1
|
Penazzi L, Freire TGB, Theodoro SDS, Frias JL, Ala U, Carciofi AC, Prola L. Lentils pasta by-product in a complete extruded diet for dogs and its effect on extrusion, digestibility, and carbohydrate metabolism. Front Vet Sci 2024; 11:1429218. [PMID: 38993281 PMCID: PMC11238134 DOI: 10.3389/fvets.2024.1429218] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/07/2024] [Accepted: 06/07/2024] [Indexed: 07/13/2024] Open
Abstract
Introduction Recently, increasing effort has been directed toward environmental sustainability in pet food. The aim of this study was to evaluate the extrusion parameters, nutrient digestibility, fecal characteristics, palatability and insulinemic and glycaemic curves of a complete diet for dogs in which the main carbohydrate source was a red lentil pasta by-product (LP). Methods Five experimental diets were formulated: a basal diet (CO) based on rice and a poultry by-product meal; three experimental diets where LP substituted rice at 33, 66, or 100% (LP33, LP66, and LP100, respectively); and a diet formulated on 70% of the basal diet (CO) plus 30% LP (LPS) to evaluate the digestibility of LP ingredient. Results and discussion The extruder pressure, hardness and bulk density of the kibble increased in a linear manner with increasing LP percentage (P < 0.05), without affecting starch gelatinization. According to polynomial contrast analysis, rice replacement with LP at 33 and 66% caused no reduction in apparent total tract digestibility coefficient (ATTDC), with similar or higher values compared with the CO diet. Nitrogen balance did not change (P > 0.05), but we observed a linear increase in feces production and moisture content as the LP inclusion rate rose and a linear decrease in feces pH (P < 0.05). Nevertheless, the fecal score was unaffected. Fecal acetate, propionate, total short-chain fatty acids (SCFA), branched-chain fatty acids, and lactate all increased linearly as the LP inclusion rate increased (P < 0.05), without altering ammonia concentration in feces. Feces concentrations of cadaverine, tyramine, histamine, and spermidine also increased in a linear manner with increasing LP inclusion (P < 0.05). The fermentation of LP dietary fiber by the gut microbiota increased the concentration of desirable fermentation by-products, including SCFA and spermidine. The post-prandial glucose and insulin responses were lower in the dogs fed the LP100 diet compared with CO, suggesting the possible use of this ingredient in diets designed to generate a low glycaemic response. Finally, the palatability study results showed a preference for the LP100 ration in both the "first choice" and the "consumption rate" evaluation (P < 0.05). This trial reveals how a by-product discarded from the human-grade food chain retains both its nutritional and organoleptic properties.
Collapse
Affiliation(s)
- Livio Penazzi
- Department of Veterinary Sciences, University of Turin, Grugliasco, Italy
- Department of Veterinary Clinic and Surgery, Universidade Estadual Paulista (UNESP), Jaboticabal, São Paulo, Brazil
| | | | - Stephanie de Souza Theodoro
- Department of Veterinary Clinic and Surgery, Universidade Estadual Paulista (UNESP), Jaboticabal, São Paulo, Brazil
| | - Juliana Lopes Frias
- Department of Veterinary Clinic and Surgery, Universidade Estadual Paulista (UNESP), Jaboticabal, São Paulo, Brazil
| | - Ugo Ala
- Department of Veterinary Sciences, University of Turin, Grugliasco, Italy
| | - Aulus Cavalieri Carciofi
- Department of Veterinary Clinic and Surgery, Universidade Estadual Paulista (UNESP), Jaboticabal, São Paulo, Brazil
| | - Liviana Prola
- Department of Veterinary Sciences, University of Turin, Grugliasco, Italy
| |
Collapse
|
2
|
Lisciani S, Marconi S, Le Donne C, Camilli E, Aguzzi A, Gabrielli P, Gambelli L, Kunert K, Marais D, Vorster BJ, Alvarado-Ramos K, Reboul E, Cominelli E, Preite C, Sparvoli F, Losa A, Sala T, Botha AM, Ferrari M. Legumes and common beans in sustainable diets: nutritional quality, environmental benefits, spread and use in food preparations. Front Nutr 2024; 11:1385232. [PMID: 38769988 PMCID: PMC11104268 DOI: 10.3389/fnut.2024.1385232] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/12/2024] [Accepted: 03/28/2024] [Indexed: 05/22/2024] Open
Abstract
In recent decades, scarcity of available resources, population growth and the widening in the consumption of processed foods and of animal origin have made the current food system unsustainable. High-income countries have shifted towards food consumption patterns which is causing an increasingly process of environmental degradation and depletion of natural resources, with the increased incidence of malnutrition due to excess (obesity and non-communicable disease) and due to chronic food deprivation. An urgent challenge is, therefore, to move towards more healthy and sustainable eating choices and reorientating food production and distribution to obtain a human and planetary health benefit. In this regard, legumes represent a less expensive source of nutrients for low-income countries, and a sustainable healthier option than animal-based proteins in developed countries. Although legumes are the basis of many traditional dishes worldwide, and in recent years they have also been used in the formulation of new food products, their consumption is still scarce. Common beans, which are among the most consumed pulses worldwide, have been the focus of many studies to boost their nutritional properties, to find strategies to facilitate cultivation under biotic/abiotic stress, to increase yield, reduce antinutrients contents and rise the micronutrient level. The versatility of beans could be the key for the increase of their consumption, as it allows to include them in a vast range of food preparations, to create new formulations and to reinvent traditional legume-based recipes with optimal nutritional healthy characteristics.
Collapse
Affiliation(s)
- Silvia Lisciani
- Research Centre for Food and Nutrition, Council for Agricultural Research and Economics, Rome, Italy
| | - Stefania Marconi
- Research Centre for Food and Nutrition, Council for Agricultural Research and Economics, Rome, Italy
| | - Cinzia Le Donne
- Research Centre for Food and Nutrition, Council for Agricultural Research and Economics, Rome, Italy
| | - Emanuela Camilli
- Research Centre for Food and Nutrition, Council for Agricultural Research and Economics, Rome, Italy
| | - Altero Aguzzi
- Research Centre for Food and Nutrition, Council for Agricultural Research and Economics, Rome, Italy
| | - Paolo Gabrielli
- Research Centre for Food and Nutrition, Council for Agricultural Research and Economics, Rome, Italy
| | - Loretta Gambelli
- Research Centre for Food and Nutrition, Council for Agricultural Research and Economics, Rome, Italy
| | - Karl Kunert
- Department of Plant and Soil Sciences, Faculty of Natural and Agricultural Sciences, University of Pretoria, Pretoria, South Africa
| | - Diana Marais
- Department of Plant and Soil Sciences, Faculty of Natural and Agricultural Sciences, University of Pretoria, Pretoria, South Africa
| | - Barend Juan Vorster
- Department of Plant and Soil Sciences, Faculty of Natural and Agricultural Sciences, University of Pretoria, Pretoria, South Africa
| | | | | | - Eleonora Cominelli
- Institute of Agricultural Biology and Biotechnology, National Research Council (CNR), Milan, Italy
| | - Chiara Preite
- Institute of Agricultural Biology and Biotechnology, National Research Council (CNR), Milan, Italy
| | - Francesca Sparvoli
- Institute of Agricultural Biology and Biotechnology, National Research Council (CNR), Milan, Italy
| | - Alessia Losa
- Research Centre for Genomics and Bioinformatics, Council for Agricultural and Economics Research, Montanaso Lombardo, Italy
| | - Tea Sala
- Research Centre for Genomics and Bioinformatics, Council for Agricultural and Economics Research, Montanaso Lombardo, Italy
| | - Anna-Maria Botha
- Department of Genetics, Stellenbosch University, Stellenbosch, South Africa
| | - Marika Ferrari
- Research Centre for Food and Nutrition, Council for Agricultural Research and Economics, Rome, Italy
| |
Collapse
|
3
|
Pinel P, Emmambux MN, Bourlieu C, Micard V. Nutritional contributions and processability of pasta made from climate-smart, sustainable crops: A critical review. Crit Rev Food Sci Nutr 2023:1-31. [PMID: 37937848 DOI: 10.1080/10408398.2023.2271952] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/09/2023]
Abstract
Total or partial replacement of traditional durum wheat semolina (DWS) by alternative flours, such as legumes or wholegrain cereals in pasta improves their nutritional quality and can make them interesting vector for fortification. Climate-smart gluten-free (C-GF) flours, such as legumes (bambara groundnut, chickpea, cowpea, faba bean, and pigeon pea), some cereals (amaranth, teff, millet, and sorghum), and tubers (cassava and orange fleshed sweet potato), are of high interest to face ecological transition and develop sustainable food systems. In this review, an overview and a critical analysis of their nutritional potential for pasta production and processing conditions are undertaken. Special emphasis is given to understanding the influence of formulation and processing on techno-functional and nutritional (starch and protein digestibility) properties. Globally C-GF flours improve pasta protein quantity and quality, fibers, and micronutrients contents while keeping a low glycemic index and increasing protein digestibility. However, their use introduces anti-nutritional factors and could lead to the alteration of their techno-functional properties (higher cooking losses, lower firmness, and variability in color in comparison to classical DWS pasta). Nevertheless, these alternative pasta remain more interesting in terms of nutritional and techno-functional quality than traditional maize and rice-based gluten free pasta.
Collapse
Affiliation(s)
- P Pinel
- UMR IATE, INRAE, Institut Agro, Univ. Montpellier, Montpellier, France
| | - M N Emmambux
- Department of Consumer and Food Sciences, University of Pretoria, Pretoria, South Africa
| | - C Bourlieu
- UMR IATE, INRAE, Institut Agro, Univ. Montpellier, Montpellier, France
| | - V Micard
- UMR IATE, INRAE, Institut Agro, Univ. Montpellier, Montpellier, France
| |
Collapse
|
4
|
Badjona A, Bradshaw R, Millman C, Howarth M, Dubey B. Faba Bean Flavor Effects from Processing to Consumer Acceptability. Foods 2023; 12:foods12112237. [PMID: 37297480 DOI: 10.3390/foods12112237] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/26/2023] [Revised: 05/22/2023] [Accepted: 05/29/2023] [Indexed: 06/12/2023] Open
Abstract
Faba beans as an alternative source of protein have received significant attention from consumers and the food industry. Flavor represents a major driving force that hinders the utilization faba beans in various products due to off-flavor. Off-flavors are produced from degradation of amino acids and unsaturated fatty acids during seed development and post-harvest processing stages (storage, dehulling, thermal treatment, and protein extraction). In this review, we discuss the current state of knowledge on the aroma of faba bean ingredients and various aspects, such as cultivar, processing, and product formulation that influence flavour. Germination, fermentation, and pH modulation were identified as promising methods to improve overall flavor and bitter compounds. The probable pathway in controlling off-flavor evolution during processing has also been discussed to provide efficient strategies to limit their impact and to encourage the use of faba bean ingredients in healthy food design.
Collapse
Affiliation(s)
- Abraham Badjona
- National Centre of Excellence for Food Engineering, Sheffield Hallam University, Sheffield S1 1WB, UK
| | - Robert Bradshaw
- Bimolecular Research Centre, Sheffield Hallam University, Sheffield S1 1WB, UK
| | - Caroline Millman
- National Centre of Excellence for Food Engineering, Sheffield Hallam University, Sheffield S1 1WB, UK
| | - Martin Howarth
- National Centre of Excellence for Food Engineering, Sheffield Hallam University, Sheffield S1 1WB, UK
| | - Bipro Dubey
- National Centre of Excellence for Food Engineering, Sheffield Hallam University, Sheffield S1 1WB, UK
| |
Collapse
|
5
|
Duijsens D, Alfie Castillo AI, Verkempinck SHE, Pälchen K, Hendrickx ME, Grauwet T. In vitro macronutrient digestibility and mineral bioaccessibility of lentil-based pasta: The influence of cellular intactness. Food Chem 2023; 423:136303. [PMID: 37182489 DOI: 10.1016/j.foodchem.2023.136303] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/12/2022] [Revised: 04/27/2023] [Accepted: 05/01/2023] [Indexed: 05/16/2023]
Abstract
Recently, pulse ingredients with (partial) cellular intactness are put forward as promising innovative food ingredients with slowed macronutrient digestibility. This study compared cooking quality and nutrient (starch, protein, and mineral) digestibility/bioaccessibility of lentil-based pasta prepared from 100% raw-milled flour, and by substituting 30% of the formulation by isolated cotyledon cell powder or whole precooked powder. Formulation had little effect on cooking properties. Both amylolysis and proteolysis were significantly slowed by incorporating cellular ingredients: towards the end of simulated digestion, amylolysis was lowered by 16-25%, while differences in proteolysis became small. Cellular ingredient incorporation slightly decreased Zn and Mg but did not affect Ca and Fe bioaccessibility, overall yielding a low mineral bioaccessibility comparable to cooked whole pulses. To conclude, lentil-based pasta substituted with cellular ingredients showed improved nutritional properties (i.e., high in digestible protein and slowed amylolysis), with perspectives for the development of different innovative foods with targeted nutritional properties.
Collapse
Affiliation(s)
- D Duijsens
- Laboratory of Food Technology and Leuven Food Science and Nutrition Research Centre (LFoRCe), Department of Microbial and Molecular Systems (M2S), KU Leuven, Kasteelpark Arenberg 22, PB 2457, 3001 Leuven, Belgium.
| | - A I Alfie Castillo
- Laboratory of Food Technology and Leuven Food Science and Nutrition Research Centre (LFoRCe), Department of Microbial and Molecular Systems (M2S), KU Leuven, Kasteelpark Arenberg 22, PB 2457, 3001 Leuven, Belgium
| | - S H E Verkempinck
- Laboratory of Food Technology and Leuven Food Science and Nutrition Research Centre (LFoRCe), Department of Microbial and Molecular Systems (M2S), KU Leuven, Kasteelpark Arenberg 22, PB 2457, 3001 Leuven, Belgium
| | - K Pälchen
- Laboratory of Food Technology and Leuven Food Science and Nutrition Research Centre (LFoRCe), Department of Microbial and Molecular Systems (M2S), KU Leuven, Kasteelpark Arenberg 22, PB 2457, 3001 Leuven, Belgium
| | - M E Hendrickx
- Laboratory of Food Technology and Leuven Food Science and Nutrition Research Centre (LFoRCe), Department of Microbial and Molecular Systems (M2S), KU Leuven, Kasteelpark Arenberg 22, PB 2457, 3001 Leuven, Belgium
| | - T Grauwet
- Laboratory of Food Technology and Leuven Food Science and Nutrition Research Centre (LFoRCe), Department of Microbial and Molecular Systems (M2S), KU Leuven, Kasteelpark Arenberg 22, PB 2457, 3001 Leuven, Belgium.
| |
Collapse
|
6
|
Blandino M, Bresciani A, Locatelli M, Loscalzo M, Travaglia F, Vanara F, Marti A. Pulse type and extrusion conditions affect phenolic profile and physical properties of extruded products. Food Chem 2023; 403:134369. [DOI: 10.1016/j.foodchem.2022.134369] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/28/2022] [Revised: 09/05/2022] [Accepted: 09/19/2022] [Indexed: 10/14/2022]
|
7
|
Boudouira N, Yüksel AN, Bayram M, Benatallah L, Zidoune MN. Characterisation of gluten‐free couscous produced with different legume flours by traditional method. Int J Food Sci Technol 2023. [DOI: 10.1111/ijfs.16266] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/24/2023]
Affiliation(s)
- Nassira Boudouira
- Laboratoire de Nutrition et Technologie Alimentaire (L.N.T.A.), Institut de la Nutrition, de l'Alimentation et des Technologies Agro‐Alimentaires (I.N.A.T.A.A.) Université des Frères Mentouri Constantine 1 Route de Ain El‐Bey 25000 Constantine Algeria
| | - Ayşe Nur Yüksel
- Department of Gastronomy and Culinary Arts, Faculty of Engineering, Architecture and Design Kahramanmaraş Istiklal University 46100 Kahramanmaraş Turkey
| | - Mustafa Bayram
- Department of Food Engineering, Faculty of Engineering Gaziantep University 27310 Gaziantep Turkey
| | - Leila Benatallah
- Laboratoire de Nutrition et Technologie Alimentaire (L.N.T.A.), Institut de la Nutrition, de l'Alimentation et des Technologies Agro‐Alimentaires (I.N.A.T.A.A.) Université des Frères Mentouri Constantine 1 Route de Ain El‐Bey 25000 Constantine Algeria
| | - Mohammed Nasreddine Zidoune
- Laboratoire de Nutrition et Technologie Alimentaire (L.N.T.A.), Institut de la Nutrition, de l'Alimentation et des Technologies Agro‐Alimentaires (I.N.A.T.A.A.) Université des Frères Mentouri Constantine 1 Route de Ain El‐Bey 25000 Constantine Algeria
| |
Collapse
|
8
|
Suo X, Pompei F, Bonfini M, Mustafa AM, Sagratini G, Wang Z, Vittadini E. Quality of wholemeal pasta made with pigmented and ancient wheats. Int J Gastron Food Sci 2023. [DOI: 10.1016/j.ijgfs.2023.100665] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Submit a Manuscript] [Subscribe] [Scholar Register] [Indexed: 01/18/2023]
|
9
|
Betrouche A, Estivi L, Colombo D, Pasini G, Benatallah L, Brandolini A, Hidalgo A. Antioxidant Properties of Gluten-Free Pasta Enriched with Vegetable By-Products. MOLECULES (BASEL, SWITZERLAND) 2022; 27:molecules27248993. [PMID: 36558126 PMCID: PMC9784952 DOI: 10.3390/molecules27248993] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 11/05/2022] [Revised: 12/12/2022] [Accepted: 12/13/2022] [Indexed: 12/23/2022]
Abstract
The only therapy for coeliac disease patients is to completely avoid foods containing gluten, a protein complex common in several small-grain cereals. However, many alternative gluten-free foods available on the market present nutritional deficiencies. Therefore, the aim of this research was to evaluate the composition and the antioxidant properties of gluten-free pasta enriched with 10% or 15% of tomato waste or linseed meal, two food industry by-products. The traits analysed were protein, lipid, ash and fibre content, heat damage, tocols, carotenoids and phenolics composition (by HPLC), antioxidant capacity, and pasta fracturability. The enriched pastas contained more fibre and lipids than the control, while the protein and ash values were similar. The addition of tomato and linseed waste improved tocols concentration but had no effect on carotenoids content. The free soluble polyphenols increase was similar for both by-products and proportional to the enrichment percentage, while the bound insoluble polyphenols were higher in linseed-enriched pastas. The samples with linseed meal showed the greatest antioxidant capacity and, at 10% addition, the highest fracturability value. In conclusion, the addition of tomato and linseed by-products significantly increases the presence of bioactive compounds (particularly polyphenols), improving the nutritional value of gluten-free pasta.
Collapse
Affiliation(s)
- Amel Betrouche
- Food Engineering Laboratory, Institute of Nutrition, Food and Agri-Food Technologies (GéniAAl-INATAA), University Frères Mentouri Constantine 1 (UFMC1), 325 Route de Ain El Bey, Constantine 25017, Algeria
| | - Lorenzo Estivi
- Department of Food, Environmental and Nutritional Sciences (DeFENS), University of Milan, Via Celoria 2, 20133 Milan, Italy
| | - Davide Colombo
- Department of Food, Environmental and Nutritional Sciences (DeFENS), University of Milan, Via Celoria 2, 20133 Milan, Italy
| | - Gabriella Pasini
- Department of Agronomy, Food, Natural Resources, Animals and Environment (DAFNAE), University of Padua, Viale dell’ Università 16, 35020 Legnaro, Italy
| | - Leila Benatallah
- Food Engineering Laboratory, Institute of Nutrition, Food and Agri-Food Technologies (GéniAAl-INATAA), University Frères Mentouri Constantine 1 (UFMC1), 325 Route de Ain El Bey, Constantine 25017, Algeria
| | - Andrea Brandolini
- Research Centre for Animal Production and Aquaculture (CREA-ZA), Council for Agricultural Research and Economics, Via Piacenza 29, 26900 Lodi, Italy
- Correspondence: (A.B.); (A.H.); Tel.: +39-0371-404750 (A.B.); +39-02-50319189 (A.H.)
| | - Alyssa Hidalgo
- Department of Food, Environmental and Nutritional Sciences (DeFENS), University of Milan, Via Celoria 2, 20133 Milan, Italy
- Correspondence: (A.B.); (A.H.); Tel.: +39-0371-404750 (A.B.); +39-02-50319189 (A.H.)
| |
Collapse
|
10
|
Hoehnel A, Bez J, Petersen IL, Amarowicz R, Juśkiewicz J, Zannini E, Arendt EK. Combining high-protein ingredients from pseudocereals and legumes for the development of fresh high-protein hybrid pasta: enhanced nutritional profile. JOURNAL OF THE SCIENCE OF FOOD AND AGRICULTURE 2022; 102:5000-5010. [PMID: 33314156 DOI: 10.1002/jsfa.11015] [Citation(s) in RCA: 7] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/13/2020] [Revised: 12/08/2020] [Accepted: 12/14/2020] [Indexed: 06/12/2023]
Abstract
BACKGROUND The fortification of wheat-based staple foods, such as pasta, with pseudocereal and legume flours has received growing research interest in recent years. While it is associated with many challenges regarding technological and sensory quality of the products, it promises a substantial improvement of the nutritional value of pasta. However, investigations of the nutritional quality of fortified pasta often focus on the carbohydrate/starch fraction, and information on changes in protein quality is relatively scarce. This study evaluates the nutritional profile of a high-protein hybrid pasta (HPHP) formulation in which a combination of three high-protein ingredients (HPIs) from buckwheat, faba bean and lupin is used to partially replace wheat semolina. The formulation's macronutrient composition, protein quality and the content of antinutritional compounds are assessed in comparison to regular wheat pasta. RESULTS The HPHP formulation represents a more favourable macronutrient profile compared to regular wheat pasta, particularly in relation to the isocaloric replacement of wheat starch by non-wheat protein. Furthermore, a more balanced amino acid profile, improved N utilisation and increased protein efficiency ratio (in vivo) were determined for HPHP, which conclusively suggests a substantially enhanced protein quality. The cooking process was shown to significantly reduce levels of vicine/convicine and trypsin inhibitor activity originating from HPIs. The small remaining levels seem not to adversely affect HPHP's nutritional quality. CONCLUSION This significant upgrade of pasta's nutritional value identifies HPHP, and similar hybrid formulations, as a healthy food choice and valuable alternative to regular wheat pasta, specifically for a protein supply of adequate quality in mostly plant-based diets. © 2020 Society of Chemical Industry.
Collapse
Affiliation(s)
- Andrea Hoehnel
- School of Food and Nutritional Sciences, University College Cork, Cork, Ireland
| | - Jürgen Bez
- Fraunhofer Institute for Process Engineering and Packaging, Freising, Germany
| | - Iben L Petersen
- Department of Food Science, University of Copenhagen, Frederiksberg C, Denmark
| | - Ryszard Amarowicz
- Institute of Animal Reproduction and Food Research of the Polish Academy of Sciences, Olsztyn, Poland
| | - Jerzy Juśkiewicz
- Institute of Animal Reproduction and Food Research of the Polish Academy of Sciences, Olsztyn, Poland
| | - Emanuele Zannini
- School of Food and Nutritional Sciences, University College Cork, Cork, Ireland
| | - Elke K Arendt
- School of Food and Nutritional Sciences, University College Cork, Cork, Ireland
- APC Microbiome Ireland, Cork, Ireland
| |
Collapse
|
11
|
Jebalia I, Della Valle G, Kristiawan M. Extrusion of pea snack foods and control of biopolymer changes aided by rheology and simulation. FOOD AND BIOPRODUCTS PROCESSING 2022. [DOI: 10.1016/j.fbp.2022.08.001] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/04/2022]
|
12
|
Hoehnel A, Bez J, Amarowicz R, Arendt EK, Zannini E. Combining high-protein ingredients from pseudocereals and legumes for the development of fresh high-protein hybrid pasta: maintained technological quality and adequate sensory attributes. JOURNAL OF THE SCIENCE OF FOOD AND AGRICULTURE 2022; 102:4977-4987. [PMID: 33280110 DOI: 10.1002/jsfa.10994] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/03/2020] [Revised: 11/28/2020] [Accepted: 12/06/2020] [Indexed: 06/12/2023]
Abstract
BACKGROUND The fortification of cereal foods, like pasta, with pseudocereal and legume ingredients promises a substantial improvement of their nutritional quality. However, partial replacement of wheat by pseudocereals and legumes in pasta formulations bears challenges regarding the products' technological and sensory quality. This study investigates the partial replacement of wheat semolina by a combination of high-protein ingredients (HPIs) from buckwheat, faba bean and lupin to reach a protein level of 20% of calories provided by protein. This high-protein hybrid pasta (HPHP) formulation was subjected to a thorough evaluation of technological quality characteristics and compared to regular wheat pasta and pasta formulations containing the single HPIs. Additionally, descriptive sensory profiling was performed to compare organoleptic properties of HPHP with regular wheat pasta. RESULTS The quality of pasta formulations containing single HPIs was significantly reduced with regard to at least one of the determined quality characteristics. For the HPHP formulation containing all three HPIs, the technological quality was found to be equal to regular wheat pasta. No significant differences were detected for the most indicative quality characteristics cooking loss, firmness and stickiness. This was attributed primarily to compensating effects of the HPIs with respect to different quality characteristics. Sensory analysis revealed only slightly inferior overall quality of HPHP in comparison to regular wheat pasta, especially promoted by similar textural properties. CONCLUSION The combination of selected HPIs offers the opportunity to produce high-protein hybrid pasta with technological and sensory quality similar to regular wheat pasta at a level of wheat semolina replacement of 25%. © 2020 Society of Chemical Industry.
Collapse
Affiliation(s)
- Andrea Hoehnel
- School of Food and Nutritional Sciences, University College Cork, Cork, Ireland
| | - Jürgen Bez
- Fraunhofer Institute for Process Engineering and Packaging, Freising, Germany
| | - Ryszard Amarowicz
- Institute of Animal Reproduction and Food Research of the Polish Academy of Sciences, Olsztyn, Poland
| | - Elke K Arendt
- School of Food and Nutritional Sciences, University College Cork, Cork, Ireland
- APC Microbiome Ireland, Cork, Ireland
| | - Emanuele Zannini
- School of Food and Nutritional Sciences, University College Cork, Cork, Ireland
| |
Collapse
|
13
|
Namir M, Iskander A, Alyamani A, Sayed-Ahmed ETA, Saad AM, Elsahy K, El-Tarabily KA, Conte-Junior CA. Upgrading Common Wheat Pasta by Fiber-Rich Fraction of Potato Peel Byproduct at Different Particle Sizes: Effects on Physicochemical, Thermal, and Sensory Properties. Molecules 2022; 27:2868. [PMID: 35566217 PMCID: PMC9101751 DOI: 10.3390/molecules27092868] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/14/2022] [Revised: 04/25/2022] [Accepted: 04/26/2022] [Indexed: 02/04/2023] Open
Abstract
Fiber-enriched food has numerous health benefits. This study develops functional fiber-enriched pasta (FEP) by partially substituting wheat flour for alcohol-insoluble residue prepared from potato processing byproducts (AIR-PPB) at various particle sizes (PS). The independent variables' effects, AIR-PPB at 2-15% substitution levels, and PS 40-250 µm were investigated in terms of chemical, cooking, thermal, and sensory properties. AIR-PPB is rich in total dietary fibers (TDF) (83%), exhibiting high water-holding capacity (WHC) and vibrant colors. Different concentrations of AIR-PPB increase TDF content in FEPs by 7-21 times compared to the control pasta (CP). Although the optimal cooking time (OCT) decreases by 15-18% compared to CP, where a lower OCT should reduce cooking time and save energy, cooking loss (Cl) increases slightly but remains within an acceptable range of 8%. Additionally, AIR-PPB altered the texture properties of FEP, with a moderate decrease in mass increase index (MII), firmness, and stickiness. AIR-PPB impairs the gluten network's structure in pasta due to AIR-PPB's WHC, which competes with starch for water binding, increasing the starch gelatinization temperature. FEPs show an increased lightness and yellowness and improved sensory properties. Highly acceptable FEPs were obtained for the following substitution levels: FEP11 (AIR-PPB at 2% and PS of 145 µm), FEP9 (AIR-PPB 4% level with PS of 70 µm), FEP6 (AIR-PPB of 4% level with 219 µm PS), and FEP1 (AIR-PPB = 8.5% with 40 µm PS), as compared to other FEPs.
Collapse
Affiliation(s)
- Mohammad Namir
- Food Science Department, Faculty of Agriculture, Zagazig University, Zagazig 44511, Egypt; (M.N.); (A.I.); (E.T.A.S.-A.); (K.E.)
| | - Ali Iskander
- Food Science Department, Faculty of Agriculture, Zagazig University, Zagazig 44511, Egypt; (M.N.); (A.I.); (E.T.A.S.-A.); (K.E.)
- General Organization for Export and Import Control, Ministry of Trade and Industry, Garden City, Cairo 11519, Egypt
| | - Amal Alyamani
- Department of Biotechnology, Faculty of Sciences, Taif University, P.O. Box 11099, Taif 21944, Saudi Arabia;
| | - Eman T. Abou Sayed-Ahmed
- Food Science Department, Faculty of Agriculture, Zagazig University, Zagazig 44511, Egypt; (M.N.); (A.I.); (E.T.A.S.-A.); (K.E.)
| | - Ahmed M. Saad
- Biochemistry Department, Faculty of Agriculture, Zagazig University, Zagazig 44511, Egypt
| | - Kamal Elsahy
- Food Science Department, Faculty of Agriculture, Zagazig University, Zagazig 44511, Egypt; (M.N.); (A.I.); (E.T.A.S.-A.); (K.E.)
| | - Khaled A. El-Tarabily
- Department of Biology, College of Science, United Arab Emirates University, Al Ain 15551, United Arab Emirates
| | - Carlos Adam Conte-Junior
- Center for Food Analysis (NAL), Technological Development Support Laboratory (LADETEC), Federal University of Rio de Janeiro (UFRJ), Cidade Universitária, Rio de Janeiro 21941-598, Brazil;
| |
Collapse
|
14
|
Quality and Sensory Profile of Durum Wheat Pasta Enriched with Carrot Waste Encapsulates. Foods 2022; 11:foods11081130. [PMID: 35454716 PMCID: PMC9025160 DOI: 10.3390/foods11081130] [Citation(s) in RCA: 6] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/29/2022] [Revised: 04/12/2022] [Accepted: 04/13/2022] [Indexed: 01/25/2023] Open
Abstract
Consumer knowledge about pasta quality differs around the world. Modern consumers are more sophisticated compared to past times, due to the availability of information on pasta types and quality. Therefore, this study investigated the nutritional, physical, textural, and morphological quality of durum wheat pasta enriched with carrot waste encapsulates (10 and 20% freeze-dried encapsulate (FDE) and 10 and 20% spray-dried encapsulate (SDE)), as well as determining consumer preferences for this type of product. Replacement of semolina with FDE and SDE contributed to changes in the pasta nutritional quality, which was reflected in the increased protein, fat, and ash content. Additionally, changes in cooking quality, color, and texture were within satisfactory limits. The uncooked pasta enriched with 10 and 20% SDE was characterized by a lighter yellow intensity with color saturation, as well as an imperceptible waxy appearance compared to the control and enriched pasta with 10 and 20% FDE. After cooking, the yellow color was more intense in all the enriched pasta samples which can be linked to the raw cereal which was significantly greater in the control in comparison to the FDE and SDE containing samples. Overall, carrot waste can be a promising material for the food industry to produce high-quality pasta.
Collapse
|
15
|
Krause S, Keller S, Hashemi A, Descharles N, Bonazzi C, Rega B. From flours to cakes: Reactivity potential of pulse ingredients to generate volatile compounds impacting the quality of processed foods. Food Chem 2022; 371:131379. [PMID: 34808773 DOI: 10.1016/j.foodchem.2021.131379] [Citation(s) in RCA: 10] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/03/2021] [Revised: 09/20/2021] [Accepted: 10/07/2021] [Indexed: 01/13/2023]
Abstract
This study investigated the impact of substituting wheat with pulse flours (lentil, chickpea, lupin, green and yellow pea) on reactivity during different steps of sponge cake development. Pulses exhibited a greater ability to generate volatiles with probable odor activity. Batter beating initiated lipid oxidation which depended on lipoxygenase activity and the fatty acid profile of the flours. Among the pulses, pea batters were richest in oxidation markers whereas lupin was least reactive, probably due to thermal pre-treatment. Baking triggered caramelization and Maillard reactions, notably with the pulse products which were particularly enriched in pyrazines and furanic compounds. Principle component analysis revealed that pea cakes were associated with oxidation markers that typically possess green-beany flavors, while Maillard markers known to impart nutty, roasted notes were assigned to lentil and chickpea cakes. These findings highlight the importance of ingredient type and its pre-processing in the development of quality-related markers for gluten-free products.
Collapse
Affiliation(s)
- Svenja Krause
- Université Paris-Saclay, INRAE, AgroParisTech, UMR SayFood, 91300 Massy, France.
| | - Séverine Keller
- Université Paris-Saclay, INRAE, AgroParisTech, UMR SayFood, 91300 Massy, France.
| | - Anahita Hashemi
- Université Paris-Saclay, INRAE, AgroParisTech, UMR SayFood, 91300 Massy, France
| | - Nicolas Descharles
- Université Paris-Saclay, INRAE, AgroParisTech, UMR SayFood, 91300 Massy, France.
| | - Catherine Bonazzi
- Université Paris-Saclay, INRAE, AgroParisTech, UMR SayFood, 91300 Massy, France.
| | - Barbara Rega
- Université Paris-Saclay, INRAE, AgroParisTech, UMR SayFood, 91300 Massy, France.
| |
Collapse
|
16
|
Suo X, Dall'Asta M, Giuberti G, Minucciani M, Wang Z, Vittadini E. The effect of chickpea flour and its addition levels on quality and in vitro starch digestibility of corn-rice-based gluten-free pasta. Int J Food Sci Nutr 2022; 73:600-609. [PMID: 35168444 DOI: 10.1080/09637486.2022.2040008] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/19/2022]
Abstract
Development of gluten-free (GF) pasta with improved nutritional attributes is one of the main trends in the gluten-free pasta industry. Considerable interest lays in introducing legume-based ingredients into traditional corn/rice GF formulations. This work aims to fortify multi-cereal (corn-rice) GF pasta with chickpea to investigate how different chickpea addition levels affect its quality and in vitro starch digestibility. Chickpea significantly increased pasta protein and dietary fibre contents to a level that supports the "source" or "high" fibre/protein content claims. Chickpea addition induced darkening, softening, adhesiveness decrease and solid loss reduction compared to the control. In addition, chickpea substitution significantly modified the in vitro starch digestion, which showed increasing resistant starch and decreasing slowly digestible starch contents suggesting potential mitigation of postprandial glucose response in vivo. Reformulating GF pasta with chickpea flour should, therefore, be considered as an effective tool to improve the corn-rice-based GF products' nutritional profile.
Collapse
Affiliation(s)
- Xinying Suo
- School of Biosciences and Veterinary Medicine, University of Camerino, Camerino, MC, Italy.,School of Food and Bioengineering, Collaborative Innovation Centre of Food Production and Safety, Zhengzhou University of Light Industry, Zhengzhou, China
| | - Margherita Dall'Asta
- Department of Animal Science, Food and Nutrition, Università Cattolica del Sacro Cuore, Piacenza, Italy
| | - Gianluca Giuberti
- Department for Sustainable Food Process, Università Cattolica del Sacro Cuore, Piacenza, Italy
| | | | - Zhangcun Wang
- School of Food and Bioengineering, Collaborative Innovation Centre of Food Production and Safety, Zhengzhou University of Light Industry, Zhengzhou, China
| | - Elena Vittadini
- School of Biosciences and Veterinary Medicine, University of Camerino, Camerino, MC, Italy
| |
Collapse
|
17
|
Chigwedere CM, Wanasundara JPD, Shand PJ. Sensory descriptors for pulses and pulse-derived ingredients: Toward a standardized lexicon and sensory wheel. Compr Rev Food Sci Food Saf 2022; 21:999-1023. [PMID: 35122393 DOI: 10.1111/1541-4337.12893] [Citation(s) in RCA: 15] [Impact Index Per Article: 7.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/21/2021] [Revised: 11/07/2021] [Accepted: 11/10/2021] [Indexed: 02/06/2023]
Abstract
The organoleptic quality of pulses and their derived ingredients is fundamental in human utilization and evolution of food. However, the widespread use of pulses is hindered by their inherent sensorial aspects, which are regarded as atypical by the consumers who are unfamiliar to them. In most studies involving sensory assessment of pulses and pulse-ingredients using classical descriptive analysis methods, assessors establish their own lexica. This review is a synthesis of descriptive terms by which sensations emanating from pea, chickpea, lentil, faba bean, dry bean, bambara groundnut, lupin, pigeon pea and cowpea, and their derived ingredients have been described in the literature. Studies involving sensory assessment of processed whole seeds, slurries of raw flour, slurries of protein extracted from raw flour, and food products containing components of pulses were considered. The terms are categorized into those denoting basic taste, aroma, flavor, and trigeminal sensations. Bitterness is the most widely perceived basic taste. Beany, which is broad and complex with subcharacter notes, is predominantly used to describe aroma and flavor. The frequency of use of the collated terms in the reviewed studies was used to establish a sensory wheel. Inconsistency in the use of descriptive terms in the literature necessitates establishment of a standard lexicon that can be applied in both classical and increasingly popular rapid descriptive methods (e.g., check-all-that-apply) throughout the pulse value chain. This review is timely considering the dominance of pulses in plant-based foods and their increasing appeal to the food industry.
Collapse
Affiliation(s)
- Claire M Chigwedere
- Department of Food and Bioproduct Sciences, College of Agriculture and Bioresources, University of Saskatchewan, Saskatoon, Canada
| | - Janitha P D Wanasundara
- Department of Food and Bioproduct Sciences, College of Agriculture and Bioresources, University of Saskatchewan, Saskatoon, Canada.,Saskatoon Research and Development Centre, Agriculture and Agri-Food Canada, Saskatoon, Canada
| | - Phyllis J Shand
- Department of Food and Bioproduct Sciences, College of Agriculture and Bioresources, University of Saskatchewan, Saskatoon, Canada
| |
Collapse
|
18
|
SCARTON M, CLERICI MTPS. Gluten-free pastas: ingredients and processing for technological and nutritional quality improvement. FOOD SCIENCE AND TECHNOLOGY 2022. [DOI: 10.1590/fst.65622] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/06/2022]
Affiliation(s)
- Michele SCARTON
- Universidade Estadual de Campinas, Brasil; Serviço Nacional de Aprendizagem Industrial, Brasil
| | | |
Collapse
|
19
|
Thakur A, Vaidya D, Kumar S, Kaushal M, Chauhan N. Standardization and characterization of Himalayan wild apricot (geographical indicator) kernel press cake protein isolate and utilization for manufacture of gluten‐free pasta. J FOOD PROCESS PRES 2021. [DOI: 10.1111/jfpp.16271] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/30/2022]
Affiliation(s)
- Abhishek Thakur
- Food Science and Technology Dr YS Parmar University of Horticulture & Forestry Solan HP India
| | - Devina Vaidya
- Food Science and Technology Dr YS Parmar University of Horticulture & Forestry Solan HP India
| | - Satish Kumar
- Food Science and Technology Dr YS Parmar University of Horticulture & Forestry Solan HP India
| | - Manisha Kaushal
- Food Science and Technology Dr YS Parmar University of Horticulture & Forestry Solan HP India
| | - Nilakshi Chauhan
- Food Science and Nutrition Technology College of Community Science CSKHPKV Palampur India
| |
Collapse
|
20
|
Sajid Mushtaq B, Zhang W, Al-Ansi W, Ul Haq F, Rehman A, Omer R, Mahmood Khan I, Niazi S, Ahmad A, Ali Mahdi A, Al-Maqtari QA, Walayat N, Wang L. A Critical Review on the Development, Physicochemical Variations and Technical Concerns of Gluten Free Extrudates in Food Systems. FOOD REVIEWS INTERNATIONAL 2021. [DOI: 10.1080/87559129.2021.1976793] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 10/20/2022]
Affiliation(s)
- Bilal Sajid Mushtaq
- School of Food Science and Technology, State Key Laboratory of Food Science and Technology, National Engineering Research Center for Functional Food, Jiangnan University, Wuxi, China
| | - Wenhui Zhang
- Institute of Food Science, Tibet Academy of Agriculture and Animal Husbandry Sciences, Lhasa, Tibet, China
| | - Waleed Al-Ansi
- School of Food Science and Technology, State Key Laboratory of Food Science and Technology, National Engineering Research Center for Functional Food, Jiangnan University, Wuxi, China
| | - Faizan Ul Haq
- School of Food Science and Technology, State Key Laboratory of Food Science and Technology, National Engineering Research Center for Functional Food, Jiangnan University, Wuxi, China
| | - Abdur Rehman
- School of Food Science and Technology, State Key Laboratory of Food Science and Technology, National Engineering Research Center for Functional Food, Jiangnan University, Wuxi, China
| | - Rabia Omer
- State Key Laboratory of Bioreactor Engineering, East China University of Science and Technology, Shanghai, China
| | - Imran Mahmood Khan
- School of Food Science and Technology, State Key Laboratory of Food Science and Technology, National Engineering Research Center for Functional Food, Jiangnan University, Wuxi, China
| | - Sobia Niazi
- School of Food Science and Technology, State Key Laboratory of Food Science and Technology, National Engineering Research Center for Functional Food, Jiangnan University, Wuxi, China
| | - Aqsa Ahmad
- School of Biotechnology, Jiangnan University, Wuxi, China
| | - Amer Ali Mahdi
- School of Food and Biological Engineering, Jiangsu University, Zhenjiang, China
| | - Qais Ali Al-Maqtari
- School of Food Science and Technology, State Key Laboratory of Food Science and Technology, National Engineering Research Center for Functional Food, Jiangnan University, Wuxi, China
| | - Noman Walayat
- Department of Food Science and Engineering, College of Ocean, Zhejiang University of Technology, Hangzhou, China
| | - Li Wang
- School of Food Science and Technology, State Key Laboratory of Food Science and Technology, National Engineering Research Center for Functional Food, Jiangnan University, Wuxi, China
| |
Collapse
|
21
|
Duijsens D, Gwala S, Pallares AP, Pälchen K, Hendrickx M, Grauwet T. How postharvest variables in the pulse value chain affect nutrient digestibility and bioaccessibility. Compr Rev Food Sci Food Saf 2021; 20:5067-5096. [PMID: 34402573 DOI: 10.1111/1541-4337.12826] [Citation(s) in RCA: 12] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/25/2021] [Revised: 06/22/2021] [Accepted: 07/14/2021] [Indexed: 01/12/2023]
Abstract
Pulses are increasingly being put forward as part of healthy diets because they are rich in protein, (slowly digestible) starch, dietary fiber, minerals, and vitamins. In pulses, nutrients are bioencapsulated by a cell wall, which mostly survives cooking followed by mechanical disintegration (e.g., mastication). In this review, we describe how different steps in the postharvest pulse value chain affect starch and protein digestion and the mineral bioaccessibility of pulses by influencing both their nutritional composition and structural integrity. Processing conditions that influence structural characteristics, and thus potentially the starch and protein digestive properties of (fresh and hard-to-cook [HTC]) pulses, have been reported in literature and are summarized in this review. The effect of thermal treatment on the pulse microstructure seems highly dependent on pulse type-specific cell wall properties and postharvest storage, which requires further investigation. In contrast to starch and protein digestion, the bioaccessibility of minerals is not dependent on the integrity of the pulse (cellular) tissue, but is affected by the presence of mineral antinutrients (chelators). Although pulses have a high overall mineral content, the presence of mineral antinutrients makes them rather poorly accessible for absorption. The negative effect of HTC on mineral bioaccessibility cannot be counteracted by thermal processing. This review also summarizes lessons learned on the use of pulses for the preparation of foods, from the traditional use of raw-milled pulse flours, to purified pulse ingredients (e.g., protein), to more innovative pulse ingredients in which cellular arrangement and bioencapsulation of macronutrients are (partially) preserved.
Collapse
Affiliation(s)
- Dorine Duijsens
- Laboratory of Food Technology, Leuven Food Science and Nutrition Research Centre (LFoRCe), Department of Microbial and Molecular Systems (M2S), KU Leuven, Leuven, Belgium
| | - Shannon Gwala
- Laboratory of Food Technology, Leuven Food Science and Nutrition Research Centre (LFoRCe), Department of Microbial and Molecular Systems (M2S), KU Leuven, Leuven, Belgium
| | - Andrea Pallares Pallares
- Laboratory of Food Technology, Leuven Food Science and Nutrition Research Centre (LFoRCe), Department of Microbial and Molecular Systems (M2S), KU Leuven, Leuven, Belgium
| | - Katharina Pälchen
- Laboratory of Food Technology, Leuven Food Science and Nutrition Research Centre (LFoRCe), Department of Microbial and Molecular Systems (M2S), KU Leuven, Leuven, Belgium
| | - Marc Hendrickx
- Laboratory of Food Technology, Leuven Food Science and Nutrition Research Centre (LFoRCe), Department of Microbial and Molecular Systems (M2S), KU Leuven, Leuven, Belgium
| | - Tara Grauwet
- Laboratory of Food Technology, Leuven Food Science and Nutrition Research Centre (LFoRCe), Department of Microbial and Molecular Systems (M2S), KU Leuven, Leuven, Belgium
| |
Collapse
|
22
|
Costantini M, Summo C, Faccia M, Caponio F, Pasqualone A. Kabuli and Apulian black Chickpea Milling By-Products as Innovative Ingredients to Provide High Levels of Dietary Fibre and Bioactive Compounds in Gluten-Free Fresh Pasta. Molecules 2021; 26:4442. [PMID: 34361595 PMCID: PMC8348039 DOI: 10.3390/molecules26154442] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/28/2021] [Revised: 07/17/2021] [Accepted: 07/21/2021] [Indexed: 11/16/2022] Open
Abstract
Gluten-free (GF) products, including pasta, are often characterised by nutritional deficiencies, such as scarce dietary fibre and excess of calories. Chickpea flour is increasingly being used by the food industries. Hulls, rich in dietary fibre and bioactive compounds, are discarded after milling. The aim of this work was to evaluate the quality features of short-cut GF fresh pasta added of hull (8% w/w) derived from kabuli (KH) or Apulian black (ABH) chickpeas, in comparison with control GF pasta prepared without hull. The enriched pasta, which could be labelled as "high fibre", was characterised by a higher level of bioactive compounds and antioxidant activity than the control. ABH-enriched pasta showed the highest anthocyanins (33.37 ± 1.20 and 20.59 ± 0.11 mg/kg of cyanidin-3-O-glucoside on dry matter in raw and cooked pasta, respectively). Hull addition increased colour intensity and structural quality of GF pasta: ABH-enriched pasta had the lowest cooking loss and the highest water absorption capacity; KH-enriched pasta showed the highest firmness. No significant differences in sensory liking were found among the samples, except for "aftertaste". Chickpea hull can be used as an innovative ingredient to produce potentially functional GF pasta, meeting the dietary needs of consumers without affecting quality.
Collapse
Affiliation(s)
| | | | | | | | - Antonella Pasqualone
- Department of Soil, Plant and Food Science (DISSPA), University of Bari Aldo Moro, Via Amendola 165/A, I-70126 Bari, Italy; (M.C.); (C.S.); (M.F.); (F.C.)
| |
Collapse
|
23
|
Pasta from yellow lentils: How process affects starch features and pasta quality. Food Chem 2021; 364:130387. [PMID: 34233245 DOI: 10.1016/j.foodchem.2021.130387] [Citation(s) in RCA: 10] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/16/2021] [Revised: 06/11/2021] [Accepted: 06/14/2021] [Indexed: 02/08/2023]
Abstract
The effects of conventional extrusion (CV) and extrusion-cooking (EC) were investigated on 100% yellow lentils (YL). Both the extrusion processes led to pasta with good cooking quality (cooking loss: 7.0-7.1 g/100 g, firmness: 530-608 N), even in overcooking (cooking loss: 7.7-7.9 g/100 g, firmness: 418-513 N). Contrary to what is known for gluten-free cereals, CV is effective in producing pasta from native YL with no need for a pre-gelatinization step. However, pasta from EC showed a higher compression energy (2898 versus 2448 N*mm). In this sample, starch presented a higher degree of gelatinization (75.5 versus 57.6 g/100 g) and lower enthalpy (0.97 versus 1.07 J/g). At the same time, EC promoted a more compact structure that required higher temperature for melting (66.49 versus 63.16 °C) and showing pasting properties (79.1 versus 74.7 °C). Thus, by selecting suitable extrusion conditions it is possible to improve the cooking behavior of 100% pulse pasta.
Collapse
|
24
|
Garcia-Valle DE, Bello-Perez LA, Tovar J. Addition of chickpea markedly increases the indigestible carbohydrate content in semolina pasta as eaten. JOURNAL OF THE SCIENCE OF FOOD AND AGRICULTURE 2021; 101:2869-2876. [PMID: 33155278 DOI: 10.1002/jsfa.10918] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/31/2020] [Revised: 10/06/2020] [Accepted: 11/06/2020] [Indexed: 06/11/2023]
Abstract
BACKGROUND There is a growing interest in increasing dietary fiber (DF) consumption because of the health benefits associated with this nutrient. Pulses are considered a good source of non-digestible carbohydrates. The aim of this study was to investigate the possibility of substituting semolina with chickpea flour to increase indigestible carbohydrate content without altering the texture of the pasta. RESULTS Pasta was prepared by extruding semolina-chickpea blends. The protein and DF content in the cooked pasta increased with the chickpea level, with an important contribution of resistant starch (RS) to the DF values. The optimum cooking time decreased as the chickpea content increased, which was related to the degree of starch gelatinization of the raw pasta. The in vitro digestible starch content decreased with the chickpea substitution level, concomitant with the increase in RS content. In general, the texture of the chickpea-containing pasta was similar to that of semolina pasta. CONCLUSIONS Pending acceptability studies on these pastas may grant their promotion as good fiber sources, probably helpful in the fight against obesity and diet-related non-communicable diseases. © 2020 Society of Chemical Industry.
Collapse
Affiliation(s)
| | | | - Juscelino Tovar
- Department of Food Technology Engineering and Nutrition, Lund University, Lund, Sweden
| |
Collapse
|
25
|
In vitro digestibility, cooking quality, bio-functional composition, and sensory properties of pasta incorporated with potato and pigeonpea flour. Int J Gastron Food Sci 2021. [DOI: 10.1016/j.ijgfs.2020.100300] [Citation(s) in RCA: 16] [Impact Index Per Article: 5.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Submit a Manuscript] [Subscribe] [Scholar Register] [Indexed: 12/26/2022]
|
26
|
Boukid F, Rosell CM, Rosene S, Bover-Cid S, Castellari M. Non-animal proteins as cutting-edge ingredients to reformulate animal-free foodstuffs: Present status and future perspectives. Crit Rev Food Sci Nutr 2021; 62:6390-6420. [PMID: 33775185 DOI: 10.1080/10408398.2021.1901649] [Citation(s) in RCA: 38] [Impact Index Per Article: 12.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 02/07/2023]
Abstract
Consumer interest in protein rich diets is increasing, with more attention being paid to the protein source. Despite the occurrence of animal proteins in the human diet, non-animal proteins are gaining popularity around the world due to their health benefits, environmental sustainability, and ethical merit. These sources of protein qualify for vegan, vegetarian, and flexitarian diets. Non-animal proteins are versatile, derived mainly from cereals, vegetables, pulses, algae (seaweed and microalgae), fungi, and bacteria. This review's intent is to analyze the current and future direction of research and innovation in non-animal proteins, and to elucidate the extent (limitations and opportunities) of their applications in food and beverage industries. Prior knowledge provided relevant information on protein features (processing, structure, and techno-functionality) with particular focus on those derived from soy and wheat. In the current food landscape, beyond conventionally used plant sources, other plant proteins are gaining traction as alternative ingredients to formulate animal-free foodstuffs (e.g., meat alternatives, beverages, baked products, snack foods, and others). Microbial proteins derived from fungi and algae are also food ingredients of interest due to their high protein quantity and quality, however there is no commercial food application for bacterial protein yet. In the future, key points to consider are the importance of strain/variety selection, advances in extraction technologies, toxicity assessment, and how this source can be used to create food products for personalized nutrition.
Collapse
Affiliation(s)
- Fatma Boukid
- Institute of Agriculture and Food Research and Technology (IRTA), Food Safety and Functionality Programme, Monells, Catalonia, Spain
| | - Cristina M Rosell
- Institute of Agrochemistry and Food Technology (IATA-CSIC), Paterna, Valencia, Spain
| | - Sara Rosene
- General Mills, Golden Valley, Minnesota, USA
| | - Sara Bover-Cid
- Institute of Agriculture and Food Research and Technology (IRTA), Food Safety and Functionality Programme, Monells, Catalonia, Spain
| | - Massimo Castellari
- Institute of Agriculture and Food Research and Technology (IRTA), Food Safety and Functionality Programme, Monells, Catalonia, Spain
| |
Collapse
|
27
|
Laleg K, Cassan D, Abecassis J, Micard V. Processing a 100% legume pasta in a classical extruder without agglomeration during mixing. J Food Sci 2021; 86:724-729. [PMID: 33533024 PMCID: PMC8248116 DOI: 10.1111/1750-3841.15604] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/15/2020] [Revised: 12/21/2020] [Accepted: 12/23/2020] [Indexed: 12/01/2022]
Abstract
Pasta made exclusively from legume has high nutritional potential (rich in protein and gluten free). However, it is difficult to produce 100% legume dough suitable for the extrusion step in pasta production that comprises hydration, mixing, and extrusion. This paper addresses the biochemical phenomena at the origin of the agglomeration of dough particles frequently reported in the literature, which results in very sticky dough that cannot be extruded. We tested changes in mixing conditions including mixing temperature, addition of antioxidants, and flour pretreatment. Our results suggest that enzymatic reactions, notably lipoxygenase related redox activity, are responsible for this impairment of dough mixing and extrusion. Some of the process conditions studied can be applied at industrial scale and will help produce a legume food with nutritional and culinary qualities, beneficial for people with celiac disease, or gluten intolerance, as well as the general population. PRACTICAL APPLICATION: In the context of a sustainable and healthy food transition, the food industry is developing legume-based food of high nutritional quality that is widely consumed, like pasta. However, using legumes often leads to technological problems during the mixing and extrusion of pasta. This article demonstrates they are linked to enzymatic oxidative phenomena and provides an easy solution to reduce the problems without drastically changing pasta processing. Applied at industrial scale, it will allow the production of naturally gluten-free pasta rich in protein (two to three times the protein content of wheat pasta), of good nutritional quality.
Collapse
Affiliation(s)
- Karima Laleg
- IATE, Univ MontpellierINRAE, Institut AgroMontpellierFrance
| | - Denis Cassan
- IATE, Univ MontpellierINRAE, Institut AgroMontpellierFrance
| | - Joël Abecassis
- IATE, Univ MontpellierINRAE, Institut AgroMontpellierFrance
| | - Valérie Micard
- IATE, Univ MontpellierINRAE, Institut AgroMontpellierFrance
| |
Collapse
|
28
|
Romão B, Falcomer AL, Palos G, Cavalcante S, Botelho RBA, Nakano EY, Raposo A, Shakeel F, Alshehri S, Mahdi WA, Zandonadi RP. Glycemic Index of Gluten-Free Bread and Their Main Ingredients: A Systematic Review and Meta-Analysis. Foods 2021; 10:506. [PMID: 33673401 PMCID: PMC7996770 DOI: 10.3390/foods10030506] [Citation(s) in RCA: 24] [Impact Index Per Article: 8.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/25/2021] [Revised: 02/20/2021] [Accepted: 02/23/2021] [Indexed: 12/18/2022] Open
Abstract
This study aimed to perform a systematic review and meta-analysis of the glycemic index (GI) of gluten-free bread (GFB) and its main ingredients. The systematic review followed PRISMA guidelines, using seven electronic databases (PubMed, EMBASE, Scopus, Science Direct, Web of Science, gray literature research with Google Scholar, and patents with Google Patent tool), from inception to November 2020. Eighteen studies met the inclusion criteria evaluating 132 GFB samples. Five articles tested GI in vivo, eleven in vitro; and two studies tested both methods. The analysis showed that 60.7% (95% CI: 40.2-78.1%) of the samples presented high glycemic indexes, evidencing a high glycemic profile for GFB. Only 18.2% (95% CI: 11.7-27.2%) of the bread samples presented in the studies were classified as a low GI. Meta-analysis presented moderate/low heterogenicity between studies (I2 = 61% and <1% for both high and low GIs) and reinforced the proportion of high GIs. Lower GIs were found in formulations based on Colocasia esculenta flour or enriched with fiber, yogurt and curd cheese, sourdough, psyllium, hydrocolloids, enzymes, fructans, and resistant starch, highlighting the efficacy of these ingredients to lower GFBs' GI. GFB tends to present high GI, impacting the development of chronic diseases when consumed.
Collapse
Affiliation(s)
- Bernardo Romão
- Department of Nutrition, Faculty of Health Sciences, Campus Universitário Darcy Ribeiro, University of Brasilia, Brasilia, DF 70910-900, Brazil; (B.R.); (A.L.F.); (G.P.); (S.C.); (R.B.A.B.)
| | - Ana Luísa Falcomer
- Department of Nutrition, Faculty of Health Sciences, Campus Universitário Darcy Ribeiro, University of Brasilia, Brasilia, DF 70910-900, Brazil; (B.R.); (A.L.F.); (G.P.); (S.C.); (R.B.A.B.)
| | - Gabriela Palos
- Department of Nutrition, Faculty of Health Sciences, Campus Universitário Darcy Ribeiro, University of Brasilia, Brasilia, DF 70910-900, Brazil; (B.R.); (A.L.F.); (G.P.); (S.C.); (R.B.A.B.)
| | - Sandra Cavalcante
- Department of Nutrition, Faculty of Health Sciences, Campus Universitário Darcy Ribeiro, University of Brasilia, Brasilia, DF 70910-900, Brazil; (B.R.); (A.L.F.); (G.P.); (S.C.); (R.B.A.B.)
| | - Raquel Braz Assunção Botelho
- Department of Nutrition, Faculty of Health Sciences, Campus Universitário Darcy Ribeiro, University of Brasilia, Brasilia, DF 70910-900, Brazil; (B.R.); (A.L.F.); (G.P.); (S.C.); (R.B.A.B.)
| | | | - António Raposo
- CBIOS (Research Center for Biosciences and Health Technologies), Universidade Lusófona de Humanidades Tecnologias, Campo Grande 376, 1749-024 Lisboa, Portugal
| | - Faiyaz Shakeel
- Department of Pharmaceutics, College of Pharmacy, King Saud University, Riyadh 11451, Saudi Arabia; (F.S.); (S.A.); (W.A.M.)
| | - Sultan Alshehri
- Department of Pharmaceutics, College of Pharmacy, King Saud University, Riyadh 11451, Saudi Arabia; (F.S.); (S.A.); (W.A.M.)
- Department of Pharmaceutical Sciences, College of Pharmacy, Almaarefa University, Riyadh 11597, Saudi Arabia
| | - Wael A. Mahdi
- Department of Pharmaceutics, College of Pharmacy, King Saud University, Riyadh 11451, Saudi Arabia; (F.S.); (S.A.); (W.A.M.)
| | - Renata Puppin Zandonadi
- Department of Nutrition, Faculty of Health Sciences, Campus Universitário Darcy Ribeiro, University of Brasilia, Brasilia, DF 70910-900, Brazil; (B.R.); (A.L.F.); (G.P.); (S.C.); (R.B.A.B.)
| |
Collapse
|
29
|
Autoclaved and Extruded Legumes as a Source of Bioactive Phytochemicals: A Review. Foods 2021; 10:foods10020379. [PMID: 33572460 PMCID: PMC7919342 DOI: 10.3390/foods10020379] [Citation(s) in RCA: 20] [Impact Index Per Article: 6.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/17/2020] [Revised: 02/02/2021] [Accepted: 02/04/2021] [Indexed: 12/20/2022] Open
Abstract
Legumes have been consumed since ancient times all over the world due to their easy cultivation and availability as a low-cost food. Nowadays, it is well known that pulses are also a good source of bioactive phytochemicals that play an important role in the health and well-being of humans. Pulses are mainly consumed after processing to soften cotyledons and to improve their nutritive and sensorial characteristics. However, processing affects not only their nutritive constituents, but also their bioactive compounds. The final content of phytochemicals depends on the pulse type and variety, the processing method and their parameters (mainly temperature and time), the food matrix structure and the chemical nature of each phytochemical. This review focuses on the changes produced in the bioactive-compound content of pulses processed by a traditional processing method like cooking (with or without pressure) or by an industrial processing technique like extrusion, which is widely used in the food industry to develop new food products with pulse flours as ingredients. In particular, the effect of processing methods on inositol phosphates, galactosides, protease inhibitors and phenolic-compound content is highlighted in order to ascertain their content in processed pulses or pulse-based products as a source of healthy phytochemicals.
Collapse
|
30
|
Dello Russo M, Spagnuolo C, Moccia S, Angelino D, Pellegrini N, Martini D. Nutritional Quality of Pasta Sold on the Italian Market: The Food Labelling of Italian Products (FLIP) Study. Nutrients 2021; 13:nu13010171. [PMID: 33429881 PMCID: PMC7827935 DOI: 10.3390/nu13010171] [Citation(s) in RCA: 16] [Impact Index Per Article: 5.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/28/2020] [Revised: 12/18/2020] [Accepted: 01/04/2021] [Indexed: 12/04/2022] Open
Abstract
Pasta represents a staple food in many populations and, in recent years, an increasing number of pasta items has been placed on the market to satisfy needs and trends. The aims of this work were: (i) to investigate the nutritional composition of the different types of pasta currently sold in Italy by collecting the nutrition facts on their packaging; (ii) to compare energy, nutrient and salt content per 100 g and serving in fresh and dried pasta; (iii) to compare the nutrition declaration in pairs of products with and without different declarations (i.e., gluten free (GF), organic, and nutrition claims (NC)). A total of 756 items, made available by 13 retailers present on the Italian market, were included in the analysis. Data showed a wide difference between dried and fresh pasta, with high inter-type variability. A negligible amount of salt was observed in all types of pasta, except for stuffed products, which had a median high quantity of salt (>1 g/100 g and ~1.5 g/serving). Organic pasta had higher fibre and lower protein contents compared to conventional pasta. GF products were higher in carbohydrate and fat but lower in fibre and protein than not-GF products, while only a higher fibre content was found in pasta with NC compared to products not boasting claims. Overall, the results show high variability in terms of nutrition composition among the pasta items currently on the market, supporting the importance of reading and understanding food labels for making informed food choices.
Collapse
Affiliation(s)
- Marika Dello Russo
- Institute of Food Sciences, National Research Council, 83100 Avellino, Italy; (M.D.R.); (C.S.); (S.M.)
| | - Carmela Spagnuolo
- Institute of Food Sciences, National Research Council, 83100 Avellino, Italy; (M.D.R.); (C.S.); (S.M.)
| | - Stefania Moccia
- Institute of Food Sciences, National Research Council, 83100 Avellino, Italy; (M.D.R.); (C.S.); (S.M.)
| | - Donato Angelino
- Faculty of Bioscience and Technology for Food, Agriculture and Environment, University of Teramo, 64100 Teramo, Italy;
| | - Nicoletta Pellegrini
- Department of Agricultural, Food, Environmental and Animal Sciences, University of Udine, 33100 Udine, Italy
- Correspondence: ; Tel.: +39-043-255-8183
| | - Daniela Martini
- Department of Food, Environmental and Nutritional Sciences (DeFENS), Università degli Studi di Milano, 20133 Milan, Italy;
| | | |
Collapse
|
31
|
Pallares Pallares A, Gwala S, Pälchen K, Duijsens D, Hendrickx M, Grauwet T. Pulse seeds as promising and sustainable source of ingredients with naturally bioencapsulated nutrients: Literature review and outlook. Compr Rev Food Sci Food Saf 2021; 20:1524-1553. [DOI: 10.1111/1541-4337.12692] [Citation(s) in RCA: 12] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/24/2020] [Revised: 10/24/2020] [Accepted: 11/30/2020] [Indexed: 12/23/2022]
Affiliation(s)
- Andrea Pallares Pallares
- Laboratory of Food Technology, Centre for Food and Microbial Technology, Department of Microbial and Molecular Systems (M2S), Faculty of Bioscience Engineering KU Leuven Heverlee Belgium
| | - Shannon Gwala
- Laboratory of Food Technology, Centre for Food and Microbial Technology, Department of Microbial and Molecular Systems (M2S), Faculty of Bioscience Engineering KU Leuven Heverlee Belgium
| | - Katharina Pälchen
- Laboratory of Food Technology, Centre for Food and Microbial Technology, Department of Microbial and Molecular Systems (M2S), Faculty of Bioscience Engineering KU Leuven Heverlee Belgium
| | - Dorine Duijsens
- Laboratory of Food Technology, Centre for Food and Microbial Technology, Department of Microbial and Molecular Systems (M2S), Faculty of Bioscience Engineering KU Leuven Heverlee Belgium
| | - Marc Hendrickx
- Laboratory of Food Technology, Centre for Food and Microbial Technology, Department of Microbial and Molecular Systems (M2S), Faculty of Bioscience Engineering KU Leuven Heverlee Belgium
| | - Tara Grauwet
- Laboratory of Food Technology, Centre for Food and Microbial Technology, Department of Microbial and Molecular Systems (M2S), Faculty of Bioscience Engineering KU Leuven Heverlee Belgium
| |
Collapse
|
32
|
Sharan S, Zanghelini G, Zotzel J, Bonerz D, Aschoff J, Saint-Eve A, Maillard MN. Fava bean (Vicia faba L.) for food applications: From seed to ingredient processing and its effect on functional properties, antinutritional factors, flavor, and color. Compr Rev Food Sci Food Saf 2020; 20:401-428. [PMID: 33331050 DOI: 10.1111/1541-4337.12687] [Citation(s) in RCA: 48] [Impact Index Per Article: 12.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/26/2020] [Revised: 11/03/2020] [Accepted: 11/10/2020] [Indexed: 11/28/2022]
Abstract
The food industry, along with the consumers, is interested in plant-based diet because of its health benefits and environmental sustainability. Vicia faba L. (V. faba) is a promising source of pulse proteins for the human diet and can yield potential nutritional and functional ingredients, namely, flours, concentrates, and isolates, which are relevant for industrial food applications. Different processes produce and functionalize V. faba ingredients relevant for industrial food applications, along with various alternatives within each unit operation used in their production. Processing modifies functional properties of the ingredients, which can occur by (i) changing in overall nutritional composition after processing steps and/or (ii) modifying the structure and conformation of protein and of other components present in the ingredients. Furthermore, V. faba limitations due to off-flavor, color, and antinutritional factors are influenced by ingredient production and processing that play a significant role in their consumer acceptability in foods. This review attempts to elucidate the influence of different ways of processing on the functional, sensory, and safety aspects of V. faba L. ingredients, highlighting the need for further research to better understand how the food industry could improve their utilization in the market.
Collapse
Affiliation(s)
- Siddharth Sharan
- Université Paris-Saclay, INRAE, AgroParisTech, UMR SayFood, Massy, France.,Döhler GmBH, Darmstadt, Germany
| | | | | | | | | | - Anne Saint-Eve
- Université Paris-Saclay, INRAE, AgroParisTech, UMR SayFood, Massy, France
| | | |
Collapse
|
33
|
Binou P, Yanni AE, Karathanos VT. Physical properties, sensory acceptance, postprandial glycemic response, and satiety of cereal based foods enriched with legume flours: a review. Crit Rev Food Sci Nutr 2020; 62:2722-2740. [PMID: 33305591 DOI: 10.1080/10408398.2020.1858020] [Citation(s) in RCA: 15] [Impact Index Per Article: 3.8] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/19/2022]
Abstract
Legumes are rich in proteins and widely consumed around the world. Their consumption has been associated with improved glycemic and lipidemic profile and positive alterations of gut microbiota. These beneficial effects have created a growing scientific interest in the role of legume-enriched foods on the promotion of human health. The aim of this review was to critically record the studies examining the nutritional value and textural properties of these products, as well as their efficacy on lowering postprandial glucose response and satiety. Reviewed data have shown that cereal products with high nutritional value are formulated when fortified with legume flours. The postprandial glucose response appears to be ameliorated and the enriched foods have a medium or a low glycemic index, however not enough data are presented referring to the appetite hormones responses. Textural properties are affected by the addition of legumes and occasionally, when substitution level is high, the final product has not acceptable odor and appearance. To overcome this barrier, particular food processes such as fermentation, extrusion and addition of hydrocolloids, are used and have shown great results on the textural and sensory properties of the final products. The development of healthy legume-enriched cereal-based products is of great importance for the increase of legume consumption and the promotion of public health.
Collapse
Affiliation(s)
- Panagiota Binou
- Laboratory of Chemistry-Biochemistry-Physical Chemistry of Foods, Department of Nutrition and Dietetics, Harokopion University of Athens, Athens, Greece
| | - Amalia E Yanni
- Laboratory of Chemistry-Biochemistry-Physical Chemistry of Foods, Department of Nutrition and Dietetics, Harokopion University of Athens, Athens, Greece
| | - Vaios T Karathanos
- Laboratory of Chemistry-Biochemistry-Physical Chemistry of Foods, Department of Nutrition and Dietetics, Harokopion University of Athens, Athens, Greece
| |
Collapse
|
34
|
Adeleye OO, Awodiran ST, Ajayi AO, Ogunmoyela TF. Influence of extrusion cooking on physicochemical properties and starch digestion kinetics of Sphenostylis stenocarpa, Cajanus cajan, and Vigna subterranean grains. PLoS One 2020; 15:e0242697. [PMID: 33259524 PMCID: PMC7707511 DOI: 10.1371/journal.pone.0242697] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/21/2020] [Accepted: 11/08/2020] [Indexed: 11/18/2022] Open
Abstract
Thermal degradation of sugars and amino acids, and depolymerization of macromolecules such as starch, proteins and fibre occasioned by high-temperature short-time extrusion cooking modify the physicochemical and functional properties of raw materials. High-temperature short-time extrusion cooking holds promise for the expanded use of non-conventional ingredients as food/feed due to its practicality, increased productivity and efficiency, and ability to retain thermally degradable nutrients during cooking. However, little is known about the effect of the high-temperature short-time extrusion cooking process on the physicochemical properties and starch digestibility of lesser-known grain legumes such as African yam beans (Sphenostylis stenocarpa), Pigeon pea (Cajanus cajan), and Bambara peanut (Vigna subterranean). In this study, we investigate the effect of high-temperature short-time extrusion cooking and extrusion cooking temperature; low (100°C) vs high (140°C) temperatures in a single screw extruder, on hydration characteristics, viscoamylolytic properties, in vitro starch digestibility and digestion kinetics of these grain legumes. We show that water holding capacity and swelling power increased (p < 0.05) with increasing extrusion temperature for Sphenostylis stenocarpa and Vigna subterranean but not Cajanus cajan extrudates. Significant effects of extrusion cooking (i.e unextruded vs 100°C and unextruded vs 140°C) and extrusion temperatures (i.e. 100°C vs 140°C) were observed in peak, trough, final and setback viscosities of all extrudates. Starch digestibility and digestion characteristics were modified with increase in extrusion temperature, however, no effect of extrusion temperatures (i.e. 100°C vs 140°C) on starch digestion kinetics was observed for Sphenostylis stenocarpa and Vigna subterranean except for hydrolysis index (34.77 vs 40.77%). Nutritional and physiological implications of extruded grain legumes in monogastric animal feeding were also highlighted. The Information presented herein will influence expanded use of extruded grain legumes as feed ingredients for intensive monogastric animal feeding.
Collapse
Affiliation(s)
- Oluwafunmilayo O. Adeleye
- Agricultural Biochemistry and Nutrition Laboratory, Department of Animal Science, University of Ibadan, Ibadan, Nigeria
| | - Seun T. Awodiran
- Agricultural Biochemistry and Nutrition Laboratory, Department of Animal Science, University of Ibadan, Ibadan, Nigeria
| | - Atinuke O. Ajayi
- Agricultural Biochemistry and Nutrition Laboratory, Department of Animal Science, University of Ibadan, Ibadan, Nigeria
| | - Toluwalope F. Ogunmoyela
- Agricultural Biochemistry and Nutrition Laboratory, Department of Animal Science, University of Ibadan, Ibadan, Nigeria
| |
Collapse
|
35
|
Proserpio C, Bresciani A, Marti A, Pagliarini E. Legume Flour or Bran: Sustainable, Fiber-Rich Ingredients for Extruded Snacks? Foods 2020; 9:E1680. [PMID: 33212867 PMCID: PMC7698416 DOI: 10.3390/foods9111680] [Citation(s) in RCA: 16] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/16/2020] [Revised: 11/13/2020] [Accepted: 11/14/2020] [Indexed: 01/08/2023] Open
Abstract
The impact of using legume flour and bran on both sensory and texture properties in extruded, sustainable snack formulations was investigated. Sensory attributes determining consumer preference or rejection of legume-based snacks, as well as food neophobia and food technology neophobia were also explored. Seven samples of extruded snacks (R = 100% rice flour; C = 100% chickpea flour; P = 100% green pea flour; C30 = 30% chickpea bran and 70% rice flour; C15 = 15% chickpea bran and 85% rice flour; P30 = 30% green pea bran and 70% rice flour; P15 = 15% green pea bran and 85% rice flour) were subjected to the three-point bend method using a TA.XT plus texture analyzer. Seventy-two subjects (42 women; aged = 29.6 ± 9.3 years) evaluated the samples for liking and sensory properties by means of the check-all-that-apply (CATA) method. The sample made with 100% rice flour obtained the lowest liking scores, and it was not considered acceptable by the consumers. Samples P, C, C15, and P15 were the preferred ones. Crumbliness and mild flavor attributes positively influenced hedonic scores, whereas stickiness, dryness, hardness, and to a lesser extent, visual aspect affected them negatively. Neophilic and neutral subjects preferred the snacks compared with the neophobic ones, while no differences in liking scores were found regarding food technology neophobia. Extruded snacks with legume flour and bran were moderately accepted by consumers involved in the present study, albeit to a lesser extent for neophobic subjects, and could represent an interesting sustainable source of fiber and high-value proteins, as well as a valuable alternative to gluten-free foods present on the market.
Collapse
Affiliation(s)
- Cristina Proserpio
- Department of Food, Environmental and Nutritional Sciences (DeFENS), Università degli Studi di Milano, 20133 Milan, Italy; (A.B.); (A.M.); (E.P.)
| | | | | | | |
Collapse
|
36
|
ALBUJA-VACA D, YÉPEZ C, VERNAZA MG, NAVARRETE D. Gluten-free pasta: development of a new formulation based on rice and lupine bean flour (Lupinus Mutabilis) using a mixture-process design. FOOD SCIENCE AND TECHNOLOGY 2020. [DOI: 10.1590/fst.02319] [Citation(s) in RCA: 7] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/21/2022]
|
37
|
Berrazaga I, Bourlieu-Lacanal C, Laleg K, Jardin J, Briard-Bion V, Dupont D, Walrand S, Micard V. Effect of protein aggregation in wheat-legume mixed pasta diets on their in vitro digestion kinetics in comparison to "rapid" and "slow" animal proteins. PLoS One 2020; 15:e0232425. [PMID: 32365065 PMCID: PMC7197814 DOI: 10.1371/journal.pone.0232425] [Citation(s) in RCA: 9] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/07/2020] [Accepted: 04/14/2020] [Indexed: 11/29/2022] Open
Abstract
The aim of this work was to evaluate the impact of incorporating different legume flours (faba bean, lentil or split pea flours) on the pasta protein network and its repercussion on in vitro protein digestibility, in comparison with reference dairy proteins. Kinetics and yields of protein hydrolysis in legume enriched pasta and, for the first time, the peptidomes generated by the pasta at the end of the in vitro gastric and intestinal phases of digestion are presented. Three isoproteic (21%) legume enriched pasta with balanced essential amino acids, were made from wheat semolina and 62% to 79% of legume flours (faba bean or F-pasta; lentil or L-pasta and split pea or P-pasta). Pasta were prepared following the conventional pastification steps (hydration, mixing, extrusion, drying, cooking). Amino acid composition and protein network structure of the pasta were determined along with their culinary and rheological properties and residual trypsin inhibitor activity (3-5% of the activity initially present in raw legume flour). F- and L-pasta had contrasted firmness and proportion of covalently linked proteins. F-pasta had a generally weaker protein network and matrix structure, however far from the weakly linked soluble milk proteins (SMP) and casein proteins, which in addition contained no antitrypsin inhibitors and more theoretical cleavage sites for digestive enzymes. The differences in protein network reticulation between the different pasta and between pasta and dairy proteins were in agreement in each kinetic phase with the yield of the in vitro protein hydrolysis, which reached 84% for SMP, and 66% for casein at the end of intestinal phase, versus 50% for L- and P-pasta and 58% for F-pasta. The peptidome of legume enriched pasta is described for the first time and compared with the peptidome of dairy proteins for each phase of digestion. The gastric and intestinal phases were important stages of peptide differentiation between legumes and wheat. However, peptidome analysis revealed no difference in wheat-derived peptides in the three pasta diets regardless of the digestion phase, indicating that there was a low covalent interaction between wheat gluten and legume proteins.
Collapse
Affiliation(s)
- Insaf Berrazaga
- IATE Agropolymers Engineering and Emerging Technologies, Université Montpellier, CIRAD INRA, Montpellier SupAgro, Montpellier, France
- UNH, Unité de Nutrition Humaine, CRNH, Université Clermont Auvergne, INRA, Auvergne, Clermont-Ferrand, France
| | - Claire Bourlieu-Lacanal
- IATE Agropolymers Engineering and Emerging Technologies, Université Montpellier, CIRAD INRA, Montpellier SupAgro, Montpellier, France
| | - Karima Laleg
- IATE Agropolymers Engineering and Emerging Technologies, Université Montpellier, CIRAD INRA, Montpellier SupAgro, Montpellier, France
- UNH, Unité de Nutrition Humaine, CRNH, Université Clermont Auvergne, INRA, Auvergne, Clermont-Ferrand, France
| | - Julien Jardin
- UMR 1253 STLO Science et Technologie du Lait et de l'Œuf, Agrocampus Ouest, INRA, Rennes, France
| | - Valérie Briard-Bion
- UMR 1253 STLO Science et Technologie du Lait et de l'Œuf, Agrocampus Ouest, INRA, Rennes, France
| | - Didier Dupont
- UMR 1253 STLO Science et Technologie du Lait et de l'Œuf, Agrocampus Ouest, INRA, Rennes, France
| | - Stéphane Walrand
- UNH, Unité de Nutrition Humaine, CRNH, Université Clermont Auvergne, INRA, Auvergne, Clermont-Ferrand, France
- Service de Nutrition Clinique, Centre Hospitalier Universitaire (CHU) Gabriel Montpied, Clermont-Ferrand, France
| | - Valérie Micard
- IATE Agropolymers Engineering and Emerging Technologies, Université Montpellier, CIRAD INRA, Montpellier SupAgro, Montpellier, France
| |
Collapse
|
38
|
Arribas C, Cabellos B, Cuadrado C, Guillamón E, Pedrosa MM. Cooking Effect on the Bioactive Compounds, Texture, and Color Properties of Cold-Extruded Rice/Bean-Based Pasta Supplemented with Whole Carob Fruit. Foods 2020; 9:E415. [PMID: 32252323 PMCID: PMC7230172 DOI: 10.3390/foods9040415] [Citation(s) in RCA: 16] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/03/2020] [Revised: 03/26/2020] [Accepted: 03/30/2020] [Indexed: 02/07/2023] Open
Abstract
Pasta is considered as the ideal vehicle for fortification; thus, different formulations of gluten-free pasta have been developed (rice 0-100%, bean 0-100%, and carob fruit 0% or 10%). In this article, the content of individual inositol phosphates, soluble sugars and α-galactosides, protease inhibitors, lectin, phenolic composition, color, and texture were determined in uncooked and cooked pasta. The highest total inositol phosphates and protease inhibitors contents were found in the samples with a higher bean percentage. After cooking, the content of total inositol phosphates ranged from 2.12 to 7.97 mg/g (phytic acid or inositol hexaphosphate (IP6) was the major isoform found); the protease inhibitor activities showed values up to 12.12 trypsin inhibitor (TIU)/mg and 16.62 chymotrypsin inhibitor (CIU)/mg, whereas the competitive enzyme-linked immunosorbent assay (ELISA) showed the elimination of lectins. Considering the different α-galactosides analyzed, their content was reduced up to 70% (p < 0.05) by the cooking process. The total phenols content was reduced around 17-48% after cooking. The cooked samples fortified with 10% carob fruit resulted in darker fettuccine with good firmness and hardness and higher antioxidant activity, sucrose, and total phenols content than the corresponding counterparts without this flour. All of the experimental fettuccine can be considered as functional and healthy pasta mainly due to their bioactive compound content, compared to the commercial rice pasta.
Collapse
Affiliation(s)
- Claudia Arribas
- Food Technology Department, SGIT-INIA, Ctra de La Coruña, Km 7.5, 28040 Madrid, Spain; (C.A.); (B.C.); (C.C.)
| | - Blanca Cabellos
- Food Technology Department, SGIT-INIA, Ctra de La Coruña, Km 7.5, 28040 Madrid, Spain; (C.A.); (B.C.); (C.C.)
| | - Carmen Cuadrado
- Food Technology Department, SGIT-INIA, Ctra de La Coruña, Km 7.5, 28040 Madrid, Spain; (C.A.); (B.C.); (C.C.)
| | - Eva Guillamón
- Centre for the Food Quality, SGIT-INIA, C/Universidad s/n, 42004 Soria, Spain;
| | - Mercedes M. Pedrosa
- Food Technology Department, SGIT-INIA, Ctra de La Coruña, Km 7.5, 28040 Madrid, Spain; (C.A.); (B.C.); (C.C.)
| |
Collapse
|
39
|
Michalak-Majewska M, Teterycz D, Muszyński S, Radzki W, Sykut-Domańska E. Influence of onion skin powder on nutritional and quality attributes of wheat pasta. PLoS One 2020; 15:e0227942. [PMID: 31986166 PMCID: PMC6984720 DOI: 10.1371/journal.pone.0227942] [Citation(s) in RCA: 22] [Impact Index Per Article: 5.5] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/05/2019] [Accepted: 12/16/2019] [Indexed: 11/19/2022] Open
Abstract
Onion skin is a waste produced during onion bulb processing. Recent studies have reported that it contains large amounts of bioaccessible and bioavailable compounds thus it can be used to design of novel food products. The objective of the study was an attempt to substitute semolina with onion skin (OS) powder in pasta at 2.5, 5 and 7.5 g/100 g levels. The effects on the chemical composition, antioxidant potential, technological and sensory properties of the fortified pasta samples were evaluated compared with a control sample. Fortification with OS resulted in a significant (P < 0.05) improvement in nutritional properties, which was demonstrated by an increase in the content of dietary fibre, ash, total phenolic compounds, flavonoids content and antioxidant activity (FRAP and DPPH). Cooking loss increased with increasing levels of OS, however, all pasta samples were in the acceptable range (8 g/100 g). Onion skin incorporation decreased optimal cooking time, water solubility index and increase redness (a*), compared to the control sample. Results of sensory evaluation suggest that pasta, in which 2.5% of the flour was replaced by this plant component, showed the highest value of the “overall quality”. Our study indicates that onion skin powder can be a potential alternative for the food industry to provide nutritional enriched pasta.
Collapse
Affiliation(s)
- Monika Michalak-Majewska
- Department of Plant Food Technology and Gastronomy, Department of Fruits, Vegetables and Mushrooms Technology, University of Life Sciences in Lublin, Lublin, Poland
- * E-mail:
| | - Dorota Teterycz
- Division of Engineering and Cereals Technology, Department of Plant Food Technology and Gastronomy, University of Life Sciences in Lublin, Lublin, Poland
| | - Siemowit Muszyński
- Department of Biophysics, University of Life Sciences in Lublin, Lublin, Poland
| | - Wojciech Radzki
- Department of Plant Food Technology and Gastronomy, Department of Fruits, Vegetables and Mushrooms Technology, University of Life Sciences in Lublin, Lublin, Poland
| | - Emilia Sykut-Domańska
- Division of Engineering and Cereals Technology, Department of Plant Food Technology and Gastronomy, University of Life Sciences in Lublin, Lublin, Poland
| |
Collapse
|
40
|
Llavata B, Albors A, Martin-Esparza ME. High Fibre Gluten-Free Fresh Pasta with Tiger Nut, Chickpea and Fenugreek: Technofunctional, Sensory and Nutritional Properties. Foods 2019; 9:foods9010011. [PMID: 31877757 PMCID: PMC7022698 DOI: 10.3390/foods9010011] [Citation(s) in RCA: 12] [Impact Index Per Article: 2.4] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/06/2019] [Revised: 12/16/2019] [Accepted: 12/19/2019] [Indexed: 11/16/2022] Open
Abstract
Gluten-free pasta production with a low glycaemic index and improved nutritional profile is still a challenge for the food industry. In this study, pasta was produced from fenugreek (FF), chickpea (CPF) and tiger nut (TNF) flours. CPF and FF are interesting for a balanced contribution of soluble and insoluble fibre by combining the health benefits of each type of fibre that promotes health. TNF, also rich in insoluble fibre, can provide additional healthy properties. The partial substitution of TNF for FF (0, 2.5, 5, 7.5 and 10% w/w solids) was assessed, and the relation linking chemical composition, structure, cooking and rheological properties and predictive in-vitro starch digestion (eGI, expected glycaemic index) was analysed. The results revealed that FF, rich in galactomannans, not only improves the nutritional profile and lowers the eGI but also helps to naturally enhance the structure of the pasta product and, thus, cooking behaviour (higher swelling index and fewer cooking losses).
Collapse
|
41
|
Nilusha RAT, Jayasinghe JMJK, Perera ODAN, Perera PIP. Development of Pasta Products with Nonconventional Ingredients and Their Effect on Selected Quality Characteristics: A Brief Overview. INTERNATIONAL JOURNAL OF FOOD SCIENCE 2019; 2019:6750726. [PMID: 31886166 PMCID: PMC6925700 DOI: 10.1155/2019/6750726] [Citation(s) in RCA: 30] [Impact Index Per Article: 6.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 05/30/2019] [Revised: 09/20/2019] [Accepted: 10/08/2019] [Indexed: 11/18/2022]
Abstract
Pasta is a widely consumed food in all over the world. Coarse semolina obtained from durum wheat and water are the main ingredients of conventional pasta products. The amount of gluten and quality level of durum wheat, are two important factors for the superiority of finished pasta. Market price of durum wheat is higher than the common wheat and it contributes no more than 5% of the world wheat production. Thus, to come across the challenge of emerging pasta consumption, new field of research that is dealing with the incorporation of nonconventional ingredients to the conventional formula of pasta has initiated. The compositions of raw materials which are used for pasta preparation directly affect the physical, chemical, and textural properties of the product. Therefore, incorporation of nonconventional ingredients can lead to a contradictory effect of pasta quality. This review will focus on the various types of nonconventional ingredients that are being incorporated in pasta products and their effect on the quality attributes of different pasta products.
Collapse
Affiliation(s)
- R. A. T. Nilusha
- Department of Food Science and Technology, Faculty of Applied Sciences, University of Sri Jayewardenepura, Gangodawila, Nugegoda, Sri Lanka
| | - J. M. J. K. Jayasinghe
- Department of Food Science and Technology, Faculty of Applied Sciences, University of Sri Jayewardenepura, Gangodawila, Nugegoda, Sri Lanka
| | - O. D. A. N. Perera
- Department of Food Science and Technology, Faculty of Livestock, Fisheries and Nutrition, Wayamba University of Sri Lanka, Makandura, Gonawila, Sri Lanka
| | - P. I. P. Perera
- Department of Horticulture and Landscape Gardening, Faculty of Agriculture and Plantation Management, Wayamba University of Sri Lanka, Makandura, Gonawila, Sri Lanka
| |
Collapse
|
42
|
Effects of Transglutaminase on the Protein Network and In Vitro Starch Digestibility of Asian Wheat Noodles. Foods 2019; 8:foods8120607. [PMID: 31766681 PMCID: PMC6963939 DOI: 10.3390/foods8120607] [Citation(s) in RCA: 11] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/24/2019] [Revised: 11/19/2019] [Accepted: 11/20/2019] [Indexed: 11/17/2022] Open
Abstract
Wheat noodles are a staple commonly consumed in Asia, but high intakes have been associated with type 2 diabetes due to its rapid starch digestibility. We hypothesised that protein network-binding via transglutaminase (TG) would form a stronger barrier encapsulating the starch granules to limit enzymatic access and digestion. The amount of glucose release decreased significantly with increasing TG concentration, with a reduction of approximately 16% with 2% TG after 120 min of digestion. The slower rate of glucose release during the first 60 min of digestion for 2% compared to 0% TG suggested impeded first stage enzymatic access rather than second stage starch hydrolysis into glucose. Upon increasing the TG concentration, confocal microscopy revealed a denser protein network with increased connectivity, supported by a decrease in protein solubility and gelatinisation enthalpy, and increased firmness and work of shear. Therefore, transglutaminase can potentially be used to reduce starch digestibility in wheat noodles via protein network-binding.
Collapse
|
43
|
Özdoğan A, Gunes R, Palabiyik I. Investigating release kinetics of phenolics from defatted wheat germ incorporated chewing gums. JOURNAL OF THE SCIENCE OF FOOD AND AGRICULTURE 2019; 99:6333-6341. [PMID: 31268169 DOI: 10.1002/jsfa.9910] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/02/2019] [Revised: 06/28/2019] [Accepted: 06/28/2019] [Indexed: 06/09/2023]
Abstract
BACKGROUND Wheat germ (WG) is a valuable by-product of the commercial milling industry and is used as a functional ingredient in various foods. Therefore, in this study, it is aimed to utilize defatted wheat germ (DWG) (1%, 3%, 5%, 10%) in chewing gum formulation, which is a different food matrix besides the conventional structures, and investigate the release kinetics of phenolics from DWG incorporated chewing gums with a new centrifugation method. RESULTS According to the results, it was observed that DWG was a good source of total phenolics (2254.15 mg GAE kg-1 ). Based on the results obtained from texture profile and sensory analyses, DWG addition did not cause any reverse effect on the chewing gum texture. Centrifugation method was used to indirectly simulate the physical effects of the chewing process. In particular, after 5 min of chewing and centrifugation, phenolic release levels were 59.07% and 59.41%, respectively. The model used in the previous studies showed a better correlation than Korsmeyer-Peppas model for ABTS (2,2'-azino-bis-(3-ethylbenzothiazoline-6-sulphonic acid), CUPRAC (cupric ion reducing antioxidant capacity), and DPPH (2,2-diphenyl-1-picrylhydrazyl) assay results. CONCLUSION The results showed that phenolics release from gum base polymer matrix might be dominated by erosion of matrix due to chewing action. Similar phenolic release kinetics were obtained by centrifugation and chewing methods. Therefore, centrifuge equipment can be used to simulate the chewing forces acting on the gum when optimization is performed. © 2019 Society of Chemical Industry.
Collapse
Affiliation(s)
- Ayşe Özdoğan
- Department of Food Engineering, Namık Kemal University, Tekirdağ, Turkey
| | - Recep Gunes
- Department of Food Engineering, Kırklareli University, Kırklareli, Turkey
| | - Ibrahim Palabiyik
- Department of Food Engineering, Namık Kemal University, Tekirdağ, Turkey
| |
Collapse
|
44
|
Physical and sensory characterisation of noodles with added native and denatured pea protein isolate. Food Chem 2019; 294:152-159. [DOI: 10.1016/j.foodchem.2019.05.042] [Citation(s) in RCA: 27] [Impact Index Per Article: 5.4] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/14/2019] [Revised: 03/26/2019] [Accepted: 05/07/2019] [Indexed: 11/22/2022]
|
45
|
Proximate composition and anti-nutritional factors of fava-bean (Vicia faba), green-pea and yellow-pea (Pisum sativum) flour. J Food Compost Anal 2019. [DOI: 10.1016/j.jfca.2019.103233] [Citation(s) in RCA: 57] [Impact Index Per Article: 11.4] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/19/2022]
|
46
|
Berrazaga I, Micard V, Gueugneau M, Walrand S. The Role of the Anabolic Properties of Plant- versus Animal-Based Protein Sources in Supporting Muscle Mass Maintenance: A Critical Review. Nutrients 2019; 11:E1825. [PMID: 31394788 PMCID: PMC6723444 DOI: 10.3390/nu11081825] [Citation(s) in RCA: 185] [Impact Index Per Article: 37.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/17/2019] [Revised: 08/02/2019] [Accepted: 08/05/2019] [Indexed: 02/06/2023] Open
Abstract
Plant-sourced proteins offer environmental and health benefits, and research increasingly includes them in study formulas. However, plant-based proteins have less of an anabolic effect than animal proteins due to their lower digestibility, lower essential amino acid content (especially leucine), and deficiency in other essential amino acids, such as sulfur amino acids or lysine. Thus, plant amino acids are directed toward oxidation rather than used for muscle protein synthesis. In this review, we evaluate the ability of plant- versus animal-based proteins to help maintain skeletal muscle mass in healthy and especially older people and examine different nutritional strategies for improving the anabolic properties of plant-based proteins. Among these strategies, increasing protein intake has led to a positive acute postprandial muscle protein synthesis response and even positive long-term improvement in lean mass. Increasing the quality of protein intake by improving amino acid composition could also compensate for the lower anabolic potential of plant-based proteins. We evaluated and discussed four nutritional strategies for improving the amino acid composition of plant-based proteins: fortifying plant-based proteins with specific essential amino acids, selective breeding, blending several plant protein sources, and blending plant with animal-based protein sources. These nutritional approaches need to be profoundly examined in older individuals in order to optimize protein intake for this population who require a high-quality food protein intake to mitigate age-related muscle loss.
Collapse
Affiliation(s)
- Insaf Berrazaga
- UNH, Unité de Nutrition Humaine, CRNH, Université Clermont Auvergne, INRA, Auvergne, 63000 Clermont-Ferrand, France
- IATE Agropolymer Engineering and Emerging Technologies, Univ. Montpellier, INRA, CIRAD, Montpellier SupAgro, 34060 Montpellier, France
| | - Valérie Micard
- IATE Agropolymer Engineering and Emerging Technologies, Univ. Montpellier, INRA, CIRAD, Montpellier SupAgro, 34060 Montpellier, France
| | - Marine Gueugneau
- UNH, Unité de Nutrition Humaine, CRNH, Université Clermont Auvergne, INRA, Auvergne, 63000 Clermont-Ferrand, France
| | - Stéphane Walrand
- UNH, Unité de Nutrition Humaine, CRNH, Université Clermont Auvergne, INRA, Auvergne, 63000 Clermont-Ferrand, France.
- Service de Nutrition Clinique, Centre Hospitalier Universitaire (CHU) Gabriel Montpied, 63000 Clermont-Ferrand, France.
| |
Collapse
|
47
|
Trevisan S, Pasini G, Simonato B. An overview of expected glycaemic response of one ingredient commercial gluten free pasta. Lebensm Wiss Technol 2019. [DOI: 10.1016/j.lwt.2019.04.013] [Citation(s) in RCA: 11] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/25/2022]
|
48
|
Rachman A, Brennan MA, Morton J, Brennan CS. Effect of cassava and banana flours blend on physico‐chemical and glycemic characteristics of gluten‐free pasta. J FOOD PROCESS PRES 2019. [DOI: 10.1111/jfpp.14084] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/19/2022]
Affiliation(s)
- Adetiya Rachman
- Department of Wine, Food and Molecular Biosciences Lincoln University Christchurch New Zealand
- Indonesia Institute for Agricultural Research and Development Jakarta Indonesia
- Riddet Institute Palmerston North New Zealand
| | - Margaret A. Brennan
- Department of Wine, Food and Molecular Biosciences Lincoln University Christchurch New Zealand
| | - James Morton
- Department of Wine, Food and Molecular Biosciences Lincoln University Christchurch New Zealand
| | - Charles S. Brennan
- Department of Wine, Food and Molecular Biosciences Lincoln University Christchurch New Zealand
- Riddet Institute Palmerston North New Zealand
| |
Collapse
|
49
|
Chigwedere CM, Njoroge DM, Van Loey AM, Hendrickx ME. Understanding the Relations Among the Storage, Soaking, and Cooking Behavior of Pulses: A Scientific Basis for Innovations in Sustainable Foods for the Future. Compr Rev Food Sci Food Saf 2019; 18:1135-1165. [PMID: 33337000 DOI: 10.1111/1541-4337.12461] [Citation(s) in RCA: 28] [Impact Index Per Article: 5.6] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/07/2019] [Revised: 05/09/2019] [Accepted: 05/10/2019] [Indexed: 12/18/2022]
Abstract
The world faces challenges that require sustainable solutions: food and nutrition insecurity; replacement of animal-based protein sources; and increasing demand for convenient, nutritious, and health-beneficial foods; as well as functional ingredients. The irrefutable potential of pulses as future sustainable food systems is undermined by the hardening phenomenon that develops upon their storage under adverse conditions of temperature and relative humidity. Occurrence of this phenomenon indicates storage instability. In this review, the application of a material science approach, in particular the glass transition temperature concept, is presented to explain phenomena of storage instability such as the occurrence of hardening and loss of viability under adverse storage conditions. In addition to storage (in)stability, application of this concept during processing of pulses is discussed. The state-of-the-art on how hardening occurs, that is, mechanistic insights, is provided, including a critical evaluation of some of the existing postulations using recent research findings. Moreover, the influence of hardening on the properties and processing of pulses is included. Prevention of hardening and curative actions for pulses affected by the hardening phenomenon are described in addition to the current trends on uses of pulses and pulse-derived products. Based on the knowledge progress presented in this review, suggestions for the future include: first, the need for innovation toward implementation of recommended solutions for the prevention of hardening; second, the optimization of the identified most effective and efficient curative action against hardening; and third, areas to focus on for elucidation of mechanisms of hardening, although existing analytical methods require advancement.
Collapse
Affiliation(s)
- Claire M Chigwedere
- Laboratory of Food Technology, Dept. of Microbial and Molecular Systems (M2S), Leuven Food Science and Nutrition Research Center (LFoRCe), KU Leuven, Kasteelpark Arenberg 22, Box 2457, 3001, Heverlee, Belgium
| | - Daniel M Njoroge
- Inst. of Food Bioresources Technology, Dedan Kimathi Univ. of Technology, Private Bag, Dedan Kimathi, Nyeri, Kenya
| | - Ann M Van Loey
- Laboratory of Food Technology, Dept. of Microbial and Molecular Systems (M2S), Leuven Food Science and Nutrition Research Center (LFoRCe), KU Leuven, Kasteelpark Arenberg 22, Box 2457, 3001, Heverlee, Belgium
| | - Marc E Hendrickx
- Laboratory of Food Technology, Dept. of Microbial and Molecular Systems (M2S), Leuven Food Science and Nutrition Research Center (LFoRCe), KU Leuven, Kasteelpark Arenberg 22, Box 2457, 3001, Heverlee, Belgium
| |
Collapse
|
50
|
Joye I. Protein Digestibility of Cereal Products. Foods 2019; 8:E199. [PMID: 31181787 PMCID: PMC6617089 DOI: 10.3390/foods8060199] [Citation(s) in RCA: 137] [Impact Index Per Article: 27.4] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/05/2019] [Revised: 06/01/2019] [Accepted: 06/03/2019] [Indexed: 12/26/2022] Open
Abstract
Protein digestibility is currently a hot research topic and is of big interest to the food industry. Different scoring methods have been developed to describe protein quality. Cereal protein scores are typically low due to a suboptimal amino acid profile and low protein digestibility. Protein digestibility is a result of both external and internal factors. Examples of external factors are physical inaccessibility due to entrapment in e.g., intact cell structures and the presence of antinutritional factors. The main internal factors are the amino acid sequence of the proteins and protein folding and crosslinking. Processing of food is generally designed to increase the overall digestibility through affecting these external and internal factors. However, with proteins, processing may eventually also lead to a decrease in digestibility. In this review, protein digestion and digestibility are discussed with emphasis on the proteins of (pseudo)cereals.
Collapse
Affiliation(s)
- Iris Joye
- Department of Food Science, University of Guelph, Guelph, ON N1G 2W1, Canada.
| |
Collapse
|