Effect of proximity to a cattle feedlot on Escherichia coli O157:H7 contamination of leafy greens and evaluation of the potential for airborne transmission

Aggregative Swab Sampling Method for Romaine Lettuce Show Similar Quality and Safety Indicators and Microbial Profiles Compared to Composite Produce Leaf Samples in a Pilot Study

Composite produce leaf samples from commercial production rarely test positive for pathogens, potentially due to low pathogen prevalence or the relatively small number of plants sampled. Aggregative sampling may offer a more representative alternative. This pilot study investigated whether aggregative swab samples performed similarly to produce leaf samples in their ability to recover quality indicators (APCs and coliforms), detect Escherichia coli, and recover representative microbial profiles. Aggregative swabs of the outer leaves of romaine plants (n = 12) and composite samples consisting of various grabs of produce leaves (n = 14) were collected from 60 by 28 ft sections of a one-acre commercial romaine lettuce field. Aerobic plate counts were 9.17 ± 0.43 and 9.21 ± 0.42 log(CFU/g) for produce leaf samples and swabs, respectively. Means and variance were not significantly different (p = 0.38 and p = 0.92, respectively). Coliform recoveries were 3.80 ± 0.76 and 4.19 ± 1.15 log(CFU/g) for produce leaf and swabs, respectively. Means and variances were not significantly different (p = 0.30 and p = 0.16, respectively). Swabs detected generic E. coli in 8 of 12 samples, more often than produce leaf samples (3 of 14 positive, Fisher's p = 0.045). Full-length 16S rRNA microbial profiling revealed that swab and produce leaf samples did not show significantly different alpha diversities (p = 0.75) and had many of the most prevalent bacterial taxa in common and in similar abundances. These data suggest that aggregative swabs perform similarly to, if not better than, produce leaf samples in recovering indicators of quality (aerobic and coliform bacteria) and food safety (E. coli), justifying further method development and validation.

Inactivation of Desiccation-Resistant Salmonella on Apple Slices Following Treatment with ε-Polylysine, Sodium Bisulfate, or Peracetic Acid and Subsequent Dehydration

Salmonella is capable of surviving dehydration within various foods, such as dried fruit. Dried fruit, including apple slices, have been the subject of product recalls due to contamination with Salmonella. A study was conducted to determine the fate of Salmonella on apple slices, following immersion in three antimicrobial solutions (viz., ε-polylysine [epsilon-polylysine or EP], sodium bisulfate [SBS], or peracetic acid [PAA]), and subsequent hot air dehydration. Gala apples were aseptically cored and sliced into 0.4 cm thick rings, bisected, and inoculated with a five-strain composite of desiccation-resistant Salmonella, to a population of 8.28 log CFU/slice. Slices were then immersed for 2 min in various concentrations of antimicrobial solutions, including EP (0.005, 0.02, 0.05, and 0.1%), SBS (0.05, 0.1, 0.2, and 0.3%), PAA (18 or 42 ppm), or varying concentrations of PAA + EP, and then dehydrated at 60°C for 5 h. Salmonella populations in positive control samples (inoculated apple slices washed in sterile water) declined by 2.64 log after drying. In the present study, the inactivation of Salmonella, following EP and SBS treatments, increased with increasing concentrations, with maximum reductions of 3.87 and 6.20 log (with 0.1 and 0.3% of the two compounds, respectively). Based on preliminary studies, EP concentrations greater than 0.1% did not result in lower populations of Salmonella. Pretreatment washes with either 18 or 42 ppm of PAA inactivated Salmonella populations by 4.62 and 5.63 log, respectively, following desiccation. Combining PAA with up to 0.1% EP induced no greater population reductions of Salmonella than washing with PAA alone. The addition of EP to PAA solutions appeared to destabilize PAA concentrations, reducing its biocidal efficacy. These results may provide antimicrobial predrying treatment alternatives to promote the reduction of Salmonella during commercial or consumer hot air drying of apple slices.

Comparison of Three Air Sampling Methods for the Quantification of Salmonella, Shiga-toxigenic Escherichia coli (STEC), Coliforms, and Generic E. coli from Bioaerosols of Cattle and Poultry Farms

Recent fresh produce outbreaks potentially associated with bioaerosol contamination from animal operations in adjacent land highlighted the need for further study to better understand the associated risk. The purpose of this research was to evaluate three sampling methods for quantifying target bacterial bioaerosols from animal operations. A dairy cattle and poultry farm located in Georgia, U.S. were visited six times each. Air was collected for 10 min using: 2-stage Andersen impactor with and without mineral oil overlay and impingement samplers. Sampling devices were run concurrently at 0.1, 1, and 2 m heights (n = 36). Andersen samplers were loaded with CHROMagar™ Salmonella, CHROMagar™ STEC, or Brilliance™ coliforms/E. coli. The impingement sampler contained buffered peptone water (20 mL) which was vacuum filtered through a 0.45 µm filter and placed onto the respective media. Plates were incubated at 37 ℃ for 48 h. PCR confirmation followed targeting ttr for Salmonella and stx1, stx2, and eae genes for STEC. No significant differences were found among methods to quantify coliforms and E. coli. Salmonella and STEC bioaerosols were not detected by any of the methods (Limit of detection: 0.55 log CFU/m3). E. coli bioaerosols were significantly greater in the poultry (2.76-5.00 log CFU/m3) than in the cattle farm (0.55-2.82 log CFU/m3) (p < 0.05), and similarly distributed at both stages in the Andersen sampler (stage 1:>7 μm; stage 2: 0.65-7 μm particle size). Sampling day did not have a significant effect on the recovery of coliforms/E. coli bioaerosols in the poultry farm when samples were taken at the broiler house exhaust fan (p > 0.05). A greater and constant emission of coliforms and E. coli bioaerosols from the poultry farm warrants further investigation. These data will help inform bioaerosol sampling techniques which can be used for the quantification of bacterial foodborne pathogens and indicator organisms for future research.

From wheat grain to flour: a review of potential sources of enteric pathogen contamination in wheat milled products

The number of food safety issues linked to wheat milled products have increased in the past decade. These incidents were mainly caused by the contamination of wheat-based products by enteric pathogens. This manuscript is the first of a two-part review on the status of the food safety of wheat-based products. This manuscript focused on reviewing the available information on the potential pre-harvest and post-harvest sources of microbial contamination, and potential foodborne pathogens present in wheat-based products. Potential pre-harvest sources of microbial contamination in wheat included animal activity, water, soil, and manure. Improper grain storage practices, pest activity, and improperly cleaned and sanitized equipment are potential sources of post-harvest microbial contamination for wheat-based foods. Raw wheat flour products and flour-based products are potentially contaminated with enteric pathogens such as Shiga toxin-producing E. coli (STECs), and Salmonella at low concentrations. Wheat grains and their derived products (i.e., flours) are potential vehicles for foodborne illness in humans due to the presence of enteric pathogens. A more holistic approach is needed for assuring the food safety of wheat-based products in the farm-to-table continuum. Future developments in the wheat supply chain should also be aimed at addressing this emerging food safety threat.

Minimum Concentrations of Slow Pyrolysis Paper and Walnut Hull Cyclone Biochars Needed to Inactivate Escherichia coli O157:H7 in Soil

Antimicrobial properties of biochar have been attributed to its ability to inactivate foodborne pathogens in soil, to varying degrees. High concentrations of biochar have reduced E. coli O157:H7 in soil and dairy manure compost, based on alkaline pH. Preliminary studies evaluating 31 different biochars determined that two slow pyrolysis biochars (paper biochar and walnut hull cyclone biochar) were the most effective at inactivating E. coli in soil. A study was conducted to determine the lowest percentages of paper and walnut hull cyclone biochars needed to reduce E. coli O157:H7 in soil. A model soil was adjusted to 17.75% moisture, and the two types of biochar were added at concentrations of 1.0, 1.5, 2.0, 2.5, 3.5, 4.5, 5.5, and 6.5%. Nontoxigenic E. coli O157:H7 were inoculated into soil at 6.84 log CFU/g and stored for up to 6 weeks at 21°C. Mean E. coli O157:H7 counts were 6.01-6.86 log CFU/g at all weeks between 1 and 6 in soil-only positive control samples. Populations in all soil amended with 1.0 and 1.5% of either type of biochar (as well as 2.0% of the walnut hull biochar) resulted in ≤0.68 log reductions at week 6, when compared with positive controls. All other concentrations (i.e., ≥2.0% paper and ≥2.5% walnut hull) inactivated ≥2.7 log at all weeks between 1 and 6 (p < 0.05). At the end of 6 weeks, E. coli O157:H7 declined by 2.84 log in 2.0% paper biochar samples, while concentrations of between 2.5 and 6.5% paper biochar completely inactivated E. coli O157:H7, as determined by spiral plating, at weeks 5 and 6. In contrast, 2.0% walnut hull biochar lowered populations by only 0.38 log at week 6, although 2.5-6.5% concentrations of walnut hull biochar resulted in complete inactivation at all weeks between 3 and 6, as assessed by spiral plating. In summary, ≥2.5% paper or walnut hull biochar reduced ≥5.0 log of E. coli O157:H7 during the 6-week storage period, which we attribute to high soil alkalinity. Amended at a 2.5% concentration, the pH of soil with paper or walnut hull biochar was 10.67 and 10.06, respectively. Results from this study may assist growers in the use of alkaline biochar for inactivating E. coli O157:H7 in soil.

Oversampling methods for machine learning model data training to improve model capabilities to predict the presence of Escherichia coli MG1655 in spinach wash water

We assessed the efficacy of oversampling techniques to enhance machine learning model performance in predicting Escherichia coli MG1655 presence in spinach wash water. Three oversampling methods were applied to balance two datasets, forming the basis for training random forest (RF), support vector machines (SVMs), and binomial logistic regression (BLR) models. Data underwent method-specific centering and standardization, with outliers replaced by feature-specific means in training datasets. Testing occurred without these preprocessing steps. Model hyperparameters were optimized using a subset of testing data via 10-fold cross-validation. Models were trained on full datasets and tested on newly acquired spinach wash water samples. Synthetic Minority Oversampling Technique (SMOTE) and Adaptive Synthetic Sampling approach (ADASYN) achieved strong results, with SMOTE RF reaching an accuracy of 90.0%, sensitivity of 93.8%, specificity of 87.5%, and an area under the curve (AUC) of 98.2% (without data preprocessing) and ADASYN achieving 86.55% accuracy, 87.5% sensitivity, 83.3% specificity, and a 92.4% AUC. SMOTE and ADASYN significantly improved (p < 0.05) SVM and RF models, compared to their non-oversampled counterparts without preprocessing. Data preprocessing had a mixed impact, improving (p < 0.05) the accuracy and specificity of the BLR model but decreasing the accuracy and specificity (p < 0.05) of the SVM and RF models. The most influential physiochemical feature for E. coli detection in wash water was water conductivity, ranging from 7.9 to 196.2 µS. Following closely was water turbidity, ranging from 2.97 to 72.35 NTU within this study.

Bacterial composition of refrigerators in households and inactivation of airborne Staphylococcus aureus using a TiO2-UVLED module in a 512 L aerobiology chamber

This study aimed to investigate the microbiota in the air and on the surface of a refrigerator and to inactivate aerosolized Staphylococcus aureus using a TiO₂-UVLED module. A total of 100 L of the air and 5000 cm² surfaces in seven household refrigerators were collected using an air sampler and a swab, respectively. Samples were subjected to microbiota analysis as well as quantitative analyses of aerobic or anaerobic bacteria. The level of airborne aerobic bacteria was 4.26 log CFU/vol (100 L), while that of surface aerobic bacteria was 5.27 log CFU/surface (5000 cm²). PCoA based on the Bray-Curtis metric revealed that the bacterial composition differed between samples collected from refrigerators with and without a vegetable drawer. Moreover, pathogenic bacteria containing genera and order from each sample were found, such as Enterobacaterales, Pseudomonas, Staphylococcus, Listeria, and Bacillus. Among them, Staphylococcus aureus was determined to be a core hazardous pathogen in air. Therefore, three S. aureus strains isolated from the air in refrigerators, as well as a reference strain of S. aureus (ATCC 6538P), were inactivated by a TiO₂-UVLED module in a 512 L aerobiology chamber. All aerosolized S. aureus were reduced over 1.6 log CFU/vol after treatment with TiO₂ under UVA (365 nm) light at 40 J/cm². These findings suggest that TiO₂-UVLED modules have the potential to be used to control airborne bacteria in household refrigerators.

Quantitative risk assessment-epidemic curve prediction model for leafy green outbreak investigation

The objective of this study was to leverage quantitative risk assessment to investigate possible root cause(s) of foodborne illness outbreaks related to Shiga toxin-producing Escherichia coli O157:H7 (STEC O157) infections in leafy greens in the United States. To this end, we developed the FDA leafy green quantitative risk assessment epidemic curve prediction model (FDA-LG QRA-EC) that simulated the lettuce supply chain. The model was used to predict the number of reported illnesses and the epidemic curve associated with lettuce contaminated with STEC O157 for a wide range of scenarios representing various contamination conditions and facility processing/sanitation practices. Model predictions were generated for fresh-cut and whole lettuce, quantifying the differing impacts of facility processing and home preparation on predicted illnesses. Our model revealed that the timespan (i.e., number of days with at least one reported illness) and the peak (i.e., day with the most predicted number of reported illnesses) of the epidemic curve of a STEC O157-lettuce outbreak were not strongly influenced by facility processing/sanitation practices and were indications of contamination pattern among incoming lettuce batches received by the facility or distribution center. Through comparisons with observed number of illnesses from recent STEC O157-lettuce outbreaks, the model identified contamination conditions on incoming lettuce heads that could result in an outbreak of similar size, which can be used to narrow down potential root cause hypotheses.

Possible sources of Listeria monocytogenes contamination of fresh-cut apples and antimicrobial interventions during antibrowning treatments: a review

Fresh-cut apples, being rich in antioxidants and other nutrients, have emerged as popular snacks in restaurants, at home and in school lunch programs, partially due to freshness, convenience, and portion size availability. Two major challenges in processing fresh-cut apples are browning of cut surfaces and contamination with human pathogens. Regarding human pathogens, contamination by Listeria monocytogenes is a major concern, as evidenced by two recent outbreaks of whole apples and numerous recalls of fresh-cut apples. Antibrowning agents currently used by the industry have little to no antimicrobial properties. The present review discusses possible origins of L. monocytogenes in fresh-cut apples, including contaminated whole apples, and contamination via the processing environment and the equipment in fresh-cut facilities. Treatment with antibrowning solutions could be an opportunity for Listeria contamination and represents the last chance to inactivate pathogens. The discussion is focused on the antibrowning treatments where formulations and coatings with antibrowning and antimicrobial properties have been developed and evaluated against Listeria and other microorganisms. In addition, several research needs and considerations are discussed to further reduce the chance of pathogen contamination on fresh-cut apples.

Dispersal and risk factors for airborne E. coli in the proximity to beef cattle feedlots

California Leafy Green Products Handler Marketing Agreement (LGMA) established food safety metrics with guidance recommendations of 366 m (1200 feet) and 1609 m (1-mile) distances between production fields of leafy greens and a concentrated animal feeding operation (CAFO) containing >1000 and >80,000 head of cattle, respectively. This study evaluated the effect of these distance metrics and environmental factors on the occurrence of airborneE. coliin proximity to seven commercial beef cattle feedlots located in Imperial Valley, California. A total of 168 air samples were collected from seven beef cattle feedlots during March and April, 2020, which were the month's implicated in the 2018 Yuma Arizona lettuce outbreak of E. coli O157:H7. The distance between air sampling sites and the edge of the feedlot ranged from ∼0 to ∼ 2200 m (∼1.3 mile), with each sample comprised of 1000 liters of processed air taken at a 1.2 m elevation over a 10-minute duration. E. colicolonies were enumerated on CHROMagar ECC selective agar and confirmed with conventional PCR. Meteorological data (air temperature, wind speed, wind direction, relative humidity) was collectedin situ. The prevalence and mean concentration ofE. coliwas 6.55% (11/168) and 0.09 CFU per 1000 L of air, with positive samples limited to within 37 m (120 ft) of the feedlot.Based on logistic regression, the odds of airborne E. coli detection were associated with little to no wind and close proximity to a feedlot. This pilot study found limited dispersal of airborne E. coli in proximity to commercial feedlots in Imperial Valley, with light to no wind and proximity within 37 m of a feedlot significant factors associated airborne E. coli in this produce growing region of California.

Draft Genome Sequences of 110 Shiga Toxin-Producing Escherichia coli Isolates Collected from Bovine Manure Samples in the Southern United States

Shiga toxin-producing Escherichia coli (STEC) bacteria continue to impact the food industry. Environmental sampling of potential sources of contamination is important to aid epidemiologic efforts in tracking foodborne illnesses throughout the United States. Here, the draft genome sequences of 110 STEC isolates from bovine manure collected in Florida and Texas are reported.

Risk factors associated with the prevalence of Shiga-toxin-producing Escherichia coli in manured soils on certified organic farms in four regions of the USA

Introduction

Biological soil amendments of animal origin (BSAAO), including untreated amendments are often used to improve soil fertility and are particularly important in organic agriculture. However, application of untreated manure on cropland can potentially introduce foodborne pathogens into the soil and onto produce. Certified organic farms follow the USDA National Organic Program (NOP) standards that stipulate a 90- or 120-day interval between application of untreated manure and crop harvest, depending on whether the edible portion of the crop directly contacts the soil. This time-interval metric is based on environmental factors and does not consider a multitude of factors that might affect the survival of the main pathogens of concern. The objective of this study was to assess predictors for the prevalence of Shiga-toxin-producing Escherichia coli (non-O157 STEC) in soils amended with untreated manure on USDA-NOP certified farms.

Methods

A longitudinal, multi-regional study was conducted on 19 farms in four USA regions for two growing seasons (2017–2018). Untreated manure (cattle, horse, and poultry), soil, and irrigation water samples were collected and enrichment cultured for non-O157 STEC. Mixed effects logistic regression models were used to analyze the predictors of non-O157 STEC in the soil up to 180 days post-manure application.

Results and discussion

Results show that farm management practices (previous use with livestock, presence of animal feces on the field, season of manure application) and soil characteristics (presence of generic E. coli in the soil, soil moisture, sodium) increased the odds of STEC-positive soil samples. Manure application method and snowfall decreased the odds of detecting STEC in the soil. Time-variant predictors (year and sampling day) affected the presence of STEC. This study shows that a single metric, such as the time interval between application of untreated manure and crop harvest, may not be sufficient to reduce the food safety risks from untreated manure, and additional environmental and farm-management practices should also be considered. These findings are of particular importance because they provide multi-regional baseline data relating to current NOP wait-time standards. They can therefore contribute to the development of strategies to reduce pathogen persistence that may contribute to contamination of fresh produce typically eaten raw from NOP-certified farms using untreated manure.

Disease Occurrence in- and the Transferal of Zoonotic Agents by North American Feedlot Cattle

North America is a large producer of beef and contains approximately 12% of the world's cattle inventory. Feedlots are an integral part of modern cattle production in North America, producing a high-quality, wholesome protein food for humans. Cattle, during their final stage, are fed readily digestible high-energy density rations in feedlots. Cattle in feedlots are susceptible to certain zoonotic diseases that impact cattle health, growth performance, and carcass characteristics, as well as human health. Diseases are often transferred amongst pen-mates, but they can also originate from the environment and be spread by vectors or fomites. Pathogen carriage in the gastrointestinal tract of cattle often leads to direct or indirect contamination of foods and the feedlot environment. This leads to the recirculation of these pathogens that have fecal-oral transmission within a feedlot cattle population for an extended time. Salmonella, Shiga toxin-producing Escherichia coli, and Campylobacter are commonly associated with animal-derived foods and can be transferred to humans through several routes such as contact with infected cattle and the consumption of contaminated meat. Brucellosis, anthrax, and leptospirosis, significant but neglected zoonotic diseases with debilitating impacts on human and animal health, are also discussed.

Low to Zero Concentrations of Airborne Bacterial Pathogens and Indicator E. coli in Proximity to Beef Cattle Feedlots in Imperial Valley, California

This study characterized the effect of distance from beef cattle feedlots, environmental factors, and climate on the occurrence of airborne bacterial indicators and pathogens. Three hundred air samples were collected over 6 months from five feedlots, with each air sample comprising 6000 L of air. Air samples were processed onto TSB-enriched air filters, qPCR-screened, and then qPCR-confirmed for suspect positive colonies of E. coli O157, non-O157-Shiga-toxin-producing E. coli (STEC), Salmonella, and E. coli. Direct enumeration of E. coli was also collected. Although no bacterial pathogens were qPCR-confirmed for the 300 samples, E. coli was detected in 16.7% (50/300) of samples, with an overall mean concentration of 0.17 CFU/6000 L air. Logistic regression analyses revealed a higher odds of E. coli for samples in close proximity compared to >610 m (2000 ft) distance from feedlots, along with significant associations with meteorological factors, sampling hour of day, and the presence of a dust-generating activity such as plowing a field or nearby vehicular traffic. The lack of bacterial pathogen detection suggests airborne deposition from nearby feedlots may not be a significant mechanism of leafy green bacterial pathogen contamination; the result of our study provides data to inform future revisions of produce-safety guidance.

Structural Equation Models Suggest That On-Farm Noncrop Vegetation Removal Is Not Associated with Improved Food Safety Outcomes but Is Linked to Impaired Water Quality

While growers have reported pressures to minimize wildlife intrusion into produce fields through noncrop vegetation (NCV) removal, NCV provides key ecosystem services. To model food safety and environmental tradeoffs associated with NCV removal, published and publicly available food safety and water quality data from the Northeastern United States were obtained. Because data on NCV removal are not widely available, forest-wetland cover was used as a proxy, consistent with previous studies. Structural equation models (SEMs) were used to quantify the effect of forest-wetland cover on (i) food safety outcomes (e.g., detecting pathogens in soil) and (ii) water quality (e.g., nutrient levels). Based on the SEMs, NCV was not associated with or had a protective effect on food safety outcomes (more NCV was associated with a reduced likelihood of pathogen detection). The probabilities of detecting Listeria spp. in soil (effect estimate [EE] = -0.17; P = 0.005) and enterohemorrhagic Escherichia coli in stream samples (EE = -0.27; P < 0.001) were negatively associated with the amount of NCV surrounding the sampling site. Larger amounts of NCV were also associated with lower nutrient, salinity, and sediment levels, and higher dissolved oxygen levels. Total phosphorous levels were negatively associated with the amount of NCV in the upstream watershed (EE = -0.27; P < 0.001). Similar negative associations (P < 0.05) were observed for other physicochemical parameters, such as nitrate (EE = -0.38). Our findings suggest that NCV should not be considered an inherent produce safety risk or result in farm audit demerits. This study also provides a framework for evaluating environmental tradeoffs associated with using specific preharvest food safety strategies. IMPORTANCE Currently, on-farm food safety decisions are typically made independently of conservation considerations, often with detrimental impacts on agroecosystems. Comanaging agricultural environments to simultaneously meet conservation and food safety aims is complicated because farms are closely linked to surrounding environments, and management decisions can have unexpected environmental, economic, and food safety consequences. Thus, there is a need for research on the conservation and food safety tradeoffs associated with implementing specific preharvest food safety practices. Understanding these tradeoffs is critical for developing adaptive comanagement strategies and ensuring the short- and long-term safety, sustainability, and profitability of agricultural systems. This study quantifies tradeoffs and synergies between food safety and environmental aims, and outlines a framework for modeling tradeoffs and synergies between management aims that can be used to support future comanagement research.

Two multistate outbreaks of a reoccurring Shiga toxin-producing Escherichia coli strain associated with romaine lettuce: USA, 2018-2019

Leafy green vegetables are a common source of Shiga toxin-producing Escherichia coli O157:H7 (STEC O157) foodborne illness outbreaks. Ruminant animals, primarily cattle, are the major reservoir of STEC O157. Epidemiological, traceback and field investigations were conducted to identify potential outbreak sources. Product and environmental samples were tested for STEC. A reoccurring strain of STEC O157 caused two multistate outbreaks linked to romaine lettuce in 2018 and 2019, resulting in 234 illnesses in 33 states. Over 80% of patients interviewed consumed romaine lettuce before illness. The romaine lettuce was sourced from two California growing regions: Santa Maria and Salinas Valley in 2018 and Salinas Valley in 2019. The outbreak strain was isolated from environmental samples collected at sites >90 miles apart across growing regions, as well as from romaine-containing products in 2019. Although the definitive route of romaine contamination was undetermined, use of a contaminated agricultural water reservoir in 2018 and contamination from cattle grazing on adjacent land in 2019 were suspected as possible factors. Preventing lettuce contamination from growth to consumption is imperative to preventing illness. These outbreaks highlight the need to further understand mechanisms of romaine contamination, including the role of environmental or animal reservoirs for STEC O157.

Survival and Persistence of Foodborne Pathogens in Manure-Amended Soils and Prevalence on Fresh Produce in Certified Organic Farms: A Multi-Regional Baseline Analysis

Biological soil amendments of animal origin (BSAAOs), including untreated (e.g., raw or aged manure, or incompletely composted manure) and treated animal products (e.g., compost), are used for crop production and as part of soil health management. Application of BSAAO's must be done cautiously, as raw manure commonly contains enteric foodborne pathogens that can potentially contaminate edible produce that may be consumed without cooking. USDA National Organic Program (NOP) certified production systems follow the 90-or 120-day interval standards between applications of untreated BSAAOs and crop harvest, depending on whether the edible portions of the crops are in indirect or direct contact with the soil, respectively. This study was conducted to evaluate the survival of four foodborne pathogens in soils amended with BSAAOs and to examine the potential for bacterial transfer to fresh produce harvested from USDA NOP certified organic farms (19) from four states. Only 0.4% (2/527) of produce samples were positive for L. monocytogenes. Among the untreated manure and compost samples, 18.0% (42/233) were positive for at least one of the tested and culturable bacterial foodborne pathogens. The prevalence of non-O157 STEC and Salmonella in untreated manure was substantially &gt; that of E. coli O157:H7 and L. monocytogenes. Of the 2,461 soil samples analyzed in this study, 12.9% (318) were positive for at least one pathogen. In soil amended with untreated manure, the prevalence of non-O157 STEC [7.7% (190) and L. monocytogenes (5.0% (122), was &gt; that of Salmonella (1.1% (26)] or E. coli O157 [0.04% (1)]. Foodborne pathogen prevalence in the soil peaked after manure application and decreased significantly 30 days post-application (dpa). However, non-O157 STEC and L. monocytogenes were recovered from soil samples after 90 and 120 dpa. Results indicate that produce contamination by tested foodborne pathogens was infrequent, but these data should not be generalized outside of the specific wait-time regulations for organic crop production and the farms studied. Moreover, other sources of contamination, e.g., irrigation, wildlife, environmental conditions, cropping and management practices, should be considered. This study also provides multi-regional baseline data relating to current NOP application intervals and development of potential risk mitigation strategies to reduce pathogen persistence in soils amended with BSAAOs. These findings contribute to filling critical data gaps concerning occurrence of fecal pathogens in NOP-certified farming systems used for production of fresh produce in different US regions.

The effect of vegetation barriers at reducing the transmission of Salmonella and Escherichia coli from animal operations to fresh produce

Due to the recent outbreaks of Salmonella and Escherichia coli in fresh produce in the United States, the transfer of foodborne pathogens between animal feeding operations and fresh produce continues to be a considerable risk. The purpose of this study was to determine if the establishment of a vegetation barrier (VB) on small-scale sustainable farms could prevent the transmission of Salmonella and E. coli to nearby fresh produce fields. A 5-layer VB (31 × 49 m) was constructed between a dairy farm, a poultry farm, and a nearby produce field. Fresh produce (i.e., romaine lettuce and tomato), animal feces, and environmental (i.e., air, soil, and barrier) samples were collected for 15 months from 2018 to 2019. Four replicates of soil and fresh produce samples were taken from three plots located 10 m, 61 m, and 122 m away from the respective animal locations and processed for Salmonella and E. coli. Air and vegetative strip samples were sampled at 15-day intervals. Multiple colonies were processed from each positive sample, and a total of 143 positive Salmonella (n = 15) and E. coli (n = 128) isolates were retrieved from the soil, produce, air, and fecal samples. Interestingly, 18.2% of the Salmonella and E. coli isolates (n = 26) were recovered from fresh produce (n = 9) samples. Surprisingly, Salmonella isolates (n = 9) were only found in fecal (n = 3) samples collected from the dairy pasture. Data analysis suggests that the VB is an effective tool at reducing the transmission of E. coli and Salmonella from animal farms to fresh produce fields. However, based on phenotypic and genotypic testing, it is clear that fecal samples from animal farms are not the only source of pathogen contamination. This indicates that the environment (e.g., soil and wind), as well as the initial setup of the farm (e.g., proximity to service roads and produce plot placement), can contribute to the contamination of fresh produce. Our study recommends the need for more effective bioremediation and prevention control measures to use in conjunction with VBs to reduce pathogen transmission.

Prevalence of Salmonella enterica in Flies on a Diversified Cattle and Fresh Produce Farm across Two Growing Seasons

ABSTRACT

Flies are a vector for spreading foodborne pathogens pertinent to fresh produce, such as Shiga toxigenic Escherichia coli and Salmonella; however, most studies focus on concentrated animal feeding operations, which do not reflect low-density animal farming practices that often adjoin fruit and vegetable acreage. In this study, we determined the prevalence of Salmonella in flies collected biweekly on an integrated animal and produce operation over two growing seasons. Eleven of 889 pooled samples tested positive for Salmonella. Flies from the Calliphoridae, Muscidae, Sarcophagidae, and Tachinidae families were associated with Salmonella carriage, but fly family was not a significant factor for isolation of Salmonella (P = 0.303). Fly species were a significant factor (P = 0.026), with five Pentacricia aldrichii pools testing positive for Salmonella. With the exception of single specimen isolation, prevalence ranged from 2.2 to 15.2%. With the exception of the Tachinidae family, these results reflect a strong association of flies that are commonly associated with feces or are pests of animals. Trap location was not significantly associated with isolation of Salmonella-positive flies (P = 0.236). Overall, the population of flies was not as abundant as studies conducted with produce grown close to concentrated animal feeding operations, indicating a reduced risk of transmission; however, similar to these studies, fly families that are commonly isolated from fecal and decaying matter were most frequently associated with Salmonella isolation. Further work is warranted to elucidate the foodborne pathogen transmission rates to produce and subsequent survival over time.

HIGHLIGHTS

Big Data Impacting Dynamic Food Safety Risk Management in the Food Chain

Foodborne pathogens are a major contributor to foodborne illness worldwide. The adaptation of a more quantitative risk-based approach, with metrics such as Food safety Objectives (FSO) and Performance Objectives (PO) necessitates quantitative inputs from all stages of the food value chain. The potential exists for utilization of big data, generated through digital transformational technologies, as inputs to a dynamic risk management concept for food safety microbiology. The industrial revolution in Internet of Things (IoT) will leverage data inputs from precision agriculture, connected factories/logistics, precision healthcare, and precision food safety, to improve the dynamism of microbial risk management. Furthermore, interconnectivity of public health databases, social media, and e-commerce tools as well as technologies such as blockchain will enhance traceability for retrospective and real-time management of foodborne cases. Despite the enormous potential of data volume and velocity, some challenges remain, including data ownership, interoperability, and accessibility. This paper gives insight to the prospective use of big data for dynamic risk management from a microbiological safety perspective in the context of the International Commission on Microbiological Specifications for Foods (ICMSF) conceptual equation, and describes examples of how a dynamic risk management system (DRMS) could be used in real-time to identify hazards and control Shiga toxin-producing Escherichia coli risks related to leafy greens.

AmpC- and Extended-Spectrum β-Lactamase-Producing Enterobacteriaceae Detected in Fresh Produce in Central Ohio

ABSTRACT

Salad vegetables purchased from farmer's markets and grocery stores in central Ohio during the summers of 2015 and 2016 were tested for the presence of Enterobacteriaceae resistant to extended-spectrum cephalosporins and carbapenems, Salmonella contamination, and coliform bacterial counts. A total of 364 samples were collected from 36 farmers' markets and 33 grocery stores. Using selective media, we found 23 (6.3%) samples that produced Enterobacteriaceae expressing an AmpC β-lactamase phenotype, with 11 (3.0%) confirmed to contain blaCMY and 6 (1.6%) that produced Enterobacteriaceae with an extended-spectrum β-lactamase (ESBL) phenotype, 1 (0.3%) of which was confirmed to contain blaCTX-M. All blaCMY and blaCTX-M strains were isolated from leafy greens. No Salmonella spp. or carbapenem-resistant Enterobacteriaceae were recovered from fresh produce samples. Adjusting for year, the geometric mean coliform count differed (P < 0.05) between produce types, with the count in tomatoes (15 CFU/mL) being lower than those in cucumbers (77.4 CFU/mL) and leafy greens (75.0 CFU/mL). The coliform counts also differed (P < 0.05) between years, with 19.6 CFU/mL in 2015 and 96.0 CFU/mL in 2016. There was no difference in coliform counts or the prevalences of Enterobacteriaceae expressing AmpC or ESBL phenotypes in produce purchased from farmers' markets and grocery stores.

HIGHLIGHTS

Multi-Scale Airborne Infectious Disease Transmission

Airborne disease transmission is central to many scientific disciplines including agriculture, veterinary biosafety, medicine, and public health. Legal and regulatory standards are in place to prevent agricultural, nosocomial, and community airborne disease transmission. However, the overall importance of the airborne pathway is underappreciated, e.g.,, US National Library of Medicine's Medical Subjects Headings (MESH) thesaurus lacks an airborne disease transmission indexing term. This has practical consequences as airborne precautions to control epidemic disease spread may not be taken when airborne transmission is important, but unrecognized. Publishing clearer practical methodological guidelines for surveillance studies and disease outbreak evaluations could help address this situation.To inform future work, this paper highlights selected, well-established airborne transmission events - largely cases replicated in multiple, independently conducted scientific studies. Methodologies include field experiments, modeling, epidemiology studies, disease outbreak investigations and mitigation studies. Collectively, this literature demonstrates that airborne viruses, bacteria, and fungal pathogens have the capability to cause disease in plants, animals, and humans over multiple distances - from near range (< 5 m) to continental (> 500 km) in scale. The plausibility and implications of undetected airborne disease transmission are discussed, including the notable underreporting of disease burden for several airborne transmitted diseases.

Microbial and physicochemical assessment of irrigation water treatment methods

AIMS

The presence of foodborne pathogens in preharvest agricultural water has been identified as a potential contamination source in outbreak investigations, driving markets and auditing bodies to begin requiring water treatment for high-risk produce. Therefore, it is essential that we identify water treatment methods which are effective as well as practical in their application on farm.

METHODS AND RESULTS

In this work, we evaluated two sanitizers which are most prominent in preharvest agricultural water treatment (calcium hypochlorite (free chlorine: 3-5 ppm) and peracetic acid (PAA: 5 ppm)), an EPA registered antimicrobial device (ultraviolet light (UV)), in addition to a combination approach (chlorine + UV, PAA + UV). Treatments were evaluated for their ability to inactivate total coliforms and generic Escherichia coli and consistency in treatment efficacy over 1 h of operation. Physicochemical variables were measured along with microbial populations at 0, 5, 15, 30, 45 and 60 min of operation. Escherichia coli and coliform counts showed a significant (P < 0·05) reduction after treatment, with combination and singular treatments equally effective at inactivating E. coli and coliforms. A significant increase (P < 0·05) in oxidation-reduction potential was seen during water treatment (Chlorine; UV + Chlorine), and a significant reduction (P < 0·05) in pH was seen after PAA and PAA + UV treatments (60 min).

CONCLUSION

Overall, the results indicate that all treatments evaluated are equally efficacious for inactivating E. coli and coliforms present in surface agricultural water.

SIGNIFICANCE AND IMPACT OF THE STUDY

This information when paired with challenge studies targeting foodborne pathogens of interest can be used to support grower decisions when selecting and validating a preharvest agricultural water treatment programme.

The Microbiome of Size-Fractionated Airborne Particles from the Sahara Region

Diverse airborne microbes affect human health and biodiversity, and the Sahara region of West Africa is a globally important source region for atmospheric dust. We collected size-fractionated (>10, 10-2.5, 2.5-1.0, 1.0-0.5, and <0.5 μm) atmospheric particles in Mali, West Africa and conducted the first cultivation-independent study of airborne microbes in this region using 16S rRNA gene sequencing. Abundant and diverse microbes were detected in all particle size fractions at levels higher than those previously hypothesized for desert regions. Average daily abundance was 1.94 × 10⁵ 16S rRNA copies/m³. Daily patterns in abundance for particles <0.5 μm differed significantly from other size fractions likely because they form mainly in the atmosphere and have limited surface resuspension. Particles >10 μm contained the greatest fraction of daily abundance (51-62%) and had significantly greater diversity than smaller particles. Greater bacterial abundance of particles >2.5 μm that are bigger than the average bacterium suggests that most airborne bacteria are present as aggregates or attached to particles rather than as free-floating cells. Particles >10 μm have very short atmospheric lifetimes and thus tend to have more localized origins. We confirmed the presence of several potential pathogens using polymerase chain reaction that are candidates for viability and strain testing in future studies. These species were detected on all particle sizes tested, including particles <2.5 μm that are expected to undergo long-range transport. Overall, our results suggest that the composition and sources of airborne microbes can be better discriminated by collecting size-fractionated samples.

Spatial Effects of Livestock Farming on Human Infections With Shiga Toxin-Producing Escherichia coli O157 in Small but Densely Populated Regions: The Case of the Netherlands

The role of environmental transmission of typically foodborne pathogens like Shiga toxin-producing Escherichia coli (STEC) O157 is increasingly recognized. To gain more insights into spatially restricted risk factors that play a role in this transmission, we assessed the spatial association between sporadic STEC O157 human infections and the exposure to livestock (i.e. small ruminants, cattle, poultry, and pigs) in a densely populated country: the Netherlands. This was done for the years 2007-2016, using a state-of-the-art spatial analysis method in which hexagonal areas with different sizes (90, 50, 25 and 10 km2) were used in combination with a novel probability of exposure metric: the population-weighted number of animals per hexagon. To identify risk factors for STEC O157 infections and their population attributable fraction (PAF), a spatial regression model was fitted using integrated nested Laplace approximation (INLA). Living in hexagonal areas of 25, 50 and 90 km2 with twice as much population-weighted small ruminants was associated with an increase of the incidence rate of human STEC O157 infections in summer (RR of 1.09 [95%CI;1.01-1.17], RR of 1.17 [95%CI;1.07-1.28] and RR of 1.13 [95%CI;1.01-1.26]), with a PAF of 49% (95%CI;8-72%). Results suggest exposure to small ruminants to be a risk factor, although no evidence on the mode of transmission is provided. Therefore, the underlying mechanisms warrant further investigation and could offer new targets for control. The newly proposed exposure metric has potential to improve existing spatial modeling studies on infectious diseases related to livestock exposure, especially in densely populated countries like the Netherlands.

Lessons Learned from a Decade of Investigations of Shiga Toxin-Producing Escherichia coli Outbreaks Linked to Leafy Greens, United States and Canada

Shiga toxin-producing Escherichia coli (STEC) cause substantial and costly illnesses. Leafy greens are the second most common source of foodborne STEC O157 outbreaks. We examined STEC outbreaks linked to leafy greens during 2009-2018 in the United States and Canada. We identified 40 outbreaks, 1,212 illnesses, 77 cases of hemolytic uremic syndrome, and 8 deaths. More outbreaks were linked to romaine lettuce (54%) than to any other type of leafy green. More outbreaks occurred in the fall (45%) and spring (28%) than in other seasons. Barriers in epidemiologic and traceback investigations complicated identification of the ultimate outbreak source. Research on the seasonality of leafy green outbreaks and vulnerability to STEC contamination and bacterial survival dynamics by leafy green type are warranted. Improvements in traceability of leafy greens are also needed. Federal and state health partners, researchers, the leafy green industry, and retailers can work together on interventions to reduce STEC contamination.

Outbreaks of Escherichia coli O157:H7 Infections Linked to Romaine Lettuce in Canada from 2008 to 2018: An Analysis of Food Safety Context

ABSTRACT

Foodborne diseases are a major cause of illness in Canada. One of the main pathogens causing cases and outbreaks of foodborne illness in Canada is Escherichia coli O157:H7. From 2008 to 2018, 11 outbreaks of E. coli O157:H7 infection in Canada were linked to leafy greens, including 7 (63.6%) linked to romaine lettuce, 2 (18.2%) linked to iceberg lettuce, and 2 (18.2%) linked to other or unspecified types of leafy greens. The consumption of lettuce in Canada, the behavior of E. coli O157:H7 on lettuce leaves, and the production practices used for romaine and iceberg lettuce do not seem to explain why a higher number of outbreaks of E. coli O157:H7 infection were linked to romaine than to iceberg lettuce. However, the difference in the shape of iceberg and romaine lettuce heads could be an important factor. Among the seven outbreaks linked to romaine lettuce in Canada between 2008 and 2018, an eastern distribution of cases was observed. Cases from western provinces were reported only twice. The consumption of romaine and iceberg lettuce by the Canadian population does not seem to explain the eastern distribution of cases observed, but the commercial distribution, travel distances, and the storage practices used for lettuce may be important factors. In the past 10 years, the majority of the outbreaks of E. coli O157:H7 infection linked to romaine lettuce occurred during the spring (March to June) and fall (September to December). The timing of these outbreaks may be explained by the availability of lettuce in Canada, the growing region transition periods in the United States, and the seasonality in the prevalence of E. coli O157:H7. The consumption of romaine lettuce by the Canadian population does not explain the timing of the outbreaks observed.

HIGHLIGHTS

Microorganisms Move a Short Distance into an Almond Orchard from an Adjacent Upwind Poultry Operation

Over a 2-year period, drag swabs of orchard soil surface and air, soil, and almond leaf samples were collected in an almond orchard adjacent to (35 m from the first row of trees) and downwind from a poultry operation and in two almond orchards (controls) that were surrounded by other orchards. Samples were evaluated for aerobic plate count, generic Escherichia coli, other coliforms, the presence of Salmonella, bacterial community structure (analyzed through sequencing of the 16S rRNA gene), and amounts of dry solids (dust) on leaf surfaces on trees 0, 60, and 120 m into each orchard. E. coli was isolated from 41 of 206 (20%) and 1 of 207 (0.48%) air samples in the almond-poultry and control orchards, respectively. Salmonella was not isolated from any of the 529 samples evaluated. On average, the amount of dry solids on leaves collected from trees closest to the poultry operation was more than 2-fold greater than from trees 120 m into the orchard or from any of the trees in the control orchards. Members of the family Staphylococcaceae-often associated with poultry-were, on average, significantly (P < 0.001) more abundant in the phyllosphere of trees closest to the poultry operation (10% of relative abundance) than in trees 120 m into the orchard (1.7% relative abundance) or from any of the trees in control orchards (0.41% relative abundance). Poultry-associated microorganisms from a commercial operation transferred a short distance into an adjacent downwind almond orchard.IMPORTANCE The movement of microorganisms, including foodborne pathogens, from animal operations into adjacent plant crop-growing environments is not well characterized. This study provides evidence that dust and bioaerosols moved from a commercial poultry operation a short distance downwind into an almond orchard and altered the microbiome recovered from the leaves. These data provide growers with information they can use to assess food safety risks on their property.

Predicting Escherichia coli loads in cascading dams with machine learning: An integration of hydrometeorology, animal density and grazing pattern

Accurate prediction of Escherichia coli contamination in surface waters is challenging due to considerable uncertainty in the physical, chemical and biological variables that control E. coli occurrence and sources in surface waters. This study proposes a novel approach by integrating hydro-climatic variables as well as animal density and grazing pattern in the feature selection modeling phase to increase E. coli prediction accuracy for two cascading dams at the US Meat Animal Research Center (USMARC), Nebraska. Predictive models were developed using regression techniques and an artificial neural network (ANN). Two adaptive neuro-fuzzy inference system (ANFIS) structures including subtractive clustering and fuzzy c-means (FCM) clustering were also used to develop models for predicting E. coli. The performances of the predictive models were evaluated and compared using root mean squared log error (RMSLE). Cross-validation and model performance results indicated that although the majority of models predicted E. coli accurately, ANFIS models resulted in fewer errors compared to the other models. The ANFIS models have the potential to be used to predict E. coli concentration for intervention plans and monitoring programs for cascading dams, and to implement effective best management practices for grazing and irrigation during the growing season.

Survival of Salmonella during Apple Dehydration as Affected by Apple Cultivar and Antimicrobial Pretreatment

ABSTRACT

Dehydrated fruits, including dried coconut (Cocos nucifera) and dried apple (Malus sp.) slices, have been the subject of manufacturer recalls due to contamination with Salmonella. A study was conducted to determine the survival of Salmonella on apple slices of six apple cultivars after dehydration and also following treatment with antimicrobial solutions (0.5%, w/w) and dehydration. Samples of six apple cultivars (Envy, Gala, Red Delicious, Fuji, Pink Lady, Granny Smith) were cored and sliced into 0.4-cm rings, halved, inoculated with a five-strain composite of desiccation-resistant Salmonella, and dehydrated at 60°C for 5 h. Subsequently, Gala apple slices were treated in 0.5% solutions of one of eight antimicrobial rinses for 2 min and then dehydrated at 60°C for 5 h. Antimicrobial solutions used were potassium sorbate, sodium benzoate, ascorbic acid, propionic acid, lactic acid, citric acid, fumaric acid, and sodium bisulfate. Reduction of Salmonella populations varied according to apple cultivar. Salmonella survival on Envy, Gala, Red Delicious, Fuji, Pink Lady, and Granny Smith was 5.92, 5.58, 4.83, 4.68, 4.45, and 3.84 log CFU, respectively. There was significantly greater (P < 0.05) Salmonella inactivation on Granny Smith, Pink Lady, and Fuji apples than on Gala and Envy. Survival of Salmonella on Gala apple slices following dehydration was 5.58 log CFU for the untreated control and 4.76, 3.90, 3.29, 3.13, 2.89, 2.83, 2.64, and 0.0 log CFU for those treated with potassium sorbate, sodium benzoate, ascorbic acid, propionic acid, lactic acid, citric acid, fumaric acid, and sodium bisulfate, respectively. Pretreatment of apple slices with either fumaric acid or sodium bisulfate before dehydration led to lower Salmonella survival than pretreatment with all other antimicrobial treatments. Lower apple pH was statistically correlated (P < 0.05) with decreasing survival of Salmonella following dehydration. These results may provide methodology applicable to the food industry for increasing the inactivation of Salmonella during the dehydration of apple slices.

HIGHLIGHTS

Transmission of antimicrobial resistant non-O157 Escherichia coli at the interface of animal-fresh produce in sustainable farming environments

The interaction of typical host adapted enteric bacterial pathogens with fresh produce grown in fields is complex. These interactions can be more pronounced in co-managed or sustainable farms where animal operations are, by design, close to fresh produce, and growers frequently move between the two production environments. The primary objectives of this study were to 1) determine the transmission of STEC or enteric pathogens from small and large animal herds or operations to fresh produce on sustainable farms in TN and NC, 2) identify the possible sources that impact transmission of AMR E. coli, specifically STEC on these systems, and 3) WGS to characterize recovered E. coli from these sources. Samples were collected from raw and composted manure, environment, and produce sources. The serotype, virulence, and genotypic resistance profile were determined using the assembled genome sequences sequenced by Illumina technology. Broth microdilution was used to determine the antimicrobial susceptibility of each isolate against a panel of fourteen antimicrobials. The prevalence of E. coli increased during the summer season for all sources tested. ParSNP trees generated demonstrated that the transmission of AMR E. coli is occurring between animal feeding operations and fresh produce. Ten isolates were identified as serotype O45, a serotype that is associated with the "Big Six" group that is frequently linked with foodborne outbreaks caused by non-O157 E. coli. However, these isolates did not possess the stx gene. The highest frequency of resistance was detected against streptomycin (n = 225), ampicillin (n = 190) and sulfisoxazole FIS (n = 140). A total of 35 (13.7%) isolates from two TN farms were positive for the blaCMY (n = 5) and blaTEM (n = 32) genes. The results of this study show the potential of AMR E. coli transmission between animal feeding operations and fresh produce, and more studies are recommended to study this interaction and prevent dissemination in sustainable farming systems.

Multistate Outbreaks of Foodborne Illness in the United States Associated With Fresh Produce From 2010 to 2017

In the United States, the consumption of fresh fruits and vegetables has increased during recent years as consumers seek to make healthier lifestyle choices. However, the number of outbreaks associated with fresh produce that involve cases in more than one state (multistate) has increased concomitantly. As the distance along the farm-to-fork continuum has lengthened over time, there are also more opportunities for fresh produce contamination with bacterial pathogens before it reaches the consumer. This review provides an overview of the three bacterial pathogens (i.e., pathogenic Escherichia coli, Listeria monocytogenes, and Salmonella enterica) associated with multistate fresh produce outbreaks that occurred between 2010 and 2017 in the U.S. Possible routes of fresh produce contamination, including pre- and post-harvest, are summarized and outcomes of selected outbreaks within this timeframe are highlighted. Eighty-five multistate outbreaks linked to fresh produce with a confirmed etiology occurred from 2010 to 2017. Cross-contamination within the distribution chain and poor agricultural practices, along with the production of sprouts and importation of fresh produce were frequently implicated contributors to these events. The evolution of the food supply chain in the U.S. necessitates an examination of multistate outbreaks to shed light on factors that increase the scale of these events.

Occurrence of Escherichia coli O157:H7 in Pest Flies Captured in Leafy Greens Plots Grown Near a Beef Cattle Feedlot

Leafy greens are leading vehicles for Escherichia coli O157:H7 foodborne illness. Pest flies can harbor this pathogen and may disseminate it to produce. We determined the occurrence of E. coli O157:H7-positive flies in leafy greens planted up to 180 m from a cattle feedlot and assessed their relative risk to transmit this pathogen to leafy greens. The primary fly groups captured on sticky traps at the feedlot and leafy greens plots included house flies (Musca domestica L.), face flies (Musca autumnalis L.), stable flies (Stomoxys calcitrans L.), flesh flies (family Sarcophagidae), and blow flies (family Calliphoridae). E. coli O157:H7 carriage rates of house, face, flesh, and blow flies were similar (P > 0.05), ranging from 22.3 to 29.0 flies per 1,000 flies. In contrast, the carriage rate of stable flies was lower at 1.1 flies per 1,000 flies (P < 0.05). Differences in carriage rates are likely due to the uses of fresh bovine feces and manure by these different pest fly groups. E. coli O157:H7 carriage rates of total flies did not differ (P > 0.05) by distance (ranging from 0 to 180 m) from the feedlot. Most fly isolates were the same predominant pulsed-field gel electrophoresis types found in feedlot surface manure and leafy greens, suggesting a possible role for flies in transmitting E. coli O157:H7 to the leafy greens. However, further research is needed to clarify this role and to determine set-back distances between cattle production facilities and produce crops that will reduce the risk for pathogen contamination by challenging mechanisms like flies.

Bedding and bedding management practices are associated with mesophilic and thermophilic spore levels in bulk tank raw milk

Mesophilic and thermophilic spore-forming bacteria represent a challenge to the dairy industry, as these bacteria are capable of surviving adverse conditions associated with processing and sanitation and eventually spoil dairy products. The dairy farm environment, including soil, manure, silage, and bedding, has been implicated as a source for spores in raw milk. High levels of spores have previously been isolated from bedding, and different bedding materials have been associated with spore levels in bulk tank (BT) raw milk; however, the effect of different bedding types, bedding management practices, and bedding spore levels on the variance of spore levels in BT raw milk has not been investigated. To this end, farm and bedding management surveys were administered and unused bedding, used bedding, and BT raw milk samples were collected from dairy farms (1 or 2 times per farm) across the United States over 1 yr; the final data set included 182 dairy farms in 18 states. Bedding suspensions and BT raw milk were spore pasteurized (80°C for 12 min), and mesophilic and thermophilic spores were enumerated. Piecewise structural equation modeling analysis was used to determine direct and indirect pathways of association among farm and bedding practices, levels of spores in unused and used bedding, and levels of spores in BT raw milk. Separate models were constructed for mesophilic and thermophilic spore levels. The analyses showed that bedding material had a direct influence on levels of spores in unused and used bedding as well as an indirect association with spore levels in BT raw milk through used bedding spore levels. Specific bedding and farm management practices as well as cow hygiene in the housing area were associated with mesophilic and thermophilic spore levels in unused bedding, used bedding, and BT raw milk. Notably, levels of spores in used bedding were positively related to those in unused bedding, and used bedding spore levels were positively related to those in BT raw milk. The results of this study increase the understanding of the levels and ecology of mesophilic and thermophilic spores in raw milk, emphasize the possible role of bedding as a source of spores on-farm, and present opportunities for dairy producers to reduce spore levels in BT raw milk.

Survival of Escherichia coli in Manure-Amended Soils Is Affected by Spatiotemporal, Agricultural, and Weather Factors in the Mid-Atlantic United States

Untreated biological soil amendments of animal origin (BSAAO), such as manure, are commonly used to fertilize soils for growing fruit and vegetable crops and can contain enteric bacterial foodborne pathogens. Little is known about the comparative longitudinal survival of pathogens in agricultural fields containing different types of BSAAO, and field data may be useful to determine intervals between manure application and harvest of produce intended for human consumption to minimize foodborne illness. This study generated 324 survival profiles from 12 different field trials at three different sites (UMES, PA, and BARC) in the Mid-Atlantic United States from 2011 to 2015 of inoculated nonpathogenic Escherichia coli (gEc) and attenuated O157 E. coli (attO157) in soils which were unamended (UN) or amended with untreated poultry litter (PL), horse manure (HM), or dairy manure solids (DMS) or liquids (DML). Site, season, inoculum level (low/high), amendment type, management (organic/conventional), and depth (surface/tilled) all significantly (P < 0.0001) influenced survival duration (dpi100mort). Spatiotemporal factors (site, year, and season) in which the field trial was conducted influenced survival durations of gEc and attO157 to a greater extent than weather effects (average daily temperature and rainfall). Initial soil moisture content was the individual factor that accounted for the greatest percentage of variability in survival duration. PL supported greater survival durations of gEc and attO157, followed by HM, UN, and DMS in amended soils. The majority of survival profiles for gEc and attO157 which survived for more than 90 days came from a specific year (i.e., 2013). The effect of management and depth on dpi100mort were dependent on the amendment type evaluated.IMPORTANCE Current language in the Food Safety Modernization Act Produce Safety Rule states no objection to a 90- or 120-day interval between application of untreated BSAAO and harvest of crops to minimize transfer of pathogens to produce intended for human consumption with the intent to limit potential cases of foodborne illness. This regional multiple season, multiple location field trial determined survival durations of Escherichia coli in soils amended with manure to determine whether this interval is appropriate. Spatiotemporal factors influence survival durations of E. coli more than amendment type, total amount of E. coli present, organic or conventional soil management, and depth of manure application. Overall, these data show poultry litter may support extended survival of E. coli compared to horse manure or dairy manure, but spatiotemporal factors like site and season may have more influence than manure type in supporting survival of E. coli beyond 90 days in amended soils in the Mid-Atlantic United States.

Composting To Inactivate Foodborne Pathogens for Crop Soil Application: A Review

Compost is organic material that has been degraded into a nutrient-stabilized humus-like substance through intense microbial activity, which can provide essential plant nutrients (nitrogen, phosphorus) to aid in the growth of fruits and vegetables. Compost can be generated from animal waste feedstocks; these can contain human pathogens, which can be inactivated through the heat and microbial competition promoted during the composting process. Outbreaks of infections caused by bacterial pathogens such as Escherichia coli O157:H7, Salmonella, and Listeria monocytogenes on fruit and vegetable commodities consumed raw emphasize the importance of minimizing the risk of pathogenic contamination on produce commodities. This review article investigates factors that affect the reduction and survival of bacterial foodborne pathogens during the composting process. Interactions with indigenous microorganisms, carbon:nitrogen ratios, and temperature changes influence pathogen survival, growth, and persistence in finished compost. Understanding the mechanisms of pathogen survival during the composting process and mechanisms that reduce pathogen populations can minimize the risk of pathogen contamination in the cultivation of fruits and vegetables.

Genome Sequences of Eight Shiga Toxin-Producing Escherichia coli Strains Isolated from a Produce-Growing Region in California

Produce contaminated with Shiga toxin-producing Escherichia coli (STEC) is a continuing source of foodborne illness in the United States. This report documents the complete genome sequences of eight STEC strains isolated from livestock and water samples taken from a major agricultural region for leafy greens in California.

Preharvest Farming Practices Impacting Fresh Produce Safety

Advancements in agriculture and food processing techniques have been instrumental in the development of modern human societies. Vast improvements in agronomic practices, handling, and processing have allowed us to produce and preserve mass quantities of food. Yet despite all these innovations and potentially as a consequence of these mass production practices, more and more outbreaks of human pathogens linked to raw and processed foods are identified every year. It is evident that our increased capacity for microbial detection has contributed to the greater number of outbreaks detected. However, our understanding of how these events originate and what agronomic, packaging, and environmental factors influence the survival, persistence, and proliferation of human pathogens remains of scientific debate. This review seeks to identify those past and current challenges to the safety of fresh produce and focuses on production practices and how those impact produce safety. It reflects on 20 years of research, industry guidelines, and federal standards and how they have evolved to our current understanding of fresh produce safety. This document is not intended to summarize and describe all fruit and vegetable farming practices across the United States and the rest of the world. We understand the significant differences in production practices that exist across regions. This review highlights those general farming practices that significantly impact past and current food safety issues. It focuses on current and future research needs and on preharvest food safety control measures in fresh-produce safety that could provide insight into the mechanisms of pathogen contamination, survival, and inactivation under field and packinghouse conditions.

Exploring links between water quality and E. coli O157:H7 survival potential in well waters from a rural area of southern Changchun City, China

Waterborne infectious disease outbreak associated with well water contamination is a worldwide public health issue, especially for rural areas in developing countries. In the current study, we characterized 20 well water samples collected from a rural area of southern Changchun city, China, and investigated the survival potential of Escherichia coli O157:H7 in those water samples. The results showed that nitrate and ammonia concentrations in some well water samples exceed the corresponding China drinking water standards, indicating potential contamination by local agricultural farms. Our results also revealed that the average survival time (ttd) of E. coli O157:H7 in all well water samples was 30.09 days, with shortest and longest ttd being 17.95 and 58.10 days, respectively. The ttds were significantly correlated with pH and the ratio of total nitrogen to total phosphorus. In addition, it was found that the shape parameter (p) and first decimal reduction parameter (δ) were negatively (P < 0.05) and positively (P < 0.05) correlated to ttd, respectively. Our study showed that E. coli O157:H7 could survive up to two months in well water, suggesting that this pathogen could constitute a great public health risk.

Identifying and modeling meteorological risk factors associated with pre-harvest contamination of Listeria species in a mixed produce and dairy farm

This study sought to investigate the prevalence of Listeria species (including L. monocytogenes) in a mixed produce and dairy farm and to identify specific meteorological factors affecting Listeria spp. presence. Environmental samples were collected monthly from locations within the mixed farm over 14months and were analyzed for Listeria spp. Meteorological factors were evaluated for their association with the presence of Listeria spp. by using logistic regression (LR) and random forest (RF). The developed LR model identified wind speed and precipitation as significant risk factors (P<0.05), indicating higher wind speed at day 2 prior to sampling and higher average precipitation over the previous 25days before sampling increased the probability of isolation of Listeria spp. from the mixed farm. Results from RF revealed that average wind speed at day 2 prior to sampling and average precipitation in the previous 25days before sampling were the most important factors influencing the presence of Listeria spp., which supported the findings from LR. These findings indicate that the occurrence of Listeria spp. was influenced by wind speed and precipitation, suggesting run-off and wind-driven dust might be possible routes of pathogen transmission in mixed farms. The developed LR and RF models, with robust predictive performances as measured by the area under the receiver operating characteristic curves, can be used to predict Listeria spp. contamination risk in a mixed farm under different weather conditions and can help with the evaluation of farm management practices and the development of control strategies aimed at reducing pre-harvest microbial contamination in a mixed farming system.

Reducing Foodborne Pathogen Persistence and Transmission in Animal Production Environments: Challenges and Opportunities

Preharvest strategies to reduce zoonotic pathogens in food animals are important components of the farm-to-table food safety continuum. The problem is complex; there are multiple pathogens of concern, multiple animal species under different production and management systems, and a variety of sources of pathogens, including other livestock and domestic animals, wild animals and birds, insects, water, and feed. Preharvest food safety research has identified a number of intervention strategies, including probiotics, direct-fed microbials, competitive exclusion cultures, vaccines, and bacteriophages, in addition to factors that can impact pathogens on-farm, such as seasonality, production systems, diet, and dietary additives. Moreover, this work has revealed both challenges and opportunities for reducing pathogens in food animals. Animals that shed high levels of pathogens and predominant pathogen strains that exhibit long-term persistence appear to play significant roles in maintaining the prevalence of pathogens in animals and their production environment. Continued investigation and advancements in sequencing and other technologies are expected to reveal the mechanisms that result in super-shedding and persistence, in addition to increasing the prospects for selection of pathogen-resistant food animals and understanding of the microbial ecology of the gastrointestinal tract with regard to zoonotic pathogen colonization. It is likely that this continued research will reveal other challenges, which may further indicate potential targets or critical control points for pathogen reduction in livestock. Additional benefits of the preharvest reduction of pathogens in food animals are the reduction of produce, water, and environmental contamination, and thereby lower risk for human illnesses linked to these sources.

Shiga Toxin (Verotoxin)-producing Escherichia coli and Foodborne Disease: A Review

Shiga toxin (verotoxin)-producing Escherichia coli (STEC) is an important cause of foodborne disease. Since outcomes of the infections with STEC have a broad range of manifestation from asymptomatic infection or mild intestinal discomfort, to bloody diarrhea, hemolytic uremic syndrome (HUS), end-stage renal disease (ESRD), and death, the disease is a serious burden in public health and classified as a notifiable infectious disease in many countries. Cattle and other ruminants are considered to be the major reservoirs of STEC though isolation of STEC from other animals have been reported. Hence, the source of contamination extends to a wide range of foods, not only beef products but also fresh produce, water, and environment contaminated by excretes from the animals, mainly cattle. A low- infectious dose of STEC makes the disease relatively contagious, and causes outbreaks with unknown contamination sources and, therefore, as a preventive measure against STEC infection, it is important to obtain characteristics of prevailing STEC isolates in the region through robust surveillance. Analysis of the isolates by pulsed-field gel electrophoresis (PFGE) and multiple-locus variable-number tandem repeat analysis (MLVA) could help finding unrecognized foodborne outbreaks due to consumption of respective contaminated sources. However, though the results of molecular analysis of the isolates could indicate linkage of sporadic cases of STEC infection, it is hardly concluded that the cases are related via contaminated food source if it were not for epidemiological information. Therefore, it is essential to combine the results of strain analysis and epidemiological investigation rapidly to detect rapidly foodborne outbreaks caused by bacteria. This article reviews STEC infection as foodborne disease and further discusses key characteristics of STEC including pathogenesis, clinical manifestation, prevention and control of STEC infection. We also present the recent situation of the disease in Japan based on the surveillance of STEC infection.

Contamination of Fresh Produce by Microbial Indicators on Farms and in Packing Facilities: Elucidation of Environmental Routes

To improve food safety on farms, it is critical to quantify the impact of environmental microbial contamination sources on fresh produce. However, studies are hampered by difficulties achieving study designs with powered sample sizes to elucidate relationships between environmental and produce contamination. Our goal was to quantify, in the agricultural production environment, the relationship between microbial contamination on hands, soil, and water and contamination on fresh produce. In 11 farms and packing facilities in northern Mexico, we applied a matched study design: composite samples (n = 636, equivalent to 11,046 units) of produce rinses were matched to water, soil, and worker hand rinses during two growing seasons. Microbial indicators (coliforms, Escherichia coli, Enterococcus spp., and somatic coliphage) were quantified from composite samples. Statistical measures of association and correlations were calculated through Spearman's correlation, linear regression, and logistic regression models. The concentrations of all microbial indicators were positively correlated between produce and hands (ρ range, 0.41 to 0.75; P < 0.01). When E. coli was present on hands, the handled produce was nine times more likely to contain E. coli (P < 0.05). Similarly, when coliphage was present on hands, the handled produce was eight times more likely to contain coliphage (P < 0.05). There were relatively low concentrations of indicators in soil and water samples, and a few sporadic significant associations were observed between contamination of soil and water and contamination of produce. This methodology provides a foundation for future field studies, and results highlight the need for interventions surrounding farmworker hygiene and sanitation to reduce microbial contamination of farmworkers' hands.IMPORTANCE This study of the relationships between microbes on produce and in the farm environment can be used to support the design of targeted interventions to prevent or reduce microbial contamination of fresh produce with associated reductions in foodborne illness.

Airborne soil particulates as vehicles for Salmonella contamination of tomatoes

The presence of dust is ubiquitous in the produce growing environment and its deposition on edible crops could occur. The potential of wind-distributed soil particulate to serve as a vehicle for S. Newport transfer to tomato blossoms and consequently, to fruits, was explored. Blossoms were challenged with previously autoclaved soil containing S. Newport (9.39log CFU/g) by brushing and airborne transfer. One hundred percent of blossoms brushed with S. Newport-contaminated soil tested positive for presence of the pathogen one week after contact (P<0.0001). Compressed air was used to simulate wind currents and direct soil particulates towards blossoms. Airborne soil particulates resulted in contamination of 29% of the blossoms with S. Newport one week after contact. Biophotonic imaging of blossoms post-contact with bioluminescent S. Newport-contaminated airborne soil particulates revealed transfer of the pathogen on petal, stamen and pedicel structures. Both fruits and calyxes that developed from blossoms contaminated with airborne soil particulates were positive for presence of S. Newport in both fruit (66.6%) and calyx (77.7%). Presence of S. Newport in surface-sterilized fruit and calyx tissue tested indicated internalization of the pathogen. These results show that airborne soil particulates could serve as a vehicle for Salmonella. Hence, Salmonella contaminated dust and soil particulate dispersion could contribute to pathogen contamination of fruit, indicating an omnipresent yet relatively unexplored contamination route.

Importance of Soil Amendments: Survival of Bacterial Pathogens in Manure and Compost Used as Organic Fertilizers

Biological soil amendments (BSAs) such as manure and compost are frequently used as organic fertilizers to improve the physical and chemical properties of soils. However, BSAs have been known to be a reservoir for enteric bacterial pathogens such as enterohemorrhagic Escherichia coli (EHEC), Salmonella spp., and Listeria spp. There are numerous mechanisms by which manure may transfer pathogens to growing fruits and vegetables, and several outbreaks of infections have been linked to manure-related contamination of leafy greens. In the United States several commodity-specific guidelines and current and proposed federal rules exist to provide guidance on the application of BSAs as fertilizers to soils, some of which require an interval between the application of manure to soils and the harvest of fruits and vegetables. This review examines the survival, persistence, and regrowth/resuscitation of bacterial pathogens in manure, biosolids, and composts. Moisture, along with climate and the physicochemical properties of soil, manure, or compost, plays a significant role in the ability of pathogens to persist and resuscitate in amended soils. Adaptation of enteric bacterial pathogens to the nonhost environment of soils may also extend their persistence in manure- or compost-amended soils. The presence of antibiotic-resistance genes in soils may also be increased by manure application. Overall, BSAs applied as fertilizers to soils can support the survival and regrowth of pathogens. BSAs should be handled and applied in a manner that reduces the prevalence of pathogens in soils and the likelihood of transfer of food-borne pathogens to fruits and vegetables. This review will focus on two BSAs—raw manure and composted manure (and other feedstocks)—and predominantly on the survival of enteric bacterial pathogens in BSAs as applied to soils as organic fertilizers.