1
|
Krska D, Mazurkewich S, Brown HA, Theibich Y, Poulsen JCN, Morris AL, Koropatkin NM, Lo Leggio L, Larsbrink J. Structural and Functional Analysis of a Multimodular Hyperthermostable Xylanase-Glucuronoyl Esterase from Caldicellulosiruptor kristjansonii. Biochemistry 2021; 60:2206-2220. [PMID: 34180241 PMCID: PMC8280721 DOI: 10.1021/acs.biochem.1c00305] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/28/2022]
Abstract
![]()
The hyperthermophilic bacterium Caldicellulosiruptor kristjansonii encodes an unusual enzyme, CkXyn10C-GE15A, which
incorporates two catalytic domains, a xylanase and a glucuronoyl esterase,
and five carbohydrate-binding modules (CBMs) from families 9 and 22.
The xylanase and glucuronoyl esterase catalytic domains were recently
biochemically characterized, as was the ability of the individual
CBMs to bind insoluble polysaccharides. Here, we further probed the
abilities of the different CBMs from CkXyn10C-GE15A
to bind to soluble poly- and oligosaccharides using affinity gel electrophoresis,
isothermal titration calorimetry, and differential scanning fluorimetry.
The results revealed additional binding properties of the proteins
compared to the former studies on insoluble polysaccharides. Collectively,
the results show that all five CBMs have their own distinct binding
preferences and appear to complement each other and the catalytic
domains in targeting complex cell wall polysaccharides. Additionally,
through renewed efforts, we have achieved partial structural characterization
of this complex multidomain protein. We have determined the structures
of the third CBM9 domain (CBM9.3) and the glucuronoyl esterase (GE15A)
by X-ray crystallography. CBM9.3 is the second CBM9 structure determined
to date and was shown to bind oligosaccharide ligands at the same
site but in a different binding mode compared to that of the previously
determined CBM9 structure from Thermotoga maritima. GE15A represents a unique intermediate between reported fungal
and bacterial glucuronoyl esterase structures as it lacks two inserted
loop regions typical of bacterial enzymes and a third loop has an
atypical structure. We also report small-angle X-ray scattering measurements
of the N-terminal CBM22.1–CBM22.2–Xyn10C construct,
indicating a compact arrangement at room temperature.
Collapse
Affiliation(s)
- Daniel Krska
- Division of Industrial Biotechnology, Department of Biology and Biological Engineering, Chalmers University of Technology, SE-412 96 Gothenburg, Sweden
| | - Scott Mazurkewich
- Division of Industrial Biotechnology, Department of Biology and Biological Engineering, Chalmers University of Technology, SE-412 96 Gothenburg, Sweden.,Wallenberg Wood Science Center, Chalmers University of Technology, SE-412 96 Gothenburg, Sweden
| | - Haley A Brown
- Department of Microbiology and Immunology, University of Michigan Medical School, Ann Arbor, Michigan 48109, United States
| | - Yusuf Theibich
- Department of Chemistry, University of Copenhagen, DK-2100 Copenhagen, Denmark
| | | | - Adeline L Morris
- Department of Microbiology and Immunology, University of Michigan Medical School, Ann Arbor, Michigan 48109, United States
| | - Nicole M Koropatkin
- Department of Microbiology and Immunology, University of Michigan Medical School, Ann Arbor, Michigan 48109, United States
| | - Leila Lo Leggio
- Department of Chemistry, University of Copenhagen, DK-2100 Copenhagen, Denmark
| | - Johan Larsbrink
- Division of Industrial Biotechnology, Department of Biology and Biological Engineering, Chalmers University of Technology, SE-412 96 Gothenburg, Sweden.,Wallenberg Wood Science Center, Chalmers University of Technology, SE-412 96 Gothenburg, Sweden
| |
Collapse
|
2
|
Østby H, Hansen LD, Horn SJ, Eijsink VGH, Várnai A. Enzymatic processing of lignocellulosic biomass: principles, recent advances and perspectives. J Ind Microbiol Biotechnol 2020; 47:623-657. [PMID: 32840713 PMCID: PMC7658087 DOI: 10.1007/s10295-020-02301-8] [Citation(s) in RCA: 63] [Impact Index Per Article: 15.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/30/2020] [Accepted: 07/30/2020] [Indexed: 02/06/2023]
Abstract
Efficient saccharification of lignocellulosic biomass requires concerted development of a pretreatment method, an enzyme cocktail and an enzymatic process, all of which are adapted to the feedstock. Recent years have shown great progress in most aspects of the overall process. In particular, increased insights into the contributions of a wide variety of cellulolytic and hemicellulolytic enzymes have improved the enzymatic processing step and brought down costs. Here, we review major pretreatment technologies and different enzyme process setups and present an in-depth discussion of the various enzyme types that are currently in use. We pay ample attention to the role of the recently discovered lytic polysaccharide monooxygenases (LPMOs), which have led to renewed interest in the role of redox enzyme systems in lignocellulose processing. Better understanding of the interplay between the various enzyme types, as they may occur in a commercial enzyme cocktail, is likely key to further process improvements.
Collapse
Affiliation(s)
- Heidi Østby
- Faculty of Chemistry, Biotechnology and Food Science, Norwegian University of Life Sciences (NMBU), P.O. Box 5003, 1432, Aas, Norway
| | - Line Degn Hansen
- Faculty of Chemistry, Biotechnology and Food Science, Norwegian University of Life Sciences (NMBU), P.O. Box 5003, 1432, Aas, Norway
| | - Svein J Horn
- Faculty of Chemistry, Biotechnology and Food Science, Norwegian University of Life Sciences (NMBU), P.O. Box 5003, 1432, Aas, Norway
| | - Vincent G H Eijsink
- Faculty of Chemistry, Biotechnology and Food Science, Norwegian University of Life Sciences (NMBU), P.O. Box 5003, 1432, Aas, Norway
| | - Anikó Várnai
- Faculty of Chemistry, Biotechnology and Food Science, Norwegian University of Life Sciences (NMBU), P.O. Box 5003, 1432, Aas, Norway.
| |
Collapse
|
3
|
Christensen SJ, Badino SF, Cavaleiro AM, Borch K, Westh P. Functional analysis of chimeric TrCel6A enzymes with different carbohydrate binding modules. Protein Eng Des Sel 2020; 32:401-409. [PMID: 32100026 DOI: 10.1093/protein/gzaa003] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/15/2019] [Revised: 01/10/2019] [Accepted: 01/13/2019] [Indexed: 11/14/2022] Open
Abstract
The glycoside hydrolase (GH) family 6 is an important group of enzymes that constitute an essential part of industrial enzyme cocktails used to convert lignocellulose into fermentable sugars. In nature, enzymes from this family often have a carbohydrate binding module (CBM) from the CBM family 1. These modules are known to promote adsorption to the cellulose surface and influence enzymatic activity. Here, we have investigated the functional diversity of CBMs found within the GH6 family. This was done by constructing five chimeric enzymes based on the model enzyme, TrCel6A, from the soft-rot fungus Trichoderma reesei. The natural CBM of this enzyme was exchanged with CBMs from other GH6 enzymes originating from different cellulose degrading fungi. The chimeric enzymes were expressed in the same host and investigated in adsorption and quasi-steady-state kinetic experiments. Our results quantified functional differences of these phylogenetically distant binding modules. Thus, the partitioning coefficient for substrate binding varied 4-fold, while the maximal turnover (kcat) showed a 2-fold difference. The wild-type enzyme showed the highest cellulose affinity on all tested substrates and the highest catalytic turnover. The CBM from Serendipita indica strongly promoted the enzyme's ability to form productive complexes with sites on the substrate surface but showed lower turnover of the complex. We conclude that the CBM plays an important role for the functional differences between GH6 wild-type enzymes.
Collapse
Affiliation(s)
- Stefan Jarl Christensen
- Research Unit for Functional Biomaterials, Department of Science and Environment, Roskilde University, building 28B, DK-4000, Roskilde, Denmark
| | - Silke Flindt Badino
- Research Unit for Functional Biomaterials, Department of Science and Environment, Roskilde University, building 28B, DK-4000, Roskilde, Denmark
| | - Ana Mafalda Cavaleiro
- Research Unit for Functional Biomaterials, Department of Science and Environment, Roskilde University, building 28B, DK-4000, Roskilde, Denmark.,Novozymes A/S, Department of Enzyme Discovery, Rævehøjvej 32A, DK-2800 Kgs. Lyngby, Denmark
| | - Kim Borch
- Novozymes A/S, Department of Enzyme Discovery, Rævehøjvej 32A, DK-2800 Kgs. Lyngby, Denmark
| | - Peter Westh
- Department of Biotechnology and Biomedicine, Technical University of Denmark, building 224, DK-2800, Kgs. Lyngby, Denmark
| |
Collapse
|
4
|
Baig KS. Interaction of enzymes with lignocellulosic materials: causes, mechanism and influencing factors. BIORESOUR BIOPROCESS 2020. [DOI: 10.1186/s40643-020-00310-0] [Citation(s) in RCA: 23] [Impact Index Per Article: 5.8] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 02/06/2023] Open
Abstract
AbstractFor the production of biofuel (bioethanol), enzymatic adsorption onto a lignocellulosic biomass surface is a prior condition for the enzymatic hydrolysis process to occur. Lignocellulosic substances are mainly composed of cellulose, hemicellulose and lignin. The polysaccharide matrix (cellulose and hemicellulose) is capable of producing bioethanol. Therefore, lignin is removed or its concentration is reduced from the adsorption substrates by pretreatments. Selected enzymes are used for the production of reducing sugars from cellulosic materials, which in turn are converted to bioethanol. Adsorption of enzymes onto the substrate surface is a complicated process. A large number of research have been performed on the adsorption process, but little has been done to understand the mechanism of adsorption process. This article reviews the mechanisms of adsorption of enzymes onto the biomass surfaces. A conceptual adsorption mechanism is presented which will fill the gaps in literature and help researchers and industry to use adsorption more efficiently. The process of enzymatic adsorption starts with the reciprocal interplay of enzymes and substrates and ends with the establishment of molecular and cellular binding. The kinetics of an enzymatic reaction is almost the same as that of a characteristic chemical catalytic reaction. The influencing factors discussed in detail are: surface characteristics of the participating materials, the environmental factors, such as the associated flow conditions, temperature, concentration, etc. Pretreatment of lignocellulosic materials and optimum range of shear force and temperature for getting better results of adsorption are recommended.
Collapse
|
5
|
Røjel N, Kari J, Sørensen TH, Badino SF, Morth JP, Schaller K, Cavaleiro AM, Borch K, Westh P. Substrate binding in the processive cellulase Cel7A: Transition state of complexation and roles of conserved tryptophan residues. J Biol Chem 2020; 295:1454-1463. [PMID: 31848226 PMCID: PMC7008363 DOI: 10.1074/jbc.ra119.011420] [Citation(s) in RCA: 11] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/09/2019] [Revised: 12/17/2019] [Indexed: 11/06/2022] Open
Abstract
Cellobiohydrolases effectively degrade cellulose and are of biotechnological interest because they can convert lignocellulosic biomass to fermentable sugars. Here, we implemented a fluorescence-based method for real-time measurements of complexation and decomplexation of the processive cellulase Cel7A and its insoluble substrate, cellulose. The method enabled detailed kinetic and thermodynamic analyses of ligand binding in a heterogeneous system. We studied WT Cel7A and several variants in which one or two of four highly conserved Trp residues in the binding tunnel had been replaced with Ala. WT Cel7A had on/off-rate constants of 1 × 105 m-1 s-1 and 5 × 10-3 s-1, respectively, reflecting the slow dynamics of a solid, polymeric ligand. Especially the off-rate constant was many orders of magnitude lower than typical values for small, soluble ligands. Binding rate and strength both were typically lower for the Trp variants, but effects of the substitutions were moderate and sometimes negligible. Hence, we propose that lowering the activation barrier for complexation is not a major driving force for the high conservation of the Trp residues. Using so-called Φ-factor analysis, we analyzed the kinetic and thermodynamic results for the variants. The results of this analysis suggested a transition state for complexation and decomplexation in which the reducing end of the ligand is close to the tunnel entrance (near Trp-40), whereas the rest of the binding tunnel is empty. We propose that this structure defines the highest free-energy barrier of the overall catalytic cycle and hence governs the turnover rate of this industrially important enzyme.
Collapse
Affiliation(s)
- Nanna Røjel
- Institut for Naturvidenskab og Miljo, Roskilde University, DK-4000 Roskilde, Denmark
| | - Jeppe Kari
- Department of Biotechnology and Biomedicine, Technical University of Denmark, DK-2800 Kgs. Lyngby, Denmark
| | | | - Silke F Badino
- Institut for Naturvidenskab og Miljo, Roskilde University, DK-4000 Roskilde, Denmark
| | - J Preben Morth
- Department of Biotechnology and Biomedicine, Technical University of Denmark, DK-2800 Kgs. Lyngby, Denmark
| | - Kay Schaller
- Department of Biotechnology and Biomedicine, Technical University of Denmark, DK-2800 Kgs. Lyngby, Denmark
| | | | - Kim Borch
- Novozymes A/S, DK-2800 Kgs. Lyngby Denmark
| | - Peter Westh
- Department of Biotechnology and Biomedicine, Technical University of Denmark, DK-2800 Kgs. Lyngby, Denmark.
| |
Collapse
|
6
|
A biochemical comparison of fungal GH6 cellobiohydrolases. Biochem J 2019; 476:2157-2172. [DOI: 10.1042/bcj20190185] [Citation(s) in RCA: 6] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/18/2019] [Revised: 07/14/2019] [Accepted: 07/16/2019] [Indexed: 02/02/2023]
Abstract
AbstractCellobiohydrolases (CBHs) from glycoside hydrolase family 6 (GH6) make up an important part of the secretome in many cellulolytic fungi. They are also of technical interest, particularly because they are part of the enzyme cocktails that are used for the industrial breakdown of lignocellulosic biomass. Nevertheless, functional studies of GH6 CBHs are scarce and focused on a few model enzymes. To elucidate functional breadth among GH6 CBHs, we conducted a comparative biochemical study of seven GH6 CBHs originating from fungi living in different habitats, in addition to one enzyme variant. The enzyme sequences were investigated by phylogenetic analyses to ensure that they were not closely related phylogenetically. The selected enzymes were all heterologously expressed in Aspergillus oryzae, purified and thoroughly characterized biochemically. This approach allowed direct comparisons of functional data, and the results revealed substantial variability. For example, the adsorption capacity on cellulose spanned two orders of magnitude and kinetic parameters, derived from two independent steady-state methods also varied significantly. While the different functional parameters covered wide ranges, they were not independent since they changed in parallel between two poles. One pole was characterized by strong substrate interactions, high adsorption capacity and low turnover number while the other showed weak substrate interactions, poor adsorption and high turnover. The investigated enzymes essentially defined a continuum between these two opposites, and this scaling of functional parameters raises interesting questions regarding functional plasticity and evolution of GH6 CBHs.
Collapse
|
7
|
NMR Analysis on Molecular Interaction of Lignin with Amino Acid Residues of Carbohydrate-Binding Module from Trichoderma reesei Cel7A. Sci Rep 2019; 9:1977. [PMID: 30760856 PMCID: PMC6374431 DOI: 10.1038/s41598-018-38410-9] [Citation(s) in RCA: 11] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/05/2018] [Accepted: 12/12/2018] [Indexed: 12/20/2022] Open
Abstract
Lignocellulosic biomass is anticipated to serve as a platform for green chemicals and fuels. Nonproductive binding of lignin to cellulolytic enzymes should be avoided for conversion of lignocellulose through enzymatic saccharification. Although carbohydrate-binding modules (CBMs) of cellulolytic enzymes strongly bind to lignin, the adsorption mechanism at molecular level is still unclear. Here, we report NMR-based analyses of binding sites on CBM1 of cellobiohydrolase I (Cel7A) from a hyper-cellulase-producing fungus, Trichoderma reesei, with cellohexaose and lignins from Japanese cedar (C-MWL) and Eucalyptus globulus (E-MWL). A method was established to obtain properly folded TrCBM1. Only TrCBM1 that was expressed in freshly transformed E. coli had intact conformation. Chemical shift perturbation analyses revealed that TrCBM1 adsorbed cellohexaose in highly specific manner via two subsites, flat plane surface and cleft, which were located on the opposite side of the protein surface. Importantly, MWLs were adsorbed at multiple binding sites, including the subsites, having higher affinity than cellohexaose. G6 and Q7 were involved in lignin binding on the flat plane surface of TrCBM1, while cellohexaose preferentially interacted with N29 and Q34. TrCBM1 used much larger surface area to bind with C-MWL than E-MWL, indicating the mechanisms of adsorption toward hardwood and softwood lignins are different.
Collapse
|
8
|
Djajadi DT, Pihlajaniemi V, Rahikainen J, Kruus K, Meyer AS. Cellulases adsorb reversibly on biomass lignin. Biotechnol Bioeng 2018; 115:2869-2880. [PMID: 30132790 PMCID: PMC6282830 DOI: 10.1002/bit.26820] [Citation(s) in RCA: 23] [Impact Index Per Article: 3.8] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/17/2018] [Revised: 07/30/2018] [Accepted: 08/13/2018] [Indexed: 12/14/2022]
Abstract
Adsorption of cellulases onto lignin is considered a major factor in retarding enzymatic cellulose degradation of lignocellulosic biomass. However, the adsorption mechanisms and kinetics are not well understood for individual types of cellulases. This study examines the binding affinity, kinetics of adsorption, and competition of four monocomponent cellulases of Trichoderma reesei during adsorption onto lignin.
TrCel7A,
TrCel6A,
TrCel7B, and
TrCel5A were radiolabeled for adsorption experiments on lignin‐rich residues (LRRs) isolated from hydrothermally pretreated spruce (L‐HPS) and wheat straw (L‐HPWS), respectively. On the basis of adsorption isotherms fitted to the Langmuir model, the ranking of binding affinities was
TrCel5A >
TrCel6A >
TrCel7B >
TrCel7A on both types of LRRs. The enzymes had a higher affinity to the L‐HPS than to the L‐HPWS. Adsorption experiments with dilution after 1 and 24 hr and kinetic modeling were performed to quantify any irreversible binding over time. Models with reversible binding parameters fitted well and can explain the results obtained. The adsorption constants obtained from the reversible models agreed with the fitted Langmuir isotherms and suggested that reversible adsorption–desorption existed at equilibrium. Competitive binding experiments showed that individual types of cellulases competed for binding sites on the lignin and the adsorption data fitted the Langmuir adsorption model. Overall, the data strongly indicate that the adsorption of cellulases onto lignin is reversible and the findings have implications for the development of more efficient cellulose degrading enzymes.
Collapse
Affiliation(s)
- Demi T Djajadi
- Department of Chemical and Biochemical Engineering, Technical University of Denmark, Kongens Lyngby, Denmark
| | | | | | | | - Anne S Meyer
- Department of Chemical and Biochemical Engineering, Technical University of Denmark, Kongens Lyngby, Denmark
| |
Collapse
|
9
|
Fang W, Nonappa, Vitikainen M, Mohammadi P, Koskela S, Soikkeli M, Westerholm-Parvinen A, Landowski CP, Penttilä M, Linder MB, Laaksonen P. Coacervation of resilin fusion proteins containing terminal functionalities. Colloids Surf B Biointerfaces 2018; 171:590-596. [PMID: 30098537 DOI: 10.1016/j.colsurfb.2018.07.048] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/08/2018] [Revised: 05/11/2018] [Accepted: 07/23/2018] [Indexed: 12/16/2022]
Abstract
Liquid-liquid phase transition known as coacervation of resilin-like-peptide fusion proteins containing different terminal domains were investigated. Two different modular proteins were designed and produced and their behavior were compared to a resilin-like-peptide without terminal domains. The size of the particle-like coacervates was modulated by the protein concentration, pH and temperature. The morphology and three-dimensional (3D) structural details of the coacervate particles were investigated by cryogenic transmission electron microscopy (cryo-TEM) and tomography (cryo-ET) reconstruction. Selective adhesion of the coacervates on cellulose and graphene surfaces was demonstrated.
Collapse
Affiliation(s)
- Wenwen Fang
- Department of Bioproducts and Biosystems, Aalto University, Espoo, FI-00076, AALTO, Finland
| | - Nonappa
- Department of Bioproducts and Biosystems, Aalto University, Espoo, FI-00076, AALTO, Finland; Department of Applied Physics, Aalto University, Espoo, FI-00076, AALTO, Finland
| | - Marika Vitikainen
- VTT Technical Research Centre of Finland Ltd., Espoo, FI-02044, VTT, Finland
| | - Pezhman Mohammadi
- Department of Bioproducts and Biosystems, Aalto University, Espoo, FI-00076, AALTO, Finland
| | - Salla Koskela
- VTT Technical Research Centre of Finland Ltd., Espoo, FI-02044, VTT, Finland
| | - Miika Soikkeli
- VTT Technical Research Centre of Finland Ltd., Espoo, FI-02044, VTT, Finland
| | | | | | - Merja Penttilä
- Department of Bioproducts and Biosystems, Aalto University, Espoo, FI-00076, AALTO, Finland; VTT Technical Research Centre of Finland Ltd., Espoo, FI-02044, VTT, Finland
| | - Markus B Linder
- Department of Bioproducts and Biosystems, Aalto University, Espoo, FI-00076, AALTO, Finland
| | - Päivi Laaksonen
- Department of Bioproducts and Biosystems, Aalto University, Espoo, FI-00076, AALTO, Finland.
| |
Collapse
|
10
|
Zhai R, Hu J, Saddler JN. The inhibition of hemicellulosic sugars on cellulose hydrolysis are highly dependant on the cellulase productive binding, processivity, and substrate surface charges. BIORESOURCE TECHNOLOGY 2018; 258:79-87. [PMID: 29524690 DOI: 10.1016/j.biortech.2017.12.006] [Citation(s) in RCA: 12] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/04/2017] [Revised: 12/02/2017] [Accepted: 12/04/2017] [Indexed: 05/24/2023]
Abstract
In this study, the influence of major hemicellulosic sugars (mannose and xylose) on cellulose hydrolysis and major enzyme activities were evaluated by using both commercial enzyme cocktail and purified cellulase monocomponents over a "library" of cellulosic substrates. Surprisingly, the results showed that unlike glucose, mannose/xylose did not inhibit individual cellulase activities but significantly decreased their hydrolytic performance on cellulose substrates. When various enzyme-substrate interactions (e.g. adsorption/desorption, productive binding, and processive moving) were evaluated, it appeared that these hemicellulosic sugars significantly reduced the productive binding and processivity of Cel7A, which in turn limited cellulase hydrolytic efficacy. Among a range of major cellulose characteristics (e.g. crystallinity, degree of polymerization, accessibility, and surface charges), the acid group content of the cellulosic substrates seemed to be the main driver that determined the extent of hemicellulosic sugar inhibition. Our results provided new insights for better understanding the sugar inhibition mechanisms of cellulose hydrolysis.
Collapse
Affiliation(s)
- Rui Zhai
- School of Environmental and Biological Engineering, Nanjing University of Science and Technology, 200 Xiaolingwei Street, Nanjing 210094, China; Forest Products Biotechnology and Bioenergy Group, Department of Wood Science, Faculty of Forestry, The University of British Columbia, 2424 Main Mall, Vancouver, BC, Canada
| | - Jinguang Hu
- Forest Products Biotechnology and Bioenergy Group, Department of Wood Science, Faculty of Forestry, The University of British Columbia, 2424 Main Mall, Vancouver, BC, Canada.
| | - Jack N Saddler
- Forest Products Biotechnology and Bioenergy Group, Department of Wood Science, Faculty of Forestry, The University of British Columbia, 2424 Main Mall, Vancouver, BC, Canada
| |
Collapse
|
11
|
Westh P, Borch K, Sørensen T, Tokin R, Kari J, Badino S, Cavaleiro MA, Røjel N, Christensen S, Vesterager CS, Schiano-di-Cola C. Thermoactivation of a cellobiohydrolase. Biotechnol Bioeng 2018; 115:831-838. [PMID: 29240229 DOI: 10.1002/bit.26513] [Citation(s) in RCA: 11] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/15/2017] [Revised: 11/21/2017] [Accepted: 12/04/2017] [Indexed: 01/11/2023]
Abstract
We have measured activity and substrate affinity of the thermostable cellobiohydrolase, Cel7A, from Rasamsonia emersonii over a broad range of temperatures. For the wild type enzyme, which does not have a Carbohydrate Binding Module (CBM), higher temperature only led to moderately increased activity against cellulose, and we ascribed this to a pronounced, temperature induced desorption of enzyme from the substrate surface. We also tested a "high affinity" variant of R. emersonii Cel7A with a linker and CBM from a related enzyme. At room temperature, the activity of the variant was similar to the wild type, but the variant was more accelerated by temperature and about two-fold faster around 70 °C. This better thermoactivation of the high-affinity variant could not be linked to differences in stability or the catalytic process, but coincided with less desorption as temperature increased. Based on these observations and earlier reports on moderate thermoactivation of cellulases, we suggest that better cellulolytic activity at industrially relevant temperatures may be attained by engineering improved substrate affinity into enzymes that already possess good thermostability.
Collapse
Affiliation(s)
- Peter Westh
- Department of Science and Environment, INM, Universitetsvej 1, Roskilde, Denmark
| | | | - Trine Sørensen
- Department of Science and Environment, INM, Universitetsvej 1, Roskilde, Denmark
| | - Radina Tokin
- Department of Science and Environment, INM, Universitetsvej 1, Roskilde, Denmark
| | - Jeppe Kari
- Department of Science and Environment, INM, Universitetsvej 1, Roskilde, Denmark
| | - Silke Badino
- Department of Science and Environment, INM, Universitetsvej 1, Roskilde, Denmark
| | | | - Nanna Røjel
- Department of Science and Environment, INM, Universitetsvej 1, Roskilde, Denmark
| | - Stefan Christensen
- Department of Science and Environment, INM, Universitetsvej 1, Roskilde, Denmark
| | - Cynthia S Vesterager
- Department of Science and Environment, INM, Universitetsvej 1, Roskilde, Denmark
| | | |
Collapse
|
12
|
Badino SF, Kari J, Christensen SJ, Borch K, Westh P. Direct kinetic comparison of the two cellobiohydrolases Cel6A and Cel7A from Hypocrea jecorina. BIOCHIMICA ET BIOPHYSICA ACTA-PROTEINS AND PROTEOMICS 2017; 1865:1739-1745. [DOI: 10.1016/j.bbapap.2017.08.013] [Citation(s) in RCA: 13] [Impact Index Per Article: 1.9] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/12/2017] [Revised: 07/25/2017] [Accepted: 08/14/2017] [Indexed: 01/17/2023]
|
13
|
Lu X, Wang C, Li X, Zhao J. Temperature and pH influence adsorption of cellobiohydrolase onto lignin by changing the protein properties. BIORESOURCE TECHNOLOGY 2017; 245:819-825. [PMID: 28926914 DOI: 10.1016/j.biortech.2017.08.139] [Citation(s) in RCA: 9] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/27/2017] [Revised: 08/21/2017] [Accepted: 08/22/2017] [Indexed: 05/03/2023]
Abstract
Non-productive adsorption of cellulase onto lignin restricted the movement of cellulase and also hindered the cellulase recycling in bioconversion of lignocellulose. In this study, effect of temperature and pH on adsorption and desorption of cellobiohydrolase (CBH) on lignin and its possible mechanism were discussed. It found that pH value and temperature influenced the adsorption and desorption behaviors of CBH on lignin. Different thermodynamic models suggested that the action between lignin and CBH was physical action. More CBH was adsorbed onto lignin, but lower initial adsorption velocity was detected at 50°C comparing with 4°C. Elevating pH value could improve desorption of cellulase from lignin. The changes of hydrophobicity and electric potential on protein surface may partially explain the impact of environmental conditions on the adsorption and desorption behaviors of CBH on lignin, and comparing to electrical interaction, the hydrophobicity may be the dominating factor influencing the behaviors.
Collapse
Affiliation(s)
- Xianqin Lu
- State Key Laboratory of Microbial Technology, Shandong University, Jinan City, Shandong Province 250100, China
| | - Can Wang
- State Key Laboratory of Microbial Technology, Shandong University, Jinan City, Shandong Province 250100, China
| | - Xuezhi Li
- State Key Laboratory of Microbial Technology, Shandong University, Jinan City, Shandong Province 250100, China
| | - Jian Zhao
- State Key Laboratory of Microbial Technology, Shandong University, Jinan City, Shandong Province 250100, China.
| |
Collapse
|
14
|
Badino SF, Bathke JK, Sørensen TH, Windahl MS, Jensen K, Peters GHJ, Borch K, Westh P. The influence of different linker modifications on the catalytic activity and cellulose affinity of cellobiohydrolase Cel7A from Hypocrea jecorina. Protein Eng Des Sel 2017; 30:495-501. [PMID: 28873985 DOI: 10.1093/protein/gzx036] [Citation(s) in RCA: 18] [Impact Index Per Article: 2.6] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/21/2017] [Accepted: 07/04/2017] [Indexed: 12/13/2022] Open
Abstract
Various cellulases consist of a catalytic domain connected to a carbohydrate-binding module (CBM) by a flexible linker peptide. The linker if often strongly O-glycosylated and typically has a length of 20-50 amino acid residues. Functional roles, other than connecting the two folded domains, of the linker and its glycans, have been widely discussed, but experimental evidence remains sparse. One of the most studied cellulose degrading enzymes is the multi-domain cellobiohydrolase Cel7A from Hypocrea jecorina. Here, we designed variants of Cel7A with mutations in the linker region to elucidate the role of the linker. We found that moderate modification of the linker could result in significant changes in substrate affinity and catalytic efficacy. These changes were quite different for different linker variants. Thus, deletion of six residues near the catalytic domain had essentially no effects on enzyme function. Conversely, a substitution of four glycosylation sites near the middle of the linker reduced substrate affinity and increased maximal turnover. The observation of weaker binding provides some support of recent suggestions that linker glycans may be directly involved in substrate interactions. However, a variant with several inserted glycosylation sites near the CBM also showed lower affinity for the substrate compared to the wild-type, and we suggest that substrate interactions of the glycans depend on their exact location as well as other factors such as changes in structure and dynamics of the linker peptide.
Collapse
Affiliation(s)
- Silke Flindt Badino
- Research Unit for Functional Biomaterials, Department of Science and Environment, INM, Roskilde University, 1 Universitetsvej, Build. 28 C, DK-4000, Roskilde, Denmark
| | - Jenny Kim Bathke
- Department of Chemistry, Technical University of Denmark, Kemitorvet, Build. 207, DK-2800 Kgs. Lyngby, Denmark
| | - Trine Holst Sørensen
- Research Unit for Functional Biomaterials, Department of Science and Environment, INM, Roskilde University, 1 Universitetsvej, Build. 28 C, DK-4000, Roskilde, Denmark
| | - Michael Skovbo Windahl
- Research Unit for Functional Biomaterials, Department of Science and Environment, INM, Roskilde University, 1 Universitetsvej, Build. 28 C, DK-4000, Roskilde, Denmark
| | - Kenneth Jensen
- Novozymes A/S, Krogshøjvej 36, DK-2880, Bagsværd, Denmark
| | - Günther H J Peters
- Department of Chemistry, Technical University of Denmark, Kemitorvet, Build. 207, DK-2800 Kgs. Lyngby, Denmark
| | - Kim Borch
- Novozymes A/S, Krogshøjvej 36, DK-2880, Bagsværd, Denmark
| | - Peter Westh
- Research Unit for Functional Biomaterials, Department of Science and Environment, INM, Roskilde University, 1 Universitetsvej, Build. 28 C, DK-4000, Roskilde, Denmark
| |
Collapse
|
15
|
Fang W, Paananen A, Vitikainen M, Koskela S, Westerholm-Parvinen A, Joensuu JJ, Landowski CP, Penttilä M, Linder MB, Laaksonen P. Elastic and pH-Responsive Hybrid Interfaces Created with Engineered Resilin and Nanocellulose. Biomacromolecules 2017; 18:1866-1873. [PMID: 28440631 DOI: 10.1021/acs.biomac.7b00294] [Citation(s) in RCA: 17] [Impact Index Per Article: 2.4] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 02/08/2023]
Abstract
We investigated how a genetically engineered resilin fusion protein modifies cellulose surfaces. We characterized the pH-responsive behavior of a resilin-like polypeptide (RLP) having terminal cellulose binding modules (CBM) and showed its binding to cellulose nanofibrils (CNF). Characterization of the resilin fusion protein at different pHs revealed substantial conformational changes of the protein, which were observed as swelling and contraction of the protein layer bound to the nanocellulose surface. In addition, we showed that employment of the modified resilin in cellulose hydrogel and nanopaper increased their modulus of stiffness through a cross-linking effect.
Collapse
Affiliation(s)
- Wenwen Fang
- Department of Bioproducts and Biosystems, Aalto University , Espoo, FI-00076 Aalto, Finland
| | - Arja Paananen
- VTT Technical Research Centre of Finland Ltd., Espoo, FI-02044 VTT, Finland
| | - Marika Vitikainen
- VTT Technical Research Centre of Finland Ltd., Espoo, FI-02044 VTT, Finland
| | - Salla Koskela
- VTT Technical Research Centre of Finland Ltd., Espoo, FI-02044 VTT, Finland
| | | | - Jussi J Joensuu
- VTT Technical Research Centre of Finland Ltd., Espoo, FI-02044 VTT, Finland
| | | | - Merja Penttilä
- VTT Technical Research Centre of Finland Ltd., Espoo, FI-02044 VTT, Finland
| | - Markus B Linder
- Department of Bioproducts and Biosystems, Aalto University , Espoo, FI-00076 Aalto, Finland
| | - Päivi Laaksonen
- Department of Bioproducts and Biosystems, Aalto University , Espoo, FI-00076 Aalto, Finland
| |
Collapse
|
16
|
Arola S, Linder MB. Binding of cellulose binding modules reveal differences between cellulose substrates. Sci Rep 2016; 6:35358. [PMID: 27748440 PMCID: PMC5066208 DOI: 10.1038/srep35358] [Citation(s) in RCA: 26] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/12/2016] [Accepted: 09/28/2016] [Indexed: 11/20/2022] Open
Abstract
The interaction between cellulase enzymes and their substrates is of central importance to several technological and scientific challenges. Here we report that the binding of cellulose binding modules (CBM) from Trichoderma reesei cellulases Cel6A and Cel7A show a major difference in how they interact with substrates originating from wood compared to bacterial cellulose. We found that the CBM from TrCel7A recognizes the two substrates differently and as a consequence shows an unexpected way of binding. We show that the substrate has a large impact on the exchange rate of the studied CBM, and moreover, CBM-TrCel7A seems to have an additional mode of binding on wood derived cellulose but not on cellulose originating from bacterial source. This mode is not seen in double CBM (DCBM) constructs comprising both CBM-TrCel7A and CBM-TrCel6A. The linker length of DCBMs affects the binding properties, and slows down the exchange rates of the proteins and thus, can be used to analyze the differences between the single CBM. These results have impact on the cellulase research and offer new understanding on how these industrially relevant enzymes act.
Collapse
Affiliation(s)
- Suvi Arola
- School of Science, Aalto University, P. O. Box 11100, FI-00076, Aalto, Finland
- School of Chemical Technology, Aalto University, P.O. Box 16100, FI-00076, Aalto, Finland
- VTT, Technical Research Centre of Finland, Bio and process technology, P.O.Box 1000, FIN–02044 VTT, Finland
| | - Markus B. Linder
- School of Chemical Technology, Aalto University, P.O. Box 16100, FI-00076, Aalto, Finland
| |
Collapse
|
17
|
Sun X, Qian MD, Guan SS, Shan YM, Dong Y, Zhang H, Wang S, Han WW. Investigation of an "alternate water supply system" in enzymatic hydrolysis in the processive endocellulase Cel7A from Rasamsonia emersonii by molecular dynamics simulation. Biopolymers 2016; 107:46-60. [PMID: 27696356 DOI: 10.1002/bip.22991] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/20/2016] [Revised: 09/26/2016] [Accepted: 09/28/2016] [Indexed: 01/10/2023]
Abstract
Cel7A from Rasamsonia emersonii is one of the processive endocellulases classified under family 7 glycoside hydrolase. Molecular dynamics simulations were carried out to obtain the optimized sliding and hydrolyzing conformations, in which the reducing ends of sugar chains are located on different sites. Hydrogen bonds are investigated to clarify the interactions between protein and substrate in either conformation. Nine hydrogen bonding interactions are identified in the sliding conformation, and six similar interactions are also found correspondingly in the hydrolyzing conformation. In addition, four strong hydrophobic interactions are also determined. The domain cross-correlation map analysis shows movement correlation of protein including autocorrelation between residues. The root mean square fluctuations analysis represents the various flexibilities of different fragment in the two conformations. Comparing the two conformations reveals the water-supply mechanism of selective hydrolysis of cellulose in Cel7A. The mechanism can be described as follow. When the reducing end of substrate slides from the unhydrolyzing site (sliding conformation) to the hydrolyzing site (hydrolyzing conformation), His225 is pushed down and rotated, the rotation leads to the movement of Glu209 with the interstrand hydrogen bonding in β-sheet. It further makes Asp211 close to the hydrolysis center and provides a water molecule bounding on its carboxyl in the previous unhydrolyzing site. After the hydrolysis takes place and the product is excluded from the enzyme, the Asp211 comes back to its initial position. In summary, Asp211 acts as an elevator to transport outer water molecules into the hydrolysis site for every other glycosidic bond.
Collapse
Affiliation(s)
- Xun Sun
- Institute of Theoretical Chemistry, Jilin University, Changchun, 130023, People's Republic of China
| | - Meng-Dan Qian
- Institute of Theoretical Chemistry, Jilin University, Changchun, 130023, People's Republic of China
| | - Shan-Shan Guan
- Key Laboratory for Molecular Enzymology and Engineering of Ministry of Education, National Engineering Laboratory for AIDS Vaccine, College of Life Sciences, Jilin University, Changchun, 130012, People's Republic of China
| | - Ya-Ming Shan
- Key Laboratory for Molecular Enzymology and Engineering of Ministry of Education, National Engineering Laboratory for AIDS Vaccine, College of Life Sciences, Jilin University, Changchun, 130012, People's Republic of China
| | - Ying Dong
- Bethune pharmaceutical factory, Jilin University, Changchun, 130012, People's Republic of China
| | - Hao Zhang
- Institute of Theoretical Chemistry, Jilin University, Changchun, 130023, People's Republic of China
| | - Song Wang
- Institute of Theoretical Chemistry, Jilin University, Changchun, 130023, People's Republic of China
| | - Wei-Wei Han
- Key Laboratory for Molecular Enzymology and Engineering of Ministry of Education, National Engineering Laboratory for AIDS Vaccine, College of Life Sciences, Jilin University, Changchun, 130012, People's Republic of China.,Department of Computer Science, C.S. Bond Life Sciences Center, University of Missouri Columbia, Missouri, 65211
| |
Collapse
|
18
|
Sørensen TH, Windahl MS, McBrayer B, Kari J, Olsen JP, Borch K, Westh P. Loop variants of the thermophileRasamsonia emersoniiCel7A with improved activity against cellulose. Biotechnol Bioeng 2016; 114:53-62. [DOI: 10.1002/bit.26050] [Citation(s) in RCA: 17] [Impact Index Per Article: 2.1] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/10/2016] [Revised: 07/08/2016] [Accepted: 07/11/2016] [Indexed: 01/09/2023]
Affiliation(s)
- Trine Holst Sørensen
- NSM, Research Unit for Functional Biomaterials, Roskilde University, Universitetsvej 1; Building 28, DK-4000 Roskilde Denmark
| | | | | | - Jeppe Kari
- NSM, Research Unit for Functional Biomaterials, Roskilde University, Universitetsvej 1; Building 28, DK-4000 Roskilde Denmark
| | - Johan Pelck Olsen
- NSM, Research Unit for Functional Biomaterials, Roskilde University, Universitetsvej 1; Building 28, DK-4000 Roskilde Denmark
| | | | - Peter Westh
- NSM, Research Unit for Functional Biomaterials, Roskilde University, Universitetsvej 1; Building 28, DK-4000 Roskilde Denmark
| |
Collapse
|
19
|
Nakamura A, Tasaki T, Ishiwata D, Yamamoto M, Okuni Y, Visootsat A, Maximilien M, Noji H, Uchiyama T, Samejima M, Igarashi K, Iino R. Single-molecule Imaging Analysis of Binding, Processive Movement, and Dissociation of Cellobiohydrolase Trichoderma reesei Cel6A and Its Domains on Crystalline Cellulose. J Biol Chem 2016; 291:22404-22413. [PMID: 27609516 DOI: 10.1074/jbc.m116.752048] [Citation(s) in RCA: 38] [Impact Index Per Article: 4.8] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/04/2016] [Revised: 08/24/2016] [Indexed: 11/06/2022] Open
Abstract
Trichoderma reesei Cel6A (TrCel6A) is a cellobiohydrolase that hydrolyzes crystalline cellulose into cellobiose. Here we directly observed the reaction cycle (binding, surface movement, and dissociation) of single-molecule intact TrCel6A, isolated catalytic domain (CD), cellulose-binding module (CBM), and CBM and linker (CBM-linker) on crystalline cellulose Iα The CBM-linker showed a binding rate constant almost half that of intact TrCel6A, whereas those of the CD and CBM were only one-tenth of intact TrCel6A. These results indicate that the glycosylated linker region largely contributes to initial binding on crystalline cellulose. After binding, all samples showed slow and fast dissociations, likely caused by the two different bound states due to the heterogeneity of cellulose surface. The CBM showed much higher specificity to the high affinity site than to the low affinity site, whereas the CD did not, suggesting that the CBM leads the CD to the hydrophobic surface of crystalline cellulose. On the cellulose surface, intact molecules showed slow processive movements (8.8 ± 5.5 nm/s) and fast diffusional movements (30-40 nm/s), whereas the CBM-Linker, CD, and a catalytically inactive full-length mutant showed only fast diffusional movements. These results suggest that both direct binding and surface diffusion contribute to searching of the hydrolysable point of cellulose chains. The duration time constant for the processive movement was 7.7 s, and processivity was estimated as 68 ± 42. Our results reveal the role of each domain in the elementary steps of the reaction cycle and provide the first direct evidence of the processive movement of TrCel6A on crystalline cellulose.
Collapse
Affiliation(s)
- Akihiko Nakamura
- From the Okazaki Institute for Integrative Bioscience and.,the Department of Functional Molecular Science, School of Physical Sciences, Graduate University for Advanced Studies (SOKENDAI), Kanagawa 240-0193, Japan
| | - Tomoyuki Tasaki
- the Department of Applied Chemistry, Graduate School of Engineering, University of Tokyo, Tokyo 113-8656, Japan
| | - Daiki Ishiwata
- From the Okazaki Institute for Integrative Bioscience and
| | | | - Yasuko Okuni
- From the Okazaki Institute for Integrative Bioscience and
| | - Akasit Visootsat
- the Department of Biochemistry, Faculty of Science, Kasetsart University, Bangkok 10900, Thailand
| | - Morice Maximilien
- the National Chemical Engineering Institute in Paris, Paris 75005, France
| | - Hiroyuki Noji
- the Department of Applied Chemistry, Graduate School of Engineering, University of Tokyo, Tokyo 113-8656, Japan
| | - Taku Uchiyama
- the Department of Biomaterial Sciences, Graduate School of Agricultural and Life Sciences, University of Tokyo, Tokyo 113-8657, Japan, and
| | - Masahiro Samejima
- the Department of Biomaterial Sciences, Graduate School of Agricultural and Life Sciences, University of Tokyo, Tokyo 113-8657, Japan, and
| | - Kiyohiko Igarashi
- the Department of Biomaterial Sciences, Graduate School of Agricultural and Life Sciences, University of Tokyo, Tokyo 113-8657, Japan, and.,the VTT Technical Research Centre of Finland, Espoo FI-02044 VTT, Finland
| | - Ryota Iino
- From the Okazaki Institute for Integrative Bioscience and .,the Department of Functional Molecular Science, School of Physical Sciences, Graduate University for Advanced Studies (SOKENDAI), Kanagawa 240-0193, Japan.,Institute for Molecular Science, National Institutes of Natural Sciences, Aichi 444-8787, Japan
| |
Collapse
|
20
|
Hasunuma T, Ishii J, Kondo A. Rational design and evolutional fine tuning of Saccharomyces cerevisiae for biomass breakdown. Curr Opin Chem Biol 2015; 29:1-9. [DOI: 10.1016/j.cbpa.2015.06.004] [Citation(s) in RCA: 26] [Impact Index Per Article: 2.9] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/25/2015] [Revised: 06/06/2015] [Accepted: 06/08/2015] [Indexed: 12/31/2022]
|
21
|
Hamid SBA, Islam MM, Das R. Cellulase biocatalysis: key influencing factors and mode of action. CELLULOSE 2015; 22:2157-2182. [DOI: 10.1007/s10570-015-0672-5] [Citation(s) in RCA: 11] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 09/02/2023]
|
22
|
Sørensen TH, Cruys-Bagger N, Windahl MS, Badino SF, Borch K, Westh P. Temperature Effects on Kinetic Parameters and Substrate Affinity of Cel7A Cellobiohydrolases. J Biol Chem 2015; 290:22193-202. [PMID: 26183777 DOI: 10.1074/jbc.m115.658930] [Citation(s) in RCA: 45] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/16/2015] [Indexed: 11/06/2022] Open
Abstract
We measured hydrolytic rates of four purified cellulases in small increments of temperature (10-50 °C) and substrate loads (0-100 g/liter) and analyzed the data by a steady state kinetic model that accounts for the processive mechanism. We used wild type cellobiohydrolases (Cel7A) from mesophilic Hypocrea jecorina and thermophilic Rasamsonia emersonii and two variants of these enzymes designed to elucidate the role of the carbohydrate binding module (CBM). We consistently found that the maximal rate increased strongly with temperature, whereas the affinity for the insoluble substrate decreased, and as a result, the effect of temperature depended strongly on the substrate load. Thus, temperature had little or no effect on the hydrolytic rate in dilute substrate suspensions, whereas strong temperature activation (Q10 values up to 2.6) was observed at saturating substrate loads. The CBM had a dual effect on the activity. On one hand, it diminished the tendency of heat-induced desorption, but on the other hand, it had a pronounced negative effect on the maximal rate, which was 2-fold larger in variants without CBM throughout the investigated temperature range. We conclude that although the CBM is beneficial for affinity it slows down the catalytic process. Cel7A from the thermophilic organism was moderately more activated by temperature than the mesophilic analog. This is in accord with general theories on enzyme temperature adaptation and possibly relevant information for the selection of technical cellulases.
Collapse
Affiliation(s)
- Trine Holst Sørensen
- From Roskilde University, Nature, Systems, and Models, Research Unit for Functional Biomaterials, 1 Universitetsvej, Building 28, DK-4000 Roskilde, Denmark and
| | - Nicolaj Cruys-Bagger
- From Roskilde University, Nature, Systems, and Models, Research Unit for Functional Biomaterials, 1 Universitetsvej, Building 28, DK-4000 Roskilde, Denmark and
| | - Michael Skovbo Windahl
- From Roskilde University, Nature, Systems, and Models, Research Unit for Functional Biomaterials, 1 Universitetsvej, Building 28, DK-4000 Roskilde, Denmark and Novozymes A/S, Krogshøjvej 36, DK-2880 Bagsværd, Denmark
| | - Silke Flindt Badino
- From Roskilde University, Nature, Systems, and Models, Research Unit for Functional Biomaterials, 1 Universitetsvej, Building 28, DK-4000 Roskilde, Denmark and Novozymes A/S, Krogshøjvej 36, DK-2880 Bagsværd, Denmark
| | - Kim Borch
- Novozymes A/S, Krogshøjvej 36, DK-2880 Bagsværd, Denmark
| | - Peter Westh
- From Roskilde University, Nature, Systems, and Models, Research Unit for Functional Biomaterials, 1 Universitetsvej, Building 28, DK-4000 Roskilde, Denmark and
| |
Collapse
|
23
|
Sørensen TH, Cruys-Bagger N, Borch K, Westh P. Free Energy Diagram for the Heterogeneous Enzymatic Hydrolysis of Glycosidic Bonds in Cellulose. J Biol Chem 2015; 290:22203-11. [PMID: 26183776 DOI: 10.1074/jbc.m115.659656] [Citation(s) in RCA: 26] [Impact Index Per Article: 2.9] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/16/2015] [Indexed: 01/25/2023] Open
Abstract
Kinetic and thermodynamic data have been analyzed according to transition state theory and a simplified reaction scheme for the enzymatic hydrolysis of insoluble cellulose. For the cellobiohydrolase Cel7A from Hypocrea jecorina (Trichoderma reesei), we were able to measure or collect relevant values for all stable and activated complexes defined by the reaction scheme and hence propose a free energy diagram for the full heterogeneous process. For other Cel7A enzymes, including variants with and without carbohydrate binding module (CBM), we obtained activation parameters for the association and dissociation of the enzyme-substrate complex. The results showed that the kinetics of enzyme-substrate association (i.e. formation of the Michaelis complex) was almost entirely entropy-controlled and that the activation entropy corresponded approximately to the loss of translational and rotational degrees of freedom of the dissolved enzyme. This implied that the transition state occurred early in the path where the enzyme has lost these degrees of freedom but not yet established extensive contact interactions in the binding tunnel. For dissociation, a similar analysis suggested that the transition state was late in the path where most enzyme-substrate contacts were broken. Activation enthalpies revealed that the rate of dissociation was far more temperature-sensitive than the rates of both association and the inner catalytic cycle. Comparisons of one- and two-domain variants showed that the CBM had no influence on the transition state for association but increased the free energy barrier for dissociation. Hence, the CBM appeared to promote the stability of the complex by delaying dissociation rather than accelerating association.
Collapse
Affiliation(s)
- Trine Holst Sørensen
- From Roskilde University, NSM, Research Unit for Functional Biomaterials, 1 Universitetsvej, Building 28, DK-4000 Roskilde, Denmark and
| | - Nicolaj Cruys-Bagger
- From Roskilde University, NSM, Research Unit for Functional Biomaterials, 1 Universitetsvej, Building 28, DK-4000 Roskilde, Denmark and
| | - Kim Borch
- Novozymes A/S, Krogshøjvej 36, DK-2880 Bagsværd, Denmark
| | - Peter Westh
- From Roskilde University, NSM, Research Unit for Functional Biomaterials, 1 Universitetsvej, Building 28, DK-4000 Roskilde, Denmark and
| |
Collapse
|
24
|
Gomes D, Rodrigues AC, Domingues L, Gama M. Cellulase recycling in biorefineries—is it possible? Appl Microbiol Biotechnol 2015; 99:4131-43. [DOI: 10.1007/s00253-015-6535-z] [Citation(s) in RCA: 57] [Impact Index Per Article: 6.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/08/2015] [Revised: 03/09/2015] [Accepted: 03/11/2015] [Indexed: 11/28/2022]
|
25
|
Greene ER, Himmel ME, Beckham GT, Tan Z. Glycosylation of Cellulases: Engineering Better Enzymes for Biofuels. Adv Carbohydr Chem Biochem 2015; 72:63-112. [PMID: 26613815 DOI: 10.1016/bs.accb.2015.08.001] [Citation(s) in RCA: 31] [Impact Index Per Article: 3.4] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/22/2022]
Abstract
Cellulose in plant cell walls is the largest reservoir of renewable carbon on Earth. The saccharification of cellulose from plant biomass into soluble sugars can be achieved using fungal and bacterial cellulolytic enzymes, cellulases, and further converted into fuels and chemicals. Most fungal cellulases are both N- and O-glycosylated in their native form, yet the consequences of glycosylation on activity and structure are not fully understood. Studying protein glycosylation is challenging as glycans are extremely heterogeneous, stereochemically complex, and glycosylation is not under direct genetic control. Despite these limitations, many studies have begun to unveil the role of cellulase glycosylation, especially in the industrially relevant cellobiohydrolase from Trichoderma reesei, Cel7A. Glycosylation confers many beneficial properties to cellulases including enhanced activity, thermal and proteolytic stability, and structural stabilization. However, glycosylation must be controlled carefully as such positive effects can be dampened or reversed. Encouragingly, methods for the manipulation of glycan structures have been recently reported that employ genetic tuning of glycan-active enzymes expressed from homogeneous and heterologous fungal hosts. Taken together, these studies have enabled new strategies for the exploitation of protein glycosylation for the production of enhanced cellulases for biofuel production.
Collapse
|
26
|
Colussi F, Sørensen TH, Alasepp K, Kari J, Cruys-Bagger N, Windahl MS, Olsen JP, Borch K, Westh P. Probing substrate interactions in the active tunnel of a catalytically deficient cellobiohydrolase (Cel7). J Biol Chem 2014; 290:2444-54. [PMID: 25477511 DOI: 10.1074/jbc.m114.624163] [Citation(s) in RCA: 32] [Impact Index Per Article: 3.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/06/2022] Open
Abstract
Cellobiohydrolases break down cellulose sequentially by sliding along the crystal surface with a single cellulose strand threaded through the catalytic tunnel of the enzyme. This so-called processive mechanism relies on a complex pattern of enzyme-substrate interactions, which need to be addressed in molecular descriptions of processivity and its driving forces. Here, we have used titration calorimetry to study interactions of cellooligosaccharides (COS) and a catalytically deficient variant (E212Q) of the enzyme Cel7A from Trichoderma reesei. This enzyme has ∼10 glucopyranose subsites in the catalytic tunnel, and using COS ligands with a degree of polymerization (DP) from 2 to 8, different regions of the tunnel could be probed. For COS ligands with a DP of 2-3 the binding constants were around 10(5) m(-1), and for longer ligands (DP 5-8) this value was ∼10(7) m(-1). Within each of these groups we did not find increased affinity as the ligands got longer and potentially filled more subsites. On the contrary, we found a small but consistent affinity loss as DP rose from 6 to 8, particularly at the higher investigated temperatures. Other thermodynamic functions (ΔH, ΔS, and ΔCp) decreased monotonously with both temperature and DP. Combined interpretation of these thermodynamic results and previously published structural data allowed assessment of an affinity profile along the length axis of the active tunnel.
Collapse
Affiliation(s)
- Francieli Colussi
- From the Roskilde University, NSM, Research Unit for Functional Biomaterials, 1 Universitetsvej, Building 28, DK-4000 Denmark and
| | - Trine H Sørensen
- From the Roskilde University, NSM, Research Unit for Functional Biomaterials, 1 Universitetsvej, Building 28, DK-4000 Denmark and
| | - Kadri Alasepp
- From the Roskilde University, NSM, Research Unit for Functional Biomaterials, 1 Universitetsvej, Building 28, DK-4000 Denmark and
| | - Jeppe Kari
- From the Roskilde University, NSM, Research Unit for Functional Biomaterials, 1 Universitetsvej, Building 28, DK-4000 Denmark and
| | - Nicolaj Cruys-Bagger
- From the Roskilde University, NSM, Research Unit for Functional Biomaterials, 1 Universitetsvej, Building 28, DK-4000 Denmark and
| | - Michael S Windahl
- From the Roskilde University, NSM, Research Unit for Functional Biomaterials, 1 Universitetsvej, Building 28, DK-4000 Denmark and Novozymes A/S, Krogshøjvej 36, DK-2880, Bagsværd, Denmark
| | - Johan P Olsen
- From the Roskilde University, NSM, Research Unit for Functional Biomaterials, 1 Universitetsvej, Building 28, DK-4000 Denmark and
| | - Kim Borch
- Novozymes A/S, Krogshøjvej 36, DK-2880, Bagsværd, Denmark
| | - Peter Westh
- From the Roskilde University, NSM, Research Unit for Functional Biomaterials, 1 Universitetsvej, Building 28, DK-4000 Denmark and
| |
Collapse
|
27
|
Pellegrini VOA, Lei N, Kyasaram M, Olsen JP, Badino SF, Windahl MS, Colussi F, Cruys-Bagger N, Borch K, Westh P. Reversibility of substrate adsorption for the cellulases Cel7A, Cel6A, and Cel7B from Hypocrea jecorina. LANGMUIR : THE ACS JOURNAL OF SURFACES AND COLLOIDS 2014; 30:12602-12609. [PMID: 25322452 DOI: 10.1021/la5024423] [Citation(s) in RCA: 14] [Impact Index Per Article: 1.4] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/04/2023]
Abstract
Adsorption of cellulases on the cellulose surface is an integral part of the catalytic mechanism, and a detailed description of the adsorption process is therefore required for a fundamental understanding of this industrially important class of enzymes. However, the mode of adsorption has proven intricate, and several key questions remain open. Perhaps most notably it is not clear whether the adsorbed enzyme is in dynamic equilibrium with the free population or irreversibly associated with no or slow dissociation. To address this, we have systematically investigated adsorption reversibility for two cellobiohydrolases (Cel7A and Cel6A) and one endoglucanase (Cel7B) on four types of pure cellulose substrates. Specifically, we monitored dilution-induced release of adsorbed enzyme in samples that had previously been brought to a steady state (constant concentration of free enzyme). In simple dilution experiments (without centrifugation), the results consistently showed full reversibility. In contrast to this, resuspension of enzyme-substrate pellets separated by centrifugation showed extensive irreversibility. We conclude that these enzymes are in a dynamic equilibrium between free and adsorbed states but suggest that changes in the physical properties of cellulose caused by compaction of the pellet hampers subsequent release of adsorbed enzyme. This latter effect may be pertinent to both previous controversies in the literature on adsorption reversibility and the development of enzyme recycling protocols in the biomass industry.
Collapse
Affiliation(s)
- Vanessa O A Pellegrini
- Research Unit for Functional Biomaterials, NSM, Roskilde University , 1 Universitetsvej, Build. 18.1, DK-4000 Roskilde, Denmark
| | | | | | | | | | | | | | | | | | | |
Collapse
|
28
|
Kari J, Olsen J, Borch K, Cruys-Bagger N, Jensen K, Westh P. Kinetics of cellobiohydrolase (Cel7A) variants with lowered substrate affinity. J Biol Chem 2014; 289:32459-68. [PMID: 25271162 DOI: 10.1074/jbc.m114.604264] [Citation(s) in RCA: 51] [Impact Index Per Article: 5.1] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/06/2022] Open
Abstract
Cellobiohydrolases are exo-active glycosyl hydrolases that processively convert cellulose to soluble sugars, typically cellobiose. They effectively break down crystalline cellulose and make up a major component in industrial enzyme mixtures used for deconstruction of lignocellulosic biomass. Identification of the rate-limiting step for cellobiohydrolases remains controversial, and recent reports have alternately suggested either association (on-rate) or dissociation (off-rate) as the overall bottleneck. Obviously, this uncertainty hampers both fundamental mechanistic understanding and rational design of enzymes with improved industrial applicability. To elucidate the role of on- and off-rates, respectively, on the overall kinetics, we have expressed a variant in which a tryptophan residue (Trp-38) in the middle of the active tunnel has been replaced with an alanine. This mutation weakens complex formation, and the population of substrate-bound W38A was only about half of the wild type. Nevertheless, the maximal, steady-state rate was twice as high for the variant enzyme. It is argued that these opposite effects on binding and activity can be reconciled if the rate-limiting step is after the catalysis (i.e. in the dissociation process).
Collapse
Affiliation(s)
- Jeppe Kari
- From Department of Science, Systems and Models, Research Unit for Functional Biomaterials, Roskilde University, 1 Universitetsvej, DK-4000 Roskilde, Denmark and
| | - Johan Olsen
- From Department of Science, Systems and Models, Research Unit for Functional Biomaterials, Roskilde University, 1 Universitetsvej, DK-4000 Roskilde, Denmark and
| | - Kim Borch
- Novozymes A/S, Krogshøjvej 36, Bagsværd DK-2880, Denmark
| | - Nicolaj Cruys-Bagger
- From Department of Science, Systems and Models, Research Unit for Functional Biomaterials, Roskilde University, 1 Universitetsvej, DK-4000 Roskilde, Denmark and
| | - Kenneth Jensen
- Novozymes A/S, Krogshøjvej 36, Bagsværd DK-2880, Denmark
| | - Peter Westh
- From Department of Science, Systems and Models, Research Unit for Functional Biomaterials, Roskilde University, 1 Universitetsvej, DK-4000 Roskilde, Denmark and
| |
Collapse
|
29
|
Jalak J, Väljamäe P. Multi-mode binding of Cellobiohydrolase Cel7A from Trichoderma reesei to cellulose. PLoS One 2014; 9:e108181. [PMID: 25265511 PMCID: PMC4180464 DOI: 10.1371/journal.pone.0108181] [Citation(s) in RCA: 30] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/22/2014] [Accepted: 08/19/2014] [Indexed: 01/26/2023] Open
Abstract
Enzymatic hydrolysis of recalcitrant polysaccharides like cellulose takes place on the solid-liquid interface. Therefore the adsorption of enzymes to the solid surface is a pre-requisite for catalysis. Here we used enzymatic activity measurements with fluorescent model-substrate 4-methyl-umbelliferyl-β-D-lactoside for sensitive monitoring of the binding of cellobiohydrolase TrCel7A from Trichoderma reesei to bacterial cellulose (BC). The binding at low nanomolar free TrCel7A concentrations was exclusively active site mediated and was consistent with Langmuir's one binding site model with Kd and Amax values of 2.9 nM and 126 nmol/g BC, respectively. This is the strongest binding observed with non-complexed cellulases and apparently represents the productive binding of TrCel7A to cellulose chain ends on the hydrophobic face of BC microfibril. With increasing free TrCel7A concentrations the isotherm gradually deviated from the Langmuir's one binding site model. This was caused by the increasing contribution of lower affinity binding modes that included both active site mediated binding and non-productive binding with active site free from cellulose chain. The binding of TrCel7A to BC was found to be only partially reversible. Furthermore, the isotherm was dependent on the concentration of BC with more efficient binding observed at lower BC concentrations. The phenomenon can be ascribed to the BC concentration dependent aggregation of BC microfibrils with concomitant reduction of specific surface area.
Collapse
Affiliation(s)
- Jürgen Jalak
- Institute of Molecular and Cell Biology, University of Tartu, Tartu, Estonia
| | - Priit Väljamäe
- Institute of Molecular and Cell Biology, University of Tartu, Tartu, Estonia
- * E-mail:
| |
Collapse
|
30
|
Alasepp K, Borch K, Cruys-Bagger N, Badino S, Jensen K, Sørensen TH, Windahl MS, Westh P. In situ stability of substrate-associated cellulases studied by DSC. LANGMUIR : THE ACS JOURNAL OF SURFACES AND COLLOIDS 2014; 30:7134-7142. [PMID: 24856176 DOI: 10.1021/la500161e] [Citation(s) in RCA: 14] [Impact Index Per Article: 1.4] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/03/2023]
Abstract
This work shows that differential scanning calorimetry (DSC) can be used to monitor the stability of substrate-adsorbed cellulases during long-term hydrolysis of insoluble cellulose. Thermal transitions of adsorbed enzyme were measured regularly in subsets of a progressing hydrolysis, and the size of the transition peak was used as a gauge of the population of native enzyme. Analogous measurements were made for enzymes in pure buffer. Investigations of two cellobiohydrolases, Cel6A and Cel7A, from Trichoderma reesei, which is an anamorph of the fungus Hypocrea jerorina, showed that these enzymes were essentially stable at 25 °C. Thus, over a 53 h experiment, Cel6A lost less than 15% of the native population and Cel7A showed no detectable loss for either the free or substrate-adsorbed state. At higher temperatures we found significant losses in the native populations, and at the highest tested temperature (49 °C) about 80% Cel6A and 35% of Cel7A was lost after 53 h of hydrolysis. The data consistently showed that Cel7A was more long-term stable than Cel6A and that substrate-associated enzyme was less long-term stable than enzyme in pure buffer stored under otherwise equal conditions. There was no correlation between the intrinsic stability, specified by the transition temperature in the DSC, and the long-term stability derived from the peak area. The results are discussed with respect to the role of enzyme denaturation for the ubiquitous slowdown observed in the enzymatic hydrolysis of cellulose.
Collapse
Affiliation(s)
- Kadri Alasepp
- Research Unit for Functional Biomaterials, NSM, Roskilde University. 1 Universitetsvej , Build. 18.1, DK-4000 Roskilde Denmark
| | | | | | | | | | | | | | | |
Collapse
|
31
|
Shang BZ, Chu JW. Kinetic Modeling at Single-Molecule Resolution Elucidates the Mechanisms of Cellulase Synergy. ACS Catal 2014. [DOI: 10.1021/cs500126q] [Citation(s) in RCA: 19] [Impact Index Per Article: 1.9] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/07/2023]
Affiliation(s)
- Barry Z. Shang
- Department
of Chemical and Biomolecular Engineering, University of California, Berkeley, California 94720, United States
| | - Jhih-Wei Chu
- Department
of Chemical and Biomolecular Engineering, University of California, Berkeley, California 94720, United States
- Department
of Biological Science and Technology, National Chiao Tung University, Hsinchu, Taiwan, ROC
- Institute
of Bioinformatics and Systems Biology, National Chiao Tung University, Hsinchu, Taiwan, ROC
| |
Collapse
|
32
|
Specificity of O-glycosylation in enhancing the stability and cellulose binding affinity of Family 1 carbohydrate-binding modules. Proc Natl Acad Sci U S A 2014; 111:7612-7. [PMID: 24821760 DOI: 10.1073/pnas.1402518111] [Citation(s) in RCA: 67] [Impact Index Per Article: 6.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/18/2022] Open
Abstract
The majority of biological turnover of lignocellulosic biomass in nature is conducted by fungi, which commonly use Family 1 carbohydrate-binding modules (CBMs) for targeting enzymes to cellulose. Family 1 CBMs are glycosylated, but the effects of glycosylation on CBM function remain unknown. Here, the effects of O-mannosylation are examined on the Family 1 CBM from the Trichoderma reesei Family 7 cellobiohydrolase at three glycosylation sites. To enable this work, a procedure to synthesize glycosylated Family 1 CBMs was developed. Subsequently, a library of 20 CBMs was synthesized with mono-, di-, or trisaccharides at each site for comparison of binding affinity, proteolytic stability, and thermostability. The results show that, although CBM mannosylation does not induce major conformational changes, it can increase the thermolysin cleavage resistance up to 50-fold depending on the number of mannose units on the CBM and the attachment site. O-Mannosylation also increases the thermostability of CBM glycoforms up to 16 °C, and a mannose disaccharide at Ser3 seems to have the largest themostabilizing effect. Interestingly, the glycoforms with small glycans at each site displayed higher binding affinities for crystalline cellulose, and the glycoform with a single mannose at each of three positions conferred the highest affinity enhancement of 7.4-fold. Overall, by combining chemical glycoprotein synthesis and functional studies, we show that specific glycosylation events confer multiple beneficial properties on Family 1 CBMs.
Collapse
|
33
|
Lee DS, Wi SG, Lee SJ, Lee YG, Kim YS, Bae HJ. Rapid saccharification for production of cellulosic biofuels. BIORESOURCE TECHNOLOGY 2014; 158:239-47. [PMID: 24607460 DOI: 10.1016/j.biortech.2014.02.039] [Citation(s) in RCA: 14] [Impact Index Per Article: 1.4] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/26/2013] [Revised: 02/07/2014] [Accepted: 02/10/2014] [Indexed: 05/11/2023]
Abstract
The economical production of biofuels is hindered by the recalcitrance of lignocellulose to processing, causing high consumption of processing enzymes and impeding hydrolysis of pretreated lignocellulosic biomass. We determined the major rate-limiting factor in the hydrolysis of popping pre-treated rice straw (PPRS) by examining cellulase adsorption to lignin and cellulose, amorphogenesis of PPRS, and re-hydrolysis. Based on the results, equivalence between enzyme loading and the open structural area of cellulose was required to significantly increase productive adsorption of cellulase and to accelerate enzymatic saccharification of PPRS. Amorphogenesis of PPRS by phosphoric acid treatment to expand open structural area of the cellulose fibers resulted in twofold higher cellulase adsorption and increased the yield of the first re-hydrolysis step from 13% to 46%. The total yield from PPRS was increased to 84% after 3h. These results provide evidence that cellulose structure is one of major effects on the enzymatic hydrolysis.
Collapse
Affiliation(s)
- Dae-Seok Lee
- Bio-energy Research Institute, Chonnam National University, Gwangju 500-757, Republic of Korea
| | - Seung Gon Wi
- Bio-energy Research Institute, Chonnam National University, Gwangju 500-757, Republic of Korea
| | - Soo Jung Lee
- Bio-energy Research Institute, Chonnam National University, Gwangju 500-757, Republic of Korea
| | - Yoon-Gyo Lee
- Department of Forest Products and Technology, Chonnam National University, Gwangju 500-757, Republic of Korea
| | - Yeong-Suk Kim
- Department of Forest Products, Kookmin University, Seoul 136-702, Republic of Korea
| | - Hyeun-Jong Bae
- Bio-energy Research Institute, Chonnam National University, Gwangju 500-757, Republic of Korea; Department of Forest Products and Technology, Chonnam National University, Gwangju 500-757, Republic of Korea; Department of Bioenergy Science and Technology, Chonnam National University, Gwangju 500-757, Republic of Korea.
| |
Collapse
|
34
|
Wahlström R, Rahikainen J, Kruus K, Suurnäkki A. Cellulose hydrolysis and binding with Trichoderma reesei Cel5A and Cel7A and their core domains in ionic liquid solutions. Biotechnol Bioeng 2013; 111:726-33. [PMID: 24258388 DOI: 10.1002/bit.25144] [Citation(s) in RCA: 24] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/26/2013] [Revised: 09/26/2013] [Accepted: 10/28/2013] [Indexed: 11/06/2022]
Abstract
Ionic liquids (ILs) dissolve lignocellulosic biomass and have a high potential as pretreatment prior to total enzymatic hydrolysis. ILs are, however, known to inactivate cellulases. In this article, enzymatic hydrolysis of microcrystalline cellulose (MCC) and enzyme binding onto the cellulosic substrate were studied in the presence of cellulose-dissolving ILs. Two different ILs, 1,3-dimethylimidazolium dimethylphosphate ([DMIM]DMP) and 1-ethyl-3-methylimidazolium acetate ([EMIM]AcO), and two monocomponent cellulases, Trichoderma reesei cellobiohydrolase Cel7A and endoglucanase Cel5A, were used in the study. The role and IL sensitivity of the carbohydrate-binding module (CBM) were studied by performing hydrolysis and binding experiments with both the intact cellulases, and their respective core domains (CDs). Based on hydrolysis yields and substrate binding experiments for the intact enzymes and their CDs in the presence of ILs, the function of the CBM appeared to be very IL sensitive. Binding data suggested that the CBM was more important for the substrate binding of endoglucanase Cel5A than for the binding of cellobiohydrolase Cel7A. The CD of Cel7A was able to bind well to cellulose even without a CBM, whereas Cel5A CD had very low binding affinity. Hydrolysis also occurred with Cel5A CD even if this protein had very low binding affinity in all the studied matrices. Binding and hydrolysis were less affected by the studied ILs for Cel7A than for Cel5A. To our knowledge, this is the first systematic study of IL effects on cellulase substrate binding.
Collapse
Affiliation(s)
- Ronny Wahlström
- VTT - Technical Research Centre of Finland, P.O. Box 1000, FI-02044 VTT, Espoo, Uusimaa, Finland.
| | | | | | | |
Collapse
|
35
|
Teugjas H, Väljamäe P. Product inhibition of cellulases studied with 14C-labeled cellulose substrates. BIOTECHNOLOGY FOR BIOFUELS 2013; 6:104. [PMID: 23883520 PMCID: PMC3726336 DOI: 10.1186/1754-6834-6-104] [Citation(s) in RCA: 57] [Impact Index Per Article: 5.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/20/2013] [Accepted: 07/11/2013] [Indexed: 05/02/2023]
Abstract
BACKGROUND As a green alternative for the production of transportation fuels, the enzymatic hydrolysis of lignocellulose and subsequent fermentation to ethanol are being intensively researched. To be economically feasible, the hydrolysis of lignocellulose must be conducted at a high concentration of solids, which results in high concentrations of hydrolysis end-products, cellobiose and glucose, making the relief of product inhibition of cellulases a major challenge in the process. However, little quantitative information on the product inhibition of individual cellulases acting on cellulose substrates is available because it is experimentally difficult to assess the hydrolysis of the heterogeneous polymeric substrate in the high background of added products. RESULTS The cellobiose and glucose inhibition of thermostable cellulases from Acremonium thermophilum, Thermoascus aurantiacus, and Chaetomium thermophilum acting on uniformly 14C-labeled bacterial cellulose and its derivatives, 14C-bacterial microcrystalline cellulose and 14C-amorphous cellulose, was studied. Cellulases from Trichoderma reesei were used for comparison. The enzymes most sensitive to cellobiose inhibition were glycoside hydrolase (GH) family 7 cellobiohydrolases (CBHs), followed by family 6 CBHs and endoglucanases (EGs). The strength of glucose inhibition followed the same order. The product inhibition of all enzymes was relieved at higher temperatures. The inhibition strength measured for GH7 CBHs with low molecular-weight model substrates did not correlate with that measured with 14C-cellulose substrates. CONCLUSIONS GH7 CBHs are the primary targets for product inhibition of the synergistic hydrolysis of cellulose. The inhibition must be studied on cellulose substrates instead of on low molecular-weight model substrates when selecting enzymes for lignocellulose hydrolysis. The advantages of using higher temperatures are an increase in the catalytic efficiency of enzymes and the relief of product inhibition.
Collapse
Affiliation(s)
- Hele Teugjas
- Institute of Molecular and Cell Biology, University of Tartu, Riia 23b – 202, Tartu 51010, Estonia
| | - Priit Väljamäe
- Institute of Molecular and Cell Biology, University of Tartu, Riia 23b – 202, Tartu 51010, Estonia
| |
Collapse
|
36
|
Cruys-Bagger N, Elmerdahl J, Praestgaard E, Borch K, Westh P. A steady-state theory for processive cellulases. FEBS J 2013; 280:3952-61. [PMID: 23786663 DOI: 10.1111/febs.12397] [Citation(s) in RCA: 45] [Impact Index Per Article: 4.1] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/19/2013] [Revised: 05/17/2013] [Accepted: 06/13/2013] [Indexed: 11/28/2022]
Abstract
Processive enzymes perform sequential steps of catalysis without dissociating from their polymeric substrate. This mechanism is considered essential for efficient enzymatic hydrolysis of insoluble cellulose (particularly crystalline cellulose), but a theoretical framework for processive kinetics remains to be fully developed. In this paper, we suggest a deterministic kinetic model that relies on a processive set of enzyme reactions and a quasi steady-state assumption. It is shown that this approach is practicable in the sense that it leads to mathematically simple expressions for the steady-state rate, and only requires data from standard assay techniques as experimental input. Specifically, it is shown that the processive reaction rate at steady state may be expressed by a hyperbolic function related to the conventional Michaelis-Menten equation. The main difference is a 'kinetic processivity coefficient', which represents the probability of the enzyme dissociating from the substrate strand before completing n sequential catalytic steps, where n is the mean processivity number measured experimentally. Typical processive cellulases have high substrate affinity, and therefore this probability is low. This has significant kinetic implications, for example the maximal specific rate (V(max)/E₀) for processive cellulases is much lower than the catalytic rate constant (k(cat)). We discuss how relationships based on this theory may be used in both comparative and mechanistic analyses of cellulases.
Collapse
Affiliation(s)
- Nicolaj Cruys-Bagger
- Department of Science, Systems and Models, Research Unit for Functional Biomaterials, Roskilde University, Roskilde, Denmark
| | | | | | | | | |
Collapse
|
37
|
Increased enzyme binding to substrate is not necessary for more efficient cellulose hydrolysis. Proc Natl Acad Sci U S A 2013; 110:10922-7. [PMID: 23784776 DOI: 10.1073/pnas.1213426110] [Citation(s) in RCA: 73] [Impact Index Per Article: 6.6] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/18/2022] Open
Abstract
Substrate binding is typically one of the rate-limiting steps preceding enzyme catalytic action during homogeneous reactions. However, interfacial-based enzyme catalysis on insoluble crystalline substrates, like cellulose, has additional bottlenecks of individual biopolymer chain decrystallization from the substrate interface followed by its processive depolymerization to soluble sugars. This additional decrystallization step has ramifications on the role of enzyme-substrate binding and its relationship to overall catalytic efficiency. We found that altering the crystalline structure of cellulose from its native allomorph I(β) to III(I) results in 40-50% lower binding partition coefficient for fungal cellulases, but surprisingly, it enhanced hydrolytic activity on the latter allomorph. We developed a comprehensive kinetic model for processive cellulases acting on insoluble substrates to explain this anomalous finding. Our model predicts that a reduction in the effective binding affinity to the substrate coupled with an increase in the decrystallization procession rate of individual cellulose chains from the substrate surface into the enzyme active site can reproduce our anomalous experimental findings.
Collapse
|
38
|
Pribowo AY, Hu J, Arantes V, Saddler JN. The development and use of an ELISA-based method to follow the distribution of cellulase monocomponents during the hydrolysis of pretreated corn stover. BIOTECHNOLOGY FOR BIOFUELS 2013; 6:80. [PMID: 23687947 PMCID: PMC3666928 DOI: 10.1186/1754-6834-6-80] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.4] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/06/2013] [Accepted: 05/10/2013] [Indexed: 05/11/2023]
Abstract
BACKGROUND It is widely recognised that fast, effective hydrolysis of pretreated lignocellulosic substrates requires the synergistic action of multiple types of hydrolytic and some non-hydrolytic proteins. However, due to the complexity of the enzyme mixture, the enzymes interaction with and interference from the substrate and a lack of specific methods to follow the distribution of individual enzymes during hydrolysis, most of enzyme-substrate interaction studies have used purified enzymes and pure cellulose model substrates. As the enzymes present in a typical "cellulase mixture" need to work cooperatively to achieve effective hydrolysis, the action of one enzyme is likely to influence the behaviour of others. The action of the enzymes will be further influenced by the nature of the lignocellulosic substrate. Therefore, it would be beneficial if a method could be developed that allowed us to follow some of the individual enzymes present in a cellulase mixture during hydrolysis of more commercially realistic biomass substrates. RESULTS A high throughput immunoassay that could quantitatively and specifically follow individual cellulase enzymes during hydrolysis was developed. Using monoclonal and polyclonal antibodies (MAb and PAb, respectively), a double-antibody sandwich enzyme-linked immunosorbent assay (ELISA) was developed to specifically quantify cellulase enzymes from Trichoderma reesei: cellobiohydrolase I (Cel7A), cellobiohydrolase II (Cel6A), and endoglucanase I (Cel7B). The interference from substrate materials present in lignocellulosic supernatants could be minimized by dilution. CONCLUSION A double-antibody sandwich ELISA was able to detect and quantify individual enzymes when present in cellulase mixtures. The assay was sensitive over a range of relatively low enzyme concentration (0 - 1 μg/ml), provided the enzymes were first pH adjusted and heat treated to increase their antigenicity. The immunoassay was employed to quantitatively monitor the adsorption of cellulase monocomponents, Cel7A, Cel6A, and Cel7B, that were present in both Celluclast and Accellerase 1000, during the hydrolysis of steam-pretreated corn stover (SPCS). All three enzymes exhibited different individual adsorption profiles. The specific and quantitative adsorption profiles observed with the ELISA method were in agreement with earlier work where more labour intensive enzyme assay techniques were used.
Collapse
Affiliation(s)
- Amadeus Y Pribowo
- Forest Products Biotechnology/Bioenergy Group, University of British Columbia, 2424 Main Mall, Vancouver, British Columbia, V6T1Z4, Canada
| | - Jinguang Hu
- Forest Products Biotechnology/Bioenergy Group, University of British Columbia, 2424 Main Mall, Vancouver, British Columbia, V6T1Z4, Canada
| | - Valdeir Arantes
- Forest Products Biotechnology/Bioenergy Group, University of British Columbia, 2424 Main Mall, Vancouver, British Columbia, V6T1Z4, Canada
| | - Jack N Saddler
- Forest Products Biotechnology/Bioenergy Group, University of British Columbia, 2424 Main Mall, Vancouver, British Columbia, V6T1Z4, Canada
| |
Collapse
|
39
|
Guo J, Catchmark JM. Binding Specificity and Thermodynamics of Cellulose-Binding Modules from Trichoderma reesei Cel7A and Cel6A. Biomacromolecules 2013; 14:1268-77. [DOI: 10.1021/bm300810t] [Citation(s) in RCA: 47] [Impact Index Per Article: 4.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/10/2023]
Affiliation(s)
- Jing Guo
- Intercollege
Graduate Degree Program in Plant Biology, §Department of Agricultural and Biological
Engineering, ‡Center for NanoCellulosics, The Pennsylvania State University, University Park, Pennsylvania 16802,
United States
| | - Jeffrey M. Catchmark
- Intercollege
Graduate Degree Program in Plant Biology, §Department of Agricultural and Biological
Engineering, ‡Center for NanoCellulosics, The Pennsylvania State University, University Park, Pennsylvania 16802,
United States
| |
Collapse
|
40
|
Matano Y, Hasunuma T, Kondo A. Simultaneous improvement of saccharification and ethanol production from crystalline cellulose by alleviation of irreversible adsorption of cellulase with a cell surface-engineered yeast strain. Appl Microbiol Biotechnol 2012. [DOI: 10.1007/s00253-012-4587-x] [Citation(s) in RCA: 18] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/28/2022]
|
41
|
Aoyama A, Kurane R, Nagai K. Penicillium sp. strain that efficiently adsorbs lignosulfonate in the presence of sulfate ion. J Biosci Bioeng 2012; 115:279-83. [PMID: 23085419 DOI: 10.1016/j.jbiosc.2012.09.019] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.2] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/26/2012] [Revised: 09/21/2012] [Accepted: 09/25/2012] [Indexed: 10/27/2022]
Abstract
Lignin is one of the major water insoluble substances that support the physical properties of plants and can be solubilized by sulfite or alkaline treatment in accordance with pulpification. The lignin derivatives produced by both the sulfite and the kraft processes are called lignosulfonate (LS) and kraft lignin (KL), respectively, and both derivatives show a broad spectrum of optical absorbance from ultraviolet to visible light. When the spore suspension of an isolated Penicillium sp., Penicillium sp. A, was inoculated to a medium containing 0.1% commercial LS, absorbance at 480 nm (A480) almost completely disappeared after 5 days of cultivation. Maximum decolorization of the culture broth was observed when the microbe was cultured in the 0.8% LS medium reaching 88%, and the amount of LS removed was calculated to be 7 g/L. In a similar assay with the dark-liquid containing KL, 80% of the A480 of a 20% (v/v) dark-liquid medium disappeared after 5 days of culturing and the amount of KL removed was calculated to be 2.9 g/L. These values significantly exceeded the previously reported amounts with respect to substrate concentration and decolorization. Furthermore, since similar results were obtained in the cases of both LS and KL, it is expected that the present strain is able to non-specifically adsorb a wide range of lignin derivatives, because most of the colored substances were recovered in the culture sediments. Thus, the strain can be used to clean up waste fluids containing water soluble lignin derivatives, adsorb lignin derivatives in waste fluids before dehydration.
Collapse
Affiliation(s)
- Akihisa Aoyama
- Department of Biological Chemistry, College of Bioscience and Biotechnology, Chubu University, 1200 Matsumoto-cho, Kasugai, Aichi, Japan.
| | | | | |
Collapse
|
42
|
Kumar R, Hu F, Sannigrahi P, Jung S, Ragauskas AJ, Wyman CE. Carbohydrate derived-pseudo-lignin can retard cellulose biological conversion. Biotechnol Bioeng 2012; 110:737-53. [DOI: 10.1002/bit.24744] [Citation(s) in RCA: 156] [Impact Index Per Article: 13.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/27/2012] [Revised: 07/26/2012] [Accepted: 09/24/2012] [Indexed: 11/08/2022]
|
43
|
Taneda D, Ueno Y, Ikeo M, Okino S. Characteristics of enzyme hydrolysis of cellulose under static condition. BIORESOURCE TECHNOLOGY 2012; 121:154-60. [PMID: 22858480 DOI: 10.1016/j.biortech.2012.06.104] [Citation(s) in RCA: 14] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/08/2012] [Revised: 06/26/2012] [Accepted: 06/28/2012] [Indexed: 05/14/2023]
Abstract
The effect of enzyme loading under static and agitated conditions was investigated. Enzymatic hydrolysis of 10 w/v% de-lignified cellulose slurry such as filter paper, avicel and pulp was conducted under agitated (120 rpm) and static condition, and the enzyme loading ranging from 1.2 to 120 mg-protein/g-dry substrate. Under the agitated condition, the final sugar concentration decreased with the decreasing enzyme loading. Under the static condition, the final sugar concentration was maintained even if the enzyme loading was decreased. The above phenomenon was caused by a rapid precipitation of cellobiohydrolase 2 (CBH2) under the agitated condition, which was not observed under the static condition. The hydrolysis experiments using enzymes containing different ratios of cellobiohydrolase 1 (CBH1) and CBH2 under the static condition suggested that preservation of CBH2 and its synergism with CBH1 is essential for static condition's characteristics, and for efficient hydrolysis of cellulose.
Collapse
Affiliation(s)
- Daisuke Taneda
- JGC Corporation, 2205, Narita-cho, Oarai-machi, Higashiibaraki-gun, Ibaraki Pref., 311-1313, Japan.
| | | | | | | |
Collapse
|
44
|
Segato F, Damasio ARL, Gonçalves TA, Murakami MT, Squina FM, Polizeli M, Mort AJ, Prade RA. Two structurally discrete GH7-cellobiohydrolases compete for the same cellulosic substrate fiber. BIOTECHNOLOGY FOR BIOFUELS 2012; 5:21. [PMID: 22494694 PMCID: PMC3431977 DOI: 10.1186/1754-6834-5-21] [Citation(s) in RCA: 14] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/14/2011] [Accepted: 03/30/2012] [Indexed: 05/14/2023]
Abstract
BACKGROUND Cellulose consisting of arrays of linear beta-1,4 linked glucans, is the most abundant carbon-containing polymer present in biomass. Recalcitrance of crystalline cellulose towards enzymatic degradation is widely reported and is the result of intra- and inter-molecular hydrogen bonds within and among the linear glucans. Cellobiohydrolases are enzymes that attack crystalline cellulose. Here we report on two forms of glycosyl hydrolase family 7 cellobiohydrolases common to all Aspergillii that attack Avicel, cotton cellulose and other forms of crystalline cellulose. RESULTS Cellobiohydrolases Cbh1 and CelD have similar catalytic domains but only Cbh1 contains a carbohydrate-binding domain (CBD) that binds to cellulose. Structural superpositioning of Cbh1 and CelD on the Talaromyces emersonii Cel7A 3-dimensional structure, identifies the typical tunnel-like catalytic active site while Cbh1 shows an additional loop that partially obstructs the substrate-fitting channel. CelD does not have a CBD and shows a four amino acid residue deletion on the tunnel-obstructing loop providing a continuous opening in the absence of a CBD. Cbh1 and CelD are catalytically functional and while specific activity against Avicel is 7.7 and 0.5 U.mg prot-1, respectively specific activity on pNPC is virtually identical. Cbh1 is slightly more stable to thermal inactivation compared to CelD and is much less sensitive to glucose inhibition suggesting that an open tunnel configuration, or absence of a CBD, alters the way the catalytic domain interacts with the substrate. Cbh1 and CelD enzyme mixtures on crystalline cellulosic substrates show a strong combinatorial effort response for mixtures where Cbh1 is present in 2:1 or 4:1 molar excess. When CelD was overrepresented the combinatorial effort could only be partially overcome. CelD appears to bind and hydrolyze only loose cellulosic chains while Cbh1 is capable of opening new cellulosic substrate molecules away from the cellulosic fiber. CONCLUSION Cellobiohydrolases both with and without a CBD occur in most fungal genomes where both enzymes are secreted, and likely participate in cellulose degradation. The fact that only Cbh1 binds to the substrate and in combination with CelD exhibits strong synergy only when Cbh1 is present in excess, suggests that Cbh1 unties enough chains from cellulose fibers, thus enabling processive access of CelD.
Collapse
Affiliation(s)
- Fernando Segato
- Department of Microbiology & Molecular Genetics, Oklahoma State University, Stillwater, OK, USA
- Laboratório Nacional de Ciência e Tecnologia do Bioetanol (CTBE), Centro Nacional de Pesquisas em Energia e Materiais, Campinas, Sao Paulo, Brazil
| | - André R L Damasio
- Department of Microbiology & Molecular Genetics, Oklahoma State University, Stillwater, OK, USA
- Department of Biochemistry, Ribeirão Preto School of Medicine, Ribeirão Preto, Sao Paulo, Brazil
| | - Thiago Augusto Gonçalves
- Laboratório Nacional de Ciência e Tecnologia do Bioetanol (CTBE), Centro Nacional de Pesquisas em Energia e Materiais, Campinas, Sao Paulo, Brazil
| | - Mario T Murakami
- Laboratório Nacional de Biociências (LNBio), Campinas, Sao Paulo, Brazil
| | - Fabio M Squina
- Laboratório Nacional de Ciência e Tecnologia do Bioetanol (CTBE), Centro Nacional de Pesquisas em Energia e Materiais, Campinas, Sao Paulo, Brazil
| | | | - Andrew J Mort
- Department of Biochemistry and Molecular Biology, Oklahoma State University, Stillwater, OK, USA
| | - Rolf A Prade
- Department of Microbiology & Molecular Genetics, Oklahoma State University, Stillwater, OK, USA
- Laboratório Nacional de Ciência e Tecnologia do Bioetanol (CTBE), Centro Nacional de Pesquisas em Energia e Materiais, Campinas, Sao Paulo, Brazil
| |
Collapse
|
45
|
Rodrigues AC, Leitão AF, Moreira S, Felby C, Gama M. Recycling of cellulases in lignocellulosic hydrolysates using alkaline elution. BIORESOURCE TECHNOLOGY 2012; 110:526-33. [PMID: 22357293 DOI: 10.1016/j.biortech.2012.01.140] [Citation(s) in RCA: 24] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/31/2011] [Revised: 01/20/2012] [Accepted: 01/24/2012] [Indexed: 05/18/2023]
Abstract
The recovery of cellulases from lignin, lignocellulosic hydrolysates and cellulose by alkaline washes at pH 9 and 10 was examined. The effect of the pH on the structural stability of purified Cel7A was analyzed by circular dichroism. Purified Cel7A showed conformational changes at pH 9 and 10 that were reversible at pH 4.8. Temperature influenced the enzymatic hydrolysis of wheat straw and may be critical for the efficiency of cellulase recycling from wheat straw hydrolysates. Operation at moderate temperatures (37°C) resulted in a rate of saccharification 19% higher than that obtained at 50° C, improving cellulase recycling by 49%. Over 60% of the enzyme activity on the synthetic substrate 4-methylumbelliferyl-β-d-cellobioside (MUC) may be recovered by using a simple alkaline wash. This is thus a promising strategy for enzyme recycling that is simple to implement at industrial scale, economical and effective.
Collapse
Affiliation(s)
- Ana Cristina Rodrigues
- Departamento Engenharia Biológica, Universidade do Minho, Campus de Gualtar 4710-057 Braga, Portugal
| | | | | | | | | |
Collapse
|
46
|
The adsorption and enzyme activity profiles of specific Trichoderma reesei cellulase/xylanase components when hydrolyzing steam pretreated corn stover. Enzyme Microb Technol 2012; 50:195-203. [DOI: 10.1016/j.enzmictec.2011.12.004] [Citation(s) in RCA: 66] [Impact Index Per Article: 5.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/31/2011] [Revised: 12/07/2011] [Accepted: 12/19/2011] [Indexed: 11/23/2022]
|
47
|
Abstract
Natural cellulolytic enzyme systems as well as leading commercial cellulase cocktails are dominated by enzymes that degrade cellulose chains in a processive manner. Despite the abundance of processivity among natural cellulases, the molecular basis as well as the biotechnological implications of this mechanism are only partly understood. One of the major limitations lies in the fact that it is not straightforward to measure and quantify processivity in what essentially are biphasic experimental systems. Here, we describe and discuss both well-established methods and newer methods for measuring cellulase processivity. In addition, we discuss recent insights from studies on chitinases that may help direct further studies on processivity in cellulases.
Collapse
Affiliation(s)
- Svein J Horn
- Department of Chemistry, Biotechnology and Food Science, Norwegian University of Life Sciences, Aas, Norway
| | | | | | | | | |
Collapse
|
48
|
Igarashi K, Uchihashi T, Koivula A, Wada M, Kimura S, Okamoto T, Penttilä M, Ando T, Samejima M. Traffic jams reduce hydrolytic efficiency of cellulase on cellulose surface. Science 2011; 333:1279-82. [PMID: 21885779 DOI: 10.1126/science.1208386] [Citation(s) in RCA: 350] [Impact Index Per Article: 26.9] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/02/2022]
Abstract
A deeper mechanistic understanding of the saccharification of cellulosic biomass could enhance the efficiency of biofuels development. We report here the real-time visualization of crystalline cellulose degradation by individual cellulase enzymes through use of an advanced version of high-speed atomic force microscopy. Trichoderma reesei cellobiohydrolase I (TrCel7A) molecules were observed to slide unidirectionally along the crystalline cellulose surface but at one point exhibited collective halting analogous to a traffic jam. Changing the crystalline polymorphic form of cellulose by means of an ammonia treatment increased the apparent number of accessible lanes on the crystalline surface and consequently the number of moving cellulase molecules. Treatment of this bulky crystalline cellulose simultaneously or separately with T. reesei cellobiohydrolase II (TrCel6A) resulted in a remarkable increase in the proportion of mobile enzyme molecules on the surface. Cellulose was completely degraded by the synergistic action between the two enzymes.
Collapse
Affiliation(s)
- Kiyohiko Igarashi
- Department of Biomaterial Sciences, Graduate School of Agricultural and Life Sciences, University of Tokyo, Bunkyo-ku, Tokyo 113-8657, Japan.
| | | | | | | | | | | | | | | | | |
Collapse
|
49
|
Suchy M, Linder MB, Tammelin T, Campbell JM, Vuorinen T, Kontturi E. Quantitative assessment of the enzymatic degradation of amorphous cellulose by using a quartz crystal microbalance with dissipation monitoring. LANGMUIR : THE ACS JOURNAL OF SURFACES AND COLLOIDS 2011; 27:8819-28. [PMID: 21699170 DOI: 10.1021/la2014418] [Citation(s) in RCA: 30] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 05/06/2023]
Abstract
The systematic evaluation of the degradation of an amorphous cellulose film by a monocomponent endoglucanase (EG I) by using a quartz crystal microbalance with dissipation monitoring (QCM-D) identified several important aspects relevant to the study the kinetics of cellulose degradation by enzymes. It was demonstrated that, to properly evaluate the mechanism of action, steady state conditions in the experimental set up need to be reached. Rinsing or diluting the enzyme, as well as concentration of the enzyme, can have a pronounced effect on the hydrolysis. Quantification of the actual hydrolysis was carried out by measuring the film thickness reduction by atomic force microscopy after the enzymatic treatment. The values correlated well with the frequency data obtained by QCM-D measurement for corresponding films. This demonstrated that the evaluation of hydrolysis by QCM-D can be done quantitatively. Tuning of the initial thickness of films enabled variation of the volume of substrate available for hydrolysis which was then utilized in establishing a correlation between substrate volume and hydrolytic activity of EG I as measured by QCM-D. It was shown that, although the amount of substrate affects the absolute rate of hydrolysis, the relative rate of hydrolysis does not depend on the initial amount of substrate in steady state system. With this experimental setup it was also possible to demonstrate the impact of concentration on crowding of enzyme and subsequent hydrolysis efficiency. This effort also shows the action of EG I on a fully amorphous substrate as observed by QCM-D. The enzyme was shown to work uniformly within the whole volume of swollen film, however being unable to fully degrade the amorphous film.
Collapse
Affiliation(s)
- Miro Suchy
- Department of Forest Products Technology, School of Chemical Technology, Aalto University, Aalto, Finland
| | | | | | | | | | | |
Collapse
|
50
|
Prakash P, Jayalakshmi SK, Prakash B, Rubul M, Sreeramulu K. Production of alkaliphilic, halotolerent, thermostable cellulase free xylanase by Bacillus halodurans PPKS-2 using agro waste: single step purification and characterization. World J Microbiol Biotechnol 2011; 28:183-92. [DOI: 10.1007/s11274-011-0807-2] [Citation(s) in RCA: 23] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/07/2011] [Accepted: 05/29/2011] [Indexed: 11/30/2022]
|