1
|
Sun X, Chen M, Li Y, Wang J, Zhang M, Li N, Dai R, Wang Z, Wang X. A novel Anaerobic Cathodic Dynamic Membrane Bioreactor (AnCDMBR) for efficient mitigating fouling and recovering bioenergy from municipal wastewater. WATER RESEARCH 2024; 265:122225. [PMID: 39142072 DOI: 10.1016/j.watres.2024.122225] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/13/2024] [Revised: 07/25/2024] [Accepted: 08/05/2024] [Indexed: 08/16/2024]
Abstract
Concerns regarding membrane fouling and suboptimal bioenergy recovery have constrained the implementation of anaerobic membrane bioreactor (AnMBR) for treating low-strength municipal wastewater. This study presents a novel anaerobic cathodic dynamic membrane bioreactor (AnCDMBR) designed to address these challenges. A self-formed cathodic dynamic membrane (CDM) on inexpensive carbon cloth was developed to function as both a membrane and biocathode to achieve dual-function effects of mitigating membrane fouling and accelerating organics conversion. Compared with common dynamic membrane (1.52 kPa/d) and commercial membranes (7.52 kPa/d), the developed CDM presented a significantly reduced fouling rate (1.02 kPa/d), exhibiting the potential as a substitute for high-cost conductive membranes. Furthermore, efficient and stable biomethanation occurred in AnCDMBR with a superior methane yield rate of 0.26 L-CH4/g-COD (CH4 content > 95 %), which was 1.42 times higher than the control, linked to the higher activities of microbial metabolism and methanogenic-related key enzymes. Further analysis revealed that electrostimulation-induced niche differentiation of microbiota regulated interspecies interactions between electroactive microorganisms and complex anaerobic digestion microbiomes, facilitating organic matter conversion to methane and leading to superior bioenergy recovery. This study offered a new strategy for effectively mitigating fouling and recovering bioenergy from low-strength wastewater, potentially expanding the application of AnMBRs.
Collapse
Affiliation(s)
- Xinyi Sun
- MOE Key Laboratory of Pollution Processes and Environmental Criteria / Tianjin Engineering Center of Environmental Diagnosis and Contamination Remediation, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China
| | - Mei Chen
- MOE Key Laboratory of Pollution Processes and Environmental Criteria / Tianjin Engineering Center of Environmental Diagnosis and Contamination Remediation, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China.
| | - Yanli Li
- MOE Key Laboratory of Pollution Processes and Environmental Criteria / Tianjin Engineering Center of Environmental Diagnosis and Contamination Remediation, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China; Department of Civil, Construction, and Environmental Engineering, The university of Alabama, Tuscaloosa, AL 35487, USA
| | - Jinning Wang
- MOE Key Laboratory of Pollution Processes and Environmental Criteria / Tianjin Engineering Center of Environmental Diagnosis and Contamination Remediation, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China
| | - Minliang Zhang
- MOE Key Laboratory of Pollution Processes and Environmental Criteria / Tianjin Engineering Center of Environmental Diagnosis and Contamination Remediation, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China
| | - Nan Li
- School of Environmental Science and Engineering, Tianjin University, No. 92 Weijin Road, Nankai District, Tianjin 300072, China
| | - Ruobin Dai
- State Key Laboratory of Pollution Control and Resource Reuse, Shanghai Institute of Pollution Control and Ecological Security, Tongji Advanced Membrane Technology Center, School of Environmental Science and Engineering, Tongji University, Shanghai 200092, China
| | - Zhiwei Wang
- State Key Laboratory of Pollution Control and Resource Reuse, Shanghai Institute of Pollution Control and Ecological Security, Tongji Advanced Membrane Technology Center, School of Environmental Science and Engineering, Tongji University, Shanghai 200092, China
| | - Xin Wang
- MOE Key Laboratory of Pollution Processes and Environmental Criteria / Tianjin Engineering Center of Environmental Diagnosis and Contamination Remediation, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China
| |
Collapse
|
2
|
Wu S, Ma B, Fan H, Hua X, Hu C, Ulbricht M, Qu J. Influence of water quality factors on cake layer 3D structures and water channels during ultrafiltration process. WATER RESEARCH 2023; 242:120226. [PMID: 37364354 DOI: 10.1016/j.watres.2023.120226] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/29/2023] [Revised: 05/28/2023] [Accepted: 06/12/2023] [Indexed: 06/28/2023]
Abstract
The three-dimensional (3D) structure of the cake layer, which could be influenced by water quality factors, plays a significant role in the ultrafiltration (UF) efficiency of water purification. However, it remains challenging to precisely reveal the variation of cake layer 3D structures and water channel characteristics. Herein, we systematically report the variation in the cake layer 3D structure at the nanoscale induced by key water quality factors and reveal its influence on water transport, in particular the abundance of water channels within the cake layer. In comparison with pH and Na+, Ca2+ played more significant role in determining cake layer structures. The sandwich-like cake layer, which was induced by the asynchronous deposition of humic acids and sodium alginate (SA), shifted to an isotropic structure when Ca2+ was present due to the Ca2+ bridging. In comparison with the sandwich-like structure, the isotropic cake layer has higher fractions of free volume (voids) and more water channels, leading to a 147% improvement in the water transport coefficient, 60% reduction in the cake layer resistance, and 21% increase in the final membrane specific flux. Our work elucidates a structure-property relationship where improving the isotropy of the cake layer 3D structure is conducive to the optimization of water channels and water transport within cake layers. This could inspire tailored regulation strategies for cake layers to enhance the UF efficiency of water purification.
Collapse
Affiliation(s)
- Siqi Wu
- Key Laboratory of Drinking Water Science and Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China
| | - Baiwen Ma
- Key Laboratory of Drinking Water Science and Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China; Lehrstuhl für Technische Chemie II, Universität Duisburg-Essen, Essen 45117, Germany.
| | - Hongwei Fan
- College of Chemical Engineering, Beijing University of Chemical Technology, Beijing 100029, China
| | - Xin Hua
- Jiangsu Engineering Laboratory of Smart Carbon-Rich Materials and Device, School of Chemistry and Chemical Engineering, Southeast University, Nanjing 211189, China; School of Chemistry and Molecular Engineering, East China University of Science and Technology, Shanghai 200237, China
| | - Chengzhi Hu
- Key Laboratory of Drinking Water Science and Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China
| | - Mathias Ulbricht
- Lehrstuhl für Technische Chemie II, Universität Duisburg-Essen, Essen 45117, Germany
| | - Jiuhui Qu
- Key Laboratory of Drinking Water Science and Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; University of Chinese Academy of Sciences, Beijing 100049, China
| |
Collapse
|
3
|
Yang Y, Wang J, Chen M, Li N, Yan J, Wang X. Self-forming electroactive dynamic membrane for enhancing the decolorization of methyl orange by weak electrical stimulation. THE SCIENCE OF THE TOTAL ENVIRONMENT 2023; 863:160897. [PMID: 36521609 DOI: 10.1016/j.scitotenv.2022.160897] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/26/2022] [Revised: 12/08/2022] [Accepted: 12/08/2022] [Indexed: 06/17/2023]
Abstract
An electroactive dynamic membrane (EADM), which enabled simultaneous solid-liquid separation and contaminants removal, has been developed by electrostimulation using domestic wastewater as inoculum. Results showed that both the control dynamic membrane (CDM), without electrical stimulation, and the EADM systems exhibited stable removal performance with chemical oxygen demand (COD), and a robustness in responding to a fluctuating organic load. With the introduction of a weak electrical field, the EADM transmembrane pressure (TMP) was significantly reduced (0.02 kPa/d) compared with the control (0.20 kPa/d). In the treatment of methyl orange (MO), the EADM system achieved a decolorization efficiency of 85.87 %, much higher than the control dynamic membrane (CDM) system (58.84 %), which can be attributed to electrical stimulation and H2 production on cathode. Microbial analysis has established that electrostimulation enriched the electroactive bacteria in the dynamic biofilm, and shaped the microbial structure, with improved contaminant removal. The results of this study highlight the potential of regulating the microbial community and creating a beneficial biofilm as a dynamic layer to facilitate contaminant removal.
Collapse
Affiliation(s)
- Yang Yang
- College of Environmental Science and Engineering, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China; MOE Key Laboratory of Pollution Processes and Environmental Criteria, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China; Tianjin Key Laboratory of Environmental Remediation and Pollution Control, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China
| | - Jinning Wang
- College of Environmental Science and Engineering, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China; MOE Key Laboratory of Pollution Processes and Environmental Criteria, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China; Tianjin Key Laboratory of Environmental Remediation and Pollution Control, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China
| | - Mei Chen
- College of Environmental Science and Engineering, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China; MOE Key Laboratory of Pollution Processes and Environmental Criteria, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China; Tianjin Key Laboratory of Environmental Remediation and Pollution Control, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China.
| | - Nan Li
- School of Environmental Science and Engineering, Tianjin University, No. 35 Yaguan Road, Jinnan District, Tianjin 300350, China
| | - Jiaguo Yan
- Division of Oilfield Chemicals, China Oilfield Services Limited, No. 1581, Haichuan Road, Binhai New District, Tianjin, China
| | - Xin Wang
- College of Environmental Science and Engineering, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China; MOE Key Laboratory of Pollution Processes and Environmental Criteria, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China; Tianjin Key Laboratory of Environmental Remediation and Pollution Control, Nankai University, No. 38 Tongyan Road, Jinnan District, Tianjin 300350, China
| |
Collapse
|
4
|
An B, Wang Y, Huang Y, Wang X, Liu Y, Xun D, Church GM, Dai Z, Yi X, Tang TC, Zhong C. Engineered Living Materials For Sustainability. Chem Rev 2023; 123:2349-2419. [PMID: 36512650 DOI: 10.1021/acs.chemrev.2c00512] [Citation(s) in RCA: 38] [Impact Index Per Article: 38.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/15/2022]
Abstract
Recent advances in synthetic biology and materials science have given rise to a new form of materials, namely engineered living materials (ELMs), which are composed of living matter or cell communities embedded in self-regenerating matrices of their own or artificial scaffolds. Like natural materials such as bone, wood, and skin, ELMs, which possess the functional capabilities of living organisms, can grow, self-organize, and self-repair when needed. They also spontaneously perform programmed biological functions upon sensing external cues. Currently, ELMs show promise for green energy production, bioremediation, disease treatment, and fabricating advanced smart materials. This review first introduces the dynamic features of natural living systems and their potential for developing novel materials. We then summarize the recent research progress on living materials and emerging design strategies from both synthetic biology and materials science perspectives. Finally, we discuss the positive impacts of living materials on promoting sustainability and key future research directions.
Collapse
Affiliation(s)
- Bolin An
- Center for Materials Synthetic Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China.,CAS Key Laboratory of Quantitative Engineering Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China
| | - Yanyi Wang
- Center for Materials Synthetic Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China.,CAS Key Laboratory of Quantitative Engineering Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China
| | - Yuanyuan Huang
- Center for Materials Synthetic Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China.,CAS Key Laboratory of Quantitative Engineering Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China
| | - Xinyu Wang
- Center for Materials Synthetic Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China.,CAS Key Laboratory of Quantitative Engineering Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China
| | - Yuzhu Liu
- Center for Materials Synthetic Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China.,CAS Key Laboratory of Quantitative Engineering Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China
| | - Dongmin Xun
- Center for Materials Synthetic Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China.,CAS Key Laboratory of Quantitative Engineering Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China
| | - George M Church
- Center for Materials Synthetic Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China.,Wyss Institute for Biologically Inspired Engineering, Harvard University, Boston 02115, Massachusetts United States.,Department of Genetics, Blavatnik Institute, Harvard Medical School, Boston 02115, Massachusetts United States
| | - Zhuojun Dai
- Center for Materials Synthetic Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China.,CAS Key Laboratory of Quantitative Engineering Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China
| | - Xiao Yi
- Center for Materials Synthetic Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China.,CAS Key Laboratory of Quantitative Engineering Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China
| | - Tzu-Chieh Tang
- Wyss Institute for Biologically Inspired Engineering, Harvard University, Boston 02115, Massachusetts United States.,Department of Genetics, Blavatnik Institute, Harvard Medical School, Boston 02115, Massachusetts United States
| | - Chao Zhong
- Center for Materials Synthetic Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China.,CAS Key Laboratory of Quantitative Engineering Biology, Shenzhen Institute of Synthetic Biology, Shenzhen Institute of Advanced Technology, Chinese Academy of Sciences, Shenzhen 518055, China
| |
Collapse
|
5
|
Maitreya A, Pal S, Qureshi A, Reyed RM, Purohit HJ. Nitric oxide-secreting probiotics as sustainable bio-cleaners for reverse osmosis membrane systems. ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2022; 29:4911-4929. [PMID: 34797547 DOI: 10.1007/s11356-021-17289-6] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/24/2021] [Accepted: 10/27/2021] [Indexed: 06/13/2023]
Abstract
Membrane biofouling in water purification plants is a serious issue of worldwide concern. Various chemical, physical, and biochemical processes are practised for membrane clean-up. A high-dosage treatment adversely affects the life expectancy of the membrane, and minimum dosage seems unable to deteriorate the biofilms on the membrane. It is reported that quorum quenchers like nitric oxide (NO) disrupt biofilm signals through metabolic rewiring, and also NO is known to be secreted by probiotics (good bacteria). In the present review, it is hypothesized that if probiotic biofilms secreting NO are used, other microbes that aggregate on the filtration membrane could be mitigated. The concept of probiotic administration on filtration membrane seeks to be encouraged because probiotic bacteria will not be hazardous, even if released during filtration. The fundamental motive to present probiotics as a resource for sequestering NO may serve as multifunctional bioweapons for membrane remediation, which will virtually guarantee their long-term sustainability and green approach.
Collapse
Affiliation(s)
- Anuja Maitreya
- Environmental Biotechnology and Genomics Division (EBGD), CSIR-National Environmental Engineering Research Institute (CSIR-NEERI), Nehru Marg, Nagpur, 440 020, India
- Academy of Scientific and Innovative Research (AcSIR), Ghaziabad, 201002, India
| | - Smita Pal
- Division of Endocrinology, CSIR -Central Drug Research Institute, Lucknow, 226031, India
| | - Asifa Qureshi
- Environmental Biotechnology and Genomics Division (EBGD), CSIR-National Environmental Engineering Research Institute (CSIR-NEERI), Nehru Marg, Nagpur, 440 020, India.
- Academy of Scientific and Innovative Research (AcSIR), Ghaziabad, 201002, India.
| | - Reyed M Reyed
- Bioprocess Development Department, Genetic Engineering and Biotechnology Research Institute, City for Scientific Research and Applied Technology, New Borg Al Arab, Alexandria, Egypt
| | - Hemant J Purohit
- Environmental Biotechnology and Genomics Division (EBGD), CSIR-National Environmental Engineering Research Institute (CSIR-NEERI), Nehru Marg, Nagpur, 440 020, India
| |
Collapse
|
6
|
Su Z, Liu T, Li X, Graham N, Yu W. Beneficial impacts of natural biopolymers during surface water purification by membrane nanofiltration. WATER RESEARCH 2021; 201:117330. [PMID: 34134038 DOI: 10.1016/j.watres.2021.117330] [Citation(s) in RCA: 13] [Impact Index Per Article: 4.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/21/2021] [Revised: 05/30/2021] [Accepted: 06/01/2021] [Indexed: 06/12/2023]
Abstract
Membrane filtration in various forms has become an increasingly used treatment method worldwide for the supply of safe drinking water. The fouling of membranes is commonly considered to be the major operational limitation to its wider application since it leads to frequent backwashing and a shortening of membrane life, and increased production costs. The components of natural organic matter (NOM) in surface waters have been reported previously to be important foulants of nanofiltration (NF) membranes, however, the potential beneficial effect of particular components of these 'foulants' has not been investigated or demonstrated to date. In this study, we have considered the roles of different organic materials including autochthonous NOM (e.g., biopolymers) and allochthonous NOM (e.g., humic substances) on the fouling of NF membranes by bench-scale tests with samples of two representative source waters (UK) taken in two different seasons (autumn and winter). Microfiltration (MF) and ultrafiltration (UF) were employed to generate two permeates, between which the presence of biopolymers (30 kDa - 90 kDa) is the major difference. We developed sequential filtration (MF/UF-NF) to investigate biopolymers' behaviours in NF process. The results showed that the accumulation of biopolymers on NF membranes can mitigate fouling by providing a protective layer in which medium-low molecular weight (MW) materials (e.g. humic substances) are separated by adsorption and/or size exclusion. The protective layers assisted by biopolymers were seen to be thicker under scanning electron microscope (SEM) observation and characterized by higher roughness (i.e. three-dimensional, spacial structure) and greater adsorptive capacity. Moreover, improvement on NF membrane fouling mitigation could be more significant in autumn, comparing to that in winter. The findings in this study were found to be repeatable in similar tests with samples of comparable raw waters in China, and will be important to the practical application of NF membrane systems in terms of a new approach to combating fouling in long-term operation.
Collapse
Affiliation(s)
- Zhaoyang Su
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Civil and Environmental Engineering, Imperial College London, South Kensington Campus, London SW7 2AZ, UK; College of Architecture and Civil Engineering, Beijing University of Technology, Beijing 100024, China.
| | - Ting Liu
- School of Chemistry and Chemical Engineering, Beijing Institute of Technology, Beijing 100081, China.
| | - Xing Li
- College of Architecture and Civil Engineering, Beijing University of Technology, Beijing 100024, China.
| | - Nigel Graham
- Department of Civil and Environmental Engineering, Imperial College London, South Kensington Campus, London SW7 2AZ, UK.
| | - Wenzheng Yu
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; Department of Civil and Environmental Engineering, Imperial College London, South Kensington Campus, London SW7 2AZ, UK.
| |
Collapse
|
7
|
Wu S, Hua X, Ma B, Fan H, Miao R, Ulbricht M, Hu C, Qu J. Three-Dimensional Analysis of the Natural-Organic-Matter Distribution in the Cake Layer to Precisely Reveal Ultrafiltration Fouling Mechanisms. ENVIRONMENTAL SCIENCE & TECHNOLOGY 2021; 55:5442-5452. [PMID: 33710872 DOI: 10.1021/acs.est.1c00435] [Citation(s) in RCA: 10] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 05/09/2023]
Abstract
Cake layer formation is the dominant ultrafiltration membrane fouling mechanism after long-term operation. However, precisely analyzing the cake-layer structure still remains a challenge due to its thinness (micro/nano scale). Herein, based on the excellent depth-resolution and foulant-discrimination of time-of-flight secondary ion mass spectrometry, a three-dimensional analysis of the cake-layer structure caused by natural organic matter was achieved at lower nanoscale for the first time. When humic substances or polysaccharides coexisted with proteins separately, a homogeneous cake layer was formed due to their interactions. Consequently, membrane fouling resistances induced by proteins were reduced by humic substances or polysaccharides, leading to a high flux. However, when humic substances and polysaccharides coexisted, a sandwich-like cake layer was formed owing to the asynchronous deposition based on molecular dynamics simulations. As a result, membrane fouling resistances were superimposed, and the flux was low. Furthermore, it is interesting that cake-layer structures were relatively stable under common UF operating conditions (i.e., concentration and stirring). These findings better elucidate membrane fouling mechanisms of different natural-organic-matter mixtures. Moreover, it is demonstrated that membrane fouling seems lower with a more homogeneous cake layer, and humic substances or polysaccharides play a critical role. Therefore, regulating the cake-layer structure by feed pretreatment scientifically based on proven mechanisms should be an efficient membrane-fouling-control strategy.
Collapse
Affiliation(s)
- Siqi Wu
- Key Laboratory of Drinking Water Science and Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
- University of Chinese Academy of Sciences, Beijing 100049, China
| | - Xin Hua
- Jiangsu Engineering Laboratory of Smart Carbon-Rich Materials and Device, School of Chemistry and Chemical Engineering, Southeast University, Nanjing 211189, China
- School of Chemistry and Molecular Engineering, East China University of Science and Technology, Shanghai 200237, China
| | - Baiwen Ma
- Key Laboratory of Drinking Water Science and Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
- University of Chinese Academy of Sciences, Beijing 100049, China
- Lehrstuhl fur Technische Chemie II, Universitat Duisburg-Essen, Essen 45117, Germany
| | - Hongwei Fan
- Institute of Physical Chemistry and Electrochemistry, Leibniz Universitat Hannover, Hannover 30167, Germany
| | - Rui Miao
- School of Environmental and Municipal Engineering, Xi'an University of Architecture and Technology, Xi'an 710055, China
| | - Mathias Ulbricht
- Lehrstuhl fur Technische Chemie II, Universitat Duisburg-Essen, Essen 45117, Germany
| | - Chengzhi Hu
- Key Laboratory of Drinking Water Science and Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
- University of Chinese Academy of Sciences, Beijing 100049, China
| | - Jiuhui Qu
- Key Laboratory of Drinking Water Science and Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
- University of Chinese Academy of Sciences, Beijing 100049, China
| |
Collapse
|
8
|
Nilusha RT, Wei Y. New Insights into the Microbial Diversity of Cake Layer in Yttria Composite Ceramic Tubular Membrane in an Anaerobic Membrane Bioreactor (AnMBR). MEMBRANES 2021; 11:108. [PMID: 33546268 PMCID: PMC7913466 DOI: 10.3390/membranes11020108] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 12/23/2020] [Revised: 01/19/2021] [Accepted: 01/27/2021] [Indexed: 11/17/2022]
Abstract
Cake layer formation is an inevitable challenge in membrane bioreactor (MBR) operation. The investigations on the cake layer microbial community are essential to control biofouling. This work studied the bacterial and archaeal communities in the cake layer, the anaerobic sludge, and the membrane cleaning solutions of anaerobic membrane bioreactor (AnMBR) with yttria-based ceramic tubular membrane by polymerase chain reaction (PCR) amplification of 16S rRNA genes. The cake layer resistance was 69% of the total membrane resistance. Proteins and soluble microbial by-products (SMPs) were the dominant foulants in the cake layer. The pioneering archaeal and bacteria in the cake layer were mostly similar to those in the anaerobic bulk sludge. The dominant biofouling bacteria were Proteobacteria, Bacteroidetes, Firmicutes, and Chloroflexi and the dominant archaeal were Methanosaetacea and Methanobacteriacea at family level. This finding may help to develop antifouling membranes for AnMBR treating domestic wastewater.
Collapse
Affiliation(s)
- Rathmalgodage Thejani Nilusha
- State Key Joint Laboratory of Environmental Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
- Environment Technology Section, Industrial Technology Institute, 363, Bauddhaloka Mawatha, Colombo 07 00700, Sri Lanka; or
- Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
- University of Chinese Academy of Sciences, Beijing 100049, China
| | - Yuansong Wei
- State Key Joint Laboratory of Environmental Simulation and Pollution Control, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
- Department of Water Pollution Control Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
- University of Chinese Academy of Sciences, Beijing 100049, China
- Institute of Energy, Jiangxi Academy of Sciences, Nanchang 330029, China
| |
Collapse
|
9
|
Mukherjee M, Cao B. Engineering controllable biofilms for biotechnological applications. Microb Biotechnol 2021; 14:74-78. [PMID: 33249757 PMCID: PMC7888450 DOI: 10.1111/1751-7915.13715] [Citation(s) in RCA: 12] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [MESH Headings] [Grants] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/09/2020] [Accepted: 11/09/2020] [Indexed: 11/30/2022] Open
Affiliation(s)
- Manisha Mukherjee
- Singapore Centre for Environmental Life Sciences EngineeringNanyang Technological UniversitySingapore637551Singapore
- School of Civil and Environmental EngineeringNanyang Technological UniversitySingapore639798Singapore
| | - Bin Cao
- Singapore Centre for Environmental Life Sciences EngineeringNanyang Technological UniversitySingapore637551Singapore
- School of Civil and Environmental EngineeringNanyang Technological UniversitySingapore639798Singapore
| |
Collapse
|
10
|
Elewa SI, Fatthallah NA, Nessim MI, El-Farargy AF. Synthesis and characterization of some tetrazoles and their prospective for aerobic micro-fouling mitigation. ARAB J CHEM 2020. [DOI: 10.1016/j.arabjc.2020.10.005] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/16/2022] Open
|
11
|
Pileggi M, Pileggi SA, Sadowsky MJ. Herbicide bioremediation: from strains to bacterial communities. Heliyon 2020; 6:e05767. [PMID: 33392402 PMCID: PMC7773584 DOI: 10.1016/j.heliyon.2020.e05767] [Citation(s) in RCA: 24] [Impact Index Per Article: 6.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/18/2020] [Revised: 08/23/2020] [Accepted: 12/15/2020] [Indexed: 01/12/2023] Open
Abstract
There is high demand for herbicides based on the necessity to increase crop production to satisfy world-wide demands. Nevertheless, there are negative impacts of herbicide use, manifesting as selection for resistant weeds, production of toxic metabolites from partial degradation of herbicides, changes in soil microbial communities and biogeochemical cycles, alterations in plant nutrition and soil fertility, and persistent environmental contamination. Some herbicides damage non-target microorganisms via directed interference with host metabolism and via oxidative stress mechanisms. For these reasons, it is necessary to identify sustainable, efficient methods to mitigate these environmental liabilities. Before the degradation process can be initiated by microbial enzymes and metabolic pathways, microorganisms need to tolerate the oxidative stresses caused by the herbicides themselves. This can be achieved via a complex system of enzymatic and non-enzymatic antioxidative stress systems. Many of these response systems are not herbicide specific, but rather triggered by a variety of substances. Collectively, these nonspecific response systems enhance the survival and fitness potential of microorganisms. Biodegradation studies and remediation approaches have relied on individually selected strains to effectively remediate herbicides in the environment. Nevertheless, it has been shown that microbial communication systems that modulate social relationships and metabolic pathways inside biofilm structures among microorganisms are complex; therefore, use of isolated strains for xenobiotic degradation needs to be enhanced using a community-based approach with biodegradation pathway integration. Bioremediation efforts can use omics-based technologies to gain a deeper understanding of the molecular complexes of bacterial communities to achieve to more efficient elimination of xenobiotics. With this knowledge, the possibility of altering microbial communities is increased to improve the potential for bioremediation without causing other environmental impacts not anticipated by simpler approaches. The understanding of microbial community dynamics in free-living microbiota and those present in complex communities and in biofilms is paramount to achieving these objectives. It is also essential that non-developed countries, which are major food producers and consumers of pesticides, have access to these techniques to achieve sustainable production, without causing impacts through unknown side effects.
Collapse
Affiliation(s)
- Marcos Pileggi
- Laboratory of Environmental Microbiology, Biological Science and Health Institute, Department of Structural and Molecular Biology, and Genetics, State University of Ponta Grossa, Ponta Grossa, Paraná, Brazil
| | - Sônia A.V. Pileggi
- Laboratory of Environmental Microbiology, Biological Science and Health Institute, Department of Structural and Molecular Biology, and Genetics, State University of Ponta Grossa, Ponta Grossa, Paraná, Brazil
| | - Michael J. Sadowsky
- The Biotechnology Institute, Department of Soil, Water, and Climate, Department of Plant and Microbial Biology, University of Minnesota, Saint Paul, MN, USA
| |
Collapse
|
12
|
Stephens K, Bentley WE. Synthetic Biology for Manipulating Quorum Sensing in Microbial Consortia. Trends Microbiol 2020; 28:633-643. [DOI: 10.1016/j.tim.2020.03.009] [Citation(s) in RCA: 44] [Impact Index Per Article: 11.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/18/2020] [Accepted: 03/25/2020] [Indexed: 12/13/2022]
|
13
|
Hong SH, Gorce JB, Punzmann H, Francois N, Shats M, Xia H. Surface waves control bacterial attachment and formation of biofilms in thin layers. SCIENCE ADVANCES 2020; 6:eaaz9386. [PMID: 32766446 PMCID: PMC7385439 DOI: 10.1126/sciadv.aaz9386] [Citation(s) in RCA: 10] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/22/2019] [Accepted: 03/19/2020] [Indexed: 05/06/2023]
Abstract
Formation of bacterial biofilms on solid surfaces within a fluid starts when bacteria attach to the substrate. Understanding environmental factors affecting the attachment and the early stages of the biofilm development will help develop methods of controlling the biofilm growth. Here, we show that biofilm formation is strongly affected by the flows in thin layers of bacterial suspensions controlled by surface waves. Deterministic wave patterns promote the growth of patterned biofilms, while wave-driven turbulent motion discourages patterned attachment of bacteria. Strong biofilms form under the wave antinodes, while inactive bacteria and passive particles settle under nodal points. By controlling the wavelength, its amplitude, and horizontal mobility of the wave patterns, one can shape the biofilm and either enhance the growth or discourage the formation of the biofilm. The results suggest that the deterministic wave-driven transport channels, rather than hydrodynamic forces acting on microorganisms, determine the preferred location for the bacterial attachment.
Collapse
Affiliation(s)
- Sung-Ha Hong
- Research School of Physics, The Australian National University, Canberra, ACT 2601, Australia
| | - Jean-Baptiste Gorce
- Research School of Physics, The Australian National University, Canberra, ACT 2601, Australia
| | | | | | | | | |
Collapse
|
14
|
Fang K, Park OJ, Hong SH. Controlling biofilms using synthetic biology approaches. Biotechnol Adv 2020; 40:107518. [PMID: 31953206 PMCID: PMC7125041 DOI: 10.1016/j.biotechadv.2020.107518] [Citation(s) in RCA: 17] [Impact Index Per Article: 4.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/02/2019] [Revised: 01/09/2020] [Accepted: 01/11/2020] [Indexed: 12/22/2022]
Abstract
Bacterial biofilms are formed by the complex but ordered regulation of intra- or inter-cellular communication, environmentally responsive gene expression, and secretion of extracellular polymeric substances. Given the robust nature of biofilms due to the non-growing nature of biofilm bacteria and the physical barrier provided by the extracellular matrix, eradicating biofilms is a very difficult task to accomplish with conventional antibiotic or disinfectant treatments. Synthetic biology holds substantial promise for controlling biofilms by improving and expanding existing biological tools, introducing novel functions to the system, and re-conceptualizing gene regulation. This review summarizes synthetic biology approaches used to eradicate biofilms via protein engineering of biofilm-related enzymes, utilization of synthetic genetic circuits, and the development of functional living agents. Synthetic biology also enables beneficial applications of biofilms through the production of biomaterials and patterning biofilms with specific temporal and spatial structures. Advances in synthetic biology will add novel biofilm functionalities for future therapeutic, biomanufacturing, and environmental applications.
Collapse
Affiliation(s)
- Kuili Fang
- Department of Chemical and Biological Engineering, Illinois Institute of Technology, Chicago, IL 60616, USA
| | - Oh-Jin Park
- Department of Chemical and Biological Engineering, Illinois Institute of Technology, Chicago, IL 60616, USA; Department of Biological and Chemical Engineering, Yanbian University of Science and Technology, Yanji, Jilin, People's Republic of China
| | - Seok Hoon Hong
- Department of Chemical and Biological Engineering, Illinois Institute of Technology, Chicago, IL 60616, USA.
| |
Collapse
|
15
|
de Vries HJ, Stams AJM, Plugge CM. Biodiversity and ecology of microorganisms in high pressure membrane filtration systems. WATER RESEARCH 2020; 172:115511. [PMID: 31986400 DOI: 10.1016/j.watres.2020.115511] [Citation(s) in RCA: 18] [Impact Index Per Article: 4.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/29/2019] [Revised: 12/19/2019] [Accepted: 01/13/2020] [Indexed: 06/10/2023]
Abstract
High-pressure membrane filtration (reverse osmosis and nanofiltration) is used to purify different water sources, including wastewater, surface water, groundwater and seawater. A major concern in membrane filtration is the accumulation and growth of micro-organisms and their secreted polymeric substances, leading to reduced membrane performance and membrane biofouling. The fundamental understanding of membrane biofouling is limited despite years of research, as the means of microbial interactions and response to the conditions on the membrane surface are complicated. Here, we discuss studies that investigated the microbial diversity of fouled high-pressure membranes. High-throughput amplicon sequencing of the 16S rRNA gene have shown that Burkholderiales, Pseudomonadales, Rhizobiales, Sphingomonadales and Xanthomonadales frequently obtain a high relative abundance on fouled membranes. The bacterial communities present in the diverse feed water types and in pre-treatment compartments are different from the communities on the membrane, because high-pressure membrane filtration provides a selective environment for certain bacterial groups. The biofilms that form within the pre-treatment compartments do not commonly serve as an inoculum for the subsequent high-pressure membranes. Besides bacteria also fungi are detected in the water treatment compartments. In contrast to bacteria, the fungal community does not change much throughout membrane cleaning. The stable fungal diversity indicates that they are more significant in membrane biofouling than previously thought. By reviewing the biodiversity and ecology of microbes in the whole high pressure membrane filtration water chain, we have been able to identify potentials to improve biofouling control. These include modulation of hydrodynamic conditions, nutrient limitation and the combination of cleaning agents to target the entire membrane microbiome.
Collapse
Affiliation(s)
- Hendrik J de Vries
- Laboratory of Microbiology, Wageningen University & Research, Stippeneng 4, 6708, WE, Wageningen, the Netherlands; Wetsus, European Centre of Excellence for Sustainable Water Technology, Oostergoweg 9, 8911, MA, Leeuwarden, the Netherlands
| | - Alfons J M Stams
- Laboratory of Microbiology, Wageningen University & Research, Stippeneng 4, 6708, WE, Wageningen, the Netherlands
| | - Caroline M Plugge
- Laboratory of Microbiology, Wageningen University & Research, Stippeneng 4, 6708, WE, Wageningen, the Netherlands; Wetsus, European Centre of Excellence for Sustainable Water Technology, Oostergoweg 9, 8911, MA, Leeuwarden, the Netherlands.
| |
Collapse
|
16
|
Vanwonterghem I, Webster NS. Coral Reef Microorganisms in a Changing Climate. iScience 2020; 23:100972. [PMID: 32208346 PMCID: PMC7096749 DOI: 10.1016/j.isci.2020.100972] [Citation(s) in RCA: 30] [Impact Index Per Article: 7.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/20/2019] [Revised: 02/24/2020] [Accepted: 03/05/2020] [Indexed: 01/09/2023] Open
Abstract
Coral reefs are one of the most diverse and productive ecosystems on the planet, yet they have suffered tremendous losses due to anthropogenic disturbances and are predicted to be one of the most adversely affected habitats under future climate change conditions. Coral reefs can be viewed as microbially driven ecosystems that rely on the efficient capture, retention, and recycling of nutrients in order to thrive in oligotrophic waters. Microorganisms play vital roles in maintaining holobiont health and ecosystem resilience under environmental stress; however, they are also key players in positive feedback loops that intensify coral reef decline, with cascading effects on biogeochemical cycles and marine food webs. There is an urgent need to develop a fundamental understanding of the complex microbial interactions within coral reefs and their role in ecosystem acclimatization, and it is important to include microorganisms in reef conservation in order to secure a future for these unique environments.
Collapse
Affiliation(s)
- Inka Vanwonterghem
- Australian Centre for Ecogenomics, School of Chemistry and Molecular Biosciences, University of Queensland, Brisbane, QLD 4072, Australia.
| | - Nicole S Webster
- Australian Centre for Ecogenomics, School of Chemistry and Molecular Biosciences, University of Queensland, Brisbane, QLD 4072, Australia; Australian Institute of Marine Science, Townsville, QLD 4810, Australia
| |
Collapse
|
17
|
Tang M, Hou D, Ding C, Wang K, Wang D, Wang J. Anti-oil-fouling hydrophobic-superoleophobic composite membranes for robust membrane distillation performance. THE SCIENCE OF THE TOTAL ENVIRONMENT 2019; 696:133883. [PMID: 31446287 DOI: 10.1016/j.scitotenv.2019.133883] [Citation(s) in RCA: 21] [Impact Index Per Article: 4.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/18/2019] [Revised: 07/25/2019] [Accepted: 08/10/2019] [Indexed: 06/10/2023]
Abstract
As a promising thermally driven separation process, membrane distillation (MD) is capable of treating challenging wastewaters. However, the traditional hydrophobic membranes are vulnerable to fouling by non-polar contaminants owing to the strong hydrophobic-hydrophobic interactions. To address this problem, we developed novel anti-oil-fouling MD membranes in this study. The composite membranes with asymmetric wettability were fabricated through electrospinning polyacrylonitrile (PAN) fibrous coating on a hydrophobic polytetrafluoroethylene (PTFE) membrane, followed by hydrolyzing the PAN coating with ethylenediamine (EDA) and NaOH, respectively. These two composite membranes exhibited excellent underwater superoleophobicity, with the underwater oil contact angle >150°, which can be attributed to the fibrous and re-entrant surface structure and the optimized surface hydrophilicity of the electrospun coating. During MD process using saline and oily emulsion as feed, the composite membranes presented robust anti-oil-fouling performance, indicating by stable permeate flux and salt rejection. A novel oil-droplet adhesion force probe was introduced to quasi-quantitatively elucidate oil-membrane interaction and evaluate membrane fouling propensity, the force spectroscopy indicated that the fabricated composite membranes had fairly less attractive to crude oil compared with the PTFE membrane. Our research results suggest that the novel composite membranes with asymmetric wettability were competent to serve as an anti-oil-fouling MD membrane for desalinating challenging saline and oily wastewaters.
Collapse
Affiliation(s)
- Min Tang
- Key Laboratory of Drinking Water Science and Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; College of Resources and Environment, University of Chinese Academy of Sciences, Beijing 100190, China
| | - Deyin Hou
- Key Laboratory of Drinking Water Science and Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; College of Resources and Environment, University of Chinese Academy of Sciences, Beijing 100190, China.
| | - Chunli Ding
- School of Chemical Engineering and Technology, Hebei University of Technology, Tianjin 300130, China
| | - Kunpeng Wang
- Key Laboratory of Drinking Water Science and Technology, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China; College of Resources and Environment, University of Chinese Academy of Sciences, Beijing 100190, China
| | - Dewu Wang
- School of Chemical Engineering and Technology, Hebei University of Technology, Tianjin 300130, China
| | - Jun Wang
- State Key Laboratory of Environmental Aquatic Chemistry, Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China
| |
Collapse
|
18
|
Influence of feed temperature to biofouling of ultrafiltration membrane during skim milk processing. Int Dairy J 2019. [DOI: 10.1016/j.idairyj.2019.02.005] [Citation(s) in RCA: 14] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/20/2022]
|
19
|
García-Contreras R, Wood TK, Tomás M. Editorial: Quorum Network (Sensing/Quenching) in Multidrug-Resistant Pathogens. Front Cell Infect Microbiol 2019; 9:80. [PMID: 31001486 PMCID: PMC6456689 DOI: 10.3389/fcimb.2019.00080] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.4] [Reference Citation Analysis] [Key Words] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/26/2019] [Accepted: 03/08/2019] [Indexed: 11/27/2022] Open
Affiliation(s)
- Rodolfo García-Contreras
- Department of Microbiology and Parasitology, Faculty of Medicine, National Autonomous University of Mexico, Mexico City, Mexico
| | - Thomas K Wood
- Department of Chemical Engineering, Pennsylvania State University, University Park, PA, United States
| | - Maria Tomás
- Microbiology Department, Complejo Hospitalario Universitario A Coruña, Instituto de Investigación Biomédica (INIBIC-CHUAC), Universidad de A Coruña, A Coruña, Spain
| |
Collapse
|
20
|
Klotz M, Kretschmer M, Goetz A, Ezendam S, Lieleg O, Opitz M. Importance of the biofilm matrix for the erosion stability of Bacillus subtilis NCIB 3610 biofilms. RSC Adv 2019; 9:11521-11529. [PMID: 35520264 PMCID: PMC9063333 DOI: 10.1039/c9ra01955c] [Citation(s) in RCA: 11] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/14/2019] [Accepted: 04/02/2019] [Indexed: 12/12/2022] Open
Abstract
Erosion of bacterial biofilms is dependent on the composition of the biofilm matrix and the surrounding chemical environment.
Collapse
Affiliation(s)
- M. Klotz
- Center for NanoScience
- Faculty of Physics
- Ludwig-Maximilians-Universität München
- Munich
- Germany
| | - M. Kretschmer
- Munich School of BioEngineering and Department of Mechanical Engineering
- Technische Universität München
- Garching
- Germany
| | - A. Goetz
- Center for NanoScience
- Faculty of Physics
- Ludwig-Maximilians-Universität München
- Munich
- Germany
| | - S. Ezendam
- Center for NanoScience
- Faculty of Physics
- Ludwig-Maximilians-Universität München
- Munich
- Germany
| | - O. Lieleg
- Munich School of BioEngineering and Department of Mechanical Engineering
- Technische Universität München
- Garching
- Germany
| | - M. Opitz
- Center for NanoScience
- Faculty of Physics
- Ludwig-Maximilians-Universität München
- Munich
- Germany
| |
Collapse
|
21
|
Zhang J, Poh CL. Regulating exopolysaccharide gene wcaF allows control of Escherichia coli biofilm formation. Sci Rep 2018; 8:13127. [PMID: 30177768 PMCID: PMC6120894 DOI: 10.1038/s41598-018-31161-7] [Citation(s) in RCA: 18] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/21/2018] [Accepted: 08/09/2018] [Indexed: 12/17/2022] Open
Abstract
While biofilms are known to cause problems in many areas of human health and the industry, biofilms are important in a number of engineering applications including wastewater management, bioremediation, and bioproduction of valuable chemicals. However, excessive biofilm growth remains a key challenge in the use of biofilms in these applications. As certain amount of biofilm growth is required for efficient use of biofilms, the ability to control and maintain biofilms at desired thickness is vital. To this end, we developed synthetic gene circuits to control E. coli MG1655 biofilm formation by using CRISPRi/dCas9 to regulate a gene (wcaF) involved in the synthesis of colanic acid (CA), a key polysaccharide in E. coli biofilm extracellular polymeric substance (EPS). We showed that the biofilm formation was inhibited when wcaF was repressed and the biofilms could be maintained at a different thickness over a period of time. We also demonstrated that it is also possible to control the biofilm thickness spatially by inhibiting wcaF gene using a genetic light switch. The results demonstrate that the approach has great potential as a new means to control and maintain biofilm thickness in biofilm related applications.
Collapse
Affiliation(s)
- Jingyun Zhang
- Department of Biomedical Engineering, Faculty of Engineering, National University of Singapore, 117583, 4 Engineering Drive 3, Singapore, Singapore
- NUS Synthetic Biology for Clinical and Technological Innovation (SynCTI), Life Sciences Institute, National University of Singapore, 117456, 28 Medical Drive, Singapore, Singapore
| | - Chueh Loo Poh
- Department of Biomedical Engineering, Faculty of Engineering, National University of Singapore, 117583, 4 Engineering Drive 3, Singapore, Singapore.
- NUS Synthetic Biology for Clinical and Technological Innovation (SynCTI), Life Sciences Institute, National University of Singapore, 117456, 28 Medical Drive, Singapore, Singapore.
| |
Collapse
|
22
|
Pal S, Qureshi A, Purohit HJ. Intercepting signalling mechanism to control environmental biofouling. 3 Biotech 2018; 8:364. [PMID: 30105189 DOI: 10.1007/s13205-018-1383-z] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/17/2018] [Accepted: 07/29/2018] [Indexed: 12/29/2022] Open
Abstract
Biofouling in environmental systems employs bacterial quorum sensing signals (autoinducers) and extracellular polymeric substances to onset the event. The present review has highlighted on the fundamental mechanisms behind biofilm formation over broad spectrum environmental niches especially membrane biofouling in water systems and consequent chances of pathogenic contamination leading to global economic loss. It has broadly discussed on bioelectrical signal (via, potassium gradient) and molecular signal (via, AHLs) mediated quorum sensing which help to propagate biofilm formation. The review has illustrated the potential of genomic intervention towards biofouled membrane microbial community and has uncovered possible features of biofilm microenvironment like quorum quenching bacteria, bioelectrical waves capture, siderophores arrest and surface modifications. Based on information, the concept of interception of quorum signals (AHLs) and bioelectrical signals (K+) by employing electro-modified (negative charges) membrane surface have been hypothesized in the present review to favour anti-biofouling.
Collapse
Affiliation(s)
- Smita Pal
- 1Academy of Scientific and Innovative Research (AcSIR), CSIR-National Environmental Engineering Research Institute (NEERI), Nehru Marg, Nagpur, Maharashtra 440020 India
- 2CSIR-Environmental Biotechnology and Genomics Division, CSIR-National Environmental Engineering Research Institute (NEERI), Nehru Marg, Nagpur, Maharashtra 440020 India
| | - Asifa Qureshi
- 1Academy of Scientific and Innovative Research (AcSIR), CSIR-National Environmental Engineering Research Institute (NEERI), Nehru Marg, Nagpur, Maharashtra 440020 India
- 2CSIR-Environmental Biotechnology and Genomics Division, CSIR-National Environmental Engineering Research Institute (NEERI), Nehru Marg, Nagpur, Maharashtra 440020 India
| | - Hemant J Purohit
- 2CSIR-Environmental Biotechnology and Genomics Division, CSIR-National Environmental Engineering Research Institute (NEERI), Nehru Marg, Nagpur, Maharashtra 440020 India
| |
Collapse
|
23
|
von Bronk B, Götz A, Opitz M. Complex microbial systems across different levels of description. Phys Biol 2018; 15:051002. [PMID: 29757151 DOI: 10.1088/1478-3975/aac473] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/22/2022]
Abstract
Complex biological systems offer a variety of interesting phenomena at the different physical scales. With increasing abstraction, details of the microscopic scales can often be extrapolated to average or typical macroscopic properties. However, emergent properties and cross-scale interactions can impede naïve abstractions and necessitate comprehensive investigations of these complex systems. In this review paper, we focus on microbial communities, and first, summarize a general hierarchy of relevant scales and description levels to understand these complex systems: (1) genetic networks, (2) single cells, (3) populations, and (4) emergent multi-cellular properties. Second, we employ two illustrating examples, microbial competition and biofilm formation, to elucidate how cross-scale interactions and emergent properties enrich the observed multi-cellular behavior in these systems. Finally, we conclude with pointing out the necessity of multi-scale investigations to understand complex biological systems and discuss recent investigations.
Collapse
Affiliation(s)
- Benedikt von Bronk
- Faculty of Physics and Center for NanoScience, Ludwig-Maximilians-Universität München, Geschwister-Scholl-Platz 1, D-80539 Munich, Germany
| | | | | |
Collapse
|
24
|
Seghal Kiran G, Ramasamy P, Sekar S, Ramu M, Hassan S, Ninawe A, Selvin J. Synthetic biology approaches: Towards sustainable exploitation of marine bioactive molecules. Int J Biol Macromol 2018; 112:1278-1288. [DOI: 10.1016/j.ijbiomac.2018.01.149] [Citation(s) in RCA: 8] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/09/2017] [Revised: 01/18/2018] [Accepted: 01/21/2018] [Indexed: 12/18/2022]
|
25
|
Nguyen PQ, Courchesne NMD, Duraj-Thatte A, Praveschotinunt P, Joshi NS. Engineered Living Materials: Prospects and Challenges for Using Biological Systems to Direct the Assembly of Smart Materials. ADVANCED MATERIALS (DEERFIELD BEACH, FLA.) 2018; 30:e1704847. [PMID: 29430725 PMCID: PMC6309613 DOI: 10.1002/adma.201704847] [Citation(s) in RCA: 201] [Impact Index Per Article: 33.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/24/2017] [Revised: 10/25/2017] [Indexed: 05/20/2023]
Abstract
Vast potential exists for the development of novel, engineered platforms that manipulate biology for the production of programmed advanced materials. Such systems would possess the autonomous, adaptive, and self-healing characteristics of living organisms, but would be engineered with the goal of assembling bulk materials with designer physicochemical or mechanical properties, across multiple length scales. Early efforts toward such engineered living materials (ELMs) are reviewed here, with an emphasis on engineered bacterial systems, living composite materials which integrate inorganic components, successful examples of large-scale implementation, and production methods. In addition, a conceptual exploration of the fundamental criteria of ELM technology and its future challenges is presented. Cradled within the rich intersection of synthetic biology and self-assembling materials, the development of ELM technologies allows the power of biology to be leveraged to grow complex structures and objects using a palette of bio-nanomaterials.
Collapse
Affiliation(s)
- Peter Q. Nguyen
- School of Engineering and Applied Sciences, Wyss Institute for Biologically Inspired Engineering, Harvard University, Cambridge, MA 02138, USA
| | - Noémie-Manuelle Dorval Courchesne
- School of Engineering and Applied Sciences, Wyss Institute for Biologically Inspired Engineering, Harvard University, Cambridge, MA 02138, USA
| | - Anna Duraj-Thatte
- School of Engineering and Applied Sciences, Wyss Institute for Biologically Inspired Engineering, Harvard University, Cambridge, MA 02138, USA
| | - Pichet Praveschotinunt
- School of Engineering and Applied Sciences, Wyss Institute for Biologically Inspired Engineering, Harvard University, Cambridge, MA 02138, USA
| | - Neel S. Joshi
- School of Engineering and Applied Sciences, Wyss Institute for Biologically Inspired Engineering, Harvard University, Cambridge, MA 02138, USA
| |
Collapse
|
26
|
Biofilm Lithography enables high-resolution cell patterning via optogenetic adhesin expression. Proc Natl Acad Sci U S A 2018; 115:3698-3703. [PMID: 29555779 PMCID: PMC5889658 DOI: 10.1073/pnas.1720676115] [Citation(s) in RCA: 57] [Impact Index Per Article: 9.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022] Open
Abstract
Bacteria live in surface-attached communities known as biofilms, where spatial structure is tightly linked to community function. We have developed a genetically encoded biofilm patterning tool (“Biofilm Lithography”) by engineering bacteria such that the expression of membrane adhesion proteins responsible for surface attachment is optically regulated. Accordingly, these bacteria only form biofilm on illuminated surface regions. With this tool, we are able to use blue light to pattern Escherichia coli biofilms with 25 μm spatial resolution. We present an accompanying biophysical model to understand the mechanism behind light-regulated biofilm formation and to provide insight on related natural biofilm processes. Overall, this biofilm patterning tool can be applied to study natural microbial communities as well as to engineer living biomaterials. Bacterial biofilms represent a promising opportunity for engineering of microbial communities. However, our ability to control spatial structure in biofilms remains limited. Here we engineer Escherichia coli with a light-activated transcriptional promoter (pDawn) to optically regulate expression of an adhesin gene (Ag43). When illuminated with patterned blue light, long-term viable biofilms with spatial resolution down to 25 μm can be formed on a variety of substrates and inside enclosed culture chambers without the need for surface pretreatment. A biophysical model suggests that the patterning mechanism involves stimulation of transiently surface-adsorbed cells, lending evidence to a previously proposed role of adhesin expression during natural biofilm maturation. Overall, this tool—termed “Biofilm Lithography”—has distinct advantages over existing cell-depositing/patterning methods and provides the ability to grow structured biofilms, with applications toward an improved understanding of natural biofilm communities, as well as the engineering of living biomaterials and bottom–up approaches to microbial consortia design.
Collapse
|
27
|
Yang WS, Hong Y, Zhang Y, Wang DC, Li DF, Hou YJ. A potential substrate binding pocket of BdcA plays a critical role in NADPH recognition and biofilm dispersal. Biochem Biophys Res Commun 2018; 497:863-868. [PMID: 29462616 DOI: 10.1016/j.bbrc.2018.02.143] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.2] [Reference Citation Analysis] [Abstract] [Key Words] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/14/2018] [Accepted: 02/16/2018] [Indexed: 11/29/2022]
Abstract
Biofilm dispersal is characterized by the cell detachment from biofilms and expected to provide novel "anti-biofilm" approaches of prevention and treatment of biofilms in clinical and industrial settings. The E.coli protein BdcA has been identified as a biofilm dispersal factor and designed to be an important component in engineered applications to control biofilm formation. It belongs to short-chain dehydrogenase/reductase (SDR) family with the specific affinity to NADPH. Here, we show the structure of BdcA in complex with NADPH and confirm that NADPH binding is requisite for BdcA facilitating cell motility and increasing biofilm dispersal. Especially, we observe a potential substrate binding pocket surrounded by hydrophobic residues upon NADPH binding and present evidences that this pocket is essential for BdcA binding NADPH and exerting its biological functions. Our study provides the clues for illuminating the molecular mechanism of BdcA regulating biofilm dispersal and better utilizing BdcA to eliminate the biofilms.
Collapse
Affiliation(s)
- Wen-Si Yang
- National Laboratory of Biomacromolecules, CAS Center for Excellence in Biomacromolecules, Institute of Biophysics, Chinese Academy of Sciences, Beijing 100101, China; University of Chinese Academy of Sciences, Beijing 100049, China
| | - Yuan Hong
- National Laboratory of Biomacromolecules, CAS Center for Excellence in Biomacromolecules, Institute of Biophysics, Chinese Academy of Sciences, Beijing 100101, China
| | - Ying Zhang
- National Laboratory of Biomacromolecules, CAS Center for Excellence in Biomacromolecules, Institute of Biophysics, Chinese Academy of Sciences, Beijing 100101, China
| | - Da-Cheng Wang
- National Laboratory of Biomacromolecules, CAS Center for Excellence in Biomacromolecules, Institute of Biophysics, Chinese Academy of Sciences, Beijing 100101, China.
| | - De-Feng Li
- National Laboratory of Biomacromolecules, CAS Center for Excellence in Biomacromolecules, Institute of Biophysics, Chinese Academy of Sciences, Beijing 100101, China; State Key Laboratory of Microbial Resources, Institute of Microbiology, Chinese Academy of Sciences, Beijing 100101, China.
| | - Yan-Jie Hou
- National Laboratory of Biomacromolecules, CAS Center for Excellence in Biomacromolecules, Institute of Biophysics, Chinese Academy of Sciences, Beijing 100101, China.
| |
Collapse
|
28
|
Mao B, Cheng L, Wang S, Zhou J, Deng L. Combat biofilm by bacteriostatic aptamer-functionalized graphene oxide. Biotechnol Appl Biochem 2018; 65:355-361. [PMID: 29357405 DOI: 10.1002/bab.1631] [Citation(s) in RCA: 16] [Impact Index Per Article: 2.7] [Reference Citation Analysis] [Abstract] [Key Words] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/20/2017] [Accepted: 12/06/2017] [Indexed: 11/07/2022]
Abstract
Biofilms are the main reason for a large number deaths and high health costs. Their better protection compared to planktonic form against conventional antibiotics leads to poor treatment efficiency. Nanoagent-targeted delivery is a promising avenue for disease therapeutic, but its application targeting biofilms has not been reported currently. The roles, if any, of aptamers acting as delivery carrier and targeting factor, the graphene oxide (GO), and GO modified with aptamers against biofilms were then systematically evaluated. Here, we successfully developed an aptamer-targeted GO strategy against biofilms. We investigated the efficacy of aptamer-GO conjugates by UV spectrophotometer, inverted microscopy, and atomic force microscopy; 93.5 ± 3.4% Salmonella typhimurium biofilms were inhibited and 84.6 ± 5.1% of biofilms were dispersed by a ST-3-GO conjugate. More importantly, this conjugate represented distinctively toxicity to S. typhimurium. Thus, this strategy significantly displays excellent antibiofilm properties and may serve as a long-term solution for biofilm control.
Collapse
Affiliation(s)
- Biyao Mao
- State Key Laboratory of Developmental Biology of Freshwater Fish, College of Life Sciences, Hunan Normal University, Changsha, Hunan, People's Republic of China
| | - Lijuan Cheng
- State Key Laboratory of Developmental Biology of Freshwater Fish, College of Life Sciences, Hunan Normal University, Changsha, Hunan, People's Republic of China.,Department of Biochemistry and Molecular Biology, Hunan University of Chinese Medicine, Changsha, Hunan, People's Republic of China
| | - Sheng Wang
- State Key Laboratory of Developmental Biology of Freshwater Fish, College of Life Sciences, Hunan Normal University, Changsha, Hunan, People's Republic of China
| | - Jiaqi Zhou
- State Key Laboratory of Developmental Biology of Freshwater Fish, College of Life Sciences, Hunan Normal University, Changsha, Hunan, People's Republic of China
| | - Le Deng
- State Key Laboratory of Developmental Biology of Freshwater Fish, College of Life Sciences, Hunan Normal University, Changsha, Hunan, People's Republic of China
| |
Collapse
|
29
|
Silveira CB, Cavalcanti GS, Walter JM, Silva-Lima AW, Dinsdale EA, Bourne DG, Thompson CC, Thompson FL. Microbial processes driving coral reef organic carbon flow. FEMS Microbiol Rev 2017; 41:575-595. [PMID: 28486655 DOI: 10.1093/femsre/fux018] [Citation(s) in RCA: 36] [Impact Index Per Article: 5.1] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/30/2016] [Accepted: 04/10/2017] [Indexed: 01/13/2023] Open
Abstract
Coral reefs are one of the most productive ecosystems on the planet, with primary production rates compared to that of rain forests. Benthic organisms release 10-50% of their gross organic production as mucus that stimulates heterotrophic microbial metabolism in the water column. As a result, coral reef microbes grow up to 50 times faster than open ocean communities. Anthropogenic disturbances cause once coral-dominated reefs to become dominated by fleshy organisms, with several outcomes for trophic relationships. Here we review microbial processes implicated in organic carbon flux in coral reefs displaying species phase shifts. The first section presents microbial players and interactions within the coral holobiont that contribute to reef carbon flow. In the second section, we identify four ecosystem-level microbial features that directly respond to benthic species phase shifts: community composition, biomass, metabolism and viral predation. The third section discusses the significance of microbial consumption of benthic organic matter to reef trophic relationships. In the fourth section, we propose that the 'microbial phase shifts' discussed here are conducive to lower resilience, facilitating the transition to new degradation states in coral reefs.
Collapse
Affiliation(s)
- Cynthia B Silveira
- Institute of Biology and COPPE/SAGE, Federal University of Rio de Janeiro. Av. Carlos Chagas Filho, 373, Cidade Universitária, RJ 21941-599, Brazil.,Biology Department, San Diego State University, 5500 Campanille Dr, San Diego, CA 92182, USA
| | - Giselle S Cavalcanti
- Institute of Biology and COPPE/SAGE, Federal University of Rio de Janeiro. Av. Carlos Chagas Filho, 373, Cidade Universitária, RJ 21941-599, Brazil.,Biology Department, San Diego State University, 5500 Campanille Dr, San Diego, CA 92182, USA
| | - Juline M Walter
- Institute of Biology and COPPE/SAGE, Federal University of Rio de Janeiro. Av. Carlos Chagas Filho, 373, Cidade Universitária, RJ 21941-599, Brazil
| | - Arthur W Silva-Lima
- Institute of Biology and COPPE/SAGE, Federal University of Rio de Janeiro. Av. Carlos Chagas Filho, 373, Cidade Universitária, RJ 21941-599, Brazil
| | - Elizabeth A Dinsdale
- Biology Department, San Diego State University, 5500 Campanille Dr, San Diego, CA 92182, USA
| | - David G Bourne
- College of Science and Engineering, James Cook University and Australian Institute of Marine Science, Townsville, Queensland 4810, Australia
| | - Cristiane C Thompson
- Institute of Biology and COPPE/SAGE, Federal University of Rio de Janeiro. Av. Carlos Chagas Filho, 373, Cidade Universitária, RJ 21941-599, Brazil
| | - Fabiano L Thompson
- Institute of Biology and COPPE/SAGE, Federal University of Rio de Janeiro. Av. Carlos Chagas Filho, 373, Cidade Universitária, RJ 21941-599, Brazil
| |
Collapse
|
30
|
Guha R, Xiong B, Geitner M, Moore T, Wood TK, Velegol D, Kumar M. Reactive micromixing eliminates fouling and concentration polarization in reverse osmosis membranes. J Memb Sci 2017. [DOI: 10.1016/j.memsci.2017.07.044] [Citation(s) in RCA: 28] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/17/2022]
|
31
|
Oh HS, Tan CH, Low JH, Rzechowicz M, Siddiqui MF, Winters H, Kjelleberg S, Fane AG, Rice SA. Quorum quenching bacteria can be used to inhibit the biofouling of reverse osmosis membranes. WATER RESEARCH 2017; 112:29-37. [PMID: 28129553 DOI: 10.1016/j.watres.2017.01.028] [Citation(s) in RCA: 44] [Impact Index Per Article: 6.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/21/2016] [Revised: 01/16/2017] [Accepted: 01/17/2017] [Indexed: 06/06/2023]
Abstract
Over the last few decades, significant efforts have concentrated on mitigating biofouling in reverse osmosis (RO) systems, with a focus on non-toxic and sustainable strategies. Here, we explored the potential of applying quorum quenching (QQ) bacteria to control biofouling in a laboratory-scale RO system. For these experiments, Pantoea stewartii was used as a model biofilm forming organism because it was previously shown to be a relevant wastewater isolate that also forms biofilms in a quorum sensing (QS) dependent fashion. A recombinant Escherichia coli strain, which can produce a QQ enzyme, was first tested in batch biofilm assays and significantly reduced biofilm formation by P. stewartii. Subsequently, RO membranes were fouled with P. stewartii and the QQ bacterium was introduced into the RO system using two different strategies, direct injection and immobilization within a cartridge microfilter. When the QQ bacterial cells were directly injected into the system, N-acylhomoserine lactone signals were degraded, resulting in the reduction of biofouling. Similarly, the QQ bacteria controlled biofouling when immobilized within a microfilter placed downstream of the RO module to remove QS signals circulating in the system. These results demonstrate the proof-of-principle that QQ can be applied to control biofouling of RO membranes and may be applicable for use in full-scale plants.
Collapse
Affiliation(s)
- Hyun-Suk Oh
- Singapore Membrane Technology Centre, Nanyang Environment and Water Research Institute, Nanyang Technological University, Singapore; Singapore Centre for Environmental Life Sciences Engineering, Nanyang Technological University, Singapore
| | - Chuan Hao Tan
- Singapore Centre for Environmental Life Sciences Engineering, Nanyang Technological University, Singapore; School of Materials Science & Engineering, Nanyang Technological University, Singapore
| | - Jiun Hui Low
- Singapore Membrane Technology Centre, Nanyang Environment and Water Research Institute, Nanyang Technological University, Singapore; Interdisciplinary Graduate School, Nanyang Technological University, Singapore
| | - Miles Rzechowicz
- Singapore Membrane Technology Centre, Nanyang Environment and Water Research Institute, Nanyang Technological University, Singapore
| | - Muhammad Faisal Siddiqui
- Singapore Membrane Technology Centre, Nanyang Environment and Water Research Institute, Nanyang Technological University, Singapore
| | - Harvey Winters
- Singapore Membrane Technology Centre, Nanyang Environment and Water Research Institute, Nanyang Technological University, Singapore; Fairleigh Dickinson University, 1000 River Road, Teaneck, NJ, USA
| | - Staffan Kjelleberg
- Singapore Centre for Environmental Life Sciences Engineering, Nanyang Technological University, Singapore; The School of Biological Sciences, Nanyang Technological University, Singapore; Centre for Marine Bio-Innovation, University of New South Wales, Sydney, Australia
| | - Anthony G Fane
- Singapore Membrane Technology Centre, Nanyang Environment and Water Research Institute, Nanyang Technological University, Singapore; School of Civil and Environmental Engineering, Nanyang Technological University, Singapore.
| | - Scott A Rice
- Singapore Centre for Environmental Life Sciences Engineering, Nanyang Technological University, Singapore; The School of Biological Sciences, Nanyang Technological University, Singapore; Centre for Marine Bio-Innovation, University of New South Wales, Sydney, Australia.
| |
Collapse
|
32
|
Kesel S, von Bronk B, Falcón García C, Götz A, Lieleg O, Opitz M. Matrix composition determines the dimensions of Bacillus subtilis NCIB 3610 biofilm colonies grown on LB agar. RSC Adv 2017. [DOI: 10.1039/c7ra05559e] [Citation(s) in RCA: 15] [Impact Index Per Article: 2.1] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/21/2022] Open
Abstract
Exopolymeric substances secreted by biofilm formingBacillus subtilisNCIB 3610 bacteria influence the growth and final dimensions of these biofilms.
Collapse
Affiliation(s)
- Sara Kesel
- Center for NanoScience
- Faculty of Physics
- Ludwig-Maximilians-Universität München
- Munich
- Germany
| | - Benedikt von Bronk
- Center for NanoScience
- Faculty of Physics
- Ludwig-Maximilians-Universität München
- Munich
- Germany
| | - Carolina Falcón García
- Institute of Medical Engineering IMETUM
- Department of Mechanical Engineering
- Technische Universität München
- Garching
- Germany
| | - Alexandra Götz
- Center for NanoScience
- Faculty of Physics
- Ludwig-Maximilians-Universität München
- Munich
- Germany
| | - Oliver Lieleg
- Institute of Medical Engineering IMETUM
- Department of Mechanical Engineering
- Technische Universität München
- Garching
- Germany
| | - Madeleine Opitz
- Center for NanoScience
- Faculty of Physics
- Ludwig-Maximilians-Universität München
- Munich
- Germany
| |
Collapse
|
33
|
Iorhemen OT, Hamza RA, Tay JH. Membrane Bioreactor (MBR) Technology for Wastewater Treatment and Reclamation: Membrane Fouling. MEMBRANES 2016; 6:E33. [PMID: 27314394 PMCID: PMC4931528 DOI: 10.3390/membranes6020033] [Citation(s) in RCA: 128] [Impact Index Per Article: 16.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 04/14/2016] [Revised: 06/08/2016] [Accepted: 06/12/2016] [Indexed: 11/16/2022]
Abstract
The membrane bioreactor (MBR) has emerged as an efficient compact technology for municipal and industrial wastewater treatment. The major drawback impeding wider application of MBRs is membrane fouling, which significantly reduces membrane performance and lifespan, resulting in a significant increase in maintenance and operating costs. Finding sustainable membrane fouling mitigation strategies in MBRs has been one of the main concerns over the last two decades. This paper provides an overview of membrane fouling and studies conducted to identify mitigating strategies for fouling in MBRs. Classes of foulants, including biofoulants, organic foulants and inorganic foulants, as well as factors influencing membrane fouling are outlined. Recent research attempts on fouling control, including addition of coagulants and adsorbents, combination of aerobic granulation with MBRs, introduction of granular materials with air scouring in the MBR tank, and quorum quenching are presented. The addition of coagulants and adsorbents shows a significant membrane fouling reduction, but further research is needed to establish optimum dosages of the various coagulants/adsorbents. Similarly, the integration of aerobic granulation with MBRs, which targets biofoulants and organic foulants, shows outstanding filtration performance and a significant reduction in fouling rate, as well as excellent nutrients removal. However, further research is needed on the enhancement of long-term granule integrity. Quorum quenching also offers a strong potential for fouling control, but pilot-scale testing is required to explore the feasibility of full-scale application.
Collapse
Affiliation(s)
- Oliver Terna Iorhemen
- Department of Civil Engineering, University of Calgary, Calgary, AB T2N 1N4, Canada.
| | - Rania Ahmed Hamza
- Department of Civil Engineering, University of Calgary, Calgary, AB T2N 1N4, Canada.
| | - Joo Hwa Tay
- Department of Civil Engineering, University of Calgary, Calgary, AB T2N 1N4, Canada.
| |
Collapse
|