Accelerated methanogenesis from effluents of hydrogen-producing stage in anaerobic digestion by mixed cultures enriched with acetate and nano-sized magnetite particles

Magnetite particles accelerate methanogenic degradation of highly concentrated acetic acid in anaerobic digestion process

The anaerobic digestion (AD) process has become significant for its capability to convert organic wastewater into biogas, a valuable energy source. Excessive acetic acid accumulation in the anaerobic digester can inhibit methanogens, ultimately leading to the deterioration of process performance. Herein, the effect of magnetite particles (MP) as an enhancer on the methanogenic degradation of highly-concentrated acetate (6 g COD/L) was examined through long-term sequential AD batch tests. Bioreactors with (AM) and without (AO) MP were compared. AO experienced inhibition and its methane production rate (qm) converged to 0.45 L CH4/g VSS/d after 10 sequential batches (AO10, the 10th batch in a series of the sequential batch tests conducted using bioreactors without MP addition). In contrast, AM achieved 3-425% higher qm through the sequential batches, indicating that MP could counteract the inhibition caused by the highly-concentrated acetate. MP addition to inhibited bioreactors (AO10) successfully restored them, achieving qm of 1.53 L CH4/g VSS/d, 3.4 times increase from AO10 after 8 days lag time, validating its potential as a recovery strategy for inhibited digesters with acetate accumulation. AM exhibited higher microbial populations (1.8-3.8 times) and intracellular activity (9.3 times) compared to AO. MP enriched Methanosaeta, Peptoclostridium, Paraclostridium, OPB41, and genes related to direct interspecies electron transfer and acetate oxidation, potentially driving the improvement of qm through MP-mediated methanogenesis. These findings demonstrated the potential of MP supplementation as an effective strategy to accelerate acetate-utilizing methanogenesis and restore an inhibited anaerobic digester with high acetate accumulation.

Role of KOH-activated biochar on promoting anaerobic digestion of biomass from Pennisetumgianteum

Pennisetum giganteum is a promising non-food crop feedstock for biogas production due to its high productivity and bio-methane potential. However, the accumulation of volatile fatty acids (VFA) usually restricts the conversion efficiency of P. giganteum biomass (PGB) during anaerobic digestion (AD). Here, the role of KOH-activated biochar (KB) in improving the AD efficiency of PGB and the related mechanisms were investigated in detail. The results revealed that KB exhibited excellent electrical conductivity, electron transfer capacity and specific capacitance, which might be related to the decrease in the electron transfer resistance after adding KB to the AD process. In addition, the KB addition not only reinforced metabolisms of energy and VFAs but also promoted the conversion of VFAs to methane, leading to a 52% increase in the methane production rate. Bioinformatics analysis showed that Smithella and Methanosaeta were key players in the KB-mediated AD process of PGB. The stimulatory effect of methanogenesis probably resulted from the establishment of direct interspecies electron transfer (DIET) between VFA-oxidizing acetogens (e.g., Smithella) and Methanosaeta. These findings provided a key step to improve the PGB-based AD process.

Magnetite-boosted syntrophic conversion of acetate to methane during thermophilic anaerobic digestion

Using a batch thermophilic anaerobic system established with 60 mL serum bottles, the mechanism on how microbial enrichments obtained from magnetite-amended paddy soil via repeated batch cultivation affected methane production from acetate was investigated. Magnetite-amended enrichments (MAEs) can improve the methane production rate rather than the methane yield. Compared with magnetite-unamended enrichments, the methane production rate in MAE was improved by 50%, concomitant with the pronounced electrochemical response, high electron transfer capacity, and fast acetate degradation. The promoting effects might be ascribed to direct interspecies electron transfer facilitated by magnetite, where magnetite might function as electron conduits to link the acetate oxidizers (Anaerolineaceae and Peptococcaceae) with methanogens (Methanosarcinaceae). The findings demonstrated the potential application of MAE for boosting methanogenic performance during thermophilic anaerobic digestion.

Enhanced co-digestion of sewage sludge and food waste using novel electrochemical anaerobic membrane bioreactor (EC-AnMBR)

Membrane fouling remains a big challenge hindering the wide-application of anaerobic membrane bioreactor (AnMBR) technology. In this study, an electrochemical anaerobic membrane bioreactor (EC-AnMBR) was developed by coupling electrochemical regulation to enhance co-digestion of sewage sludge and food waste and mitigate membrane fouling. The highest methane production (0.12 ± 0.02 L/L_reactor/day) and net energy recovery (31.82 kJ/day) were achieved under the optimum conditions of 0.8 V, hydraulic retention time of 10 days and solids retention time of 50 days. Electrochemical regulation accelerated the mineralization of high-molecular-weight organics and reinforced the membrane antifouling ability by inducing electrostatic repulsive force and electrochemical oxidation. Besides, symbiotic relationships among functional microorganisms (Spirochaetes, Methanolinea, etc.) were enhanced, improving the hydrolysis and methanogenesis processes of complex organics and the long-term stability. This study confirms the technical feasibility of EC-AnMBR in treating high-solid biowastes, and provides the fundamental data to support its application in real-world scenarios.

Emerging Strategies for Enhancing Propionate Conversion in Anaerobic Digestion: A Review

Anaerobic digestion (AD) is a triple-benefit biotechnology for organic waste treatment, renewable production, and carbon emission reduction. In the process of anaerobic digestion, pH, temperature, organic load, ammonia nitrogen, VFAs, and other factors affect fermentation efficiency and stability. The balance between the generation and consumption of volatile fatty acids (VFAs) in the anaerobic digestion process is the key to stable AD operation. However, the accumulation of VFAs frequently occurs, especially propionate, because its oxidation has the highest Gibbs free energy when compared to other VFAs. In order to solve this problem, some strategies, including buffering addition, suspension of feeding, decreased organic loading rate, and so on, have been proposed. Emerging methods, such as bioaugmentation, supplementary trace elements, the addition of electronic receptors, conductive materials, and the degasification of dissolved hydrogen, have been recently researched, presenting promising results. But the efficacy of these methods still requires further studies and tests regarding full-scale application. The main objective of this paper is to provide a comprehensive review of the mechanisms of propionate generation, the metabolic pathways and the influencing factors during the AD process, and the recent literature regarding the experimental research related to the efficacy of various strategies for enhancing propionate biodegradation. In addition, the issues that must be addressed in the future and the focus of future research are identified, and the potential directions for future development are predicted.

Effects of micron-scale zero valent iron on behaviors of antibiotic resistance genes and pathogens in thermophilic anaerobic digestion of waste activated sludge

This work investigated the metagenomics-based behavior and risk of antibiotic resistance genes (ARGs), and their potential hosts during thermophilic anaerobic digestion (TAD) of waste activated sludge, enhanced by micron-scale zero valent iron (mZVI). Tests were conducted with 0, 25, 100, and 250 mg mZVI/g total solids (TS). Results showed that up to 7.3% and 4.8% decrease in ARGs' abundance and diversity, respectively, were achieved with 100 mg mZVI/g TS. At these conditions, ARGs with health risk in abundance and human pathogenic bacteria (HPB) diversity were also decreased by 8.3% and 3.6%, respectively. Additionally, mZVI reduced abundance of 72 potential pathogenic supercarriers for ARGs with high health risk by 2.5%, 5.0%, and 6.1%, as its dosage increased. Overall, mZVI, especially at 100 mg/g TS, can mitigate antibiotic resistance risk in TAD. These findings are important for better understanding risks of ARGs and their pathogenic hosts in ZVI-enhanced TAD of solid wastes.

Nano magnetite-loaded biochar boosted methanogenesis through shifting microbial community composition and modulating electron transfer

A batch anaerobic fermentation system was employed to clarify how nano magnetite-loaded biochar can improve methanogenic performance of the propionate-degrading consortia (PDC). The nano magnetite-loaded biochar was prepared in a sequential hydrothermal and pyrolysis procedure using the household waste (HW), biogas residue (BR) and Fe (NO₃)₃ as pristine materials. Comprehensive characterization showed that the nano magnetite-loaded biochar ameliorated the biochar properties with large specific surface area, high electrochemical response and low electron transfer resistance. PDC supplemented with the magnetite/BR-originated biochar composites displayed excellent methanogenic performance, where the methane production rate was enhanced by 1.6-fold compared with the control. The nano magnetite-loaded biochar promoted methane production probably by promoting direct interspecies electron transfer between syntrophic bacteria (e.g., Syntrophobacter and Thauera) and their partners (e.g., Methanosaeta). In this process, magnetite might be responsible for triggering rapidly extracellular electron release, whereas both external functional groups and intrinsic graphitic matrices of biochar might work as electron bridges for electron transport.

A Review of Biogenic Coalbed Methane Experimental Studies in China

Biogenic coalbed methane (CBM) is an important alternative energy that can help achieve carbon neutrality. Accordingly, its exploration and development have become a research hotspot in the field of fossil energy. In this review, the latest detection technologies for and experimental research on biogenic CBM in China in recent decades are summarized. The factors influencing the generation of biogenic CBM and the identification method of biogenic CBM are systematically analyzed. The technologies to detect biogas and the research methods to study microbial diversity are summarized. The literature shows that biogenic CBM is easily produced in the presence of highly abundant organic matter of low maturity, and the organic matter reaching a certain thickness can compensate for the limitation of biogenic CBM gas production due to the small abundance of organic matter to a certain extent. Biogenic CBM production could be increased in an environment with low salinity, medium alkalinity, and rich Fe²⁺ and Ni²⁺ sources. Furthermore, biogenic CBM can be identified by considering three aspects: (1) the presence of gas composition indicators; (2) the content of heavy hydrocarbon; and (3) variation in the abundance of biomarkers. In recent years, research methods to study the microbial community and diversity of CBM-producing environments in China have mainly included 16S rRNA gene library, fluorescence in situ hybridization, and high-throughput sequencing, and the dominant microorganisms have been determined in various basins in China. The results of numerous studies show that the dominant bacterial phyla are commonly Firmicutes and Proteobacteria, while the archaeal fraction mainly includes Methanoculleus, Methanobacterium, Methanocorpusculum, and Methanothrix. This review summarizes and discusses the advances in biogenic CBM production and the associated microbial community in order to promote further development of coal biotransformation and CO₂ bio-utilization to meet energy demands under carbon neutrality.

Effect of magnetite particle size on propionate degradation in the propionate-based anaerobic system

The size effect of magnetite (Fe₃O₄) on the degradation of propionate (PA) in the PA-based anaerobic system was investigated. The sequential bench-scale experiments were conducted. Results showed that the effects of different sized magnetite particles on PA degradation varied, and reaction cycles also played a role in substrate removal/degradation. With the increase of reaction cycle, nano-magnetite promoted PA degradation and CH₄ production, which caused faster PA degradation rate (0.997 g/L·d) than the control group (CK) without magnetite (0.834 g/L·d), whereas the groups with micron- and millimeter-sized magnetite had slower PA degradation rates (0.746 and 0.636 g/L·d) than CK group. The particle size or surface characteristics of the magnetite may become the main factor determining the PA degradation rate. Furthermore, the analysis of PA conversion and volatile fatty acids (VFAs) distribution showed the C6-dismutation pathway, which converses PA to butyrate, enhanced by the introduction of magnetite. Microbial community analysis showed that PA was degraded mainly by methyl-malonyl-CoA (MMC) pathway. The relative abundance of Syntrophobacter that catalyze MMC pathway in the group with nano-magnetite were much higher after three reaction cycles at 39 %, as compared to micro-magnetite at 28 %, and millimeter-sized magnetite at 27 %, which contributed to faster degradation of PA. Functional enzyme-encoding genes for the four methanogenesis pathways were identified with reference to KEGG database entries. The methanogenesis pathway using acetate was the most abundant pathway in all groups. The observations have important implications for enhancing the PA removal in PA-inhibited anaerobic digester.

Bioelectrochemical systems in aid of sustainable biorefineries for the production of value-added products and resource recovery from wastewater: A critical review and future perspectives

Bioelectrochemical systems (BES) have the potential to be used in a variety of applications such as waste biorefinery, pollutants removal, CO₂ capture, and the electrosynthesis of clean and renewable biofuels or byproducts, among others. In contrast, many technical challenges need to be addressed before BES can be scaled up and put into real-world applications. Utilizing BES, this review article presents a state-of-the-art overall view of crucial concepts and the most recent innovative results and achievements acquired from the BES system. Special attention is placed on a hybrid approach for product recovery and wastewater treatment. There is also a comprehensive overview of waste biorefinery designs that are included. In conclusion, the significant obstacles and technical concerns found throughout the BES studies are discussed, and suggestions and future requirements for the virtual usage of the BES concept in actual waste treatment are outlined.

Improvement of Direct Interspecies Electron Transfer via Adding Conductive Materials in Anaerobic Digestion: Mechanisms, Performances, and Challenges

Anaerobic digestion is an effective and sustainable technology for resource utilization of organic wastes. Recently, adding conductive materials in anaerobic digestion to promote direct interspecies electron transfer (DIET) has become a hot topic, which enhances the syntrophic conversion of various organics to methane. This review comprehensively summarizes the recent findings of DIET mechanisms with different mediating ways. Meanwhile, the influence of DIET on anaerobic digestion performance and the underlying mechanisms of how DIET mediated by conductive materials influences the lag phase, methane production, and system stability are systematically explored. Furthermore, current challenges such as the unclear biological mechanisms, influences of non-DIET mechanisms, limitations of organic matters syntrophically oxidized by way of DIET, and problems in practical application of DIET mediated by conductive materials are discussed in detail. Finally, the future research directions for practical application of DIET are outlined.

A unique microbiome in a highly polluted and alkalic lake in a seasonally frozen area

Highly polluted waters profoundly promoted microbial activities and vice versa. Although microbial community structures and bioprocesses in polluted environments have been fully investigated, they are rarely uncovered in abandoned and highly polluted aquatic environment, especially in a seasonally frozen area. East Lake had been polluted by surrounding paper mills and dairy plants from the 1960s to the early 2000s. Under low biodegradability (BOD₅/COD ratio<0.2) and alkalic (pH > 9) conditions, a unique microbiome was discovered in East lake. Proteobacteria was the largest taxonomic group in the microbial community, covering almost half of the top-100 genera. Among them, seven genera are sulfate-reducing bacteria, including Desulfuromusa, Desulfuromonas, Desulfobulbus, Desulfocapsa, Desulfurivibrio, Desulfatiglans, and Desulfomicrobium. Functional analysis revealed abundant predicted functional genes for the respiration of sulfur compounds and sulfate respiration. Great vertical variations were found to both microbial community structures and predicted functions. This work provides unique evidence for future microbiome studies of nutrient-rich, alkalic, and seasonally frozen water habitats.

Effect of sludge retention time on microbial succession and assembly in thermal hydrolysis pretreated sludge digesters: Deterministic versus stochastic processes

Thermal hydrolysis process (THP) assisted anaerobic digestion (AD) has been demonstrated to be an efficient approach to improve biogas production and solids reduction. Given the faster reaction kinetics in the THP-AD system, reduction of sludge retention time (SRT) is possible. However, a comprehensive understanding of the effects of sludge retention time (SRT) on microbial dynamics and community assemblages is still lacking in THP-AD systems. Thus, twelve THP-AD reactors were operated at different SRTs (10-30 d) to fulfill the knowledge gap. Results showed that, although all the bioreactors displayed good performance, shorter SRT reactors (SRT 10 d) took a longer time to reach the stable state. The total biogas production at SRT of 10 d was lower than that at other longer SRTs, attributing to the limited hydrolytic/fermentative capacities of AD microbiomes. Different SRTs resulted in distinct succession patterns of AD microbiomes. THP sludge reduced the microbial diversity in all the bioreactors over time, but longer SRTs maintained higher biodiversity. Null model analysis suggested that THP-AD microbial community assembly was predominately driven by deterministic selection at the tested SRT range, but stochasticity increased with elevated SRTs, likely attributing to the immigrants from the feedstock. Phylogenetic molecular ecological networks (pMENs) analysis revealed more stable network structures at longer SRTs, evidenced by the lower modularity, shorter harmonic geodesic distance, and higher connectivity. The potential keystone taxa under varied SRTs were identified, some of which were hydrolytic/fermentative bacteria (e.g., Peptostreptococcus, Lutispora, Synergistaceae), suggesting that these species related to organic hydrolysis/fermentation even with low-abundance could still play pivotal ecological roles in maintaining the THP-AD microbial community structure and functions. Collectively, this study provides comprehensive and in-depth insights into the mechanisms underlying community assembly in THP-AD reactors, which could aid in diagnosing system stability.

Historical Perspective of the Addition of Magnetic Nanoparticles Into Anaerobic Digesters (2014-2021)

The addition of magnetic nanoparticles to batch anaerobic digestion was first reported in 2014. Afterwards, the number of works dealing with this subject has been increasing year by year. The discovery of the enhancement of anaerobic digestion by adding iron-based nanoparticles has created a multidisciplinary emerging research field. As a consequence, in the last years, great efforts have been made to understand the enhancement mechanisms by which magnetic nanoparticles (NPs) addition enhances the anaerobic digestion process of numerous organic wastes. Some hypotheses point to the dissolution of iron as essential iron for anaerobic digestion development, and the state of oxidation of iron NPs that can reduce organic matter to methane. The evolution and trends of this novel topic are discussed in this manuscript. Perspectives on the needed works on this topic are also presented.

Sparking Anaerobic Digestion: Promoting Direct Interspecies Electron Transfer to Enhance Methane Production

Anaerobic digestion was one of the first bioenergy strategies developed, yet the interactions of the microbial community that is responsible for the production of methane are still poorly understood. For example, it has only recently been recognized that the bacteria that oxidize organic waste components can forge electrical connections with methane-producing microbes through biologically produced, protein-based, conductive circuits. This direct interspecies electron transfer (DIET) is faster than interspecies electron exchange via diffusive electron carriers, such as H2. DIET is also more resilient to perturbations such as increases in organic load inputs or toxic compounds. However, with current digester practices DIET rarely predominates. Improvements in anaerobic digestion associated with the addition of electrically conductive materials have been attributed to increased DIET, but experimental verification has been lacking. This deficiency may soon be overcome with improved understanding of the diversity of microbes capable of DIET, which is leading to molecular tools for determining the extent of DIET. Here we review the microbiology of DIET, suggest molecular strategies for monitoring DIET in anaerobic digesters, and propose approaches for re-engineering digester design and practices to encourage DIET.

Different inhibitory mechanisms of chlortetracycline and enrofloxacin on mesophilic anaerobic degradation of propionate

In anaerobic digestion, propionate is a key intermediate whose degradation is thermodynamically challenging and accumulation is detrimental to the process. Many wastewater streams contain antibiotics due to its globally increasing use, and these compounds can inhibit methane production. However, the effect of antibiotics on propionate degradation in anaerobic digestion remains unclear. In this study, the influence of two antibiotics (chlortetracycline [CTC] and enrofloxacin [EFX]) on biogas production and mesophilic propionate-degrading microbial community was investigated. CTC strongly repressed propionate oxidation, acetate utilization, and methane production, while EFX only inhibited propionate oxidation and methane production to a lesser extent. Microbial community analyses showed that syntrophic propionate-oxidizing bacteria (SPOB) Syntrophobacter had strong tolerance to both CTC and EFX. CTC inhibition mainly acted on the activity of acetate-oxidizing bacteria (Mesotoga, Geovibrio, Tepidanaerobacter, unclassified Bacteroidetes, and unclassified Clostridia) and acetoclastic methanogen, while EFX inhibition applied to the SPOB Smithella and acetoclastic methanogen. Network analysis further indicated that more complicated correlation among bacterial genera occurred in CTC treatments. These results suggested that CTC and EFX inhibited propionate degradation via different mechanisms, which was the result of joint action by antibiotics and microbial interactions.

Enhancing direct interspecies electron transfer in syntrophic-methanogenic associations with (semi)conductive iron oxides: Effects and mechanisms

Anaerobic digestion is an effective biological treatment process that produces methane by degrading organic compounds in waste/wastewater. It is a complicated microbial process by metabolic interactions among different types of microorganisms. In this process, efficient interspecies electron transfer between secondary fermenting bacteria and methanogens is the critical process for fast and effective methanogenesis. In syntrophic metabolism, hydrogen or formate has been considered as the conventional electron carrier transferring electrons from secondary fermenting bacteria to hydrogenotrophic methanogens. Recently, direct interspecies electron transfer (DIET) without the involvement of dissolved redox mediators is arousing great concerns and has been regarded as a more efficient and thermodynamically favorable interspecies electron transfer pathway for methanogenesis. Interspecies electron exchange through DIET is accomplished via the membrane-bound cytochromes or conductive pili. Several kinds of exogenously-added conductive or semiconductive iron oxides have been discovered to greatly enhance anaerobic methanogenesis through promoting DIET. Different (semi)conductive iron oxides give a boost to DIET through different mechanisms based on the physicochemical properties of the iron oxides and the reciprocal interactions between iron oxides and functional microorganisms. In this review, the current understanding of interspecies electron transfer in syntrophic-methanogenic consortions is summarized, the effects and deep-rooted mechanisms of (semi)conductive iron oxides on methanogenesis and DIET are discussed, and possible future perspectives and development directions are suggested for DIET via (semi)conductive iron oxides in anaerobic digestion.

Synergetic alginate conversion by a microbial consortium of hydrolytic bacteria and methanogens

Sludge, of which alginate-like biomaterial is a major organic component, is an increasing environmental problem. Thus, efficient anaerobic degradation of alginate provides a new method for sludge utilization. In this study, anaerobic alginate hydrolytic bacteria (AHB) were proposed to enrich with methanogens synergetically to reduce the inhibition of intermediate metabolites. The COD of produced methane reached 80.7 ± 1.9% (n = 4) of initial alginate COD. After considering the microbial growth (8%-18% of COD), a good COD balance indicated that alginate was fully consumed and the main final metabolites were methane and CO₂. Methanogenesis could promote alginate conversion by AHB. The enriched bacteria for alginate degradation in this study were different from that of former known AHB. The metabolic pathway of alginate degradation was revealed by metagenomics, in which oligo-alginate lyase was detected in twelve bacteria, and typical carbon metabolic pathways to convert alginate to methane were identified. More studies of bacterial isolation and biofuel production are still needed in the future.

Magnetite as an enhancer in methanogenic degradation of volatile fatty acids under ammonia-stressed condition

Anaerobic batch tests with a 2² full-factorial design of ammonia (1.5, 6.5 g N/L) and magnetite concentrations (0, 20 mmol/L) were conducted separately for methanogenic degradation of acetate, propionate, and butyrate (volatile fatty acids (VFAs)) to 1) quantify the effect of magnetite as an enhancer in methanogenic degradation of each of the VFAs in conditions without ammonia stress (1.5 g N/L) and with ammonia stress (6.5 g N/L), and 2) identify methanogenic consortia that are related to such enhancement. Among the three VFAs, methanogenic degradation of propionate was the least feasible (57% lower specific methanogenic activity R_CH4 and three times longer lag time λ than acetate degradation). At low ammonia concentration, only propionate showed improvement in R_CH4 (46%) with supplementation of magnetite. In the ammonia-stressed condition without magnetite, R_CH4 decreased by 38-58% and λ increased 2.2-8.8 times for all VFAs; magnetite supplementation significantly alleviated these effects. These results demonstrate that magnetite supplementation effectively increases methanogenic degradation of the VFAs even under ammonia-stressed conditions. 16S metagenomic sequencing revealed that distinctive methanogenic consortia were active in the different combinations of substrate, ammonia and magnetite. Alkaliphilus, Hyphomonadaceae SWB02 and Clostridia DTU014, Clostridia D8A-2, Christensenellaceae R-7 group and Rikenellaceae DMER64 were identified as potential syntrophic bacteria that can establish magnetite-mediated direct electron transfer with methanogens (Methanosaeta concilii, Methanosaeta harundinacea, Methanolinea tarda, Methanoculleus bourgensis and Methanosarcina spp.) during methanogenic degradation of VFAs. The results may be useful as a reference to develop effective strategies using magnetite supplementation to remediate anaerobic digestion processes that have been afflicted by VFA accumulation and ammonia inhibition.

NanoFe3O4 as Solid Electron Shuttles to Accelerate Acetotrophic Methanogenesis by Methanosarcina barkeri

Magnetite nanoparticles (nanoFe₃O₄) have been reported to facilitate direct interspecies electron transfer (DIET) between syntrophic bacteria and methanogens thereby improving syntrophic methanogenesis. However, whether or how nanoFe₃O₄ affects acetotrophic methanogenesis remain unknown. Herein, we demonstrate the unique role of nanoFe₃O₄ in accelerating methane production from direct acetotrophic methanogenesis in Methanosarcina-enriched cultures, which was further confirmed by pure cultures of Methanosarcina barkeri. Compared with other nanomaterials of higher electrical conductivity such as carbon nanotubes and graphite, nanoFe₃O₄ with mixed valence Fe(II) and Fe(III) had the most significant stimulatory effect on methane production, suggesting its redox activity rather than electrical conductivity led to enhanced methanogenesis by M. barkeri. Cell morphology and spectroscopy analysis revealed that nanoFe₃O₄ penetrated into the cell membrane and cytoplasm of M. barkeri. These results provide the unprecedented possibility that nanoFe₃O₄ in the cell membrane of methanogens serve as electron shuttles to facilitate intracellular electron transfer and thus enhance methane production. This work has important implications not only for understanding the mechanisms of mineral-methanogen interaction but also for optimizing engineered methanogenic processes.

New insights into enhanced anaerobic degradation of coal gasification wastewater (CGW) with the assistance of graphene

The up-flow anaerobic sludge blanket (UASB) system with graphene assisted was developed for coal gasification wastewater (CGW) treatment. Short-term results showed that optimal graphene addition (0.5 g/L) resulted in a more significant enhancement of methane production and chemical oxygen demand (COD) removal compared with that of the optimal activated carbon addition (10.0 g/L). Long-term results demonstrated that COD removal efficiency and methane production rate with graphene assisted achieved 64.7% and 180.5 mL/d, respectively. In addition, graphene could promote microbes accumulation and enzymes activity, resulting in higher extracellular polymeric substances (EPS) and coenzyme F₄₂₀ concentrations. X-ray Diffraction (XRD) analysis indicated that chemical of graphene changed insignificantly during the experiment. Meanwhile, with graphene assisted, cells were attached together to form microbial aggregates to facilitate sludge granulation process. Furthermore, the enriched Geobacter and Pseudomonas might perform direct interspecies electron transfer (DIET) with Methanosaeta via biological electrical connection, enhancing the anaerobic degradation of CGW.

Combination of bioaugmentation and biostimulation for remediation of paddy soil contaminated with 2,4-dichlorophenoxyacetic acid

The batch and fed-batch tests were performed to evaluate the efficiency of bioaugmentation in combination with biostimulation for remediation of paddy soil contaminated with 2,4-dichlorophenoxyacetic acid (2,4-D). 2,4-D degrading enrichments were used for bioaugmentation, and effluents prepared through biological hydrogen production process were used as substrate for biostimulation. The batch tests indicated that 2,4-D degradation depended on the enrichment/substrate ratio (E/S), where E/S of 0.03 showed an excellent performance. The fed-batch tests showed that biostimulation only led to an improvement in 2,4-D degradation, while the pattern of repeated augmentation of enrichments (FRA) together with biostimulation obviously improved degradation of 2,4-D, 2-chlorophenol (2-CP) and phenol. DNA-sequencing approach showed that the FRA pattern altered the bacterial community composition, and high removal of 2,4-D, 2-CP and phenol may be attributed to the acclimation and persistence of Thauera. The findings demonstrated the importance of the FRA pattern on remediation of paddy soil contaminated with 2,4-D.

Promoting degradation of 2,4-dichlorophenoxyacetic acid with fermentative effluents from hydrogen-producing reactor

This research aims to identifying the potential effect of using a hydrogen-producing reactor's effluent as an enrichment amendment for enhancing the degradation rates of 2,4-dichlorophenoxyacetic acid (2,4-D) during the bioremediation of contaminated paddy soils. The results showed that addition of the effluents to 2,4-D- degrading enrichment culture enhanced (up to 1.3-fold) the degradation rate constant of 2,4-D. The enhancement effect most probably resulted from the co-metabolic degradation of 2,4-D facilitated by volatile fatty acids (e.g., acetate, propionate, and butyrate) in the effluents which served as the beneficial substrates. Results from DNA sequencing analysis showed that the effluent additions shifted the bacterial community composition in the enrichment culture. Dechloromonas and Clostridium were two dominant bacterial genera involved in 2,4-D degradation. The findings will make a substantial contribution to remediation of soils contaminated with 2,4-D.

Time-dependent bacterial community and electrochemical characterizations of cathodic biofilms in the surfactant-amended sediment-based bioelectrochemical reactor with enhanced 2,3,4,5-tetrachlorobiphenyl dechlorination

Applying an electric field to stimulate the microbial reductive dechlorination of polychlorinated biphenyls (PCBs) represents a promising approach for bioremediation of PCB-contaminated sites. This study aimed to demonstrate the biocathodic film-facilitated reduction of PCB 61 in a sediment-based bioelectrochemical reactor (BER) and, more importantly, the characterizations of electrode-microbe interaction from microbial and electrochemical perspectives particularly in a time-dependent manner. The application of a cathodic potential (-0.45 V vs. SHE) significantly improved the rate and extent of PCB 61 dechlorination compared to the open-circuit scenario (without electrical stimulation), and the addition of an external surfactant further increased the dechlorination, with Tween 80 exerting more pronounced effects than rhamnolipid. The bacterial composition of the biofilms and the bioelectrochemical kinetics of the BERs were found to be time-dependent and to vary considerably with the incubation time and slightly with the coexistence of an external surfactant. Excellent correlations were observed between the dechlorination rate and the relative abundance of Dehalogenimonas, Dechloromonas, and Geobacter, the dechlorination rate and the cathodic current density recorded from the chronoamperometry tests, and the dechlorination rate and the charge transfer resistance derived from the electrochemical impedance tests, with respect to the 120 day-operation. After day 120, PCB 61 was resistant to further appreciable reduction, but substantial hydrogen production was detected, and the bacterial community and electrochemical parameters observed on day 180 were not distinctly different from those on day 120.

Accelerated ciprofloxacin biodegradation in the presence of magnetite nanoparticles

Ciprofloxacin (CIP) biodegradation was investigated using enrichments obtained in the presence of magnetite nanoparticles, CIP and human fecal sewage. CIP addition inhibited methanogenic activity and altered the bacterial community composition. The magnetite-supplemented enrichments significantly promoted CIP biodegradation, especially in the presence of 2-bromoethanesulfonate (BES). When BES was added, CIP biodegradation in the magnetite-supplemented enrichments was 67% higher than in the magnetite-unamended enrichments. Fe (II) concentrations were also significantly increased in the BES and magnetite-supplemented enrichments. This indicated that there might be a positive relationship of CIP biodegradation with microbial reduction of Fe (III) to Fe (II). As for the magnetite-supplemented enrichments, DNA-sequencing analysis revealed that Stenotrophomonas was the dominant genus, while Desulfovibrio became the dominant genus in the presence of BES. These two genera might be related to Fe (III) reduction in the magnetite. The findings provide a strategy for improving CIP biodegradation during waste treatment.

In-situ sludge pretreatment in a single-stage anaerobic digester

This study aimed to develop an in-situ sludge pretreatment method by increasing the temperature from thermophilic to extreme thermophilic condition in a single-stage anaerobic digester. The results revealed that a stable performance was obtained within the temperature range of 55-65°C, and the maximum methane yield of 208.51±13.66mL/g VS was obtained at 65°C. Moreover, the maximum extent of hydrolysis (33%) and acidification (27.1%) was also observed at 65°C. However, further increase of temperature to 70°C did not improve the organic conversion efficiency. Microbial community analysis revealed that Coprothermobacter, highly related to acetate oxidisers, appeared to be the abundant bacterial group at higher temperature. A progressive shift in methanogenic members from Methanosarcina to Methanothermobacter was observed upon increasing the temperature. This work demonstrated single-stage sludge digestion system can be successfully established at high temperature (65°C) with stable performance, which can eliminate the need of conventional thermophilic pretreatment step.

Inferring microbial interactions in thermophilic and mesophilic anaerobic digestion of hog waste

Anaerobic digestion (AnD) is a microbiological process that converts organic waste materials into biogas. Because of its high methane content, biogas is a combustible energy source and serves as an important environmental technology commonly used in the management of animal waste generated on large animal farms. Much work has been done on hardware design and process engineering for the generation of biogas. However, little is known about the complexity of the microbiology in this process. In particular, how microbes interact in the digester and eventually breakdown and convert organic matter into biogas is still regarded as a "black box." We used 16S rRNA sequencing as a tool to study the microbial community in laboratory hog waste digesters under tightly controlled conditions, and systematically unraveled the distinct interaction networks of two microbial communities from mesophilic (MAnD) and thermophilic anaerobic digestion (TAnD). Under thermophilic conditions, the well-known association between hydrogen-producing bacteria, e.g., Ruminococcaceae and Prevotellaceae, and hydrotrophic methanogens, Methanomicrobiaceae, was reverse engineered by their interactive topological niches. The inferred interaction network provides a sketch enabling the determination of microbial interactive relationships that conventional strategy of finding differential taxa was hard to achieve. This research is still in its infancy, but it can help to depict the dynamics of microbial ecosystems and to lay the groundwork for understanding how microorganisms cohabit in the anaerobic digester.

iTRAQ quantitative proteomic analysis reveals the pathways for methanation of propionate facilitated by magnetite

Methanation of propionate requires syntrophic interaction of propionate-oxidizing bacteria and hydrogenotrophic methanogens, which is referred to as interspecies electron transfer. The present study showed that 10 mg/L conductive magnetite enhanced the methane production rate from propionate by around 44% in batch experiments, and both direct interspecies electron transfer and interspecies H₂ transfer were thermodynamically feasible with the addition of magnetite. The methanation of propionate facilitated by magnetite was also demonstrated in a long-term operated continuous reactor. The methane production rate from acetate by the enriched mixed culture with magnetite was higher than that without magnetite, while similar methane production rates were found from H₂/CO₂ by the enriched mixed culture with and without magnetite. The ability to utilize molecular H₂ indicated interspecies H₂ transfer played a role in the enriched culture with magnetite, and propionate-oxidizing bacteria relating with interspecies H₂ transfer were also detected by metagenomic sequencing. Metagenomic sequencing analysis also showed that Thauera, possibly relating with direct interspecies electron transfer, were enriched with the addition of magnetite. iTRAQ quantitative proteomic analysis, which was used in mixed culture for the first time, showed that magnetite induced the changes of protein expression levels involved in various pathways during the methanation of propionate. The up-regulation of proteins involved in propionate metabolism were found, and they were mainly originated from propionate-oxidizing bacteria which were not reported to be capable of direct interspecies electron transfer until now. Cytochrome c oxidase was also revealed as the possible protein relating with direct interspecies electron transfer considering its up-regulation with the addition of magnetite and origination from Thauera. Most of the up-regulated proteins in methane metabolism were originated from Methanosaeta, while most of the enzymes with down-regulated proteins were originated from Methanosarcina. However, the up-regulated proteins relating with hydrogenotrophic methanogenesis were originated from neither Methanosaeta nor Methanosarcina, indicating they were not involved in direct interspecies electron transfer. The hydrogenotrophic methanogens, e.g. Methanospirillum, Methanosphaerula et al., might be involved in direct interspecies electron transfer. Overall, the present study showed that both direct interspecies electron transfer and interspecies H₂ transfer were present during methanation of propionate facilitated by magnetite.

Enhancing methane production from food waste fermentate using biochar: the added value of electrochemical testing in pre-selecting the most effective type of biochar

BACKGROUND

Recent studies have suggested that addition of electrically conductive biochar particles is an effective strategy to improve the methanogenic conversion of waste organic substrates, by promoting syntrophic associations between acetogenic and methanogenic organisms based on interspecies electron transfer processes. However, the underlying fundamentals of the process are still largely speculative and, therefore, a priori identification, screening, and even design of suitable biochar materials for a given biotechnological process are not yet possible.

RESULTS

Here, three charcoal-like products (i.e., biochars) obtained from the pyrolysis of different lignocellulosic materials, (i.e., wheat bran pellets, coppiced woodlands, and orchard pruning) were tested for their capacity to enhance methane production from a food waste fermentate. In all biochar-supplemented (25 g/L) batch experiments, the complete methanogenic conversion of fermentate volatile fatty acids proceeded at a rate that was up to 5 times higher than that observed in the unamended (or sand-supplemented) controls. Fluorescent in situ hybridization analysis coupled with confocal laser scanning microscopy revealed an intimate association between archaea and bacteria around the biochar particles and provided a clear indication that biochar also shaped the composition of the microbial consortium. Based on the application of a suite of physico-chemical and electrochemical characterization techniques, we demonstrated that the positive effect of biochar is directly related to the electron-donating capacity (EDC) of the material, but is independent of its bulk electrical conductivity and specific surface area. The latter properties were all previously hypothesized to play a major role in the biochar-mediated interspecies electron transfer process in methanogenic consortia.

CONCLUSIONS

Collectively, these results of this study suggest that for biochar addition in anaerobic digester operation, the screening and identification of the most suitable biochar material should be based on EDC determination, via simple electrochemical tests.

Kinetics of methane production and biodegradation of linear alkylbenzene sulfonate from laundry wastewater

This study evaluates the kinetics of methane production and degradation of standard linear alkylbenzene sulfonate (LAS) (50 ± 3.5 mg/L) and LAS from laundry wastewater (85 ± 2.1 mg/L) in anaerobic batch reactors at 30°C with different sources of inoculum. The inocula were obtained by auto-fermentation (AFM) and UASB reactors from wastewater treatment of poultry slaughterhouse (SGH), swine production (SWT) and wastewater treatment thermophilic of sugarcane industry (THR). The study was divided into three phases: synthetic substrate (Phase I), standard LAS (Phase II) and LAS from laundry wastewater (Phase III). For SGH, the highest values for cumulative methane productions (1,844.8 ± 149 µmol-Phase II), methane production rate (70.8 ± 88 µmol/h-Phase II and 4.01 ± 07 µmol/h-Phase III) were observed. The use of thermophilic biomass (THR) incubated at 30°C was not favorable for methane production and LAS biodegradation, but the highest kinetic coefficient degradation (k₁^app) was obtained for LAS (0.33 ± 0.3 h) compared with mesophilic biomass (SGH and SWT) (0.13 ± 0.02 h). Therefore, both LAS sources influenced the kinetics of methane production and organic matter degradation. For SGH, inoculum obtained the highest LAS degradation. In the SGH inoculum sequenced by MiSeq-Illumina was identified genera (VadinCA02, Candidatus Cloacamonas, VadinHB04, PD-UASB-13) related to degrade toxic compounds. Therefore, it recommended the reactor mesophilic inoculum UASB (SGH) for the LAS degradation.

Magnetite/graphene oxide nano-composite for enhancement of hydrogen production from gelatinaceous wastewater

The effect of substrate to inoculum (So/Xo) ratio and supplementation of magnetite/graphene oxide (MGO) nano-composite material on hydrogen production from gelatinaceous wastewater via dark fermentation process was investigated. Results demonstrated that optimum So/Xo ratio of 1.0gCOD/gVSS achieved maximal hydrogen yield (HY) of 79.2±11.9mL H2/gCOD removed. Supplementation of anaerobes with 100mg/L MGO promoted HY up to 112.4±10.5mL H2/gCOD removed. Moreover, the degradation efficiency of carbohydrates, proteins and lipids was improved to 80.8±7.6, 34.4±2.3 and 31.4±2.2%, respectively. Acetate (HAc) and butyrate (HBu) concentrations increased from 102±6.8 to 125.3±6.3 and from 31.1±1.5 to 48.8±3.5mg/gVSS, respectively. However, propionate (HPr) concentration dropped from 35.9±2.7 to 15±1.3mg/gVSS. Hydrogenase enzyme activity increased 9-folds and the anaerobes elongated from ca. 1.8-2.9 to ca. 2.5-5.1μm with MGO addition. Moreover, Proteobacteria, Firmicutes, Clostridia and Bacilli were detected with the batches supplemented with MGO.

Enhanced methane production via repeated batch bioaugmentation pattern of enriched microbial consortia

Using batch and repeated batch cultivations, this study investigated the effects of bioaugmentation with enriched microbial consortia (named as EMC) on methane production from effluents of hydrogen-producing stage of potato slurry, as well as on the indigenous bacterial community. The results demonstrated that the improved methane production and shift of the indigenous bacterial community structure were dependent on the EMC/sludge ratio and bioaugmentation patterns. The methane yield and production rate in repeated batch bioaugmentation pattern of EMC were, respectively, average 15% and 10% higher than in one-time bioaugmentation pattern of EMC. DNA-sequencing approach showed that the enhanced methane production in the repeated batch bioaugmentation pattern of EMC mainly resulted from the enriched iron-reducing bacteria and the persistence of the introduced Syntrophomonas, which led to a rapid degradation of individual VFAs to methane. The findings contributed to understanding the correlation between the bioaugmentation of microbial consortia, community shift, and methane production.

Enhanced biohydrogen and subsequent biomethane production from sugarcane bagasse using nano-titanium dioxide pretreatment

Nano-titanium dioxide (nanoTiO2) under ultraviolet irradiation (UV) followed by dilute sulfuric acid hydrolysis of sugarcane bagasse was used to enhance the production of biohydrogen and biomethane in a consecutive dark fermentation and anaerobic digestion. Different concentrations of 0.001, 0.01, 0.1 and 1g nanoTiO2/L under different UV times of 30, 60, 90 and 120min were used. Sulfuric acid (2%v/v) at 121°C was used for 15, 30 and 60min to hydrolyze the pretreated bagasse. For acidic hydrolysis times of 15, 30 and 60min, the highest total free sugar values were enhanced by 260%, 107%, and 189%, respectively, compared to samples without nanoTiO2 pretreatment. The highest hydrogen production samples for the same acidic hydrolysis times showed 88%, 127%, and 25% enhancement. The maximum hydrogen production of 101.5ml/g VS (volatile solids) was obtained at 1g nanoTiO2/L and 120min UV irradiation followed by 30min acid hydrolysis.

Bioaugmentation of Hydrogenispora ethanolica LX-B affects hydrogen production through altering indigenous bacterial community structure

Bioaugmentation can facilitate hydrogen production from complex organic substrates, but it still is unknown how indigenous microbial communities respond to the added bacteria. Here, using a Hydrogenispora ethanolica LX-B (named as LX-B) bioaugmentation experiments, the distribution of metabolites and the responses of indigenous bacterial communities were investigated via batch cultivation (BC) and repeated batch cultivation (RBC). In BC the LX-B/sludge ratio of 0.12 achieved substantial high hydrogen yield, which was over twice that of control. In RBC one-time bioaugmentation and repeated batch bioaugmentation of LX-B resulted in the hydrogen yield that was average 1.2-fold and 0.8-fold higher than that in control, respectively. This improved hydrogen production performance mainly benefited from a shift in composition of the indigenous bacterial community caused by LX-B bioaugmentation. The findings represented an important step in understanding the relationship between bioaugmentation, a shift in bacterial communities, and altered bioreactor performance.

Enrichment of Secondary Wastewater Sludge for Production of Hydrogen from Crude Glycerol and Comparative Evaluation of Mono-, Co- and Mixed-Culture Systems

Anaerobic digestion using mixed-culture with broader choice of pretreatments for hydrogen (H₂) production was investigated. Pretreatment of wastewater sludge by five methods, such as heat, acid, base, microwave and chloroform was conducted using crude glycerol (CG) as substrate. Results for heat treatment (100 °C for 15 min) showed the highest H₂ production across the pretreatment methods with 15.18 ± 0.26 mmol/L of medium at 30 °C in absence of complex media and nutrient solution. The heat-pretreated inoculum eliminated H₂ consuming bacteria and produced twice as much as H₂ as compared to other pretreatment methods. The fermentation conditions, such as CG concentration (1.23 to 24 g/L), percentage of inoculum size (InS) (1.23% to 24% v/v) along with initial pH (2.98 to 8.02) was tested using central composite design (CCD) with H₂ production as response parameter. The maximum H₂ production of 29.43 ± 0.71 mmol/L obtained at optimum conditions of 20 g/L CG, 20% InS and pH 7. Symbiotic correlation of pH over CG and InS had a significant (p-value: 0.0011) contribution to H₂ production. The mixed-culture possessed better natural acclimatization activity for degrading CG, at substrate inhibition concentration and provided efficient inoculum conditions in comparison to mono- and co-culture systems. The heat pretreatment step used across mixed-culture system is simple, cheap and industrially applicable in comparison to mono-/co-culture systems for H₂ production.

Magnetite nanoparticles enable a rapid conversion of volatile fatty acids to methane

Evaluation of whether paddy soil enrichments obtained in the presence of magnetite and propionate can accelerate methane production from mixed volatile fatty acids.

Research advances in deriving renewable energy from biomass in wastewater treatment plants

Anaerobic digestion (AD) can be used to derive renewable energy from biomass in wastewater treatment plants, and the produced biogas represents a valuable end-product that can greatly offset operation costs.

Magnetite nanoparticles facilitate methane production from ethanol via acting as electron acceptors

Potential for interspecies hydrogen transfer within paddy soil enrichments obtained via addition of magnetite nanoparticles and ethanol (named as PEM) was investigated. To do this, PEM derived from rice field of Hangzhou (named as PEM-HZ) was employed, because it offered the best methane production performance. Methane production and Fe (III) reduction proceeded in parallel in the presence of magnetite. Inhibition experiments with 2-bromoethane sulfonate (BES) or phosphate showed that interspecies hydrogen transfer and Fe (III) reduction also occurred in methane production from ethanol. 16S rRNA-based Illumina sequencing results showed that Dechloromonas, Thauera, Desulfovibrio and Clostridium were the dominant putative Fe (III) -reducers, and that hydrogenotrophic Methanobacterium accounted for about 88% of the total archaeal community. These results indicated that magnetite nanoparticles that acted as electron acceptor could facilitate rapid oxidation of ethanol by members of the Fe (III) -reducers in PEM-HZ and establishment of the syntrophic relationship of Fe (III) -reducers with Methanobacterium via interspecies hydrogen transfer. Our results could offer a model to understand the microbial interaction with magnetite from a novel angle during methanogenesis.