Effect of high-pressure treatment on denaturation of bovine lactoferrin and lactoperoxidase

The Effect of Hyperbaric Storage on the Nutritional Value and Retention of Certain Bioactive Proteins in Human Milk

Human milk (HM) contains the essential macronutrients and bioactive compounds necessary for the normal growth and development of newborns. The milk collected by human milk banks is stored frozen and pasteurized, reducing its nutritional and biological value. The purpose of this study was to determine the effect of hyperbaric storage at subzero temperatures (HS-ST) on the macronutrients and bioactive proteins in HM. As control samples, HM was stored at the same temperatures under 0.1 MPa. A Miris HM analyzer was used to determine the macronutrients and the energy value. The lactoferrin (LF), lysozyme (LYZ) and α-lactalbumin (α-LAC) content was checked using high-performance liquid chromatography, and an ELISA test was used to quantify secretory immunoglobulin A (sIgA). The results showed that the macronutrient content did not change significantly after 90 days of storage at 60 MPa/-5 °C, 78 MPa/-7 °C, 111 MPa/-10 °C or 130 MPa/-12 °C. Retention higher than 90% of LYZ, α-LAC, LF and sIgA was observed in the HM stored at conditions of up to 111 MPa/-10 °C. However, at 130 MPa/-12 °C, there was a reduction in LYZ and LF, by 39 and 89%, respectively. The storage of HM at subzero temperatures at 0.1 MPa did not affect the content of carbohydrates or crude and true protein. For fat and the energy value, significant decreases were observed at -5 °C after 90 days of storage.

Antirotaviral activity of dairy byproducts enriched in fractions from hyperimmune bovine colostrum: the effect of thermal and high hydrostatic pressure treatments

Nowadays, rotaviruses remain a major health burden, especially in developing countries, and strategies complementary to vaccination are needed. In this view, dairy fractions have attracted great scientific interest, due to their high content of bioactive compounds. The objective of this study was to evaluate the antiviral activity of whey and buttermilk enriched in proteins from hyperimmune bovine colostrum (HBC) against rotavirus. The enriched fractions were spray-dried and subsequently tested for their neutralizing activity against the bovine rotavirus WC3 strain in vitro, using differentiated Caco-2/TC7 cells. The highest antirotaviral activity was observed when whey and buttermilk were enriched in purified immunoglobulin G (IgG), showing complete rotavirus neutralization at concentrations of 3 and 6 mg mL-1 for whey and buttermilk, respectively. Additionally, the use of a crude immunoglobulin fraction also gave satisfactory results. The inhibitory activities of all samples significantly decreased after the application of heat, except for the IgG-enriched buttermilk which showed a slight increase of activity following the application of short-time treatments (75 or 85 °C for 20 s). This sample also showed a significant increase of activity (13%) after the application of low-intensity high hydrostatic pressure treatment (400 MPa for 5 min). The maximum loss of bioactivity was observed at 600 MPa for 10 min (31 and 20% for whey- and buttermilk-based formulas, respectively). This study provides relevant information on the potential of whey, buttermilk, and HBC to be part of functional products as complementary strategies to combat rotavirus infections.

Nutritional, Physicochemical, and Endogenous Enzyme Assessment of Raw Milk Preserved under Hyperbaric Storage at Variable Room Temperature

Raw milk (a highly perishable food) was preserved at variable room temperature (RT) under hyperbaric storage (HS) (50-100 MPa) for 60 days and compared with refrigeration (RF) under atmospheric pressure (AP) on quality, nutritional, and endogenous enzyme activity parameters. Overall, a comparable raw milk preservation outcome was observed between storage under AP/RF and 50/RT after 14 days, with similar variations in the parameters studied indicating milk degradation. Differently, even after 60 days (the maximum period studied) under 75-100/RT, a slower milk degradation was achieved, keeping most of the parameters similar to those of milk prior to storage, including pH, titratable acidity, total solid content, density, color, viscosity, and volatile organic and fatty acid profiles, but with higher free amino acid content, signs of an overall better preservation. These results indicate an improved preservation and enhanced shelf life of raw milk by HS/RT versus RF, showing HS potential for milk and highly perishable food preservation in general.

Effects of High-Pressure Processing, UV-C Irradiation and Thermoultrasonication on Donor Human Milk Safety and Quality

Holder pasteurization (HoP) is the current recommended treatment for donor human milk. Although this method inactivates microbial contaminants, it also negatively affects various milk components. High-pressure processing (HPP, 400, 500, and 600 MPa), ultraviolet-C irradiation (UV-C, 2,430, 3,645, and 4,863 J/L) and thermoultrasonication (TUS, 1,080 and 1,620 kJ/L) were investigated as alternatives to thermal pasteurization (HoP). We assessed the effects of these methods on microbiological safety, and on concentration and functionality of immunoglobulin A, lactoferrin, lysozyme and bile salt-stimulated lipase, with LC-MS/MS-based proteomics and activity assays. HoP, HPP, TUS, and UV-C at 4863 J/L, achieved >5-log10 microbial reduction. Native protein levels and functionality showed the highest reduction following HoP, while no significant reduction was found after less intense HPP and all UV-C treatments. Immunoglobulin A, lactoferrin, and lysozyme contents were also preserved after low intensity TUS, but bile salt-stimulated lipase activity was significantly reduced. This study demonstrated that HPP and UV-C may be considered as suitable alternatives to HoP, since they were able to ensure sufficient microbial inactivation while at the same time better preserving the bioactive components of donor human milk. In summary, our results provide valuable insights regarding the evaluation and selection of suitable processing methods for donor human milk treatment, which may replace HoP in the future.

The efficacy and safety of high-pressure processing of food

High-pressure processing (HPP) is a non-thermal treatment in which, for microbial inactivation, foods are subjected to isostatic pressures (P) of 400-600 MPa with common holding times (t) from 1.5 to 6 min. The main factors that influence the efficacy (log10 reduction of vegetative microorganisms) of HPP when applied to foodstuffs are intrinsic (e.g. water activity and pH), extrinsic (P and t) and microorganism-related (type, taxonomic unit, strain and physiological state). It was concluded that HPP of food will not present any additional microbial or chemical food safety concerns when compared to other routinely applied treatments (e.g. pasteurisation). Pathogen reductions in milk/colostrum caused by the current HPP conditions applied by the industry are lower than those achieved by the legal requirements for thermal pasteurisation. However, HPP minimum requirements (P/t combinations) could be identified to achieve specific log10 reductions of relevant hazards based on performance criteria (PC) proposed by international standard agencies (5-8 log10 reductions). The most stringent HPP conditions used industrially (600 MPa, 6 min) would achieve the above-mentioned PC, except for Staphylococcus aureus. Alkaline phosphatase (ALP), the endogenous milk enzyme that is widely used to verify adequate thermal pasteurisation of cows' milk, is relatively pressure resistant and its use would be limited to that of an overprocessing indicator. Current data are not robust enough to support the proposal of an appropriate indicator to verify the efficacy of HPP under the current HPP conditions applied by the industry. Minimum HPP requirements to reduce Listeria monocytogenes levels by specific log10 reductions could be identified when HPP is applied to ready-to-eat (RTE) cooked meat products, but not for other types of RTE foods. These identified minimum requirements would result in the inactivation of other relevant pathogens (Salmonella and Escherichia coli) in these RTE foods to a similar or higher extent.

Current insights into non-thermal preservation technologies alternative to conventional high-temperature short-time pasteurization of drinking milk

Milk is an important nutritional food source characterized by a perishable nature and conventionally thermally treated to guarantee its safety. In recent years, an increasing focus on competing non-thermal food processing technologies has been driven mainly by consumers' expectations for minimally processed products. Due to the heat sensitivity of milk, much research interest has been addressed to mild non-thermal pasteurization processing to keep safety, 'fresh-like' taste and to maintain the organoleptic qualities of raw milk. This review provides an overview of the current literature on non-thermal treatments as standalone alternative technologies to high-temperature short-time (HTST) pasteurization of drinking milk. Results of lab-scale experimentations suggest the feasibility of most emerging non-thermal processing technologies, including high hydrostatic pressure, pulsed electric field, cold plasma, cavitation and light-based technologies, as alternative to thermal treatment of drinking milk with premium in shelf life duration. Nevertheless, a series of regulatory, technological and economical hurdles hinder the industrial scaling-up for most of these substitutes. To date, only high hydrostatic pressure treatments are applied as alone alternative to HTSH pasteurization for processing of "cold pasteurized" drinking milk. Milk submitted to HTST treatment combined to ultraviolet light is currently accepted in EU countries as novel food.

Effects of Pasteurization and High-Pressure Processing of Camel and Bovine Cheese Quality, and Proteolysis Contribution to Camel Cheese Softness

The effects of high-pressure processing (HPP) compared to thermal treatments on the quality of camel vs. bovine cheeses were studied. The study showed that camel milk has a lower microbial load compared to bovine milk, which is maintained during 7 days' storage of the processed milk. The effect of three HPP treatments (350, 450, and 550 MPa for 5 min at 4°C) and two pasteurization treatments (65°C for 30 min and 75°C for 30 s) on the quality of soft unripened camel and bovine milk cheeses were accessed. The cheeses were evaluated for pH, yield, proximate composition, textural and rheological properties, microstructure, and protein profile by SDS-PAGE electrophoresis. The effects of the treatments on cheese's hardness were different between the camel and bovine cheeses; while heat treatment at 65°C for 30 min gave the hardest bovine milk cheese (1,253 ± 20), HPP treatment at 350 MPa for 5 min gave the highest value for camel milk cheese (519 ± 5) (p < 0.05). The hardness of the cheeses was associated with low yield and moisture content. SDS-PAGE electrophoresis revealed that extensive proteolysis might have contributed to the softness of camel cheeses compared to bovine and suggested the involvement of some residual enzyme activities.

Gastric Digestion of Milk Proteins in Adult and Elderly: Effect of High-Pressure Processing

Reduced physiological capability of the human gastrointestinal tract with increasing age has recently attracted considerable attention to the potential of novel technologies to modify food digestion. Thus, the aim of this study was to investigate gastric digestion of milk proteins after application of high-pressure processing (HPP) at 400 MPa 15 min, 600 MPa 5 min and 600 MPa 15 min using two static in vitro models of adults (INFOGEST) and the elderly in comparison to a fresh untreated raw milk. Peptides distribution classified based on the number of amino acids (AA) (<10, 11-15, 16-20, 21-30, >30 AA) were investigated after 0, 5, 10 and 30 min of digestion using LC-MS and multivariate data analysis. Our results show significantly less efficient protein digestion of all investigated milks in the elderly model indicated by higher percentages of longer peptides during digestion, except for the HPP milk 400 MPa 15 min, which indicated an improved and comparable digestion in the elderly as in the adult model. Furthermore, increasing the pressurization time at 600 MPa did not have a significant effect on the peptides profile during the digestion. More efficient digestion of whey proteins in HPP milks, with the majority of peptides in the 16-20 AA range, compared to fresh milk was also noticed. According to the findings of this study, HPP at 400 MPa 15 min showed the most efficient digestion of major milk proteins and thus may be considered a suitable process to improve bioaccessibility of milk proteins, especially in products intended for the elderly.

Investigation of nitrogen purging prior to UV treatment on quality of milk

Ultraviolet treatment (UV-C) is well known for its antimicrobial effects and current research shows that it has the potential to inactivate microorganisms in milk at much lower temperatures than conventional thermal treatment. However, Ultraviolet irradiation may result in adverse effects on milk quality, which arises due to photo oxidation in the presence of oxygen. Limiting the dissolved oxygen content in milk can minimize oxidative damage and thus, result in a better product quality. Nitrogen purging could be an effective method for reducing dissolved oxygen from liquids. The present study evaluates effects of nitrogen purging (prior to UV treatment) on milk quality. It was found that nitrogen purged UV treated milk causes minimal changes to physicochemical properties of milk.

Antirotaviral potential of lactoferrin from different origin: effect of thermal and high pressure treatments

Rotaviral gastroenteritis causes a high rate of infant mortality and severe healthcare implications worldwide. Several studies have pointed out that human milk and dairy fractions, such as whey and buttermilk, possess antirotaviral activity. This activity has been mainly associated with glycoproteins, among them lactoferrin (LF). Thermal treatments are necessary to provide microbiological safety and extend the shelf life of milk products, though they may diminish their biological value. High hydrostatic pressure (HHP) treatment is a non-thermal method that causes lower degradation of food components than other treatments. Thus, the main objective of this study was to prove the antirotaviral activity of LFs from different origin and to evaluate the effect of several thermal and HHP treatments on that activity. LF exerted a high antirotaviral activity, regardless of its origin. Native LFs from bovine, ovine, swine and camel milk, and the human recombinant forms, at 1 mg/mL, showed neutralizing values in the range 87.5-98.6%, while human LF neutralized 58.2%. Iron saturation of bovine LF did not modify its antirotaviral activity. Results revealed interspecies differences in LFs heat susceptibility. Thus, pasteurization at 63 °C for 30 min led to a decrease of 60.1, 44.5, 87.1, 3.8 and 8% of neutralizing activity for human, bovine, swine, ovine and camel LFs, respectively. Pasteurization at 75 °C for 20 s was less harmful to the activity of LFs, with losses ranging from 0 to 13.8%. HHP treatment at 600 MPa for 15 min did not cause any significant decrease in the neutralizing activity of LFs.

Effect of technological treatments on bovine lactoferrin: An overview

Lactoferrin (LF) is a multifunctional protein that exerts important activities in the neonate through its presence in milk, and also in other external mucosas, acting as a defense protein of innate immunity. The addition of bovine LF to infant formula and also to other functional products and cosmetics has increased during the last decades. Consequently, it is essential to know the effect that the technological processes, necessary to elaborate those products, have on LF activity. In this study, we have revised the effect of classical treatments on lactoferrin structure and activity, such as heat treatment or drying, and also of emerging technologies, like high pressure or pulsed electric field. The results of the studies included in this review indicate that LF stability is dependent on its level of iron-saturation and on the characteristics of the treatment media. Furthermore, the studies revised here reveal that the non-thermal treatments are interesting alternatives to the traditional ones, as they protect better the structure and activity of lactoferrin. It is also clear the need for research on LF encapsulation by different ways, to protect its properties before it reaches the intestine. All this knowledge would allow designing processes less harmful for LF, thus maintaining all its functionality.

Effect of cow colostrum on the performance and survival rate of local newborn piglets in Benin Republic

The effect of bovine colostrum, including its thermally labile compounds, on the survival and growth performance of local breed piglets reared by their mother, in Benin, was evaluated over a 49-day trial. Three groups of 16 piglets, stemming from two primiparous sows belonging to a unique traditional farm, were respectively fed for the first 48 h of life with either bovine colostrum heated to 85 °C for 30 min, or thawed bovine colostrum, or colostrum from the mother. Thereafter, the animals that received bovine colostrum turned back to their mother. At day 21, almost all piglets from the group that received heated colostrum died. The highest total weight gain was obtained in the group that received thawed bovine colostrum (P ˂ 0.01), followed by the group left with the mother. Corresponding average daily gains (ADGs) were 56, 34 and 2 g/day, respectively (P ˂ 0.05). At the end of the trial, the treatment effect was highly significant on the survival of piglets (100% in the thawed colostrum group vs. 00 and 50%, respectively, in the heated colostrum group and in the group left with the mother). At day 49, numerically higher weight and ADGs were obtained in the group that received thawed cow colostrum. Thawed bovine colostrum improved the growth performance and piglet survival in the local pig breed in Benin, probably owing to thermally labile components. Bovine colostrum may be used in our farms in order to reduce pre-weaning mortality, improve the profitability of livestock farmers, and ensure survival of traditional farms. The use of bovine colostrum on farms could be facilitated by collaboration between pig farmers and bovine farmers. It could also be facilitated by the creation of a colostrum bank.

Development of a test strip for rapid detection of lactoperoxidase in raw milk

Traditional methods for detecting lactoperoxidase (LP) are complex and time-consuming, so a test strip was made based on the enzymatic reaction principle to enable quick and convenient detection of LP in raw milk. In this study 0.1 mol/L citric acid (CA)/0.2 mol/L disodium hydrogen phosphate (NaP) buffer solution (pH 5.0), 22 mmol/L 3,3',5,5'-tetramethylbenzidine (TMB), 0.6 mmol/L hydrogen peroxide (H2O2), and 0.5% Tween-20 or 0.3% cetyltrimethyl ammonium bromide (CTAB) were optimal for preparing a quick, sensitive, and accurate LP test strip. The coefficient of variation (CV) of the estimated LP concentrations ranged from 2.47% to 6.72% and the minimum LP concentration detected by the test strip was 1-2 mg/L. Estimates of active LP in sixteen raw milk samples obtained using the test strip or the TMB method showed a good correlation (r=0.9776). So the test strip provides a quick, convenient, and accurate method for detecting the LP concentration of raw milk.

Effect of high pressure on the structure and antibacterial activity of bovine lactoferrin treated in different media

The effect of high-pressure treatment (400, 500 and 650 MPa) on the structure and activity of bovine lactoferrin in different iron-saturation forms has been studied by several techniques. The structural changes produced in lactoferrin by high-pressure were analysed by differential scanning calorimetry and fluorescence spectroscopy, and the immunoreactivity by ELISA. The effect of high-pressure was also studied on some biological properties of lactoferrin, such as iron binding capacity, retention of the bound iron, and antibacterial activity against Escherichia coli O157:H7. Results obtained indicate that treatment at 400 MPa does not substantially modify the conformation of lactoferrin, meanwhile treatments at 500 and 650 MPa greatly affect some of its properties. With respect to the antibacterial activity, the apo and native forms of lactoferrin maintain that activity against Esch. coli only after 400 MPa treatment.