1
|
Cufadar Y, Golzar Adabi S, Gül ET, Nollet L. Effects of graded levels of dietary microbial 6-phytase on performance, intestinal histomorphology, caecal microbial population and short-chain fatty acid composition of Lohmann white-classics. Br Poult Sci 2024:1-10. [PMID: 38995214 DOI: 10.1080/00071668.2024.2352835] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/08/2024] [Accepted: 03/09/2024] [Indexed: 07/13/2024]
Abstract
1. This study was conducted to determine the effects of graded levels of phytase on the performance, egg quality and gut health of white laying hens.2. Treatments consisted of a negative control (NC) diet containing 0.14% available phosphorus (avP), positive control (PC) diet containing 0.35% avP provided via dicalcium phosphate (DCP) and DCP replaced in the PC by with three graded levels of phytase derived from Komagataella phaffii at 500 (PC-500), 750 (PC-750) and 1000 (PC-1000) FTU/kg which provided 0.176%, 0.188% and 0.200% of avP, respectively.3. Egg production, feed intake, feed conversion ratio and jejunal morphometry were negatively affected in NC-fed birds (p < 0.05). Considering the whole period, birds fed a diet supplemented with graded levels of phytase shared the same egg production and feed intake levels with PC birds (p < 0.05). Feed conversion ratio was significantly lowered by 4.9%, 1.6% and 7.6% in hens fed on diets PC-500, PC-750 and PC-1000, respectively compared to those fed the PC (p < 0.05).4. Neither of the dietary treatments affected cracked eggs, dirty eggs, eggshell breaking strength and eggshell thickness. Dietary supplementation of phytase significantly increased villus surface area by 15%, 36% and 40% in PC-500, PC-750 and PC-1000 birds, respectively compared to PC (p < 0.05).5. A significant increase in lactobacillus count was observed in line with increasing the level of phytase (p < 0.05). Dietary treatments had no effect on the caecal coliform or aerobic populations. Furthermore, phytase supplementation significantly increased the concentrations of total caecal short-chain fatty acid (SCFA; p < 0.01).6. In conclusion, along with improving performance parameters, the inclusion of phytase in laying hen diets can ameliorate intestinal morphology and stimulate caecal microflora and increase SCFA concentrations.
Collapse
Affiliation(s)
- Y Cufadar
- Department of Animal Science, Feeds and Animal Nutrition, Faculty of Agriculture, Selçuk University, Konya, Türkiye
| | - S Golzar Adabi
- Advanced Technologies Supplies, Şişli/Istanbul, Türkiye
- Avesa Nutrition, Ankara, Türkiye
| | - E T Gül
- Department of Animal Science, Feeds and Animal Nutrition, Faculty of Agriculture, Selçuk University, Konya, Türkiye
| | | |
Collapse
|
2
|
Sobotik EB, House GM, Stiewert AM, Bello A, Dersjant-Li Y, Marchal L, Archer GS. Effects of a Novel Consensus Bacterial 6-Phytase Variant on Growth Performance and Bone Ash of Broilers Fed Complex Diets Highly Deficient in Minerals, Digestible Amino Acids and Energy through 42 Days of Age. Animals (Basel) 2024; 14:1563. [PMID: 38891610 PMCID: PMC11171212 DOI: 10.3390/ani14111563] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/21/2024] [Revised: 05/08/2024] [Accepted: 05/14/2024] [Indexed: 06/21/2024] Open
Abstract
An experiment was conducted to evaluate the effects of increasing the dose of a novel consensus bacterial 6-phytase variant expressed in Trichoderma reesei (PhyG) in broilers fed complex diets highly deficient in minerals, dig AA, and energy. Diets were a nutrient-adequate control (PC); a nutrient-reduced control (NC) formulated with a reduction in available P (avP) by 0.199%, Ca by 0.21%, crude protein by 0.72-1.03%, dig Lys by 0.064-0.084%, Na by 0.047%, and ME by 87.8 kcal/kg, respectively; and NC supplemented with PhyG at 500, 1000, and 2000 FTU/kg feed. BW was decreased and FCR increased in the NC vs. PC, while the PhyG treatments were similar to the PC. Carcass yield and bone ash were also maintained with PhyG supplementation. Phytase provided economic benefit on a feed cost per kg of weight basis for 1 to 35 d; the cost reductions equated to USD 0.006, 0.016, and 0.02/kg BWG at 500, 1000, and 2000 FTU/kg. In conclusion, this trial demonstrated that supplementation with a novel consensus phytase variant in diets highly deficient in minerals, dig AA, and energy maintained growth performance and provided economic benefit, with production benefits being maximized at inclusion levels of 2000 FTU/kg.
Collapse
Affiliation(s)
- Eric B. Sobotik
- Poultry Science Department, Texas A&M University, College Station, TX 77843, USA (G.M.H.)
| | - Gabrielle M. House
- Poultry Science Department, Texas A&M University, College Station, TX 77843, USA (G.M.H.)
| | - Austin M. Stiewert
- Poultry Science Department, Texas A&M University, College Station, TX 77843, USA (G.M.H.)
| | - Abiodun Bello
- Danisco Animal Nutrition, IFF, 2342 BH Oegstgeest, The Netherlands
| | | | - Leon Marchal
- Danisco Animal Nutrition, IFF, 2342 BH Oegstgeest, The Netherlands
- Animal Nutrition Group, Wageningen University & Research, 2342 BH Oegstgeest, The Netherlands
| | - Gregory S. Archer
- Poultry Science Department, Texas A&M University, College Station, TX 77843, USA (G.M.H.)
| |
Collapse
|
3
|
Shi H, Lopes T, Tompkins YH, Liu G, Choi J, Sharma MK, Kim WK. Effects of phytase supplementation on broilers fed with calcium and phosphorus-reduced diets, challenged with Eimeria maxima and Eimeria acervulina: influence on growth performance, body composition, bone health, and intestinal integrity. Poult Sci 2024; 103:103511. [PMID: 38340661 PMCID: PMC10869301 DOI: 10.1016/j.psj.2024.103511] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/07/2023] [Revised: 01/23/2024] [Accepted: 01/24/2024] [Indexed: 02/12/2024] Open
Abstract
An experiment was conducted to evaluate the effects of phytase in calcium (Ca) and available phosphorous (avP)-reduced diet on growth performance, body composition, bone health, and intestinal integrity of broilers challenged with Eimeria maxima and Eimeria acervulina. A total of 672 14-day-old male broilers were allocated to a 2 × 4 factorial arrangement with 6 replicates per treatment and 14 birds per replicate. Two factors were Eimeria challenge and 4 dietary treatments: 1) a positive control (PC; 0.84% Ca and 0.42% avP); 2) a negative control (NC; 0.74% Ca and 0.27% avP); 3) NC + 500 FTU/Kg of phytase (NC + 500PHY); and 4) NC + 1,500 FTU/Kg of phytase (NC + 1500PHY). On d 14, birds in the Eimeria-challenged groups received a solution containing 15,000 sporulated oocysts of E. maxima and 75,000 sporulated oocysts of E. acervulina via oral gavage. At 5 d postinoculation (DPI), the challenged birds showed a higher (P < 0.01) FITC-d level than the unchallenged birds. While the permeability of the NC group did not differ from the PC group, the phytase supplementation groups (NC + 500PHY and NC + 1500PHY) showed lower (P < 0.05) serum FITC-d levels compared to the NC group. Interaction effects (P < 0.05) of Eimeria challenge and dietary treatments on feed intake (FI), mucin-2 (MUC2) gene expression, bone ash concentration, and mineral apposition rate (MAR) were observed. On 0 to 6 and 0 to 9 DPI, Eimeria challenge decreased (P < 0.01) body weight (BW), body weight gain (BWG), FI, bone mineral density (BMD), bone mineral content (BMC), bone area, fat free bone weight (FFBW), bone ash weight, bone ash percentage and bone ash concentration; and it showed a higher FCR (P < 0.01) compared to the unchallenged group. The reduction Ca and avP in the diet (NC) did not exert adverse effects on all parameters in birds, and supplementing phytase at levels of 500 or 1,500 FTU/Kg improved body composition, bone mineralization, and intestinal permeability, with the higher dose of 1,500 FTU/Kg showing more pronounced enhancements. There was an observed increase in FI (P < 0.01) when phytase was supplemented at 1,500 FTU/Kg during 0 to 6 DPI. In conclusion, results from the current study suggest that dietary nutrients, such as Ca and avP, can be moderately reduced with the supplementation of phytase, particularly in birds infected with Eimeria spp., which has the potential to save feed cost without compromising growth performance, bone health, and intestinal integrity of broilers.
Collapse
Affiliation(s)
- Hanyi Shi
- Department of Poultry Science, University of Georgia, Athens, GA, 30602, USA
| | - Taina Lopes
- Department of Poultry Science, Auburn University, Auburn, AL, 36849, USA
| | - Yuguo Hou Tompkins
- Department of Poultry Science, University of Georgia, Athens, GA, 30602, USA
| | - Guanchen Liu
- Department of Poultry Science, University of Georgia, Athens, GA, 30602, USA
| | - Janghan Choi
- US National Poultry Research Center, United States Department of Agriculture Agricultural Research Service, Athens, GA, 30605, USA
| | - Milan Kumar Sharma
- Department of Poultry Science, University of Georgia, Athens, GA, 30602, USA
| | - Woo Kyun Kim
- Department of Poultry Science, University of Georgia, Athens, GA, 30602, USA.
| |
Collapse
|
4
|
Osunbami OT, Walk CL, Adeola O. Digestible calcium equivalency of phytase and nutrient utilization of broiler chickens fed graded levels of limestone or phytase during the starter phase. Poult Sci 2024; 103:103360. [PMID: 38160615 PMCID: PMC10792742 DOI: 10.1016/j.psj.2023.103360] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/21/2023] [Revised: 11/28/2023] [Accepted: 12/04/2023] [Indexed: 01/03/2024] Open
Abstract
The current study aimed to quantify the digestible calcium (Ca) equivalency of a new phytase (HiPhorius) in broiler chickens. A total of 1,152 male Cobb 500 broiler chickens were used in an experiment in which 8 diets consisting of graded levels of Ca supplied with limestone or graded levels of the phytase were fed. The 8 dietary treatments were based on a corn-soybean meal diet containing 5.1 g/kg of Ca and 5.1 g/kg of phosphorus (P) as negative control (NC); the NC + 1.3, 2.6, or 3.9 g/kg of Ca from limestone; and the NC + 500, 1,000, 2,000, or 4,000 FYT/kg of phytase. Birds were fed the experimental diets for 3 d (from d 7 to 10) or 14 d (from d 7 to 21) to determine apparent ileal digestibility (AID) and apparent total tract retention (ATTR) of dry matter (DM), CP, Ca, and P. In the 10-day-old birds, increasing the levels of Ca decreased the AID of P and Ca (linear, P < 0.05). Increasing the levels of phytase quadratically improved (P < 0.05) the AID of Ca and P. The AID of DM and CP in the younger birds quadratically increased (P < 0.05) as the levels of Ca increased. There were linear and quadratic effects (P < 0.05) of increasing phytase level for the AID of DM and a linear effect (P < 0.05) for the AID of CP. In the 21-day-old birds, increasing Ca levels resulted in a linear decrease (P < 0.05) in the AID of CP and P, and a quadratic decrease (P < 0.05) in the ATTR of CP. Increasing phytase levels linearly and quadratically (P < 0.05) improved the AID and ATTR of CP, P, and the ATTR of Ca. The analyzed phytase activity in the diets supplemented with phytase ranged from 1,520 to 7,661 FYT/kg. The digestible Ca equivalence for dietary phytase at 1,520 to 7,661 FYT/kg ranged from 1.55 to 2.02 g/kg in the 10-day-old birds fed for 3 d and from 0.52 to 0.64 g/kg in 21-day-old birds fed for 14 d. The results showed the reduction in Ca level that could be accommodated by phytase supplementation, which is markedly different between the younger and older birds. Feeding duration influenced the impact of phytase supplementation on Ca and P digestibility, with better efficacy of phytase observed in the 10-day-old birds fed for 3 d. Also, the results showed the extra-phosphoric effects of phytase on the utilization of other essential nutrients such as protein and Ca.
Collapse
Affiliation(s)
- O T Osunbami
- Department of Animal Sciences, Purdue University, West Lafayette, IN 47907, USA
| | - C L Walk
- DSM Nutritional Products, Kaiseraugst, Switzerland
| | - O Adeola
- Department of Animal Sciences, Purdue University, West Lafayette, IN 47907, USA.
| |
Collapse
|
5
|
Ahmadi M, Ghasemi HA, Hajkhodadadi I, Khaligh F. Effect of an Escherichia coli-derived phytase and a carbohydrase-protease cocktail derived from Bacillus spp. on performance, digestibility, bone mineralization and gut morphology in broilers fed different nutrient density diets. Vet Med Sci 2024; 10:e1344. [PMID: 38227704 PMCID: PMC10790325 DOI: 10.1002/vms3.1344] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/23/2023] [Revised: 08/27/2023] [Accepted: 12/10/2023] [Indexed: 01/18/2024] Open
Abstract
BACKGROUND Enzyme combinations, particularly phytase (PHY) with various carbohydrases and proteases, are utilized in commercial broiler production to enhance nutrient and energy bioavailability. OBJECTIVE A feeding study was undertaken to determine whether the efficiency of an Escherichia coli-derived PHY and a feed enzyme complex (FEC) derived from Bacillus spp. containing carbohydrase and protease as main activities in broiler chickens is dependent on diet quality. A total of 900 male one-day-old broiler chickens (Ross 308) were assigned to a 2 × 3 factorial arrangement of the treatments with 2 different nutrient density diets, standard nutrient diet (SN diet) and a low-nutrient diet (LN diet; -100 kcal/kg for AMEn and -5% for crude protein [CP] and limiting amino acids), and 3 enzyme treatments (control [no enzymes], PHY and PHY + FEC). Each treatment group was composed of 6 replicates of 25 birds each. RESULTS The LN diet caused a decrease in performance index, tibia length and diameter, tibia calcium content and jejunal villus surface area (VSA). The interaction effects between diet and enzyme supplementation were observed (p < 0.05) on overall average daily gain (ADG), performance index, tibia ash content and jejunal villus height (VH) and VSA, with the favourable benefits of PHY + FEC treatment being more pronounced in the LN diets. Regardless of dietary nutrient density, supplementation with PHY alone or combined with FEC enhanced (p < 0.05) final body weight, overall ADG and jejunal villus height (VH)/crypt depth, with the highest values observed in the PHY + FEC group. The PHY + FEC treatment also improved (p < 0.05) overall feed conversion ratio, apparent ileal digestibility of dry matter, organic matter, CP, and energy, and tibia phosphorus content compared to the control treatment. CONCLUSIONS The results indicate that the simultaneous addition of PHY and FEC to the LN diets improved the growth rate, bone mineralization and gut morphology.
Collapse
Affiliation(s)
- Mostafa Ahmadi
- Department of Animal ScienceFaculty of Agriculture and EnvironmentArak UniversityArakIran
| | - Hossein Ali Ghasemi
- Department of Animal ScienceFaculty of Agriculture and EnvironmentArak UniversityArakIran
| | - Iman Hajkhodadadi
- Department of Animal ScienceFaculty of Agriculture and EnvironmentArak UniversityArakIran
| | - Farhad Khaligh
- Department of Animal ScienceFaculty of AgricultureFerdowsi University of MashhadMashhadIran
| |
Collapse
|
6
|
David LS, Anwar MN, Abdollahi MR, Bedford MR, Ravindran V. Calcium Nutrition of Broilers: Current Perspectives and Challenges. Animals (Basel) 2023; 13:ani13101590. [PMID: 37238019 DOI: 10.3390/ani13101590] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/27/2023] [Revised: 05/08/2023] [Accepted: 05/08/2023] [Indexed: 05/28/2023] Open
Abstract
Calcium (Ca) plays an essential role in poultry nutrition as 99% of Ca is located in birds' skeletal system. However, oversupply of Ca rather than deficiency of Ca is the current concern in commercial broiler diets. Calcium is an inexpensive dietary nutrient due to the cheap and abundant availability of limestone, the major Ca source; therefore, little attention was given to the oversupply of Ca in the past. The recent shift in the use of digestible P in broiler feed formulations has necessitated a closer look at digestible Ca, as Ca and P are interrelated in their absorption and postabsorptive utilisation. In this context, data on ileal digestibility of Ca and P in ingredients has been determined. Preliminary data on the digestible Ca and digestible P requirements for the different growth stages of broilers have also recently become available. The present review focusses on these recent advances in Ca nutrition. In addition, aspects of homeostatic control mechanisms, different Ca sources and factors influencing Ca digestibility in poultry are covered.
Collapse
Affiliation(s)
- Laura Shiromi David
- Monogastric Research Centre, School of Agriculture and Environment, Massey University, Palmerston North 4442, New Zealand
| | - M Naveed Anwar
- Monogastric Research Centre, School of Agriculture and Environment, Massey University, Palmerston North 4442, New Zealand
- Van Den Brink Poultry Ltd., Christchurch 7677, New Zealand
| | - M Reza Abdollahi
- Monogastric Research Centre, School of Agriculture and Environment, Massey University, Palmerston North 4442, New Zealand
| | | | - Velmurugu Ravindran
- Monogastric Research Centre, School of Agriculture and Environment, Massey University, Palmerston North 4442, New Zealand
| |
Collapse
|
7
|
Moradi S, Abdollahi MR, Moradi A, Jamshidi L. Effect of Bacterial Phytase on Growth Performance, Nutrient Utilization, and Bone Mineralization in Broilers Fed Pelleted Diets. Animals (Basel) 2023; 13:ani13091450. [PMID: 37174487 PMCID: PMC10177589 DOI: 10.3390/ani13091450] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/05/2023] [Revised: 03/14/2023] [Accepted: 03/20/2023] [Indexed: 05/15/2023] Open
Abstract
The influence of a bacterial 6-phytase on growth performance, coefficient of apparent ileal digestibility (CAID) of nutrients, blood parameters, and bone mineralization in broilers was evaluated. A total of 630 one-day-old male broilers were allocated to 7 dietary treatments, including positive control (PC) diet containing dicalcium phosphate, the PC marginally reduced in available P (avP) by 0.1% and calcium (Ca) by 0.2% vs. PC (NC1) or moderately reduced by 0.15 and 0.3% vs. PC (NC2), respectively, and four further diets comprising the NC1 and NC2 supplemented with 500 or 1000 FTU/kg of phytase in starter and finisher phases. A constant Ca to avP ratio was maintained across all diets. The body weight gain (BWG) and feed per unit gain (FCR) of birds fed NC1 and NC2 diets supplemented with phytase (500 and 1000 U/kg) was equivalent to that of birds fed the PC diet at 35 days. Phytase supplementation in the NC1 diet linearly increased the CAID of nitrogen (N) (p < 0.01), phosphorus (P) (p < 0.01), and Ca (p < 0.05). Additionally, phytase reduced (p < 0.01) excreta P concentration by approximately 27%, improved (p < 0.001) toe ash, and tended to increase tibia ash (p = 0.08), comparable with the PC. In conclusion, the addition of bacterial 6-phytase dosed in the range of 500-1000 FTU/kg was effective in replacing 1.5 g/kg avP and 3 g/kg Ca in broilers fed pelleted diets, using bone quality, BWG, and FCR as outcome measures.
Collapse
Affiliation(s)
- Soudabeh Moradi
- Department of Animal Science, Faculty of Agriculture and Natural Resources, Razi University, Kermanshah 85438-67156, Iran
| | - Mohammad Reza Abdollahi
- Monogastric Research Center, School of Agriculture and Environment, Massey University, Private Bag 11 222, Palmerston North 4442, New Zealand
| | - Arash Moradi
- Department of Animal Science, Faculty of Agriculture and Natural Resources, Razi University, Kermanshah 85438-67156, Iran
| | - Leili Jamshidi
- Department of Animal Science, College of Agriculture, Ilam University, Ilam 516-69315, Iran
| |
Collapse
|
8
|
Sobotik EB, House GM, Stiewert AM, Bello A, Dersjant-Li Y, Shoesmith E, Remus J, Archer GS. Evaluating a novel consensus bacterial 6-phytase variant on growth performance of broilers fed U.S. commercial diets deficient in nutrients and energy through 63 days of age. J Anim Sci 2023; 101:skac407. [PMID: 36516414 PMCID: PMC9904173 DOI: 10.1093/jas/skac407] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/24/2022] [Accepted: 12/09/2022] [Indexed: 12/15/2022] Open
Abstract
An experiment was conducted to evaluate the efficacy of a novel consensus bacterial 6-phytase variant expressed in Trichoderma reesei (PhyG) in broilers fed corn-soybean meal-based diets with application of dose-specific full nutrient and energy matrix values. Ross 708, straight-run broilers (n = 2,016) were assigned to one of 7 dietary treatments, with 12 replicate pens/diet and 24 birds/pen. Diets were a nutrient adequate control (PC), nutrient reduced negative controls 1, 2, and 3 (NC1, NC2, and NC3) with reductions in available phosphorus (avP) by 0.15%, 0.18%, and 0.19%, calcium (Ca) by 0.17%, 0.20%, and 0.21%, dig amino acids (AA) by 0.02%-0.05%, sodium (Na) by 0.03%-0.05%, and metabolizable energy (ME) by 62.8, 68.8, and 69.5 kcal/kg, respectively. Other diets were the NC1, NC2, and NC3 respectively supplemented with 500 (PhyG500), 1,000 (PhyG1000), and 2,000 (PhyG2000) FTU/kg. Over the 63-day feeding period, decreasing nutrient specifications lowered body weights (P < 0.05) in broilers from 4,518 g in PC to 4,256 g and 4,191 g and increased body weight-corrected feed conversion ratio (FCR, P < 0.05) from 1.92 in PC to 2.06 and 2.08 in the NC2 and NC3, respectively. Compared with PC, PhyG maintained (P > 0.05) BW in broilers fed PhyG500 (4,474 g), PhyG1000 (4,417 g), and PhyG2000 (4,449 g). Moreover, PhyG at all dose-levels maintained (P > 0.05) overall FCR vs. PC. The NC1, NC2, and NC3 diets decreased (P < 0.05) tibia ash vs. PC, and each PhyG500, PhyG1000, and PhyG2000 completely restored tibia ash to the similar levels (P > 0.05) as the PC. Carcass yield was decreased (P < 0.05) by NC1 (80.63%), NC2 (80.51%), and NC3 (80.31%) vs. PC (81.96%) with complete alleviation by PhyG500 (82.11%), PhyG1000 (81.80%), and PhyG2000 (81.54%). In conclusion, the novel consensus phytase variant completely compensated for the reduction in dietary avP, Ca, dig AA, and ME at each dose-level and maintained growth performance, bone quality, carcass characteristics, and nutrient digestibility in a typical corn-soybean mean based diet fed to broilers through 63 days of age.
Collapse
Affiliation(s)
- E B Sobotik
- Poultry Science Department, Texas A&M University, College Station, TX 77843, USA
| | - G M House
- Poultry Science Department, Texas A&M University, College Station, TX 77843, USA
| | - A M Stiewert
- Poultry Science Department, Texas A&M University, College Station, TX 77843, USA
| | - A Bello
- Danisco Animal Nutrition, IFF, 2342 BH Oegstgeest, the Netherlands
- Danisco Animal Nutrition, IFF, Wilmington, DE 19803, USA
| | - Y Dersjant-Li
- Danisco Animal Nutrition, IFF, 2342 BH Oegstgeest, the Netherlands
| | - E Shoesmith
- Danisco Animal Nutrition, IFF, 2342 BH Oegstgeest, the Netherlands
| | - J Remus
- Danisco Animal Nutrition, IFF, Wilmington, DE 19803, USA
| | - G S Archer
- Poultry Science Department, Texas A&M University, College Station, TX 77843, USA
| |
Collapse
|
9
|
Bello A, Kwakernaak C, Dersjant-Li Y. Effects of limestone solubility on the efficacy of a novel consensus bacterial 6-phytase variant to improve mineral digestibility, retention, and bone ash in young broilers fed low-calcium diets containing no added inorganic phosphate. J Anim Sci 2022; 100:skac337. [PMID: 36239636 PMCID: PMC9746795 DOI: 10.1093/jas/skac337] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/20/2022] [Accepted: 10/11/2022] [Indexed: 12/15/2022] Open
Abstract
This study evaluated the effect of limestone solubility on the capacity of a novel consensus bacterial 6-phytase variant (PhyG) to improve phosphorus (P) and calcium (Ca) digestibility, retention, and utilization in low-Ca broiler diets containing no added inorganic phosphate (Pi). Male Ross 308 broilers (n = 1,152) were fed one of 16 experimental diets from 11 to 21 d of age in a randomized complete design (12 birds/cage, 6 cages/treatment). Diets comprised three positive controls (PC3, PC2, and PC1) containing 1.8, 1.2, or 0.6 g/kg MCP-P and 7.7, 7.0, or 6.2 g/kg Ca, respectively, and a negative control (NC) containing no added Pi (4.4 g/kg P; 2.8 g/kg phytate-P) and 5.5 g/kg Ca from either low or high solubility limestone (LSL or HSL, respectively, [with 42% and 97% solubility after 5 min at pH 3.0]), supplemented with 0, 250, 500, 1,000, or 2,000 FTU/kg of PhyG. Fecal samples collected on days 18 to 20 and ileal digesta collected on day 21 were analyzed for titanium dioxide, Ca, P, and phytate (IP6, inositol hexakisphosphate). Tibias (day 21) were analyzed for ash content. Data were analyzed by factorial analysis (2 limestone solubilities × 4 MCP-P levels and 2 limestone solubilities × 5 phytase dose levels) and exponential regression. Increasing dose levels of PhyG resulted in an exponential increase (P < 0.01) in the apparent ileal digestibility (AID) of P, ileal digestible P content of the diet, ileal IP6 content, and IP6 disappearance in birds fed either HSL or LSL diets, but AID Ca and ileal digestible Ca were exponentially increased by the phytase only in HSL diets (P < 0.01). Relative to HSL, the LSL increased AID P, ileal digestible P, and IP6 disappearance (P < 0.05) but reduced AID Ca, ileal digestible Ca, and retainable Ca (P < 0.05), resulting in reduced retainable P and tibia ash. Phytase exponentially increased the apparent total tract digestibility of P, retainable P, and tibia ash in HSL and LSL diets, but at or above 500 FTU/kg values were higher in HSL than LSL (interaction P < 0.05). The findings highlight that phytase dose-response effects on mineral digestibility and utilization are different for high- and low-solubility limestones, and it is therefore recommended to use digestible rather than total Ca content during diet formulation to ensure an optimal balance of Ca and P, especially in low-Ca diets. In diets containing HSL, higher phytase dose levels may be needed to compensate for the low digestible P content of the basal diet.
Collapse
Affiliation(s)
- Abiodun Bello
- Danisco Animal Nutrition and Health, IFF, Wilmington, 19803 DE, USA
| | | | - Yueming Dersjant-Li
- Danisco Animal Nutrition and Health, IFF, 2342 BH Oegstgeest, The Netherlands
| |
Collapse
|
10
|
Mirisakhani L, Taheri H. Interactive effect of calcium, citric acid, and high-dose phytase on performance of broiler chicken fed diet severely limited in phosphorus. Anim Feed Sci Technol 2022. [DOI: 10.1016/j.anifeedsci.2022.115512] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/06/2022]
|
11
|
Hernandez JR, Gulizia JP, Adkins JB, Rueda MS, Haruna SI, Pacheco WJ, Downs KM. Effect of Phytase Level and Form on Broiler Performance, Tibia Characteristics, and Residual Fecal Phytate Phosphorus in Broilers from 1 to 21 Days of Age. Animals (Basel) 2022; 12:ani12151952. [PMID: 35953941 PMCID: PMC9367546 DOI: 10.3390/ani12151952] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/03/2022] [Revised: 07/29/2022] [Accepted: 07/29/2022] [Indexed: 11/16/2022] Open
Abstract
The present study evaluated the individual and combined effects of coated and uncoated phytase on broiler performance, tibia characteristics, and residual phytate phosphorus (P) in manure. Two repeated studies were conducted using 240-day-old Cobb 500 by-product male broilers per trial. For each trial, birds were assigned to four treatments with four replicate battery cages per treatment (60 birds/trt) and grown for 21 days. Treatments included: (1) negative control (NC), (2) NC + 1000 phytase units (FTU) coated phytase (C), (3) NC + 1000 FTU uncoated phytase (U), and (4) NC + 500 FTU coated + 500 FTU uncoated phytase (CU). Data were analyzed with a one-way ANOVA and means were separated using Tukey’s HSD. In the pooled data for both trials, all treatments with dietary phytase had a higher body weight (BW) and feed consumption (FC) than the NC on day 21 (p < 0.05). Similarly, a six-point reduction was observed for day 1 to 21 feed conversion (FCR) for U and CU (p < 0.05). All treatments with phytase inclusion differed from the NC in every evaluated parameter for bone mineralization (p < 0.05) and had significantly lower fecal phytate P concentrations compared to the NC (p < 0.05). Overall, bird performance was essentially unaffected by phytase form, indicating that combining phytase forms does not appear to offer any advantage to the evaluated parameters from day 1 to 21.
Collapse
Affiliation(s)
- Jose R. Hernandez
- Department of Poultry Science, Auburn University, Auburn, AL 36849, USA; (J.R.H.); (J.P.G.); (M.S.R.); (W.J.P.)
| | - Joseph P. Gulizia
- Department of Poultry Science, Auburn University, Auburn, AL 36849, USA; (J.R.H.); (J.P.G.); (M.S.R.); (W.J.P.)
| | - John B. Adkins
- School of Agriculture, Middle Tennessee State University, Murfreesboro, TN 37132, USA; (J.B.A.); (S.I.H.)
| | - Martha S. Rueda
- Department of Poultry Science, Auburn University, Auburn, AL 36849, USA; (J.R.H.); (J.P.G.); (M.S.R.); (W.J.P.)
| | - Samuel I. Haruna
- School of Agriculture, Middle Tennessee State University, Murfreesboro, TN 37132, USA; (J.B.A.); (S.I.H.)
| | - Wilmer J. Pacheco
- Department of Poultry Science, Auburn University, Auburn, AL 36849, USA; (J.R.H.); (J.P.G.); (M.S.R.); (W.J.P.)
| | - Kevin M. Downs
- School of Agriculture, Middle Tennessee State University, Murfreesboro, TN 37132, USA; (J.B.A.); (S.I.H.)
- Correspondence:
| |
Collapse
|
12
|
Javadi M, Cerisuelo A, Cambra-López M, Macías-Vidal J, Donadeu A, Dupuy J, Carpintero L, Ferrer P, Pascual JJ. The Duration of the Trial Influences the Effects of Mineral Deficiency and the Effective Phytase Dose in Broilers' Diets. Animals (Basel) 2022; 12:ani12111418. [PMID: 35681882 PMCID: PMC9179909 DOI: 10.3390/ani12111418] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/16/2022] [Revised: 05/27/2022] [Accepted: 05/27/2022] [Indexed: 11/16/2022] Open
Abstract
Two trials varying in duration (short- and long-term) were conducted to evaluate the effects of providing deficient (NC) or sufficient (PC) Ca and P levels, and different doses of a new phytase (250, 500, and 1000 FTU/kg feed), in broiler feed on growth performance, nutrient digestibility and retention, and tibia mineralization. A total of 80 and 490 male chicks (Ross) of 21 and 1 days of age were used in the short- and long-term trials, respectively. In the long-term trial, chicks fed NC diets showed a lower (p < 0.05) average daily gain and feed intake compared to chicks fed PC and a greater (p < 0.05) feed conversion ratio compared to 500 and 1000 FTU/kg feed during the starting period. Regarding the effects on minerals’ and nutrients’ coefficients of retention, animals fed NC showed a significantly higher digestibility for P than those fed the PC diet in the long-term trial. Additionally, feeding 250 to 500 FTU/kg diets increased most of the nutrients’ digestibility in the short-term but only P digestibility in the long-term trial. Tibia mineralization increased linearly with phytase addition (p < 0.05) only in the long-term trial. In conclusion, the effects of dietary mineral and phytase levels on growth performance are more noticeable in young animals. In addition, the duration of the trial is key due to a possible adaptation phenomenon of birds to low P supplementary levels.
Collapse
Affiliation(s)
- Mehran Javadi
- Institute for Animal Science and Technology, Universitat Politècnica de València, Camino de Vera s/n, 46022 Valencia, Spain; (M.J.); (M.C.-L.); (J.J.P.)
| | - Alba Cerisuelo
- Centro de Investigación y Tecnología Animal, Instituto Valenciano de Investigaciones Agrarias, 12400 Segorbe, Spain;
- Correspondence: ; Tel.: +34-964-712166
| | - María Cambra-López
- Institute for Animal Science and Technology, Universitat Politècnica de València, Camino de Vera s/n, 46022 Valencia, Spain; (M.J.); (M.C.-L.); (J.J.P.)
| | - Judit Macías-Vidal
- Departamento de I+D+i, Global Feed S.L.U., Grupo Tervalis, Av. Francisco Montenegro s/n, 21001 Huelva, Spain; (J.M.-V.); (A.D.); (J.D.); (L.C.)
| | - Andrés Donadeu
- Departamento de I+D+i, Global Feed S.L.U., Grupo Tervalis, Av. Francisco Montenegro s/n, 21001 Huelva, Spain; (J.M.-V.); (A.D.); (J.D.); (L.C.)
| | - Javier Dupuy
- Departamento de I+D+i, Global Feed S.L.U., Grupo Tervalis, Av. Francisco Montenegro s/n, 21001 Huelva, Spain; (J.M.-V.); (A.D.); (J.D.); (L.C.)
| | - Laura Carpintero
- Departamento de I+D+i, Global Feed S.L.U., Grupo Tervalis, Av. Francisco Montenegro s/n, 21001 Huelva, Spain; (J.M.-V.); (A.D.); (J.D.); (L.C.)
| | - Pablo Ferrer
- Centro de Investigación y Tecnología Animal, Instituto Valenciano de Investigaciones Agrarias, 12400 Segorbe, Spain;
| | - Juan José Pascual
- Institute for Animal Science and Technology, Universitat Politècnica de València, Camino de Vera s/n, 46022 Valencia, Spain; (M.J.); (M.C.-L.); (J.J.P.)
| |
Collapse
|
13
|
Hakami Z, Sulaiman ARA, Alharthi AS, Casserly R, Bouwhuis MA, Abudabos AM. Growth performance, carcass and meat quality, bone strength, and immune response of broilers fed low-calcium diets supplemented with marine mineral complex and phytase. Poult Sci 2022; 101:101849. [PMID: 35390569 PMCID: PMC8987615 DOI: 10.1016/j.psj.2022.101849] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/06/2021] [Revised: 02/28/2022] [Accepted: 02/28/2022] [Indexed: 12/05/2022] Open
Abstract
Influence of marine mineral complex (CeltiCal) as a partial substitute for limestone on growth efficiency, carcass traits, meat quality, bone strength, calcium (Ca) retention, and immune response was investigated in broilers fed low-Ca diets with or without phytase (PHY) addition for a 35-d trial period. A total of 300 one-day-old Ross 308 straight-run broilers were randomly allocated to: T1 (positive control), recommended Ca levels + PHY; T2 (negative control), 0.2% below the recommended Ca levels + PHY; T3, 0.1% below the recommended Ca levels + 0.2% CeltiCal + PHY; T4, 0.2% below the recommended Ca levels + 0.4% CeltiCal + PHY; T5, 0.2% below the recommended Ca levels + 0.4% CeltiCal. PHY was added at 500 phytase units/kg diets. Each dietary treatment had 10 replications of 6 chicks each. Results revealed that production efficiency factor was greater for T4 compared to T2 and T5 during 22-35 d and for T1, T3, and T4 compared to T2 during 0 to 35 d (P < 0.05). Feed conversion ratio was lower for T3 and T4 compared to T2 and T5 during 0 to 35 d (P < 0.05). T4 had a greater (P < 0.05) dressing percentage than T2, which had a lighter (P < 0.01) small intestinal relative weight than all other treatments. Breast meat temperature at 15 min postmortem was highest for T1 and lowest for T3 (P < 0.001). Breast meat pH was greater for T1 compared to T5 at 15 min postmortem and for T3 compared to T4 at 24 h postmortem (P < 0.05). T5 had a lower breast meat redness than all other treatments at 15 min postmortem and then T1 and T3 at 24 h postmortem (P < 0.01). Tibia and femur weights were greater (P < 0.05) for T3, T4, and T5 compared to T2, which had the lowest tibia ash content (P < 0.05) and femur geometric properties (P < 0.001). Greater antibodies to infectious bronchitis virus (P < 0.01) and Ca retention (P < 0.001) were observed for T3 and T4 in comparison to T2. Based on the findings of this research, CeltiCal can adequately replace a considerable portion of limestone in broiler reduced-Ca diets containing PHY.
Collapse
|
14
|
Bello A, Dersjant-Li Y, van Eerden E, Kwakernaak C, Marchal L. Supplementation of an all-plant-based inorganic phosphate-free diet with a novel phytase maintained tibia ash and performance in broilers under a commercial production setting. J APPL POULTRY RES 2022. [DOI: 10.1016/j.japr.2022.100253] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022] Open
|
15
|
Dersjant-Li Y, Bello A, Esteve-Garcia E, Creus CR, Marchal L. A novel consensus bacterial 6-phytase variant added to phytate-rich diets totally replaced inorganic phosphate in broilers. JOURNAL OF APPLIED ANIMAL NUTRITION 2022. [DOI: 10.3920/jaan2021.0011] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/19/2022]
Abstract
The capacity of a novel bacterial 6-phytase variant (PhyG) to totally replace dietary supplemental inorganic phosphate (Pi) in broilers aged one day old was evaluated using a phased dosing strategy and reduction in dietary phytate. A total of 1,248 one-day-old Ross 308 broilers were assigned to 24 pens (52 birds/pen, 12 pens/diet, six each males and females) in a complete randomised block design with a 2×2 factorial arrangement (two diets, two genders). Diets comprised: (1) a positive control (PC) based on maize, wheat and soybean meal, containing Pi from monocalcium phosphate and 2,000 XU/kg xylanase, and; (2) an inorganic phosphate-free (IPF) diet equivalent to PC but with reduced Ca (-2.0 g/kg) and supplemented with PhyG at 3,000, 2,000 and 1000 FTU/kg from d 0 to 11 (3.4 g/kg phytate-P (PP)), d 11 to 22 (3.3 g/kg PP) and d 22 to 42 (2.8 to 2.9 g/kg PP), respectively. A negative control was not included for animal welfare reasons. Tibias were collected on d 11, 22 and 42 from two birds/pen. Treatment IPF maintained or improved average daily gain (ADG), average daily feed intake and feed conversion ratio (FCR) vs PC during all phases; Body weight was higher in the IPF treatment than the PC at d 42 (+3.97%, P<0.01) and ADG during d 0 to 42 (+4.10%, P<0.01). Overall (d 0 to 42), treatment IPF improved FCR in males (-5 points vs PC, P<0.05) but not females. Tibia ash was equivalent in IPF and PC throughout, with no gender differences. In conclusion, when applied as a phased dosing strategy to diets with graded reduction in PP content, PhyG totally replaced supplemental Pi during all growth phases in males and females.
Collapse
Affiliation(s)
- Y. Dersjant-Li
- Danisco Animal Nutrition & Health, IFF, Willem Einthovenstraat 4, 2342 BH Oegstgeest, the Netherlands
| | - A. Bello
- Danisco Animal Nutrition & Health, IFF, Willem Einthovenstraat 4, 2342 BH Oegstgeest, the Netherlands
| | | | | | - L. Marchal
- Danisco Animal Nutrition & Health, IFF, Willem Einthovenstraat 4, 2342 BH Oegstgeest, the Netherlands
- Animal Nutrition Group, Wageningen University & Research, De Elst 1, 6708 WD Wageningen, the Netherlands
| |
Collapse
|
16
|
Gilani S, Mereu A, Li W, Plumstead P, Angel R, Wilks G, Dersjant-Li Y. Global survey of limestone used in poultry diets: calcium content, particle size and solubility. JOURNAL OF APPLIED ANIMAL NUTRITION 2022. [DOI: 10.3920/jaan2021.0015] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/19/2022]
Abstract
Limestone is used in poultry diets as a calcium (Ca) source. Feed formulation is often based on an estimate of limestone Ca content or, less frequently, wet chemistry analysis. However, limestone composition may vary, which has not previously been studied on a large scale. In this study, 641 limestone samples supplied to poultry feed mills in 40 countries across eight global regions were collected and analysed for macro- and micromineral content, particle size (geometric mean diameter, GMD), and in vitro solubility. Mean Ca content of fine limestone (GMD<1000 μm, n=566) was 37.8% (range 33.3-39.7%) and for coarse limestone (GMD>1000 μm, n=75) was 38.0% (range 34.7-40.0%). There was marked variation among and within regions in the concentration of other macro minerals and microminerals. Particle size (GMD) of fine limestone was 288 μm (range 37.7-991.9 μm) and 1,689 mm for coarse limestone (range 301.6-3,067.9 μm). In vitro solubility of fine limestone (5 min incubation, pH=3.0) was 68.4% (range 18.8 to 99.4%). Particle size only explained 52% of the variation in 5 min incubation solubility (R2=0.52). For coarse limestone, mean solubility (30 min incubation) was 65.5% (range 23.2-96%) which was not correlated (R2=0.09) with particle size. Particle size and solubility rate of limestone have been shown to alter Ca and phosphorus utilisation in broilers and laying hens. Hence, better understanding of variation in mineral analysis, particle size and solubility rate would enable more accurate feed inclusion and subsequently digestibility to support health and performance.
Collapse
Affiliation(s)
- S. Gilani
- Danisco Animal Nutrition and Health (IFF), Willem Einthovenstraat 4, 2342 BH Oegstgeest, the Netherlands
| | - A. Mereu
- Danisco Animal Nutrition and Health (IFF), Willem Einthovenstraat 4, 2342 BH Oegstgeest, the Netherlands
| | - W. Li
- Danisco Animal Nutrition and Health (IFF), Willem Einthovenstraat 4, 2342 BH Oegstgeest, the Netherlands
| | - P.W. Plumstead
- Chemuniqué (Pty) Ltd, Lanseria Business Park, 28 Eagle Lane, 1739 Lanseria, South Africa
| | - R. Angel
- Department of Animal and Avian Sciences, University of Maryland, College Park, MD 20742, USA
| | - G. Wilks
- Chemuniqué (Pty) Ltd, Lanseria Business Park, 28 Eagle Lane, 1739 Lanseria, South Africa
| | - Y. Dersjant-Li
- Danisco Animal Nutrition and Health (IFF), Willem Einthovenstraat 4, 2342 BH Oegstgeest, the Netherlands
| |
Collapse
|
17
|
Babatunde OO, Bello A, Dersjant-Li Y, Adeola O. Evaluation of the responses of broiler chickens to varying concentrations of phytate phosphorus and phytase. Ⅰ. Starter phase (day 1-11 post hatching). Poult Sci 2021; 100:101396. [PMID: 34454357 PMCID: PMC8399047 DOI: 10.1016/j.psj.2021.101396] [Citation(s) in RCA: 7] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/11/2021] [Revised: 07/13/2021] [Accepted: 07/21/2021] [Indexed: 12/03/2022] Open
Abstract
Growth performance, tibia ash, apparent ileal digestibility (AID), and total tract retention (TTR) of nutrients responses of broiler chickens fed diets containing varying concentrations of phytate P (PP) and a novel consensus bacterial 6-phytase variant (PhyG) from d 1 to 11 post hatching were evaluated with 1,152 broiler chicks. Diets were a nutrient-adequate positive control diet (PC) with 2.8 g PP/kg or one of 15 nutrient-reduced negative control (NC: PC minus 88 kcal/kg ME, 0.8 g/kg dig. Lys, 2.0 g/kg available P, 1.8 g/kg Ca and 0.5 g/kg Na) diets with 3 PP (g/kg) levels, mainly from rice bran, at 2.3 (NC1), 2.8 (NC2), or 3.3 (NC3) and 5 PhyG supplementation at 0, 500, 1,000, 2,000, or 4,000 FTU/kg in a 1 + 3 × 5 factorial. All treatments had 6 replicate cages with 12 birds per cage. Despite comparable PP levels, birds fed the PC diet had greater (P ≤ 0.01) body weight (BW), feed intake (FI), tibia ash, AID of energy, AA, P, and Ca as compared with birds fed the NC2 without phytase. There was no interaction between PP and phytase for all responses. Increasing PP concentrations linearly decreased (P < 0.01) BW, FI, AID, and TTR of P and Ca. With phytase supplementation, there was a quadratic response (P < 0.05) in BW, FI, tibia ash, and a linear increase (P < 0.05) in the AID of energy, nitrogen, and all the measured AA. Increasing phytase dose from 0 to 4,000 FTU/kg increased (P < 0.01) AID of P and Ca by 88 and 18%, respectively. There was also a quadratic response (P ≤ 0.05) on TTR of P and Ca with increasing phytase dose. In conclusion, increasing levels of PP reduced growth performance and most nutrient utilization responses of broiler chickens while phytase supplementation positively impacted the responses of broiler chickens during d 1 to 11 post hatching.
Collapse
Affiliation(s)
- O O Babatunde
- Department of Animal Sciences, Purdue University, West Lafayette, IN, 47907, USA
| | - A Bello
- Danisco Animal Nutrition, Oegstgeest, 2342 BH, The Netherlands
| | - Y Dersjant-Li
- Danisco Animal Nutrition, Oegstgeest, 2342 BH, The Netherlands
| | - O Adeola
- Department of Animal Sciences, Purdue University, West Lafayette, IN, 47907, USA.
| |
Collapse
|
18
|
Dersjant-Li Y, Bello A, Esteve-Garcia E, Ramírez Creus C, Marchal L. A novel consensus bacterial 6-phytase variant totally replaced supplemental inorganic phosphate from one day of age in both male and female broilers. Br Poult Sci 2021. [PMID: 33988059 DOI: 10.1080/00071668.2021.1929841] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/21/2022]
Abstract
1. This study tested the capacity of a novel consensus bacterial 6-phytase variant (PhyG) to totally replace dietary supplemental inorganic phosphate (Pi) in broilers from one day of age, using a phased dosing strategy for the phytase and a phased reduction in phytate content of the diet. A 2x2 factorial arrangement including two treatments and two genders was used.2. A total of 1,248, one-day-old Ross 308 broilers were assigned to 24 floor pens (52 birds/pen). Two treatments included: 1) a positive control diet (PC) based on mixed grains and oilseed meals, containing inorganic phosphorus (Pi) from monocalcium phosphate (MCP) and 2,000 XU/kg xylanase, and; 2) an inorganic P free (IPF) diet reformulated without Pi, reduced in Ca (-2.0 g/kg) vs. PC and supplemented with PhyG at 3,000 FTU/kg in starter (d 0 to 11, 3.4 g/kg phytate-P (PP)), 2,000 FTU/kg in grower (d 11 to 22, 3.3 g/kg PP), and 1,000 FTU/kg in finisher 1 (d 22 to d 35, 2.9 g/kg PP) and finisher 2 (d 35 to d 42, 2.8 g/kg PP) phase. Each treatment was assigned to 12 pens, with six pens containing males and six containing females. Tibia samples were collected on d 11, 22 and 42 from two birds per pen.3. The IPF treatment maintained or improved ADG, ADFI and FCR compared to PC in all feed phases. IPF increased BW at 42 days of age by 3.97% (P<0.01) and ADG from d 0 to 42 by 4.10% (P<0.01), and reduced corresponding FCR by 1.5 points (P<0.05), respectively, vs. PC. Males exhibited higher BW, ADG and ADFI than females from 11 d of age onwards (P<0.05). An interaction (P<0.05) between treatment and gender was observed for FCR (d 0 to 22, d 0 to 42) and FCRc (body weight corrected FCR, d 0 to 42), whereby IPF treatment reduced (P<0.05) FCR vs. PC in males but not in females. Tibia ash from birds fed IPF was equivalent to PC at 11, 22 and 42 d of age and did not differ between males and females.4.The data demonstrated that the phytase, when applied in a phased dosing-regimen to broiler diets with a graded reduction in phytate-P content, was effective in totally replacing Pi during all growth phases, as determined by performance and tibia ash from both males and females.
Collapse
Affiliation(s)
- Yueming Dersjant-Li
- Danisco Animal Nutrition (IFF), Willem Einthovenstraat 4, 2342 BH Oegstgeest, The Netherlands
| | - Abiodun Bello
- Danisco Animal Nutrition (IFF), Willem Einthovenstraat 4, 2342 BH Oegstgeest, The Netherlands
| | | | | | - Leon Marchal
- Danisco Animal Nutrition (IFF), Willem Einthovenstraat 4, 2342 BH Oegstgeest, The Netherlands
| |
Collapse
|
19
|
Performance and ileal amino acid digestibility in broilers fed diets containing solid-state fermented and enzyme-supplemented canola meals. Anim Feed Sci Technol 2021. [DOI: 10.1016/j.anifeedsci.2021.114876] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/24/2022]
|
20
|
Dersjant-Li Y, Davin R, Christensen T, Kwakernaak C. Effect of two phytases at two doses on performance and phytate degradation in broilers during 1-21 days of age. PLoS One 2021; 16:e0247420. [PMID: 33765064 PMCID: PMC7993876 DOI: 10.1371/journal.pone.0247420] [Citation(s) in RCA: 7] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/24/2020] [Accepted: 02/07/2021] [Indexed: 11/18/2022] Open
Abstract
The effect of two microbial phytases at two dose-levels on performance and apparent ileal digestibility (AID) of nutrients in broilers fed European-type diets was studied. A total of 1,200 d-old Ross 308 male broilers were randomly assigned to 5 treatments with 30 birds/pen and 8 pens/treatment. A nutritionally adequate positive control (PC) diet was tested against 4 experimental diets containing reduced total P, retainable P, Ca and Na as per the recommended nutritional contribution for Buttiauxella phytase (Phy B) at 1,000 FTU/kg (-1.87 g/kg, -1.59 g/kg, -1.99 g/kg and -0.4 g/kg vs. PC, respectively). Experimental diets were supplemented with Phy B at 500 FTU/kg or 1,000 FTU/kg, or Citrobacter phytase (Phy C) at 1,000 FTU/kg or 2,000 FTU/kg. Diets were based on corn, soybean meal, rapeseed meal and sunflower meal and formulated by phase (starter 1–10 d, grower 11–21 d) in crumbled or pelleted form. Overall (d 1–21), at 1,000 FTU/kg, birds fed Phy C exhibited lower BWG (-2.7%), FI (-3.4%) and tibia ash (-2.2%) vs. PC (P < 0.05), and reduced BWG (-3.6%), FI (-3.9%) and tibia ash (-1.8%) vs. Phy B (P < 0.05). Phy B at 1,000 FTU/kg and Phy C at 2,000 FTU/kg maintained performance equivalent to the PC. Digestibility of Ca did not differ among phytase treatments but at 1,000 FTU/kg AID P was greater with Phy B than Phy C (72.3% vs. 62.7%, P < 0.05). Ileal phytate (myo-inositol hexakisphosphate, IP6) digestibility was greatest with Phy B at 1,000 FTU/kg which was higher than Phy C at 1,000 FTU/kg (87.6 vs. 60.6%, P < 0.05). The findings indicate a higher phytate degradation rate of Phy B than Phy C at equivalent dose-level and this is correlated to the performance of the broilers.
Collapse
Affiliation(s)
| | - Roger Davin
- Schothorst Feed Research, Lelystad, The Netherlands
| | | | | |
Collapse
|
21
|
Krieg J, Borda-Molina D, Siegert W, Sommerfeld V, Chi YP, Taheri HR, Feuerstein D, Camarinha-Silva A, Rodehutscord M. Effects of calcium level and source, formic acid, and phytase on phytate degradation and the microbiota in the digestive tract of broiler chickens. Anim Microbiome 2021; 3:23. [PMID: 33722307 PMCID: PMC7962351 DOI: 10.1186/s42523-021-00083-7] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/10/2020] [Accepted: 02/08/2021] [Indexed: 11/21/2022] Open
Abstract
BACKGROUND Diet acidification, dietary calcium (Ca) level, and phytase supplementation are known influences on the microbial community in the digestive tract and on phosphorus (P) utilization of broiler chickens. Effects of dietary factors and microbiota on P utilization may be linked because microorganisms produce enzymes that release P from phytate (InsP6), the main source of P in plant feedstuffs. This study aimed to detect linkages between microbiota and InsP6 degradation by acidifying diets (i.e., replacing Ca carbonate (CaCO3) by Ca formate or adding formic acid to CaCO3-containing diets), varying Ca levels, and supplementing phytase in a three-factorial design. We investigated i) the microbial community and pH in the digestive tract, ii) prececal (pc) P and Ca digestibility, and iii) InsP6 degradation. RESULTS All factors under investigation influenced digesta pH and the microbiota composition. Predicted functionality and relative abundance of microorganisms indicated that diets influenced the potential contribution of the microbiota on InsP degradation. Values of InsP6 degradation and relative abundance of the strains Lactobacillus johnsonii and Lactobacillus reuteri were correlated. Phytase supplementation increased pc InsP6 disappearance, with differences between Ca levels, and influenced concentrations of lower inositol phosphate isomers in the digestive tract. Formic acid supplementation increased pc InsP6 degradation to myo-inositol. Replacing CaCO3 by Ca-formate and the high level of these Ca sources reduced pc InsP6 disappearance, except when the combination of CaCO3 + formic acid was used. Supplementing phytase to CaCO3 + formic acid led to the highest InsP6 disappearance (52%) in the crop and increased myo-inositol concentration in the ileum digesta. Supplementing phytase leveled the effect of high Ca content on pc InsP6 disappearance. CONCLUSIONS The results point towards a contribution of changing microbial community on InsP6 degradation in the crop and up to the terminal ileum. This is indicated by relationships between InsP6 degradation and relative abundance of phosphatase-producing strains. Functional predictions supported influences of microbiota on InsP6 degradation. The extent of such effects remains to be clarified. InsP6 degradation may also be influenced by variation of pH caused by dietary concentration and solubility of the Ca in the feed.
Collapse
Affiliation(s)
- Jochen Krieg
- Institute of Animal Science, University of Hohenheim, 70599 Stuttgart, Germany
| | - Daniel Borda-Molina
- Institute of Animal Science, University of Hohenheim, 70599 Stuttgart, Germany
| | - Wolfgang Siegert
- Institute of Animal Science, University of Hohenheim, 70599 Stuttgart, Germany
| | - Vera Sommerfeld
- Institute of Animal Science, University of Hohenheim, 70599 Stuttgart, Germany
| | - Yung Ping Chi
- Institute of Animal Science, University of Hohenheim, 70599 Stuttgart, Germany
| | - Hamid Reza Taheri
- Institute of Animal Science, University of Hohenheim, 70599 Stuttgart, Germany
- Department of Animal Science, Faculty of Agriculture, University of Zanjan, Zanjan, 45371-38791 Iran
| | | | | | - Markus Rodehutscord
- Institute of Animal Science, University of Hohenheim, 70599 Stuttgart, Germany
| |
Collapse
|
22
|
Marchal L, Bello A, Sobotik EB, Archer G, Dersjant-Li Y. A novel consensus bacterial 6-phytase variant completely replaced inorganic phosphate in broiler diets, maintaining growth performance and bone quality: data from two independent trials. Poult Sci 2021; 100:100962. [PMID: 33652522 PMCID: PMC7936205 DOI: 10.1016/j.psj.2020.12.059] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/21/2020] [Revised: 11/11/2020] [Accepted: 12/20/2020] [Indexed: 01/17/2023] Open
Abstract
Total replacement of dietary inorganic phosphate (Pi) by a novel consensus bacterial 6-phytase variant (PhyG) in phytate-rich diets (>0.3% phytate-P) was investigated in 2 trials using growth performance and bone quality as outcome measures. Both trials utilized a completely randomized design with 5 dietary treatments across 4 phases: starter (0-10 d), grower (10-21 d), finisher 1 (21-35 d), and finisher 2 (35-42 d). Treatments comprised a nutritionally adequate positive control (PC) diet containing monocalcium phosphate and 4 experimental diets (IPF1, IPF2, IPF3, and IPF4), all containing no added Pi and reduced in Ca by 0.2 to 0.3% units vs. PC. IPF1contained PhyG at 1,000 FTU/kg (all phases); IPF2 contained PhyG at 1,000 FTU/kg (all phases) and was additionally reduced in digestible AA, ME, and sodium (-0.2 to -0.4% points, -74 kcal/kg, -0.04% points, respectively, vs. PC); IPF3 contained PhyG at 3,000 FTU/kg in starter, 2,000 FTU/kg in grower, and 1,000 FTU/kg in finisher phases; and IPF4 contained xylanase (2,000 U/kg) and PhyG (2,000 FTU/kg in starter, 1,500 FTU/kg in grower, and 1,000 FTU/kg in finisher phases) and was additionally reduced in ME (-71 kcal/kg vs. PC). Ross 308 broilers were used (trial 1: n = 1,200 mixed sex; 24 birds per pen × 10 replicates; trial 2: n = 1,300 males; 26 birds × 10 replicates). During all phases in both trials, all IPF treatments maintained or improved BW, ADG, ADFI, FCR and BW-corrected FCRc and bone quality parameters vs. PC. vs. PC, treatment IPF3 increased ADG during starter phase (+10.8%) and reduced overall FCRc (-12 points, P < 0.05) in Trial 1, and increased overall ADG (+4.4%), day 35 and day 42 BW (+3.5%, +4.9%), and reduced overall FCRc (-11 points) in Trial 2 (P < 0.05). IPF4 produced equivalent performance to IPF3 (both trials). These are the first data to demonstrate total replacement of Pi by microbial phytase during an entire growth cycle in broiler diets.
Collapse
Affiliation(s)
- L Marchal
- Animal Nutrition, DuPont Nutrition and Biosciences, 2342 BH Oegstgeest, the Netherlands; Animal Nutrition Group, Wageningen University & Research, Wageningen, the Netherlands.
| | - A Bello
- Animal Nutrition, DuPont Nutrition and Biosciences, 2342 BH Oegstgeest, the Netherlands
| | - E B Sobotik
- Department of Poultry Science, Texas A&M University, College Station, 77843-2472 USA
| | - G Archer
- Department of Poultry Science, Texas A&M University, College Station, 77843-2472 USA
| | - Y Dersjant-Li
- Animal Nutrition, DuPont Nutrition and Biosciences, 2342 BH Oegstgeest, the Netherlands
| |
Collapse
|
23
|
Zhu X, Liu J, Yang G. Effects of soybean oligosaccharide, stachyose, and raffinose on growth performance and cecal microbiota in broiler chickens. Anim Sci J 2021; 92:e13668. [PMID: 34881496 DOI: 10.1111/asj.13668] [Citation(s) in RCA: 6] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/24/2021] [Revised: 10/19/2021] [Accepted: 11/10/2021] [Indexed: 12/30/2022]
Abstract
This study was conducted to examine the effects of soybean oligosaccharide, stachyose, and raffinose on growth performance and cecal microbiota in broiler chickens. Three-hundred 1-day-old Arbor Acres broiler chickens were randomly assigned to five dietary treatments: a basal diet (control diet); diets supplemented with soybean oligosaccharide, stachyose, or raffinose at levels of 0.6% total sugar content; and diet with soybean meals (positive control). Results showed that feed-to-gain ratio (F/G) was improved (p < 0.05) in broiler chickens that received stachyose, but not raffinose, while addition of soybean oligosaccharide to the diet significantly (p < 0.05) resulted in decreases in the average daily feed intake (ADFI) and average daily gain (ADG). Supplementation with soybean oligosaccharide, stachyose, or raffinose had a positive effect (p < 0.05) on the nutrient digestibility, but not on the blood immune parameters (p > 0.05). The results of the gene sequencing indicated that, at the family level, Ruminococcaceae, Lachnospiraceae, and Lactobacillaceae were comparatively present in all the treatments but the cecal microbial composition was changed after dietary addition of different oligosaccharides. Our study had led to a greater understanding of prebiotic effects of these oligosaccharides on growth and intestinal health.
Collapse
Affiliation(s)
- Xin Zhu
- College of Animal Science and Veterinary Medicine, Shenyang Agricultural University, Shenyang, China
| | - Jizhe Liu
- College of Animal Science and Veterinary Medicine, Shenyang Agricultural University, Shenyang, China
| | - Guiqin Yang
- College of Animal Science and Veterinary Medicine, Shenyang Agricultural University, Shenyang, China
| |
Collapse
|
24
|
Taheri H, Abbasi M. Effect of high-dose phytase and low calcium concentration on performance of broiler chicken given diet severely limited in nonphytate phosphorus. J APPL POULTRY RES 2020. [DOI: 10.1016/j.japr.2020.07.004] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/17/2022] Open
|
25
|
Jlali M, Cozannet P, Alleno C, Preynat A. Evaluation of a multicarbohydrase and phytase complex in reduced energy, amino acids, available phosphorus and calcium diets fed to broilers. Livest Sci 2020. [DOI: 10.1016/j.livsci.2020.104227] [Citation(s) in RCA: 6] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/16/2022]
|
26
|
Davin R, Kwakernaak C, Dersjant-Li Y. Effect of two commercial limestone sources with different solubility on the efficacy of two phytases in 0-21 d old broilers. JOURNAL OF APPLIED ANIMAL NUTRITION 2020. [DOI: 10.3920/jaan2020.0003] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 01/20/2023]
Abstract
A study evaluated the effects of limestone sources with different solubility on the efficacy of two phytases in broilers. A 2×5 factorial arrangement was employed with two commercial limestone sources and five diet treatments; a positive control (PC) diet with 7.2 g/kg P and 9.6 g/kg Ca, and a negative control diet containing reductions of 1.87 g/kg available P, 1.99 g/kg Ca and 0.4 g/kg Na, supplemented with either Buttiauxella phytase (PhyB) or Escherichia coli phytase (PhyE) at 500 or 1000 FTU/kg diet. The two limestone sources were feed-grade commercial products with different particle sizes and solubility (fast-soluble (FS) 100%; slow-soluble (SS) 26% soluble after 30 minutes at pH 3) containing similar levels of Ca. Diets were fed to one-day-old Ross 308 males (n=2,400) with 30 birds/pen and eight pens/treatment in two phases (starter 0-10 d and grower 10-21 d). On d 21, ileal digesta was collected from 12 birds/pen to determine apparent ileal digestibility (AID) of P and Ca, and myo-inositol hexakisphosphate (IP6) disappearance, and tibias from four birds/pen for ash determination. The SS limestone improved body weight gain (BWG), feed intake (FI) and FCR vs FS limestone in starter/grower phases (P<0.05), and improved AID of P (P<0.05) and IP6 disappearance (P<0.05) at d 21. There was an interaction between limestone and phytase on BWG, FI and FCR in the grower phase (P≤0.05) whereby FS (vs SS) limestone reduced BWG at either dose of PhyE, but only at 500 FTU/kg of PhyB. At an equivalent dose, PhyB had higher BWG and feed intake than PhyE (P<0.05). At 1000 FTU/kg, performance was equivalent (BWG and FI) or superior (FCR) to the PC, PhyB produced greater tibia ash, AID of P and IP6 disappearance (P<0.05). The findings showed that the effects of limestone particle size on phytase efficacy varied with phytase source and dose.
Collapse
Affiliation(s)
- R. Davin
- Schothorst Feed Research, P.O. Box 553, 8200 AM Lelystad, the Netherlands
| | - C. Kwakernaak
- Schothorst Feed Research, P.O. Box 553, 8200 AM Lelystad, the Netherlands
| | - Y. Dersjant-Li
- DuPont Animal Nutrition, DuPont Nutrition and Biosciences, Archimedesweg 30, 2333 CN Leiden, the Netherlands
| |
Collapse
|
27
|
Functionality of a next generation biosynthetic bacterial 6-phytase in enhancing phosphorus availability to broilers fed a corn-soybean meal-based diet. Anim Feed Sci Technol 2020. [DOI: 10.1016/j.anifeedsci.2020.114481] [Citation(s) in RCA: 9] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/13/2022]
|
28
|
Bello A, Dersjant-Li Y, Korver DR. The efficacy of 2 phytases on inositol phosphate degradation in different segments of the gastrointestinal tract, calcium and phosphorus digestibility, and bone quality of broilers. Poult Sci 2020; 98:5789-5800. [PMID: 31265114 PMCID: PMC6771769 DOI: 10.3382/ps/pez375] [Citation(s) in RCA: 17] [Impact Index Per Article: 4.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/18/2019] [Accepted: 06/11/2019] [Indexed: 11/20/2022] Open
Abstract
The anti-nutritional effects of dietary inositol phosphates (IP6 through IP3) have been recognized in broiler chickens; however, inositol hexaphosphate (IP6) is more potent than the lower IP esters. The efficacies of 2 commercial phytases, a Buttiauxella sp. phytase (BSP) and a Citrobacter braakii phytase (CBP) at 500 and 1,000 FTU/kg, were studied on IP6-3 concentrations in the crop, proventriculus + gizzard, and distal ileum digesta, and ileal IP6 disappearance in broilers at day 22. Apparent ileal P and Ca digestibility, and bone quality at days 22 and 33 were also measured. Female Ross 308 broilers (n = 1,890; 30 birds × 7 diets × 9 replicates) were fed corn-soy-based crumbled diets. The 7 diets included a primary breeder recommendation-based positive control diet (PC); the PC marginally reduced in available P by 0.146% and Ca by 0.134% of the diet, (NC1) or moderately reduced by 0.174 and 0.159% of the diet, respectively (NC2). Other diets were the NC1 + BSP or CBP at 500 FTU/kg (NC1+500BSP and NC1+500CBP) and the NC2 + BSP or CBP at 1,000 FTU/kg (NC2+1,000BSP and NC2+1,000CBP). Each of the NC1 and NC2 had distal ileum IP6 disappearance similar to that of PC, but each had lower P digestibility and the majority of measured bone quality parameters than the PC. The ileal IP6 levels were decreased by 52.0 and 32.7% for NC1+500BSP and NC1+500CBP, respectively, relative to NC1 and by 73.6 and 50.9% for NC2+1,000BSP and NC2+1,000CBP, respectively, relative to NC2 (P < 0.001), with a similar effect for distal ileum IP6 disappearance. Overall, phytase in the NC diets increased P digestibility, and femur breaking strength and cortical bone mineral density at days 22 and 33. Overall, each of the phytases at each dose degraded IP6-3 across the gastrointestinal tract segments to increase P digestibility and the P and Ca utilization in bone. However, dietary BSP at 1,000 FTU/kg was most effective. Supplemental phytase degrades phytate to decrease the anti-nutritional effects in a dose- and phytase-dependent manner.
Collapse
Affiliation(s)
- A Bello
- Department of Agricultural, Food and Nutritional Science, University of Alberta, Edmonton, AB T6G 2P5, Canada.,DuPont Animal Nutrition, Nutrition & Biosciences Archimedesweg 30, 2333 CN Leiden, Netherlands
| | - Y Dersjant-Li
- DuPont Animal Nutrition, Nutrition & Biosciences Archimedesweg 30, 2333 CN Leiden, Netherlands
| | - D R Korver
- Department of Agricultural, Food and Nutritional Science, University of Alberta, Edmonton, AB T6G 2P5, Canada
| |
Collapse
|
29
|
Bingtong L, Yongliang Z, Liping S. Identification and characterization of the peptides with calcium-binding capacity from tilapia (Oreochromis niloticus) skin gelatin enzymatic hydrolysates. J Food Sci 2019; 85:114-122. [PMID: 31869867 DOI: 10.1111/1750-3841.14975] [Citation(s) in RCA: 26] [Impact Index Per Article: 5.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/15/2019] [Revised: 10/15/2019] [Accepted: 10/24/2019] [Indexed: 11/28/2022]
Abstract
The aim of this study was to isolate and identify the peptides with calcium-binding capacity from the different tilapia skin gelatin enzymatic hydrolysates. The complex protease was selected and its hydrolysates were further separated using gel filtration chromatography (Sephadex G-25) and reverse phase high-performance liquid chromatography. Two purified peptides with strong calcium-binding capacity were identified as Tyr-Gly-Thr-Gly-Leu (YGTGL, 509.25 Da) and Leu-Val-Phe-Leu (LVFL, 490.32 Da). The calcium-binding capacities of YGTGL and LVFL reached 76.03 and 79.50 µg/mg, respectively. The structures of the complex of purified peptides and calcium (YGTGL-Ca and LVFL-Ca) were characterized by ultraviolet-visible spectroscopy (UV-VIS), scanning electron microscopy (SEM), X-ray diffraction (XRD), Fourier transform infrared spectroscopy (FTIR), and mass spectrometry (LC-MS/MS). The results of UV-VIS, SEM, and XRD indicated that YGTGL-Ca and LVFL-Ca were formed as new compounds. The results of FTIR and LC-MS/MS indicated the nitrogen atom of the amino group and the oxygen atom of the carboxyl group in terminates of the peptides provided primary binding sites. Moreover, the hydrophobic amino acids in purified peptides could provide more chelating spaces. This study was of great significance for the development of calcium supplement foods. PRACTICAL APPLICATION: Compared with inorganic calcium and organic calcium, the bioactive gelatin peptide chelated calcium has the characteristics of high utilization rate, high solubility, and high absorption rate. The raw materials are extracted from the tilapia processed waste, which reduce the cost, make full use of resources, and improve the bioavailability. The tilapia skin gelatin peptide calcium chelate can be directly absorbed by the human body, and the absorption efficiency is high, further improving the resource utilization rate and having high economic benefits, which is a comprehensive supplement that can also be used as a functional food.
Collapse
Affiliation(s)
- Liu Bingtong
- Yunnan Inst. of Food Safety, Kunming Univ. of Science and Technology, No. 727 South Jingming Road, Kunming, Yunnan, 650500, China
| | - Zhuang Yongliang
- Yunnan Inst. of Food Safety, Kunming Univ. of Science and Technology, No. 727 South Jingming Road, Kunming, Yunnan, 650500, China
| | - Sun Liping
- Yunnan Inst. of Food Safety, Kunming Univ. of Science and Technology, No. 727 South Jingming Road, Kunming, Yunnan, 650500, China
| |
Collapse
|
30
|
Effect of different phytases derived from E. coli AppA gene on the performance, bone mineralisation and nutrient digestibility of broiler chicken. JOURNAL OF APPLIED ANIMAL NUTRITION 2019. [DOI: 10.1017/jan.2019.6] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.4] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/06/2022]
Abstract
AbstractThis study evaluated the effects of three different thermostable phytase variants, based on the AppA gene fromE. coli(AppAT1, AppAT2 and AppAT3) on growth performance, nutrient digestibility and bone mineralisation in broiler chickens at inclusion levels of 250 and 500 FTU/kg. The eight treatment groups included a positive control (PC) which was sufficient in Ca and P, a negative control (NC, the same basal formulation as the PC, but reduced in Ca and P), and NC supplemented with AppAT1 at 250 and 500 FTU/kg (AppAT1-250 and AppAT1-500), AppAT2 at 250 and 500 FTU/kg (AppAT2-250 and AppAT2-500) and with AppAT3 at 250 and 500 FTU/kg (AppAT3-250 and AppAT3-500). Over the entire feeding period, body weight (BW) and average daily gain (ADG) were significantly higher in the PC group, with all phytase supplemented groups being statistically the same, compared to the NC group. Feed conversion (FCR) for the PC-fed birds (1.479) was significantly (P<0.05) better compared to the NC birds (1.582) and those fed the AppAT3-250 diet (1.523). Reduced levels of Ca and P in the NC group led to significantly (P<0.05) lower tibia ash (40.9%) compared to the PC group (47.4%). Birds fed the phytase diets had significantly higher tibia ash compared to the NC birds, with those from the AppAT2-500 and AppAT3-500 groups being statistically the same as the PC group. Diets AppAT1-500, AppAT2-250, AppAT2-500 and AppAT3-500 significantly increased Ca digestibility compared to the NC. Apparent total track digestibility (ATTD) of P was improved for AppAT1-500 and AppAT2-250. The ATTD of Ca and P for all of the phytase supplemented groups reached the same level of the PC and AppAT1-500 group. It was concluded that adding any of the phytases tested, especially when included at 500 FTU/kg to a feed reduced in Ca and P, led to improved performance and bone mineralisation back to the same levels as seen for the Ca and P sufficient diet.
Collapse
|