1
|
Grandmont A, Rhouma M, Létourneau-Montminy MP, Thériault W, Mainville I, Arcand Y, Leduc R, Demers B, Thibodeau A. Characterization of the Effects of a Novel Probiotic on Salmonella Colonization of a Piglet-Derived Intestinal Microbiota Using Improved Bioreactor. Animals (Basel) 2024; 14:787. [PMID: 38473172 DOI: 10.3390/ani14050787] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/18/2024] [Revised: 02/20/2024] [Accepted: 02/26/2024] [Indexed: 03/14/2024] Open
Abstract
The carriage of Salmonella in pigs is a major concern for the agri-food industry and for global healthcare systems. Humans could develop salmonellosis when consuming contaminated pig products. On the other hand, some Salmonella serotypes could cause disease in swine, leading to economic losses on farms. The purpose of the present study was to characterize the anti-Salmonella activity of a novel Bacillus-based probiotic using a bioreactor containing a piglet-derived intestinal microbiota. Two methods of probiotic administration were tested: a single daily and a continuous dose. Salmonella enumeration was performed using selective agar at T24h, T48h, T72h, T96h and T120h. The DNA was extracted from bioreactor samples to perform microbiome profiling by targeted 16S rRNA gene sequencing on Illumina Miseq. The quantification of short-chain fatty acids (SCFAs) was also assessed at T120h. The probiotic decreased Salmonella counts at T96 for the daily dose and at T120 for the continuous one. Both probiotic doses affected the alpha and beta diversity of the piglet-derived microbiota (p < 0.05). A decrease in acetate concentration and an increase in propionate proportion were observed in the continuous condition. In conclusion, the tested Bacillus-based product showed a potential to modulate microbiota and reduce Salmonella colonization in a piglet-derived intestinal microbiota and could therefore be used in vivo.
Collapse
Affiliation(s)
- Amely Grandmont
- Chaire de Recherche en Salubrité des Viandes, Département de Microbiologie et Pathologie, Faculté de Médecine Vétérinaire, Université de Montréal, Montreal, QC J2S 2M2, Canada
- Groupe de Recherche et d'Enseignement en Salubrité Alimentaire, Faculté de Médecine Vétérinaire, Université de Montréal, Montreal, QC J2S 2M2, Canada
- Centre de Recherche en Infectiologie Porcine et Avicole, Faculté de Médecine Vétérinaire, Université de Montréal, Montreal, QC J2S 2M2, Canada
| | - Mohamed Rhouma
- Chaire de Recherche en Salubrité des Viandes, Département de Microbiologie et Pathologie, Faculté de Médecine Vétérinaire, Université de Montréal, Montreal, QC J2S 2M2, Canada
- Groupe de Recherche et d'Enseignement en Salubrité Alimentaire, Faculté de Médecine Vétérinaire, Université de Montréal, Montreal, QC J2S 2M2, Canada
- Centre de Recherche en Infectiologie Porcine et Avicole, Faculté de Médecine Vétérinaire, Université de Montréal, Montreal, QC J2S 2M2, Canada
| | - Marie-Pierre Létourneau-Montminy
- Centre de Recherche en Infectiologie Porcine et Avicole, Faculté de Médecine Vétérinaire, Université de Montréal, Montreal, QC J2S 2M2, Canada
- Chaire de Recherche sur les Stratégies Alternatives d'Alimentation des Porcs et des Volailles: Approche Systémique pour un Développement Durable, Faculté des Sciences de l'Agriculture et de l'Alimentation, Université Laval, Quebec, QC G1V 0A6, Canada
| | - William Thériault
- Chaire de Recherche en Salubrité des Viandes, Département de Microbiologie et Pathologie, Faculté de Médecine Vétérinaire, Université de Montréal, Montreal, QC J2S 2M2, Canada
- Groupe de Recherche et d'Enseignement en Salubrité Alimentaire, Faculté de Médecine Vétérinaire, Université de Montréal, Montreal, QC J2S 2M2, Canada
- Centre de Recherche en Infectiologie Porcine et Avicole, Faculté de Médecine Vétérinaire, Université de Montréal, Montreal, QC J2S 2M2, Canada
| | | | - Yves Arcand
- Agriculture et Agroalimentaire Canada, St-Hyacinthe, QC J2S 8E3, Canada
| | - Roland Leduc
- NUVAC Éco-Sciences, Valcourt, QC J0E 2L0, Canada
| | - Bruno Demers
- NUVAC Éco-Sciences, Valcourt, QC J0E 2L0, Canada
| | - Alexandre Thibodeau
- Chaire de Recherche en Salubrité des Viandes, Département de Microbiologie et Pathologie, Faculté de Médecine Vétérinaire, Université de Montréal, Montreal, QC J2S 2M2, Canada
- Groupe de Recherche et d'Enseignement en Salubrité Alimentaire, Faculté de Médecine Vétérinaire, Université de Montréal, Montreal, QC J2S 2M2, Canada
- Centre de Recherche en Infectiologie Porcine et Avicole, Faculté de Médecine Vétérinaire, Université de Montréal, Montreal, QC J2S 2M2, Canada
| |
Collapse
|
2
|
Koutsoumanis K, Allende A, Bolton D, Bover‐Cid S, Chemaly M, De Cesare A, Herman L, Hilbert F, Lindqvist R, Nauta M, Nonno R, Peixe L, Ru G, Simmons M, Skandamis P, Suffredini E, Fox E, Gosling R(B, Gil BM, Møretrø T, Stessl B, da Silva Felício MT, Messens W, Simon AC, Alvarez‐Ordóñez A. Persistence of microbiological hazards in food and feed production and processing environments. EFSA J 2024; 22:e8521. [PMID: 38250499 PMCID: PMC10797485 DOI: 10.2903/j.efsa.2024.8521] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/23/2024] Open
Abstract
Listeria monocytogenes (in the meat, fish and seafood, dairy and fruit and vegetable sectors), Salmonella enterica (in the feed, meat, egg and low moisture food sectors) and Cronobacter sakazakii (in the low moisture food sector) were identified as the bacterial food safety hazards most relevant to public health that are associated with persistence in the food and feed processing environment (FFPE). There is a wide range of subtypes of these hazards involved in persistence in the FFPE. While some specific subtypes are more commonly reported as persistent, it is currently not possible to identify universal markers (i.e. genetic determinants) for this trait. Common risk factors for persistence in the FFPE are inadequate zoning and hygiene barriers; lack of hygienic design of equipment and machines; and inadequate cleaning and disinfection. A well-designed environmental sampling and testing programme is the most effective strategy to identify contamination sources and detect potentially persistent hazards. The establishment of hygienic barriers and measures within the food safety management system, during implementation of hazard analysis and critical control points, is key to prevent and/or control bacterial persistence in the FFPE. Once persistence is suspected in a plant, a 'seek-and-destroy' approach is frequently recommended, including intensified monitoring, the introduction of control measures and the continuation of the intensified monitoring. Successful actions triggered by persistence of L. monocytogenes are described, as well as interventions with direct bactericidal activity. These interventions could be efficient if properly validated, correctly applied and verified under industrial conditions. Perspectives are provided for performing a risk assessment for relevant combinations of hazard and food sector to assess the relative public health risk that can be associated with persistence, based on bottom-up and top-down approaches. Knowledge gaps related to bacterial food safety hazards associated with persistence in the FFPE and priorities for future research are provided.
Collapse
|
3
|
Viltrop A, Niine T, Tobias T, Sassu EL, Bartolo ID, Pavoni E, Alborali GL, Burow E, Smith RP. A Review of Slaughter Practices and Their Effectiveness to Control Microbial - esp. Salmonella spp. - Contamination of Pig Carcasses. J Food Prot 2023; 86:100171. [PMID: 37778508 DOI: 10.1016/j.jfp.2023.100171] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/25/2023] [Revised: 09/06/2023] [Accepted: 09/26/2023] [Indexed: 10/03/2023]
Abstract
The BIOPIGEE project (part of the One Health European Joint Programme under Horizon 2020) aimed to identify relevant measures to effectively control Salmonella, and another zoonotic pathogen, hepatitis E virus (HEV) within the pig meat food chain. The aim of this study was to identify biosecurity measures or management practices that are relevant for limiting Salmonella and/or HEV occurrence and spread within pig slaughterhouses. This was with the final goal of compiling a list of biosecurity measures for different processes and operations along the slaughter line with evidence of their effectiveness. To achieve this, a literature review was conducted on studies estimating the effectiveness of measures applied in slaughterhouses to reduce the microbial contamination of pig carcasses. Results of this literature search are discussed and presented in summary tables that could be used as a source of information for the pig slaughter industry to further develop their guidelines on hygienic slaughter.
Collapse
Affiliation(s)
- Arvo Viltrop
- Estonian University of Life Sciences, Institute of Veterinary Medicine and Animal Sciences, Kreutzwaldi 62, Tartu 51006, Estonia.
| | - Tarmo Niine
- Estonian University of Life Sciences, Institute of Veterinary Medicine and Animal Sciences, Kreutzwaldi 62, Tartu 51006, Estonia.
| | - Tijs Tobias
- Utrecht University, Faculty of Veterinary Medicine, Department of Population Health Sciences, Farm Animal Health Unit, Yalelaan 7, 3584CL Utrecht, the Netherlands; Royal GD (Animal Health Service), P.O. Box 9, 7400 AA Deventer, the Netherlands.
| | - Elena Lucia Sassu
- Institute of Veterinary Disease Control, Austrian Agency for Health and Food Safety (AGES), Mödling, Austria.
| | - Ilaria Di Bartolo
- Dept. of Food Safety, Nutrition and Veterinary Public Health, Istituto Superiore di Sanità, Viale Regina Elena 299, 00161 Roma, Italy.
| | - Enrico Pavoni
- Experimental Zooprophylactic Institute of Lombardy and Emilia Romagna, via Bianchi 7/9, 25124 Brescia, Italy.
| | - Giovanni Loris Alborali
- Experimental Zooprophylactic Institute of Lombardy and Emilia Romagna, via Bianchi 7/9, 25124 Brescia, Italy.
| | - Elke Burow
- German Institute for Risk Assessment (BfR), Department of Biological Safety, Max-Dohrn Str. 8-10, 10589 Berlin, Germany.
| | - Richard Piers Smith
- Department of Epidemiological Sciences, Animal and Plant Health Agency - Weybridge, Woodham Lane, New Haw, Addlestone, Surrey KT15 3NB, UK.
| |
Collapse
|
4
|
Bernad-Roche M, Marín-Alcalá CM, Cebollada-Solanas A, de Blas I, Mainar-Jaime RC. Building a predictive model for assessing the risk of Salmonella shedding at slaughter in fattening pigs. Front Microbiol 2023; 14:1232490. [PMID: 37680527 PMCID: PMC10482039 DOI: 10.3389/fmicb.2023.1232490] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/31/2023] [Accepted: 07/25/2023] [Indexed: 09/09/2023] Open
Abstract
Salmonellosis continues to be a major cause of foodborne outbreaks worldwide, and pigs are one of the main sources of human infection. Salmonella pork contamination is a major concern for abattoirs and is related to the presence of Salmonella in pigs' feces at slaughter. Being able to predict the risk of Salmonella shedding in pigs arriving at the slaughterhouse could help mitigate abattoir and carcass contamination. For this purpose, 30 batches of 50 pigs each were selected from 30 different fattening units. The pigs were tagged and bled for the detection of antibodies against Salmonella approximately one month before slaughter. Pooled floor fecal samples were also collected from 10 pens per unit for Salmonella detection, and a questionnaire on biosecurity was administered to each farm. At the abattoir, colon content was collected from each tagged pig for the Salmonella shedding assessment. A predictive model for Salmonella shedding at slaughter was built with two-third of the pigs by employing random-effects logistic regression analysis, with Salmonella shedding as the dependent variable and pig serology and other farm/environmental characteristics as the independent variables. The model included farm as the grouping factor. Data from the remaining one-third of the pigs were used for model validation. Out of 1,500 pigs initially selected, 1,341 were identified at the abattoir and analyzed. Salmonella was detected in 13 (43.3%; 95%CI = 27.4-60.8) of the fattening units. The mean batch seroprevalence (cut-off OD% ≥40) among the fattening units was 31.7% (95%CI = 21.8-41.0), and a total of 316 pigs (23.6%; 95%CI = 21.4-25.9) shed Salmonella at slaughter. The model predicted reasonably well (Area under the curve = 0.76; P < 0.05) whether a pig would shed Salmonella at slaughter, with estimates of sensitivity and specificity at 71.6% and 73.6%, respectively. Serology, the percentage of Salmonella-positive pens on the farm, and the internal biosecurity score were significantly associated (P < 0.05) with Salmonella shedding at the abattoir, and several scenarios were observed by the model. The study highlighted that although serology may be helpful for identifying batches of pigs at risk of shedding Salmonella upon their arrival at the abattoir, it may not be necessary in some scenarios.
Collapse
Affiliation(s)
- María Bernad-Roche
- Departamento de Patología Animal, Facultad de Veterinaria, Instituto Agroalimentario de Aragón-IA2, Universidad de Zaragoza-CITA, Zaragoza, Spain
| | - Clara María Marín-Alcalá
- Departamento de Ciencia Animal, Centro de Investigación y Tecnología Agroalimentaria de Aragón, Instituto Agroalimentario de Aragón-IA2, Universidad de Zaragoza-CITA, Zaragoza, Spain
| | - Alberto Cebollada-Solanas
- Unidad de Biocomputación, Instituto Aragonés de Ciencias de la Salud (IACS/IIS Aragón), Centro de Investigación Biomédica de Aragón (CIBA), Zaragoza, Spain
| | - Ignacio de Blas
- Departamento de Patología Animal, Facultad de Veterinaria, Instituto Agroalimentario de Aragón-IA2, Universidad de Zaragoza-CITA, Zaragoza, Spain
| | - Raúl Carlos Mainar-Jaime
- Departamento de Patología Animal, Facultad de Veterinaria, Instituto Agroalimentario de Aragón-IA2, Universidad de Zaragoza-CITA, Zaragoza, Spain
| |
Collapse
|
5
|
Ntakiyisumba E, Lee S, Won G. Identification of risk profiles for Salmonella prevalence in pig supply chains in South Korea using meta-analysis and a quantitative microbial risk assessment model. Food Res Int 2023; 170:112999. [PMID: 37316069 DOI: 10.1016/j.foodres.2023.112999] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/06/2023] [Revised: 05/13/2023] [Accepted: 05/16/2023] [Indexed: 06/16/2023]
Abstract
International travel and the globalization of food supplies have increased the risk of epidemic foodborne infections. Salmonella strains, particularly non-typhoidal Salmonella (NTS), are major zoonotic pathogens responsible for gastrointestinal diseases worldwide. In this study, the prevalence and Salmonella contamination in pigs/carcasses throughout the South Korean pig supply chain and the associated risk factors were evaluated using Systematic reviews and meta-analyses (SRMA), and quantitative microbial risk assessment (QMRA). The prevalence of Salmonella in finishing pigs, which is one of the major starting inputs of the QMRA model was calculated through SRMA of studies conducted in south Korea in order to complement and enhance the robustness of the model. Our findings revealed that the pooled Salmonella prevalence in pigs was 4.15% with a 95% confidence interval (CI) of 2.56 to 6.66%. Considering the pig supply chain, the highest prevalence was detected in slaughterhouses (6.27% [95% CI: 3.36; 11.37]), followed by farms (4.16% [95% CI: 2.32; 7.35]) and meat stores (1.21% [95% CI: 0.42; 3.46]). The QMRA model predicted a 3.9% likelihood of Salmonella-free carcasses and a 96.1% probability of Salmonella-positive carcasses at the end of slaughter, with an average Salmonella concentration of 6.38 log CFU/carcass (95% CI: 5.17; 7.28). This corresponds to an average contamination of 1.23 log CFU/g (95% CI: 0.37; 2.48) of pork meat. Across the pig supply chain, the highest Salmonella contamination was predicted after transport and lairage, with an average concentration of 8 log CFU/pig (95% CI: 7.15; 8.42). Sensitivity analysis indicated that Salmonella fecal shedding (r = 0.68) and Salmonella prevalence in finishing pigs (r = 0.39) at pre-harvest were the most significant factors associated with Salmonella contamination in pork carcasses. Although disinfection and sanitation interventions along the slaughter line can reduce contamination levels to some extent, effective measures should be taken to reduce Salmonella prevalence at the farm level to improve the safety of pork consumption.
Collapse
Affiliation(s)
- Eurade Ntakiyisumba
- College of Veterinary Medicine, Jeonbuk National University, Iksan Campus, Gobong-ro 79, Iksan 54596, Republic of Korea
| | - Simin Lee
- College of Veterinary Medicine, Jeonbuk National University, Iksan Campus, Gobong-ro 79, Iksan 54596, Republic of Korea
| | - Gayeon Won
- College of Veterinary Medicine, Jeonbuk National University, Iksan Campus, Gobong-ro 79, Iksan 54596, Republic of Korea.
| |
Collapse
|
6
|
Dias Costa R, Silva V, Leite A, Saraiva M, Lopes TT, Themudo P, Campos J, Vieira-Pinto M. Salmonella spp., Escherichia coli and Enterobacteriaceae Control at a Pig Abattoir: Are We Missing Lairage Time Effect, Pig Skin, and Internal Carcass Surface Contamination? Foods 2023; 12:2910. [PMID: 37569179 PMCID: PMC10418833 DOI: 10.3390/foods12152910] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/05/2023] [Revised: 07/18/2023] [Accepted: 07/29/2023] [Indexed: 08/13/2023] Open
Abstract
To provide meat safety and consumer protection, appropriate hygiene control measures at an abattoir are required. This study aimed to evaluate the influence of visual fecal contamination level (VFCL) and lairage time (LT) on pig skin (PS) and external (ECS) and internal (ICS) carcass surfaces. The presence of Enterobacteriaceae, Escherichia coli (E. coli) and Salmonella in PS, ECS, and ICS were evaluated. A total of 300 paired samples were collected from 100 pigs. Results underlined the importance of the skin (Enterobacteriaceae: 3.27 ± 0.68 log CFU/cm2; E. coli: 3.15 ± 0.63 log CFU/cm2; Salmonella: 21% of samples) as a direct or indirect source of carcass contamination. Although VFCL revealed no significant effect (p > 0.05), the increase of LT had a significant impact (p < 0.001) on Enterobacteriaceae and E. coli levels across all analysed surfaces, and Salmonella presence on ICS (p < 0.01), demanding attention to LT. Also, the ICS showed a higher level of these bacteria compared to ECS. These results highlight the need of food business operators to consider ICS as an alternative area to sample for Salmonella, as a criterion for process hygiene based on EC Regulation No. 2073/2005, and as a potential contamination source to be integrated in the hazard analysis critical control point (HACCP) plans.
Collapse
Affiliation(s)
- Rui Dias Costa
- CITAB—Centre for the Research and Technology of Agro-Environmental and Biological Sciences/Inov4Agro—Institute for Innovation, Capacity Building and Sustainability of Agri-Food Production, University of Trás-os-Montes and Alto Douro, Quinta de Prados, 5000-801 Vila Real, Portugal;
| | - Vanessa Silva
- CECAV—Animal and Veterinary Research Centre, University of Trás-os-Montes and Alto Douro, Quinta de Prados, 5000-801 Vila Real, Portugal; (V.S.); (A.L.)
| | - Ana Leite
- CECAV—Animal and Veterinary Research Centre, University of Trás-os-Montes and Alto Douro, Quinta de Prados, 5000-801 Vila Real, Portugal; (V.S.); (A.L.)
| | - Margarida Saraiva
- INSA—National Institute of Health Dr. Ricardo Jorge, Food Microbiology Laboratory, Reference Unit, Department of Food and Nutrition, Rua Alexandre Herculano 321, 4000-055 Porto, Portugal; (M.S.); (T.T.L.)
| | - Teresa Teixeira Lopes
- INSA—National Institute of Health Dr. Ricardo Jorge, Food Microbiology Laboratory, Reference Unit, Department of Food and Nutrition, Rua Alexandre Herculano 321, 4000-055 Porto, Portugal; (M.S.); (T.T.L.)
| | - Patrícia Themudo
- INIAV—National Institute of Agrarian and Veterinary Research, Bacteriology and Micology Laboratory, Avenida da República, Quinta do Marquês, 2780-157 Oeiras, Portugal;
| | - Joana Campos
- CITAB—Centre for the Research and Technology of Agro-Environmental and Biological Sciences/Inov4Agro—Institute for Innovation, Capacity Building and Sustainability of Agri-Food Production, University of Trás-os-Montes and Alto Douro, Quinta de Prados, 5000-801 Vila Real, Portugal;
| | - Madalena Vieira-Pinto
- CECAV—Animal and Veterinary Research Centre, University of Trás-os-Montes and Alto Douro, Quinta de Prados, 5000-801 Vila Real, Portugal; (V.S.); (A.L.)
- Veterinary Science Department—Gab. B.1.02, University of Trás-os-Montes and Alto Douro, Quinta de Prados, 5000-801 Vila Real, Portugal
| |
Collapse
|
7
|
Salmonella enterica prevalence, serotype diversity, antimicrobial resistance and control in the European pork production chain. Trends Food Sci Technol 2023. [DOI: 10.1016/j.tifs.2022.12.007] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/24/2022]
|
8
|
Quantitative Bio-Mapping of Salmonella and Indicator Organisms at Different Stages in a Commercial Pork Processing Facility. Foods 2022; 11:foods11172580. [PMID: 36076766 PMCID: PMC9455759 DOI: 10.3390/foods11172580] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/30/2022] [Revised: 08/20/2022] [Accepted: 08/24/2022] [Indexed: 11/29/2022] Open
Abstract
The purpose of this study was to develop a quantitative baseline of indicator organisms and Salmonella by bio-mapping throughout the processing chain from harvest to final product stages within a commercial conventional design pork processing establishment. Swab samples were taken on the harvest floor at different processing steps, gambrel table, after polisher, before final rinse, after the final rinse, post snap chill, and after peroxyacetic acid (PAA) application, while 2-pound product samples were collected for trim and ground samples. The samples were subjected to analysis for indicator microorganism enumeration, Aerobic Count (AC), Enterobacteriaceae (EB), and generic Escherichia coli (EC), with the BioMérieux TEMPO®. Salmonella prevalence and enumeration was evaluated using the BAX® System Real-Time Salmonella and the SalQuant™ methodology. Microbial counts were converted to Log Colony-forming units (CFU) on a per mL, per g or per sample basis, presented as LogCFU/mL, LogCFU/g and LogCFU/sample, prior to statistical analysis. All indicator microorganisms were significantly reduced at the harvest floor (p-value < 0.001), from gambrel table to after PAA cabinet location. The reduction at harvest was 2.27, 2.46 and 2.24 LogCFU/mL for AC, EB and EC, respectively. Trim sample values fluctuated based on cut, with the highest average AC count found at neck trim (2.83 LogCFU/g). Further process samples showed the highest AC count in sausage with a mean of 5.28 LogCFU/g. EB counts in sausage (3.19 LogCFU/g) showed an evident increase, compared to the reduction observed at the end of harvest and throughout trim processing. EC counts showed a similar trend to EB counts with the highest value found in sausage links (1.60 LogCFU/g). Statistical microbial process control (SPC) parameters were also developed for each of the indicator microorganisms, using the overall mean count (X=), the Lower control limit (LCL) and Upper control limit (UCL) at each sampling location. For Salmonella prevalence, a total of 125/650 samples were found positive (19%). From those positive samples, 47 samples (38%) were suitable for enumeration using the BAX® System SalQuant™, the majority detected at the gambrel table location. From those enumerable samples, 60% were estimated to be between 0.97 and 1.97 LogCFU/sample, while the rest (40%) were higher within the 2.00−4.02 LogCFU/sample range. This study provides evidence for the application of indicator and pathogen quantification methodologies for food safety management in commercial pork processing operations.
Collapse
|
9
|
Deane A, Murphy D, Leonard FC, Byrne W, Clegg T, Madigan G, Griffin M, Egan J, Prendergast DM. Prevalence of Salmonella spp. in slaughter pigs and carcasses in Irish abattoirs and their antimicrobial resistance. Ir Vet J 2022; 75:4. [PMID: 35249551 PMCID: PMC8898491 DOI: 10.1186/s13620-022-00211-y] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/12/2021] [Accepted: 02/18/2022] [Indexed: 11/10/2022] Open
Abstract
Background Salmonella is an important zoonotic pathogen and is one of the main causes of foodborne outbreaks and infections in the European Union. Pigs are a significant reservoir and are frequently subclinical carriers of this organism. Salmonella can be shed in the faeces allowing infection to spread to other pigs, the environment, transport vehicles, lairages and other areas. Inadvertent spillage of gut contents during the slaughter process also leads to contamination. A pig Salmonella control programme has operated in Ireland since 2002 but many local surveys and an EUMS baseline survey in 2008 continued to indicate high levels of the organism in the pig sector. The objectives of this study were to generate updated information on the prevalence of Salmonella spp, in slaughter pigs and carcasses in Irish abattoirs. Five pigs from each of 164 herds were randomly sampled over a 14-week period during 2016. One sample from each of the five pigs of; caecal content, ileo-caecal lymph nodes and carcass swabs (pre-chill) were collected. The five caeca and lymph node samples from each herd were processed as one pool of caecal samples and one pool of lymph node samples, respectively, while the five carcass swabs were tested as individual samples. All isolates were characterised by serotyping and antimicrobial susceptibility. Results In total, 235 Salmonella spp. were isolated from 820 individual carcass swabs, 164 pooled lymph nodes and 164 caecal contents. Salmonella spp. were isolated from 54.3% of the caecal contents and from 31.7% of the ileo-caecal lymph node sample pools. A total of 11.5% of carcass-swab samples yielded Salmonella spp. S. Typhimurium 4,[5],12:i:1,2 or its monophasic variant 4,[5],12:i:-: predominated among isolates from all positive samples; accounting for 73% of lymph nodes, 68% of caecal contents and 56% of carcass swab isolates. S. London and S. Derby were the next most common isolated serotypes. Conclusions These results confirm continuing high levels of Salmonella in fattening pigs in Ireland although reductions in carcass contamination compared to previous surveys were noted. A high prevalence of Salmonella in lymph nodes suggests that it remains a significant problem pre slaughter and a challenge to abattoirs in adhering to process hygiene requirements. The high prevalence of monophasic S. Typhimurim 4,[5],12:i:-: is of serious concern. Therefore, it is important to identify contributing factors in the dissemination of this pathogen in the pork industry in order to minimise the risk of human salmonellosis cases.
Collapse
|
10
|
Jiu Y, Meng X, Hong X, Huang Q, Wang C, Chen Z, Zhao L, Liu X, Lu Y, Li S. Prevalence and Characterization of Salmonella in Three Typical Commercial Pig Abattoirs in Wuhan, China. Foodborne Pathog Dis 2020; 17:620-627. [PMID: 32130028 DOI: 10.1089/fpd.2019.2737] [Citation(s) in RCA: 9] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/12/2022] Open
Abstract
This study was designed to investigate the prevalence and characteristics of Salmonella in three Chinese pig abattoirs (A, B, and C) in Wuhan city in 2016. Four types of pig samples were collected and cultured for Salmonella. Salmonella was detected from 329 samples among the 1440 tested (22.9%). There was no significant difference in the overall prevalence between the first visit and the second visit and among the three abattoirs. Rectal swabs (RS) exhibited a significantly higher prevalence than carcass swabs and pork. A total of 177 isolates were characterized by multilocus sequence typing, serotyping, and antimicrobial susceptibility testing. Among 17 sequence types (STs) and 13 serotypes detected, ST40, ST469, and ST34, corresponding to serovars Derby, Rissen, and Typhimurium, respectively, were predominant. The isolates from different abattoirs exhibited diverse ST distribution. The minimum inhibitory concentrations were determined using the microdilution broth method. Resistance to at least one of the antimicrobials was observed for 96.6% of the strains (171/177), and multidrug resistant (MDR) isolates accounted for 75.7% of the strains (134/177). The highest resistance proportion was for tetracycline (92.7%), and the lowest was for cefotaxime (14.1%). The isolates from abattoir A exhibited a significantly lower MDR proportion than those from other abattoirs (p < 0.05). The isolates recovered from RS and pork samples exhibited significantly higher MDR proportions than those recovered from carcass swab samples. Notably, among three predominant STs of isolates, the ST34 isolates showed the highest MDR proportion. In view of the high Salmonella prevalence and antimicrobial resistance, great attention must be paid to the monitoring and controlling of Salmonella in a full pork production chain.
Collapse
Affiliation(s)
- Yueguang Jiu
- Key Laboratory of Preventive Veterinary Medicine in Hubei Province, College of Veterinary Medicine, Huazhong Agricultural University, Wuhan, China
| | - Xianrong Meng
- Key Laboratory of Preventive Veterinary Medicine in Hubei Province, College of Veterinary Medicine, Huazhong Agricultural University, Wuhan, China
| | - Xuan Hong
- Key Laboratory of Preventive Veterinary Medicine in Hubei Province, College of Veterinary Medicine, Huazhong Agricultural University, Wuhan, China
| | - Qi Huang
- Key Laboratory of Preventive Veterinary Medicine in Hubei Province, College of Veterinary Medicine, Huazhong Agricultural University, Wuhan, China
| | - Chunfang Wang
- Wuhan Agricultural Comprehensive Law Enforcement Inspector Corps, Wuhan Municipal Agricultural and Rural Bureau, Wuhan, China
| | - Zhou Chen
- Wuhan Agricultural Comprehensive Law Enforcement Inspector Corps, Wuhan Municipal Agricultural and Rural Bureau, Wuhan, China
| | - Liangjin Zhao
- Animal Health Supervision Institute in Jiangxia District of Wuhan City, JiangXia District Agricultural and Rural University, Wuhan, China
| | - Xiaoying Liu
- Key Laboratory of Preventive Veterinary Medicine in Hubei Province, College of Veterinary Medicine, Huazhong Agricultural University, Wuhan, China
| | - Yangchao Lu
- Key Laboratory of Preventive Veterinary Medicine in Hubei Province, College of Veterinary Medicine, Huazhong Agricultural University, Wuhan, China
| | - Shaowen Li
- Key Laboratory of Preventive Veterinary Medicine in Hubei Province, College of Veterinary Medicine, Huazhong Agricultural University, Wuhan, China
| |
Collapse
|
11
|
Marin C, Chinillac MC, Cerdà-Cuéllar M, Montoro-Dasi L, Sevilla-Navarro S, Ayats T, Marco-Jimenez F, Vega S. Contamination of pig carcass with Salmonella enterica serovar Typhimurium monophasic variant 1,4[5],12:i:- originates mainly in live animals. THE SCIENCE OF THE TOTAL ENVIRONMENT 2020; 703:134609. [PMID: 31753504 DOI: 10.1016/j.scitotenv.2019.134609] [Citation(s) in RCA: 9] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/02/2019] [Revised: 09/18/2019] [Accepted: 09/21/2019] [Indexed: 06/10/2023]
Abstract
Pork is considered a major source of Salmonella Typhimurium infection in humans in the EU, including monophasic strains (mST). Widespread distribution of virulent serotypes such as monophasic variants of S. Typhimurium have emerged as a public health threat. Despite the current situation, within the EU there is no mandatory programme for the control of Salmonella at pork production level. In this context, the aims of this study were: to examine the presence of Salmonella in the swine production system from arrival at the slaughterhouse until the end of processing, and investigate the genetic relationship among serovars. A total of 21 pig herds were intensively sampled during processing at the slaughterhouse. ERIC-PCR followed by PFGE were performed among isolates recovered at the different steps in the slaughterhouse to assess their genetic relationship. The results showed a high level of Salmonella pork batch contamination upon arrival at the slaughterhouse (71.4%) and at the end of the slaughtering process (66.7%), with mST the main serovar isolated from both origins (53.1% and 38.2%, respectively). Similarly, this study shows that 14.3% of the strains isolated from carcasses have the same Xbal-PFGE profile as those previously recovered in the slaughterhouse environment, but not in the live animals from that same batch. In conclusion, there is a high level of Salmonella swine batch contamination upon arrival at the slaughterhouse and at the end of the slaughtering process, mST being the most frequently isolated serovar. Moreover, a strong genetic relationship has been observed between strains isolated from the batch on arrival at the slaughterhouse, the processing environment and pork carcass contamination. In this sense, it would be necessary to implement a control programme to reduce the bacterium from pork farms and raise the awareness of biosecurity measures.
Collapse
Affiliation(s)
- Clara Marin
- Instituto de Ciencias Biomédicas, Departamento de Producción Animal, Sanidad Animal, Salud Pública Veterinaria y Ciencia y Tecnología de los Alimentos, Facultad de Veterinaria, Universidad Cardenal Herrera-CEU, CEU Universities, 46115 Alfara del Patriarca, Valencia, Spain.
| | - Mª Carmen Chinillac
- Instituto de Ciencias Biomédicas, Departamento de Producción Animal, Sanidad Animal, Salud Pública Veterinaria y Ciencia y Tecnología de los Alimentos, Facultad de Veterinaria, Universidad Cardenal Herrera-CEU, CEU Universities, 46115 Alfara del Patriarca, Valencia, Spain
| | - Marta Cerdà-Cuéllar
- Centre de Recerca en Sanitat Animal (CReSA)-Institut de Recerca i Tecnología Agroalimentàries (IRTA), Campus de la Universitat Autònoma de Barcelona, 08193, Bellaterra, Spain
| | - Laura Montoro-Dasi
- Centro de Calidad Avícola y Alimientación Animal de la Comunidad Valenciana, C/Nules, 16, 12539, Alquerias del NP, Castellón, Spain; Instituto de Ciencia y Tecnología Animal, Universitat Politècnica de València, Valencia 46022, Spain
| | - Sandra Sevilla-Navarro
- Instituto de Ciencias Biomédicas, Departamento de Producción Animal, Sanidad Animal, Salud Pública Veterinaria y Ciencia y Tecnología de los Alimentos, Facultad de Veterinaria, Universidad Cardenal Herrera-CEU, CEU Universities, 46115 Alfara del Patriarca, Valencia, Spain; Centro de Calidad Avícola y Alimientación Animal de la Comunidad Valenciana, C/Nules, 16, 12539, Alquerias del NP, Castellón, Spain; Instituto de Ciencia y Tecnología Animal, Universitat Politècnica de València, Valencia 46022, Spain
| | - Teresa Ayats
- Centre de Recerca en Sanitat Animal (CReSA)-Institut de Recerca i Tecnología Agroalimentàries (IRTA), Campus de la Universitat Autònoma de Barcelona, 08193, Bellaterra, Spain
| | - Francisco Marco-Jimenez
- Instituto de Ciencia y Tecnología Animal, Universitat Politècnica de València, Valencia 46022, Spain
| | - Santiago Vega
- Instituto de Ciencias Biomédicas, Departamento de Producción Animal, Sanidad Animal, Salud Pública Veterinaria y Ciencia y Tecnología de los Alimentos, Facultad de Veterinaria, Universidad Cardenal Herrera-CEU, CEU Universities, 46115 Alfara del Patriarca, Valencia, Spain
| |
Collapse
|
12
|
Viana C, Sereno MJ, Pegoraro K, Yamatogi RS, Call DR, dos Santos Bersot L, Nero LA. Distribution, diversity, virulence genotypes and antibiotic resistance for Salmonella isolated from a Brazilian pork production chain. Int J Food Microbiol 2019; 310:108310. [DOI: 10.1016/j.ijfoodmicro.2019.108310] [Citation(s) in RCA: 17] [Impact Index Per Article: 3.4] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/01/2019] [Revised: 07/09/2019] [Accepted: 08/22/2019] [Indexed: 01/04/2023]
|
13
|
Risk factors associated with Salmonella spp. prevalence along smallholder pig value chains in Vietnam. Int J Food Microbiol 2019; 290:105-115. [DOI: 10.1016/j.ijfoodmicro.2018.09.030] [Citation(s) in RCA: 18] [Impact Index Per Article: 3.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/03/2018] [Revised: 08/06/2018] [Accepted: 09/29/2018] [Indexed: 01/08/2023]
|
14
|
Van Ba H, Seo HW, Seong PN, Kang SM, Cho SH, Kim YS, Park BY, Moon SS, Kang SJ, Choi YM, Kim JH. The fates of microbial populations on pig carcasses during slaughtering process, on retail cuts after slaughter, and intervention efficiency of lactic acid spraying. Int J Food Microbiol 2019; 294:10-17. [PMID: 30711888 DOI: 10.1016/j.ijfoodmicro.2019.01.015] [Citation(s) in RCA: 11] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/13/2018] [Revised: 12/27/2018] [Accepted: 01/24/2019] [Indexed: 11/26/2022]
Abstract
This study was conducted to detect and identify microbial populations on pig carcasses at different slaughtering stages and on retail pork cuts at 24 h after slaughter as well as to evaluate the intervention efficiency of sprays containing different concentrations (2% and 4%) of lactic acid. The sprays were applied to the carcass surfaces at the end of the slaughter line. Microbial samples were collected from carcass surfaces after bleeding and after eviscerating, and from retail cuts at 24 h after chilling/spraying. The detected microorganisms were identified through using a Microflex identification instrument and 16S rRNA gene sequencing. The diversity of the bacterial genera; Staphylococcus, Salmonella, Shigella, Enterococci, Escherichia, Acinetobacter and Corynebacterium spp. showed counts ranging from 2.70 to 4.91 log10 cfu/100 cm2 on the carcasses during slaughter. Most of these genera were also detected on the carcasses after 24 h of chilling. Three species (Staphylococcus hyicus, Acinetobacter albensis, and Corynebacterium xerosis) were also found on the retail cuts of non-sprayed carcasses but not on those of the sprayed groups. Significantly greater reductions in all bacterial species were observed on the carcasses and retail cuts that were sprayed with lactic acid, particularly at the 4% level. Thus, spraying with 4% lactic acid may be an effective intervention for controlling bacterial contamination on pig carcasses to improve the microbiological safety of pork meat.
Collapse
Affiliation(s)
- Hoa Van Ba
- National Institute of Animal Science, Rural Development Administration, Wanju 55365, Republic of Korea
| | - Hyun-Woo Seo
- National Institute of Animal Science, Rural Development Administration, Wanju 55365, Republic of Korea
| | - Pil-Nam Seong
- National Institute of Animal Science, Rural Development Administration, Wanju 55365, Republic of Korea
| | - Sun-Moon Kang
- National Institute of Animal Science, Rural Development Administration, Wanju 55365, Republic of Korea
| | - Soo-Huyn Cho
- National Institute of Animal Science, Rural Development Administration, Wanju 55365, Republic of Korea
| | - Yoon-Seok Kim
- National Institute of Animal Science, Rural Development Administration, Wanju 55365, Republic of Korea
| | - Beom-Young Park
- National Institute of Animal Science, Rural Development Administration, Wanju 55365, Republic of Korea
| | - Sung-Sil Moon
- Sunjin Meat Research Center, Ansung 17532, Republic of Korea
| | - Se-Ju Kang
- National Institute of Agricultural Sciences, RDA, Wanju 55365, Republic of Korea
| | - Yong-Min Choi
- National Institute of Agricultural Sciences, RDA, Wanju 55365, Republic of Korea
| | - Jin-Hyoung Kim
- National Institute of Animal Science, Rural Development Administration, Wanju 55365, Republic of Korea.
| |
Collapse
|
15
|
Gosling RJ, Mueller-Doblies D, Martelli F, Nunez-Garcia J, Kell N, Rabie A, Wales AD, Davies RH. Observations on the distribution and persistence of monophasic Salmonella Typhimurium on infected pig and cattle farms. Vet Microbiol 2018; 227:90-96. [PMID: 30473358 DOI: 10.1016/j.vetmic.2018.10.032] [Citation(s) in RCA: 12] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/21/2018] [Revised: 10/26/2018] [Accepted: 10/31/2018] [Indexed: 11/24/2022]
Abstract
Following a rapid rise in cases of monophasic Salmonella Typhimurium DT193 (mST) in humans and pigs since 2007 a detailed study of the prevalence and persistence of mST on pig and cattle farms in Great Britain (GB) was undertaken. Thirteen commercial pig farms and twelve cattle farms, identified as mST-positive from surveillance data, were intensively sampled over a three year period. Five indoor and eight outdoor pig farms and four beef and eight dairy farms were included. Individual and pooled faecal samples were collected from each epidemiological group and environmental samples throughout each farm and the antimicrobial resistance profile determined for a selection of mST-positive isolates. Indoor pig farms had a higher mST prevalence than outdoor pig farms, and across both cattle and pig farms the juvenile animals had a higher mST prevalence than the adult animals. Overall, mST prevalence decreased with time across all pig farms, from 25% to less than 15% of environmental samples and 22% to 15% of pooled faecal samples; only one organic outdoor breeding farm was Salmonella-negative at the end of the study. Across the cattle farms no mST was detected by the end of the study, apart from one persistent farm. Clearance time of mST was between seven and twenty-five months. Farms were selected based on having the antimicrobial resistance profile ampicillin, streptomycin, sulphonamides and tetracycline (A, S, SU, T), although resistance to trimethoprim-potentiated sulphamethoxazole was also identified on five pig farms sampled. This study provided a detailed insight into the distribution and persistence of mST on individual pig and cattle farms in GB. It has identified variation in mST shedding of individual animals, and the data can be applied to the wider livestock industry when considering the distribution of mST once identified on an individual farm.
Collapse
Affiliation(s)
- Rebecca J Gosling
- Animal and Plant Health Agency, New Haw, Addlestone, Surrey, KT15 3NB, UK.
| | | | - Francesca Martelli
- Animal and Plant Health Agency, New Haw, Addlestone, Surrey, KT15 3NB, UK
| | | | - Nick Kell
- Animal and Plant Health Agency, New Haw, Addlestone, Surrey, KT15 3NB, UK
| | - Andre Rabie
- Animal and Plant Health Agency, New Haw, Addlestone, Surrey, KT15 3NB, UK
| | - Andy D Wales
- Department of Pathology and Infectious Diseases, School of Veterinary Medicine, Vet School Main Building, Daphne Jackson Road, University of Surrey, Guildford, GU2 7AL, UK
| | - Robert H Davies
- Animal and Plant Health Agency, New Haw, Addlestone, Surrey, KT15 3NB, UK
| |
Collapse
|
16
|
Cabral CC, Panzenhagen PHN, Delgado KF, Silva GRA, Rodrigues DDP, Franco RM, Conte-Junior CA. Contamination of Carcasses and Utensils in Small Swine Slaughterhouses by Salmonella in the Northwestern Region of the State of Rio de Janeiro, Brazil. J Food Prot 2017; 80:1128-1132. [PMID: 28585863 DOI: 10.4315/0362-028x.jfp-16-387] [Citation(s) in RCA: 11] [Impact Index Per Article: 1.6] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/11/2022]
Abstract
Salmonella is a major foodborne pathogen that constantly threatens food safety in developed countries and underdeveloped countries such as Brazil, where it is responsible for 38% of notified cases of foodborne illness. Swine are one of the main meat-producing species that may asymptomatically carry Salmonella, periodically shedding the bacteria through feces. The state of Rio de Janeiro is not a major producer of swine meat, but small slaughterhouses are operational and produce meat for consumption within the state, although few studies have been conducted in the region. In this context, this study was designed to evaluate Salmonella contamination in carcasses, lymph nodes, feces, utensils, and the environment of three small slaughterhouses in the state of Rio de Janeiro. A total of 344 samples from carcasses, utensils, equipment, water, and the environment were collected from these slaughterhouses in the northwestern region of Rio de Janeiro. Salmonella was isolated from 36 (10.5%) samples: 10 of 48 carcasses, 19 of 96 lymph nodes, 4 of 48 fecal samples, 2 of 6 water samples, and 1 of 6 bleeding knives; 55 isolates were recovered. Serotyping revealed the predominance of Salmonella Typhimurium (20 isolates) followed by Salmonella Abony (10 isolates), Salmonella Give (7 isolates), Salmonella Heidelberg (4 isolates), and Salmonella Infantis (1 isolate). Ten isolates were only partially typeable, with only their O antigen identified, and three isolates had rough, nontypeable colonies. Despite the overall low prevalence of Salmonella in this study, all three slaughterhouses had poor hygienic and sanitary conditions, providing easy routes for carcass and, consequently, meat contamination. Thus, it is imperative to enforce sanitary inspections in these establishments and to apply good manufacture practices to assure the safety of the produced pork.
Collapse
Affiliation(s)
- Claudius Couto Cabral
- 1 Departamento de Tecnologia de Alimentos, Faculdade de Veterinária, Universidade Federal Fluminense, Rua Vital Brasil Filho, 62, 24230-340, Niterói, Rio de Janeiro, Brazil
| | - Pedro Henrique Nunes Panzenhagen
- 2 Departamento de Bioquímica, Instituto de Química, Universidade Federal do Rio de Janeiro, Av. Athos da Silveira ramos, Sala 545, 149 Cidade Universitária, 21949-909, Rio de Janeiro, Brazil
| | - Karina Frensel Delgado
- 2 Departamento de Bioquímica, Instituto de Química, Universidade Federal do Rio de Janeiro, Av. Athos da Silveira ramos, Sala 545, 149 Cidade Universitária, 21949-909, Rio de Janeiro, Brazil
| | - Gabriela Rodrigues Alves Silva
- 1 Departamento de Tecnologia de Alimentos, Faculdade de Veterinária, Universidade Federal Fluminense, Rua Vital Brasil Filho, 62, 24230-340, Niterói, Rio de Janeiro, Brazil
| | - Dália Dos Prazeres Rodrigues
- 3 Laboratório de Enterobactérias, Instituto Oswaldo Cruz, Fundação Oswaldo Cruz, Avenida Brazil, 4365 Pav. Rocha Lima, 21040-900, Manguinhos, Rio de Janeiro, Brazil
| | - Robson Maia Franco
- 1 Departamento de Tecnologia de Alimentos, Faculdade de Veterinária, Universidade Federal Fluminense, Rua Vital Brasil Filho, 62, 24230-340, Niterói, Rio de Janeiro, Brazil
| | - Carlos Adam Conte-Junior
- 1 Departamento de Tecnologia de Alimentos, Faculdade de Veterinária, Universidade Federal Fluminense, Rua Vital Brasil Filho, 62, 24230-340, Niterói, Rio de Janeiro, Brazil
| |
Collapse
|
17
|
Walia K, Lynch H, Grant J, Duffy G, Leonard FC, Lawlor PG, Gardiner GE. The efficacy of disinfectant misting in the lairage of a pig abattoir to reduce Salmonella and Enterobacteriaceae on pigs prior to slaughter. Food Control 2017. [DOI: 10.1016/j.foodcont.2016.12.028] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/20/2022]
|
18
|
Walia K, Argüello H, Lynch H, Grant J, Leonard FC, Lawlor PG, Gardiner GE, Duffy G. The efficacy of different cleaning and disinfection procedures to reduce Salmonella and Enterobacteriaceae in the lairage environment of a pig abattoir. Int J Food Microbiol 2017; 246:64-71. [DOI: 10.1016/j.ijfoodmicro.2017.02.002] [Citation(s) in RCA: 17] [Impact Index Per Article: 2.4] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/14/2016] [Revised: 12/23/2016] [Accepted: 02/03/2017] [Indexed: 11/26/2022]
|
19
|
Reid R, Fanning S, Whyte P, Kerry J, Bolton D. The fate of Salmonella Typhimurium and Escherichia coli O157 on hot boned versus conventionally chilled beef. Meat Sci 2017; 126:50-54. [DOI: 10.1016/j.meatsci.2016.12.010] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/27/2016] [Revised: 12/13/2016] [Accepted: 12/19/2016] [Indexed: 12/25/2022]
|
20
|
Salmonella in the pork production chain and its impact on human health in the European Union. Epidemiol Infect 2017; 145:1513-1526. [PMID: 28241896 DOI: 10.1017/s095026881700036x] [Citation(s) in RCA: 107] [Impact Index Per Article: 15.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/05/2022] Open
Abstract
Salmonella spp. comprise the second most common food-borne pathogens in the European Union (EU). The role of pigs as carriers of Salmonella has been intensively studied both on farm and at slaughter. Salmonella infection in pigs may cause fever, diarrhoea, prostration and mortality. However, most infected pigs remain healthy carriers, and those infected at the end of the fattening period could pose a threat to human health. Contamination of pig carcasses can occur on the slaughter line, and it is linked to cross-contamination from other carcasses and the presence of Salmonella in the environment. Therefore, Salmonella serovars present on pig carcasses can be different from those detected in the same bathes on the farm. In recent years, S. Typhimurium, S. Derby and S. serotype 4,[5],12:i:- (a monophasic variant of S. Typhimurium) have been the most common serovars to be detected in pigs in EU countries, but S. Rissen, S. Infantis, S. Enteritidis and S. Brandenburg have also been reported. In humans, several cases of salmonellosis have been linked to the consumption of raw or undercooked pork and pork products. Among the main serovars of porcine origin detected in confirmed human cases, S. Typhimurium, the monophasic variant S. 4,[5],12:i:- and S. Derby are certainly the most important.
Collapse
|
21
|
Diseases of the Alimentary Tract. Vet Med (Auckl) 2017. [PMCID: PMC7167529 DOI: 10.1016/b978-0-7020-5246-0.00007-3] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/18/2023]
|
22
|
Effect of strategic administration of an encapsulated blend of formic acid, citric acid, and essential oils on Salmonella carriage, seroprevalence, and growth of finishing pigs. Prev Vet Med 2016; 137:28-35. [PMID: 28107878 DOI: 10.1016/j.prevetmed.2016.12.007] [Citation(s) in RCA: 25] [Impact Index Per Article: 3.1] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/12/2016] [Revised: 10/27/2016] [Accepted: 12/12/2016] [Indexed: 11/21/2022]
Abstract
Controlling Salmonella at farm level can act as the first line of defence in reducing salmonellosis from pork. This study investigated the efficacy of an encapsulated blend of formic acid, citric acid, and essential oils (FormaXOL™) administered to finisher pigs for 28days prior to slaughter in controlling Salmonella shedding on a commercial farm with a history of high Salmonella seroprevalence. Fourteen pens of 8-10 pigs/pen were randomly assigned to a control (finisher diet without additive) or a treatment group (the same diet with 4kg/t of FormaXOL™) for 28 days. Faeces were collected from each pig on days 0, 14, and 28, while on day 29 blood, caecal digesta and ileocaecal-mesenteric lymph nodes were collected at slaughter. Pigs were weighed at the start and end of the trial, feed intake was recorded, and carcass quality parameters were recorded at slaughter. On day 14, Salmonella shedding was reduced in the treatment compared to the control group (27.9% versus 51.7% probability of detecting Salmonella in faeces, respectively; p=0.001). However, on day 28, no reduction was observed (20.6% versus 35.9% probability of detecting Salmonella in faeces, respectively; p=0.07). Interestingly, Salmonella shedding rates in the treated pigs remained stable throughout the trial compared to the control group. This suggests that the feed additive prevented additional pigs from acquiring the Salmonella infection. A lower Salmonella seroprevalence was detected at slaughter in the treatment compared to the control group using the 40% optical density cut-off (64.5% versus 88.5%, respectively; p=0.01). However, no significant differences in Salmonella recovery rates were observed in the caecal digesta or lymph nodes between treated and control groups. Treated pigs had a lower feed intake than pigs fed the control diet (p=0.001); however, average daily gain and feed conversion efficiency were not affected by treatment (p=0.45 and 0.55, respectively). Consequently, supplementing the diet with FormaXOL™ for 28days increased the feed cost per kg of live-weight gain by €0.08. Overall, results suggest that strategic administration of an encapsulated blend of formic acid, citric acid, and essential oils, to finishing pigs for 28days prior to slaughter has potential to prevent increased Salmonella shedding at certain time points as well as seroprevalence. However, this additive did not lower intestinal carriage, nor did it reduce seroprevalence to below the cut-off used for the high Salmonella risk category in Ireland (50%) or improve growth performance.
Collapse
|
23
|
Young I, Wilhelm BJ, Cahill S, Nakagawa R, Desmarchelier P, Rajić A. A Rapid Systematic Review and Meta-Analysis of the Efficacy of Slaughter and Processing Interventions to Control Non-Typhoidal Salmonella in Beef and Pork. J Food Prot 2016; 79:2196-2210. [PMID: 28104927 PMCID: PMC5238939 DOI: 10.4315/0362-028x.jfp-16-203] [Citation(s) in RCA: 15] [Impact Index Per Article: 1.9] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/11/2022]
Abstract
Pork is one of the major food sources of human salmonellosis worldwide, while beef products have been implicated in numerous foodborne outbreaks. As a result, effective interventions to reduce Salmonella contamination during beef and pork processing are of interest to both regulators and industry. We conducted a rapid systematic review and meta-analysis of literature investigating the efficacy of slaughter and processing interventions to control Salmonella in beef and pork. Review steps included: a comprehensive search strategy; relevance screening of abstracts; relevance confirmation of articles; data extraction; risk-of-bias assessment; meta-analysis (where appropriate); and a weight-of-evidence assessment. A total of 191 relevant experimental studies were identified. Two controlled trials indicated that hot water and steam treatments are effective at reducing the prevalence of Salmonella on beef carcasses (relative risk [RR] = 0.11, 95% confidence interval [CI]: 0.02, 0.58), while four trials found that pre-chill organic acid washes are effective at reducing Salmonella on pork carcasses (RR = 0.32, 95% CI: 0.13, 0.78), with high confidence in the estimates of effect. Four quasi-experimental studies found that post-exsanguination chemical washes were effective to reduce the prevalence of Salmonella on cattle hides, with low confidence in the specific estimate of effect; moderate confidence was found for the effect estimates of scalding (RR = 0.20, 95% CI: 0.14, 0.29) and singeing (RR = 0.34, 95% CI: 0.22, 0.52) of pork carcasses. The overall evidence supported enhanced reductions of Salmonella through a multiple-hurdle approach. In conclusion, various slaughter and processing interventions can contribute to reducing Salmonella on beef and pork carcasses, depending on the context of application; an appropriate combination should be selected, validated, and verified by establishment operators within their local conditions.
Collapse
Affiliation(s)
- Ian Young
- School of Occupational and Public Health, Ryerson University, 350 Victoria Street, POD 249, Toronto, Ontario, Canada, M5B 2K3
| | - Barbara J Wilhelm
- Department of Population Medicine, University of Guelph, 50 Stone Road, Guelph, Ontario, Canada, N1G 2W1
| | - Sarah Cahill
- Food Safety and Quality Unit, Office of Food Safety, Agriculture and Consumer Protection Department, Food and Agriculture Organization of the United Nations, Viale delle Terme di Caracalla, Rome 00153, Italy
| | - Rei Nakagawa
- Department of Food Safety and Zoonoses, World Health Organization, 20 Avenue Appia, 1211 Geneva 27, Switzerland
| | | | - Andrijana Rajić
- Food Safety and Quality Unit, Office of Food Safety, Agriculture and Consumer Protection Department, Food and Agriculture Organization of the United Nations, Viale delle Terme di Caracalla, Rome 00153, Italy
| |
Collapse
|
24
|
Guerra Filho JB, Yamatogi RS, Possebon FS, Fernandes SA, Tiba-Casas MR, Lara GH, Ribeiro MG, Pinto JP. Frequency, serotyping and antimicrobial resistance pattern of Salmonella from feces and lymph nodes of pigs. PESQUISA VETERINARIA BRASILEIRA 2016. [DOI: 10.1590/s0100-736x2016001200004] [Citation(s) in RCA: 7] [Impact Index Per Article: 0.9] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/22/2022]
Abstract
ABSTRACT: Salmonellosis is a foodborne disease caused by bacteria of the genus Salmonella, being pigs and pork-products potentially important for its occurrence. In recent decades, some serovars of Salmonella have shown increase of resistance to conventional antimicrobials used in human and animal therapy, with serious risks for public health. The aim of this study was to evaluate feces (n=50), mediastinal (n=50), mesenteric (n=50) and mandibular (n=50) lymph nodes obtained from slaughter houses for Salmonella spp. Positive samples were serotyped and subjected to an in vitro antimicrobial susceptibility test, including the extended-spectrum beta-lactamase (ESBL) production. Salmonella species were identified in 10% (20/200) of total samples. From these, 20% (10/50) were identified in the submandibular lymph nodes, 18% (9/50) in the mesenteric lymph nodes, 2% (1/50) in feces and 0% (0/50) in the mediastinal lymph nodes. The serotypes found were Salonella Typhimurium (55%), S. enterica subsp. enterica 4,5,12: i: - (35%), S. Brandenburg and S. Derby with 5% (5% each). All strains showed resistance to at least one antimicrobial; 90% were resistant to four or more antimicrobials, and 15% were multidrug-resistant. Resistance to ciprofloxacin, tetracycline and nalidixic acid was particularly prevalent amongst the tested serovars. Here, we highlighted the impact of pigs in the epidemiological chain of salmonellosis in domestic animals and humans, as well as the high antimicrobial resistance rates of Salmonella strains, reinforcing the necessity for responsible use of antimicrobials for animals as an emergent One Health issue, and to keep these drugs for human therapy approaches.
Collapse
|
25
|
Sanchez-Maldonado AF, Aslam M, Service C, Narváez-Bravo C, Avery BP, Johnson R, Jones TH. Prevalence and antimicrobial resistance of Salmonella isolated from two pork processing plants in Alberta, Canada. Int J Food Microbiol 2016; 241:49-59. [PMID: 27750110 DOI: 10.1016/j.ijfoodmicro.2016.10.004] [Citation(s) in RCA: 21] [Impact Index Per Article: 2.6] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/09/2016] [Revised: 09/14/2016] [Accepted: 10/05/2016] [Indexed: 10/20/2022]
Abstract
This study investigated the frequency of Salmonella serovars on pig carcasses at various processing steps in two commercial pork processing plants in Alberta, Canada and characterized phenotypic and genotypic antimicrobial resistance (AMR) and PFGE patterns of the Salmonella isolates. Over a one year period, 1000 swab samples were collected from randomly selected pigs at two slaughter plants. Sampling points were: carcass swabs after bleeding (CSAB), carcass swabs after de-hairing (CSAD, plant A) or skinning (CSASk, plant B), carcass swabs after evisceration (CSAE), carcass swabs after pasteurization (CSAP, plant A) or washing (CSAW, plants B) and retail pork (RP). For plant A, 87% of CSAB and 8% of CSAE were positive for Salmonella while at plant B, Salmonella was recovered from 94% of CSAB and 10% of CSAE. Salmonella was not recovered from the RP samples at either plant, indicating that the plants used effective control measures. Salmonella enterica serovar Derby was the most common serotype (23%, 29/127) recovered in plant A and plant B (61%, 76/124). For plant A, 35% (45/127) of isolates were resistant to at least one antimicrobial. Five isolates (3.9%), 4 serovar Ohio strains and one serovar I:Rough-O:I,v:-, strain were simultaneously resistant to antimicrobials of very high (Category I), high (Category II), and medium (Category III) importance to human medicine. The 4 S. Ohio isolates were recovered from 3 different steps of pork processing on the same sampling day and displayed resistance to 5-7 antimicrobials, with all of them displaying resistance to ceftiofur and ceftriaxone (Category I). An I:Rough-O:l,v:- isolate, recovered on a different sampling day, was resistant to 7 antimicrobials that included resistance to ampicillin/clavulanic acid, ceftiofur and ceftriaxone (Category I). Salmonella strains isolated from plant A harbored 12 different AMR genes. The most prevalent genes were sul1, sul2, tet(A), tet(B), aadA, strA/strB, aac(3)IV and aphA1. For Salmonella isolates from plant B, 7 resistance genes were identified alone or in combination where tet(B) was found in 77 (62.3%) of the isolates. For plant A, 19 different PFGE subtypes of Salmonella isolates that displayed phenotypic and/or genotypic resistance were observed while 13 different PFGE subtypes were observed for plant B. The lack of detection of Salmonella on the surfaces of RP suggests that current pork processing practices can dramatically reduce Salmonella. Salmonella isolates from pig carcasses at various steps displayed multidrug resistance, including to those of very high importance in human medicine, which represent a public health concern.
Collapse
Affiliation(s)
| | - Mueen Aslam
- Agriculture and Agri-Food Canada, Lacombe Research Centre, 6000 C & E Trail, Lacombe, AB T4L 1W1, Canada
| | - Cara Service
- Agriculture and Agri-Food Canada, Lacombe Research Centre, 6000 C & E Trail, Lacombe, AB T4L 1W1, Canada
| | - Claudia Narváez-Bravo
- Department of Food Science, Faculty of Agricultural and Food Sciences, University of Manitoba, Winnipeg, MB R3T 2N2, Canada
| | - Brent P Avery
- Centre for Food-borne, Environmental Zoonotic Infectious Diseases, Public Health Agency of Canada, Guelph, Ontario N1G 5B2, Canada
| | - Roger Johnson
- National Microbiology Laboratory @ Guelph, Public Health Agency of Canada, Guelph, Ontario, N1G 3W4, Canada
| | - Tineke H Jones
- Agriculture and Agri-Food Canada, Lacombe Research Centre, 6000 C & E Trail, Lacombe, AB T4L 1W1, Canada.
| |
Collapse
|
26
|
Di Ciccio P, Ossiprandi MC, Zanardi E, Ghidini S, Belluzzi G, Vergara A, Ianieri A. Microbiological contamination in Three Large-Scale Pig Slaughterhouses in Northern Italy. Ital J Food Saf 2016; 5:6151. [PMID: 28058247 PMCID: PMC5178835 DOI: 10.4081/ijfs.2016.6151] [Citation(s) in RCA: 6] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/02/2016] [Revised: 05/30/2016] [Accepted: 05/30/2016] [Indexed: 12/04/2022] Open
Abstract
The aim of this survey was to obtain data on microbiological contamination of pig carcasses and environments in three large-scale Italian slaughterhouses (identified as A-B-C) located in Northern Italy. Each slaughterhouse was visited six times. Five carcasses and three different sites of the slaughterhouse (before and during slaughter) were sampled on each sampling day. A single pooled caecal sample was taken on each sampling day. A total of 90 carcasses, 108 environmental samples and 18 caecal samples were collected. Samples from pig carcasses and slaughterhouse environment were analyzed for total viable count (TVC), Enterobacteriaceae count (EBC) and Salmonella. The caecal contents were examined for Salmonella. Carcasses from slaughterhouse A presented the greatest TVC and EBC mean log value, whereas environmental samples collected during slaughter activities from slaughterhouse C showed the greatest TVC and EBC mean log value. As far as the environmental samples collected before slaughter activities are concerned, an average up to 6 log10 colony forming unit (CFU)/cm2 TVC in two slaughter plants (A and C) and 5 log10 CFU/cm2 TVC in one slaughter plant (B) was detected. Salmonella was recovered in two slaughterhouses (A and B). Four different Salmonella serotypes were detected in the positive samples (11). Within serotype S. Rissen and S. Typhimurium monophasic-variant isolates, two pulsed-field gel electrophoresis patterns were identified. The findings in this survey suggest that carcass contamination is influenced by the slaughterhouse plant and this could be a result of differences in line speed. The results of environmental sampling have not shown an association with the slaughterhouse plant.
Collapse
Affiliation(s)
| | | | | | | | | | - Alberto Vergara
- Faculty of Veterinary Medicine, University of Teramo, Teramo, Italy
| | | |
Collapse
|
27
|
Walia K, Argüello H, Lynch H, Leonard FC, Grant J, Yearsley D, Kelly S, Duffy G, Gardiner GE, Lawlor PG. Effect of feeding sodium butyrate in the late finishing period on Salmonella carriage, seroprevalence, and growth of finishing pigs. Prev Vet Med 2016; 131:79-86. [PMID: 27544256 DOI: 10.1016/j.prevetmed.2016.07.009] [Citation(s) in RCA: 24] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/04/2016] [Revised: 06/07/2016] [Accepted: 07/18/2016] [Indexed: 11/29/2022]
Abstract
Pork is an important source of human salmonellosis and low-cost on-farm control measures may provide a useful element in reducing the prevalence of this pathogen in food. This study investigated the effectiveness of dietary supplementation with sodium butyrate administered to finisher pigs for ∼4-weeks prior to slaughter to control Salmonella shedding on highly contaminated farms. Two trials (A and B) were conducted on two commercial pig farms, which had a history of high Salmonella seroprevalence. In both trials, pens (14 pens of 12 pigs/pen in Trial A and 12 pens of 12-17 pigs/pen in Trial B) were randomly assigned to a control (finisher feed without additive) or a treatment group (the same feed with 3kg sodium butyrate/t) for 24-28days, depending on the trial. Faeces were collected from each pig on days 0, 12 and 24/28, and blood, caecal digesta and ileocaecal/mesenteric lymph nodes were collected from the slaughterhouse. Pigs were weighed at the start and end of the trials, feed intake was recorded, and carcass quality parameters were recorded at slaughter. In Trial A, Salmonella shedding was reduced in the treatment compared to the control group at the end of the trial (30% versus 57% probability of detecting Salmonella in faeces, respectively; p<0.001). This reflected the serology results, with detection of a lower seroprevalence in the treatment compared to the control group using the 20% optical density cut-off (69.5% versus 89%; p=0.001). However, no effect on faecal shedding or seroprevalance was observed in Trial B, which may be explained by the detection of a concomitant infection with Lawsonia intracellularis. No significant differences in Salmonella recovery rates were observed in the caecal digesta or lymph nodes in either trial. Furthermore, feed intake, weight gain, and feed conversion efficiency (FCE) did not differ between groups (p>0.05) in either trial. Numerical improvements in weight gain and FCE were found with sodium butyrate treatment, which gave a cost benefit of €0.04/kg of live-weight gain. Overall, results suggest that strategic feeding of sodium butyrate, at 3kg/t of feed, to finishing pigs for 24-28days prior to slaughter was effective in reducing Salmonella shedding and seroprevalance but perhaps only in the absence of co-infection with other pathogens. However, sodium butyrate supplementation at this rate did not influence intestinal carriage, nor did it reduce seroprevalence to below the cut-off used for the high Salmonella risk category in Ireland (50%), or significantly improve growth performance.
Collapse
Affiliation(s)
- Kavita Walia
- Teagasc, Food Research Centre, Ashtown, Dublin 15, Ireland; Department of Science, Waterford Institute of Technology, Waterford, Ireland; Teagasc, Pig Development Department, Animal and Grassland Research and Innovation Centre, Moorepark, Fermoy, Co. Cork, Ireland
| | | | - Helen Lynch
- Teagasc, Food Research Centre, Ashtown, Dublin 15, Ireland; School of Veterinary Medicine, University College Dublin, Dublin, Ireland; Teagasc, Pig Development Department, Animal and Grassland Research and Innovation Centre, Moorepark, Fermoy, Co. Cork, Ireland
| | - Finola C Leonard
- School of Veterinary Medicine, University College Dublin, Dublin, Ireland
| | - Jim Grant
- Teagasc, Food Research Centre, Ashtown, Dublin 15, Ireland
| | - Dermot Yearsley
- Department of Agriculture, Food and the Marine, Central Veterinary Research Laboratory, Backweston, Ireland
| | - Sinead Kelly
- Department of Agriculture, Food and the Marine, Central Veterinary Research Laboratory, Backweston, Ireland
| | | | - Gillian E Gardiner
- Department of Science, Waterford Institute of Technology, Waterford, Ireland.
| | - Peadar G Lawlor
- Teagasc, Pig Development Department, Animal and Grassland Research and Innovation Centre, Moorepark, Fermoy, Co. Cork, Ireland
| |
Collapse
|
28
|
Bermúdez PM, Pulecio SL, Suárez MC. Susceptibilidad antimicrobiana de aislamientos de Salmonella enterica provenientes de pisos, equipos, utensilios y producto terminado en el beneficio porcino en Colombia. REVISTA DE LA FACULTAD DE MEDICINA VETERINARIA Y DE ZOOTECNIA 2016. [DOI: 10.15446/rfmvz.v63n1.56903] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.1] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/09/2022] Open
Abstract
<p>La diseminación de aislamientos de Salmonella spp resistentes a antimicrobianos, a través de las cadenas productivas de alimentos de origen animal, es una preocupación de salud pública de carácter mundial. Éste estudio describe los patrones de resistencia antimicrobiana de 283 aislamientos de Salmonella enterica procedentes de plantas de beneficio porcino en Colombia. Se evaluó la susceptibilidad antimicrobiana frente a diez antimicrobianos: amoxacilina-ácido clavulánico (30 ug), ampicilina(10 ug), ceftiofur (30 ug), ciprofloxacina (5 ug), cloranfenicol (30 ug), florfenicol (30 ug), gentamicina (10 ug), sulfadiazina/trimetroprim (25 ug), tetraciclina (30 ug) y tilmicosina (15 ug) mediante el método de difusión en disco (Bauer & Kirby, 1966). Los resultados evidenciaron la presencia de 279 aislamientos multiresistentes de Salmonella enterica de origen porcino provenientes del ambiente y producto terminado de las plantas de beneficio evaluadas (46.64% n: 132). Se detectaron 52 patrones de multiresistencia, el más común fue ceftiofur-tetraciclina-tilmicosina en el 9,89% (n: 28) de los aislamientos. Con referencia a éstos antimicrobianos el 96,82% (n: 274) de los aislamientos fueron resistentes a tetraciclina, 73,14% (n: 207) a tilmicosina y 28,27% (n: 80) a ceftiofur. De especial interés fue la alta proporción de aislamientos resistentes a éste último, debido a una posible resistencia cruzada con ceftriaxona. Los resultados obtenidos demuestran la necesidad de promover y fortalecer un Programa oficial de Vigilancia de la Resistencia Antimicrobiana y sistemas de monitoreo voluntario en cada eslabón de las cadenas productivas, para contribuir a la prevención y control de la transmisión de microorganismos resistentes de origen alimentario en el marco del sistema de gestión de inocuidad alimentaria en Colombia.</p>
Collapse
|
29
|
Corbellini LG, Júnior AB, de Freitas Costa E, Duarte ASR, Albuquerque ER, Kich JD, Cardoso M, Nauta M. Effect of slaughterhouse and day of sample on the probability of a pig carcass being Salmonella-positive according to the Enterobacteriaceae count in the largest Brazilian pork production region. Int J Food Microbiol 2016; 228:58-66. [PMID: 27107299 DOI: 10.1016/j.ijfoodmicro.2016.03.030] [Citation(s) in RCA: 19] [Impact Index Per Article: 2.4] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/18/2014] [Revised: 01/22/2016] [Accepted: 03/26/2016] [Indexed: 02/07/2023]
Abstract
Sources of contamination of carcasses during slaughter include infected pigs as well as environmentally related sources. There are many microbial indicators that can be used in the processing of food to assess food hygiene and the safety of food processing. The presence of some microbial indicators can be viewed as a result of direct or indirect contamination of a food with fecal material. The presence of Enterobacteriaceae is often used as a hygiene indicator, as they are found both in the environment and in the intestine of warm-blooded animals. An association between Salmonella isolation and Enterobacteriaceae count (EC) on pre-chill carcasses has been described, however the impact of slaughterhouse and the day of sampling on the occurrence of Salmonella has not been previously investigated. To this end, mixed logistic regressions (MLRs) with random effects and fixed slopes were performed to assess the change in EC and its correlation with Salmonella occurrence using two data sets. The first describes the EC and Salmonella isolation in 60 pork carcasses in one slaughterhouse sampled at 11 different slaughter steps, including the carcass as a random effect. The second describes the EC and Salmonella isolation on 1150 pre-chill carcasses sampled in 13 slaughterhouses over 230 sampling days, and the model combined two random intercepts, slaughterhouse and date of sampling nested with slaughterhouse (day/slaughterhouse). Statistically significant associations (p<0.0001) between the log of the EC and Salmonella occurrence were found in all models. Nevertheless, although a strong association was found between Enterobacteriaceae and Salmonella contamination in pork carcasses, this association was not constant, given that there was a high variation in the probability of a carcass being positive for Salmonella according to the EC mainly between days of samples. The effect of the day of sampling on Salmonella prevalence was so large that the predictive value of the EC count for Salmonella isolation on a daily basis was compromised. It is possible that on some days batches with a high prevalence of Salmonella carriers shedding a high number of Salmonella were slaughtered. On these days, the potential for contamination/cross-contamination of carcasses will be so large that even hygienic slaughter, confirmed by the low EC on carcasses, will not be able to prevent the presence of Salmonella on some carcasses. The results of this study demonstrate that, despite the statistically significant association found, it may be difficult to predict when hygiene failure measured via EC actually indicates Salmonella contamination, and neither the inverse.
Collapse
Affiliation(s)
- Luís Gustavo Corbellini
- Departamento de Medicina Veterinária Preventiva, Faculdade de Veterinária, Universidade Federal do Rio Grande do Sul, Brazil; Division of Epidemiology and Microbial Genomics, National Food Institute, Technical University of Denmark, Denmark.
| | | | - Eduardo de Freitas Costa
- Departamento de Medicina Veterinária Preventiva, Faculdade de Veterinária, Universidade Federal do Rio Grande do Sul, Brazil
| | - Ana Sofia Ribeiro Duarte
- Division of Epidemiology and Microbial Genomics, National Food Institute, Technical University of Denmark, Denmark
| | | | | | - Marisa Cardoso
- Departamento de Medicina Veterinária Preventiva, Faculdade de Veterinária, Universidade Federal do Rio Grande do Sul, Brazil
| | - Maarten Nauta
- Division of Epidemiology and Microbial Genomics, National Food Institute, Technical University of Denmark, Denmark
| |
Collapse
|
30
|
Cai Y, Tao J, Jiao Y, Fei X, Zhou L, Wang Y, Zheng H, Pan Z, Jiao X. Phenotypic characteristics and genotypic correlation between Salmonella isolates from a slaughterhouse and retail markets in Yangzhou, China. Int J Food Microbiol 2016; 222:56-64. [PMID: 26851738 DOI: 10.1016/j.ijfoodmicro.2016.01.020] [Citation(s) in RCA: 74] [Impact Index Per Article: 9.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/19/2015] [Revised: 12/22/2015] [Accepted: 01/25/2016] [Indexed: 11/24/2022]
Abstract
An epidemiological investigation of Salmonella spp. in pig and pork samples from one slaughterhouse and its downstream retail markets in Yangzhou, Jiangsu Province, China, was conducted from October 2013 to March 2014. A total of 71.8% (155/216) and 70.9% (78/110), respectively, of the slaughterhouse and retail market samples were recovered positive for Salmonella. All Salmonella isolates were characterized using serotyping, antimicrobial resistance detection, multilocus sequence typing (MLST), and pulsed-field gel electrophoresis (PFGE). Seven serotypes were shared by isolates from the two sources, with the most common serotypes being Salmonella Derby, Typhimurium, and Uganda. Antimicrobial sensitivity testing revealed that the highest antimicrobial resistance rate was against tetracycline (49.7% and 37.2% in isolates from the slaughterhouse and retail market, respectively) with many multidrug-resistant (MDR) isolates in both sources. MLST analysis showed that eight sequence type (ST) patterns were shared, and ST40 occupied an absolute superiority among isolates from both sources. PFGE permitted the resolution of XbaI macrorestriction fragments of the selected 31 Salmonella Derby and 19 Salmonella Typhimurium into 30 and 10 distinct pulsotypes, displaying the high similarity between the isolates from the two sources. Our findings indicated that Salmonella isolates from a slaughterhouse and its downstream retail markets were phenotypically and genetically homologous. Additionally, Salmonella may propagate along the slaughter line and pork production chain from the slaughterhouse to retail markets.
Collapse
Affiliation(s)
- Yinqiang Cai
- Jiangsu Co-Innovation Center for Prevention and Control of Important Animal Infectious Diseases and Zoonoses, Yangzhou University, Yangzhou, Jiangsu 225009, China; Jiangsu Key Laboratory of Zoonosis, Yangzhou University, Yangzhou, Jiangsu 225009, China.
| | - Jing Tao
- Jiangsu Co-Innovation Center for Prevention and Control of Important Animal Infectious Diseases and Zoonoses, Yangzhou University, Yangzhou, Jiangsu 225009, China; Jiangsu Key Laboratory of Zoonosis, Yangzhou University, Yangzhou, Jiangsu 225009, China
| | - Yang Jiao
- Jiangsu Co-Innovation Center for Prevention and Control of Important Animal Infectious Diseases and Zoonoses, Yangzhou University, Yangzhou, Jiangsu 225009, China; Jiangsu Key Laboratory of Zoonosis, Yangzhou University, Yangzhou, Jiangsu 225009, China
| | - Xiao Fei
- Jiangsu Co-Innovation Center for Prevention and Control of Important Animal Infectious Diseases and Zoonoses, Yangzhou University, Yangzhou, Jiangsu 225009, China; Jiangsu Key Laboratory of Zoonosis, Yangzhou University, Yangzhou, Jiangsu 225009, China
| | - Le Zhou
- Yangzhou Center for Disease Control and Prevention, Yangzhou, Jiangsu 225002, China
| | - Yan Wang
- Yangzhou Center for Disease Control and Prevention, Yangzhou, Jiangsu 225002, China
| | - Huijuan Zheng
- Jiangsu Co-Innovation Center for Prevention and Control of Important Animal Infectious Diseases and Zoonoses, Yangzhou University, Yangzhou, Jiangsu 225009, China; Jiangsu Key Laboratory of Zoonosis, Yangzhou University, Yangzhou, Jiangsu 225009, China
| | - Zhiming Pan
- Jiangsu Co-Innovation Center for Prevention and Control of Important Animal Infectious Diseases and Zoonoses, Yangzhou University, Yangzhou, Jiangsu 225009, China; Jiangsu Key Laboratory of Zoonosis, Yangzhou University, Yangzhou, Jiangsu 225009, China.
| | - Xinan Jiao
- Jiangsu Co-Innovation Center for Prevention and Control of Important Animal Infectious Diseases and Zoonoses, Yangzhou University, Yangzhou, Jiangsu 225009, China; Jiangsu Key Laboratory of Zoonosis, Yangzhou University, Yangzhou, Jiangsu 225009, China.
| |
Collapse
|
31
|
Salmonella occurrence and Enterobacteriaceae counts in pig feed ingredients and compound feed from feed mills in Ireland. Prev Vet Med 2015. [DOI: 10.1016/j.prevetmed.2015.07.002] [Citation(s) in RCA: 26] [Impact Index Per Article: 2.9] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/21/2022]
|
32
|
Belluco S, Barco L, Roccato A, Ricci A. Variability of Escherichia coli and Enterobacteriaceae counts on pig carcasses: A systematic review. Food Control 2015. [DOI: 10.1016/j.foodcont.2015.02.042] [Citation(s) in RCA: 12] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/01/2022]
|
33
|
Corbellini LG, Duarte ASR, de Knegt LV, da Silva LE, Cardoso M, Nauta M. The impact of screening-test negative samples not enumerated by MPN. Int J Food Microbiol 2015; 205:1-6. [PMID: 25866905 DOI: 10.1016/j.ijfoodmicro.2015.03.023] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/07/2014] [Revised: 01/10/2015] [Accepted: 03/21/2015] [Indexed: 10/23/2022]
Abstract
In microbiological surveys, false negative results in detection tests precluding the enumeration by MPN may occur. The objective of this study was to illustrate the impact of screening test failure on the probability distribution of Salmonella concentrations in pork using a Bayesian method. A total of 276 swab samples in four slaughter steps (69 samples in each slaughter step: after dehairing, after singeing, after evisceration, and before chilling) were screened for Salmonella and enumerated by the MPN method. Salmonella contamination data were fitted to a lognormal distribution by using a Bayesian model that uses the number of positive tubes at each dilution in an MPN analysis to estimate the parameters of the concentration distribution. With Salmonella paired data, three data sets were used for each slaughter step: one that includes the positives in the screening test only, a second one that includes false negative results from the screening, and a third that considers the entire data set. The relative sensitivity of the screening test was also calculated assuming as gold standard samples with confirmed Salmonella. Salmonella was confirmed by a reference laboratory in 29 samples either by screening or MPN method. The relative sensitivity of the screening test was 69% (CI 95%: 52%-85%). The data set that included enumerations from screen-negative samples (false negative results) tended to have higher μ̂ and smaller σ̂ in comparison with the data set that discards false negative results, suggesting that the lack of sensitivity of the screening test affects the distribution that describes the contamination across the population. Numerous surveys on fitting distribution methods of microbial censored data have been published and discuss source of bias due to fitting method. Results of this survey contribute with that discussion by illustrating another possible source of bias due to failure of the screening methods preceding the MPN.
Collapse
Affiliation(s)
- Luís Gustavo Corbellini
- Departamento de Medicina Veterinária Preventiva, Faculdade de Veterinária, Universidade Federal do Rio Grande do Sul, Brazil; Division of Epidemiology and Microbial Genomics, National Food Institute, Technical University of Denmark, Denmark.
| | - Ana Sofia Ribeiro Duarte
- Division of Epidemiology and Microbial Genomics, National Food Institute, Technical University of Denmark, Denmark
| | - Leonardo Víctor de Knegt
- Division of Epidemiology and Microbial Genomics, National Food Institute, Technical University of Denmark, Denmark
| | | | - Marisa Cardoso
- Departamento de Medicina Veterinária Preventiva, Faculdade de Veterinária, Universidade Federal do Rio Grande do Sul, Brazil
| | - Maarten Nauta
- Division of Epidemiology and Microbial Genomics, National Food Institute, Technical University of Denmark, Denmark
| |
Collapse
|
34
|
Lambertini E, Buchanan RL, Narrod C, Pradhan AK. Transmission of Bacterial Zoonotic Pathogens between Pets and Humans: The Role of Pet Food. Crit Rev Food Sci Nutr 2015; 56:364-418. [DOI: 10.1080/10408398.2014.902356] [Citation(s) in RCA: 23] [Impact Index Per Article: 2.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 02/08/2023]
|
35
|
Airborne Salmonella and Listeria associated with Irish commercial beef, sheep and pig plants. Meat Sci 2014; 97:255-61. [DOI: 10.1016/j.meatsci.2014.01.025] [Citation(s) in RCA: 8] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/07/2013] [Revised: 01/24/2014] [Accepted: 01/31/2014] [Indexed: 11/22/2022]
|
36
|
Smid J, van Hoek A, Aarts H, Havelaar A, Heres L, de Jonge R, Pielaat A. Quantifying the sources of Salmonella on dressed carcasses of pigs based on serovar distribution. Meat Sci 2014; 96:1425-31. [DOI: 10.1016/j.meatsci.2013.12.002] [Citation(s) in RCA: 6] [Impact Index Per Article: 0.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/09/2012] [Revised: 10/31/2013] [Accepted: 12/05/2013] [Indexed: 10/25/2022]
|
37
|
Scientific Opinion on the public health risks related to the maintenance of the cold chain during storage and transport of meat. Part 1 (meat of domestic ungulates). EFSA J 2014. [DOI: 10.2903/j.efsa.2014.3601] [Citation(s) in RCA: 6] [Impact Index Per Article: 0.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/11/2022] Open
|
38
|
Argüello H, Carvajal A, Álvarez-Ordóñez A, Jaramillo-Torres HA, Rubio P. Effect of logistic slaughter on Salmonella contamination on pig carcasses. Food Res Int 2014. [DOI: 10.1016/j.foodres.2013.10.041] [Citation(s) in RCA: 12] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/28/2022]
|
39
|
McCarthy G, Lawlor PG, Gutierrez M, Gardiner GE. Assessing the biosafety risks of pig manure for use as a feedstock for composting. THE SCIENCE OF THE TOTAL ENVIRONMENT 2013; 463-464:712-719. [PMID: 23850661 DOI: 10.1016/j.scitotenv.2013.06.069] [Citation(s) in RCA: 15] [Impact Index Per Article: 1.4] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/01/2013] [Revised: 06/13/2013] [Accepted: 06/14/2013] [Indexed: 06/02/2023]
Abstract
The objective was to assess the biosafety risks of pig manure for use as a feedstock for composting. Salmonella was detected in the manure from half of the 30 pig farms sampled, with 52% of isolates recovered identified as multi-drug resistant S. Typhimurium. The highest prevalence (60%) was found on Salmonella category 2 and 3 farms i.e. those with medium and high Salmonella seroprevalence, respectively, although this was not statistically significant. Escherichia coli counts were, however, significantly higher in manure from Salmonella category 3 farms. Manure separation may be useful as a means of reducing/eliminating pathogens from manure prior to composting, as manure solids generated using a decanter centrifuge had lower E. coli and Enterococcus counts than manure. These findings should be taken into consideration when selecting pig manure for use as a feedstock for compost or other marketable manure by-products.
Collapse
Affiliation(s)
- G McCarthy
- Department of Chemical & Life Sciences, Waterford Institute of Technology, Waterford, Ireland; Teagasc Pig Development Department, Animal & Grassland Research & Innovation Centre, Moorepark, Fermoy, Co. Cork, Ireland
| | | | | | | |
Collapse
|
40
|
Mueller-Doblies D, Speed K, Davies RH. A retrospective analysis of Salmonella serovars isolated from pigs in Great Britain between 1994 and 2010. Prev Vet Med 2013; 110:447-55. [DOI: 10.1016/j.prevetmed.2013.02.023] [Citation(s) in RCA: 24] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/08/2012] [Revised: 02/27/2013] [Accepted: 02/28/2013] [Indexed: 11/29/2022]
|
41
|
Evidence of metabolic switching and implications for food safety from the phenome(s) of Salmonella enterica serovar Typhimurium DT104 cultured at selected points across the pork production food chain. Appl Environ Microbiol 2013; 79:5437-49. [PMID: 23770904 DOI: 10.1128/aem.01041-13] [Citation(s) in RCA: 21] [Impact Index Per Article: 1.9] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/17/2023] Open
Abstract
Salmonella enterica serovar Typhimurium DT104 is a recognized food-borne pathogen that displays a multidrug-resistant phenotype and that is associated with systemic infections. At one extreme of the food chain, this bacterium can infect humans, limiting the treatment options available and thereby contributing to increased morbidity and mortality. Although the antibiotic resistance profile is well defined, little is known about other phenotypes that may be expressed by this pathogen at key points across the pork production food chain. In this study, 172 Salmonella enterica serovar Typhimurium DT104/DT104b isolated from an extensive "farm-to-fork" surveillance study, focusing on the pork food chain, were characterized in detail. Isolates were cultured from environmental, processing, retail, and clinical sources, and the study focused on phenotypes that may have contributed to persistence/survival in these different niches. Molecular subtypes, along with antibiotic resistance profiles, tolerance to biocides, motility, and biofilm formation, were determined. As a basis for human infection, acid survival and the ability to utilize a range of energy sources and to adhere to and/or invade Caco-2 cells were also studied. Comparative alterations to biocide tolerance were observed in isolates from retail. l-Tartaric acid and d-mannose-1-phosphate induced the formation of biofilms in a preselected subset of strains, independent of their origin. All clinical isolates were motile and demonstrated an enhanced ability to survive in acidic conditions. Our data report on a diverse phenotype, expressed by S. Typhimurium isolates cultured from the pork production food chain. Extending our understanding of the means by which this pathogen adapts to environmental niches along the "farm-to-fork" continuum will facilitate the protection of vulnerable consumers through targeted improvements in food safety measures.
Collapse
|
42
|
Gonzales-Barron U, Cadavez V, Sheridan JJ, Butler F. Modelling the effect of chilling on the occurrence of Salmonella on pig carcasses at study, abattoir and batch levels by meta-analysis. Int J Food Microbiol 2013; 163:101-13. [DOI: 10.1016/j.ijfoodmicro.2013.03.006] [Citation(s) in RCA: 25] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/17/2012] [Revised: 01/23/2013] [Accepted: 03/02/2013] [Indexed: 11/24/2022]
|
43
|
Arguello H, Alvarez-Ordoñez A, Carvajal A, Rubio P, Prieto M. Role of slaughtering in Salmonella spreading and control in pork production. J Food Prot 2013; 76:899-911. [PMID: 23643137 DOI: 10.4315/0362-028x.jfp-12-404] [Citation(s) in RCA: 73] [Impact Index Per Article: 6.6] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/11/2022]
Abstract
Salmonella is one of the major foodborne pathogens worldwide. Pork products are among the main sources of Salmonella infection in humans, and several countries have established Salmonella surveillance and control programs. The role of slaughtering in carcass contamination has been indicated by studies focused on the slaughterhouse environment. In this review, we examine and discuss the information available regarding the influence that farm status, pig transport, and lairage have on the carriage of Salmonella by pigs entering the slaughter line. The evolution of carcass contamination throughout the slaughtering process, the main sources of contamination in the dirty and clean zones of the slaughter line, and previously reported prevalence of Salmonella on carcasses and factors affecting this prevalence also are discussed. The importance of implementing interventions at the slaughter level is discussed briefly. Consistent with the information available, pigs from infected farms and newly acquired or recrudescent infections in pigs at the subsequent stages of transport and lairage are important sources of Salmonella at the slaughtering plant. The continuous introduction of Salmonella into the slaughterhouse and the potential for resident flora constitute a risk for carcass contamination. At the slaughterhouse, some dressing activities can reduce carcass contamination, but others are critical control points that jeopardize carcass hygiene. This information indicates the importance of considering slaughter and previous stages in the pork production chain for controlling Salmonella in swine production.
Collapse
Affiliation(s)
- Hector Arguello
- Infectious Diseases and Epidemiology Unit, Department of Animal Health, University of León, León, Spain.
| | | | | | | | | |
Collapse
|
44
|
Baer AA, Miller MJ, Dilger AC. Pathogens of Interest to the Pork Industry: A Review of Research on Interventions to Assure Food Safety. Compr Rev Food Sci Food Saf 2013. [DOI: 10.1111/1541-4337.12001] [Citation(s) in RCA: 72] [Impact Index Per Article: 6.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/30/2022]
Affiliation(s)
- Arica A. Baer
- Dept. of Animal Science, Univ. of Illinois Urbana-Champaign; 1503 S
| | - Michael J. Miller
- Dept. of Food Science and Human Nutrition; Div. of Nutritional Sciences; 905 S.; Goodwin Ave.; Urbana; IL 61801; U.S.A
| | - Anna C. Dilger
- Dept. of Animal Science, Univ. of Illinois Urbana-Champaign; 1503 S
| |
Collapse
|
45
|
Salmonella prevalence and characterization in a free-range pig processing plant: Tracking in trucks, lairage, slaughter line and quartering. Int J Food Microbiol 2013; 162:48-54. [DOI: 10.1016/j.ijfoodmicro.2012.12.026] [Citation(s) in RCA: 32] [Impact Index Per Article: 2.9] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/31/2012] [Revised: 11/06/2012] [Accepted: 12/20/2012] [Indexed: 11/24/2022]
|
46
|
De Busser EV, De Zutter L, Dewulf J, Houf K, Maes D. Salmonella control in live pigs and at slaughter. Vet J 2013; 196:20-7. [PMID: 23414643 DOI: 10.1016/j.tvjl.2013.01.002] [Citation(s) in RCA: 49] [Impact Index Per Article: 4.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/27/2012] [Revised: 11/05/2012] [Accepted: 01/07/2013] [Indexed: 02/07/2023]
Abstract
As European Union legislation sets reduction targets to lower the incidence of human salmonellosis, Member States are obliged to take effective measures to control Salmonella infection and contamination along the pig production chain. This review considers the most important control measures in the primary phase of pig production as well as during transport, lairage and along the slaughter line. Pig feed should be free of Salmonella, and contamination after feed processing must be prevented. Cleaning and disinfection procedures should be improved, although this can be complicated by the development of biofilms and the interaction between Salmonella and protozoa. Further research is required on the acid tolerance response of Salmonella strains regarding the use of organic acids in feed and/or drinking water. Vaccination of sows and piglets can be helpful but can interfere with current serosurveillance as no differentiation can yet be made between naturally infected and vaccinated animals. Fasting, transport and lairage conditions should be critically evaluated and improved. Slaughterhouses must avoid contamination and cross-contamination during all stages of the slaughter process. Scalding by steam and implementing a second singeing step after polishing are beneficial. Attention should be paid to the cleaning and disinfection procedures along the slaughter line. Carcass decontamination is a promising approach, but needs to be considered as a tool to add to good hygiene practices.
Collapse
Affiliation(s)
- Emily V De Busser
- Faculty of Veterinary Medicine, Ghent University, Salisburylaan 133, B-9820 Merelbeke, Belgium.
| | | | | | | | | |
Collapse
|
47
|
Arguello H, Carvajal A, Naharro G, Arcos M, Rodicio MR, Martin MC, Rubio P. Sero- and genotyping of Salmonella in slaughter pigs, from farm to cutting plant, with a focus on the slaughter process. Int J Food Microbiol 2013; 161:44-52. [DOI: 10.1016/j.ijfoodmicro.2012.11.013] [Citation(s) in RCA: 19] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/25/2012] [Revised: 11/14/2012] [Accepted: 11/15/2012] [Indexed: 10/27/2022]
|
48
|
O'Leary D, Cabe EMM, McCusker MP, Martins M, Fanning S, Duffy G. Microbiological study of biofilm formation in isolates of Salmonella enterica Typhimurium DT104 and DT104b cultured from the modern pork chain. Int J Food Microbiol 2013; 161:36-43. [DOI: 10.1016/j.ijfoodmicro.2012.11.021] [Citation(s) in RCA: 15] [Impact Index Per Article: 1.4] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/04/2012] [Revised: 10/30/2012] [Accepted: 11/27/2012] [Indexed: 10/27/2022]
|
49
|
da SILVA LUISEDUARDO, DIAS VANESSA, FERRONATTO ANDRÉIA, GUERRA PRISCILA, BERNO LAÍS, TRICHES NELISE, KICH JALUSADEON, CORBELLINI LUISGUSTAVO, CARDOSO MARISA. Longitudinal Dissemination of Salmonella enterica Clonal Groups through the Slaughter Process of Salmonella-Positive Pig Batches. J Food Prot 2012; 75:1580-8. [DOI: 10.4315/0362-028x.jfp-11-515] [Citation(s) in RCA: 26] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/11/2022]
Abstract
This study was conducted to assess the dissemination of Salmonella clonal groups in slaughterhouses that received batches of Salmonella-positive pigs and used different routine processing procedures. Eight serial sampling sessions were conducted in three slaughterhouses (A, B, and C). Blood was collected randomly (n = 25) from each batch of pigs and processed for serology. Carcasses (n = 12) were identified and sampled after dehairing, after singeing, after evisceration, and before chilling. A section of cecum also was collected. Salmonella isolates were submitted to pulsed-field gel electrophoresis. The overall seroprevalence of Salmonella was 80.6% (316 of 392 samples), and cecal contents were positive for Salmonella in 23.8% (26 of 109) of the pigs sampled. Carcasses after dehairing had a significantly higher prevalence of Salmonella (P = 0.004) and the highest Salmonella levels (median = 0.26 log CFU/300 cm2). The singeing step significantly affected the Salmonella status of the carcasses (P < 0.001); however, the efficacy of singeing differed among slaughterhouses. In the prechilling step, 14.7% (16 of 109) of the carcasses were positive for Salmonella. Salmonella pulsotypes found on the prechill carcasses were also found in the lairage, in the cecal contents, and on carcasses after dehairing, suggesting that the main source of contamination was the slaughter process before singeing. Slaughterhouse C was the most likely (odds ration [OR] = 6.51) to have pigs carrying Salmonella in the gut, and slaughterhouse B was the most likely (OR = 14.66) to have contaminated carcasses at the prechilling step. These findings indicate that the procedures adopted in slaughterhouse B contributed to the spread of Salmonella strains. In contrast, in slaughterhouse C the Salmonella strains carried by the pigs or found in the lairage were not recovered from prechilled carcasses, validating the effectiveness of the slaughterhouse interventions. These results indicate that an effective slaughter process can help decrease the number of Salmonella-positive carcasses in slaughterhouses that receive Salmonella-positive pig batches.
Collapse
Affiliation(s)
- LUIS EDUARDO da SILVA
- 1Departamento de Medicina Veterinária Preventiva, Faculdade de Veterinária, Universidade Federal do Rio Grande do Sul, Av. Bento Gonçalves 9090, 90540-000 Porto Alegre, Rio Grande do Sul, Brazil
| | - VANESSA DIAS
- 1Departamento de Medicina Veterinária Preventiva, Faculdade de Veterinária, Universidade Federal do Rio Grande do Sul, Av. Bento Gonçalves 9090, 90540-000 Porto Alegre, Rio Grande do Sul, Brazil
| | - ANDRÉIA FERRONATTO
- 1Departamento de Medicina Veterinária Preventiva, Faculdade de Veterinária, Universidade Federal do Rio Grande do Sul, Av. Bento Gonçalves 9090, 90540-000 Porto Alegre, Rio Grande do Sul, Brazil
| | - PRISCILA GUERRA
- 1Departamento de Medicina Veterinária Preventiva, Faculdade de Veterinária, Universidade Federal do Rio Grande do Sul, Av. Bento Gonçalves 9090, 90540-000 Porto Alegre, Rio Grande do Sul, Brazil
| | - LAÍS BERNO
- 2Embrapa Suínos e Aves, Concórdia, 89700-000 Santa Catarina, Brazil
| | - NELISE TRICHES
- 2Embrapa Suínos e Aves, Concórdia, 89700-000 Santa Catarina, Brazil
| | - JALUSA DEON KICH
- 2Embrapa Suínos e Aves, Concórdia, 89700-000 Santa Catarina, Brazil
| | - LUIS GUSTAVO CORBELLINI
- 1Departamento de Medicina Veterinária Preventiva, Faculdade de Veterinária, Universidade Federal do Rio Grande do Sul, Av. Bento Gonçalves 9090, 90540-000 Porto Alegre, Rio Grande do Sul, Brazil
| | - MARISA CARDOSO
- 1Departamento de Medicina Veterinária Preventiva, Faculdade de Veterinária, Universidade Federal do Rio Grande do Sul, Av. Bento Gonçalves 9090, 90540-000 Porto Alegre, Rio Grande do Sul, Brazil
| |
Collapse
|
50
|
Schmidt JW, Brichta-Harhay DM, Kalchayanand N, Bosilevac JM, Shackelford SD, Wheeler TL, Koohmaraie M. Prevalence, enumeration, serotypes, and antimicrobial resistance phenotypes of salmonella enterica isolates from carcasses at two large United States pork processing plants. Appl Environ Microbiol 2012; 78:2716-26. [PMID: 22327585 PMCID: PMC3318825 DOI: 10.1128/aem.07015-11] [Citation(s) in RCA: 32] [Impact Index Per Article: 2.7] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/26/2011] [Accepted: 01/30/2012] [Indexed: 11/20/2022] Open
Abstract
The objective of this study was to characterize Salmonella enterica contamination on carcasses in two large U.S. commercial pork processing plants. The carcasses were sampled at three points, before scalding (prescald), after dehairing/polishing but before evisceration (preevisceration), and after chilling (chilled final). The overall prevalences of Salmonella on carcasses at these three sampling points, prescald, preevisceration, and after chilling, were 91.2%, 19.1%, and 3.7%, respectively. At one of the two plants, the prevalence of Salmonella was significantly higher (P < 0.01) for each of the carcass sampling points. The prevalences of carcasses with enumerable Salmonella at prescald, preevisceration, and after chilling were 37.7%, 4.8%, and 0.6%, respectively. A total of 294 prescald carcasses had Salmonella loads of >1.9 log CFU/100 cm(2), but these carcasses were not equally distributed between the two plants, as 234 occurred at the plant with higher Salmonella prevalences. Forty-one serotypes were identified on prescald carcasses with Salmonella enterica serotypes Derby, Typhimurium, and Anatum predominating. S. enterica serotypes Typhimurium and London were the most common of the 24 serotypes isolated from preevisceration carcasses. The Salmonella serotypes Johannesburg and Typhimurium were the most frequently isolated serotypes of the 9 serotypes identified from chilled final carcasses. Antimicrobial susceptibility was determined for selected isolates from each carcass sampling point. Multiple drug resistance (MDR), defined as resistance to three or more classes of antimicrobial agents, was identified for 71.2%, 47.8%, and 77.5% of the tested isolates from prescald, preevisceration, and chilled final carcasses, respectively. The results of this study indicate that the interventions used by pork processing plants greatly reduce the prevalence of Salmonella on carcasses, but MDR Salmonella was isolated from 3.2% of the final carcasses sampled.
Collapse
Affiliation(s)
- John W Schmidt
- U.S. Department of Agriculture, Agricultural Research Service, Roman L. Hruska U.S. Meat Animal Research Center, Clay Center, Nebraska, USA.
| | | | | | | | | | | | | |
Collapse
|