1
|
Shah MAR, Zhang Y, Cui Y, Hu X, Zhu F, Kumar S, Li G, Kubar AA, Mehmood S, Huo S. Ultrasonic-assisted green extraction and incorporation of Spirulina platensis bioactive components into turmeric essential oil-in-water nanoemulsion for enhanced antioxidant and antimicrobial activities. Food Chem 2024; 452:139561. [PMID: 38728897 DOI: 10.1016/j.foodchem.2024.139561] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/13/2023] [Revised: 03/30/2024] [Accepted: 05/02/2024] [Indexed: 05/12/2024]
Abstract
The utilization of essential oils as natural antioxidants and preservatives is limited by high volatility, poor water solubility, and long-term instability. To address this, a novel ultrasonic-assisted method was used to prepare and stabilize a nanoemulsion of turmeric essential oil-in-water, incorporating bioactive components extracted from Spirulina platensis. Ultrasonic treatment enhanced the extraction efficacy and nanoemulsion stability. Algal biomass subjected to ultrasonic treatment (30 min at 80% amplitude) yielded a dry extract of 73.66 ± 3.05%, with the highest protein, phenolic, phycocyanin, and allophycocyanin content, as well as maximum emulsifying activity. The resulting nanoemulsion (5% oil, 0.3% extract, 10 min ultrasonic treatment) showed reduced particle size (173.31 ± 2.24 nm), zeta potential (-36.33 ± 1.10 mV), low polydispersity index, and enhanced antioxidant and antibacterial properties. Rheology analysis indicated shear-thinning behavior, while microscopy and spectroscopy confirmed structural changes induced by ultrasonic treatment and extract concentration. This initiative developed a novel ultrasonic-assisted algal-based nanoemulsion with antioxidant and antibacterial properties.
Collapse
Affiliation(s)
| | - Yajie Zhang
- School of Food and Biological Engineering, Jiangsu University, Zhenjiang 212013, China
| | - Yi Cui
- School of Food and Biological Engineering, Jiangsu University, Zhenjiang 212013, China
| | - Xinjuan Hu
- School of Food and Biological Engineering, Jiangsu University, Zhenjiang 212013, China
| | - Feifei Zhu
- School of Life Sciences, Jiangsu University, Zhenjiang 212013, China
| | - Santosh Kumar
- School of Food and Biological Engineering, Jiangsu University, Zhenjiang 212013, China
| | - Gang Li
- School of Artificial Intelligence, Beijing Technology and Business University, Beijing 100048, China.
| | - Ameer Ali Kubar
- School of Food and Biological Engineering, Jiangsu University, Zhenjiang 212013, China
| | - Shahid Mehmood
- School of Life Sciences, Jiangsu University, Zhenjiang 212013, China
| | - Shuhao Huo
- School of Food and Biological Engineering, Jiangsu University, Zhenjiang 212013, China.
| |
Collapse
|
2
|
Jui TJ, Tasnim A, Islam SR, Manjur OHB, Hossain MS, Tasnim N, Karmakar D, Hasan MR, Karim MR. Optimal growth conditions to enhance Chlorella vulgaris biomass production in indoor phyto tank and quality assessment of feed and culture stock. Heliyon 2024; 10:e31900. [PMID: 38841447 PMCID: PMC11152938 DOI: 10.1016/j.heliyon.2024.e31900] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/30/2023] [Revised: 05/19/2024] [Accepted: 05/23/2024] [Indexed: 06/07/2024] Open
Abstract
Commercial microalgae cultivation is a dynamic field with ongoing efforts to improve efficiency, reduce costs, and explore new applications. We conducted a study to examine how different light exposure periods affect Chlorella vulgaris's growth. We employed a Phyto tank batch system of approximately 3.5 L with LED light control, controlled airflow, and sterilized bags, maintained at 22.0 ± 2.0 °C indoors. Various methods, including spectrophotometry, and cell counter were employed to monitor Chlorella vulgaris growth under different light exposure cycles. Additionally, quality analysis as feed source was employed by proximate, amino acid, beta-glucan, and microbial content analysis. The results revealed significant variations in C. vulgaris biomass production based on light exposure duration. Notably, the 16:8-h light-dark photoperiod exhibited the highest biomass concentration, reaching 6.48 × 107 ± 0.50 cells/mL with an optical density (OD) of 1.165 absorbance at 682 nm. The 12:12-h light-dark photoperiod produced the second-highest biomass concentration, with 2.305 × 106 ± 0.60 cells/mL at an OD of 0.489. Proximate analysis of dry algae powder revealed low lipid content (0.48 %), high protein content (37.61 %), variable ash concentration (average 10.75 %), and a significant carbohydrate fraction (51.16 %) during extended daylight and shorter dark periods. Amino acid analysis identified nine essential amino acids, with glutamic acid being the most abundant (17.7 %) and methionine the least (0.4 %). Furthermore, quality analysis and microbiological assays demonstrated that the C. vulgaris biomass is well-suited for fish and livestock use as a feed source and possibility as human nutraceuticals. These findings can be considered more environmentally friendly and ethically sound due to the absence of genetic modification.
Collapse
Affiliation(s)
- Turfatul Jannat Jui
- Institute of Technology Transfer and Innovation, Bangladesh Council of Scientific and Industrial Research, Dhaka, 1205, Bangladesh
| | - Anika Tasnim
- Institute of Technology Transfer and Innovation, Bangladesh Council of Scientific and Industrial Research, Dhaka, 1205, Bangladesh
| | - S.M. Rashadul Islam
- Institute of Technology Transfer and Innovation, Bangladesh Council of Scientific and Industrial Research, Dhaka, 1205, Bangladesh
| | - Omar Hamza Bin Manjur
- Institute of Technology Transfer and Innovation, Bangladesh Council of Scientific and Industrial Research, Dhaka, 1205, Bangladesh
| | - Md. Saddam Hossain
- Institute of Technology Transfer and Innovation, Bangladesh Council of Scientific and Industrial Research, Dhaka, 1205, Bangladesh
| | - Nishat Tasnim
- Institute of Technology Transfer and Innovation, Bangladesh Council of Scientific and Industrial Research, Dhaka, 1205, Bangladesh
| | - Debabrata Karmakar
- Institute of Technology Transfer and Innovation, Bangladesh Council of Scientific and Industrial Research, Dhaka, 1205, Bangladesh
| | - Md. Rakibul Hasan
- Institute of Technology Transfer and Innovation, Bangladesh Council of Scientific and Industrial Research, Dhaka, 1205, Bangladesh
| | - Md. Rezaul Karim
- Institute of Technology Transfer and Innovation, Bangladesh Council of Scientific and Industrial Research, Dhaka, 1205, Bangladesh
| |
Collapse
|
3
|
Liu Y, Aimutis WR, Drake M. Dairy, Plant, and Novel Proteins: Scientific and Technological Aspects. Foods 2024; 13:1010. [PMID: 38611316 PMCID: PMC11011482 DOI: 10.3390/foods13071010] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/27/2024] [Revised: 03/19/2024] [Accepted: 03/20/2024] [Indexed: 04/14/2024] Open
Abstract
Alternative proteins have gained popularity as consumers look for foods that are healthy, nutritious, and sustainable. Plant proteins, precision fermentation-derived proteins, cell-cultured proteins, algal proteins, and mycoproteins are the major types of alternative proteins that have emerged in recent years. This review addresses the major alternative-protein categories and reviews their definitions, current market statuses, production methods, and regulations in different countries, safety assessments, nutrition statuses, functionalities and applications, and, finally, sensory properties and consumer perception. Knowledge relative to traditional dairy proteins is also addressed. Opportunities and challenges associated with these proteins are also discussed. Future research directions are proposed to better understand these technologies and to develop consumer-acceptable final products.
Collapse
Affiliation(s)
- Yaozheng Liu
- Department of Food, Bioprocessing, and Nutrition Sciences, North Carolina State University, Raleigh, NC 27695, USA; (Y.L.); (W.R.A.)
| | - William R. Aimutis
- Department of Food, Bioprocessing, and Nutrition Sciences, North Carolina State University, Raleigh, NC 27695, USA; (Y.L.); (W.R.A.)
- North Carolina Food Innovation Lab, North Carolina State University, Kannapolis, NC 28081, USA
| | - MaryAnne Drake
- Department of Food, Bioprocessing, and Nutrition Sciences, North Carolina State University, Raleigh, NC 27695, USA; (Y.L.); (W.R.A.)
| |
Collapse
|
4
|
Çelekli A, Özbal B, Bozkurt H. Challenges in Functional Food Products with the Incorporation of Some Microalgae. Foods 2024; 13:725. [PMID: 38472838 DOI: 10.3390/foods13050725] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/15/2023] [Revised: 12/07/2023] [Accepted: 02/23/2024] [Indexed: 03/14/2024] Open
Abstract
Much attention has been given to the use of microalgae to produce functional foods that have valuable bioactive chemicals, including essential amino acids, polyunsaturated fatty acids, vitamins, carotenoids, fiber, and minerals. Microalgal biomasses are increasingly being used to improve the nutritional values of foods because of their unique nutrient compositions that are beneficial to human health. Their protein content and amino acid composition are the most important components. The microalgal biomass used in the therapeutic supplement industry is dominated by bio-compounds like astaxanthin, β-carotene, polyunsaturated fatty acids like eicosapentaenoic acid and docosahexaenoic acid, and polysaccharides such as β-glucan. The popularity of microalgal supplements is growing because of the health benefits of their bioactive substances. Moreover, some microalgae, such as Dunaliella, Arthrospira (Spirulina), Chlorella, and Haematococcus, are commonly used microalgal species in functional food production. The incorporation of microalgal biomass leads not only to enhanced nutritional value but also to improved sensory quality of food products without altering their cooking or textural characteristics. Microalgae, because of their eco-friendly potential, have emerged as one of the most promising and novel sources of new functional foods. This study reviews some recent and relevant works, as well as the current challenges for future research, using different methods of chemical modification in foods with the addition of a few commercial algae to allow their use in nutritional and sensory areas. It can be concluded that the production of functional foods through the use of microalgae in foods has become an important issue.
Collapse
Affiliation(s)
- Abuzer Çelekli
- Department of Biology, Faculty of Art and Science, Gaziantep University, 27310 Gaziantep, Turkey
| | - Buket Özbal
- Department of Biology, Faculty of Art and Science, Gaziantep University, 27310 Gaziantep, Turkey
| | - Hüseyin Bozkurt
- Department of Food Engineering, Faculty of Engineering, University of Gaziantep, 27310 Gaziantep, Turkey
| |
Collapse
|
5
|
Ou Z, Chen X, Wu X, Zhou C, Zhang K, Luo J, Fang F, Sun Y, Li M, Feng Q. N-acyl homoserine lactone mediating initial adhesion of microalgal biofilm formation. ENVIRONMENTAL RESEARCH 2023; 233:116446. [PMID: 37331555 DOI: 10.1016/j.envres.2023.116446] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/30/2023] [Revised: 06/07/2023] [Accepted: 06/16/2023] [Indexed: 06/20/2023]
Abstract
While pioneering methods have demonstrated that bacterial N-acyl homoserine lactone (AHL) signaling molecules can influence the growth and self-aggregation of suspended microalgae, whether AHLs can affect the initial adhesion to a carrier has remained an open question. Here we revealed that the microalgae exhibited different adhesion potential under AHL mediation, where the performance was affiliated to both AHL types and concentrations. The result can be well explained by the interaction energy theory, where the energy barrier between the carriers and the cells varied due to AHL mediation. Depth analyses revealed that AHL acted through modifying the properties of the surface electron donor of the cells, which were dependent upon three major components, i.e., extracellular protein (PN) secretion, the PN secondary structure, and the PN amino acid composition. These findings expand the known diversity of AHLs mediation on microalgal initial adhesion and metabolisms, which may interface with other major cycles and become helpful to theoretically guide the application of AHLs in microalgal culture and harvesting.
Collapse
Affiliation(s)
- Zixuan Ou
- Key Laboratory of Integrated Regulation and Resource Development on Shallow Lakes, Ministry of Education, Hohai University, 1 Xikang Road, Nanjing, 210098, PR China; College of Environment, Hohai University, 1 Xikang Road, Nanjing, 210098, PR China
| | - Xindi Chen
- State Key Laboratory of Hydrology-Water Resources and Hydraulic Engineering, College of Harbor, Coastal and Offshore Engineering, Hohai University, Nanjing, PR China
| | - Xinming Wu
- Key Laboratory of Integrated Regulation and Resource Development on Shallow Lakes, Ministry of Education, Hohai University, 1 Xikang Road, Nanjing, 210098, PR China; College of Environment, Hohai University, 1 Xikang Road, Nanjing, 210098, PR China
| | - Changren Zhou
- Key Laboratory of Integrated Regulation and Resource Development on Shallow Lakes, Ministry of Education, Hohai University, 1 Xikang Road, Nanjing, 210098, PR China; College of Environment, Hohai University, 1 Xikang Road, Nanjing, 210098, PR China
| | - Kaijie Zhang
- Key Laboratory of Integrated Regulation and Resource Development on Shallow Lakes, Ministry of Education, Hohai University, 1 Xikang Road, Nanjing, 210098, PR China; College of Environment, Hohai University, 1 Xikang Road, Nanjing, 210098, PR China
| | - Jingyang Luo
- Key Laboratory of Integrated Regulation and Resource Development on Shallow Lakes, Ministry of Education, Hohai University, 1 Xikang Road, Nanjing, 210098, PR China; College of Environment, Hohai University, 1 Xikang Road, Nanjing, 210098, PR China
| | - Fang Fang
- Key Laboratory of Integrated Regulation and Resource Development on Shallow Lakes, Ministry of Education, Hohai University, 1 Xikang Road, Nanjing, 210098, PR China; College of Environment, Hohai University, 1 Xikang Road, Nanjing, 210098, PR China
| | - Yinqiang Sun
- School of Chemistry & Chemical Engineering, Anhui University, Anhui, 230039, PR China
| | - Ming Li
- College of Resources and Environment, Northwest A&F University, Yangling, Shanxi, 712100, PR China
| | - Qian Feng
- Key Laboratory of Integrated Regulation and Resource Development on Shallow Lakes, Ministry of Education, Hohai University, 1 Xikang Road, Nanjing, 210098, PR China; College of Environment, Hohai University, 1 Xikang Road, Nanjing, 210098, PR China.
| |
Collapse
|
6
|
Cheng P, Shan S, Zhu Z, Liu K, Namsaraev Z, Dubovskiy I, Xu Q. The role of microalgae culture modes in aquaculture: a brief opinion. Front Bioeng Biotechnol 2023; 11:1196948. [PMID: 37288356 PMCID: PMC10242044 DOI: 10.3389/fbioe.2023.1196948] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Key Words] [Grants] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/30/2023] [Accepted: 05/02/2023] [Indexed: 06/09/2023] Open
Affiliation(s)
- Pengfei Cheng
- Marine Drugs and Biological Products Department, Ningbo Institute of Oceanography, Ningbo, Zhejiang, China
- College of Food and Pharmaceutical Sciences, Ningbo University, Ningbo, China
| | - Shengzhou Shan
- College of Food and Pharmaceutical Sciences, Ningbo University, Ningbo, China
| | - Zhujun Zhu
- Marine Drugs and Biological Products Department, Ningbo Institute of Oceanography, Ningbo, Zhejiang, China
| | - Kui Liu
- Marine Drugs and Biological Products Department, Ningbo Institute of Oceanography, Ningbo, Zhejiang, China
| | - Zorigto Namsaraev
- Kurchatov Centre for Genome Research, NRC “Kurchatov Institute”, Moscow, Russia
| | - Ivan Dubovskiy
- Laboratory of Biological Plant Protection and Biotechnology, Novosibirsk State Agrarian University, Novosibirsk, Russia
| | - Qingshan Xu
- Lijiang Cheng Hai Bao Er Biological Development Co., Ltd., Lijiang, China
| |
Collapse
|
7
|
Chen Y, Liang H, Du H, Jesumani V, He W, Cheong KL, Li T, Hong T. Industry chain and challenges of microalgal food industry-a review. Crit Rev Food Sci Nutr 2022; 64:4789-4816. [PMID: 36377724 DOI: 10.1080/10408398.2022.2145455] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/16/2022]
Abstract
Currently, the whole world is facing hunger due to the increase in the global population and the rising level of food consumption. Unfortunately, the impact of environmental, climate, and political issues on agriculture has resulted in limited global food resources. Thus, it is important to develop new food sources that are environmentally friendly and not subject to climate or space limitations. Microalgae represent a potential source of nutrients and bioactive components for a wide range of high-value products. Advances in cultivation and genetic engineering techniques provide prospective approaches to widen their application for food. However, there are currently problems in the microalgae food industry in terms of assessing nutritional value, selecting processes for microalgae culture, obtaining suitable commercial strains of microalgae, etc. Additionally, the limitations of real data of market opportunities for microalgae make it difficult to assess their actual potential and to develop a better industrial chain. This review addresses the current status of the microalgae food industry, the process of commercializing microalgae food and breeding methods. Current research progress in addressing the limitations of microalgae industrialization and future prospects for developing microalgae food products are discussed.
Collapse
Affiliation(s)
- Yuanhao Chen
- Guangdong Provincial Key Laboratory of Marine Biotechnology, Department of Biology, College of Science, Shantou University, Shantou, Guangdong, China
- STU-UNIVPM Joint Algal Research Center, Institute of Marine Sciences, Shantou University, Shantou, Guangdong, China
- Guangdong Provincial Key Laboratory of Marine Disaster Prediction and Prevention, Shantou University, Shantou, Guangdong, China
| | - Honghao Liang
- Guangdong Provincial Key Laboratory of Marine Biotechnology, Department of Biology, College of Science, Shantou University, Shantou, Guangdong, China
- STU-UNIVPM Joint Algal Research Center, Institute of Marine Sciences, Shantou University, Shantou, Guangdong, China
- Guangdong Provincial Key Laboratory of Marine Disaster Prediction and Prevention, Shantou University, Shantou, Guangdong, China
| | - Hong Du
- Guangdong Provincial Key Laboratory of Marine Biotechnology, Department of Biology, College of Science, Shantou University, Shantou, Guangdong, China
- STU-UNIVPM Joint Algal Research Center, Institute of Marine Sciences, Shantou University, Shantou, Guangdong, China
- Guangdong Provincial Key Laboratory of Marine Disaster Prediction and Prevention, Shantou University, Shantou, Guangdong, China
| | - Valentina Jesumani
- Guangdong Provincial Key Laboratory of Marine Biotechnology, Department of Biology, College of Science, Shantou University, Shantou, Guangdong, China
| | - Weiling He
- Guangdong Provincial Key Laboratory of Marine Biotechnology, Department of Biology, College of Science, Shantou University, Shantou, Guangdong, China
- STU-UNIVPM Joint Algal Research Center, Institute of Marine Sciences, Shantou University, Shantou, Guangdong, China
- Guangdong Provincial Key Laboratory of Marine Disaster Prediction and Prevention, Shantou University, Shantou, Guangdong, China
| | - Kit-Leong Cheong
- Guangdong Provincial Key Laboratory of Marine Biotechnology, Department of Biology, College of Science, Shantou University, Shantou, Guangdong, China
| | - Tangcheng Li
- Guangdong Provincial Key Laboratory of Marine Biotechnology, Department of Biology, College of Science, Shantou University, Shantou, Guangdong, China
- STU-UNIVPM Joint Algal Research Center, Institute of Marine Sciences, Shantou University, Shantou, Guangdong, China
- Guangdong Provincial Key Laboratory of Marine Disaster Prediction and Prevention, Shantou University, Shantou, Guangdong, China
| | - Ting Hong
- Guangdong Provincial Key Laboratory of Marine Biotechnology, Department of Biology, College of Science, Shantou University, Shantou, Guangdong, China
- STU-UNIVPM Joint Algal Research Center, Institute of Marine Sciences, Shantou University, Shantou, Guangdong, China
- Guangdong Provincial Key Laboratory of Marine Disaster Prediction and Prevention, Shantou University, Shantou, Guangdong, China
| |
Collapse
|
8
|
Muñoz-Tebar N, Ong L, Gamlath CJ, Yatipanthalawa BS, Ashokkumar M, Gras SL, Berruga MI, Martin GJ. Nutrient enrichment of dairy curd by incorporation of whole and ruptured microalgal cells (Nannochloropsis salina). INNOV FOOD SCI EMERG 2022. [DOI: 10.1016/j.ifset.2022.103211] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/17/2022]
|
9
|
Zi Y, Xu J, Huang S, Zheng Y, Peng J, Yang M, Wang X, Zhong J. Effects of octenyl succinic anhydride chemical modification and surfactant physical modification of bovine bone gelatin on the stabilization of fish oil-loaded emulsions. Food Chem X 2022; 16:100517. [DOI: 10.1016/j.fochx.2022.100517] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/25/2022] [Revised: 08/30/2022] [Accepted: 11/16/2022] [Indexed: 11/18/2022] Open
|
10
|
Micro-Encapsulated Microalgae Oil Supplementation Has No Systematic Effect on the Odor of Vanilla Shake-Test of an Electronic Nose. Foods 2022; 11:foods11213452. [PMID: 36360065 PMCID: PMC9654470 DOI: 10.3390/foods11213452] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/26/2022] [Revised: 10/24/2022] [Accepted: 10/25/2022] [Indexed: 11/26/2022] Open
Abstract
In this study, we aimed to carry out the efficient fortification of vanilla milkshakes with micro-encapsulated microalgae oil (brand: S17-P100) without distorting the product’s odor. A 10-step oil-enrichment protocol was developed using an inclusion rate of 0.2 to 2 w/w%. Fatty acid (FA) profile analysis was performed using methyl esters with the GC-MS technique, and the recovery of docosahexaenoic acid (C22:6 n3, DHA) was robust (r = 0.97, p < 0.001). The enrichment process increased the DHA level to 412 mg/100 g. Based on this finding, a flash-GC-based electronic nose (e-nose) was used to describe the product’s odor. Applying principal component (PC) analysis to the acquired sensor data revealed that for the first four PCs, only PC3 (6.5%) showed a difference between the control and the supplemented products. However, no systematic pattern of odor profiles corresponding to the percentages of supplementation was observed within the PC planes. Similarly, when discriminant factor analysis (DFA) was applied, though a classification of the control and supplemented products, we obtained a validation score of 98%, and the classification pattern of the odor profiles did not follow a systematic format. Again, when a more targeted approach such as the partial least square regression (PLSR) was used on the most dominant sensors, a weak relationship (R2 = 0.50) was observed, indicating that there was no linear combination of the qualitative sensors’ signals that could accurately describe the supplemented concentration variation. It can therefore be inferred that no detectable off-odor was present as a side effect of the increase in the oil concentration. Some volatile compounds of importance in regard to the odor, such as ethylacetate, ethyl-isobutarate, pentanal and pentyl butanoate, were found in the supplemented product. Although the presence of yeasts and molds was excluded from the product, ethanol was detected in all samples, but with an intensity that was insufficient to cause an off-odor.
Collapse
|
11
|
Hassoun A, Cropotova J, Trif M, Rusu AV, Bobiş O, Nayik GA, Jagdale YD, Saeed F, Afzaal M, Mostashari P, Khaneghah AM, Regenstein JM. Consumer acceptance of new food trends resulting from the fourth industrial revolution technologies: A narrative review of literature and future perspectives. Front Nutr 2022; 9:972154. [PMID: 36034919 PMCID: PMC9399420 DOI: 10.3389/fnut.2022.972154] [Citation(s) in RCA: 15] [Impact Index Per Article: 7.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/17/2022] [Accepted: 07/15/2022] [Indexed: 12/11/2022] Open
Abstract
The growing consumer awareness of climate change and the resulting food sustainability issues have led to an increasing adoption of several emerging food trends. Some of these trends have been strengthened by the emergence of the fourth industrial revolution (or Industry 4.0), and its innovations and technologies that have fundamentally reshaped and transformed current strategies and prospects for food production and consumption patterns. In this review a general overview of the industrial revolutions through a food perspective will be provided. Then, the current knowledge base regarding consumer acceptance of eight traditional animal-proteins alternatives (e.g., plant-based foods and insects) and more recent trends (e.g., cell-cultured meat and 3D-printed foods) will be updated. A special focus will be given to the impact of digital technologies and other food Industry 4.0 innovations on the shift toward greener, healthier, and more sustainable diets. Emerging food trends have promising potential to promote nutritious and sustainable alternatives to animal-based products. This literature narrative review showed that plant-based foods are the largest portion of alternative proteins but intensive research is being done with other sources (notably the insects and cell-cultured animal products). Recent technological advances are likely to have significant roles in enhancing sensory and nutritional properties, improving consumer perception of these emerging foods. Thus, consumer acceptance and consumption of new foods are predicted to continue growing, although more effort should be made to make these food products more convenient, nutritious, and affordable, and to market them to consumers positively emphasizing their safety and benefits.
Collapse
Affiliation(s)
- Abdo Hassoun
- Sustainable AgriFoodtech Innovation and Research (SAFIR), Arras, France
- Syrian Academic Expertise (SAE), Gaziantep, Turkey
| | - Janna Cropotova
- Department of Biological Sciences Ålesund, Norwegian University of Science and Technology, Ålesund, Norway
| | - Monica Trif
- Department of Food Research, Centre for Innovative Process Engineering (CENTIV) GmbH, Syke, Germany
| | - Alexandru Vasile Rusu
- Life Science Institute, University of Agricultural Sciences and Veterinary Medicine Cluj-Napoca, Cluj-Napoca, Romania
- Genetics and Genetic Engineering, Faculty of Animal Science and Biotechnology, University of Animal Sciences and Veterinary Medicine Cluj-Napoca, Cluj-Napoca, Romania
| | - Otilia Bobiş
- Animal Science and Biotechnology Faculty, University of Agricultural Sciences and Veterinary Medicine Cluj-Napoca, Cluj-Napoca, Romania
| | - Gulzar Ahmad Nayik
- Department of Food Science and Technology, Government Degree College, Shopian, India
| | - Yash D. Jagdale
- MIT School of Food Technology, MIT ADT University, Pune, India
| | - Farhan Saeed
- Department of Food Sciences, Government College University Faisalabad, Faisalabad, Pakistan
| | - Muhammad Afzaal
- Department of Food Sciences, Government College University Faisalabad, Faisalabad, Pakistan
| | - Parisa Mostashari
- Department of Food Science and Technology, Faculty of Nutrition Sciences and Food Technology, National Nutrition and Food Technology Research Institute, Shahid Beheshti University of Medical Sciences, Tehran, Iran
| | - Amin Mousavi Khaneghah
- Department of Fruit and Vegetable Product Technology, Prof. Wacław Dabrowski Institute of Agricultural and Food Biotechnology – State Research Institute, Warsaw, Poland
| | - Joe M. Regenstein
- Department of Food Science, Cornell University, Ithaca, NY, United States
| |
Collapse
|
12
|
Microalgae: Bioactive Composition, Health Benefits, Safety and Prospects as Potential High-Value Ingredients for the Functional Food Industry. Foods 2022; 11:foods11121744. [PMID: 35741941 PMCID: PMC9222421 DOI: 10.3390/foods11121744] [Citation(s) in RCA: 13] [Impact Index Per Article: 6.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/28/2022] [Revised: 06/07/2022] [Accepted: 06/09/2022] [Indexed: 01/27/2023] Open
Abstract
Global population is estimated to reach about 9.22 billion by 2075. The increasing knowledge on the relationship between food biochemistry and positive health gives an indication of the urgency to exploit food resources that are not only sustainable but also impact human health beyond basic nutrition. A typical example of such novel food is microalgae, an aquatic microorganism with a plethora of diverse bioactive compounds including phenolics, carotenoids, vitamin B12 and peptides. Microalgal bioactive compounds have been shown to possess positive health effects such as antihypertensive, anti-obesity, antioxidative, anticancer and cardiovascular protection. Although, the utilization of microalgal biomass by the functional food industry has faced lots of challenges because of species diversity and variations in biomass and cultivation factors. Other documented challenges were ascribed to changes in functional structures during extraction and purification due to inefficient bio-processing techniques, inconclusive literature information on the bioavailability and safety of the microalgal bioactive compounds and the fishy odor and taste when applied in food formulations. In spite of these challenges, great opportunities exist to exploit their utilization for the development of functional foods. Microalgae are a renewable resource and have fast growth rate. Therefore, detailed research is needed to bridge these challenges to pave way for large-scale commercialization of microalgal-based healthy foods. The focus of this review is to discuss the potential of microalgae as natural ingredients for functional food development, factors limiting their acceptance and utilization in the food industry as well as their safety concerns with respect to human consumption.
Collapse
|
13
|
Kumar D, Lal MK, Dutt S, Raigond P, Changan SS, Tiwari RK, Chourasia KN, Mangal V, Singh B. Functional Fermented Probiotics, Prebiotics, and Synbiotics from Non-Dairy Products: A Perspective from Nutraceutical. Mol Nutr Food Res 2022; 66:e2101059. [PMID: 35616160 DOI: 10.1002/mnfr.202101059] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/18/2021] [Revised: 04/11/2022] [Indexed: 12/24/2022]
Abstract
The current trend of health-conscious consumers and healthy food habits prompts researchers to explore developing food products with synbiotic benefits. Synbiotic foods have gained popularity in recent years due to their functional, nutritional, physiological, and therapeutic characteristics. Lactose intolerance, dyslipidemia, and allergic milk proteins become the barriers in the development of dairy probiotics. The present scenario of an increase in the demand for vegetarian products leads to a rise in the consumption of non-dairy probiotics. Prebiotics like, resistant starch, inulin, and polyphenols are selectively used by gut microbiota to enhance the selection and colonization of probiotics bacteria. Probiotic's action mechanisms include the production of bacteriocins, peptides, short-chain fatty acids, amino acids, vitamins, and other metabolites. Therefore, this review article explores the alternative sources of probiotics so it will help to an understanding of non-dairy based functional fermented foods for both pro and prebiotics. Dietary fibers in vegetables, fruits, and cereals are one of prospective prebiotics and highlighted the various methods for making non-dairy synbiotics based on dietary fibers, such as microencapsulation, freeze-drying, and spray drying is also addressed.
Collapse
Affiliation(s)
- Dharmendra Kumar
- ICAR-Central Potato Research Institute, Shimla, Himachal Pradesh, 171001, India
| | - Milan Kumar Lal
- ICAR-Central Potato Research Institute, Shimla, Himachal Pradesh, 171001, India
| | - Som Dutt
- ICAR-Central Potato Research Institute, Shimla, Himachal Pradesh, 171001, India
| | - Pinky Raigond
- ICAR-Central Potato Research Institute, Shimla, Himachal Pradesh, 171001, India
| | | | - Rahul Kumar Tiwari
- ICAR-Central Potato Research Institute, Shimla, Himachal Pradesh, 171001, India
| | - Kumar Nishant Chourasia
- ICAR-Central Research Institute for Jute and Allied Fibres, Kolkata, West Bengal, 700120, India
| | - Vikas Mangal
- ICAR-Central Potato Research Institute, Shimla, Himachal Pradesh, 171001, India
| | - Brajesh Singh
- ICAR-Central Potato Research Institute, Shimla, Himachal Pradesh, 171001, India
| |
Collapse
|
14
|
Bioremediation of Textile Industrial Effluents Using Nutraceutical Industrial Spent: Laboratory-Scale Demonstration of Circular Economy. NANOMATERIALS 2022; 12:nano12101684. [PMID: 35630906 PMCID: PMC9147257 DOI: 10.3390/nano12101684] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 02/08/2022] [Revised: 04/27/2022] [Accepted: 04/28/2022] [Indexed: 11/17/2022]
Abstract
This research reports the first-ever study on abundantly available, environmentally friendly, low-cost and ready-for-use Nutraceutical Industrial Cumin Seed Spent (NICUS) as an innovative adsorbent for bioremediation of a bisazo Acid Red 119 (AR119) dye, a probable mutagen from textile industrial effluents (TIEs). The experiment at the laboratory scale is designed to suit the concepts of sustainability and valorisation under the domain of circular economy. The experimental qe value obtained was 96.00 mg g−1. The optimised conditions of parameters are as follows: pH of 2; adsorption time, 210 min; adsorbent dosage, 0.300 g L−1; particle size, 175 µM; initial dye concentration, 950 mg L−1; orbital shaking, 165 rpm and temperature, 50 °C, producing an impressive value of 748 mg of dye adsorbing on 1 g of dry NICUS. The adsorption capacity of NICUS obtained from the quadratic model developed for process optimisation gave values of 748 mg g−1. As a prelude to commercialisation, five variables that affect the adsorption process were experimentally studied. For the feasibility and efficiency of the process, a two-level fractional factorial experimental design (FFED) was applied to identify variables that influence the adsorption capacity of NICUS. The identified variables were applied to scale experiments by three orders. Nine isotherm models were used to analyse the adsorption equilibrium data. The Vieth–Sladek adsorption isotherm model was found to be the best fit. The pseudo-second-order reaction was the appropriate mechanism for the overall rate of the adsorption process. Mechanistic studies related to mass transfer phenomena were more likely to be dominant over the diffusion process. Techniques such as SEM, FTIR and CHN analysis were used to characterise NICUS. The dye-adsorbed NICUS obtained as “sludge” was used as a reinforcing material for the fabrication of composites using plastic waste. The physicomechanical and chemical properties of thermoplastic and thermoset composite using dye-adsorbed NICUS were evaluated and compared with NICUS composites. Prospects of integrating Small and Medium Enterprises (SMEs) into the circular economy of Nutraceutical Industrial Spent (NIS) are discussed.
Collapse
|
15
|
Hosseinkhani N, McCauley JI, Ralph PJ. Key challenges for the commercial expansion of ingredients from algae into human food products. ALGAL RES 2022. [DOI: 10.1016/j.algal.2022.102696] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/24/2022]
|
16
|
Singh S, Verma DK, Thakur M, Tripathy S, Patel AR, Shah N, Utama GL, Srivastav PP, Benavente-Valdés JR, Chávez-González ML, Aguilar CN. Supercritical fluid extraction (SCFE) as green extraction technology for high-value metabolites of algae, its potential trends in food and human health. Food Res Int 2021; 150:110746. [PMID: 34865764 DOI: 10.1016/j.foodres.2021.110746] [Citation(s) in RCA: 13] [Impact Index Per Article: 4.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/16/2021] [Revised: 10/01/2021] [Accepted: 10/06/2021] [Indexed: 02/07/2023]
Abstract
Application of high-value algal metabolites (HVAMs) in cosmetics, additives, pigments, foods and medicines are very important. These HVAMs can be obtained from the cultivation of micro- and macro-algae. These metabolites can benefit human and animal health in a physiological and nutritional manner. However, because of conventional extraction methods and their energy and the use of pollutant solvents, the availability of HVAMs from algae remains insufficient. Receiving their sustainability and environmental benefits have recently made green extraction technologies for HVAM extractions more desirable. But very little information is available about the technology of green extraction of algae from these HVAM. This review, therefore, highlights the supercritical fluid extraction (SCFE) as principal green extraction technologyand theirideal parameters for extracting HVAMs. In first, general information is provided concerning the HVAMs and their components of macro and micro origin. The review also includes a description of SCFE technology's properties, instrumentation operation, solvents used, and the merits and demerits. Moreover, there are several HVAMs associated with their numerous high-level biological activities which include high-level antioxidant, anti-inflammatory, anticancer and antimicrobial activity and have potential health-beneficial effects in humans since they are all HVAMs, such as foods and nutraceuticals. Finally, it provides future insights, obstacles, and suggestions for selecting the right technologies for extraction.
Collapse
Affiliation(s)
- Smita Singh
- Department of Nutrition and Dietetics, University Institute of Applied Health Sciences, Chandigarh University, Chandigarh 140413, Punjab, India.
| | - Deepak Kumar Verma
- Agricultural and Food Engineering Department, Indian Institute of Technology Kharagpur, Kharagpur 721302, West Bengal, India.
| | - Mamta Thakur
- Department of Food Technology, School of Sciences, ITM University, Gwalior 474001, Madhya Pradesh, India.
| | - Soubhagya Tripathy
- Agricultural and Food Engineering Department, Indian Institute of Technology Kharagpur, Kharagpur 721302, West Bengal, India
| | - Ami R Patel
- Division of Dairy Microbiology, Mansinhbhai Institute of Dairy and Food Technology-MIDFT, Dudhsagar Dairy Campus, Mehsana 384 002, Gujarat, India
| | - Nihir Shah
- Division of Dairy Microbiology, Mansinhbhai Institute of Dairy and Food Technology-MIDFT, Dudhsagar Dairy Campus, Mehsana 384 002, Gujarat, India
| | - Gemilang Lara Utama
- Faculty of Agro-Industrial Technology, Universitas Padjadjaran, Sumedang 45363, Indonesia; Center for Environment and Sustainability Science, Universitas Padjadjaran, Bandung 40132, Indonesia
| | - Prem Prakash Srivastav
- Agricultural and Food Engineering Department, Indian Institute of Technology Kharagpur, Kharagpur 721302, West Bengal, India
| | - Juan Roberto Benavente-Valdés
- Bioprocesses and Bioproducts Research Group, Food Research Department, School of Chemistry, Autonomous University of Coahuila, Saltillo Campus, 25280 Coahuila, Mexico
| | - Mónica L Chávez-González
- Bioprocesses and Bioproducts Research Group, Food Research Department, School of Chemistry, Autonomous University of Coahuila, Saltillo Campus, 25280 Coahuila, Mexico
| | - Cristobal Noe Aguilar
- Bioprocesses and Bioproducts Research Group, Food Research Department, School of Chemistry, Autonomous University of Coahuila, Saltillo Campus, 25280 Coahuila, Mexico.
| |
Collapse
|
17
|
D'Elia L, Imbimbo P, Liberti D, Bolinesi F, Mangoni O, Pollio A, Olivieri G, Monti DM. Thermo resistant antioxidants from photoautotrophic microorganisms: screening and characterization. World J Microbiol Biotechnol 2021; 37:215. [PMID: 34762205 DOI: 10.1007/s11274-021-03180-6] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/27/2021] [Accepted: 10/27/2021] [Indexed: 11/30/2022]
Abstract
The demand for natural antioxidants to be used in food industry is increasing, as synthetic antioxidants are toxic and have high production costs. Specifically, food processing and preservation require antioxidants resistant to thermal sterilization processes. In this study, twenty-five strains among microalgae and cyanobacteria were screened as antioxidants producers. The species Enallax sp., Synechococcus bigranulatus and Galdieria sulphuraria showed the highest content of chlorophyll a and total carotenoids. In vitro stability and antioxidant activity of the ethanolic extracts were performed. The results revealed that pigments present in the extracts, obtained from the previously mentioned species, were stable at room temperature and exhibited in vitro free radical scavenging potential with IC50 values of 0.099 ± 0.001, 0.048 ± 0.001 and 0.13 ± 0.02 mg mL-1, respectively. Biocompatibility assay showed that the extracts were not toxic on immortalized cell lines. The antioxidant activity was also tested on a cell-based model by measuring intracellular ROS levels after sodium arsenite treatment. Noteworthy, extracts were able to exert the same protective effect, before and after the pasteurization process. Results clearly indicate the feasibility of obtaining biologically active and thermostable antioxidants from microalgae. Green solvents can be used to obtain thermo-resistant antioxidants from cyanobacteria and microalgae which can be used in the food industry. Thus, the substitution of synthetic pigments with natural ones is now practicable.
Collapse
Affiliation(s)
- Luigi D'Elia
- Department of Chemical Sciences, University of Naples Federico II, Via Cinthia 4, 80126, Naples, Italy
| | - Paola Imbimbo
- Department of Chemical Sciences, University of Naples Federico II, Via Cinthia 4, 80126, Naples, Italy
| | - Davide Liberti
- Department of Chemical Sciences, University of Naples Federico II, Via Cinthia 4, 80126, Naples, Italy
| | - Francesco Bolinesi
- Department of Biology, University of Naples Federico II, Via Cinthia 4, 80126, Naples, Italy
| | - Olga Mangoni
- Department of Biology, University of Naples Federico II, Via Cinthia 4, 80126, Naples, Italy
| | - Antonino Pollio
- Department of Biology, University of Naples Federico II, Via Cinthia 4, 80126, Naples, Italy
| | - Giuseppe Olivieri
- Bioprocess Engineering Group, Wageningen University and Research, Droevendaalsesteeg 1, 6700AA, Wageningen, The Netherlands. .,Department of Chemical, Materials and Industrial Engineering, University of Naples Federico II, Piazzale Tecchio 80, 80125, Naples, Italy.
| | - Daria Maria Monti
- Department of Chemical Sciences, University of Naples Federico II, Via Cinthia 4, 80126, Naples, Italy.
| |
Collapse
|
18
|
Aljobair MO, Albaridi NA, Alkuraieef AN, AlKehayez NM. Physicochemical properties, nutritional value, and sensory attributes of a nectar developed using date palm puree and spirulina. INTERNATIONAL JOURNAL OF FOOD PROPERTIES 2021. [DOI: 10.1080/10942912.2021.1938604] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 10/21/2022]
Affiliation(s)
- Moneera O. Aljobair
- Nutrition and Food Science (PHD), Department of Physical Sport Science, Princess Nourah Bint Abdulrahman University, Riyadh, Saudi Arabia
| | - Najla A. Albaridi
- Nutrition and Food Science (PHD), Department of Physical Sport Science, Princess Nourah Bint Abdulrahman University, Riyadh, Saudi Arabia
| | - Amal N. Alkuraieef
- Nutrition and Food Science (PHD), Department of Physical Sport Science, Princess Nourah Bint Abdulrahman University, Riyadh, Saudi Arabia
| | - Nora M. AlKehayez
- Nutrition and Food Science (PHD), Department of Physical Sport Science, Princess Nourah Bint Abdulrahman University, Riyadh, Saudi Arabia
| |
Collapse
|
19
|
Patel AK, Singhania RR, Awasthi MK, Varjani S, Bhatia SK, Tsai ML, Hsieh SL, Chen CW, Dong CD. Emerging prospects of macro- and microalgae as prebiotic. Microb Cell Fact 2021; 20:112. [PMID: 34090444 PMCID: PMC8180151 DOI: 10.1186/s12934-021-01601-7] [Citation(s) in RCA: 25] [Impact Index Per Article: 8.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/29/2021] [Accepted: 05/26/2021] [Indexed: 12/15/2022] Open
Abstract
Macro- and microalgae-based foods are becoming popular due to their high nutritious value. The algal biomass is enriched with polysaccharides, protein, polyunsaturated fatty acids, carotenoids, vitamins and minerals. However, the most promising fraction is polysaccharides (PS) or their derivatives (as dietary fibers) which are not entirely fermented by colonic bacteria hence act as potential prebiotic. Primarily, algae become famous as prominent protein sources. Recently, these are widely adopted as functional food (e.g., desserts, dairy products, oil-derivatives, pastas etc.) or animal feed (for poultry, cattle, fish etc.). Besides prebiotic and balanced amino acids source, algae derived compounds implied as therapeutics due to comprising bioactive properties to elicit immunomodulatory, antioxidative, anticancerous, anticoagulant, hepato-protective, and antihypertensive responses. Despite the above potentials, broader research determinations are inevitable to explore these algal compounds until microalgae become a business reality for broader and specific applications in all health domains. However, scale up of algal bioprocess remains a major challenge until commercial affordability is accomplished which can be possible by discovering their hidden potentials and increasing their value and application prospects. This review provides an overview of the significance of algae consumption for several health benefits in humans and animals mainly as prebiotics, however their functional food and animal feed potential are briefly covered. Moreover, their potential to develop an algal-based food industry to meet the people's requirements not only as a sustainable food solution with several health benefits but also as therapeutics is inevitable.
Collapse
Affiliation(s)
- Anil Kumar Patel
- Department of Marine Environmental Engineering, National Kaohsiung University of Science and Technology, Kaohsiung City, 81157, Taiwan
| | - Reeta Rani Singhania
- Department of Marine Environmental Engineering, National Kaohsiung University of Science and Technology, Kaohsiung City, 81157, Taiwan
| | - Mukesh Kumar Awasthi
- College of Natural Resources and Environment, Northwest A&F University, Yangling, Shaanxi Province, 712100, People's Republic of China
| | - Sunita Varjani
- Gujarat Pollution Control Board, Gandhinagar, Gujarat, 382010, India
| | - Shashi Kant Bhatia
- Department of Biological Engineering, College of Engineering, Konkuk University, Seoul, 05029, Republic of Korea
| | - Mei-Ling Tsai
- Department of Seafood Science, National Kaohsiung University of Science and Technology, Kaohsiung, 81157, Taiwan
| | - Shu-Ling Hsieh
- Department of Seafood Science, National Kaohsiung University of Science and Technology, Kaohsiung, 81157, Taiwan
| | - Chiu-Wen Chen
- Department of Marine Environmental Engineering, National Kaohsiung University of Science and Technology, Kaohsiung City, 81157, Taiwan
| | - Cheng-Di Dong
- Department of Marine Environmental Engineering, National Kaohsiung University of Science and Technology, Kaohsiung City, 81157, Taiwan.
| |
Collapse
|
20
|
Sui Y, Harvey PJ. Effect of Light Intensity and Wavelength on Biomass Growth and Protein and Amino Acid Composition of Dunaliella salina. Foods 2021; 10:foods10051018. [PMID: 34067033 PMCID: PMC8150290 DOI: 10.3390/foods10051018] [Citation(s) in RCA: 13] [Impact Index Per Article: 4.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/29/2021] [Revised: 04/30/2021] [Accepted: 05/06/2021] [Indexed: 01/13/2023] Open
Abstract
Dunaliella salina is a halotolerant, photoautotrophic marine microalga and one of the richest sources of natural carotenoids but also shows potential as a novel food source with high protein quality. This study sought to optimise the production of biomass, protein and amino acids from D. salina, alongside carotenoids using a two-stage cultivation approach based on the use of light of different intensities and quality, i.e., white, red and blue LED light. In stage 1, four white LED light intensities were tested. In stage 2, the same four light intensities from either blue or red LEDs were applied once exponential growth ceased and cells reached the stationary phase under white LED light in stage 1. Remarkably, both biomass concentration and biomass productivity showed a 1.3–1.7-fold increase in stage 2, without medium replenishment, while protein concentration and protein productivity showed an ~1.1-fold increase. The amino acid content and amino acid index remained unchanged from stage 1 to stage 2, and minimum difference was found across different light intensities. Overall, D. salina delivered so-called high protein quality, with an essential amino acid index (EAAI) of 0.99, and red light, which has previously been shown to increase carotenoid production, boosted further biomass production over and above white light, at all light intensities tested.
Collapse
|
21
|
Barbosa V, Maulvault AL, Anacleto P, Santos M, Mai M, Oliveira H, Delgado I, Coelho I, Barata M, Araújo-Luna R, Ribeiro L, Eljasik P, Sobczak M, Sadowski J, Tórz A, Panicz R, Dias J, Pousão-Ferreira P, Carvalho ML, Martins M, Marques A. Effects of steaming on health-valuable nutrients from fortified farmed fish: Gilthead seabream (Sparus aurata) and common carp (Cyprinus carpio) as case studies. Food Chem Toxicol 2021; 152:112218. [PMID: 33882300 DOI: 10.1016/j.fct.2021.112218] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/20/2021] [Revised: 04/07/2021] [Accepted: 04/13/2021] [Indexed: 10/21/2022]
Abstract
Fish fortification with iodine-rich macroalgae (Laminaria digitata) and Selenium-rich yeast is expected to promote nutritional added value of this crucial food item, contributing to a healthy and balanced diet for consumers. However, it is not known if steaming can affect these nutrient levels in fortified fish. The present study evaluates the effect of steaming on nutrients contents in fortified farmed gilthead seabream (Sparus aurata) and common carp (Cyprinus carpio). Fortified seabream presented enhanced I, Se and Fe contents, whereas fortified carp presented enhanced I, Se and Zn contents. Steaming resulted in increased I and Se contents in fortified seabream, and increased Fe and Zn levels in fortified carp, with higher elements true retention values (TRVs >90%). The consumption of 150 g of steamed fortified seabream contributes to a significant daily intake (DI) of I (up to 12%) and Se (up to >100%). On the other hand, steamed fortified carp contributes to 19-23% of I DI and 30%-71% of Se DI. These results demonstrate that steaming is a healthy cooking method, maintaining the enhanced nutritional quality of fortified fish. Moreover, the present fortification strategy is a promising solution to develop high-quality farmed fish products to overcome nutritional deficiencies.
Collapse
Affiliation(s)
- Vera Barbosa
- Aquaculture, Valorization and Bioprospection Division (DivAV), Portuguese Institute for the Sea and Atmosphere, I.P. (IPMA), Lisbon, Portugal; Interdisciplinary Centre of Marine and Environmental Research (CIIMAR), University of Porto, Porto, Portugal; MARE - Marine and Environmental Science Centre, Department of Environmental Sciences and Engineering (DCEA), NOVA School of Science and Technology (FCT NOVA), Caparica, Portugal.
| | - Ana Luísa Maulvault
- Aquaculture, Valorization and Bioprospection Division (DivAV), Portuguese Institute for the Sea and Atmosphere, I.P. (IPMA), Lisbon, Portugal; Interdisciplinary Centre of Marine and Environmental Research (CIIMAR), University of Porto, Porto, Portugal; MARE - Marine and Environmental Sciences Centre, Guia Marine Laboratory, Faculty of Sciences, University of Lisbon (FCUL), Lisbon, Portugal
| | - Patrícia Anacleto
- Aquaculture, Valorization and Bioprospection Division (DivAV), Portuguese Institute for the Sea and Atmosphere, I.P. (IPMA), Lisbon, Portugal; Interdisciplinary Centre of Marine and Environmental Research (CIIMAR), University of Porto, Porto, Portugal; MARE - Marine and Environmental Sciences Centre, Guia Marine Laboratory, Faculty of Sciences, University of Lisbon (FCUL), Lisbon, Portugal
| | - Marta Santos
- Aquaculture, Valorization and Bioprospection Division (DivAV), Portuguese Institute for the Sea and Atmosphere, I.P. (IPMA), Lisbon, Portugal
| | - Mónica Mai
- Interdisciplinary Centre of Marine and Environmental Research (CIIMAR), University of Porto, Porto, Portugal
| | - Helena Oliveira
- Aquaculture, Valorization and Bioprospection Division (DivAV), Portuguese Institute for the Sea and Atmosphere, I.P. (IPMA), Lisbon, Portugal; Interdisciplinary Centre of Marine and Environmental Research (CIIMAR), University of Porto, Porto, Portugal
| | - Inês Delgado
- Food and Nutrition Department, National Health Institute Doutor Ricardo Jorge (INSA), Lisbon, Portugal
| | - Inês Coelho
- Food and Nutrition Department, National Health Institute Doutor Ricardo Jorge (INSA), Lisbon, Portugal
| | - Marisa Barata
- EPPO, Aquaculture Research Station, Portuguese Institute for the Sea and Atmosphere, I.P. (IPMA), Olhão, Portugal
| | - Ravi Araújo-Luna
- EPPO, Aquaculture Research Station, Portuguese Institute for the Sea and Atmosphere, I.P. (IPMA), Olhão, Portugal
| | - Laura Ribeiro
- EPPO, Aquaculture Research Station, Portuguese Institute for the Sea and Atmosphere, I.P. (IPMA), Olhão, Portugal
| | - Piotr Eljasik
- Zachodniopomorski Uniwersytet Technologiczny w Szczecinie (ZUT), Szczecin, Poland
| | - Małgorzata Sobczak
- Zachodniopomorski Uniwersytet Technologiczny w Szczecinie (ZUT), Szczecin, Poland
| | - Jacek Sadowski
- Zachodniopomorski Uniwersytet Technologiczny w Szczecinie (ZUT), Szczecin, Poland
| | - Agnieszka Tórz
- Zachodniopomorski Uniwersytet Technologiczny w Szczecinie (ZUT), Szczecin, Poland
| | - Remigiusz Panicz
- Zachodniopomorski Uniwersytet Technologiczny w Szczecinie (ZUT), Szczecin, Poland
| | | | - Pedro Pousão-Ferreira
- EPPO, Aquaculture Research Station, Portuguese Institute for the Sea and Atmosphere, I.P. (IPMA), Olhão, Portugal
| | - Maria Luísa Carvalho
- (LIBPhYs-UNL), Physics Department, NOVA School of Science and Technology, Caparica, Portugal
| | - Marta Martins
- MARE - Marine and Environmental Science Centre, Department of Environmental Sciences and Engineering (DCEA), NOVA School of Science and Technology (FCT NOVA), Caparica, Portugal
| | - António Marques
- Aquaculture, Valorization and Bioprospection Division (DivAV), Portuguese Institute for the Sea and Atmosphere, I.P. (IPMA), Lisbon, Portugal; Interdisciplinary Centre of Marine and Environmental Research (CIIMAR), University of Porto, Porto, Portugal
| |
Collapse
|
22
|
Remize M, Brunel Y, Silva JL, Berthon JY, Filaire E. Microalgae n-3 PUFAs Production and Use in Food and Feed Industries. Mar Drugs 2021; 19:113. [PMID: 33670628 PMCID: PMC7922858 DOI: 10.3390/md19020113] [Citation(s) in RCA: 45] [Impact Index Per Article: 15.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/15/2021] [Revised: 02/13/2021] [Accepted: 02/15/2021] [Indexed: 12/11/2022] Open
Abstract
N-3 polyunsaturated fatty acids (n-3 PUFAs), and especially eicosapentaenoic acid (EPA) and docosahexaenoic acid (DHA), are essential compounds for human health. They have been proven to act positively on a panel of diseases and have interesting anti-oxidative, anti-inflammatory or anti-cancer properties. For these reasons, they are receiving more and more attention in recent years, especially future food or feed development. EPA and DHA come mainly from marine sources like fish or seaweed. Unfortunately, due to global warming, these compounds are becoming scarce for humans because of overfishing and stock reduction. Although increasing in recent years, aquaculture appears insufficient to meet the increasing requirements of these healthy molecules for humans. One alternative resides in the cultivation of microalgae, the initial producers of EPA and DHA. They are also rich in biochemicals with interesting properties. After defining macro and microalgae, this review synthesizes the current knowledge on n-3 PUFAs regarding health benefits and the challenges surrounding their supply within the environmental context. Microalgae n-3 PUFA production is examined and its synthesis pathways are discussed. Finally, the use of EPA and DHA in food and feed is investigated. This work aims to define better the issues surrounding n-3 PUFA production and supply and the potential of microalgae as a sustainable source of compounds to enhance the food and feed of the future.
Collapse
Affiliation(s)
- Marine Remize
- GREENSEA, 3 Promenade du Sergent Jean-Louis Navarro, 34140 MÈZE, France; (M.R.); (Y.B.)
| | - Yves Brunel
- GREENSEA, 3 Promenade du Sergent Jean-Louis Navarro, 34140 MÈZE, France; (M.R.); (Y.B.)
| | - Joana L. Silva
- ALLMICROALGAE–Natural Products, Avenida 25 Abril, 2445-413 Pataias, Portugal;
| | | | - Edith Filaire
- GREENTECH, Biopôle Clermont-Limagne, 63360 SAINT BEAUZIRE, France;
- ECREIN Team, UMR 1019 INRA-UcA, UNH (Human Nutrition Unity), University Clermont Auvergne, 63000 Clermont-Ferrand, France
| |
Collapse
|
23
|
Benkhoud H, Baâti T, Njim L, Selmi S, Hosni K. Antioxidant, antidiabetic, and antihyperlipidemic activities of wheat flour-based chips incorporated with omega-3-rich fish oil and artichoke powder. J Food Biochem 2020; 45:e13297. [PMID: 32515503 DOI: 10.1111/jfbc.13297] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [Key Words] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/02/2020] [Revised: 04/21/2020] [Accepted: 05/05/2020] [Indexed: 12/29/2022]
Abstract
In the present study, the omega-3-rich oil from fish viscera and gill by-products, and caffeoylquinic-rich powder of artichoke bract by-products were used for the enrichment of wheat flour chips. Incorporation of these ingredients improved the lipid profile by increasing the level of polyunsaturated essential fatty acids mainly linoleic, linolenic, eicosapentaenoic, and docosahexaenoic acids enhancing thereby their nutritional quality. In alloxan-induced diabetic mice, the novel products reverts the blood glucose and serum markers including alanine aminotransferase, aspartate aminotransferase, alkaline phosphatase, urea, and creatinine to their normal levels. Concomitantly, they prevented lipid peroxidation and activated antioxidant enzymes (catalase, superoxide dismutase, and glutathione peroxidase). They ameliorate the lipid profile by reducing triglycerides, cholesterol, and LDL. Additional efforts aimed at investigating the potential of other raw materials including algal biomass, and shrimps as a sustainable source of valuable ingredients would contribute to the development of new products with improved nutritional and functional attributes. PRACTICAL APPLICATIONS: Icorporation of cheap, available, and functional ingredients from fish (omega-3-rich oil) and artichoke bract by-products into wheat flour chips could be successfully adopted for the development of functional foods destined for diabetic patient.
Collapse
Affiliation(s)
- Haifa Benkhoud
- Laboratoire des Substances Naturelles, Institut National de Recherche et d'Analyse Physico-chimique (INRAP), Biotechpôle de Sidi thabet, Ariana, Tunisia.,Institut National Agronomique de Tunis, Université de Carthage, Tunis, Tunisia
| | - Tarek Baâti
- Laboratoire des Substances Naturelles, Institut National de Recherche et d'Analyse Physico-chimique (INRAP), Biotechpôle de Sidi thabet, Ariana, Tunisia
| | - Leila Njim
- Service d'Anatomie et de Cytologie Pathologique, CHU Fattouma Bourguiba, Monastir, Tunisia
| | - Slimen Selmi
- Laboratoire des Substances Naturelles, Institut National de Recherche et d'Analyse Physico-chimique (INRAP), Biotechpôle de Sidi thabet, Ariana, Tunisia.,Unité de Physiologie Fonctionnelle et Valorisation des Bioressources, Institut Supérieur de Biotechnologie de Béja, Université de Jendouba, Béja, Tunisia
| | - Karim Hosni
- Laboratoire des Substances Naturelles, Institut National de Recherche et d'Analyse Physico-chimique (INRAP), Biotechpôle de Sidi thabet, Ariana, Tunisia
| |
Collapse
|
24
|
Durmaz Y, Kilicli M, Toker OS, Konar N, Palabiyik I, Tamtürk F. Using spray-dried microalgae in ice cream formulation as a natural colorant: Effect on physicochemical and functional properties. ALGAL RES 2020. [DOI: 10.1016/j.algal.2020.101811] [Citation(s) in RCA: 19] [Impact Index Per Article: 4.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/04/2023]
|
25
|
Fabris M, Abbriano RM, Pernice M, Sutherland DL, Commault AS, Hall CC, Labeeuw L, McCauley JI, Kuzhiuparambil U, Ray P, Kahlke T, Ralph PJ. Emerging Technologies in Algal Biotechnology: Toward the Establishment of a Sustainable, Algae-Based Bioeconomy. FRONTIERS IN PLANT SCIENCE 2020; 11:279. [PMID: 32256509 PMCID: PMC7090149 DOI: 10.3389/fpls.2020.00279] [Citation(s) in RCA: 102] [Impact Index Per Article: 25.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/29/2019] [Accepted: 02/24/2020] [Indexed: 05/18/2023]
Abstract
Mankind has recognized the value of land plants as renewable sources of food, medicine, and materials for millennia. Throughout human history, agricultural methods were continuously modified and improved to meet the changing needs of civilization. Today, our rapidly growing population requires further innovation to address the practical limitations and serious environmental concerns associated with current industrial and agricultural practices. Microalgae are a diverse group of unicellular photosynthetic organisms that are emerging as next-generation resources with the potential to address urgent industrial and agricultural demands. The extensive biological diversity of algae can be leveraged to produce a wealth of valuable bioproducts, either naturally or via genetic manipulation. Microalgae additionally possess a set of intrinsic advantages, such as low production costs, no requirement for arable land, and the capacity to grow rapidly in both large-scale outdoor systems and scalable, fully contained photobioreactors. Here, we review technical advancements, novel fields of application, and products in the field of algal biotechnology to illustrate how algae could present high-tech, low-cost, and environmentally friendly solutions to many current and future needs of our society. We discuss how emerging technologies such as synthetic biology, high-throughput phenomics, and the application of internet of things (IoT) automation to algal manufacturing technology can advance the understanding of algal biology and, ultimately, drive the establishment of an algal-based bioeconomy.
Collapse
Affiliation(s)
- Michele Fabris
- Climate Change Cluster (C3), University of Technology Sydney, Ultimo, NSW, Australia
- CSIRO Synthetic Biology Future Science Platform, Brisbane, QLD, Australia
| | - Raffaela M. Abbriano
- Climate Change Cluster (C3), University of Technology Sydney, Ultimo, NSW, Australia
| | - Mathieu Pernice
- Climate Change Cluster (C3), University of Technology Sydney, Ultimo, NSW, Australia
| | - Donna L. Sutherland
- Climate Change Cluster (C3), University of Technology Sydney, Ultimo, NSW, Australia
| | - Audrey S. Commault
- Climate Change Cluster (C3), University of Technology Sydney, Ultimo, NSW, Australia
| | - Christopher C. Hall
- Climate Change Cluster (C3), University of Technology Sydney, Ultimo, NSW, Australia
| | - Leen Labeeuw
- Climate Change Cluster (C3), University of Technology Sydney, Ultimo, NSW, Australia
| | - Janice I. McCauley
- Climate Change Cluster (C3), University of Technology Sydney, Ultimo, NSW, Australia
| | | | - Parijat Ray
- Climate Change Cluster (C3), University of Technology Sydney, Ultimo, NSW, Australia
| | - Tim Kahlke
- Climate Change Cluster (C3), University of Technology Sydney, Ultimo, NSW, Australia
| | - Peter J. Ralph
- Climate Change Cluster (C3), University of Technology Sydney, Ultimo, NSW, Australia
| |
Collapse
|
26
|
Bernaerts TM, Gheysen L, Foubert I, Hendrickx ME, Van Loey AM. The potential of microalgae and their biopolymers as structuring ingredients in food: A review. Biotechnol Adv 2019; 37:107419. [DOI: 10.1016/j.biotechadv.2019.107419] [Citation(s) in RCA: 88] [Impact Index Per Article: 17.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/21/2018] [Revised: 07/15/2019] [Accepted: 07/16/2019] [Indexed: 12/11/2022]
|
27
|
Papalia T, Sidari R, Panuccio MR. Impact of Different Storage Methods on Bioactive Compounds in Arthrospira platensis Biomass. Molecules 2019; 24:molecules24152810. [PMID: 31374946 PMCID: PMC6696024 DOI: 10.3390/molecules24152810] [Citation(s) in RCA: 22] [Impact Index Per Article: 4.4] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/05/2019] [Revised: 07/26/2019] [Accepted: 07/31/2019] [Indexed: 11/16/2022] Open
Abstract
Arthrospira platensis (spirulina) is considered a source of natural molecules with nutritional and health benefits. As the different storage forms can affect the quantity and quality of bioactive ingredients, the aim of the present work was to evaluate the effects of freezing, oven-drying and freeze-drying on chemical composition of spirulina biomass. Total proteins, photosynthetic pigments and antioxidants, were analyzed and compared to respective quantities in fresh biomass. The frozen sample exhibited the highest content of phycocyanin-C, phenols, and ascorbic acid, also respect to the fresh biomass. The highest total flavonoid amount was in the freeze-dried biomass. HPLC-DAD analysis of phenolic acids revealed the presence of the isoflavone genistein, known for its therapeutic role, in all the spirulina samples. The phosphomolybdenum method (TAC) and DPPH scavenging activity were applied to determine the antioxidant activity of different samples. The highest DPPH scavenging activity was detected in fresh and freeze-dried biomass and it was positively related to carotenoid content. A positive correlation indicated that carotenoids, chlorophyll, ascorbic acid and all phenolic compounds were the major contributors to the TAC activity in spirulina biomass. The results highlighted a different functional value of spirulina biomass, depending on the processing methods used for its storage.
Collapse
Affiliation(s)
- Teresa Papalia
- Department of Agricultural Science, "Mediterranea" University, Feo di Vito, 89124 Reggio Calabria, Italy
| | - Rossana Sidari
- Department of Agricultural Science, "Mediterranea" University, Feo di Vito, 89124 Reggio Calabria, Italy
| | - Maria Rosaria Panuccio
- Department of Agricultural Science, "Mediterranea" University, Feo di Vito, 89124 Reggio Calabria, Italy.
| |
Collapse
|