Growth performance, blood lipids, and fat digestibility of broilers fed diets supplemented with bile acid and xylanase

This study aimed to show the effect of bile acid (BA) and xylanase (Xyl) supplementation on the growth, fat digestibility, serum lipid metabolites, and ileal digesta viscosity of broilers. A total of 720 1 d old male broilers were allocated to one of nine treatments with four replicates in each under a factorial design arrangement of three levels of BA (0 %, 0.25 %, and 0.50 %) and three levels of Xyl (0 %, 0.05 %, and 0.10 %) supplementation. The duration of the experiment was 35 d (7-42 d). Growth performance, blood lipids, fat digestibility, and ileal digesta viscosity were determined. The experimental treatments did not affect feed intake (FI) and weight gain (WG). Supplementation of BA or Xyl did not significantly ameliorate the feed conversion rate (FCR) (p < 0.05 ). The addition of BA linearly increased fat digestibility. At 7-21 d of age, the addition of BA or Xyl had a significant (p < 0.05 ) increase in serum cholesterol (Chol) but no significant difference for other serum lipid parameters in broiler chickens fed with Xyl in the starter and grower periods. However, the supplementation of 0.5 % BA at 7-21 d of age significantly increased the Chol and low-density-lipoprotein (LDL) levels. The results of this trial revealed that the supplementation of xylanases had a great effect on the degradation of arabinoxylan from wheat, which led to a relatively greater reduction in ileal digesta viscosity; it was also found that supplementation of BA significantly increased the concentration of serum lipid metabolites, whereas BA and Xyl supplementation linearly increased the fat digestibility of the birds fed wheat and tallow diets.

The ileal and total tract digestibility fibre and nutrients in pigs fed high-fibre cereal-based diets provided without and with a carbohydrase complex

The effect of carbohydrase can be variable according to the complexity of cereal grains and co-products. Studies on the effect of carbohydrase on cereal diets varying in complexity are scarce. This study was conducted to investigate the apparent ileal (AID) and total tract digestibility (ATTD) of energy, fibre and nutrients in pigs fed diets based on cereal grains and co-products without and with supplementation with a carbohydrase complex in the form of xylanase, arabinofuranosidase and β-glucanase. The experiment was carried out as an 8 × 4 Youden Square design (eight diets and four periods by two blocks) using 16 growing pigs (33.3 ± 0.8 kg) surgically fitted with a T-cannula in the terminal ileum. The pigs were fed eight experimental diets based on either - maize, wheat, rye, or a wheat and rye mix that were provided with or without enzyme supplementation. The AID and ATTD of DM, organic matter, energy, CP, fat, starch, and soluble and insoluble non-starch polysaccharides (NSPs) were studied using titanium dioxide as an indigestible marker. There was a cereal type effect (P < 0.05) of the AID of most of the nutrients investigated but ash and NSP and some of its constituents but with no interactions between cereal types and carbohydrase supplementation (P > 0.05). The ATTD of nutrients in the large intestine was mainly influenced by the fibre composition and was significantly lower (P < 0.001) for NSP, protein and energy for the Maize than the other diets. Supplementation of the cereal diets with the carbohydrase complex partially degrades arabinoxylan (AX) and β-glucan giving rise to a generally higher AID of high-molecular weight arabinoxylan (P = 0.044), starch (P = 0.042), a tendency (P < 0.10) of higher AID of non-cellulosic polysaccharide glucose residue (β-glucan) and soluble arabinoxylan (AX) whereas none of the other components were affected (P > 0.05). Collectively, the results indicate that the carbohydrase complex degrades AX in the stomach and small intestine, leading to a higher AID but with no influence on the ATTD of fibres, nutrients, and energy.

Effects of substituting wheat by rye in diets for young fattening pigs on nutrient digestibility, performance, products of intestinal fermentation, and fecal characteristics

Climate change and increasing demands to reduce the environmental impact of feed production are major challenges for animal nutritionists. Compared to wheat, which is commonly used in high levels in European piglet diets, rye is more efficient in using limited resources, most importantly, water and phosphorus. As a result, its cultivation has a relatively low carbon footprint. The high amounts of non-starch polysaccharides of rye might lead to an increased intestinal fermentation with potential beneficial effects on gut health. However, the high levels of non-starch polysaccharides in rye, which have a major impact on the physico-chemical conditions of the digesta, might affect digestibility and performance especially in young animals. It was therefore of interest to compare the effects of isoenergetic diets with increasing levels of rye as a replacement for wheat fed to young fattening pigs (bodyweight: 16-40 kg). The control diet contained 69% of wheat, while in the other three experimental diets, the amount of wheat was gradually replaced (by a third in each case) with rye. Thus, the experimental diets contained 23, 46, and 69% of rye. A total of 40 young pigs were housed individually in four dietary treatment groups. During a 4 week trial, effects on performance, digestibility, products of intestinal fermentation, and fecal characteristics were evaluated. There were no negative effects on feed intake and gains, even though the feed conversion ratio increased with the highest dietary rye level (69%). Digestibility rates of organic matter and crude protein did not differ significantly. Without affecting the characteristics of the feces, numerically higher amounts of intestinal fermentation products and higher colonic digesta mass were observed.

A simple tandem mass spectrometry method for structural identification of pentose oligosaccharides

Differentiation of stereoisomers that are only dissimilar in the orientation of chemical bonds in space by mass spectrometry remains challenging. Structural determination of carbohydrates by mass spectrometry is difficult, mainly due to the large number of stereoisomers in carbohydrates. Arabinose and xylose are pentose stereoisomers typically present in plant polysaccharides and exist in α- and β-anomeric configurations of furanose and pyranose forms. Conventional methods used to determine the structures of polysaccharides include hydrolysis of polysaccharides into oligosaccharides followed by identification of these oligosaccharides' structures individually through nuclear magnetic resonance spectroscopy (NMR). Although the sensitivity of mass spectrometry is much higher than that of NMR, conventional mass spectrometry provides only limited useful information on oligosaccharide structure determination, only the linkage positions of glycosidic bonds. In this study, we demonstrated a mass spectrometry method for the identification of linkage positions, anomeric configurations, and monosaccharide stereoisomers of intact oligosaccharides consisting of arabinose and xylose. We separated arabinose and xylose monosaccharides into α-furanose, β-furanose, α-pyranose, and β-pyranose forms through high-performance liquid chromatography and obtained the corresponding collision-induced dissociation mass spectra. Using these monosaccharide spectra and a flow chart consisting of the proper CID sequences derived from the dissociation mechanisms of pentose, a simple multi-stage tandem mass spectrometry method for structural identification of intact oligosaccharides consisting of arabinose and xylose was developed. The new mass spectrometry method provides a simple method for determining the structure of polysaccharides consisting of arabinose and xylose. The flow chart can be used in computer coding for automation, an ultimate goal for oligosaccharide structure determination.

Beneficial effects of butyrate on brain functions: A view of epigenetic

Brain functions are influenced by the presence, activity, and metabolism of the gut microbiota through the gut-microbiota-brain (GMB) axis. The consumption of a fiber-rich diet increases the content of short-chain fatty acids (SCFAs) from bacterial fermentation in the colon. Among SCFAs, butyrate stands out because of its wide array of biological functions, such as ability to influence brain functions. Pharmacologically, sodium butyrate (NaB) regulates gene expression in the brain, where it has several beneficial effects ranging from neurodegenerative diseases to behavioral disorders through inhibitors of histone deacetylases (HDACis). In this context, we review the mechanisms of action of the two types of butyrate on brain functions, with an emphasis on the epigenetic approach. Both types of butyrate are potentially interesting for the prevention and adjuvant therapy of neurological and psychological disorders due to their neuroprotective functions. However, further studies are needed to investigate the possible neuroepigenetic effects of butyrate derived from bacterial fermentation.

High Dietary Intake of Rye Affects Porcine Gut Microbiota in a Salmonella Typhimurium Infection Study

Bacterial fermentation of undigested carbohydrates in the hindgut has considerable potential for the stimulation or inhibition of the growth of distinct bacteria within microbiota. The aim of the present study was to evaluate whether high levels of rye affect porcine gut microbiota composition with subsequent effects on the load of Salmonella Typhimurium, an intestinal pathogen with zoonotic relevance. Therefore, forty-two 25-day-old piglets were allocated to two groups and fed a diet containing either 69% wheat or 69% rye for 35 days. One week after introducing the two different diets, the piglets were experimentally infected with Salmonella Typhimurium. The microbiota composition of cecal and fecal samples of the piglets were evaluated 28 days after infection. In the cecum, promoted growth of Bifidobacterium, several lactic acid bacteria and Faecalibacterium prausnitzii were seen in pigs fed the diet containing 69% rye. Bacterial species belonging to the genera Bifidobacterium and Catenisphaera were associated with differing bacterial counts of Salmonella Typhimurium detected in the cecal contents of all piglets in both feeding groups via cultural cultivation. The high intake of rye instead of wheat seems to promote the growth of beneficial intestinal bacteria accompanied by impaired growth conditions for the foodborne pathogen Salmonella Typhimurium.

An Update Regarding the Bioactive Compound of Cereal By-Products: Health Benefits and Potential Applications

Cereal processing generates around 12.9% of all food waste globally. Wheat bran, wheat germ, rice bran, rice germ, corn germ, corn bran, barley bran, and brewery spent grain are just a few examples of wastes that may be exploited to recover bioactive compounds. As a result, a long-term strategy for developing novel food products and ingredients is encouraged. High-value compounds like proteins, essential amino acids, essential fatty acids, ferulic acid, and other phenols, tocopherols, or β-glucans are found in cereal by-products. This review aims to provide a critical and comprehensive overview of current knowledge regarding the bioactive compounds recovered from cereal by-products, emphasizing their functional values and potential human health benefits.

In vitro evaluation of sodium butyrate on the growth of three Salmonella serovars derived from pigs at a mild acidic pH value

Foodborne zoonotic diseases can be transferred into the food chain at the stage of livestock farming. As an emerging public health challenge, practicable reduction measures in porcine health management for Salmonella are constantly being investigated. This in vitro study aimed to determine the influence of six different sodium butyrate (SB) concentrations (0, 5, 10, 20, 40, and 80 mM) on the growth of three different Salmonella enterica serovars at a constant pH value of 6.0, corresponding to conditions in the pig's hindgut. S. Derby and S. Typhimurium, isolated from a pig farm, and S. Typhimurium DSM 19587, which served as control, were used. Broth microdilution assay was applied to record Salmonella growth in the presence of different SB-concentrations over six different incubation periods (0, 1, 2, 4, 6, and 24 h). Results were quantified in the log colony-forming units (log10 CFU/mL). For 1 h incubation, the addition of SB showed no significant differences in the range of initial Salmonella dose of about 5.7 log10 between concentrations (0-80 mM, 5.26 ± 0.10-5.60 ± 0.07 log10, p > 0.05). After 6 h, for SB addition, the range of Salmonella counts was significantly lower compared to no addition of SB (5-80 mM, p < 0.05), 6.78 ± 0.84-7.90 ± 0.10 log10 for 5 mM, and 7.53 ± 0.04-8.71 ± 0.22 log10 for 0 mM. Moreover, for SB concentrations of 40 and 80 mM, no difference in the range of Salmonella counts over 6 h was obtained (5.23 ± 0.11-5.38 ± 0.05 log10, p > 0.05), and minor Salmonella growth was recorded at the earliest after 24 h incubation. Growth rates for varying SB concentrations and incubation times were confirmed in a similar manner for the three serovars. Obtained results suggest that increasing SB concentrations suppress Salmonella growth for concentrations of 5-20 mM over a 6 h incubation period and for 40 and 80 mM over a 24 h incubation period. When transferring these in vitro findings to the porcine organism, it may be assumed that Salmonella reduction can be achieved by increased butyrate content in the chyme of the large intestine.

Rye Flour and Rye Bran: New Perspectives for Use

Rye (Secale cereale L.) is abundantly cultivated in countries like Europe and North America, particularly in regions where soil and climate conditions are unfavorable for the growth of other cereals. Among all the cereals generally consumed by human beings, rye grains are characterized by the presence of the highest content of fiber. They are also a rich source of many phytochemical compounds, which are mainly distributed in the outer parts of the grain. This review focuses on the current knowledge regarding the characteristics of rye bran and wholemeal rye flour, as well as their applications in the production of both food and nonfood products. Previous studies have shown that the physicochemical properties of ground rye products are determined by the type of milling technique used to grind the grains. In addition, the essential biologically active compounds found in rye grains were isolated and characterized. Subsequently, the possibility of incorporating wholemeal rye flour, rye bran, and other compounds extracted from rye bran into different industrial products is discussed.

Valorization of cereal by-product hemicelluloses: Fractionation and purity considerations

The biomass from cereal side streams is rich in valuable components, such as hemicelluloses. Among the hemicelluloses, arabinoxylans and β-glucans are the most acknowledged for potential health benefits. Numerous publications discuss the potential to use purified forms of these hemicelluloses for various applications. However, as the purification of hemicelluloses may not be economically feasible to upscale, sustainable and cost-effective methods are needed to make their valorization more realistic for industrial applications. Co-components present in hemicellulose-rich fractions may also provide added functionality, such as flavonoid content and antioxidant capacity. This review provides an overview on the feasibility of sustainably upscaling hemicellulose extraction processes, focusing on by-products from different cereal streams. We describe the hemicelluloses' physicochemical properties and provide various possible applications of pure and impure fractions from small scale to pilot and industrial scale. Furthermore, real case examples on the industrial utilization of cereal side streams are enclosed. This review provides pathways for future research for developing the hemicellulose extraction methods to obtain fractions with optimized purity, and offers suggestions to valorize them.

Effects of Dietary Cereal and Protein Source on Fiber Digestibility, Composition, and Metabolic Activity of the Intestinal Microbiota in Weaner Piglets

Simple Summary

Rye and rapeseed meal can be alternative feed components for weaner piglets instead of wheat and soybean meal. Both components can help to meet current challenges in pig nutrition, such as increasingly dry weather conditions and the high amount of imported soybean. Since they contain more and differently composed fiber, effects on digestive physiology and intestinal microbiota might help to maintain gut health and prevent post-weaning diarrhea. This study shows that despite a similar composition of the large intestinal microbiota, the higher amount and solubility of complex carbohydrates from rye lead to a higher fermentative activity compared to wheat, which is considered a beneficial effect. The high amount of insoluble dietary fiber in rapeseed-based diets lowered bacterial metabolic activity and caused a shift toward insoluble fiber degrading bacteria.

Abstract

This study aimed to investigate the effect of fiber-rich rye and rapeseed meal (RSM) compared to wheat and soybean meal (SBM) on fiber digestibility and the composition and metabolic activity of intestinal microbiota. At weaning, 88 piglets were allocated to four feeding groups: wheat/SBM, wheat/RSM, rye/SBM, and rye/RSM. Dietary inclusion level was 48% for rye and wheat, 25% for SBM, and 30% for RSM. Piglets were euthanized after 33 days for collection of digesta and feces. Samples were analyzed for dry matter and non-starch-polysaccharide (NSP) digestibility, bacterial metabolites, and relative abundance of microbiota. Rye-based diets had higher concentrations of soluble NSP than wheat-based diets. RSM-diets were higher in insoluble NSP compared to SBM. Rye-fed piglets showed a higher colonic and fecal digestibility of NSP (p < 0.001, p = 0.001, respectively). RSM-fed piglets showed a lower colonic and fecal digestibility of NSP than SBM-fed piglets (p < 0.001). Rye increased jejunal and colonic concentration of short-chain fatty acids (SCFA) compared to wheat (p < 0.001, p = 0.016, respectively). RSM-fed pigs showed a lower jejunal concentration of SCFA (p = 0.001) than SBM-fed pigs. Relative abundance of Firmicutes was higher (p = 0.039) and of Proteobacteria lower (p = 0.002) in rye-fed pigs compared to wheat. RSM reduced Firmicutes and increased Actinobacteria (jejunum, colon, feces: p < 0.050), jejunal Proteobacteria (p = 0.019) and colonic Bacteroidetes (p = 0.014). Despite a similar composition of the colonic microbiota, the higher amount and solubility of NSP from rye resulted in an increased fermentative activity compared to wheat. The high amount of insoluble dietary fiber in RSM-based diets reduced bacterial metabolic activity and caused a shift toward insoluble fiber degrading bacteria. Further research should focus on host–microbiota interaction to improve feeding concepts with a targeted use of dietary fiber.

Rye: A wonder crop with industrially important macromolecules and health benefits

Rye (Secale cereale) is a rich source of macromolecules, especially starch, fiber, and proteins which encourages the researchers and industries to use it for various purposes including bakery products, beverages and edible films formulation. However, despite many nutritional and health benefiting properties, rye has not been explored up to its full potential. Interest of consumers in formulating foods with high fiber and phenolic compounds has generated our interest in compiling the detailed information on rye. The present review on rye grains summarizes the existing scientific data on rye macronutrients (starch, arabinoxylan, β-glucan, fructan and proteins) and their corresponding industrial importance. Detailed description in this review unfolds the potential of rye grains for human nutrition. This review provides comprehensive knowledge and fills the remaining gap between the previous and latest scientific findings. Comprehensive information on rye nutrients along with health benefits will help to open a new era for scientific world and industrial sectors.

Rye: Current state and future trends in research and applications

After wheat, rye is the second most important raw material for bread and bakery products, and it is one of the most excellent sources of dietary fibres and bioactive compounds. Besides, rye is utilised in more and more other food products as well, such as breakfast cereals, porridges, pasta, snack products, etc. Interestingly, its production is decreasing worldwide, probably because of the expansion of other cereals (e.g. triticale), but also the effect of climate change can also play a role therein. However, there is no doubt that scientific research aimed at studying the possible health benefits and the potential of rye in the development of novel food products has intensified over the past decade.

The aim of our paper is to make a comprehensive review of the latest results on the compositional and technological properties of rye that fundamentally influence its utilisation for food purposes. Furthermore, this review aims to identify the current development directions and trends of rye products.

Effects of increasing dietary rye levels on physicochemical characteristics of digesta and its impact on stomach emptying as well as the formation of 'doughballs' in stomachs of young pigs

Despite quite similar contents of starch and crude fibre of wheat and rye, the unique non-starch-polysaccharide fraction of rye (e.g. high levels of arabinoxylans and fructans) might have an impact on physicochemical properties of the digesta in pigs. Forty pigs (age: 46.8 ± 5.28 days; bodyweight: 16.1 ± 4.13 kg) were divided into four treatment groups. During four weeks, the pigs received diets consisting of wheat and/or rye, barley, soy, potato protein and a mineral supplement. The sum of wheat and rye was 69% in all diets, whereby the compound feed of each group was characterized by a different ratio (%) of wheat/rye (69/0; 46/23; 23/46; 0/69, respectively). In the stomach, 'doughballs' occurred more frequently with increasing dietary rye levels (9/10; 69% rye). With higher DM content and extract-viscosity of gastric digesta, the stomach emptying tended to be retarded in rye groups. Compared to the control group (69% wheat), maximum dietary rye levels (69%) resulted in significantly higher concentrations of lactic acid in digesta of the stomach and small intestine. With increasing lactic acid concentrations, the pH tended to be lower in small intestinal digesta. With an intensified formation of lactic acid, effects against Gram-negative bacteria, for example Salmonella, can be expected. Moreover, because of higher viscosity and the retarded stomach emptying, there could be advantages of including rye in compound feeds when a longer lasting satiety is intended, for example when feeding pregnant sows (regularly fed restrictively).

Hybrid rye may replace up to 75% of the corn in diets for gestating and lactating sows without negatively impacting sow and piglet performance

An experiment was conducted to test the hypothesis that hybrid rye can replace a part of the corn in gestation and lactation diets without negatively affecting sow and litter performance. For each phase, a corn-soybean meal diet and three diets in which hybrid rye replaced 25%, 50%, or 75% of corn were formulated. Two hundred sows were randomly allotted by parity to the four treatments. Results indicated that diet did not affect body weight or average daily gain (ADG) of sows or number of pigs born. The number of pigs weaned, litter weaning weight, and litter ADG increased and then decreased (quadratic, P < 0.05) as hybrid rye in diets increased. Pig mortality and number of crushed pigs tended (quadratic, P < 0.10) to be reduced as hybrid rye was added to the diet. Serum cytokines did not differ among treatments on day 105 of gestation or in pigs on the day of weaning, but interleukin (IL)-4, IL-10, and IL-18 on day 13 of lactation increased and then decreased (quadratic, P < 0.05) as hybrid rye inclusion increased in diets. Milk urea N increased (linear, P < 0.05) as hybrid rye was included in the diet, but no other differences in milk composition were observed. Overall, replacing 25% or 50% of corn with hybrid rye resulted in improved lactation performance, and replacing 75% of corn with hybrid rye resulted in sow and litter performance that was not different from that of sows fed control diets.

Effects of cereal and protein source on performance, apparent ileal protein digestibility and intestinal characteristics in weaner piglets

Rye and rapeseed meal (RSM) are alternatives to wheat and soybean meal (SBM) in pig nutrition. The inclusion of rye and RSM instead of wheat and SBM may increase dietary fibre content in the feed, which may affect digestive physiology and intestinal function. However, research on the combined feeding of rye and RSM in piglets is still scarce. The aim of this study was to investigate the effects of rye and RSM containing feed on growth performance, protein and amino acid digestibility, physical characteristics of the digesta and the intestinal morphology in weaner piglets. A total of 88 piglets aged 28 d were randomly allotted to four different feeding groups at weaning: wheat/SBM, wheat/RSM, rye/SBM, rye/RSM. Cereals were included at 48%, SBM at 25% and RSM at 30%. Body weight gain and feed intake were recorded weekly. After 33 d, piglets were euthanised for assessment of digesta and intestinal morphology. Rye did not affect performance, whilst RSM resulted in reduced weight gain (p = 0.024) and feed intake (p = 0.037). Apparent ileal digestibility of crude protein and amino acids was decreased by rye and RSM (p < 0.05). Rye caused an acidification (p = 0.045) and increased viscosity (p = 0.013) of small intestinal digesta, a lower dry matter content of jejunal and colonic digesta (p < 0.05) and an increased relative weight of the colon tissue (p < 0.001). In conclusion, performance was not reduced when rye was used as an alternative to wheat in diets for weaner piglets. The inclusion of RSM instead of SBM to piglets' diet lowered animal performance under our conditions. Further investigations are warranted to characterise the quality of rapeseed meal and the optimum inclusion level in the diet for young pigs.

Comparison of Alkaline/Oxidative and Hydrothermal Extraction of Wheat Bran Arabinoxylans

The bran accounts for approximately 25% of the wheat kernel but is currently only a by-product, used as animal feed. However, due to its high arabinoxylan content it could be a valuable raw material for food production. Arabinoxylans cannot be digested in the human intestine but are intensely studied for their health-beneficial properties. These include glycemic control by formation of a highly viscous gel in the intestine, and hence delaying starch digestion, alongside an increase in short chain fatty acids. To apply sufficient amounts of arabinoxylan for health-beneficial effects, extraction and concentration is required. Alkaline/oxidative conditions are commonly used, but for potential food applications more cost-efficient methods, without hazardous chemicals, are required. Therefore, this study aimed to optimize the conditions for hydrothermal extraction (extraction time and temperature) at laboratory-scale and to compare the results to an established alkaline/oxidative method. The resulting extracts were characterized for yield, purity, arabinoxylan molecular mass, arabinose/xylose ratio, and viscosity to evaluate the quality of the method. For the hydrothermal extraction, an extraction time of 1 h at 160 °C and 6.5 bar gave the best results. However, even these optimized conditions resulted in lower extract purity and severely degraded arabinoxylans. Although further optimization of the hydrothermal process is required, the present work builds an important foundation for the development of an industrial hydrothermal extraction method.

The role of rye bran and antibiotics on the digestion, fermentation process and short-chain fatty acid production and absorption in an intact pig model

The effects of arabinoxylan (AX)-rich rye bran based diet (RB) and antibiotics on digestion, fermentation and short-chain fatty acids (SCFA) absorption were studied compared with an iso-dietary fibre (DF) cellulose based diet (CEL). Thirty female pigs (body weight 72.5 ± 3.9 kg) were fed a standard swine diet in week 1, CEL as wash-out for bran-associated bioactive components in week 2 and then divided into 3 groups fed either the CEL (n = 10) or RB (n = 20) for 2 weeks, where 10 pigs from RB had daily intramuscular antibiotic injections (RB+) and the other 10 pigs were untreated (RB-) in week 4. In RB, the degradation of AX mainly occurred in caecum and proximal colon (P < 0.01) and to a higher extent than cellulose, which on the other hand, irrespective of antibiotic treatment, was less degraded in the RB groups than in the CEL (P < 0.01). The apparent digestibility of fat and protein in the distal small intestine was lower for RB than CEL (P < 0.05), the protein digestibility remained lower in most of the colon, and the digestibility was not affected by treatment with antibiotics. The colonic concentrations of SCFA, acetate and propionate as well as the butyrate concentration in the distal colon were lower with the RB treatments compared with CEL (P < 0.01). Caecal butyrate concentrations were on the other hand higher, and a significant reduction was seen with antibiotic treatment (P < 0.001). The daily net absorption of SCFA and acetate was lower with RB than with CEL (P < 0.01). In conclusion, RB resulted in different DF degradation processes and SCFA production compared with CEL, whereas antibiotic treatment had marginal effects on the intestinal DF degradation but hampered butyrate production.

Health benefits of whole grain: effects on dietary carbohydrate quality, the gut microbiome, and consequences of processing

Grains are important sources of carbohydrates in global dietary patterns. The majority of these carbohydrates, especially in refined-grain products, are digestible. Most carbohydrate digestion takes place in the small intestine where monosaccharides (predominantly glucose) are absorbed, delivering energy to the body. However, a considerable part of the carbohydrates, especially in whole grains, is indigestible dietary fibers. These impact gut motility and transit and are useful substrates for the gut microbiota affecting its composition and quality. For the most part, the profile of digestible and indigestible carbohydrates and their complexity determine the nutritional quality of carbohydrates. Whole grains are more complex than refined grains and are promoted as part of a healthy and sustainable diet mainly because the contribution of indigestible carbohydrates, and their co-passenger nutrients, is significantly higher. Higher consumption of whole grain is recommended because it is associated with lower incidence of, and mortality from, CVD, type 2 diabetes, and some cancers. This may be due in part to effects on the gut microbiota. Although processing of cereals during milling and food manufacturing is necessary to make them edible, it also offers the opportunity to still further improve the nutritional quality of whole-grain flours and foods made from them. Changing the composition and availability of grain carbohydrates and phytochemicals during processing may positively affect the gut microbiota and improve health.

Nutrient Digestibility of a Vegetarian Diet with or without the Supplementation of Feather Meal and Either Corn Meal, Fermented Rye or Rye and Its Effect on Fecal Quality in Dogs

Cereals with low environmental input like rye and animal by-products which cannot be used for human food like feather meal are receiving growing interest as sustainable feed sources. Thus, eight Beagle dogs were included in a 4 × 4 Latin Square design and received a vegetarian basic diet or the same diets supplemented with hydrolyzed feather meal (2.7%) and either 20.1% of corn meal, 60.4% of fermented rye or 20.1% of rye as is basis (moisture content of the diets about 42%). Compared to other groups the dry matter (DM) content of feces from dogs fed the basic diet was higher (30.0%, p < 0.05), while dogs fed the basic diet + rye had the lowest DM-content (26.5%, p < 0.05). However, the fecal scores were considered to be within an acceptable range (well-formed and firm). Starch digestibility was lower (p < 0.05) for dogs fed the basic diet + corn meal. The dogs showed a high and identical acceptance (scoring of food intake) of the experimental diets. As a comparable quality of feces and a high nutrient digestibility were observed when rye was used in the experimental diets-it can be considered an alternative carbohydrate source in dog foods.

Rye Bread Defects: Analysis of Composition and Further Influence Factors as Determinants of Dry-Baking

For decades, the evaluation of rye milling products have been aimed at detecting raw material defects that are linked to excessive enzyme activity. Those defects were indirectly characterized by the rheological methods of the dough or the final products. However, such methods do not sufficiently reflect the baking properties of all rye flours present on the market. A further problem is the continuing climate change, which affects compound composition in rye. So far, these bread defects can only be corrected by process engineering (e.g., extended dough resting). Therefore, it is necessary to characterize the main determinants of the quality defects prior to the baking process in order to predict baking quality and not waste raw material, energy, and time. In this study, it was found that the water accessibility of starch for gelatinization and its partial inhibition by certain components play a major role in baking quality. Specifically, high amounts of insoluble nonstarch-polysaccharides (NSPSs) and a hindered denaturation of proteins seem to be an indication and reason for poor baking quality. However, traditional quantitative analysis of the ingredients and properties of the rye milling products (e.g., falling number, protein content, amylographic data) does not allow any reliable conclusions about rye flour suitability for use as bread rye. It can be concluded that more complex compositional aspects (e.g., complexation of compounds) need to be characterized for future quality control of rye.

Capitalizing on a double crop: Recent advances in proso millet's transition to a food crop

Across the globe, strategies to adapt food production to a changing climate as well as to unforeseen events (such as a pandemic) are needed, for example, if farmers miss planting times due to abnormal weather patterns or harvests are lost. Such food security considerations represent reasons for why proso millet deserves a more prominent place at the table. It has one of the shortest growing seasons and water requirements among cereals and is already grown in rotation with other crops, for example, in the American Midwest. Yet, most consumers in the Western world are unfamiliar with it, which limits its market potential. Introducing proso millet to consumers requires development of products with acceptable textural and sensory attributes as well as convincing selling points. These can be found in its nutritional profile, as it is a gluten-free "ancient" grain and millet-based products frequently have low glycemic indices. This review presents a synthesis of recent studies that utilized processing strategies to advance proso millet functionality. Results are put into the context of the most frequently addressed compositional and functional attributes, organized in clusters. Diversity across varieties in amylose to amylopectin ratios presents an opportunity to utilize proso millet for foods with specific pasting requirements, as in bread versus pasta. Hydrothermal or pressure treatments may further adapt its functionality for baked goods. Bitterness remains an unsolved issue, even when decorticated material is used. In addition, heating dramatically lowers in vitro protein digestibility, whereas starch digestibility appears to be matrix dependent (more than raw material dependent).

Faecal Microbiota of Dogs Offered a Vegetarian Diet with or without the Supplementation of Feather Meal and either Cornmeal, Rye or Fermented Rye: A Preliminary Study

Anthropomorphism of dogs has affected feeding and the choice of components present in diets for dogs. Conflicting trends are present: raw or vegetarian appear more prevalent. Animal-derived proteins seem to have unfavourable impacts on intestinal microflora by decreasing the presence of Bacteroidetes. This preliminary study evaluates whether effects of diets with animal proteins on intestinal microbiota can be compensated by the addition of certain carbohydrates to dog diet. Eight female beagles were included in a cross-over study and fed a vegetarian diet or the same diet supplemented with feather meal (2.7%) and either 20% of cornmeal, fermented or non-fermented rye (moisture content of the diets about 42%). A 16S rRNA gene amplification was performed within the hypervariable region V4 on faecal samples and sequenced with the Illumina MiSeq platform. The Firmicutes/Bacteroidetes ratio tended to shift to the advantage of Firmicutes when feather meal and cornmeal were added (Firmicutes/Bacteroidetes ratio of 5.12 compared to 2.47 when offered the vegetarian diet) and tended to switch back to the advantage of Bacteroidetes if rye: fermented (2.17) or not (1.03) was added. The addition of rye might have the potential to compensate possible unfavourable effects of diets with animal proteins on intestinal microbiota of dogs.

Structural characteristics and rheological properties of alkali-extracted arabinoxylan from dehulled barley kernel

Arabinoxylan (BIF-60) was isolated from barley water-insoluble fiber (BIF) by ethanol precipitation at 60 % (v/v). BIF-60 was composed of xylose (48.5 %) and arabinose (30.3 %). Its average molecular weight was 1360 kDa. Methylation and 1D/2D NMR analysis showed that BIF-60 possessed β-(l→4)-xylan as backbone, comprised of un-substituted (1,4-linked β-Xylp, 56.9 %), mono-substituted (1,2,4-linked and 1,3,4-linked β-Xylp, 22.1 %) and di-substituted (1,2,3,4-lin4ked β-Xylp, 18.4 %) xylose units, as well as other residues (T-Araf-(1→, T-Xylp-(1→, →5)-Araf-(1→, →2)-Araf-(1→, →3)-Araf-(1→ and →4)-Glcp-(1→). BIF-60 exhibited shear-thinning behaviour, low gel stability and weak gelling ability at high concentrations. This work provides a theoretical and experimental basis for molecular structure and properties of the alkali-extracted arabinoxylan from barley kernel, which could guide further functional research and application of barley-derived arabinoxylan.

Nørskov N, Knudsen KEB, Hedemann MS, Lærke HN. Effects of dietary fibre and protein content on intestinal fibre degradation, short-chain fatty acid and microbiota composition in a high-fat fructose-rich diet induced obese Göttingen Minipig model

An AX-enriched high DF diet improved the intestinal environment and attenuated protein fermentation, while protein did not show prebiotic effects.

Fermentation characteristics of resistant starch, arabinoxylan, and β-glucan and their effects on the gut microbial ecology of pigs: A review

Dietary fibers (DF) contain an abundant amount of energy, although the mammalian genome does not encode most of the enzymes required to degrade them. However, a mutual dependence is developed between the host and symbiotic microbes, which has the potential to extract the energy present in these DF. Dietary fibers escape digestion in the foregut and are fermented in the hindgut, producing short-chain fatty acids (SCFA) that alter the microbial ecology in the gastrointestinal tract (GIT) of pigs. Most of the carbohydrates are fermented in the proximal part, allowing protein fermentation in the distal part, resulting in colonic diseases. The structures of resistant starch (RS), arabinoxylan (AX), and β-glucan (βG) are complex; hence, makes their way into the hindgut where these are fermented and provide energy substrates for the colonic epithelial cells. Different microbes have different preferences of binding to different substrates. The RS, AX and βG act as a unique substrate for the microbes and modify the relative composition of the gut microbial community. The granule dimension and surface area of each substrate are different, which influences the penetration capacity of microbes. Arabinose and xylan are 2 different hemicelluloses, but arabinose is substituted on the xylan backbone and occurs in the form of AX. Fermentation of xylan produces butyrate primarily in the small intestine, whereas arabinose produces butyrate in the large intestine. Types of RS and forms of βG also exert beneficial effects by producing different metabolites and modulating the intestinal microbiota. Therefore, it is important to have information of different types of RS, AX and βG and their roles in microbial modulation to get the optimum benefits of fiber fermentation in the gut. This review provides relevant information on the similarities and differences that exist in the way RS, AX, and βG are fermented, and their positive and negative effects on SCFA production and gut microbial ecology of pigs. These insights will help nutritionists to develop dietary strategies that can modulate specific SCFA production and promote beneficial microbiota in the GIT of swine.

Evaluation of arabinoxylan isolated from sorghum bran, biomass, and bagasse for film formation

Arabinoxylans (AX) are potential agricultural co-products for material applications. Sorghum has seen increased production as a bioenergy crop for biofuel and co-product generation. AX from three sorghum fractions (bran, bagasse, and biomass) were isolated to study film formation. All three AX fractions exhibited high moisture sensitivity. Sorghum biomass AX produced low water vapor permeability compared to sorghum bran or sorghum bagasse AX films. Glycerol addition to sorghum bran AX films reduced tensile strength from 34.8 to 16.0 MPa at 0% and 10% (w/w) glycerol, respectively; reduced the storage and loss moduli during dynamic mechanical analyses at 50% relative humidity (RH) and decreased the rubber-to-plastic material transition temperature at 50% RH, from 78.1 °C to 38.4 °C at 0 and 10% (w/w) glycerol, respectively. Sorghum bran AX, while sensitive to water absorption at high RH, produced favorable strength performance compared to AX from other cereal grains indicating potential utilization as a renewable material.

Impact of Diet-Modulated Butyrate Production on Intestinal Barrier Function and Inflammation

A major challenge in affluent societies is the increase in disorders related to gut and metabolic health. Chronic over nutrition by unhealthy foods high in energy, fat, and sugar, and low in dietary fibre is a key environmental factor responsible for this development, which may cause local and systemic inflammation. A low intake of dietary fibre is a limiting factor for maintaining a viable and diverse microbiota and production of short-chain fatty acids in the gut. A suppressed production of butyrate is crucial, as this short-chain fatty acid (SCFA) can play a key role not only in colonic health and function but also at the systemic level. At both sites, the mode of action is through mediation of signalling pathways involving nuclear NF-κB and inhibition of histone deacetylase. The intake and composition of dietary fibre modulate production of butyrate in the large intestine. While butyrate production is easily adjustable it is more variable how it influences gut barrier function and inflammatory markers in the gut and periphery. The effect of butyrate seems generally to be more consistent and positive on inflammatory markers related to the gut than on inflammatory markers in the peripheral tissue. This discrepancy may be explained by differences in butyrate concentrations in the gut compared with the much lower concentration at more remote sites.

Mechanisms of utilisation of arabinoxylans by a porcine faecal inoculum: competition and co-operation

Recent studies show that a single or small number of intestinal microbes can completely degrade complex carbohydrates. This suggests a drive towards competitive utilisation of dietary complex carbohydrates resulting in limited microbial diversity, at odds with the health benefits associated with a diverse microbiome. This study investigates the enzymatic metabolism of wheat and rye arabinoxylans (AX) using in vitro fermentation, with a porcine faecal inoculum. Through studying the activity of AX-degrading enzymes and the structural changes of residual AX during fermentation, we show that the AX-degrading enzymes are mainly cell-associated, which enables the microbes to utilise the AX competitively. However, potential for cross-feeding is also demonstrated to occur by two distinct mechanisms: (1) release of AX after partial degradation by cell-associated enzymes, and (2) release of enzymes during biomass turnover, indicative of co-operative AX degradation. This study provides a model for the combined competitive-co-operative utilisation of complex dietary carbohydrates by gut microorganisms.

Amino acid digestibility of different rye genotypes in caecectomised laying hens

This study investigated the variability of amino acid (AA) digestibility of rye grains in laying hens. Relationships between AA digestibility and physical properties (thousand seed weight, test weight, falling number, and extract viscoelasticity), chemical composition (proximate nutrients, non-starch polysaccharides, AA, minerals, and inositol phosphates), gross energy concentration, and in vitro solubility of nitrogen (N) of the grains were also examined. Twenty rye genotypes were grown under standardised agronomic and environmental conditions as part of a collaborative research project known as "GrainUp". Each genotype was added to a basal diet at 500 g/kg at the expense of maize starch to produce 20 rye diets. The experimental design comprised four Latin Squares (6 × 6) distributed over two runs, resulting in 12 experimental periods. Caecectomised laying hens (LSL-Classic) were individually kept in metabolism cages. Excreta were collected quantitatively for 4 d, and AA digestibility of the rye genotypes was determined using a regression approach. The digestibility of AA was generally low but varied significantly among the 20 rye genotypes, especially for Lys (digestibility range 35-59%), Met (57-75%), Thr (34-54%), and Trp (36-71%). Nevertheless, physical and chemical characteristics as well as the in vitro solubility of N correlated in only a few cases with AA digestibility. Multiple linear regression was used to calculate equations to predict AA digestibility based on the analysed characteristics. However, their explanatory power, as judged by the adjusted R(2), was not sufficiently precise for practical application (below 0.6 for most AA). In conclusion, the AA digestibility of rye grain is generally low and varies significantly between crop genotypes. Equations based on its physical and chemical characteristics are not sufficiently precise to be useful for feed formulation.

Effect of xylanases on ileal viscosity, intestinal fiber modification, and apparent ileal fiber and nutrient digestibility of rye and wheat in growing pigs

Two experiments were performed to study the effect of xylanase on ileal extract viscosity, in vivo fiber solubilization and degradation, and apparent ileal digestibility (AID) of fiber constituents, OM, CP, starch, and crude fat in rye and wheat in ileal-cannulated pigs. In Exp. 1, coarse rye without (NX) or with addition of xylanase from Aspergillus niger (AN), (BS), or (TR) was fed to 8 ileal-cannulated barrows (initial BW 30.9 ± 0.3 kg) for 1 wk each according to a double 4 × 4 Latin square design. In Exp. 2, fine rye, fine wheat, and coarse wheat with or without a combination of xylanase from and were fed to 6 ileal-cannulated barrows (initial BW 33.6 ± 0.5 kg) for 1 wk according to a 6 × 6 Latin square design with a 2 × 3 factorial arrangement of enzyme and cereal matrix. Chromic oxide (0.2%) was used as an inert marker. Ileal effluent was collected for 8 h on d 5 and 7 and pooled for analysis. In Exp. 1, TR reduced intestinal viscosity of pigs fed rye from 9.3 mPa·s in the control diet (NX) to 6.0 mPa·s ( < 0.001), whereas AN and BS had no effect. None of the enzymes changed the concentration of total arabinoxylan, high-molecular-weight arabinoxylan (HMW-AX), or arabinoxylan oligosaccharides (AXOS) in the liquid phase of digesta. In Exp. 2, the enzyme combination reduced intestinal viscosity for all 3 cereal matrices ( < 0.05), but the viscosity was much higher with fine rye (7.6 mPa·s) than with fine and coarse wheat (<1.7 mPa·s). Simultaneously, the total concentration of arabinoxylan in the liquid phase of digesta increased by 82.4% in fine wheat ( < 0.002) and by 45.9% in coarse wheat ( < 0.006), and AXOS increased 16-fold with enzyme addition. Similar effects of enzyme were not seen with rye. The concentration of xylooligosaccharides in the liquid phase of digesta increased with enzyme addition, but for xylose, it was only significant for wheat, for which it increased 3.9-fold ( < 0.001). None of the xylanases affected AID of arabinoxylan of rye in Exp. 1. In Exp. 2, the enzyme combination increased AID of arabinoxylan by 91% to 107% ( < 0.001) across cereal matrices. Enzyme addition did not affect AID of nutrients in any of the experiments except for a higher starch and crude fat digestibility of fine wheat with enzyme addition ( < 0.012) in Exp. 2. Collectively, the results suggest that xylanase is more efficient in degrading arabinoxylan from wheat than from rye.

A search for synbiotics: effects of enzymatically modified arabinoxylan and Butyrivibrio fibrisolvens on short-chain fatty acids in the cecum content and plasma of rats

Identification of dietary strategies to increase large intestinal production and absorption of short-chain fatty acids (SCFAs), especially butyrate, is of great interest due to the possible health promoting effects.

Effects of Resistant Starch and Arabinoxylan on Parameters Related to Large Intestinal and Metabolic Health in Pigs Fed Fat-Rich Diets

This study compared the effects of a resistant starch (RS)-rich, arabinoxylan (AX)-rich, or low-DF Western-style control diet (all high-fat) on large intestinal gene expression, adiposity, and glycemic response parameters in pigs. Animals were slaughtered after 3 weeks of treatment. Plasma butyrate concentration was higher following the high-DF diets, whereas plasma glucose, insulin, and insulin resistance increased after 3 weeks irrespective of diet. The mRNA abundance in the large intestine of genes involved in nutrient transport, immune response, and intestinal permeability was affected by segment (cecum, proximal, mid or distal colon) and some genes also by diet. In contrast, there was no diet-induced effect on adipose mRNA abundance or adipocyte size. Overall, a high level of RS or AX did not demonstrate strong beneficial effects on large intestinal gene expression as indicators of colonic health or glycemic response parameters when included in a high-fat diet for pigs as a model of healthy humans.

Diets high in resistant starch and arabinoxylan modulate digestion processes and SCFA pool size in the large intestine and faecal microbial composition in pigs

The effects of a high level of dietary fibre (DF) either as arabinoxylan (AX) or resistant starch (RS) on digestion processes, SCFA concentration and pool size in various intestinal segments and on the microbial composition in the faeces were studied in a model experiment with pigs. A total of thirty female pigs (body weight 63.1 (sem 4.4) kg) were fed a low-DF, high-fat Western-style control diet (WSD), an AX-rich diet (AXD) or a RS-rich diet (RSD) for 3 weeks. Diet significantly affected the digestibility of DM, protein, fat, NSP and NSP components, and the arabinose:xylose ratio, as well as the disappearance of NSP and AX in the large intestine. RS was mainly digested in the caecum. AX was digested at a slower rate than RS. The digesta from AXD-fed pigs passed from the ileum to the distal colon more than twice as fast as those from WSD-fed pigs, with those from RSD-fed pigs being intermediate (P< 0.001). AXD feeding resulted in a higher number of Faecalibacterium prausnitzii, Roseburia intestinalis, Blautia coccoides-Eubacterium rectale, Bifidobacterium spp. and Lactobacillus spp. in the faeces sampled at week 3 of the experimental period (P< 0.05). In the caecum, proximal and mid colon, AXD feeding resulted in a 3- to 5-fold higher pool size of butyrate compared with WSD feeding, with the RSD being intermediate (P <0.001). In conclusion, the RSD and AXD differently affected digestion processes compared with the WSD, and the AXD most efficiently shifted the microbial composition towards butyrogenic species in the faeces and increased the large-intestinal butyrate pool size.

A metabolomics approach used to profile plasma from portal-arterial pigs revealed differences between breads incurred by dietary fibre and protein contents

A liquid chromatography-MS (LC-MS) metabolomics analysis of plasma from portal-arterial catheterised pigs fed breads prepared with whole-grain rye or wheat flour with added concentrated arabinoxylan (AX) or β-glucan (BG) was conducted. Comparison of the effects of concentrated fibres with whole grains has received little attention. Six female catheterised pigs were given two white wheat breads with wheat AX or oat BG, two rye breads with ground rye (GR) or intact rye kernels (RK), and a control white wheat bread (WF) on separate occasions in a randomised cross-over design. The amount of available carbohydrate was similar for the five breads but varied in the content of protein. Plasma was collected continuously for 4 h after feeding. Glucose levels in the portal vein were reduced postprandially in response to the AX, GR and RK breads that had high contents of AX compared with WF bread (P < 0·03). AX and RK breads further tended to decrease plasma levels of some lysophosphatidylcholine species (P ≤ 0·10). The abundance of amino acids in plasma correlated with the protein contents in the breads and leucine uptake significantly affected insulin secretion in the mesenteric artery. In conclusion, the present study revealed that concentrated AX in wheat bread had similar positive effects as whole-grain rye bread on glucose and lipid metabolism.

Enzymatic polishing of cereal grains for improved nutrient retainment

Consumer acceptance of food products is largely driven by the dietary and functional quality of their ingredients. Though whole cereal grains are well known for bioactive components, scientists are facing dire need for better technologies to prevent the nutritional losses incurred through the conventional food processing technologies. Application of enzyme for depolymerisation of carbohydrates present in bran layer of grain is becoming an efficient method for phenolic mobilization and dietary fiber solubilisation. The present article emphasizes deep insights about the application of enzyme as an alternative technology for cereal grain processing to improve the product quality while forbidding the nutritional losses in an eco-friendly manner.

Concentrated arabinoxylan but not concentrated β-glucan in wheat bread has similar effects on postprandial insulin as whole-grain rye in porto-arterial catheterized pigs

The acute glycemic effects of concentrated dietary fibers (DF) versus whole-grain rye were studied in porto-arterial catheterized pigs. Two white wheat breads with wheat arabinoxylan (AX) or oat β-glucan (BG), two rye breads with intact rye kernels (RK) or milled rye (GR), and a low DF white wheat bread were fed to six pigs in a randomized crossover design. Blood profiles were collected for 4 h after feeding. Glucose absorption was reduced in pigs fed the AX bread at 60 min postprandial (3.1 mmol/min for AX compared to 9.4 mmol/min for WF, P = 0.02) and insulin secretion was lowered at 30 min postprandial for AX and GR (74.4 and 129 pmol/min for AX and GR, respectively, compared to 738 pmol/min for WF, P < 0.04). In conclusion, the GR and AX breads were most effective in improving insulin economy, suggesting that arabinoxylan from wheat and rye induces similar outcomes in the metabolic response.

Changes in molecular characteristics of cereal carbohydrates after processing and digestion

Different extraction, purification and digestion methods were used to investigate the molecular properties of carbohydrates in arabinoxylan and β-glucan concentrates, dietary fiber (DF) rich breads and ileum content of bread fed pigs. The breads studied were: a low DF wheat bread (WF), whole meal rye bread (GR), rye bread with kernels (RK), wheat bread supplemented with wheat arabinoxylan concentrate (AX) and wheat bread supplemented with oat β-glucan concentrate (BG). The weight average molecular weight (M(w)) of extractable carbohydrates in β-glucan concentrate decreased eight-fold after inclusion in the BG bread when exposed to in vitro digestion, while the M(w) of purified extractable carbohydrates in AX bread was reduced two-fold, and remained almost unaffected until reaching the terminal ileum of pigs. Similarly, the M(w) of purified extractable carbohydrates in GR and RK bread was not significantly changed in the ileum. The AX bread resulted in the highest concentration of dissolved arabinoxylan in the ileum among all the breads that caused a substantial increased in ileal AX viscosity. Nevertheless, for none of the breads, the M(w) of extractable carbohydrates was related neither to the bread extract nor ileal viscosity.

Formation of phenolic microbial metabolites and short-chain fatty acids from rye, wheat, and oat bran and their fractions in the metabolical in vitro colon model

Rye bran and aleurone, wheat bran and aleurone, and oat bran and cell wall concentrate were compared in their in vitro gut fermentation patterns of individual phenolic acids and short-chain fatty acids, preceded by enzymatic in vitro digestion mimicking small intestinal events. The formation of phenolic metabolites was the most pronounced from the wheat aleurone fraction. Phenylpropionic acids, presumably derived from ferulic acid (FA), were the major phenyl metabolites formed from all bran preparations. The processed rye, wheat, and oat bran fractions contained more water-extractable dietary fiber (DF) and had smaller particle sizes and were thus more easily fermentable than the corresponding brans. Rye aleurone and bran had the highest fermentation rate and extent probably due to high fructan and water-extractable arabinoxylan content. Oat samples also had a high content of water-extractable DF, β-glucan, but their fermentation rate was lower. Enzymatic digestion prior to in vitro colon fermentation changed the structure of oat cell walls as visualized by microscopy and increased the particle size, which is suggested to have retarded the fermentability of oat samples. Wheat bran was the most slowly fermentable among the studied samples, presumably due to the high proportion of water-unextractable DF. The in vitro digestion reduced the fructan content of wheat samples, thus also decreasing their fermentability. Among the studied short-chain fatty acids, acetate dominated the profiles. The highest and lowest production of propionate was from the oat and wheat samples, respectively. Interestingly, wheat aleurone generated similar amounts of butyrate as the rye fractions even without rapid gas production.

Characterization of Xyn30A and Axh43A of Bacillus licheniformis SVD1 identified by its genomic analysis

The genome sequence of Bacillus licheniformis SVD1, that produces a cellulolytic and hemi-cellulolytic multienzyme complex, was partially determined, indicating that the glycoside hydrolase system of this strain is highly similar to that of B. licheniformis ATCC14580. All of the fifty-six genes encoding glycoside hydrolases identified in B. licheniformis ATCC14580 were conserved in strain SVD1. In addition, two new genes, xyn30A and axh43A, were identified in the B. licheniformis SVD1 genome. The xyn30A gene was highly similar to Bacillus subtilis subsp. subtilis 168 xynC encoding for a glucuronoarabinoxylan endo-1,4-β-xylanase. Xyn30A, produced by a recombinant Escherichia coli, had high activity toward 4-O-methyl-D-glucurono-D-xylan but showed definite activity toward oat-spelt xylan and unsubstituted xylooligosaccharides. Recombinant Axh43A, consisting of a family-43 catalytic module of the glycoside hydrolases and a family-6 carbohydrate-binding module (CBM), was an arabinoxylan arabinofuranohydrolase (α-L-arabinofuranosidase) classified as AXH-m23 and capable of releasing arabinosyl residues, which are linked to the C-2 or C-3 position of singly substituted xylose residues in arabinoxylan or arabinoxylan oligomers. The isolated CBM polypeptide had an affinity for soluble and insoluble xylans and removal of the CBM from Axh43A abolished the catalytic activity of the enzyme, indicating that the CBM plays an essential role in hydrolysis of arabinoxylan.