1
|
Ma F, Li Y, Zhang Y, Zhang Q, Li X, Cao Q, Ma H, Xie D, Zhang B, Yu J, Li X, Xie Q, Wan G, Guo M, Guo J, Yin J, Liu G. Effects of umami substances as taste enhancers on salt reduction in meat products: A review. Food Res Int 2024; 185:114248. [PMID: 38658067 DOI: 10.1016/j.foodres.2024.114248] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/28/2023] [Revised: 03/13/2024] [Accepted: 03/15/2024] [Indexed: 04/26/2024]
Abstract
Sodium is one of the essential additives in meat processing, but excessive sodium intake may increase risk of hypertension and cardiovascular disease. However, reducing salt content while preserving its preservative effect, organoleptic properties, and technological characteristics poses challenges. In this review, the mechanism of salt reduction of umami substances was introduced from the perspective of gustation-taste interaction, and the effects of the addition of traditional umami substances (amino acids, nucleotides, organic acids(OAs)) and natural umami ingredients (mushrooms, seaweeds, tomatoes, soybeans, tea, grains) on the sensory properties of the meat with reduced-salt contents were summarized. In addition, the impacts of taste enhancers on eating quality (color, sensory, textural characteristics, and water-holding capacity (WHC)), and processing quality (lipid oxidation, pH) of meat products (MP) and their related mechanisms were also discussed. Among them, natural umami ingredients exhibit distinct advantages over traditional umami substances in terms of enhancing quality and nutritional value. On the basis of salt reduction, natural umami ingredients improve the flavor, texture, WHC and antioxidant capacity. This comprehensive review may provide the food industry with a theoretical foundation for mitigating salt consumption through the utilization of umami substances and natural ingredients.
Collapse
Affiliation(s)
- Fang Ma
- School of Food Science and Engineering, Ningxia University, Yinchuan, Ningxia 750021, China
| | - Yang Li
- School of Food Science and Engineering, Ningxia University, Yinchuan, Ningxia 750021, China
| | - Yuanlv Zhang
- School of Food Science and Engineering, Ningxia University, Yinchuan, Ningxia 750021, China
| | - Qian Zhang
- School of Food Science and Engineering, Ningxia University, Yinchuan, Ningxia 750021, China
| | - Xiaoxue Li
- School of Food Science and Engineering, Ningxia University, Yinchuan, Ningxia 750021, China
| | - Qingqing Cao
- School of Food Science and Engineering, Ningxia University, Yinchuan, Ningxia 750021, China
| | - Haiyang Ma
- School of Food Science and Engineering, Ningxia University, Yinchuan, Ningxia 750021, China
| | - Delang Xie
- School of Food Science and Engineering, Ningxia University, Yinchuan, Ningxia 750021, China
| | - Bingbing Zhang
- School of Food Science and Engineering, Ningxia University, Yinchuan, Ningxia 750021, China
| | - Jia Yu
- School of Food Science and Engineering, Ningxia University, Yinchuan, Ningxia 750021, China
| | - Xiaojun Li
- School of Food Science and Engineering, Ningxia University, Yinchuan, Ningxia 750021, China
| | - Qiwen Xie
- School of Food Science and Engineering, Ningxia University, Yinchuan, Ningxia 750021, China
| | - Guoling Wan
- School of Food Science and Engineering, Ningxia University, Yinchuan, Ningxia 750021, China
| | - Mei Guo
- School of Food Science and Engineering, Ningxia University, Yinchuan, Ningxia 750021, China
| | - Jiajun Guo
- School of Food Science and Engineering, Ningxia University, Yinchuan, Ningxia 750021, China
| | - Junjie Yin
- School of Food Science and Engineering, Ningxia University, Yinchuan, Ningxia 750021, China
| | - Guishan Liu
- School of Food Science and Engineering, Ningxia University, Yinchuan, Ningxia 750021, China.
| |
Collapse
|
2
|
Ayimbila F, Keawsompong S. Nutritional Quality and Biological Application of Mushroom Protein as a Novel Protein Alternative. Curr Nutr Rep 2023:10.1007/s13668-023-00468-x. [PMID: 37032416 PMCID: PMC10088739 DOI: 10.1007/s13668-023-00468-x] [Citation(s) in RCA: 5] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Accepted: 03/13/2023] [Indexed: 04/11/2023]
Abstract
PURPOSE OF REVIEW Global concerns about population growth, economic, and nutritional transitions and health have led to the search for a low-cost protein alternative to animal origins. This review provides an overview of the viability of exploring mushroom protein as a future protein alternative considering the nutritional value, quality, digestibility, and biological benefits. RECENT FINDINGS Plant proteins are commonly used as alternatives to animal proteins, but the majority of them are low in quality due to a lack of one or more essential amino acids. Edible mushroom proteins usually have a complete essential amino acid profile, meet dietary requirements, and provide economic advantages over animal and plant sources. Mushroom proteins may provide health advantages by eliciting antioxidant, antitumor, angiotensin-converting enzyme (ACE), inhibitory and antimicrobial properties over animal proteins. Protein concentrates, hydrolysates, and peptides from mushrooms are being used to improve human health. Also, edible mushrooms can be used to fortify traditional food to increase protein value and functional qualities. These characteristics highlight mushroom proteins as inexpensive, high-quality proteins that can be used as a meat alternative, as pharmaceuticals, and as treatments to alleviate malnutrition. Edible mushroom proteins are high in quality, low in cost, widely available, and meet environmental and social requirements, making them suitable as sustainable alternative proteins.
Collapse
Affiliation(s)
- Francis Ayimbila
- Specialized Research Units: Prebiotics and Probiotics for Health, Department of Biotechnology, Faculty of Agro-Industry, Kasetsart University, Bangkok, 10900, Thailand
- Center for Advanced Studies for Agriculture and Food, KU Institute of Advanced Studies, Kasetsart University (CASAF, NRU-KU), Bangkok, 10900, Thailand
| | - Suttipun Keawsompong
- Specialized Research Units: Prebiotics and Probiotics for Health, Department of Biotechnology, Faculty of Agro-Industry, Kasetsart University, Bangkok, 10900, Thailand.
- Center for Advanced Studies for Agriculture and Food, KU Institute of Advanced Studies, Kasetsart University (CASAF, NRU-KU), Bangkok, 10900, Thailand.
| |
Collapse
|
3
|
Physicochemical Characteristics and Storage Stability of Hybrid Beef Patty Using Shiitake Mushroom (Lentinus edodes). J FOOD QUALITY 2023. [DOI: 10.1155/2023/7239709] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 02/09/2023] Open
Abstract
This study evaluated the physicochemical characteristics and storage stability (at 0, 3, and 7 days) of hybrid beef patties with different amount of shiitake mushrooms (Lentinus edodes) added. Shiitake mushrooms contain healthy ingredients such as ergosterol and β-glucan. Four proportions of shiitake mushrooms were added to beef patties (T1, 20%, T2, 40%, T3, 60%, T4, 80%) as a substitute for beef and compared with a control group (CON 0%). Chemical composition, water holding capacity (WHC), cooking loss, pH, color, texture profile analysis, and sensory properties of the products were compared on day 0. As a storage stability experiment, volatile basic nitrogen (VBN), 2-thiobarbituric acid reactive substances (TBARS), and total microbial count were compared (0, 3, and 7 days). The results revealed that replacement with shiitake improved the WHC and cooking loss of patties but had a negative effect on sensory properties and storage stability. These results indicate that shiitake mushrooms can be added along with beef to produce hybrid patties; however, the usage amount must be considered.
Collapse
|
4
|
See Toh CJY, Bi X, Lee HW, Yeo MTY, Henry CJ. Is mushroom polysaccharide extract a better fat replacer than dried mushroom powder for food applications? Front Nutr 2023; 10:1111955. [PMID: 36819704 PMCID: PMC9935597 DOI: 10.3389/fnut.2023.1111955] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/30/2022] [Accepted: 01/16/2023] [Indexed: 02/05/2023] Open
Abstract
Introduction β-glucans found in the cell walls of mushrooms can be a beneficial food additive in replacing fat in commercial food products. Methods Four commonly consumed mushroom species in Singapore, i.e., Pleurotus ostreatus spp., Lentinus edodes, Agaricus bisporus, and Flammulina velutipes were profiled for the β-glucan content in the lyophilized form and ultrasonicated assisted extracted form. Both forms were added into chicken patties, which were characterized for the moisture, cooking loss, texture, color, and chemically analyzed for the protein, crude fat, and fatty acid profiles with gas chromatography mass spectrometry (GC-MS). Results and discussion Pleurotus Ostreatus spp. had the highest β-glucan of 29.8 ± 0.7 g/100 g in the pure powder form and 15.9 ± 0.3 g/100 g from the extract. Crude fat in 100% fat substituted patties was lowest in Flammulina velutipes extract enriched patties and least in A. bisporus pure powder patties. Additionally, fat replacement with A. bisporus extract and powder forms resulted in the highest polyunsaturated fatty acid profile of 49.6 ± 1.9 mg/100 g patty and 79.9 ± 4.5 mg/100 g patty, respectively. Chicken patties with added mushroom extract were notable in retaining moisture, cooking yield and its structure. Fat substitution with mushroom powder was also conducted, satisfactory results indicated a possibility as a better fat replacer that is easily processed and an efficient alternative to β-glucan extract. With increasing demand for low fat foods with acceptable organoleptic properties, our study demonstrates that the inclusion of dry mushroom powder has the ability to mimic the "fattiness" of chicken patties.
Collapse
Affiliation(s)
- Cheryl Jie Yi See Toh
- Clinical Nutrition Research Centre (CNRC), Singapore Institute of Food and Biotechnology Innovation (SIFBI), Agency for Science, Technology and Research (A*STAR), Singapore, Singapore
| | - Xinyan Bi
- Clinical Nutrition Research Centre (CNRC), Singapore Institute of Food and Biotechnology Innovation (SIFBI), Agency for Science, Technology and Research (A*STAR), Singapore, Singapore
| | - Hui Wen Lee
- Clinical Nutrition Research Centre (CNRC), Singapore Institute of Food and Biotechnology Innovation (SIFBI), Agency for Science, Technology and Research (A*STAR), Singapore, Singapore
| | - Michelle Ting Yun Yeo
- Clinical Nutrition Research Centre (CNRC), Singapore Institute of Food and Biotechnology Innovation (SIFBI), Agency for Science, Technology and Research (A*STAR), Singapore, Singapore
| | - Christiani Jeyakumar Henry
- Clinical Nutrition Research Centre (CNRC), Singapore Institute of Food and Biotechnology Innovation (SIFBI), Agency for Science, Technology and Research (A*STAR), Singapore, Singapore,Department of Biochemistry, Yong Loo Lin School of Medicine, National University of Singapore, Singapore, Singapore,*Correspondence: Christiani Jeyakumar Henry,
| |
Collapse
|
5
|
Nan H, Stepanova T, Li B. Effects of Button Mushroom Agaricus bisporus (Agaricomycetes) and Soybean Oil on Storage Characteristics of Chicken Sausage. Int J Med Mushrooms 2023; 25:73-83. [PMID: 37824407 DOI: 10.1615/intjmedmushrooms.2023049470] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/14/2023]
Abstract
To investigate the effect of Agaricus bisporus and soybean oil as complex fat substitutes on the storage characteristics of chicken sausages, a pre-mixture of A. bisporus and soybean oil (1:2) was used to replace 0% (CK), 30% (T30), 60% (T60), and 90% (T90) of pork back fat in chicken sausages. The changes in color (brightness value, L*; redness value, a*; and yellowness value, b*), texture, pH, and total viable count of the sausages were examined at 1, 5, 10, 15, 20, 25, 30 and 35 d of storage at 4°C, respectively. The results showed that A. bisporus and soybean oil altered the color of the sausages. At the same storage time, compared with CK, L* values of fat-reduced chicken sausages decreased significantly, while a* values increased significantly (P < 0.05), b* values increased significantly (P < 0.05) at the 10 d of storage. During storage, L* and a* values of CK gradually decreased and b* values gradually increased, fat-reduced sausages exhibited opposite trends in a* values and b* values compared with CK. The hardness and chewiness of fat-reduced sausages increased significantly (P < 0.05) compared with CK at the same storage time. During storage, the overall hardness of fat-reduced sausages increased, and the springiness and chewiness fluctuated. T60 did not change significantly in cohesiveness throughout the storage period (P < 0.05). The pH of fat-reduced sausage was relatively stable during storage. The higher the amount of A. bisporus added, the greater the pH. The pH of T60 did not change throughout the storage period. A. bisporus and soybean oil showed some antibacterial effect on sausage and the minimum shelf life of chicken sausage with A. bisporus was 25 d. In conclusion, A. bisporus and soybean oil increased the redness and hardness of the sausages during storage, but the pH and total viable bacteria count remained relatively stable. T60 displayed the most stable storage properties among them, making it the optimum method for the manufacturing of fat-reduced chicken sausages.
Collapse
Affiliation(s)
- Haijuan Nan
- School of Food Science, Henan Institute of Science and Technology, Xinxiang City, P.R. China; Food Technologies Faculty, Sumy National Agrarian University, Sumy, Ukraine
| | - Tetiana Stepanova
- Food Technologies Faculty, Sumy National Agrarian University, Sumy, Ukraine
| | - Bo Li
- School of Food Science, Henan Institute of Science and Technology, Xinxiang City, P.R. China
| |
Collapse
|
6
|
Use of Pleurotus ostreatus to Enhance the Oxidative Stability of Pork Patties during Storage and In Vitro Gastrointestinal Digestion. Foods 2022; 11:foods11244075. [PMID: 36553817 PMCID: PMC9778142 DOI: 10.3390/foods11244075] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/21/2022] [Revised: 12/11/2022] [Accepted: 12/14/2022] [Indexed: 12/23/2022] Open
Abstract
Lipid and protein oxidation are the major causes of meat quality deterioration. Edible mushrooms have been proposed as a strategy to prevent quality deterioration during cold storage. This study aimed to assess the effects of Pleurotus ostreatus powder (POP) on the oxidative stability of pork patties during cold storage and after in vitro gastrointestinal digestion (ivGD). Pork patties were subjected to four treatments: control (without antioxidant), T1 (2% POP, w/w) and T2 (5% POP, w/w), and T3 as positive control (0.02% BHT, fat basis). POP aqueous, ethanolic, and aqueous ethanol extract were subjected to phytochemical and antioxidant assays. Raw pork patties were subjected to a chemical proximate composition evaluation. At the same time, raw and cooked pork patties were stored at 2 °C for 9 days and subjected to meat quality measurements. Furthermore, the total antioxidant activity of cooked pork patties was determined after ivGD. Results showed that POP ethanol extract showed the highest polysaccharide, phenol, and flavonoid content, as well as antiradical and reducing power properties. POP incorporation into raw and cooked pork patties enhances meat quality traits, including pH, water-holding capacity, cooking-loss weight, texture, color, lipid, and protein oxidation (p < 0.05). Furthermore, incorporating POP into cooked samples increases the phytochemical content and antioxidant activity during ivGD. In conclusion, POP has great potential as a natural antioxidant for meat products.
Collapse
|
7
|
Pachekrepapol U, Thangrattana M, Kitikangsadan A. Impact of oyster mushroom (Pleurotus ostreatus) on chemical, physical, microbiological and sensory characteristics of fish burger prepared from salmon and striped catfish filleting by-product. Int J Gastron Food Sci 2022. [DOI: 10.1016/j.ijgfs.2022.100598] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Submit a Manuscript] [Subscribe] [Scholar Register] [Indexed: 10/14/2022]
|
8
|
Jadeja R, Teng XM, Mohan A, Duggirala K. Value-Added Utilization of Beef Byproducts and Low-Value Comminuted Beef: Challenges and Opportunities. Curr Opin Food Sci 2022. [DOI: 10.1016/j.cofs.2022.100938] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/03/2022]
|
9
|
Zhao Y, Wang Y, Li K, Mazurenko I. Effect of Oudemansiella raphanipies Powder on Physicochemical and Textural Properties, Water Distribution and Protein Conformation of Lower-Fat Pork Meat Batter. Foods 2022; 11:foods11172623. [PMID: 36076809 PMCID: PMC9455643 DOI: 10.3390/foods11172623] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/31/2022] [Revised: 08/17/2022] [Accepted: 08/25/2022] [Indexed: 12/05/2022] Open
Abstract
The effects of the addition of different amounts (0%, 1%, 2%, 3% and 4%) of Oudemansiella raphanipies powder (ORP) to lower-fat pork batter on its physicochemical, textural and rheological properties, water distribution and protein conformation were evaluated. The results showed that the addition of ORP from 0% to 4% significantly decreased the pH and L* value of pork batter (p < 0.05); however, it also increased the a* value and enhanced the cooking yield of pork batter from 77% to 92%. Pork batter with 1−2% ORP added had an improved texture profile and a higher storage modulus (G’), but the addition of 3−4% ORP resulted in an inferior texture of pork batter and G’. LF-NMR showed that the addition of ORP significantly increased the peak area ratio of immobile water and reduced the peak area ratio of free water (p < 0.05). ORP significantly affected protein secondary structure of pork batter. The α-helix content of pork batter with 1−2% ORP decreased and β-sheet content increased. Overall, the addition level of 1−2% ORP effectively improved the texture and water holding capacity of lower-fat emulsified sausage and provides a new reference for developing nutritional meat products.
Collapse
Affiliation(s)
- Yingying Zhao
- College of Food and Bioengineering, Zhengzhou University of Light Industry, Zhengzhou 450001, China
| | - Yanqiu Wang
- College of Food and Bioengineering, Zhengzhou University of Light Industry, Zhengzhou 450001, China
| | - Ke Li
- College of Food and Bioengineering, Zhengzhou University of Light Industry, Zhengzhou 450001, China
- Correspondence: ; Tel.: +86-187-3606-7558
| | - Igor Mazurenko
- Department of Food Technology, Sumy National Agrarian University, 40021 Sumy, Ukraine
- School of Agriculture and Biotechnology, Hunan University of Humanities, Science and Technology (HUHST), Loudi 417000, China
| |
Collapse
|
10
|
Santos EM, Rodriguez JA, Lorenzo JM, Mondragón AC, Pateiro M, Gutiérrez E, Ferreira TA. Antioxidant Effect of Pumpkin Flower (Cucurbita maxima) in Chicken Patties. Foods 2022; 11:foods11152258. [PMID: 35954026 PMCID: PMC9368278 DOI: 10.3390/foods11152258] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/01/2022] [Revised: 07/21/2022] [Accepted: 07/23/2022] [Indexed: 12/04/2022] Open
Abstract
In this work, the antioxidant effect of pumpkin flower powder was evaluated in chicken patties. For this purpose, three drying methods were proposed to obtain the pumpkin flower powder and preserve its properties (antioxidants, color, odor): foam-mat drying, freeze drying, and oven drying. The drying process of the powder plays an important role in the conservation of bioactive compounds. The foam-mat drying method would allow the preservation of these compounds after cooking and after cold storage due to encapsulation like mechanism of the added proteins. Thus, these powders were selected as the most adequate vehicle to incorporate in the formulation, since patties with these additives presented the better antioxidant scores for DPPH, ABTS, and FRAP even after 7 days of storage. In addition, total polyphenolic content and the presence or thiobarbituric acid reactive substances (TBARS) were better scored in samples with the pumpkin flowers. The incorporation of the pumpkin flower additives in the patty formulation improved sensorial attributes of the chicken patties and consumers acceptance after cold storage.
Collapse
Affiliation(s)
- Eva María Santos
- Área Académica de Química, Universidad Autónoma del Estado de Hidalgo, Carr. Pachuca-Tulancingo Km. 4.5, Mineral de la Reforma 42184, Mexico; (E.M.S.); (J.A.R.)
| | - Jose A. Rodriguez
- Área Académica de Química, Universidad Autónoma del Estado de Hidalgo, Carr. Pachuca-Tulancingo Km. 4.5, Mineral de la Reforma 42184, Mexico; (E.M.S.); (J.A.R.)
| | - Jose M. Lorenzo
- Centro Tecnológico de la Carne de Galicia, Rúa Galicia n° 4, Parque Tecnológico de Galicia, San Cibrao das Viñas, 32900 Ourense, Spain; (J.M.L.); (M.P.)
- Área de Tecnología de los Alimentos, Facultad de Ciencias de Ourense, Universidad de Vigo, 32004 Ourense, Spain
| | - Alicia C. Mondragón
- Laboratorio de Higiene Inspeccion y Control de Alimentos, Departamento de Quimica Analitica Nutricion y Bromatologia, Universidad de Santiago de Compostela, 27002 Lugo, Spain;
| | - Mirian Pateiro
- Centro Tecnológico de la Carne de Galicia, Rúa Galicia n° 4, Parque Tecnológico de Galicia, San Cibrao das Viñas, 32900 Ourense, Spain; (J.M.L.); (M.P.)
| | - Evelin Gutiérrez
- Departamento de Ingenieria Mecatronica, Universidad Politécnica de Pachuca, Ex. Hacienda Sta. Barbara, Zempoala 43830, Mexico;
| | - Thania Alexandra Ferreira
- Área Académica de Química, Universidad Autónoma del Estado de Hidalgo, Carr. Pachuca-Tulancingo Km. 4.5, Mineral de la Reforma 42184, Mexico; (E.M.S.); (J.A.R.)
- Correspondence:
| |
Collapse
|
11
|
Go HY, Lee SH, Kim HY. The Effect of Hot-Air Dried Lentinula edodes on the Quality and Oranoleptic Properties of Rolled-Dumplings. Food Sci Anim Resour 2022; 42:593-608. [PMID: 35855265 PMCID: PMC9289801 DOI: 10.5851/kosfa.2022.e24] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/28/2022] [Revised: 04/29/2022] [Accepted: 05/09/2022] [Indexed: 11/14/2022] Open
Abstract
The effect of hot-air dried Lentinula edodes pileus (DLE) on the quality and organoleptic properties of rolled-dumplings was evaluated. DLE was prepared by drying at 60°C for 24 h and added (Non, 7%, and 9%) to rolled-dumplings. The proximate composition, pH, color (CIE L*, a*, b*), and cooking yield were analyzed. Texture profile analysis, electronic-nose (e-nose), electronic-tongue (e-tongue), and organoleptic evaluation were also conducted. The cooking yield of dumplings with 9% DLE was significantly lower than that of the congeners without DLE, whereas 7% DLE did not lead to significant differences compared without DLE. With increasing DLE addition, the pH and lightness of the dumplings decreased significantly, whereas the redness tended to increase. The texture profile was significantly higher for the dumplings with DLE compared to those without DLE. E-nose analysis confirmed that DLE addition led to the positive odors (methanethiol: meaty, sulfurous; 3-methylbutanal: malty, toasted) and the negative odors (trimethylamine: ammoniacal; acetic acid: acidic, sour). E-tongue analysis showed that DLE addition decreased the intensity of the sourness and increased the intensity of the saltiness and umami of rolled-dumplings. DLE addition improved the overall organoleptic properties, but 9% DLE can be recognized as a foreign substance in organoleptic acceptance. Consequently, DLE has the potential to serve as a flavor and odor enhancer for rolled-dumplings, and the addition of DLE can positively improve consumer acceptance by improving the quality and organoleptic properties.
Collapse
Affiliation(s)
- Ha-Yoon Go
- Department of Animal Resources Science, Kongju National University, Yesan 32439, Korea
| | - Sol-Hee Lee
- Department of Animal Resources Science, Kongju National University, Yesan 32439, Korea
| | - Hack-Youn Kim
- Department of Animal Resources Science, Kongju National University, Yesan 32439, Korea
| |
Collapse
|
12
|
Campagnol PCB, Lorenzo JM, Dos Santos BA, Cichoski AJ. Recent advances in the development of healthier meat products. ADVANCES IN FOOD AND NUTRITION RESEARCH 2022; 102:123-179. [PMID: 36064292 DOI: 10.1016/bs.afnr.2022.04.009] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 02/07/2023]
Abstract
Meat products are an excellent source of high biological value proteins, in addition to the high content of minerals, vitamins, and bioactive compounds. However, meat products contain compounds that can cause a variety of adverse health effects and pose a serious health threat to humans. In this sense, this chapter will address recent strategies to assist in the development of healthier meat products. The main advances about the reduction of sodium and animal fat in meat products will be presented. In addition, strategies to make the lipid profile of meat products more nutritionally advantageous for human health will also be discussed. Finally, the reduction of substances of safety concern in meat products will be addressed, including phosphates, nitrites, polycyclic aromatic hydrocarbons, heterocyclic aromatic amines, as well as products from lipid and protein oxidation.
Collapse
Affiliation(s)
| | - José Manuel Lorenzo
- Centro Tecnológico de la Carne de Galicia, Parque Tecnológico de Galicia, Ourense, Spain; Universidad de Vigo, Área de Tecnología de los Alimentos, Facultad de Ciencias de Ourense, Ourense, Spain
| | | | | |
Collapse
|
13
|
Textural, Sensory and Volatile Compounds Analyses in Formulations of Sausages Analogue Elaborated with Edible Mushrooms and Soy Protein Isolate as Meat Substitute. Foods 2021; 11:foods11010052. [PMID: 35010178 PMCID: PMC8750815 DOI: 10.3390/foods11010052] [Citation(s) in RCA: 19] [Impact Index Per Article: 6.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/02/2021] [Revised: 12/21/2021] [Accepted: 12/22/2021] [Indexed: 11/17/2022] Open
Abstract
In this study, edible mushroom and soybean protein isolate (SPI) were used to prepare a fibrous meat analogue using thermos-extrusion and the extruded mushroom-based meat analogue as meat replacer was further developed with different formulations in fabricating sausage analogues. The effect of water content (35%, 70% and 100%), three types of edible mushroom (Lentinus edodes, Pleurotus ostreatus, Coprinus comatus and a mixture of equal proportions) and their amounts (from 15% to 100%) on the physicochemical and structural profiles were studied. The results showed that the extruded mushroom-based meat analogue prepared from Coprinus comatus (15% addition) and SPI with a water content of 35% exhibited close textural profiles to real beef. Furthermore, a texture profile analysis (TPA) combined with a principal component analysis (PCA) was conducted to compare and assess the textural traits of the sausage analogues with similar commercial products. The characterization and comparison of the flavor profile of post-processing mushroom-based meat sausage analogues (MMSA) were performed using headspace-phase microextraction (HS-SPME), coupled with gas chromatography-mass spectrometry (GC-MS). A total of 64 volatile compounds were identified, and the content in dried-processing treatment was significantly higher than for steamed-processing, which indicated that the natural fermentation process contributed to the increase in aroma substances in the non-animal sourced sausage. This study developed a feasible method to fabricate a meat replacement and to create high added-value products, which offer an opportunity for developing non-animal products with satisfactory sensory properties and flavor profiles.
Collapse
|
14
|
Cerón‐Guevara MI, Santos EM, Lorenzo JM, Pateiro M, Bermúdez‐Piedra R, Rodríguez JA, Castro‐Rosas J, Rangel‐Vargas E. Partial replacement of fat and salt in liver pâté by addition of
Agaricus bisporus
and
Pleurotus ostreatus
flour. Int J Food Sci Technol 2021. [DOI: 10.1111/ijfs.15076] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/17/2022]
Affiliation(s)
- Magdalena I. Cerón‐Guevara
- Área Académica de Química Universidad Autónoma del Estado de Hidalgo Carr. Pachuca‐Tulancingo Km 4.5 s/n, Col. Carboneras, Mineral de la Reforma Hidalgo 42183 Mexico
| | - Eva M. Santos
- Área Académica de Química Universidad Autónoma del Estado de Hidalgo Carr. Pachuca‐Tulancingo Km 4.5 s/n, Col. Carboneras, Mineral de la Reforma Hidalgo 42183 Mexico
| | - José M. Lorenzo
- Meat Technology Centre of Galicia Rúa Galicia N° 4, Parque Tecnológico de Galicia, San Cibrao das Viñas Ourense 32900 Spain
- Área de Tecnología de los Alimentos Facultad de Ciencias de Ourense Universidad de Vigo Ourense 32004 Spain
| | - Mirian Pateiro
- Meat Technology Centre of Galicia Rúa Galicia N° 4, Parque Tecnológico de Galicia, San Cibrao das Viñas Ourense 32900 Spain
| | - Roberto Bermúdez‐Piedra
- Meat Technology Centre of Galicia Rúa Galicia N° 4, Parque Tecnológico de Galicia, San Cibrao das Viñas Ourense 32900 Spain
| | - José A. Rodríguez
- Área Académica de Química Universidad Autónoma del Estado de Hidalgo Carr. Pachuca‐Tulancingo Km 4.5 s/n, Col. Carboneras, Mineral de la Reforma Hidalgo 42183 Mexico
| | - Javier Castro‐Rosas
- Área Académica de Química Universidad Autónoma del Estado de Hidalgo Carr. Pachuca‐Tulancingo Km 4.5 s/n, Col. Carboneras, Mineral de la Reforma Hidalgo 42183 Mexico
| | - Esmeralda Rangel‐Vargas
- Área Académica de Química Universidad Autónoma del Estado de Hidalgo Carr. Pachuca‐Tulancingo Km 4.5 s/n, Col. Carboneras, Mineral de la Reforma Hidalgo 42183 Mexico
| |
Collapse
|
15
|
Yuan X, Zhu X, Sun R, Jiang W, Zhang D, Liu H, Sun B. Sensory attributes and characterization of aroma profiles of fermented sausages based on fibrous-like meat substitute from soybean protein and Coprinus comatus. Food Chem 2021; 373:131537. [PMID: 34776312 DOI: 10.1016/j.foodchem.2021.131537] [Citation(s) in RCA: 9] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/23/2021] [Revised: 10/18/2021] [Accepted: 11/04/2021] [Indexed: 01/03/2023]
Abstract
Plant-based meat substitutes are emerging as healthy, balanced, and sustainable non-animal alternatives to alleviate stress from the increased demand for meat products. In this study, fibrous-like extrudates acting as meat substitutes were manufactured from soybean protein and Coprinus comatus by thermos-extrusion and fermentation processing improved the meat-like physicochemical and textural properties, taste, and flavor of products. The fermentation period was greatly shortened than animal meat-based fermented sausage. For comparison reasons, the aroma profiles of meat substitute fermented sausages (MS-FS), fermented sausages without curing (MS-NCFS) and natural fermented sausages (MS-NFS) were systemically analyzed by headspace solid phase microextraction-gas chromatography-mass spectrometry (HS-SPME-GC-MS). A total of 156 volatile compounds were identified, and the curing and fermenting process contributed to the increased contents of volatile compounds greatly. Moreover, the MS-FS without curing evaded undesired off-flavors like grass and bean flavor from 1-octen-3-ol. Sensory evaluation was also showed higher scores for MS-FS than other processing.
Collapse
Affiliation(s)
- Xinyue Yuan
- Beijing Advanced Innovation Center for Food Nutrition and Human Health, Beijing Engineering and Technology Research Center of Food Additives, Beijing Technology and Business University, 11 Fucheng Road, Beijing 100048, China
| | - Xuecheng Zhu
- Beijing Advanced Innovation Center for Food Nutrition and Human Health, Beijing Engineering and Technology Research Center of Food Additives, Beijing Technology and Business University, 11 Fucheng Road, Beijing 100048, China
| | - Ruohao Sun
- Beijing Advanced Innovation Center for Food Nutrition and Human Health, Beijing Engineering and Technology Research Center of Food Additives, Beijing Technology and Business University, 11 Fucheng Road, Beijing 100048, China
| | - Wei Jiang
- Beijing Advanced Innovation Center for Food Nutrition and Human Health, Beijing Engineering and Technology Research Center of Food Additives, Beijing Technology and Business University, 11 Fucheng Road, Beijing 100048, China
| | - Dianwei Zhang
- Beijing Advanced Innovation Center for Food Nutrition and Human Health, Beijing Engineering and Technology Research Center of Food Additives, Beijing Technology and Business University, 11 Fucheng Road, Beijing 100048, China.
| | - Huilin Liu
- Beijing Advanced Innovation Center for Food Nutrition and Human Health, Beijing Engineering and Technology Research Center of Food Additives, Beijing Technology and Business University, 11 Fucheng Road, Beijing 100048, China.
| | - Baoguo Sun
- Beijing Advanced Innovation Center for Food Nutrition and Human Health, Beijing Engineering and Technology Research Center of Food Additives, Beijing Technology and Business University, 11 Fucheng Road, Beijing 100048, China
| |
Collapse
|
16
|
Rangel-Vargas E, Rodriguez JA, Domínguez R, Lorenzo JM, Sosa ME, Andrés SC, Rosmini M, Pérez-Alvarez JA, Teixeira A, Santos EM. Edible Mushrooms as a Natural Source of Food Ingredient/Additive Replacer. Foods 2021; 10:2687. [PMID: 34828969 PMCID: PMC8624290 DOI: 10.3390/foods10112687] [Citation(s) in RCA: 24] [Impact Index Per Article: 8.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/22/2021] [Revised: 10/27/2021] [Accepted: 10/29/2021] [Indexed: 11/23/2022] Open
Abstract
Although mushrooms have been exploited since ancient times because of their particular taste and therapeutic properties, the interest in edible species as a source of ingredients and bioactive compounds is recent. Their valuable nutritional contents in protein, dietary fiber and bioactive compounds make them ideal candidates for use in foods in efforts to improve their nutritional profiles. This trend is in line with the consumer's growing demand for more plant-based foods. The present review paper explores different studies focused on the use of common edible mushrooms as an ingredient and additive replacer by using them in fresh, dried, or even extract forms, as meat, fat, flour, salt, phosphates, and antioxidant replacers. The replacement of meat, fat, flour, and salt by mushrooms from commercial species has been successful despite sensorial and textural parameters can be affected. Moderate concentrations of mushrooms, especially in powder form, should be considered, particularly in non-familiarized consumers. In the case of antioxidant and antimicrobial properties, results are variable, and more studies are necessary to determine the chemical aspects involved.
Collapse
Affiliation(s)
- Esmeralda Rangel-Vargas
- Área Académica de Química, Universidad Autónoma del Estado de Hidalgo, Ctra. Pachuca-Tulancingo Km 4.5 s/n, Col. Carboneras, Mineral de la Reforma 42183, Hidalgo, Mexico; (E.R.-V.); (J.A.R.)
| | - Jose Antonio Rodriguez
- Área Académica de Química, Universidad Autónoma del Estado de Hidalgo, Ctra. Pachuca-Tulancingo Km 4.5 s/n, Col. Carboneras, Mineral de la Reforma 42183, Hidalgo, Mexico; (E.R.-V.); (J.A.R.)
| | - Rubén Domínguez
- Centro Tecnológico de la Carne de Galicia, Rúa Galicia n° 4, Parque Tecnológico de Galicia, San Cibrao das Viñas, 32900 Ourense, Spain;
| | - José Manuel Lorenzo
- Centro Tecnológico de la Carne de Galicia, Rúa Galicia n° 4, Parque Tecnológico de Galicia, San Cibrao das Viñas, 32900 Ourense, Spain;
- Área de Tecnología de los Alimentos, Facultad de Ciencias de Ourense, Universidad de Vigo, 32004 Ourense, Spain
| | - Maria Elena Sosa
- Departamento de Alimentos, Campus Irapuato-Salamanca, Universidad de Guanajuato, Ex-Hacienda El Copal, Carretera Irapuato-Silao km 9, Irapuato 36500, Guanajuato, Mexico;
| | - Silvina Cecilia Andrés
- Centro de Investigación y Desarrollo en Criotecnología de Alimentos (CIDCA, CONICET-CICPBA-UNLP), Facultad de Ciencias Exactas, UNLP, 47 y 116, La Plata 1900, Argentina;
| | - Marcelo Rosmini
- Department of Public Health, Faculty of Veterinary Science, National University of Litoral, Esperanza 3080, Argentina;
| | - José Angel Pérez-Alvarez
- IPOA Research Group, Agro-Food Technology Department, Orihuela Polytechnical High School, Environmental and Agrofood Research Centre for Research and Innovation (CIAGRO), Universidad Miguel Hernández de Elche, 03312 Orihuela, Alicante, Spain;
| | - Alfredo Teixeira
- Centro de Investigação de Montanha (CIMO), Instituto Politécnico de Bragança, Campus de Santa Apolónia, 5300-253 Bragança, Portugal;
| | - Eva María Santos
- Área Académica de Química, Universidad Autónoma del Estado de Hidalgo, Ctra. Pachuca-Tulancingo Km 4.5 s/n, Col. Carboneras, Mineral de la Reforma 42183, Hidalgo, Mexico; (E.R.-V.); (J.A.R.)
| |
Collapse
|
17
|
Saldaña E, Merlo TC, Patinho I, Rios-Mera JD, Contreras-Castillo CJ, Selani MM. Use of sensory science for the development of healthier processed meat products: a critical opinion. Curr Opin Food Sci 2021. [DOI: 10.1016/j.cofs.2020.04.012] [Citation(s) in RCA: 26] [Impact Index Per Article: 8.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/15/2022]
|
18
|
Pateiro M, Domínguez R, Lorenzo JM. Recent Research Advances in Meat Products. Foods 2021; 10:1303. [PMID: 34200135 PMCID: PMC8230034 DOI: 10.3390/foods10061303] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.7] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/25/2021] [Accepted: 06/01/2021] [Indexed: 12/20/2022] Open
Abstract
Recent trends in meat products have their origin in the new needs of consumers that are related to nutrition, health concerns, well-being and natural products [...].
Collapse
Affiliation(s)
- Mirian Pateiro
- Centro Tecnológico de la Carne de Galicia, Parque Tecnológico de Galicia, rúa Galicia No. 4, San Cibrao das Viñas, 32900 Ourense, Spain; (R.D.); (J.M.L.)
| | - Rubén Domínguez
- Centro Tecnológico de la Carne de Galicia, Parque Tecnológico de Galicia, rúa Galicia No. 4, San Cibrao das Viñas, 32900 Ourense, Spain; (R.D.); (J.M.L.)
| | - José M. Lorenzo
- Centro Tecnológico de la Carne de Galicia, Parque Tecnológico de Galicia, rúa Galicia No. 4, San Cibrao das Viñas, 32900 Ourense, Spain; (R.D.); (J.M.L.)
- Área de Tecnología de los Alimentos, Facultad de Ciencias de Ourense, Universidad de Vigo, 32004 Ourense, Spain
| |
Collapse
|
19
|
Effects of Adding Moringa oleifera Leaves Powder on the Nutritional Properties, Lipid Oxidation and Microbial Growth in Ground Beef during Cold Storage. APPLIED SCIENCES-BASEL 2021. [DOI: 10.3390/app11072944] [Citation(s) in RCA: 9] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 01/26/2023]
Abstract
The utilisation of Moringa oleifera leaves powder (MOLP) to improve the nutritional properties and inhibit lipid oxidation and the proliferation of microorganisms in ground beef during cold storage was examined. The effects of 0.2, 0.4, 0.6, and 0.8% MOLP on the nutritional properties (proximate composition, total phenolic and total flavonoid content), thiobarbituric acid reactive substances (TBARS), microbial composition, physicochemical characteristics (pH value, colour attributes, and cooking properties), and sensory analysis of ground beef were investigated. The findings showed that ash, protein, polyphenolic compounds, pH, colour, and microbial growth increased significantly, while moisture, fat content, and TBARS decreased significantly, with an increase in the concentration of MOLP during cold storage. Moderate levels (0.2 and 0.4%) of MOLP did not affect the sensory attributes of stored ground beef. Evidently, MOLP can be utilised as a natural preservative in ground beef to improve the nutritional value and inhibit lipid oxidation.
Collapse
|
20
|
Pérez-Montes A, Rangel-Vargas E, Lorenzo JM, Romero L, Santos EM. Edible mushrooms as a novel trend in the development of healthier meat products. Curr Opin Food Sci 2021. [DOI: 10.1016/j.cofs.2020.10.004] [Citation(s) in RCA: 11] [Impact Index Per Article: 3.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 02/07/2023]
|
21
|
Doğan N, Doğan C, Çam M, Hayoğlu İ. Optimization and comparison of three cooking methods for wheat flour‐oyster mushroom (
P. ostreatus
) powder composite chips. J FOOD PROCESS PRES 2020. [DOI: 10.1111/jfpp.14873] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/01/2022]
Affiliation(s)
- Nurcan Doğan
- Department of Food Technology Bogazliyan Vocational High SchoolBozok University Yozgat Turkey
| | - Cemhan Doğan
- Department of Food Technology Bogazliyan Vocational High SchoolBozok University Yozgat Turkey
| | - Mustafa Çam
- Department of Food Engineering Faculty of Engineering Erciyes University Kayseri Turkey
| | - İbrahim Hayoğlu
- Department of Food Engineering Faculty of Engineering Harran University Sanliurfa Turkey
| |
Collapse
|
22
|
Reduction of Salt and Fat in Frankfurter Sausages by Addition of Agaricus bisporus and Pleurotus ostreatus Flour. Foods 2020; 9:foods9060760. [PMID: 32526952 PMCID: PMC7353507 DOI: 10.3390/foods9060760] [Citation(s) in RCA: 22] [Impact Index Per Article: 5.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/12/2020] [Revised: 05/29/2020] [Accepted: 06/01/2020] [Indexed: 11/16/2022] Open
Abstract
The reduction of fat and salt and the incorporation of fiber-rich compounds in frankfurters is a trend to improve their nutritional profile. The objective of this study was to evaluate the partial replacement of 30 and 50% of pork backfat and 50% of salt by adding edible mushroom flour (2.5 and 5%) from Agaricus bisporus (Ab) and Pleurotus ostreatus (Po) on physicochemical, microbiological and sensory properties of frankfurters sausages during cold storage. The addition of flours increased the moisture, and the dietary fiber contents in frankfurters, keeping the amino acid profile. Lipid oxidation remained under acceptable values despite not antioxidant effect was observed by mushrooms flours. Only spore-forming bacteria were found during cold storage. Color and texture was modified by addition of mushroom, being the Ab samples darker, while Po flour addition resulted in softer and less cohesive sausages. Although lower color, flavor, and taste scores were given to the mushroom samples than the control, they ranked in the acceptable level confirming that the inclusion of 2.5 and 5% of Ab and Po flours in fat- and salt-reduced frankfurter sausages resulted a feasible strategy to enhance the nutritional profile these products.
Collapse
|
23
|
Application of Enoki Mushroom ( Flammulina Velutipes) Stem Wastes as Functional Ingredients in Goat Meat Nuggets. Foods 2020; 9:foods9040432. [PMID: 32260391 PMCID: PMC7231162 DOI: 10.3390/foods9040432] [Citation(s) in RCA: 26] [Impact Index Per Article: 6.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/04/2020] [Revised: 03/30/2020] [Accepted: 04/02/2020] [Indexed: 01/07/2023] Open
Abstract
The impact of different amounts (2%, 4% and 6%) of enoki (Flammulina velutipes) mushroom stem waste (MSW) powder on the physicochemical quality, color and textural, oxidative stability, sensory attributes and shelf-life of goat meat nuggets was evaluated. These mushroom by-products (MSW powder) contained a good source of protein (13.5%), ash (8.2%), total phenolics content (6.3 mg GAE/g), and dietary fiber (32.3%) and also exhibited the potential to be strong antioxidants, due to their good metal chelating ability (41.3%), reducing power (60.1%), and free radical scavenging activity (84.2%). Mushroom stem waste improved (p < 0.05) the emulsion stability, dietary fiber, ash and phenolics content of nuggets compared to control. Although no significant differences (p > 0.05) in expressible water and textural properties were observed among the formulations, but MSW powder improved the water holding capacity and slightly decreased the hardness. Further, the inclusion of MSW significantly (p < 0.05) improved the oxidative stability and shelf-life of treated nuggets by reducing lipid oxidation during the nine-day storage period. Again, the inclusion of MSW did not negatively affect the color and sensory attributes of treated meat nuggets. Overall, our results suggest that enoki mushroom stem waste (4%) can be used as a value-added functional ingredient to produce nutritionally improved and healthier meat products.
Collapse
|