1
|
Huang S, Zhang B, Cui F, He Y, Shi J, Yang X, Lens PNL, Shi W. Mechanisms underlying the detrimental impact of micro(nano)plastics on the stability of aerobic granular sludge: Interactions between micro(nano)plastics and extracellular polymeric substances. JOURNAL OF HAZARDOUS MATERIALS 2024; 478:135512. [PMID: 39151361 DOI: 10.1016/j.jhazmat.2024.135512] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/11/2024] [Revised: 07/16/2024] [Accepted: 08/12/2024] [Indexed: 08/19/2024]
Abstract
Microplastics (MPs) and nanoplastics (NPs) present in wastewater can pose a negative impact to aerobic granular sludge (AGS). Herein, this study found that MPs and NPs (20 mg/L) deteriorated the sludge settleability and granule integrity, resulting in a 15.7 % and 21.9 % decrease in the total nitrogen removal efficiency of the AGS system, respectively. This was possibly due to the reduction of the extracellular polymeric substances (EPS) content. The subsequent analysis revealed that tyrosine, tryptophan, and humic acid-like substances in EPS exhibited a higher propensity for chemisorption and inhomogeneous multilayer adsorption onto NPs compared to MPs. The binding of EPS onto the surface of plastic particles increased the electronegativity of the MPs, but facilitated the aggregation of NPs through reducing the electrostatic repulsion, thereby mitigating the adverse effects of MPs/NPs on the AGS stability. Additionally, comprehensive analysis of the extended Derjaguin-Landau-Verwey-Overbeek theory indicated that the suppressed aggregation of microorganisms was the internal mechanisms contributing to the inadequate stability of AGS induced by MPs/NPs. This study provides novel insights into the detrimental mechanisms of MPs/NPs on the AGS stability, highlighting the key role of EPS in maintaining the structural stability of AGS when exposed to MPs/NPs.
Collapse
Affiliation(s)
- Shuchang Huang
- College of Environment and Ecology, Chongqing University, Chongqing 400044, China
| | - Bing Zhang
- College of Environment and Ecology, Chongqing University, Chongqing 400044, China.
| | - Fuyi Cui
- College of Environment and Ecology, Chongqing University, Chongqing 400044, China
| | - Yuankai He
- College of Environment and Ecology, Chongqing University, Chongqing 400044, China
| | - Jinyu Shi
- College of Environment and Ecology, Chongqing University, Chongqing 400044, China
| | - Xinyu Yang
- College of Environment and Ecology, Chongqing University, Chongqing 400044, China
| | - Piet N L Lens
- UNESCO-IHE, Institute for Water Education, Westvest 7, 2601 DA Delft, the Netherlands
| | - Wenxin Shi
- College of Environment and Ecology, Chongqing University, Chongqing 400044, China.
| |
Collapse
|
2
|
Han NN, Yang JH, Fan NS, Jin RC. Mechanistic insight into microbial interaction and metabolic pattern of anammox consortia on surface-modified biofilm carrier with extracellular polymeric substances. BIORESOURCE TECHNOLOGY 2024; 407:131092. [PMID: 38986879 DOI: 10.1016/j.biortech.2024.131092] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/11/2024] [Revised: 06/25/2024] [Accepted: 07/06/2024] [Indexed: 07/12/2024]
Abstract
The extremely slow growth rate of anaerobic ammonia oxidation (anammox) bacteria limits full-scale application of anammox process worldwide. In this study, extracellular polymeric substances (EPS)-coated polypropylene (PP) carriers were prepared for biofilm formation. The biomass adhesion rate of EPS-PP carrier was 12 times that of PP carrier, and EPS-PP achieved significant enrichment of E. coli BY63. The 120-day continuous flow experiment showed that the EPS-PP carrier accelerated the formation of anammox biofilm, and the nitrogen removal efficiency increased by 10.5 %. In addition, the abundance of Candidatus Kuenenia in EPS-PP biofilm was 27.1%. Simultaneously, amino acids with high synthesis cost and the metabolites of glycerophospholipids related to biofilm formation on EPS-PP biofilm were significantly up-regulated. Therefore, EPS-PP carriers facilitated the rapid formation of anammox biofilm and promoted the metabolic activity of functional bacteria, which further contributed to the environmental and economic sustainability of anammox process.
Collapse
Affiliation(s)
- Na-Na Han
- Laboratory of Water Pollution Remediation, School of Life and Environmental Sciences, Hangzhou Normal University, Hangzhou 311121, China
| | - Jia-Hui Yang
- Laboratory of Water Pollution Remediation, School of Life and Environmental Sciences, Hangzhou Normal University, Hangzhou 311121, China
| | - Nian-Si Fan
- School of Engineering, Hangzhou Normal University, Hangzhou 311121, China.
| | - Ren-Cun Jin
- School of Engineering, Hangzhou Normal University, Hangzhou 311121, China
| |
Collapse
|
3
|
Ren Y, Oleszkiewicz JA, Uyaguari M, Devlin TR. Response and recovery of nitrifying moving bed biofilm reactor systems exposed to 1°C with varying levels of ammonia starvation. WATER RESEARCH 2024; 261:122026. [PMID: 38971078 DOI: 10.1016/j.watres.2024.122026] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/19/2024] [Revised: 06/21/2024] [Accepted: 06/29/2024] [Indexed: 07/08/2024]
Abstract
This study investigated the impact of varying total ammonia nitrogen (TAN) feed levels along with water temperature decreases on the performance of nitrifying moving bed biofilm reactor (MBBR) at 1 °C and its recovery at 3 °C. Five MBBR reactors were operated with different TAN concentrations as water temperature decreased from 20 to 3 °C: reactor R1 at 30 mg N/L, reactor R2 at 20 mg N/L, reactor R3 at 15 mg N/L, reactor R4 at 10 mg N/L and reactor R5 at 0 mg N/L. The corresponding biofilm characteristics were also analyzed to understand further nitrifying MBBR under different TAN feeding scenarios. The findings revealed that the higher TAN levels were before reaching 1 °C, the better nitrification performance and the more biomass grew. However, the highest TAN concentration (30 mg N/L) might negatively affect the nitrification performance, the activity of nitrifiers, and the growth of biofilms at 1 °C because of the toxic effects of un-ionized or free ammonia (FA). It was observed that the activities of ammonia-oxidizing bacteria (AOB) and nitrite-oxidizing bacteria (NOB) were affected by FA concentrations ranging from 0.2 to 0.7 mg N/L at 1 °C, but they could gradually be adapted to such inhibitory environment, with NOB recovering more quickly and robustly than AOB. The study identified 20 mg N/L (67 % of maximum influent TAN at 1 °C in R2 as the optimal TAN feeding concentration, achieving over 90 % TAN removal and a surface area removal rate (SARR) of 0.78 ± 0.02 g N/m2·d at 1 °C. Meanwhile, R2 also exhibited the highest biofilm mass, with total solids at 13.3 mg/carrier and volatile solids at 11.3 mg/carrier. As TAN was removed, nitrite accumulation was observed at 1 °C, and higher influent TAN concentrations prior to 1 °C appeared to delay the accumulation. When water temperature increased from 1 °C to 3 °C, nitrification performance improved significantly in all reactors without nitrite accumulation, and the higher TAN feeding in the previous stage led to faster recovery. Compared with 20 °C, biofilm became thinner and denser at 1 °C and 3 °C. Furthermore, this study revealed significant shifts in microbial community composition and nitrifier abundances in response to changes in water temperature and influent TAN levels. The dominant nitrifiers were identified as Nitrosomonadaceae (AOB) and Nitrospiraceae (NOB). At 1 °C, the nitrifier abundances were significantly correlated with SARRs, FA, and biofilm density. R2, which exhibited the best nitrification performance, maintained higher nitrifier abundances at 1 °C.
Collapse
Affiliation(s)
- Yanan Ren
- Department of Civil Engineering, University of Manitoba, 75 Chancellors Circle, Winnipeg, Manitoba R3T 5V6, Canada.
| | - Jan A Oleszkiewicz
- Department of Civil Engineering, University of Manitoba, 75 Chancellors Circle, Winnipeg, Manitoba R3T 5V6, Canada
| | - Miguel Uyaguari
- Department of Microbiology, University of Manitoba, 45 Chancellors Circle, Winnipeg, Manitoba R3T 2N2, Canada
| | | |
Collapse
|
4
|
Min KJ, Lee E, Lee AH, Kim DY, Park KY. Effect of settling time and organic loading rates on aerobic granulation processes treating high strength wastewater. Heliyon 2024; 10:e36018. [PMID: 39247328 PMCID: PMC11379613 DOI: 10.1016/j.heliyon.2024.e36018] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/31/2024] [Accepted: 08/07/2024] [Indexed: 09/10/2024] Open
Abstract
Despite its numerous advantages, the aerobic granular sludge (AGS) process faces several challenges that hinder its widespread implementation. One such challenge is the requirement for high organic load ratios (OLR), which significantly impacts AGS formation and stability, posing a barrier to commercialization. In response to these challenges, this study investigates the granulation and treatment efficacy of the AGS process for treating high-concentration wastewater under various OLR and settling time. Three sequential batch reactors (R1, R2, R3) were operated at OLRs of 0.167, 0.33, and 1 kg COD/m3·day. The study focuses on analyzing key parameters including sludge characteristics, extracellular polymeric substances (EPS) content, PN/PS ratio, and microbial clusters. Results demonstrate that reducing settling time from 90 to 30 min enhances sludge settleability, resulting in a maximum 50.8 % decrease in SVI30 (from 98.1 to 122.8 mL/g to 51.9-81.3 mL/g), thereby facilitating the selection of beneficial microorganisms during granulation. Particularly, at R2, the PN/PS ratio was 4.3, and EPS content increased by 1.52-fold, leading to a 1.41-fold increase in sludge attachment. This observation suggests a progressive maturation of AGS. Additionally, analysis of microbial diversity and cluster composition highlights the influence of OLR variations on the ratios of Proteobacteria and Bacteroidetes. These findings emphasize the significant impact of SBR operational strategies on AGS process performance and biological stability, offering valuable insights for the efficient operation of future high-concentration wastewater treatment processes.
Collapse
Affiliation(s)
- Kyung Jin Min
- Department of Tech Center for Research Facilities, Konkuk University, 120 Neungdong-ro, Gwangjin-gu, Seoul, 05029, South Korea
| | - Eunyoung Lee
- Department of Civil and Environmental Engineering, Konkuk University, 120 Neungdong-ro, Gwangjin-gu, Seoul, 05029, South Korea
| | - Ah Hyun Lee
- Department of Civil and Environmental Engineering, Konkuk University, 120 Neungdong-ro, Gwangjin-gu, Seoul, 05029, South Korea
| | - Do Yeon Kim
- Department of Civil and Environmental Engineering, Konkuk University, 120 Neungdong-ro, Gwangjin-gu, Seoul, 05029, South Korea
| | - Ki Young Park
- Department of Civil and Environmental Engineering, Konkuk University, 120 Neungdong-ro, Gwangjin-gu, Seoul, 05029, South Korea
| |
Collapse
|
5
|
Zhao ZC, Li RL, Fan SQ, Lu Y, Liu BF, Xing DF, Ren NQ, Xie GJ. Deciphering the formation of granules by n-DAMO and Anammox microorganisms. ENVIRONMENTAL RESEARCH 2024; 255:119209. [PMID: 38782336 DOI: 10.1016/j.envres.2024.119209] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/25/2024] [Revised: 05/18/2024] [Accepted: 05/20/2024] [Indexed: 05/25/2024]
Abstract
Nitrate/nitrite-dependent anaerobic methane oxidation (n-DAMO) process is a promising wastewater treatment technology, but the slow microbial growth rate greatly hinders its practical application. Although high-level nitrogen removal and excellent biomass accumulation have been achieved in n-DAMO granule process, the formation mechanism of n-DAMO granules remains unresolved. To elucidate the role of functional microbes in granulation, this study attempted to cultivate granules dominated by n-DAMO microorganisms and granules coupling n-DAMO with anaerobic ammonium oxidation (Anammox). After long-term operation, dense granules were developed in the two systems where both n-DAMO archaea and n-DAMO bacteria were enriched, whereas granulation did not occur in the other system dominated by n-DAMO bacteria. Extracellular polymeric substances (EPS) measurement indicated the critical role of EPS production in the granulation of n-DAMO process. Metagenomic and metatranscriptomic analyses revealed that n-DAMO archaea and Anammox bacteria were active in EPS biosynthesis, while n-DAMO bacteria were inactive. Consequently, more EPS were produced in the systems containing n-DAMO archaea and Anammox bacteria, leading to the successful development of n-DAMO granules. Furthermore, EPS biosynthesis in n-DAMO systems is potentially regulated by acyl-homoserine lactones and c-di-GMP. These findings not only provide new insights into the mechanism of granule formation in n-DAMO systems, but also hint at potential strategies for management of the granule-based n-DAMO process.
Collapse
Affiliation(s)
- Zhi-Cheng Zhao
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, 150090, China
| | - Ruo-Lin Li
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, 150090, China
| | - Sheng-Qiang Fan
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, 150090, China.
| | - Yang Lu
- The Australian Centre for Ecogenomics, School of Chemistry and Molecular Biosciences, The University of Queensland, St Lucia, Queensland, 4072, Australia
| | - Bing-Feng Liu
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, 150090, China
| | - De-Feng Xing
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, 150090, China
| | - Nan-Qi Ren
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, 150090, China
| | - Guo-Jun Xie
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, 150090, China.
| |
Collapse
|
6
|
Pereira Almeida FD, Bandeira de Carvalho C, Mendes Barros AR, Amancio Frutuoso FK, Bezerra Dos Santos A. Aerobic granulation and resource production under continuous and intermittent saline stress. CHEMOSPHERE 2024; 360:142402. [PMID: 38777193 DOI: 10.1016/j.chemosphere.2024.142402] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/11/2024] [Revised: 05/09/2024] [Accepted: 05/20/2024] [Indexed: 05/25/2024]
Abstract
Three sequential batch reactors (SBR) were operated to evaluate salt addition's impact on granulation, performance, and biopolymer production in aerobic granular sludge (AGS) systems. System R1 was fed without adding salt (control); system R2 operated with saline pulses, i.e., one cycle with salt (2.5 g NaCl/L) addition followed by another without salt; and R3 received continuous supplementation of 2.5 g NaCl/L. The results indicated that the reactors supplemented with salt presented higher concentrations of mixed liquor volatile suspended solids (MLVSS) and better settleability than R1, showing that osmotic pressure contributed to biomass growth, accelerated granulation, and improved physical characteristics. The faster granulation occurred in R2, thus proving the beneficial effects of intermittent salt addition through alternating pulses. Salt addition did not impair the simultaneous removal of carbon, nitrogen, and phosphorus. In fact, R2 showed better carbon removals. In conclusion, continuous or intermittent (pulsed) supplementation of 2.5 g NaCl/L did not lead to increased production of extracellular polymeric substances (EPS) and alginate-like exopolymers (ALE). This outcome could be attributed to the low saline concentration employed, a higher food-to-microorganism (F/M) ratio observed in R1, and possibly greater endogenous consumption of biopolymers in the famine period in R2 and R3 due to the greater solids retention time (SRT). Therefore, this study brings important results that contribute to a better understanding of the effect of salt in continuous dosing or in pulses as a selection pressure strategy to accelerate granulation, as well as the behavior of the AGS systems for saline effluents.
Collapse
Affiliation(s)
| | - Clara Bandeira de Carvalho
- Department of Hydraulic and Environmental Engineering, Federal University of Ceará, Fortaleza, Ceará, Brazil
| | | | | | - André Bezerra Dos Santos
- Department of Hydraulic and Environmental Engineering, Federal University of Ceará, Fortaleza, Ceará, Brazil.
| |
Collapse
|
7
|
Wang J, Li Z, Xiong P, Li Z, Liu H, Zhang Y, Lei Z, Liu X, Lee DJ, Qian X. Reduction of greenhouse gas emissions from closed activated sludge- to aerobic granular sludge-based biosystems via gas circulation. BIORESOURCE TECHNOLOGY 2024; 401:130748. [PMID: 38677387 DOI: 10.1016/j.biortech.2024.130748] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/24/2023] [Revised: 04/08/2024] [Accepted: 04/25/2024] [Indexed: 04/29/2024]
Abstract
Greenhouse gas (GHG) emissions from biological treatment units are challenging wastewater treatment plants (WWTPs) due to their wide applications and global warming. This study aimed to reduce GHG emissions (especially N2O) using a gas circulation strategy in a closed sequencing-batch reactor when the biological unit varies from activated sludge (AS) to aerobic granular sludge (AGS). Results show that gas circulation lowers pH to 6.3 ± 0.2, facilitating regular granules but elevating total N2O production. From AS to AGS, N2O emission factor increased (0.07-0.86 %) due to decreasing ammonia-oxidizing rates while the emissions of CO2 (0.3 ± 0.1 kg-CO2/kg-chemical oxygen demand) and CH4 remained in the closed biosystem. The gas circulation decreased N2O emission factor by 63 ± 15 % after granulation higher than 44 ± 34 % before granulation, which is implemented by heterotrophic denitrification. This study provides a feasible strategy to enhance heterotrophic N2O elimination in the biological WWTPs.
Collapse
Affiliation(s)
- Jixiang Wang
- Shanghai Academy of Environmental Sciences, Shanghai 200233, China; Department of Environmental Science and Engineering, Fudan University, Shanghai 200438, China
| | - Zejiao Li
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Pengyu Xiong
- Shanghai Academy of Environmental Sciences, Shanghai 200233, China; Department of Environmental Science and Engineering, Fudan University, Shanghai 200438, China
| | - Zhengwen Li
- Shanghai Academy of Environmental Sciences, Shanghai 200233, China; Department of Environmental Science and Engineering, Fudan University, Shanghai 200438, China
| | - Hui Liu
- Shanghai Academy of Environmental Sciences, Shanghai 200233, China
| | - Yili Zhang
- Shanghai Academy of Environmental Sciences, Shanghai 200233, China
| | - Zhongfang Lei
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Xiang Liu
- Department of Environmental Science and Engineering, Fudan University, Shanghai 200438, China
| | - Duu-Jong Lee
- Department of Mechanical Engineering, City University of Hong Kong, Kowloon Tang, Hong Kong; Department of Chemical Engineering & Materials Science, Yuan-Ze University, Chungli 320, Taiwan
| | - Xiaoyong Qian
- Shanghai Academy of Environmental Sciences, Shanghai 200233, China.
| |
Collapse
|
8
|
Gan Y, Gong B, Huang X, Fang F, Peng T, Liu Z. Response of aerobic granular sludge under acute inhibition by polystyrene microplastics: Activity, aggregation performance, and microbial analysis. ENVIRONMENTAL POLLUTION (BARKING, ESSEX : 1987) 2024; 349:123923. [PMID: 38580060 DOI: 10.1016/j.envpol.2024.123923] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/16/2024] [Revised: 03/25/2024] [Accepted: 04/02/2024] [Indexed: 04/07/2024]
Abstract
In this study, the activity, aggregation performance, microbial community and functional proteins of aerobic granular sludge (AGS) in response to acute inhibition by different concentrations of polystyrene microplastics (PS-MPs) were investigated. As the PS-MPs concentration increased from 0 mg/L to 200 mg/L, the specific nitrogen removal rate and the activity of enzymes were inhibited. The inhibition of specific nitrite reduction rate (SNIRR) and specific nitrate reduction rate (SNRR) was most obvious at the PS-MPs concentration of 100 mg/L, and that of nitrite reductase (NIR) and nitrate reductase (NR) was most obvious at the concentration of 50 mg/L. But the inhibitory effects were mitigated at the concentration of 200 mg/L. The increase of reactive oxygen species (ROS) and lactate dehydrogenase (LDH) indicated that the cells were damaged with the increase of PS-MPs concentration. The content of proteins and polysaccharides in extracellular polymeric substances (EPS) decreased, especially the polysaccharides were more affected. Analysis of zeta potential, hydrophobicity and surface thermodynamics of AGS revealed that addition of PS-MPs was unfavorable for AGS aggregation. It was also found that bacteria genera associated with EPS secretion and nitrogen removal functions were inhibited, while functions associated with cell metabolism, protein synthesis and cell repair were enhanced. This also confirmed that acute inhibition of PS-MPs had a detrimental effect on the nitrogen removal and aggregation performance of AGS. This study can provide theoretical support for the operation of AGS reactors under microplastics impact load.
Collapse
Affiliation(s)
- Yushuang Gan
- College of Environment and Ecology, Chongqing University, Chongqing, 400045, China
| | - Bingrou Gong
- College of Environment and Ecology, Chongqing University, Chongqing, 400045, China
| | - Xiaohua Huang
- College of Environment and Ecology, Chongqing University, Chongqing, 400045, China
| | - Fang Fang
- College of Environment and Ecology, Chongqing University, Chongqing, 400045, China; Key Laboratory of the Three Gorges Reservoir Region's Eco-Environment, Chongqing University, Chongqing, 400045, China
| | - Ting Peng
- College of Environment and Ecology, Chongqing University, Chongqing, 400045, China
| | - Zhiping Liu
- College of Environment and Ecology, Chongqing University, Chongqing, 400045, China; Key Laboratory of the Three Gorges Reservoir Region's Eco-Environment, Chongqing University, Chongqing, 400045, China.
| |
Collapse
|
9
|
Zhao Z, Liu Y, Dong X, Jiang Q, Wang J, Yang X, Chen J, Lei Z. Unveiling the role of ferrous ion in driving microalgae granulation from salt-tolerant strains for mariculture wastewater treatment. THE SCIENCE OF THE TOTAL ENVIRONMENT 2024; 923:171315. [PMID: 38431177 DOI: 10.1016/j.scitotenv.2024.171315] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/27/2023] [Revised: 02/18/2024] [Accepted: 02/25/2024] [Indexed: 03/05/2024]
Abstract
Development of microalgal-bacterial granular sludge (MBGS) from saline-adapted microalgae is a promising approach for efficient mariculture wastewater treatment, whereas the elusive mechanisms governing granulation have impeded its widespread adoption. In this study, spherical and regular MBGS were successfully developed from mixed culture of pure Spirulina platensis and Chlorella sp. GY-H4 at 10 mg/L Fe2+ concentration. The addition of Fe2+ was proven to induce the formation of Fe-precipitates which served as nucleation sites for microbial attachment and granulation initiation. Additionally, Fe2+ increased the prevalence of exopolysaccharide-producing cyanobacteria, i.e. Synechocystis and Leptolyngbya, facilitating microbial cell adhesion. Furthermore, it stimulated the secretion of extracellular proteins (particularly tryptophan and aromatic proteins), which acted as structural backbone for the development of spherical granule form microalgal flocs. Lastly, it fostered the accumulation of exogenous heterotrophic functional genera, resulting in the efficient removal of DOC (98 %), PO43--P (98 %) and NH4+-N (87 %). Nevertheless, inadequate Fe2+ hindered microalgal floc transformation into granules, excessive Fe2+ expanded the anaerobic zone within the granules, almost halved protein content in the TB-EPS, and inhibited the functional genes expression, ultimately leading to an irregular granular morphology and diminished nutrient removal. This research provides valuable insights into the mechanisms by which Fe2+ promotes the granulation of salt-tolerant microalgae, offering guidance for the establishment and stable operation of MBGS systems in mariculture wastewater treatment.
Collapse
Affiliation(s)
- Ziwen Zhao
- South China Institute of Environmental Sciences, Ministry of Ecology and Environment, Guangzhou 510345, China
| | - Yuqi Liu
- South China Institute of Environmental Sciences, Ministry of Ecology and Environment, Guangzhou 510345, China
| | - Xiaochuan Dong
- Graduate School of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Qianrong Jiang
- South China Institute of Environmental Sciences, Ministry of Ecology and Environment, Guangzhou 510345, China
| | - Jixiang Wang
- Shanghai Academy of Environmental Sciences, Shanghai 200233, China.
| | - Xiaojing Yang
- School of Environmental Science and Engineering, Sun Yat-sen University, Guangzhou 510006, China.
| | - Jianyu Chen
- South China Institute of Environmental Sciences, Ministry of Ecology and Environment, Guangzhou 510345, China
| | - Zhongfang Lei
- Graduate School of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| |
Collapse
|
10
|
Ren Z, Fu R, Sun L, Li H, Bai Z, Tian Y, Zhang G. Unraveling biological behavior and influence of magnetic iron-based nanoparticles in algal-bacterial systems: A comprehensive review. THE SCIENCE OF THE TOTAL ENVIRONMENT 2024; 915:169852. [PMID: 38190907 DOI: 10.1016/j.scitotenv.2023.169852] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/24/2023] [Revised: 12/19/2023] [Accepted: 12/30/2023] [Indexed: 01/10/2024]
Abstract
Magnetic iron-based nanoparticles have been found to stimulate algae growth and harvest, repair disintegrated particles and improve stability, and facilitate operation in extreme environments, which help improve the wide application of algal-bacterial technology. Nevertheless, up to now, no literature collected to systematically review the research progress of on the employment of magnetic iron-based nanoparticles in the algal-bacterial system. This review summarizes the special effects (e.g., size effect, surface effect and biological effect) and corresponding properties of magnetic iron-based nanoparticles (e.g., magnetism, adsorption, electricity, etc.), which is closely related to biological effects and algal-bacterial behaviors. Additionally, it was found that magnetic iron-based nanoparticles offer remarkable impacts on improving the growth and metabolism of algal-bacterial consortia and the mechanisms mainly include its possible iron uptake pathways in bacteria and/or algae cells, as well as the magnetic biological effect of magnetic iron-based nanoparticles on algae-bacteria growth. Furthermore, in terms of the mechanism for establishing the algae-bacteria symbiotic relationship, the most recent works reveal that the charge effect, material transfer and signal transmission of magnetic iron-based nanoparticles possess a large array of potential mechanisms by which it can affect the establishment of algal-bacterial symbiosis. This discussion is expected to promote the progress of magnetic iron-based nanoparticles, as an eco-friendly, convenient and cost-effective technology that can be applied in algal-bacterial wastewater treatment fields.
Collapse
Affiliation(s)
- Zhijun Ren
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin 300401, China
| | - Ruiyao Fu
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin 300401, China
| | - Li Sun
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin 300401, China.
| | - Huixue Li
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin 300401, China
| | - Zijia Bai
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin 300401, China
| | - Yu Tian
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin 150090, China
| | - Guangming Zhang
- School of Energy and Environmental Engineering, Hebei University of Technology, Tianjin 300401, China; State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin 150090, China.
| |
Collapse
|
11
|
Pan Z, Wei H, Qiu C, Yang Q, Liang Y, Huang Z, Li J. Two-stage sequencing batch reactors with added iron shavings for nutrient removal and aerobic sludge granulation treating real wastewater with low carbon to nitrogen ratios. BIORESOURCE TECHNOLOGY 2024; 396:130380. [PMID: 38281551 DOI: 10.1016/j.biortech.2024.130380] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/15/2023] [Revised: 01/21/2024] [Accepted: 01/23/2024] [Indexed: 01/30/2024]
Abstract
In response to the challenges of limited nutrient removal and the difficulty in forming aerobic granular sludge (AGS) with low carbon to nitrogen (C/N) ratios, a novel two-stage sequencing batch reactors (SBRs) (R1 and R2) system with added iron shavings was proposed and established. The results showed that AGS was developed and nitrogen (82.8 %) and phosphorus (94.7 %) were effectively removed under a C/N ratio at 1.7 ± 0.5. The average size of R1 and R2 increased from 45.3 μm to 138.7 μm and 132.8 μm. Under high biological selective pressure, phosphorus accumulating organisms like Comamonadaceae (14.8 %) and Chitinophagales (5.7 %) experienced enrichment in R1. Furthermore, R2 exhibited an increased abundance of nitrifying bacteria (2.3 %) and a higher proportion of nitrogen removal through autotrophic denitrification (>17.5 %). Overall, this study introduces an innovative two-stage SBRs with added iron shavings, offering a novel approach for the treatment of low C/N ratios wastewater.
Collapse
Affiliation(s)
- Zengrui Pan
- Key Laboratory of Microbial Technology for Industrial Pollution Control of Zhejiang Province, College of Environment, Zhejiang University of Technology, Hangzhou 310014, China
| | - Hongtang Wei
- Zhejiang Shuanglin Environment Co., Ltd., Hangzhou 311100, China
| | - Chong Qiu
- Zhejiang Shuanglin Environment Co., Ltd., Hangzhou 311100, China
| | - Qianjin Yang
- Zhejiang Shuanglin Environment Co., Ltd., Hangzhou 311100, China
| | - Yifan Liang
- Key Laboratory of Microbial Technology for Industrial Pollution Control of Zhejiang Province, College of Environment, Zhejiang University of Technology, Hangzhou 310014, China
| | - Zuchao Huang
- Key Laboratory of Microbial Technology for Industrial Pollution Control of Zhejiang Province, College of Environment, Zhejiang University of Technology, Hangzhou 310014, China
| | - Jun Li
- Key Laboratory of Microbial Technology for Industrial Pollution Control of Zhejiang Province, College of Environment, Zhejiang University of Technology, Hangzhou 310014, China.
| |
Collapse
|
12
|
Bodle KB, Kirkland CM. Pharmaceutical impacts on aerobic granular sludge morphology and potential implications for abiotic removal. CHEMOSPHERE 2024; 350:141187. [PMID: 38211794 PMCID: PMC10843683 DOI: 10.1016/j.chemosphere.2024.141187] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/26/2023] [Revised: 01/08/2024] [Accepted: 01/09/2024] [Indexed: 01/13/2024]
Abstract
The goal of this study was to investigate abiotic pharmaceutical removal and abiotic pharmaceutical effects on aerobic granular sludge morphology. For 80 days, a pharmaceutical mixture containing approximately 150 μg/L each of diclofenac, erythromycin, and gemfibrozil was fed to an aerobic granular sludge sequencing batch reactor and granule characteristics were compared with those from a control reactor. Aqueous and solid phase pharmaceutical concentrations were monitored and staining was used to assess changes in biofilm structures. Solid phase pharmaceutical concentrations were elevated over the first 12 days of dosing; however, they then dropped, indicative of desorption. The lipid content in pharmaceutical-exposed granules declined by approximately half over the dosing period, though the relative concentrations of other key biofilm components (proteins, alpha-, and beta-polysaccharides) did not change. Batch experiments were conducted to try to find an explanation for the desorption observed, but reduced solid phase pharmaceutical concentrations could not be linked with the presence of common wastewater constituents such as ammonia or phosphate. Sorption of all three compounds was modeled best by the Henry isotherm, indicating that, even at 150 μg/L, granules' sorption site coverage was incomplete. Altogether, this study demonstrates that simplified batch systems may not accurately represent the complex abiotic processes occurring in flow-through, biotic systems.
Collapse
Affiliation(s)
- Kylie B Bodle
- Department of Civil Engineering, 205 Cobleigh Hall, Montana State University, Bozeman, MT, USA; Center for Biofilm Engineering, 366 Barnard Hall, Montana State University, Bozeman, MT, USA.
| | - Catherine M Kirkland
- Department of Civil Engineering, 205 Cobleigh Hall, Montana State University, Bozeman, MT, USA; Center for Biofilm Engineering, 366 Barnard Hall, Montana State University, Bozeman, MT, USA
| |
Collapse
|
13
|
Chen B, Shen Y, Zhang X, Ji B. Influence mechanism of sludge bed position on microalgal-bacterial granular sludge process. THE SCIENCE OF THE TOTAL ENVIRONMENT 2024; 907:168118. [PMID: 37884157 DOI: 10.1016/j.scitotenv.2023.168118] [Citation(s) in RCA: 3] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/12/2023] [Revised: 10/16/2023] [Accepted: 10/23/2023] [Indexed: 10/28/2023]
Abstract
Sludge bed position in the reactor is one of the key parameters for microalgal-bacterial granular sludge (MBGS) process, which lacks of study. To fill this gap, this study investigated the influence of sludge bed position on MBGS. The sludge bed located closer to the bottom of the bioreactor demonstrated the optimal pollutant removal performance due to a close synergistic effect between microalgae and bacteria, resulting in the high growth rate as well as agglomeration rate of MBGS. Specifically, organics and ammonia removals were closely related to the sludge bed position. For the bottom bed position, the removals of organic matter, ammonia, and phosphate were 75.1 %, 73.1 %, and 82.5 %, whereas for the top bed position, they were only 13.2 %, 9.6 %, and 68.9 %, respectively. Additionally, a significant correlation between the position of the sludge bed and the relative abundance of Rotifera (R2 = 0.931) and Chlorophyta (R2 = 0.733) was observed, while the microbial communities at the lower sludge bed positions underwent rapider succession. It can be inferred that that a sludge bed located closer to the bottom of the bioreactor ensures that the light source and substrate matrix are transmitted in the same direction, thereby resulting in a close synergistic effect between microalgae and bacteria for achieving the excellent performance of MBGS. These results can provide basis knowledge for engineering application of MBGS process.
Collapse
Affiliation(s)
- Bingheng Chen
- Department of Water and Wastewater Engineering, School of Urban Construction, Wuhan University of Science and Technology, Wuhan 430065, China
| | - Yao Shen
- Department of Water and Wastewater Engineering, School of Urban Construction, Wuhan University of Science and Technology, Wuhan 430065, China
| | - Xiaoyuan Zhang
- Engineering Laboratory of Low-Carbon Unconventional Water Resources Utilization and Water Quality Assurance, College of Environmental Science and Engineering, Nankai University, Tianjin 300350, China
| | - Bin Ji
- Department of Water and Wastewater Engineering, School of Urban Construction, Wuhan University of Science and Technology, Wuhan 430065, China; Hubei Provincial Engineering Research Center of Urban Regeneration, Wuhan University of Science and Technology, Wuhan 430065, China.
| |
Collapse
|
14
|
Guo T, Pan K, Chen Y, Tian Y, Deng J, Li J. When aerobic granular sludge faces emerging contaminants: A review. THE SCIENCE OF THE TOTAL ENVIRONMENT 2024; 907:167792. [PMID: 37838059 DOI: 10.1016/j.scitotenv.2023.167792] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/30/2023] [Revised: 10/04/2023] [Accepted: 10/11/2023] [Indexed: 10/16/2023]
Abstract
The evolution of emerging contaminants (ECs) has caused greater requirements and challenges to the current biological wastewater treatment technology. As one of the most promising biological treatment technologies, the aerobic granular sludge (AGS) process also faces the challenge of ECs. This study summarizes the recent progress and characteristics of several representative ECs (persistent organic pollutants, endocrine disrupting chemicals, antibiotics, and microplastics) in AGS systems that have garnered widespread attention. Additionally, the biodegradation and adsorption mechanisms of ECs were discussed, and the interactions between various ECs and AGS was elucidated. The importance of extracellular polymeric substances for the stabilization of AGS and the removal of ECs is also discussed. Knowledge gaps and future research directions that may enable the practical application of AGS are highlighted. Overall, AGS processes show great application potential and this review provides guidance for the future implementation of AGS technology as well as elucidating the mechanism of its interaction with ECs.
Collapse
Affiliation(s)
- Tao Guo
- Key Laboratory of Microbial Technology for Industrial Pollution Control of Zhejiang Province, College of Environment, Zhejiang University of Technology, Hangzhou, China
| | - Kuan Pan
- Key Laboratory of Microbial Technology for Industrial Pollution Control of Zhejiang Province, College of Environment, Zhejiang University of Technology, Hangzhou, China
| | - Yunxin Chen
- Key Laboratory of Microbial Technology for Industrial Pollution Control of Zhejiang Province, College of Environment, Zhejiang University of Technology, Hangzhou, China
| | - Yajun Tian
- Key Laboratory of Microbial Technology for Industrial Pollution Control of Zhejiang Province, College of Environment, Zhejiang University of Technology, Hangzhou, China
| | - Jing Deng
- Key Laboratory of Microbial Technology for Industrial Pollution Control of Zhejiang Province, College of Environment, Zhejiang University of Technology, Hangzhou, China
| | - Jun Li
- Key Laboratory of Microbial Technology for Industrial Pollution Control of Zhejiang Province, College of Environment, Zhejiang University of Technology, Hangzhou, China.
| |
Collapse
|
15
|
Huang YP, Wang X, Wang RL, He JT, Huang Y, Hang ZY, Chen X, Li ZH. Managing stability of aerobic granules by coordinating diameter and denitrification. THE SCIENCE OF THE TOTAL ENVIRONMENT 2024; 906:167795. [PMID: 37838046 DOI: 10.1016/j.scitotenv.2023.167795] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/08/2023] [Revised: 10/10/2023] [Accepted: 10/11/2023] [Indexed: 10/16/2023]
Abstract
Aerobic Granular Sludge (AGS) technology is a promising solution for wastewater treatment due to its structure and high biomass retention capacity. However, the stability of AGS is still a challenge for widespread use. This study investigated the relationships among granule stability, granule diameter, biomass retention capacity, and denitrification efficiency. The results showed that granule diameter did not necessarily indicate granule stability, nor was it associated with biomass retention capacity. For mature granules, promoting simultaneous nitrification and denitrification rather than anoxic denitrification was found to improve granule stability. The deterioration of clarification capacity caused by increased anoxic denitrification at high nitrate concentration was not indicated by diameters or the commonly used SVI5/SVI30. Therefore, ensuring coordination between diameter and denitrification control is crucial for the stability of AGS. These results provide a basis for further research and development of efficient and user-friendly methods for monitoring granular stability.
Collapse
Affiliation(s)
- Yong-Peng Huang
- Key Laboratory of Northwest Water Resource, Environment, and Ecology, MOE, School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Xi'an 710055, China; Xi'an Key Laboratory of Intelligent Equipment Technology for Environmental Engineering, Xi'an University of Architecture and Technology, Xi'an 710055, China
| | - Xin Wang
- Key Laboratory of Northwest Water Resource, Environment, and Ecology, MOE, School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Xi'an 710055, China; Xi'an Key Laboratory of Intelligent Equipment Technology for Environmental Engineering, Xi'an University of Architecture and Technology, Xi'an 710055, China
| | - Ruo-Lan Wang
- Key Laboratory of Northwest Water Resource, Environment, and Ecology, MOE, School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Xi'an 710055, China; Xi'an Key Laboratory of Intelligent Equipment Technology for Environmental Engineering, Xi'an University of Architecture and Technology, Xi'an 710055, China
| | - Jin-Tao He
- Key Laboratory of Northwest Water Resource, Environment, and Ecology, MOE, School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Xi'an 710055, China; Xi'an Key Laboratory of Intelligent Equipment Technology for Environmental Engineering, Xi'an University of Architecture and Technology, Xi'an 710055, China
| | - Yuan Huang
- Key Laboratory of Northwest Water Resource, Environment, and Ecology, MOE, School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Xi'an 710055, China; Xi'an Key Laboratory of Intelligent Equipment Technology for Environmental Engineering, Xi'an University of Architecture and Technology, Xi'an 710055, China
| | - Zhen-Yu Hang
- Key Laboratory of Northwest Water Resource, Environment, and Ecology, MOE, School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Xi'an 710055, China; Xi'an Key Laboratory of Intelligent Equipment Technology for Environmental Engineering, Xi'an University of Architecture and Technology, Xi'an 710055, China
| | - Xi Chen
- School of Urban Planning and Municipal Engineering, Xi'an Polytechnic University, Xi'an 710048, China
| | - Zhi-Hua Li
- Key Laboratory of Northwest Water Resource, Environment, and Ecology, MOE, School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Xi'an 710055, China; Xi'an Key Laboratory of Intelligent Equipment Technology for Environmental Engineering, Xi'an University of Architecture and Technology, Xi'an 710055, China.
| |
Collapse
|
16
|
Lv PL, Jia C, Guo X, Zhao HP, Chen R. Microbial stratification protects denitrifying anaerobic methane oxidation archaea and bacteria from external oxygen shock in membrane biofilm reactor. BIORESOURCE TECHNOLOGY 2024; 391:129966. [PMID: 37918493 DOI: 10.1016/j.biortech.2023.129966] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/14/2023] [Revised: 10/30/2023] [Accepted: 10/30/2023] [Indexed: 11/04/2023]
Abstract
Different gradients of dissolved oxygen (DO) regulate the microbial community and nitrogen removal pathways of denitrifying anaerobic methane oxidation (DAMO) and anaerobic ammonium oxidation (Anammox) coupled process in a batch biofilm reactor. Under completely anaerobic condition, approximately 72 mg NO3--N/L was removed at a daily rate of 6.55 mg N/L, whereas a peak accumulation of 95 mg NO3--N/L was observed during DO reached 0.5 mg/L. There is a decrease in the abundance of Candidatus Methylomirabilis (24.1%), Candidatus Methanoperedens (23.3%), and Candidatus Kuenenia (22.6%) to below 5% when DO levels reached 0.2 mg/L. Moreover, key genes associated with the reverse methanogenesis (mcrA) and anaerobic ammonium oxidase (hzo) decreased. These findings indicate that during oxygen shock, methanotrophs and denitrifiers replace Anammox bacteria on the outer sphere of the biofilm, whereas DAMO bacteria and archaea are protected from external oxygen shock due to the microbial stratification of biofilm.
Collapse
Affiliation(s)
- Pan-Long Lv
- Key Lab of Environmental Engineering, Shaanxi Province, Xi'an University of Architecture and Technology, No. 13 Yanta Road, Xi'an 710055, PR China
| | - Chuan Jia
- Key Lab of Environmental Engineering, Shaanxi Province, Xi'an University of Architecture and Technology, No. 13 Yanta Road, Xi'an 710055, PR China
| | - Xu Guo
- Department of Environmental Engineering, College of Environmental and Resource Science, Zhejiang University, Hangzhou, PR China
| | - He-Ping Zhao
- Department of Environmental Engineering, College of Environmental and Resource Science, Zhejiang University, Hangzhou, PR China
| | - Rong Chen
- Key Lab of Environmental Engineering, Shaanxi Province, Xi'an University of Architecture and Technology, No. 13 Yanta Road, Xi'an 710055, PR China; International S&T Cooperation Center for Urban Alternative Water Resources Development, Key Laboratory of Northwest Water Resource, Environment and Ecology, MOE, Xi'an University of Architecture and Technology, No. 13 Yanta Road, Xi'an 710055, PR China.
| |
Collapse
|
17
|
Zhang X, Zhao B, An Q, Zhang P. The influence of different nitrate concentrations on aerobic sludge granulation and the role of extracellular polymeric substances. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2023; 348:119226. [PMID: 37820429 DOI: 10.1016/j.jenvman.2023.119226] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/18/2023] [Revised: 09/13/2023] [Accepted: 10/02/2023] [Indexed: 10/13/2023]
Abstract
This study investigated the influence of nitrate on aerobic granular sludge (AGS) granulation. The introduction of nitrate at 5, 15 and 20 mg L-1 promoted AGS granulation, and the promoting effect was positively correlated with nitrate concentrations. Meanwhile, exogenous nitrate significantly increased denitrification rate in the AGS system. However, granular disintegration appeared at a long-term addition of nitrate. An in-deep analysis showed that nitrate stimulated the secretion of extracellular polymeric substances (EPS), especially the content of proteins, which might be the main reason for the AGS granulation. However, the rapid and excessive increase in EPS might cause granular disintegration, as excessive EPS blocked the transmission of substrates, leading to the increase of dead cells in the granules. Besides, nitrate also altered the hydrophobicity of EPS and the content of α-helix, 3-turned helix and polymeric chain that favored aggregation, which also affected AGS granulation. From the microbial community level, nitrate induced the enrichment of denitrifying bacteria, including those that also functioned as EPS producers, such as Micropruina and Flavobacterium, resulting in the rapid increase of functional enzymes associated with amino acid synthesis, thereby promoting the secretion of proteins in EPS. Conversely, disintegration caused by mass transfer blockage might lead to the loss of EPS producing bacteria and subsequent decrease in EPS content, further accelerating granular disintegration.
Collapse
Affiliation(s)
- Xinyi Zhang
- Key Laboratory of the Three Gorges Reservoir Region's Eco-Environment, Ministry of Education, Chongqing University, Chongqing, 400045, PR China; College of Environment and Ecology, Chongqing University, Chongqing, 400045, PR China
| | - Bin Zhao
- Key Laboratory of the Three Gorges Reservoir Region's Eco-Environment, Ministry of Education, Chongqing University, Chongqing, 400045, PR China; College of Environment and Ecology, Chongqing University, Chongqing, 400045, PR China.
| | - Qiang An
- Key Laboratory of the Three Gorges Reservoir Region's Eco-Environment, Ministry of Education, Chongqing University, Chongqing, 400045, PR China; College of Environment and Ecology, Chongqing University, Chongqing, 400045, PR China
| | - Peng Zhang
- Key Laboratory of the Three Gorges Reservoir Region's Eco-Environment, Ministry of Education, Chongqing University, Chongqing, 400045, PR China; College of Environment and Ecology, Chongqing University, Chongqing, 400045, PR China
| |
Collapse
|
18
|
Miyake M, Hasebe Y, Furusawa K, Shiomi H, Inoue D, Ike M. Enhancement of nutrient removal in an activated sludge process using aerobic granular sludge augmentation strategy with ammonium-based aeration control. CHEMOSPHERE 2023; 340:139826. [PMID: 37586487 DOI: 10.1016/j.chemosphere.2023.139826] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/17/2023] [Revised: 07/18/2023] [Accepted: 08/12/2023] [Indexed: 08/18/2023]
Abstract
To enhance nutrient removal from low-strength municipal wastewater in a continuous-flow activated sludge (CFAS) process using aerobic granular sludge (AGS) augmentation strategy, a pilot-scale demonstration was configured with a mainstream reactor (anaerobic/aerobic process) and a sidestream sequencing batch reactor for AGS production. The aeration of the mainstream reactor was controlled based on dissolved oxygen (DO) and ammonium concentrations during Phases I and II-III, respectively. During Phase III, an anoxic zone was created in the mainstream aerobic tank. Throughout the demonstration period, excellent sludge settleability in the mainstream reactor (SVI30 ≤ 80 mL g-1) under long sludge retention time conditions (≥12 d) allowed the maintenance of a high mixed liquor suspended solids concentration (≥3000 mg L-1). The total nitrogen (TN) removal ratio improved significantly during Phases II and III (49.3 ± 4.1% and 50.1 ± 10.2%, respectively) compared to Phase I (43.2 ± 5.5%). Low DO concentration (< 0.5 mg L-1) by the ammonium-based aeration tended to increase the simultaneous nitrification and denitrification efficiency (> 40%), enhancing TN removal (> 50%). The reduction of DO and nitrate concentrations in the returning sludge liquor can stabilize phosphorus removal (approximately 80% of the 25th percentile). In addition, the aeration efficiency during Phase III decreased by 26-29% compared to Phase I. These results suggest that the introduction of ammonium-based aeration control to the CFAS using the AGS augmentation strategy could contribute to superior sewerage treatment, including nutrient removal and a low carbon footprint.
Collapse
Affiliation(s)
- Masaki Miyake
- R&D Center, Organo Corporation, 4-4-1 Nishionuma, Minami-ku, Sagamihara, Kanagawa 252-0332, Japan; Division of Sustainable Energy and Environmental Engineering, Osaka University, 2-1 Yamadaoka, Suita, Osaka 565-0871, Japan.
| | - Yoshiaki Hasebe
- R&D Center, Organo Corporation, 4-4-1 Nishionuma, Minami-ku, Sagamihara, Kanagawa 252-0332, Japan
| | - Kazuki Furusawa
- Bureau of Sewerage, Tokyo Metropolitan Government, 2-8-1 Nishishinjuku, Shinjuku-ku, Tokyo 163-8001, Japan
| | - Hiroshi Shiomi
- Bureau of Sewerage, Tokyo Metropolitan Government, 2-8-1 Nishishinjuku, Shinjuku-ku, Tokyo 163-8001, Japan
| | - Daisuke Inoue
- Division of Sustainable Energy and Environmental Engineering, Osaka University, 2-1 Yamadaoka, Suita, Osaka 565-0871, Japan
| | - Michihiko Ike
- Division of Sustainable Energy and Environmental Engineering, Osaka University, 2-1 Yamadaoka, Suita, Osaka 565-0871, Japan
| |
Collapse
|
19
|
Li Z, Wang J, Liu W, Zhao Y, Lei Z, Yuan T, Shimizu K, Zhang Z, Lee DJ. Photosynthetic oxygen-supported algal-bacterial aerobic granular sludge can facilitate carbon, nitrogen and phosphorus removal from wastewater: Focus on light intensity selection. BIORESOURCE TECHNOLOGY 2023; 388:129752. [PMID: 37714495 DOI: 10.1016/j.biortech.2023.129752] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/16/2023] [Revised: 09/02/2023] [Accepted: 09/07/2023] [Indexed: 09/17/2023]
Abstract
Photosynthetic O2 is a promising alternative for mechanical aeration, the major energy-intensive unit in wastewater treatment plants. This study aimed to investigate the effects of light intensity varied from 190 to 1400 µmol·s-1·m-2 on photosynthetic O2-supported algal-bacterial aerobic granular sludge (AGS) system. Results indicate photosynthetic O2 can implement aerobic phosphorus (P) uptake and ammonia oxidation under the test illumination range even at dissolved oxygen concentration < 0.5 mg/L. An obvious O2 accumulation occurred after 60-90% nutrients being removed under 330-1400 µmol·s-1·m-2, and highly efficient ammonia removal, P uptake, and dissolved inorganic carbon removal were achieved under 670-1400 µmol·s-1·m-2. On the other hand, photosynthesis as O2 supplier showed little effect on major ions except for K+. This study provides a better understanding of the roles of light intensity on photosynthetic O2-supported algal-bacterial AGS system, targeting a sustainable wastewater industry.
Collapse
Affiliation(s)
- Zejiao Li
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Jixiang Wang
- Shanghai Academy of Environmental Sciences, Shanghai 200233, China
| | - Wenjun Liu
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Yankai Zhao
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Zhongfang Lei
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan.
| | - Tian Yuan
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Kazuya Shimizu
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Zhenya Zhang
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Duu-Jong Lee
- Department of Mechanical Engineering, City University of Hong Kong, Kowloon Tang, Hong Kong, China; Department of Chemical Engineering and Materials Science, Yuan Ze University, Chung-li, Taiwan 32003
| |
Collapse
|
20
|
Liu J, Han X, Zhu X, Li J, Zhong D, Wei L, Liang H. A systemic evaluation of aerobic granular sludge among granulation, operation, storage, and reactivation processes in an SBR. ENVIRONMENTAL RESEARCH 2023; 235:116594. [PMID: 37467940 DOI: 10.1016/j.envres.2023.116594] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/01/2023] [Revised: 06/27/2023] [Accepted: 07/06/2023] [Indexed: 07/21/2023]
Abstract
As a biological promising wastewater treatment technology, aerobic granular sludge (AGS) technology had been widely studied in sequencing batch reactors (SBRs) for the decades. Presently, the whole processes of its granulation, long-term operation, storage, and reactivation have not been thoroughly evaluated, and also the relationships among microbial diversity, granular size, and characteristics were still not that clear. Hence, they were systematically evaluated in an AGS-SBR in this work. The results demonstrated that Proteobacteria and Bacteroidetes were the dominant phyla, Flavobacterium, Acinetobacter, Azoarcus, and Chryseobacterium were the core genera with discrepant abundances in diverse stages or granular size. Microbial immigration was significant in various stages due to microbial diversity had a line relationship with COD/MLVSS ratio (R2 = 0.367). However, microbial diversity had no line relationship with granular size (R2 = 0.001), indicating the microbial diversity in different-sized AGS was similar, although granular size had a line relationship with settleability (R2 = 0.978). Overall, compared to sludge traits (e.g., sludge size, settleability), COD/MLVSS played a key role on microbial evolution. This study revealed the relationships between granule characteristics and microbial community, and contributed to the future AGS-related studies.
Collapse
Affiliation(s)
- Jun Liu
- School of Modern Agriculture, Jiaxing Vocational & Technical College, Jiaxing, 314036, PR China; Department of Civil Engineering, Tongji Zhejiang College, Jiaxing, 314051, PR China
| | - Xushen Han
- State Environmental Protection Key Laboratory of Environmental Risk Assessment and Control on Chemical Process, East China University of Science and Technology, Shanghai, 200237, PR China
| | - Xuewu Zhu
- School of Municipal and Environmental Engineering, Shandong Jianzhu University, Jinan, 250101, PR China
| | - Jun Li
- College of Environment, Zhejiang University of Technology, Hangzhou, 310014, PR China
| | - Dan Zhong
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, 150090, PR China
| | - Liangliang Wei
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, 150090, PR China
| | - Heng Liang
- State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin, 150090, PR China.
| |
Collapse
|
21
|
Nuid M, Aris A, Krishnen R, Chelliapan S, Muda K. Pineapple wastewater as co-substrate in treating real alkaline, non-biodegradable textile wastewater using biogranulation technology. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2023; 344:118501. [PMID: 37418913 DOI: 10.1016/j.jenvman.2023.118501] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/03/2023] [Revised: 05/25/2023] [Accepted: 06/22/2023] [Indexed: 07/09/2023]
Abstract
This study was to develop biogranules using a sequencing batch reactor (SBR) and to evaluate the effect of pineapple wastewater (PW) as a co-substrate for treating real textile wastewater (RTW). The biogranular system cycle was 24 h (2 stages of phase), with an anaerobic phase (17.8 h) followed by an aerobic phase (5.8 h) for every stage of the phase. The concentration of pineapple wastewater was the main factor studied in influencing COD and color removal efficiency. Pineapple wastewater with different concentrations (7, 5, 4, 3, and 0% v/v) makes a total volume of 3 L and causes the OLRs to vary from 2.90 to 0.23 kg COD/m3day. The system achieved 55% of average color removal and 88% of average COD removal at 7%v/v PW concentration during treatment. With the addition of PW, the removal increased significantly. The experiment on the treatment of RTW without any added nutrients proved the importance of co-substrate in dye degradation.
Collapse
Affiliation(s)
- Maria Nuid
- Centre for Environmental Sustainability and Water Security, Research Institute for Sustainable Environment, Universiti Teknologi Malaysia, 81310 UTM Skudai, Johor Bahru, Malaysia
| | - Azmi Aris
- Centre for Environmental Sustainability and Water Security, Research Institute for Sustainable Environment, Universiti Teknologi Malaysia, 81310 UTM Skudai, Johor Bahru, Malaysia; Department of Water and Environmental Engineering, Faculty of Civil Engineering, Universiti Teknologi Malaysia, 81310 UTM Skudai, Johor Bahru, Malaysia.
| | - Ranjeni Krishnen
- Bactiguard South East Asia SDN. BHD., 308b, Jalan Perindustrian Bukit Minyak 18, Penang Science Park, 14100 Penang, Malaysia
| | - Shreeshivadasan Chelliapan
- Centre for Environmental Sustainability and Water Security, Research Institute for Sustainable Environment, Universiti Teknologi Malaysia, 81310 UTM Skudai, Johor Bahru, Malaysia; Department of Engineering and Technology, Razak Faculty of Technology and Informatics, Universiti Teknologi Malaysia, Jalan Sultan Yahya Petra, Kuala Lumpur 54100, Malaysia
| | - Khalida Muda
- Department of Water and Environmental Engineering, Faculty of Civil Engineering, Universiti Teknologi Malaysia, 81310 UTM Skudai, Johor Bahru, Malaysia
| |
Collapse
|
22
|
Zhang B, Shen J, Mao X, Zhang B, Shen Y, Shi W. A novel membrane bioreactor inoculated with algal-bacterial granular sludge for sewage reuse and membrane fouling mitigation: Performance and mechanism. ENVIRONMENTAL POLLUTION (BARKING, ESSEX : 1987) 2023; 334:122194. [PMID: 37453682 DOI: 10.1016/j.envpol.2023.122194] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/24/2023] [Revised: 07/04/2023] [Accepted: 07/12/2023] [Indexed: 07/18/2023]
Abstract
In this study, a novel membrane bioreactor (MBR) inoculated with algal-bacterial granular sludge (ABGMBR) was established to improve pollutant removal and alleviate membrane fouling. The ABGMBR system showed higher pollutant removal rate and longer operation time (152 day) compared to the control MBR (AGMBR). Moreover, the contents of the pollutants such as granular sludges, extracellular polymeric substances (EPS), and soluble microbial products on the membrane were remarkably reduced, leading to the formation of a porous and loose cake layer on the membrane and a slow increase in transmembrane pressure. Standard blocking was the main mechanism of membrane fouling; however, the membrane pore blockage was significantly reduced in ABGMBR. The extended Derjaguin-Landau-Verwey-Overbeek (XDLVO) theory suggested that the aggregation and adhesion of foulants on the membrane were greatly inhibited in ABGMBR. Furthermore, correlation analysis showed significant differences in membrane fouling characteristics between AGMBR and ABGMBR. The ABGMBR system effectively retarded sludge disintegration and increased the repulsion between the sludge and membrane owing to the favorable mixed liquor characteristics. This study showcases the superior operational efficiency and anti-fouling performance of ABGMBR, offering a novel perspective on sewage reuse and membrane fouling mitigation.
Collapse
Affiliation(s)
- Bing Zhang
- National Research Base of Intelligent Manufacturing Service, Chongqing Technology and Business University, Chongqing, 400067, China; Chongqing Yujiang Intelligent Technology Co., Ltd., Chongqing, 409003, China; Chongqing South-to-Thais Environmental Protection Technology Research Institute Co., Ltd., Chongqing, 400060, China.
| | - Jing Shen
- National Research Base of Intelligent Manufacturing Service, Chongqing Technology and Business University, Chongqing, 400067, China
| | - Xin Mao
- National Research Base of Intelligent Manufacturing Service, Chongqing Technology and Business University, Chongqing, 400067, China
| | - Bing Zhang
- School of Environmental and Ecology, Chongqing University, Chongqing, 400044, China.
| | - Yu Shen
- National Research Base of Intelligent Manufacturing Service, Chongqing Technology and Business University, Chongqing, 400067, China; Chongqing Yujiang Intelligent Technology Co., Ltd., Chongqing, 409003, China; Chongqing South-to-Thais Environmental Protection Technology Research Institute Co., Ltd., Chongqing, 400060, China
| | - Wenxin Shi
- School of Environmental and Ecology, Chongqing University, Chongqing, 400044, China
| |
Collapse
|
23
|
Bodle KB, Mueller RC, Pernat MR, Kirkland CM. Treatment performance and microbial community structure in an aerobic granular sludge sequencing batch reactor amended with diclofenac, erythromycin, and gemfibrozil. FRONTIERS IN MICROBIOMES 2023; 2:1242895. [PMID: 38076031 PMCID: PMC10705044 DOI: 10.3389/frmbi.2023.1242895] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Indexed: 01/31/2024]
Abstract
This study characterizes the effects of three commonly detected pharmaceuticals-diclofenac, erythromycin, and gemfibrozil-on aerobic granular sludge. Approximately 150 μg/L of each pharmaceutical was fed in the influent to a sequencing batch reactor for 80 days, and the performance of the test reactor was compared with that of a control reactor. Wastewater treatment efficacy in the test reactor dropped by approximately 30-40%, and ammonia oxidation was particularly inhibited. The relative abundance of active Rhodocyclaceae, Nitrosomonadaceae, and Nitrospiraceae families declined throughout exposure, likely explaining reductions in wastewater treatment performance. Pharmaceuticals were temporarily removed in the first 12 days of the test via both sorption and degradation; both removal processes declined sharply thereafter. This study demonstrates that aerobic granular sludge may successfully remove pharmaceuticals in the short term, but long-term tests are necessary to confirm if pharmaceutical removal is sustainable.
Collapse
Affiliation(s)
- Kylie B. Bodle
- Department of Civil Engineering, Montana State University, Bozeman, MT, United States
- Center for Biofilm Engineering, Montana State University, Bozeman, MT, United States
| | - Rebecca C. Mueller
- Center for Biofilm Engineering, Montana State University, Bozeman, MT, United States
- United States Department of Agriculture (USDA) Agricultural Research Service, Western Regional Research Center, Albany, CA, United States
| | - Madeline R. Pernat
- Department of Civil Engineering, Montana State University, Bozeman, MT, United States
- Center for Biofilm Engineering, Montana State University, Bozeman, MT, United States
| | - Catherine M. Kirkland
- Department of Civil Engineering, Montana State University, Bozeman, MT, United States
- Center for Biofilm Engineering, Montana State University, Bozeman, MT, United States
| |
Collapse
|
24
|
Lin Y, Wang Y, Wang W, Hao T, Su K. Mechanistic study on the ferric chloride-based rapid cultivation and enhancement of aerobic granular sludge. ENVIRONMENTAL TECHNOLOGY 2023; 44:3281-3293. [PMID: 35318893 DOI: 10.1080/09593330.2022.2057235] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/17/2021] [Accepted: 03/10/2022] [Indexed: 06/14/2023]
Abstract
Aerobic granular sludge (AGS) can achieve simultaneous carbon, nitrogen and phosphorus removal owing to its three-dimensional oxygen gradient structure. However, long start-up period and poor operational stability restrict its application and promotion. A novel rapid granulation strategy, viz., the short-term (7 days) addition of ferric chloride at the commissioning stage, was developed and verified in this study. The granulation period was shortened by 9 days, and the formed granules were compact and dense with an Fe3+ concentration of 250 mg L-1. The addition of flocculant not only maintained a high sludge concentration during the initial stages of granulation (5.3 g L-1), but also stimulated the secretion of TB-EPS and increased protein and polysaccharide contents, thereby expediting granule formation. Additionally, ferric chloride induced a diverse microbial community in granules, resulting in the emergence of new genera, such as Thaurea, Brevundimonas and Kinneretia, which improved pollutant removal performance and flocculent aggregation. The removal efficiencies of COD, PO43--P, and NH4+-N stabilized at 94.2, 62.4, and 71.3%, respectively. Therefore, it has been demonstrated that short-term ferric chloride dosing has a synergistic effect on aerobic granulation.
Collapse
Affiliation(s)
- Yuxin Lin
- Department of Civil Engineering, Hefei University of Technology, Hefei, People's Republic of China
- Harbour and Waterway Development Center of Department of Transport of Jiangsu Province, Nanjing, People's Republic of China
| | - Yuyin Wang
- Department of Resources and Environmental Engineering, Hefei University of Technology, Hefei, People's Republic of China
- Civil Engineering, College of Science and Engineering, National University of Ireland, Galway, Ireland
| | - Wei Wang
- Department of Civil Engineering, Hefei University of Technology, Hefei, People's Republic of China
| | - Tianwei Hao
- Department of Civil and Environmental Engineering, Faculty of Science and Technology, University of Macau, Macau, People's Republic of China
| | - Kuizu Su
- Department of Civil Engineering, Hefei University of Technology, Hefei, People's Republic of China
- Anhui Provincial Engineering Laboratory for Rural Water Environment and Resources, Hefei, People's Republic of China
| |
Collapse
|
25
|
Xu J, Gao Y, Bi X, Li L, Xiang W, Liu S. Positive effects of lignocellulose on the formation and stability of aerobic granular sludge. Front Microbiol 2023; 14:1254152. [PMID: 37670989 PMCID: PMC10475587 DOI: 10.3389/fmicb.2023.1254152] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/06/2023] [Accepted: 07/31/2023] [Indexed: 09/07/2023] Open
Abstract
Introduction Lignocellulose is one of the major components of particulate organic matter in sewage, which has a significant influence on biological wastewater treatment process. However, the effect of lignocellulose on aerobic granular sludge (AGS) system is still unknown. Methods In this study, two reactors were operated over 5 months to investigate the effect of lignocellulose on granulation process, structure stability and pollutants removal of AGS. Results and discussion The results indicated that lignocellulose not only promoted the secretion of tightly bound polysaccharide in extracellular polymeric substances, but also acted as skeletons within granules, thereby facilitating AGS formation, and enhancing structural strength. Lignocellulose imposed little effect on the removal efficiency of pollutants, with more than 95, 99, and 92% of COD, NH4+-N, and PO43--P were removed in both reactors. However, it did exhibit a noticeable influence on pollutants conversion processes. This might be due to that the presence of lignocellulose promoted the enrichment of functional microorganisms, including Candidatus_Accumulibacter, Candidatus_Competibacter, Nitrosomonas, and Nitrospira, etc. These findings might provide valuable insights into the control strategy of lignocellulose in practical AGS systems.
Collapse
Affiliation(s)
- Jie Xu
- School of Environmental and Municipal Engineering, Qingdao University of Technology, Qingdao, China
| | - Yuan Gao
- School of Environmental and Municipal Engineering, Qingdao University of Technology, Qingdao, China
| | - Xuejun Bi
- School of Environmental and Municipal Engineering, Qingdao University of Technology, Qingdao, China
| | - Lin Li
- Key Laboratory of the Three Gorges Reservoir Region’s Eco-Environment, Ministry of Education, College of Environment and Ecology, Chongqing University, Chongqing, China
| | - Wenjuan Xiang
- School of Environmental and Municipal Engineering, Qingdao University of Technology, Qingdao, China
| | - Shichang Liu
- School of Environmental and Municipal Engineering, Qingdao University of Technology, Qingdao, China
| |
Collapse
|
26
|
Goswami A, Stein N, Fawzy M, Nasr M, Goel R. Retention and recycling of granules in continuous flow-through system to accomplish denitrification and perchlorate reduction. BIORESOURCE TECHNOLOGY 2023:129367. [PMID: 37394045 DOI: 10.1016/j.biortech.2023.129367] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/18/2023] [Revised: 06/14/2023] [Accepted: 06/17/2023] [Indexed: 07/04/2023]
Abstract
This study employed a completely anoxic reactor and a gravity-settling design for continuously separating from flocculated biomass and hydraulically recycling granules back to the main reactor. The average chemical oxygen demand (COD) removal in the reactor was 98 %. Average nitrate (NO3--N) and perchlorate (ClO4-) removal efficiencies of 99 % and 74 ± 19 % were observed, respectively. Preferential utilization of NO3- over ClO4- led to COD limiting conditions, which resulted in ClO4- in the effluent. The average granule diameter in continuous flow-through bubble-column (CFB) anoxic granular sludge (AxGS) bioreactor was 6325 ± 2434 µm, and the average SVI30/SVI1 was > 90% throughout its operation. 16s rDNA amplicon sequencing revealed Proteobacteria (68.53% - 88.57%) and Dechloromonas (10.46% - 54.77%) to be the most abundant phylum and genus present in reactor sludge representing the denitrifying and ClO4- reducing microbial community. This work represents a pioneering development of CFB-AxGS bioreactor.
Collapse
Affiliation(s)
- Anjan Goswami
- Department of Civil and Environmental Engineering, University of Utah, Salt Lake City, UT 84102, USA
| | - Nathan Stein
- Department of Civil and Environmental Engineering, University of Utah, Salt Lake City, UT 84102, USA
| | - Manal Fawzy
- Department of Environmental Sciences, Alexandria University, Alexandria Governorate 5424041, Egypt
| | - Mahmoud Nasr
- Environmental Engineering Department, Egypt-Japan University of Science and Technology (E-JUST), New Borg El-Arab City, Alexandria, 21934, Egypt; Sanitary Engineering Department, Faculty of Engineering, Alexandria University, P.O. Box 21544, Alexandria, 21526, Egypt
| | - Ramesh Goel
- Department of Civil and Environmental Engineering, University of Utah, Salt Lake City, UT 84102, USA.
| |
Collapse
|
27
|
Xie Z, Zhang N, Yang G, Xu Q, Wang D, Tang L, Xia J, Li P, Li X. Environmentally relevant level of perfluorooctanoic acid affect the formation of aerobic granular sludge. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2023; 336:117659. [PMID: 36893544 DOI: 10.1016/j.jenvman.2023.117659] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/26/2022] [Revised: 02/10/2023] [Accepted: 03/01/2023] [Indexed: 06/18/2023]
Abstract
The growing increasing occurrence of perfluorooctanoic acid (PFOA) in wastewater has raised concerns about its potential impact on the environment. Nevertheless, the impact of PFOA at environmentally relevant level on the formation of aerobic granular sludge (AGS) is still a 'black box'. This study thus aims to fill this gap by comprehensive investigation of sludge properties, reactor performance and microbial community during the formation of AGS. It was found that 0.1 mg/L PFOA delayed the formation of AGS, causing relatively lower proportion of large size AGS at the end of operation process. Interestingly, the microorganisms contribute to the reactor's tolerance to PFOA by secreting more extracellular polymeric substances (EPS) to slow or block the entry of toxic substances into the cells. During the granule maturation period, the reactor nutrient removal especially chemical oxygen demand (COD) and total nitrogen (TN) were affected by PFOA, decreasing the corresponding removal efficiencies to ∼81.2% and ∼69.8%, respectively. Microbial analysis further revealed that PFOA decreased the abundances of Plasticicumulans, Thauera, Flavobacterium and Cytophagaceae_uncultured, but it has promoted Zoogloea and Betaproteobacteria_unclassified growth, which maintained the structures and functions of AGS. The above results revealed that the intrinsic mechanism of PFOA on the macroscopic representation of sludge granulation process was revealed, and it is expected to provide theoretical insights and practical support for direct adoption of municipal or industrial wastewater containing perfluorinated compounds to cultivate AGS.
Collapse
Affiliation(s)
- Zhouyun Xie
- College of Biological and Environmental Sciences, Zhejiang Wanli University, Ningbo, 315100, PR China
| | - Ni Zhang
- College of Biological and Environmental Sciences, Zhejiang Wanli University, Ningbo, 315100, PR China; College of Environmental Science and Engineering and Key Laboratory of Environmental Biology and Pollution Control (Ministry of Education), Hunan University, Changsha, 410082, PR China
| | - Guojing Yang
- College of Biological and Environmental Sciences, Zhejiang Wanli University, Ningbo, 315100, PR China; College of Environmental Science and Engineering and Key Laboratory of Environmental Biology and Pollution Control (Ministry of Education), Hunan University, Changsha, 410082, PR China.
| | - Qiuxiang Xu
- College of Biological and Environmental Sciences, Zhejiang Wanli University, Ningbo, 315100, PR China; College of Environmental Science and Engineering and Key Laboratory of Environmental Biology and Pollution Control (Ministry of Education), Hunan University, Changsha, 410082, PR China
| | - Dongbo Wang
- College of Environmental Science and Engineering and Key Laboratory of Environmental Biology and Pollution Control (Ministry of Education), Hunan University, Changsha, 410082, PR China.
| | - Li Tang
- College of Biological and Environmental Sciences, Zhejiang Wanli University, Ningbo, 315100, PR China
| | - Jingfen Xia
- College of Biological and Environmental Sciences, Zhejiang Wanli University, Ningbo, 315100, PR China
| | - Ping Li
- College of Biological and Environmental Sciences, Zhejiang Wanli University, Ningbo, 315100, PR China
| | - Xiaoming Li
- College of Environmental Science and Engineering and Key Laboratory of Environmental Biology and Pollution Control (Ministry of Education), Hunan University, Changsha, 410082, PR China
| |
Collapse
|
28
|
Stein N, Goswami A, Goel R. Anoxic granular activated sludge process for simultaneous removal of hazardous perchlorate and nitrate. JOURNAL OF HAZARDOUS MATERIALS 2023; 458:131809. [PMID: 37343405 DOI: 10.1016/j.jhazmat.2023.131809] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/29/2023] [Revised: 06/06/2023] [Accepted: 06/07/2023] [Indexed: 06/23/2023]
Abstract
An airtight, anoxic bubble-column sequencing batch reactor (SBR) was developed for the rapid cultivation of perchlorate (ClO4-) and nitrate (NO3-) reducing granular sludge (GS) in this study. Feast/famine conditions and shear force selection pressures in tandem with a short settling time (2-min) as a hydraulic section pressure resulted in the accelerated formation of anoxic granular activated sludge (AxGS). ClO4- and NO3- were efficiently (>99.9%) reduced over long-term (>500-d) steady-state operation. Specific NO3- reduction, ClO4- reduction, chloride production, and non-purgeable dissolved organic carbon (DOC) oxidation rates of 5.77 ± 0.54 mg NO3--N/g VSS·h, 8.13 ± 0.74 mg ClO4-/g VSS·h, 2.40 ± 0.40 mg Cl-/g VSS·h, and 16.0 ± 0.06 mg DOC/g VSS·h were recorded within the reactor under steady-state conditions, respectively. The AxGS biomass cultivated in this study exhibited faster specific ClO4- reduction, NO3- reduction, and DOC oxidation rates than flocculated biomass cultivated under similar conditions and AxGS biomass operated in an up-flow anaerobic sludge blank (UASB) bioreactor receiving the same influent loading. EPS peptide identification revealed a suite of extracellular catabolic enzymes. Dechloromonas species were present in high abundance throughout the entirety of this study. This is one of the initial studies on anoxic granulation to simultaneously treat hazardous chemicals and adds to the science of the granular activated sludge process.
Collapse
Affiliation(s)
- Nathan Stein
- Department of Civil and Environmental Engineering, University of Utah, Salt Lake City, UT 84112, USA
| | - Anjan Goswami
- Department of Civil and Environmental Engineering, University of Utah, Salt Lake City, UT 84112, USA
| | - Ramesh Goel
- Department of Civil and Environmental Engineering, University of Utah, Salt Lake City, UT 84112, USA.
| |
Collapse
|
29
|
Stein N, Podder A, Goel R. Biodegradation of insensitive munition (IM) formulations: IMX-101 and IMX-104 using aerobic granule technology. JOURNAL OF HAZARDOUS MATERIALS 2023; 449:130942. [PMID: 36801711 DOI: 10.1016/j.jhazmat.2023.130942] [Citation(s) in RCA: 3] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/26/2022] [Revised: 01/15/2023] [Accepted: 02/02/2023] [Indexed: 06/18/2023]
Abstract
A laboratory-scale aerobic granular sludge (AGS) sequencing batch bioreactor (SBR) was initiated in this study for the biodegradation of hazardous insensitive munition (IM) formulation constituents; 2,4-dinitroanisole (DNAN), hexahydro-1,3,5-trinitro-1,3,5-triazine (RDX), 1-nitroguanidine (NQ), and 3-nitro-1,2,4-triazol-5-one (NTO). Efficient (bio)transformation of the influent DNAN and NTO was achieved throughout reactor operation with removal efficiencies greater than 95%. An average removal efficiency of 38.4 ± 17.5% was recorded for RDX. NQ was only slightly removed (3.96 ± 4.15%) until alkalinity was provided in the influent media, which subsequently increased the NQ removal efficiency up to an average of 65.8 ± 24.4%. Batch experiments demonstrated a competitive advantage for aerobic granular biofilms over flocculated biomass for the (bio)transformation DNAN, RDX, NTO, and NQ, as aerobic granules were capable of reductively (bio)transforming each IM compound under bulk aerobic conditions while flocculated biomass could not, thus demonstrating the contribution of inner oxygen-free zones within aerobic granules. A variety of catalytic enzymes were identified in the extracellular polymeric matrix of the AGS biomass. 16 S rDNA amplicon sequencing found Proteobacteria (27.2-81.2%) to be the most abundant phyla, with many genera associated with nutrient removal as well as genera previously described in relation to the biodegradation of explosives or related compounds.
Collapse
Affiliation(s)
- Nathan Stein
- Department of Civil and Environmental Engineering, University of Utah, Salt Lake City, UT 84112, USA
| | | | - Ramesh Goel
- Department of Civil and Environmental Engineering, University of Utah, Salt Lake City, UT 84112, USA.
| |
Collapse
|
30
|
Yang X, Zhu W, Chen F, Song Y, Yu Y, Zhuang H. Modified biochar prepared from Retinervus luffae fructus for dyes adsorption and aerobic sludge granulation. CHEMOSPHERE 2023; 322:138088. [PMID: 36754295 DOI: 10.1016/j.chemosphere.2023.138088] [Citation(s) in RCA: 5] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/19/2022] [Revised: 01/23/2023] [Accepted: 02/05/2023] [Indexed: 06/18/2023]
Abstract
Retinervus luffae fructus biochar (RLFB) and ZnCl2 pretreated Retinervus luffae fructus biochar (ZRLFB) were prepared by pyrolysis. The as-prepared biochar was investigated for its applicability as a dye adsorber using sunset yellow (SY) and basic red 46 (BR46) dyes. Additionally, ZRLFB was used for the experimental cultivation of granular sludge. The results indicated that the adsorption effect of ZRLFB on the two dyes was higher than RLFB. The adsorption of RLFB to SY was related to the Langmuir and Freundlich models, whereas the adsorption of RLFB-BR46, ZRLFB-SY, and ZRLFB-BR46 was more in line with the Langmuir model. The adsorption process of dyes on two kinds of biochars can be described using pseudo-second-order mechanisms. The maximum adsorption capacity obtained was 1.9586 (RLFB-SY), 6.1286 (RLFB-BR46), 49.2611 (ZRLFB-SY), and 181.4882 mg g-1 (RLFB-BR46). The result of the SBR operation showed that ZRLFB can potentially be applied as the core of aerobic granular sludge.
Collapse
Affiliation(s)
- Xinyuan Yang
- School of Civil Engineering and Architecture, Zhejiang University of Science and Technology, Hangzhou, 310000, China
| | - Wenfang Zhu
- School of Civil Engineering and Architecture, Zhejiang University of Science and Technology, Hangzhou, 310000, China; Key Laboratory of Recycling and Eco-treatment of Waste Biomass of Zhejiang Province, Hangzhou, 310023, China.
| | - Fangyuan Chen
- School of Civil Engineering and Architecture, Zhejiang University of Science and Technology, Hangzhou, 310000, China
| | - Yali Song
- School of Civil Engineering and Architecture, Zhejiang University of Science and Technology, Hangzhou, 310000, China; Key Laboratory of Recycling and Eco-treatment of Waste Biomass of Zhejiang Province, Hangzhou, 310023, China
| | - Ya Yu
- School of Civil Engineering and Architecture, Zhejiang University of Science and Technology, Hangzhou, 310000, China
| | - Haifeng Zhuang
- School of Environmental and Natural Resources, Zhejiang University of Science and Technology, Hangzhou, 310000, China; Key Laboratory of Recycling and Eco-treatment of Waste Biomass of Zhejiang Province, Hangzhou, 310023, China
| |
Collapse
|
31
|
Li Z, Wang J, Liu J, Chen X, Lei Z, Yuan T, Shimizu K, Zhang Z, Lee DJ, Lin Y, Adachi Y, van Loosdrecht MCM. Highly efficient carbon assimilation and nitrogen/phosphorus removal facilitated by photosynthetic O 2 from algal-bacterial aerobic granular sludge under controlled DO/pH operation. WATER RESEARCH 2023; 238:120025. [PMID: 37156104 DOI: 10.1016/j.watres.2023.120025] [Citation(s) in RCA: 9] [Impact Index Per Article: 9.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/27/2023] [Revised: 04/26/2023] [Accepted: 04/29/2023] [Indexed: 05/10/2023]
Abstract
Reducing CO2 emission and energy consumption is crucial for the sustainable management of wastewater treatment plants (WWTPs). In this study, an algal-bacterial aerobic granular sludge (AGS) system was developed for efficient carbon (C) assimilation and nitrogen (N)/phosphorus (P) removal without the need for mechanical aeration. The photosynthetic O2 production by phototrophic organisms maintained the dissolved oxygen (DO) level at 3-4 mg/L in the bulk liquid, and an LED light control system reduced 10-30% of light energy consumption. Results showed that the biomass assimilated 52% of input dissolved total carbon (DTC), and the produced O2 simultaneously facilitated aerobic nitrification and P uptake with the coexisting phototrophs serving as a C fixer and O2 supplier. This resulted in a stably high total N removal of 81 ± 7% and an N assimilation rate of 7.55 mg/(g-MLVSS∙d) with enhanced microbial assimilation and simultaneous nitrification/denitrification. Good P removal of 92-98% was maintained during the test period at a molar ∆P/∆C ratio of 0.36 ± 0.03 and high P release and uptake rates of 10.84 ± 0.41 and 7.18 ± 0.24 mg/(g- MLVSS∙h), respectively. Photosynthetic O2 was more advantageous for N and P removal than mechanical aeration. This proposed system can contribute to a better design and sustainable operation of WWTPs using algal-bacterial AGS.
Collapse
Affiliation(s)
- Zejiao Li
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Jixiang Wang
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Jialin Liu
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Xingyu Chen
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Zhongfang Lei
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan.
| | - Tian Yuan
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Kazuya Shimizu
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan; Faculty of Life Sciences, Toyo University, 1-1-1 Izumino, Oura-gun Itakura, Gunma 374-0193, Japan
| | - Zhenya Zhang
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Duu-Jong Lee
- Department of Mechanical Engineering, City University of Hong Kong, Kowloon Tang, Hong Kong; Department of Chemical Engineering and Materials Science, Yuan Ze University, Chung-Li 32003Taiwan
| | - Yuemei Lin
- Department of Biotechnology, Delft University of Technology, van der Maasweg 9, HZ, Delft 2629, the Netherlands
| | - Yasuhisa Adachi
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Mark C M van Loosdrecht
- Department of Biotechnology, Delft University of Technology, van der Maasweg 9, HZ, Delft 2629, the Netherlands
| |
Collapse
|
32
|
Challenges of aerobic granular sludge utilization: Fast start-up strategies and cationic pollutant removal. Heliyon 2023; 9:e13503. [PMID: 36852066 PMCID: PMC9958455 DOI: 10.1016/j.heliyon.2023.e13503] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/21/2022] [Revised: 01/26/2023] [Accepted: 02/02/2023] [Indexed: 02/11/2023] Open
Abstract
Aerobic granular sludge (AGS) is a self-aggregated microorganism consortium with pollutant removal properties. The aim of this work is to study and review the application of aerobic granules for water treatment with special focus on new applications and methodologies. Carbon-nitrogen containing pollutants are the classic targets of AGS technology. Carbon and nitrogen removal of AGS are classified as a biodegradation process. More recently, the AGS granules have been studied as sorbent materials for wastewater treatment. In particular, the sorption of cationic pollutants has been studied through biosorption and bioaccumulation mechanisms without distinguishing when one or the other process is involved. AGS conformation made them suitable for complex wastewater treatment. Indeed, several studies have demonstrated the removal of polyvalent cationic pollutants even with higher capacity than conventional sorbent materials. However, this was achieved almost exclusively for synthetic substrates, with single cation evaluation and using in some cases only qualitative measures. For successful industrial AGS application in complex substrates, it is necessary to evaluate and demonstrate the technology in real industrial conditions and reduce the currently long start-up times which limits its utility. Two new strategies have been proposed: autoinducer molecules and the production of artificial granular from common active sludge with commercial alginate. Finally, the increase of research on AGS cations assimilation properties will allow a new point of view, where granules will be materials for the recovery of valuable metals from industrial wastewater streams.
Collapse
|
33
|
Li MY, Zhang RD, Lin YX, Li QW, Zhao QY, Zhao ZX, Ling ZM, Shu LF, Zhang M, Hu LX, Shi YJ, Ying GG. Biotransformation of sulfamonomethoxine in a granular sludge system: Pathways and mechanisms. CHEMOSPHERE 2023; 313:137508. [PMID: 36493889 DOI: 10.1016/j.chemosphere.2022.137508] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/27/2022] [Revised: 10/20/2022] [Accepted: 12/06/2022] [Indexed: 06/17/2023]
Abstract
The biotransformation of sulfamonomethoxine (SMM) was studied in an aerobic granular sludge (AGS) system to understand the role of sorption by microbial cells and extracellular polymeric substances (EPS) and the role of functional microbe/enzyme biodegradation. Biodegradation played a more important role than adsorption, while microbial cells covered with tightly bound EPS (TB-EPS) showed higher adsorption capacity than microbial cells themselves or microbial cells covered with both loosely bound EPS (LB-EPS) and TB-EPS. The binding tests between EPS and SMM and the spectroscopic analyses (3D-EEM, UV-Vis, and FTIR) were performed to obtain more information about the adsorption process. The data showed that SMM could interact with EPS by combining with aromatic protein compounds, fulvic acid-like substances, protein amide II, and nucleic acids. Batch tests with various substances showed that SMM removal rates were in an order of NH2OH (60.43 ± 2.21 μg/g SS) > NH4Cl (52.96 ± 0.30 μg/g SS) > NaNO3 (31.88 ± 1.20 μg/g SS) > NaNO2 (21.80 ± 0.42 μg/g SS). Hydroxylamine and hydroxylamine oxidoreductase (HAO) favored SMM biotransformation and the hydroxylamine-mediated biotransformation of SMM was more effective than others. In addition, both ammonia monooxygenase (AMO) and CYP450 were able to co-metabolize SMM. Analysis of UPLC-QTOF-MS indicated the biotransformation mechanisms, revealing that acetylation of arylamine, glucuronidation of sulfonamide, deamination, SO2 extrusion, and δ cleavage were the five major transformation pathways. The detection of TP202 in the hydroxylamine-fed Group C indicated a new biotransformation pathway through HAO. This study contributes to a better understanding of the biotransformation of SMM.
Collapse
Affiliation(s)
- Meng-Yuan Li
- Environmental Research Institute, School of Environment, Guangdong Provincial Key Laboratory of Chemical Pollution and Environmental Safety & MOE Key Laboratory of Theoretical Chemistry of Environment, South China Normal University, Guangzhou, 510006, China
| | - Run-Dong Zhang
- Environmental Research Institute, School of Environment, Guangdong Provincial Key Laboratory of Chemical Pollution and Environmental Safety & MOE Key Laboratory of Theoretical Chemistry of Environment, South China Normal University, Guangzhou, 510006, China
| | - Yi-Xing Lin
- Environmental Research Institute, School of Environment, Guangdong Provincial Key Laboratory of Chemical Pollution and Environmental Safety & MOE Key Laboratory of Theoretical Chemistry of Environment, South China Normal University, Guangzhou, 510006, China
| | - Qi-Wen Li
- Environmental Research Institute, School of Environment, Guangdong Provincial Key Laboratory of Chemical Pollution and Environmental Safety & MOE Key Laboratory of Theoretical Chemistry of Environment, South China Normal University, Guangzhou, 510006, China
| | - Qiu-Yue Zhao
- Environmental Research Institute, School of Environment, Guangdong Provincial Key Laboratory of Chemical Pollution and Environmental Safety & MOE Key Laboratory of Theoretical Chemistry of Environment, South China Normal University, Guangzhou, 510006, China
| | - Zong-Xi Zhao
- Environmental Research Institute, School of Environment, Guangdong Provincial Key Laboratory of Chemical Pollution and Environmental Safety & MOE Key Laboratory of Theoretical Chemistry of Environment, South China Normal University, Guangzhou, 510006, China
| | - Zhong-Ming Ling
- National Center for Wetland Park Management and Conservation, Cuiheng, Zhongshan, 528437, China
| | - Long-Fei Shu
- Environmental Microbiomics Research Center, School of Environmental Science and Engineering, Southern Marine Science and Engineering Guangdong Laboratory (Zhuhai), Sun Yat-sen University, Guangzhou, 510006, China; Guangdong Provincial Key Laboratory of Environmental Pollution Control and Remediation Technology, Sun Yat-sen University, Guangzhou, 510006, China
| | - Min Zhang
- The Pearl River Hydraulic Research Institute, Pearl River Water Resources Commission of the Ministry of Water Resources, Guangzhou, 510610, China
| | - Li-Xin Hu
- Environmental Research Institute, School of Environment, Guangdong Provincial Key Laboratory of Chemical Pollution and Environmental Safety & MOE Key Laboratory of Theoretical Chemistry of Environment, South China Normal University, Guangzhou, 510006, China.
| | - Yi-Jing Shi
- Environmental Research Institute, School of Environment, Guangdong Provincial Key Laboratory of Chemical Pollution and Environmental Safety & MOE Key Laboratory of Theoretical Chemistry of Environment, South China Normal University, Guangzhou, 510006, China; Guangdong Provincial Key Laboratory of Environmental Pollution Control and Remediation Technology, Sun Yat-sen University, Guangzhou, 510006, China.
| | - Guang-Guo Ying
- Environmental Research Institute, School of Environment, Guangdong Provincial Key Laboratory of Chemical Pollution and Environmental Safety & MOE Key Laboratory of Theoretical Chemistry of Environment, South China Normal University, Guangzhou, 510006, China
| |
Collapse
|
34
|
Zhang Z, Wang L, Ji Y, Cao R, Zhou J, Li M, Zhu L, Xu X. Understanding the N-acylated homoserine lactones(AHLs)-based quorum sensing for the stability of aerobic granular sludge in the aspect of substrate hydrolysis enhancement. THE SCIENCE OF THE TOTAL ENVIRONMENT 2023; 858:159581. [PMID: 36397605 DOI: 10.1016/j.scitotenv.2022.159581] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/08/2022] [Revised: 10/08/2022] [Accepted: 10/16/2022] [Indexed: 06/16/2023]
Abstract
Efficient substrate metabolism is the premise for stable operation of aerobic granular sludge and can be regulated by quorum sensing (QS). In this study, starch and acetate were selected to represent complex and simple substrates to provide comparable amount of metabolic energy for granules cultivation. Starch-fed granules were larger in size and contained higher EPS content than acetate-fed granules, though both granules exhibited similar substrate-degradation rates during sequencing batch reactor (SBR) cycle. Three N-acylhomoserine lactones (AHLs), including C8-HSL, 3OHC8-HSL and 3OHC12-HSL, were detected as dominant autoinducers in granules. They accumulated more in starch-fed granules than acetate-fed granules. The batch experiments were implemented to investigate QS regulation for granular stability in terms of substrate hydrolysis and transformation. The addition of three AHLs increased the activity of α-amylase, the main starch hydrolase, 4-6 times, significantly (p < 0.01) higher than the control treatment without AHLs amendment. While activity of dehydrogenase, the main simple substrate degradation enzyme, was increased only 1-2 times. Higher enzyme activity, especially α-amylase, significantly (p < 0.05) promoted the substrate-degradation rate (65 % than control group) and EPS yield in starch-fed system. Overall, QS can facilitate complex substrate uptake via hydrolysis enhancement and EPS secretion, which together promote sludge granulation and stability.
Collapse
Affiliation(s)
- Zhiming Zhang
- College of Environmental and Resource Sciences, Zhejiang University, Hangzhou 310058, China
| | - Linlin Wang
- College of Environmental and Resource Sciences, Zhejiang University, Hangzhou 310058, China
| | - Yatong Ji
- College of Environmental and Resource Sciences, Zhejiang University, Hangzhou 310058, China
| | - Runjuan Cao
- College of Environmental and Resource Sciences, Zhejiang University, Hangzhou 310058, China
| | - Jiaheng Zhou
- College of Civil Engineering and Architecture, Zhejiang University of Technology, Hangzhou 310014, China
| | - Mengyan Li
- Department of Chemistry and Environmental Science, New Jersey Institute of Technology, Newark 07102, USA
| | - Liang Zhu
- College of Environmental and Resource Sciences, Zhejiang University, Hangzhou 310058, China; Zhejiang Province Key Laboratory for Water Pollution Control and Environmental Safety, Hangzhou 310058, China; Zhejiang Provincial Engineering Laboratory of Water Pollution Control, 388 Yuhangtang Road, Hangzhou 310058, China.
| | - Xiangyang Xu
- College of Environmental and Resource Sciences, Zhejiang University, Hangzhou 310058, China; Zhejiang Province Key Laboratory for Water Pollution Control and Environmental Safety, Hangzhou 310058, China; Zhejiang Provincial Engineering Laboratory of Water Pollution Control, 388 Yuhangtang Road, Hangzhou 310058, China
| |
Collapse
|
35
|
Xiong W, Wang S, Jin Y, Wu Z, Liu D, Su H. Insights into nitrogen and phosphorus metabolic mechanisms of algal-bacterial aerobic granular sludge via metagenomics: Performance, microbial community and functional genes. BIORESOURCE TECHNOLOGY 2023; 369:128442. [PMID: 36470490 DOI: 10.1016/j.biortech.2022.128442] [Citation(s) in RCA: 21] [Impact Index Per Article: 21.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/01/2022] [Revised: 11/30/2022] [Accepted: 12/01/2022] [Indexed: 06/17/2023]
Abstract
Aiming to propose the potential mechanism for the enhancement of nitrogen (N) and phosphorus (P) removal of algal-bacterial aerobic granular sludge (A-AGS), metagenomic analysis was applied to identify the metabolic pathways. The results showed that chemical oxygen demand, ammonia nitrogen, total N, and total P removal of A-AGS could reach to 94.5%, 97.5%, 78.1%, and 88.5%, respectively. Algae enriched the content of extracellular polymeric substance, which significantly promoted the formation of A-AGS. Further investigations in functional genes suggested that nitrification process (amo, nxr, hao, etc.), denitrification process (nir, nap, nor, etc.), and polyphosphate accumulation (ppk, ppk2, etc.) were enhanced greatly in A-AGS. Notably, genus Thauera was the dominant source of functional genes, which penetrated both in N and P metabolism. The higher N and P removal performance in A-AGS could be attributed to synergistic effect between bacteria and microalgae, which may provide the basic for the application in wastewater treatment.
Collapse
Affiliation(s)
- Wei Xiong
- State Key Laboratory of Chemical Resource Engineering, Beijing Key Laboratory of Bioprocess, and Beijing Advanced Innovation Center for Soft Matter Science and Engineering, Beijing University of Chemical Technology, Beijing 100029, People's Republic of China
| | - Shaojie Wang
- State Key Laboratory of Chemical Resource Engineering, Beijing Key Laboratory of Bioprocess, and Beijing Advanced Innovation Center for Soft Matter Science and Engineering, Beijing University of Chemical Technology, Beijing 100029, People's Republic of China
| | - Yu Jin
- State Key Laboratory of Chemical Resource Engineering, Beijing Key Laboratory of Bioprocess, and Beijing Advanced Innovation Center for Soft Matter Science and Engineering, Beijing University of Chemical Technology, Beijing 100029, People's Republic of China
| | - Zhiqing Wu
- State Key Laboratory of Chemical Resource Engineering, Beijing Key Laboratory of Bioprocess, and Beijing Advanced Innovation Center for Soft Matter Science and Engineering, Beijing University of Chemical Technology, Beijing 100029, People's Republic of China
| | - Dan Liu
- State Key Laboratory of Chemical Resource Engineering, Beijing Key Laboratory of Bioprocess, and Beijing Advanced Innovation Center for Soft Matter Science and Engineering, Beijing University of Chemical Technology, Beijing 100029, People's Republic of China
| | - Haijia Su
- State Key Laboratory of Chemical Resource Engineering, Beijing Key Laboratory of Bioprocess, and Beijing Advanced Innovation Center for Soft Matter Science and Engineering, Beijing University of Chemical Technology, Beijing 100029, People's Republic of China.
| |
Collapse
|
36
|
Xue Y, Ma H, Li YY. Anammox-based granulation cycle for sustainable granular sludge biotechnology from mechanisms to strategies: A critical review. WATER RESEARCH 2023; 228:119353. [PMID: 36423549 DOI: 10.1016/j.watres.2022.119353] [Citation(s) in RCA: 15] [Impact Index Per Article: 15.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/23/2022] [Revised: 11/06/2022] [Accepted: 11/11/2022] [Indexed: 06/16/2023]
Abstract
Anaerobic ammonium oxidation (anammox) granular sludge is a promising biotechnological process for treating low-carbon nitrogenous wastewater, and is featured with low energy consumption and footprint. Previous theoretical and experimental research on anammox granular sludge processes mainly focused on granulation (flocs → granules), but pay little attention to the granulation cycle including granulation and regeneration. This work reviewed the previous studies from the perspective of anammox granules lifecycle and proposed various sustainable formation mechanisms of anammox granules. By reviewing the anaerobic, aerobic, and anammox granulation mechanisms, we summarize the mechanisms of thermodynamic theory, heterogeneous growth, extracellular polymeric substance (EPS)-based adhesion, quorum sensing (QS)-based regulation, biomineralization-based growth, and stratification of microorganisms to understand anammox granulation. In the regeneration process, the formation of precursors for re-granulation is explained by the mechanisms of physical crushing, quorum quenching and dispersion cue sensing. Based on the granulation cycle mechanism, the rebuilding of the normal regeneration process is considered essential to avoid granule floatation and the wash-out of granules. This comprehensive review indicates that future research on anammox granulation cycle should focus on the effects of filamentous bacteria in denitrification-anammox granulation cycle, the role of QS/ quorum quenching (QQ)-based autoinducers, development of diversified mechanisms to understand the cycle and the cycle mechanisms of stored granules.
Collapse
Affiliation(s)
- Yi Xue
- Graduate School of Environmental Studies, Tohoku University, 6-6-06 Aza-Aoba, Aramaki, Aoba-ku, Sendai, Miyagi 980-8579, Japan
| | - Haiyuan Ma
- College of Environment and Ecology, Chongqing University, Chongqing 40045, China
| | - Yu-You Li
- Graduate School of Environmental Studies, Tohoku University, 6-6-06 Aza-Aoba, Aramaki, Aoba-ku, Sendai, Miyagi 980-8579, Japan; Department of Civil and Environmental Engineering, Graduate School of Engineering, Tohoku University, 6-6-06 Aza-Aoba, Aramaki, Aoba-ku, Sendai, Miyagi 980-8579, Japan.
| |
Collapse
|
37
|
Wu L, Lu C, Huang N, Zhong M, Teng Y, Tian Y, Ye K, Liang L, Hu Z. Exploration of the effect of simultaneous removal of EDCs in the treatment process of different types of wastewater. WATER SCIENCE AND TECHNOLOGY : A JOURNAL OF THE INTERNATIONAL ASSOCIATION ON WATER POLLUTION RESEARCH 2023; 87:436-453. [PMID: 36706292 DOI: 10.2166/wst.2022.429] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/18/2023]
Abstract
The SPE-HPLC-MS/MS method was used to investigate the concentration distribution of nine types of estrogens in 18 locations of pollution source along the Jiuzhou River belonging to river systems in Guangdong province and Guangxi Zhuang autonomous region in China, and the estrogenic activity and potential ecological risks were evaluated by calculating the estradiol equivalency (EEQ). The results showed that the calculated estradiol equivalents (cEEQs) of wastewater treatment plants from 17 locations were all higher than 1 ng/L. To further study the removal effect of the treatment process on the estrogens, the pig breeding wastewater from P4 and the municipal wastewater from P13, as well as the black-odorous water, were sampled and surveyed during the entire process. It turned out that estrogens were effectively removed after nitrification activated sludge treatment. Meanwhile, there was a positive correlation between the removal of NH3-N, total nitrogen (TN) and total phosphorus (TP) and the removal of endocrine disrupting chemicals (EDCs). It is shown in the study the secondary treatment process has achieved a significant effect on the removal of estrogen in both the wet and dry periods and that there has been a positive correlation between the activities of total phosphorus compounds, nitrogen-based compounds and the removal of EDCs.
Collapse
Affiliation(s)
- Lieshan Wu
- School of Resources, Environment and Materials, Guangxi University, Nanning 530004, PR China
| | - Chunliu Lu
- School of Resources, Environment and Materials, Guangxi University, Nanning 530004, PR China
| | - Ning Huang
- Guangxi Zhuang Autonomous Region Ecological and Environmental Monitoring Centre, Nanning 530028, PR China E-mail:
| | - Minjie Zhong
- School of Resources, Environment and Materials, Guangxi University, Nanning 530004, PR China
| | - Yunmei Teng
- Guangxi Zhuang Autonomous Region Ecological and Environmental Monitoring Centre, Nanning 530028, PR China E-mail:
| | - Yan Tian
- Guangxi Zhuang Autonomous Region Ecological and Environmental Monitoring Centre, Nanning 530028, PR China E-mail:
| | - Kaixiao Ye
- Guangxi Zhuang Autonomous Region Ecological and Environmental Monitoring Centre, Nanning 530028, PR China E-mail:
| | - Liuling Liang
- Guangxi Zhuang Autonomous Region Ecological and Environmental Monitoring Centre, Nanning 530028, PR China E-mail:
| | - Zaoshi Hu
- Guangxi Zhuang Autonomous Region Ecological and Environmental Monitoring Centre, Nanning 530028, PR China E-mail:
| |
Collapse
|
38
|
Kosar S, Isik O, Cicekalan B, Gulhan H, Cingoz S, Yoruk M, Ozgun H, Koyuncu I, van Loosdrecht MCM, Ersahin ME. Coupling high-rate activated sludge process with aerobic granular sludge process for sustainable municipal wastewater treatment. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2023; 325:116549. [PMID: 36419284 DOI: 10.1016/j.jenvman.2022.116549] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/27/2022] [Revised: 09/28/2022] [Accepted: 10/15/2022] [Indexed: 06/16/2023]
Abstract
Achieving a neutral/positive energy balance without compromising discharge standards is one of the main goals of wastewater treatment plants (WWTPs) in terms of sustainability. Aerobic granular sludge (AGS) technology promises high treatment performance with low energy and footprint requirement. In this study, high-rate activated sludge (HRAS) process was coupled to AGS process as an energy-efficient pre-treatment option in order to increase energy recovery from municipal wastewater and decrease the particulate matter load of AGS process. Three different feeding strategies were applied throughout the study. AGS system was fed with raw municipal wastewater, with the effluent of HRAS process, and with the mixture of the effluent of HRAS process and raw municipal wastewater at Stage 1, Stage 2 and Stage 3, respectively. Total suspended solids (TSS), chemical oxygen demand (COD), ammonia nitrogen (NH4+-N), and total phosphorus (TP) concentrations in the effluent were less than 10 mg/L, 60 mg/L, 0.4 mg/L, and 1.3 mg/L respectively at all stages. Fluctuations were observed in the denitrification performance due to changes in the influent COD/total nitrogen (TN) ratio. This study showed that coupling HRAS process with AGS process by feeding the AGS process with the mixture of HRAS process effluent and raw municipal wastewater could be an appropriate option for both increasing the energy recovery potential of WWTPs and enabling high effluent quality.
Collapse
Affiliation(s)
- Sadiye Kosar
- Istanbul Technical University, Civil Engineering Faculty, Environmental Engineering Department, Ayazaga Campus, Maslak, 34469, Istanbul, Turkey.
| | - Onur Isik
- Istanbul Technical University, Civil Engineering Faculty, Environmental Engineering Department, Ayazaga Campus, Maslak, 34469, Istanbul, Turkey; National Research Center on Membrane Technologies, Istanbul Technical University, 34469, Maslak, Istanbul, Turkey; Kahramanmaras Sutcu Imam University, Engineering and Architecture Faculty, Environmental Engineering Department, Onikisubat, 46100, Kahramanmaras, Turkey
| | - Busra Cicekalan
- Istanbul Technical University, Civil Engineering Faculty, Environmental Engineering Department, Ayazaga Campus, Maslak, 34469, Istanbul, Turkey
| | - Hazal Gulhan
- Istanbul Technical University, Civil Engineering Faculty, Environmental Engineering Department, Ayazaga Campus, Maslak, 34469, Istanbul, Turkey
| | - Seyma Cingoz
- ISKI, Istanbul Water and Sewerage Administration, Eyup, 34060, Istanbul, Turkey
| | - Mustafa Yoruk
- ISKI, Istanbul Water and Sewerage Administration, Eyup, 34060, Istanbul, Turkey
| | - Hale Ozgun
- Istanbul Technical University, Civil Engineering Faculty, Environmental Engineering Department, Ayazaga Campus, Maslak, 34469, Istanbul, Turkey; National Research Center on Membrane Technologies, Istanbul Technical University, 34469, Maslak, Istanbul, Turkey
| | - Ismail Koyuncu
- Istanbul Technical University, Civil Engineering Faculty, Environmental Engineering Department, Ayazaga Campus, Maslak, 34469, Istanbul, Turkey; National Research Center on Membrane Technologies, Istanbul Technical University, 34469, Maslak, Istanbul, Turkey
| | - Mark C M van Loosdrecht
- Delft University of Technology, Department of Biotechnology, van der Maasweg 9, 2629, HZ, Delft, the Netherlands
| | - Mustafa Evren Ersahin
- Istanbul Technical University, Civil Engineering Faculty, Environmental Engineering Department, Ayazaga Campus, Maslak, 34469, Istanbul, Turkey; National Research Center on Membrane Technologies, Istanbul Technical University, 34469, Maslak, Istanbul, Turkey
| |
Collapse
|
39
|
Yuan C, Sun F, Zhang J, Feng L, Tu H, Li A. Low-temperature-resistance granulation of activated sludge and the microbial responses to the granular structural stabilization. CHEMOSPHERE 2023; 311:137146. [PMID: 36347348 DOI: 10.1016/j.chemosphere.2022.137146] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/07/2022] [Revised: 10/14/2022] [Accepted: 11/03/2022] [Indexed: 06/16/2023]
Abstract
Completely loss of granular structural stability and reliable start-up of aerobic granular sludge (AGS) system are considered as the biggest challenges for its engineering application under seasonal temperature variation, especially extremely low temperatures. In this study, two identical sequencing batch reactors (SBR) were successfully start-up at 10 °C (R1) and 25 °C (R2), respectively, and then operated under a strategy of stepwise change of temperatures to investigate the stability of the granular sludge by examining its microbial characteristics, bis (3'-5')-cyclic dimeric guanosine monophosphate (c-di-GMP), extracellular polymeric substance (EPS) and sludge physiochemical properties. The results showed that AGS formed under the low temperature preferentially secrete EPS and c-di-GMP for stable granulation and improvement of its resistance to temperature changes. Meanwhile, R1 successfully obtained aerobic granulation with high biomass concentration and superior settleability, as well as high pollutant removal performance. In comparison, R2 took a longer time for granulation and was subjected to serious disintegration of AGS. The matrix structure partially formed by filamentous bacteria during the start-up stage in R1 was one of major reasons for its own superiority beyond R2 in granulation. Slow-growing organisms such as autotrophic nitrifying and Anammox bacteria, phosphorus accumulation organisms, EPS-producing genera, and c-di-GMP pathway-dependent genera, were exclusively enriched in the R1 and resulted in higher pollutants removal efficiencies and stable structure, whereas Sphaerotilus dominated in R2 that related closely with its unstable performance. Therefore, the strategy based on the stepwise change of temperatures from extremely low temperatures may be one feasible way for the sustainable application of AGS system, which is of significance to address the challenging problems of AGS applications.
Collapse
Affiliation(s)
- Chunyan Yuan
- State Key Laboratory of Urban Water Resource and Environment, School of Environment, Harbin Institute of Technology, Harbin 150090, People's Republic of China; Harbin Institute of Technology (Shenzhen), Shenzhen Key Laboratory of Water Resource Utilization and Environmental Pollution Control, Shenzhen, 518055, People's Republic of China
| | - Feiyun Sun
- State Key Laboratory of Urban Water Resource and Environment, School of Environment, Harbin Institute of Technology, Harbin 150090, People's Republic of China; Harbin Institute of Technology (Shenzhen), Shenzhen Key Laboratory of Water Resource Utilization and Environmental Pollution Control, Shenzhen, 518055, People's Republic of China.
| | - Jianjun Zhang
- Shenzhen Municipal Design & Research Institute Co. Ltd., People's Republic of China
| | - Liang Feng
- Harbin Institute of Technology (Shenzhen), Shenzhen Key Laboratory of Water Resource Utilization and Environmental Pollution Control, Shenzhen, 518055, People's Republic of China
| | - Honghua Tu
- Harbin Institute of Technology (Shenzhen), Shenzhen Key Laboratory of Water Resource Utilization and Environmental Pollution Control, Shenzhen, 518055, People's Republic of China
| | - Ang Li
- State Key Laboratory of Urban Water Resource and Environment, School of Environment, Harbin Institute of Technology, Harbin 150090, People's Republic of China.
| |
Collapse
|
40
|
Zheng X, Han Z, Shao X, Zhao Z, Zhang H, Lin T, Yang S, Zhou C. Response of aerobic granular sludge under polyethylene microplastics stress: Physicochemical properties, decontamination performance, and microbial community. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2022; 323:116215. [PMID: 36113287 DOI: 10.1016/j.jenvman.2022.116215] [Citation(s) in RCA: 19] [Impact Index Per Article: 9.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/22/2022] [Revised: 08/21/2022] [Accepted: 09/05/2022] [Indexed: 06/15/2023]
Abstract
Microplastics are widely detected in sewage and sludge in wastewater treatment plants and can thereby influence biological processes. In this study, the overall impacts of polyethylene microplastics (PE MPs) and their toxicity mechanisms on aerobic granular sludge (AGS) were investigated. Particle structure, settling properties, particle size distribution, and extracellular polymeric substance characteristics of AGS were significantly affected by PE MPs with concentrations of 20 and 200 n/L. Increased relative contents of reactive oxygen species (ROS) (146.34% and 191.43%) and lactate dehydrogenase (LDH) (185.71% and 316.67%) under PE MPs (20 and 200 n/L) exposure resulted in disruption of cellular structure. The activities of enzymes related to denitrification and phosphorus removal were greatly decreased, while ammonia monooxygenase (AMO) was stable, supporting the high efficiency removal of ammonia nitrogen. High-throughput sequencing demonstrated that the relative abundance of nitrifying and denitrifying bacteria (Nitrospira, Thermomonas, Flavobacterium), and PAOs (Comamonas and Rhodocyclus) were significantly reduced from 4.47%, 3.57%, 2.02%, 9.38%, and 5.45%-2.95%, 2.88%, 1.77%, 8.01%, and 4.86% as the concentration of PE MPs increased from 0 to 200 n/L, respectively. Those findings were consistent with the deterioration in decontamination capability.
Collapse
Affiliation(s)
- Xiaoying Zheng
- Ministry of Education Key Laboratory of Integrated Regulation and Resource Development on Shallow Lakes, Hohai University, Nanjing, 210098, PR China; College of Environment, Hohai University, Nanjing, 210098, PR China.
| | - Zongshuo Han
- Ministry of Education Key Laboratory of Integrated Regulation and Resource Development on Shallow Lakes, Hohai University, Nanjing, 210098, PR China; College of Environment, Hohai University, Nanjing, 210098, PR China
| | - Xiaoyao Shao
- Ministry of Education Key Laboratory of Integrated Regulation and Resource Development on Shallow Lakes, Hohai University, Nanjing, 210098, PR China; College of Environment, Hohai University, Nanjing, 210098, PR China
| | - Zhilin Zhao
- Ministry of Education Key Laboratory of Integrated Regulation and Resource Development on Shallow Lakes, Hohai University, Nanjing, 210098, PR China; College of Environment, Hohai University, Nanjing, 210098, PR China
| | - Huijie Zhang
- Ministry of Education Key Laboratory of Integrated Regulation and Resource Development on Shallow Lakes, Hohai University, Nanjing, 210098, PR China; College of Environment, Hohai University, Nanjing, 210098, PR China
| | - Tao Lin
- Ministry of Education Key Laboratory of Integrated Regulation and Resource Development on Shallow Lakes, Hohai University, Nanjing, 210098, PR China; College of Environment, Hohai University, Nanjing, 210098, PR China
| | - Shanshan Yang
- Ministry of Education Key Laboratory of Integrated Regulation and Resource Development on Shallow Lakes, Hohai University, Nanjing, 210098, PR China; College of Environment, Hohai University, Nanjing, 210098, PR China
| | - Chao Zhou
- Ministry of Education Key Laboratory of Integrated Regulation and Resource Development on Shallow Lakes, Hohai University, Nanjing, 210098, PR China; College of Environment, Hohai University, Nanjing, 210098, PR China
| |
Collapse
|
41
|
Cavanaugh SK, Nguyen Quoc B, Jacobson E, Bucher R, Sukapanpotharam P, Winkler MKH. Impact of nitrite and oxygen on nitrous oxide emissions from a granular sludge sequencing batch reactor. CHEMOSPHERE 2022; 308:136378. [PMID: 36113651 DOI: 10.1016/j.chemosphere.2022.136378] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/07/2022] [Revised: 09/03/2022] [Accepted: 09/05/2022] [Indexed: 06/15/2023]
Abstract
Maximizing nutrient removal and minimizing greenhouse gas (GHG) emissions is imperative for the future of wastewater treatment. As municipalities focus on minimizing their carbon footprints, future permits could regulate GHG emissions from wastewater treatment plants. This study investigates how nitrous oxide (N2O) emissions are affected by dissolved oxygen and nitrite concentrations, providing potential strategies to meet possible gaseous emission permits. A lab-scale sequencing batch reactor (SBR) was enriched with aerobic granular sludge (AGS) capable of phosphate removal and simultaneous nitrification-denitrification (SND). N2O emissions were tracked at varying dissolved oxygen (DO) and nitrite (NO2-) concentrations, with >99% SND efficiency and 93%-100% phosphate removal efficiency. Higher DO and NO2- concentrations were associated with higher N2O emissions. Emissions were minimized at a DO concentration of 1 mg L-1, with an average emission factor of 0.18% of oxidized NH3-N emitted as N2O-N, which is lower than factors from many full-scale treatment plants (Vasilaki et al., 2019) and similar to a Nereda® full-scale AGS SBR (van Dijk et al., 2021). This challenges assertions that AGS emits more N2O than conventional activated sludge, although more research at full-scale with influent quality variations is required to confirm this trend. Molecular analyses revealed that the efficient SND was likely achieved with shortcut nitrogen removal facilitated by a low presence of nitrite oxidizing bacteria and a large population of denitrifying phosphate accumulating organisms, which far outnumbered denitrifying glycogen accumulating organisms.
Collapse
Affiliation(s)
- Shannon K Cavanaugh
- University of Washington, Department of Civil & Environmental Engineering, Seattle, WA, 98195, USA.
| | - Bao Nguyen Quoc
- University of Washington, Department of Civil & Environmental Engineering, Seattle, WA, 98195, USA
| | - Eron Jacobson
- Resource Recovery, Wastewater Treatment Division, King County Department of Natural Resources and Parks, Seattle, WA, 98104, USA
| | - Robert Bucher
- Resource Recovery, Wastewater Treatment Division, King County Department of Natural Resources and Parks, Seattle, WA, 98104, USA
| | - Pardi Sukapanpotharam
- Resource Recovery, Wastewater Treatment Division, King County Department of Natural Resources and Parks, Seattle, WA, 98104, USA
| | - Mari-Karoliina H Winkler
- University of Washington, Department of Civil & Environmental Engineering, Seattle, WA, 98195, USA
| |
Collapse
|
42
|
Liang Y, Pan Z, Guo T, Feng H, Yan A, Ni Y, Li J. Filamentous Bacteria and Stalked Ciliates for the Stable Structure of Aerobic Granular Sludge Treating Wastewater. INTERNATIONAL JOURNAL OF ENVIRONMENTAL RESEARCH AND PUBLIC HEALTH 2022; 19:15747. [PMID: 36497821 PMCID: PMC9735926 DOI: 10.3390/ijerph192315747] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 10/28/2022] [Revised: 11/22/2022] [Accepted: 11/24/2022] [Indexed: 06/17/2023]
Abstract
Aerobic granular sludge (AGS) is a promising technology for wastewater treatment. AGS formation belongs to microbial self-aggregation. Investigation of the formation and stability of AGS is widely paid attention to, in particular the structure stability of large size granules. Two types of AGS were developed in two sequencing batch reactors fed by two different wastewaters, respectively. Through confocal laser scanning microscope (CLSM) and scanning electron microscopy (SEM), the structure and composition of granules were analyzed. Filamentous bacteria were observed in granules from synthetic wastewater reactor, while filamentous bacteria and stalked ciliates (Epistylis sp.) were simultaneously found in granules from domestic wastewater reactor. The analytic results show that filamentous bacteria and stalked ciliates acting as skeletons play important roles in the formation and stability of granules. With the bonding of extracellular polymeric substances (EPS), the filamentous bacteria and stalked ciliates could build bridges and frames to promote the aggregation of bacteria; these microorganisms could create a space grid structure around the surface layer of granules to enhance the strength of granules, and the remnants of the stalks could serve as supports to fix the steadiness of granules.
Collapse
|
43
|
Chen X, Lee YJ, Yuan T, Lei Z, Adachi Y, Zhang Z, Lin Y, van Loosdrecht MCM. A review on recovery of extracellular biopolymers from flocculent and granular activated sludges: Cognition, key influencing factors, applications, and challenges. BIORESOURCE TECHNOLOGY 2022; 363:127854. [PMID: 36067889 DOI: 10.1016/j.biortech.2022.127854] [Citation(s) in RCA: 11] [Impact Index Per Article: 5.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/18/2022] [Revised: 08/21/2022] [Accepted: 08/22/2022] [Indexed: 06/15/2023]
Abstract
A reasonable recovery of excess sludge may shift the waste into wealth. Recently an increasing attention has been paid to the recycling of extracellular biopolymers from conventional and advanced biological wastewater treatment systems such as flocculent activated sludge (AS), bacterial aerobic granular sludge (AGS), and algal-bacterial AGS processes. This review provides the first overview of current research developments and future directions in the recovery and utilization of high value-added biopolymers from the three types of sludge. It details the discussion on the recent evolvement of cognition or updated knowledge on functional extracellular biopolymers, as well as a comprehensive summary of the operating conditions and wastewater parameters influencing the yield, quality, and functionality of alginate-like exopolymer (ALE). In addition, recent attempts for potential practical applications of extracellular biopolymers are discussed, suggesting research priorities for overcoming identification challenges and future prospects.
Collapse
Affiliation(s)
- Xingyu Chen
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Yu-Jen Lee
- Department of Chemical Engineering, National Taiwan University, Taipei 10617, Taiwan
| | - Tian Yuan
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Zhongfang Lei
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan.
| | - Yasuhisa Adachi
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Zhenya Zhang
- Faculty of Life and Environmental Sciences, University of Tsukuba, 1-1-1 Tennodai, Tsukuba, Ibaraki 305-8572, Japan
| | - Yuemei Lin
- Department of Biotechnology, Delft University of Technology, van der Maasweg 9, 2629 HZ, Delft, the Netherlands
| | - Mark C M van Loosdrecht
- Department of Biotechnology, Delft University of Technology, van der Maasweg 9, 2629 HZ, Delft, the Netherlands
| |
Collapse
|
44
|
Barrón-Hernández LM, Gonzaga-Galeana VE, Colín-Cruz A, Esparza-Soto M, Lucero-Chávez M, Bâ K, Fall C. Consistency between the metabolic performance of two aerobic granular sludge systems and the functional groups of bacteria detected by amplicon sequencing. ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2022; 29:83512-83525. [PMID: 35768715 DOI: 10.1007/s11356-022-21692-y] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/21/2021] [Accepted: 06/22/2022] [Indexed: 06/15/2023]
Abstract
Two sequential batch reactors (R1 and R2) of aerobic granular sludge (AGS) were inoculated with activated sludge of different origins. The objective was to investigate the granulation and the consistency between the structure of the microbial communities (16S rRNA amplicon sequencing) in each reactor and their metabolic performance (removal of C, N, and P). Both reactors were fed with acetate-based synthetic wastewater, targeting an anaerobic-aerobic cycle reputed to favor the phosphorus- and glycogen-accumulating organisms (PAO and GAO). Stable granulation was achieved in both reactors, where, instead of PAO, the dominant genera were ordinary heterotrophic organisms (OHO) such as Thauera, Paracoccus, and Flavobacterium known for their high capacity of aerobic storage of polyhydroxyalkanoates (PHA). Generally, there was good consistency between the metabolic behavior of each reactor and the bacterial genera detected. Both reactors showed high removals of C and complete nitrification (Nitrosomonas and Nitrospira detected) but a low level of simultaneous nitrification-denitrification (SND) during the aerated phase. The latter causes that nitrates were recycled to the initial phase, in detriment of PAO selection. Meanwhile, the study showed that selecting slow-growing OHOs (with aerobic storage capacity) favors stable granulation, revealing an alternative AGS technology for C and N removal.
Collapse
Affiliation(s)
- Lilia Magdalena Barrón-Hernández
- Instituto Interamericano de Tecnología Y Ciencias del Agua, Universidad Autónoma del Estado de México (UAEM), Apdo postal 367, 50091, Toluca, C.P, Mexico
| | - Víctor Enrique Gonzaga-Galeana
- Instituto Interamericano de Tecnología Y Ciencias del Agua, Universidad Autónoma del Estado de México (UAEM), Apdo postal 367, 50091, Toluca, C.P, Mexico
| | - Arturo Colín-Cruz
- UAEM, Facultad de Química, Unidad Colón, Paseo Colón Esq. Paseo Tollocán Residencial Colón Y Col Ciprés, Estado de México, 50120, Toluca, Mexico
| | - Mario Esparza-Soto
- Instituto Interamericano de Tecnología Y Ciencias del Agua, Universidad Autónoma del Estado de México (UAEM), Apdo postal 367, 50091, Toluca, C.P, Mexico
| | - Mercedes Lucero-Chávez
- Instituto Interamericano de Tecnología Y Ciencias del Agua, Universidad Autónoma del Estado de México (UAEM), Apdo postal 367, 50091, Toluca, C.P, Mexico
| | - Khalidou Bâ
- Instituto Interamericano de Tecnología Y Ciencias del Agua, Universidad Autónoma del Estado de México (UAEM), Apdo postal 367, 50091, Toluca, C.P, Mexico
| | - Cheikh Fall
- Instituto Interamericano de Tecnología Y Ciencias del Agua, Universidad Autónoma del Estado de México (UAEM), Apdo postal 367, 50091, Toluca, C.P, Mexico.
| |
Collapse
|
45
|
Gemza N, Janiak K, Zięba B, Przyszlak J, Kuśnierz M. Long-term effects of hydrocyclone operation on activated sludge morphology and full-scale secondary settling tank wet-weather operation in long sludge age WWTP. THE SCIENCE OF THE TOTAL ENVIRONMENT 2022; 845:157224. [PMID: 35835188 DOI: 10.1016/j.scitotenv.2022.157224] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/21/2022] [Revised: 06/30/2022] [Accepted: 07/04/2022] [Indexed: 06/15/2023]
Abstract
This paper presents the study concerning long-term effects of a full scale hydrocyclone unit implemented in a continuous flow long sludge age system, on sedimentation, treatment efficiency and sludge morphology. The research concentrates on identifying the mechanisms of sludge behaviour within the system. The gravimetric selection of activated sludge via a hydrocyclone is a recent development for enhancing sludge separation, where heavier flocs are retained in the system, and lighter ones are discarded as waste sludge. The effects of implementing hydroclyclones were analysed with the use of SEM imagining and fractal dimensioning through the frequent assessment of sludge settling capabilities, effluent quality, and floc properties. Over the course of 60 weeks of hydrocyclone operation, sedimentation efficiency varied significantly. Sludge volume index values of 40 mL/g, achieved during the warm season, were not sustained when the temperature decreased and an overgrowth of filamentous bacteria occurred. Good settling efficiency was also observed in batch tests, where settling velocity of experimental sludge was app. 1 m/h higher than for the reference train at the same concentrations. This was confirmed during wet weather, as the experimental train sustained safe sludge blanket height in secondary clarifiers. SEM imaging and fractal dimension analysis revealed that the underflow that returned to the system had a more compact and spherical shape, which led to an increased content of granule-like particles in the reactor. The presence of flocs with a diameter exceeding 900 μm in the underflow, which is not observed in the feed, indicated agglomeration within the hydrocyclone. This is contradictory to most of the literature data coming from laboratory experiments. This phenomenon was attributed to differences in the size and geometry of the used hydrocyclones, and the potential process mechanism was presented.
Collapse
Affiliation(s)
- Natalia Gemza
- Faculty of Environmental Engineering, Wroclaw University of Science and Technology, Wybrzeże Wyspiańskiego 27, 50-370 Wroclaw, Poland; Wroclaw Municipal Water and Sewage Company, Na Grobli 19, 50-421 Wroclaw, Poland.
| | - Kamil Janiak
- Faculty of Environmental Engineering, Wroclaw University of Science and Technology, Wybrzeże Wyspiańskiego 27, 50-370 Wroclaw, Poland; Wroclaw Municipal Water and Sewage Company, Na Grobli 19, 50-421 Wroclaw, Poland
| | - Bartosz Zięba
- Faculty of Environmental Engineering, Wroclaw University of Science and Technology, Wybrzeże Wyspiańskiego 27, 50-370 Wroclaw, Poland
| | - Jacek Przyszlak
- Wroclaw Municipal Water and Sewage Company, Na Grobli 19, 50-421 Wroclaw, Poland
| | - Magdalena Kuśnierz
- The Faculty of Environmental Engineering and Geodesy, Wroclaw University of Environmental and Life Sciences, Norwida 25, 50-375 Wroclaw, Poland
| |
Collapse
|
46
|
Yang YR, Wang XD, Chang JS, Lee DJ. Homogeneously and heterogeneously structured biofilm models for wastewater treatment. BIORESOURCE TECHNOLOGY 2022; 362:127763. [PMID: 35964918 DOI: 10.1016/j.biortech.2022.127763] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/26/2022] [Revised: 08/04/2022] [Accepted: 08/06/2022] [Indexed: 06/15/2023]
Abstract
Biofilm, a layer comprising extracellular polymeric substances, is the platform where the embedded living cells degrade the substances in the wastewaters. Biofilm models have been developed as part of the comprehensive models for the wastewater treatment process. This review summarizes the biofilm models applied in contemporary literature based on the spatial dimensions adopted for model build-up. The most commonly applied biofilm models are null-dimensional, considering the biofilm active biomass for the substrate sink's biological reaction. The one-dimensional, multi-species models are the second standard models for contemporary studies, providing transport and reaction resistances of substrates in the biofilm matrix and the interactions of competing or collaborating strains in the biofilm. The structural homogeneity of the biofilm challenges the validity of the uniformly structured models, highlighting the need to re-examine the validity of the uniformly structured models. The challenges and prospects of biofilm model developments and applications are outlined.
Collapse
Affiliation(s)
- Yan-Ru Yang
- Research Center of Engineering Thermophysics, North China Electric Power University, Beijing 102206, China; School of Energy Power and Mechanical Engineering, North China Electric Power University, Beijing 102206, China
| | - Xiao-Dong Wang
- Research Center of Engineering Thermophysics, North China Electric Power University, Beijing 102206, China; School of Energy Power and Mechanical Engineering, North China Electric Power University, Beijing 102206, China
| | - Jo-Shu Chang
- Research Center for Smart Sustainable Circular Economy, Tunghai University, Taichung 407, Taiwan; Department of Chemical Engineering, National Cheng Kung University, Tainan, Taiwan; Department of Chemical and Materials Engineering, Tunghai University, Taichung 407, Taiwan
| | - Duu-Jong Lee
- Department of Mechanical Engineering, City University of Hong Kong, Kowloon Tong, Hong Kong; Department of Chemical Engineering & Materials Science, Yuan Ze University, Chung-Li, 32003, Taiwan.
| |
Collapse
|
47
|
Chen L, Wang XD, Chang JS, Lee DJ. Biofilm with highly heterogeneous interior structure for pollutant removal: Effects of individual extracellular polymeric substance. BIORESOURCE TECHNOLOGY 2022; 361:127669. [PMID: 35878769 DOI: 10.1016/j.biortech.2022.127669] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/14/2022] [Revised: 07/16/2022] [Accepted: 07/18/2022] [Indexed: 06/15/2023]
Abstract
For the first time, this study reveals the effects of an individual component of extracellular polymeric substances on the substrate consumption rates by the embedded cells based on the highly heterogeneous interior structures of a working biofilm. The flow-across mode in operation established a boundary-layer flow field with high transport resistance, making the uniformly structured model valid. Conversely, the flow field of the flow-through mode is determined by 46% jointly by proteins and β-d-glucopyranose polysaccharides. The substrate consumption rates hindered by β-d-glucopyranose polysaccharide is up to 60% over the 20%-40% biofilm height from the bottom, much lower than expected by the uniformly structured models. The strategies to maximize the biofilm performance have been suggested.
Collapse
Affiliation(s)
- Liuyi Chen
- Research Center of Engineering Thermophysics, North China Electric Power University, Beijing 102206, China; School of Energy Power and Mechanical Engineering, North China Electric Power University, Beijing 102206, China
| | - Xiao-Dong Wang
- Research Center of Engineering Thermophysics, North China Electric Power University, Beijing 102206, China; School of Energy Power and Mechanical Engineering, North China Electric Power University, Beijing 102206, China
| | - Jo-Shu Chang
- Research Center for Smart Sustainable Circular Economy, Tunghai University, Taichung 407, Taiwan
| | - Duu-Jong Lee
- Department of Mechanical Engineering, City University of Hong Kong, Kowloon Tong, Hong Kong; Department of Chemical Engineering & Materials Science, Yuan Ze University, Chung-Li 32003, Taiwan.
| |
Collapse
|
48
|
Ilmasari D, Sahabudin E, Riyadi FA, Abdullah N, Yuzir A. Future trends and patterns in leachate biological treatment research from a bibliometric perspective. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2022; 318:115594. [PMID: 35759967 DOI: 10.1016/j.jenvman.2022.115594] [Citation(s) in RCA: 13] [Impact Index Per Article: 6.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/21/2022] [Revised: 06/10/2022] [Accepted: 06/18/2022] [Indexed: 06/15/2023]
Abstract
Leachate has become a great deal of concern due to its complex properties which are primarily caused by the high concentrations of organics and ammonia. Thus, proper leachate treatment is required prior to its discharge. Leachate can be treated in various ways, and biological treatment is one of the approaches. This treatment has been shown to be both effective and cost-efficient while offering the possibility of resource recovery in the form of bioenergy. In this study, the underlying patterns in publications related to leachate biological treatment were uncovered through bibliometric analysis. This study also lays the groundwork for a deeper understanding of the past, current, and future trends of the leachate biological treatment. Research publications from 1974 to 2021 were retrieved from the Scopus database, and it was identified that 2013 articles were published in the span of 47 years. From the analyzed publications, China played a leading role in publishing leachate biological treatment research articles as well as having the most productive institutions and authors. Meanwhile, the USA was found to be the most active country in initiating international collaborations with 33 countries. The research hotspots were also successfully identified using keyword co-occurrences analysis. Anaerobic digestion and constructed wetland were revealed to be the research hotspots. The critical role of biological treatment in removing nitrogen from leachate was also highlighted. Besides, numerous research gaps were identified in the application of aerobic granular sludge (AGS) for leachate treatment. This can be a potential area for research in the future. Finally, future research should be encouraged to focus on the use of sustainable treatment systems in which energy recovery in the form of biogases is promoted.
Collapse
Affiliation(s)
- Dhaneswara Ilmasari
- Department of Chemical and Environmental Engineering (ChEE), Malaysia-Japan International Institute of Technology (MJIIT), Universiti Teknologi Malaysia, Jalan Sultan Yahya Petra, 54100, Kuala Lumpur, Malaysia
| | - Eri Sahabudin
- Department of Chemical and Environmental Engineering (ChEE), Malaysia-Japan International Institute of Technology (MJIIT), Universiti Teknologi Malaysia, Jalan Sultan Yahya Petra, 54100, Kuala Lumpur, Malaysia
| | - Fatimah Azizah Riyadi
- Department of Chemical and Environmental Engineering (ChEE), Malaysia-Japan International Institute of Technology (MJIIT), Universiti Teknologi Malaysia, Jalan Sultan Yahya Petra, 54100, Kuala Lumpur, Malaysia
| | - Norhayati Abdullah
- Department of Chemical and Environmental Engineering (ChEE), Malaysia-Japan International Institute of Technology (MJIIT), Universiti Teknologi Malaysia, Jalan Sultan Yahya Petra, 54100, Kuala Lumpur, Malaysia; UTM International, Aras 8 Menara Razak, Jalan Sultan Yahya Petra, 54100, Kuala Lumpur, Malaysia
| | - Ali Yuzir
- Department of Chemical and Environmental Engineering (ChEE), Malaysia-Japan International Institute of Technology (MJIIT), Universiti Teknologi Malaysia, Jalan Sultan Yahya Petra, 54100, Kuala Lumpur, Malaysia.
| |
Collapse
|
49
|
Watari T, Asano K, Omine T, Hatamoto M, Araki N, Mimura K, Nagano A, Yamaguchi T. Effects of denitrifying granular sludge addition on activated sludge and anaerobic-aerobic systems for municipal sewage treatment. JOURNAL OF ENVIRONMENTAL SCIENCE AND HEALTH. PART A, TOXIC/HAZARDOUS SUBSTANCES & ENVIRONMENTAL ENGINEERING 2022; 57:830-839. [PMID: 36097952 DOI: 10.1080/10934529.2022.2118485] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/21/2022] [Revised: 08/15/2022] [Accepted: 08/18/2022] [Indexed: 06/15/2023]
Abstract
Conventional activated sludge (AS) systems are widely used to treat domestic sewage worldwide. However, the removal of nitrogen in the AS system is limited, and its concentration in the effluent exceeds the recommended values in the discharge standards. In this study, a pilot experiment was conducted to improve nitrogen removal during municipal sewage treatment by operating AS and anaerobic-aerobic (AO) systems under low dissolved oxygen (DO) conditions of less than 0.5 mg L-1 and by adding denitrifying granular sludge. The low DO operation of the AS and AO systems led to the sludge washout and increased the organic content and ammonia and nitrate concentration of the effluent. In contrast, the nitrate concentrations of the effluents produced by the AS and AO systems were 9.4 ± 3.6 and 8.4 ± 0.7 mg-N L-1, respectively, indicated that denitrifying granular sludge addition enhanced denitrification during sewage treatment. The total nitrogen (TN) removal efficiency increased by 13% and 9% for the AS and AO systems despite a decrease in the temperature of 6 °C for the water in the aeration tank. Thus, adding denitrifying granular sludge to the aeration tank is a simple and effective approach to improve organic and nitrogen removal during wastewater treatment.
Collapse
Affiliation(s)
- Takahiro Watari
- Department of Civil and Environmental Engineering, Nagaoka University of Technology, Nagaoka, Niigata, Japan
- Department of Chemical Engineering, Hanoi University of Science and Technology, Hanoi, Vietnam
| | - Kenya Asano
- Department of Civil and Environmental Engineering, Nagaoka University of Technology, Nagaoka, Niigata, Japan
- Department of Civil Engineering, National Institute of Technology (KOSEN), Nagano College, Nagano, Nagano, Japan
| | - Takanori Omine
- Department of Civil and Environmental Engineering, Nagaoka University of Technology, Nagaoka, Niigata, Japan
| | - Masashi Hatamoto
- Department of Civil and Environmental Engineering, Nagaoka University of Technology, Nagaoka, Niigata, Japan
| | - Nobuo Araki
- Department of Civil Engineering, National Institute of Technology (KOSEN), Nagaoka College, Nagaoka, Niigata, Japan
- National Institute of Technology (KOSEN), Ichinoseki College, Ichinoseki, Iwate, Japan
| | - Kazuhisa Mimura
- Technical Research and Development Institute, Sanki Engineering Co., Ltd, Yamato, Kanagawa, Japan
| | - Akihiro Nagano
- Technical Research and Development Institute, Sanki Engineering Co., Ltd, Yamato, Kanagawa, Japan
| | - Takashi Yamaguchi
- Department of Civil and Environmental Engineering, Nagaoka University of Technology, Nagaoka, Niigata, Japan
- Department of Science of Technology Innovation, Nagaoka University of Technology, Nagaoka, Niigata, Japan
| |
Collapse
|
50
|
Fast Granulation by Combining External Sludge Conditioning with FeCl 3 Addition and Reintroducing into an SBR. Polymers (Basel) 2022; 14:polym14173688. [PMID: 36080762 PMCID: PMC9460750 DOI: 10.3390/polym14173688] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/17/2022] [Revised: 08/31/2022] [Accepted: 09/01/2022] [Indexed: 11/16/2022] Open
Abstract
The separation of light and heavy sludge, as well as the aggregation rate of floccular sludge, are two critical aspects of the rapid granulation process in sequencing batch reactors (SBRs) in the early stages. In this study, we investigated the impact of a method to improve both sludge separation and granulation by coupling effluent sludge external conditioning with FeCl3 addition and then reintroducing it into the SBR. By supplementation with 0.1 g Fe3+ (g dried sludge (DS))−1, the concentration of extracellular polymeric substances (EPS) and sludge retention efficiency greatly increased, whereas the moisture content and specific oxygen uptake rate (SOUR) sharply decreased within 24 h external conditioning. Aggregates (1.75 ± 0.05 g·L−1) were reintroduced into the bioreactor once daily from day 13 to day 15. Afterwards, on day 17, aerobic granules with a concentration of mixed liquor suspended solids (MLSS) of 5.636 g/L, a sludge volume index (SVI30) of 45.5 mL/g and an average size of 2.5 mm in diameter were obtained. These results suggest that the external conditioning step with both air-drying and the addition of Fe3+ enhanced the production of EPS in the effluent sludge and improved rapid aggregation and high sludge retention efficiency. Consequently, the reintroduced aggregates with good traits shortened the time required to obtain mature aerobic granular sludge (AGS) and properly separate light and heavy sludge. Indeed, this method jump-started the aggregation, and rapid granulation processes were successful in this work. Additionally, while the removal efficiency of chemical oxygen demand (COD) and nitrogen from ammonium (NH4+-N) decreased when reintroducing the treated sludge into the SBR, such properties increased again as the AGS matured in the SBR, up to removal efficiencies of 96% and 95%, respectively.
Collapse
|