Sulfur concentration in diets containing corn, soybean meal, and distillers dried grains with solubles does not affect feed preference or growth performance of weanling or growing-finishing pigs

Review: Aspects of digestibility and requirements for minerals and vitamin D by growing pigs and sows

Some of the biggest changes in mineral nutrition for pigs that have occurred due to recent research were caused by the understanding that there is a loss of endogenous Ca and P into the intestinal tract of pigs. This resulted in development of the concept of formulating diets based on standardized total tract digestibility (STTD) rather than apparent total tract digestibility because the values for STTD of these minerals are additive in mixed diets. There are, however, no recent summaries of research on digestibility and requirements of macro- and microminerals and vitamin D for pigs. Therefore, the objective of this review was to summarize selected results of research conducted over the last few decades to determine the digestibility and requirements of some minerals and vitamin D fed to sows and growing pigs. Benefits of microbial phytase in terms of increasing the digestibility of most minerals have been demonstrated. Negative effects on the growth performance of pigs of over-feeding Ca have also been demonstrated, and frequent analysis of Ca in complete diets and raw materials is, therefore, recommended. There is no evidence that current requirements for vitamin D for weanling or growing-finishing pigs are not accurate, but it is possible that gestating and lactating sows need more vitamin D than currently recommended. Vitamin D analogs and metabolites such as 1(OH)D3 and 25(OH)D3 have beneficial effects when added to diets for sows in combination with vitamin D3. Recent research on requirements for macrominerals other than Ca and P is scarce, but it is possible that Mg in diets containing low levels of soybean meal is marginal. Some of the chelated microminerals have increased digestibility compared with sulfate forms, and hydroxylated forms of Cu and Zn appear to be superior to sulfate or oxide forms. Likewise, dicopper oxide and Cu methionine hydroxy analog have a greater positive effect on the growth performance of growing pigs than copper sulfate. The requirement for Mn may need to be increased whereas there appears to be no benefits of providing Fe above current requirements. In conclusion, diets for pigs should be formulated based on values for STTD of Ca and P and there are negative effects of providing excess Ca in diets. It is possible vitamin D analogs and metabolites offer benefits over vitamin D3 in diets for sows. Likewise, chelated forms of microminerals or chemical forms of minerals other than sulfates or oxides may result in improved pig performance.

Growth performance and carcass quality are not different between pigs fed diets containing cold-fermented low-oil DDGS and pigs fed conventional DDGS, but pelleting improves gain to feed ratio regardless of source of DDGS

The objective of this study was to test the hypothesis that growth performance and carcass characteristics of pigs fed diets containing cold-fermented, low oil distillers dried grains with solubles (DDGS) is not different from that of pigs fed diets containing conventional DDGS regardless of the physical form of the diets. A total of 160 barrows and gilts were used. There were 4 diets, 10 pens per diet, and 4 pigs per pen. Pigs were weaned at 21 d of age and fed a common phase 1 diet that did not contain DDGS during the initial 7 d post-weaning. Pigs were then allotted to the four diets that were arranged in a 2 × 2 factorial design with two sources of DDGS (cold-fermented and conventional DDGS) and two diet forms (meal and pellets). Pigs were fed phase 2 diets from day 7 to 21 and phase 3 diets from day 21 to 43 post-weaning. All diets were based on corn and soybean meal, but phase 2 diets also contained 15% DDGS and phase 3 diets contained 30% DDGS. From day 43, pigs were fed grower diets for 38 d, early finisher diets for 38 d, and late finisher diets for 18 d and these diets also contained 30% DDGS. Feed was provided on an ad libitum basis and daily feed allotments were recorded. Pigs were weighed at the beginning of each phase and at the conclusion of the experiment. On the last day of the experiment, the pig in each pen with a body weight that was closest to the pen average was slaughtered and carcass measurements were determined. Combined results for the two nursery phases indicated that feeding meal diets instead of pelleted diets increased (P < 0.001) average daily feed intake and decreased (P < 0.05) gain to feed ratio (G:F). However, no differences between the two sources of DDGS were observed for the overall growth performance of weanling pigs. For the entire growing-finishing period, the source of DDGS did not affect growth performance, but pigs fed meal diets had reduced (P < 0.001) G:F compared with pigs fed the pelleted diets. There were no differences between the two sources of DDGS for carcass characteristics. Back fat was greater (P < 0.05) for pigs fed pelleted diets than for pigs fed meal diets. In conclusion, no differences in growth performance or carcass characteristics between pigs fed cold-fermented DDGS and pigs fed conventional DDGS were observed. However, pigs fed pelleted diets had greater G:F and greater back fat than pigs fed meal diets.

Maize distillers dried grains with solubles alter dietary digestibility and improve intestine health of pacu, Piaractus mesopotamicus juveniles

Two trials were conducted to evaluate the effects of soyabean meal replacement by maize distillers dried grains with solubles (DDGS) in diets for pacu juveniles. Five diets were formulated with 0, 100, 200, 300 and 400 g of DDGS/kg diet replacing up to total dietary soyabean meal. In trial 1, the experimental diets were fed to five groups of fish to evaluate the apparent digestibility coefficients (ADC). In trial 2, four groups of fish were fed each experimental diet for 100 d to evaluate the effects of these diets on digestive enzyme activity, intestine oxidative stress and intestine morphology. The ADC of DM and energy was reduced with dietary DDGS inclusion, while the ADC of lipids was increased, and no differences were observed for the ADC of protein. Independent of dietary treatment, pH increased from anterior to the distal intestine with dietary DDGS inclusion. Digestive enzyme activities were higher on anterior than the distal intestine. Dietary DDGS decreased lipase, amylase, chymotrypsin and trypsin activities, while no differences were observed for total protease activity. Intestine glucose-6-phosphate dehydrogenase was reduced in fish fed the DDGS diets, while catalase activity increased. Lipid peroxidation was lower in fish fed DDGS diets than the control. Intestine histomorphology improved with dietary DDGS inclusion. Overall, the negative effects of soyabean meal could be decreased by dietary replacement with maize DDGS which may have a prebiotic effect, improving intestine health.

Swine diets impact manure characteristics and gas emissions: Part II sulfur source

Sulfur is a key nutrient in swine diets and is associated with hydrogen sulfide (H₂S) emissions, odor, and respiratory distress of animals. Due to potential increases in S levels in swine diets by using alternative feedstuffs, a feeding trial study was conducted to determine the effect of dietary S source has on manure slurry chemical properties and gas emissions. A total of 24 gilts averaging 139 kg BW were fed a control diet formulated with corn and soybean meal (CSBM) containing 1.80 g S kg^-1 or diets containing 3.50 g S kg^-1 feed as supplied by calcium sulfate (CaSO₄), distillers dried grains with solubles (DDGS), or feather meal (CFM). Diets were fed for 41 d with an ADFI of 2.70 kg/d. Feces and urine were collected twice daily after each feeding and added to the manure storage containers. At the end of the study, manure slurries were monitored for gas emissions and chemical properties. Dietary S source had a significant effect on excretion of DM, C, N, and S in manure. Pigs fed the diets containing DDGS had significantly higher levels of NH₃, VFAs, and phenols in manure compared to pigs fed the CSBM diet. Pigs fed diets with organic S (i.e., DDGS and CFM) had lower emissions of H₂S compared to pigs fed the diet with inorganic sulfur (CaSO₄). In contrast, there were no significant differences in C or N emissions as affected by dietary treatment. Odor and odorant emissions differed by dietary treatment, with pigs fed the CFM diet having the highest odor emissions as compared to pigs fed the control CSBM diet. Pigs fed diets containing CFM and DDGS had a greater percentage of their chemical odor associated with volatile organic compounds while animals fed the CSBM diet or the diet with CaSO₄ had greater percentage associated with H₂S emissions.

Swine diets impact manure characteristics and gas emissions: Part I sulfur level

Sulfur is an essential nutrient for animal growth but is also associated with odor and morbidity of animals from swine operations. A study was conducted to determine the effects of increasing dietary S levels in swine diets on DM, pH, C, N, S, VFA, indole, and phenol concentrations in the manure, and on the emissions of C-, N-, and S-containing gases. A total of 24 gilts averaging 152 kg BW were fed diets containing 0.19, 0.30, 0.43, or 0.64% dietary S, as supplied by CaSO₄, for 31 d, with an ADFI of 3.034 kg d^-1. Feces and urine were collected after each feeding and added to manure storage containers. At the end of the study, manure slurries were monitored for gas emissions and chemical properties. Increasing dietary S lowered manure pH by 0.3 units and increased DM, N, and S by 10% for each 1.0 g S increase kg^-1 feed intake. Increased dietary S increased NH₃, sulfide, butanoic, and pentanoic acid concentrations in manure. Carbon and N emissions were not significantly impacted by dietary S, but S emissions in the form of hydrogen sulfide (H₂S) increased by 8% for each 1.0 g S increase kg^-1 feed intake. Odor increased by 2% for each 1.0 g increase of S consumed kg^-1 feed intake. Phenolic compounds and H₂S were the major odorants emitted from manure that increased with increasing dietary S.

Digestibility of amino acids, energy, acid hydrolyzed ether extract, and neutral detergent fiber, and concentration of digestible and metabolizable energy in low-oil distillers dried grains with solubles fed to growing pigs

Two experiments were conducted to test the hypothesis that digestibility of amino acids (AA), gross energy (GE), acid hydrolyzed ether extract (AEE), and neutral detergent fiber (NDF), and values for metabolizable energy (ME) in low-oil distillers dried grains with solubles (DDGS) vary among suppliers. In Exp. 1, the apparent total tract digestibility (ATTD) of GE, AEE, and NDF, and concentration of ME were determined in eight sources of DDGS (sources A, B, C, D, E, G, H, and I). A corn-based basal diet and eight diets containing corn and each source of DDGS were fed to 72 barrows (initial body weight = 18.1 ± 1.3 kg) with eight pigs per diet. Feces and urine were collected for 5 d after 7 d of adaptation. The ME did not differ among the eight sources of DDGS with the exception that DDGS source E contained less (P < 0.05) ME than DDGS source D. The ATTD of GE did also not differ among the eight sources of DDGS, but ME and ATTD of GE in corn were greater (P < 0.05) than in the eight sources of DDGS. However, the ATTD of AEE in corn and the eight sources of DDGS was not different, but the ATTD of AEE in DDGS source E was greater (P < 0.05) than in DDGS source A. The ATTD of NDF in DDGS source D was also greater (P < 0.05) than in DDGS sources E, G, and H, but ATTD of NDF did not differ between corn and the eight sources of DDGS. In Exp. 2, standardized ileal digestibility (SID) of AA was determined in seven sources of DDGS (sources A, B, C, D, E, G, and H). Twenty-four barrows (initial body weight = 63.4 ± 3.4 kg) that had a T-cannula installed in the distal ileum were allotted to a two-period incomplete Latin square design with eight diets. Seven diets were formulated to contain each of the seven sources of DDGS and an N-free diet was also used. Ileal digesta were collected for 2 d after 5 d of adaptation. There were no differences between pigs fed DDGS sources A and B in SID of AA, and the SID of Lys, Met, and Trp did not differ among DDGS sources A, B, and E. However, SID of most indispensable and dispensable AA except Gly were greater (P < 0.05) in DDGS source B than in DDGS sources C, D, E, G, and H. In conclusion, variability in SID of AA, ATTD of NDF and AEE, and ME were observed among the sources of DDGS used in this experiment.

Feed preference of weaned pigs fed diets containing soybean meal, Brassica napus canola meal, or Brassica juncea canola meal

Brassica napus and Brassica juncea canola meal (CM) may replace soybean meal (SBM) in pig diets, but differ in fiber, glucosinolates content and profile. Preference of weaned pigs provided double-choice selections to diets containing 20% SBM, B. napus CM, or B. juncea CM was evaluated in two studies. In experiment 1, 216 pigs (9.4 ± 1.6 kg initial BW) were housed in 27 pens of 8 pigs (four gilts and four barrows). In experiment 2, 144 pigs (8.9 ± 1.1 kg) were housed in 36 pens of 4 pigs (two gilts and two barrows). Pigs were offered three dietary choices: B. napus CM with SBM as reference (B. napus CM [SBM]), B. juncea CM with SBM as reference (B. juncea CM [SBM]), and B. juncea CM with B. napus CM as reference (B. juncea CM [B. napus CM]) in a replicated 3 × 3 Latin square. Diets were formulated to provide 2.4 Mcal NE/kg and 4.5 g standardized ileal digestible Lys/Mcal NE and were balanced using canola oil and crystalline AA. Each pair of diets was offered in two self-feeders per pen as mash (experiment 1) or pellets (experiment 2) during three test-periods of 4-d, followed by a 3-d non-test period when a common diet was offered in both feeders. Feeders with different diets were rotated daily among pens during preference periods for both experiments, and feeder positions (right or left) were switched daily in experiment 2. Prior to the study and between periods, pigs were fed non-test diets containing SBM (experiment 1) or without test feedstuffs (experiment 2). Overall in both experiments, pigs preferred (P < 0.001) SBM over B. napus and B. juncea CM diets, and preferred (P < 0.001) B. napus over B. juncea CM diet. Dietary choice did not affect (P > 0.05) growth performance in both experiments, except for greater G:F (P < 0.05) for pigs fed the B. juncea CM [B. napus CM] diets than pigs fed the B. napus CM [SBM] or B. juncea CM [SBM] diets in experiment 1. In conclusion, weaned pigs preferred SBM over CM diets when given a choice, and preferred B. napus over the B. juncea diet that contained more total glucosinolates especially gluconapin. Weaned pigs fed the B. juncea CM [B. napus CM] diets in the double-choice selection did not reduce feed intake, weight gain, and G:F compared to pigs fed the B. napus CM [SBM] or B. juncea CM [SBM] diets.

Effects of a 3 strain -based direct-fed microbial and dietary fiber concentration on growth performance and expression of genes related to absorption and metabolism of volatile fatty acids in weanling pigs

Effects of a -based direct-fed microbial (DFM) on growth performance, plasma tumor necrosis factor ɑ (TNFɑ), relative gene expression, and intestinal VFA concentrations in weanling pigs fed low- or high-fiber diets were evaluated. Two hundred pigs (initial BW: 6.31 ± 0.73 kg) were allotted to 1 of 4 dietary treatments (5 pigs per pen and 10 pens per treatment). Treatments were arranged in a 2 × 2 factorial design with 2 diet types [low-fiber (LF) or high-fiber (HF)] and 2 concentrations of DFM (0 or 60 g DFM/t of feed). The DFM contained 1.5 × 10 cfu/g and was obtained from Danisco Animal Nutrition-DuPont Industrial Biosciences, Marlborough, UK. Phase 1 diets were fed for 2 wk post-weaning and phase 2 diets were fed over the following 29 d. Low fiber diets contained corn and soybean meal as main ingredients and HF diets contained corn, soybean meal, corn distillers dried grains with solubles (7.5 and 15.0% in phase 1 and 2, respectively), and wheat middlings (10.0%). Pigs and feed were weighed at the start and at the end of each phase, and ADG, ADFI, and G:F were calculated. At the conclusion of phase 2, blood was collected from 1 pig per pen and 1 pig per pen was sacrificed. Cecum and rectum contents were analyzed for VFA, and tissue samples were collected from the ileum, cecum, rectum, and liver to determine expression of genes related to absorption and metabolism of VFA using quantitative reverse transcription-PCR. Results indicated that feeding HF diets reduced ( ≤ 0.05) ADFI and ADG of pigs compared with feeding LF diets. Pigs fed DFM diets had improved ( ≤ 0.05) G:F compared with pigs fed non-DFM diets. Pigs fed LF diets had greater ( ≤ 0.05) BW at the end of phase 2 compared with pigs fed HF diets. The concentration of VFA in rectum contents was greater ( ≤ 0.05) in pigs fed LF diets than in pigs fed HF diets. The expression of in the rectum of pigs fed HF diets was greater ( ≤ 0.05) than for pigs fed LF diets, and pigs fed DFM-containing diets had an increased ( ≤ 0.05) expression of in the liver. Pigs fed HF diets had greater ( ≤ 0.05) concentrations of urea N in plasma compared with pigs fed LF diets, but dietary fiber and DFM had no effect on plasma concentration of TNF-ɑ. In conclusion, the -based DFM improved overall G:F of weanling pigs, but pigs fed LF diets had greater final BW than pigs fed HF diets.

Effects of corn distillers dried grains with solubles on performance, oxidative status, intestinal immunity and meat quality of Chinese Yellow broilers

The study assessed the effects of different dietary levels of corn distillers dried grains with solubles (DDGS) on performance, oxidation status, intestinal immunity and meat quality in Chinese Yellow broilers aged from 1 to 63 days. Lingnan male hatchings (1440) were randomly assigned to six treatments, each consisting of six replicates of 40 birds. The basal diet (I) was a typical corn-soya bean ration while the experimental diets (II to VI) partially substituted corn DDGS for soya bean meal. The level of substitution in starter, grower and finisher diets was as follows: II, 2%, 4% then 6%; III, 4%, 8% then 12%; IV, 6%, 12% then 18%; V, 8%, 16% then 24%; VI, 10%, 20% then 30%. Average daily feed intake and feed-to-gain ratio increased as linear responses to corn DDGS substitution from 1 to 21 days (p < 0.001). The plasma content of triglycerides and liver content of malondialdehyde increased as linear responses to corn DDGS substitution (p < 0.05). There was a linear decrease (p < 0.001) in jejunal abundance of IL-6 transcripts, with a substantial reduction to approximately 25% those of broilers fed the control diet, and a quadratic effect existed for secretory immunoglobulin A (sIgA) (p < 0.001). In addition, increased dietary corn DDGS caused favourable changes in selected functional properties of the meat: drip loss at 24 and 96 h increased as linear response to corn DDGS substitution (p < 0.001). Further, meat colour L* values decreased and a* values increased linearly in response to increasing corn DDGS (p < 0.05). In conclusion, diet IV (6%, 12% then 18% corn DDGS) in Chinese Yellow broiler diets had no negative effects on performance, antioxidant capacity and meat quality. This level of inclusion also appeared to promote sIgA secretion and enhance anti-inflammatory status.

The Role of Biofuels Coproducts in Feeding the World Sustainably

One of the grand challenges facing our society today is finding solutions for feeding the world sustainably. The food-versus-fuel debate is a controversy embedded in this challenge, involving the trade-offs of using grains and oilseeds for biofuels production versus animal feed and human food. However, only 6% of total global grain produced is used to produce ethanol. Furthermore, biofuels coproducts contribute to sustainability of food production because only 1% to 2.5% of the overall energy efficiency is lost from converting crops into biofuels and animal feed, and approximately one-third of the corn used to produce ethanol is recovered as feed coproducts. Extensive research has been conducted over the past 15 years on biofuels coproducts to (a) optimize their use for improving caloric and nutritional efficiency in animal feeds, (b) identify benefits and limitations of use in various animal diets,

Estimation of emission factor for odorants released from swine excretion slurries

In this study, the odorant emission rates from excretory wastes collected in sealed containers from a large swine facility were determined offsite in a laboratory using both raw slurry from ([1] windowless pigpen (WP) and [2] open pigpen (OP)) and treated waste samples ([3] composting facility (CF) and [4] slurry treatment facility (SF)). The emission rates of up to 41 volatile odorants were measured for 100g waste samples (of all four types) in a 0.75L impinger with an air change rate of 8h(-1). The initial emission rates (mgkg(-1)·h(-1)) for the most dominant species from each waste type can be summarized as: (1) WP: NH3 (16.3) and H2S (0.54); (2) OP: H2S (1.78), NH3 (1.69), and p-cresol (0.36); (3) CF: NH3 (7.04), CH3SH (0.30), and DMS (0.12); and (4) SF: NH3 (11.7), H2S (11.7), and p-cresol (0.25). Accordingly, the emission factors for the key odorant (mE, kg·pig(-1))) for fattening pigs in the WP and OP facilities of S. Korea were extrapolated as 3.46 (NH3) and 0.38 (H2S), respectively. The emission factors were estimated assuming exponentially decaying emission rates and slurry production rates obtained from the literature.

Effects of co-products from the corn-ethanol industry on body composition, retention of protein, lipids and energy, and on the net energy of diets fed to growing or finishing pigs

BACKGROUND

Conventional distillers dried grains with solubles (DDGS-CV), uncooked distillers dried grains with solubles (DDGS-BPX) and high-protein distillers dried grains (HP-DDG) are used in diets for pigs to provide protein and energy. These ingredients may have different effects on body composition and energy retention. Therefore, an experiment was conducted to determine effects of DDGS-CV, DDGS-BPX and HP-DDG on body composition and on retention of protein, lipids, and energy when fed to growing or finishing pigs.

RESULTS

The total organ weight was greater (P < 0.05) for finishing pigs fed the HP-DDG diet than for finishing pigs fed the basal diet or the DDGS-CV diet. Finishing pigs fed the DDGS-CV diet had greater (P < 0.05) lipid gain than pigs fed the other diets, and the net energy (NE) for DDGS-CV was greater (P < 0.05) than for DDGS-BPX, but the NE value of HP-DDG was not different from that of DDGS-CV or DDGS-BPX.

CONCLUSION

Inclusion of up to 30% DDGS or HP-DDG in diets fed to growing or finishing pigs will not affect body composition or the retention of energy, protein and lipids, regardless of the stage of growth of pigs. The NE value of DDGS-BPX and HP-DDG is not affected by the stage of growth of pigs, but the NE value of DDGS-CV is greater in finishing than in growing pigs.

Effects of dietary sulfur and distillers dried grains with solubles on carcass characteristics, loin quality, and tissue concentrations of sulfur, selenium, and copper in growing-finishing pigs

Inclusion of up to 0.38% S in diets that contain 30% distillers dried grains with solubles (DDGS) has no negative effect on growth performance of growing-finishing pigs, but there is no information about the effects of dietary S on accumulation of S in tissues in pigs. Therefore, the objective of this experiment was to determine if the concentration of S in diets containing DDGS affects carcass characteristics, loin quality, or tissue mineral concentrations in growing-finishing pigs. A total of 120 barrows (34.2 ± 2.3 kg BW) were allotted to 3 dietary treatments with 10 replicate pens and 4 pigs per pen in a randomized complete block design. Pigs were fed grower diets for 42 d and finisher diets for 42 d. At the conclusion of the experiment, the pig in each pen with the BW closest to the pen average was slaughtered. The control diet was based on corn and soybean meal and the finisher diet contained 0.14% S, 0.19 mg/kg Se, and 15.3 mg/kg Cu. The DDGS diet was formulated with corn, soybean meal, and 30% DDGS and the finisher diet with DDGS contained 0.16% S, 0.32 mg/kg Se, and 14.0 mg/kg Cu. The DDGS plus S (DDGS-S) diet was similar to the DDGS diet, except that 1.10% CaSO4 (16.2% S) was included in this diet, and the finisher diet with DDGS-S contained 0.37% S, 0.35 mg/kg Se, and 13.8 mg/kg Cu. Results indicated that organ weights and loin quality, 24-h pH, drip loss, loin subjective color, marbling, and firmness did not differ among treatments, but loin a* was greater (P < 0.05) for pigs fed the control diet than for pigs fed the DDGS-S diet. Concentrations of S in hair, liver, heart, loin, and all other tissues did not differ among treatments, but urinary S concentration was greater (P < 0.05) for pigs fed the DDGS-S diet than for pigs fed the other diets. Pigs fed the DDGS diet or the DDGS-S diet had greater (P < 0.01) concentrations of Se in hair, liver, heart, and loin than pigs fed the control diet, but liver concentrations of Cu did not differ among treatments. In conclusion, inclusion of 30% DDGS in diets fed to growing-finishing pigs did not influence carcass characteristics or tissue S concentrations regardless of S concentration in the diet, and excess dietary S was excreted in the urine. However, because of the greater concentration of Se in DDGS than in corn and soybean meal and, therefore, greater concentrations in DDGS-containing diets, tissue concentrations of Se were increased in pigs fed diets that contained DDGS. In contrast, dietary DDGS did not influence liver concentrations of Cu.