In vitro aflatoxin adsorption by means of a montmorillonite silicate. A study of adsorption isotherms

Nursery pigs fed with feed contaminated by aflatoxin B1 (Aspergillus flavus) and anti-mycotoxin blend: Pathogenesis and negative impact on animal health and weight gain

The present study aimed to evaluate whether a moderate dose of aflatoxin B1 in pigs' diet interferes with pigs' growth and health in the nursery phase and whether an anti-mycotoxin mixture minimizes the adverse effects of the toxin. One blend with Saccharomyces cerevisiae lysate, zeolite, silicon dioxide, propylene glycol, Carduus marianus extract, soy lecithin, and carbonate was used as an anti-mycotoxin. Four treatments, with six repetitions per treatment and three pigs/pen: Afla0-AntiMyc0 - negative control (without aflatoxin); Afla500-AntiMyc0 - positive control (500 ppb of aflatoxin); Afla0-AntiMyc1000 - 1000 mg/kg of anti-mycotoxin blend; Afla500-AntiMyc1000 - 500 ppb aflatoxin +1000 mg/kg of anti-mycotoxin blend. It was observed that pigs in the positive control (Afla500-AntiMyc0) had lower body weight and weight gain when compared to the other treatments during the experimental period. Also, pigs from Afla500-AntiMyc0 had lower feed intake between days 1-20 and 1 to 30 than Afla0-AntiMyc0. The pigs from Afla500-AntiMyc0 had higher levels of liver enzymes aspartate aminotransferase and alanine aminotransferase compared to other treatments. The pigs from Afla500-AntiMyc0 had higher villus height than the other treatments, while the folded size was smaller in this treatment. Crypts were deeper in the intestines of pigs in both treatments that consumed aflatoxin. In general, it is concluded that the intake of aflatoxin B1 by nursery pigs has negative impacts on the health and, consequently, the animals' growth performance; however, the addition of the contaminated feed with an anti-mycotoxin blend was able to protect the pigs, minimizing the adverse effects caused by the mycotoxin.

Invited review: Remediation strategies for mycotoxin control in feed

Mycotoxins are secondary metabolites of different species of fungi. Aflatoxin B1 (AFB1), deoxynivalenol (DON), zearalenone (ZEN) and fumonisin B1 (FB1) are the main mycotoxins contaminating animal feedstuffs. These mycotoxins can primarily induce hepatotoxicity, immunotoxicity, neurotoxicity and nephrotoxicity, consequently cause adverse effects on the health and performance of animals. Therefore, physical, chemical, biological and nutritional regulation approaches have been developed as primary strategies for the decontamination and detoxification of these mycotoxins in the feed industry. Meanwhile, each of these techniques has its drawbacks, including inefficient, costly, or impractically applied on large scale. This review summarized the advantages and disadvantages of the different remediation strategies, as well as updates of the research progress of these strategies for AFB1, DON, ZEN and FB1 control in the feed industry.

Saccharomyces cerevisiae Cell Wall-Based Adsorbent Reduces Aflatoxin B1 Absorption in Rats

Mycotoxins are naturally occurring toxins that can affect livestock health and performance upon consumption of contaminated feedstuffs. To mitigate the negative effects of mycotoxins, sequestering agents, adsorbents, or binders can be included to feed to interact with toxins, aiding their passage through the gastrointestinal tract (GI) and reducing their bioavailability. The parietal cell wall components of Saccharomyces cerevisiae have been found to interact in vitro with mycotoxins, such as, but not limited to, aflatoxin B1 (AFB1), and to improve animal performance when added to contaminated diets in vivo. The present study aimed to examine the pharmacokinetics of the absorption of radiolabeled AFB1 in rats in the presence of a yeast cell wall-based adsorbent (YCW) compared with that in the presence of the clay-based binder hydrated sodium calcium aluminosilicate (HSCAS). The results of the initial pharmacokinetic analysis showed that the absorption process across the GI tract was relatively slow, occurring over a matter of hours rather than minutes. The inclusion of mycotoxin binders increased the recovery of radiolabeled AFB1 in the small intestine, cecum, and colon at 5 and 10 h, revealing that they prevented AFB1 absorption compared with a control diet. Additionally, the accumulation of radiolabeled AFB1 was more significant in the blood plasma, kidney, and liver of animals fed the control diet, again showing the ability of the binders to reduce the assimilation of AFB1 into the body. The results showed the potential of YCW in reducing the absorption of AFB1 in vivo, and in protecting against the damaging effects of AFB1 contamination.

Effects of montmorillonite on the growth performance, immunity, intestinal morphology and caecal microflora of broilers

Context Montmorillonite (MMT), as a potential antibiotic alternative, has rarely been reported in broiler chickens. Aims The present study was conducted to determine the effects of dietary MMT supplementation on the growth performance, immunity, intestinal microflora and morphological features of broilers. Methods One-day-old male broilers (Arbor Acres; n = 240) were randomly assigned to the following four groups before a 42-day feeding trial: (i) basal diet with no supplementation (control group); (ii) basal diet supplemented with 0.1% MMT; (iii) basal diet supplemented with 0.2% MMT; and (iv) basal diet supplemented with 0.3% MMT. Key results The results demonstrated that supplementation with 0.1% and 0.2% MMT markedly improved the average daily gain of broilers compared with the control group. Moreover, supplementation with 0.1% MMT remarkably decreased the total viable count of Escherichia coli in the caecum of broilers. Compared with the control group, 0.1% MMT supplementation significantly elevated the concentrations of secretory immunoglobulin A and systemic immunoglobulin G in the jejunal mucosa of broilers (P < 0.05). Furthermore, MMT supplementation was associated with a greater villus height (VH) and a higher ratio of VH to crypt depth (CD) in the intestinal mucosa of broilers (P < 0.05). However, in the duodenal and jejunal mucosa, dietary supplementation with MMT exhibited no significant (P > 0.05) impact on the CD values of broilers compared with the control group. Conclusions This study showed that supplementation with 0.1% MMT could enhance broiler growth, increase the small intestinal VH and the VH:CD ratio, promote the intestinal-mucosa development, affect microflora population and improve immune function in the intestinal tract of broilers. Implications Supplementation with MMT could alter morphological changes in the intestinal villi, regulate microbial population and improve immune function in the intestinal tract, thus contributing to broiler growth. Our results indicated that MMT may serve as a natural beneficial feed additive for poultry gut health.

Preparation of magnetic mesoporous silica from rice husk for aflatoxin B1 removal: Optimum process and adsorption mechanism

The liquid foodstuffs such as edible oil products remain a problem of excessive aflatoxin B1 (AFB1) content. This paper focused on the preparation of magnetic mesoporous silica (MMS) from rice husk ash for the removal of AFB1 in oil system. The MMS preparation process, adsorption conditions, structural characteristics, and adsorption mechanism were investigated. The optimum conditions for MMS preparation were pH 11.0 and 80°C for 24 h. The characterization results showed that magnetic particles were successfully embedded in the MMS and had high responsiveness to a magnetic field, which was advantageous for recyclability. The MMS had ordered uniform channels with a specific surface area of 730.98 m2/g and pore diameter of 2.43 nm. The optimum adsorption conditions were 2 h at 20°C. For AFB1 with an initial concentration of 0.2 μg/mL, the MMS adsorption capacity was 171.98 μg/g and the adsorption rate was 94.59%. The MMS adsorption isotherm fitted the Langmuir model well under the assumption of monolayer AFB1 adsorption with uniformly distributed adsorption sites on the MMS surface. The maximum amount of AFB1 adsorbed according to the Langmuir isotherm was 1118.69 μg/g. A quasi-second-order kinetic model gave a better fit to the process of AFB1 adsorption on MMS. The values of ΔH (-19.17 kJ/mol) and ΔG (-34.09, -34.61, and -35.15 kJ/mol at 283, 293, and 303 K, respectively) were negative, indicating that AFB1 adsorption on MMS was a spontaneous exothermic process. The results indicated that MMS was a promising material for AFB1 removal in oil system, and this study will serve as a guide for practical MMS applications.

Dietary montmorillonite as growth promoter and immunomodulator in rainbow trout (Oncorhynchus mykiss)

A 98-day research was conducted to assess the influence of dietary montmorillonite (MMT) on growth and immune competence in rainbow trout (Oncorhynchus mykiss). Fish fry (mean weight: 500 ± 35 mg) were fed with four experimental diets contained MMT at levels of 0 (as control group), 1, 2 and 4%. At the end of the experiment, the survival rate and growth parameters and serum total protein and albumin levels in MMT experimental groups was higher than the control group. Regarding humoral immune responses, fish being fed with 2 and 4% MMT diets showed the greatest and the lowest serum C₃, C₄ and lysozyme levels, respectively. Serum alternative complement pathway activity (ACH50) in groups fed with 1 and 2% MMT supplemented diets was higher than the other groups. At the end of the challenge test with VHSV, the mortality rate reached to 28 and 20% in the control group and 4% MMT supplemented groups, respectively, whereas fish fed with 1 and 2% MMT supplemented diets showed the lowest mortality rate (2.5%) Fish fed with 1 and 2% MMT supplemented groups showed higher head kidney IL-1β and TNF-α genes expression compared to the other treatment groups. In addition, fish fed with 2% MMT-supplemented diet had the highest head kidney Lyz-2 gene expression. In summary, the results of this research suggests that supplementing diet with MMT at 1 or 2% improve growth and non-specific humoral immune responses and induce head kidney immune relate genes expression and disease resistance against VHS in O. mykiss.

Functionalized nanoflower-like hydroxyl magnesium silicate for effective adsorption of aflatoxin B1

Aflatoxin B1 (AFB1), which is widely found in food and feed, poses a serious threat to the health of human and livestock. In this work, functionalized nanoflower-like hydroxyl magnesium silicate (FNHMS) was synthesized for adsorption of AFB1. First, bulk magnesium silicate (MS) was converted into nanoflower-like hydroxyl magnesium silicate (NHMS) by hydroxylation. Cetyltrimethylammonium bromide (CTMAB) modification then enhanced the hydrophobicity and the affinity to AFB1 of NHMS. The adsorption performance for AFB1 followed the order of MS < NHMS < FNHMS, and the adsorption performance increased with the increase of the dose of CTMAB. Isothermal adsorption analysis indicated that the surface of FNHMS was heterogeneous. The adsorption capacity of FNHMS-0.4 to AFB1 was estimated to be 27.34 mg g^-1 and 28.61 mg g^-1 by Freundlich and Dubinin-Radushkevich isotherm adsorption model, respectively. By analyzing the adsorption kinetics and adsorption thermodynamics, both physical adsorption and chemisorption existed in the process of AFB1 being adsorbed on FNHMS-0.4. Adsorption mechanisms analysis indicated that the adsorption followed the adsorption site priority of H > O > Mg. This work demonstrates that FNHMS could be a promising adsorbent for removal of AFB1.

Decontamination of Mycotoxin-Contaminated Feedstuffs and Compound Feed

Mycotoxins are known worldwide as fungus-produced toxins that adulterate a wide heterogeneity of raw feed ingredients and final products. Consumption of mycotoxins-contaminated feed causes a plethora of harmful responses from acute toxicity to many persistent health disorders with lethal outcomes; such as mycotoxicosis when ingested by animals. Therefore, the main task for feed producers is to minimize the concentration of mycotoxin by applying different strategies aimed at minimizing the risk of mycotoxin effects on animals and human health. Once mycotoxins enter the production chain it is hard to eliminate or inactivate them. This paper examines the most recent findings on different processes and strategies for the reduction of toxicity of mycotoxins in animals. The review gives detailed information about the decontamination approaches to mitigate mycotoxin contamination of feedstuffs and compound feed, which could be implemented in practice.

The mechanism of anionic polyacrylamide adsorption on the montmorillonite surface in the presence of Cr(VI) ions

The anionic polyacrylamide AN PAM (with various contents of carboxyl groups) adsorption mechanism on the montmorillonite surface was examined. The effect of hazardous chromium(VI) ions addition was studied. The anionic polyacrylamide is a popular soil flocculant, commonly used to prevent erosion of arable soils. On the other hand, polymeric macromolecules can increase the accumulation of various toxic substances, such as heavy metal ions (among others Cr(VI) ions) in soil minerals. For this purpose the adsorption properties of soil mineral - montmorillonite in relation to mixed system containing AN PAM and Cr(VI) ions was investigated. The impact of solution pH, order of individual adsorbates addition, chromium(VI) ions concentration and anionic groups content in the polymeric macromolecules were determined. The montmorillonite was characterized using the low-temperature nitrogen adsorption/desorption method, XRF, FTIR and SEM techniques. In turn, the adsorption and electrokinetic properties of examined montmorillonite - AN PAM - Cr(VI) systems were examined by means of spectrophotometry, potentiometric titration and microelectrophoresis methods.

Effect of Montmorillonite on 4-Nonylphenol Enrichment in Zebrafish

The aim of this study was to investigate the effect of montmorillonite on nonylphenol (4-nonylphenol, 4-NP) enrichment in a zebrafish model. The AB strain zebrafish were used as the animal subjects, and three concentration gradients were set for both nonylphenol and montmorillonite, according to their actual concentrations in aquaculture water in Huzhou City. A group treated with nonylphenol alone was also set, adding up to 12 experimental groups. Concentrations of nonylphenol enriched in the liver, muscle and gills of zebrafish were detected by solid phase microextraction–high performance liquid chromatography at Days 7, 15 and 30, respectively. Additionally, the relative enzymatic activity of superoxide dismutase (SOD) and the glutathione S-transferase (GST) were also detected, and the data were statistically analyzed. The results showed that the concentrations of nonylphenol in zebrafish peaked at Day 7 and gradually decreased afterwards for all the experimental groups. The montmorillonite reduces short-term accumulation of nonylphenol in gills, and the high concentration of nonylphenol facilitates its enrichment in liver and muscle, while the low concentration of nonylphenol does not. Meanwhile, the low concentration of nonylphenol in liver exerts an influence on the inductive effect of SOD and GST, while the high concentration of nonylphenol shows the inhibiting effect of SOD and GST.

Probiotic characteristics and zearalenone-removal ability of a Bacillus licheniformis strain

Zearalenone (ZEN) is a mycotoxin produced by Fusarium species, which is one of the main animal feed contaminants causing reproductive disorders in livestock. The aim of this study was to evaluate the probiotic characteristics and ZEN removal ability of a Bacillus licheniformis strain CK1. The probiotic properties, including acidic tolerance, bile salt tolerance, adherence capability, and anti-pathogenic activities of CK1 were evaluated. CK1 survived after incubation at pH 2.0 or 3.0 for 3 h, grew well in LB broth containing 0.3% oxgall, possessed adherence capability to Caco-2 cells, and inhibited the growth of Escherichia coli O157:H7 and Listeria monocytogenes. The ZEN removal ability of CK1 was compared with a mineral mycotoxin-adsorbing agent, hydrated sodium calcium aluminosilicate (HSCAS), and a well-characterized biological mycotoxin-adsorbing agent, Lactobacillus rhamnosus GG (LGG). At 37°C in phosphate-buffered saline (PBS, pH 7.0) containing 5 μg mL^-1 of ZEN, the ZEN removal percentage of CK1 was 73.0%, which was significantly higher than that of HSCAS and LGG (45.9% and 48.4%, respectively). In the pH range of 2.5–8.0, CK1 removed up to 65% of ZEN. At temperatures between 4 and 42°C, CK1 removed more than 75% of ZEN. In the adsorption stability analysis, the amounts of ZEN removed by CK1 was over 30% even after five consecutive rounds of washing procedures. These findings demonstrated that CK1 displayed probiotic characteristics and removed ZEN effectively. Therefore, CK1 has a great potential for the development of feed additive to remove ZEN.

A review of the mycotoxin adsorbing agents, with an emphasis on their multi-binding capacity, for animal feed decontamination

Contamination of animal feed with mycotoxins still occurs very often, despite great efforts in preventing it. Animal feeds are contaminated, at low levels, with several mycotoxins, particularly with those produced by Aspergillus and Fusarium genera (Aflatoxin B_1, Ochratoxin A, Zearalenone, Deoxynivalenol and Fumonisina B₁). In animal feed, to date, only Aflatoxin B₁ is limited through EU regulation. Consequently, mycotoxins cause serious disorders and diseases in farm animals. In 2009, the European Union (386/2009/EC) approved the use of mycotoxin-detoxifying agents, as feed additives, to prevent mycotoxicoses in farm animals. The present review gives an overview of the problem of multi-mycotoxin contamination of feed, and aims to classify mycotoxin adsorbing agents (minerals, organic, and synthetic) for feed decontamination, focusing on adsorbents with the ability to bind to multiple mycotoxins, which should have a more effective application in farms but they are still little studied in scientific literature.

Evaluation of nonionic surfactant modified montmorillonite as mycotoxins adsorbent for aflatoxin B1 and zearalenone

This work aims at exploring the potential of nonionic surfactant octylphenol polyoxyethylene ether (OP-10) modified montmorillonites (NMts) as mycotoxins adsorbent. The resulting NMts has different structural configurations, organic carbon contents, surface hydrophobicity and textural properties at different surfactant loadings. The prepared NMts were used for adsorption of polar aflatoxin B₁ (AFB₁) and weak polar zearalenone (ZER) in both single and binary-contaminate systems by simulating conditions of gastrointestinal tract. The adsorption capacities of NMts to AFB₁ and ZER increased up to 2.78 and 8.54 mg/g respectively from 0.51 and 0.00 mg/g of raw montmorillonite (Mt). High adsorption capacities of NMts to AFB₁ and ZER could be reached at low surfactant loadings. There was little decrease from pH of 3.5 to 6.5 but became negligible with increasing the surfactant loadings. In binary-contaminate adsorption system, the adsorption of ZER was obviously affected by the existence of AFB₁, while ZER had little effect on the adsorption process of AFB₁ due to different adsorption mechanism. This study demonstrates that NMts could be a promising adsorbent for simultaneous detoxification of polar and non-polar mycotoxins.

Effects of hydrated sodium calcium aluminosilicate on growth performance, fatty liver, intestine morphology, and serum parameters of overfed geese

In geese, overfeeding induces hepatic steatosis and makes the liver functions enhanced. Aluminosilicate absorbs toxins created by moulds in animal feeds and enhances nutrient absorption. In the present study, the effects of hydrated sodium calcium aluminosilicate (Improved HSCAS, Jumpstar) on the growth performance, fatty liver, serum parameters, and intestinal morphology of overfed Landes geese were evaluated. The study included two Control groups, a non-overfed Control (Control I) and an overfed Control (Control II), as well as a treatment group. The results showed that compared with the Control I group, liver weight, relative liver weight, abdominal fat weight, intestinal fat weight, villus height, total cholesterol, very low density lipoproteins, lipoprotein lipase, aspartate aminotransferase, IgM, and IgG in the HSCAS treatment group all significantly increased (P < 0.05) at Days 10 and 20. The villus height/crypt depth, triglycerides, cholinesterase, alanine aminotransferase, and serum IgA levels were higher than those in the Control I (P < 0.05) after 20 days of overfeeding. Compared with the Control II group, the relative abdominal fat weight, relative intestinal fat weight, and crypt depth in the HSCAS treatment group were significantly increased (P < 0.05) after 10 days of overfeeding, whereas villus height/crypt depth decreased (P < 0.05). Relative liver weight and IgA were higher in HACAS group after 20 days’ overfeeding (P < 0.05). HSCAS treatment also led to higher cholinesterase, very low density lipoproteins and decreased lipase, alanine aminotransferase (P > 0.05), and decreased aspartate aminotransferase levels than those in the Control II group (P < 0.05). In conclusion, HSCAS treatment had a beneficial effect on fatty liver production, intestinal development, and serum parameters in overfed Landes geese, which could enhance the health status of these geese.

Simultaneous adsorption of aflatoxin B1 and zearalenone by mono- and di-alkyl cationic surfactants modified montmorillonites

Organo-montmorillonites (OMts) modified with mono- and di-alkyl cationic surfactants were prepared to remove polar mycotoxin aflatoxin B₁ (AFB₁) and weak polar, hydrophobic mycotoxin zearalenone (ZER) simultaneously. The structural and surface properties of the prepared OMts were investigated. In vitro adsorption experiments were carried out to simulate the in vivo conditions of gastrointestinal tract of animals by a batch mode. The adsorption of AFB₁ and ZER in both single and binary-contaminate systems were investigated systematically. Both OMts showed super enhanced adsorption capacities towards AFB₁ and ZER whenever in single and binary-contaminate systems compared with raw Mt, indicating the effectiveness of the prepared OMts acted as mycotoxins adsorbents. DODAC-Mt showed a higher adsorption capacity towards AFB₁ and ZER than OTAB-Mt. The equilibrium data of AFB₁ on OMts were fitted satisfactorily with Freundlich and Linear models, suggesting the co-existence of different adsorption mechanism which were proposed to be ion-dipole interactions (between surfactant cations and carbonyl groups of AFB₁) and adsorption/partition mechanisms. The adsorption isotherms of OMts to ZER matched best with Linear models, implying the adsorption/partition mechanism. For simultaneous adsorption, the adsorption process of one mycotoxin was slightly affected by the presence of the other mycotoxin due to the requirement of partial same sorption sites. In addition, the solution pH had negligible influence on the adsorption process of OMts, meaning no desorption occurred when the adsorbents pass through from stomach to intestine as animal feed.

In Vitro Adsorption and in Vivo Pharmacokinetic Interaction between Doxycycline and Frequently Used Mycotoxin Binders in Broiler Chickens

Mycotoxin binders are readily mixed in feeds to prevent uptake of mycotoxins by the animal. Concerns were raised for nonspecific binding with orally administered veterinary drugs by the European Food Safety Authority in 2010. This paper describes the screening for in vitro adsorption of doxycycline-a broad-spectrum tetracycline antibiotic-to six different binders that were able to bind >75% of the doxycycline. Next, an in vivo pharmacokinetic interaction study of doxycycline with two of the binders, which demonstrated significant in vitro binding, was performed in broiler chickens using an oral bolus model. It was shown that two montmorillonite-based binders were able to lower the area under the plasma concentration-time curve of doxycycline by >60% compared to the control group. These results may indicate a possible risk for reduced efficacy of doxycycline when used concomitantly with montmorillonite-based mycotoxin binders.

Effects of graded levels of montmorillonite on performance, hematological parameters and bone mineralization in weaned pigs

The aim of this study was to investigate the effects of graded levels of montmorillonite, a constituent of clay, on performance, hematological parameters and bone mineralization in weaned pigs. One hundred and twenty, 35-d-old crossbred pigs (Duroc×Large White×Landrace, 10.50±1.20 kg) were used in a 28-d experiment and fed either an unsupplemented corn-soybean meal basal diet or similar diets supplemented with 0.5, 1.0, 2.5 or 5.0% montmorillonite added at the expense of wheat bran. Each treatment was replicated six times with four pigs (two barrows and two gilts) per replicate. Feed intake declined (linear and quadratic effect, p< 0.01) with increasing level of montmorillonite while feed conversion was improved (linear and quadratic effect, p<0.01). Daily gain was unaffected by dietary treatment. Plasma myeloperoxidase declined linearly (p = 0.03) with increasing dietary level of montmorillonite. Plasma malondialdehyde and nitric oxide levels were quadratically affected (p<0.01) by montmorillonite with increases observed for pigs fed the 0.5 and 1.0% levels which then declined for pigs fed the 2.5 and 5.0% treatments. In bone, the content of potassium, sodium, copper, iron, manganese and magnesium were decreased (linear and quadratic effect, p<0.01) in response to an increase of dietary montmorillonite. These results suggest that dietary inclusion of montmorillonite at levels as high as 5.0% does not result in overt toxicity but could induce potential oxidative damage and reduce bone mineralization in pigs.

The efficacy of bamboo charcoal in comparison with smectite to reduce the detrimental effect of aflatoxin B1 on in vitro rumen fermentation of a hay-rich feed mixture

Two commercial materials, a bamboo charcoal (BC) and a smectite clay (SC), were assessed in vitro with aflatoxin B1 (AFB1) in an equilibrium adsorption test. The adsorption capacity and proportion adsorbed (0.381 μg/mg, 0.955) for BC were greater than for SC (0.372 μg/mg, 0.931). The effects of in vitro ruminal fermentation of hay-rich feed incubated with 1.0 μg/mL AFB1 for 0-10 g/L doses of BC and SC were measured at 39 °C for 72 h. The BC and SC binders increased AFB1 loss at dosages ≥1.0 g/L (p < 0.0001). Average AFB1 loss (p < 0.0001) was greater for SC (0.904) than BC (0.881). Both SC and SC addition increased in vitro dry matter loss, and the average dry matter losses were similar. Asymptotic gas volume and volatile fatty acid production were greater for BC than for SC (p < 0.0001). Thus, BC may be as effective as SC in removing aflatoxin B1's detrimental effects on rumen degradability and fermentation under the occurrence of microbial aflatoxin degradation.

In vitro evaluation of the capacity of zeolite and bentonite to adsorb aflatoxin B1 in simulated gastrointestinal fluids

Anin vitro study using single concentration and isotherm adsorption was carried out to evaluate the capacity of Vietnamese produced zeolite and bentonite to adsorb aflatoxin B1 (AFB1) in simulated gastrointestinal fluids (SGFs), and a commercial sorbent hydrated sodium calcium aluminosilicate (HSCAS) was used as reference. In this study, AFB1 solution was mixed with sorbents (0.3, 0.4 and 0.5% w/v) in SGFs at pH 3 and pH 7 and shaken for 8 h, centrifuged and the supernatant measured by Vicam fluorometer. Adsorption of AFB1 onto zeolite and bentonite varied according to the pH of SGFs and was lower than HSCAS. Linearity between the increased amount of AFB1 adsorbed on sorbents and the decrease of sorbent concentration was observed for bentonite and HSCAS, except for zeolite in SGFs at pH 7. The observed maximum amounts of AFB1 adsorbed on bentonite and HSCAS were 1.54 and 1.56 mg/g, respectively. The adsorption capacities of bentonite and HSCAS for AFB1 were 12.7 and 13.1 mg/g, respectively, from fitting the data to the Freundlich isotherm equation. Improvement in processing and purification for bentonite is needed to enhance the surface area, which would probably result in better adsorptive capacity for this sorbent.

In vitro and in vivo efficacy of a hydrated sodium calcium aluminosilicate to bind and reduce aflatoxin residues in tissues of broiler chicks fed aflatoxin B1

The aim of this study was to determine the binding capacity of a hydrated sodium calcium aluminosilicate (HSCAS) for aflatoxin B(1) (AFB(1)), and the efficacy of the HSCAS to reduce the concentrations of residual AFB(1) and its metabolites in the liver and kidney of broilers fed AFB(1). One hundred 1-d-old male broilers (Ross 708) were maintained in chick batteries and allowed ad libitum access to feed and water. A completely randomized design was used with 5 replicate pens of 5 chicks assigned to each of 4 dietary treatments from hatch to 21 d. Dietary treatments included the following: A) basal diet (BD), with no HSCAS or AFB(1), B) BD supplemented with 0.5% HSCAS only, C) BD supplemented with 2.5 mg of AFB(1)/kg of feed, and D) BD supplemented with 2.5 mg of AFB(1)/kg of feed and 0.5% HSCAS. On d 21, 5 chicks from each treatment were anesthetized with carbon dioxide, killed by cervical dislocation, and samples of liver and kidney were collected for analysis of AFB(1) residues. The percentage of AFB(1) bound for each concentration of adsorbent (100, 10, 1, 0.5, 0.25, and 0.05 mg/10 mL) was 100, 91.1, 81.8, 75.4, 40.1, and 8.8%, respectively. Concentrations of aflatoxin residues (AFB(1), aflatoxicol, aflatoxins B(2) and G(1)) were lower (P < 0.05) in livers and kidneys of birds fed AFB(1) plus HSCAS (diet D), when compared with birds fed AFB(1) alone (diet C). However, histopathology data from the in vivo study indicated that HSCAS did not prevent lesions associated with aflatoxicosis. The decrease in the bioavailability of AFB(1) caused by the HSCAS reduced aflatoxin residues in liver and kidney, but not enough to completely prevent the toxic effects of AFB(1) in broilers.

Immobilization of mycotoxins on modified nanodiamond substrates

The effectiveness of modified nanodiamonds (NDs) for the adsorption of mycotoxins, aflatoxin B1 (AfB1) and ochratoxin A (OTA), are investigated in this paper. Binding and release mechanisms of the mycotoxins were addressed using an assortment of NDs modified by different surface treatments, including carboxylation, hydrogenation and hydroxylation, followed by isolating NDs of different sizes. Results indicate that AfB1 adsorption on NDs is directly related to aggregate size, whereas OTA adsorption is primarily centered upon electrostatic interactions that depend on the types of surface functional groups on the ND. Findings show that modified NDs with small aggregation sizes (∼40 nm) have greater adsorption capacities for AfB1 than yeast cells walls and untreated NDs from various vendors, but comparable to activated charcoal. In OTA studies, positively charged NDs outperformed clay minerals, which are well-known and efficient sorbents for mycotoxins. Furthermore, ND adsorption capacities can be preserved in a wide range of pH.

In vitro assessment of the effectiveness of non-nutritive sorbent materials as binding agents for boar taint compounds

Boar taint, an off-odor and an off-flavor in the meat from some uncastrated male pigs, is due to high levels of the testicular steroid hormone, androstenone, and the indole, skatole. Thus far, there are no known methods for controlling both androstenone and skatole through dietary means. We tested the adsorbent agents, cholestyramine (CH), activated carbon (AC), tween-60 (Tween), bentonite (BNT) and polyvinylpolypyrrolidone (PVPP) for binding androstenone, estrone (E(1)), estrone sulfate (E(1)S) and skatole from buffer solutions in an in vitro system. The goal was to determine the potential utility of these binding agents as feed additives to control boar taint. Michaelis-Menten analysis was utilized to determine the effectiveness of the adsorbents. At pH 7.4, E(1)S was bound to AC and CH with the highest B(max) (maximum binding), whereas Tween and AC had the greatest B(max) for E(1). The B(max) for skatole at pH 7.4 was highest for AC, CH and PVPP. AC had a higher B(max) for androstenone than CH and Tween. The B(max) values at pH 3.0 with E(1)S for AC and CH were essentially 100%, whereas the binding of Tween to E(1)S at pH 3.0 decreased by 49.5% from binding at pH 7.4 (P < 0.05). The Ad(int) values, which represent efficiency of binding, illustrated that AC bound E(1), androstenone and skatole with greater efficiency than the other binding agents at pH 7.4, whereas AC bound E(1)S as efficiently as CH. We conclude that AC was the most effective adsorbent agent for binding E(1), E(1)S, androstenone and skatole in vitro, followed by CH, Tween, PVPP and lastly BNT. These adsorbent agents may be useful for binding boar taint compounds in in vivo studies to decrease the risk of boar taint.

Substances for reduction of the contamination of feed by mycotoxins: a review

The global occurrence of mycotoxins is considered to be a major risk factor for human and animal health. Contamination of different agricultural commodities with mycotoxins still occurs despite the most strenuous prevention efforts. As a result, mycotoxin contaminated feed can cause serious disorders and diseases in farm animals. A number of approaches, such as physical and chemical detoxification procedures, have been used to counteract mycotoxins. However, only a few of them have practical application. A recent and promising approach to protect animals against the harmful effects of mycotoxin contaminated feed is the use of substances for reduction of the contamination of feed by mycotoxins. These substances, so-called mycotoxin binders (MB), are added to the diet in order to reduce the absorption of mycotoxins from the gastrointestinal tract and their distribution to blood and target organs, thus preventing or reducing mycotoxicosis in livestock. Recently, the use of such substances as technological feed additives has been officially allowed in the European Union. The efficacy of MB appears to depend on the properties of both the binder and the mycotoxin. Depending on their mode of action, these feed additives may act either by binding mycotoxins to their surface (adsorption), or by degrading or transforming them into less toxic metabolites (biotransformation). Biotransformation can be achieved by mycotoxin-degrading enzymes or by microorganisms producing such enzymes. Various inorganic adsorbents, such as hydrated sodium calcium aluminosilicate, zeolites, bentonites, clays, and activated carbons, have been tested and used as MB. An interesting alternative to inorganic adsorbents for the detoxification of mycotoxins is the use of organic binders, such as yeast cell wall components, synthetic polymers (cholestyramine, polyvinylpyrrolidone), humic substances and dietary fibres. This paper gives an overview of the current knowledge and situation in the field of MB. The most important types of MB, mechanism of their action, and their application as a part of general strategy to counteract mycotoxins are described in this review. Recent advances in the use and study of MB, as well as data of their in vitro and in vivo effectiveness are given. Problems, potential, current trends and perspectives associated with the use of MB are discussed as well in the review.

Effects of montmorillonite on alleviating dietary Cd-induced oxidative damage in carp (Carassius auratus)

The present study was designed to investigate the effects of montmorillonite (MMT) on dietary Cd-induced oxidative damage in liver and kidney of carp (Carassius auratus). One hundred eighty carp were randomly divided into four groups and fed with a basal diet, a basal diet supplemented with 0.5% MMT, Cd-comtaminated basal diet (120 mg Cd/kg dry weight) and Cd-contaminated basal diet supplemented with 0.5% MMT, respectively. After 60 days, fish were sacrificed to measure malondialdehyde (MDA) content and antioxidative indices in liver and kidney. The results showed that the exposure of carp to dietary Cd caused decreases in glutathione peroxidase activity, catalase activity, superoxide dismutase activity, glutathione content and total antioxidant capacity level, while MMT supplemented in diet compensated Cd-induced decreases in above antioxidant indices to some extent in liver and kidney. As compared with the control group, increases in MDA content were observed in both measured tissues of carp exposed to dietary Cd, while MDA content decreased in carp exposed to Cd-contaminated basal diet supplemented with MMT in comparison with the Cd-contaminated group. It was suggested that MMT, when co-administered with Cd in diet, could alleviate dietary Cd-induced oxidative damage in liver and kidney of carp.

Effects of montmorillonite on Pb accumulation, oxidative stress, and DNA damage in tilapia (Oreochromis niloticus) exposed to dietary Pb

In order to investigate the effects of montmorillonite (MMT) on reducing dietary lead (Pb) toxicity to tilapia (Oreochromis niloticus), 240 fish were randomly divided into four treatments denominated as follows: control treatment (fed with a basal diet), MMT treatment (fed with a basal diet added with 0.5% MMT), Pb treatment (fed with a basal diet added with 100 mg Pb per kilogram dry weight (dw)), and Pb + MMT treatment (fed with a basal diet added with 100 mg Pb per kilogram dw and 0.5% MMT). Changes in Pb accumulation, oxidative stress, and DNA damage in tilapia were measured after 60 days. DNA damage was assessed using comet assay. The results showed that MMT supplemented in diet significantly reduced Pb accumulation in kidney and blood of tilapia exposed to dietary Pb (P < 0.05). Malondialdehyde level decreased insignificantly while levels of total antioxidant capacity and glutathione (GSH), activities of glutathione peroxidase, and superoxide dismutase increased insignificantly in kidney of tilapia in Pb + MMT treatment as compared to Pb treatment (P > 0.05). Significant decreases in tail length, tail DNA, tail moment, and Olive tail moment of peripheral blood cells in Pb + MMT treatment were observed when compared with Pb treatment (P < 0.05). The results indicated that dietary MMT supplementation could alleviate dietary Pb toxicity to tilapia effectively.

Decontamination and detoxification strategies for the Fusarium mycotoxin deoxynivalenol in animal feed and the effectiveness of microbial biodegradation

Trichothecenes are a group of mycotoxins mainly produced by fungi of the Fusarium genus. Deoxynivalenol (DON) is one of the most abundant and important trichothecenes in food and feed, and is a significant contaminants due to its frequent occurrence in toxicologically relevant concentrations worldwide. Since toxin production depends strongly on environmental conditions, such as temperature and humidity, Fusarium toxin contamination can not be avoided completely. Therefore, exposure to this toxin is a permanent health risk for both humans and farm animals. As cereal crops are commonly contaminated with DON and animal diets consist mainly of cereals, it can be assumed that animals are frequently exposed to DON-contaminated feeds. Many strategies can be undertaken to reduce the toxic effect of DON. In addition to the general necessity for minimizing all risk factors that might influence the contamination of cereals with DON, such as the so-called field toxins before harvest, several post-harvest strategies can be applied to counteract possible deleterious effects of this mycotoxin in farm animals. Another approach for decontamination in feedstuffs is the use of adsorbent materials. Adsorbent materials may bind mycotoxins in the gastrointestinal tract and reduce absorption and systemic toxicity. It has been shown that some adsorbents are suitable to alleviate the toxic effects of specific mycotoxins, but its efficacy against trichothecenes is practically zero. Therefore, alternative strategies to reduce animal and human health risk are needed. The use of microbial additives is a method which uses microorganisms having the capability to detoxify mycotoxins by metabolism or degradation prior to their resorption in the gastrointestinal tract. DON has been reported to be completely transformed to de-epoxy-DON by ruminal and intestinal microflora. Eubacterium BBSH 797 was capable of DON degradation and counteracted the toxic effects of DON in animals. This review focuses on the efficacy of microbial feed additives in ameliorating the toxic effects of DON. According to the results of experiments to date, it appears that microorganisms are the main living organisms suitable for this mycotoxin biodegradation. However, the use of this approach depends on its effectiveness from both a practical and economic perspective.

Effect of the inclusion of adsorbents on aflatoxin B1 quantification in animal feedstuffs

The extraction efficiency of aflatoxin B1 (AFB1) in cattle feed containing nine adsorbents (ADSs) was investigated using two organic/aqueous solvents composed of methanol/water (80/20 v/v; MeOH) and acetone/water (85/15 v/v; AC). Samples were obtained including a highly AFB1-contaminated (HC) and a low-level AFB(1)-contaminated (LC) feedstuff (15.33 and 7.57 microg kg(-1), respectively), nine ADSs (four clay minerals; one yeast cell wall-based product; one activated carbon and three commercial ADS products) at two different levels of inclusion (10 and 20 g kg(-1)). After solvent extraction and immunoaffinity column clean-up, all samples were analysed for AFB1 by high-performance liquid chromatography (HPLC) with fluorescence detection. For each contamination level (HC and LC), the data obtained were analysed using a factorial arrangement in a completely randomized design. Means were compared with the correspondent controls using the Dunnett's test. No statistical difference was found in AFB1 levels of feedstuffs not containing ADSs when extracted with AC or MeOH, even if numerically higher values were obtained with AC. A dose-dependent effect (p < 0.01) of ADSs inclusion was observed on AFB1 recoveries that were lower when the higher ADS level (20 g kg(-1)) was included in the HC and LC feedstuffs. Higher AFB(1) recoveries were obtained using AC compared with MeOH, both in HC (75.0% versus 12.0%, respectively) and in LC (84.0% versus 22.8%, respectively) ADSs containing feedstuffs. However, when the activated carbon and the sodium bentonite were included in feeds, lower AFB1 concentrations with respect to control values (p < 0.001 and <0.05, respectively) were obtained also using AC. The data obtained in this study indicate that routine use of the MeOH solvent for AFB1 analysis of unknown feedstuffs, can produce misleading results if they contain an ADS.

Assessment of Cu (II)-bearing montmorillonite on Cd adsorption

The abilities of montmorillonite (MMT) and Cu (II)-bearing montmorillonite (Cu-MMT) for adsorption of Cd from aqueous solutions have been studied at different optimized conditions of shaking time, pH value, and initial concentration, respectively. The results showed that the adsorbability of Cu-MMT onto Cd is stronger than the MMT. The amount of Cu-MMT necessary to remove Cd from solution was about 0.5 g for 100-200 mg/L Cd solution at a pH of 4.0. The maximum adsorption (94%) was 20 min of shaking time using Cu-MMT as adsorbent. The maximum adsorption of Cd = 95% at a pH of 4.0. By increasing the initial concentration, the adsorption amount of Cd onto Cu-MMT increased. Animal experiment of this study indicated that the addition of Cu-MMT to the Cd-contaminated diet of pigs reduced significantly the Cd levels in tissues (p < 0.05) and increased contents in feces (p < 0.01), improving the safety of animal products. Thus, the overall results established the use of Cu-MMT as a heavy metal adsorbent in animal's diets, implying a potential protective role against heavy metal toxicities.

Effect of montmorillonite superfine composite on growth performance and tissue lead level in pigs

A feeding trial was conducted to study the effect of montmorillonite superfine composite (MSC) on growth performance and tissue lead levels in pigs. Sixty barrows were randomly divided into two groups. They were fed the same basal diet supplemented with 0 or 0.5% MSC, respectively, for 100 days. Serum samples were collected and analyzed to study growth hormone secretion pattern. The mean lead concentration in selected tissues was analyzed. The results showed that average daily gain, average daily feed intake, and feed conversion ratio of pigs were improved by 8.97% (p < 0.05), 3.90% (p < 0.05), and 4.76% (p < 0.05), respectively, with the supplementation of MSC compared to the control group. Serum sample analysis indicated that peak amplitude, base-line level, and mean level of growth hormone were increased by 117.14% (p < 0.01), 42.78% (p < 0.01), and 51.75% (p < 0.01), respectively. Supplementation of MSC in the diet was found to significantly reduce lead concentration of tissues in blood, brain, liver, bone, kidney and hair.

Aflatoxin B(1) adsorption by natural and copper modified montmorillonite

Adsorption of aflatoxin B(1) (AFB1) by natural montmorillonite (MONT) and montmorillonite modified with copper ions (Cu-MONT) was investigated. Both MONTs were characterized using the X-ray powder diffraction (XRPD) analysis, thermal analysis (DTA/TGA) and scanning electron miscroscopy/electron dispersive spectroscopy (SEM/EDS). The results of XRPD and SEM/EDS analyses of Cu-MONT suggested partial ion exchange of native inorganic cations in MONT with copper occurred. Investigation of AFB1 adsorption by MONT and Cu-MONT, at pH 3, 7 or 9, showed that adsorption of this toxin by both MONTs was high (over 93%). Since AFB1 is nonionizable, no differences in AFB1 adsorption by both MONTs, at different pHs, were observed, as expected. Futhermore, it was determined that adsorption of AFB1 by both MONTs followed a non-linear (Langmuir) type of isotherm, at pH 3. The calculated maximum adsorbed amounts of AFB1 by MONT (40.982mg/g) and Cu-MONT (66.225mg/g), derived from Langmuir plots of isotherms, indicate that Cu-MONT was much effective in adsorbing AFB1. Since, the main cation in an exchangeable position in MONT is calcium, and in Cu-MONT both calcium and copper, the fact that ion exchange of inorganic cations in MONT with copper increases adsorption of AFB1 suggests that additional interactions between AFB1 and copper ions in Cu-MONT caused greater adsorption.

Intestinal morphology, brush border and digesta enzyme activities of broilers fed on a diet containing Cu2+-loaded montmorillonite

1. A total of 320 1-d-old Arbor Acres broiler chicks were used to investigate the effect of Cu(2+)-loaded montmorillonite (CM) on the growth performance, intestinal morphology and activities of brush border enzyme in the intestinal mucosa and digestive enzyme in the intestinal digesta of broilers. 2. The chicks were assigned randomly into 4 groups with 80 chicks per treatment. The 4 dietary treatments were: basal diet only (control group), basal diet + 2 g montmorillonite/kg, basal diet + 1 g CM/kg, and basal diet + 2 g CM/kg. The chicks were raised in cages and feed and water were provided ad libitum for a period of 42 d. 3. The addition of CM to the diet of broilers significantly increased body weight and feed efficiency. Similarly, birds receiving montmorillonite had higher feed efficiency than the control after 42 d of feeding. 4. Data on villus height and crypt depth for duodenum, jejunum and ileum indicated that treating the diet of broilers with either CM or montmorillonite improved the mucosal morphology of the small intestine. 5. The presence of CM in the diet of broilers significantly increased the activities of maltase, aminopeptidase N and alkaline phosphatase in small intestinal mucosa. However, the activities of protease, trypsin, chymotrypsin, amylase and lipase in small intestinal digesta of broilers fed on the CM-supplemented diet were slightly higher than control values.