Distinct and diverse anaerobic respiration of methanogenic community in response to MnO2 nanoparticles in anaerobic digester sludge

Boosting Volatile fatty acids (VFAs) production in fermentation microorganisms through genes expression control: Unraveling the role of iron homeostasis transcription factors

Iron (Fe0, Fe (II), and Fe (III)) has been previously documented to upregulate the expression of key genes, enhancing the production of volatile fatty acids (VFAs) to achieve waste/wastewater resource recovery. However, the precise mechanism by why iron influences gene expression remains unclear. This study applied iron-assisted fermentation systems to explore the behind enhancing mechanism by constructing regulon networks among genes, microbes, and transcription factors. In iron-conditioned systems, a significant enhancement in VFAs production and upregulation of genes expression (1.19-3.92 folds) related to organic conversion and the electron transfer chain was observed. Besides, gene co-expression network and Procrustes analysis identified ten hub transcription factors (e.g., arsR, crp, iscR, perR) and their major contributors (genus) (e.g., Paludibacter, Acinetobacter, Tolumonas). Further analysis suggested that most of hub transcription factors were implicated in iron homeostasis regulation, which speculated that the induced iron homeostasis transcription factors probably effectively regulated the expression of genes encoding enzymes involving in VFAs production and electron transfer of functional microbes, in the case of Paludibacter, Acinetobacter, and Tolumonas while regulating the iron homeostasis, resulting in the efficient production of VFAs in iron-conditioned systems. This study might contribute to an enhanced understanding of the underlying genetic mechanisms by why iron influences gene expression regulation of microbes, which also provides a genetic theoretical basis for improving system VFAs production and resource recovery.

Influence of oxygen partial pressure on homoacetogenesis and promotion of acetic acid accumulation through low pH regulation under microaerobic conditions

Homoacetogenesis is an important pathway for bio-utilization of CO2; however, oxygen is a key environmental influencing factor. This study explored the impact of different initial oxygen partial pressures (OPPs) on homoacetogenesis, while implementing low pH regulation enhanced acetic acid (HAc) accumulation under microaerobic conditions. Results indicated that cumulative HAc production increased by 18.2% in 5% OPP group, whereas decreases of 31.3% and 56.0% were observed in 10% and 20% OPP groups, respectively, compared to the control group. However, hydrogenotrophic methanogens adapted to microaerobic environment and competed with homoacetogens for CO2, thus limiting homoacetogenesis. Controlling influent pH 5.0 per cycle increased cumulative HAc production by 18.3% and 18.2% in 5% and 10% OPP groups, respectively, compared with the control group. Consequently, regulating low pH effectively inhibited methanogenic activity under microaerobic conditions, thus increasing HAc production. This study was expected to expand the practical application of homoacetogenesis in bio-utilization of CO2.

Fe-Mn binary oxides improve the methanogenic performance and reduce the environmental health risks associated with antibiotic resistance genes during anaerobic digestion

Increasing evidence indicates that metal oxides can improve the methanogenic performance during anaerobic digestion (AD) of piggery wastewater. However, the impacts of composite metal oxides on the methanogenic performance and risk of antibiotic resistance gene (ARG) transmission during AD are not fully understood. In this study, different concentrations of Fe-Mn binary oxides (FMBO at 0, 250, 500, and 1000 mg/L) were added to AD to explore the effects of FMBO on the process. The methane yield was 7825.1 mL under FMBO at 250 mg/L, 35.2% higher than that with FMBO at 0 mg/L. PICRUSt2 functional predictions showed that FMBO promoted the oxidation of acetate and propionate, and the production of methane from the substrate, as well as increasing the abundances of most methanogens and genes encoding related enzymes. Furthermore, under FMBO at 250 mg/L, the relative abundances of 14 ARGs (excluding tetC and sul2) and four mobile gene elements (MGEs) decreased by 24.7% and 55.8%, respectively. Most of the changes in the abundances of ARGs were explained by microorganisms, especially Bacteroidetes (51.20%), followed by MGEs (11.98%). Thus, the methanogenic performance of AD improved and the risk of horizontal ARG transfer decreased with FMBO, especially at 250 mg/L.

Effect of zero-valent iron (ZVI) and biogas slurry reflux on methane production by anaerobic digestion of waste activated sludge

This study aimed to improve anaerobic digestion (AD) efficiency through the addition of zero-valent iron (ZVI) and biogas slurry. This paper demonstrated that methane production was most effectively promoted at a biogas slurry reflux ratio of 60%. The introduction of ZVI into anaerobic systems does not enhance its bioavailability. However, both biogas slurry reflux and the combination of ZVI with biogas slurry reflux increase the relative abundance of microorganisms involved in the direct interspecific electron transfer (DIET) process. Among them, the dominant microorganisms Methanosaeta, Methanobacterium, Methanobrevibacter, and Methanolinea accounted for over 60% of the total methanogenic archaea. The Tax4Fun function prediction results indicate that biogas slurry reflux and the combination of ZVI with biogas slurry reflux can increase the content of key enzymes in the acetotrophic and hydrotrophic methanogenesis pathways, thereby strengthening these pathways. The corrosion of ZVI promotes hydrogen production, and the biogas slurry reflux provided additional alkaline and anaerobic microorganisms for the anaerobic system. Their synergistic effect promoted the growth of hydrotrophic methanogens and improved the activities of various enzymes in the hydrolysis and acidification phases, enhanced the system's buffer capacity, and prevented secondary environmental pollution. PRACTITIONER POINTS: Optimal methane production was achieved at a biogas slurry reflux ratio of 60%. Biogas slurry reflux in anaerobic digestion substantially reduced discharge. ZVI addition in combination with biogas slurry reflux facilitates the DIET process.

Use of magnetic powder to effectively improve the denitrification employing the activated sludge fermentation liquid as carbon source

Nitrogen removal is often limited in municipal wastewater treatment due to the lack of sufficient carbon source. Utilizing volatile fatty acids (VFAs) from waste activated sludge (WAS) fermentation broth as a carbon source is an ideal alternative to reduce the cost for wastewater treatment plants (WWTPs) and improve denitrification efficiency simultaneously. In this study, an anaerobic system was applied for simultaneous denitrification and WAS fermentation and the addition of magnetic microparticles (MMP) were confirmed to enhance both denitrification and WAS fermentation. Firstly, the addition of MMP increased the nitrate reduction rate by over 25.36% and improve the production of N2. Additionally, the equivalent chemical oxygen demand (COD) of the detected VFAs increased by 7.06%-14.53%, suggesting that MMP promoted the WAS fermentation. The electron transfer efficiency of denitrifies was accelerated by MMP via electron-transporting system (ETS) activity and cyclic voltammetry (CV) experiments, which might result in the promotional denitrification and WAS fermentation performance. Furthermore, the high-throughput sequencing displayed that, MMP enriched key microbes capable of degrading the complex organics (Chloroflexi, Synergistota and Spirochaetota) as well as the typical denitrifies (Bacteroidetes_vadinHA17 and Denitratisoma). Therefore, this study provides a novel strategy to realize simultaneous WAS utilization and denitrification for WWTPs.

Metatranscriptome analysis unveils the mechanisms of zero-valent iron enhancing reactivation of starvation hydrolysis acidification sludge by inducing high-level gene expression

Hydrolysis acidification (HA) is a promising method for wastewater treatment and resource recovery. However, the extended time required for bacterial reactivation after starvation or a change in living conditions often poses a challenge to the efficient operation of the system. Although the addition of zero-valent iron (ZVI) could enhance HA performance, its effects on sludge reactivation in the HA process are not fully understood. In this study, ZVI was employed to accelerate sludge reactivation and its involved genetic mechanisms were unveiled. The results demonstrated that ZVI addition activated the sludge within 35 days with stable HA performance. Sludge characteristics revealed that ZVI improved active biomass, enzyme activity (by 11.4 % ∼ 26.7 %), ETS activity (by 566 %), and cell viability, with a higher concentration of MLVSS, live cells, more microbial byproducts in EPS, and relative abundance of HA bacteria (63.41 %). Moreover, metatranscriptome analysis showed that ZVI upregulated the expression of genes related to key enzymes in carbohydrate degradation metabolism, biosynthesis of electron transfer media such as heme and ubiquinone, and biosynthesis of vital cofactors like vitamin B12 and folate during microbial growth and metabolism. These findings suggest that ZVI enhanced electron transfer, bacterial growth, and metabolism, resulting in effective starch conversion and VFAs generation. Overall, these results deepen our understanding of the mechanism by which ZVI enhanced HA sludge reactivation, providing valuable information for addressing sludge starvation issues in HA systems.

Enhanced anaerobic biodegradation of typical phenolic compounds in coal gasification wastewater (CGW) using biochar: Focusing on the hydrolysis-acidification process and microbial community succession

The aim of this research is to investigate the effects of biochar (BC) on treatment performance (especially hydrolysis-acidification process) and microbial community shifts during anaerobic degradation of typical phenolic compounds in coal gasification wastewater. Compared to the control group, the removal of phenol, p-cresol and 3, 5-xylenol was gradually enhanced when increasing the BC addition within the test dosage (1-5 g/L). The biodegradation of phenol and p-cresol was significantly enhanced by BC addition while limited improvement for 3, 5-xylenol. The addition of BC significantly accelerated the hydrolysis-acidification process with the hydrolytic removal of phenol improved by 69.14%, the microbial activity was enhanced by 57.01%, and the key hydrolase bamA gene was enriched by 117.27%, respectively. Compared to 1-2 g/L dose, more protein-like and humic acid-like substances were secreted with 5 g/L BC, which probably contributed to higher extracellular electron transfer efficiency. In addition, phenol degrading bacteria (Syntrophorhabdus, Dysgonomonas, Holophaga, etc.) and electroactive microorganisms (Geobacter, Syntrophorhabdus, Methanospirillum, etc.) were enriched by BC addition. The functional genes related to carboxylation, benzoylation and ring cleavage processes of benzoyl-CoA pathway were potentially activated by BC.

The degradation of high emulsified oil wastewater in an intermittently-aerated MBBR packed with magnetic polystyrene particles

This work aims to explore the effects of the magnetic polystyrene particles (MPS) on contaminants removal of the high emulsified oil wastewater. 26 days intermittently-aerated progress illustrated that COD removal efficiency and the resistance to the shock loading was promoted in the presence of MPS. Gas chromatography (GC) results also indicated that MPS enhanced the number of organic species reduced. According to the cyclic voltammetry test, conductive MPS appeared special redox performance which was considered could to facilitate the extracellular electron transfer. Furthermore, MPS dosing accelerated the electron-transporting system (ETS) activity by 24.91% compared the control. Based on the superior performance above, the conductivity of MPS is considered to be responsible for the enhanced organic removal efficiency. Moreover, the high-throughput sequencing displayed that electroactive Cloacibacterium and Acinetobacter accounted for a higher proportion in the MPS reactor. Additionally, Porphyrobacter and Dysgonomonas which were capable of degrading organics were also enriched more by MPS. To sum up, MPS is a promising additive to enhance the organic substances removal for the high emulsified oil wastewater.

Conductive materials enhance microbial salt-tolerance in anaerobic digestion of food waste: Microbial response and metagenomics analysis

Previous studies have shown that high salinity environments can inhibit anaerobic digestion (AD) of food waste (FW). Finding ways to alleviate salt inhibition is important for the disposal of the growing amount of FW. We selected three common conductive materials (powdered activated carbon, magnetite, and graphite) to understand their performance and individual mechanisms that relieve salinity inhibition. Digester performances and related enzyme parameters were compared. Our data revealed that under normal and low salinity stress conditions, the anaerobic digester ran steady without significant inhibitions. Further, the presence of conductive materials promoted conversion rate of methanogenesis. This promotion effect was highest from magnetite > powdered activated carbon (PAC) > graphite. At 1.5% salinity, PAC and magnetite are beneficial in maintaining high methane production efficiency while control and the graphite added digester acidified and failed rapidly. Additionally, metagenomics and binning were used to analyze the metabolic capacity of the microorganisms. Some species enriched by PAC and magnetite possessed higher cation transport capacities and were to accumulate compatible solutes. PAC and magnetite promoted direct interspecies electron transference (DIET) and syntrophic oxidation of butyrate and propionate. Also, the microorganisms had more energy available to cope with salt inhibition in the PAC and magnetite added digesters. Our data imply that the promotion of Na+/H+ antiporter, K+ uptake, and osmoprotectant synthesis or transport by conductive materials may be crucial for their proliferation in highly stressful environments. These findings will help to understand the mechanisms of alleviate salt inhibition by conductive materials and help to recover methane from high-salinity FW.

Sequentially modified carbon felt for enhanced p-nitrophenol biodegradation through direct interspecific electron transfer

The widely applied aromatic nitration in modern industry leads to toxic p-nitrophenol (PNP) in environment. Exploring its efficient degradation routes is of great interests. In this study, a novel four-step sequential modification procedure was developed to increase the specific surface area, functional group, hydrophilicity, and conductivity of carbon felt (CF). The implementation of the modified CF promoted reductive PNP biodegradation, attaining 95.2 ± 0.8% of removal efficiency with less accumulation of highly toxic organic intermediates (e.g., p-aminophenol), compared to carrier-free and CF-packed biosystems. The constructed anaerobic-aerobic process with modified CF in 219-d continuous operation achieved further removal of carbon and nitrogen containing intermediates and partial mineralization of PNP. The modified CF promoted the secretion of extracellular polymeric substances (EPS) and cytochrome c (Cyt c), which were essential components to facilitate direct interspecies electron transfer (DIET). Synergistic relationship was deduced that glucose was converted into volatile fatty acids by fermenters (e.g., Longilinea and Syntrophobacter), which donated electrons to the PNP degraders (e.g., Bacteroidetes_vadinHA17) through DIET channels (CF, Cyt c, EPS) to complete PNP removal. This study proposes a novel strategy using engineered conductive material to enhance the DIET process for efficient and sustainable PNP bioremediation.

Effect of riboflavin and carbon black co-modified fillers coupled with alkaline pretreatment on anaerobic digestion of waste activated sludge

Additional various carbon and free riboflavin could improve anaerobic digestion of waste activated sludge (WAS). However, these substances were not reused. In this study, a reusable riboflavin and carbon black (RCB) co-modified filler was developed and combined with alkaline pretreatment for enhancing the production of volatile fatty acids (VFAs) and methane during anaerobic digestion of WAS. The results showed that RCB-modified fillers exhibited a promoting effect on the reduction of alkali-pretreated WAS. The amounts of the accumulated VFAs mainly containing acetate and the produced methane rose with the increased concentration of immobilized riboflavin (0-0.75 g/L) in the presence of 4 g/L carbon black. When the alkaline pretreatment time of WAS increased from 3 d to 8 d, the amount of methane production increased from 22.8% to 63.9% in the presence of 0.75 g/L riboflavin and 4 g/L carbon black compared with that without RCB-modified fillers. Moreover, 0.75 g/L riboflavin and 4 g/L carbon black had a synergetic effect on promoting methane production via broadening extracellular electron transfer pathways. During this process, microbial dehydrogenase activity, electron transport system activity and coenzyme F420 were enhanced. Microbial community analysis showed that RCB-modified filler addition promoted the enrichment of Syntrophomonas and Pseudomonas involved in direct interspecies electron transfer (DIET). These results indicated that DIET establishment was accelerated. Meanwhile, the populations of acetic acid-producing bacteria including Rikenellaceae_RC9_gut_group and Proteiniphilum, aceticlastic and acid-tolerant methanogenic archaea including Methanosarcina and Methanosaeta, RumEn_M2 were increased. These results indicate that RCB-modified fillers coupled with alkaline pretreatment is an effective method to promote the production of methane during anaerobic digestion of WAS.

Response mechanisms of anaerobic fermentative sludge to zinc oxide nanoparticles during medium-chain carboxylates production from waste activated sludge

The conversion of waste activated sludge (WAS) into medium chain carboxylates (MCCs) has attracted much attention, while investigations of the impacts of ZnO nanoparticles (NPs) on this process are sparse. The present study showed that 8 mg/g-TSS of ZnO NPs have little effects on all key steps and the activity of anaerobes, and finally leading to unchanged MCCs production. Although 30 mg/g-TSS of ZnO NPs weakly inhibited the hydrolysis, acidogenesis, and chain elongation process, WAS solubilization was enhanced, thus, the improvement was enough to offset inhibition, also resulting in an insignificant impact on overall MCCs production. However, the improvement with ZnO NPs dosages above 100 mg/g-TSS was not sufficient to offset the biological inhibition, thus inducing negative impact on overall MCCs production. The decline of EPS induced by Zn²⁺ and generation of excessive reactive oxygen species (ROS) were the main factors responsible for the inhibitory effects of ZnO NPs on lower activity of anaerobes. For chain elongation process, the discriminative Clostridium IV (as MCCs-forming bacteria) with a strong adaptation to ZnO NPs (300 mg/g-TSS) was observed. The present study provided a deep understanding related to the effects of ZnO NPs on the production of MCCs production from WAS and identified a zinc resistance anaerobe, which would be significant for the evaluation of influence and alleviation of inhibition induced by ZnO NPs on the carbon cycle of organic wastes.

Nonmonotonic effect of CuO nanoparticles on medium-chain carboxylates production from waste activated sludge

The growing applications of CuO nanoparticles (NPs) in industrial and agriculture has increased their concentrations in wastewater and subsequently accumulated in waste activated sludge (WAS), raising concerns about their impact on reutilization of WAS, especially on the medium-chain carboxylates (MCCs) production from anaerobic fermentation of WAS. Here we showed that CuO NPs at 10-50 mg/g-TS can significantly inhibit MCCs production, and reactive oxygen species generation was revealed to be the key factor linked to the phenomena. At lower CuO NPs concentrations (0.5-2.5 mg/g-TS), however, MCCs production was enhanced, with a maximum level of 37% compared to the control. The combination of molecular approaches and metaproteomic analysis revealed that although low dosage CuO NPs (2.5 mg/g-TS) weakly inhibited chain elongation process, they displayed contributive characteristics both in WAS solubilization and transport/metabolism of carbohydrate. These results demonstrated that the complex microbial processes for MCCs production in the anaerobic fermentation of WAS can be affected by CuO NPs in a dosage-dependent manner via regulating microbial protein expression level. Our findings can provide new insights into the influence of CuO NPs on anaerobic fermentation process and shed light on the treatment option for the resource utilization of CuO NPs polluted WAS.

Dioctyl phthalate enhances volatile fatty acids production from sludge anaerobic fermentation: Insights of electron transport and metabolic functions

As one of the most widely used phthalate plasticizers, dioctyl phthalate (DOP) has been detected in wastewater and accumulates in sludge through wastewater treatment, which may adversely affect further sludge treatment. However, the role of DOP on sludge anaerobic fermentation and its mechanism are not yet clear. Therefore, this study focused on the effect of DOP on the volatile fatty acids (VFAs) generation via the anaerobic fermentation of sludge. The results demonstrated that the presence of DOP had a considerable contribution to the generation of VFAs, and the maximum production of VFAs reached 4769 mg COD/L at 500 mg/kg DOP, which was 1.57 folds that of the control. Mechanistic investigation showed that DOP mainly enhanced the hydrolysis, acidification and related enzymes activities of sludge. VFAs-producing microorganisms (e.g., Clostridium and Conexibacter) were also enriched under DOP exposure. Importantly, the presence of DOP increased the electron transfer activity by 26 %, consequently facilitating the organics conversion and fermentation process. Notably, the functional gene expressions involved in substrate metabolism and VFAs biosynthesis were enhanced with DOP, resulting in increased VFAs production from sludge. The results obtained in this study offered a new strategy for the control of pollutants and the recycling of valuable products from sludge.

Dissimilatory manganese reduction facilitates synergistic cooperation of hydrolysis, acidogenesis, acetogenesis and methanogenesis via promoting microbial interaction during anaerobic digestion of waste activated sludge

Anaerobic digestion (AD) of waste activated sludge (WAS) is commonly limited to poor synergistic cooperation of four stages including hydrolysis, acidogenesis, acetogenesis and methanogenesis. Dissimilatory metal reduction that induced by metal-based conductive materials is promising strategy to regulate anaerobic metabolism with the higher metabolic driving force. In this study, MnO₂ as inducer of dissimilatory manganese reduction (DMnR) was added into WAS-feeding AD system for mediating complicated anaerobic metabolism. The results demonstrated that main operational performances including volatile solid (VS) degradation efficiency and cumulative CH₄ production with MnO₂ dosage of 60 mg/g·VS reached up to maximum 53.6 ± 3.4% and 248.2 ± 10.1 mL/g·VS while the lowest operational performances in control group (38.5 ± 2.8% and 183.5 ± 8.5 mL/g·VS) was originated from abnormal operation of four stages. Furthermore, high-throughput 16 S rRNA pyrosequencing revealed that enrichment of dissimilatory manganese-reducing contributors and methanogens such as Thermovirga, Christensenellaceae_R_7_group and Methanosaeta performed the crucial role in short-chain fatty acids (SCFAs) oxidation and final methanogenesis, which greatly optimized operational environment of hydrolysis, acidogenesis and acetogenesis. More importantly, analysis of functional genes expression proved that abundances of genes encoding enzymes participated in acetate oxidation, direct interspecies electron transfer (DIET) and CO₂ reduction pathway were simultaneously up-regulated with the optimum MnO₂ dosage, suggesting that DMnR with SCFAs oxidation as electron sink could benefit stable operation of four stages via triggering effective DIET-based microbial interaction mode.

Effects of Fe3O4 nanoparticles on anaerobic digestion enzymes and microbial community of sludge

Fe₃O₄ nanoparticles (NPs) have potential effects on the anaerobic digestion of excess sludge. The effects of different concentrations of Fe₃O₄ NPs (0, 100, 200, 400 and 600 mg/L) on enzymes and microorganisms in anaerobic digestion were studied to explore the mechanism of the effect of Fe₃O₄ NPs on anaerobic digestion. The results showed that 100, 200 and 400 mg/L Fe₃O₄ NPs could promote anaerobic digestion, and 200 mg/L Fe₃O₄ NPs had the most obvious promoting effect. The activities of protease, cellulase, dehydrogenase, acetic kinase and coenzyme F420 in the 200 mg/L Fe₃O₄ NPs group reached 120 U/mg VS, 71.75 U/g VS, 135 U/mL, 94 mol/L, 1.37 umol/g VSS, respectively, which were 3.8, 1.5, 1.2, 1.2 and 1.6 times of the blank group, respectively. However, when the concentration of Fe₃O₄ NPs reached 600 mg/L, the activities of cellulase, dehydrogenase and acetic kinase were lower than those of the blank group, and anaerobic digestion was inhibited. The above conclusions can also be confirmed by high-throughput sequencing. The abundance of longilinea and ornatilina in the 200 mg/L Fe₃O₄ NPs group was 8.8% and 4.1% respectively, and methanthrix abundance was 69%, which was more conducive to decomposition acetic acid into CH₄.Highlights To explore the effects of Fe3O4 NPS on enzyme activity and microorganisms.200mg/L Fe₃O₄ NPs could significantly promote the activity of enzyme.200mg/L Fe₃O₄ NPs could promote the diversity of bacterial and archaeal communities.600mg/L Fe₃O₄ NPs could inhibit some enzyme activities and microbial community diversity.

Metagenomic analysis reveals the size effect of magnetite on anaerobic digestion of waste activated sludge after thermal hydrolysis pretreatment

Although magnetite has been widely investigated in anaerobic digestion (AD), its role in the practical AD of waste-activated sludge (WAS) after thermal hydrolysis pretreatment (THP) and its size effect remain unclear. In this study, magnetite with four different particle sizes was added during the AD of WAS after THP. With the reduction of magnetite particle size, cumulative methane production was increased, while the optimal dosage of magnetite decreased, with 0.1 μm magnetite at an optimal dosage of 2 g/L achieving the highest cumulative methane production increase of 111.97 % compared with the blank group (without magnetite). Smaller magnetite particles increased α-glucosidase and protease activities, coenzyme F₄₂₀ concentration, and electron-transport system activity (20.30 %, 173.02 %, 60.39 % and 158.08 % higher respectively than the blank group). The size of magnetite also influenced the establishment of direct interspecies electron transfer (DIET) during AD. Based on the analysis of the pilA gene abundance, magnetite with a large particle size could promote the formation of e-pili in syntrophic electroactive bacteria (Clostridium, Syntrophomonas, and Pseudomonas) and methanogens (Methanospirillum), thereby completing electron transfer. However, small-sized magnetite particles stimulated DIET by enhancing the secretion of conductive proteins in extracellular polymeric substances and membrane-bound enzymes (Fpo) in Methanosarcina.

Towards BioMnOx-mediated intra/extracellular electron shuttling for doxycycline hydrochloride metabolism in Bacillus thuringiensis

Doxycycline hydrochloride (DCH) could be continuously removed by Bacillus thuringiensis S622 with the in-situ biogenic manganese oxide (BioMnOx) via oxidizing/regenerating. The DCH removal rate was significantly increased by 3.01-fold/1.47-fold at high/low Mn loaded via the integration of biological (intracellular/extracellular electron transfer (IET/EET)) and abiotic process (BioMnOx, Mn(III) and •OH). BioMnOx accelerated IET via activating coenzyme Q to enhance electrons transfer (ET) from complex I to complex III, and as an alternative electron acceptor for respiration and provide another electron transfer transmission channel. Additionally, EET was also accelerated by stimulating to secrete flavins, cytochrome c (c-Cyt) and flavin bounded with c-Cyt (Flavins & Cyts). To our best knowledge, this is the first report about the role of BioMnOx on IET/EET during antibiotic biodegradation. These results suggested that Bacillus thuringiensis S622 incorporated with BioMnOx could adopt an alternative strategy to enhance DCH degradation, which may be of biogeochemical and technological significance.

Biofilm formation during wastewater treatment: Motility and physiological response of aerobic denitrifying bacteria under ammonia stress based on surface plasmon resonance imaging

A bacterial image analysis system based on surface plasmon resonance imaging was established to investigate the effect of bacterial motility on biofilm formation under high ammonia nitrogen at the single-cell level. The results showed that the bacterial mean rotation speed and vertical motility distance decreased with the increasing concentration of ammonia nitrogen. Ammonia nitrogen inhibited the metabolic activity of the bacteria, decreasing bacterial motility. Bacterial motility was negatively correlated with the biofilm-formation ability. The biofilm formation ability of Enterobacter cloacae strain HNR exposed to ammonia nitrogen was enhanced by reducing its movement and promoting EPS secretion. Genes related to the tricarboxylic acid cycle and oxidative phosphorylation were down-regulated, indicating inhibition of microbial energy metabolism. Genes related to bacterial secretion and lipopolysaccharide synthesis were up-regulated, facilitating the formation of biofilms and enabling the bacteria to resist ammonia nitrogen stress. This study provides new insights into the biofilm formation under ammonia stress.

Performance and Mechanism of Fe3O4 Improving Biotransformation of Waste Activated Sludge into Liquid High-Value Products

This study demonstrated that Fe₃O₄ simultaneously improves the total production and formation rate of medium-chain fatty acids (MCFAs) and long-chain alcohols (LCAs) from waste activated sludge (WAS) in anaerobic fermentation. Results revealed that when Fe₃O₄ increased from 0 to 5 g/L, the maximal MCFA and LCA production increased significantly, and the optimal fermentation time was also remarkably shortened from 24 to 9 days. Moreover, Fe₃O₄ also enhanced WAS degradation, and the corresponding degradation rate in the fermentation system increased from 43.86 to 72.38% with an increase in Fe₃O₄ from 0 to 5 g/L. Further analysis showed that Fe₃O₄ promoted the microbe activities of all the bioprocesses (including hydrolysis, acidogenesis, and chain elongation processes) involved in the MCFA and LCA production from WAS. Microbial community analysis indicated that Fe₃O₄ increased the abundances of key microbes involved in abovementioned bioprocesses correspondingly. Mechanistic investigations showed that Fe₃O₄ increased the conductivity of the fermented sludge, providing a better conductive environment for the anaerobic microbes. The redox cycle of Fe(II) and Fe(III) existed in the fermentation system with Fe₃O₄, which was likely to act as electron shuttles to conduct electron transfer (ET) from the electron donor to the acceptor, thus increasing ET efficiency. This study provides an effective method for enhancing the biotransformation of WAS into high-value products, potentially bringing economic benefits to WAS treatment.

Recovery of Iron-Dependent Autotrophic Denitrification Activity from Cell-Iron Mineral Aggregation-Induced Reversible Inhibition by Low-Intensity Ultrasonication

Iron-dependent autotrophic denitrification (IDAD) has garnered increasing interests as an efficient method for removing nitrogen from wastewater with a low carbon to nitrogen ratio. However, an inevitable deterioration of IDAD performance casts a shadow over its further development. In this work, the hidden cause for such a deterioration is uncovered, and a viable solution to this problem is provided. Batch test results reveal that the aggregation of microbial cells and iron-bearing minerals induced a cumulative and reversible inhibition on the activity of IDAD sludge. Extracellular polymeric substances were found to play a glue-like role in the cell-iron mineral aggregates, where microbial cells were caged, and their metabolisms were suppressed. Adopting low-intensity ultrasound treatment efficiently restored the IDAD activity by disintegrating such aggregates rather than stimulating the microbial metabolism. Moreover, the ultrasonication-assisted IDAD bioreactor exhibited an advantageous nitrogen removal efficiency (with a maximum enhancement of 72.3%) and operational stability compared to the control one, demonstrating a feasible strategy to achieve long-term stability of the IDAD process. Overall, this work provides a better understanding about the mechanism for the performance deterioration and a simple approach to maintain the stability of IDAD.

Mechanism study of improving anaerobic co-digestion performance of waste activated sludge and food waste by Fe3O4

A large amount of waste activated sludge (WAS) and food waste (FW) are produced every year in China. Anaerobic co-digestion is considered to be an effective way to solve this problem. This study applied FW/WAS mixture as co-substrate to create different digestive environment, aiming to understand the mechanism of Fe₃O₄ particles in promoting AD performance. The results showed that the addition of Fe₃O₄ presented various performances when facing different digestive acidification stress brought by different mixing ratios of WAS and FW. Methanogenic pathways and microbial communities varied with substrates' properties. For group A (WAS mono-digestion), the acetoclastic methanogens dominated, 20 mg/g VS (according to the iron element) Fe₃O₄ could promote methane production, while 200 mg/g VS Fe₃O₄ would inhibit microbial activity. The promoted methane production by Fe₃O₄ was attributable to the promotion of sludge hydrolysis. For group B (WAS: FW = 1:0.5, based on VS addition, similarly hereinafter), Fe₃O₄ triggered direct interspecific electron transfer (DIET) between bacteria and methanogens. For group C (WAS: FW = 1:1), the hydrogenotrophic methanogens dominated, bacteria excreted more non-conductive polysaccharides in EPS to resist unfavorable environment, thereby it prevented their contact with Fe₃O₄ particles. So, it was difficult for Fe₃O₄ to trigger DIET and promote the digestive performance of batch experiments in such condition.

Rapid initiation of methanogenesis in the anaerobic digestion of food waste by acclimatizing sludge with sulfidated nanoscale zerovalent iron

Although coupling of sulfidated nanoscale zero-valent iron (S-nZVI) into anaerobic digestion of food waste (FW) for improving methanogenesis has been reported, the specific role of S-nZVI during start-up process and its influence on subsequent methanogenesis and system stability remains unknown. In this study, S-nZVI was added into the unacclimatized sludge system to investigate its influence on microbial acclimatization and methanogenic performance. During acclimatization phase, CH₄ production improved and VFAs transformation facilitated with the addition of S-nZVI. Furthermore, enzymatic activity analysis and electrochemical measurements presented direct evidence that electron transfer capacity of acclimatized sludge was significantly improved. S-nZVI favored the transition of microbial community to a robust and specialized population. During evaluation phase, acclimatized sludge still exhibited strong methanogenic ability, but the microbial community inevitably changed under the stress of FW. This research provides a novel perspective on initiating anaerobic digestion of FW for shorter start-up time and stronger methanogenesis.

Effects of nano metal oxide particles on activated sludge system: Stress and performance recovery mechanism

Nano metal oxide particles (NMOPs) are widely used in daily life because of their superior performance, and inevitably enter the sewage treatment system. Pollutants in sewage are adsorbed and degraded in wastewater treatment plants (WWTPs) depending on the microbial aggregates of activated sludge system to achieve sewage purification. NMOPs may cause ecotoxicity to the microbial community and metabolism due to their complex chemical behavior, resulting in a potential threat to the safe and steady operation of activated sludge system. It is of great significance to clarify the influencing mechanism of NMOPs on activated sludge system and reduce the risk of WWTPs. Herein, we first introduce the physicochemical behavior of six typical engineering NMOPs including ZnO, TiO₂, CuO, CeO₂, MgO, and MnO₂ in water environment, then highlight the principal mechanisms of NMOPs for activated sludge system. In particular, the performance recovery mechanisms of activated sludge systems in the presence of NMOPs and their future development trends are well documented and discussed extensively. This review can provide a theoretical guidance and technical support for predicting and evaluating the potential threat of NMOPs on activated sludge systems, and promoting the establishment of effective control strategies and performance recovery measures of biological wastewater treatment process under the stress of NMOPs.

Biochar addition supports high digestion performance and low membrane fouling rate in an anaerobic membrane bioreactor under low temperatures

The enhancement effects of biochar to an anaerobic membrane bioreactor (AnMBR) treating sewage at low temperatures was investigated in this study through analyzing organics removal, digestion performance, mixed liquor properties, membrane resistance, and foulant compositions. The chemical oxygen demand (COD) removal efficiency and the COD converted to methane rate increased by more than 12.5% at 10 °C, mainly because of the promotion of biochar to volatile fatty acids degradation. Although biochar caused higher dissolved organic matter (DOM) concentration in the AnMBR, it improved the filtration property of the bulk sludge and absorbed the hydrophobic DOM. The decreased filtration resistance assisted by biochar leads to a prolonged membrane operation duration over 200%. Surface foulants, especially cake foulants, were largely mitigated by the enhanced scouring intensity of mixed liquor at the membrane surface, and hence, decreasing the cake/gel foulants ratio.

Insights on the inhibition of anaerobic digestion performances under short-term exposure of metal-doped nanoplastics via Methanosarcina acetivorans

Anaerobic digestion is an attractive waste treatment technology, achieving both pollution control and energy recovery. Though the inhibition of polystyrene nanoplastics in anaerobic granular sludge is well studied, no direct evidence has been found on the interaction of methanogens and nanoplastics. In this study, to characterize the location of nanoplastics, Pd-doped polystyrene nanoplastics (Pd-PS) were used to explore the inhibition mechanism of anaerobic sludge through short-term exposure to Methanosarcina acetivorans C2A. The results showed that Pd-PS inhibited the methanogenesis of the anaerobic sludge, and the methane production decreased as the Pd-PS increased, with a 14.29% reduction at the Pd-PS concentration of 2.36 × 10¹⁰ particles/mL. Also, Pd-PS interacted with the protein in the extracellular polymeric substances (EPS). Furthermore, Pd-PS inhibited the methanogenesis of M. acetivorans C2A without exhibiting an evident reduction in the growth. The inhibition of Pd-PS on methane was due to the inhibition of methane production related genes, MtaA and mcrA. These results provide potential explication for the inhibition of nanoplastics on the methanogens, which will fulfill the knowledge on the stability of methanogens under the short-term exposure of nanoplastics.

Integrating microbial electrolysis cell based on electrochemical carbon dioxide reduction into anaerobic osmosis membrane reactor for biogas upgrading

It has been reported that anaerobic osmosis membrane bioreactors have the potential for energy recovery since dissolved methane was almost rejected by commercial forward osmosis membranes. Notwithstanding, upgraded biogas has to be achieved by removing as much carbon dioxide as possible. In this study, a novel anaerobic osmotic membrane bioreactor-microbial electrolysis cell (AnOMBR-MEC) system was developed for simultaneous biogas upgrading and wastewater treatment. The AnOMBR-MEC elicited an excellent and stable soluble chemical oxygen demand and phosphorus removal. As the experiment progressed, unwanted carbon dioxide produced from biogas was reduced to formate using a SnO₂ nanoparticles electrocatalytic cathode in an electrocatalytic-assisted MEC, with the highest faradic efficiency of formate being 85% at 1.2V. Compared to AnOMBR, the methane content increased from 55% to 90% at the end of operation and methane yield experienced a1.6-fold increment in the AnOMBR-MEC. Microbial community analysis revealed that hydrogenotrophic methanogens (e.g. Methanobacterium and Methanobrevibacter) converted the produced H₂ and formate to methane at saline conditions. These results have demonstrated an efficient strategy based on the integration of an electrocatalytic-assisted MEC into AnOMBR for upgrading biogas, enhancing methane yield and wastewater treatment.

Efficient removal of 17α-ethinylestradiol from secondary wastewater treatment effluent by a biofilm process incorporating biogenic manganese oxide and Pseudomonas putida strain MnB1

This study proposes a biofilm process to immobilize biogenic manganese oxide (BMO) and Pseudomonas putida MnB1 (BMO-MnB1), which shows excellent synergistic effects for 17α-ethinylestradiol (EE2) from secondary wastewater treatment effluent (WWTE). Modified granular activated carbon (M-GAC) was used as the packing carrier, inoculated with Pseudomonas putida MnB1 and Mn(II) to form the BMO-MnB1 biofilm. Feasibility tests were performed to compare the EE2 removal efficiency with that of the conventional biofilm process (BAC) for heterogeneous microbial communities. Results show that in the BAC, EE2 was removed mainly by adsorption, with biodegradation contributing only slightly to the overall performance. In contrast, the BMO-MnB1 biofilter outperformed the BAC. Furthermore, less than 4% of the total EE2 removed was extracted from the biofilter medium over 150 days of operation, confirming that EE2 was biodegraded by P. putida MnB1 or chemically oxidized by BMO. Our results suggest that BMO-MnB1 biofilm processes have high potential for practical applications in removal of endocrine disrupting compounds from wastewater effluent.

Effects of Fe-Mn-modified biochar addition on anaerobic digestion of sewage sludge: Biomethane production, heavy metal speciation and performance stability

This study investigated the effects of MnFe₂O₄-biochar on sludge anaerobic digestion performance, methane production and heavy metal stabilization. The highest cumulative methane yield was achieved when the MnFe₂O₄-biochar dose was 1.50 g, which was 55.86% higher than control. A suitable dose of MnFe₂O₄-biochar stimulated methanogenic activities and improved methane yield, whereas excessive addition shows an inhibitory effect on anaerobic digestion. MnFe₂O₄-biochar addition significantly enhanced the biodegradation of organic matter, as the average volatile fatty acids degradation rate increased by 35.44%, compared to the control. Chemical speciation analyses demonstrated that MnFe₂O₄-biochar addition was more helpful for immobilization and risk reduction of heavy metals in sewage sludge. Simultaneously, microbial community analysis indicated that MnFe₂O₄-biochar obviously enriched acetoclastic methanogens Methanosarcina that capable of participating in direct interspecies electron transfer, which could accelerate substrate decomposition and methane production. These findings supply useful information for the resource utilization of sewage sludge.

Enhanced two-phase anaerobic digestion of waste-activated sludge by combining magnetite and zero-valent iron

Previous studies have found that magnetite can promote the hydrolysis-acidification but inhibit the methanogenesis, while zero-valent iron (ZVI) only promoted the methanogenesis. Therefore, a new two-phase anaerobic digestion model, in which magnetite was added to the first phase, and ZVI was added to the second phase, was proposed to promote both hydrolysis-acidification and methanogenesis and avoid magnetite inhibition. The results showed that in the new model, methane production was improved by 10.2% and 18.1% and chemical oxygen demand (COD) removal was improved by 7.9% and 10.9% compared with reactors that included only magnetite and only ZVI, respectively. In the new model reactors, inhibition of methanogenesis by magnetite was avoided compared with that of the magnetite-only reactors, and hydrolysis efficiency was improved via dissimilatory iron reduction (DIR) compared with that of ZVI-only reactors. The data on volatile fatty acids (VFAs), coenzyme F420 and electron transfer system (ETS) further confirmed these conclusions.

Optimization ofS/Fe ratio for enhanced nitrobenzene biological removal in anaerobicSystem amended withSulfide-modified nanoscale zerovalent iron

Anaerobic reduction of nitrobenzene (NB) can be efficiently enhanced bySupplementing withSulfide-modified nanoscale zerovalent iron (S-nZVI). In thisStudy,S/Fe ratio ofS-nZVI was further optimized for enhancing biological NB removal in anaerobicSystem amended withS-nZVI and inoculated by anaerobicSludge. The results indicated that the performance andStability of the coupled anaerobicSystem for NB reduction and aniline formation were remarkably improved byS-nZVI atS/Fe molar ratio of 0.3 (0.3S-nZVI). TheSecretion of extracellular polymericSubstances (EPS), transformation of volatile fatty acids (VFAs), yield of methane and activity ofSeveral key enzymes could be efficiently improved by 0.3S-nZVI. Furthermore,Species related to NB reduction, fermentation, electroactivity and methanogenesis could be enriched in 0.3S-nZVI coupled anaerobicSystem, with remarkable improvement in the biodiversity observed. ThisStudy demonstrated thatSulfidation would be a promising method to improve the performance of nZVI in coupled anaerobicSystems for the removal of recalcitrant nitroaromatic compounds from wastewater.

Exclusive microbially driven autotrophic iron-dependent denitrification in a reactor inoculated with activated sludge

Autotrophic iron-dependent denitrification (AIDD) is arising as a promising process for nitrogen removal from wastewater with a low carbon to nitrogen ratio. However, there is still a debate about the existence of such a process in activated sludge systems. This work provides evidence and elucidated the feasibility of autotrophic Fe(II)-oxidizing nitrate-reducing culture for nitrogen removal by long-term reactor operation, batch experimental verification, unstructured kinetic modeling and microbial community analyses. A relatively stable nitrate removal rate was achieved coupled with the oxidation of ferrous ions in 3-month operation of reactor. The kinetic modeling suggests that the iron oxidation was a growth-associated process in AIDD. Utilization of extracellular polymeric substances (and/or soluble microbial products) as electron donor for denitrification by heterotrophic denitrifiers was not mainly responsible for nitrogen removal in the reactor. After long-term operation of the reactor with activated sludge as inoculum, the enrichment culture KS-like consortium, dominated by Fe(II) oxidizer, Gallionellaceae, was successfully acclimated for autotrophic Fe(II)-oxidizing nitrate reduction. This work extents our understanding about the existence of such an autotrophic Fe(II)-oxidizing nitrate-reducing culture in both natural and engineered systems, and opens a door for its potential application in wastewater treatment.

No difference in inhibition among free acids of acetate, propionate and butyrate on hydrogenotrophic methanogen of Methanobacterium formicicum

Free volatile fatty acids such as free acetic acid (FAA) and free butyrate acid (FBA) are true inhibitors of hydrogenotrophic methanogens (HM) in mixed culture. However, their inhibitory effects on pure culture of HM remain unclear. In this study, a typical HM of Methanobacterium formicicum demonstrated no difference in toxicity conferred by FAA, free propionate acid (FPA), or FBA in regard to the specific methanogenic activity (SMA) based on the C_50% (0.19, 0.17, and 0.23 g/L, respectively) and recoverable concentration values (0.97, 0.69, and 0.61 g/L, respectively). These results were within the same order of magnitude. The concentrations of FAA, FBA, and FPA all correlated well with the SMA values according to the inhibition model. Additionally, changes in the activity of the electron transport system also agreed well with the trend in the SMA variation. Together, the results of this study provide a benchmark to control methanogenesis during industrial applications.

Nitrate stimulation of N-Methylpyrrolidone biodegradation by Paracoccus pantotrophus: Metabolite mechanism and Genomic characterization

Due to the toxicological nature of N-methylpyrrolidone (NMP), the conventional anaerobic bioprocess is quite ineffective for NMP removal from wastewater. In order to achieve effective NMP biodegradation under anoxic condition, Paracoccus pantotrophus NJUST38 was isolated for the first time. The supplementation of nitrate into anoxic system resulted in complete removal of 5 mM NMP by NJUST38 within 11 h compared to 24% in the anaerobic control system in the absence of nitrate. Genome characterization revealed that NMP biodegradation catalyzed by several key enzymes/genes, including N-methylhydantoin amidohydrolase (hyuB), methyltransferase (cobA), 4-aminobutyrate-2-oxoglutarate transaminase (gabT), succinate-semialdehyde dehydrogenase (gabD) and so on. NMP biodegradation pathway was proposed based on several intermediates, where NMP was biodegraded mainly for providing electrons and reducing power to support microbial denitrification through tricarboxylic acid (TCA) cycle. The proposed mechanism should aid our mechanistic understanding of NMP biodegradation by Paracoccus pantotrophus and the development of sustainable bioremediation strategies.

Coupling the phenolic oxidation capacities of a bacterial consortium and in situ-generated manganese oxides in a moving bed biofilm reactor (MBBR)

Phenolic wastewater containing phenol and 4-chlorophenol pose a risk to the environment and to human health. Treating them using chemical-biological coupling method is challenging. In this study, manganese oxidizing bacteria (MnOB) were enriched in moving bed biofilm reactor (MBBR) using synthetic phenol wastewater (800 mg L^-1) to facilitate in situ production of biogenic manganese oxides (BioMnOx) after 90 days of operation. Then, 4-chlorophenol (4-CP) was added to the MBBR to simulate mixed phenolic wastewater. Comparing the MBBR (R1) without feeding Mn(II) and the MBBR with BioMnOx (R2) production, R2 exhibited robust phenol and 4-CP removal performance. 16S rRNA gene sequencing was employed to determine the microbial community. Subsequently, a batch experiment demonstrated that partly purified BioMnOx does not exhibits a capacity for phenol removal, but can efficiently remove 4-CP. Interestingly, 5-chloro-2-hydroxymuconic semialdehyde was found in the products of 4-CP degradation, which was the unique product of 4-CP degradation by catechol 2,3-dioxygenase (C23O). In both reactors, only catechol 1,2-dioxygenase (C12O) activity from microbes can be detected, indicating that the existence of BioMnOx provide an alternative pathway in addition to microbe driven 4-CP degradation. Overall, MBBR based MnOB enrichment under high phenol concentration was achieved, and 4-CP/phenol removal can be accelerated by in situ-formed BioMnOx. Considering the C23O-like activity of BioMnOx, our results suggest a new coupling strategy that involves nanomaterials and a microbial consortium.

The performance and microbial community in response to MnO2 nanoparticles in anammox granular sludge

The response of anaerobic ammonium oxidation (anammox) process and granular sludge in the upflow anaerobic sludge blanket reactor was analyzed under long-term exposure to MnO₂ nanoparticles (NPs) (1-200 mg L^-1). The addition of 200 mg L^-1 MnO₂ NPs had a significantly positive effect on nitrogen removal and this system exhibited excellent performance, with a total nitrogen removal efficiency of 93.1%. Moreover, the specific anammox activity enhanced with increasing concentrations of MnO₂ NPs up to the maximum value of 657.3 ± 9.3 mg TN g^-1 VSS d^-1 under MnO₂ NPs concentration of 200 mg L^-1. This value was approximately 1.6-fold higher than that of the reactor in the absence of MnO₂ NPs. The extracellular polymeric substances and settling velocity were both increased with MnO₂ NPs addition. Meanwhile, the high-throughput sequencing results revealed that MnO₂ NPs increased the relative abundance of dominant bacteria (Candidatus Kuenenia) from 17.3% at the absence of MnO₂ NPs to 23.9% at 200 mg L^-1 MnO₂ NPs, which resulted in a higher efficiency of biological nitrogen removal on the anammox system. These results indicated that MnO₂ NPs enhanced nitrogen removal performance of anammox process.

Substantially enhanced anaerobic reduction of nitrobenzene by biochar stabilized sulfide-modified nanoscale zero-valent iron: Process and mechanisms

Nanoscale zero-valent iron (nZVI), although being increasingly used in anaerobic systems for strengthening the removal of various refractory pollutants, is limited by various inherent drawbacks, such as easy precipitation, passivation, poor mass and electron transfer. To address the above issues, biochar stabilized sulfide-modified nZVI (S-nZVI@BC) was added into an up-flow anaerobic sludge blanket (UASB) to investigate the enhancement of anaerobic biodegradation of nitrobenzene (NB) and its impacts on microbial community structure. The results demonstrated that both NB reduction and aniline formation could be substantially facilitated in S-nZVI@BC coupled system compared to other anaerobic ones coupled with nZVI or S-nZVI. The dosage of S-nZVI@BC resulted in the formation of densely packed aggregates, evidently increased the extracellular polymeric substances content, promoted the volatile fatty acids transformation and stimulated the methane yield. Furthermore, species related to fermentation (Bacteroides and Longilinea), methanogenesis (Methanosarcina and Methanomethylovorans), electroactivity (Pelobacter, Thiobacillus and Phaselicystis) as well as reduction (Desulfovibrio) were considerably enriched in S-nZVI@BC coupled system. The activities of electron transport, total adenosine triphosphate, nitroreductase and NAD(P)H, which were closely related to microbial activity and NB transformation, were increased noticeably in S-nZVI@BC coupled anaerobic system. This study demonstrated the promising potential for long-term operation and full-scale application of S-nZVI@BC coupled system for the treatment of NB containing wastewater.

Low-temperature anaerobic digestion enhanced by bioelectrochemical systems equipped with graphene/PPy- and MnO2 nanoparticles/PPy-modified electrodes

Bioelectrochemical systems (BESs) with graphene (Gr)/polypyrrole (PPy)- and MnO₂ nanoparticles (NPs)/PPy-modified electrodes were developed to enhance low-temperature anaerobic digestion (LTAD) of low-strength wastewater. At 20 °C, the chemical oxygen demand removal efficiencies and CH₄ yield of the BESs with Gr/PPy (R2) and MnO₂ NPs/PPy (R3)-modified electrodes were 12.7% and 25.6%, and 43.9% and 66.3%, respectively, higher than those of the control (R1, without modification). Although the performance of all reactors decreased as temperature dropping to 12 °C, the CH₄ yield rates of R2 and R3 were still 22.8% and 39.0% higher than that of R1. Further analysis indicated that the modified electrodes might stimulate the metabolic activity of the anaerobic digester sludge. Scanning electron microscopy observation showed that the modified electrodes had higher specific surface area, favoring the attachment and formation of dense biofilms on the surface of electrodes. 16S rRNA gene-sequencing results demonstrated that H₂-consuming methanogens dominated in the BESs and the influence of Gr/PPy and MnO₂ NPs/PPy differed on the microbial community structure of biofilms. These findings justify the wider use of Gr and MnO₂ NPs in electrode modification to assist LTAD using BESs.

Effects of nano-sized MnO2 on methanogenic propionate and butyrate degradation in anaerobic digestion

The responses of methanogenic propionate and butyrate degradation to nano-sized MnO₂ exposure were explored. The results showed that supplementation with 50 mg/g volatile suspended solids (VSS) of nano-sized MnO₂ significantly enhanced the production rate of CH₄ in propionate and butyrate degradation by 25.6% and 21.7%, respectively. The stimulatory effects most likely resulted from enhancements in the microbial metabolic activity based on the observed increases in the extracellular polymeric substance (EPS) secretion and activity of the electron transport system. In contrast, the CH₄ yields obtained were irreversibly inhibited by the presence of 400 mg/g VSS of nano-sized MnO₂, in which just 62.8% and 6.5%, respectively, of the yield obtained from the control. Further investigations indicated that supplementation by nano-sized MnO₂ could cause oxidative stress in microbial cells, resulting in the release of reactive oxygen species (ROS). Compared with that of the control, the amount of intracellular ROS generated in the systems increased by 28.3% (fed with propionate) and 42.5% (fed with butyrate), corresponding to approximately 43.9% and 64.8% losses in cell viability, respectively; thus, ROS generation was suggested to be the main factor responsible for the inhibitory effects of nano-sized MnO₂ on methanogenic propionate and butyrate degradation.

The revolution of performance, sludge characteristics and microbial community of anammox biogranules under long-term NiO NPs exposure

Given the increasing applications of NiO nanoparticles (NPs) in battery products, the potential effects of NiO NPs on anaerobic ammonium oxidation (anammox) systems were studied for the first time. The results showed that the anammox system performance obviously differed under the stresses of different NiO NPs concentrations. After the withdrawal of NiO NPs, the nitrogen removal performance of the anammox reactor returned to nearly that of the initial phase within 35 days. Compared with 0 mg L^-1 NiO NPs, the specific anammox activity first increased and then decreased to the minimum value of 116.8 ± 13.8 mg TN g^-1 VSS d^-1 at 60 mg L^-1 NiO NPs. The variations in the heme c contents and extracellular polymeric substance amounts were similar to the variations in the specific anammox activity throughout the whole experiment. Additionally, the relative abundance of the dominant bacteria (Candidatus kuenenia) increased from 20.44% at 60 mg L^-1 NiO NPs to 23.14% at the end of the last phase. Thus, the potential effects of NiO NPs on anammox systems should be a cause for great concern.

Effects of individual and complex ciprofloxacin, fullerene C60, and ZnO nanoparticles on sludge digestion: Methane production, metabolism, and microbial community

Antibiotics and nanoparticles, emerging contaminants, present great environmental risks and human health concerns. Sludge adsorption, a biological wastewater treatment removal mechanism, targets ciprofloxacin (Cip) antibiotics, C₆₀, and ZnO, leaving complex pollution in sludge anaerobic digestion. This study investigated the mechanisms through which individual and combined ZnO, Cip, and C₆₀ affect sludge anaerobic digestion by studying their effects on CH₄ production, metabolism, and microbial community. ZnO was generally more toxic to CH₄ production than Cip. The ZnO + Cip complex was more influential (>29%) than ZnO or ZnO + C₆₀, with short-lasting acute and additive toxicity effects on methanogenesis and degradation of protein and carbohydrate. ZnO + C₆₀ and ZnO + Cip exerted apparent additional complex effects on Firmicutes, Aminicenantes, Chloroflexi, and Parcubacteria. These results would potentially aid toxicity control related to complex pollution, and improve energy production and reduce pollution risks when used in land applications.

Effects of molybdenum, selenium and manganese supplementation on the performance of anaerobic digestion and the characteristics of bacterial community in acidogenic stage

The addition of trace elements to aid anaerobic digestion has already been widely studied. However, the effects of rare trace elements on anaerobic digestion remain unclear. In this study, the effects of Mo, Se and Mn on anaerobic digestion of rice straw were explored. The results showed the methane yield increased by 59.3%, 47.1% and 48.9% in the first 10 days following addition of Mo (0.01 mg/L), Se (0.1 mg/L) and Mn (1.0 mg/L), respectively. Toxic effects and the accumulation of volatile fatty acids (VFAs) were observed when the Se, Mo and Mn concentrations were greater than 100, 1000 and 1000 mg/L, respectively. The half-maximal inhibitory concentrations (IC₅₀) for Se, Mn and Mo were 79.9 mg/L, 773.9 mg/L and 792.3 mg/L, respectively. The addition of trace elements has changed the bacterial structure of the bacteria, which in turn has affected the digestion performance.

Free acetic acid as the key factor for the inhibition of hydrogenotrophic methanogenesis in mesophilic mixed culture fermentation

The inhibition of acetate under acidic pH is an ideal way to reduce methanogenesis in mesophilic mixed culture fermentation (MCF). However, the effects of acetate concentration and acidic pH on methanogenesis remain unclear. Besides, although hydrogenotrophic methanogens can be suitable targets in MCF, they are generally ignored. Therefore, we intentionally enriched hydrogenotrophic methanogens and found that free acetic acid (FAA, x) concentration and specific methanogenic activity (SMA, y) were correlated according to the equation: y = 0.86 × 0.31/(0.31 + x) (R² = 0.909). The SMA was decreased by 50% and 90% at the FAA concentrations of 0.31 and 2.36 g/L, respectively. The coenzyme M concentration and relative electron transport activity agreed well with the FAA concentration. Moreover, the methanogenic activity could not be recovered when the FAA concentration exceeded 0.81 g/L. These findings indicated that neither acetate nor acidic pH, but FAA was the key factor to inhibit methanogenesis in MCF.