Synthetic surfactant based on analogues of SP-B and SP-C is superior to single-peptide surfactants in ventilated premature rabbits

Transamniotic Delivery of Surfactant Protein B mRNA in a Healthy Model

INTRODUCTION

We sought to determine whether exogenous surfactant protein B (SPB) mRNA could be incorporated and translated by the fetal lung after simple transamniotic administration.

METHODS

Fetuses (n = 149) of twelve time-dated dams underwent intra-amniotic injections of either human SPB (hSPB) mRNA encapsulated into lipopolyplex (mRNA, n = 99) or lipopolyplex without mRNA (control; n = 50) on gestational day 17 (E17, term = E21-22). Lungs were screened for hSPB by enzyme-linked immunosorbent assay daily until term. Phosphatidylcholine (PC) (a surrogate for surfactant production) was measured in the amniotic fluid by fluorometric assay. Statistical analysis included nonparametric Wilcoxon rank sum test.

RESULTS

Significantly improved survival in the mRNA group compared to controls was observed at E18 (100% vs. 85.7%) and E20 (100% vs. 83.3%) (both p < 0.001). When controlled by mRNA-free injections, hSPB protein was detected in the mRNA group's lungs at E18, 19, and term (p = 0.002 to <0.001). Amniotic fluid PC levels were increased compared to control at term [285.9 (251.1, 363.9) μM versus 263.1 (222.8, 309.1) μM]; however, this did not reach significance (p = 0.33).

CONCLUSIONS

Encapsulated exogenous SPB mRNA can be incorporated and translated by fetal lung cells following intra-amniotic injection in a healthy rat model. Transamniotic mRNA delivery could become a novel strategy for perinatal surfactant protein replacement.

Pulmonary Surfactant: A Mighty Thin Film

Pulmonary surfactant is a critical component of lung function in healthy individuals. It functions in part by lowering surface tension in the alveoli, thereby allowing for breathing with minimal effort. The prevailing thinking is that low surface tension is attained by a compression-driven squeeze-out of unsaturated phospholipids during exhalation, forming a film enriched in saturated phospholipids that achieves surface tensions close to zero. A thorough review of past and recent literature suggests that the compression-driven squeeze-out mechanism may be erroneous. Here, we posit that a surfactant film enriched in saturated lipids is formed shortly after birth by an adsorption-driven sorting process and that its composition does not change during normal breathing. We provide biophysical evidence for the rapid formation of an enriched film at high surfactant concentrations, facilitated by adsorption structures containing hydrophobic surfactant proteins. We examine biophysical evidence for and against the compression-driven squeeze-out mechanism and propose a new model for surfactant function. The proposed model is tested against existing physiological and pathophysiological evidence in neonatal and adult lungs, leading to ideas for biophysical research, that should be addressed to establish the physiological relevance of this new perspective on the function of the mighty thin film that surfactant provides.

Synthetic surfactant with a combined SP-B and SP-C analogue is efficient in rabbit models of adult and neonatal respiratory distress syndrome

Respiratory distress syndrome (RDS) in premature infants is caused by insufficient amounts of endogenous lung surfactant and is efficiently treated with replacement therapy using animal-derived surfactant preparations. On the other hand, adult/acute RDS (ARDS) occurs secondary to for example, sepsis, aspiration of gastric contents, and multitrauma and is caused by alveolar endothelial damage, leakage of plasma components into the airspaces and inhibition of surfactant activity. Instillation of surfactant preparations in ARDS has so far resulted in very limited treatment effects, partly due to inactivation of the delivered surfactants in the airspace. Here, we develop a combined surfactant protein B (SP-B) and SP-C peptide analogue (Combo) that can be efficiently expressed and purified from Escherichia coli without any solubility or purification tag. NMR spectroscopy shows that Combo peptide forms α-helices both in organic solvents and in lipid micelles, which coincide with the helical regions described for the isolated SP-B and SP-C parts. Artificial Combo surfactant composed of synthetic dipalmitoylphosphatidylcholine:palmitoyloleoylphosphatidylglycerol, 1:1, mixed with 3 weights % relative to total phospholipids of Combo peptide efficiently improves tidal volumes and lung gas volumes at end-expiration in a premature rabbit fetus model of RDS. Combo surfactant also improves oxygenation and respiratory parameters and lowers cytokine release in an acid instillation-induced ARDS adult rabbit model. Combo surfactant is markedly more resistant to inhibition by albumin and fibrinogen than a natural-derived surfactant in clinical use for the treatment of RDS. These features of Combo surfactant make it attractive for the development of novel therapies against human ARDS.

Surfactant Treatment Shows Higher Correlation Between Ventilator and EIT Tidal Volumes in an RDS Animal Model

Neonatal respiratory distress syndrome (RDS) is a condition of pulmonary surfactant insufficiency in the premature newborn. As such, artificial pulmonary surfactant administration is a key treatment. Despite continued improvement in the clinical outcomes of RDS, there are currently no established bedside tools to monitor whether pulmonary surfactant is effectively instilled throughout the lungs. Electrical impedance tomography (EIT) is an emerging technique in which physiological functions are monitored on the basis of temporal changes in conductivity of different tissues in the body. In this preliminary study, we aimed to assess how EIT tidal volumes correlate with ventilator tidal volumes in an RDS animal model, namely untreated, surfactant-treated, and normal control rabbit pups. Tidal volumes were measured simultaneously on an EIT system and a mechanical ventilator and compared at different peak inspiratory pressures. The linear correlation between tidal volumes measured by EIT and by ventilator had an R² of 0.71, 0.76 and 0.86 in the untreated, surfactant-treated, and normal control groups, respectively. Bland–Altman analysis showed a good correlation between the measurements obtained with these two modalities. The intraclass correlation coefficients (ICC) between ventilator tidal volume and EIT tidal volume were 0.83, 0.87, and 0.93 (all p < 0.001) in the untreated, surfactant-treated, and normal control groups, respectively, indicating that the higher ICC value, the better inflated status of the lung. In conclusion, we demonstrated that EIT tidal volume correlated with ventilator tidal volume. ICC was higher in the surfactant treated group.

A recipe for a good clinical pulmonary surfactant

The lives of thousands premature babies have been saved along the last thirty years thanks to the establishment and consolidation of pulmonary surfactant replacement therapies (SRT). It took some time to close the gap between the identification of the biophysical and molecular causes of the high mortality associated with respiratory distress syndrome in very premature babies and the development of a proper therapy. Closing the gap required the elucidation of some key questions defining the structure–function relationships in surfactant as well as the particular role of the different molecular components assembled into the surfactant system. On the other hand, the application of SRT as part of treatments targeting other devastating respiratory pathologies, in babies and adults, is depending on further extensive research still required before enough amounts of good humanized clinical surfactants will be available. This review summarizes our current concepts on the compositional and structural determinants defining pulmonary surfactant activity, the principles behind the development of efficient natural animal-derived or recombinant or synthetic therapeutic surfactants, as well as a the most promising lines of research that are already opening new perspectives in the application of tailored surfactant therapies to treat important yet unresolved respiratory pathologies.

Treatment of Respiratory Distress Syndrome with Single Recombinant Polypeptides that Combine Features of SP-B and SP-C

Treatment of respiratory distress syndrome (RDS) with surfactant replacement therapy in prematurely born infants was introduced more than 30 years ago; however, the surfactant preparations currently in clinical use are extracts from animal lungs. A synthetic surfactant that matches the currently used nature-derived surfactant preparations and can be produced in a cost-efficient manner would enable worldwide treatment of neonatal RDS and could also be tested against lung diseases in adults. The major challenge in developing fully functional synthetic surfactant preparations is to recapitulate the properties of the hydrophobic lung surfactant proteins B (SP-B) and SP-C. Here, we have designed single polypeptides that combine properties of SP-B and SP-C and produced them recombinantly using a novel solubility tag based on spider silk production. These Combo peptides mixed with phospholipids are as efficient as nature-derived surfactant preparations against neonatal RDS in premature rabbit fetuses.

Pulmonary surfactant: a unique biomaterial with life-saving therapeutic applications

Pulmonary surfactant is a complex lipoprotein mixture secreted into the alveolar lumen by type 2 pneumocytes, which is composed by tens of different lipids (approximately 90% of its entire mass) and surfactant proteins (approximately 10% of the mass). It is crucially involved in maintaining lung homeostasis by reducing the values of alveolar liquid surface tension close to zero at end-expiration, thereby avoiding the alveolar collapse, and assembling a chemical and physical barrier against inhaled pathogens. A deficient amount of surfactant or its functional inactivation is directly linked to a wide range of lung pathologies, including the neonatal respiratory distress syndrome. This paper reviews the main biophysical concepts of surfactant activity and its inactivation mechanisms, and describes the past, present and future roles of surfactant replacement therapy, focusing on the exogenous surfactant preparations marketed worldwide and new formulations under development. The closing section describes the pulmonary surfactant in the context of drug delivery. Thanks to its peculiar composition, biocompatibility, and alveolar spreading capability, the surfactant may work not only as a shuttle to the branched anatomy of the lung for other drugs but also as a modulator for their release, opening to innovative therapeutic avenues for the treatment of several respiratory diseases.

Towards the Molecular Mechanism of Pulmonary Surfactant Protein SP-B: At the Crossroad of Membrane Permeability and Interfacial Lipid Transfer

Pulmonary surfactant is a lipid-protein complex that coats the alveolar air-liquid interface, enabling the proper functioning of lung mechanics. The hydrophobic surfactant protein SP-B, in particular, plays an indispensable role in promoting the rapid adsorption of phospholipids into the interface. For this, formation of SP-B ring-shaped assemblies seems to be important, as oligomerization could be required for the ability of the protein to generate membrane contacts and to mediate lipid transfer among surfactant structures. SP-B, together with the other hydrophobic surfactant protein SP-C, also promotes permeability of surfactant membranes to polar molecules although the molecular mechanisms underlying this property, as well as its relevance for the surface activity of the protein, remain undefined. In this work, the contribution of SP-B and SP-C to surfactant membrane permeability has been further investigated, by evaluation of the ability of differently-sized fluorescent polar probes to permeate through giant vesicles with different lipid/protein composition. Our results are consistent with the generation by SP-B of pores with defined size in surfactant membranes. Furthermore, incubation of surfactant with an anti-SP-B antibody not only blocked membrane permeability but also affected lipid transfer into the air-water interface, as observed in a captive bubble surfactometer device. Our findings include the identification of SP-C and anionic phospholipids as modulators required for maintaining native-like permeability features in pulmonary surfactant membranes. Proper permeability through membrane assemblies could be crucial to complement the overall role of surfactant in maintaining alveolar equilibrium, beyond its biophysical function in stabilizing the respiratory air-liquid interface.

Synthetic Surfactant CHF5633 Compared with Poractant Alfa in the Treatment of Neonatal Respiratory Distress Syndrome: A Multicenter, Double-Blind, Randomized, Controlled Clinical Trial

OBJECTIVE

To compare efficacy and safety of a new synthetic surfactant, CHF5633, enriched with surfactant proteins, SP-B and SP-C peptide analogues, with porcine surfactant, poractant alfa, for the treatment of respiratory distress syndrome in infants born preterm.

STUDY DESIGN

Neonates born preterm on respiratory support requiring fraction of inspired oxygen (FiO₂) ≥0.30 from 24^0/7 to 26^6/7 weeks and FiO₂ ≥0.35 from 27^0/7 to 29^6/7 weeks of gestation to maintain 88%-95% oxygen saturation were randomized to receive 200 mg/kg of CHF5633 or poractant alfa. If necessary, redosing was given at 100 mg/kg. Efficacy end points were oxygen requirement (FiO₂, respiratory severity score [FiO₂ × mean airway pressure]) in the first 24 hours, 7 and 28 days, discharge home, and/or 36 weeks of postmenstrual age; mortality and bronchopulmonary dysplasia at 28 days and 36 weeks of PMA. Adverse events and immunogenicity were monitored for safety.

RESULTS

Of the 123 randomized neonates, 113 were treated (56 and 57 in CHF5633 and poractant alfa groups, respectively). In both arms, FiO₂ and respiratory severity score decreased from baseline at all time points (P < .001) with no statistically significant differences between groups. Rescue surfactant use (19 [33.9%] vs 17 [29.8%]), bronchopulmonary dysplasia (31 [55.4%] and 32 [56.1%]), and mortality at day 28 (4 [7.1%] and 3 [5.3%]) were similar in the CHF5633 and poractant alfa groups, respectively. In 2 (3.4%) and 1 (1.7%) neonates, adverse drug reactions were reported in CHF5633 and poractant alfa groups, respectively. No immunogenicity was detected.

CONCLUSIONS

Treatment with CHF5633 showed similar efficacy and safety as poractant alfa in neonates born preterm with moderate-to-severe respiratory distress syndrome.

TRIAL REGISTRATION

ClinicalTrials.gov: NCT02452476.

Lipid-Protein and Protein-Protein Interactions in the Pulmonary Surfactant System and Their Role in Lung Homeostasis

Pulmonary surfactant is a lipid/protein complex synthesized by the alveolar epithelium and secreted into the airspaces, where it coats and protects the large respiratory air–liquid interface. Surfactant, assembled as a complex network of membranous structures, integrates elements in charge of reducing surface tension to a minimum along the breathing cycle, thus maintaining a large surface open to gas exchange and also protecting the lung and the body from the entrance of a myriad of potentially pathogenic entities. Different molecules in the surfactant establish a multivalent crosstalk with the epithelium, the immune system and the lung microbiota, constituting a crucial platform to sustain homeostasis, under health and disease. This review summarizes some of the most important molecules and interactions within lung surfactant and how multiple lipid–protein and protein–protein interactions contribute to the proper maintenance of an operative respiratory surface.

In Vitro Functional and Structural Characterization of A Synthetic Clinical Pulmonary Surfactant with Enhanced Resistance to Inhibition

CHF5633 is a novel synthetic clinical pulmonary surfactant preparation composed by two phospholipid species, dipalmitoyl phosphatidylcholine (DPPC) and palmitoyloleoyl phosphatidylglycerol (POPG), and synthetic analogues of the hydrophobic surfactant proteins SP-B and SP-C. In this study, the interfacial properties of CHF5633 in the absence and in the presence of inhibitory serum proteins have been assessed in comparison with a native surfactant purified from porcine lungs and with poractant alpha, a widely used clinical surfactant preparation. The study of the spreading properties of CHF5633 in a Wilhelmy balance, its ability to adsorb and accumulate at air-liquid interfaces as revealed by a multiwell fluorescence assay, and its dynamic behavior under breathing-like compression-expansion cycling in a Captive Bubble Surfactometer (CBS), all revealed that CHF5633 exhibits a good behavior to reduce and sustain surface tensions to values below 5 mN/m. CHF5633 shows somehow slower initial interfacial adsorption than native surfactant or poractant alpha, but a better resistance to inhibition by serum proteins than the animal-derived clinical surfactant, comparable to that of the full native surfactant complex. Interfacial CHF5633 films formed in a Langmuir-Blodgett balance coupled with epifluorescence microscopy revealed similar propensity to segregate condensed lipid domains under compression than films made by native porcine surfactant or poractant alpha. This ability of CHF5633 to segregate condensed lipid phases can be related with a marked thermotropic transition from ordered to disordered membrane phases as exhibited by differential scanning calorimetry (DSC) of CHF5633 suspensions, occurring at similar temperatures but with higher associated enthalpy than that shown by poractant alpha. The good interfacial behavior of CHF5633 tested under physiologically meaningful conditions in vitro and its higher resistance to inactivation by serum proteins, together with its standardized and well-defined composition, makes it a particularly useful therapeutic preparation to be applied in situations associated with lung inflammation and edema, alone or in combined strategies to exploit surfactant-facilitated drug delivery.

Efficient delipidation of a recombinant lung surfactant lipopeptide analogue by liquid-gel chromatography

Pulmonary surfactant preparations extracted from natural sources have been used to treat millions of newborn babies with respiratory distress syndrome (RDS) and can possibly also be used to treat other lung diseases. Due to costly production and limited supply of animal-derived surfactants, synthetic alternatives are attractive. The water insolubility and aggregation-prone nature of the proteins present in animal-derived surfactant preparations have complicated development of artificial surfactant. A non-aggregating analog of lung surfactant protein C, SP-C33Leu is used in synthetic surfactant and we recently described an efficient method to produce rSP-C33Leu in bacteria. Here rSP-C33Leu obtained by salt precipitation of bacterial extracts was purified by two-step liquid gel chromatography and analyzed using mass spectrometry and RP-HPLC, showing that it is void of modifications and adducts. Premature New Zealand White rabbit fetuses instilled with 200mg/kg of 2% of rSP-C33Leu in phospholipids and ventilated with a positive end expiratory pressure showed increased tidal volumes and lung gas volumes compared to animals treated with phospholipids only. This shows that rSP-C33Leu can be purified from bacterial lipids and that rSP-C33Leu surfactant is active against experimental RDS.

History of Pulmonary Surfactant Replacement Therapy for Neonatal Respiratory Distress Syndrome in Korea

Neonatal respiratory distress syndrome (RDS) is a disease that is unique to newborn infants. It is caused by a deficiency of pulmonary surfactant (PS), which is usually ready to be activated around the perinatal period. Until RDS was more clearly understood, it was not known why premature infants died from respiratory failure, although pathology revealed hyaline membranes in the alveoli. Surprisingly, the era of PS replacement therapy began only relatively recently. The first clinical trial investigating neonatal RDS was conducted in 1980. Since then, newborn survival has improved dramatically, which has led to significant advances in the field of neonatology. The present comprehensive review addresses PS, from its discovery to the application of artificial PS in newborns with RDS. It also reviews the history of PS in Korea, including its introduction, various commercial products, present and past research, newborn registries, and health insurance issues. Finally, it describes the inception of the Korean Society of Neonatology and future directions of research and treatment.

Synthetic surfactants with SP-B and SP-C analogues to enable worldwide treatment of neonatal respiratory distress syndrome and other lung diseases

Treatment of neonatal respiratory distress syndrome (RDS) using animal-derived lung surfactant preparations has reduced the mortality of handling premature infants with RDS to a 50th of that in the 1960s. The supply of animal-derived lung surfactants is limited and only a part of the preterm babies is treated. Thus, there is a need to develop well-defined synthetic replicas based on key components of natural surfactant. A synthetic product that equals natural-derived surfactants would enable cost-efficient production and could also facilitate the development of the treatments of other lung diseases than neonatal RDS. Recently the first synthetic surfactant that contains analogues of the two hydrophobic surfactant proteins B (SP-B) and SP-C entered clinical trials for the treatment of neonatal RDS. The development of functional synthetic analogues of SP-B and SP-C, however, is considerably more challenging than anticipated 30 years ago when the first structural information of the native proteins became available. For SP-B, a complex three-dimensional dimeric structure stabilized by several disulphides has necessitated the design of miniaturized analogues. The main challenge for SP-C has been the pronounced amyloid aggregation propensity of its transmembrane region. The development of a functional non-aggregating SP-C analogue that can be produced synthetically was achieved by designing the amyloidogenic native sequence so that it spontaneously forms a stable transmembrane α-helix.

Disulphide Bridges in Surfactant Protein B Analogues Affect Their Activity in Synthetic Surfactant Preparations

BACKGROUND

Limited supply and complicated manufacturing procedure of animal-derived surfactants make the development of synthetic surfactants warranted. The synthesis of surfactant protein (SP)-B and SP-C is complicated and several analogues have been developed. Mini-BLeu is an analogue that corresponds to the first and last helix of SP-B joined by a loop and linked by 2 disulphide bridges. SP-C33Leu is an SP-C analogue that can be cost-efficiently produced, but no such analogue has yet been described for SP-B.

OBJECTIVE

To design short SP-B analogues which lack disulphide bridges, are easy to produce and are efficacious in a preterm rabbit fetus model of neonatal RDS.

METHODS

Synthetic surfactants were prepared by adding 2 or 8% (w/w) of synthetic variants of Mini-B27, similar to Mini-BLeu but with a short loop, or different peptides covering helix 1 of SP-B to 2% (w/w) of SP-C33Leu in 80 mg/mL of 1,2-dipalmitoyl-sn-glycero-3-phosphocholine/egg yolk phosphatidylcholine/1-palmitoyl-2-oleoyl-sn-glycero-3-phosphoglycerol, 50: 40: 10 (by weight). Premature newborn rabbit fetuses were treated with 200 mg/kg of the surfactant preparations and ventilated with defined pressures for 30 min without positive end-expiratory pressure. Tidal volumes were registered during the experiments and lung gas volumes were measured at the end of the ventilation period.

RESULTS

Synthetic surfactant containing the Mini-B27 analogue with 2 disulphides gives similar lung gas volumes as treatment with an animal-derived surfactant preparation, but all other SP-B analogues gave lower lung gas volumes. All synthetic surfactants studied gave no significant differences in compliances except the surfactant containing the Mini-B27 analogue without cysteines that performed somewhat better at 30 min.

CONCLUSION

The helix-loop-helix SP-B analogues tested in this study require the presence of 2 disulphide bridges for optimal activity in a rabbit RDS model.

Quenching of tryptophan fluorescence in a highly scattering solution: Insights on protein localization in a lung surfactant formulation

CHF5633 (Chiesi Farmaceutici, Italy) is a synthetic surfactant developed for respiratory distress syndrome replacement therapy in pre-term newborn infants. CHF5633 contains two phospholipids (dipalmitoylphosphatidylcholine and 1-palmitoyl-2oleoyl-sn-glycero-3-phosphoglycerol sodium salt), and peptide analogues of surfactant protein C (SP-C analogue) and surfactant protein B (SP-B analogue). Both proteins are fundamental for an optimal surfactant activity in vivo and SP-B genetic deficiency causes lethal respiratory failure after birth. Fluorescence emission of the only tryptophan residue present in SP-B analogue (SP-C analogue has none) could in principle be exploited to probe SP-B analogue conformation, localization and interaction with other components of the pharmaceutical formulation. However, the high light scattering activity of the multi-lamellar vesicles suspension characterizing the pharmaceutical surfactant formulation represents a challenge for such studies. We show here that quenching of tryptophan fluorescence and Singular Value Decomposition analysis can be used to accurately calculate and subtract background scattering. The results indicate, with respect to Trp microenvironment, a conformationally homogeneous population of SP-B. Trp is highly accessible to the water phase, suggesting a surficial localization on the membrane of phospholipid vesicles, similarly to what observed for full length SP-B in natural lung surfactant, and supporting an analogous role in protein anchoring to the lipid phase.

Effective in vivo treatment of acute lung injury with helical, amphipathic peptoid mimics of pulmonary surfactant proteins

Acute lung injury (ALI) leads to progressive loss of breathing capacity and hypoxemia, as well as pulmonary surfactant dysfunction. ALI's pathogenesis and management are complex, and it is a significant cause of morbidity and mortality worldwide. Exogenous surfactant therapy, even for research purposes, is impractical for adults because of the high cost of current surfactant preparations. Prior in vitro work has shown that poly-N-substituted glycines (peptoids), in a biomimetic lipid mixture, emulate key biophysical activities of lung surfactant proteins B and C at the air-water interface. Here we report good in vivo efficacy of a peptoid-based surfactant, compared with extracted animal surfactant and a synthetic lipid formulation, in a rat model of lavage-induced ALI. Adult rats were subjected to whole-lung lavage followed by administration of surfactant formulations and monitoring of outcomes. Treatment with a surfactant protein C mimic formulation improved blood oxygenation, blood pH, shunt fraction, and peak inspiratory pressure to a greater degree than surfactant protein B mimic or combined formulations. All peptoid-enhanced treatment groups showed improved outcomes compared to synthetic lipids alone, and some formulations improved outcomes to a similar extent as animal-derived surfactant. Robust biophysical mimics of natural surfactant proteins may enable new medical research in ALI treatment.

A first-in-human clinical study of a new SP-B and SP-C enriched synthetic surfactant (CHF5633) in preterm babies with respiratory distress syndrome

OBJECTIVE

CHF5633 (Chiesi Farmaceutici S.p.A., Parma, Italy) is the first fully synthetic surfactant enriched by peptide analogues of two human surfactant proteins. We planned to assess safety and tolerability of CHF5633 and explore preliminary efficacy.

DESIGN

Multicentre cohort study.

PATIENTS

Forty infants from 27⁺⁰ to 33⁺⁶ weeks gestation with respiratory distress syndrome requiring fraction of inspired oxygen (FiO₂) ≥0.35 were treated with a single dose of CHF5633 within 48 hours after birth. The first 20 received 100 mg/kg and the second 20 received 200 mg/kg.

OUTCOME MEASURES

Adverse events (AEs) and adverse drug reactions (ADRs) were monitored with complications of prematurity considered AEs if occurring after dosing. Systemic absorption and immunogenicity were assessed. Efficacy was assessed by change in FiO₂ after dosing and need for poractant-alfa rescue.

RESULTS

Rapid and sustained improvements in FiO₂ were observed in 39 (98%) infants. One responded neither to CHF5633 nor two poractant-alfa doses. A total of 79 AEs were experienced by 19 infants in the 100 mg/kg cohort and 53 AEs by 20 infants in the 200 mg/kg cohort. Most AEs were expected complications of prematurity. Two unrelated serious AEs occurred in the second cohort. One infant died of necrotising enterocolitis and another developed viral bronchiolitis after discharge. The single ADR was an episode of transient endotracheal tube obstruction following a 200 mg/kg dose. Neither systemic absorption, nor antibody development to either peptide was detected.

CONCLUSIONS

Both CHF5633 doses were well tolerated and showed promising clinical efficacy profile. These encouraging data provide a basis for ongoing randomised controlled trials.

TRIAL REGISTRATION NUMBER

ClinicalTrials.gov NCT01651637.

A Combination of Short and Simple Surfactant Protein B and C Analogues as a New Synthetic Surfactant: In Vitro and Animal Experiments

PURPOSE

Pulmonary surfactants for preterm infants contain mostly animal-derived surfactant proteins (SPs), which are essential for lowering surface tension. We prepared artificial pulmonary surfactants using synthetic human SP analogs and performed in vitro and in vivo experiments.

MATERIALS AND METHODS

We synthesized peptide analogues that resemble human SP-B (RMLPQLVCRLVLRCSMD) and SP-C (CPVHLKRLLLLLLLLLLLLLLLL). Dipalmitoylphosphatidylcholine (DPPC), phosphatidylglycerol (PG), and palmitic acid (PA) were added and mixed in lyophilized to render powdered surfactant. Synsurf-1 was composed of DPPC:PG:PA:SP-B (75:25:10:3, w/w); Synsurf-2 was composed of DPPC:PG:PA:SP-C (75:25:10:3, w/w); and Synsurf-3 was composed of DPPC:PG:PA:SP-B:SP-C (75:25:10:3:3, w/w). We performed in vitro study to compare the physical characteristics using pulsating bubble surfactometer and modified Wilhelmy balance test. Surface spreading and adsorption test of the surfactant preparations were measured. In vivo test was performed using term and preterm rabbit pups. Pressure-volume curves were generated during the deflation phase. Histologic findings were examined.

RESULTS

Pulsating bubble surfactometer readings revealed following minimum and maximum surface tension (mN/m) at 5 minutes: Surfacten® (5.5±0.4, 32.8±1.6), Synsurf-1 (16.7±0.6, 28.7±1.5), Synsurf-2 (7.9±1.0, 33.1±1.6), and Synsurf-3 (7.1±0.8, 34.5±1.0). Surface spreading rates were as follows: Surfacten® (27 mN/m), Synsurf-1 (43 mN/m), Synsurf-2 (27 mN/m), and Synsurf-3 (27 mN/m). Surface adsorption rate results were as follows: Surfacten® (28 mN/m), Synsurf-1 (35 mN/m), Synsurf-2 (29 mN/m), and Synsurf-3 (27 mN/m). The deflation curves were best for Synsurf-3; those for Synsurf-2 were better than those for Surfacten®. Synsurf-1 was the worst surfactant preparation. Microscopic examination showed the largest aerated area of the alveoli in the Synsurf-3 group, followed by Synsurf-1 and Surfacten®; Synsurf-2 was the smallest.

CONCLUSION

Synsurf-3 containing both SP-B and SP-C synthetic analogs showed comparable and better efficacy than commercially used Surfacten® in lowering surface tension, pressure-volume curves, and tissue aerated area of the alveoli.

Cerebral and lung effects of a new generation synthetic surfactant with SP-B and SP-C analogs in preterm lambs

BACKGROUND

Though natural surfactants (SF) are clinically superior to protein-free synthetic preparations, CHF-5633, a synthetic SF containing SP-B and SP-C analog peptides is a potential alternative to natural SF for treating neonatal respiratory distress syndrome (RDS). Nevertheless, information is lacking regarding the safety of this new treatment for the neonatal brain. We sought to compare the cerebral and pulmonary effects of this new synthetic surfactant (CHF5633) with those of natural porcine surfactant (Cursosurf) in premature lambs with RDS.

METHODS

Twenty-one preterm lambs were randomly assigned to receive CHF5633, Curosurf, or no treatment (control). Pulmonary (gas exchange, lung mechanics) and cerebral (carotid artery blood flow, cerebral oxygen metabolism) effects were measured every 30 min for 6 h. Pulmonary and cerebral histological analysis were also performed.

RESULTS

After delivery, lambs developed severe RDS (F_IO2 :1, pH < 7.15, P_aCO2  > 70 mmHg, P_aO2  < 40 mmHg, C_dyn  < 0.1 mL/cmH₂ O/kg). By 30 min after treatment, animals in both SF-treated groups had consistently better gas exchange and lung mechanics than controls. After CHF5633 administration, P_aCO2 , carotid artery blood flow, and cerebral oxygen delivery tended to slowly decrease compared to other groups. By 2 h, SF-treated groups had similar values of all parameters studied, these remaining steady for the rest of the experiment. Lambs administered CHF5633 obtained better lung and brain injury scores than controls.

CONCLUSION

Intratracheal administration of a bolus of CHF5633 improves pulmonary status in preterm lambs with severe RDS, obtaining better lung and brain injury scores than controls and favorable cerebral hemodynamics, comparable to those with gold standard Curosurf treatment.

In vitro and in vivo comparison between poractant alfa and the new generation synthetic surfactant CHF5633

BACKGROUND

CHF5633 is a new generation synthetic surfactant containing both SP-B and SP-C analogues developed for the treatment of respiratory distress syndrome. Here, the optimal dose and its performance in comparison to the animal-derived surfactant poractant alfa were investigated.

METHODS

In vitro surfactant activity was determined by means of the Wilhelmy balance and the capillary surfactometer. The dose-finding study was performed in preterm rabbits with severe surfactant deficiency. CHF5633 doses ranging from 50 to 300 mg/kg were used. Untreated animals and animals treated with 200 mg/kg of poractant alfa were included for comparison.

RESULTS

In vitro, minimum surface tension (γ_min) was decreased from values above 70 to 0 mN/m by both surfactants, and they formed rapidly a film at the air-liquid interface. In vivo studies showed a clear dose-dependent improvement of lung function for CHF5633. The pulmonary effect of CHF5633 200 mg/kg dose was comparable to the pulmonary response elicited by 200 mg/kg of poractant alfa in preterm rabbits.

CONCLUSION

CHF5633 is as efficient as poractant alfa in our in vitro and in vivo settings. A clear dose-dependent improvement of lung function could be observed for CHF5633, with the dose of 200 mg/kg being the most efficient one.

Genetic Polymorphisms of SP-A, SP-B, and SP-D and Risk of Respiratory Distress Syndrome in Preterm Neonates

Background

We examined selected polymorphisms in 3 pulmonary surfactant-associated proteins (SP) for their influence on serum SP levels and risk of respiratory distress syndrome (RDS) in preterm neonates.

Material/Methods

Premature infants from a Han population were enrolled, including 100 premature infants with RDS (case group) and 120 premature infants without RDS (control group). SNP genotyping for SP-A (+186A/G and +655C/T), SP-B (−18A/C and 1580C/T), and SP-D (Met11ThrT/C and Ala160ThrG/A) used polymerase chain reaction-restriction fragment length polymorphism. Haplotypes were calculated with Shesis software and serum SP-A/B/D levels were quantified by ELISA.

Results

Case and control groups exhibited significant differences in genotype and allele frequencies of SP-A (+186A/G, +655C/T) and SP-B (1580C/T). However, no statistically significant differences were observed in the allele and genotype frequencies of SP-B −18A/C, SP-D Met11ThrT/C, and SP-D Ala160ThrG/A. Importantly, serum SP-A and SP-B levels were reduced in RDS patients carrying SP-A (+186A/G, +655C/T) and SP-B (1580C/T) polymorphisms. AA genotype of +186A/G, SP-A level, and CC genotype of 1580C/T were independently correlated with increased RDS risk.

Conclusions

SP-A (+186A/G) and SP-B (1580C/T) polymorphisms are strongly associated with the risk of RDS in preterm infants. Notably, reduced serum SP-A levels were correlated with a high risk of RDS and may serve as novel biomarkers for RDS detection and monitoring.

Synthetic lung surfactants containing SP-B and SP-C peptides plus novel phospholipase-resistant lipids or glycerophospholipids

Background

This study examines the biophysical and preclinical pulmonary activity of synthetic lung surfactants containing novel phospholipase-resistant phosphonolipids or synthetic glycerophospholipids combined with Super Mini-B (S-MB) DATK and/or SP-Css ion-lock 1 peptides that replicate the functional biophysics of surfactant proteins (SP)-B and SP-C. Phospholipase-resistant phosphonolipids used in synthetic surfactants are DEPN-8 and PG-1, molecular analogs of dipalmitoyl phosphatidylcholine (DPPC) and palmitoyl-oleoyl phosphatidylglycerol (POPG), while glycerophospholipids used are active lipid components of native surfactant (DPPC:POPC:POPG 5:3:2 by weight). The objective of the work is to test whether these novel lipid/peptide synthetic surfactants have favorable preclinical activity (biophysical, pulmonary) for therapeutic use in reversing surfactant deficiency or dysfunction in lung disease or injury.

Methods

Surface activity of synthetic lipid/peptide surfactants was assessed in vitro at 37 °C by measuring adsorption in a stirred subphase apparatus and dynamic surface tension lowering in pulsating and captive bubble surfactometers. Shear viscosity was measured as a function of shear rate on a Wells-Brookfield micro-viscometer. In vivo pulmonary activity was determined by measuring lung function (arterial oxygenation, dynamic lung compliance) in ventilated rats and rabbits with surfactant deficiency/dysfunction induced by saline lavage to lower arterial PO₂ to <100 mmHg, consistent with clinical acute respiratory distress syndrome (ARDS).

Results

Synthetic surfactants containing 5:3:2 DPPC:POPC:POPG or 9:1 DEPN-8:PG-1 combined with 3% (by wt) of S-MB DATK, 3% SP-Css ion-lock 1, or 1.5% each of both peptides all adsorbed rapidly to low equilibrium surface tensions and also reduced surface tension to ≤1 mN/m under dynamic compression at 37 °C. However, dual-peptide surfactants containing 1.5% S-MB DATK + 1.5% SP-Css ion-lock 1 combined with 9:1 DEPN-8:PG-1 or 5:3:2 DPPC:POPC:POPG had the greatest in vivo activity in improving arterial oxygenation and dynamic lung compliance in ventilated animals with ARDS. Saline dispersions of these dual-peptide synthetic surfactants were also found to have shear viscosities comparable to or below those of current animal-derived surfactant drugs, supporting their potential ease of deliverability by instillation in future clinical applications.

Discussion

Our findings support the potential of dual-peptide synthetic lipid/peptide surfactants containing S-MB DATK + SP-Css ion-lock 1 for treating diseases of surfactant deficiency or dysfunction. Moreover, phospholipase-resistant dual-peptide surfactants containing DEPN-8/PG-1 may have particular applications in treating direct forms of ARDS where endogenous phospholipases are present in the lungs.

Synthetic lung surfactant reduces alveolar-capillary protein leakage in surfactant-deficient rabbits

PURPOSE OF THE STUDY

Alveolar-capillary leakage of proteinaceous fluid impairs alveolar ventilation and surfactant function and decreases lung compliance in acute lung injury. We investigated the correlation between lung function and total protein levels in bronchoalveolar lavage fluid (BALF) of ventilated, lavaged surfactant-deficient rabbits treated with various clinical and synthetic lung surfactant preparations.

MATERIALS AND METHODS

109 ventilated, young adult New Zealand White rabbits underwent lung lavage to induce surfactant-deficiency (PaO2 <100 torr in 100% O2), were treated with a clinical surfactant or a synthetic surfactant preparation with surfactant protein B (SP-B) and/or surfactant protein C (SP-C) analogs, and mechanically ventilated for 120 min. Total protein levels in postmortem BALF were correlated with arterial PO2 (PaO2) and dynamic lung compliance values at 120 min post-surfactant treatment.

RESULTS

Repeated lung lavages decreased mean PaO2 values from 540 to 58 torr and lung compliance from 0.64 to 0.33 mL/kg/cm H2O. Two hours after surfactant therapy and mechanical ventilation, mean PaO2 values had increased to 346 torr and lung compliance to 0.44 mL/kg/cm H2O. Eighty-six rabbits (79%) responded to surfactant therapy with an increase in PaO2 to values >200 torr. Fourteen non-responders received inactive surfactant preparations. BALF protein levels were inversely correlated with PaO2 and lung compliance (P < .001). Surfactant preparations containing both SP-B and SP-C proteins or peptide analogs outperformed single protein/peptide preparations.

CONCLUSIONS

Clinical and synthetic surfactant therapy reduces alveolar-capillary protein leakage in surfactant-deficient rabbits. Surfactant preparations with both SP-B and SP-C (analogs) were more efficient than preparations with SP-B or SP-C alone.

Phospholipid Composition in Synthetic Surfactants Is Important for Tidal Volumes and Alveolar Stability in Surfactant-Treated Preterm Newborn Rabbits

BACKGROUND

The development of synthetic surfactants for the treatment of lung pulmonary diseases has been going on for many years.

OBJECTIVES

To investigate the effects of phospholipid mixtures combined with SP-B and SP-C analogues on lung functions in an animal model of respiratory distress syndrome.

METHODS

Natural and synthetic phospholipid mixtures with/without SP-B and/or SP-C analogues were instilled in ventilated premature newborn rabbits. Lung functions were evaluated.

RESULTS

Treatment with Curosurf or phospholipids from Curosurf combined with SP-B and SP-C analogues gave similar results. Treatment with phospholipids from adult rabbit lungs or liver combined with dipalmitoylphosphatidylcholine (DPPC) and palmitoyloleoylphosphatidylglycerol (POPG) gave tidal volumes (VT) well above physiological levels, but alveolar stability at end-expiration was only achieved when these phospholipids were combined with analogues of SP-B and SP-C. Treatment with egg yolk-PC mixed with DPPC with and without POPG gave small VT, but after addition of both analogues VT was only somewhat lower and lung gas volumes (LGV) similar to those obtained with Curosurf. Substitution of egg yolk-PC (≥99% PC) with 1-palmitoyl-2-oleoyl-sn-glycero-3-phosphocholine and 1-palmitoyl-2-linoleoyl-sn-glycero-3-phosphocholine, and combining them with DPPC, POPG and 2% each of the SP-B and SP-C analogue gave a completely synthetic surfactant with similar effects on VT and LGV as Curosurf.

CONCLUSIONS

Phospholipid composition is important for VT while the SP-B and SP-C analogues increase alveolar stability at end-expiration. Synthetic surfactant consisting of unsaturated and saturated phosphatidylcholines, POPG and the analogues of SP-B and SP-C has similar activity as Curosurf regarding VT and LGV in an animal model using preterm newborn rabbits ventilated without positive end-expiratory pressure.

Development of a Synthetic Surfactant Using a Surfactant Protein-C Peptide Analog: In Vitro Studies of Surface Physical Properties

PURPOSE

Pulmonary surfactant (PS) replacement has been the gold standard therapy for neonatal respiratory distress syndrome; however, almost all commercial PSs contain animal proteins. We prepared a synthetic PS by using a human surfactant protein (SP) analog and evaluated its in vitro properties.

MATERIALS AND METHODS

A peptide sequence (CPVHLKRLLLLLLLLLLLLLLLL) of human SP-C was chosen to develop the peptide analog (SPa-C). The new synthetic SP-C PS (sSP-C PS) was synthesized from SPa-C, dipalmitoyl phosphatidylcholine, phosphatidyl glycerol, and palmitic acid. Physical properties of the sSP-C PS were evaluated by measuring the maximum and minimum surface tensions (STs), surfactant spreading, and adsorption rate. In addition, we recorded an ST-area diagram. The data obtained on sSP-C PS were subsequently compared with those of purified natural bovine surfactant (PNBS), and the commercial product, Surfacten®.

RESULTS

The sSP-C PS and Surfacten® were found to have maximum ST values of 32-33 mN/m, whereas that of PNBS was much lower at 19 mN/m. The minimum ST values of all three products were less than 10 mN/m. The values that were measured for the equilibrium ST of rapidly spreading sSP-C PS, Surfacten®, and PNBS were 27, 27, and 24 mN/m, respectively. The surface adsorptions were found to be the same for all three PSs (20 mN/m). ST-area diagrams of sSP-C PS and Surfacten® revealed similar properties.

CONCLUSION

In an in vitro experiment, the physical properties exhibited by sSP-C PS were similar to those of Surfacten®. Further study is required to evaluate the in vivo efficacy.

A unique story in neonatal research: the development of a porcine surfactant

Surfactant deficiency was identified as the cause of respiratory distress syndrome (RDS) as long ago as 1959. Trials of surfactant replacement in the 1960s were unsuccessful because the preparations used contained only phospholipids and they were administered inefficiently by nebulization. In the 1970s Bengt Robertson and Göran Enhörning showed that natural surfactant, containing both phospholipids and proteins, could ameliorate the signs of RDS in immature rabbits. In the 1980s Bengt Robertson and Tore Curstedt developed a porcine surfactant, Curosurf (named after their surnames), which was effective in immature animals and was used in a pilot clinical trial beginning in 1983. Subsequent randomized clinical trials were planned a year later by Bengt Robertson, Tore Curstedt and Henry Halliday, and the first trial was begun in 1985. This showed that Curosurf reduced pulmonary air leaks and neonatal mortality in preterm infants with severe RDS. A second trial, coordinated by Christian Speer, demonstrated that multiple doses of Curosurf were more effective than a single dose. Subsequent trials conducted by the Collaborative European Multicenter Study Group, which included among others Guilio Bevilacqua, Janna Koppe, Ola Saugstad, Nils Svenningsen and Jean-Pierre Relier, showed that early treatment was more effective than later administration and that infants treated at birth had similar neurodevelopmental status to untreated controls at a corrected age of 2 years. Members of the Collaborative European Multicenter Study Group in Denmark and Sweden performed studies to demonstrate the benefits of a combination of surfactant treatment and early continuous positive airway pressure. Curosurf has also been compared with several synthetic and natural surfactants, and at a dose of 200 mg/kg Curosurf has been shown to be superior to either Survanta or Curosurf used at a dose of 100 mg/kg. Recently, new-generation synthetic surfactants containing both phospholipids and proteins have been developed. After preclinical testing, CHF5633 (developed by Tore Curstedt and Jan Johansson in collaboration with Chiesi Farmaceutici) has undergone a preliminary first study in humans under the guidance of Christian Speer. If effective, this new surfactant preparation could revolutionize the treatment of preterm infants worldwide as it could be made consistently and safely in almost unlimited quantities. This story of a porcine surfactant preparation has been truly remarkable, and many thousands of preterm babies worldwide are now alive and well because of it.

The role of surfactant and non-invasive mechanical ventilation in early management of respiratory distress syndrome in premature infants

BACKGROUND

Surfactant replacement therapy has been used for few decades for the treatment of respiratory distress syndrome (RDS) and has significantly improved morbidity and mortality in premature infants. Non-invasive respiratory support has recently emerged as a strategy in the early management of RDS. In this review, we discuss the different strategies of early management of RDS.

DATA SOURCES

A literature search of PubMed database was conducted to review the subject. The quality of evidence of key clinical studies was graded according to a modified grading system of the international GRADE group.

RESULTS

Continuous positive airway pressure (CPAP) with selective surfactant is a safe alternative to routine intubation, surfactant and mechanical ventilation in preterm infants with spontaneous breathing, and such an approach has been associated with decreased risk of death and bronchopulmonary dysplasia. There is a risk of pneumothorax when using a high pressure of CPAP (≥8 cm of H2O), a high partial pressure of carbon dioxide (PCO2 >75 mm of Hg), and a high fraction of inspired oxygen (FiO2 >0.6) as a threshold for intubation while on CPAP.

CONCLUSION

Not all preterm infants need surfactant treatment, and non-invasive respiratory support is a safe and effective approach.

Surfactant protein C peptides with salt-bridges ("ion-locks") promote high surfactant activities by mimicking the α-helix and membrane topography of the native protein

Background. Surfactant protein C (SP-C; 35 residues) in lungs has a cationic N-terminal domain with two cysteines covalently linked to palmitoyls and a C-terminal region enriched in Val, Leu and Ile. Native SP-C shows high surface activity, due to SP-C inserting in the bilayer with its cationic N-terminus binding to the polar headgroup and its hydrophobic C-terminus embedded as a tilted, transmembrane α-helix. The palmitoylcysteines in SP-C act as ‘helical adjuvants’ to maintain activity by overriding the β-sheet propensities of the native sequences.

Objective. We studied SP-C peptides lacking palmitoyls, but containing glutamate and lysine at 4-residue intervals, to assess whether SP-C peptides with salt-bridges (“ion-locks”) promote surface activity by mimicking the α-helix and membrane topography of native SP-C.

Methods. SP-C mimics were synthesized that reproduce native sequences, but without palmitoyls (i.e., SP-Css or SP-Cff, with serines or phenylalanines replacing the two cysteines). Ion-lock SP-C molecules were prepared by incorporating single or double Glu⁻–Lys⁺ into the parent SP-C’s. The secondary structures of SP-C mimics were studied with Fourier transform infrared (FTIR) spectroscopy and PASTA, an algorithm that predicts β-sheet propensities based on the energies of the various β-sheet pairings. The membrane topography of SP-C mimics was investigated with orientated and hydrogen/deuterium (H/D) exchange FTIR, and also Membrane Protein Explorer (MPEx) hydropathy analysis. In vitro surface activity was determined using adsorption surface pressure isotherms and captive bubble surfactometry, and in vivo surface activity from lung function measures in a rabbit model of surfactant deficiency.

Results. PASTA calculations predicted that the SP-Css and SP-Cff peptides should each form parallel β-sheet aggregates, with FTIR spectroscopy confirming high parallel β-sheet with ‘amyloid-like’ properties. The enhanced β-sheet properties for SP-Css and SP-Cff are likely responsible for their low surfactant activities in the in vitro and in vivo assays. Although standard ¹²C-FTIR study showed that the α-helicity of these SP-C sequences in lipids was uniformly increased with Glu⁻–Lys⁺ insertions, elevated surfactant activity was only selectively observed. Additional results from oriented and H/D exchange FTIR experiments indicated that the high surfactant activities depend on the SP-C ion-locks recapitulating both the α-helicity and the membrane topography of native SP-C. SP-Css ion-lock 1, an SP-Css with a salt-bridge for a Glu⁻–Lys⁺ ion-pair predicted from MPEx hydropathy calculations, demonstrated enhanced surfactant activity and a transmembrane helix simulating those of native SP-C.

Conclusion. Highly active SP-C mimics were developed that replace the palmitoyls of SP-C with intrapeptide salt-bridges and represent a new class of synthetic surfactants with therapeutic interest.

Aerosol delivery of synthetic lung surfactant

Background. Nasal continuous positive airway pressure (nCPAP) is a widely accepted technique of non-invasive respiratory support in premature infants with respiratory distress syndrome due to lack of lung surfactant. If this approach fails, the next step is often intubation, mechanical ventilation (MV) and intratracheal instillation of clinical lung surfactant.

Objective. To investigate whether aerosol delivery of advanced synthetic lung surfactant, consisting of peptide mimics of surfactant proteins B and C (SP-B and SP-C) and synthetic lipids, during nCPAP improves lung function in surfactant-deficient rabbits.

Methods. Experimental synthetic lung surfactants were produced by formulating 3% Super Mini-B peptide (SMB surfactant), a highly surface active SP-B mimic, and a combination of 1.5% SMB and 1.5% of the SP-C mimic SP-Css ion-lock 1 (BC surfactant), with a synthetic lipid mixture. After testing aerosol generation using a vibrating membrane nebulizer and aerosol conditioning (particle size, surfactant composition and surface activity), we investigated the effects of aerosol delivery of synthetic SMB and BC surfactant preparations on oxygenation and lung compliance in saline-lavaged, surfactant-deficient rabbits, supported with either nCPAP or MV.

Results. Particle size distribution of the surfactant aerosols was within the 1–3 µm distribution range and surfactant activity was not affected by aerosolization. At a dose equivalent to clinical surfactant therapy in premature infants (100 mg/kg), aerosol delivery of both synthetic surfactant preparations led to a quick and clinically relevant improvement in oxygenation and lung compliance in the rabbits. Lung function recovered to a greater extent in rabbits supported with MV than with nCPAP. BC surfactant outperformed SMB surfactant in improving lung function and was associated with higher phospholipid values in bronchoalveolar lavage fluid; these findings were irrespective of the type of ventilatory support (nCPAP or MV) used.

Conclusions. Aerosol delivery of synthetic lung surfactant with a combination of highly active second generation SP-B and SP-C mimics was effective as a therapeutic approach towards relieving surfactant deficiency in spontaneously breathing rabbits supported with nCPAP. To obtain similar results with nCPAP as with intratracheal instillation, higher dosage of synthetic surfactant and reduction of its retention by the delivery circuit will be needed to increase the lung dose.

Mechanism of action of lung damage caused by a nanofilm spray product

Inhalation of waterproofing spray products has on several occasions caused lung damage, which in some cases was fatal. The present study aims to elucidate the mechanism of action of a nanofilm spray product, which has been shown to possess unusual toxic effects, including an extremely steep concentration-effect curve. The nanofilm product is intended for application on non-absorbing flooring materials and contains perfluorosiloxane as the active film-forming component. The toxicological effects and their underlying mechanisms of this product were studied using a mouse inhalation model, by in vitro techniques and by identification of the binding interaction. Inhalation of the aerosolized product gave rise to increased airway resistance in the mice, as evident from the decreased expiratory flow rate. The toxic effect of the waterproofing spray product included interaction with the pulmonary surfactants. More specifically, the active film-forming components in the spray product, perfluorinated siloxanes, inhibited the function of the lung surfactant due to non-covalent interaction with surfactant protein B, a component which is crucial for the stability and persistence of the lung surfactant film during respiration. The active film-forming component used in the present spray product is also found in several other products on the market. Hence, it may be expected that these products may have a toxicity similar to the waterproofing product studied here. Elucidation of the toxicological mechanism and identification of toxicological targets are important to perform rational and cost-effective toxicological studies. Thus, because the pulmonary surfactant system appears to be an important toxicological target for waterproofing spray products, study of surfactant inhibition could be included in toxicological assessment of this group of consumer products.

Synthetic surfactant containing SP-B and SP-C mimics is superior to single-peptide formulations in rabbits with chemical acute lung injury

Background. Chemical spills are on the rise and inhalation of toxic chemicals may induce chemical acute lung injury (ALI)/acute respiratory distress syndrome (ARDS). Although the pathophysiology of ALI/ARDS is well understood, the absence of specific antidotes has limited the effectiveness of therapeutic interventions.

Objectives. Surfactant inactivation and formation of free radicals are important pathways in (chemical) ALI. We tested the potential of lipid mixtures with advanced surfactant protein B and C (SP-B and C) mimics to improve oxygenation and lung compliance in rabbits with lavage- and chemical-induced ALI/ARDS.

Methods. Ventilated young adult rabbits underwent repeated saline lung lavages or underwent intratracheal instillation of hydrochloric acid to induce ALI/ARDS. After establishment of respiratory failure rabbits were treated with a single intratracheal dose of 100 mg/kg of synthetic surfactant composed of 3% Super Mini-B (S-MB), a SP-B mimic, and/or SP-C33 UCLA, a SP-C mimic, in a lipid mixture (DPPC:POPC:POPG 5:3:2 by weight), the clinical surfactant Infasurf^®, a bovine lung lavage extract with SP-B and C, or synthetic lipids alone. End-points consisted of arterial oxygenation, dynamic lung compliance, and protein and lipid content in bronchoalveolar lavage fluid. Potential mechanism of surfactant action for S-MB and SP-C33 UCLA were investigated with captive bubble surfactometry (CBS) assays.

Results. All three surfactant peptide/lipid mixtures and Infasurf equally lowered the minimum surface tension on CBS, and also improved oxygenation and lung compliance. In both animal models, the two-peptide synthetic surfactant with S-MB and SP-C33 UCLA led to better arterial oxygenation and lung compliance than single peptide synthetic surfactants and Infasurf. Synthetic surfactants and Infasurf improved lung function further in lavage- than in chemical-induced respiratory failure, with the difference probably due to greater capillary-alveolar protein leakage and surfactant dysfunction after HCl instillation than following lung lavage. At the end of the duration of the experiments, synthetic surfactants provided more clinical stability in ALI/ARDS than Infasurf, and the protein content of bronchoalveolar lavage fluid was lowest for the two-peptide synthetic surfactant with S-MB and SP-C33 UCLA.

Conclusion. Advanced synthetic surfactant with robust SP-B and SP-C mimics is better equipped to tackle surfactant inactivation in chemical ALI than synthetic surfactant with only a single surfactant peptide or animal-derived surfactant.

Effects of different ventilation strategies on lung injury in newborn rabbits

BACKGROUND

The results from experimental and clinical studies have shown that mechanical ventilation (MV) and/or hyperoxia may aggravate a pre-existing lung injury, or even cause lung injury in healthy lungs, despite the fact that it might be the only life-saving intervention available to a patient. The present study was designed to investigate the roles of MV and hyperoxia in the pathogenesis of lung injury.

METHODS

Newborn New Zealand white rabbits were randomly assigned to an unventilated air control group or to one of the 2 × 3 × 3 ventilation strategies using a factorial design. The experimental groups were assigned different fractions of inspired oxygen (FiO(2)), peak inspiratory pressures (PIP), and respiratory times (RT). The lung wet-to-dry ratio (W/D), lung histopathology scores, and cells in the bronchoalveolar lavage fluid (BALF) were analyzed for each group. The apoptosis levels were studied by immunohistochemistry and a terminal deoxynucleotidyl transferase dUTP nick end-labeling (TUNEL) assay.

RESULTS

Different ventilation regimes induced alterations in microvascular permeability, differential histopathological grading, WBC and/or neutrophil and/or lymphocyte influx, and apoptosis levels; moreover, there were significant correlations and interaction effects between these indices.

CONCLUSIONS

Our data demonstrate that different ventilation regimes can induce lung injury and that the interaction effects of the FiO(2), the PIP and the RT may play crucial roles in the pathogenesis of lung injury.

New surfactant with SP-B and C analogs gives survival benefit after inactivation in preterm lambs

BACKGROUND

Respiratory distress syndrome in preterm babies is caused by a pulmonary surfactant deficiency, but also by its inactivation due to various conditions, including plasma protein leakage. Surfactant replacement therapy is well established, but clinical observations and in vitro experiments suggested that its efficacy may be impaired by inactivation. A new synthetic surfactant (CHF 5633), containing synthetic surfactant protein B and C analogs, has shown comparable effects on oxygenation in ventilated preterm rabbits versus Poractant alfa, but superior resistance against inactivation in vitro. We hypothesized that CHF 5633 is also resistant to inactivation by serum albumin in vivo.

METHODOLOGY/PRINCIPAL FINDINGS

Nineteen preterm lambs of 127 days gestational age (term = 150 days) received CHF 5633 or Poractant alfa and were ventilated for 48 hours. Ninety minutes after birth, the animals received albumin with CHF 5633 or Poractant alfa. Animals received additional surfactant if P(a)O(2) dropped below 100 mmHg. A pressure volume curve was done post mortem and markers of pulmonary inflammation, surfactant content and biophysiology, and lung histology were assessed. CHF 5633 treatment resulted in improved arterial pH, oxygenation and ventilation efficiency index. The survival rate was significantly higher after CHF 5633 treatment (5/7) than after Poractant alfa (1/8) after 48 hours of ventilation. Biophysical examination of the surfactant recovered from bronchoalveolar lavages revealed that films formed by CHF 5633-treated animals reached low surface tensions in a wider range of compression rates than films from Poractant alfa-treated animals.

CONCLUSIONS

For the first time a synthetic surfactant containing both surfactant protein B and C analogs showed significant benefit over animal derived surfactant in an in vivo model of surfactant inactivation in premature lambs.

The role of surfactant in respiratory distress syndrome

The key feature of respiratory distress syndrome (RDS) is the insufficient production of surfactant in the lungs of preterm infants. As a result, researchers have looked into the possibility of surfactant replacement therapy as a means of preventing and treating RDS. We sought to identify the role of surfactant in the prevention and management of RDS, comparing the various types, doses, and modes of administration, and the recent development. A PubMed search was carried out up to March 2012 using phrases: surfactant, respiratory distress syndrome, protein-containing surfactant, protein-free surfactant, natural surfactant, animal-derived surfactant, synthetic surfactant, lucinactant, surfaxin, surfactant protein-B, surfactant protein-C.Natural, or animal-derived, surfactant is currently the surfactant of choice in comparison to protein-free synthetic surfactant. However, it is hoped that the development of protein-containing synthetic surfactant, such as lucinactant, will rival the efficacy of natural surfactants, but without the risks of their possible side effects. Administration techniques have also been developed with nasal continuous positive airway pressure (nCPAP) and selective surfactant administration now recommended; multiple surfactant doses have also reported better outcomes. An aerosolised form of surfactant is being trialled in the hope that surfactant can be administered in a non-invasive way. Overall, the advancement, concerning the structure of surfactant and its mode of administration, offers an encouraging future in the management of RDS.

SP-B and SP-C containing new synthetic surfactant for treatment of extremely immature lamb lung

Although superiority of synthetic surfactant over animal-driven surfactant has been known, there is no synthetic surfactant commercially available at present. Many trials have been made to develop synthetic surfactant comparable in function to animal-driven surfactant. The efficacy of treatment with a new synthetic surfactant (CHF5633) containing dipalmitoylphosphatidylcholine, phosphatidylglycerol, SP-B analog, and SP-C analog was evaluated using immature newborn lamb model and compared with animal lung tissue-based surfactant Survanta. Lambs were treated with a clinical dose of 200 mg/kg CHF5633, 100 mg/kg Survanta, or air after 15 min initial ventilation. All the lambs treated with air died of respiratory distress within 90 min of age. During a 5 h study period, Pco(2) was maintained at 55 mmHg with 24 cmH(2)O peak inspiratory pressure for both groups. The preterm newborn lamb lung functions were dramatically improved by CHF5633 treatment. Slight, but significant superiority of CHF5633 over Survanta was demonstrated in tidal volume at 20 min and dynamic lung compliance at 20 and 300 min. The ultrastructure of CHF5633 was large with uniquely aggregated lipid particles. Increased uptake of CHF5633 by alveolar monocytes for catabolism was demonstrated by microphotograph, which might be associated with the higher treatment dose of CHF5633. The higher catabolism of CHF5633 was also suggested by the similar amount of surfactant lipid in bronchoalveolar lavage fluid (BALF) between CHF5633 and Survanta groups, despite the 2-fold higher treatment dose of CHF5633. Under the present ventilation protocol, lung inflammation was minimal for both groups, evaluated by inflammatory cell numbers in BALF and expression of IL-1β, IL-6, IL-8, and TNFα mRNA in the lung tissue. In conclusion, the new synthetic surfactant CHF5633 was effective in treating extremely immature newborn lambs with surfactant deficiency during the 5 h study period.

Old and new uses of surfactant

Exogenous surfactant has been the primary life-saving therapy for respiratory distress syndrome (RDS) of preterm infants for many years. More recently, early surfactant treatment administered less invasively by transient endotracheal intubation and combined to nasal ventilation has been shown to further improve neonatal outcome by reducing the need of mechanical ventilation. In addition to RDS, other neonatal and pediatric respiratory disorders characterized by surfactant inactivation or dysfunction, such as pulmonary hemorrhage, aspiration pneumonia, and viral lower respiratory tract infection, might also be amenable to surfactant replacement therapy. However, the nature of lung injury and the influence of co-morbidities may reduce the efficacy of surfactant in these conditions. Currently under investigation are new synthetic surfactant formulations which may be more effective and resistant to inactivation than natural ones and could be produced at a lower cost. The use of surfactants to deliver drugs directly to the lung also seems to be a promising technique worthy of study.