negative impact on the fluorescence signal. The assay allows for straightforward, non-hazardous, parallelized, cheap and reliable measurements, making research on ureolytic bacteria for Microbial Induced Calcite Precipitation more efficient. The assay could be adapted to other enzymes, which have a strong impact on the pH value.
Collapse
Affiliation(s)
- Frédéric M. Lapierre
- Munich University of Applied Sciences HM, Munich, Germany
- *Correspondence: Frédéric M. Lapierre, ; Robert Huber,
| | - Isabel Bolz
- Munich University of Applied Sciences HM, Munich, Germany
| | - Jochen Büchs
- Chair of Biochemical Engineering (AVT.BioVT), RWTH Aachen University, Aachen, Germany
| | - Robert Huber
- Munich University of Applied Sciences HM, Munich, Germany
- *Correspondence: Frédéric M. Lapierre, ; Robert Huber,
| |
Collapse
|
13
|
Characterizing the Mechanisms of Metalaxyl, Bronopol and Copper Sulfate against Saprolegnia parasitica Using Modern Transcriptomics. Genes (Basel) 2022; 13:genes13091524. [PMID: 36140692 PMCID: PMC9498376 DOI: 10.3390/genes13091524] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/04/2022] [Revised: 08/23/2022] [Accepted: 08/23/2022] [Indexed: 11/17/2022] Open
Abstract
Saprolegniasis, which is caused by Saprolegnia parasitica, leads to considerable economic losses. Recently, we showed that metalaxyl, bronopol and copper sulfate are good antimicrobial agents for aquaculture. In the current study, the efficacies of metalaxyl, bronopol and copper sulfate are evaluated by in vitro antimicrobial experiments, and the mechanism of action of these three antimicrobials on S. parasitica is explored using transcriptome technology. Finally, the potential target genes of antimicrobials on S. parasitica are identified by protein–protein interaction network analysis. Copper sulfate had the best inhibitory effect on S. parasitica, followed by bronopol. A total of 1771, 723 and 2118 DEGs upregulated and 1416, 319 and 2161 DEGs downregulated S. parasitica after three drug treatments (metalaxyl, bronopol and copper sulfate), separately. Additionally, KEGG pathway analysis also determined that there were 17, 19 and 13 significantly enriched metabolic pathways. PPI network analysis screened out three important proteins, and their corresponding genes were SPRG_08456, SPRG_03679 and SPRG_10775. Our results indicate that three antimicrobials inhibit S. parasitica growth by affecting multiple biological functions, including protein synthesis, oxidative stress, lipid metabolism and energy metabolism. Additionally, the screened key genes can be used as potential target genes of chemical antimicrobial drugs for S. parasitica.
Collapse
|
14
|
Improved Time Resolved KPI and Strain Characterization of Multiple Hosts in Shake Flasks Using Advanced Online Analytics and Data Science. BIOENGINEERING (BASEL, SWITZERLAND) 2022; 9:bioengineering9080339. [PMID: 35892752 PMCID: PMC9331495 DOI: 10.3390/bioengineering9080339] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 05/20/2022] [Revised: 07/11/2022] [Accepted: 07/22/2022] [Indexed: 01/19/2023]
Abstract
Shake flasks remain one of the most widely used cultivation systems in biotechnology, especially for process development (cell line and parameter screening). This can be justified by their ease of use as well as their low investment and running costs. A disadvantage, however, is that cultivations in shake flasks are black box processes with reduced possibilities for recording online data, resulting in a lack of control and time-consuming, manual data analysis. Although different measurement methods have been developed for shake flasks, they lack comparability, especially when changing production organisms. In this study, the use of online backscattered light, dissolved oxygen, and pH data for characterization of animal, plant, and microbial cell culture processes in shake flasks are evaluated and compared. The application of these different online measurement techniques allows key performance indicators (KPIs) to be determined based on online data. This paper evaluates a novel data science workflow to automatically determine KPIs using online data from early development stages without human bias. This enables standardized and cost-effective process-oriented cell line characterization of shake flask cultivations to be performed in accordance with the process analytical technology (PAT) initiative. The comparison showed very good agreement between KPIs determined using offline data, manual techniques, and automatic calculations based on multiple signals of varying strengths with respect to the selected measurement signal.
Collapse
|
15
|
Beam width and arm position but not cognitive task affect walking balance in older adults. Sci Rep 2022; 12:6854. [PMID: 35477729 PMCID: PMC9046185 DOI: 10.1038/s41598-022-10848-y] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/23/2021] [Accepted: 04/11/2022] [Indexed: 11/08/2022] Open
Abstract
Detection of changes in dynamic balance could help identify older adults at fall risk. Walking on a narrow beam with its width, cognitive load, and arm position manipulated could be an alternative to current tests. Therefore, we examined additive and interactive effects of beam width, cognitive task (CT), and arm position on dynamic balance during beam walking in older adults. Twenty older adults (69 ± 4y) walked on 6, 8, and 10-cm wide beams (2-cm high, 4-m-long), with and without CT, with three arm positions (free, crossed, akimbo). We determined cognitive errors, distance walked, step speed, root mean square (RMS) of center of mass (COM) displacement and trunk acceleration in the frontal plane. Beam width decrease progressively reduced distance walked and increased trunk acceleration RMS. Step speed decreased on the narrowest beam and with CT. Arm crossing decreased distance walked and step speed. COM displacement RMS and cognitive errors were not affected by any manipulation. In conclusion, distance walked indicated that beam width and arm position, but less so CT, affected dynamic balance, implying that beam walking has the potential to become a test of fall risk. Stability measurements suggested effective trunk adjustments to control COM position and keep dynamic balance during the task.
Collapse
|
16
|
Comadran-Casas C, Schaschke CJ, Akunna JC, Jorat ME. Cow urine as a source of nutrients for Microbial-Induced Calcite Precipitation in sandy soil. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2022; 304:114307. [PMID: 34942547 DOI: 10.1016/j.jenvman.2021.114307] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/21/2021] [Revised: 11/16/2021] [Accepted: 12/12/2021] [Indexed: 06/14/2023]
Abstract
Microbial Induced Calcite Precipitation (MICP) via biostimulation of urea hydrolysis is a biogeochemical process in which soil indigenous ureolytic microorganisms catalyse the decomposition of urea into ammonium and carbonate ions which, in the presence of calcium, precipitate as calcium carbonate minerals. The environmental conditions created by urine in soil resemble those induced by MICP via urea hydrolysis. Thus, this study assesses the suitability of a waste product, cow urine, as a source of nutrients for MICP. Urea stability in fresh and sterilised urine were monitored for a month to cover the length of a potential MICP intervention. An experimental soil column set up was used to compare the soil response to the repeated application of fresh and sterilised cow urine, within pH of 7 and 9, and the chemical-based solution. Urea hydrolysis and the carbonate content in solution were monitored to assess the suitability of the proposed alternative. In addition, the nitrification process was monitored. Key findings indicated i) urea concentration and stability in fresh and sterilised cow urine are suitable for MICP application; ii) the soil response to treatments of cow urine within pH of 7 and 9 are similar to the chemical-based solution; and iii) increasing solution pH results in a faster activation of ureolytic microorganisms and higher carbonate content in solution. These results demonstrate that cow urine is a suitable substitute of the chemical-based MICP application.
Collapse
Affiliation(s)
| | - Carl J Schaschke
- School of Computing, Engineering and Physical Sciences, University of the West of Scotland, Paisley, United Kingdom
| | - Joseph C Akunna
- School of Applied Sciences, Abertay University, Dundee, United Kingdom
| | - M Ehsan Jorat
- School of Applied Sciences, Abertay University, Dundee, United Kingdom
| |
Collapse
|
17
|
Wu Y, Li H, Li Y. Biomineralization Induced by Cells of Sporosarcina pasteurii: Mechanisms, Applications and Challenges. Microorganisms 2021; 9:2396. [PMID: 34835521 PMCID: PMC8621315 DOI: 10.3390/microorganisms9112396] [Citation(s) in RCA: 10] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/03/2021] [Revised: 11/18/2021] [Accepted: 11/19/2021] [Indexed: 11/17/2022] Open
Abstract
Biomineralization has emerged as a novel and eco-friendly technology for artificial mineral formation utilizing the metabolism of organisms. Due to its highly efficient urea degradation ability, Sporosarcina pasteurii(S. pasteurii) is arguably the most widely investigated organism in ureolytic biomineralization studies, with wide potential application in construction and environmental protection. In emerging, large-scale commercial engineering applications, attention was also paid to practical challenges and issues. In this review, we summarize the features of S. pasteurii cells contributing to the biomineralization reaction, aiming to reveal the mechanism of artificial mineral formation catalyzed by bacterial cells. Progress in the application of this technology in construction and environmental protection is discussed separately. Furthermore, the urgent challenges and issues in large-scale application are also discussed, along with potential solutions. We aim to offer new ideas to researchers working on the mechanisms, applications and challenges of biomineralization.
Collapse
Affiliation(s)
- Yang Wu
- School of Chemical Engineering and Technology, Tianjin University, Tianjin 300072, China; (H.L.); (Y.L.)
| | | | | |
Collapse
|