Growth performance and feed conversion efficiency of three edible mealworm species (Coleoptera: Tenebrionidae) on diets composed of organic by-products

Utilising common bean and strawberry vegetative wastes in yellow mealworm (Tenebrio molitor) substrates: effects of pre-treatment on growth and composition

Integrating plant production with insect farming, termed "entomoponics," involves using plant waste as a substrate for insect rearing, while returning insect frass to fertilise the plants. In this study, vegetative wastes from strawberry (Fragaria x ananassa), and common bean (Phaseolus vulgaris), were incorporated into a wheat bran-based substrate for rearing the yellow mealworms (MW; Tenebrio molitor). The wastes were either autoclaved or autoclaved then fermented with the fungus Trichoderma reesei, and mixed in a 50:50 ratio with wheat bran. Replacing 50% of the wheat bran with autoclaved beans waste did not significantly affect MW yield, but the yield was reduced when beans wastes were fermented or left untreated. Incorporating beans waste, whether treated or untreated, increased the Ca, K, and Fe content in the MW. Incorporating strawberry vegetative waste into the substrate compensated the yield regardless of the pre-treatment, but enhanced Mn, Zn, and Fe levels in the produced MW. Plant flavonoids were reduced when the wastes were pre-treated and did not accumulate in the MW biomass. These findings provide insights into using plant vegetative wastes as a partial supplement in MW rearing substrates, and the potential effects on the growth and nutritional composition of the resulting MW biomass.

Could insects be an alternative food source? A comprehensive review

According to the United Nations, more than 800 million people are exposed to starvation. It is predicted that the world population will face much more serious starvation for reasons such as global warming, diseases, economic problems, rapid urbanization, and destruction of agricultural areas and water resources. Thus, there are significant hesitations about the sustainability of food resources, and the search for alternative food sources has increased. One of the leading alternative food sources is insects. Although the use of edible insects has been accepted in some areas of the world, entomophagy is not preferred in some countries due to sociocultural conditions, health concerns, neophobia, and entomophobia. Many people do not accept the direct consumption of raw insects, but insects can be transformed into more preferred forms by using different cooking techniques. Some ground edible insects are satisfactory in terms of nutritional value and have a reasonable level of acceptability when added to products such as bread, tortilla, and pasta in varying percentages. The world market value of edible insects was estimated to be US$3.2 million in 2021 and US$17.6 billion in 2032. In this review, the current and future situation of insects as an alternative food source is comprehensively discussed.

Metabolic Performance of Mealworms and Black Soldier Fly Larvae Reared on Food and Agricultural Waste and By-Products

Mealworms and black soldier fly (BSF) larvae are two of the most reared insects at an industrial scale. Both may feed on by-products from agricultural and food industries. Feed efficiency is one of the most important aspects of such processes and varies between species and feed substrates and depends on the metabolic performance of the larvae. Compared to each other, both species may hold advantageous capabilities affecting their feed efficiency, likely depending on the feed substrate. We reared mealworms and BSF larvae on a diverse selection of by-products from agricultural and food industries, quantified major metabolic rates across their life spans, and compared their performances. The type of feed substrates had stronger effects on the growth of mealworms than on black soldier fly larvae. Generally, BSF larvae were advantageous in terms of the highest maximal specific growth rate (0.50-0.77 day-1) and feed assimilation rate (0.81-1.16 day-1) and shortest development period (23-25 days) but disadvantageous in terms of metabolic maintenance cost (0.07-0.21 day-1). In mealworms, the maximal specific growth rates were 0.02-0.11 day-1, the highest feed assimilation rates were 0.16-0.37 day-1, and the development period was at least 65-93 days, while maintenance was only 0.02-0.05 day-1. In contrast to the BSF larvae, the specific maintenance rate was weight dependent in the mealworms and lowest in the largest individuals. The combined outcome of these metabolic rates resulted in an average carbon net growth efficiency, NGE*avg of 0.16-0.40 in mealworms and 0.33-0.56 in BSF larvae across their life span. It thus seems that BSF larvae are more versatile and somewhat more efficient at converting diverse feed substrates into growth than mealworms. Differences in NGE*avg affected the substrate conversion efficiencies (i.e., the ratio of the weight gain of the larvae to the reduced weight of feed substrates) and may thus impact the overall outcome of insect farming.

Advancing Food Security with Farmed Edible Insects: Economic, Social, and Environmental Aspects

Farmed edible insects are considered a potential resource to help address food security concerns toward the year 2050. The sustainability (e.g., lower environmental impact), nutritional (e.g., high-quality proteins, essential amino acids, fiber, unsaturated fats, vitamins, and minerals) and health (e.g., antioxidant, antihypertensive, anti-inflammatory, antimicrobial, and immunomodulatory) benefits are the main reasons for the rise in interest for insects as alternative protein sources for food and feed production. Thus, edible insects can address the future global protein demand of an ever-increasing world population. In this context, several aspects related to their sustainability have been explored and addressed from an environmental perspective. This review describes the rationale for using insects as alternative protein sources and provides a comprehensive viewpoint, integrating economic, environmental, and social aspects into their sustainability framework toward addressing food insecurity concerns. For example, edible insects offer a more sustainable protein source comparable to, or even better than, that of conventional livestock. Considering their sustainability advantages, insects are noted for their lower impact on natural resources (e.g., water and agrarian land) and lower greenhouse gas emissions (e.g., carbon dioxide and methane). From a socioeconomic point of view, edible insects have lower production costs compared to conventional animal protein sources because of their high feed efficiency conversion, rapid growth rate, and short life cycles. Currently, the market for edible, farmed insects is becoming a significant economic activity that not only meets the needs of industry and consumers but also supports the ability of future generations to maintain a secure and sustainable community.

Beyond balance: the impact of adult sex ratios on reproduction and longevity in Zophobas morio rearing

Over the years, the study of adult sex ratio is a topic that has gained attention for its impact on reproductive outcomes and aging across various insect species. However, there is still limited research focused on insects reared for food and feed production. To address this gap, this study aimed to evaluate the impact of different adult sex ratios on the reproductive dynamics and longevity of the superworm, Zophobas morio (F.) (Coleoptera: Tenebrionidae), a species with interesting potential as a nutrient source. In this study, we assessed three adult sex ratios, i.e., 5:5, 6:4 and 8:2 (female:male) with mesh used to each setup. An additional 5:5 sex ratio without mesh served as control. On a weekly basis, adult survival, egg production, and egg hatching rates were recorded. Our results revealed statistically significant differences in egg production across the different sex ratios tested, but no statistically significant differences in hatching rates and adult survival. These findings suggest that both balanced and female-biased sex ratios are suitable for Z. morio and that it is important to consider this factor when enhancing efficiency in large-scale insect production.

Rearing mealworm larvae with wheat, barley or maize grains as main source of nutrients in unbalanced or balanced substrates

Feeding conditions of mealworm (T. molitor) larvae for livestock nutrition need to be optimised. The effects of the cereal offered as main nutrient source on growth performance and composition of T. molitor larvae were evaluated. In Experiment 1 (unbalanced diets), substrates included 80% of wheat (W1), barley (B1) or maize (M1) and 20% wheat straw. In Experiment 2 (balanced diets), substrates were formulated using wheat (W2), barley (B2) or maize (M2) as the main ingredient, combined with wheat bran or straw to contain similar N, starch and NDF contents (19.5, 520, and 270 g/kg DM, respectively). A control substrate based solely on wheat bran was also included in each experiment (C1 and C2). Each treatment was replicated four times in trays containing 24 g of substrate and 60 larvae, and the experimental period lasted for 28 (Experiment 1) or 35 (Experiment 2) days. Larval weight and residual substrate were monitored weekly, and larval chemical composition was analysed at the end of each experiment. In Experiment 1, feed intake was greatest for B1 and W1, intermediate for C1 and lowest for M1 (P < 0.001). However, larval growth was greater for C1 than for B1 and W1, with the lowest rates observed for M1 (P < 0.001). Consequently, the feed to gain (F:G) ratio was lowest for C1 and highest for M1 (P < 0.001). Mortality was also greatest for M1 (P < 0.001). In Experiment 2, feed intake (P < 0.001) and larval growth (P < 0.01) decreased in M2 compared to B2 and W2, which in turn showed similar growth performance to C2 (P < 0.001). Larval composition followed a similar trend in both experiments, with the highest N content observed in larvae fed C1 and C2 (P < 0.001), while DM and ether extract contents were higher in larvae reared on barley (P < 0.001). In summary, maize-based substrates may compromise feed intake and growth performance of T. molitor larvae compared to those based on wheat or barley, regardless of the nutrient content of the diet. Apparently, larval performance does not respond to the substrate starch content but it might be influenced by the endosperm physical structure. Additionally, a lower N content in the substrate could impair growth performance, an effect that is alleviated once larval protein requirements are achieved. Larval composition was affected by the main dietary ingredient, with substrates based on wheat bran increasing the N content of larvae, whereas those based on barley resulted in increased DM and Ether extract contents.

Study of the effect of feeding Tenebrio molitor larvae during their rearing on their growth, nutritional profile, value and safety of the produced flour

Science and food industry must strive to ensure and improve edible insect's benefits, and especially their safety and nutritional value. This study investigated how various food substrates used in the rearing of Tenebrio molitor larvae influence their growth, the safety of the larvae, and the nutritional quality of the resulting flour. The main findings indicate that all samples showed significant differences in their nutritional profile, larval characteristics, and heavy metal content. Regarding the content of protein, fat and fiber it ranges from 44.1 to 51.8 %, 28.6-34.8 % and 10.5-14.9 %, respectively. These results suggest that insect diet is a very crucial parameter that can affect all that factors and must be taken into account, especially when they are intended as raw materials to be used for food production.

Bread By-Product and Maize Silage as Alternative Ingredient Feeds for Production of Tenebrio molitor Larvae in High-Concentrate Substrates

Bread by-product and maize silage as substrates for Tenebrio molitor larvae were studied in four isonitrogenous diets: a control substrate (CTL) made of wheat grain, wheat bran, and soybean meal and three diets where wheat grain and wheat bran were partly substituted with bread by-product (BBP) or with this and either a low (MSL) or high (MSH) proportion of maize silage (170 or 310 g/kg, respectively). Larval weight was weekly monitored, and the chemical composition of larvae and residual substrates was analyzed at the end of the experiment. Larvae fed CTL and BBP grew more than those fed MSL and MSH (p < 0.001). Feed intake was greatest for BBP (p < 0.001), and consequently, feed-to-gain ratio (F:G) was better for larvae fed CTL than BBP, and better for BBP than MSL and MSH (p < 0.001). Besides, total production of crude protein and ether extract were greater for CTL and BBP than for MSH and MSL (p < 0.001). The inclusion of bread by-product in the substrate did not affect growth performance, whereas diets including maize silage impaired larval growth, substrate intake, and F:G. Both by-products can be advantageously used for feeding T. molitor larvae, but the impairments in growth performance should be considered to optimize production costs.

Yellow mealworm: effects of adults breeding density on adults and larvae performances from an industrial perspective

A key aspect to optimise the Tenebrio molitor (TM) farm productivity is to find an optimal breeding density for adults. To this purpose, this study investigated, from an industrial perspective, the impact of four breeding densities (D1, D2, D3 and D4, equal to 0.8, 1.1, 1.3 and 1.6 adults/cm2, respectively) on mortality and reproductive performances of TM adults and larvae. Two weeks after pupae emergence, TM adults were randomly assigned to the four groups and housed in 48 breeding crates (60 × 40 × 14.5 cm; 12 crates/group). The trial consisted of 4 consecutive weeks of adult breeding (each week represented one oviposition), and 8 weeks of larvae growth. From each week of oviposition, a batch of larvae was obtained for a total of four batches of larvae (48 crates/batch). Larvae of each batch were grown until 8 weeks of age, corresponding to the period required to reach the selling size. Larvae were kept in the original crates until the 5th weeks of age, after which they were divided into additional crates to ensure a density of 4.2 larvae/cm2 and a final weight of 1 500 g of larvae/crate (0.6 g of larvae/cm2). For each oviposition week, TM adult's mortality, egg hatchability, BW, feed intake, chemical composition and fatty acid profile were evaluated, while ovary weight was measured at weeks 1 and 4. The number of larvae was monitored at week 5 of age while their chemical composition was determined at week 5 and 8. Larvae feed intake and BW were monitored over the 8-weeks growth period. Individual feed intake and BW of adults increased with increasing breeding density (P < 0.0001 and P < 0.05, respectively). With increasing adult breeding density, the number of larvae per crate increased (P < 0.001) while the grams of larvae/gram of adults decreased (R2 = 0.8856). Larvae from groups D2, D3 and D4 showed higher feed intake per crate and higher individual and total final BW than D1 (P < 0.001). However, the feed conversion ratio (FCR) worsened with increasing breeding density (P < 0.001). D4 larvae had higher percentages of protein (P < 0.001), lipids (P < 0.05) and cholesterol (P < 0.001) compared to larvae from other groups. Concluding, a breeding density of 0.8 adults/cm2 maximised both grams of larvae produced/grams of adults and larvae FCR. However, breeding densities above 0.8 adults/cm2 resulted in a higher number of produced larvae per crate with a greater final mass weight making a density of 1.6 adults/cm2 the preferable choice from and industrial perspective.

Effects of straw structure and component on feeding efficiency of yellow mealworm for insect protein production

Elucidating the influence of straw structure and component on the feeding efficacy of yellow mealworm is pivotal for improving insect protein production from straw. This research utilized four distinct types of straws-water hyacinth straw (WHS), corn straw (CS), rape straw (RAS), and rice straw (RIS)-as the sole substrate for larvae. Results indicated that the straw utilization rate and fresh larval weight gain rate followed the order of WHS > CS > RAS > RIS. Analysis of straw structural characteristics demonstrated that decreasing straw hardness and cellulose crystallinity, while enhancing straw chewability, facilitated the ingestion of larvae. Feeding efficiency of yellow mealworm was positively correlated with the hemicellulose and crude protein content, and inversely correlated with lignin content in the straw. Additionally, the structural characteristics and components of straw significantly influenced the composition of the gut microbiota. These results offer valuable insights for optimizing yellow mealworm feeding on straw.

Impacts of industrial food wastes on nutritional value of mealworm (Tenebrio molitor) and its gut microbiota community shift

The extensive investigation into the capacity of mealworms to digest diverse food by-products, as well as plastic wastes, has been a focal point in recent years. The transition from traditional diet sources like brans to food wastes has the potential to impact the physiological properties of mealworms. This study explored the utilization of various industrial food wastes such as okara, barley spent grain (BSG), sesame oil meal (SOM), and spent coffee grounds (SCG) as feed alternatives, and reports on their survival rate, biomass variations, and nutritional composition. In additional, the shift in their gut microbiota was also assessed. Among the range of industrial food wastes, mealworms exhibited the most robust growth performance when nourished with BSG. This particular group showed a survival rate of 98.33 % and a biomass increase of 23.06 %. In contrast, mealworms fed with SCG demonstrated the lowest survival rate and experienced a significant reduction in biomass. Although the groups fed with okara and SCG displayed moderate growth performance, both exhibited protein levels comparable to those observed in the oatmeal-fed group (used as the positive control). Notably, the inclusion of BSG in the mealworm diet exhibited the potential to enrich their omega-3 fatty acid content, suggesting potential benefits for applications as animal feed or even human consumption. Furthermore, an analysis of the gut microbiome was conducted to investigate the associations between specific diets and the composition of mealworm gut microbiota. In summary, food wastes such as BSG may be repurposed as feed substrates for mealworms before converting them into an alternative source of protein.

Sustainable poultry farming practices: a critical review of current strategies and future prospects

As global demand for poultry products, environmental sustainability, and health consciousness rises with time, the poultry industry faces both substantial challenges and new opportunities. Therefore, this review paper provides a comprehensive overview of sustainable poultry farming, focusing on integrating genetic improvements, alternative feed, precision technologies, waste management, and biotechnological innovations. Together, these strategies aim to minimize ecological footprints, uphold ethical standards, improve economic feasibility, and enhance industry resilience. In addition, this review paper explores various sustainable strategies, including eco-conscious organic farming practices and innovative feed sources like insect-based proteins, single-cell proteins, algal supplements, and food waste utilization. It also addresses barriers to adoption, such as technical challenges, financial constraints, knowledge gaps, and policy frameworks, which are crucial for advancing the poultry industry. This paper examined organic poultry farming in detail, noting several benefits like reduced pesticide use and improved animal welfare. Additionally, it discusses optimizing feed efficiency, an alternate energy source (solar photovoltaic/thermal), effective waste management, and the importance of poultry welfare. Transformative strategies, such as holistic farming systems and integrated approaches, are proposed to improve resource use and nutrient cycling and promote climate-smart agricultural practices. The review underscores the need for a structured roadmap, education, and extension services through digital platforms and participatory learning to promote sustainable poultry farming for future generations. It emphasizes the need for collaboration and knowledge exchange among stakeholders and the crucial role of researchers, policymakers, and industry professionals in shaping a future where sustainable poultry practices lead the industry, committed to ethical and resilient poultry production.

Boosted Meat Flavor by the Metabolomic Effects of Nile Tilapia Dietary Inclusion of Zophobas atratus Larval Meal

BACKGROUND

Zophobas atratus larval meal (ZLM) is a high-quality feed supplement with potential activities that can improve fish growth performance and promote meat quality. However, there have been limited recent studies investigating the metabolic effects of ZLM. Therefore, this study aims to uncover the metabolomic mechanism through which ZLM improves tilapia meat flavor using metabolomic strategies.

METHOD

In this study, soybean meal in the basal diets was replaced with 15%, 30%, or 60% ZLM, where anti-nutrient factors were destroyed by high temperature treatment. After being fed these ZLM supplements for 30 days, dorsal muscles were collected from tilapia for meat sensory evaluation tests. Liver samples were also collected for metabolomic analysis using the gas chromatography-mass spectrometry (GC-MS) platform and combined with biochemical assays to verify metabolism-related enzyme activities and reveal crucial metabolic pathways and critical biomarkers associated with ZLM's ability to improve meat flavor.

RESULTS

In tilapia livers, ZLM enhanced the activity of enzymes involved in energy metabolism including succinate dehydrogenase (SDH), pyruvate dehydrogenase (PDH), α-ketoglutarate dehydrogenase (α-KGDH), NADP-malate dehydrogenase (NAD-MDH) and mitochondrial isocitrate dehydrogenase (ICDHm). This resulted in increased levels of reduced nicotinamide adenine dinucleotide (NADH), acetyl CoA and ATP which led to accumulation of flavor fatty acids such as arachidonic acid, linoleic acid (9,12-Octadecadienoic acid), linolenic acid (9,12,15-Octadecatrienoic acid) and oleic acid (9-Octadecenoic acid). Additionally, there was an increase in flavor nucleotides like guanosine adenosine-5'-monophosphate and uridine-5'-monophosphate while off-flavor metabolites like inosine and hypoxanthine decreased. Furthermore, beneficial metabolomic responses led to a decrease in off-flavor metabolites such as 2-methylisoborneol trimethylamine and geosmin while increasing umami metabolites like 2-methyl-3-furanthiol and nonanal.

CONCLUSIONS

This metabolomic study demonstrates that inclusion of ZLM diets enhances the flavor profile of tilapia dorsal muscle. The accumulation of flavor compounds, coupled with a reduction in earthy taste and off-flavor metabolites, contributes to an improved meat flavor and freshness. Additionally, there is an increase in the levels of flavor-related amino acids and nucleotides. These previously unidentified metabolic effects highlight the potential significance of ZLM as a dietary supplement for enhancing the biosynthesis of flavor metabolites in tilapia.

Tenebrio molitor (Mealworm) protein as a sustainable dietary strategy to improve health span in D-galactose-induced aged mice

Aging is an irreversible and continuous biological process involving intricate and interconnected mechanisms. The present work is focused on unravelling the anti-aging mechanisms of mealworm protein and protein-enriched fruit bar and vegetable soup in D-galactose-induced aged mice. Mealworm protein and enriched products significantly enhanced body weight, organ indices, and gut health. Behavioral assessments reflected enhanced neuroprotective effects. Mealworm protein and its enriched products demonstrated protective effects through anti-inflammatory activity with the highest reduction of TNFα (17.1 %), IL-6 (55.5 %), and IL-1β (75.1 %) levels and upregulated the anti-inflammatory marker (IL-4). Gene expression studies confirmed the induction of anti-aging effects by promoting metabolism, reducing cellular senescence, and enhancing anti-oxidant enzyme activity. The treatments extended telomere lengths by 3-4 times, further affirming the potential anti-aging efficacy of mealworm protein and its enriched products. Mealworm protein demonstrated positive effects on weight gain, anti-inflammatory responses, and telomere length; while fruit and vegetable products enhanced antioxidant activity, and positively influenced gut health. Further, a synergistic effect was observed by combining them, which resulted in improved overall anti-aging effect. The present work provides valuable insights into the multifaceted anti-aging mechanisms associated with mealworm protein and enriched products, highlighting their potential as functional foods with significant health-promoting effects.

The Nutritional Quality of Commercially Bred Yellow Mealworm (Tenebrio molitor) Compared to European Union Nutrition Claims

Due to its potential as a sustainable protein source, the industrial relevance of Tenebrio molitor, known as yellow mealworm, is set to increase substantially. Given the novelty of its application in the food industry, knowledge is lacking regarding the nutritional quality of commercially farmed mealworms. This study investigated the nutritional composition of larvae from four different rearing facilities in Belgium and specifically investigated whether their nutritional profiles adhered to defined European nutrition claims (Regulation (EC) No. 1924/2006). In particular, the European nutrition claims "high in protein", "high unsaturated fat", "high in fibre" and "rich in P, Mg, K, Zn and Mn" were applicable for all mealworm samples on a dry matter basis. On a fresh matter basis, yellow mealworms were found to be "high in protein", "high unsaturated fat" and "low in sugar".

A Treatment for Rice Straw and Its Use for Mealworm (Tenebrio molitor L.) Feeding: Effect on Insect Performance and Diet Digestibility

The development of reuse processes for plant by-products for both animal and human food offers numerous possibilities for quality-of-life improvements that align with a circular economy model. For this reason, we divided this study into two experiments. First, we designed a combined treatment consisting of laccase, ultrasound, and ascorbic acid to hydrolyze rice straw plant fibers and used the resulting feed as the basis for T. molitor diets. Second, we formulated diets with different inclusion levels (0%, 25%, 50%, 75%, and 100%) of rice straw and treated rice straw to assess their impact on larvae growth and diet digestibility. For each treatment, six replicates were employed: four for the growth-performance-digestibility trial and two for complementary uric acid determination tests. The combined laccase enzyme, ultrasound, and ascorbic acid treatment hydrolyzed 13.2% of the vegetable fibers. The diets containing treated rice straw resulted in higher larvae weight and a better feed conversion ratio; however, reaching 100% by-product inclusion values led to similar results between both diets. In conclusion, these treatments improve the potential of low-nutritional-value vegetable by-products as part of a T. molitor diet, opening the possibility of new methodologies for the use of recalcitrant vegetable by-products for insect rearing.

Consumer Perceptions and Acceptance of Edible Insects in Slovenia

Slovenia, influenced by Slavic, Mediterranean, and Balkan cultures, along with Austro-Hungarian traditions and strong environmental concerns, is an ideal case study for understanding consumer perceptions of edible insects and increasing their acceptance as an alternative protein source. A survey conducted in Slovenian and English with 537 participants examined existing perceptions and acceptance of edible insects as food and livestock feed. Findings show moderate interest in insects, particularly in non-visible, integrated forms, despite most participants not having tried whole insects. Young, educated individuals and those residing in rural areas have tried insects more often than other sociodemographic groups. Men showed more interest in entomophagy compared to women. Crickets, grasshoppers, and locusts were most acceptable, while cockroaches were least favored. Economic factors are crucial, with a preference for insect-based products priced similarly to conventional foods. The majority also support using insects as livestock feed. These results can aid policymakers at regional and national levels, help businesses market these products, and contribute to the literature on consumer responses in different European regions regarding edible insects as a sustainable food source.

Influence of the processing on composition, protein structure and techno-functional properties of mealworm protein concentrates produced by isoelectric precipitation and ultrafiltration/diafiltration

Edible insects represent a great alternative protein source but food neophobia remains the main barrier to consumption. However, the incorporation of insects as protein-rich ingredients, such as protein concentrates, could increase acceptance. In this study, two methods, isoelectric precipitation and ultrafiltration-diafiltration, were applied to produce mealworm protein concentrates, which were compared in terms of composition, protein structure and techno-functional properties. The results showed that the protein content of the isoelectric precipitation concentrate was higher than ultrafiltration-diafiltration (80 versus 72%) but ash (1.91 versus 3.82%) and soluble sugar (1.43 versus 8.22%) contents were lower. Moreover, the protein structure was affected by the processing method, where the ultrafiltration-diafiltration concentrate exhibited a higher surface hydrophobicity (493.5 versus 106.78 a.u) and a lower denaturation temperature (161.32 versus 181.44 °C). Finally, the ultrafiltration-diafiltration concentrate exhibited higher solubility (87 versus 41%) and emulsifying properties at pH 7 compared to the concentrate obtained by isoelectric precipitation.

Mealworm larvae and black soldier fly larvae as novel protein supplements for cattle consuming low-quality forage

The global population is projected to increase, indicating that there will be greater demand for animal protein to meet the associated food needs. This demand will place additional pressure on livestock systems to increase output while also minimizing natural resource inputs. Insect protein has emerged as a potential alternative to conventional protein feeds, such as soybean meal. Mealworm larvae (MWL; Tenebrio molitor) have been studied in poultry and swine as an alternative protein source; however, there is no research currently evaluating MWL for cattle. Black soldier fly larvae (BSFL; Hermetia illucens) have also received attention for their potential use in livestock feed due to their scalability and nutritional value, but research in cattle is limited. The objective of this study was to evaluate the effects of whole-dried MWL and defatted BSFL as protein supplements for cattle consuming forage. Five ruminally cannulated steers were utilized in a 5 × 5 Latin square experiment to determine how MWL and BSFL supplementations affect forage utilization. Steers consuming ad libitum low-quality forage (76.5% neutral detergent fiber [NDF], 4.2% crude protein) were provided one of the five treatments each period: 1) control with no supplement (CON), 2) soybean meal (CONV), 3) BSFL, 4) MWL, or 5) 50/50 by-weight blend of BSFL and MWL (MIX). All treatments were provided at 100 mg N/kg BW and periods included 8 d for treatment adaptation, 5 d for intake and digestion, and 1 d for ruminal fermentation measures. Protein supplementation stimulated forage organic matter intake (FOMI; P ≤ 0.01) relative to CON (3.28 kg/d). There was a significant difference in FOMI (P ≤ 0.01) between BSFL (4.30 kg/d) and CONV (4.71 kg/d), but not between CONV and MWL (P = 0.06, 4.43 kg/d). Total digestible OM intake (TDOMI) was also stimulated by the provision of protein (P ≤ 0.01), from 1.94 kg/d for CON to an average of 3.24 kg/d across protein supplements. Organic matter digestibility (OMD) and NDF digestibility (NDFD) were not affected by treatment (P ≥ 0.37), for an average OMD of 66.5% and NDFD of 62.7%. There was also no treatment effect on ruminal volatile fatty acid (P = 0.96) or ammonia-N (P = 0.22) concentrations. These data indicate that MWL may stimulate forage utilization by beef cattle to a greater extent than BSFL, but both are viable protein supplements.

Efficient agri-food waste valorization using mealworm (Coleoptera: Tenebrionidae) into nutrient-rich biomass for food and feed

The utilization of yellow mealworm, Tenebrio molitor (Linnaeus, Coleoptera: Tenebrionidae), for food and feed is gaining interest globally. However, its production is hindered by expensive commercial diets. This study assessed mealworm growth performance, survival, bioconversion, and nutritional composition when fed on wheat bran (WB) with different inclusion levels (25%, 50%, 75%, and 100%) of Irish potato waste (PW). Results indicated that mealworms fed on diets with 25%-75% PW had increased body length and 1-2 times higher weight gain compared to sole WB and PW diets. The survival rate was 93%-94% across all diets. Mealworms fed on WB had a feed conversion ratio of 3.26, while the efficiency of diet conversion increased with PW inclusion levels. Mealworms fed on diets with 75% PW inclusion had the highest crude fat (48%) and energy levels (598 kcal/100 g), while sole WB produced mealworms with the highest crude protein (55%). The acid detergent fiber achieved using 100% WB was 2- to 3-fold higher, but the crude fiber and neutral detergent fiber did not vary significantly. Considerable amounts of lysine (1.6-2 mg/100 g), methionine (0.5-0.7 mg/100 g), leucine (1.4-2 mg/100 g), and threonine (0.8-1 mg/100 g) were achieved in the mealworm larvae. Our findings revealed that cheap agricultural by-products could be successfully used for the mass production of mealworms, substantially contributing to reduced production costs. Further exploration of the nutrient-dense mealworm larvae for the development of novel food and feed products is crucial.

Effects of Edible Insect Powders as Meat Partial Substitute on Physicochemical Properties and Storage Stability of Pork Patties

In this study, physicochemical and antioxidant properties, and storage stability (1, 3, and 7 days) of pork patties added with edible insect powders (EIP) of four species (Larvae of Tenenbrio molitor, Protaetia brevitarsis seulensis, Allomyrina dichotoma, and Gryllus bimaculatus) as meat partial substitutes were investigated. Twenty percent of each EIP was added to pork patties, and four treatments were prepared. On the other hand, two control groups were set, one with 0.1 g of ascorbic acid and the other without anything. Adding EIP decreased water content but increased protein, fat, carbohydrate, and ash contents. In addition, the use of EIP increased the water holding capacity and texture properties as well as decreased the cooking loss. However, the sensory evaluation and storage stability were negatively affected by the addition of EIP. The 2,2-diphenyl-1-picrylhydrazyl radical scavenging activity had a positive effect on storage stability. It is believed that the addition of EIP resulted in high antioxidants due to the presence of polyphenol compounds in EIP. These results indicate that EIP has great potential to be used as meat partial substitute to improve the quality improvement and antioxidant in pork patties. However, in order to improve storage stability and consumer preference, further research is needed to apply it to patties by reducing the amount of EIP or adding auxiliary ingredients.

Proximate and fatty acid profile analysis of Tenebrio molitor and Zophobas morio using different killing methods

The present work aimed to quantify the macronutrients and the fatty acid (FA) profile in different killing methods, blanching (BC) and freezing (FR), on edible insects of the speciesTenebrio molitor(TM) andZophobas morio(ZM). Concerning macronutrients TM-BC and TM-FR presented 51.2% and 50.6% of protein, 28% and 29.4% of lipids, and 12.4% and 11.4%. Meanwhile, ZM-BC and ZM-FR expressed 42.8% and 43.7% of protein, 39.1% and 40.1% of lipids, and 10.7% and 8.9% of carbohydrates. The FA of TM and ZM shows respectively values of Saturated Fatty Acids (∑SFA) 30% - 45%, Monounsaturated (MUFA) 47% - 32%, Polyunsaturated (∑PUFA) 23% - 22%, Atherogenicity Index (AI) 0.64 - 0.75, Thrombogenicity Index (TI) 0.77 - 1.44 and hypocholesterolemic/hypercholesterolemic index (h/H) of 2.50-1.51. Based on the results obtained, the slaughter methods showed statistically differences in relation to MUFA's in TM, and ZM larvae only in the minority fraction of FA.

Newly Woody Artificial Diet Reveals Antibacterial Activity of Hemolymph in Larvae of Zophobas atratus (Fabricius, 1775) (Coleoptera: Tenebrionidae)

The rearing of saproxylic insects in laboratory conditions is an important task for studying the biology of insects. Through understanding nutritional needs, it is possible to optimize beetle rearing in laboratory conditions. In this study, an artificial fungi-based diet (FD) was developed for the cultivation of the darkling beetle Zophobas atratus (Fabricius, 1775) (Coleoptera: Tenebrionidae) in laboratory conditions as a model object for studying the biology of saproxylophagous beetles. To assess the influence of the diet, a number of physiological parameters were measured, including development time, body size, and weight of all stages of the beetle's life cycle, as well as its immune status. The immune status of Z. atratus was assessed on the basis of larval hemolymph antibacterial activity against six different bacterial strains assessed using disk-diffusion and photometric tests. Our findings show that the FD reduces development time and boosts the immune status as compared to beetles reared on a standard diet (SD). Samples from FD-reared larvae had pronounced antibacterial activity as compared to samples from SD-reared larvae. This work is of fundamental importance for understanding the correlations between nutrition and development of saproxylic Coleoptera and is the first report on immune status regulation in this group of insects.

Responses of physiological, microbiome and lipid metabolism to lignocellulose wastes in gut of yellow mealworm (Tenebrio molitor)

There is limited research on physiological and degradation mechanisms of yellow mealworm, a novel organic waste converter, in processing lignocellulosic wastes. This study has selected two types of lignocellulosic wastes, distillers' grains (DG) and maize straw (MS), to feed yellow mealworms. This study investigated the effects of lignocellulosic wastes on the growth, antioxidant system, microbiome, and lipidome of yellow mealworms. The relative growth of lignocellulosic waste group was not significantly different from wheat bran. The antioxidant level was elevated in DG. MS was significantly enriched in cellulose-degrading bacteria in the gut and was accompanied by disturbances in lipid metabolism. The correlation coefficients were used to construct a network connecting diet, microbiota, and lipids. The correlation analysis indicated that two sphingolipids, hexylglyceramide and dihydroglyceramide, were strongly and positively linked with the dominating species. This study provides comprehensive information on physiological and mechanism of mealworms in process of treating lignocellulosic waste.

Culinary treatments impact the digestibility and protein quality of edible insects: a case study with Tenebrio molitor and Gryllus assimilis

The escalating global population is anticipated to intensify the demand for high-quality proteins, necessitating the exploration of alternative protein sources. Edible insects are a promising solution, owing to their nutritional richness and sustainability. However, their digestibility and protein quality, particularly after culinary treatment, remains underexplored. In the present study, we investigated the effects of various culinary treatments on the protein digestibility of two insect species, Tenebrio molitor and Gryllus assimilis. Our findings revealed that culinary treatments such as boiling, roasting, drying, and microwave heating significantly influenced the digestibility of both insect species. Notably, drying emerged as the most effective method, leading to a substantial increase in digestibility. Furthermore, we assessed protein quality using the digestible indispensable amino acid score (DIAAS) and found that the choice of the calculation method significantly influenced the evaluation of protein quality. By including the sum of the anhydrous amino acids, we eliminated the potential overestimation of protein content and obtained a more reliable assessment of protein quality. Our results underscore the importance of culinary treatments and calculation methods in determining the suitability of insects as protein sources for human nutrition.

Biodegradation of various grades of polyethylene microplastics by Tenebrio molitor and Tenebrio obscurus larvae: Effects on their physiology

Polyethylene (PE) is the most productive plastic product and includes three major polymers including high-density polyethylene (HDPE), linear low-density polyethylene (LLDPE) and low-density polyethylene (LDPE) variation in the PE depends on the branching of the polymer chain and its crystallinity. Tenebrio obscurus and Tenebrio molitor larvae biodegrade PE. We subsequently tested larval physiology, gut microbiome, oxidative stress, and PE degradation capability and degradation products under high-purity HDPE, LLDPE, and LDPE powders (<300 μm) diets for 21 days at 65 ± 5% humidity and 25 ± 0.5 °C. Our results demonstrated the specific PE consumption rates by T. molitor was 8.04-8.73 mg PE ∙ 100 larvae-1⋅day-1 and by T. obscurus was 7.68-9.31 for LDPE, LLDPE and HDPE, respectively. The larvae digested nearly 40% of the ingested three PE and showed similar survival rates and weight changes but their fat content decreased by 30-50% over 21-day period. All the PE-fed groups exhibited adverse effects, such as increased benzoquinone concentrations, intestinal tissue damage and elevated oxidative stress indicators, compared with bran-fed control. In the current study, the digestive tract or gut microbiome exhibited a high level of adaptability to PE exposure, altering the width of the gut microbial ecological niche and community diversity, revealing notable correlations between Tenebrio species and the physical and chemical properties (PCPs) of PE-MPs, with the gut microbiome and molecular weight change due to biodegradation. An ecotoxicological simulation by T.E.S.T. confirmed that PE degradation products were little ecotoxic to Daphnia magna and Rattus norvegicus providing important novel insights for future investigations into the environmentally-friendly approach of insect-mediated biodegradation of persistent plastics.

Performance of Hermetia illucens (Diptera: Stratiomyidae) larvae reared on organic waste diets and pupal chitin and chitosan yield

Recently, much research has been oriented towards the influence of different food wastes and agricultural by-products on the final larval biomass and chemical composition of the insect species Hermetia illucens L. (Diptera: Stratiomyidae). However, there is a gap in the literature regarding the possible relationship between the feeding substrate of H. illucens larvae and chitin. In this context, in the present study, larvae of H. illucens derived from two populations (i.e., UNIPI and UTH), were reared on different diets composed of fruits, vegetables, and meat. Based on the results, the larval survival was high for all diets tested. Larval growth in terms of weight gain, larval length, and feed conversion ratio (FCR) depended on the composition of each diet. The chitin and chitosan composition of larvae, reared on different substrates, did not reveal significant differences. Given the fact that the feeding substrate represent a significant cost in the industrial production of insects, its correlation with a high value product (i.e. chitosan) is important. On the other hand, as the prepupal stage of H. illucens is currently used as animal feed, the metabolization of chitin by farmed animals when the larvae or prepupae were offered as feed could have adverse effects. Thus, depending on the final product that is to be produced, industries could benefit from the establishment of a suitable diet.

Novel foods, old issues: Metabarcoding revealed mislabeling in insect-based products sold by e-commerce on the EU market

Insects intended for human consumption are considered Novel Foods according to EU legislation. marketed in form of powders, bars, snacks are increasingly available on the EU market, especially on e-commerce. The commercial form and the way of distribution make IBPs particularly prone to mislabeling. Literature concerning the mislabeling occurrence in IBPs is extremely scarce. In this study, 46 processed IBPs were collected on nine EU e-commerce platforms (e-CO) to be authenticated by metabarcoding. A 200 bp region from 16S rRNA gene was used as molecular target. Sequencing data were processed using DADA2 R package, and sequences were taxonomically assigned through BLAST analysis against GenBank. Procedural blanks and positive controls were included in the analysis, and threshold values were established to filter the final data. The mislabeling rate (i. e. the mismatch between the species declared on the IBP label and the species identified by metabarcoding) was calculated. Overall, a high mislabeling rate (33.3 %) was observed, although this percentage is influenced by the e-CO platform and the insect species, with A. domesticus particularly involved. The use of species not listed in authorized Novel Food (e. g. Gryllus locorojo), and/or the partial replacement of high value species with lower value species was highlighted for the first time in processed IBPs. The presence of insect pests was also detected. Metabarcoding was confirmed as an effective tool for IBPs authentication. Also, outcomes from this study can provide useful data on the main issues involving the EU IBPs' market, that can represent an incentive to reinforce both official controls and FBO's self-controls on these poorly investigated products.

Larval biomass production from the co-digestion of mushroom root waste and soybean curd residues by black soldier fly larvae (Hermetia illucens L.)

People are increasingly using black soldier fly larvae (BSFL) as a sustainable waste management solution. They are high in protein and other essential nutrients, making them an ideal food source for livestock, poultry, and fish. Prior laboratory studies with BSFL developed on pure mushroom root waste (MRW) showed poor conversion efficiency compared to a regular artificial diet. Therefore, we mixed the nutrient-rich soybean curd residues (SCR) with MRW in different ratios (M2-M5). Pure mushroom root waste (M1, MRW 100%) had the lowest survival rate (86.2%), but it increased up to 96.9% with the SCR percentage increasing. M1 had the longest developmental period (31.1 days) and the lowest BSFL weight (7.4 g). However, the addition of SCR reduced the development time to 22.0 and 21.5 days in M4 (MRW 40%, SCR 60%) and M5 (MRW 20%, SCR 80%), respectively, and improved the larval weight to 10.9 g in M4 and 11.8 g in M5. Other groups did not have as much feed conversion ratio (FCR) (8.4 for M4 and M5), bioconversion (M4 5.4%; M5 5.9%), or lipid content (M4 25.2%; M5 24.3%). These mixtures did. Compare this to M1. We observed better results, with no significant differences between the M4 and M5 groups and their parameters. In the present study, our main target was to utilize more MRW. Therefore, we preferred the M4 group in our nutritional and safety investigation and further compared it with the artificial diet (M7). The heavy metals and essential amino acids (histidine 3.6%, methionine 2.7%, and threonine 3.8%) required for human consumption compared to WHO/FAO levels showed satisfactory levels. Furthermore, fatty acids (capric acid 1.9%, palmitic acid 15.3%, oleic acid 17.3%, and arachidonic acid 0.3%) also showed higher levels in M4 than M7. The SEM images and FT-IR spectra from the residues showed that the BSFL in group M4 changed the structure of the compact fiber to crack and remove fibers, which made the co-conversion mixture better.

Larval performance of Zophobas morio (F.) (Coleoptera: Tenebrionidae) on various diets enriched with post-distillation residues and essential oils of aromatic and medicinal plants

The increasing demands for resources driven by the global population necessitate exploring sustainable alternatives for affordable animal protein over the use of traditional protein sources. Insects, with their high protein content, offer a promising solution, especially when reared on agricultural post-distillation residues for enhanced sustainability and cost-effectiveness. We assessed the development of Zophobas morio (F.) (Coleoptera: Tenebrionidae) larvae on diets enriched with essential oils and post-distillation residues from Greek aromatic and medicinal plants. Two aromatic plant mixtures (A and B) were examined. Mixture A consisted of post-distillation residues, while Mixture B incorporated these residues along with essential oils. Insect rearing diets were enriched with different proportions (10, 20, and 30 %) of these mixtures, with wheat bran serving as the control. Enrichment positively influenced larval development without compromising survival. Larval weight remained unchanged with Mixture A, but improved with Mixture B. No adverse effects were detected in the case of the enriched diets, although higher concentrations of Mixture B prolonged development time.

Recent advances in edible insect processing technologies

Alternative foods have emerged as one of the hot research topics aiming at alleviating food shortage. Insects are one of the alternative foods due to their rich nutrients. Processing is a critical step to develop insect foods, while there is a lack of comprehensive reviews to summarize the main studies. This review aims to demonstrate different processing methods in terms of their impact on insect nutrition and their potential risks. Heat treatments such as boiling and blanching show a negative effect on insect nutrition, but essential to assure food safety. Insects treated by high-pressure hydrostatic technology (HPP) and cold atmospheric pressure plasma (CAPP) can achieve a similar sterilization effect but retain the nutritional and sensory properties. Drying is a practical processing method for industrial insect production, where oven drying serves as a cost-effective method yielding products comparable in quality to freeze-dried ones. In terms of extraction technology, supercritical carbon dioxide and ultrasound-assisted technology can improve the extraction efficiency of proteins and lipids from insects, enhance the production of composite insect-fortified foods, and thus facilitate the development of the insect food industry. To address the widespread negative perceptions and low acceptance towards insect foods among consumers, the primary development direction of the insect food industry may involve creating composite fortified foods and extracting insect-based food components.

Go local: Enhancing sustainable production of Tenebrio molitor through valorization of locally available agricultural byproducts

Insects receive increasing attention as an alternative source of protein for animals and humans, and thus, the production of low-cost insects for meeting the dietary demand on sustained basis is an ever-growing concept. This study aims to design dietswith locally available agricultural byproducts from Greece as feed for larvae of the yellow mealworm, Tenebrio molitor L. (Coleoptera: Tenebrionidae). This will considerably reduce the cost of insect feed and the environmental impact of insect farming by using locally available agricultural byproducts as economic insect feedstock. More specifically, five agricultural byproducts derived from the production of cereals and legumes were utilized to design twelve different diets at two protein levels, i.e., 17.4 and 22.5% protein content. All diets were evaluated both at laboratory scale, but also at pilot scale. Based on the obtained results, both bioassays revealed that the diets contained one legume and one cereal byproduct (i.e., lupin and triticale as well as lupin and oat) supported more efficiently the growth and performance of the larvae, irrespective of the protein level. Indicatively, individual larval weight of the best performed larvae from both groups ranged from 132 to 142 mg. Moreover, our results highlight the fact that data derived from laboratory scale bioassays are not always easy to be extrapolated to industrial production. For instance, the total harvest of larvae, a parameter assessed in the tray scale bioassay, exhibited a disparity between diet A2 (910 g) and diet A3 (749 g), despite both being deemed optimal in the laboratory-scale experiment. Our study aims to promote a circular approach for the industrial rearing of insects through integration of local agricultural byproducts into specific diets for T. molitor larvae.

Improving Tenebrio molitor Growth and Nutritional Value through Vegetable Waste Supplementation

Huge amounts of vegetable wastes are generated by the food industry. Their bioconversion into valuable products (e.g., insect flours or biofertilizer) through insect farming is a promising solution to reduce their negative environmental and economic impacts. This study evaluates the growth of Tenebrio molitor larvae and their nutritional profile after supplementing their diets with vegetable wastes. Over a 6-week period, 45-day larvae were fed a diet comprising wheat bran supplemented (1:1) with cucumber or tomato wastes from both conventional and ecological crops. The control diet consisted of wheat bran and an equivalent amount of water to compensate for the waste moisture. Larval weight was measured weekly, and length measures were taken fortnightly. Nutritional composition and fatty acid profile were analyzed at the end of the study in 90-day larvae. Regardless of using vegetable waste from conventional or ecological harvesting, the weight of 6-week supplemented larvae almost doubled that of larvae fed with just wheat bran, and their length was 15% higher. Supplementation also increased larval polyunsaturated fatty acid percentage by 22-37%, with linoleic acid being the most abundant. Likewise, larval protein content reached 50% after supplementation. This study demonstrates that both cucumber and tomato wastes from conventional or ecological crops are excellent supplements for T. molitor's diet, improving their nutritional value and reducing the time necessary for larvae growth.

Combined Dietary Supplementation of Tenebrio molitor Larvae and Chitosan in Growing Pigs: A Pilot Study

Nowadays, the global animal industry faces considerable challenges in securing sufficient feed resources. Responding to consumer demands for reduced use of antibiotics in animal nutrition, better animal welfare status, and reduced impact on the environment, there is an increased urgency to develop innovative functional feeds with a reduced environmental footprint and the ability to improve meat quality and safety. In an effort to explore innovative feed ingredients for growing pig diets, the combined dietary supplementation of Tenebrio molitor larvae and chitosan was investigated. An experimental trial was performed with 48 weaned pigs (34 days of life; mixed sex) that were randomly assigned to four treatment groups (with six males and six females each): Group A (control), Group B (supplemented with T. molitor larvae at 10%), Group C (supplemented with chitosan at 0.05%), and Group D (supplemented with both ingredients at 10% and 0.05%, respectively). On the 42nd day of the experimental trial, samples of blood, feces, and carcass parts were taken for analysis. The results indicated that the insect larvae meal significantly improved (p < 0.05) overall performance, increased (p < 0.05) blood red blood cell content, increased meat phenolic content (p < 0.05), improved meat oxidative stability (p < 0.05), and affected meat fatty acid profile (p < 0.05). On the other hand, chitosan had no significant effect on overall performance (p > 0.05), but it significantly increased blood lymphocyte content (p < 0.05), affected the fecal microbiota (p < 0.05), improved meat oxidative stability (p < 0.05), increased meat phenolic content (p < 0.05), and affected meat fatty acid composition (p < 0.05) and (p < 0.05) meat color. Finally, the combined use of both T. molitor and chitosan significantly affected some important zootechnical parameters (p < 0.05), fecal microbial populations (p < 0.05), meat color (p < 0.05), and fatty acid profile (p < 0.05). Further investigation into the potential interaction between insect larvae meals and chitosan in pig diets is advised.

From feed to functionality: Unravelling the nutritional composition and techno-functional properties of insect-based ingredients

In recent years, there has been a growing interest in using insects as a sustainable resource for biorefinery processes. This emerging field aims to convert insect biomass into valuable products while minimizing waste. The integration of emerging green technologies and the efficient extraction of high-value compounds from insects offer promising avenues for addressing the growing demand for sustainable food production and resource utilization. The review examines the impact of dietary modifications on the nutritional profile of insects. It highlights the potential for manipulating insect feed to optimize protein quality, amino acid profile, lipid content and fatty acid composition. Additionally, innovative green processing technologies such as ultrasound, high pressure processing, pulsed electric fields, cold plasma and enzymatic hydrolysis are discussed for their ability to enhance the extraction and techno-functional properties of insect-based ingredients. The review finds that dietary modifications can impact the nutritional composition of insects, allowing the customization of their nutrient content. By optimizing the insect feed, it is possible to increase the quantity and improve the quality of essential nutrients like proteins or lipids in the derived ingredients. Moreover, alternative processing technologies can improve the techno-functional properties (e.g., solubility, water and oil holding capacities, among others) of insect-based ingredients by modifying proteins' conformation. By harnessing these strategies, researchers and industry professionals can unlock the full potential of insects as a sustainable and nutritional food source, paving the way for innovative insect-based food products.

The Influence of Different Sustainable Substrates on the Nutritional Value of Tenebrio molitor Larvae

Every year, over 30% of food production is wasted. However, promoting a sustainable food supply not only fosters economic stability in agriculture and the food industry, but also safeguards precious natural resources and ensures universal food access and safety. Therefore, the aim of the study was to determine how specific growth conditions (utilizing by-products: sprouted potatoes (1), wheat bran (2), brewers' spent grain (3), and a control sample with agar-agar gels (4)) affect the larvae of yellow mealworms (Tenebrio molitor). This includes their nutritional and energy value, consumer sensory profiling, and technological parameters of processing. The results have indicated that larvae reared on the substrate with wheat bran had the highest energy value, at 708.26 kcal. In larvae, the difference in protein content was not significant when changing the rearing conditions, and ranged between 48.54 and 59.18%. The larvae contained a significant content of fibers, with the highest amount detected in samples with brewers' spent grain. The data indicate that glucose and arabinose were distinctive to larvae. Our study has also revealed a statistical difference in ash content between larvae and the substrate, with higher levels of nitrogen, copper, and zinc detected in the larvae compared to the substrate. We have found that the salt was naturally occurring in the substrates, with the brewers' spent grain sample having the highest amount, at 1.83%. However, the control sample yielded the highest ratings, achieving a score of 7.30 for general smell acceptability. These findings emphasize the potential of utilizing various industrial and farm by-products as substrates for mealworms, transforming them into a sustainable and nutrient-rich food source. This contribution adds to the broader discourse on nutritional value and resource efficiency.

Insect-based agri-food waste valorization: Agricultural applications and roles of insect gut microbiota

Meeting the demands of the growing population requires increased food and feed production, leading to higher levels of agri-food waste. As this type of waste seriously threatens public health and the environment, novel approaches to waste management should be developed. Insects have been proposed as efficient agents for biorefining waste, producing biomass that can be used for commercial products. However, challenges in achieving optimal outcomes and maximizing beneficial results remain. Microbial symbionts associated with insects are known to have a critical role in the development, fitness, and versatility of insects, and as such, they can be utilized as targets for the optimization of agri-food waste insect-based biorefinery systems. This review discusses insect-based biorefineries, focusing on the agricultural applications of edible insects, mainly as animal feed and organic fertilizers. We also describe the interplay between agri-food waste-utilizing insects and associated microbiota and the microbial contribution in enhancing insect growth, development, and involvement in organic waste bioconversion processes. The potential contribution of insect gut microbiota in eliminating pathogens, toxins, and pollutants and microbe-mediated approaches for enhancing insect growth and the bioconversion of organic waste are also discussed. The present review outlines the benefits of using insects in agri-food and organic waste biorefinery systems, describes the roles of insect-associated microbial symbionts in waste bioconversion processes, and highlights the potential of such biorefinery systems in addressing the current agri-food waste-related challenges.

Nutritional Value of Banded Cricket and Mealworm Larvae

Insect farming is more ecological than traditional animal farming, as it requires less water and contributes to lower greenhouse gas emissions. In our study, banded cricket (BC) and mealworm larvae (ML) were analyzed. The proximate composition was determined according to Association of Official Analytical Chemists. The mineral content was determined by colorimetry and mass spectrometry. Fatty acid methyl esters (FAMEs) were obtained from the samples and separated using a gas chromatography apparatus, coupled with a mass spectrometer. Our research confirmed that insects are a rich source of protein, with ML containing significantly more protein than BC (74.41 and 65.66 g/100 g dry matter (DM), respectively). In terms of the content of macrominerals, ML was significantly richer than BC, especially in terms of magnesium content (8.75 g/100 g DM). In terms of the content of saturated fatty acids, BC contained almost twice as much as ML (40.05 and 24.74% of the sum of fatty acids, respectively). EPA and DHA were only detected in the fat of BC. The presented results prove that both ML and BC can be good sources of protein both in human and companion animal diets. The component that is predominantly high in insects is fat, with a favorable fatty acid profile, especially in terms of polyunsaturated fatty acids. This study contributes new knowledge on the nutritional value of edible insects. In this research, we included three different nitrogen conversion factors for crude protein content. Our results partially confirm previous studies by other authors, although they provide new information on the content of fatty acids.

Future Proteins: Sustainable Diets for Tenebrio molitor Rearing Composed of Food By-Products

Since the human population is continuously growing, sufficient food with low environmental impact is required. Especially, the challenge of providing proteins will deepen and insects can contribute to a more sustainable and efficient source of protein for human consumption. Tenebrio molitor larvae are highly nutritious and rearing mealworms is more environmentally friendly compared to the production of traditional livestock meat. To use T. molitor as a more sustainable alternative to conventional proteins, it is essential to apply diets from a local and sustainable source. Therefore, the objective of this study was to find local by-products or leftovers which can be used in mass production of larvae as a main substrate. Feeding trials investigating twenty-nine different substrates were conducted to evaluate larval growth performance and adult reproduction by determining development times, survival rates, biomass, and fecundity. Several suitable by-products were identified that can be used in high quantities as single component diet for T. molitor rearing, revealing a high survival rate, short development time, high mean total biomass, and successful breeding. The most successful substrate-malt residual pellets-was found to be an alternative to the most used substrate, wheat bran. Furthermore, corn germ meal, sweet chestnuts, bread remains, soybeans, sweet potatoes, and wheat germs have been discovered to be suitable diets for T. molitor. Moreover, the findings of this study contribute towards using several substrates as supplements.

First Optimization of Tomato Pomace in Diets for Tenebrio molitor (L.) (Coleoptera: Tenebrionidae)

Tomato pomace (TP), an agricultural industrial waste product from the tomato processing industry, is valorized as a rearing substrate for Tenebrio molitor (L.). This study evaluated bran-based diets with increasing tomato pomace (0%, 27%, 41%, and 100%). Protein sources, such as brewer's spent grain and yeast, were used in TP27 and TP41 diets to ensure equal protein contents to the control diet. Results showed no different for larval and pupal weights between diets; however, the time of development significantly increases in TP100 compared to all diets. The feed conversion rate progressively increases from 2.7 to 4.3, respectively, from the control to the TP100 diet. Conversely, lycopene and β-carotene increase in the larvae. The fatty acid composition improves by increasing polyunsaturated fatty acids (mainly α-linoleic acid). Although the best nutritional quality was obtained in T100, the TP41 is the optimal diet for balance between larval performance and qualitative improvement of larvae. Therefore, tomato pomace is suitable for the formulation of mealworm diets, even in high dosages, when supplemented with sustainable protein and carbohydrate sources.

From waste to food and bioinsecticides: An innovative system integrating Tenebrio molitor bioconversion and pyrolysis bio-oil production

To achieve a waste-free clean production, the present study aimed to valorize an underused agroindustrial byproduct (rice bran) by mealworms bioconversion and produce bio-oil from pyrolysis of insect excreta (frass) as bioinsecticide. To reach the first goal, the suitability of rice bran (RB) versus standard diet, wheat bran (WB), was examined by determining feed conversion, growth performance, and nutritional profile of T. molitor larvae. RB diet was an appropriate feed substrate for breeding mealworms, as evidenced by their high survival rates, optimal feed conversion parameters, and its capability to support the growth and life cycle of this insect. Besides, RB did not affect soluble larval protein content but modified crude fat content and fatty acid profile. In order to address the second aim, egested frass from RB and WB were subjected to pyrolysis to obtain bio-oils. The main compound was acetic acid (≈37%) followed by 1,6-anhydro-β-d-glucopyranose (from 16 to 25%), as measured by GC-MS analysis. Nitrogen-containing chemicals accounted for ≈10%. Frass bio-oils could represent a novel source of bioinsecticides due to their bioeffectiveness in insect pests of economic importance (Plodia interpunctella and Tribolium castaneum) and medical interest (Culex pipiens pipiens). For P. interpunctella adults, frass bio-oils produced insecticidal activity by fumigant and contact exposure whereas for T. castaneum adults, just fumigant. By a miniaturized model that simulates semireal storage conditions, it was seen that, on T. castaneum, frass RB bio-oil generated higher repellent effect than frass WB. Finally, bio-oils proved to have larvicidal activity against Cx. p. pipiens.

Growth Performance, Diet Digestibility, and Chemical Composition of Mealworm (Tenebrio molitor L.) Fed Agricultural By-Products

Humanity's growing demand for animal protein exceeds the capacity of traditional protein sources to support growing livestock production. Insects offer promising partial substitutes, converting low-nutritional quality materials into high-value biomass. Hence, the bioconversion ability of Tenebrio molitor larvae was assessed by using three types of agricultural by-products (broccoli by-product, tigernut pulp, and grape pomace) at different inclusion levels (0%, 25%, 50%, and 100%) in a carbohydrate-based diet. Ten diets were formulated to assess their impact on the growth, diet digestibility, and nutritional composition of the larvae. For each treatment, eight replicates were employed: five for the growth-performance-digestibility trial and three for the complementary test of uric acid determination. The growth was influenced by the type of diet administered. The broccoli by-product resulted in higher larvae weight and a better feed conversion ratio. However, diets based solely on a single by-product (100%) compromised the productivity and diet digestibility. The larvae changed their nutritional composition depending on the rearing substrate, although the amino acid profile remained consistent. In conclusion, the studied by-products have the potential for use in T. molitor rearing as part of the diet but not as the exclusive ingredients, indicating promising opportunities for using agricultural by-products in T. molitor rearing and production.

Outbreak of densovirus with high mortality in a commercial mealworm (Tenebrio molitor) farm: A molecular, bright-field, and electron microscopic characterization

Mealworms are one of the most economically important insects in large-scale production for human and animal nutrition. Densoviruses are highly pathogenic for invertebrates and exhibit an extraordinary level of diversity which rivals that of their hosts. Molecular, clinical, histological, and electron microscopic characterization of novel densovirus infections is of utmost economic and ecological importance. Here, we describe an outbreak of densovirus with high mortality in a commercial mealworm (Tenebrio molitor) farm. Clinical signs included inability to prehend food, asymmetric locomotion evolving to nonambulation, dehydration, dark discoloration, and death. Upon gross examination, infected mealworms displayed underdevelopment, dark discoloration, larvae body curvature, and organ/tissue softness. Histologically, there was massive epithelial cell death, and cytomegaly and karyomegaly with intranuclear inclusion (InI) bodies in the epidermis, pharynx, esophagus, rectum, tracheae, and tracheoles. Ultrastructurally, these InIs represented a densovirus replication and assembly complex composed of virus particles ranging from 23.79 to 26.99 nm in diameter, as detected on transmission electron microscopy. Whole-genome sequencing identified a 5579-nucleotide-long densovirus containing 5 open reading frames. A phylogenetic analysis of the mealworm densovirus showed it to be closely related to several bird- and bat-associated densoviruses, sharing 97% to 98% identity. Meanwhile, the nucleotide similarity to a mosquito, cockroach, and cricket densovirus was 55%, 52%, and 41%, respectively. As this is the first described whole-genome characterization of a mealworm densovirus, we propose the name Tenebrio molitor densovirus (TmDNV). In contrast to polytropic densoviruses, this TmDNV is epitheliotropic, primarily affecting cuticle-producing cells.

Mapping the nutritional landscape in the yellow mealworm: testing the nutrient-mediated life-history trade-offs

Animals must acquire an ideal amount and balance of macronutrients to optimize their performance, health and fitness. The nutritional landscape provides an integrative framework for analysing how animal phenotypes are associated with multiple nutritional components. Here, we applied this powerful approach to examine how the intake of protein and carbohydrate affects nutrient acquisition and performance in the yellow mealworm (Tenebrio molitor) reared on one of 42 synthetic foods varying in protein and carbohydrate content. Tenebrio molitor larvae increased their food consumption rate in response to nutrient dilution, but this increase was not sufficient to fully compensate for the dilution. Diluting the food nutrient content with cellulose reduced the efficiency of post-ingestive nutrient utilization, further restricting macronutrient acquisition. Tenebrio molitor larvae utilized macronutrients most efficiently at a protein to carbohydrate (P:C) ratio of 1.77:1, but became less efficient at imbalanced P:C ratios. Survivorship was high at high protein intake and fell with decreasing protein intake. Pupal mass and growth rate exhibited a bell-shaped landscape, with the nutritional optima being located around protein-biased P:C ratios of 1.99:1 to 2.03:1 and 1.66:1 to 2.86:1, respectively. The nutritional optimum for development time was also identified at high P:C ratios (1.66:1  to 5.86:1). Unlike these performance traits, lipid content was maximized at carbohydrate-biased P:C ratios of 1:3.88 to 1:3.06. When given a food choice, T. molitor larvae self-composed a slightly carbohydrate-biased P:C ratio of 1:1.24, which lies between the P:C ratios that maximize performance and lipid content. Our findings indicate the occurrence of a nutrient-mediated trade-off between performance and energy storage in this insect.

The nutritional profile, mineral content and heavy metal uptake of yellow mealworm reared with supplementation of agricultural sidestreams

Insect farming, a potential approach to deal with the increasing global protein demand, is a new activity in the Western world with many unanswered questions regarding product quality and safety. Insects may fulfill an important role in a circular economy by upcycling biowaste into valuable biomass. About half of the total mass of mealworm feeding substrates exists out of wet feed. This can be sourced from biowaste, increasing the sustainability of insect farming. This paper reports on the nutritional profile of yellow mealworm, Tenebrio molitor, reared with supplementation of organic sidestreams. These included unsold vegetables, potato cuttings, fermented chicory roots and horticultural foliage. The evaluation was performed by analyzing proximate compositions, fatty acid profiles, mineral and heavy metal contents. Mealworms fed with potato cuttings doubled their fat content and increased saturated and mono-unsaturated fatty acids. Providing fermented chicory roots increased the mineral content and accumulated heavy metals. Additionally, the uptake of minerals by mealworms was selective as only calcium, iron and manganese concentrations increased. Adding vegetable mix or horticultural foliage to the diet did not significantly change the nutritional profile. In conclusion, sidestreams were successfully recycled into protein-rich biomass and their nutrient content and bio-availability influenced the composition of mealworms.

Suitability of maize crop residue fermented by Pleurotus ostreatus as feed for edible crickets: growth performance, micronutrient content, and iron bioavailability

Small-scale farming of edible insects could help combat public health challenges such as protein energy malnutrition and anemia, but reliable low-cost feeds for insects are needed. In resource-limited contexts, where grains such as maize are prohibitively costly for use as insect feed, the feasibility of insect farming may depend on finding alternatives. Here, we explore the potential to modify plentiful maize crop residue with edible mushroom mycelium to generate a low-cost feed adjunct for the farmed two-spotted cricket, Gryllus bimaculatus. Mushroom farming, like insect agriculture, is versatile; it can yield nutritious food while increasing system circularity by utilizing lignocellulosic residues from row crops as inputs. Pleurotus ostreatus, is an edible basidiomycete capable of being cultivated on corn stover (Zea mays). Mushroom harvest results in abundant "spent" substrate, which we investigated as a candidate feed ingredient. We created six cricket feeds containing fermented Pleurotus substrate plus an unfermented control, measuring cricket mass, mortality, and maturation weekly to evaluate cricket growth performance impacts of both fungal fermentation duration and mushroom formation. Pasteurized corn stover was inoculated with P. ostreatus mycelium and fermented for 0, 2, 3, 4, or 8 weeks. Some 4 and 8-week substrates were induced to produce mushrooms through manipulations of temperature, humidity, and light conditions. Dried fermented stover (40%) was added to a 1:1 corn/soy grain mix and fed to crickets ad libitum for 44 days. The unfermented control group showed higher survivorship compared to several fermented diets. Control group mass yield was higher for 2 out of 6 fermented diets. Little variation in cricket iron content was observed via ICP-spectrometry across feeds, averaging 2.46 mg/100 g. To determine bioavailability, we conducted in vitro Caco-2 human colon epithelial cell absorption assays, showing that iron in crickets fed fruiting-induced substrates was more bioavailable than in unfruited groups. Despite more bioavailable iron in crickets reared on post-fruiting substrates, we conclude that Pleurotus-fermented stover is an unsuitable feed ingredient for G. bimaculatus due to high mortality, variability in growth responses within treatments, and low mass yield.

Unveiling the residual plastics and produced toxicity during biodegradation of polyethylene (PE), polystyrene (PS), and polyvinyl chloride (PVC) microplastics by mealworms (Larvae of Tenebrio molitor)

Evidence for plastic degradation by mealworms has been reported. However, little is known about the residual plastics derived from incomplete digestion during mealworm-mediated plastic biodegradation. We herein reveal the residual plastic particles and toxicity produced during mealworm-mediated biodegradation of the three most common microplastics, i.e., polyethylene (PE), polystyrene (PS), and polyvinyl chloride (PVC). All three microplastics are effectively depolymerized and biodegraded. We discover that the PVC-fed mealworms exhibit the lowest survival rate (81.3 ± 1.5%) and the highest body weight reduction (15.1 ± 1.1%) among the experimental groups by the end of the 24-day experiment. We also demonstrate that the residual PVC microplastic particles are more difficult to depurate and excrete for the mealworms compared to the residual PE and PS particles by using laser direct infrared spectrometry. The levels of oxidative stress responses, including reactive oxygen species, antioxidant enzyme activities, and lipid peroxidation, are also highest in the PVC-fed mealworms. Sub-micron microplastics and small microplastics are found in the frass of mealworms fed with PE, PS, and PVC, with the smallest particles detected at diameters of 5.0, 4.0, and 5.9 µm, respectively. Our findings provide insights into the residual microplastics and microplastic-induced stress responses in macroinvertebrates under micro(nano)plastics exposure.

Temperature- and Diet-Induced Plasticity of Growth and Digestive Enzymes Activity in Spongy Moth Larvae

Temperature and food quality are the most important environmental factors determining the performance of herbivorous insects. The objective of our study was to evaluate the responses of the spongy moth (formerly known as the gypsy moth) [Lymantria dispar L. (Lepidoptera: Erebidae)] to simultaneous variation in these two factors. From hatching to the fourth instar, larvae were exposed to three temperatures (19 °C, 23 °C, and 28 °C) and fed four artificial diets that differed in protein (P) and carbohydrate (C) content. Within each temperature regime, the effects of the nutrient content (P+C) and ratio (P:C) on development duration, larval mass, growth rate, and activities of digestive proteases, carbohydrases, and lipase were examined. It was found that temperature and food quality had a significant effect on the fitness-related traits and digestive physiology of the larvae. The greatest mass and highest growth rate were obtained at 28 °C on a high-protein low-carbohydrate diet. A homeostatic increase in activity was observed for total protease, trypsin, and amylase in response to low substrate levels in the diet. A significant modulation of overall enzyme activities in response to 28 °C was detected only with a low diet quality. A decrease in the nutrient content and P:C ratio only affected the coordination of enzyme activities at 28 °C, as indicated by the significantly altered correlation matrices. Multiple linear regression analysis showed that variation in fitness traits in response to different rearing conditions could be explained by variation in digestion. Our results contribute to the understanding of the role of digestive enzymes in post-ingestive nutrient balancing.

Use of the sludge obtained from the electrocoagulation process of pumping waters of fishmeal factories for feeding Tenebrio molitor larvae

Sludge residue from pumping water treatment obtained by electrocoagulation process (LEC) in fishmeal factories, was used as a feeding ingredient for Tenebrio molitor larvae. LEC was conditioned by three bioprocesses: fermentation with Lactobacillus casei, fermentation with Sacharomyces, and hydrolysis with pancreatin enzymatic mixture. Soybean isolate was used as a control. Larvae consuming LEC-containing diets presented a higher weight gain rate than the controls. The proximal larvae dry basis composition values of fat, ash, and protein (37.2% ± 2%, 3.9% ± 0.4%, and 50.2% ± 4.9%, respectively) did not present significant intergroup differences. LEC contained 4.2% aluminum and its conditioning through fermentation with lactic bacteria reduced its bioavailability in the larvae, with values similar to those of controls (3.9 ± 0.7 μg Al/g). The iron content in LEC-fed larvae was higher than that in the control group, while their fatty acid profile was only slightly different. These initial results with LEC, which organic material is difficult to hydrate and assimilate, suggest its suitability as a protein source and attractant for a faster growth of T. molitor larvae.