Hydrothermal pretreatment on the anaerobic digestion of washed vinegar residue

Efficient Co-Production of Xylooligosaccharides and Glucose from Vinegar Residue by Biphasic Phenoxyethanol-Maleic Acid Pretreatment

A new biphasic organic solvent, phenoxyethanol-maleic acid, was carried out to pretreat and fractionate vinegar residue into glucan, xylan and lignin under mild conditions. Additional effects of key factors, temperature and phenoxyethanol concentration, on vinegar residue, were evaluated. Under the biphasic system (0.5% maleic acid, 60% phenoxyethanol), 140 °C cooking vinegar residue for 1 h, 80.91% of cellulose retention in solid residue, 75.44% of hemicellulose removal and 69.28% of lignin removal were obtained. Optimal identified conditions resulted in maximum XOS of 47.3%. Then, the solid residue was enzymatically digested with a glucose yield of 82.67% at 72 h with the addition of 2.5 g/L bovine serum albumin. Finally, the residue was characterized by SEM, FTIR, XRD and BET analysis. This work demonstrated the phenoxyethanol-maleic acid pretreatment yielded XOS, fermentable sugar, and lignin with high processibility.

A Review of the Current State and Future Prospects in Resource Recovery of Chinese Cereal Vinegar Residue

Vinegar residue (VR) is a typical organic solid waste in Chinese cereal vinegar production. It is characterized by high yield, high moisture and low pH and is rich in lignocellulose and other organic matter. To avoid the environmental pollution caused by VR, it should be properly treated. The industry’s existing treatment processes, landfills and incineration, cause secondary pollution and waste of resources. Therefore, there is an urgent demand for environmentally friendly and cost-effective resource recovery technologies for VR. To date, a considerable amount of research has been performed in the area of resource recovery technologies for VR. This review summarizes the reported resource recovery technologies, mainly anaerobic digestion, feed production, fertilizer production, high-value product production and soil/water remediation. The principles, advantages and challenges of these technologies are highlighted. Finally, as a future perspective, a cascade and full utilization model for VR is proposed by considering the inherent drawbacks and economic-environmental feasibility of these technologies.

Characteristic and calculation on the co-contribution in the bio-H2 energy recovery enhancement with low temperature pretreated peanut shell as co-substrate

Bio-H₂ production from organic wastewater together with lignocellulose wastes not only achieved the H₂ energy recovery, but also be beneficial to carbon emission reduction and carbon neutralization. In order to obtain higher energy recoveries, promotion attempts were performed in bio-H₂ fermentation with low temperature (-80-0 °C) pretreated peanut shell powder (PSP) as co-substrate. A maximum H₂ production of 109.2 mL was obtained as almost double of the sum from the same amount of untreated PSP and glucose as sole substrate. The enhancement was co-contributed by 44% from PSP supplementary, 35% from low-temperature pretreatment, and 2.8% from buffer effect and acidification, respectively, and realized through C/N balancing, PSP conversion influencing, fermentative pH buffering and time prolonging. The experimental results uncovered the co-contribution realization ways of supplementing low-temperature pretreated lignocellulose wastes in the bio-H₂ fermentation system, and provided mechanism support for application potential of low-temperature pretreatment on lignocellulose wastes in cold regions.

Effects of combined ultrasonic and grinding pre-treatments on anaerobic digestion of vinegar residue: organic solubilization, hydrolysis, and CH4 production

ABSTRACTThe high lignocellulose content of vinegar residues (VR) limits their biochemical methane potential (BMP) in anaerobic digestion (AD). However, unlike reported high cellulosic materials such as straw and grass, single pre-treatment with ultrasonication or grinding only slightly improved VR AD, due to the high protein and carbohydrate contents of VR. This study used statistical analysis to show that the methane yield, protein and polysaccharide release, and hydrolysis performance during VR AD were significantly enhanced with a combined grinding-ultrasound pre-treatment. Specifically, at 60 min of ultrasonic, the group with the combined pre-treatment (60 min + RS) showed the highest VR BMP (∼307.1 mLCH₄/gVS), 68.7% greater than that in the control group. This group also exhibited optimal conditions for dissolution of polysaccharide and protein, with accumulated amounts of ∼500 and 1600 mg/L, respectively. The highest volatile fatty acid (VFA) concentration in the 60 min + RS group was 61.5% higher than that in the control group. Both dissolution and hydrolysis experiments suggested that ultrasound accelerated protein release from VR, particularly after the particle size was reduced, and that the grinding pre-treatment had a positive effect on polysaccharide release.

The role of waste management in reducing bioplastics' leakage into the environment: A review

Bioplastics are becoming more and more widespread as substitutes for petroleum-derived plastics due to their biodegradability. Bioplastics degradation under different environments has been described and reported to depend mainly on bioplastics' compositions and the environmental conditions. Incomplete degradation during waste management processes and leakage of bioplastics into the environment are becoming major concerns that need to be further investigated. In this context, the present paper aimed to review recent literature dealing with biodegradation of bioplastics under industrial (e.g. anaerobic digestion and composting) and natural (e.g. soil and water) environments, and to link it to the potential bioplastics' leakage into the environment. Reviewed data were used to estimate the potential role of waste management processes in decreasing the potential leakage of bioplastics. Depending on bioplastics' type and processing conditions, waste management can effectively reduce bioplastics' potential leakage, decreasing the concentration of these materials that can reach the natural environments.

Using Vinegar Residue-Based Carrier Materials to Improve the Biodegradation of Phenanthrene in Aqueous Solution

A large amount of vinegar residue (VR) is generated every year in China, causing serious environmental pollutions. Meanwhile, as a kind of persistent organic pollutants, polycyclic aromatic hydrocarbons (PAHs) ubiquitously exist in environments. With a goal of reusing VR and reducing PAHs pollutions, we herein isolated one B. subtilis strain, ZL09-26, which can degrade phenanthrene and produce biosurfactants. Subsequently, raw VR was dried under different temperatures (50 °C, 80 °C, 100 °C and 120 °C) or pyrolyzed under 350 °C and 700 °C, respectively. After being characterized by various approaches, the treated VR were mixed with ZL09-26 as carriers to degrade phenanthrene. We found that VR dried at 50 °C (VR50) was the best in promoting the growth of ZL09-26 and the degradation of phenanthrene. This result may be attributed to the residual nutrients, suitable porosity and small surface charge of VR50. Our results demonstrate the potential of VR in the biodegradation of phenanthrene, which may be meaningful for developing new VR-based approaches to remove PAHs in aqueous environments.

Pretreatments for enhanced biomethane production from buckwheat hull: Effects on organic matter degradation and process sustainability

Buckwheat manufacturing produce a large amount of lignocellulosic residue (buckwheat hull), which could be used as substrate in anaerobic digestion, even if hard lignocellulosic structure represents the main obstacle for its degradation. This study presents the results of a laboratory experiment conducted to evaluate the effects of different pretreatments on buckwheat hull anaerobic digestion. To achieve the aim, five pretreatments (alkaline, thermo-alkaline, microwave, ultrasonication and low temperature thermal pretreatment) were studied and the results were compared to non treated buckwheat hull. Cumulative biomethane yields significantly increased after alkaline and thermo-alkaline pretreatments (+61% and +122% with respect to non treated hull, respectively). These results were mainly related to organic matter solubilisation (+772% and +859% of soluble reducing sugars, respectively) and lignin, hemicellulose and cellulose degradation. Overall, process parameters behaviour and digestate quality were not affected by the pretreatments. Alkaline and thermo-alkaline pretreatments were evaluated for their energetic and economic affordability, showing that combination of thermal and alkaline pretreatments ensures significant advantages.

Why can hydrothermally pretreating lignocellulose in low severities improve anaerobic digestion performances?

A lignocellulosic residue, rice straw, was hydrothermally pretreated for the whole slurry anaerobic digestion. In contrast to the unpretreated rice straw, 110-120 °C pretreatment promoted biogas yield by 35%-38%, while only 14% promotion happened on the pretreatment at 180 °C. To understand why this improvement happened at lower severities, the pretreated rice straw at 90 °C, 120 °C, and 180 °C were selected for the further investigation, in which the liquor and solid fraction were separated for digestion, and compared with the whole slurry digestion. Results indicated more methane was released from the derived liquor of 180 °C than that of 90 °C and 120 °C, however, solid fraction did not exhibit significantly different methane yields (187.77-193.91 mL/g TS). These results suggested that the released soluble fraction from pretreatment could facilitate the methanogenesis. Furthermore, the released inherent soluble fraction in rice straw was mainly responsible for higher biogas yield at lower temperatures. Pretreatment at higher temperatures disintegrated the rice straw recalcitrance more, and intensified the release of soluble fraction accordingly. Consequently, the methanogenesis of whole slurry could be promoted at the initial digestion; the hydrolysis/acidification of the solid fraction in whole slurry was weakened greatly, which resulted in a lower biogas yield. This can also be proved by the evolution of dominant bacteria and archaea in the anaerobic digestion of whole slurry, separated solid and liquor fraction.

The effects of solid lignin on the anaerobic digestion of microcrystalline cellulose and application of smoothing splines for extended data analysis of its inhibitory effects

Lignocellulose is an abundant substrate for biogas production; however, for efficient utilization, proper pre-treatment is required to enhance the biomethane yield and hydrolysis rate significantly. Phenolic compounds from dissolved lignin, produced during alkali pre-treatment, have inhibitory effects on the anaerobic digestion; however, the possible inhibitory effects of solid lignin have not gathered enough interest. Especially, the effect of solid lignin on methanogenesis remains a knowledge gap. In this study, kraft lignin was used as a model solid lignin substrate for its co-digestion with microcrystalline cellulose. A new approach of modelling biomethane production curves using smoothing splines was developed to describe the long-term inhibitory effects of solid lignin on hydrolysis and methanogenesis. The method gives possibility to describe long-term inhibitory effects by using batch instead of continuous test data. Results revealed that kraft lignin showed mild inhibitory effects on methanogens. However lignin impact combined with volatile fatty accumulation can prolong hydrolysis and reactor recovery start-up by 47.3% and 75.3%, respectively. For small dosages of solid lignin adaptation of methanogens is possible.

Effects of hydrothermal pretreatment on the mono- and co-digestion of waste activated sludge and wheat straw

The refractory properties of waste activated sludge and wheat straw inhibit their bioenergy recovery by anaerobic digestion. This paper attempted to estimate the digestive performance, energy conversion efficiency and economic feasibility of wheat straw mono-digestion and its co-digestion with sludge by hydrothermal pretreatment at different temperature gradients (125, 150 and 175 °C). The results illustrated that the hydrolysis of both wheat straw and sludge were improved with the temperature increasing. It is noted that after pretreatment at 175 °C, wheat straw mono-digestion obtained the cumulative specific methane yield of 168.8 mL/g·VS, 6.9% reduction compared to the unpretreated straw (181.4 mL/g·VS) due to the inhibition by by-products (furfural and 5-hydroxymethylfurfural, 5-HMF) formed at high temperatures. The highest cumulative specific methane yield of 225.7 mL/g·VS was achieved by the co-digestion of pretreated wheat straw and pretreated sludge under 175 °C, indicating that the participation of sludge in co-digestion improved the buffer capacity of the system to relieve the inhibition. In addition, the co-digestion of sludge and wheat straw both pretreated at 175 °C obtained the maximum energy production of 7901.1 MJ/t, 52% promotion compared to the mono-digestion without pretreatment. The results of economic analysis showed that the mono-digestion of wheat straw obtained relatively low net profits and the mono-digestion of sludge pretreated at 175 °C achieved the highest net profit of 31.44 US$/t. These results suggest that the co-digestion of both pretreated wheat straw and sludge can achieve the highest biogas production and energy conversion efficiency.

Activation or sequestration of heavy metals during hydrothermal process of swine manure: Interactions among metal species and particulates

Whether the heavy metals in solid biomass is activated or sequestrated during hydrothermal process (HTP) is still debated. Herein, the speciation of light and heavy metals during HTP of swine manure (SM) was investigated to reveal the interactions among these metal species and specific particulates. With increasing temperature, most of exchangeable species and that bound to carbonates were released to liquid phase via ion exchange and acid dissolution. Dissociation of Fe-Mn oxides rarely happened in spite of anoxic atmosphere formed during HTP. Substantial decomposition of lignocelluloses hardly caused significant liberation of fraction bound to organics. Instead, a part of fraction in liquid phase was re-captured by new oxygen-containing functional groups on solid product surface to form fraction bound to organics. Donpeacorite, butschliite and iwakiite were formed as primary minerals, resulting in increase of residual fraction of all metals except for K and Mg at 250 °C. In summary, Cu, Zn and Pb species evolution was affected by speciation of K, Ca, Mg, Fe and Mn significantly. Cu, Zn, Pb, Fe, Mn and Ca were sequestrated whereas K and Mg were activated with enhancing temperature during HTP in terms of their mobility factors.

Knowledge Domain and Emerging Trends in Vinegar Research: A Bibliometric Review of the Literature from WoSCC

Vinegar is one of the most widely used acidic condiments. In recent decades, rapid advances have been made in the area of vinegar research, and the intellectual structure pertaining to this domain has significantly evolved. Thus, it is important that scientists keep abreast of associated developments to ensure an appropriate understanding of this field. To facilitate this current study, a bibliometric analysis method was adopted to visualize the knowledge map of vinegar research based on literature data retrieved from the Web of Science Core Collection (WoSCC) database. In total, 883 original research and review articles from between 1998 and 2019 with 19,663 references were analyzed by CiteSpace. Both a macroscopical sketch and microscopical characterization of the whole knowledge domain were realized. According to the research contents, the main themes that underlie vinegar research can be divided into six categories, that is, microorganisms, substances, health functions, production technologies, adjuvant medicines, and vinegar residues. In addition to the latter analysis, emerging trends and future research foci were predicted. Finally, the evolutionary stage of vinegar research was discerned according to Shneider's four-stage theory. This review will help scientists to discern the dynamic evolution of vinegar research, as well as highlight areas for future research.

Liquid hot water pretreatment to enhance the anaerobic digestion of wheat straw-effects of temperature and retention time

Wheat straw is an abundant agricultural waste that is rich in lignocellulose. However, its waxy surface, highly crystallized structure, and limited surface area make it difficult to be hydrolyzed and used efficiently by microorganisms. Liquid hot water (LHW) pretreatment was studied to explore the feasibility of improving the methane yield of wheat straw in anaerobic digestion (AD). The results showed that the crosslinking structure of wheat straw was broken by LHW pretreatment. Some pores and cracks appeared on the surface of the pretreated wheat straw, increasing the microbial attachment sites. Under different hydrothermal temperatures (150-225 °C) and retention times (5-60 min), the degradation of hemicellulose ranged from 27.69 to 99.07%. The maximum methane yield (201.81 mL CH₄/g volatile solids) was achieved after LHW pretreatment at 175 °C for 30 min, which was a 62.9% increase compared with non-treated straw. LHW at high temperatures such as 225 °C was not suitable for the AD of wheat straw. Methane yield results were fitted with the first-order and modified Gompertz equations to evaluate the hydrolysis rate and inhibitory effects of the pretreated materials in AD.

Effect of hydrothermal pretreatment severity on the pretreatment characteristics and anaerobic digestion performance of corn stover

The pretreatment characteristics and anaerobic digestion (AD) performance of corn stover were investigated at different hydrothermal pretreatment (HP) severity levels. The pretreatment of corn stover with and without ammonia was performed at different temperatures (100, 150, and 200 °C) and with a holding time of 5-30 mins. Results showed that after HP, the highest volatile fatty acid (VFAs) concentration was 10533.94 mg/L at a HP severity of 7.27, which was 1.72-3.35 times greater than those of others HP severity levels. Similarly, the highest removal rates of hemicellulose and lignin were 95.41% and 13.85% for HP severity levels of 6.81 and 1.98, respectively. The maximum biogas and methane increasing yield at 100 °C holding 30 min without ammonia were 16.26% and 22.74% greater than that of the untreated, respectively. These results suggest that an appropriate HP intensity can promote biogas production.

A novel strategy for efficient anaerobic co-digestion based on the pretreatment of corn stover with fresh vinegar residue

A novel method was advanced for efficient anaerobic co-digestion by using fresh vinegar residue (FVR) as acidifier for pretreating corn stover (CS). FVR acted as one substrate as well as an acidifier by the acids contained in FVR. It was found that the organic acids in FVR could efficiently enhance the hydrolysis of lignocellulose in CS. The biomethane production from co-digestion of FVR and CS pretreated reached 140.48 L/kg VS, which was 35.7% higher than that of unpretreated mixture substrates. The highest biomethane production was obtained when pretreatment was conducted at 150 °C. The increase of biomethane production was contributed to the improved hydrolysis of CS due to the acidic pretreatment. Pretreatment and co-digestion could improve the asynchronism and generate synergistic effect. The study provides one novel method for efficient biomethane conversion from FVR and CS.

Hemp-Straw Composites: Gluing Study and Multi-Physical Characterizations

In order to meet the requirement of sustainable development, building materials are increasingly environmentally friendly. They can be partially or fully bio-based or recycled. This paper looks at the development of fully bio-based composites where agro-resources are valued as bio-based aggregates (hemp) and as binding materials (wheat). In a previous work, a feasibility study simultaneously investigated the processing and ratio of wheat straw required to ensure a gluing effect. In this paper, three kinds of hemp-straw composites are selected and compared with a hemp-polysaccharides composite. The gluing effect is analyzed chemically and via SEM. The developed composites were characterized multi-physically. They showed sufficiently high mechanical properties to be used as insulating materials. Furthermore, they showed good thermal performances with a low thermal conductivity (67.9–69.0 mW/(m·K) at 23 °C, dry).

Anaerobic digestion and the effect of hydrothermal pretreatment on the biogas yield of cocoa pods residues

The current research investigated the possibility of valorizing cocoa pods residues through anaerobic digestion and the possibility of increasing the biogas yield by hydrothermal pretreatment. Using a central composite surface response methodology, the effect of temperature and reaction time on the hydrothermal pretreatment process was studied. Temperature and reaction time was varied between 150-220 °C and 5-15 min respectively. The result show that untreated cocoa pods residues has a biogas potential of 357 l(N)/kgVS and a methane content of 55%. The effect of hydrothermal pretreatment on the biogas yield was diverse. Severities below 3.0 resulted in increased biogas yield. However, higher severity resulted in lower biogas yield. The optimum biogas yield (526.38 l(N)/kgVS) was obtained at 150 °C and 15 min, which represents a severity of 2.65.

Selective Conversion of Phenol in a Subcritical Water Medium Using γ-Al2O3 Supported Ni–Co Bimetallic Catalyst

The selective conversion of phenolic materials is a well-adopted solution to upgrade lignin-based bioresources into high-value bio-oil in biomass refinery industries. This study focused on four main aspects: characterization, selection of catalysts, reaction dynamics behaviors, and mathematical modelling. A model lignin, that is, phenol, was selectively transformed into cyclohexanol by using the prepared Ni–xCo/γ-Al2O3 catalysts in a subcritical water medium. The hydrogenation results showed that when using 15 wt% of Ni–3Co/γ-Al2O3 particles, both total mole yield and selectivity of cyclohexanol could reach approximately 80%, which further indicated that the particles are suitable for catalytic hydrogenation of phenol in subcritical water. Moreover, a reaction kinetics model was developed by chemical reaction kinetics and least squares regression analysis, the robustness and predictability of which were also verified.

Effect of thermal pretreatment on chemical composition, physical structure and biogas production kinetics of wheat straw

Hard lignocellulosic structure of wheat straw is the main hindrance in its anaerobic digestion. Thus, a laboratory scale batch experiment was conducted to study the effect of thermal pretreatment on anaerobic digestion of wheat straw. For this purpose, different thermal pretreatment temperatures of 120, 140, 160 and 180 °C were studied and the results were compared with raw wheat straw. Significant differences in biogas production were observed at temperature higher than 160 °C. Highest biogas yield of 615 Nml/gVS and volatile solids reduction of 69% was observed from wheat straw pretreated at 180 °C. Wheat straw pretreated at 180 °C showed 53% higher biogas yield as compared to untreated. Further, FTIR analysis revealed change in chemical bonds of lignocellulosic structure of wheat straw. Modified Gompertz model was best fitted on biogas production data and predicted shorter lag phase time and higher biogas production as the pretreatment temperature increased. Overall, change in lignocellulosic structure and increase in cellulose content were the main reason in enhancing biogas production.