The use of an approved biodegradable polymer scaffold as a solid support system for improvement of islet engraftment

Function and composition of pancreatic islet cell implants in omentum of type 1 diabetes patients

Intraportal (IP) islet cell transplants can restore metabolic control in type 1 diabetes patients, but limitations raise the need for establishing a functional beta cell mass (FBM) in a confined extrahepatic site. This study reports on function and composition of omental (OM) implants after placement of islet cell grafts with similar beta cell mass as in our IP-protocol (2-5.10⁶ beta cells/kg body weight) on a scaffold. Four of seven C-peptide-negative recipients achieved low beta cell function (hyperglycemic clamp [HGC] 2-8 percent of controls) until laparoscopy, 2-6 months later, for OM-biopsy and concomitant IP-transplant with similar beta cell dose. This IP-transplant increased HGC-values to 15-40 percent. OM-biopsies reflected the composition of initial grafts, exhibiting varying proportions of endocrine-cell-enriched clusters with more beta than alpha cells and leucocyte pole, non-endocrine cytokeratin-positive clusters surrounded by leucocytes, and scaffold remnants with foreign body reaction. OM-implants on a polyglactin-thrombin-fibrinogen-scaffold presented larger endocrine clusters with infiltrating endothelial cells and corresponded to the higher HGC-values. No activation of cellular immunity to GAD/IA2 was measured post-OM-transplant. Establishment of a metabolically adequate FBM in omentum may require a higher beta cell number in grafts but also elimination of their immunogenic non-endocrine components as well as local conditioning that favors endocrine cell engraftment and function.

Chitosan/Gelatin/PVA Scaffolds for Beta Pancreatic Cell Culture

Chitosan scaffolds based on blending polymers are a common strategy used in tissue engineering. The objective of this study was evaluation the properties of scaffolds based on a ternary blend of chitosan (Chi), gelatin (Ge), and polyvinyl alcohol (PVA) (Chi/Ge/PVA), which were prepared by cycles of freeze-thawing and freeze-drying. It then was used for three-dimensional BRIN-BD11 beta-cells culturing. Weight ratios of Chi/Ge/PVA (1:1:1, 2:2:1, 2:3:1, and 3:2:1) were proposed and porosity, pore size, degradation, swelling rate, compressive strength, and cell viability analyzed. All ternary blend scaffolds structures are highly porous (with a porosity higher than 80%) and interconnected. The pore size distribution varied from 0.6 to 265 μm. Ternary blends scaffolds had controllable degradation rates compared to binary blend scaffolds, and an improved swelling capacity of the samples with increasing chitosan concentration was found. An increase in Young’s modulus and compressive strength was observed with increasing gelatin concentration. The highest compressive strength reached 101.6 Pa. The MTT assay showed that the ternary blends scaffolds P3 and P4 supported cell viability better than the binary blend scaffold. Therefore, these results illustrated that ternary blends scaffolds P3 and P4 could provide a better environment for BRIN-BD11 cell proliferation.

High density culture of pancreatic islet-like 3D tissue organized in oxygen-permeable porous scaffolds with external oxygen supply

Transplantation of macroencapsulated pancreatic islets within semipermeable membranes is a promising approach for the treatment of type 1 diabetes. Encapsulation beneficially isolates the implants from the host immune system. Deleteriously however, it also limits oxygen supply to the cells. This creates challenges in loading islets at the amount and density required to meet the practical demands of clinical usage. To overcome this challenge, we investigated the feasibility of using macroporous scaffolds made of an oxygen-permeable polymer, poly(dimethylsiloxane) (PDMS) by culturing pancreatic islet-like three-dimensional tissue made of a rat pancreatic beta cell line on the scaffolds. With external oxygenation, the density and function of cells on the PDMS scaffold were more than three times and almost two times higher than those without oxygenation, respectively. This suggests that the oxygenation afforded by the PDMS scaffolds allows for high-density loading of islet tissue into the devices.

White Adipose Tissue as a Site for Islet Transplantation

Although islet transplantation is recognized as a useful cellular replacement therapy for severe diabetes, surgeons face difficulties in islet engraftment. The transplant site is a pivotal factor that influences the engraftment. Although the liver is the current representative site for clinical islet transplantation, it is not the best site because of limitations in immunity, inflammation, and hypoxia. White adipose tissue, including omentum, is recognized as a useful candidate site for islet transplantation. Its effectiveness has been evaluated in not only various basic and translational studies using small and large animals but also in some recent clinical trials. In this review, we attempt to shed light on the characteristics and usefulness of white adipose tissue as a transplant site for islets.

White Adipose Tissue as a Site for Islet Transplantation

Although islet transplantation is recognized as a useful cellular replacement therapy for severe diabetes, surgeons face difficulties in islet engraftment. The transplant site is a pivotal factor that influences the engraftment. Although the liver is the current representative site for clinical islet transplantation, it is not the best site because of limitations in immunity, inflammation, and hypoxia. White adipose tissue, including omentum, is recognized as a useful candidate site for islet transplantation. Its effectiveness has been evaluated in not only various basic and translational studies using small and large animals but also in some recent clinical trials. In this review, we attempt to shed light on the characteristics and usefulness of white adipose tissue as a transplant site for islets.

The emerging field of pancreatic tissue engineering: A systematic review and evidence map of scaffold materials and scaffolding techniques for insulin-secreting cells

A bioartificial endocrine pancreas is proposed as a future alternative to current treatment options. Patients with insulin-secretion deficiency might benefit. This is the first systematic review that provides an overview of scaffold materials and techniques for insulin-secreting cells or cells to be differentiated into insulin-secreting cells. An electronic literature survey was conducted in PubMed/MEDLINE and Web of Science, limited to the past 10 years. A total of 197 articles investigating 60 different materials met the inclusion criteria. The extracted data on materials, cell types, study design, and transplantation sites were plotted into two evidence gap maps. Integral parts of the tissue engineering network such as fabrication technique, extracellular matrix, vascularization, immunoprotection, suitable transplantation sites, and the use of stem cells are highlighted. This systematic review provides an evidence-based structure for future studies. Accumulating evidence shows that scaffold-based tissue engineering can enhance the viability and function or differentiation of insulin-secreting cells both in vitro and in vivo.

Selection of Implantation Sites for Transplantation of Encapsulated Pancreatic Islets

Pancreatic islet transplantation has been validated as a valuable therapy for type 1 diabetes mellitus patients with exhausted insulin treatment. However, this therapy remains limited by the shortage of donor and the requirement of lifelong immunosuppression. Islet encapsulation, as an available bioartificial pancreas (BAP), represents a promising approach to enable protecting islet grafts without or with minimal immunosuppression and possibly expanding the donor pool. To develop a clinically implantable BAP, some key aspects need to be taken into account: encapsulation material, capsule design, and implant site. Among them, the implant site exerts an important influence on the engraftment, stability, and biocompatibility of implanted BAP. Currently, an optimal site for encapsulated islet transplantation may include sufficient capacity to host large graft volumes, portal drainage, ease of access using safe and reproducible procedure, adequate blood/oxygen supply, minimal immune/inflammatory reaction, pliable for noninvasive imaging and biopsy, and potential of local microenvironment manipulation or bioengineering. Varying degrees of success have been confirmed with the utilization of liver or extrahepatic sites in an experimental or preclinical setting. However, the ideal implant site remains to be further engineered or selected for the widespread application of encapsulated islet transplantation.

Pancreatic islet macroencapsulation using microwell porous membranes

Allogeneic islet transplantation into the liver in combination with immune suppressive drug therapy is widely regarded as a potential cure for type 1 diabetes. However, the intrahepatic system is suboptimal as the concentration of drugs and nutrients there is higher compared to pancreas, which negatively affects islet function. Islet encapsulation within semipermeable membranes is a promising strategy that allows for the islet transplantation outside the suboptimal liver portal system and provides environment, where islets can perform their endocrine function. In this study, we develop a macroencapsulation device based on thin microwell membranes. The islets are seeded in separate microwells to avoid aggregation, whereas the membrane porosity is tailored to achieve sufficient transport of nutrients, glucose and insulin. The non-degradable, microwell membranes are composed of poly (ether sulfone)/polyvinylpyrrolidone and manufactured via phase separation micro molding. Our results show that the device prevents aggregation and preserves the islet’s native morphology. Moreover, the encapsulated islets maintain their glucose responsiveness and function after 7 days of culture (stimulation index above 2 for high glucose stimulation), demonstrating the potential of this novel device for islet transplantation.

Operative management of chronic pancreatitis: A review

BACKGROUND

Pain secondary to chronic pancreatitis is a difficult clinical problem to manage. Many patients are treated medically or undergo endoscopic therapy and surgical intervention is often reserved for those who have failed to gain adequate pain relief from a more conservative approach.

RESULTS

There have been a number of advances in the operative management of chronic pancreatitis over the last few decades and current therapies include drainage procedures (pancreaticojejunostomy, etc.), resection (pancreticoduodenectomy, etc.) and combined drainage/resection procedures (Frey procedure, etc.). Additionally, many centers currently perform total pancreatectomy with islet autotransplantation, in addition to minimally invasive options that are intended to tailor therapy to individual patients.

DISCUSSION

Operative management of chronic pancreatitis often improves quality of life, and is associated with low rates of morbidity and mortality. The decision as to which procedure is optimal for each patient should be based on a combination of pathologic changes, prior interventions, and individual surgeon and center experience.

Re-engineering islet cell transplantation

We are living exciting times in the field of beta cell replacement therapies for the treatment of diabetes. While steady progress has been recorded thus far in clinical islet transplantation, novel approaches are needed to make cell-based therapies more reproducible and leading to long-lasting success. The multiple facets of diabetes impose the need for a transdisciplinary approach to attain this goal, by targeting immunity, promoting engraftment and sustained functional potency. We discuss herein the emerging technologies applied to this rapidly evolving field.

Pancreatic islet transplantation: from dogs to humans and back again

Pancreatic islet transplantation is a cell-based therapy that provides a potential cure for type 1 diabetes mellitus. After the introduction of an automated method for islet isolation and steroid-free immunosuppressive protocols, reversal of diabetes by islet transplantation is now performed at major human medical centers around the world. Despite extensive use of animal models in islet transplantation research, practical concerns have slowed the introduction of the technique into clinical veterinary practice and only a small number of studies have reported results of transplantation in dogs with spontaneously occurring diabetes mellitus; however, recent advances in islet isolation and encapsulation may make it possible to perform islet transplantation without immunosuppression in companion animals. This review summarizes experimental and clinical studies of pancreatic islet transplantation in dogs, including future directions for cell therapy in animals with naturally occurring disease.

Engineering a local microenvironment for pancreatic islet replacement

Intraportal islet transplantation has emerged as a promising treatment for type 1 diabetes mellitus (T1DM). Nevertheless, long-term efficacy has been limited to a marginal number of patients. Outcomes have been restricted, in part, by challenges associated with the transplant site, poor vascularization, and disruption of the native islet architecture during the isolation process. Engineering a biomaterial platform that recapitulates critical components of the pancreatic environment can serve to address these hurdles. This review highlights the challenges and opportunities in engineering 3D niches for islets, specifically: the importance of site selection; the application of scaffold functionalization to present bioactive motifs; and the development of technologies for enhancing implant nutritional profiles. The potential of these novel approaches to improve islet engraftment and duration of function is discussed.

Microwell scaffolds for the extrahepatic transplantation of islets of Langerhans

Allogeneic islet transplantation into the liver has the potential to restore normoglycemia in patients with type 1 diabetes. However, the suboptimal microenvironment for islets in the liver is likely to be involved in the progressive islet dysfunction that is often observed post-transplantation. This study validates a novel microwell scaffold platform to be used for the extrahepatic transplantation of islet of Langerhans. Scaffolds were fabricated from either a thin polymer film or an electrospun mesh of poly(ethylene oxide terephthalate)-poly(butylene terephthalate) (PEOT/PBT) block copolymer (composition: 4000PEOT30PBT70) and were imprinted with microwells, ∼400 µm in diameter and ∼350 µm in depth. The water contact angle and water uptake were 39±2° and 52.1±4.0 wt%, respectively. The glucose flux through electrospun scaffolds was three times higher than for thin film scaffolds, indicating enhanced nutrient diffusion. Human islets cultured in microwell scaffolds for seven days showed insulin release and insulin content comparable to those of free-floating control islets. Islet morphology and insulin and glucagon expression were maintained during culture in the microwell scaffolds. Our results indicate that the microwell scaffold platform prevents islet aggregation by confinement of individual islets in separate microwells, preserves the islet’s native rounded morphology, and provides a protective environment without impairing islet functionality, making it a promising platform for use in extrahepatic islet transplantation.

Embedding islet in a liquid scaffold increases islet viability and function

INTRODUCTION

Islet transplantation is a promising strategy to restore efficient insulin regulation in type 1 diabetes mellitus patients. However, shortage of islet donors, poor islet survival and toxicity of immunosuppressants often reduce the graft functional lifetime.

METHODS

We previously showed that a fibroblast populated-collagen matrix (CM) significantly improved engrafted islet viability/function. However, this composite was prone to gradual biodegradation and contraction. Moreover, to avoid use of systemic immunosuppressants, we proposed the use of a local immunosuppressive enzyme, indoleamine-2,3-dioxygenase (IDO). We developed a novel bioengineered crosslinked CM (CCM) to provide optimal matrix biomimetic. Viability and insulin secretory function of islets embedded within fibroblast populated CCM (FP-CCM) was evaluated in vitro and in vivo. IDO expression was transduced in fibroblasts by a lentiviral vector carrying IDO gene and islet viability was evaluated in the presence and absence of IDO producing cells.

RESULTS

Islet survival/function markedly improved within FP-CCM. Furthermore, our data shows that local lentiviral induction of IDO delivered by FP-CCM is nontoxic to the embedded islets.

CONCLUSIONS

This promising finding offers a new approach to improving islet transplant outcome.

Macroporous three-dimensional PDMS scaffolds for extrahepatic islet transplantation

Clinical islet transplantation has demonstrated success in treating type 1 diabetes. A current limitation is the intrahepatic portal vein transplant site, which is prone to mechanical stress and inflammation. Transplantation of pancreatic islets into alternative sites is preferable, but challenging, as it may require a three-dimensional vehicle to confer mechanical protection and to confine islets to a well-defined, retrievable space where islet neovascularization can occur. We have fabricated biostable, macroporous scaffolds from poly(dimethylsiloxane) (PDMS) and investigated islet retention and distribution, metabolic function, and glucose-dependent insulin secretion within these scaffolds. Islets from multiple sources, including rodents, nonhuman primates, and humans, were tested in vitro. We observed high islet retention and distribution within PDMS scaffolds, with retention of small islets (< 100 µm) improved through the postloading addition of fibrin gel. Islets loaded within PDMS scaffolds exhibited viability and function comparable to standard culture conditions when incubated under normal oxygen tensions, but displayed improved viability compared to standard two-dimensional culture controls under low oxygen tensions. In vivo efficacy of scaffolds to support islet grafts was evaluated after transplantation in the omental pouch of chemically induced diabetic syngeneic rats, which promptly achieved normoglycemia. Collectively, these results are promising in that they indicate the potential for transplanting islets into a clinically relevant, extrahepatic site that provides spatial distribution of islets as well as intradevice vascularization.

The use of biomaterials in islet transplantation

Pancreatic islet transplantation is a therapeutic option to replace destroyed β cells in autoimmune diabetes. Islets are transplanted into the liver via the portal vein; however, inflammation, the required immunosuppression, and lack of vasculature decrease early islet viability and function. Therefore, the use of accessory therapy and biomaterials to protect islets and improve islet function has definite therapeutic potential. Here we review the application of niche accessory cells and factors, as well as the use of biomaterials as carriers or capsules, for pancreatic islet transplantation.

Alternative transplantation sites for pancreatic islet grafts

The liver is the current site of choice for pancreatic islet transplantation, even though it is far from being an ideal site because of immunologic, anatomic, and physiologic factors leading to a significant early graft loss. A huge amount of alternative sites have been used for islet transplantation in experimental animal models to provide improved engraftment and long-term survival minimizing surgical complications. The pancreas, gastric submucosa, genitourinary tract, muscle, omentum, bone marrow, kidney capsule, peritoneum, anterior eye chamber, testis, and thymus have been explored. Site-specific differences exist in term of islet engraftment, but few alternative sites have potential clinical translation and generally the evidence of a post-transplant islet function better than that reached after intraportal infusion is still lacking. This review discusses site-specific benefits and drawbacks taking into account immunologic, metabolic, and technical aspects to identify the ideal microenvironment for islet function and survival.

Extrahepatic islet transplantation with microporous polymer scaffolds in syngeneic mouse and allogeneic porcine models

Intraportal transplantation of islets has successfully treated select patients with type 1 diabetes. However, intravascular infusion and the intrahepatic site contribute to significant early and late islet loss, yet a clinical alternative has remained elusive. We investigated non-encapsulating, porous, biodegradable polymer scaffolds as a vehicle for islet transplantation into extrahepatic sites, using syngeneic mouse and allogeneic porcine models. Scaffold architecture was modified to enhance cell infiltration leading to revascularization of the islets with minimal inflammatory response. In the diabetic mouse model, 125 islets seeded on scaffolds implanted into the epididymal fat pad restored normoglycemia within an average of 1.95 days and transplantation of only 75 islets required 12.1 days. Increasing the pore size to increase islet-islet interactions did not significantly impact islet function. The porcine model was used to investigate early islet engraftment. Increasing the islet seeding density led to a greater mass of engrafted islets, though the efficiency of islet survival decreased. Transplantation into the porcine omentum provided greater islet engraftment than the gastric submucosa. These results demonstrate scaffolds support murine islet transplantation with high efficiency, and feasibility studies in large animals support continued pre-clinical studies with scaffolds as a platform to control the transplant microenvironment.

Fibroblast populated collagen matrix promotes islet survival and reduces the number of islets required for diabetes reversal

Islet transplantation represents a viable treatment for type 1 diabetes. However, due to loss of substantial mass of islets early after transplantation, islets from two or more donors are required to achieve insulin independence. Islet-extracellular matrix disengagement, which occurs during islet isolation process, leads to subsequent islet cell apoptosis and is an important contributing factor to early islet loss. In this study, we developed a fibroblast populated collagen matrix (FPCM) as a novel scaffold to improve islet cell viability and function post-transplantation. FPCM was developed by embedding fibroblasts within type-I collagen and used as scaffold for islet grafts. Viability and insulin secretory function of islets embedded within FPCM was evaluated in vitro and in a syngeneic murine islet transplantation model. Islets embedded within acellular matrix or naked islets were used as control. Islet cell survival and function was markedly improved particularly after embedding within FPCM. The composite scaffold significantly promoted islet isograft survival and reduced the critical islet mass required for diabetes reversal by half (from 200 to 100 islets per recipient). Fibroblast embedded within FPCM produced fibronectin and growth factors and induced islet cell proliferation. No evidence of fibroblast over-growth within composite grafts was noticed. These results confirm that FPCM significantly promotes islet viability and functionality, enhances engraftment of islet grafts and decreases the critical islet mass needed to reverse hyperglycemia. This promising finding offers a new approach to reducing the number of islet donors per recipient and improving islet transplant outcome.