1
|
Mahieux M, Richard C, Aemig Q, Delgenès JP, Juge M, Trably E, Escudié R. Archaeal community composition as key driver of H2 consumption rates at the start-up of the biomethanation process. THE SCIENCE OF THE TOTAL ENVIRONMENT 2024; 931:172922. [PMID: 38701927 DOI: 10.1016/j.scitotenv.2024.172922] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/29/2024] [Revised: 04/03/2024] [Accepted: 04/29/2024] [Indexed: 05/05/2024]
Abstract
The performance of hydrogen consumption by various inocula derived from mesophilic anaerobic digestion plants was evaluated under ex situ biomethanation. A panel of 11 mesophilic inocula was operated at a concentration of 15 gVS.L-1 at a temperature of 35 °C in batch system with two successive injections of H2:CO2 (4:1 mol:mol). Hydrogen consumption and methane production rates were monitored from 44 h to 72 h. Hydrogen consumption kinetics varies significantly based on the inoculum origin, with no accumulation of volatile fatty acids. Microbial community analyses revealed that microbial indicators such as the increase in Methanosarcina sp. abundance and the increase of the Archaea/Bacteria ratio were associated to high initial hydrogen consumption rates. The improvement in the hydrogen consumption rate between the two injections was correlated with the enrichment in hydrogenotrophic methanogens. This work provides new insights into the early response of microbial communities to hydrogen injection and on the microbial structures that may favor their adaptation to the biomethanation process.
Collapse
Affiliation(s)
- M Mahieux
- INRAE, Univ. Montpellier, LBE, 102 Avenue des étangs, F-11100 Narbonne, France; ENGIE, Lab CRIGEN, 4 Rue Joséphine Baker, 93240 Stains, France
| | - C Richard
- ENGIE, Lab CRIGEN, 4 Rue Joséphine Baker, 93240 Stains, France
| | - Q Aemig
- ENGIE, Lab CRIGEN, 4 Rue Joséphine Baker, 93240 Stains, France
| | - J-P Delgenès
- INRAE, Univ. Montpellier, LBE, 102 Avenue des étangs, F-11100 Narbonne, France
| | - M Juge
- ENGIE, Lab CRIGEN, 4 Rue Joséphine Baker, 93240 Stains, France
| | - E Trably
- INRAE, Univ. Montpellier, LBE, 102 Avenue des étangs, F-11100 Narbonne, France
| | - R Escudié
- INRAE, Univ. Montpellier, LBE, 102 Avenue des étangs, F-11100 Narbonne, France.
| |
Collapse
|
2
|
Mitraka GC, Kontogiannopoulos KN, Zouboulis AI, Kougias PG. Evaluation of the optimal sewage sludge pre-treatment technology through continuous reactor operation: Process performance and microbial community insights. WATER RESEARCH 2024; 257:121662. [PMID: 38678834 DOI: 10.1016/j.watres.2024.121662] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/19/2024] [Revised: 04/12/2024] [Accepted: 04/21/2024] [Indexed: 05/01/2024]
Abstract
This study investigated the impact of two low-temperature thermal pre-treatments on continuous anaerobic reactors' performance, sequentially fed with sludge of different total solids content (∼3 % and ∼6 %) and subjected to progressively increasing Organic Loading Rates (OLR) from 1.0 to 2.5 g volatile solids/(LReactor⋅day). Assessing pre-treatments' influence on influent sludge characteristics revealed enhanced organic matter hydrolysis, facilitating sludge solubilization and methanogenesis; volatile fatty acids concentration also increased, particularly in pre-treated sludge of ∼6 % total solids, indicating improved heating efficiency under increased solids content. The reactor fed with sludge pre-treated at 45 °C for 48 h and 55 °C for an extra 48 h exhibited the highest methane yield under all applied OLRs, peaking at 240 ± 3.0 mL/g volatile solids at the OLR of 2.5 g volatile solids/(LReactor⋅day). 16S rRNA gene sequencing demonstrated differences in the reactors' microbiomes as evidence of sludge thickening and the different pre-treatments applied, which promoted the release of organic matter in diverse concentrations and compositions. Finally, the microbial analysis revealed that specific foam-related genera increased in abundance in the foam layer of reactors' effluent bottles, dictating their association with the sludge foaming incidents that occurred inside the reactors during their operation at 2.0 g volatile solids/(LReactor⋅day).
Collapse
Affiliation(s)
- Georgia-Christina Mitraka
- Laboratory of Chemical & Environmental Technology, Department of Chemistry, Aristotle University of Thessaloniki, Thessaloniki GR-54124, Greece; Soil and Water Resources Institute, Hellenic Agricultural Organisation Dimitra, Thermi, P.O. Box 60458, Thessaloniki GR-57001, Greece
| | - Konstantinos N Kontogiannopoulos
- Soil and Water Resources Institute, Hellenic Agricultural Organisation Dimitra, Thermi, P.O. Box 60458, Thessaloniki GR-57001, Greece
| | - Anastasios I Zouboulis
- Laboratory of Chemical & Environmental Technology, Department of Chemistry, Aristotle University of Thessaloniki, Thessaloniki GR-54124, Greece
| | - Panagiotis G Kougias
- Soil and Water Resources Institute, Hellenic Agricultural Organisation Dimitra, Thermi, P.O. Box 60458, Thessaloniki GR-57001, Greece.
| |
Collapse
|
3
|
Bellini R, Vasile NS, Bassani I, Vizzarro A, Coti C, Barbieri D, Scapolo M, Pirri CF, Verga F, Menin B. Investigating the activity of indigenous microbial communities from Italian depleted gas reservoirs and their possible impact on underground hydrogen storage. Front Microbiol 2024; 15:1392410. [PMID: 38725680 PMCID: PMC11079786 DOI: 10.3389/fmicb.2024.1392410] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/27/2024] [Accepted: 04/09/2024] [Indexed: 05/12/2024] Open
Abstract
H2 produced from renewable energies will play a central role in both greenhouse gas reduction and decarbonization by 2050. Nonetheless, to improve H2 diffusion and utilization as a fuel, large storage capacity systems are needed. Underground storage of natural gas in depleted reservoirs, aquifers and salt caverns is a well-established technology. However, new challenges arise when it comes to storing hydrogen due to the occurrence and activity of indigenous microbial populations in deep geological formations. In a previous study, four Italian natural gas reservoirs were characterized both from a hydro-chemical and microbiological point of view, and predictive functional analyses were carried out with the perspective of underground hydrogen storage (UHS). In the present work, formation waters from the same reservoirs were used as inoculant during batch cultivation tests to characterize microbial activity and its effects on different gas mixtures. Results evidence a predominant acidogenic/acetogenic activity, whilst methanogenic and sulfate reducing activity were only marginal for all tested inoculants. Furthermore, the microbial activation of tested samples is strongly influenced by nutrient availability. Obtained results were fitted and screened in a computational model which would allow deep insights in the study of microbial activity in the context of UHS.
Collapse
Affiliation(s)
- Ruggero Bellini
- Centre for Sustainable Future Technologies, Fondazione Istituto Italiano di Tecnologia, Turin, Italy
| | - Nicolò Santi Vasile
- Centre for Sustainable Future Technologies, Fondazione Istituto Italiano di Tecnologia, Turin, Italy
- Department of Applied Science and Technology, Politecnico di Torino, Turin, Italy
| | - Ilaria Bassani
- Centre for Sustainable Future Technologies, Fondazione Istituto Italiano di Tecnologia, Turin, Italy
| | - Arianna Vizzarro
- Centre for Sustainable Future Technologies, Fondazione Istituto Italiano di Tecnologia, Turin, Italy
| | | | | | | | - Candido Fabrizio Pirri
- Centre for Sustainable Future Technologies, Fondazione Istituto Italiano di Tecnologia, Turin, Italy
- Department of Applied Science and Technology, Politecnico di Torino, Turin, Italy
| | - Francesca Verga
- Department of Applied Science and Technology, Politecnico di Torino, Turin, Italy
| | - Barbara Menin
- Centre for Sustainable Future Technologies, Fondazione Istituto Italiano di Tecnologia, Turin, Italy
- National Research Council, Institute of Agricultural Biology and Biotechnology (CNR-IBBA), Milan, Italy
| |
Collapse
|
4
|
Ceron-Chafla P, de Vrieze J, Rabaey K, van Lier JB, Lindeboom REF. Steering the product spectrum in high-pressure anaerobic processes: CO 2 partial pressure as a novel tool in biorefinery concepts. BIOTECHNOLOGY FOR BIOFUELS AND BIOPRODUCTS 2023; 16:27. [PMID: 36803622 PMCID: PMC9938588 DOI: 10.1186/s13068-023-02262-x] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 04/22/2022] [Accepted: 01/05/2023] [Indexed: 02/19/2023]
Abstract
BACKGROUND Elevated CO2 partial pressure (pCO2) has been proposed as a potential steering parameter for selective carboxylate production in mixed culture fermentation. It is anticipated that intermediate product spectrum and production rates, as well as changes in the microbial community, are (in)directly influenced by elevated pCO2. However, it remains unclear how pCO2 interacts with other operational conditions, namely substrate specificity, substrate-to-biomass (S/X) ratio and the presence of an additional electron donor, and what effect pCO2 has on the exact composition of fermentation products. Here, we investigated possible steering effects of elevated pCO2 combined with (1) mixed substrate (glycerol/glucose) provision; (2) subsequent increments in substrate concentration to increase the S/X ratio; and (3) formate as an additional electron donor. RESULTS Metabolite predominance, e.g., propionate vs. butyrate/acetate, and cell density, depended on interaction effects between pCO2-S/X ratio and pCO2-formate. Individual substrate consumption rates were negatively impacted by the interaction effect between pCO2-S/X ratio and were not re-established after lowering the S/X ratio and adding formate. The product spectrum was influenced by the microbial community composition, which in turn, was modified by substrate type and the interaction effect between pCO2-formate. High propionate and butyrate levels strongly correlated with Negativicutes and Clostridia predominance, respectively. After subsequent pressurized fermentation phases, the interaction effect between pCO2-formate enabled a shift from propionate towards succinate production when mixed substrate was provided. CONCLUSIONS Overall, interaction effects between elevated pCO2, substrate specificity, high S/X ratio and availability of reducing equivalents from formate, rather than an isolated pCO2 effect, modified the proportionality of propionate, butyrate and acetate in pressurized mixed substrate fermentations at the expense of reduced consumption rates and increased lag-phases. The interaction effect between elevated pCO2 and formate was beneficial for succinate production and biomass growth with a glycerol/glucose mixture as the substrate. The positive effect may be attributed to the availability of extra reducing equivalents, likely enhanced carbon fixating activity and hindered propionate conversion due to increased concentration of undissociated carboxylic acids.
Collapse
Affiliation(s)
- Pamela Ceron-Chafla
- Sanitary Engineering Section, Department of Water Management, Delft University of Technology, Stevinweg 1, 2628 CN, Delft, The Netherlands.
| | - Jo de Vrieze
- grid.5342.00000 0001 2069 7798Center for Microbial Ecology and Technology (CMET), Ghent University, Coupure Links 653, 9000 Ghent, Belgium
| | - Korneel Rabaey
- grid.5342.00000 0001 2069 7798Center for Microbial Ecology and Technology (CMET), Ghent University, Coupure Links 653, 9000 Ghent, Belgium ,grid.510907.aCenter for Advanced Process Technology for Urban Resource Recovery (CAPTURE), Coupure Links 653, 9000 Ghent, Belgium
| | - Jules B. van Lier
- grid.5292.c0000 0001 2097 4740Sanitary Engineering Section, Department of Water Management, Delft University of Technology, Stevinweg 1, 2628 CN Delft, The Netherlands
| | - Ralph E. F. Lindeboom
- grid.5292.c0000 0001 2097 4740Sanitary Engineering Section, Department of Water Management, Delft University of Technology, Stevinweg 1, 2628 CN Delft, The Netherlands
| |
Collapse
|
5
|
De Bernardini N, Basile A, Zampieri G, Kovalovszki A, De Diego Diaz B, Offer E, Wongfaed N, Angelidaki I, Kougias PG, Campanaro S, Treu L. Integrating metagenomic binning with flux balance analysis to unravel syntrophies in anaerobic CO 2 methanation. MICROBIOME 2022; 10:117. [PMID: 35918706 PMCID: PMC9347119 DOI: 10.1186/s40168-022-01311-1] [Citation(s) in RCA: 18] [Impact Index Per Article: 9.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/17/2022] [Accepted: 05/30/2022] [Indexed: 05/29/2023]
Abstract
BACKGROUND Carbon fixation through biological methanation has emerged as a promising technology to produce renewable energy in the context of the circular economy. The anaerobic digestion microbiome is the fundamental biological system operating biogas upgrading and is paramount in power-to-gas conversion. Carbon dioxide (CO2) methanation is frequently performed by microbiota attached to solid supports generating biofilms. Despite the apparent simplicity of the microbial community involved in biogas upgrading, the dynamics behind most of the interspecies interaction remain obscure. To understand the role of the microbial species in CO2 fixation, the biofilm generated during the biogas upgrading process has been selected as a case study. The present work investigates via genome-centric metagenomics, based on a hybrid Nanopore-Illumina approach the biofilm developed on the diffusion devices of four ex situ biogas upgrading reactors. Moreover, genome-guided metabolic reconstruction and flux balance analysis were used to propose a biological role for the dominant microbes. RESULTS The combined microbiome was composed of 59 species, with five being dominant (> 70% of total abundance); the metagenome-assembled genomes representing these species were refined to reach a high level of completeness. Genome-guided metabolic analysis appointed Firmicutes sp. GSMM966 as the main responsible for biofilm formation. Additionally, species interactions were investigated considering their co-occurrence in 134 samples, and in terms of metabolic exchanges through flux balance simulation in a simplified medium. Some of the most abundant species (e.g., Limnochordia sp. GSMM975) were widespread (~ 67% of tested experiments), while others (e.g., Methanothermobacter wolfeii GSMM957) had a scattered distribution. Genome-scale metabolic models of the microbial community were built with boundary conditions taken from the biochemical data and showed the presence of a flexible interaction network mainly based on hydrogen and carbon dioxide uptake and formate exchange. CONCLUSIONS Our work investigated the interplay between five dominant species within the biofilm and showed their importance in a large spectrum of anaerobic biogas reactor samples. Flux balance analysis provided a deeper insight into the potential syntrophic interaction between species, especially Limnochordia sp. GSMM975 and Methanothermobacter wolfeii GSMM957. Finally, it suggested species interactions to be based on formate and amino acids exchanges. Video Abstract.
Collapse
Affiliation(s)
- Nicola De Bernardini
- Department of Biology, University of Padova, Via U. Bassi 58/b, 35121, Padua, Italy
| | - Arianna Basile
- Department of Biology, University of Padova, Via U. Bassi 58/b, 35121, Padua, Italy
| | - Guido Zampieri
- Department of Biology, University of Padova, Via U. Bassi 58/b, 35121, Padua, Italy
| | - Adam Kovalovszki
- Department of Environmental Engineering, Technical University of Denmark, 2800, Kgs. Lyngby, Denmark
| | | | - Elisabetta Offer
- Department of Biology, University of Padova, Via U. Bassi 58/b, 35121, Padua, Italy
| | - Nantharat Wongfaed
- Department of Biotechnology, Faculty of Technology, Khon Kaen University, Khon Kaen, 40002, Thailand
| | - Irini Angelidaki
- Department of Chemical and Biochemical Engineering, Technical University of Denmark, Kgs, DK-2800, Lyngby, Denmark
| | - Panagiotis G Kougias
- Hellenic Agricultural Organization DEMETER, Soil and Water Resources Institute, Thermi, Thessaloniki, Greece.
| | - Stefano Campanaro
- Department of Biology, University of Padova, Via U. Bassi 58/b, 35121, Padua, Italy.
- CRIBI Biotechnology Center, University of Padova, 35131, Padova, Italy.
| | - Laura Treu
- Department of Biology, University of Padova, Via U. Bassi 58/b, 35121, Padua, Italy
| |
Collapse
|
6
|
Biological Aspects, Advancements and Techno-Economical Evaluation of Biological Methanation for the Recycling and Valorization of CO2. ENERGIES 2022. [DOI: 10.3390/en15114064] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 02/04/2023]
Abstract
Nowadays, sustainable and renewable energy production is a global priority. Over the past decade, several Power-to-X (PtX) technologies have been proposed to store and convert the surplus of renewable energies into chemical bonds of chemicals produced by different processes. CO2 is a major contributor to climate change, yet it is also an undervalued source of carbon that could be recycled and represents an opportunity to generate renewable energy. In this context, PtX technologies would allow for CO2 valorization into renewable fuels while reducing greenhouse gas (GHG) emissions. With this work we want to provide an up-to-date overview of biomethanation as a PtX technology by considering the biological aspects and the main parameters affecting its application and scalability at an industrial level. Particular attention will be paid to the concept of CO2-streams valorization and to the integration of the process with renewable energies. Aspects related to new promising technologies such as in situ, ex situ, hybrid biomethanation and the concept of underground methanation will be discussed, also in connection with recent application cases. Furthermore, the technical and economic feasibility will be critically analyzed to highlight current options and limitations for implementing a sustainable process.
Collapse
|
7
|
de Jonge N, Poulsen JS, Vechi NT, Kofoed MVW, Nielsen JL. Wood-Ljungdahl pathway utilisation during in situ H 2 biomethanation. THE SCIENCE OF THE TOTAL ENVIRONMENT 2022; 806:151254. [PMID: 34710425 DOI: 10.1016/j.scitotenv.2021.151254] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/24/2021] [Revised: 10/22/2021] [Accepted: 10/22/2021] [Indexed: 06/13/2023]
Abstract
Biogas production from organic waste is a waste-to-energy technology with the potential to contribute significantly to sustainable energy production. Upgrading of biogas using in situ biomethanation with hydrogen has the potential for surplus electricity storage, and delivery of biogas with a methane content of >90%, allowing for easier integration into the natural gas grid, as well as conversion to other products. Microbial communities in biomethanation reactors undergo changes, however, these changes are largely unexplored. In the present study, metagenome-resolved protein stable isotope probing (Protein-SIP) was applied to laboratory scale batch incubations operating under anaerobic digestion, and (pre-adapted) biomethanation conditions, fed with 13C-labelled bicarbonate, in order to gain insight into the microbial activities during CO2-reduction. The strongest and most microbially diverse isotopic incorporation was observed in the pre-adapted biomethanation incubation. Furthermore, divergent incorporation of 13C-labelled bicarbonate was also observed in the Wood-Ljungdahl pathway, with the anaerobic digester incubations primarily showing labelled proteins in the peripheral pathways leading toward production of energy and biomass. The pre-adapted biomethanation incubations consumed H2 and CO2, but did not convert it to CH4, suggesting the production of acetate in these incubations, which was supported by heavy labelling of key enzymes in the Wood-Ljungdahl pathway. Twelve (ten high quality) metagenome-assembled genomes (MAGs) coding for 13C-incorporated proteins were extracted from the metagenome, eight of which contained one or more of the key genes in the Wood-Ljungdahl pathway, one of which was affiliated to Methanosarcina. Together, the findings in the present study deepen our knowledge surrounding microbial communities in biomethanation systems, and contribute to the development of better strategies for implementation of biogas upgrading and microbial management.
Collapse
Affiliation(s)
- Nadieh de Jonge
- Department of Chemistry and Bioscience, Aalborg University, Fredrik Bajers Vej 7H, DK-9220 Aalborg E, Denmark.
| | - Jan Struckmann Poulsen
- Department of Chemistry and Bioscience, Aalborg University, Fredrik Bajers Vej 7H, DK-9220 Aalborg E, Denmark.
| | - Nathalia Thygesen Vechi
- Department of Biological and Chemical Engineering, Aarhus University, Hangøvej 2, DK-8200 Aarhus N, Denmark.
| | | | - Jeppe Lund Nielsen
- Department of Chemistry and Bioscience, Aalborg University, Fredrik Bajers Vej 7H, DK-9220 Aalborg E, Denmark.
| |
Collapse
|
8
|
Inoue M, Omae K, Nakamoto I, Kamikawa R, Yoshida T, Sako Y. Biome-specific distribution of Ni-containing carbon monoxide dehydrogenases. Extremophiles 2022; 26:9. [PMID: 35059858 PMCID: PMC8776680 DOI: 10.1007/s00792-022-01259-y] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/07/2021] [Accepted: 01/04/2022] [Indexed: 11/24/2022]
Abstract
Ni-containing carbon monoxide dehydrogenase (Ni-CODH) plays an important role in the CO/CO2-based carbon and energy metabolism of microbiomes. Ni-CODH is classified into distinct phylogenetic clades, A–G, with possibly distinct cellular roles. However, the types of Ni-CODH clade used by organisms in different microbiomes are unknown. Here, we conducted a metagenomic survey of a protein database to determine the relationship between the phylogeny and biome distribution of Ni-CODHs. Clustering and phylogenetic analyses showed that the metagenome assembly-derived Ni-CODH sequences were distributed in ~ 60% Ni-CODH clusters and in all Ni-CODH clades. We also identified a novel Ni-CODH clade, clade H. Biome mapping on the Ni-CODH phylogenetic tree revealed that Ni-CODHs of almost all the clades were found in natural aquatic environmental and engineered samples, whereas those of specific subclades were found only in host-associated samples. These results are comparable with our finding that the diversity in the phylum-level taxonomy of host-associated Ni-CODH owners is statistically different from those of the other biomes. Our findings suggest that while Ni-CODH is a ubiquitous enzyme produced across diverse microbiomes, its distribution in each clade is biased and mainly affected by the distinct composition of microbiomes.
Collapse
Affiliation(s)
- Masao Inoue
- Graduate School of Agriculture, Kyoto University, Kitashirakawa Oiwake-cho, Sakyo-ku, Kyoto, 606-8502, Japan.
- R-GIRO, Ritsumeikan University, 1-1-1 Nojihigashi, Kusatsu, Shiga, 525-8577, Japan.
- College of Life Sciences, Ritsumeikan University, 1-1-1 Nojihigashi, Kusatsu, Shiga, 525-8577, Japan.
| | - Kimiho Omae
- Department of Integrated Biosciences, Graduate School of Frontier Science, The University of Tokyo, 5-1-5 Kashiwanoha, Kashiwa, Chiba, 277-8561, Japan
| | - Issei Nakamoto
- Graduate School of Agriculture, Kyoto University, Kitashirakawa Oiwake-cho, Sakyo-ku, Kyoto, 606-8502, Japan
| | - Ryoma Kamikawa
- Graduate School of Agriculture, Kyoto University, Kitashirakawa Oiwake-cho, Sakyo-ku, Kyoto, 606-8502, Japan
| | - Takashi Yoshida
- Graduate School of Agriculture, Kyoto University, Kitashirakawa Oiwake-cho, Sakyo-ku, Kyoto, 606-8502, Japan
| | - Yoshihiko Sako
- Graduate School of Agriculture, Kyoto University, Kitashirakawa Oiwake-cho, Sakyo-ku, Kyoto, 606-8502, Japan
| |
Collapse
|
9
|
Braga Nan L, Trably E, Santa-Catalina G, Bernet N, Delgenes JP, Escudie R. Microbial community redundance in biomethanation systems lead to faster recovery of methane production rates after starvation. THE SCIENCE OF THE TOTAL ENVIRONMENT 2022; 804:150073. [PMID: 34517312 DOI: 10.1016/j.scitotenv.2021.150073] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/09/2021] [Revised: 08/11/2021] [Accepted: 08/28/2021] [Indexed: 06/13/2023]
Abstract
The Power-to-Gas concept corresponds to the use of the electric energy surplus to produce H2 by water electrolysis, that can be further converted to methane by biomethanation. However, the fluctuant production of renewable energy sources can lead to discontinuous H2 injections into the reactors, that may interfere with the adaptation of the microbial community to high H2 partial pressures. In this study, the response of the microbial community to H2 and organic feed starvation was evaluated in in-situ and ex-situ biomethanation. The fed-batch reactors were fed with acetate or glucose and H2, and one or four weeks of starvation periods were investigated. Methane productivity was mostly affected by the four-week starvation period. However, both in-situ and ex-situ biomethanation reactors recovered their methane production rate after starvation within approximately one-week of normal operation, while the anaerobic digestion (AD) reactors did not recover their performances even after 3 weeks of normal operation. The recovery failure of the AD reactors was probably related to a slow growth of the syntrophic and methanogen microorganisms, that led to a VFA accumulation. On the contrary, the faster recovery of both biomethanation reactors was related to the replacement of Methanoculleus sp. by Methanobacterium sp., restoring the methane production in the in-situ and ex-situ biomethanation reactors. This study has shown that biomethanation processes can respond favourably to the intermittent H2 addition without compromising their CH4 production performance.
Collapse
Affiliation(s)
- L Braga Nan
- INRAE, Univ. Montpellier, LBE, 102 AV. des Etangs, 11100 Narbonne, France
| | - E Trably
- INRAE, Univ. Montpellier, LBE, 102 AV. des Etangs, 11100 Narbonne, France
| | - G Santa-Catalina
- INRAE, Univ. Montpellier, LBE, 102 AV. des Etangs, 11100 Narbonne, France
| | - N Bernet
- INRAE, Univ. Montpellier, LBE, 102 AV. des Etangs, 11100 Narbonne, France
| | - J-P Delgenes
- INRAE, Univ. Montpellier, LBE, 102 AV. des Etangs, 11100 Narbonne, France
| | - R Escudie
- INRAE, Univ. Montpellier, LBE, 102 AV. des Etangs, 11100 Narbonne, France.
| |
Collapse
|
10
|
Impact of Granular Activated Carbon on Anaerobic Process and Microbial Community Structure during Mesophilic and Thermophilic Anaerobic Digestion of Chicken Manure. SUSTAINABILITY 2022. [DOI: 10.3390/su14010447] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 02/06/2023]
Abstract
In this work, the impact of granular activated carbon (GAC) on the mesophilic and thermophilic anaerobic digestion of chicken manure and the structure of microbial communities was investigated. These results demonstrated that GAC supplementation effectively enhanced the consumption of produced organic acids in the mesophilic and thermophilic batch tests, accompanied by faster biomethane production in the presence of GAC than from reactors without GAC. However, since the free ammonia level was 3–6 times higher in the thermophilic reactors, this led to the instability of the anaerobic digestion process of the nitrogen-rich substrate at thermophilic temperatures. Bacteroidia and Clostridia were the two main bacterial classes in the mesophilic reactors, whereas the class Clostridia had a competitive advantage over other groups in the thermophilic systems. The archaeal communities in the mesophilic reactors were mainly represented by representatives of the genera Methanosarcina, Methanobacterium, and Methanotrix, whereas the archaeal communities in the thermophilic reactors were mainly represented by members of the genera Methanosarcina, Methanoculleus, and Methanothermobacter. New data obtained in this research will help control and manage biogas reactors in the presence of GAC at different temperatures.
Collapse
|
11
|
Kim NK, Lee SH, Kim Y, Park HD. Current understanding and perspectives in anaerobic digestion based on genome-resolved metagenomic approaches. BIORESOURCE TECHNOLOGY 2022; 344:126350. [PMID: 34813924 DOI: 10.1016/j.biortech.2021.126350] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/30/2021] [Revised: 11/09/2021] [Accepted: 11/11/2021] [Indexed: 06/13/2023]
Abstract
Anaerobic digestion (AD) is a technique that can be used to treat high concentrations of various organic wastes using a consortium of functionally diverse microorganisms under anaerobic conditions. Methane gas, a beneficial by-product of the AD process, is a renewable energy source that can replace fossil fuels following purification. However, detailed functional roles and metabolic interactions between microbial populations involved in organic waste removal and methanogenesis are yet to be known. Recent metagenomic approaches based on advanced high-throughput sequencing techniques have enabled the exploration of holistic microbial taxonomy and functionality of complex microbial populations involved in the AD process. Gene-centric and genome-centric analyses based on metagenome-assembled genomes are a platform that can be used to study the composition of microbial communities and their roles during AD. This review looks at how these up-to-date metagenomic analyses can be applied to promote our understanding and improved the development of the AD process.
Collapse
Affiliation(s)
- Na-Kyung Kim
- School of Civil, Environmental and Architectural Engineering, Korea University, Seoul, South Korea
| | - Sang-Hoon Lee
- School of Civil, Environmental and Architectural Engineering, Korea University, Seoul, South Korea
| | - Yonghoon Kim
- School of Civil, Environmental and Architectural Engineering, Korea University, Seoul, South Korea
| | - Hee-Deung Park
- School of Civil, Environmental and Architectural Engineering, Korea University, Seoul, South Korea.
| |
Collapse
|
12
|
Zhao J, Li Y, Dong R. Recent progress towards in-situ biogas upgrading technologies. THE SCIENCE OF THE TOTAL ENVIRONMENT 2021; 800:149667. [PMID: 34426339 DOI: 10.1016/j.scitotenv.2021.149667] [Citation(s) in RCA: 21] [Impact Index Per Article: 7.0] [Reference Citation Analysis] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/17/2021] [Revised: 08/10/2021] [Accepted: 08/10/2021] [Indexed: 06/13/2023]
Affiliation(s)
- Jing Zhao
- Faculty of Science and Engineering, University of Groningen, Nijenborgh 4, 9747 AG Groningen, the Netherlands.
| | - Yu Li
- College of Engineering, China Agricultural University, Qinghuadonglu No.17, 100083 Beijing, China.
| | - Renjie Dong
- College of Engineering, China Agricultural University, Qinghuadonglu No.17, 100083 Beijing, China.
| |
Collapse
|
13
|
Wu H, Wang H, Zhang Y, Antonopoulou G, Ntaikou I, Lyberatos G, Yan Q. In situ biogas upgrading via cathodic biohydrogen using mitigated ammonia nitrogen during the anaerobic digestion of Taihu blue algae in an integrated bioelectrochemical system (BES). BIORESOURCE TECHNOLOGY 2021; 341:125902. [PMID: 34523575 DOI: 10.1016/j.biortech.2021.125902] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/29/2021] [Revised: 08/29/2021] [Accepted: 09/03/2021] [Indexed: 06/13/2023]
Abstract
Biohydrogen using migrated ammonia as nitrogen source, and biogas upgrading with hydrogen collected at biocathode in an integrated bioelectrochemical system (BES) were investigated, during the anaerobic digestion of Taihu blue algae. Under an applied voltage of 0.4 V, biohydrogen (202.87 mL) reached 2.34 and 2.90 times than groups with applied voltage of 0 V and 0.8 V, respectively. Moreover, biohydrogen of the group with 1000 mg/L initial ammonia addition (524.16 mL) reached 1.53 times than that the of the control. With 0.25 bar of H2 injected at the beginning (R1), highest methane production (286.62) mL and content (75.73%) were obtained. Comparing to other groups, not only microbial genus responsible for both aceticlastic and hydrogenotrophic methanogens of the group R1 were apparently enriched, but key enzymes related to methane production also acquired better abundances. Therefore, it's promising to conduct the ammonia alleviating, hydrogen producing and biogas upgrading simultaneously using BES.
Collapse
Affiliation(s)
- Huixing Wu
- School of Environmental and Civil Engineering, Jiangnan University, Wuxi 214122, China
| | - Han Wang
- School of Environmental and Civil Engineering, Jiangnan University, Wuxi 214122, China; Jiangsu Key Laboratory of Anaerobic Biotechnology, Wuxi 214122, China
| | - Yi Zhang
- Department of Environmental Science and Engineering, Fudan University, Shanghai 200438, China
| | | | - Ioanna Ntaikou
- Institute of Chemical Engineering Sciences, Platani, Patras, GR 26504, Greece
| | - Gerasimos Lyberatos
- Institute of Chemical Engineering Sciences, Platani, Patras, GR 26504, Greece; School of Chemical Engineering, National Technical University of Athens, GR 15780 Athens, Greece
| | - Qun Yan
- School of Environmental and Civil Engineering, Jiangnan University, Wuxi 214122, China; Jiangsu Key Laboratory of Anaerobic Biotechnology, Wuxi 214122, China; Jiangsu Collaborative Innovation Center of Technology and Material of Water Treatment, Suzhou 215011, China.
| |
Collapse
|
14
|
Jiang H, Wu F, Wang Y, Feng L, Zhou H, Li Y. Characteristics of in-situ hydrogen biomethanation at mesophilic and thermophilic temperatures. BIORESOURCE TECHNOLOGY 2021; 337:125455. [PMID: 34320739 DOI: 10.1016/j.biortech.2021.125455] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/15/2021] [Revised: 06/16/2021] [Accepted: 06/20/2021] [Indexed: 06/13/2023]
Abstract
In-situ hydrogen biomethanation is a promising technology to upgrade biogas. The efficiency of biomethanation relies on various parameters, e.g. gas supplement, temperature and hydrogenotrophic methanogens. Therefore, it is important to investigate the characteristics of in-situ hydrogen biomethanation under different conditions. In this study, two experiments (lasted for 91 days and 105 days) were carried out to investigate the impacts of feeding gas and operating conditions on performances of reactors and microorganisms. During the whole experiment, no obvious fluctuation of pH and limitation of gas-liquid mass transfer were found. Results showed that the hydrogenotrophic methanogenesis performed better at thermophilic condition, while the dominant archaea genera at mesophilic and thermophilic temperature was determined to be Methanobacterium and Methanothermobacter, respectively. The highest CH4 content (greater than 90%) was obtained when H2 and CO2 was feeding at ratio of 4:1 and Methanothermobacter was dominant. These findings can provide useful information for promoting hydrogen biomethanation.
Collapse
Affiliation(s)
- Hao Jiang
- School of Materials Science&Engineering, Beijing Institute of Technology, Beijing 100081, PR China
| | - Fan Wu
- State Key Laboratory of Heavy Oil Processing, Beijing Key Laboratory of Biogas Upgrading Utilization, College of New Energy and Materials, China University of Petroleum Beijing (CUPB), Beijing 102249, PR China
| | - Yuchang Wang
- State Key Laboratory of Heavy Oil Processing, Beijing Key Laboratory of Biogas Upgrading Utilization, College of New Energy and Materials, China University of Petroleum Beijing (CUPB), Beijing 102249, PR China
| | - Lu Feng
- Department of Biological and Chemical Engineering, Aarhus University, Blichers Allé 20, 8830 Tjele, Denmark
| | - Hongjun Zhou
- State Key Laboratory of Heavy Oil Processing, Beijing Key Laboratory of Biogas Upgrading Utilization, College of New Energy and Materials, China University of Petroleum Beijing (CUPB), Beijing 102249, PR China
| | - Yeqing Li
- State Key Laboratory of Heavy Oil Processing, Beijing Key Laboratory of Biogas Upgrading Utilization, College of New Energy and Materials, China University of Petroleum Beijing (CUPB), Beijing 102249, PR China.
| |
Collapse
|
15
|
Dębowski M, Korzeniewska E, Kazimierowicz J, Zieliński M. Efficiency of sweet whey fermentation with psychrophilic methanogens. ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2021; 28:49314-49323. [PMID: 33934309 PMCID: PMC8410717 DOI: 10.1007/s11356-021-14095-y] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 10/27/2020] [Accepted: 04/20/2021] [Indexed: 06/12/2023]
Abstract
Sweet whey is a waste product from the dairy industry that is difficult to manage. High hopes are fostered regarding its neutralization in the methane fermentation. An economically viable alternative to a typical mesophilic fermentation seems to be the process involving psychrophilic bacteria isolated from the natural environment. This study aimed to determine the feasibility of exploiting psychrophilic microorganisms in methane fermentation of sweet whey. The experiments were carried out under dynamic conditions using Bio Flo 310 type flow-through anaerobic bioreactors. The temperature inside the reactors was 10 ± 1 °C. The HRT was 20 days and the OLR was 0.2 g COD/dm3/day. The study yielded 132.7 ± 13.8 mL biogas/gCODremoved. The CH4 concentration in the biogas was 32.7 ± 1.6%, that of H2 was 8.7 ± 4.7%, whereas that of CO2 reached 58.42 ± 2.47%. Other gases were also determined, though in lower concentrations. The COD and BOD5 removal efficiency reached 21.4 ± 0.6% and 17.6 ± 1.0%, respectively.
Collapse
Affiliation(s)
- Marcin Dębowski
- Department of Environment Engineering, Faculty of Geoengineering, University of Warmia and Mazury in Olsztyn, 10-720, Olsztyn, Poland
| | - Ewa Korzeniewska
- Department of Water Protection Engineering and Environmental Microbiology, Faculty of Geoengineering, University of Warmia and Mazury in Olsztyn, 10-720, Olsztyn, Poland
| | - Joanna Kazimierowicz
- Department of Water Supply and Sewage Systems, Faculty of Civil Engineering and Environmental Sciences, Bialystok University of Technology, 15-351, Bialystok, Poland.
| | - Marcin Zieliński
- Department of Environment Engineering, Faculty of Geoengineering, University of Warmia and Mazury in Olsztyn, 10-720, Olsztyn, Poland
| |
Collapse
|
16
|
Wahid R, Horn SJ. Impact of operational conditions on methane yield and microbial community composition during biological methanation in in situ and hybrid reactor systems. BIOTECHNOLOGY FOR BIOFUELS 2021; 14:170. [PMID: 34416924 PMCID: PMC8379887 DOI: 10.1186/s13068-021-02019-4] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 05/27/2021] [Accepted: 08/09/2021] [Indexed: 06/13/2023]
Abstract
BACKGROUND Biogas can be upgraded to methane biologically by adding H2 to biogas reactors. The process is called biological methanation (BM) and can be done in situ in a regular biogas reactor or the biogas can be transferred to a separate ex situ upgrading reactor. The hybrid BM concept, a combination of in situ and ex situ BM, has received little attention, and only a few studies have been reported. The hybrid BM has the advantage of resolving the issue of pH increment during in situ BM, while the size of the ex situ BM reactor could be reduced. RESULTS In this study, the efficiency of in situ and hybrid biological methanation (BM) for upgrading raw biogas was investigated. The hybrid BM system achieved a CH4 yield of 257 mL gVS-1 when degrading a feedstock blend of manure and cheese waste. This represented an increase in methane yield of 76% when compared to the control reactor with no H2 addition. A 2:1 H2:CO2 ratio resulted in stable reactor performance, while a 4:1 ratio resulted in a high accumulation of volatile fatty acids. H2 consumption rate was improved when a low manure-cheese waste ratio (90%:10%) was applied. Furthermore, feeding less frequently (every 48 h) resulted in a higher CH4 production from CO2 and H2. Methanothermobacter was found to dominate the archaeal community in the in situ BM reactor, and its relative abundance increased over the experimental time. Methanosarcina abundance was negatively affected by H2 addition and was nearly non-existent at the end of the experiment. CONCLUSIONS Our results show that hybrid BM outperforms in situ BM in terms of total CH4 production and content of CH4 in the biogas. In comparison to in situ BM, the use of hybrid BM increased CH4 yield by up to 42%. Furthermore, addition of H2 at 2:1 H2:CO2 ratio in in situ BM resulted in stable reactor operation.
Collapse
Affiliation(s)
- Radziah Wahid
- Faculty of Chemistry, Biotechnology, and Food Science, Norwegian University of Life Sciences (NMBU), P.O. Box 5003, 1432 Ås, Norway
| | - Svein Jarle Horn
- Faculty of Chemistry, Biotechnology, and Food Science, Norwegian University of Life Sciences (NMBU), P.O. Box 5003, 1432 Ås, Norway
| |
Collapse
|
17
|
Gaspari M, Treu L, Zhu X, Palù M, Angelidaki I, Campanaro S, Kougias PG. Microbial dynamics in biogas digesters treating lipid-rich substrates via genome-centric metagenomics. THE SCIENCE OF THE TOTAL ENVIRONMENT 2021; 778:146296. [PMID: 33714811 DOI: 10.1016/j.scitotenv.2021.146296] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/08/2021] [Revised: 02/24/2021] [Accepted: 03/02/2021] [Indexed: 06/12/2023]
Abstract
Co-digestion with lipid-rich substrates is a likely strategy in biogas plants, due to their high energy content. However, the process stability is vulnerable to inhibition due to the sudden increase of fatty-acid concentration. Therefore, techniques that promote the adaptation of the microorganisms to the presence of lipids have been proposed. In this frame, the initial hypothesis of the work was that a gradual change in feedstock composition would enable us to elucidate the microbial organisation as a result of deterministic (i.e. chemical composition of influent) and stochastic (e.g. interspecies interactions) factors. This study investigates the response of the biogas microbiome to gradual increment of the Organic Loading Rate by supplementing the influent feedstock with Na-Oleate. The results showed that as a response to the feedstock shifts three clusters describing microbes behaviours were formed. The dynamics and the functional role of the formed microbial clusters were unveiled, providing explanations for their abundance and behavior. Process monitoring indicated that the reactors responded immediately to lipid supplementation and they managed to stabilize their performance in a short period of time. The dominance of Candidatus Methanoculleus thermohydrogenotrophicum in the biogas reactors fed exclusively with cattle manure indicated that the predominant methanogenic pathway was hydrogenotrophic. Additionally, the abundance of this methanogen was further enhanced upon lipid supplementation and its growth was supported by syntrophic bacteria capable to metabolize fatty acids. However, with the shift back to the original feedstock (i.e. solely cattle manure), the microbial dynamicity significantly altered with a remarkable increment in the abundance of a propionate degrader affiliated to the order of Bacteroidales, which became the predominant microorganism of the consortium.
Collapse
Affiliation(s)
- Maria Gaspari
- Department of Hydraulics, Soil Science and Agricultural Engineering, Faculty of Agriculture, Aristotle University of Thessaloniki, GR-54124 Thessaloniki, Greece; Soil and Water Resources Institute, Hellenic Agricultural Organisation Demeter, Thermi, Thessaloniki 57001, Greece
| | - Laura Treu
- Department of Biology, University of Padova, 35131 Padova, Italy
| | - Xinyu Zhu
- Department of Environmental Engineering, Technical University of Denmark, Kgs. Lyngby DK-2800, Denmark
| | - Matteo Palù
- Department of Biology, University of Padova, 35131 Padova, Italy
| | - Irini Angelidaki
- Department of Environmental Engineering, Technical University of Denmark, Kgs. Lyngby DK-2800, Denmark
| | | | - Panagiotis G Kougias
- Soil and Water Resources Institute, Hellenic Agricultural Organisation Demeter, Thermi, Thessaloniki 57001, Greece
| |
Collapse
|
18
|
Kakuk B, Wirth R, Maróti G, Szuhaj M, Rakhely G, Laczi K, Kovács KL, Bagi Z. Early response of methanogenic archaea to H 2 as evaluated by metagenomics and metatranscriptomics. Microb Cell Fact 2021; 20:127. [PMID: 34217274 PMCID: PMC8254922 DOI: 10.1186/s12934-021-01618-y] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/27/2021] [Accepted: 06/24/2021] [Indexed: 11/10/2022] Open
Abstract
BACKGROUND The molecular machinery of the complex microbiological cell factory of biomethane production is not fully understood. One of the process control elements is the regulatory role of hydrogen (H2). Reduction of carbon dioxide (CO2) by H2 is rate limiting factor in methanogenesis, but the community intends to keep H2 concentration low in order to maintain the redox balance of the overall system. H2 metabolism in methanogens becomes increasingly important in the Power-to-Gas renewable energy conversion and storage technologies. RESULTS The early response of the mixed mesophilic microbial community to H2 gas injection was investigated with the goal of uncovering the first responses of the microbial community in the CH4 formation and CO2 mitigation Power-to-Gas process. The overall microbial composition changes, following a 10 min excessive bubbling of H2 through the reactor, was investigated via metagenome and metatranscriptome sequencing. The overall composition and taxonomic abundance of the biogas producing anaerobic community did not change appreciably 2 hours after the H2 treatment, indicating that this time period was too short to display differences in the proliferation of the members of the microbial community. There was, however, a substantial increase in the expression of genes related to hydrogenotrophic methanogenesis of certain groups of Archaea. As an early response to H2 exposure the activity of the hydrogenotrophic methanogenesis in the genus Methanoculleus was upregulated but the hydrogenotrophic pathway in genus Methanosarcina was downregulated. The RT-qPCR data corroborated the metatranscriptomic RESULTS: H2 injection also altered the metabolism of a number of microbes belonging in the kingdom Bacteria. Many Bacteria possess the enzyme sets for the Wood-Ljungdahl pathway. These and the homoacetogens are partners for syntrophic community interactions between the distinct kingdoms of Archaea and Bacteria. CONCLUSIONS External H2 regulates the functional activity of certain Bacteria and Archaea. The syntrophic cross-kingdom interactions in H2 metabolism are important for the efficient operation of the Power-to-Gas process. Therefore, mixed communities are recommended for the large scale Power-to-Gas process rather than single hydrogenotrophic methanogen strains. Fast and reproducible response from the microbial community can be exploited in turn-off and turn-on of the Power-to-Gas microbial cell factories.
Collapse
Affiliation(s)
- Balázs Kakuk
- Institute of Medical Biology, University of Szeged, Szeged, Hungary
- Department of Biotechnology, University of Szeged, Szeged, Hungary
| | - Roland Wirth
- Department of Biotechnology, University of Szeged, Szeged, Hungary
- Institute of Plant Biology, Biological Research Center, Szeged, Hungary
| | - Gergely Maróti
- Institute of Plant Biology, Biological Research Center, Szeged, Hungary
| | - Márk Szuhaj
- Department of Biotechnology, University of Szeged, Szeged, Hungary
| | - Gábor Rakhely
- Department of Biotechnology, University of Szeged, Szeged, Hungary
- Institute of Biophysics, Biological Research Center, Szeged, Hungary
| | - Krisztián Laczi
- Department of Biotechnology, University of Szeged, Szeged, Hungary
| | - Kornél L Kovács
- Department of Biotechnology, University of Szeged, Szeged, Hungary.
- Department of Oral Biology and Experimental Dental Research, University of Szeged, Szeged, Hungary.
| | - Zoltán Bagi
- Department of Biotechnology, University of Szeged, Szeged, Hungary.
| |
Collapse
|
19
|
Duan N, Kougias PG, Campanaro S, Treu L, Angelidaki I. Evolution of the microbial community structure in biogas reactors inoculated with seeds from different origin. THE SCIENCE OF THE TOTAL ENVIRONMENT 2021; 773:144981. [PMID: 33940708 DOI: 10.1016/j.scitotenv.2021.144981] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/14/2020] [Revised: 12/10/2020] [Accepted: 01/01/2021] [Indexed: 06/12/2023]
Abstract
The aim of this work was to provide solid proofs regarding the achievement of "steady-state conditions", which means that the performance of the anaerobic digester is representative of the applied environmental conditions. For this reason, we investigated how, starting from different inoculum sources (i.e., municipal wastewater treatment, bio-waste treatment, and agricultural waste biogas plant), the microbial community adapted to the operational parameters and led to stable biogas production in thermophilic digesters treating the same influent feedstock. The results revealed that the different system achieved similar process performance and microbial community structure after a period that was equal to four hydraulic retention times, approved by a constant pH of 7.89 ± 0.08, 7.92 ± 0.05 and 7.85 ± 0.08, respectively, and stable TAN concentration of 1500 mg/L. Moreover, it was found that the microbial composition of the inocula was a key factor for the speed of achieving stable process performance; thus, a pre-adapted to the influent feedstock inoculum can shorten the stabilization process. On the contrary, after long term reactor operation, the microbial structure was shaped according to the chemical composition of the influent feedstock. The results of the study can also be used as a guide in future researches on anaerobic degradation, particularly in determining the time interval of an experiment to reflect changes in the microbial community of anaerobic digester.
Collapse
Affiliation(s)
- Na Duan
- College of Water Resources and Civil Engineering, China Agricultural University, Beijing 100083, China; Department of Environmental Engineering, Technical University of Denmark, Kgs. Lyngby DK-2800, Denmark
| | - Panagiotis G Kougias
- Department of Environmental Engineering, Technical University of Denmark, Kgs. Lyngby DK-2800, Denmark; Soil and Water Resources Institute, Hellenic Agricultural Organisation- DEMETER, 57001 Thermi-Thessaloniki, Greece.
| | - Stefano Campanaro
- Department of Biology, University of Padova, Padova, Italy; CRIBI - Centro di Ricerca Interdipartimentale per le Biotecnologie Innovative Viale G. Colombo, 335131 Padova, Italy
| | - Laura Treu
- Department of Environmental Engineering, Technical University of Denmark, Kgs. Lyngby DK-2800, Denmark; CRIBI - Centro di Ricerca Interdipartimentale per le Biotecnologie Innovative Viale G. Colombo, 335131 Padova, Italy.
| | - Irini Angelidaki
- Department of Environmental Engineering, Technical University of Denmark, Kgs. Lyngby DK-2800, Denmark
| |
Collapse
|
20
|
Zhao R, Liu J, Feng J, Li X, Li B. Microbial community composition and metabolic functions in landfill leachate from different landfills of China. THE SCIENCE OF THE TOTAL ENVIRONMENT 2021; 767:144861. [PMID: 33422962 DOI: 10.1016/j.scitotenv.2020.144861] [Citation(s) in RCA: 43] [Impact Index Per Article: 14.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/09/2020] [Revised: 12/24/2020] [Accepted: 12/25/2020] [Indexed: 06/12/2023]
Abstract
Landfill leachate usually harbors complex microbial communities responsible for the decomposition of municipal solid waste. However, the diversity and metabolic functions of the microbial communities in landfill leachate as well as the factors that influence them are still not well understood. In this study, Illumina MiSeq high-throughput sequencing was used to investigate the microbial community composition and metabolic functions in landfill leachate from 11 cities in China. The microbial diversity and structure of different leachate samples exhibited obvious differences. In general, Bacteroidetes, Firmicutes and Proteobacteria were the three dominant microbial communities among the 26 bacterial phyla identified in landfill leachate, regardless of the geographical locations. Diverse bacterial genera associated with various functions such as cellulolytic bacteria (e.g., Sphaerochaeta and Defluviitoga), acidifying bacteria (e.g., Prevotella and Trichococcus) and sulfate-reducing bacteria (e.g., Desulfuromonas and Desulfobacterium) were detected abundantly in the landfill leachate. Moreover, the archaeal community in all leachate samples was dominated by the orders Methanomicrobiales and Methanosarcinales belonging to the Euryarchaeota phylum. Notably, the archaea-specific primer pair covered more diverse archaeal communities than the universal bacteria-archaea primer pair. Seventeen archaeal genera belonging to acetoclastic, hydrogenotrophic, and methylotrophic methanogens were identified, and the composition of the dominant genera in these samples varied greatly. The canonical correlation analysis indicated that landfill age, electrical conductivity, ammonia nitrogen, and total nitrogen were significantly correlated with the microbial community structure. Based on PICRUSt2, a total of 41 metabolic pathways belonging to six metabolic pathway groups were predicted, and the KEGG pathway Metabolism was the most abundant group across all leachate samples. This study provides an important insight into the composition and functional characteristics of the microbial communities in landfill leachate.
Collapse
Affiliation(s)
- Renxin Zhao
- Guangdong Provincial Engineering Research Center for Urban Water Recycling and Environmental Safety, Tsinghua Shenzhen International Graduate School, Tsinghua University, Shenzhen 518055, China; Shenzhen Engineering Research Laboratory for Sludge and Food Waste Treatment and Resource Recovery, Tsinghua Shenzhen International Graduate School, Tsinghua University, Shenzhen 518055, China
| | - Jie Liu
- Guangdong Provincial Engineering Research Center for Urban Water Recycling and Environmental Safety, Tsinghua Shenzhen International Graduate School, Tsinghua University, Shenzhen 518055, China; State Key Laboratory of Grassland Agro-ecosystems, Center for Grassland Microbiome, Lanzhou University, Lanzhou 730000, China
| | - Jie Feng
- Guangdong Provincial Engineering Research Center for Urban Water Recycling and Environmental Safety, Tsinghua Shenzhen International Graduate School, Tsinghua University, Shenzhen 518055, China; State Environmental Protection Key Laboratory of Drinking Water Source Management and Technology, Shenzhen Research Academy of Environmental Sciences, Shenzhen 518001, China
| | - Xiaoyan Li
- Guangdong Provincial Engineering Research Center for Urban Water Recycling and Environmental Safety, Tsinghua Shenzhen International Graduate School, Tsinghua University, Shenzhen 518055, China; Shenzhen Engineering Research Laboratory for Sludge and Food Waste Treatment and Resource Recovery, Tsinghua Shenzhen International Graduate School, Tsinghua University, Shenzhen 518055, China; Shenzhen Environmental Science and New Energy Laboratory, Tsinghua-Berkeley Shenzhen Institute, Tsinghua University, Shenzhen 518055, China
| | - Bing Li
- Guangdong Provincial Engineering Research Center for Urban Water Recycling and Environmental Safety, Tsinghua Shenzhen International Graduate School, Tsinghua University, Shenzhen 518055, China; Shenzhen Engineering Research Laboratory for Sludge and Food Waste Treatment and Resource Recovery, Tsinghua Shenzhen International Graduate School, Tsinghua University, Shenzhen 518055, China.
| |
Collapse
|
21
|
Yu D, Zhang Q, De Jaegher B, Liu J, Sui Q, Zheng X, Wei Y. Effect of proton pump inhibitor on microbial community, function, and kinetics in anaerobic digestion with ammonia stress. BIORESOURCE TECHNOLOGY 2021; 319:124118. [PMID: 32957047 DOI: 10.1016/j.biortech.2020.124118] [Citation(s) in RCA: 13] [Impact Index Per Article: 4.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/19/2020] [Revised: 09/08/2020] [Accepted: 09/09/2020] [Indexed: 06/11/2023]
Abstract
The proton pump is a convincing mechanism for ammonia inhibition in anaerobic digestion, which explained how the ammonia accumulated intercellularly due to diffusion of free ammonia. Proton pump inhibitor (PPI) was dosed for mitigating the accumulation in anaerobic digestion with ammonia stress, with respect to kinetics. Results show PPI inhibited β-oxidation of fatty acids by targeting ATPase in anaerobic digestion with ammonia stress. Alternatively, PPI stimulated syntrophic acetate oxidization. Random forest located key genera as syntrophic consortia. Methane increased 18.72 ± 7.39% with 20 mg/L PPI at the first peak, consistent with microbial results. The deterministic Gompertz kinetics and stochastic Gaussian processes contributed 97.63 ± 8.93% and 2.37 ± 8.93% in accumulated methane production, respectively. Thus, the use of PPI for anaerobic digestion allowed mitigate ammonia inhibition based on the mechanism of proton pump, facilitate intercellularly ammonia accumulation, stimulate syntrophic consortia, and eliminate uncertainty of process failure, which resulted in efficient methane production under ammonia stress.
Collapse
Affiliation(s)
- Dawei Yu
- State Key Joint Laboratory of Environmental Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China; BIOMATH, Department of Data Analysis and Mathematical Modelling, Ghent University, Coupure Links 653, Ghent 9000, Belgium
| | - Qingqing Zhang
- State Key Joint Laboratory of Environmental Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; School of Environment & Natural Resources, Renmin University of China, Beijing 100872, China
| | - Bram De Jaegher
- BIOMATH, Department of Data Analysis and Mathematical Modelling, Ghent University, Coupure Links 653, Ghent 9000, Belgium
| | - Jibao Liu
- State Key Joint Laboratory of Environmental Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China
| | - Qianwen Sui
- State Key Joint Laboratory of Environmental Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China
| | - Xiang Zheng
- School of Environment & Natural Resources, Renmin University of China, Beijing 100872, China.
| | - Yuansong Wei
- State Key Joint Laboratory of Environmental Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing, China; Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China.
| |
Collapse
|
22
|
Microbial Communities and Sulfate-Reducing Microorganisms Abundance and Diversity in Municipal Anaerobic Sewage Sludge Digesters from a Wastewater Treatment Plant (Marrakech, Morocco). Processes (Basel) 2020. [DOI: 10.3390/pr8101284] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/16/2022] Open
Abstract
Both molecular analyses and culture-dependent isolation were combined to investigate the diversity of sulfate-reducing prokaryotes and explore their role in sulfides production in full-scale anaerobic digesters (Marrakech, Morocco). At global scale, using 16S rRNA gene sequencing, Proteobacteria, Bacteroidetes, Firmicutes, Actinobacteria, Synergistetes, and Euryarchaeota were the most dominant phyla. The abundance of Archaea (3.1–5.7%) was linked with temperature. The mcrA gene ranged from 2.18 × 105 to 1.47 × 107 gene copies.g−1 of sludge. The sulfate-reducing prokaryotes, representing 5% of total sequences, involved in sulfides production were Peptococcaceae, Syntrophaceae, Desulfobulbaceae, Desulfovibrionaceae, Syntrophobacteraceae, Desulfurellaceae, and Desulfobacteraceae. Furthermore, dsrB gene ranged from 2.18 × 105 to 1.92 × 107 gene copies.g−1 of sludge. The results revealed that exploration of diversity and function of sulfate-reducing bacteria may play a key role in decreasing sulfide production, an undesirable by-product, during anaerobic digestion.
Collapse
|
23
|
Yan M, Treu L, Zhu X, Tian H, Basile A, Fotidis IA, Campanaro S, Angelidaki I. Insights into Ammonia Adaptation and Methanogenic Precursor Oxidation by Genome-Centric Analysis. ENVIRONMENTAL SCIENCE & TECHNOLOGY 2020; 54:12568-12582. [PMID: 32852203 PMCID: PMC8154354 DOI: 10.1021/acs.est.0c01945] [Citation(s) in RCA: 38] [Impact Index Per Article: 9.5] [Reference Citation Analysis] [Abstract] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/28/2020] [Revised: 08/22/2020] [Accepted: 08/27/2020] [Indexed: 05/04/2023]
Abstract
Ammonia released from the degradation of protein and/or urea usually leads to suboptimal anaerobic digestion (AD) when N-rich organic waste is used. However, the insights behind the differential ammonia tolerance of anaerobic microbiomes remain an enigma. In this study, the cultivation in synthetic medium with different carbon sources (acetate, methanol, formate, and H2/CO2) shaped a common initial inoculum into four unique ammonia-tolerant syntrophic populations. Specifically, various levels of ammonia tolerance were observed: consortia fed with methanol and H2/CO2 could grow at ammonia levels up to 7.25 g NH+-N/L, whereas the other two groups (formate and acetate) only thrived at 5.25 and 4.25 g NH+-N/L, respectively. Metabolic reconstruction highlighted that this divergent microbiome might be achieved by complementary metabolisms to maximize biomethane recovery from carbon sources, thus indicating the importance of the syntrophic community in the AD of N-rich substrates. Besides, sodium/proton antiporter operon, osmoprotectant/K+ regulator, and osmoprotectant synthesis operon may function as the main drivers of adaptation to the ammonia stress. Moreover, energy from the substrate-level phosphorylation and multiple energy-converting hydrogenases (e.g., Ech and Eha) could aid methanogens to balance the energy request for anabolic activities and contribute to thriving when exposed to high ammonia levels.
Collapse
Affiliation(s)
- Miao Yan
- Department of Environmental
Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kongens Lyngby, Denmark
| | - Laura Treu
- Department of Biology, University
of Padova, Via U. Bassi
58/b, 35121 Padova, Italy
| | - Xinyu Zhu
- Department of Environmental
Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kongens Lyngby, Denmark
| | - Hailin Tian
- Department of Environmental
Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kongens Lyngby, Denmark
- NUS Environmental Research Institute, National
University of Singapore, 1 Create Way, 138602, Singapore
| | - Arianna Basile
- Department of Biology, University
of Padova, Via U. Bassi
58/b, 35121 Padova, Italy
| | - Ioannis A. Fotidis
- Department of Environmental
Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kongens Lyngby, Denmark
- School of Civil Engineering, Southeast University, 210096 Nanjing, China
| | - Stefano Campanaro
- Department of Biology, University
of Padova, Via U. Bassi
58/b, 35121 Padova, Italy
- CRIBI Biotechnology Center, University of Padua, 35131 Padua, Italy
| | - Irini Angelidaki
- Department of Environmental
Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kongens Lyngby, Denmark
| |
Collapse
|
24
|
Fu S, Angelidaki I, Zhang Y. In situ Biogas Upgrading by CO 2-to-CH 4 Bioconversion. Trends Biotechnol 2020; 39:336-347. [PMID: 32917407 DOI: 10.1016/j.tibtech.2020.08.006] [Citation(s) in RCA: 48] [Impact Index Per Article: 12.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/21/2020] [Revised: 08/18/2020] [Accepted: 08/18/2020] [Indexed: 11/30/2022]
Abstract
Biogas produced by anaerobic digestion is an important renewable energy carrier. Nevertheless, the high CO2 content in biogas limits its utilization to mainly heat and electricity generation. Upgrading biogas into biomethane broadens its potential as a vehicle fuel or substitute for natural gas. CO2-to-CH4 bioconversion represents one cutting-edge solution for biogas upgrading. In situ bioconversion can capture endogenous CO2 directly from the biogas reactor, is easy to operate, and provides an infrastructure for renewable electricity storage. Despite these advantages, several challenges need to be addressed to move in situ upgrading technologies closer to applications at scale. This opinion article reviews the state of the art of this technology and identifies some obstacles and opportunities of biological in-situ upgrading technologies for future development.
Collapse
Affiliation(s)
- Shanfei Fu
- School of Environment and Civil Engineering, Jiangnan University, Wuxi, Jiangsu Province 214122, China; Department of Environmental Engineering, Technical University of Denmark, DK-2800 Lyngby, Denmark
| | - Irini Angelidaki
- Department of Environmental Engineering, Technical University of Denmark, DK-2800 Lyngby, Denmark
| | - Yifeng Zhang
- Department of Environmental Engineering, Technical University of Denmark, DK-2800 Lyngby, Denmark.
| |
Collapse
|
25
|
Basile A, Campanaro S, Kovalovszki A, Zampieri G, Rossi A, Angelidaki I, Valle G, Treu L. Revealing metabolic mechanisms of interaction in the anaerobic digestion microbiome by flux balance analysis. Metab Eng 2020; 62:138-149. [PMID: 32905861 DOI: 10.1016/j.ymben.2020.08.013] [Citation(s) in RCA: 27] [Impact Index Per Article: 6.8] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/05/2020] [Revised: 08/03/2020] [Accepted: 08/24/2020] [Indexed: 10/23/2022]
Abstract
Anaerobic digestion is a key biological process for renewable energy, yet the mechanistic knowledge on its hidden microbial dynamics is still limited. The present work charted the interaction network in the anaerobic digestion microbiome via the full characterization of pairwise interactions and the associated metabolite exchanges. To this goal, a novel collection of 836 genome-scale metabolic models was built to represent the functional capabilities of bacteria and archaea species derived from genome-centric metagenomics. Dominant microbes were shown to prefer mutualistic, parasitic and commensalistic interactions over neutralism, amensalism and competition, and are more likely to behave as metabolite importers and profiteers of the coexistence. Additionally, external hydrogen injection positively influences microbiome dynamics by promoting commensalism over amensalism. Finally, exchanges of glucogenic amino acids were shown to overcome auxotrophies caused by an incomplete tricarboxylic acid cycle. Our novel strategy predicted the most favourable growth conditions for the microbes, overall suggesting strategies to increasing the biogas production efficiency. In principle, this approach could also be applied to microbial populations of biomedical importance, such as the gut microbiome, to allow a broad inspection of the microbial interplays.
Collapse
Affiliation(s)
- Arianna Basile
- Department of Biology, University of Padova, Via U. Bassi 58/b, 35121, Padua, Italy
| | - Stefano Campanaro
- Department of Biology, University of Padova, Via U. Bassi 58/b, 35121, Padua, Italy; CRIBI Biotechnology Center, University of Padova, 35131, Padua, Italy.
| | - Adam Kovalovszki
- Department of Environmental Engineering, Technical University of Denmark, 2800, Kgs. Lyngby, Denmark
| | - Guido Zampieri
- Department of Biology, University of Padova, Via U. Bassi 58/b, 35121, Padua, Italy; Department of Computer Science and Information Systems, Teesside University, Middlesbrough, United Kingdom
| | - Alessandro Rossi
- Department of Biology, University of Padova, Via U. Bassi 58/b, 35121, Padua, Italy
| | - Irini Angelidaki
- Department of Environmental Engineering, Technical University of Denmark, 2800, Kgs. Lyngby, Denmark
| | - Giorgio Valle
- Department of Biology, University of Padova, Via U. Bassi 58/b, 35121, Padua, Italy
| | - Laura Treu
- Department of Biology, University of Padova, Via U. Bassi 58/b, 35121, Padua, Italy
| |
Collapse
|
26
|
Braga Nan L, Trably E, Santa-Catalina G, Bernet N, Delgenès JP, Escudié R. Biomethanation processes: new insights on the effect of a high H 2 partial pressure on microbial communities. BIOTECHNOLOGY FOR BIOFUELS 2020; 13:141. [PMID: 32793302 PMCID: PMC7419211 DOI: 10.1186/s13068-020-01776-y] [Citation(s) in RCA: 10] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 04/15/2020] [Accepted: 07/29/2020] [Indexed: 06/11/2023]
Abstract
BACKGROUND Biomethanation is a promising solution to upgrade the CH4 content in biogas. This process consists in the injection of H2 into an anaerobic digester, using the capacity of indigenous hydrogenotrophic methanogens for converting the injected H2 and the CO2 generated from the anaerobic digestion process into CH4. However, the injection of H2 could cause process disturbances by impacting the microbial communities of the anaerobic digester. Better understanding on how the indigenous microbial community can adapt to high H2 partial pressures is therefore required. RESULTS Seven microbial inocula issued from industrial bioprocesses treating different types of waste were exposed to a high H2 partial pressure in semi-continuous reactors. After 12 days of operation, even though both CH4 and volatile fatty acids (VFA) were produced as end products, one of them was the main product. Acetate was the most abundant VFA, representing up to 94% of the total VFA production. VFA accumulation strongly anti-correlated with CH4 production according to the source of inoculum. Three clusters of inocula were distinguished: (1) inocula leading to CH4 production, (2) inocula leading to the production of methane and VFA in a low proportion, and (3) inocula leading to the accumulation of mostly VFA, mainly acetate. Interestingly, VFA accumulation was highly correlated to a low proportion of archaea in the inocula, a higher amount of homoacetogens than hydrogenotrophic methanogens and, the absence or the very low abundance in members from the Methanosarcinales order. The best methanogenic performances were obtained when hydrogenotrophic methanogens and Methanosarcina sp. co-dominated all along the operation. CONCLUSIONS New insights on the microbial community response to high H2 partial pressure are provided in this work. H2 injection in semi-continuous reactors showed a significant impact on microbial communities and their associated metabolic patterns. Hydrogenotrophic methanogens, Methanobacterium sp. or Methanoculleus sp. were highly selected in the reactors, but the presence of co-dominant Methanosarcinales related species were required to produce higher amounts of CH4 than VFA.
Collapse
Affiliation(s)
- Lucia Braga Nan
- INRAE, Univ Montpellier, LBE, 102 Avenue des Etangs, 11100 Narbonne, France
| | - Eric Trably
- INRAE, Univ Montpellier, LBE, 102 Avenue des Etangs, 11100 Narbonne, France
| | | | - Nicolas Bernet
- INRAE, Univ Montpellier, LBE, 102 Avenue des Etangs, 11100 Narbonne, France
| | | | - Renaud Escudié
- INRAE, Univ Montpellier, LBE, 102 Avenue des Etangs, 11100 Narbonne, France
| |
Collapse
|
27
|
Dyksma S, Jansen L, Gallert C. Syntrophic acetate oxidation replaces acetoclastic methanogenesis during thermophilic digestion of biowaste. MICROBIOME 2020; 8:105. [PMID: 32620171 PMCID: PMC7334858 DOI: 10.1186/s40168-020-00862-5] [Citation(s) in RCA: 69] [Impact Index Per Article: 17.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/28/2020] [Accepted: 05/11/2020] [Indexed: 05/19/2023]
Abstract
BACKGROUND Anaerobic digestion (AD) is a globally important technology for effective waste and wastewater management. In AD, microorganisms interact in a complex food web for the production of biogas. Here, acetoclastic methanogens and syntrophic acetate-oxidizing bacteria (SAOB) compete for acetate, a major intermediate in the mineralization of organic matter. Although evidence is emerging that syntrophic acetate oxidation is an important pathway for methane production, knowledge about the SAOB is still very limited. RESULTS A metabolic reconstruction of metagenome-assembled genomes (MAGs) from a thermophilic solid state biowaste digester covered the basic functions of the biogas microbial community. Firmicutes was the most abundant phylum in the metagenome (53%) harboring species that take place in various functions ranging from the hydrolysis of polymers to syntrophic acetate oxidation. The Wood-Ljungdahl pathway for syntrophic acetate oxidation and corresponding genes for energy conservation were identified in a Dethiobacteraceae MAG that is phylogenetically related to known SAOB. 16S rRNA gene amplicon sequencing and enrichment cultivation consistently identified the uncultured Dethiobacteraceae together with Syntrophaceticus, Tepidanaerobacter, and unclassified Clostridia as members of a potential acetate-oxidizing core community in nine full-scare digesters, whereas acetoclastic methanogens were barely detected. CONCLUSIONS Results presented here provide new insights into a remarkable anaerobic digestion ecosystem where acetate catabolism is mainly realized by Bacteria. Metagenomics and enrichment cultivation revealed a core community of diverse and novel uncultured acetate-oxidizing bacteria and point to a particular niche for them in dry fermentation of biowaste. Their genomic repertoire suggests metabolic plasticity besides the potential for syntrophic acetate oxidation. Video Abstract.
Collapse
Affiliation(s)
- Stefan Dyksma
- Faculty of Technology, Microbiology - Biotechnology, University of Applied Sciences Emden/Leer, Emden, Germany.
| | - Lukas Jansen
- Faculty of Technology, Microbiology - Biotechnology, University of Applied Sciences Emden/Leer, Emden, Germany
| | - Claudia Gallert
- Faculty of Technology, Microbiology - Biotechnology, University of Applied Sciences Emden/Leer, Emden, Germany
| |
Collapse
|
28
|
Logroño W, Popp D, Kleinsteuber S, Sträuber H, Harms H, Nikolausz M. Microbial Resource Management for Ex Situ Biomethanation of Hydrogen at Alkaline pH. Microorganisms 2020; 8:microorganisms8040614. [PMID: 32344539 PMCID: PMC7232305 DOI: 10.3390/microorganisms8040614] [Citation(s) in RCA: 26] [Impact Index Per Article: 6.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/19/2020] [Revised: 04/16/2020] [Accepted: 04/21/2020] [Indexed: 12/13/2022] Open
Abstract
Biomethanation is a promising solution to convert H2 (produced from surplus electricity) and CO2 to CH4 by using hydrogenotrophic methanogens. In ex situ biomethanation with mixed cultures, homoacetogens and methanogens compete for H2/CO2. We enriched a hydrogenotrophic microbiota on CO2 and H2 as sole carbon and energy sources, respectively, to investigate these competing reactions. The microbial community structure and dynamics of bacteria and methanogenic archaea were evaluated through 16S rRNA and mcrA gene amplicon sequencing, respectively. Hydrogenotrophic methanogens and homoacetogens were enriched, as acetate was concomitantly produced alongside CH4. By controlling the media composition, especially changing the reducing agent, the formation of acetate was lowered and grid quality CH4 (≥97%) was obtained. Formate was identified as an intermediate that was produced and consumed during the bioprocess. Stirring intensities ≥ 1000 rpm were detrimental, probably due to shear force stress. The predominating methanogens belonged to the genera Methanobacterium and Methanoculleus. The bacterial community was dominated by Lutispora. The methanogenic community was stable, whereas the bacterial community was more dynamic. Our results suggest that hydrogenotrophic communities can be steered towards the selective production of CH4 from H2/CO2 by adapting the media composition, the reducing agent and the stirring intensity.
Collapse
|
29
|
Zhu X, Campanaro S, Treu L, Seshadri R, Ivanova N, Kougias PG, Kyrpides N, Angelidaki I. Metabolic dependencies govern microbial syntrophies during methanogenesis in an anaerobic digestion ecosystem. MICROBIOME 2020; 8:22. [PMID: 32061251 PMCID: PMC7024554 DOI: 10.1186/s40168-019-0780-9] [Citation(s) in RCA: 60] [Impact Index Per Article: 15.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/29/2019] [Accepted: 12/27/2019] [Indexed: 05/03/2023]
Abstract
Methanogenesis, a biological process mediated by complex microbial communities, has attracted great attention due to its contribution to global warming and potential in biotechnological applications. The current study unveiled the core microbial methanogenic metabolisms in anaerobic vessel ecosystems by applying combined genome-centric metagenomics and metatranscriptomics. Here, we demonstrate that an enriched natural system, fueled only with acetate, could support a bacteria-dominated microbiota employing a multi-trophic methanogenic process. Moreover, significant changes, in terms of microbial structure and function, were recorded after the system was supplemented with additional H2. Methanosarcina thermophila, the predominant methanogen prior to H2 addition, simultaneously performed acetoclastic, hydrogenotrophic, and methylotrophic methanogenesis. The methanogenic pattern changed after the addition of H2, which immediately stimulated Methanomicrobia-activity and was followed by a slow enrichment of Methanobacteria members. Interestingly, the essential genes involved in the Wood-Ljungdahl pathway were not expressed in bacterial members. The high expression of a glycine cleavage system indicated the activation of alternative metabolic pathways for acetate metabolism, which were reconstructed in the most abundant bacterial genomes. Moreover, as evidenced by predicted auxotrophies, we propose that specific microbes of the community were forming symbiotic relationships, thus reducing the biosynthetic burden of individual members. These results provide new information that will facilitate future microbial ecology studies of interspecies competition and symbiosis in methanogenic niches. Video abstract.
Collapse
Affiliation(s)
- Xinyu Zhu
- Department of Environmental Engineering, Technical University of Denmark, Building 115, DK-2800, Kgs. Lyngby, Denmark
- US Department of Energy, Joint Genome Institute, Walnut Creek, CA, USA
| | - Stefano Campanaro
- Department of Biology, University of Padua, Via U. Bassi 58/b, 35121, Padua, Italy
- CRIBI Biotechnology Center, University of Padua, 35131, Padua, Italy
| | - Laura Treu
- Department of Environmental Engineering, Technical University of Denmark, Building 115, DK-2800, Kgs. Lyngby, Denmark.
- Department of Biology, University of Padua, Via U. Bassi 58/b, 35121, Padua, Italy.
| | - Rekha Seshadri
- US Department of Energy, Joint Genome Institute, Walnut Creek, CA, USA
| | - Natalia Ivanova
- US Department of Energy, Joint Genome Institute, Walnut Creek, CA, USA
| | - Panagiotis G Kougias
- Department of Environmental Engineering, Technical University of Denmark, Building 115, DK-2800, Kgs. Lyngby, Denmark.
- Soil and Water Resources Institute, Hellenic Organisation-DEMETER, 57001, Thermi-, Thessaloniki, Greece.
| | - Nikos Kyrpides
- US Department of Energy, Joint Genome Institute, Walnut Creek, CA, USA
| | - Irini Angelidaki
- Department of Environmental Engineering, Technical University of Denmark, Building 115, DK-2800, Kgs. Lyngby, Denmark
| |
Collapse
|
30
|
Campanaro S, Treu L, Rodriguez-R LM, Kovalovszki A, Ziels RM, Maus I, Zhu X, Kougias PG, Basile A, Luo G, Schlüter A, Konstantinidis KT, Angelidaki I. New insights from the biogas microbiome by comprehensive genome-resolved metagenomics of nearly 1600 species originating from multiple anaerobic digesters. BIOTECHNOLOGY FOR BIOFUELS 2020; 13:25. [PMID: 32123542 PMCID: PMC7038595 DOI: 10.1186/s13068-020-01679-y] [Citation(s) in RCA: 95] [Impact Index Per Article: 23.8] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/02/2019] [Accepted: 02/08/2020] [Indexed: 05/20/2023]
Abstract
BACKGROUND Microorganisms in biogas reactors are essential for degradation of organic matter and methane production. However, a comprehensive genome-centric comparison, including relevant metadata for each sample, is still needed to identify the globally distributed biogas community members and serve as a reliable repository. RESULTS Here, 134 publicly available metagenomes derived from different biogas reactors were used to recover 1635 metagenome-assembled genomes (MAGs) representing different biogas bacterial and archaeal species. All genomes were estimated to be > 50% complete and nearly half ≥ 90% complete with ≤ 5% contamination. In most samples, specialized microbial communities were established, while only a few taxa were widespread among the different reactor systems. Metabolic reconstruction of the MAGs enabled the prediction of functional traits related to biomass degradation and methane production from waste biomass. An extensive evaluation of the replication index provided an estimation of the growth dynamics for microbes involved in different steps of the food chain. CONCLUSIONS The outcome of this study highlights a high flexibility of the biogas microbiome, allowing it to modify its composition and to adapt to the environmental conditions, including temperatures and a wide range of substrates. Our findings enhance our mechanistic understanding of the AD microbiome and substantially extend the existing repository of genomes. The established database represents a relevant resource for future studies related to this engineered ecosystem.
Collapse
Affiliation(s)
- Stefano Campanaro
- Department of Biology, University of Padova, Via U. Bassi 58/b, 35121 Padua, Italy
- CRIBI Biotechnology Center, University of Padova, 35131 Padua, Italy
| | - Laura Treu
- Department of Biology, University of Padova, Via U. Bassi 58/b, 35121 Padua, Italy
- Department of Environmental Engineering, Technical University of Denmark, 2800 Kgs. Lyngby, Denmark
| | - Luis M. Rodriguez-R
- School of Civil & Environmental Engineering and School of Biological Sciences (Adjunct), Georgia Institute of Technology, 311 Ferst Drive, Atlanta, GA 30332-0512 USA
| | - Adam Kovalovszki
- Department of Environmental Engineering, Technical University of Denmark, 2800 Kgs. Lyngby, Denmark
| | - Ryan M. Ziels
- Department of Civil Engineering, University of British Columbia, Vancouver, BC Canada
| | - Irena Maus
- Genome Research of Industrial Microorganisms, Center for Biotechnology (CeBiTec), Bielefeld University, Universitätsstr. 27, 33615 Bielefeld, Germany
| | - Xinyu Zhu
- Department of Environmental Engineering, Technical University of Denmark, 2800 Kgs. Lyngby, Denmark
| | - Panagiotis G. Kougias
- Hellenic Agricultural Organization DEMETER, Soil and Water Resources Institute, Thermi-Thessaloniki, Greece
| | - Arianna Basile
- Department of Biology, University of Padova, Via U. Bassi 58/b, 35121 Padua, Italy
| | - Gang Luo
- Shanghai Key Laboratory of Atmospheric Particle Pollution and Prevention (LAP3), Department of Environmental Science and Engineering, Fudan University, Shanghai, 200433 China
| | - Andreas Schlüter
- Hellenic Agricultural Organization DEMETER, Soil and Water Resources Institute, Thermi-Thessaloniki, Greece
| | - Konstantinos T. Konstantinidis
- School of Civil & Environmental Engineering and School of Biological Sciences (Adjunct), Georgia Institute of Technology, 311 Ferst Drive, Atlanta, GA 30332-0512 USA
| | - Irini Angelidaki
- Department of Environmental Engineering, Technical University of Denmark, 2800 Kgs. Lyngby, Denmark
| |
Collapse
|
31
|
Tian H, Mancini E, Treu L, Angelidaki I, Fotidis IA. Bioaugmentation strategy for overcoming ammonia inhibition during biomethanation of a protein-rich substrate. CHEMOSPHERE 2019; 231:415-422. [PMID: 31146133 DOI: 10.1016/j.chemosphere.2019.05.140] [Citation(s) in RCA: 35] [Impact Index Per Article: 7.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/20/2018] [Revised: 05/16/2019] [Accepted: 05/17/2019] [Indexed: 06/09/2023]
Abstract
High ammonia levels inhibit anaerobic digestion (AD) process and bioaugmentation with ammonia tolerant methanogenic culture is proposed to alleviate ammonia inhibition. In the current study, hydrogenotrophic Methanoculleus bourgensis was bioaugmented in an ammonia-inhibited continuous reactor fed mainly with microalgae (a protein-rich biomass), at extreme ammonia levels (i.e. 11 g NH4+-N L-1). The results showed 28% increase in methane production immediately after bioaugmentation. Moreover, volatile fatty acids decreased rapidly from more than 5 g L-1 to around 1 g L-1, with a fast reduction in propionate concentration. High throughput 16s rRNA gene sequencing demonstrated that the bioaugmented M. bourgensis doubled its relative abundance after bioaugmentation. "Microbiological domino effect", triggered by the bioaugmented M. bourgensis establishing a newly efficient community, was proposed as the working mechanism of the successful bioaugmentation. Additionally, a strong aceticlastic methanogenesis was found at the end of the experiment evidenced by the dominant presence of Methanosarcina soligelidi and the low abundance of syntrophic acetate oxidising bacteria at the final period. Overall, for the first time, this study proved the positive effect of bioaugmentation on ammonia inhibition alleviation of the microalgae-dominating fed reactor, paving the way of efficient utilization of other protein-rich substrates in the future.
Collapse
Affiliation(s)
- Hailin Tian
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kgs. Lyngby, DK
| | - Enrico Mancini
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kgs. Lyngby, DK
| | - Laura Treu
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kgs. Lyngby, DK
| | - Irini Angelidaki
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kgs. Lyngby, DK
| | - Ioannis A Fotidis
- Department of Environmental Engineering, Technical University of Denmark, Bygningstorvet Bygning 115, DK-2800 Kgs. Lyngby, DK.
| |
Collapse
|
32
|
Fontana A, Falasconi I, Molinari P, Treu L, Basile A, Vezzi A, Campanaro S, Morelli L. Genomic Comparison of Lactobacillus helveticus Strains Highlights Probiotic Potential. Front Microbiol 2019; 10:1380. [PMID: 31293536 PMCID: PMC6606699 DOI: 10.3389/fmicb.2019.01380] [Citation(s) in RCA: 30] [Impact Index Per Article: 6.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/21/2019] [Accepted: 06/03/2019] [Indexed: 12/20/2022] Open
Abstract
Lactobacillus helveticus belongs to the large group of lactic acid bacteria (LAB), which are the major players in the fermentation of a wide range of foods. LAB are also present in the human gut, which has often been exploited as a reservoir of potential novel probiotic strains, but several parameters need to be assessed before establishing their safety and potential use for human consumption. In the present study, six L. helveticus strains isolated from natural whey cultures were analyzed for their phenotype and genotype in exopolysaccharide (EPS) production, low pH and bile salt tolerance, bile salt hydrolase (BSH) activity, and antibiotic resistance profile. In addition, a comparative genomic investigation was performed between the six newly sequenced strains and the 51 publicly available genomes of L. helveticus to define the pangenome structure. The results indicate that the newly sequenced strain UC1267 and the deposited strain DSM 20075 can be considered good candidates for gut-adapted strains due to their ability to survive in the presence of 0.2% glycocholic acid (GCA) and 1% taurocholic and taurodeoxycholic acid (TDCA). Moreover, these strains had the highest bile salt deconjugation activity among the tested L. helveticus strains. Considering the safety profile, none of these strains presented antibiotic resistance phenotypically and/or at the genome level. The pangenome analysis revealed genes specific to the new isolates, such as enzymes related to folate biosynthesis in strains UC1266 and UC1267 and an integrated phage in strain UC1035. Finally, the presence of maltose-degrading enzymes and multiple copies of 6-phospho-β-glucosidase genes in our strains indicates the capability to metabolize sugars other than lactose, which is related solely to dairy niches.
Collapse
Affiliation(s)
- Alessandra Fontana
- Department for Sustainable Food Process - DiSTAS, Università Cattolica del Sacro Cuore, Piacenza, Italy
| | - Irene Falasconi
- Department for Sustainable Food Process - DiSTAS, Università Cattolica del Sacro Cuore, Piacenza, Italy
| | - Paola Molinari
- Department for Sustainable Food Process - DiSTAS, Università Cattolica del Sacro Cuore, Piacenza, Italy
| | - Laura Treu
- Department of Biology, University of Padua, Padua, Italy
| | - Arianna Basile
- Department of Biology, University of Padua, Padua, Italy
| | | | - Stefano Campanaro
- Department of Biology, University of Padua, Padua, Italy.,CRIBI Biotechnology Center, University of Padua, Padua, Italy
| | - Lorenzo Morelli
- Department for Sustainable Food Process - DiSTAS, Università Cattolica del Sacro Cuore, Piacenza, Italy
| |
Collapse
|
33
|
Yanuka-Golub K, Baransi-Karkaby K, Szczupak A, Reshef L, Rishpon J, Shechter R, Gophna U, Sabbah I. An electrode-assisted anaerobic digestion process for the production of high-quality biogas. WATER SCIENCE AND TECHNOLOGY : A JOURNAL OF THE INTERNATIONAL ASSOCIATION ON WATER POLLUTION RESEARCH 2019; 79:2145-2155. [PMID: 31318352 DOI: 10.2166/wst.2019.214] [Citation(s) in RCA: 8] [Impact Index Per Article: 1.6] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/10/2023]
Abstract
Biogas is a sustainable, renewable energy source generated from organic waste degradation during anaerobic digestion (AD). AD is applied for treating different types of wastewater, mostly containing high organic load. However, AD practice is still limited due to the low quality of the produced biogas. Upgrading biogas to natural gas quality (>90% CH4) is essential for broad applications. Here, an innovative bio-electrochemically assisted AD process was developed, combining wastewater treatment and biogas upgrading. This process was based on a microbial electrolysis cell (MEC) that produced hydrogen from wastewater at a relatively high efficiency, followed by high-rate anaerobic systems for completing biodegradation of organic matter and an in situ bio-methanation process. Results showed that CH4 production yield was substantially improved upon coupling of the MEC with the AD system. Interestingly, CH4 production yield increase was most notable once circulation between AD and MEC was applied, while current density was not markedly affected by the circulation rates. The microbial community analysis confirmed that the MEC enhanced hydrogen production, leading to the enrichment of hydrogenotrophic methanogens. Thus, directing soluble hydrogen from the MEC to AD is plausible, and has great potential for biogas upgrading, avoiding the need for direct hydrogen harvesting.
Collapse
Affiliation(s)
- K Yanuka-Golub
- School of Molecular Cell Biology and Biotechnology, Tel Aviv University, P.O. Box 39040, Tel Aviv 6997801, Israel E-mail:
| | - K Baransi-Karkaby
- The Regional Research & Development Center, The Galilee Society, P.O. Box 437, Shefa-Amr 20200, Israel
| | - A Szczupak
- Fluence Water Products and Innovation, 1 HaEshel Street Caesarea Industrial Park, Caesarea 30889, Israel
| | - L Reshef
- School of Molecular Cell Biology and Biotechnology, Tel Aviv University, P.O. Box 39040, Tel Aviv 6997801, Israel E-mail:
| | - J Rishpon
- School of Molecular Cell Biology and Biotechnology, Tel Aviv University, P.O. Box 39040, Tel Aviv 6997801, Israel E-mail:
| | - R Shechter
- Fluence Water Products and Innovation, 1 HaEshel Street Caesarea Industrial Park, Caesarea 30889, Israel
| | - U Gophna
- School of Molecular Cell Biology and Biotechnology, Tel Aviv University, P.O. Box 39040, Tel Aviv 6997801, Israel E-mail:
| | - I Sabbah
- The Regional Research & Development Center, The Galilee Society, P.O. Box 437, Shefa-Amr 20200, Israel; Prof. Ephraim Katzir Department of Biotechnology Engineering, Braude College, Karmiel 2161002, Israel
| |
Collapse
|
34
|
Wahid R, Mulat DG, Gaby JC, Horn SJ. Effects of H 2:CO 2 ratio and H 2 supply fluctuation on methane content and microbial community composition during in-situ biological biogas upgrading. BIOTECHNOLOGY FOR BIOFUELS 2019; 12:104. [PMID: 31164923 PMCID: PMC6489297 DOI: 10.1186/s13068-019-1443-6] [Citation(s) in RCA: 41] [Impact Index Per Article: 8.2] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/08/2019] [Accepted: 04/16/2019] [Indexed: 05/30/2023]
Abstract
BACKGROUND Commercial biogas upgrading facilities are expensive and consume energy. Biological biogas upgrading may serve as a low-cost approach because it can be easily integrated with existing facilities at biogas plants. The microbial communities found in anaerobic digesters typically contain hydrogenotrophic methanogens, which can use hydrogen (H2) as a reducing agent for conversion of carbon dioxide (CO2) into methane (CH4). Thus, biological biogas upgrading through the exogenous addition of H2 into biogas digesters for the conversion of CO2 into CH4 can increase CH4 yield and lower CO2 emission. RESULTS The addition of 4 mol of H2 per mol of CO2 was optimal for batch biogas reactors and increased the CH4 content of the biogas from 67 to 94%. The CO2 content of the biogas was reduced from 33 to 3% and the average residual H2 content was 3%. At molar H2:CO2 ratios > 4:1, all CO2 was converted into CH4, but the pH increased above 8 due to depletion of CO2, which negatively influenced the process stability. Additionally, high residual H2 content in these reactors was unfavourable, causing volatile fatty acid accumulation and reduced CH4 yields. The reactor microbial communities shifted in composition over time, which corresponded to changes in the reactor variables. Numerous taxa responded to the H2 inputs, and in particular the hydrogenotrophic methanogen Methanobacterium increased in abundance with addition of H2. In addition, the apparent rapid response of hydrogenotrophic methanogens to intermittent H2 feeding indicates the suitability of biological methanation for variable H2 inputs, aligning well with fluctuations in renewable electricity production that may be used to produce H2. CONCLUSIONS Our research demonstrates that the H2:CO2 ratio has a significant effect on reactor performance during in situ biological methanation. Consequently, the H2:CO2 molar ratio should be kept at 4:1 to avoid process instability. A shift toward hydrogenotrophic methanogenesis was indicated by an increase in the abundance of the obligate hydrogenotrophic methanogen Methanobacterium.
Collapse
Affiliation(s)
- Radziah Wahid
- Faculty of Chemistry, Biotechnology, and Food Science, Norwegian University of Life Sciences (NMBU), P.O. Box 5003, 1432 Ås, Norway
| | - Daniel Girma Mulat
- Faculty of Chemistry, Biotechnology, and Food Science, Norwegian University of Life Sciences (NMBU), P.O. Box 5003, 1432 Ås, Norway
| | - John Christian Gaby
- Faculty of Chemistry, Biotechnology, and Food Science, Norwegian University of Life Sciences (NMBU), P.O. Box 5003, 1432 Ås, Norway
| | - Svein Jarle Horn
- Faculty of Chemistry, Biotechnology, and Food Science, Norwegian University of Life Sciences (NMBU), P.O. Box 5003, 1432 Ås, Norway
| |
Collapse
|
35
|
Porté H, Kougias PG, Alfaro N, Treu L, Campanaro S, Angelidaki I. Process performance and microbial community structure in thermophilic trickling biofilter reactors for biogas upgrading. THE SCIENCE OF THE TOTAL ENVIRONMENT 2019; 655:529-538. [PMID: 30476832 DOI: 10.1016/j.scitotenv.2018.11.289] [Citation(s) in RCA: 14] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/12/2018] [Revised: 11/05/2018] [Accepted: 11/19/2018] [Indexed: 05/07/2023]
Abstract
This study evaluated the process performance and determined the microbial community structure of two lab-scale thermophilic trickling biofilter reactors used for biological methanation of hydrogen and carbon-dioxide for a total period of 94 days. Stable and robust operation was achieved by means of a single-pass gas flow. The quality of the output gas (>97%) was comparable to the methane purity achieved by commercial biogas upgrading systems fulfilling the specifications to be used as substitute to natural gas. The reactors' methane productivity reached >1.7 LCH4/(LR·d) at hydrogen loading rate of 7.2 LH2/(LR·d). The spatial distribution of the microbial consortia localized in the liquid media and biofilm enabled us to gain a deeper understanding on how the microbiome is structured inside the trickling biofilter. Sequencing results revealed a significant predominance of Methanothermobacter sp. in the biofilm. Unknown members of the class Clostridia were highly abundant in biofilm and liquid media, while acetate utilising bacteria predominated in liquid samples.
Collapse
Affiliation(s)
- Hugo Porté
- Department of Environmental Engineering, Technical University of Denmark, Kgs. Lyngby DK-2800, Denmark
| | - Panagiotis G Kougias
- Department of Environmental Engineering, Technical University of Denmark, Kgs. Lyngby DK-2800, Denmark.
| | - Natalia Alfaro
- Department of Environmental Engineering, Technical University of Denmark, Kgs. Lyngby DK-2800, Denmark; Institute of Sustainable Processes, Department of Chemical Engineering and Environmental Technology, Escuela de Ingenierías Industriales, Sede Dr. Mergelina, University of Valladolid, Dr. Mergelina s/n, 47011 Valladolid, Spain
| | - Laura Treu
- Department of Environmental Engineering, Technical University of Denmark, Kgs. Lyngby DK-2800, Denmark
| | | | - Irini Angelidaki
- Department of Environmental Engineering, Technical University of Denmark, Kgs. Lyngby DK-2800, Denmark
| |
Collapse
|
36
|
Treu L, Tsapekos P, Peprah M, Campanaro S, Giacomini A, Corich V, Kougias PG, Angelidaki I. Microbial profiling during anaerobic digestion of cheese whey in reactors operated at different conditions. BIORESOURCE TECHNOLOGY 2019; 275:375-385. [PMID: 30599281 DOI: 10.1016/j.biortech.2018.12.084] [Citation(s) in RCA: 14] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/31/2018] [Revised: 12/20/2018] [Accepted: 12/23/2018] [Indexed: 06/09/2023]
Abstract
This study investigates the efficiency in methane production of lab-scale mesophilic (37 °C) and thermophilic (54 °C) continuous stirred tank reactors fed with cheese whey at different operational conditions. Results showed that whey mono-digestion was feasible at mesophilic conditions, while at thermophilic conditions frequent acidification incidents were recorded. The limited buffer capacity of the influent feedstock was responsible for the unstable anaerobic digestion process. The co-digestion of cheese whey with cattle manure maintained the pH levels higher than 7.0, and therefore, stable methane production rates were achieved without any significant accumulation of volatile fatty acids. An additional enhancement of the methane productivity was achieved by in-situ H2 dispersion. Microbial community composition was investigated using high-throughput 16S rRNA gene amplicon sequencing and results were correlated with process parameters. Hydrogenotrophic methanogens were the dominant archaea during the whole experiment at mesophilic and thermophilic conditions.
Collapse
Affiliation(s)
- Laura Treu
- Department of Environmental Engineering, Technical University of Denmark, Kgs. Lyngby, DK-2800, Denmark; Department of Biology, University of Padua, 35131 Padua, Italy; Department of Agronomy, Food, Natural Resources, Animals and Environment (DAFNAE), University of Padua, 35020 Legnaro, PD, Italy
| | - Panagiotis Tsapekos
- Department of Environmental Engineering, Technical University of Denmark, Kgs. Lyngby, DK-2800, Denmark.
| | - Maria Peprah
- Department of Environmental Engineering, Technical University of Denmark, Kgs. Lyngby, DK-2800, Denmark
| | | | - Alessio Giacomini
- Department of Agronomy, Food, Natural Resources, Animals and Environment (DAFNAE), University of Padua, 35020 Legnaro, PD, Italy
| | - Viviana Corich
- Department of Agronomy, Food, Natural Resources, Animals and Environment (DAFNAE), University of Padua, 35020 Legnaro, PD, Italy
| | - Panagiotis G Kougias
- Department of Environmental Engineering, Technical University of Denmark, Kgs. Lyngby, DK-2800, Denmark; Institute of Animal Science, Hellenic Agricultural Organisation Demeter, Paralimni 58100, Greece
| | - Irini Angelidaki
- Department of Environmental Engineering, Technical University of Denmark, Kgs. Lyngby, DK-2800, Denmark
| |
Collapse
|
37
|
Fontana A, Kougias PG, Treu L, Kovalovszki A, Valle G, Cappa F, Morelli L, Angelidaki I, Campanaro S. Microbial activity response to hydrogen injection in thermophilic anaerobic digesters revealed by genome-centric metatranscriptomics. MICROBIOME 2018; 6:194. [PMID: 30368244 PMCID: PMC6204281 DOI: 10.1186/s40168-018-0583-4] [Citation(s) in RCA: 23] [Impact Index Per Article: 3.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/14/2018] [Accepted: 10/18/2018] [Indexed: 05/10/2023]
Abstract
BACKGROUND The expansion of renewable energy produced by windmills and photovoltaic panels has generated a considerable electricity surplus, which can be utilized in water electrolysis systems for hydrogen production. The resulting hydrogen can then be funneled to anaerobic digesters for biogas upgrading (biomethanation) purposes (power-to-methane) or to produce high value-added compounds such as short-chain fatty acids (power-to-chemicals). Genome-centric metagenomics and metatranscriptomic analyses were performed to better understand the metabolic dynamics associated with H2 injection in two different configurations of anaerobic digesters treating acidic wastes, specifically cheese manufacturing byproducts. These approaches revealed the key-genes involved in methanation and carbon fixation pathways at species level. RESULTS The biogas upgrading process in the single-stage configuration increased the CH4 content by 7%. The dominant methanogenic species responsible for the upregulation of the hydrogenotrophic pathway in this reactor was Methanothermobacter wolfeii UC0008. In the two-stage configuration, H2 injection induced an upregulation of CO2 fixation pathways producing short-chain fatty acids, mainly acetate and butyrate. In this configuration, the abundant species Anaerobaculum hydrogeniformans UC0046 and Defluviitoga tunisiensis UC0050 primarily upregulated genes related to electron transport chains, suggesting putative syntrophisms with hydrogen scavenger microbes. Interestingly, Tepidanaerobacter acetatoxydans UC0018 did not act as an acetate-oxidizer in either reactor configurations, and instead regulated pathways involved in acetate production and uptake. A putative syntrophic association between Coprothermobacter proteolyticus UC0011 and M. wolfeii UC0008 was proposed in the two-stage reactor. In order to support the transcriptomic findings regarding the hydrogen utilization routes, an advanced bioconversion model was adapted for the simulation of the single- and two-stage reactor setups. CONCLUSIONS This is the first study investigating biogas reactor metatranscriptome dynamics following hydrogen injection for biomethanation and carbon fixation to short-chain fatty acids purposes. The same microbes showed different patterns of metabolic regulation in the two reactor configurations. It was observed an effect of the specialized acidogenic reactor on the overall microbial consortium composition and activity in the two-stage digester. There were also suggested the main species responsible for methanation, short-chain fatty acids production, and electron transport chain mechanisms, in both reactor configurations.
Collapse
Affiliation(s)
- Alessandra Fontana
- Department for Sustainable Food Process, DiSTAS, Catholic University of the Sacred Heart, 29122, Piacenza, Italy
- Department of Environmental Engineering, Technical University of Denmark, 2800, Kongens Lyngby, Denmark
| | - Panagiotis G Kougias
- Department of Environmental Engineering, Technical University of Denmark, 2800, Kongens Lyngby, Denmark
| | - Laura Treu
- Department of Environmental Engineering, Technical University of Denmark, 2800, Kongens Lyngby, Denmark.
| | - Adam Kovalovszki
- Department of Environmental Engineering, Technical University of Denmark, 2800, Kongens Lyngby, Denmark
| | - Giorgio Valle
- Department of Biology, University of Padua, 35131, Padua, Italy
| | - Fabrizio Cappa
- Department for Sustainable Food Process, DiSTAS, Catholic University of the Sacred Heart, 29122, Piacenza, Italy
| | - Lorenzo Morelli
- Department for Sustainable Food Process, DiSTAS, Catholic University of the Sacred Heart, 29122, Piacenza, Italy
| | - Irini Angelidaki
- Department of Environmental Engineering, Technical University of Denmark, 2800, Kongens Lyngby, Denmark
| | | |
Collapse
|
38
|
Spatial Distribution and Diverse Metabolic Functions of Lignocellulose-Degrading Uncultured Bacteria as Revealed by Genome-Centric Metagenomics. Appl Environ Microbiol 2018; 84:AEM.01244-18. [PMID: 30006398 DOI: 10.1128/aem.01244-18] [Citation(s) in RCA: 19] [Impact Index Per Article: 3.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/22/2018] [Accepted: 07/06/2018] [Indexed: 12/25/2022] Open
Abstract
The mechanisms by which specific anaerobic microorganisms remain firmly attached to lignocellulosic material, allowing them to efficiently decompose organic matter, have yet to be elucidated. To circumvent this issue, microbiomes collected from anaerobic digesters treating pig manure and meadow grass were fractionated to separate the planktonic microbes from those adhered to lignocellulosic substrate. Assembly of shotgun reads, followed by a binning process, recovered 151 population genomes, 80 out of which were completely new and were not previously deposited in any database. Genome coverage allowed the identification of microbial spatial distribution in the engineered ecosystem. Moreover, a composite bioinformatic analysis using multiple databases for functional annotation revealed that uncultured members of the Bacteroidetes and Firmicutes follow diverse metabolic strategies for polysaccharide degradation. The structure of cellulosome in Firmicutes species can differ depending on the number and functional roles of carbohydrate-binding modules. In contrast, members of the Bacteroidetes are able to adhere to and degrade lignocellulose due to the presence of multiple carbohydrate-binding family 6 modules in beta-xylosidase and endoglucanase proteins or S-layer homology modules in unknown proteins. This study combines the concept of variability in spatial distribution with genome-centric metagenomics, allowing a functional and taxonomical exploration of the biogas microbiome.IMPORTANCE This work contributes new knowledge about lignocellulose degradation in engineered ecosystems. Specifically, the combination of the spatial distribution of uncultured microbes with genome-centric metagenomics provides novel insights into the metabolic properties of planktonic and firmly attached to plant biomass bacteria. Moreover, the knowledge obtained in this study enabled us to understand the diverse metabolic strategies for polysaccharide degradation in different species of Bacteroidetes and Clostridiales Even though structural elements of cellulosome were restricted to Clostridiales species, our study identified a putative mechanism in Bacteroidetes species for biomass decomposition, which is based on a gene cluster responsible for cellulose degradation, disaccharide cleavage to glucose, and transport to cytoplasm.
Collapse
|