Studies on heat inactivation of hepatitis A virus with special reference to shellfish. Part 1. Procedures for infection and recovery of virus from laboratory-maintained cockles

Hepatitis a Vaccine as Opportunity of Primary Prevention for Food Handlers: A Narrative Review

The hepatitis A virus (HAV) is still a leading cause of viral hepatitis worldwide. After a long incubation period, the clinical manifestations range from asymptomatic infection to acute liver failure. The severity of the disease increases with age and pre-existing liver disease. The transmission is mainly via person-to-person contact or ingestion of contaminated food or water. Food contamination can occur at any step of the food chain, especially when infected people handle not-heated or otherwise-treated food. HAV is endemic in low-income countries because of poor sanitary and sociodemographic conditions. The populations of developed countries are highly susceptible, and large outbreaks occur when HAV is introduced from endemic countries due to globalization, travel, and movement of foodstuffs. HAV prevention includes hygiene practices, immunoglobulins, and vaccination. Safe and effective inactivated and live attenuated vaccines are available and provide long-term protection. The vaccine targets are children and subjects at increased risk of HAV exposure or serious clinical outcomes. This review discusses the critical role of food handlers in the spread of HAV and the opportunity for food industry employers to consider food handler immunization a tool to manage both food safety in compliance with HACCP principles and food operators' biologic risk.

Inactivation of Hepatitis A Virus and Human Norovirus in Clams Subjected to Heat Treatment

Bivalve mollusk contamination by enteric viruses, especially human noroviruses (HuNoV) and hepatitis A virus (HAV), is a problem with health and economic implications. The aim of the study was the evaluation of the effect of heat treatment in clams (Tawera gayi) experimentally contaminated with HuNoV using a PMA-viability RTqPCR assay to minimize measurement of non-infectious viruses, and used HAV as a model to estimate infectivity loss. Spiked clams were immersed in water at 90°C to ensure that internal meat temperature was maintained above 90°C for at least 5 min. The treatment resulted in >3.89 ± 0.24 log10 TCID50/g reduction of infectious HAV, confirming inactivation. For HuNoV, RTqPCR assays showed log10 reductions of 2.96 ± 0.79 and 2.56 ± 0.56, for GI and GII, respectively, and the use of PMA resulted in an additional log10 reduction for GII, providing a better correlation with risk reduction. In the absence of a cell culture system which could be used to determine HuNoV infectivity reduction, a performance criteria based on PMA-RTqPCR log reduction could be used to evaluate food product safety. According to data from this study, heat treatments of clams which cause reductions >3.5 log10 for GII as measured by PMA-RTqPCR assay may be regarded as an acceptable inactivation treatment, and could be set as a performance criterion to test the effectiveness of other time-temperature inactivation processes.

Persistence of Hepatitis A Virus in Fresh Produce and Production Environments, and the Effect of Disinfection Procedures: A Review

Although information is limited, it is evident that prolonged persistence of infectious Hepatitis A virus (HAV) is a factor in the transmission of the virus via fresh produce. Consequently, data on persistence of the virus on produce, and in environments relevant to production, such as soils, water and surfaces, are required to fully understand the dynamics of transmission of HAV via foods. Furthermore, information on effective disinfection procedures is necessary to implement effective post-harvest control measures. This review summarises current information on HAV persistence in fresh produce and on relevant disinfection procedures. On vegetables, HAV can remain infectious for several days; on frozen berries, it can persist for several months. HAV can remain infectious on surfaces for months, depending on temperature and relative humidity, and can survive desiccation. It can survive for several hours on hands. Washing hands can remove the virus, but further data are required on the appropriate procedure. Chlorination is effective in water, but not when HAV is associated with foodstuffs. Bleach and other sodium hypochlorite disinfectants at high concentrations can reduce HAV on surfaces, but are not suitable for use on fresh produce. There is only limited information on the effects of heating regimes used in the food industry on HAV. HAV is resistant to mild pasteurisation. Some food components, e.g. fats and sugars, can increase the virus' resistance to higher temperatures. HAV is completely eliminated by boiling. Quantitative prevalence data are needed to allow the setting of appropriate disinfection log reduction targets for fresh produce.

Effect of the Shellfish Proteinase K Digestion Method on Norovirus Capsid Integrity

Norovirus outbreaks are associated with the consumption of contaminated shellfish, and so efficient methods to recover and detect infectious norovirus in shellfish are important. The Proteinase K digestion method used to recover norovirus from shellfish, as described in the ISO 15216, would be a good candidate but its impact on the virus capsid integrity and thus infectivity was never examined. The aim of this study was to assess the impact of the Proteinase K digestion method, and of the heat treatment component of the method alone, on norovirus (genogroups I and II) and MS2 bacteriophage capsid integrity. A slightly modified version of the ISO method was used. RT-qPCR was used for virus detection following digestion of accessible viral RNA using RNases. MS2 phage infectivity was measured using a plaque assay. The effect of shellfish digestive glands (DG) on recovery was evaluated. In the presence of shellfish DG, a reduction in MS2 phage infectivity of about 1 log₁₀ was observed after the Proteinase K digestion method and after heat treatment component alone. For norovirus GII and MS2 phage, there was no significant loss of genome following the Proteinase K digestion method but there was a significant 0.24 log₁₀ loss of norovirus GI. In the absence of shellfish DG, the reduction in MS2 phage infectivity was about 2 log₁₀, with the addition of RNases resulting in a significant loss of genome for all tested viruses following complete Proteinase K digestion method and the heat treatment alone. While some protective effect from the shellfish DG on viruses was observed, the impact on capsid integrity and infectivity suggests that this method, while suitable for norovirus genome detection, may not completely preserve virus infectivity.

Hepatitis A Virus Prevention and Vaccination Within and Outside the Veterans Health Administration in Light of Recent Outbreaks

Although widespread hepatitis A vaccination has dramatically decreased infection rates, a large proportion of VA patients in traditionally high-risk groups remains susceptible to infection.

Efficacy of domestic cooking inactivation of human hepatitis A virus in experimentally infected manila clams (Ruditapes philippinarum)

AIM

The aim of this work was to evaluate the efficacy of domestic cooking in inactivating Manila clams experimentally infected with human hepatitis A virus (HAV).

METHODS AND RESULTS

Electronic temperature probes were positioned to measure the internal temperature of Manila clams during domestic cooking. Two batches were infected with 10(7) and 10(5) TCID50  ml(-1) of HAV. The infected whole-in-shell clams were divided into three replicates and cooked on a conventional stove both singularly and in group and removed from the pan at fixed intervals. Pools of three digestive glands were examined by virus isolation for three blind passages and cell culture supernatant tested with real-time PCR.

CONCLUSION

Results showed that 2-min cooking by a traditional domestic method at a temperature close to 100°C, after the opening up of the valves of all the clams, can completely devitalize the HAV in high viral load-infected clams.

SIGNIFICANCE AND IMPACT OF THE STUDY

This is the first study on inactivation of HAV in experimentally infected Manila clams subjected to domestic cooking. At present, labelling all lagoon products as 'requiring cooking before consumption' is highly recommended, but no specifications are given on how long and at what temperature they should be cooked. Considering the high commercial value of Manila clams, our results can provide both the producers and the consumer with useful indications on how to cook clams to prevent the risk of HAV foodborne illness.

International linkage of two food-borne hepatitis A clusters through traceback of mussels, the Netherlands, 2012

This report describes an outbreak investigation starting with two closely related suspected food-borne clusters of Dutch hepatitis A cases, nine primary cases in total, with an unknown source in the Netherlands. The hepatitis A virus (HAV) genotype IA sequences of both clusters were highly similar (459/460 nt) and were not reported earlier. Food questionnaires and a case–control study revealed an association with consumption of mussels. Analysis of mussel supply chains identified the most likely production area. International enquiries led to identification of a cluster of patients near this production area with identical HAV sequences with onsets predating the first Dutch cluster of cases. The most likely source for this cluster was a case who returned from an endemic area in Central America, and a subsequent household cluster from which treated domestic sewage was discharged into the suspected mussel production area. Notably, mussels from this area were also consumed by a separate case in the United Kingdom sharing an identical strain with the second Dutch cluster. In conclusion, a small number of patients in a non-endemic area led to geographically dispersed hepatitis A outbreaks with food as vehicle. This link would have gone unnoticed without sequence analyses and international collaboration.

Retention of Rotavirus Infectivity in Mussels Heated by Using the French Recipe Moules Marinières

To evaluate the persistence of infectious virus after heating, mussels contaminated with a rotavirus strain were prepared following the French recipe moules marinières (mariner's mussels). Rotavirus was then quantified by real-time quantitative PCR (RT-qPCR) and a cell culture infectivity assay. Results showed the persistence of infectious virus after 3 min of cooking. After 5 min, when no infectious virus could be detected, the RT-qPCR approach showed a 1-log decrease compared with concentrations detected after 1 min of cooking.

Thermal inactivation kinetics of hepatitis A virus in homogenized clam meat (Mercenaria mercenaria)

AIMS

Epidemiological evidence suggests that hepatitis A virus (HAV) is the most common pathogen transmitted by bivalve molluscs such as clams, cockles, mussels and oysters. This study aimed to generate thermal inactivation kinetics for HAV as a first step to design adequate thermal processes to control clam-associated HAV outbreaks.

METHODS AND RESULTS

Survivor curves and thermal death curves were generated for different treatment times (0-6 min) at different temperatures (50-72°C) and Weibull and first-order models were compared. D-values for HAV ranged from 47·37 ± 1·23 to 1·55 ± 0·12 min for the first-order model and 64·43 ± 3·47 to 1·25 ± 0·45 min for the Weibull model at temperatures from 50 to 72°C. z-Values for HAV in clams were 12·97 ± 0·59°C and 14·83 ± 0·0·28°C using the Weibull and first-order model respectively. The calculated activation energies for the first-order and Weibull model were 145 and 170 kJ mole(-1) respectively.

CONCLUSION

The Weibull model described the thermal inactivation behaviour of HAV better than the first-order model.

SIGNIFICANCE AND IMPACT OF THE STUDY

This study provides novel and precise information on thermal inactivation kinetics of HAV in homogenized clams. This will enable reliable thermal process calculations for HAV inactivation in clams and closely related seafood.

Thermal Inactivation of Foodborne Enteric Viruses and Their Viral Surrogates in Foods

Foodborne viruses, in particular human norovirus and hepatitis A virus, are the most common causes of food-associated infections and foodborne illness outbreaks around the world. Since it is currently not possible to cultivate human noroviruses and the wild-type strain of hepatitis A virus in vitro, the use of a variety of viral surrogates is essential to determine appropriate thermal processing conditions to reduce the risk associated with their contamination of food. Therefore, the objectives of this review are to (i) present pertinent characteristics of enteric foodborne viruses and their viral surrogates, (ii) discuss the viral surrogates currently used in thermal inactivation studies and their significance and value, (iii) summarize available data on thermal inactivation kinetics of enteric viruses, (iv) discuss factors affecting the efficacy of thermal treatment, (v) discuss suggested mechanisms of thermal inactivation, and (vi) provide insights on foodborne enteric viruses and viral surrogates for future studies and industrial applications. The overall goal of this review is to contribute to the development of appropriate thermal processing protocols to ensure safe food for human consumption.

Thermal Inactivation Kinetics of Human Norovirus Surrogates and Hepatitis A Virus in Turkey Deli Meat

Human noroviruses (HNoV) and hepatitis A virus (HAV) have been implicated in outbreaks linked to the consumption of presliced ready-to-eat deli meats. The objectives of this research were to determine the thermal inactivation kinetics of HNoV surrogates (murine norovirus 1 [MNV-1] and feline calicivirus strain F9 [FCV-F9]) and HAV in turkey deli meat, compare first-order and Weibull models to describe the data, and calculate Arrhenius activation energy values for each model. The D (decimal reduction time) values in the temperature range of 50 to 72°C calculated from the first-order model were 0.1 ± 0.0 to 9.9 ± 3.9 min for FCV-F9, 0.2 ± 0.0 to 21.0 ± 0.8 min for MNV-1, and 1.0 ± 0.1 to 42.0 ± 5.6 min for HAV. Using the Weibull model, the tD = 1 (time to destroy 1 log) values for FCV-F9, MNV-1, and HAV at the same temperatures ranged from 0.1 ± 0.0 to 11.9 ± 5.1 min, from 0.3 ± 0.1 to 17.8 ± 1.8 min, and from 0.6 ± 0.3 to 25.9 ± 3.7 min, respectively. The z (thermal resistance) values for FCV-F9, MNV-1, and HAV were 11.3 ± 2.1°C, 11.0 ± 1.6°C, and 13.4 ± 2.6°C, respectively, using the Weibull model. The z values using the first-order model were 11.9 ± 1.0°C, 10.9 ± 1.3°C, and 12.8 ± 1.7°C for FCV-F9, MNV-1, and HAV, respectively. For the Weibull model, estimated activation energies for FCV-F9, MNV-1, and HAV were 214 ± 28, 242 ± 36, and 154 ± 19 kJ/mole, respectively, while the calculated activation energies for the first-order model were 181 ± 16, 196 ± 5, and 167 ± 9 kJ/mole, respectively. Precise information on the thermal inactivation of HNoV surrogates and HAV in turkey deli meat was generated. This provided calculations of parameters for more-reliable thermal processes to inactivate viruses in contaminated presliced ready-to-eat deli meats and thus to reduce the risk of foodborne illness outbreaks.

Determination of thermal inactivation kinetics of hepatitis A virus in blue mussel (Mytilus edulis) homogenate

Hepatitis A virus (HAV) is a food-borne enteric virus responsible for outbreaks of hepatitis associated with shellfish consumption. The objectives of this study were to determine the thermal inactivation behavior of HAV in blue mussels, to compare the first-order and Weibull models to describe the data, to calculate Arrhenius activation energy for each model, and to evaluate model efficiency by using selected statistical criteria. The times required to reduce the population by 1 log cycle (D-values) calculated from the first-order model (50 to 72°C) ranged from 1.07 to 54.17 min for HAV. Using the Weibull model, the times required to destroy 1 log unit (tD = 1) of HAV at the same temperatures were 1.57 to 37.91 min. At 72°C, the treatment times required to achieve a 6-log reduction were 7.49 min for the first-order model and 8.47 min for the Weibull model. The z-values (changes in temperature required for a 90% change in the log D-values) calculated for HAV were 15.88 ± 3.97°C (R(2), 0.94) with the Weibull model and 12.97 ± 0.59°C (R(2), 0.93) with the first-order model. The calculated activation energies for the first-order model and the Weibull model were 165 and 153 kJ/mol, respectively. The results revealed that the Weibull model was more appropriate for representing the thermal inactivation behavior of HAV in blue mussels. Correct understanding of the thermal inactivation behavior of HAV could allow precise determination of the thermal process conditions to prevent food-borne viral outbreaks associated with the consumption of contaminated mussels.

Thermal inactivation kinetic modeling of human norovirus surrogates in blue mussel (Mytilus edulis) homogenate

Control of seafood-associated norovirus outbreaks has become an important priority for public health authorities. Due to the absence of human norovirus infectivity assays, cultivable surrogates such as feline calicivirus (FCV-F9) and murine norovirus (MNV-1) have been used to begin to understand their thermal inactivation behavior. In this study, the effect of thermal treatment on inactivation of human norovirus surrogates in blue mussels was investigated at 50, 56, 60, 65, and 72 °C for various times (0-6 min). The results obtained were analyzed using the Weibull and first-order models. The Theil error splitting method was used for model comparison. This method splits the error in the predicted data into fixed and random error. This method was applied to select satisfactory models for determination of thermal inactivation of norovirus surrogates and kinetic modeling. The D-values calculated from the first-order model (50-72 °C) were in the range of 0.07 to 5.20 min for FCV-F9 and 0.18 to 20.19 min for MNV-1. Using the Weibull model, the t(D=1) for FCV-F9 and MNV-1 to destroy 1 log (D=1) at the same temperatures were in the range of 0.08 to 4.03 min and 0.15 to 19.80 min, respectively. The z-values determined for MNV-1 were 9.91±0.71 °C (R²=0.95) using the Weibull model and 11.62±0.59 °C (R²=0.93) for the first-order model. For FCV-F9 the z-values were 12.38±0.68 °C (R²=0.94) and 11.39±0.41 °C (R²=0.97) for the Weibull and first-order models, respectively. The Theil method revealed that the Weibull model was satisfactory to represent thermal inactivation data of norovirus surrogates and that the model chosen for calculation of thermal inactivation parameters is important. Knowledge of the thermal inactivation kinetics of norovirus surrogates will allow development of processes that produce safer shellfish products and improve consumer safety.

Natural persistence of food- and waterborne viruses

This chapter summarises data on the persistence of food-and waterborne viruses in the natural environment and discusses the different factors which can affect this persistence. Conventional and alternative methods by which persistence can be studied are described, and the natural factors influencing virus persistence outside the host organism are discussed. Available data concerning virus persistence in water, soil, on surfaces and in food products are reviewed.

Scientific Opinion on an update on the present knowledge on the occurrence and control of foodborne viruses

A review of the biology, epidemiology, diagnosis and public health importance of foodborne viruses was performed. Data needs to support a risk assessment were also identified. In addition possible control options and their anticipated impact to prevent or reduce the number of foodborne viral human infections were identified, including the scientific reasons for and against the establishment of food safety criteria and process hygiene criteria for viruses for certain food categories. Food may be contaminated by virus during all stages of the food supply chain, and transmission can occur by consumption of food contaminated during the production process (primary production, or during further processing), or contaminated by infected food handlers. Transmission of zoonotic viruses (e.g. HEV) can also occur by consumption of products of animal origin. Viruses do not multiply in foods, but may persist for extended periods of time as infectious particles in the environment, or in foods. At the EU-level it is unknown how much viral disease can be attributed to foodborne spread. The relative contribution of different sources (shellfish, fresh produce, food handler including asymptomatic shedders, food handling environment) to foodborne illness has not been determined. The Panel recommends focusing controls on preventive measures to avoid viral contamination rather than trying to remove/inactivate these viruses from food. Also, it is recommended to introduce a microbiological criteria for viruses in bivalve molluscs, unless they are labelled "to be cooked before consumption". The criteria could be used by food business operators to validate their control options. Furthermore, it is recommended to refine the regulatory standards and monitoring approaches in order to improve public health protection. Introduction of virus microbiological criteria for classification of bivalve molluscs production areas should be considered. A virus monitoring programme for compliance with these criteria should be risk based according to the findings of a sanitary survey.

Foodborne spread of hepatitis A: Recent studies on virus survival, transfer and inactivation

Hepatitis A virus (HAV) is responsible for considerable morbidity and economic losses worldwide, and is the only reportable, foodborne viral pathogen in Canada. Outbreaks caused by it occur more frequently in settings such as hospitals, daycare centres, schools, and in association with foods and food service establishments. In recent years, the incidence of hepatitis A has increased in Canada. Many factors, including changing lifestyles and demographics, faster and more frequent travel, and enhanced importation of foods from hepatitis A-endemic regions, may be behind this increase. Despite its increasing significance as a human pathogen, not much was known until recently about the survival and inactivation of HAV, and even less was understood about the effectiveness of measures to prevent and control its foodborne spread. Studies conducted in the past decade have shown that HAV can survive for several hours on human hands and for several days on environmental surfaces indoors. The virus can also retain its infectivity for several days on fruits and vegetables which are often consumed raw, and such imported items have already been incriminated in disease outbreaks. Casual contact between contaminated hands and clean food items can readily lead to a transfer of as much as 10% of the infectious virus. HAV is also relatively resistant to inactivation by heat, gamma irradiation and chemical germicides. In view of these findings, better approaches to prevent the contamination of foods with HAV and more effective methods for its inactivation in foods, on environmental surfaces and on the hands of food handlers are needed.

A predictive microbiology approach for thermal inactivation of Hepatitis A virus in acidified berries

Hepatitis A virus (HAV) is a food-borne enteric virus responsible for outbreaks of hepatitis associated with consumption of raw vegetables. Soft fruits, such as red berries, exposed to faecal contamination are increasingly responsible for collective food-borne illnesses associated with HAV, when eaten raw or used in unprocessed foods. Heat is the most effective measure for the inactivation of HAV. Thermal treatments are used on fruits as a decontamination method, but they have to be adapted to product characteristics; indeed, factors such as sugar or pH may have an impact on the viral sensitivity to thermal treatments. A model was developed for the inactivation of HAV in red berries without supplemented sugar and with different pH values. Nonlinear inactivation curves in acidified raspberries were modelled using an integrated model, with a single equation nesting secondary models of temperature and pH in the primary model. Model predictions were then confronted to experimental results obtained in another laboratory on other berries with different pH values. Excellent predictions were obtained in most cases, while failed predictions provided safe results, with the model predicting higher residual virus titres than what was observed.

Viral Inactivation in Foods: A Review of Traditional and Novel Food-Processing Technologies

  Over one-half of foodborne illnesses are believed to be viral in origin. The ability of viruses to persist in the environment and foods, coupled with low infectious doses, allows even a small amount of contamination to cause serious problems. An increased incidence of foodborne illnesses and consumer demand for fresh, convenient, and safe foods have prompted research into alternative food-processing technologies. This review focuses on viral inactivation by both traditional processing technologies such as use of antimicrobial agents and the application of heat, and also novel processing technologies including high-pressure processing, ultraviolet- and gamma-irradiation, and pulsed electric fields. These industrially applicable control measures will be discussed in relation to the 2 most common causes of foodborne viral illnesses, hepatitis A virus and human noroviruses. Other enteric viruses, including adenoviruses, rotaviruses, aichi virus, and laboratory and industrial viral surrogates such as feline caliciviruses, murine noroviruses, bacteriophage MS2 and ΦX174, and virus-like particles are also discussed. The basis of each technology, inactivation efficacy, proposed mechanisms of viral inactivation, factors affecting viral inactivation, and applicability to the food industry with a focus on ready-to-eat foods, produce, and shellfish, are all featured in this review.

Effects of technological processes on the tenacity and inactivation of norovirus genogroup II in experimentally contaminated foods

Contaminated food is a significant vehicle for human norovirus transmission. The present study determined the effect of physicochemical treatments on the tenacity of infective human norovirus genogroup II in selected foods. Artificially contaminated produce was subjected to a number of processes used by the food industry for preservation and by the consumer for storage and preparation. Virus recovery was carried out by using ultrafiltration and was monitored by using bacteriophage MS2 as an internal process control. Norovirus was quantified by using monoplex one-step TaqMan real-time reverse transcription (RT)-PCR and an external standard curve based on recombinant RNA standards. An RNase pretreatment step was used to avoid false-positive PCR results caused by accessible RNA, which allowed detection of intact virus particles. Significant reductions in titers were obtained with heat treatments usually applied by consumers for food preparation (baking, cooking, roasting). Generally, processes used for preservation and storage, such as cooling, freezing, acidification (>or=pH 4.5), and moderate heat treatments (pasteurization), appear to be insufficient to inactivate norovirus within a food matrix or on the surface of food. Besides data for persistence in processed food, comparable data for individual matrix-specific protective effects, recovery rates, and inhibitory effects on the PCRs were obtained in this study. The established procedure might be used for other noncultivable enteric RNA viruses that are connected to food-borne diseases. The data obtained in this study may also help optimize the process for inactivation of norovirus in food by adjusting food processing technologies and may promote the development of risk assessment systems in order to improve consumer protection.

Foodborne outbreak of gastroenteritis due to Norovirus and Vibrio parahaemolyticus

Vibrio parahaemolyticus and Norovirus have been recognized as the cause of sporadic cases or outbreaks of diarrhoeal illness in association with the ingestion of raw or improperly cooked seafood. This report describes a foodborne outbreak of gastroenteritis caused by both Norovirus and Vibrio parahaemolyticus following the consumption of raw seafood in a restaurant in Terrassa (Catalonia, Spain) in September 2005. Measures are needed to reduce contamination of raw seafood. Consumers can reduce the risk of foodborne illness by avoiding consumption of raw or undercooked food.

Effect of heat treatment on hepatitis A virus and norovirus in New Zealand greenshell mussels (Perna canaliculus) by quantitative real-time reverse transcription PCR and cell culture

Quantitative real-time reverse transcription PCR (qRT-PCR) and cell culture (50% tissue culture infectious dose [TCID50]) were used to determine the effect of heat treatments on norovirus and hepatitis A virus (HAV) in the New Zealand Greenshell mussel (Perna canaliculus). Since it is common practice to cook mussels until the shells open, internal temperatures and opening times of mussels on boiling and steaming were determined at regular time intervals. Fifty mussels in batches of six were exposed to boiling and steaming. A mean internal temperature of 90 degrees C (recommended for virus inactivation when maintained for 90 s) was reached after boiling for 170 s, with all 50 mussels open at 210 s. For steaming, the mean internal temperature achieved was only 83 degrees C after 300 s, and all 50 mussels were open. When mussels were steamed for 180 s (mean internal temperature of 63 degrees C), a significant 1.5-log decrease in the HAV titer (log TCID50) was observed. Following the immersion of mussels in boiling water for 180 s (mean internal temperature of 92 degrees C), no viable HAV was detected. For both boiling and steaming experiments, there was no significant change in the norovirus or HAV qRT-PCR titers compared with the controls. Our results show that when New Zealand Greenshell mussels open on heating, their internal temperature may not reach the parameters required for virus inactivation. Immersion for a minimum of 3 min in boiling water rather than steaming is recommended to reduce the risk of viral foodborne illness from contaminated shellfish.

Modelling effect of physical and chemical parameters on heat inactivation kinetics of hepatitis A virus in a fruit model system

While thermal destruction of pathogenic bacteria has been thoroughly studied in food industry, heat inactivation of viruses in food has been poorly investigated. Experiments were carried out to characterize the effects of controlled physical and chemical characteristics of a food matrix upon heat resistance parameters (D and z values) of hepatitis A virus (HAV), taken as model because of its reported heat resistance. Sucrose content (28-52 degrees Brix), calcium concentration (90-1700 mg kg(-1)) and pH (3.3-4.3) were selected for possible influence on thermal inactivation of HAV in strawberry mashes and thus included in an experimental design according to a Doehlert matrix. Use of this design not only allowed to detect and quantify the direct influence of sucrose concentration upon the D85 degrees C value to be higher than the one of pH, but also to reveal a sucrose concentration/pH specific interaction, while no effect of calcium concentration was evidenced. Although the model cannot be directly used to predict heat resistance in real fruit systems, because of differences observed between predicted and measured D85 degrees C values, it is useful for predicting the trends and relative changes in D values due to sucrose concentration and pH variations. Results suggested possible effects of other constituents of strawberry products on heat resistance of HAV and confirmed the importance of experimental validation of any model-derived process. Nevertheless, such a modelling approach using response surface methodology provides a rapid answer to heat resistance evaluation of a food-borne virus as a function of specific physical and chemical parameters of specific food products.

Inactivation of caliciviruses

The viruses most commonly associated with food- and waterborne outbreaks of gastroenteritis are the noroviruses. The lack of a culture method for noroviruses warrants the use of cultivable model viruses to gain more insight on their transmission routes and inactivation methods. We studied the inactivation of the reported enteric canine calicivirus no. 48 (CaCV) and the respiratory feline calicivirus F9 (FeCV) and correlated inactivation to reduction in PCR units of FeCV, CaCV, and a norovirus. Inactivation of suspended viruses was temperature and time dependent in the range from 0 to 100 degrees C. UV-B radiation from 0 to 150 mJ/cm(2) caused dose-dependent inactivation, with a 3 D (D = 1 log(10)) reduction in infectivity at 34 mJ/cm(2) for both viruses. Inactivation by 70% ethanol was inefficient, with only 3 D reduction after 30 min. Sodium hypochlorite solutions were only effective at >300 ppm. FeCV showed a higher stability at pH <3 and pH >7 than CaCV. For all treatments, detection of viral RNA underestimated the reduction in viral infectivity. Norovirus was never more sensitive than the animal caliciviruses and profoundly more resistant to low and high pH. Overall, both animal viruses showed similar inactivation profiles when exposed to heat or UV-B radiation or when incubated in ethanol or hypochlorite. The low stability of CaCV at low pH suggests that this is not a typical enteric (calici-) virus. The incomplete inactivation by ethanol and the high hypochlorite concentration needed for sufficient virus inactivation point to a concern for decontamination of fomites and surfaces contaminated with noroviruses and virus-safe water.

Foodborne viruses: an emerging problem

Several groups of viruses may infect persons after ingestion and then are shed via stool. Of these, the norovirus (NoV) and hepatitis A virus (HAV) are currently recognised as the most important human foodborne pathogens with regard to the number of outbreaks and people affected in the Western world. NoV and HAV are highly infectious and may lead to widespread outbreaks. The clinical manifestation of NoV infection, however, is relatively mild. Asymptomatic infections are common and may contribute to the spread of the infection. Introduction of NoV in a community or population (a seeding event) may be followed by additional spread because of the highly infectious nature of NoV, resulting in a great number of secondary infections (50% of contacts). Hepatitis A is an increasing problem because of the decrease in immunity of populations in countries with high standards of hygiene. Molecular-based methods can detect viruses in shellfish but are not yet available for other foods. The applicability of the methods currently available for monitoring foods for viral contamination is unknown. No consistent correlation has been found between the presence of indicator microorganisms (i.e. bacteriophages, E. coli) and viruses. NoV and HAV are highly infectious and exhibit variable levels of resistance to heat and disinfection agents. However, they are both inactivated at 100 degrees C. No validated model virus or model system is available for studies of inactivation of NoV, although investigations could make use of structurally similar viruses (i.e. canine and feline caliciviruses). In the absence of a model virus or model system, food safety guidelines need to be based on studies that have been performed with the most resistant enteric RNA viruses (i.e. HAV, for which a model system does exist) and also with bacteriophages (for water). Most documented foodborne viral outbreaks can be traced to food that has been manually handled by an infected foodhandler, rather than to industrially processed foods. The viral contamination of food can occur anywhere in the process from farm to fork, but most foodborne viral infections can be traced back to infected persons who handle food that is not heated or otherwise treated afterwards. Therefore, emphasis should be on stringent personal hygiene during preparation. If viruses are present in food preprocessing, residual viral infectivity may be present after some industrial processes. Therefore, it is key that sufficient attention be given to good agriculture practice (GAP) and good manufacturing practice (GMP) to avoid introduction of viruses onto the raw material and into the food-manufacturing environment, and to HACCP to assure adequate management of (control over) viruses present during the manufacturing process. If viruses are present in foods after processing, they remain infectious in most circumstances and in most foods for several days or weeks, especially if kept cooled (at 4 degrees C). Therefore, emphasis should be on stringent personal hygiene during preparation. For the control of foodborne viral infections, it is necessary to: Heighten awareness about the presence and spread of these viruses by foodhandlers; Optimise and standardise methods for the detection of foodborne viruses; Develop laboratory-based surveillance to detect large, common-source outbreaks at an early stage; and Emphasise consideration of viruses in setting up food safety quality control and management systems (GHP, GMP, HACCP).

Hepatitis A Transmitted by Food

Hepatitis A is caused by hepatitis A virus (HAV). Transmission occurs by the fecal-oral route, either by direct contact with an HAV-infected person or by ingestion of HAV-contaminated food or water. Foodborne or waterborne hepatitis A outbreaks are relatively uncommon in the United States. However, food handlers with hepatitis A are frequently identified, and evaluation of the need for immunoprophylaxis and implementation of control measures are a considerable burden on public health resources. In addition, HAV-contaminated food may be the source of hepatitis A for an unknown proportion of persons whose source of infection is not identified.

Closed-circuit system for the depuration of mussels experimentally contaminated with hepatitis A virus

In Italy, the consumption of raw or slightly cooked mussels represents the most important risk factor for the transmission of hepatitis A virus (HAV). Although there exist effective methods for the bacterial depuration of contaminated mussels, these methods are poorly effective on enteric viruses. The objective of the present study was to evaluate the effectiveness of a closed-circuit depuration system that uses both ozone and UV light for disinfecting water and that allows salinity and temperature, important parameters for the metabolism of mussels (Mytilus galloprovincialis), to be maintained at constant levels. The results showed that this depuration method decreased the viral load (from 1.72 log 50% tissue culture infective dose [TCID50] ml(-1) to <1 log TCID50 ml(-1) within 24 h and from 3.82 log TCID50 ml(-1) to <1 log TCID50 ml(-1) within 48 h). However, in both cases, after 120 h of depuration, a residual amount of virus capable of replicating in cells was detected. These results show that depuration, even if performed with advanced systems, may not guarantee the absence of virus.

Viruses and bivalve shellfish

The epidemiological data clearly demonstrates that filter feeding bivalve shellfish can, and do, act as efficient vehicles for the transmission of enteric viruses transmitted by the faecal-oral route. This identified hazard has been documented as a cause for concern by various international agencies and has a long history. Disease outbreaks can occur on an epidemic scale as graphically illustrated by an outbreak of Hepatitis A in Shanghai, China in 1988 involving about 300,000 cases. Improvement of harvesting area water quality offers the most sustainable route to improvement in the virological quality of bivalve shellfish sold live. However there is growing awareness, and concern, that current regulatory standards based on faecal coliform monitoring do not fully protect the shellfish consumer from viral infection. New viral test methods based on PCR, and the development of alternative more reliable faecal pollution indicators, offer new approaches for the further development of public health controls. However, further work is required to build a scientific consensus and to understand the implications of their introduction into legislation.

Detection of norwalk-like virus in shellfish implicated in illness

In the 1990s, Norwalk-like viruses (NLVs) were identified in patient specimens as the primary pathogen associated with shellfish-borne gastroenteritis in the United States. Identification of these viruses from implicated shellfish has been difficult due to inefficient recovery of viruses, natural polymerase chain reaction (PCR) inhibitors in shellfish, and low virus contamination. Recent improvements to the method of detecting NLVs in shellfish include enhanced processing of virus and shellfish samples, application of nested PCR and nucleotide sequencing, and increased knowledge of NLV genetic diversity. Using a newly developed and sensitive method, an NLV G2 strain was identified in 2 oyster samples implicated in a 1998 California outbreak involving 171 cases. NLV capsid primers demonstrated a greater specificity of PCR detection than did polymerase primers. The 175-base viral capsid nucleotide sequences derived from oysters were 100% identical to those derived from a patient stool sample. This finding supports the epidemiologic associations indicating that contaminated shellfish serve as the vehicle for NLV transmission.

Heat inactivation of hepatitis A virus in dairy foods

Experiments were performed to determine the thermal resistance of hepatitis A virus (HAV) in three types of dairy products containing increased amounts of fat content (skim milk, homogenized milk; 3.5% MFG, and table cream; 18% MFG). HAV-inoculated dairy products were introduced into custom-made U-shaped microcapillary tubes that in turn were simultaneously immersed in a waterbath, using custom-made floating boats and a carrying platform. Following exposure to the desired time and temperature combinations, the contents of each of the tubes was retrieved and was tested by plaque assay to determine the reduction in virus titer. Our data indicated that < 0.5 min at 85 degrees C was sufficient to cause a 5-log reduction in HAV titer in all three dairy products, whereas at 80 degrees C, < or = 0.68 min (for skim and homogenized milk), and 1.24 min (for cream) were needed to cause a similar log reduction. Using a nonlinear two-phase negative exponential model (two-compartment model) to analyze the data, it was found that at temperatures of 65, 67, 69, 71, and 75 degrees C, significantly (P < 0.05) higher exposure times were needed to achieve a 1-log reduction in virus titer in cream, as compared to skim and homogenized milk. For example, at 71 degrees C, a significantly (P < 0.05) higher exposure time of 0.52 min (for cream) was needed as compared to < or = 0.18 min (for skim and homogenized milk) to achieve a 1-log reduction in virus titer. A similar trend of inactivation was observed at 73 and 75 degrees C where significantly (P < 0.05) higher exposure times of 0.29 to 0.36 min for cream were needed to cause a 1-log reduction in HAV in cream, as compared to < or = 0.17 min for skim and homogenized milk. This study has provided information on the heat resistance of HAV in skim milk, homogenized milk, and table cream and demonstrated that an increase in fat content appears to play a protective role and contributes to the heat stability of HAV.

Determination of enteroviruses, hepatitis A virus, bacteriophages and Escherichia coli in Adriatic Sea mussels

The aim of the present study was to evaluate the incidence of enteric viruses in mussels and to verify the possibility of using phages as indirect indicators of mussel viral contamination. Mussels (36 samples) collected from three different areas of the Adriatic Sea were analysed to determine the following parameters: Escherichia coli, somatic coliphage (T6 phage), F-Plus (MS2 phage), B40-8 (phage of Bacteroides fragilis), enteroviruses and hepatitis A virus. Most of the results of the bacteriological analysis (most probable number (MPN) ml-1) were in accordance with the bacteriological limits established by European law, with the exception of seven samples. The bacteriophage analyses were always negative for F-Plus and B40-8, with the exception of a few samples, whereas the somatic coliphages were generally between 0 and 20 MPN g-1, with the exception of two samples (110 MPN g-1). The virological analysis showed five samples positive for the presence of enteroviruses and 13 for the presence of hepatitis A virus (in three samples both viruses were present). Most of these samples presented acceptable bacteriological parameters and the bacteriophages were absent or their value was generally very low. The results show that the detection of E. coli and phages does not seem to be a good indicator of viral contamination.

Inactivation of hepatitis A virus in heat-treated mussels

Hepatitis A is a widespread infectious disease world-wide. In Italy, shellfish consumption was shown to be a major risk factor for hepatitis A infection, especially when these products are eaten raw or slightly cooked. The aim of the present study was to evaluate Hepatitis A virus (HAV) resistance in experimentally contaminated mussels treated at different temperatures (60, 80 and 100 degrees C) for various times. The presence of HAV was evaluated by cell culture infection and reverse transcriptase-polymerase chain reaction confirmation. The experiments, carried out on HAV suspension and contaminated mussel homogenate both containing about 10(5) 50% tissue culture infectious dose ml-1, showed that, under our experimental conditions, the treatments at 60 degrees C for 30 min, 80 degrees C for 10 min and an immersion at 100 degrees C for 1 min were not sufficient to inactivate all the viruses; it was necessary to prolong the treatment at 100 degrees C for 2 min to completely inactivate the virus. Thus it is advisable to eat only cooked shellfish, paying particular attention to the times and temperatures used in the cooking process, since evidence suggests that the shellfish body may protect the virus from the heat effect.

Dose-response in an outbreak of non-bacterial food poisoning traced to a mixed seafood cocktail

An outbreak of non-bacterial food poisoning presumed due to small round, structured viruses (SRSV) occurred at a national conference. A detailed postal survey of all conference attenders was carried out to ascertain the cause of the outbreak and 355 questionnaires were returned. Univariate analysis showed that mussels in the seafood cocktail were the likely vehicle of infection. A dose-response relationship between the amount of seafood cocktail consumed and the risk of illness was demonstrated. Dose-response has not previously been documented in a food-borne outbreak due to small round structured virus. Detailed quantitative food histories can be useful in eliciting dose-response relationships and may be crucial in establishing the vehicle of infection when investigating food poisoning following consumption of a set-menu meal. Their use should be considered in other outbreak situations.