Effect of formaldehyde inactivation on poliovirus

Comparison of structure and immunogenicity of CVB1-VLP and inactivated CVB1 vaccine candidates

Coxsackievirus B1 (CVB1) is a common cause of acute and chronic myocarditis, dilated cardiomyopathy and aseptic meningitis. However, no CVB-vaccines are available for human use. In this study, we investigated the immunogenicity of virus-like particle (VLP) and inactivated whole-virus vaccines for CVB1 when administrated to mice via either subcutaneous or intranasal routes formulated with and without commercial and experimental adjuvants. Here, the potential of utilizing epigallocatechin-3-gallate (EGCG) as a mucosal adjuvant synergistically with its ability to inactivate the virus were investigated. EGCG had promising adjuvant properties for CVB1-VLP when administered via the parenteral route but limited efficacy via intranasal administration. However, intranasal administration of the formalin-inactivated virus induced high CVB1-specific humoral, cellular, and mucosal immune responses. Also, based on CVB1-specific IgG-antibody responses, we conclude that CVB1-VLP can be taken up by immune cells when administrated intranasally and further structural engineering for the VLP may increase the mucosal immunogenicity. The preparations contained mixtures of compact and expanded A particles with 85% expanded in the formalin-inactivated virus, but only 52% in the VLP observed by cryogenic electron microscopy. To correlate the structure to immunogenicity, we solved the structures of the CVB1-VLP and the formalin-inactivated CVB1 virus at resolutions ranging from 2.15 A to 4.1 A for the expanded and compact VLP and virus particles by image reconstruction. These structures can be used in designing mutations increasing the stability and immunogenicity of CVB1-VLP in the future. Overall, our results highlight the potential of using formalin inactivated CVB1 vaccine in mucosal immunization programs and provide important information for future development of VLP-based vaccines against all enteroviruses.

Electrochemical profiling of poliovirus particles inactivated by chemical method and ionizing radiation

Electrochemical profiling of formaldehyde-inactivated poliovirus particles demonstrated a relationship between the D-antigen concentration and the intensity of the maximum amplitude currents of the poliovirus samples. The resultant signal was therefore identified as electrochemical oxidation of the surface proteins of the poliovirus. Using registration of electrooxidation of amino acid residues of the capsid proteins, a comparative electrochemical analysis of poliovirus particles inactivated by electrons accelerated with doses of 5 kGy, 10 kGy, 15 kGy, 25 kGy, 30 kGy at room temperature was carried out. An increase in the radiation dose was accompanied by an increase in electrooxidation signals. A significant increase in the signals of electrooxidation of poliovirus capsid proteins was detected upon irradiation at doses of 15-30 kGy. The data obtained suggest that the change in the profile and increase in the electrooxidation signals of poliovirus capsid proteins are associated with an increase in the degree of structural reorganization of surface proteins and insufficient preservation of the D-antigen under these conditions of poliovirus inactivation.

Antiviral responses induced by Tdap-IPV vaccination are associated with persistent humoral immunity to Bordetella pertussis

Many countries continue to experience pertussis epidemics despite widespread vaccination. Waning protection after booster vaccination has highlighted the need for a better understanding of the immunological factors that promote durable protection. Here we apply systems vaccinology to investigate antibody responses in adolescents in the Netherlands (N = 14; NL) and the United Kingdom (N = 12; UK) receiving a tetanus-diphtheria-acellular pertussis-inactivated poliovirus (Tdap-IPV) vaccine. We report that early antiviral and interferon gene expression signatures in blood correlate to persistence of pertussis-specific antibody responses. Single-cell analyses of the innate response identified monocytes and myeloid dendritic cells (MoDC) as principal responders that upregulate antiviral gene expression and type-I interferon cytokine production. With public data, we show that Tdap vaccination stimulates significantly lower antiviral/type-I interferon responses than Tdap-IPV, suggesting that IPV may promote antiviral gene expression. Subsequent in vitro stimulation experiments demonstrate TLR-dependent, IPV-specific activation of the pro-inflammatory p38 MAP kinase pathway in MoDCs. Together, our data provide insights into the molecular host response to pertussis booster vaccination and demonstrate that IPV enhances innate immune activity associated with persistent, pertussis-specific antibody responses.

Low-temperature culture enhances production of flavivirus virus-like particles in mammalian cells

Flavivirus virus-like particles (VLPs) exhibit a striking structural resemblance to viral particles, making them highly adaptable for various applications, including vaccines and diagnostics. Consequently, increasing VLPs production is important and can be achieved by optimizing expression plasmids and cell culture conditions. While attempting to express genotype III (GIII) Japanese encephalitis virus (JEV) VLPs containing the G104H mutation in the envelope (E) protein, we failed to generate VLPs in COS-1 cells. However, VLPs production was restored by cultivating plasmid-transfected cells at a lower temperature, specifically 28 °C. Furthermore, we observed that the enhancement in JEV VLPs production was independent of amino acid mutations in the E protein. The optimal condition for JEV VLPs production in plasmid-transfected COS-1 cells consisted of an initial culture at 37 °C for 6 h, followed by a shift to 28 °C (37/28 °C) for cultivation. Under 37/28 °C cultivation conditions, flavivirus VLPs production significantly increased in various mammalian cell lines regardless of whether its expression was transiently transfected or clonally selected cells. Remarkably, clonally selected cell lines expressing flavivirus VLPs consistently achieved yields exceeding 1 μg/ml. Binding affinity analyses using monoclonal antibodies revealed similar binding patterns for VLPs of genotype I (GI) JEV, GIII JEV, West Nile virus (WNV), and dengue virus serotype 2 (DENV-2) produced under both 37 °C or 37/28 °C cultivation conditions. In summary, our study demonstrated that the production of flavivirus VLPs can be significantly improved under 37/28 °C cultivation conditions without affecting the conformational structure of the E protein. KEYPOINTS: • Low-temperature culture (37/28 °C) enhances production of flavivirus VLPs. • Flavivirus VLPs consistently achieved yields exceeding 1 μg/ml. • 37/28 °C cultivation did not alter the structure of flavivirus VLPs.

Designing Selenium Nanoadjuvant as Universal Agent for Live-Killed Virus-Based Vaccine

Inactivated virus vaccines with whole antigen spectra and good safety are the commonly used modality for preventing infections. However, the poor immunogenicity greatly limits its clinical applications. Herein, by taking advantages of the crucial roles of Se in the functions of immune cells and its biomineralization property, it successfully in-situ synthesized Se nanoadjuvant on inactivated viruses such as porcine epidemic diarrhea virus (PEDV), pseudorabies virus (PRV), and porcine reproductive and respiratory syndrome virus (PRRSV) in a facile method, which is universal to construct other inactivated virus vaccines. The nanovaccine can highly effectively enhance the uptake of PEDV/PRV/PRRSV into dendritic cells (DCs) and activate DCs via triggering TLR4 signaling pathways and regulating selenoproteins expressions. Furthermore, it exhibited better activities in triggering macrophages and natural killer cells-mediated innate immunity and T cells-mediated cellular immunity compared to PEDV and the commercial inactivated PEDV vaccine on both mice and swine models. This study provides a universal Se nanoadjuvant for developing inactivated viruses-based nanovaccines for preventing virus infections.

Perspectives for the creation of a new type of vaccine preparations based on pseudovirus particles using polio vaccine as an example

Traditional antiviral vaccines are currently created by inactivating the virus chemically, most often using formaldehyde or β-propiolactone. These approaches are not optimal since they negatively affect the safety of the antigenic determinants of the inactivated particles and require additional purification stages. The most promising platforms for creating vaccines are based on pseudoviruses, i.e., viruses that have completely preserved the outer shell (capsid), while losing the ability to reproduce owing to the destruction of the genome. The irradiation of viruses with electron beam is the optimal way to create pseudoviral particles. In this review, with the example of the poliovirus, the main algorithms that can be applied to characterize pseudoviral particles functionally and structurally in the process of creating a vaccine preparation are presented. These algorithms are, namely, the analysis of the degree of genome destruction and coimmunogenicity. The structure of the poliovirus and methods of its inactivation are considered. Methods for assessing residual infectivity and immunogenicity are proposed for the functional characterization of pseudoviruses. Genome integrity analysis approaches, atomic force and electron microscopy, surface plasmon resonance, and bioelectrochemical methods are crucial to structural characterization of the pseudovirus particles.

Increasing sensitivity of antibody-antigen interactions using photo-cross-linking

Understanding antibody-antigen interactions in a polyclonal immune response in humans and animal models is critical for rational vaccine design. Current approaches typically characterize antibodies that are functionally relevant or highly abundant. Here, we use photo-cross-linking and single-particle electron microscopy to increase antibody detection and unveil epitopes of low-affinity and low-abundance antibodies, leading to a broader structural characterization of polyclonal immune responses. We employed this approach across three different viral glycoproteins and showed increased sensitivity of detection relative to currently used methods. Results were most noticeable in early and late time points of a polyclonal immune response. Additionally, the use of photo-cross-linking revealed intermediate antibody binding states and demonstrated a distinctive way to study antibody binding mechanisms. This technique can be used to structurally characterize the landscape of a polyclonal immune response of patients in vaccination or post-infection studies at early time points, allowing for rapid iterative design of vaccine immunogens.

Inactivated Cowpea Mosaic Virus for In Situ Vaccination: Differential Efficacy of Formalin vs UV-Inactivated Formulations

Cowpea mosaic virus (CPMV) has been developed as a promising nanoplatform technology for cancer immunotherapy; when applied as in situ vaccine, CPMV exhibits potent, systemic, and durable efficacy. While CPMV is not infectious to mammals, it is infectious to legumes; therefore, agronomic safety needs to be addressed to broaden the translational application of CPMV. RNA-containing formulations are preferred over RNA-free virus-like particles because the RNA and protein, each, contribute to CPMV's potent antitumor efficacy. We have previously optimized inactivation methods to develop CPMV that contains RNA but is not infectious to plants. We established that inactivated CPMV has reduced efficacy compared to untreated, native CPMV. However, a systematic comparison between native CPMV and different inactivated forms of CPMV was not done. Therefore, in this study, we directly compared the therapeutic efficacies and mechanisms of immune activation of CPMV, ultraviolet- (UV-), and formalin (Form)-inactivated CPMV to explain the differential efficacies. In a B16F10 melanoma mouse tumor model, Form-CPMV suppressed the tumor growth with prolonged survival (there were no statistical differences comparing CPMV and Form-CPMV). In comparison, UV-CPMV inhibited tumor growth significantly but not as well as Form-CPMV or CPMV. The reduced therapeutic efficacy of UV-CPMV is explained by the degree of cross-linking and aggregated state of the RNA, which renders it inaccessible for sensing by Toll-like receptor (TLR) 7/8 to activate immune responses. The mechanistic studies showed that the highly aggregated state of UV-CPMV inhibited TLR7 signaling more so than for the Form-CPMV formulation, reducing the secretion of interleukin-6 (IL-6) and interferon-α (IFN-α), cytokines associated with TLR7 signaling. These findings support the translational development of Form-CPMV as a noninfectious immunotherapeutic agent.

Current and next-generation formulation strategies for inactivated polio vaccines to lower costs, increase coverage, and facilitate polio eradication

Implementation of inactivated polio vaccines (IPV) containing Sabin strains (sIPV) will further enable global polio eradication efforts by improving vaccine safety during use and containment during manufacturing. Moreover, sIPV-containing vaccines will lower costs and expand production capacity to facilitate more widespread use in low- and middle-income countries (LMICs). This review focuses on the role of vaccine formulation in these efforts including traditional Salk IPV vaccines and new sIPV-containing dosage forms. The physicochemical properties and stability profiles of poliovirus antigens are described. Formulation approaches to lower costs include developing multidose and combination vaccine formats as well as improving storage stability. Formulation strategies for dose-sparing and enhanced mucosal immunity include employing adjuvants (e.g. aluminum-salt and newer adjuvants) and/or novel delivery systems (e.g. ID administration with microneedle patches). The potential for applying these low-cost formulation development strategies to other vaccines to further improve vaccine access and coverage in LMICs is also discussed.

Immunogenicity and Efficacy of Monovalent and Bivalent Formulations of a Virus-Like Particle Vaccine against SARS-CoV-2

Virus-like particles (VLPs) offer great potential as a safe and effective vaccine platform against SARS-CoV-2, the causative agent of COVID-19. Here, we show that SARS-CoV-2 VLPs can be generated by expression of the four viral structural proteins in a mammalian expression system. Immunization of mice with a monovalent VLP vaccine elicited a potent humoral response, showing neutralizing activity against multiple variants of SARS-CoV-2. Subsequent immunogenicity and efficacy studies were performed in the Golden Syrian hamster model, which closely resembles the pathology and progression of COVID-19 in humans. Hamsters immunized with a bivalent VLP vaccine were significantly protected from infection with the Beta or Delta variant of SARS-CoV-2. Vaccinated hamsters showed reduced viral load, shedding, replication, and pathology in the respiratory tract. Immunized hamsters also showed variable levels of cross-neutralizing activity against the Omicron variant. Overall, the VLP vaccine elicited robust protective efficacy against SARS-CoV-2. These promising results warrant further study of multivalent VLP vaccines in Phase I clinical trials in humans.

Antimicrobial monoglycerides for swine and poultry applications

The development of natural, broadly acting antimicrobial solutions to combat viral and bacterial pathogens is a high priority for the livestock industry. Herein, we cover the latest progress in utilizing lipid-based monoglycerides as feed additives to address some of the biggest challenges in animal agriculture. The current industry needs for effective antimicrobial strategies are introduced before discussing why medium-chain monoglycerides are a promising solution due to attractive molecular features and biological functions. We then critically analyze recent application examples in which case monoglycerides demonstrated superior activity to prevent feed transmission of viruses in swine and to mitigate bacterial infections in poultry along with gut microbiome modulation capabilities. Future innovation strategies are also suggested to expand the range of application possibilities and to enable new monoglyceride delivery options.

Development of an animal component free production process for Sabin inactivated polio vaccine

Inactivated polio vaccine production using attenuated Sabin strains (sIPV) instead of wild type polio viruses (cIPV) is an initiative encouraged by the World Health Organization. This use of attenuated viruses is preferred as it reduces risks related to potential outbreaks during IPV production. Previously, an sIPV production process was set up based on the cIPV production process. Optimizing this process while using only animal component free (ACF) substances allows reduction of operational costs and mitigates risks of adverse effects related with animal derived compounds. Here, development of a process for production of sIPV using only ACF compounds, is described.

The upstream process required a change in cell growth medium from serum-containing medium to ACF medium, while virus production media remained the same as the already used M199 medium was free of animal components. In the downstream process multiple modifications in existing unit operations were made including addition of a diafiltration step prior to inactivation. After optimizing each unit operation, robustness of the whole process was demonstrated using design of experiments (DoE) methodology. By using DoE we were able to vary different process parameters across unit operations to assess the impact on our quality attributes. The developed process was robust as the observed variation for quality attributes due to differences in process parameters remained within specification.

The resulting pilot process showed not only to be robust, but also to have a considerable higher product yield when compared to the serum containing sIPV process. Product yields are now comparable to the cIPV process based on using wild type polio viruses. Moreover, the potency of the produced vaccine was comparable that of cIPV vaccine. The developed ACF sIPV process can be transferred to vaccine manufacturers at the end-of pre-clinical development phase, at lab- or pilot scale, before production of clinical trial material.

Applications of Charge Detection Mass Spectrometry in Molecular Biology and Biotechnology

Charge detection mass spectrometry (CDMS) is a single-particle technique where the masses of individual ions are determined from simultaneous measurement of their mass-to-charge ratio (m/z) and charge. Masses are determined for thousands of individual ions, and then the results are binned to give a mass spectrum. Using this approach, accurate mass distributions can be measured for heterogeneous and high-molecular-weight samples that are usually not amenable to analysis by conventional mass spectrometry. Recent applications include heavily glycosylated proteins, protein complexes, protein aggregates such as amyloid fibers, infectious viruses, gene therapies, vaccines, and vesicles such as exosomes.

Methods of Inactivation of Highly Pathogenic Viruses for Molecular, Serology or Vaccine Development Purposes

The handling of highly pathogenic viruses, whether for diagnostic or research purposes, often requires an inactivation step. This article reviews available inactivation techniques published in peer-reviewed journals and their benefits and limitations in relation to the intended application. The bulk of highly pathogenic viruses are represented by enveloped RNA viruses belonging to the Togaviridae, Flaviviridae, Filoviridae, Arenaviridae, Hantaviridae, Peribunyaviridae, Phenuiviridae, Nairoviridae and Orthomyxoviridae families. Here, we summarize inactivation methods for these virus families that allow for subsequent molecular and serological analysis or vaccine development. The techniques identified here include: treatment with guanidium-based chaotropic salts, heat inactivation, photoactive compounds such as psoralens or 1.5-iodonaphtyl azide, detergents, fixing with aldehydes, UV-radiation, gamma irradiation, aromatic disulfides, beta-propiolacton and hydrogen peroxide. The combination of simple techniques such as heat or UV-radiation and detergents such as Tween-20, Triton X-100 or Sodium dodecyl sulfate are often sufficient for virus inactivation, but the efficiency may be affected by influencing factors including quantity of infectious particles, matrix constitution, pH, salt- and protein content. Residual infectivity of the inactivated virus could have disastrous consequences for both laboratory/healthcare personnel and patients. Therefore, the development of inactivation protocols requires careful considerations which we review here.

Immune response to a conserved enteroviral epitope of the major capsid VP1 protein is associated with lower risk of cardiovascular disease

BACKGROUND

Major cardiac events including myocardial infarction (MI) are associated with viral infections. However, how specific infections contribute to the cardiovascular insults has remained largely unclear.

METHODS

We employed next generation phage display mimotope-variation analysis (MVA) to explore the link between antibody-based immune response and severe cardiovascular conditions. Here, we used a case-control design, including the first-stage discovery cohort (n = 100), along with cohorts for second-stage discovery (n = 329) and validation (n = 466).

FINDINGS

We observed strong antibody response to the peptide antigens with Gly-Ile-X-Asp (G-I-X-D) core structure in healthy individuals but not in patients with MI. Analysis of the origin of this epitope linked it with the N-terminus of the VP1 protein of poliovirus 3 (PV3), but also other species of picornaviruses. Consistently, we found low levels of antibody response to the G-I-X-D epitope in individuals with severe cardiac disease complications.

INTERPRETATION

Our findings imply that antibody response to the G-I-X-D epitope is associated with polio vaccinations and that high antibody levels to this epitope could discriminate healthy individuals from prospective MI patients as a blood-derived biomarker. Together, these findings highlight the importance of epitope-specific antibody response and suggest that protective immunity against the polio- and non-polio enteroviral infections support improved cardiovascular health.

FUNDING

Estonian Ministry of Education (5.1-4/20/170), Estonian Research Council (PRG573, PRG805), H2020-MSCA-RISE-2016 (EU734791), H2020 PANBioRA (EU760921), European Union through the European Regional Development Fund (Project no. 2014-2020.4.01.15-0012), Helsinki University Hospital grants, Mary and Georg C. Ehrnrooth Foundation, Finnish Eye Foundation, Finska Läkaresällskapet, The Finnish Society of Sciences and Letters, Magnus Ehrnrooth Foundation and Sigrid Jusélius Foundation.

Sharia (Islamic Law) Perspectives of COVID-19 Vaccines

The Coronavirus disease 2019 (COVID-19) pandemic has caused health, economic, and social challenges globally. Under these circumstances, effective vaccines play a critical role in saving lives, improving population health, and facilitating economic recovery. In Muslim-majority countries, Islamic jurisprudence, which places great importance on sanctity and safety of human life and protection of livelihoods, may influence vaccine uptake. Efforts to protect humans, such as vaccines, are highly encouraged in Islam. However, concerns about vaccine products’ Halal (permissible to consume by Islamic law) status and potential harm can inhibit acceptance. Fatwa councils agree that vaccines are necessary in the context of our current pandemic; receiving a COVID-19 vaccination is actually a form of compliance with Sharia law. Broader use of animal component free reagents during manufacturing may further increase acceptance among Muslims. We herein explain the interplay between Sharia (Islamic law) and scientific considerations in addressing the challenge of COVID-19 vaccine acceptance, particularly in Muslim populations.

A live-attenuated viral vector vaccine protects mice against lethal challenge with Kyasanur Forest disease virus

Kyasanur Forest disease virus (KFDV) is a tick-borne flavivirus endemic in India known to cause severe hemorrhagic and encephalitic disease in humans. In recent years, KFDV has spread beyond its original endemic zone raising public health concerns. Currently, there is no treatment available for KFDV but a vaccine with limited efficacy is used in India. Here, we generated two new KFDV vaccine candidates based on the vesicular stomatitis virus (VSV) platform. We chose the VSV-Ebola virus (VSV-EBOV) vector either with the full-length or a truncated EBOV glycoprotein as the vehicle to express the precursor membrane (prM) and envelope (E) proteins of KFDV (VSV-KFDV). For efficacy testing, we established a mouse disease model by comparing KFDV infections in three immunocompetent mouse strains (BALB/c, C57Bl/6, and CD1). Both vaccine vectors provided promising protection against lethal KFDV challenge in the BALB/c model following prime-only prime-boost and immunizations. Only prime-boost immunization with VSV-KFDV expressing full-length EBOV GP resulted in uniform protection. Hyperimmune serum derived from prime-boost immunized mice protected naïve BALB/c mice from lethal KFDV challenge indicating the importance of antibodies for protection. The new VSV-KFDV vectors are promising vaccine candidates to combat an emerging, neglected public health problem in a densely populated part of the world.

Viral Inactivation Impacts Microbiome Estimates in a Tissue-Specific Manner

The global emergence of novel pathogenic viruses presents an important challenge for research, as high biosafety levels are required to process samples. While inactivation of infectious agents facilitates the use of less stringent safety conditions, its effect on other biological entities of interest present in the sample is generally unknown. Here, we analyzed the effect of five inactivation methods (heat, ethanol, formaldehyde, psoralen, and TRIzol) on microbiome composition and diversity in samples collected from four different body sites (gut, nasal, oral, and skin) and compared them against untreated samples from the same tissues. We performed 16S rRNA gene sequencing and estimated abundance and diversity of bacterial taxa present in all samples. Nasal and skin samples were the most affected by inactivation, with ethanol and TRIzol inducing the largest changes in composition, and heat, formaldehyde, TRIzol, and psoralen inducing the largest changes in diversity. Oral and stool microbiomes were more robust to inactivation, with no significant changes in diversity and only moderate changes in composition. Firmicutes was the taxonomic group least affected by inactivation, while Bacteroidetes had a notable enrichment in nasal samples and moderate enrichment in fecal and oral samples. Actinobacteria were more notably depleted in fecal and skin samples, and Proteobacteria exhibited a more variable behavior depending on sample type and inactivation method. Overall, our results demonstrate that inactivation methods can alter the microbiome in a tissue-specific manner and that careful consideration should be given to the choice of method based on the sample type under study. IMPORTANCE Understanding how viral infections impact and are modulated by the microbiome is an important problem in basic research but is also of high clinical relevance under the current pandemic. To facilitate the study of interactions between microbial communities and pathogenic viruses under safe conditions, the infectious agent is generally inactivated prior to processing samples. The effect of this inactivation process in the microbiome is, however, unknown. Further, it is unclear whether biases introduced by inactivation methods are dependent on the sample type under study. Estimating the magnitude and nature of the changes induced by different methods in samples collected from various body sites thus provides important information for current and future studies that require inactivation of pathogenic agents.

Development of the Inactivated QazCovid-in Vaccine: Protective Efficacy of the Vaccine in Syrian Hamsters

In March 2020, the first cases of the human coronavirus disease COVID-19 were registered in Kazakhstan. We isolated the SARS-CoV-2 virus from clinical materials from some of these patients. Subsequently, a whole virion inactivated candidate vaccine, QazCovid-in, was developed based on this virus. To develop the vaccine, a virus grown in Vero cell culture was used, which was inactivated with formaldehyde, purified, concentrated, sterilized by filtration, and then adsorbed on aluminum hydroxide gel particles. The formula virus and adjuvant in buffer saline solution were used as the vaccine. The safety and protective effectiveness of the developed vaccine were studied in Syrian hamsters. The results of the studies showed the absolute safety of the candidate vaccine in the Syrian hamsters. When studying the protective effectiveness, the developed vaccine with an immunizing dose of 5 μg/dose specific antigen protected animals from a wild homologous virus at a dose of 10⁴.⁵ TCID_50/mL. The candidate vaccine induced the formation of virus-neutralizing antibodies in vaccinated hamsters at titers of 3.3 ± 1.45 log2 to 7.25 ± 0.78 log2, and these antibodies were retained for 6 months (observation period) for the indicated titers. No viral replication was detected in vaccinated hamsters, protected against the development of acute pneumonia, and ensured 100% survival of the animals. Further, no replicative virus was isolated from the lungs of vaccinated animals. However, a virulent virus was isolated from the lungs of unvaccinated animals at relatively high titers, reaching 4.5 ± 0.7 log TCID₅₀/mL. After challenge infection, 100% of unvaccinated hamsters showed clinical symptoms (stress state, passivity, tousled coat, decreased body temperature, and body weight, and the development of acute pneumonia), with 25 ± 5% dying. These findings pave the way for testing the candidate vaccine in clinical human trials.

Characterization of Classical Vaccines by Charge Detection Mass Spectrometry

Vaccines induce immunity by presenting disease antigens through several platforms ranging from individual protein subunits to whole viruses. Due to the large difference in antigen size, the analytical techniques employed for vaccine characterization are often platform-specific. A single, robust analytical technique capable of widespread, cross-platform use would be of great benefit and allow for comparisons across manufacturing processes. One method that spans the antigen mass range is charge detection mass spectrometry (CDMS). CDMS is a single-ion approach where the mass-to-charge ratio (m/z) and charge are measured simultaneously, allowing accurate mass distributions to be measured for heterogeneous analytes over a broad size range. In this work, CDMS was used to characterize the antigens from three classical multivalent vaccines, inactivated poliomyelitis vaccine (IPOL), RotaTeq, and Gardasil-9, directly from commercial samples. For each vaccine, the antigen purity was inspected, and in the whole virus vaccines, empty virus particles were detected. For IPOL, information on the extent of formaldehyde cross-linking was obtained. RotaTeq shows a narrow peak at 61.06 MDa. This is at a slightly lower mass than expected for the double-layer particle, suggesting that around 10 pentonal trimers are missing. For Gardasil-9, buffer exchange of the vaccine resulted in very broad mass distributions. However, removal of the virus-like particles from the aluminum adjuvant using a displacement reaction generated a spectrum with narrow peaks.

Adjuvant effects of TLR agonist gardiquimod admixed with Leishmania vaccine in mice model of visceral leishmaniasis

Tropical and subtropical areas of the world are affected by leishmaniasis, which is caused by Leishmania spp. It has been categorized as an NTD (neglected tropical disease) because of its negligence. The sand fly of genus Phlebotomus acts as the vector for the transmission of the promastigote form of this protozoan parasite to the mammalian host where it converts to amastigote form in the macrophages. Visceral form of leishmaniasis (VL) is a deadly infection in the endothelial system of the human and other mammals. Only a few chemotherapeutic agents are available for the treatment of this infectious disease whereas no vaccine is available for the control of leishmanial infection. Therefore in the current study, we have tested the effects of gardiquimod (a TLR agonist) as an adjuvant in combination with the formalin-killed antigen of L. donovani as a vaccine. The mice were vaccinated thrice at an interval of 2 weeks and challenged with L. donovani promastigotes after 2 weeks of the last vaccination. We assessed the parasite load, delayed-type hypersensitivity (DTH) responses, humoral and cell-mediated immune response in BALB/c mice before and after challenge infection with L. donovani. Immunized mice were found to have the least parasite load, high DTH response, elevated levels of Th1 cytokines, IgG2a, and nitric oxide than non-immunized and infected control mice. The efficacy of the vaccine was boosted with the use of adjuvant gardiquimod that depicts its potential as an adjuvant in this study. Our study is reporting the adjuvant effects of gardiquimod for the first time. Further studies using other Leishmania species can be performed to signify its role.

In situ vaccine application of inactivated CPMV nanoparticles for cancer immunotherapy

Cowpea mosaic virus (CPMV) is currently in the development pipeline for multiple biomedical applications, including cancer immunotherapy. In particular the application of CPMV as in situ vaccine has shown promise; here the plant viral nanoparticle is used as an adjuvant and is injected directly into a tumor to reverse immunosuppression and prime systemic anti-tumor immunity. Efficacy of this CPMV-based cancer immunotherapy has been demonstrated in multiple tumor mouse models and canine cancer patients. However, while CPMV is non-infectious to mammals, it is infectious to legumes and therefore, from a safety perspective, it is desired to develop non-infectious CPMV formulations. Non-infectious virus-like particles of CPMV devoid of nucleic acids have been produced; nevertheless, efficacy of such empty CPMV nanoparticles does not match efficacy of nucleic acid-laden CPMV. The multivalent capsid activates the innate immune system through pathogen pattern recognition receptors (PRRs) such as toll-like receptors (TLRs); the RNA cargo provides additional signaling through TLR-7/8, which boosts the efficacy of this adjuvant. Therefore, in this study, we set out to develop RNA-laden, but non-infectious CPMV. We report inactivation of CPMV using UV light and chemical inactivation using β-propiolactone (βPL) or formalin. 7.5 J cm^-2 UV, 50 mM βPL or 1 mM formalin was determined to be sufficient to inactivate CPMV and prevented plant infection. We compared the immunogenicity of native CPMV and inactivated CPMV formulations in vitro and in vivo using RAW-Blue™ reporter cells and a murine syngeneic, orthotropic melanoma model (using B16F10 cells and C57BL6 mice). While the in vitro assay indicated activation of the RAW-Blue™ reporter cells by formaldehyde and UV-inactivated CPMV at levels comparable to native CPMV; βPL-inactivated CPMV appeared to have diminished activity. Tumor mouse model experiments indicate potent efficacy of the chemically-inactivated CPMV (UV-treated CPMV was not tested) leading to tumor regression and increased survival; efficacy was somewhat reduced when compared to CPMV, however these samples outperformed the empty CPMV nanoparticles. These results will facilitate the translational development of safe and potent CPMV-based cancer immunotherapies.

Adjuvanted vaccines driven protection against visceral infection in BALB/c mice by Leishmania donovani

Kinteoplastid protozoan parasite of genus Leishmania is the pathogen that causes leishmaniasis. Its prevalence is highest after malaria and visceral leishmaniasis is the most dreaded form of infection. No vaccine is available for the disease management and it relies wholly on a few chemotherapeutic agents which are toxic and besides drug resistance their costs are the limitations. Therefore, development of an effective vaccine is urgently required. In this study, Montanide ISA 201 and AddaVax were assessed for their adjuvant potential along with formalin-inactivated or killed vaccine for the immune induction. Immunological and parasitological studies were conducted to evaluate the efficacy of different vaccine formulations in BALB/c mice before challenge infection as well as 4, 8, and 12 weeks after challenge. The efficacy of vaccines was evidenced with reduced parasite burden, the higher DTH response, Th1 cytokines, and IgG2a isotype antibody in immunized mice. All the vaccines showed their potential against Leishmania donovani infection and vaccine formulated with Montanide ISA 201 exhibited maximum efficacy. Our results suggest the potential of these vaccine formulations in controlling Leishmania infection.

Revisiting respiratory syncytial virus's interaction with host immunity, towards novel therapeutics

Every year there are > 33 million cases of Respiratory Syncytial Virus (RSV)-related respiratory infection in children under the age of five, making RSV the leading cause of lower respiratory tract infection (LRTI) in infants. RSV is a global infection, but 99% of related mortality is in low/middle-income countries. Unbelievably, 62 years after its identification, there remains no effective treatment nor vaccine for this deadly virus, leaving infants, elderly and immunocompromised patients at high risk. The success of all pathogens depends on their ability to evade and modulate the host immune response. RSV has a complex and intricate relationship with our immune systems, but a clearer understanding of these interactions is essential in the development of effective medicines. Therefore, in a bid to update and focus our research community's understanding of RSV's interaction with immune defences, this review aims to discuss how our current knowledgebase could be used to combat this global viral threat.

In-Vitro Inactivation of Sabin-Polioviruses for Development of Safe and Effective Polio Vaccine

After years of global collaboration; we are steps away from a polio-free world. However, the currently conventional inactivated polio vaccine (cIPV) is suboptimal for the post eradication era. cIPV production cost and biosafety hazards hinder its availability and coverage of the global demands. Production of IPV from the attenuated Sabin strains (sIPV) was an ideal solution and scientists work extensively to perfect a safe, effective and affordable sIPV. This study investigated the ability of hydrogen peroxide (H₂O₂), ascorbic acid (AA) and epigallocatechin-3-gallate (EGCG) as alternatives for Formaldehyde (HCHO) to inactivate Sabin-polioviruses strains for sIPV production. Sabin-polioviruses vaccine strains were individually treated with AA, EGCG or H₂O₂ and were compared to HCHO. This was investigated by determination of the inactivation kinetics on HEP_2C cells, testing of D-antigen preservation by ELISA and the immune response in Wistar rats of the four vaccine preparations. H₂O₂, AA and EGCG were able to inactivate polioviruses within 24 h while HCHO required 96 h. Significant high D-antigen levels were observed using AA, EGCG and H₂O₂ compared to HCHO. Rat sera tested for neutralizing antibodies showed comparable results. These findings support the idea of using these inactivating agents as safe and time- saving alternatives for HCHO to produce sIPV.

Sanitizing agents for virus inactivation and disinfection

Viral epidemics develop from the emergence of new variants of infectious viruses. The lack of effective antiviral treatments for the new viral infections coupled with rapid community spread of the infection often result in major human and financial loss. Viral transmissions can occur via close human-to-human contact or via contacting a contaminated surface. Thus, careful disinfection or sanitization is essential to curtail viral spread. A myriad of disinfectants/sanitizing agents/biocidal agents are available that can inactivate viruses, but their effectiveness is dependent upon many factors such as concentration of agent, reaction time, temperature, and organic load. In this work, we review common commercially available disinfectants agents available on the market and evaluate their effectiveness under various application conditions. In addition, this work also seeks to debunk common myths about viral inactivation and highlight new exciting advances in the development of potential sanitizing agents.

Single B cells reveal the antibody responses of rhesus macaques immunized with an inactivated enterovirus D68 vaccine

Enterovirus D68 (EV-D68) infection may cause severe respiratory system manifestations in pediatric populations. Because of the lack of an effective preventive vaccine or specific therapeutic drug for this infection, the development of EV-D68-specific vaccines and antibodies has become increasingly important. In this study, we prepared an experimental EV-D68 vaccine inactivated by formaldehyde and found that the serum of rhesus macaques immunized with the inactivated EV-D68 vaccine exhibited potent neutralizing activity against EV-D68 virus in vitro. Subsequently, the antibody-mediated immune response of B cells elicited by the inactivated vaccine was evaluated in a rhesus monkey model. The binding activity, in vitro neutralization activity, and sequence properties of 28 paired antibodies from the rhesus macaques’ EV-D68-specific single memory B cells were analyzed, and the EV-D68 VP1-specific antibody group was found to be the main constituent in vivo. Intriguingly, we also found a synergistic effect among the E15, E18 and E20 monoclonal antibodies from the rhesus macaques. Furthermore, we demonstrated the protective efficacy of maternal antibodies in suckling C57BL/6 mice. This study provides valuable information for the future development of EV-D68 vaccines.

Comparison of purified psoralen-inactivated and formalin-inactivated dengue vaccines in mice and nonhuman primates

Dengue fever, caused by dengue viruses (DENV 1-4) is a leading cause of illness and death in the tropics and subtropics. Therefore, an effective vaccine is urgently needed. Currently, the only available licensed dengue vaccine is a chimeric live attenuated vaccine that shows varying efficacy depending on serotype, age and baseline DENV serostatus. Accordingly, a dengue vaccine that is effective in seronegative adults, children of all ages and in immunocompromised individuals is still needed. We are currently researching the use of psoralen to develop an inactivated tetravalent dengue vaccine. Unlike traditional formalin inactivation, psoralen inactivates pathogens at the nucleic acid level, potentially preserving envelope protein epitopes important for protective anti-dengue immune responses. We prepared highly purified monovalent vaccine lots of formalin- and psoralen-inactivated DENV 1-4, using Capto DeVirS and Capto Core 700 resin based column chromatography. Tetravalent psoralen-inactivated vaccines (PsIV) and formalin-inactivated vaccines (FIV) were prepared by combining the four monovalent vaccines. Mice were immunized with either a low or high dose of PsIV or FIV to evaluate the immunogenicity of monovalent as well as tetravalent formulations of each inactivation method. In general, the monovalent and tetravalent PsIVs elicited equivalent or higher titers of neutralizing antibodies to DENV than the FIV dengue vaccines and this response was dose dependent. The immunogenicity of tetravalent dengue PsIVs and FIVs were also evaluated in nonhuman primates (NHPs). Consistent with what was observed in mice, significantly higher neutralizing antibody titers for each dengue serotype were observed in the NHPs vaccinated with the tetravalent dengue PsIV compared to those vaccinated with the tetravalent dengue FIV, indicative of the importance of envelope protein epitope preservation during psoralen inactivation of DENV.

Development of Thermostable Lyophilized Sabin Inactivated Poliovirus Vaccine

Poliomyelitis is a highly contagious disease caused by the poliovirus. While the live attenuated OPV has been the vaccine of choice, a major concern is its ability to revert to a form that can cause paralysis, so-called vaccine-associated paralytic poliomyelitis. Therefore, the new endgame strategy of the Global Polio Eradication Initiative includes the introduction of an IPV. However, the feasibility of the use of current IPV formulations in developing countries is limited, because IPV is insufficiently stable to be purified, transported, and stored under unrefrigerated conditions. We successfully designed the sIPV for use in the dry state that maintains the full vaccine potency in animal models after incubation at ambient temperature. This report provides, for the first time, candidate formulations of sIPV that are stable at elevated temperatures.

As oral poliovirus vaccine (OPV) causes vaccine-associated paralytic poliomyelitis, the polio endgame strategy introduced by the Global Polio Eradication Initiative calls for a phased withdrawal of OPV and an introduction of inactivated poliovirus vaccine (IPV). The introduction of IPV creates challenges in maintaining the cold chain for vaccine storage and distribution. Recent advances in lyophilization have helped in finding a temperature-stable formulation for multiple vaccines; however, poliovirus vaccines have yet to capture a stable, safe formula for lyophilization. In addition, efficient in vitro methods for antigen measurement are needed for screening stable vaccine formulations. Here, we report size exclusion high-performance liquid chromatography (SE-HPLC) as a reliable means to identify the leading lyophilized formulation to generate thermostable Sabin inactivated poliovirus vaccine (sIPV). High-throughput screening and SE-HPLC determined the leading formulation, resulting in 95% D-antigen recovery and low residual moisture content of sIPV following lyophilization. Furthermore, the lyophilized sIPV remained stable after 4 weeks of incubation at ambient temperature and induced strong neutralizing antibodies and full protection of poliovirus receptor transgenic mice against the in vivo challenge of wild-type poliovirus. Overall, this report describes a novel means for the high-throughput evaluation of sIPV antigenicity and a thermostable lyophilized sIPV with in vivo vaccine potency.

Structural and immunologic correlates of chemically stabilized HIV-1 envelope glycoproteins

Inducing broad spectrum neutralizing antibodies against challenging pathogens such as HIV-1 is a major vaccine design goal, but may be hindered by conformational instability within viral envelope glycoproteins (Env). Chemical cross-linking is widely used for vaccine antigen stabilization, but how this process affects structure, antigenicity and immunogenicity is poorly understood and its use remains entirely empirical. We have solved the first cryo-EM structure of a cross-linked vaccine antigen. The 4.2 Å structure of HIV-1 BG505 SOSIP soluble recombinant Env in complex with a CD4 binding site-specific broadly neutralizing antibody (bNAb) Fab fragment reveals how cross-linking affects key properties of the trimer. We observed density corresponding to highly specific glutaraldehyde (GLA) cross-links between gp120 monomers at the trimer apex and between gp120 and gp41 at the trimer interface that had strikingly little impact on overall trimer conformation, but critically enhanced trimer stability and improved Env antigenicity. Cross-links were also observed within gp120 at sites associated with the N241/N289 glycan hole that locally modified trimer antigenicity. In immunogenicity studies, the neutralizing antibody response to cross-linked trimers showed modest but significantly greater breadth against a global panel of difficult-to-neutralize Tier-2 heterologous viruses. Moreover, the specificity of autologous Tier-2 neutralization was modified away from the N241/N289 glycan hole, implying a novel specificity. Finally, we have investigated for the first time T helper cell responses to next-generation soluble trimers, and report on vaccine-relevant immunodominant responses to epitopes within BG505 that are modified by cross-linking. Elucidation of the structural correlates of a cross-linked viral glycoprotein will allow more rational use of this methodology for vaccine design, and reveals a strategy with promise for eliciting neutralizing antibodies needed for an effective HIV-1 vaccine.

Biotechnological Applications of an Insect-Specific Alphavirus

The coupling of viral and arthropod host diversity, with evolving methods of virus discovery, has resulted in the identification and classification of a growing number of novel insect-specific viruses (ISVs) that appear to be evolutionarily related to many human pathogens but have either lost or have yet to gain the ability to replicate in vertebrates. The discovery of ISVs has raised many questions as to the origin and evolution of many human pathogenic viruses and points to the role that arthropods may play in this evolutionary process. Furthermore, the use of ISVs to control the transmission of arthropod-borne viruses has been proposed and demonstrated experimentally. Previously, our laboratory reported on the discovery and characterization of Eilat virus (EILV), an insect-specific alphavirus that phylogenetically groups within the mosquito-borne clade of medically relevant alphaviruses, including eastern equine encephalitis virus (EEEV) and Venezuelan equine encephalitis virus (VEEV), as well as chikungunya virus (CHIKV). Despite its evolutionary relationship to these human pathogens, EILV is unable to replicate in vertebrate cells due to blocks at attachment/entry and RNA replication. We recently demonstrated that, using a chimeric virus approach, EILV could be utilized as a platform for vaccine and diagnostic development, serving as a proof-of-concept for other ISVs. Due to the vast abundance of ISVs, there is an untapped resource for the development of vaccines and diagnostics for a variety of human pathogens and further work in this area is warranted.

Stabilized HIV-1 envelope glycoprotein trimers for vaccine use

Purpose of review

To provide an update on the latest developments in the field of HIV-1 antibody-based soluble envelope glycoprotein (Env) trimer design for vaccine use.

Recent findings

The development of soluble native-like HIV-1 Env trimer immunogens has moved the field of antibody-based vaccine design forward dramatically over the past few years with refinement of various stabilizing approaches. However, despite this progress, significant challenges remain. Firstly, although trimers are relatively stable in solution, they nevertheless sample different conformational states, some of which may be less relevant to binding and induction of broadly neutralizing antibodies (bNAbs). Secondly, these trimers expose unwanted immunodominant surfaces that may distract the adaptive immune response from recognizing more immunorecessive but conserved neutralization-relevant surfaces on the trimer. The availability of atomic-resolution structural information has allowed guided design of mutations that have further stabilized trimers and allowed reduced exposure of unwanted epitopes. Moreover, chemical cross-linking approaches that do not require structural information have also contributed to trimer stabilization and selection of particular conformational forms. However, current knowledge suggests that strategies additional to trimer stabilization will be required to elicit bNAb, including targeting naïve B cell receptors with specific immunogens, and guiding B cell lineages toward recognizing conserved surfaces on Env with high affinity.

Summary

This review will give a perspective on these challenges, and summarize current approaches to overcoming them with the aim of developing immunogens to elicit bNAb responses in humans by active vaccination.

Optimized production and purification of Coxsackievirus B1 vaccine and its preclinical evaluation in a mouse model

Coxsackie B viruses are among the most common enteroviruses, causing a wide range of diseases. Recent studies have also suggested that they may contribute to the development of type 1 diabetes. Vaccination would provide an effective way to prevent CVB infections, and the objective of this study was to develop an efficient vaccine production protocol for the generation of novel CVB vaccines. Various steps in the production of a formalin-inactivated Coxsackievirus B1 (CVB1) vaccine were optimized including the Multiplicity Of Infection (MOI) used for virus amplification, virus cultivation time, type of cell growth medium, virus purification method and formulation of the purified virus. Safety and immunogenicity of the formalin inactivated CVB1 vaccine was characterized in a mouse model. Two of the developed methods were found to be optimal for virus purification: the first employed PEG-precipitation followed by gelatin-chromatography and sucrose cushion pelleting (three-step protocol), yielding 19-fold increase in virus concentration (0.06µg/cm²) as compared to gold standard method. The second method utilized tandem sucrose pelleting without a PEG precipitation step, yielding 83-fold increase in virus concentration (0.24µg/cm²), but it was more labor-intensive and cannot be efficiently scaled up. Both protocols provide radically higher virus yields compared with traditional virus purification protocols involving PEG-precipitation and sucrose gradient ultracentrifugation. Formalin inactivation of CVB1 produced a vaccine that induced a strong, virus-neutralizing antibody response in vaccinated mice, which protected against challenge with CVB1 virus. Altogether, these results provide valuable information for the development of new enterovirus vaccines.

A chikungunya fever vaccine utilizing an insect-specific virus platform

Traditionally, vaccine development involves tradeoffs between immunogenicity and safety. Live-attenuated vaccines typically offer rapid and durable immunity but have reduced safety when compared to inactivated vaccines. In contrast, the inability of inactivated vaccines to replicate enhances safety at the expense of immunogenicity, often necessitating multiple doses and boosters. To overcome these tradeoffs, we developed the insect-specific alphavirus, Eilat virus (EILV), as a vaccine platform. To address the chikungunya fever (CHIKF) pandemic, we used an EILV cDNA clone to design a chimeric virus containing the chikungunya virus (CHIKV) structural proteins. The recombinant EILV/CHIKV was structurally identical at 10 Å to wild-type CHIKV, as determined by single-particle cryo-electron microscopy, and it mimicked the early stages of CHIKV replication in vertebrate cells from attachment and entry to viral RNA delivery. Yet the recombinant virus remained completely defective for productive replication, providing a high degree of safety. A single dose of EILV/CHIKV produced in mosquito cells elicited rapid (within 4 d) and long-lasting (>290 d) neutralizing antibodies that provided complete protection in two different mouse models. In nonhuman primates, EILV/CHIKV elicited rapid and robust immunity that protected against viremia and telemetrically monitored fever. Our EILV platform represents the first structurally native application of an insect-specific virus in preclinical vaccine development and highlights the potential application of such viruses in vaccinology.

Pre-fusion F is absent on the surface of formalin-inactivated respiratory syncytial virus

The lack of a licensed vaccine for respiratory syncytial virus (RSV) can be partly attributed to regulatory hurdles resulting from vaccine enhanced respiratory disease (ERD) subsequent to natural RSV infection that was observed in clinical trials of formalin-inactivated RSV (FI-RSV) in antigen-naïve infants. To develop an effective vaccine that does not enhance RSV illness, it is important to understand how formalin and heat inactivation affected the antigenicity and immunogenicity of FI-RSV compared to native virus. Informed by atomic structures of RSV fusion (F) glycoprotein in prefusion (pre-F) and postfusion (post-F) conformations, we demonstrate that FI-RSV predominately presents post-F on the virion surface, whereas infectious RSV presents both pre-F and post-F conformations. This significant antigenic distinction has not been previously appreciated. Thus, a stabilized pre-F antigen is more representative of live RSV than F in its post-F conformation, as displayed on the surface of FI-RSV. This finding has major implications for discriminating current pre-F-based immunogens from FI-RSV used in historical vaccine trials.

Practical aspects in the use of passive immunization as an alternative to attenuated viral vaccines

Passive immunization as a method to protect birds has been tested for many years and shown to be effective. Its advantages over active vaccination include no use of partially virulent viruses, overcoming the gap in the level of protection at young age due to interference of maternal antibodies to raise self-immune response following active vaccination and the possible immunosuppressive effect of attenuated vaccine viruses. However, a major obstacle to its implementation is its relatively high cost which is dependent, among other things, mainly on two factors: the efficacy of antibody production, and the use of specific pathogen-free (SPF) birds for antibody production to avoid the possible transfer of pathogens from commercial layers. In this study we show efficient production of immunoglobulin Y (IgY) against four different pathogens simultaneously in the same egg, and treatment of the extracted IgY with formalin to negate the need for SPF birds. Formalin, a common registered sterilization compound in vaccine production, was shown not to interfere with the Fab specific antigen binding or Fc-complement activation of the antibody. Following injection of 1-day-old broilers with antibodies against infectious bursal disease virus, protective antibody levels were acquired for the entire period of sensitivity to this pathogen (35 days). Passive vaccination with formalin-sterilized IgY against multiple antigens extracted from one commercial egg may be a cost-effective and advantageous complementary or alternative to attenuated vaccines in poultry.

Validation of γ-radiation and ultraviolet as a new inactivators for foot and mouth disease virus in comparison with the traditional methods

AIM

The present work deals with different methods for foot and mouth disease virus (FMDV) inactivation for serotypes O/pan Asia, A/Iran05, and SAT-2/2012 by heat, gamma radiation, and ultraviolet (UV) in comparison with the traditional methods and their effects on the antigenicity of viruses for production of inactivated vaccines.

MATERIALS AND METHODS

FMDV types O/pan Asia, A/Iran05, and SAT-2/2012 were propagated in baby hamster kidney 21 (BHK21) and titrated then divided into five parts; the first part inactivated with heat, the second part inactivated with gamma radiation, the third part inactivated with UV light, the fourth part inactivated with binary ethylamine, and the last part inactivated with combination of binary ethylamine and formaldehyde (BEI+FA). Evaluate the method of inactivation via inoculation in BHK21, inoculation in suckling baby mice and complement fixation test then formulate vaccine using different methods of inactivation then applying the quality control tests to evaluate each formulated vaccine.

RESULTS

The effect of heat, gamma radiation, and UV on the ability of replication of FMDV "O/pan Asia, A/Iran05, and SAT-2/2012" was determined through BHK cell line passage. Each of the 9 virus aliquots titer 10(8) TCID50 (3 for each strain) were exposed to 37, 57, and 77°C for 15, 30, and 45 min. Similarly, another 15 aliquots (5 for each strain) contain 1 mm depth of the exposed samples in petri-dish was exposed to UV light (252.7 nm wavelength: One foot distance) for 15, 30, 45, 60, and 65 min. Different doses of gamma radiation (10, 20, 25, 30, 35, 40, 45, 50, 55, and 60 KGy) were applied in a dose rate 0.551 Gy/s for each strain and repeated 6 times for each dose. FMDV (O/pan Asia, A/Iran05, and SAT-2/2012) were inactivated when exposed to heat ≥57°C for 15 min. The UV inactivation of FMDV (O/pan Asia and SAT-2) was obtained within 60 min and 65 min for type A/Iran05. The ideal dose for inactivation of FMDV (O/pan Asia, A/Iran05, and SAT-2/2012) with gamma radiation were 55-60 and 45 kGy, respectively. Inactivation of FMDV with binary was 20, 24 and 16 hr for O/pan Asia, A/Iran05, and SAT-2/2012, respectively while inactivation by (BEI+FA) was determined after 18, 19 and 11 hr for O/pan-Asia, A/Iran 05, and SAT-2/2012, respectively. The antigenicity of control virus before inactivation was 1/32, it was not changed after inactivation in case of gamma radiation and (BEI+FA) and slightly decrease to 1/16 in case of binary and declined to 1/2, 1/4 in case of heat and UV inactivation, respectively. The immune response induced by inactivated FMD vaccines by gamma radiation and (BEI+FA) lasted to 9 months post-vaccination, while the binary only still up to 8 months post-vaccination but heat and UV-inactivated vaccines were not effective.

CONCLUSION

Gamma radiation could be considered a good new inactivator inducing the same results of inactivated vaccine by binary with formaldehyde (BEI+FA).

Recent Progress towards Novel EV71 Anti-Therapeutics and Vaccines

Enterovirus 71 (EV71) is a group of viruses that belongs to the Picornaviridae family, which also includes viruses such as polioviruses. EV71, together with coxsackieviruses, is widely known for its association with Hand Foot Mouth Disease (HFMD), which generally affects children age five and below. Besides HFMD, EV71 can also trigger more severe and life-threatening neurological conditions such as encephalitis. Considering the lack of a vaccine and antiviral drug against EV71, together with the increasing spread of these viruses, the development of such drugs and vaccines becomes the top priority in protecting our younger generations. This article, hence, reviews some of the recent progress in the formulations of anti-therapeutics and vaccine generation for EV71, covering (i) inactivated vaccines; (ii) baculovirus-expressed vaccines against EV71; (iii) human intravenous immunoglobulin (IVIg) treatment; and (iv) the use of monoclonal antibody therapy as a prevention and treatment for EV71 infections.

Psoralen Inactivation of Viruses: A Process for the Safe Manipulation of Viral Antigen and Nucleic Acid

High consequence human pathogenic viruses must be handled at biosafety level 2, 3 or 4 and must be rendered non-infectious before they can be utilized for molecular or immunological applications at lower biosafety levels. Here we evaluate psoralen-inactivated Arena-, Bunya-, Corona-, Filo-, Flavi- and Orthomyxoviruses for their suitability as antigen in immunological processes and as template for reverse transcription PCR and sequencing. The method of virus inactivation using a psoralen molecule appears to have broad applicability to RNA viruses and to leave both the particle and RNA of the treated virus intact, while rendering the virus non-infectious.

Formalin Inactivation of Japanese Encephalitis Virus Vaccine Alters the Antigenicity and Immunogenicity of a Neutralization Epitope in Envelope Protein Domain III

Formalin-inactivated Japanese encephalitis virus (JEV) vaccines are widely available, but the effects of formalin inactivation on the antigenic structure of JEV and the profile of antibodies elicited after vaccination are not well understood. We used a panel of monoclonal antibodies (MAbs) to map the antigenic structure of live JEV virus, untreated control virus (UCV), formalin-inactivated commercial vaccine (FICV), and formalin-inactivated virus (FIV). The binding activity of T16 MAb against Nakayama-derived FICV and several strains of FIV was significantly lower compared to live virus and UCV. T16 MAb, a weakly neutralizing JEV serocomplex antibody, was found to inhibit JEV infection at the post-attachment step. The T16 epitope was mapped to amino acids 329, 331, and 389 within domain III (EDIII) of the envelope (E) glycoprotein. When we explored the effect of formalin inactivation on the immunogenicity of JEV, we found that Nakayama-derived FICV, FIV, and UCV all exhibited similar immunogenicity in a mouse model, inducing anti-JEV and anti-EDII 101/106/107 epitope-specific antibodies. However, the EDIII 329/331/389 epitope-specific IgG antibody and neutralizing antibody titers were significantly lower for FICV-immunized and FIV-immunized mouse serum than for UCV-immunized. Formalin inactivation seems to alter the antigenic structure of the E protein, which may reduce the potency of commercially available JEV vaccines. Virus inactivation by H₂O₂, but not by UV or by short-duration and higher temperature formalin treatment, is able to maintain the antigenic structure of the JEV E protein. Thus, an alternative inactivation method, such as H₂O₂, which is able to maintain the integrity of the E protein may be essential to improving the potency of inactivated JEV vaccines.

We demonstrated that formalin inactivation of Japanese encephalitis virus (JEV) alters the antigenic structure of the JEV envelope glycoprotein (E), in particular an epitope in domain III, and that this reduces the ability of the inactivated vaccine to elicit protective neutralizing antibodies. Ours and others’ previous studies have highlighted the importance of improving the immunogenicity of genotype III (GIII)-derived JEV vaccine in order to provide cross-protection against genotype I (GI) viruses, which are emerging and replacing GIII viruses in many JEV-endemic regions. Encouraging the wide use of live-attenuated or chimeric vaccines, such as SA14-14-2 or yellow-fever 17D/JEV vaccines, respectively, developing GI virus-derived inactivated or premembrane/E–containing, noninfectious virus-like particle (VLP) vaccines are two other possible ways to address this potential problem. In this exploratory study, we highlight an alternative inactivation method, such as H₂O₂ treatment, which may improve the antigenic stability and immunogenicity of JEV.

Twenty-Eight Years of Poliovirus Replication in an Immunodeficient Individual: Impact on the Global Polio Eradication Initiative

There are currently huge efforts by the World Health Organization and partners to complete global polio eradication. With the significant decline in poliomyelitis cases due to wild poliovirus in recent years, rare cases related to the use of live-attenuated oral polio vaccine assume greater importance. Poliovirus strains in the oral vaccine are known to quickly revert to neurovirulent phenotype following replication in humans after immunisation. These strains can transmit from person to person leading to poliomyelitis outbreaks and can replicate for long periods of time in immunodeficient individuals leading to paralysis or chronic infection, with currently no effective treatment to stop excretion from these patients. Here, we describe an individual who has been excreting type 2 vaccine-derived poliovirus for twenty eight years as estimated by the molecular clock established with VP1 capsid gene nucleotide sequences of serial isolates. This represents by far the longest period of excretion described from such a patient who is the only identified individual known to be excreting highly evolved vaccine-derived poliovirus at present. Using a range of in vivo and in vitro assays we show that the viruses are very virulent, antigenically drifted and excreted at high titre suggesting that such chronic excreters pose an obvious risk to the eradication programme. Our results in virus neutralization assays with human sera and immunisation-challenge experiments using transgenic mice expressing the human poliovirus receptor indicate that while maintaining high immunisation coverage will likely confer protection against paralytic disease caused by these viruses, significant changes in immunisation strategies might be required to effectively stop their occurrence and potential widespread transmission. Eventually, new stable live-attenuated polio vaccines with no risk of reversion might be required to respond to any poliovirus isolation in the post-eradication era.

The global polio eradication initiative is the most ambitious and complex public health programme directed at a single disease in history with a projected cost of $16.5 billion. Of the three serotypes types 2 and 3 appear to have been eradicated in the wild and type 1 is mostly confined to a region of Pakistan and Afghanistan. There is a real probability of total eradication in the near future. The main vaccine used is a live attenuated virus, and our paper concerns one of the most intractable significant implications that this has for the polio endgame. We describe virological studies of a patient deficient in humoral immunity who has been excreting type 2 vaccine-derived poliovirus for 28 years. Our results show that the viruses are excreted at high titres, extremely virulent and antigenically drifted and raise questions about how the population may best be protected from them, particularly in the light of possible changes in vaccine production which are being encouraged to increase capability and reduce costs. The study has implications for the ecology of poliovirus in the human gut and highlights the risks that such vaccine-derived isolates pose for polio re-emergence in the post-eradication era.

High resolution identity testing of inactivated poliovirus vaccines

•

Identity testing is a critical step in the quality control process.

•

Serological testing is the current approved method, but has certain limitations.

•

Existing molecular methods (qPCR) provide information about small genomic regions.

•

Random amplification and shotgun sequencing provide full genome coverage.

•

Distinction of highly similar viruses, and manufacturer-specific differences is possible.

Background

Definitive identification of poliovirus strains in vaccines is essential for quality control, particularly where multiple wild-type and Sabin strains are produced in the same facility. Sequence-based identification provides the ultimate in identity testing and would offer several advantages over serological methods.

Methods

We employed random RT-PCR and high throughput sequencing to recover full-length genome sequences from monovalent and trivalent poliovirus vaccine products at various stages of the manufacturing process.

Results

All expected strains were detected in previously characterised products and the method permitted identification of strains comprising as little as 0.1% of sequence reads. Highly similar Mahoney and Sabin 1 strains were readily discriminated on the basis of specific variant positions. Analysis of a product known to contain incorrect strains demonstrated that the method correctly identified the contaminants.

Conclusion

Random RT-PCR and shotgun sequencing provided high resolution identification of vaccine components. In addition to the recovery of full-length genome sequences, the method could also be easily adapted to the characterisation of minor variant frequencies and distinction of closely related products on the basis of distinguishing consensus and low frequency polymorphisms.