1
|
Pinto J, Colónia J, Abdolvaseei A, Vale C, Henriques B, Pereira E. Algal sorbents and prospects for their application in the sustainable recovery of rare earth elements from E-waste. ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2023:10.1007/s11356-023-27767-8. [PMID: 37227641 DOI: 10.1007/s11356-023-27767-8] [Citation(s) in RCA: 5] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Subscribe] [Scholar Register] [Received: 01/02/2023] [Accepted: 05/15/2023] [Indexed: 05/26/2023]
Abstract
Efficient and sustainable secondary sourcing of Rare-Earth Elements (REE) is essential to counter supply bottlenecks and the impacts associated with primary mining. Recycled electronic waste (E-waste) is considered a promising REE source and hydrometallurgical methods followed by chemical separation techniques (usually solvent extraction) have been successfully applied to these wastes with high REE yields. However, the generation of acidic and organic waste streams is considered unsustainable and has led to the search for "greener" approaches. Sorption-based technologies using biomass such as bacteria, fungi and algae have been developed to sustainably recover REE from e-waste. Algae sorbents in particular have experienced growing research interest in recent years. Despite its high potential, sorption efficiency is strongly influenced by sorbent-specific parameters such as biomass type and state (fresh/dried, pre-treatment, functionalization) as well as solution parameters such as pH, REE concentration, and matrix complexity (ionic strength and competing ions). This review highlights differences in experimental conditions among published algal-based REE sorption studies and their impact on sorption efficiency. Since research into algal sorbents for REE recovery from real wastes is still in its infancy, aspects such as the economic viability of a realistic application are still unexplored. However, it has been proposed to integrate REE recovery into an algal biorefinery concept to increase the economics of the process (by providing a range of additional products), but also in the prospect of achieving carbon neutrality (as large-scale algae cultivation can act as a CO2 sink).
Collapse
Affiliation(s)
- João Pinto
- Department of Chemistry, University of Aveiro, Aveiro, Portugal
- LAQV-REQUIMTE - Associated Laboratory for Green Chemistry, University of Aveiro, Aveiro, Portugal
| | - João Colónia
- Department of Chemistry, University of Aveiro, Aveiro, Portugal
| | | | - Carlos Vale
- CIIMAR - Interdisciplinary Centre of Marine and Environmental Research, Matosinhos, Portugal
| | - Bruno Henriques
- Department of Chemistry, University of Aveiro, Aveiro, Portugal.
- LAQV-REQUIMTE - Associated Laboratory for Green Chemistry, University of Aveiro, Aveiro, Portugal.
| | - Eduarda Pereira
- Department of Chemistry, University of Aveiro, Aveiro, Portugal
- LAQV-REQUIMTE - Associated Laboratory for Green Chemistry, University of Aveiro, Aveiro, Portugal
| |
Collapse
|
2
|
Production of Biodiesel from Underutilized Algae Oil: Prospects and Current Challenges Encountered in Developing Countries. BIOLOGY 2022; 11:biology11101418. [PMID: 36290321 PMCID: PMC9599019 DOI: 10.3390/biology11101418] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 09/04/2022] [Revised: 09/22/2022] [Accepted: 09/25/2022] [Indexed: 11/17/2022]
Abstract
Simple Summary The production of biofuel, especially biodiesel, from algae oil receives little attention in developing countries due to poor enlightenment on biotechnology, high poverty rates, and poor funding of research. This study focuses on finding a better understanding of the evolving prospects and current challenges facing biodiesel production from algae oil in developing nations. Interestingly, several species of microalgae that can serves as sustainable feedstocks for biodiesel production have been identified in developing nations. It is evident that microalgae oil has physicochemical properties that qualifies it for the production of biodiesel, with fuel properties that meet ASTM and EN standards. Abstract Biofuel continues to thrive as an outstanding source of renewable energy for the global community. Several resources have been proposed as sources of feedstocks for biofuel; however, some of these have shortcoming. The use of biomass such as algae as a source of feedstock for biofuel is undoubtedly sustainable and green. Unfortunately, the use of algae oil for biodiesel production is underutilized in developing countries. Therefore, this study focuses on finding a better understanding of the evolving prospects and current challenges facing biodiesel production from algae oil in developing countries. The study revealed that less attention is given to the use of algae oil in biodiesel production due to poor enlightenment on biotechnology, high poverty rates, government policies, business strategies, and poor funding of research. Interestingly, several species of algae that can serve as sustainable feedstocks for biodiesel production have been identified in developing countries. It is evident that algae oil has properties that qualify it for the production of biodiesel with fuel properties that meet both the American Society for Testing and Materials and the European standards for biodiesel.
Collapse
|
3
|
Hong JS, Shin W, Nam H, Yun JH, Kim HS, Ahn KH. Sedimentation and Rheological Study of Microalgal Cell (Chlorella sp. HS2) Suspension. BIOTECHNOL BIOPROC E 2022. [DOI: 10.1007/s12257-021-0275-y] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/02/2022]
|
4
|
Muthukrishnan L. Bio‐engineering of microalgae: Challenges and future prospects toward industrial and environmental applications. J Basic Microbiol 2022; 62:310-329. [DOI: 10.1002/jobm.202100417] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/13/2021] [Revised: 12/28/2021] [Accepted: 01/08/2022] [Indexed: 01/29/2023]
Affiliation(s)
- Lakshmipathy Muthukrishnan
- Department of Conservative Dentistry and Endodontics, Saveetha Dental College and Hospitals Saveetha Institute of Medical and Technical Sciences Chennai Tamil Nadu India
| |
Collapse
|
5
|
Sherief N, Anand M, Ramachandran M, Vidhya P. A Review on Various Biofuels and its Applications. 1 2022; 8:1-9. [DOI: 10.46632/jemm/8/1/1] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 09/01/2023]
Abstract
Biofuels derived from biofuels, plant or algae or animal wastes. Unlike fossil fuels such as petroleum, coal and natural gas, refilled immediately. Biofuels are fuels made from recently harvested plants. They act like fossil fuels: they burn when ignited, releasing energy that can be converted into kinetic energy in a car, or heat a home. Biofuels can
be obtained from a variety of crops and from a wide range of plant products from other industries. Not only is biodiesel stable, it is also a highly environmentally friendly, clean burning option that can be used without modification in diesel engines. In fact, biodiesel reduces greenhouse gas emissions by 56% to 86%, which means that the use of biodiesel has already reduced carbon emissions by 75.5 million metric tons. Many countries promote the use of biodiesel. In 2001, global biodiesel consumption was approximately 0.3 billion gallons. Based on the raw material, biofuels are divided
into four groups: third, fourth (FGBs), first biodiesel, which is the only is a locally produced, clean-burning, renewable alternative to petroleum diesel. The use of biodiesel as a vehicle fuel enhances energy conservation, improves air quality and the environment, and provides safety benefits. Biofuels are transport fuels such as ethanol and biomass based diesel fuels. These fuels are usually blended with petroleum fuels (petrol and distillation / diesel fuel and heating oil), but can also be used on their own. Scientists have found that, in practice, biofuels produced from agricultural crops
cause less pollution and greenhouse gas emissions than conventional fossil fuels, causing some environmental problems. Biofuels can also affect the poor. Various problems arise due to high prices for crops. It can go from improved water quality to creating new jobs in economically backward areas. Some applications of bioenergy require a feed based on residues from dedicated field production (such as energy crops) or agricultural production. However, many plant species grown for biofuels release higher levels of the ozone precursor isoprene than conventional crops and plants. Excess ozone poses a well-documented risk to human health, with 22,000 premature deaths each year linked to ground ozone exposure in Europe.
Collapse
Affiliation(s)
- Nisha Sherief
- Department of Mechanbical Engineering, Jyothi Engineering College, Thrissur, India
| | - M Anand
- R&D Division, Institute for Science, Engineering and Technology Research, India
| | - M Ramachandran
- REST LABS, Kaveripattinam, Krishnagiri, Tamil Nadu, India
| | | |
Collapse
|
6
|
Mariam I, Kareya MS, Rehmanji M, Nesamma AA, Jutur PP. Channeling of Carbon Flux Towards Carotenogenesis in Botryococcus braunii: A Media Engineering Perspective. Front Microbiol 2021; 12:693106. [PMID: 34394032 PMCID: PMC8358449 DOI: 10.3389/fmicb.2021.693106] [Citation(s) in RCA: 6] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/09/2021] [Accepted: 06/30/2021] [Indexed: 11/13/2022] Open
Abstract
Microalgae, due to their unique properties, gained attention for producing promising feedstocks having high contents of proteins, antioxidants, carotenoids, and terpenoids for applications in nutraceutical and pharmaceutical industries. Optimizing production of the high-value renewables (HVRs) in microalgae requires an in-depth understanding of their functional relationship of the genes involved in these metabolic pathways. In the present study, bioinformatic tools were employed for characterization of the protein-encoding genes of methyl erythritol phosphate (MEP) pathway involved in carotenoid and squalene biosynthesis based upon their conserved motif/domain organization. Our analysis demonstrates nearly 200 putative genes showing a conservation pattern within divergent microalgal lineages. Furthermore, phylogenomic studies confirm the close evolutionary proximity among these microalgal strains in the carotenoid and squalene biosynthetic pathways. Further analysis employing STRING predicts interactions among two rate-limiting genes, i.e., phytoene synthase (PSY) and farnesyl diphosphate farnesyl synthase (FPPS), which are specifically involved in the synthesis of carotenoids and squalene. Experimentally, to understand the carbon flux of these rate-limiting genes involved in carotenogenesis, an industrial potential strain, namely, Botryococcus braunii, was selected in this study for improved biomass productivity (i.e., 100 mg L-1 D-1) along with enhanced carotenoid content [0.18% dry cell weight (DCW)] when subjected to carbon supplementation. In conclusion, our approach of media engineering demonstrates that the channeling of carbon flux favors carotenogenesis rather than squalene synthesis. Henceforth, employing omics perspectives will further provide us with new insights for engineering regulatory networks for enhanced production of high-value carbon biorenewables without compromising growth.
Collapse
Affiliation(s)
- Iqra Mariam
- Omics of Algae Group and DBT-ICGEB Centre for Advanced Bioenergy Research, Industrial Biotechnology, International Centre for Genetic Engineering and Biotechnology, New Delhi, India
| | - Mukul Suresh Kareya
- Omics of Algae Group and DBT-ICGEB Centre for Advanced Bioenergy Research, Industrial Biotechnology, International Centre for Genetic Engineering and Biotechnology, New Delhi, India
| | - Mohammed Rehmanji
- Omics of Algae Group and DBT-ICGEB Centre for Advanced Bioenergy Research, Industrial Biotechnology, International Centre for Genetic Engineering and Biotechnology, New Delhi, India
| | - Asha Arumugam Nesamma
- Omics of Algae Group and DBT-ICGEB Centre for Advanced Bioenergy Research, Industrial Biotechnology, International Centre for Genetic Engineering and Biotechnology, New Delhi, India
| | - Pannaga Pavan Jutur
- Omics of Algae Group and DBT-ICGEB Centre for Advanced Bioenergy Research, Industrial Biotechnology, International Centre for Genetic Engineering and Biotechnology, New Delhi, India
| |
Collapse
|
7
|
Mona S, Malyan SK, Saini N, Deepak B, Pugazhendhi A, Kumar SS. Towards sustainable agriculture with carbon sequestration, and greenhouse gas mitigation using algal biochar. CHEMOSPHERE 2021; 275:129856. [PMID: 33636519 DOI: 10.1016/j.chemosphere.2021.129856] [Citation(s) in RCA: 27] [Impact Index Per Article: 9.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/12/2020] [Revised: 12/31/2020] [Accepted: 02/02/2021] [Indexed: 05/18/2023]
Abstract
With the increase in the world's population, demand for food and other products is continuously rising. This has put a lot of pressure on the agricultural sector. To fulfill these demands, the utilization of chemical fertilizers and pesticides has also increased. Consequently, to overcome the adverse effects of agrochemicals on our environment and health, there has been a shift towards organic fertilizers or other substitutes, which are ecofriendly and help to maintain a sustainable environment. Microalgae have a very high potential of carbon dioxide (CO2) capturing and thus, help in mitigating the greenhouse effect. It is the most productive biological system for generating biomass. The high growth rate and higher photosynthetic efficiency of the algal species compared to the terrestrial plants make them a wonderful alternative towards a sustainable environment. Moreover, they could be cultivated in photobioreactors or open ponds, which in turn reduce the demand for arable land. Biochar derived from algae is high in nutrients and exhibits the property of ion exchange. Therefore, it can be utilized for sustainable agriculture by partial substituting the chemical fertilizers that degrade the fertility of the soil in the long run. This review provides a detailed insight on the properties of algal biochar as a potential fertilizer for sustainable agriculture. Application of algal biochar in bio-refinery and its economic aspects, challenges faced and future perspective are also discusses in this study.
Collapse
Affiliation(s)
- Sharma Mona
- Department of Environmental Science & Engineering, Guru Jambheshwar University of Science & Technology, Hisar, 125001, Haryana, India.
| | - Sandeep K Malyan
- Research Management and Outreach Division, National Institute of Hydrology, Jalvigyan Bhawan, Roorkee, Uttarakhand, 247667, India.
| | - Neha Saini
- Department of Environmental Science & Engineering, Guru Jambheshwar University of Science & Technology, Hisar, 125001, Haryana, India.
| | | | - Arivalagan Pugazhendhi
- Innovative Green Product Synthesis and Renewable Environment Development Research Group, Faculty of Environment and Labour Safety, Ton Duc Thang University, Ho Chi Minh City, Viet Nam.
| | - Smita S Kumar
- Department of Environmental Sciences, J.C. Bose University of Science and Technology YMCA, Faridabad, India.
| |
Collapse
|
8
|
Ferreira J, de Assis LR, Oliveira APDS, Castro JDS, Calijuri ML. Innovative microalgae biomass harvesting methods: Technical feasibility and life cycle analysis. THE SCIENCE OF THE TOTAL ENVIRONMENT 2020; 746:140939. [PMID: 32763596 DOI: 10.1016/j.scitotenv.2020.140939] [Citation(s) in RCA: 17] [Impact Index Per Article: 4.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/04/2020] [Revised: 07/08/2020] [Accepted: 07/11/2020] [Indexed: 06/11/2023]
Abstract
In order to ease one of the main challenges of biomass production in wastewater, the harvest stage, this study proposes as main innovations: the comparison of technical and environmental performance of different methods of harvesting biomass which have not been addressed in the literature and the projection of an optimal environmental scenario for biomass harvesting. For this, three harvesting methods were evaluated and compared, namely the gravitational sedimentation (GS) via settling tank, coagulation with tannin followed by gravitational sedimentation (TC/GS), and a biofilm reactor operated in parallel with a settling tank (BR/GS). TC/GS required less time to concentrate the biomass (121.13 g/day); however, the biomass had a higher moisture content (99.02%), which may compromise its direct application for production of most bioproducts and bioenergy, only a dewatering step is recommended. The harvesting methods interfered in biomass characterisation, mainly in carbohydrate content, which was higher in biomass concentrated over time (28-37%) than biomass concentrated in a single day by coagulation (13.8%). The results of the life cycle assessment revealed that in scenarios which included TC/GS methods and the BR/GS presented less environmental impact in relation to only GS. Additionally, the combination of these two methods comprises the best scenario and promises to optimise the harvest of biomass grown in wastewater.
Collapse
Affiliation(s)
- Jéssica Ferreira
- Universidade Federal de Viçosa, Advanced Environmental Research Group - nPA, Department of Civil Engineering, Av. PH Rolfs, s/n, 36570-900, Brazil.
| | - Letícia Rodrigues de Assis
- Universidade Federal de Viçosa, Advanced Environmental Research Group - nPA, Department of Civil Engineering, Av. PH Rolfs, s/n, 36570-900, Brazil.
| | - Adriana Paulo de Sousa Oliveira
- Universidade Federal de Viçosa, Advanced Environmental Research Group - nPA, Department of Civil Engineering, Av. PH Rolfs, s/n, 36570-900, Brazil
| | - Jackeline de Siqueira Castro
- Universidade Federal de Viçosa, Advanced Environmental Research Group - nPA, Department of Civil Engineering, Av. PH Rolfs, s/n, 36570-900, Brazil
| | - Maria Lúcia Calijuri
- Universidade Federal de Viçosa, Advanced Environmental Research Group - nPA, Department of Civil Engineering, Av. PH Rolfs, s/n, 36570-900, Brazil
| |
Collapse
|
9
|
Abstract
As the demand for biofuels increases globally, microalgae offer a viable biomass feedstock to produce biofuel. With abundant sources of biomass in rural communities, these materials could be converted to biodiesel. Efforts are being done in order to pursue commercialization. However, its main usage is for other applications such as pharmaceutical, nutraceutical, and aquaculture, which has a high return of investment. In the last 5 decades of algal research, cultivation to genetically engineered algae have been pursued in order to push algal biofuel commercialization. This will be beneficial to society, especially if coupled with a good government policy of algal biofuels and other by-products. Algal technology is a disruptive but complementary technology that will provide sustainability with regard to the world’s current issues. Commercialization of algal fuel is still a bottleneck and a challenge. Having a large production is technical feasible, but it is not economical as of now. Efforts for the cultivation and production of bio-oil are still ongoing and will continue to develop over time. The life cycle assessment methodology allows for a sustainable evaluation of the production of microalgae biomass to biodiesel.
Collapse
|
10
|
Dineshbabu G, Uma VS, Mathimani T, Prabaharan D, Uma L. Elevated CO2 impact on growth and lipid of marine cyanobacterium Phormidium valderianum BDU 20041– towards microalgal carbon sequestration. BIOCATALYSIS AND AGRICULTURAL BIOTECHNOLOGY 2020. [DOI: 10.1016/j.bcab.2020.101606] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/26/2022]
|
11
|
Kumar R, Ghosh AK, Pal P. Synergy of biofuel production with waste remediation along with value-added co-products recovery through microalgae cultivation: A review of membrane-integrated green approach. THE SCIENCE OF THE TOTAL ENVIRONMENT 2020; 698:134169. [PMID: 31505365 DOI: 10.1016/j.scitotenv.2019.134169] [Citation(s) in RCA: 44] [Impact Index Per Article: 11.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/24/2019] [Revised: 08/26/2019] [Accepted: 08/27/2019] [Indexed: 06/10/2023]
Abstract
Development of advanced biofuels such as bioethanol and biodiesel from renewable resources is critical for the earth's sustainable management and to slow down the global climate change by partial replacement of gasoline and diesel in the transport sector. Being a diverse group of aquatic micro-organisms, algae are the most prominent resources on the planet, distributed in an aquatic system, a potential source of bioenergy, biomass and secondary metabolites. Microalgae-based biofuel production is widely accepted as non-food fuel sources and better choice for achieving goals of incorporation of a clean fuel source into the transportation sector. The present review article provides a comprehensive literature survey as well as a novel approach on the application of microalgae for their simultaneous cultivation and bioremediation of high nutrient containing wastewater. In addition to that, merits and demerits of different existing conventional techniques for microalgae culture reactors, harvesting of algal biomass, oil recovery, use of different catalysts for transesterification reactions and other by-products recovery have been discussed and compared with the membrane-based system to find out the best optimal conditions for higher biomass as well as lipid yield. This article also deals with the use of a tailor-made membrane in an appropriate module that can be used in upstream and downstream processes during algal-based biofuels production. Such membrane-integrated system has the potential of low-cost and eco-friendly separation, purification and concentration enrichment of biodiesel as well as other valuable algal by-products which can bring the high degree of process intensification for scale-up at the industrial stage.
Collapse
Affiliation(s)
- Ramesh Kumar
- Department of Chemistry, The University of Burdwan, 713104, India.
| | - Alak Kumar Ghosh
- Department of Chemistry, The University of Burdwan, 713104, India
| | - Parimal Pal
- Environment and Membrane Technology Laboratory, Department of Chemical Engineering, National Institute of Technology Durgapur 713209, India
| |
Collapse
|
12
|
Nguyen MK, Moon JY, Bui VKH, Oh YK, Lee YC. Recent advanced applications of nanomaterials in microalgae biorefinery. ALGAL RES 2019. [DOI: 10.1016/j.algal.2019.101522] [Citation(s) in RCA: 23] [Impact Index Per Article: 4.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/12/2023]
|
13
|
Chatterjee P, Granatier M, Ramasamy P, Kokko M, Lakaniemi AM, Rintala J. Microalgae grow on source separated human urine in Nordic climate: Outdoor pilot-scale cultivation. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2019; 237:119-127. [PMID: 30784859 DOI: 10.1016/j.jenvman.2019.02.074] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/01/2018] [Revised: 01/18/2019] [Accepted: 02/15/2019] [Indexed: 06/09/2023]
Abstract
Human urine contributes approximately 80% of nitrogen and 50% of phosphorous in urban wastewaters while having a volume of only 1-1.5 L/d per capita compared to 150-200 L/d per capita of wastewater generated. There is interest to study source separation of urine and search methods to recover the nutrients form the urine. In this study, the objective was to use the nutrients in source separated urine for outdoor cultivation of microalgae in Nordic climate. A freshwater green microalga Scenedesmus acuminatus was grown in different dilutions (1:20 and 1:15) of source separated human urine, in a semi-continuously operated outdoor raceway pond with a liquid volume of 2000 L, at hydraulic retention time of 15 d. The microalgae could remove 52% nitrogen and 38% phosphorus even at culture temperatures as low as 5 °C, while obtaining a biomass density of 0.34 g VSS/L. Harvested microalgal biomass could be used to produce methane with a yield of 285 L CH4/kg volatile solids.
Collapse
Affiliation(s)
- Pritha Chatterjee
- Faculty of Engineering and Natural Sciences, Tampere University, Finland.
| | - Marianna Granatier
- Faculty of Engineering and Natural Sciences, Tampere University, Finland
| | - Praveen Ramasamy
- Faculty of Engineering and Natural Sciences, Tampere University, Finland
| | - Marika Kokko
- Faculty of Engineering and Natural Sciences, Tampere University, Finland
| | | | - Jukka Rintala
- Faculty of Engineering and Natural Sciences, Tampere University, Finland
| |
Collapse
|
14
|
Shaikh KM, Nesamma AA, Abdin MZ, Jutur PP. Molecular profiling of an oleaginous trebouxiophycean alga Parachlorella kessleri subjected to nutrient deprivation for enhanced biofuel production. BIOTECHNOLOGY FOR BIOFUELS 2019; 12:182. [PMID: 31338124 PMCID: PMC6628475 DOI: 10.1186/s13068-019-1521-9] [Citation(s) in RCA: 26] [Impact Index Per Article: 5.2] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/12/2019] [Accepted: 07/05/2019] [Indexed: 05/05/2023]
Abstract
BACKGROUND Decreasing fossil fuels and its impact on global warming have led to an increasing demand for its replacement by sustainable renewable biofuels. Microalgae may offer a potential feedstock for renewable biofuels capable of converting atmospheric CO2 to substantial biomass and valuable biofuels, which is of great importance for the food and energy industries. Parachlorella kessleri, a marine unicellular green alga belonging to class Trebouxiophyceae, accumulates large amount of lipids under nutrient-deprived conditions. The present study aims to understand the metabolic imprints in order to elucidate the physiological mechanisms of lipid accumulations in this microalga under nutrient deprivation. RESULTS Molecular profiles were obtained using gas chromatography-mass spectrometry (GC-MS) of P. kessleri subjected to nutrient deprivation. Relative quantities of more than 60 metabolites were systematically compared in all the three starvation conditions. Our results demonstrate that in lipid metabolism, the quantities of neutral lipids increased significantly followed by the decrease in other metabolites involved in photosynthesis, and nitrogen assimilation. Nitrogen starvation seems to trigger the triacylglycerol (TAG) accumulation rapidly, while the microalga seems to tolerate phosphorous limitation, hence increasing both biomass and lipid content. The metabolomic and lipidomic profiles have identified a few common metabolites such as citric acid and 2-ketoglutaric acid which play significant role in diverting flux towards acetyl-CoA leading to accumulation of neutral lipids, whereas other molecules such as trehalose involve in cell growth regulation, when subjected to nutrient deprivation. CONCLUSIONS Understanding the entire system through qualitative (untargeted) metabolome approach in P. kessleri has led to identification of relevant metabolites involved in the biosynthesis and degradation of precursor molecules that may have potential for biofuel production, aiming towards the vision of tomorrow's bioenergy needs.
Collapse
Affiliation(s)
- Kashif Mohd Shaikh
- Omics of Algae Group, Integrative Biology, International Centre for Genetic Engineering and Biotechnology, Aruna Asaf Ali Marg, New Delhi, 110067 India
- Department of Biotechnology, School of Chemical and Life Sciences, Jamia Hamdard University, New Delhi, 110062 India
| | - Asha Arumugam Nesamma
- Omics of Algae Group, Integrative Biology, International Centre for Genetic Engineering and Biotechnology, Aruna Asaf Ali Marg, New Delhi, 110067 India
| | - Malik Zainul Abdin
- Department of Biotechnology, School of Chemical and Life Sciences, Jamia Hamdard University, New Delhi, 110062 India
| | - Pannaga Pavan Jutur
- Omics of Algae Group, Integrative Biology, International Centre for Genetic Engineering and Biotechnology, Aruna Asaf Ali Marg, New Delhi, 110067 India
| |
Collapse
|
15
|
Singh G, Patidar SK. Microalgae harvesting techniques: A review. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2018; 217:499-508. [PMID: 29631239 DOI: 10.1016/j.jenvman.2018.04.010] [Citation(s) in RCA: 175] [Impact Index Per Article: 29.2] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/04/2018] [Revised: 03/23/2018] [Accepted: 04/02/2018] [Indexed: 06/08/2023]
Abstract
Microalgae with wide range of commercial applications have attracted a lot of attention of the researchers in the last few decades. However, microalgae utilization is not economically sustainable due to high cost of harvesting. A wide range of solid - liquid separation techniques are available for microalgae harvesting. The techniques include coagulation and flocculation, flotation, centrifugation and filtration or a combination of various techniques. Despite the importance of harvesting to the economics and energy balance, there is no universal harvesting technique for microalgae. Therefore, this review focuses on assessing technical, economical and application potential of various harvesting techniques so as to allow selection of an appropriate technology for cost effectively harvesting of microalgae from their culture medium. Various harvesting and concentrating techniques of microalgae were reviewed to suggest order of suitability of the techniques for four main microalgae applications i.e biofuel, human and animal food, high valued products, and water quality restoration. For deciding the order of suitability, a comparative analysis of various harvesting techniques based on the six common criterions (i.e biomass quality, cost, biomass quantity, processing time, species specific and toxicity) has been done. Based on the order of various techniques vis-a-vis various criteria and preferred order of criteria for various applications, order of suitability of harvesting techniques for various applications has been decided. Among various harvesting techniques, coagulation and flocculation, centrifugation and filtration were found to be most suitable for considered applications. These techniques may be used alone or in combination for increasing the harvesting efficiency.
Collapse
Affiliation(s)
- Gulab Singh
- Department of Civil Engineering, National Institute of Technology, Kurukshetra, Haryana, India.
| | - S K Patidar
- Department of Civil Engineering, National Institute of Technology, Kurukshetra, Haryana, India.
| |
Collapse
|
16
|
Fasaei F, Bitter J, Slegers P, van Boxtel A. Techno-economic evaluation of microalgae harvesting and dewatering systems. ALGAL RES 2018. [DOI: 10.1016/j.algal.2017.11.038] [Citation(s) in RCA: 270] [Impact Index Per Article: 45.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/15/2022]
|
17
|
|
18
|
Bayro-Kaiser V, Nelson N. Microalgal hydrogen production: prospects of an essential technology for a clean and sustainable energy economy. PHOTOSYNTHESIS RESEARCH 2017; 133:49-62. [PMID: 28239761 PMCID: PMC5500669 DOI: 10.1007/s11120-017-0350-6] [Citation(s) in RCA: 10] [Impact Index Per Article: 1.4] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/25/2016] [Accepted: 02/06/2017] [Indexed: 05/17/2023]
Abstract
Modern energy production is required to undergo a dramatic transformation. It will have to replace fossil fuel use by a sustainable and clean energy economy while meeting the growing world energy needs. This review analyzes the current energy sector, available energy sources, and energy conversion technologies. Solar energy is the only energy source with the potential to fully replace fossil fuels, and hydrogen is a crucial energy carrier for ensuring energy availability across the globe. The importance of photosynthetic hydrogen production for a solar-powered hydrogen economy is highlighted and the development and potential of this technology are discussed. Much successful research for improved photosynthetic hydrogen production under laboratory conditions has been reported, and attempts are underway to develop upscale systems. We suggest that a process of integrating these achievements into one system to strive for efficient sustainable energy conversion is already justified. Pursuing this goal may lead to a mature technology for industrial deployment.
Collapse
Affiliation(s)
- Vinzenz Bayro-Kaiser
- Department of Biochemistry and Molecular Biology, The George S. Wise Faculty of Life Sciences, Tel Aviv University, 69978, Tel Aviv, Israel.
| | - Nathan Nelson
- Department of Biochemistry and Molecular Biology, The George S. Wise Faculty of Life Sciences, Tel Aviv University, 69978, Tel Aviv, Israel
| |
Collapse
|
19
|
Boli E, Savvidou M, Logothetis D, Louli V, Pappa G, Voutsas E, Kolisis F, Magoulas K. Magnetic harvesting of marine algae Nannochloropsis oceanica. SEP SCI TECHNOL 2017. [DOI: 10.1080/01496395.2017.1296463] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Submit a Manuscript] [Subscribe] [Scholar Register] [Indexed: 10/20/2022]
Affiliation(s)
- E. Boli
- Laboratory of Thermodynamics and Transport Phenomena, School of Chemical Engineering, National Technical University of Athens, Athens, Greece
| | - M. Savvidou
- Biotechnology Laboratory, School of Chemical Engineering, National Technical University of Athens, Athens, Greece
| | - D. Logothetis
- Laboratory of Thermodynamics and Transport Phenomena, School of Chemical Engineering, National Technical University of Athens, Athens, Greece
| | - V. Louli
- Laboratory of Thermodynamics and Transport Phenomena, School of Chemical Engineering, National Technical University of Athens, Athens, Greece
| | - G. Pappa
- Laboratory of Thermodynamics and Transport Phenomena, School of Chemical Engineering, National Technical University of Athens, Athens, Greece
| | - E. Voutsas
- Laboratory of Thermodynamics and Transport Phenomena, School of Chemical Engineering, National Technical University of Athens, Athens, Greece
| | - F. Kolisis
- Biotechnology Laboratory, School of Chemical Engineering, National Technical University of Athens, Athens, Greece
| | - K. Magoulas
- Laboratory of Thermodynamics and Transport Phenomena, School of Chemical Engineering, National Technical University of Athens, Athens, Greece
| |
Collapse
|
20
|
Paranjape K, Leite GB, Hallenbeck PC. Effect of nitrogen regime on microalgal lipid production during mixotrophic growth with glycerol. BIORESOURCE TECHNOLOGY 2016; 214:778-786. [PMID: 27220067 DOI: 10.1016/j.biortech.2016.05.020] [Citation(s) in RCA: 14] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/06/2016] [Revised: 05/06/2016] [Accepted: 05/07/2016] [Indexed: 06/05/2023]
Abstract
Mixotrophic growth of microalgae to boost lipid production is currently under active investigation. Such a process could be of practical importance if a cheap source of organic carbon, such as waste glycerol from biodiesel production, could be used. Several previous studies have already demonstrated that this carbon source can be used by different indigenous strains of microalgae. In this study it is shown that different nitrogen limitation strategies can be applied to further increase lipid production during growth with glycerol. In one strategy, cultures were grown in nitrogen replete medium and then resuspended in nitrogen free medium. In a second strategy, cultures were grown with different initial concentrations of nitrate. Lipid production by the two microalgal strains used, Chlorella sorokiniana (PCH02) and Chlorella vulgaris (PCH05), was shown to be boosted by strategies of nitrogen limitation, but they responded differently to how nitrogen limitation was imposed.
Collapse
Affiliation(s)
- Kiran Paranjape
- Département de Microbiologie, Infectiologie et Immunologie, Université de Montréal, CP6128 Succursale Centre-ville, Montréal, Québec H3C 3J7, Canada
| | - Gustavo B Leite
- Département de Microbiologie, Infectiologie et Immunologie, Université de Montréal, CP6128 Succursale Centre-ville, Montréal, Québec H3C 3J7, Canada
| | - Patrick C Hallenbeck
- Département de Microbiologie, Infectiologie et Immunologie, Université de Montréal, CP6128 Succursale Centre-ville, Montréal, Québec H3C 3J7, Canada; Life Sciences Research Center, Department of Biology, United States Air Force Academy, 2355 Faculty Drive, USAF Academy, CO 80840, United States.
| |
Collapse
|
21
|
Jaatinen S, Lakaniemi AM, Rintala J. Use of diluted urine for cultivation of Chlorella vulgaris. ENVIRONMENTAL TECHNOLOGY 2015; 37:1159-1170. [PMID: 26508358 DOI: 10.1080/09593330.2015.1105300] [Citation(s) in RCA: 6] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/05/2023]
Abstract
Our aim was to study the biomass growth of microalga Chlorella vulgaris using diluted human urine as a sole nutrient source. Batch cultivations (21 days) were conducted in five different urine dilutions (1:25-1:300), in 1:100-diluted urine as such and with added trace elements, and as a reference, in artificial growth medium. The highest biomass density was obtained in 1:100-diluted urine with and without additional trace elements (0.73 and 0.60 g L(-1), respectively). Similar biomass growth trends and densities were obtained with 1:25- and 1:300-diluted urine (0.52 vs. 0.48 gVSS L(-1)) indicating that urine at dilution 1:25 can be used to cultivate microalgal based biomass. Interestingly, even 1:300-diluted urine contained sufficiently nutrients and trace elements to support biomass growth. Biomass production was similar despite pH-variation from < 5 to 9 in different incubations indicating robustness of the biomass growth. Ammonium formation did not inhibit overall biomass growth. At the beginning of cultivation, the majority of the biomass consisted of living algal cells, while towards the end, their share decreased and the estimated share of bacteria and cell debris increased.
Collapse
Affiliation(s)
- Sanna Jaatinen
- a Department of Chemistry and Bioengineering , Tampere University of Technology , Tampere , Finland
| | - Aino-Maija Lakaniemi
- a Department of Chemistry and Bioengineering , Tampere University of Technology , Tampere , Finland
| | - Jukka Rintala
- a Department of Chemistry and Bioengineering , Tampere University of Technology , Tampere , Finland
| |
Collapse
|
22
|
Lin Z, Xu Y, Zhen Z, Fu Y, Liu Y, Li W, Luo C, Ding A, Zhang D. Application and reactivation of magnetic nanoparticles in Microcystis aeruginosa harvesting. BIORESOURCE TECHNOLOGY 2015; 190:82-88. [PMID: 25935387 DOI: 10.1016/j.biortech.2015.04.068] [Citation(s) in RCA: 22] [Impact Index Per Article: 2.4] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/26/2015] [Revised: 04/12/2015] [Accepted: 04/13/2015] [Indexed: 06/04/2023]
Abstract
This study developed a magnetic nanoparticles (MNPs) harvesting and reactivation technique for rapid cyanobacteria Microcystis aeruginosa separation. The harvesting of raw MNPs achieved high efficiency of 99.6% with the MNPs dosage of 0.58g MNPs/g dry-biomass, but gradually decreased to 59.1% when directly reused 5 times. With extra ultrasonic chloroform:methanol solvent treatment, the MNPs can be effectively reactivated for M. aeruginosa harvesting with 60% efficiency after 5 times reactivation and the separation efficiency kept above 93% with 0.20g MNPs/g dry-biomass dosage. The cyanobacteria-MNPs complex can be effectively disrupted by ultrasonic chloroform:methanol solvent treatment and the zeta potential was recovered for MNPs electrostatic attraction. The MNPs adsorption followed the Langmuir isotherm, and the maximum adsorption capacity and Langmuir constant was 3.74g dry-biomass/g and 311.64L/g respectively. This MNPs reactivation technique can achieve low energy separation and reduce MNPs consumption by 67%, providing potential engineering implementation for cyanobacterial biomass harvesting.
Collapse
Affiliation(s)
- Zhong Lin
- College of Agriculture, Guangdong Ocean University, Zhanjiang 524088, PR China; Guangzhou Institute of Geochemistry, Chinese Academy of Sciences, Guangzhou 510640, PR China; Lancaster Environment Centre, Lancaster University, Lancaster LA1 2YQ, UK
| | - Yunfeng Xu
- School of Environmental and Chemical Engineering, Shanghai University, Shanghai 200444, PR China
| | - Zhen Zhen
- College of Agriculture, Guangdong Ocean University, Zhanjiang 524088, PR China
| | - Yu Fu
- School of Environmental and Chemical Engineering, Shanghai University, Shanghai 200444, PR China
| | - Yueqiao Liu
- College of Water Sciences, Beijing Normal University, Beijing 100875, PR China
| | - Wenyan Li
- College of Natural Resources and Environment, South China Agricultural University, Guangzhou 510642, PR China
| | - Chunling Luo
- Guangzhou Institute of Geochemistry, Chinese Academy of Sciences, Guangzhou 510640, PR China
| | - Aizhong Ding
- College of Water Sciences, Beijing Normal University, Beijing 100875, PR China
| | - Dayi Zhang
- Lancaster Environment Centre, Lancaster University, Lancaster LA1 2YQ, UK.
| |
Collapse
|
23
|
Şirin S, Clavero E, Salvadó J. Efficient harvesting of Chaetoceros calcitrans for biodiesel production. ENVIRONMENTAL TECHNOLOGY 2015; 36:1902-1912. [PMID: 25655268 DOI: 10.1080/09593330.2015.1015456] [Citation(s) in RCA: 7] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/04/2023]
Abstract
Harvesting is one of the key challenges to determine the feasibility of producing biodiesel from algae. This paper presents experimental results for a cost-effective system to harvest Chaetoceros calcitrans, using natural sedimentation, flocculation, and inducing pH. No efficient sedimentation of microalgal cells was observed only by gravity. By alkalinity-induced flocculation, at a pH value of 9.51, 86% recovery of the cells was achieved with a sedimentation rate of 125 cm/h and a concentration factor (CF) of 4 (volume/volume (v/v)) in 10 min. The maximum photochemical quantum yield of photosystem II (Fv/Fm) of concentrated cells was almost the same as fresh culture (0.621). Commercial flocculants, aluminium sulphate and poly-aluminium chloride (PAC), were also successful in harvesting the studied algal cells. Optimum concentration of aluminium sulphate (AS) could be concluded as 10 ppm with 87.6% recovery and 7.10 CF (v/v) in 30 min for cost-efficient harvesting, whereas for PAC it was 20 ppm with 74% recovery and 6.6 CF (v/v). Fv/Fm yields of concentrated cells with AS and PAC showed a 1% reduction compared to fresh culture. Mg+2 was the triggering ion for alkalinity-induced flocculation in the conditions studied. The rheology behaviour of the concentrated cells was Newtonian with values between 2.2×10(-3) and 2.3×10(-3) Pa s at 30°C.
Collapse
Affiliation(s)
- Sema Şirin
- a Departament d'Enginyeria Química , Universitat Rovira i Virgili , 43007 Tarragona , Catalonia , Spain
| | | | | |
Collapse
|
24
|
Hallenbeck PC, Grogger M, Mraz M, Veverka D. Building a better mousetrap I: using Design of Experiments with unconfounded ions to discover superior media for growth and lipid production by Chlorella sp. EN1234. BIORESOURCE TECHNOLOGY 2015; 184:82-89. [PMID: 25465787 DOI: 10.1016/j.biortech.2014.10.144] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.1] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/28/2014] [Revised: 10/28/2014] [Accepted: 10/29/2014] [Indexed: 06/04/2023]
Abstract
An unconfounded Scheffe Mix approach was used to probe important ions and their interactions in supporting biomass and lipid production by Chlorella sp. EN1234. Six major cations and anions; NH4(+), NO3(-), Na(+), K(+) PO4(-) and Cl(-) were examined. Piepel plots and RSM analysis showed that in a number of cases, the major media anions PO4(-) and Cl(-) negatively influence final cell densities, and that maximal cell density is obtained with nitrate over ammonium, with an optimal effect when mixed with equal molar potassium. As well, although it is commonly assumed that lipid content increases in nitrogen deficient media, here little correlation between nitrogen content and total lipid content was found with mixtures that supported high lipid productivity. Thus these mixtures define the composition space within which further R&D might produce the best trade-off between total biomass production and high cellular lipid content.
Collapse
Affiliation(s)
- Patrick C Hallenbeck
- Life Sciences Research Center, Department of Biology, United States Air Force Academy, 2355 Faculty Drive, USAF Academy, CO 80840, United States.
| | - Melanie Grogger
- Life Sciences Research Center, Department of Biology, United States Air Force Academy, 2355 Faculty Drive, USAF Academy, CO 80840, United States
| | - Megan Mraz
- Life Sciences Research Center, Department of Biology, United States Air Force Academy, 2355 Faculty Drive, USAF Academy, CO 80840, United States
| | - Donald Veverka
- Life Sciences Research Center, Department of Biology, United States Air Force Academy, 2355 Faculty Drive, USAF Academy, CO 80840, United States
| |
Collapse
|
25
|
Lee YC, Lee K, Oh YK. Recent nanoparticle engineering advances in microalgal cultivation and harvesting processes of biodiesel production: a review. BIORESOURCE TECHNOLOGY 2015; 184:63-72. [PMID: 25465786 DOI: 10.1016/j.biortech.2014.10.145] [Citation(s) in RCA: 34] [Impact Index Per Article: 3.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/12/2014] [Revised: 10/28/2014] [Accepted: 10/29/2014] [Indexed: 06/04/2023]
Abstract
Among the various steps entailed in the production of biodiesel from microalgae, the efficiency and cost-reduction of the cultivation and harvesting steps remain key obstacles to its practical commercialization. Recently, in order to overcome the technical bottlenecks and limitations with regard to both steps, nanoparticle engineering based on particles' unique physico-chemical and mechanical properties has been extensively applied as a powerful analytical and practical tool. These applications include the enhancement of cell growth and/or pigments by light back-scattering, the induction of intracellular lipid accumulation by nutritional competition and/or stress environment, the improvement of cell separation efficiency and processing time from culture broth, the multiple reuse of magnetic nanoparticle flocculant, and integrated one-pot harvesting/cell-disruption. This review presents and discusses the recent nanoparticle-engineering-based developments in the implementation of practical microalgal cultivation and harvesting processes.
Collapse
Affiliation(s)
- Young-Chul Lee
- Department of BioNano Technology, Gachon University, Seongnam-si, Gyeonggi-do 461-701, Republic of Korea
| | - Kyubock Lee
- Biomass and Waste Energy Laboratory, Korea Institute of Energy Research (KIER), Daejeon 305-343, Republic of Korea
| | - You-Kwan Oh
- Biomass and Waste Energy Laboratory, Korea Institute of Energy Research (KIER), Daejeon 305-343, Republic of Korea.
| |
Collapse
|
26
|
Hallenbeck PC, Grogger M, Mraz M, Veverka D. Building a better mousetrap II: using Design of Experiments with unconfounded ions to compare the growth of different microalgae. BIORESOURCE TECHNOLOGY 2015; 184:90-99. [PMID: 25465789 DOI: 10.1016/j.biortech.2014.11.006] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/07/2014] [Revised: 11/02/2014] [Accepted: 11/03/2014] [Indexed: 06/04/2023]
Abstract
A large number of unconfounded media variations were used with a Scheffe Mix Model to examine in an unambiguous fashion the effects of variations in six important ions; NH4(+), NO3(-), Na(+), K(+), PO4(-), and Cl(-), on the growth of Chlorella vulgaris. This allows several novel observations on media components, for example, the inhibitory effects of chloride, to be made. Using a side by side comparison, it is shown that two strains of Chlorella show significant physiological and functional differences brought out by this approach. Testing selected formulations with a diverse set of algae demonstrated different effects on both growth and cellular lipid content, in some cases driving significant lipid production. This suggests that future work using a larger portion of media composition space could lead to the development of novel media supporting maximal biomass production and lipid production.
Collapse
Affiliation(s)
- Patrick C Hallenbeck
- Life Sciences Research Center, Department of Biology, United States Air Force Academy, 2355 Faculty Drive, USAF Academy, CO 80840, United States.
| | - Melanie Grogger
- Life Sciences Research Center, Department of Biology, United States Air Force Academy, 2355 Faculty Drive, USAF Academy, CO 80840, United States
| | - Megan Mraz
- Life Sciences Research Center, Department of Biology, United States Air Force Academy, 2355 Faculty Drive, USAF Academy, CO 80840, United States
| | - Donald Veverka
- Life Sciences Research Center, Department of Biology, United States Air Force Academy, 2355 Faculty Drive, USAF Academy, CO 80840, United States
| |
Collapse
|
27
|
Hallenbeck PC, Grogger M, Mraz M, Veverka D. The use of Design of Experiments and Response Surface Methodology to optimize biomass and lipid production by the oleaginous marine green alga, Nannochloropsis gaditana in response to light intensity, inoculum size and CO2. BIORESOURCE TECHNOLOGY 2015; 184:161-168. [PMID: 25304731 DOI: 10.1016/j.biortech.2014.09.022] [Citation(s) in RCA: 22] [Impact Index Per Article: 2.4] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/16/2014] [Revised: 09/02/2014] [Accepted: 09/04/2014] [Indexed: 06/04/2023]
Abstract
Biodiesel produced from microalgal lipids is being considered as a potential source of renewable energy. However, a number of hurdles will have to be overcome if such a process is to become practical. One important factor is the volumetric production of biomass and lipid that can be achieved. The marine alga Nannochloropsis gaditana is under study since it is known to be highly oleaginous and has a number of other attractive properties. Factors that might be important in biomass and lipid production by this alga are light intensity, inoculum size and CO2. Here we have carried out for the first time a RSM-DOE study of the influence of these important culture variables and define conditions that maximize biomass production, lipid content (BODIPY® fluorescence) and total lipid production. Moreover, flow cytometry allowed the examination on a cellular level of changes that occur in cellular populations as they age and accumulate lipids.
Collapse
Affiliation(s)
- Patrick C Hallenbeck
- Life Sciences Research Center, Department of Biology, United States Air Force Academy, 2355 Faculty Drive, USAF Academy, CO 80840, United States.
| | - Melanie Grogger
- Life Sciences Research Center, Department of Biology, United States Air Force Academy, 2355 Faculty Drive, USAF Academy, CO 80840, United States
| | - Megan Mraz
- Life Sciences Research Center, Department of Biology, United States Air Force Academy, 2355 Faculty Drive, USAF Academy, CO 80840, United States
| | - Donald Veverka
- Life Sciences Research Center, Department of Biology, United States Air Force Academy, 2355 Faculty Drive, USAF Academy, CO 80840, United States
| |
Collapse
|
28
|
Hallenbeck PC, Leite GB, Abdelaziz AE. Exploring the diversity of microalgal physiology for applications in wastewater treatment and biofuel production. ALGAL RES 2014. [DOI: 10.1016/j.algal.2014.09.006] [Citation(s) in RCA: 13] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/22/2022]
|
29
|
Abdelaziz AEM, Leite GB, Belhaj MA, Hallenbeck PC. Screening microalgae native to Quebec for wastewater treatment and biodiesel production. BIORESOURCE TECHNOLOGY 2014; 157:140-148. [PMID: 24549235 DOI: 10.1016/j.biortech.2014.01.114] [Citation(s) in RCA: 35] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/25/2013] [Revised: 01/24/2014] [Accepted: 01/27/2014] [Indexed: 06/03/2023]
Abstract
Biodiesel production from microalgae lipids is being considered as a potential source of renewable energy. However, practical production processes will probably require the use of local strains adapted to prevailing climatic conditions. This report describes the isolation of 100 microalgal strains from freshwater lakes and rivers located in the vicinity of Montreal, Quebec, Canada. Strains were identified and surveyed for their growth on secondary effluent from a municipal wastewater treatment plant (La Prairie, QC, Canada) using a simple and high throughput microalgal screening method employing 12 well plates. The biomass and lipid productivity of these strains on wastewater were compared to a synthetic medium under different temperatures (10±2°C and 22±2°C) and a number identified that showed good growth at 10°C, gave a high lipid content (ranging from 20% to 45% of dry weight) or a high capacity for nutrient removal.
Collapse
Affiliation(s)
- Ahmed E M Abdelaziz
- Département de microbiologie et immunologie, Université de Montréal, CP 6128, Centre-ville, Montréal, PQ H3C 3J7, Canada
| | - Gustavo B Leite
- Département de microbiologie et immunologie, Université de Montréal, CP 6128, Centre-ville, Montréal, PQ H3C 3J7, Canada
| | - Mohamed A Belhaj
- Département de microbiologie et immunologie, Université de Montréal, CP 6128, Centre-ville, Montréal, PQ H3C 3J7, Canada
| | - Patrick C Hallenbeck
- Département de microbiologie et immunologie, Université de Montréal, CP 6128, Centre-ville, Montréal, PQ H3C 3J7, Canada.
| |
Collapse
|
30
|
Abdelaziz AEM, Ghosh D, Hallenbeck PC. Characterization of growth and lipid production by Chlorella sp. PCH90, a microalga native to Quebec. BIORESOURCE TECHNOLOGY 2014; 156:20-8. [PMID: 24472701 DOI: 10.1016/j.biortech.2014.01.004] [Citation(s) in RCA: 10] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/02/2013] [Revised: 12/30/2013] [Accepted: 01/02/2014] [Indexed: 05/18/2023]
Abstract
Microalgae are being investigated as potential candidates for biodiesel production since they can be grown without competition with food production, have an inherently fast growth rate, and can have a high lipid content under different nutrient limiting conditions. However, large scale production will best be carried out with indigenous strains, well adapted to local conditions. This study reports on the characterization of the novel microalga Chlorella sp. PCH90, isolated in Quebec. Its molecular phylogeny was established and lipid production studies as a function of the initial concentrations of nitrate, phosphate, and sodium chloride were carried out using response surface methodology. Under the appropriate conditions this microalga could produce up to 36% lipid and grew well in both synthetic medium and secondary effluent from a wastewater treatment plant at both 22 and 10°C. Thus, this strain is promising for further development as a potential biofuels producer under local climatic conditions.
Collapse
Affiliation(s)
- Ahmed Elsayed Mohamed Abdelaziz
- Département de Microbiologie, Infectologie et Immunologie, Université de Montréal, CP 6128 Succursale Centre-ville, Montréal, Québec H3C 3J7, Canada
| | - Dipankar Ghosh
- Département de Microbiologie, Infectologie et Immunologie, Université de Montréal, CP 6128 Succursale Centre-ville, Montréal, Québec H3C 3J7, Canada
| | - Patrick C Hallenbeck
- Département de Microbiologie, Infectologie et Immunologie, Université de Montréal, CP 6128 Succursale Centre-ville, Montréal, Québec H3C 3J7, Canada.
| |
Collapse
|